FASCINATING¡-data... · • Kitchen work surfaces and table suite in CPL (laminate) •...
Transcript of FASCINATING¡-data... · • Kitchen work surfaces and table suite in CPL (laminate) •...
BOXSTAR . BOXLIFE . BOXDRIVE
FASCINATINGDISCOVER FREEDOM THAT INSPIRES YOU.
TECHNICAL SPECIFICATIONS – CUV 2020-1
2
LAYOUTS* 2020
* Description without engagement: All the illustrations shown (here) are schematic representations without engagement. The actual vehicle and equipment features may differ from the layout examples. Certain vehicle and equipment features are not granted by the illustrations and cannot (therefore) be acquired as basis/standard equipment/are not included in the standard equipment. (Therefore), please make sure to contact your dealer about the specifi c features and the selected equipment of your chosen vehicle before purchasing it.
BOXSTAR page 3 BOXLIFE page 11 BOXDRIVE page 18
BOXLIFE 600 ME
BOXLIFE 600 DQ
BOXLIFE 630 ME
BOXLIFE 540 MQ
BOXLIFE 600 MQ
BOXDRIVE 680 ME
BOXSTAR Street 600
BOXSTAR Family 600
BOXSTAR Lifetime 600
BOXSTAR Road 540
BOXSTAR Street 600 XL
BOXSTAR Lifetime 600 XL
BOXSTAR Solution 600
BOXSTAR Freeway 630
3
X Standard equipment– Not planned technically• optional
¹) Load increase at the factory with screw spring set* Please note the section „important information“ on page 24
BOXSTAR
Technical data
KNAUS BOXSTAR – Technical Data * Road 540 Street 600 Family 600 Lifetime 600 Solution 600 Freeway 630 Street 600 XL Lifetime 600 XL
FIAT BASIC ENGINEE
FIAT 2,3 l Multijet 120, Euro 6d-Temp (88 kW/120 PS) – 3.300 kg x x x x — — — —
FIAT 2,3 l Multijet 120, Euro 6d-Temp (88 kW /120 PS) – 3.500 kg / Light • • • • x x x x
CHASSISLength cm 541 599 599 599 599 636 599 599Width cm (outer/inner) 205/187 205/187 205/187 205/187 205/187 205/187 205/187 205/187Height cm (outer/inner) 258/190 258/190 258/190 258/190 282/218 282/218 308/238 308/238Mass in running order (kg)* 2.650 2.800 2.800 2.800 2.880 2.980 ca. 2.880 ca. 2.880Tecnically maximum authorized laden mass (kg)* 3.300 3.300 3.300 3.300 3.500 3.500 3.500 3.500
Maximum payload (kg)* 650 500 500 500 620 520 ca. 620 ca. 620Permitted towing load (kg)* 2.500 2.500 2.500 2.500 2.500 2.500 2.500 2.500Tyres / spare wheel / rims 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” Wheelbase (mm) 3.450 4.035 4.035 4.035 4.035 4.035 Overhang 4.035 4.035Turning circle (m) 12,4 14,2 14,2 14,2 14,2 14,2 14,2 14,2Seats with safety belt (Number of persons in driving operation) 4 4 4 4 4 4 4 4
Beds 2 / 3 ²) 2 / 3 ²) 4 / 5 ²) 2 / 3 ²) 4 / 5 ²) 2 / 5 ²) 4 / 5 ²) 4 / 5 ²)
EXTERIORWindows / doors / ventilationSeitz S7P frame windows with blinds and mosquito protection 5 5 5 7 5 7 7 9
Wet cubicle window X X X X X X X X
4
** fresh water tank capacity limited to 20 ltr. by overflow valve (recommended driving fill level)*** fresh water tank capacity is 102 ltr. with the overflow valve closed
X Standard equipment– Not planned technically• optional
²) Spare bed, 180x70cm, at the front, available as option³) Optional 4) with Option 551983 single bed, the extra bed is omitted
KNAUS BOXSTAR – Technical Data * Road 540 Street 600 Family 600 Lifetime 600 Solution 600 Freeway 630 Street 600 XL Lifetime 600 XL
Roof light Midi-Heki (700x500 mm) / Mini-Heki (400x400 mm) 1 | 1 1 | 1 1 | 1 1 | 1 1 | 1 1 | 1 1 | 1 1 | 1
Mushroom vent Toi-Room X X X X X X X X
INTERIORLiving / sleepingBed size, rear bed, lateral, with single-piece slatted frame with compact bathroom (cm) 194 x 140/125 194 x 145/140 184 x 145/140 + 180
x 145/140 — 194 x 145/140 — 194 x 145/140 —
Bed size, rear bed, lateral, with single-piece slatted frame with en-suite bathroom (cm) 194 x 140/134 194 x 145/140 184 x 145/140 + 180
x 145/140 — 194 x 145/140 — 194 x 145/140 —
Bed size, rear bed, lengthwise with compact bathroom (cm) — — — 180 x 85 + 200 x 85 — 190 x 85 + 195 x 85 — 180 x 85 + 200 x 85
Bed size, rear bed, lengthwise with en-suite bathroom (cm) — — — 189 x 85 + 200 x 85 — 199 x 85 + 195 x 85 189 x 85 + 200 x 85
Bed size, spare bed on semi-dinette and driver's seat (cm) 135 x 60 ²) ⁴) 160 x 60 ²) 160 x 60 ²) 135 x 60 ²) ⁴) 160 x 60 ²) 160 x 60 ²) 160 x 60 ²) 135 x 60 ²) ⁴)
Bed size, Classic lifting bed (cm) — — — — 176 x 130 176 x 130 ³) — —Headroom, manual Classic lifting bed (cm) — — — — 50 50 — —Bed size, Vario lifting bed (cm) — — — — 194x130 ³) 194x130 ³) — —Headroom, manual Vario lifting bed (cm) — — — — 100 100 — —Bed size, high roof comfort bed incl. cold foam mattress (cm) — — — — — — 207 x 130 190 x 130
Headroom, high roof comfort bed (cm) — — — — — — 55 55
Gas / heating / water / climateGas locker for gas bottle reserves for (in kg) 2x11 2x11 2x5 2x11 2x11 2x11 2x11 2x11Heating (incl. 10 ltr. hot water supply) Truma Combi 4 Truma Combi 4 Truma Combi 4 Truma Combi 4 Truma Combi 4 Truma Combi 6 Truma Combi 4 Truma Combi 4Fresh water tank, built-in (volume in liters) 20**/102*** 20**/102*** 20**/80*** 20**/102*** 20**/102*** 20**/102*** 20**/102*** 20**/102*** Waste water tank, built-in under floor (liters) 90 90 110 90 90 90 90 90
KitchenCUV Compressor refrigerator, incl. 7,5 ltr. freezer compartment pluged above level (liters)
— 90 90 — 90 90 90 —
CUV Compressor refrigerator incl. 7,5 ltr. freezer, integrated under kitchen unit (liters) 70 — — 70 — — — 70
Toi-RoomCompact bathroom incl. shower curtain with air ring and extendable shower head X X X X X X X X
En-suite bathroom with shower cubicle and separate shower faucet • • • • • • • •
Toilet unit Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable
5
KNAUS BOXSTAR – Standard equipment
Chassis • Fiat Ducato 2,3 l 120 Multijet, Euro 6d-Temp (88 kW/120 PS)• Standard painting white• Airbag for driver side• ABS• ESP, Hill Holder• Original Fiat captain chair seats with armrests• Driver‘s seat adjustable for height• Cupholder center console• Rear / front axle stabiliser• Disk brakes• Power steering• Height-adjustable headlights• Immobiliser system• 3-point safety belt system• Central locking for driver's cab, with remote control• Electrical window winders, front• Spare wheel
Layout plansModels with 4 seats and 2-3 sleeping berths:
� – Road 540 � – Street 600 � – Lifetime 600 � – Freeway 630
Models with 4 seats and 4-5 sleeping berths: � – Street 600 XL � – Family 600 � – Lifetime 600 XL � – Solution 600 � – Freeway 630 with option lifting bed
Car body• Seitz S7P frame window all round (incl. bathroom window and rear
window)• Assembly adapter frame for roof hoods (not 280 x 280mm)• Roof hoods: Midi-Heki (700 x 500 mm) + roof hatch (400 x 400 mm) • Insect screen door sliding door• Sliding door with manual closing aid
Isolation• Isolation without cold bridges• Polyethylene foam closed cell content on side walls and ceiling• Floor plate, sandwich construction made of 16 mm Styrodur, poplar
plywood and PVC coating• Floor thickness 25 mm• Temperature controlled intermediate floor seating group• Breathable Soft-touch side wall covers
Furniture design• Full body construction for more stability/solidity• Vertical furniture surfaces with ABS coating• Kitchen work surfaces and table suite in CPL (laminate)• Aluminium-/Rod profile with round edges• Furniture hinges with spring reinforcement• Drawers, flaps and doors fitted flush in furniture body• Kitchen Drawers open fully with ball bearing guides• Ceiling cupboards with handles, rocker arms and softclose
On-board technology• 90 ltr. CUV compressor refrigerator (exceptions: Road 540, Lifetime 600
with 70 ltr.)• 2-flame hob with glass cover, separate washbasin with cover in worktop
surface• 2 x 11 kg gas bottle locker (Family 600: 2 x 5 kg)• AGM on-board battery (95 Ah)• On-board control with digital display for power/water/waste water/
battery• 12 Volt sockets (1x) + 230 Volt sockets (2x)• LED lighting all round (exception: Entrance light + luggage compartment)• Water lines routed alongside air recirculation hose• Shower tray with minimum 2 drains in compact bath (optional variable
size wet cell with minimum 3 drains)• Toilet unit rotatable• WC disposal tunnel with full cover• Charging booster for body battery
Comfort• Living area and driver‘s cab seats in original Fiat design• Upholstery options: Turin, Indian Summer, Energy, Casual Silver• Driver seat and passenger’s seat can be swiveled• Dinette seat bench with side pull-out also during the journey; incl. Isofix• Dinette table with open access (floating table) can be rotated out;
includes a double table top• Comfort blind system• Space optimisation in bathroom kitchen, living and sleeping area• Toilet / shower room with washbasin, cassett-toilet and patented shower
curtain• Two-layer cold foam mattresses with breathable and durable mattress
cover• Rear lateral beds with full size slatted frame• Slatted frames (incl. mattresses) stackable and removable• Technology module with supply installation and appliance easily
accessible• Operating elements arranged centrally• Kitchen worktop with sink covering in surface optics and foldable
extension
KNAUSFIAT
6
KNAUS BOXSTAR – Packages
Item no.
