GEP750
-
Upload
diana-hoyos-luna -
Category
Documents
-
view
24 -
download
2
Transcript of GEP750
Engine Make & Model: Perkins 2806A-E18TAG3
Circuit Breaker Type: 3 Pole ACB/MCCB
Fuel Tank Capacity: litres (US gal) 1000 (264.2)
Frequency: 50 Hz 60 Hz
Fuel Consumption, Prime: l/hr (US gal/hr) - 138.4 (36.6)
Engine Speed: RPM - 1800
Alternator Model: LL7024J
Base Frame Type: Heavy Duty Fabricated Steel
Fuel Consumption, Standby : l/hr (US gal/hr) - 155.6 (41.1)
Output Ratings
Generating Set Model Standby*
-
-
600.0 kW
750.0 kVA
Prime*
-
-
540.0 kW
675.0 kVA480V, 60 Hz
-
* Refer to ratings definitions on page 4. Ratings at power factor.0.8
GEP750-1
Technical Data
Diesel Generator SetExclusively from your Cat ® dealer
Ratings at .8 power factor
-
-
Air Filter Type:
Combustion Air Flow:
m³/min (cfm) -Standby:
-Prime:
Max. Combustion Air Intake
Restriction: kPa (in H2O)
Replaceable Element
47.6 (1681)-44.3 (1564)-
6.3 (25.3)Radiator Cooling Air Flow:
m³/min (cfm)External Restriction to
Cooling Air Flow: Pa (in H2O) 125 (0.5)-
804.0 (28393)
Air System 60 Hz50 Hz
Moment of Inertia: kg m² (lb. in²) 7.44 (25424)
Governing Type:
Governing Class:
Compression Ratio:
Displacement: l (cu.in)
Engine Electrical System:
-Voltage/Ground:
-Battery Charger Amps:
Weight: kg (lb) - Dry:
- Wet:
Cooling Method: WaterElectronic
ISO 8528 G214.5:1
18.1 (1104.5)
Bore/Stroke: mm (in) 145.0 (5.7)/183.0 (7.2)
24/Negative
702050 (4519)
2158 (4758)
Induction:
Manufacturer: Perkins
Model: 2806A-E18TAG3No. of Cylinders/Alignment: 6 / In Line
Cycle: 4 StrokeTurbocharged Air To Air
Charge Cooled
34.0Regenerative Power: kW-Prime: - 2270.0 (329.3)
2494.0 (361.7)--Standby:
BMEP: kPa (psi)
617.5 (828.0)- -Prime:
-Standby:
Gross Engine Power: kW (hp)
- 678.2 (909.0)
1800-Engine Speed: RPM
Oil Pan l (US gal):Total Oil Capacity l (US gal):Oil Filter Type:
Oil Type:
Cooling Method:
Eco, Full Flow55.5 (14.7)53.5 (14.1)
API CH4 / CI4Water
Prime
50 Hz -60 Hz 72.6 (19.2)103.3 (27.3)138.4 (36.6)155.3 (41.0)
---
(based on diesel fuel with a specific gravity of 0.85 and conforming to BS2869, Class A2)
Recommended Fuel:
Fuel Consumption: l/hr (US gal/hr)Class A2 Diesel
110%Load
75%Load
50%Load
100%Load
Fuel Filter Type: Eco Replaceable Element
Standby
50 Hz ---60 Hz 79.2 (20.9)114.7 (30.3)155.6 (41.1)
Level: dB
Silencer System: kPa (in Hg)Pressure Drop Across
Silencer Noise Reduction
Silencer Type:
Pressure: kPa (in. Hg)Max. Allowable Back
-Prime:
m³/min (cfm) -Standby:
Exhaust Gas Flow:
-Prime:
m³/min (cfm) -Standby:
Exhaust Gas Temperature: °C (°F)
SD200 (1)Silencer Noise Reduction
0.47 (0.139)-
10-
6.8 (2.0)-
143.0 (5050)-130.0 (4591)-
542 (1008)-513 (955)-
Level 1Cooling System Capacity:
l (US gal)Water Pump Type:
Heat Rejected to Water &
Lube Oil: kW (Btu/min) -Standby:
-Prime:
-Prime:
kW (Btu/min) -Standby:
Heat Radiation to Room:
Radiator Fan Load: kW (hp)
-
14.0 (18.8)
61.0 (16.1)-Centrifugal
170.9 (9719)163.9 (9321)-
45.6 (2593)-41.6 (2366)-
-
Cooling system designed to operate in ambient conditions up to 50°C (122°F). Contact your local Olympian dealer for power ratings at specific site conditions.
