MultiCyclone Brochure USA
-
Upload
vladimir-e-balvin -
Category
Documents
-
view
219 -
download
0
Transcript of MultiCyclone Brochure USA
8/7/2019 MultiCyclone Brochure USA
http://slidepdf.com/reader/full/multicyclone-brochure-usa 1/2
www.water
In the interest o providing better quality and value we are constantly improving and updating our products. Consequently, pictures and inormation on our brochures may sometimes vary slightly rom models available.
ZZB1279
11/07
OFFICE - USAWaterco(USA)IncAugusta,USATel:+17067937291
OFFICE - CANADAWatercoCanadaQuebec,CanadaTel:+14507961421
OFFICES - OVERSEASNSW-Sydney(HeadOfce)Tel:+61298988600
Waterco(Europe)LimitedRadfeld,Kent,UKTel:+44(0)1795521733
Waterco(NZ)LimitedAuckland,NewZealandTel:+6495257570
Waterco(GZ)LimitedGuangzhou,ChinaTel:+862032222180
Waterco(FarEast)SdnBhdSelangor,MalaysiaTel:+60361456000
PTWatercoIndonesiaJakarta,IndonesiaTel:+622145851481
distributed by:
· Centriugal water fltration
· Easily installed on any existing fltrat
· No flter media to clean or replace
· No moving parts
· Simple operation
· Saves water
· 2 year warranty
Save Water and
Reduce Filter Maintenance
Minimum ow rate Maximum ow rate Maximum pressure
13gpm / 50lpm 132gpm / 500lpm 58psi / 400 kPa / 4 Bar
23.62” / 600mm
10.62" / 270mm
11.57" / 294mm
A revolutionary design to greatly reduce
flter backwashing and maintenance by
capturing particulate beore it reaches
your flter.
8/7/2019 MultiCyclone Brochure USA
http://slidepdf.com/reader/full/multicyclone-brochure-usa 2/2
www.water
MultiCyclone is a pre-ltration device that is capable o
saving water and reducing lter maintenance.
The MultiCyclone works on the basis o centriugal water
ltration. There are no moving parts to wear and tear,
and no lter media to clean or replace
Save Water
MultiCyclone is ideal as a pre-lter, extending the lie o
your existing lter and cutting water consumption as it
eases the workload on the lter.
Reduce backwash requency
MultiCyclone + Sand (granular) lter = Reduction in
backwash requency + Extends the lie o the lter
media.
Centriugal fltration
i. Incoming water enters 16 hydro cyclones tangentially,
generating a strong centriugal eect.
ii. The sediment is spun out to the hydro cyclone’s
wall, and then spirals down to the sediment bowl.
iii. The ltered water migrates towards the center o the
hydro cyclone where the fow reverses and spirals
upwards through the outlet.
iv. Accumulation o sediment can be visibly monitored
through the MultiCyclone’s clear sediment bowl.
v. The MultiCyclone is easily cleaned by opening the
valve.
Only 4 gallons / 15 litres o water is discharged to
cleanse the MultiCyclone.
Hydraulically efficientdesign
Glass filledreinforcedthermoplastic
Clear polycarbonatesediment bowl
1” sediment purge valve
Quick fit unions
UV and corrosion proof
16 multiplehydro cyclones
Lock ring
2” Outlet
2” Inlet
Micron RatingParticle Size
11.6 NTU InfuentParticle Size
10.2 NTU EfuentAverage % o
Particles trapped
5.0 – 80.0 24141 16824 30.31%
5.0 – 20.0 23608 16561 29.85%
20.0 – 40.0 509.20 260.13 48.91%
40.0 – 60.0 22.000 2.861 86.97%
60.0 – 80.0 2.333 0.000 100.00%
Laboratory testsThe laboratory test below revealed that the Multi Cyclone was capable of trapping sediment between 10 to 100 micron
The filtration efficiency of the MultiCyclone was tested by feeding 5 to 80 micron dust particles through the MultiCyclon
the percentage dust particles trapped in the sediment bowl.
The laboratory test below revealed that the MultiCyclone was effective in filtering particles sized 40 to 80 microns.
DE powder was passed through the MultiCyclone to discover its effective flow rate.
At 13.2gpm / 50 lpm, the MultiCyclone was able to remove approximately 60% of DE powder and at 92.5gpm / 350 lpm, th
was able to remove 80% of DE powder.