210009 FIAT-PACKAGE 29 kg
200488 Rear view mirrors, electrically adjustable and heatable
200176 Air-conditioning system, driver's cab, manual
200501 Airbag for passenger side
200567 Tempomat – Cruise Control
201952 Height-adjustable passenger seat
202478 Steering wheel with radio operating panel
Item no.
214102 FUNLINE-PACKAGE 42/50 kg
550990 Front/side window insulation (pleat system, driver's cab, foldable)
250599 Radio preparation for living area (cable laid incl. 2 loudspeakers)
101080 Electrical entrance step 70cm wide
501646 Awning for 540/600/630 layout plans (model-dependent!)
352059 CP-Plus control panel
352380 Truma iNet system
450740 Waste water tank insulation hood
252615 Lighting control
452718 Water filter system "BWT - Best-Camp mini"
Item no.
210045 STYLING-PACKAGE II
201788 Front bumper sprayed in vehicle colour
201815 Alloy rims with standard tyres
202140 Spoiler lips in aluminium look (skid plate)
202139 Headlights with black frame
202138 Radiator grill in FIAT shiny black
202137 LED day running light
Item no.
214117 Ambient lighting package incl. Lighting control
inlcudes:
252623Ambient lighting: Pedestal lighting (night light); RGB lighting rear - ceiling; Open bathroom: RGB lighting in baldachin; Classic bathroom: LED band side wall and ceiling
102497 Gutter with LED lighting
Item no.
210040 STYLING-PACKAGE I
201788 Front bumper sprayed in vehicle colour
201815 Alloy rims with standard tyres
Item no.
210006 MEDIA-PACKAGE 2 kg
252143 Radio DAB+, All-in-One navigations system with camping software, without CD/DVD-drive, antenna, 3 years map update
251793 Rear-view backup camera incl. Cabling
252715 Headup Display
Item no.
214118 E-PACKAGE
252625 Reading lamp “Swan’s Neck” with 2 USB slots; ceiling wardrobe at front left
252161 2 pcs. reading lamps (driver's cab)
250072 2 pcs. 230 V sockets in ceiling wardrobe front left
250940 2 pcs. 230 V power sockets rear garage
251248 2. board AGM battery
Item no.
210018 CARE-DRIVE PACKAGE
202150 Tyre pressure sensors
202710Safety Pack Fiat (consists of: Full Brake Control, Lane Departure Warning System, High-Beam Recognition Traffic Signs Recogniction and Rain & Dusk)
202164 Rain and light sensors
Item no.
210002 TV PACKAGE 21,5"
252605 Complete antenna system Oyster 60 Premium Twin incl. 21,5” LED-TV (living area)
252405 TV holder (living area) - incl. combi socket
252479 Pre-cabling for TV (bed area)
7
KNAUS BOXSTAR – Options
KNAUS BOXSTAR – Motorization KG Road 540 Street 600 Family 600 Lifetime 600 Solution 600 Freeway 630 Street 600 XLLifetime 600 XL
BASE VEHICLE 88 kW/120 PS 3.300 kg
88 kW/120 PS 3.300 kg
88 kW/120 PS 3.300 kg
88 kW/120 PS 3.300 kg
88kW/120 PS 3.500 kg / Light
88kW/120 PS 3.500 kg / Light
88kW/120 PS 3.500 kg / Light
88kW/120 PS 3.500 kg / Light
Motorization2.3 l 140 Multijet with front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (103 kW/140 PS) • • • • • • • •
2.3 l 160 Multijet with start-stop system incl. smart alternator; front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (118 kW/160 PS)
• • • • • • • •
2.3 l 180 Multijet with start-stop system incl. smart alternator; front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (130 kW/178 PS)
• • • • • • • •
Weights
3.500kg Light Chassis instead of 3.300 kg light chassis • • • • X X X X
3.500kg Maxi Chassis instead of 3.300 kg light chassis (from 103 kW/140 PS) 40 – • • • – – – –
3.500kg Maxi Chassis instead of 3.500 kg light chassis (from 103 kW/140 PS) 40 – – – – • • • •
4.000kg Maxi Chassis instead of 3.300 kg light chassis (from 103 kW/140 PS) 40 – – – – – • – –
Description: • = option | – = not available | X = standard
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XLGearbox
202711 9-speed torque converter automatic transmission instead of 6-speed manual transmission (only in conjunction with Fiat package, not possible with 120hp engine, 140hp engine only possible with Fiat ECO package, option 202756)
17 • • • • • • • •
Chassis / Load increase202132 16" steel rims instead of 15"
- only possible with 3,5 t light• • • • • • • •
201815 STYLING I+II Alloy rims with standard tyres -only in combination with Fiat Packages
4 • • • • • • • •
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
202568 17" alloy wheels including tyres (235/60R17), front polished in black gloss in exclusive KNAUS Design
6 • • • • • • • •
202569 17" alloy wheels including tyres (235/60R17), painted in titanium metallic in exclusive KNAUS Design
6 • • • • • • • •
202572 Complete wheelset aluminium rim black glossy with 255/55 R18 tyres (only for Heavy Chassis)
– • • • • • • •
202573 Complete wheelset aluminium rim sterling silver with 255/55 R18 tyres (only for Heavy Chassis)
– • • • • • • •
8
KNAUS BOXSTAR – Options
* Colour deviations of up to approx. 2.0 dE between paint on sheet metal and paint on GRP/plastic
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
202451 Complete wheelset aluminium rim 18" black glossy with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • • • • •
202248 Complete wheelset aluminium rim 18" sterling silver with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • • • • •
202765 Complete wheelset aluminium rim 18" mistral antracit glossy with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • • • • •
201041 Trailer hitch, rigid, incl. electronic installation
18 • • • • • • • •
202061 Trailer hitch, ball head removable, incl. electronic installation (lockable)
18 • • • • • • • •
202060 Dual circuit air spring set - increased driving comfort --> no upweighting!
15 • • • • • • • •
202766 Screw spring set rear axle - Optimizes the chassis --> no upweighting!
4,5 • • • • • • • •
351932 Webasto auxiliary heating (Fiat) 5 • • • • • • • •200601 Chassis in metallic painting options:
Silver (aluminum gray), Fer gray, Profondo red, Golden white, Lago blue, black, Campovolo grey
1 • • • • • • • •
200601 Chassis in special paint Campovolo grey 1 • • • • • • • •other chassis painting options free of charge (not metallic): Tiziano Red, Imperial Blue, Line Blue
• • • • • • • •
High roof in White (Standard for all colors of the basic vehicle)*
– – – – – – X X
102691 High roof in car color Campovolo grey – – – – – – • •102058 High roof painted in car color
(all colors except black!)– – – – – – • •
202140 STYLING II Spoiler lips in aluminium look (skid plate) – • • • • • • • •201788 STYLING I+II Front bumper sprayed in vehicle colour 3 • • • • • • • •201199 Mudflaps, front 1 • • • • – – – –201198 Mudflaps, rear 1 • • • • – – – –
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
Transport systems100597 Bike rack for 2 bikes 6 • • • • • • • •
Assistance systems200567 FIAT Cruise Control 0,8 • • • • • • • •202150 CARE-DRIVE Tyre pressure sensors • • • • • • • •202710 CARE-DRIVE Safety Pack Fiat (consists of: Full Brake
Control, Lane Departure Warning System, High-Beam Recognition Traffic Signs Recogniction and Rain & Dusk)
• • • • • • • •
201787 Traction control, Traction Plus 1 • • • • • • • •201062 Parking assistant 1 • • • • • • • •202762 FIAT cross traffic and lane
change assistant• • • • • • • •
Inside550990 FUNLINE Driver's cab blackout blind with
foldable front and side window blinds4 • • • • • • • •
200176 FIAT Air conditioning for driver's cab, manual incl. pollen filter with outside temperature display
18 • • • • • • • •
200980 Air conditioning for driver's cab, automatic incl. pollen filter with outside temperature display
21 • • • • • • • •
201686 Air conditioning for driver's cab, automatic, extra charge against manual air conditioning for driver's cab, with outside temperature display (in FIAT package)
21 • • • • • • • •
200501 FIAT Airbag for passenger side 2 • • • • • • • •201952 FIAT Height-adjustable passenger seat – • • • • • • • •201519 Leather steering wheel with
leather gear shift knob– • • • • • • • •
202478 FIAT Steering wheel with radio operating panel
• • • • • • • •
201843 Instrument panel in Lounge design (bronze)
1 • • • • • • • •
201857 Instrument panel in Techno design (alu) 1 • • • • • • • •201074 Footmat set, driver's cab,
with KNAUS logo1 • • • • • • • •
9
KNAUS BOXSTAR – Options
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
202392 Seat heating for driver's seat (also possible with authentic leather)
• • • • • • • •
Lighting / Technology200178 Fog lamp 1 • • • • • • • •202138 STYLING II Radiator grill in FIAT shiny black – • • • • • • • •202139 STYLING II Headlights in black frame – • • • • • • • •202137 STYLING II LED day running light – • • • • • • • •202712 Fuel tank 90 ltr. instead of 75 ltr. • • • • • • • •201609 Rear view mirrors fold in electrically 1 • • • • • • • •200488 FIAT Rear view mirrors, electrically
adjustable and heatable– • • • • • • • •
202756 Fiat ECO-Pack consisting of: Start-Stop system incl. smart alternator (only possible with 140hp engine)
• • • • • • • •
201165 Dead-Lock function for central locking – • • • • • • • •202416 Fiat alarm system incl. 2. key with remote 1 • • • • • • • •550592 Front window - insulation mat set 2 • • • • • • • •
Multimedia / Navigation252143 MEDIA
PACKAGERadio DAB+, All-in-One navigations system with camping software, without CD/DVD-drive, antenna, 3 years map update
1 • • • • • • • •
250599 FUNLINE Radio preparation for living area (cable laid incl. 2 loudspeakers)
1 • • • • • • • •
252715 MEDIA PACKAGE
Headup Display (only possible with package 210006)
• • • • • • • •
BodyWindows, doors, ventilation
101080 FUNLINE Entry step, electric, 70 cm wide 8 • • • • • • • •101982 Seitz S7P frame window at back rear,
80x40 cm, incl. sliding door stop4 • • – X • X • X
101981 Seitz S7P frame window at left rear, 80x40 cm
4 • • – X • X • X
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
102020 Curtain window (50 x 50 cm cut-out size) instead of frame window for rear doors (limited aperture)
– • • • • • • • •
102619 Third roof hatch (400 x 400 in vehicle center) - not possible in comibnation with SAT system and/or en suite bathroom
• • • • • • – –
102689 Panorama roof and hook out window rear in high roof
– – – – – – • •
INTERIOR FITTINGSLiving/Sleeping
551983 Semi-dinette with single seats instead of seat bench incl. 2x Isofix (3-point system)
25 • • • • • • • •
551994 Spare bed, lateral (180x70 cm) with additional cushion
8 • • • • • • • •
552517 Classic front loft bed, manual (no ceiling cupboards in dinette – no storage compartment over the driver cabin!)
– – – – X • – –
552256 Vario front loft bed, manual (no ceiling cupboards in dinette – no storage compartment over the driver cabin!) (excludes option 551994)
30 – – – – – • – –
552516 Vario front loft bed instead of Classic front loft bed (excludes option 551994)
– – – – • – – –
552159 Electric drive for vario front loft bed 2 – – – – • • – –552574 Fixed bed with EVOPORE HRC
mattress incl. WaterGEL pad7 • • • • • • • •
552223 Bed enlargement – – – • – • – •
Upholstery and textiles552188 Upholstery design Active Rock, incl.
seat covers for driver's cab seats– • • • • • • • •
551509 Leather design "Las Vegas", incl. seat covers for driver's cab seats
• • • • • • • •
550660 COZY HOME package includes: 2 decorative cushions, 2 sleeping pillows, 2 blankets, 1 table runner
3
EARTH • • • • • • • •
10
KNAUS BOXSTAR – Options
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
STONE • • • • • • • •AVOCADO • • • • • • • •AQUA • • • • • • • •MAGNOLIA • • • • • • • •PEACH • • • • • • • •
Gas/Heating/Air conditioning351274 E-Version Truma Combi gas heating
(not possible in combination with option 251231
1 • • • • • • • •
351166 Heater Truma Combi 6 inste-ad of Truma Combi 4
2 • • • • • X • •
351231 Diesel heater Truma Combi 6D 5 • • • • • • • •352230 Truma Combi 6 D + E heating system 6 • • • • • • • •550825 Electric floor heating 5 • • • • • • • •352059 FUNLINE CP-Plus digital heating control panel – • • • • • • • •352380 FUNLINE Truma iNet system (only possible
with option 352059)• • • • • • • •
450740 FUNLINE Waste water tank insulation hood - heated
3 • • • • • • • •
552540 Dometic air conditioning Freshjet 1700 (rear) - Roof hatch rear omitted, not possible with 452258 on STREET 600 XL
• • • • • • • •
302453 Truma MonoControl CS 1 • • • • • • • •302454 Truma DuoControl CS 1 • • – • • • • •302499 Truma LevelControl (for 1 steel gas
bottle, only possible with option 352380)• • • • • • • •
Kitchen area402602 Compressor refrigerator 150 Ltr.