Cooling System 60 Hz50 Hz
Performance 60 Hz50 Hz
Fuel System
Exhaust System
Lubrication systemPhysical Data
Engine Techncial Data
Consult your Olympian representative for more information
60 Hz50 Hz
Data Item
50 Hz 60 Hz
Motor Starting Capability* kVA - - - - 1993 1283 - - 1694
Reactances: Per Unit
Xd
X'd
X''d
- - - - 2.840 4.530 - - 3.380
- - - - 0.140 0.220 - - 0.170
- - - - 0.111 0.178 - - 0.132
Reactances shown are applicable to standby ratings.* Based on 30% voltage dip.** With optional Permanent Magnet generator or AREP excitation.
480/277V 380/220V 440/254V220/127V
Short Circuit Capacity** % 300 300 300 300 300 300 300 300 300
Manufacturer:
Model:
No. of Bearings:
Insulation Class:
Winding Pitch - Code:
Wires:
Ingress Protection Rating:
Excitation System:
AVR Model:
LL7024J
1
H
2/3 - 6
12
IP23
AREP
R450
Overspeed: RPM
Voltage Regulation (steady state) (%):
Wave Form NEMA = TIF:
Wave Form IEC = THF:
Total Harmonic Content LL/LN:
Radio Interference:
Radiant Heat: kW (Btu/min)
-50 Hz:
-60 Hz:
Supression is in line with European Standard EN61000-6
42.6 (2423)
-
4.0%
2.0%
50
+/- 0.5
2250
Physical Data Operating Data
Alternator Performance Data
Alternator Technical Data
Consult your Olympian representative for more information
OLYMPIAN
kWkVAkWkVA
Technical Data Phase Ratings and Performance at 50 Hz, RPM-3
Voltage Prime Standby
Standby Rating
These ratings are applicable for supplying continuous electricalpower (at variable load) in the event of a utility power failure. Nooverload is permitted on these ratings. The alternator on this modelis peak continuous rated (as defined in ISO 8528-3).
Prime Rating
These ratings are applicable for supplying continuous electricalpower (at variable load) in lieu of commercially purchased power.There is no limitation to the annual hours of operation and thismodel can supply 10% overload power for 1 hour in 12 hours.
Standard Reference Conditions
Note: Standard reference conditions 25°C (77°F) air inlet temp,100m (328ft) A.S.L. 30% relative humidity. Fuel consumption dataat full load with diesel fuel with specific gravity of 0.85 andconforming to BS2869: 1998, Class A2.
Definitions
-
600.0750.0540.0675.0380/220V
600.0
600.0750.0540.0675.0480/277V
kW
-
750.0
kVAkW
540.0
-
675.0
kVA
440/254V
220/127V
-
Phase Ratings and Performance at 60 Hz, RPM18003
Voltage Prime Standby
Weights & Dimensions
Weights: kg (lb)
Net (+ lube oil)
Wet (+ lube oil & coolant)
Fuel, lube oil & coolant 6116 (13483)
4975 (10968)
4905 (10814)
Dimensions: mm (in)
Height
Width
Length
2246 (88.4)
1536 (60.5)
4111 (161.9)
Documents
A full set of operation and maintenance manuals and circuit wiring diagrams.
Quality Standards
BS4999, BS5000, BSEN60034, BSEN61000, IEC60034.
Warranty
All equipment carries full manufacturer's warranty.
General Data
Note: General configuration not to be usedfor installation. See general dimensiondrawings for detail.
Information contained in this publication may be considered confidential. www.Cat-ElectricPower.comMarket: International Discretion is recommended when distributing. Materials and specifications are subject to change without notice. © 2010 CaterpillarLEHF8849-01 (09/10) CAT, CATERPILLAR, their respective logos OLYMPIAN, "Caterpillar Yellow", and the "Power Edge" trade dress, as well as All rights reserved. corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission. Printed in U.S.A.278-687
LEHF8849-02 (09-10)
Information contained in this publication may be considered confidential. Discretion is recommended when distributing.
Materials and specifications are subject to change without notice.CAT, CATERPILLAR, their respective logos, OLYMPIAN, “Caterpillar Yellow,” the “Power Edge” trade dress as well as
corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.