ENCLOSED IS SUBMITTAL DATA FOR THE … Plus/Calabasas HS Submittals - Splits.pdf · ENCLOSED IS...
-
Upload
nguyenhuong -
Category
Documents
-
view
220 -
download
1
Transcript of ENCLOSED IS SUBMITTAL DATA FOR THE … Plus/Calabasas HS Submittals - Splits.pdf · ENCLOSED IS...
Carrier Direct Sales 3050 Enterprise St.
Brea, CA 92821
(P) 714-985-5200 (F) 714-985-5336
www.commercial.carrier.com
EQUIPMENT SUBMITTAL
JOB NAME: CALABASAS HS PERFORMING ARTS CENTER
JOB LOCATION: CALABASAS, CA
ENGINEER: JAYCO
CUSTOMER: AIR PLUS CORP
ADDRESS: 15537 CABRITO ROAD VAN NUYS, CA 91406
PREPARED BY: KYLE HEINSEN
DATE: 12/22/10
REVISION #: 0
ENCLOSED IS SUBMITTAL DATA FOR THE FOLLOWING EQUIPMENT:
Qty Model Number Description
2 25HBB318A003 13 SEER Heat Pump with Puron, 1.5 Tons Cooling, 208/230-1-60 Mark For: CU-1.5-1,1.5A-1 Field-Installed Accessories ♦ Low Ambient Pressure Switch ♦ Start Assist – Capacitor and Relay ♦ Crankcase Heater ♦ Evaporator Freeze Thermostat ♦ Isolation Relay ♦ Hard Shutoff TXV
2 25HBB336A003 13 SEER Heat Pump with Puron, 3 Tons Cooling, 208/230-1-60 Mark For: CU-3A-1,3-2 Field-Installed Accessories ♦ Low Ambient Pressure Switch ♦ Start Assist – Capacitor and Relay ♦ Crankcase Heater ♦ Evaporator Freeze Thermostat ♦ Isolation Relay ♦ Hard Shutoff TXV
1 FB4CNF018000 Direct Drive Fan Coil Unit, 1.5 Tons Cooling, 208/230-1-60
Mark For: FC-1.5-1 1 FB4CNF036000 Direct Drive Fan Coil Unit, 3 Tons Cooling, 208/230-1-60
Mark For: FC-3-2
25HBB3Base 13 Heat Pumpwith Puronr Refrigerant1---1/2 to 5 Nominal Tons (Sizes 18 to 60)
Product Data
the environmentally sound refrigerant
Carrier heat pumps with Puronr refrigerant provide a collection offeatures unmatched by any other family of equipment. The 25HBBhas been designed utilizing Carrier’s Puron refrigerant. Theenvironmentally sound refrigerant allows consumers to make aresponsible decision in the protection of the earth’s ozone layer.As an Energy Starr Partner, Carrier Corporation has determinedthat this product meets the Energy Starr guidelines for energyefficiency. Refer to the combination ratings in the Product Data forsystem combinations that meet Energy Starr guidelines.NOTE: Ratings contained in this document are subject tochange at any time. Always refer to the AHRI directory(www.ahridirectory.org) for the most up--to--date ratingsinformation.
INDUSTRY LEADINGFEATURES / BENEFITSEfficiencyS 13 SEER/ 10.1 -- 10.8 EER/ 7.7 -- 8.3 HSPF (nominal)S Microtube Technologyt refrigeration systemS Indoor air quality accessories available
SoundS Sound level as low as 72 dBAS Sound levels as low as 70 dBA with accessory sound blanket
ComfortS System supports Edger Thermidistatt or standard thermostatcontrols
ReliabilityS Puronr refrigerant -- environmentally sound, won’t deplete theozone layer and low lifetime service cost.