with 30l froster compartement (wardrobe omitted)
8 – • • – • • • –
102577 Matching multifunctional bag in KNAUS design as an extension to the front-mounted kitchenette
• • • • • • • •
Item n°in
packageDescription • = option | – = not available | X = standard KG Ro
ad 5
40
Stre
et 6
00
Fam
ily 6
00
Life
time
600
Solu
tion
600
Free
way
630
Stre
et 6
00 X
L
Life
time
600
XL
Water supply / Sanitary452258 En suite bathroom instead of
compact bathroom (depending on layout with wardrobe) - not possible with option 102619, not possible with 552540 on STREET 600 XL
• • • • • • • •
452718 FUNLINE Water filter system "BWT - Best-Camp mini"
• • • • • • • •
Electric302494 Gas alarm • • • • • • • •252605 TV-PACKAGE Complete antenna system Oyster 60
Premium Twin incl. 21,5” LED-TV (living area) (only possible with option 252405)
• • • • • • • •
252448 21,5" TV unit with HD tuner incl. TV holder (bed area)
9 • • • • • • • •
252479 TV-PACKAGE Pre-cabling for TV (bed area) 1 • • • • • • • •252405 TV-PACKAGE TV holder (living area) -
incl. combi socket2 • • • • • • • •
251261 TV holder (bed area) incl. combi socket 2 • • • • • • • •251948 Cable, preinstalled for solar
and satellite systems1 • • • • • • • •
252161 E-PACKAGE Reading lamp in driver´s cab • • • • • • • •251248 E-PACKAGE Auxiliary AGM on-board battery 20 • • • • • • • •252698 GPS tracker 1 • • • • • • • •
Awning501646 FUNLINE Awning for 540/600/630 layout
plans (length-dependent!)20 //
29• • • • • • • •
11
KNAUS BOXLIFE – Technical Data * 540 MQ 600 MQ 600 ME 600 DQ 630 ME
FIAT BASIC ENGINEE
FIAT 2,3 l Multijet 120, Euro 6d-Temp (88 kW/120 PS) – 3.300 kg X X X — —
FIAT 2,3 l Multijet 120, Euro 6d-Temp (88 kW /120 PS) – 3.500 kg / Light • • • X X
CHASSISLength cm 541 599 599 599 636Width cm (outer/inner) 205/187 205/187 205/187 205/187 205/187Height cm (outer/inner) 258/190 258/190 258/190 282/218 282/218
Mass in running order (kg)* 2.650 2.800 2.800 2.880 2.980Tecnically maximum authorized laden mass (kg)* 3.300 3.300 3.300 3.500 3.500Maximum payload (kg)* 650 500 500 620 520Permitted towing load (kg)* 2.500 2.500 2.500 2.500 2.500
Tyres / spare wheel / rims 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” 215/70 R15 C; 6J x 15” Wheelbase (mm) 3.450 4.035 4.035 4.035 4.035 OverhangTurning circle (m) 12,4 14,2 14,2 14,2 14,2
Seats with safety belt (Number of persons in driving operation) 4 4 4 4 4Beds 2 / 5 ²) ³) 2 / 5 ²) ³) 2 / 5 ²) ³) 4 / 7 ²) ³) 2 / 7 ²) ³)
EXTERIORWindows / doors / ventilationSeitz S7P frame windows with blinds and mosquito protection 5 5 7 5 7
BOXLIFE
Technical data
X Standard equipment– Not planned technically• optional
¹) Load increase at the factory with screw spring set* Please note the section „important information“ on page 24
12
KNAUS BOXLIFE – Technical Data * 540 MQ 600 MQ 600 ME 600 DQ 630 ME
Wet cubicle window X X X X XRoof light Midi-Heki (700x500 mm) / Mini-Heki (400x400 mm) 1 | 1 1 | 1 1 | 1 1 | 1 1 | 1Mushroom vent Toi-Room X X X X X
INTERIORLiving / sleepingBed size, rear lifting bed with compact bathroom (cm) 173 x 139/121 173 x 142/138 — 173 x 142/138 —Bed size, rear lifting bed with en-suite bathroom (cm) 173 x 139/130 173 x 142/138 — 173 x 142/138 —Bed size, rear bunk bed unterneath with compact bathroom (cm) 184 x 136/118 ³) 184 x 139/134 ³) — 184 x 139/134 ³) —Bed size, rear bunk bed unterneath with en-suite bathroom (cm) 184 x 136/127 ³) 184 x 139/134 ³) — 184 x 139/134 ³) —Bed size, rear lifting bed lengthwise with compact bathroom (cm) — — 197/179 x 173 — 188/184 x 173Bed size, rear lifting bed lengthwise with en-suite bathroom (cm) — — 197/188 x 173 — 196/184x 173Bed size, rear bunk bed lengthwise with compact bathroom (cm) — — 197/188 x 184 ³) — 193/189 x 184 ³)Bed size, rear bunk bed lengthwise with en-suite bathroom (cm) — — 197/179 x 184 ³) — 202/189x 184 ³)Bed size, spare bed on semi-dinette and driver's seat (cm) 135 x 60 ²) 4) 160 x 60 1) 135 x 60 ²) ⁴) — 160 x 60 ¹)Bed size, Classic lifting bed (cm) — — — 176 x 130 ³) 176 x 130 ³)Headroom, manual Classic lifting bed (cm) — — — 50 50Bed size, Vario lifting bed (cm) — — — 194x130 ³) 194x130 ³)Headroom, manual Vario lifting bed (cm) — — — 100 100
Gas / heating / water / climateGas locker for gas bottle reserves for (in kg) 1x2,7 1x2,7 1x2,7 1x2,7 1x2,7Heating (incl. 10 ltr. hot water supply) Truma Combi 6D Truma Combi 6D Truma Combi 6D Truma Combi 6D Truma Combi 6DFresh water tank, built-in (volume in liters) 20**/102*** 20**/102*** 20**/102*** 20**/102*** 20**/102*** Waste water tank, built-in under floor (liters) 90 90 90 90 90
KitchenCUV Compressor refrigerator, incl. 7,5 ltr. freezer compartment pluged above level (liters) — 90 — 90 90
CUV Compressor refrigerator incl. 7,5 ltr. freezer, integrated under kitchen unit (liters) 70 — 70 — —
Toi-RoomCompact bathroom incl. shower curtain with air ring and extendable shower head X X X X X
En-suite bathroom with shower cubicle and separate shower faucet • • • • •
Toilet unit Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable Cassette toilet rotatable
** fresh water tank capacity limited to 20 ltr. by overflow valve (recommended driving fill level)*** fresh water tank capacity is 102 ltr. with the overflow valve closed
X Standard equipment– Not planned technically• optional
²) Spare bed, 180x70cm, at the front, available as option³) Optional 4) with Option 551983 single bed, the extra bed is omitted
13
KNAUS BOXLIFE – Standard equipment
Chassis • Fiat Ducato 2,3 l 120 Multijet, Euro 6d-Temp (88 kW/120 PS)• Standard painting white• Airbag for driver side• ABS• ESP, Hill Holder• Original Fiat captain chair seats with armrests• Driver‘s seat adjustable for height• Cupholder center console• Rear / front axle stabiliser• Disk brakes• Power steering• Height-adjustable headlights• Immobiliser system• 3-point safety belt system• Central locking for driver's cab, with remote control• Electrical window winders, front• Spare wheel
Layout plansModels with 4 seats and 2-5 sleeping berths:
� – 540 MQ � – 600 MQ � – 600 ME � – 630 ME
Models with 4 seats and 2-7 sleeping berths: � – 600 DQ with option lifting bed (front) � – 630 ME with option lifting bed (front)
Car body• Seitz S7P frame window all round (incl.
bathroom window and rear window)• Assembly adapter frame for roof hoods• Roof hoods: Midi-Heki (700 x 500 mm) + roof hatch (400 x 400 mm) • Insect screen door sliding door• Sliding door with manual closing aid
Isolation• Isolation without cold bridges• Polyethylene foam closed cell content on side walls and ceiling• Floor plate, sandwich construction made of 16 mm
Styrodur, poplar plywood and PVC coating• Floor thickness 25 mm• Temperature controlled intermediate floor seating group• Breathable Soft-touch side wall covers
Furniture design• Full body construction for more stability/solidity• Vertical furniture surfaces with ABS coating• Kitchen work surfaces and table suite in CPL (laminate)• Aluminium-/Rod profile with round edges• Furniture hinges with spring reinforcement• Drawers, flaps and doors fitted flush in furniture body• Kitchen Drawers open fully with ball bearing guides• Ceiling cupboards with handles, rocker arms and softclose
On-board technology• 90 ltr. CUV compressor refrigerator (exceptions:
Road 540, Lifetime 600 with 70 ltr.)• 2-flame hob with glass cover, separate washbasin
with cover in worktop surface• 1 x 2,7 kg gas bottle locker• AGM on-board battery (95 Ah)• On-board control with digital display for power/
water/waste water/battery• 12 Volt sockets (1x) + 230 Volt sockets (2x)• LED lighting all round (exception: Entrance light + luggage compartment)• Water lines routed alongside air recirculation hose (not external shower)• Shower tray with minimum 2 drains in compact bath
(optional variable size wet cell with minimum 3 drains)• Toilet unit rotatable• WC disposal tunnel with full cover• Charging booster for body battery
Comfort• Living area and driver‘s cab seats in original Fiat design• Upholstery options: TURIN (FIAT), ENERGY,
INDIAN SUMMER, CASUAL SILVER• Driver seat and passenger’s seat can be swiveled• Dinette seat bench with side pull-out also during
the journey; incl. Isofix (3-point Isofix)• Dinette table with open access (floating table) can
be rotated out; includes a double table top• Comfort blind system• Space optimisation in bathroom kitchen, living and sleeping area• Toilet / shower room with washbasin, cassett-
toilet and patented shower curtain• Two-layer cold foam mattresses with breathable
and durable mattress cover• Rear lifting beds with slatted frame• Technology module with supply installation
and appliance easily accessible• Operating elements arranged centrally• Kitchen worktop with sink covering in surface
optics and foldable extension
KNAUSFIAT
14
KNAUS BOXLIFE – Packages
Item no.
210009 FIAT-PACKAGE 29 kg
200488 Rear view mirrors, electrically adjustable and heatable
200176 Air-conditioning system, driver's cab, manual
200501 Airbag for passenger side
200567 Tempomat – Cruise Control
201952 Height-adjustable passenger seat
202478 Steering wheel with radio operating panel
Item no.
214102 FUNLINE-PACKAGE 42/50 kg
550990 Front/side window insulation (pleat system, driver's cab, foldable)
250599 Radio preparation for living area (cable laid incl. 2 loudspeakers)
101080 Electrical entrance step 70cm wide
501646 Awning for 540/600/630 layout plans (model-dependent!)
352059 CP-Plus control panel
352380 Truma iNet system
450740 Waste water tank insulation hood
252615 Lighting control
452718 Water filter system "BWT - Best-Camp mini"
Item no.
210045 STYLING-PACKAGE II
201788 Front bumper sprayed in vehicle colour
201815 Alloy rims with standard tyres
202140 Spoiler lips in aluminium look (skid plate)
202139 Headlights with black frame
202138 Radiator grill in FIAT shiny black
202137 LED day running light
Item no.
214117 Ambient lighting package incl. Lighting control
inlcudes:
252623Ambient lighting: Pedestal lighting (night light); RGB lighting rear - ceiling; Open bathroom: RGB lighting in baldachin; Classic bathroom: LED band side wall and ceiling
102497 Gutter with LED lighting
Item no.
210040 STYLING-PACKAGE I
201788 Front bumper sprayed in vehicle colour
201815 Alloy rims with standard tyres
Item no.
210006 MEDIA-PACKAGE 2 kg
252143 Radio DAB+, All-in-One navigations system with camping software, without CD/DVD-drive, antenna, 3 years map update
251793 Rear-view backup camera incl. Cabling
252715 Headup Display
Item no.
214118 E-PACKAGE
252625 Reading lamp “Swan’s Neck” with 2 USB slots; ceiling wardrobe at front left
252161 2 pcs. reading lamps (driver's cab)
250072 2 pcs. 230 V sockets in ceiling wardrobe front left
250940 2 pcs. 230 V power sockets rear garage
251248 2. board AGM battery
Item no.
210018 CARE-DRIVE PACKAGE
202150 Tyre pressure sensors
202710Safety Pack Fiat (consists of: Full Brake Control, Lane Departure Warning System, High-Beam Recognition Traffic Signs Recogniction and Rain & Dusk)
202164 Rain and light sensors
Item no.
210065 TV PACKAGE 21,5"
252605 Complete antenna system Oyster 60 Premium Twin incl. 21,5” LED-TV (living area)
252405 TV holder (living area) - incl. combi socket
15
KNAUS BOXLIFE – Optional equipment
KNAUS BOXLIFE – Motorization KG 540MQ 600MQ 600ME 600 DQ 630ME
BASE VEHICLE 88 kW/120 PS 3.300 kg
88 kW/120 PS 3.300 kg
88 kW/120 PS 3.300 kg
88kW/120 PS 3.500 kg / Light
88kW/120 PS 3.500 kg / Light
Motorization2.3 l 140 Multijet with front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (103 kW/140 PS) • • • • •
2.3 l 160 Multijet with start-stop system incl. smart alternator; front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (118 kW/160 PS) • • • • •
2.3 l 180 Multijet with start-stop system incl. smart alternator; front-wheel drive, 6-speed manual gearbox; EURO 6d-Temp (130 kW/178 PS) • • • • •
Weights
3.500kg Light Chassis instead of 3.300 kg light chassis • • X • •
3.500kg Maxi Chassis instead of 3.300 kg light chassis (from 103 kW/140 PS) 40 – • – • •
3.500kg Maxi Chassis instead of 3.500 kg light chassis (from 103 kW/140 PS) 40 – – • – –
4.000kg Maxi Chassis instead of 3.300 kg light chassis (from 103 kW/140 PS) 40 – – – – –
Description: • = option | – = not available | X = standard
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
Gearbox202711 9-speed torque converter automatic transmission
instead of 6-speed manual transmission (only in conjunction with Fiat package, not possible with 120hp engine, 140hp engine only possible with Fiat ECO package, option 202756)
17 • • • • •
Chassis / Load increase202132 16" steel rims instead of 15" - only
possible with 3,5 t light– • • • •
201815 STYLING I+II Alloy rims with standard tyres -only in combination with Fiat Packages
4 • • • • •
202568 17" alloy wheels including tyres (235/60R17), front polished in black gloss in exclusive KNAUS Design
6 • • • • •
202569 17" alloy wheels including tyres (235/60R17), painted in titanium metallic in exclusive KNAUS Design
6 • • • • •
202572 Complete wheelset aluminium rim black glossy with 255/55 R18 tyres (only for Heavy Chassis)
– • • • •
202573 Complete wheelset aluminium rim sterling silver with 255/55 R18 tyres (only for Heavy Chassis)
– • • • •
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
202451 Complete wheelset aluminium rim 18" black glossy with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • •
202248 Complete wheelset aluminium rim 18" sterling silver with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • •
202765 Complete wheelset aluminium rim 18" mistral antracit glossy with all-season tyres 255/55 R18 tyres (winter approval, only for Heavy Chassis)
– • • • •
202060 Dual circuit air spring set - increased driving comfort --> no upweighting!
15 • • • • •
202766 Screw spring set rear axle - Optimizes the chassis --> no upweighting!
4,5 • • • • •
201041 Trailer hitch, rigid, incl. electronic installation 18 • • • • •202061 Trailer hitch, ball head removable, incl.
electronic installation (lockable)18 • • • • •
351932 Webasto auxiliary heating (Fiat) 5 • • • • •200601 Chassis in metallic painting: Silver (aluminum gray),
Fer gray, Profondo red, Golden white, Lago blue, black,1 • • • • •
200601 Chassis in special paint Campovolo grey 1 • • • • •
16
KNAUS BOXLIFE – Optional equipment
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
other chassis painting options free of charge (not metallic): Tiziano Red, Imperial Blue, Line Blue
• • • • •
202140 STYLING II Spoiler lips in aluminium look (skid plate) – • • • • •201788 STYLING I+II Front bumper sprayed in vehicle colour 3 • • • • •201199 Mudflaps, front 1 • • • • •201198 Mudflaps, rear 1 • • • • •
Transport systems100597 Bike rack for 2 bikes (rear door) 6 • • • • •102714 Bike rack Thule Veloslide incl. mounting rails – – • – •
Assistance systems200567 FIAT Cruise Control 0,8 • • • • •202150 CARE-DRIVE Tyre pressure sensors • • • • •202710 CARE-DRIVE Safety Pack Fiat (consists of: Full Brake Control, Lane
Departure Warning System, High-Beam Recognition Traffic Signs Recogniction and Rain & Dusk)
• • • • •
201787 Traction control, Traction Plus 1 • • • • •201062 Parking assistant 1 • • • • •202762 FIAT cross traffic and lane change assistant • • • • •
Inside550990 FUNLINE Driver's cab blackout blind with foldable
front and side window blinds4 • • • • •
200176 FIAT Air conditioning for driver's cab, manual incl. pollen filter with outside temperature display
18 • • • • •
200980 Air conditioning for driver's cab, automatic incl. pollen filter with outside temperature display
21 • • • • •
201686 Air conditioning for driver's cab, automatic, extra charge against manual air conditioning for driver's cab, with outside temperature display (in FIAT package)
21 • • • • •
200501 FIAT Airbag for passenger side 2 • • • • •201952 FIAT Height-adjustable passenger seat – • • • • •201519 Leather steering wheel with leather gear shift knob – • • • • •202478 FIAT Steering wheel with radio operating panel • • • • •201843 Instrument panel in Lounge design (bronze) 1 • • • • •201857 Instrument panel in Techno design (alu) 1 • • • • •201074 Footmat set, driver's cab, with KNAUS logo 1 • • • • •202392 Seat heating for driver's seat (also
possible with authentic leather)• • • • •
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
Lighting / Technology200178 Fog lamp 1 • • • • •202138 STYLING II Radiator grill in FIAT shiny black – • • • • •202139 STYLING II Headlights in black frame – • • • • •202137 STYLING II LED day running light – • • • • •202712 Fuel tank 90 ltr. instead of 75 ltr. • • • • •201609 Rear view mirrors fold in electrically 1 • • • • •200488 FIAT Rear view mirrors, electrically adjustable and heatable – • • • • •202756 Fiat ECO-Pack consisting of: Start-Stop system incl.