S Scroll compressorS Internal pressure relief valveS Internal thermal overloadS High pressure switchS Loss of charge switchS Filter drierS Balanced refrigeration system for maximum reliability
DurabilityWeatherArmort protection package:S Solid, durable sheet metal constructionS Dense wire coil guard availableS Baked--on powder paint
ApplicationsS Long--line -- up to 250 feet (76.20 m) total equivalent length, upto 200 feet (60.96 m) condenser above evaporator, or up to 80 ft.(24.38 m) evaporator above condenser (See Longline Guide formore information.)
S Low ambient (down to --20_F/--28.9_C) with accessory kit
3
PHYSICAL DATAUNIT SIZE SERIES 18---31 24---31 30---31 36---31 42---31 48---31 60---31
Operating Weight lb (kg)173(78.5)
173(78.5)
191(86.6)
192(87.1)
255(115.7)
265(120.2)
287(130.2)
Shipping Weight lb (kg)202(91.6)
202(91.6)
223(101.2)
224(101.6)
287(130.2)
297(134.7)
319(144.7)
Compressor Type ScrollREFRIGERANT Puron� (R---410A)
Control TXV (Puron Hard Shutoff)Heating Piston Size 42 46 55 57 61 61 76
Charge lb (kg)6.63(3.01)
6.58(2.98)
6.56(2.98)
7.57(3.43)
11.07(5.02)
11.3(5.13)
12.58(5.71)
COND FAN Propeller Type, Direct DriveAir Discharge VerticalAir Qty (CFM) 2611 2611 3810 3810 3810 4046 4046Motor HP 1/10 1/10 1/5 1/5 1/5 1/4 1/4Motor RPM 1100 1100 800 800 800 800 800
COND COILFace Area (Sq ft) 19.40 19.4 20.12 25.15 20.12 20.12 25.15Fins per In. 20 20 20 20 20 20 20Rows 1 1 1 1 2 2 2Circuits 5 5 5 6 6 8 8
VALVE CONNECT. (In. ID)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 7/8Liquid 3/8
REFRIGERANT TUBES* (In. OD)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 1---1/8Liquid 3/8
* For tubing sets between 80 and 200 ft. (24.38 and 60.96 m) horizontal or 20 ft. (6.09 m) vertical differential, consult the Longline Guideline.Note: See unit Installation Instruction for proper installation.
VAPOR LINE SIZING AND COOLING CAPACITY LOSSLONG LINE APPLICATION: An application is considered ”Longline” when the total equivalent tubing length exceeds 80 ft. (24.38m) or when there is more than 20 ft. (6.09 m) vertical separationbetween indoor and outdoor units. These applications requireadditional accessories and system modifications for reliable systemoperation. The maximum allowable total equivalent length is 250ft. (76.2 m). The maximum vertical separation is 200 ft. (60.96 m)
when outdoor unit is above indoor unit, and 60 ft. (18.3 m) whenthe outdoor unit is below the indoor unit. Refer to AccessoryUsage Guideline below for required accessories. See LonglineApplication Guideline for required piping and systemmodifications. Also, refer to the table below for vapor tubediameters based on the total length to minimize the coolingcapacity loss.
UnitNominal
Size (Btuh)
MaximumLiquidLine
Diameters(In. OD)
VaporLine
Diameters(In.) OD
Cooling Capacity Loss (%)Total Equivalent Line Length ft. (m)
StandardApplication Long Line Application Requires Accessories
26---50(7.9---15.2)
51---80(15.5---24.4)
81---100(24.7---31.5)
101---125(30.8---38.1)
126---150(38.4---45.7)
151---175(46.0---50.3)
176---200(53.6---60.0)
201---225(61.3---68.6)
226---250(68.9---76.2)
18,0001---StagePuron HP
3/8
1/2 1 2 3 4 6 7 8 9 10
5/8 0 0 1 1 1 2 2 3 3
24,0001---StagePuron HP
5/8 0 1 1 2 3 3 4 4 5
3/4 0 0 0 0 1 1 1 1 1
30,0001---StagePuron HP
5/8 1 2 3 3 4 5 6 7 83/4 0 0 1 1 1 2 2 2 37/8 0 0 0 0 1 1 1 1 1
36,0001---StagePuron HP
5/8 1 2 4 5 6 7 9 10 113/4 0 0 1 1 2 2 3 3 47/8 0 0 0 0 1 1 1 1 2
42,0001---StagePuron HP
3/4 0 1 2 2 3 4 4 5 6
7/8 0 0 1 1 1 2 2 2 3
48,0001---StagePuron HP
3/4 0 1 2 3 4 5 5 6 7
7/8 0 0 1 1 2 2 2 3 3
60,0001---StagePuron HP
3/4 1 2 4 5 6 7 9 10 117/8 0 1 2 2 3 4 4 5 5
1---1/8 0 0 0 1 1 1 1 1 1Applications in this area are long line. Accessories are required as shown recommended on Long Line Application GuidelinesApplications in this area may have height restrictions that limit allowable total equivalent length, when outdoor unit is below indoor unit See Long Line Applica-tion Guidelines
25HBB3C
7
ELECTRICAL DATAUNITSIZE---
VOLTAGE,SERIES
V/PHOPER VOLTS* COMPR FAN
MCA
MINWIRESIZE†
MINWIRESIZE†
MAXLENGTH(FT)‡
MAXLENGTH(FT)‡
MAXFUSE**or BRKAMPSMAX MIN LRA RLA FLA 60° C 75° C 60° C 75° C
18---31
208/230/1 253 197
48 9.4 0.8 12.5 14 14 63 60 2024---31 58.3 12.8 0.8 16.8 14 14 47 45 2530---31 77 15.2 1.2 20.2 12 12 62 59 3036---31 79 16.7 1.2 22.0 12 12 57 54 3542---31 109 21.3 1.2 27.8 10 10 72 68 4048---31 117 21.8 1.2 28.4 10 10 70 67 4060---31 134 26.3 1.2 34.1 8 10 91 56 50
* Permissible limits of the voltage range at which the unit will operate satisfactorily{ If wire is applied at ambient greater than 30_C, consult table 310---16 of the NEC (ANSI/NFPA 70). The ampacity of non---metallic---sheathed cable (NM),
trade name ROMEX, shall be that of 60_C conditions, per the NEC (ANSI/NFPA 70) Article 336---26. If other than uncoated (no---plated), 60 or 75_Cinsulation, copper wire (solid wire for 10 AWG or smaller, stranded wire for larger than 10 AWG) is used, consult applicable tables of the NEC (ANSI/NFPA70).
} Length shown is as measured 1 way along wire path between unit and service panel for voltage drop not to exceed 2%.** Time---Delay fuse.FLA --- Full Load AmpsLRA --- Locked Rotor AmpsMCA --- Minimum Circuit AmpsRLA --- Rated Load AmpsNOTE: Control circuit is 24---V on all units and requires external power source. Copper wire must be used from service disconnect to unit.All motors/compressors contain internal overload protection.Complies with 2001 requirements of ASHRAE Standards 90.1
A--WEIGHTED SOUND LEVEL (dBA)
UNIT SIZE --- VOLTAGE,SERIESSTANDARDRATING(dBA)
TYPICAL OCTAVE BAND SPECTRUM (dB, without tone adjustment)
125 250 500 1000 2000 4000 8000
18---31 74 51.5 61.5 67.0 68.5 66.5 63.5 58.524---31 74 53.0 62.0 68.0 70.5 67.0 63.5 59.030---31 75 56.0 62.0 66.5 71.5 66.0 62.0 54.536---31 75 50.5 61.5 65.0 71.0 65.0 61.0 54.542---31 75 59.5 63.0 66.5 71.0 67.0 62.0 55.548---31 79 57.5 64.5 67.5 71.5 73.0 64.5 58.560---31 80 57.5 59.0 65.5 71.5 74.0 63.0 57.5
NOTE: Tested in accordance with AHRI Standard 270---95. (Not listed with AHRI).