smart alternator (only possible with 140hp engine)– • • • • •
201165 Dead-Lock function for central locking – • • • • •202416 Fiat alarm system incl. 2. key with remote 1 • • • • •550592 Front window - insulation mat set 2 • • • • •
Multimedia / Navigation252143 MEDIA
PACKAGERadio DAB+, All-in-One navigations system with camping software, without CD/DVD-drive, antenna, 3 years map update
1 • • • • •
250599 FUNLINE Radio preparation for living area (cable laid incl. 2 loudspeakers)
1 • • • • •
252715 MEDIA PACKAGE
Headup Display (only possible with package 210006) • • • • •
BodyWindows, doors, ventilation
101080 FUNLINE Entry step, electric, 70 cm wide 8 • • • • •101982 Seitz S7P frame window at back rear,
80x40 cm, incl. sliding door stop4 – • X • X
101981 Seitz S7P frame window at left rear, 80x40 cm 4 • • X • X102020 Curtain window (50 x 50 cm cut-out size) instead
of frame window for rear doors (limited aperture)– • • • • •
100750 Midi Heki instead of the front roof hatch - Air conditioning omitted
2 • • • • •
102619 Third roof hatch (400 x 400 in vehicle center) - not possible in comibnation with SAT system and en suite bathroom
– • • • •
17
KNAUS BOXLIFE – Optional equipment
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
INTERIOR FITTINGSLiving/Sleeping
551983 Semi-dinette with single seats instead of seat bench incl. 2x Isofix (3-point system)
25 • • • • •
551994 Spare bed, lateral (180x70 cm) with additional cushion 8 • • • • •552517 Classic front loft bed, manual (no ceiling cupboards in
dinette – no storage compartment over the driver cabin!)– – – X •
552256 Vario front loft bed, manual (no ceiling cupboards in dinette – no storage compartment over the driver cabin!) (excludes option 551994)
30 – – – – •
552516 Vario front loft bed instead of Classic front loft bed (excludes option 551994)
– – – • –
552159 Electric drive for vario front loft bed 2 – – – • •552574 Fixed bed with EVOPORE HRC mattress
incl. WaterGEL pad (not possible with front lifting beds and additional beds)
7 • • • • •
552529 Rear bunk bed below (= additional bed underneath rear bed)
• • • • •
Upholstery and textiles552188 Upholstery design Active Rock, incl.
seat covers for driver's cab seats– • • • • •
551509 Leather design "Las Vegas", incl. seat covers for driver's cab seats
• • • • •
550660 COZY HOME package includes: 2 decorative cushions, 2 sleeping pillows, 2 blankets, 1 table runner
3
EARTH • • • • •STONE • • • • •AVOCADO • • • • •AQUA • • • • •MAGNOLIA • • • • •PEACH • • • • •
Gas/Heating/Air conditioning352379 Electric heater for Truma Combi 6 • • • • •550825 Electric floor heating 5 • • • • •352059 FUNLINE CP-Plus digital heating control panel – • • • • •352380 FUNLINE Truma iNet system (only possible with option 352059) • • • • •552540 Dometic air conditioning Freshjet 1700
(rear) - Roof hatch rear omitted• • • • •
450740 FUNLINE Waste water tank insulation hood - heated 3 • • • • •
Item n°in
package Description • = option | – = not available | X = standard KG 540M
Q
600M
Q
600M
E
600
DQ
630M
E
Kitchen area402602 Compressor refrigerator 150 Ltr. with 30l
froster compartement (wardrobe omitted)8 • • – • •
102577 Matching multifunctional bag in KNAUS design as an extension to the front-mounted kitchenette
• • • • •
Water supply / Sanitary452258 En suite bathroom instead of compact ba-
throom (depending on layout with wardro-be) - not possible with option 102619
• • • • •
452678 Rear shower (extendable spray in rear bed, in front of right rear door)
• • • • •
452718 FUNLINE Water filter system "BWT - Best-Camp mini" • • • • •
Electric302494 Gas alarm • • • • •252605 TV-PACKAGE Complete antenna system Oyster 60
Premium Twin incl. 21,5” LED-TV (living area) (only possible with option 252405)
• • • • •
252405 TV-PACKAGE TV holder (living area) - incl. combi socket 2 • • • • •251948 Cable, preinstalled for solar and satellite systems 1 • • • • •252161 E-PACKAGE Reading lamp in driver´s cab • • • • •251248 E-PACKAGE Auxiliary AGM on-board battery 20 • • • • •252698 GPS tracker 1 • • • • •
Awning501646 FUNLINE Awning for 540/600/630 layout
plans (length-dependent!)20 // 29
• • • • •
18
KNAUS BOXDRIVE – Technical Data * 680 ME
VW BASIC ENGINEECrafter 35 Kasten HD Motor: 2,0 l TDI; Euro 6d-Temp; 103 kW SG6 X ¹)
CHASSISLength cm 684Width cm (outer/inner) 243/204Height cm (outer/inner) 172
268/192
Mass in running order (kg)* 3.125Tecnically maximum authorized laden mass (kg)* 3.500Maximum payload (kg)* 375
Permitted towing load (kg)* 3.000 (max. 6000 kg total train weight)
Tyres / spare wheel / rims 235/60R17 / 6,5Jx17"Wheelbase (mm) 449Turning circle (m) 16,2
Seats with safety belt (Number of persons in driving operation) 4 4)Beds up to 3
BOXDRIVE
Technical data
KNAUS BOXDRIVE – Technical Data * 680 ME
EXTERIORWindows / doors / ventilationSeitz S7P frame windows with blinds and mosquito protection 7Wet cubicle window XRoof light Midi-Heki (700x500 mm) / Mini-Heki (400x400 mm) 1 | 1Mushroom vent Toi-Room X
INTERIORLiving / sleepingBed size, rear (cm) 197x95 / 212x83Bed size, spare bed on semi-dinette and driver's seat (cm) 160x60 ²)
Gas / heating / water / climateGas locker for gas bottle reserves for (in kg) 3Heating (incl. 10 ltr. hot water supply) Truma Combi 6 DFresh water tank, built-in (volume in liters) 20**/110*** Waste water tank, built-in under floor (liters) 85
KitchenCUV Compressor refrigerator, incl. 6,5 ltr. freezer compartment pluged above level (liters) 90
Toi-RoomEn-suite bathroom with shower cubicle and separate shower faucet XToilet unit Dometic TD 4110
X Standard equipment¹) Load increase at the factory with screw spring set* Please note the section „important information“ on page 24
** fresh water tank capacity limited to 20 ltr. by overflow valve (recommended driving fill level)*** fresh water tank capacity is 110 ltr. with the overflow valve closed
²) Spare bed, 178x80/70cm, at the front, available as option³) Option 4) Number of persons during the trip depends on the additional equipment
19
KNAUS BOXDRIVE – Standard equipment
VW CrafterChassis
• Crafter 35 Kasten HD Motor: 2,0 l TDI; Euro 6d-Temp; 103 kW SG6• front-wheel drive• Airbag for passenger side• Painting: Candy White• Uni colors (VW) without addition charge (Metallic/special colors for extra
charge)• Front axle, strengthened (Axle load 2.100 kg, with twin wheels 2.200 kg)• Suspension/damping, standard and stabilisation, strengthened• Construction port• Front bumper in grey with sprayed cover• Radiator grill with 3 chrome strips• Side wind assistent• 6 gear manual transmission• Hill holder• Fuel tank with 75 ltr. tank volumne; AdBlue about 18 ltr.• Fog lights with turning light• Electronic stabilistation program• Rear view mirrors right and left, convex, with integrated LED flashlight
and wide angle area• Electrical window winder• Power steering with electronic immobiliser• 2 radio folding keys• Wheel center covering chrome badge• Radio preparation• Multifunction display "Plus"• Central locking with radio remote control and indoor use• Glove compartment with lockable flap, lighted• Airbag for driver and passenger side with passanger airbag deactivation• Rotatable passanger and driver chair (incl. Storable handbrake lever)• Dressing material, warning triangle and safety vest
Car body• Seitz S7P frame window all round (incl. bathroom window and rear
window)• Roof hoods: Midi-Heki (700 x 500 mm) + roof hatch (400 x 400 mm) • Insect screen door sliding door
Isolation• Isolation without cold bridges• Polyethylene foam closed cell content on side walls and ceiling• Floor plate, sandwich construction made of 12 mm Styrodur, poplar
plywood and PVC coating• Fabric-laminated side wall claddings (automotive integrated combi-
rollos)
Furniture design• Full body construction for more stability/solidity• Additional interior noise damping measures• Worktop kitchen + table seating group + washstand in HPL (laminate)• Furniture hinges with spring reinforcement and softclose• Drawers, flaps and doors fitted flush in furniture body• Kitchen Drawers open fully with ball bearing guides• Lateral kitchen function flap• Ceiling cupboards with handles, rocker arms and softclose• Full-length wardrobe with adjustable intermediate floor• Automotive storage compartment covering• Open shelves in the kitchen (with indirect LED lighting) and storage
compartment (with integrated 12/230V socket)• Charging booster for body battery
On-board technology• CUV compressor refrigerator 90 ltr. with night reduction for reduced
engergy consumption and noice reduction• 2-flame hob with divided glass cove and sink with cover in worktop
surface• 1 x 3 kg gas bottle locker• Diesel heater with boiler: Truma Combi 6D• AGM on-board battery (95 Ah)• 2. battery with isolationg relay and battery control• 8 channel light control• 4 x 12V sockets in driver's cab• LED lighting all round• Water lines routed alongside air recirculation hose > frost-resistant• Shower tray with 3 drains• Toilet unit rotatable• KNAUS operationg panel incl. distributor box: Basic• Radio compostion audio with mobile port
Comfort• Upholstery "Memphis" with ergonimic form• Other upholstery: CASUAL SILVER• Dinette seat bench with side pull-out and three-stage Lounge function,
also during the journey• Dinette table with open access (floating table) can be rotated out;
includes a double table top• Comfort blind system• Variable spacious bathroom with shower cabin • Bi-functional washbasin | Postion 1: washbasin, Position 2: ergonimic
washstand• Two-layer cold foam mattresses• Extendable steps for easier access to bed• Central, easily accessible equipment and supply installation• Kitchen worktop with foldable extenstion• Intelligent storage concept• Lashing eyes for load securing• LED luggage compartment lighting system incl. apron lighting when rear
door is open• Chrome package interior
20
KNAUS BOXDRIVE – Packages
Item no.
215200 Crafter package
222633 Air conditioning "Climatic"
222631 Rear view mirrors, electrically adjustable and heated
222632 Cruise control incl. speed limiter
Item no.
215210 BoxDrive package
101080 Electrical entrance step
250599 Radio cabling incl. additional speakers living area
352059 CP-Plus control panel
352380 Truma iNet system
452652 Waste water tank with interior insulation and E-heating cartridge
552637 Blackout curtain with thermo function
452718 Water filter system "BWT - Best-Camp mini"
Front- und Seitenscheibenverdunklung REMIfront IV-System (verfügbar ab Q1 2020)
Item no.
215225 Media Van package navigation
222657 SD card (Europe)
222641 Rear view camera
222640 Car-Net Guide & information, duration 3 years (fixed installed OCU with own card)
222642 Digital radio reception (DAB+)
222648 Multifunctional steering wheel (3 spokes)
222643 Navigation system "Discover Media", 8" touchscreen, 4 speakers, mobile phone port, app connect
Item no.
215220 Engery-Plus package
250072 Additional 230V socket - interior
251248 2. AGM battery in rear garage
250940 Additional 12V socket - interior
252654 Touch-CI-Bus multifunksjonelt panel med diverse sensorer
232667 Intelligentes Ladegerät mit 25A Ladeleistung
251757 Battery sensor (board battery)
Item no.
215215 Styling package
222638 LED main headlights with LED daytime driving lights
202568 17" alloy wheels including tyres (235/60R17), front polished in black gloss in exclusive KNAUS Design
222639 Rear view mirrors hinged
Item no.
210002 TV PACKAGE 21,5"
252605 Complete antenna system Oyster 60/65 Premium Twin incl. 24” LED-TV (living area)
252405 TV holder (living area) - incl. combi socket
252479 Pre-cabling for TV (bed area)
21
Item no.
215230 Media Van package navigation - PLUS
222657 SD card (Europe)
222641 Rear view camera
222640 Car-Net Guide & information, duration 3 years (fixed installed OCU with own card)
222642 Digital radio reception (DAB+)
222648 Multifunctional steering wheel
222643 Navigation system "Discover Media", 8" touchscreen, 4 speakers, mobile phone port, app connect
222645 Rain sensor
222644 Traffic sign recognition
KNAUS BOXDRIVE – Packages
Item no.
Assistance systems:
222646Parking assistant "Park Assist" and ParkPilot, front and rear end with active side protection - only possible with Media Van package Navigation
Item no.
Assistance systems:
222647Trailer manoeuvre assistent, parking assistant and ParkPilot with active side protection - only possible with Media Van package Navigation and hitch
Item no.
222649 Driver assistance package 1
Cruise control incl. speed limiter
Drowsiness detection
Lane-departure warning "Lane Assist"
Multifunctional steering wheel (3 spokes)
Multifunktion display "Plus"
Item no.
222650 Driver assistance package 2
Automatic distance control ACC up to 160 km/h incl. cruise control
Drowsiness detection
Lane-departure warning "Lane Assist"
"Front Assist" with city emergency brake function (for automatic distance control ACC up to 160 km/h)
Multifunctional steering wheel (3 spokes)
Multifunktion display "Plus"
Item no.
222651 Driver assistance package 3
Rear view camera
Multifunctional steering wheel (3 spokes)
"Front Assist" with city emergency brake function (for automatic distance control ACC up to 160 km/h)
Rear view mirrors, electrically adjustable and heatable
Lane-departure warning "Lane Assist" incl. Blind spot sensor with maneuvering assistant
Dynamic Light Assist
Daytime running light with headlights system (automatic), "Leaving Home" function and manual "Coming Home" function
Wiper interval switching with light and rain sensor
Automatic distance control ACC "followto stop" up to 160 km/h incl. cruise control
Multifunktion display "Plus"
Trailer manoeuvre assistent, parking assistant and ParkPilot with active side protection
22
KNAUS BOXDRIVE – Motorization 680 ME
BASIC VEHICLE
Motorization optionalCrafter 35 Kasten HD Motor: 2,0 l TDI; Euro 6d-Temp; 130 kW SG6 •
KNAUS BOXDRIVE – Options
KNAUS BOXDRIVE – Options
• optional
Item n° in package Description • = option | – = not available | X = standard KG
BASE VEHICLE
Gearbox
222535 8 speed automatic gearbox
Chassis / Load increase
202568 STYLING 17" alloy wheels including tyres (235/60R17), front polished in black gloss in exclusive KNAUS Design
10
202569 17" alloy wheels including tyres (235/60R17), painted in titanium metallic in exclusive KNAUS Design
10
222553 Load increase to 3,85t
222552 Dual circuit air spring set - load increase to 4,0t möglich 10
222656 Hitch, detachable and lockable (incl. trailer stabilization)
232676 Auxiliary heaters
232664 Verbundglas-Frontscheibe in Wärmeschutzverglasung, beheizbar 1
232665 Washer jets front, heatable -
232660 Metallic painting
222677 Special painting - Deep Black pearl effect
Transport sytems
102502 Bike rack for 2 bikes
Item n° in package Description • = option | – = not available | X = standard KG
Assistance systems
222646 Parking assistant "Park Assist" and ParkPilot, front and rear end with active side protection - only possible with Media Van package Navigation
222647 Trailer manoeuvre assistent, parking assistant and ParkPilot with active side protection - only possible with Media Van package Navigation and hitch
232663 High-beam assistant "Light Assist" (only possible with option 222645)
232680 Automatic distance control ACC up to 160 km/h incl. cruise control
222632 CRAFTER Cruise control incl. speed limiter
222645 Windscreen wiper interval circuit with rain sensor and automatic driving light circuit
-
222644 MEDIA VAN NAVIGATION
PLUS
Traffic sign recognition
232659 Detecting tiredness -
222645 MEDIA VAN NAVIGATION
PLUS
Rain sensor
232661 Tyre pressure monitoring
Inside
552777 Front and side window blackout REMIfront IV system (available from Q1 2020) instead of 552637 Blackout curtain with thermo function
552768 Front and side window blackout REMIfront IV system (available from Q1 2020) in addition to 552637 Blackout curtain with thermo function
222633 CRAFTER Air conditioning "Climatic" 11
232669 Air conditioning "Climatronic" instead of air conditioning "Climatic" (only in conjunction with Crafter package)
1
222648 MEDIA / MEDIA PLUS
Multifunctional steering wheel (3 spokes) -
232671 Multifunctional steering wheel (3 spokes), heatable -
232670 Storage package 2: Roof gallery with two 1-DIN shafts and reading lamp
11
202392 Seat heating, left and right, separately controllable 1
222679 Smoking package
23
KNAUS BOXDRIVE – Options
Item n° in package Description • = option | – = not available | X = standard KG
Lighting / Technology
222638 STYLING LED main headlights with LED daytime driving lights 5
222631 CRAFTER Rear view mirrors, electrically adjustable and heated 1
222639 STYLING Rear view mirrors hinged
222635 Spare wheel (steel rim) with driving tyre, tool kit and car jack 37
232662 Battery master switch -
Multimedia / Navigation
222642 MEDIA / MEDIA PLUS
Digital radio reception (DAB+) -
250599 BOXDRIVE Radio cabling incl. additional speakers living area
222640 MEDIA / MEDIA PLUS
Car-Net Guide & information, duration 3 years (fixed installed OCU with own card)
222643 MEDIA / MEDIA PLUS
Navigation system "Discover Media", 8" touchscreen, 4 speakers, mobile phone port, app connect
222641 MEDIA / MEDIA PLUS
Rear view camera
Body
Windows, doors, ventilation
222636 Illuminated entrance step, can be turned off in the front
101080 BOXDRIVE Electrical entrance step 8
INTERIOR FITTINGS
Living/Sleeping
201074 Footmat set, driver's cab, with KNAUS logo 1
552637 BOXDRIVE Blackout curtain with thermo function
551994 Spare bed, lateral (180x80 cm) with additional cushion 8
552574 Fixed bed with EVOPORE HRC mattress incl. WaterGEL pad
552703 Innovative folding bed function
Upholstery and textiles
552188 Upholstery design Active Rock, incl. seat covers for driver's cab seats -
551509 Leather design "Las Vegas", incl. seat covers for driver's cab seats -
Item n° in package Description • = option | – = not available | X = standard KG
Gas/Heating/Air conditioning
450740 Waste water tank insulation hood - heated 3
452652 BOXDRIVE Waste water tank with interior insulation and E-heating cartridge
352380 BOXDRIVE Truma iNet system
352059 BOXDRIVE CP-Plus digital heating control panel -
Water supply / Sanitary
452678 Rear shower (extendable spray in rear bed, in front of right rear door)
452718 BOXDRIVE Water filter system "BWT - Best-Camp mini"
Electric
252653 Ambient light (kitchen worktop, ceiling cupboard front, ceiling cupboard frieze towards the roof, light over mirror with switch contact); base light (night light); RGB light in the T-room canopy
252605 TV- PACKAGE Complete antenna system Oyster 60 Premium Twin incl. 21,5” LED-TV (living area) (only possible with option 252405)
252448 21,5" TV unit with HD tuner incl. TV holder (bed area) 9
252405 TV- PACKAGE TV holder (living area) - incl. combi socket 2
252479 TV- PACKAGE Pre-cabling for TV (bed area)
251261 TV holder (bed area) incl. combi socket (not possible with 552703) 2
252654 E-PLUS Touch control panel with intuitive operating concept 2
251248 E-PLUS Auxiliary AGM on-board battery 20
Awning
501247 Awning 4m
Art.-Nr. R08116499-EN
-INT
Important Information
KNAUS TABBERT GMBHHelmut-Knaus-Straße 1 . 94118 Jandelsbrunn . Germany
Become a member of the KNAUS community and join in:facebook.knaus.comshop.knaus.com
FOR CARAVANS, MOTORHOMES, CUV MADE BY KNAUS, WE GRANT YOU A 10-YEAR LEAK-PROOFNESS GUARANTEE ON THE BODY MANUFACTURED BY US IN ADDITION TO YOUR COMPULSORY GUARANTEE WITHIN THE FRAMEWORK OF OUR GUARANTEE CONDITIONS.
PLEASE READ THE FOLLOWING IMPORTANT NOTES FOR ALL KNAUS MOTORHOMES/CUV:
All Dimensions and weight data may vary ca.+/–5% due to tolerances of the natural raw materials used.With any modifications done on the vehicle by a non-authorized dealer or garage you may put at risk your personal security and lose KNAUS operating licence and warranty. Therefore please leave reperations and retrofits to the authorized KNAUS dealers and insist on KNAUS original equipment.Retrofittings, if technically possible, will cause additional mounting and material costs. In exceptional cases some combinations of extras and options may occur as mutually exclusive. We reserve the right to any technical modifications as to design, colour, and equipment, if technical improvement requires us to do so.The images partly show optional equipment which is delieverd with extra charge.The contents of this list reflect arrangements at printing, in 07/2019.The price list is valid as from 01.08.2019 for the 2020 model year. With publication of this price information previous price lists are no longer valid. Previous lists are no longer valid. We reserve the right to change content at our discretion.
The water supply system is minimum state of the art (03/2009) (Regulation 2002/72/EG).
Explanations on the weight data for your KNAUS motorhome/CUV: KNAUS motorhomes are characterised by their technical progress. Through innovative solutions such as the use of high-strength steels for the chassis or intelligent honeycomb technology in furniture construction, low tare weights of the KNAUS motorhomes are created.The mass of the empty vehicle as referred to in the price list is the mass of the vehicle with standard equipment and without basic equipment, i.e. without „ liquids“ and without optional fittings as referred to in art. 2, ciff. 3 VO (EU) 1230/2012.Mass in running order, see Articel 2, ciff. 4 a) VO (EU) 1230/2012, unless nothing different is regulated, is defined as follows:Mass of the vehicle with standard equipment as referred to in manufacturer specifications (incl. tool kit): + Fuel tank (filled to 90%) + 75 kg (mass of the driver) + Aluminium liquid gas bottles (11 kg) filled to 100% (i. e. 18 kg total mass) + Fresh water tank (filled to 100%) (Capacity fo the Fresh water tank
depending on vehicle type is limited to 10 ltr.***/20 ltr.**/40 ltr.** fresh water in running order, if not tecnically regulated)
+ Toilet flush tank (100 % full) + Fresh water boiler filled to 100% = Mass in ready-to-start mode
** The fresh water tank capacity referred to attachment V, part A, ciff. 2.6. Fn. VO (EU) 1230/2012 depending on vehicle type is limited by a circulation valve to 10, 20 or 40 ltr. (suggested filling for running order)
The „permissible total mass“ see Articel 2, ciff. 7 VO
(EU) 1230/2012 is defined as follows:The mentioned vehicle‘s maximum mass from the manufacturer in loaded state.
The maximum permissible payload as referred to in the KNAUS catalogue is defined as:Tecnically authorized total mass - mass in running order = maximum permissible payload
Example:(Tecnically authorized total mass) 3.500 kg- (Mass in running order) 2.850 kg= (Maximum permissible payload) 650 kg
The information on vehicles provided under the heading „Technical data / Equipment details“ refers initially to the basic model approved under the EC type-approval procedure. These figures may vary in country variants and special models. Please seek information on such deviations personally at your authorised KNAUS dealer.
Pay particular attention to the following aspects: The maximum load capacity in accordance with the catalogue specifications is reduced, for example, by the mass of passengers and also by the mass of additional equipment ordered.When choosing additional equipment, you are responsible for ensuring that your KNAUS motorhome/CUV still has a minimum loading capacity (=minimum payload) after deduction of the mass of the passengers (estimated at 75 kg per passenger) and the mass of the additional equipment from the maximum loading capacity, which must not be undercut under any circumstances (cf. Annex I, Part A, no. 2.6.4.1.2 VO (EU) 1230/2012):
(Maximum number of authorised passengers plus driver + total length of the vehicle in metres) x 10 = Minimum loading capacity in kg.
Example - calculation of the minimum payload:[(Maximum number of authorised passengers plus driver) 4 + (Total length of vehicle in metres) 6] x 10 = 100 kg.
As the buyer of the vehicle, you are obliged to comply with the minimum payload. If the vehicle you wish to order does not have the required payload capacity and minimum payload due to the optional equipment selected, you have two options to choose from for your order: - Increasing the load of the vehicle - De-selecting optional equipment
For certain motorhome models made by KNAUS and models with alcove made by KNAUS, you have the option of reducing the number of permitted seats in the vehicle when ordering (depending on the model and only
on demand). Reducing the number of permitted seats in operation by one seat increases the load capacity or the possibility of ordering additional equipment for your motorhome by a maximum of 85 kg.
Your KNAUS dealer will inform you at any time upon request how large the remaining minimum payload of your vehicle is.
The mass of the vehicle with standard equipment according to manufacturer specifications is determined through weighing of the vehicle with standard fitting.
As a user of a motorhome, you are obliged not to exceed the „technically permissible total mass“ and the respective maximum axle loads when driving and to ensure a corresponding axle load-dependent load distribution. You are also obliged to comply with all other regulations that are necessary for the safe operation of your vehicle.
Ordering optional equipment which substitutes specific package options will not be delivered additionally.
The details regarding delivery scope, dimensions and weight as well as in terms of appearance are in line with the understanding at the time of printing (07/2019). We reserve the right to make changes to the equipment, technical details, the series scope and the prices. After a contract has been concluded, we reserve the right to make technical changes within the framework of the construction insofar as they serve technical progress and are acceptable for the customer. Minor colour and texture deviations are also reserved - even after conclusion of the contract - insofar as these cannot be avoided due to the material (e.g. colour deviations of up to approx. 2.0 dE between paint on sheet metal and paint on GRP/plastic) and are reasonable for the customer.
Some of the illustrations show optional equipment that is available at an extra charge or equipment features of prototypes/studies that do not conform to the serial status and in some cases will not be available as optional equipment. Colour deviations are print-technically possible.
Therefore, before purchasing a vehicle, please seek comprehensive advice on the current status of the series from an authorised dealer. The decoration shown in the catalogue is not part of the equipment supplied.
Please also note the comments in the current price list, in particular on weights, payload options and tolerances. Reprinting, even in extracts, is only permitted with the prior written permission of Knaus Tabbert GmbH.
We reserve the right to change content at our discretion.