A--WEIGHTED SOUND LEVEL (dBA) WITH SOUND SHIELD
UNIT SIZE --- VOLTAGE,SERIESSTANDARDRATING(dBA)
TYPICAL OCTAVE BAND SPECTRUM (dB, without tone adjustment)
125 250 500 1000 2000 4000 8000
18---31 73 51.5 62.0 67.0 68.0 66.0 63.0 58.524---31 74 53.0 62.0 67.5 69.0 66.5 63.0 58.030---31 74 57.0 61.5 66.0 70.0 65.0 60.5 52.536---31 73 51.0 61.5 64.5 69.0 63.5 60.5 53.042---31 73 60.0 63.5 66.5 69.5 66.0 60.5 52.548---31 77 57.0 65.5 67.5 69.5 71.0 61.0 53.560---31 77 57.5 58.5 65.0 68.5 71.0 60.0 53.0
NOTE: Tested in accordance with AHRI Standard 270---95. (Not listed with AHRI).
CHARGING SUBCOOLING (TXV--TYPE EXPANSION DEVICE)UNIT SIZE --- VOLTAGE,SERIES REQUIRED SUBCOOLING ° F (° C)
18---31 8 (4.4)24---31 10 (5.6)30---31 10 (5.6)36---31 11 (6.1)42---31 11 (6.1)48---31 12 (6.7)60---31 11 (6.1)
25HBB3C
9
DIMENSIONS -- ENGLISH
B
3 13/16”
K
1 1/8”L
C 3 1/2”1 7/8”
N
P
M
E
F
G
A
208-230-1-60
230-1-60
208/230-3-60
460-3-60
UNIT SERIES ELECTRICALCHARACTERISTICSA B C D E F G K L M N P OPERATING
WEIGHT (lbs)SHIPPING
25HBB318 0 X O O O 25 3/4” 35 1/4” 3 3/4” 5/8” 4 7/16” 21 1/4” 9 1/8” 2 13/16” 1/2” 13 1/2” 14 1/2” 14” 148 174
25HBB324 0 X O O O 31 3/16” 28 15/16” 3 3/4” 5/8” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 15 5/8” 16 3/4” 14 1/2” 162 189
25HBB330 0 X O X O 31 3/16” 39 1/8” 3 3/4” 3/4” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 16 1/2” 15 1/2’ 17” 186 215
25HBB336 0 X O X X 35” 28 15/16” 3 3/4” 3/4” 6 9/16” 28 7/16” 9 1/8” 2 13/16” 1/2” 15 1/2” 15 3/4” 12 1/2” 172 207
25HBB342 0 X O X X 35” 39 1/8” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17 1/4” 19 1/8” 15 3/4” 246 278
25HBB348 0 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 240 273
25HBB360 0 X O O O 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282
25HBB360 1 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282
1824,30,36
36,42,48,60
AIRDISCHARGE
AIR DISCHARGE
SQ. AIR IN
VAPOR LINE CONN.D
3/8”LIQUID LINE CONN.
AIR IN
AIR IN
3/8” TIEDOWN KNOCKOUTS(2) PLACES
FIELD CONTROLSUPPLY CONN.
7/8” HOLE
FIELD POWER SUPPLY CONN.7/8” HOLE WITH
1 1/8” KNOCKOUT
X = YESO = NO
NOTES:
1. ALLOW 30” CLEARANCE TO SERVICE SIDE OF UNIT,48” ABOVE UNIT, 6” ON ONE SIDE, 12” ON REMAINING SIDE,AND 24” BETWEEN UNITS FOR PROPER AIRFLOW.
2. MINIMUM OUTDOOR OPERATING AMBIENT IN COOLINGMODE IS 55
F, MAX. 125
25HBB3
10
CLEARANCES
Clearances (various examples)
Wall6”
(152.4)
24”(609.6) Service
Wall
Wall
Wall
12” (304.8)
12”(304.8)
18” (457.2)
24”(609.6) Service
6” (152.4)
12”(304.8)
24”(609.6) Service
24”(609.6) Service
24”(609.6) Service
Note: Numbers in ( ) = mm
18” (457.2)
18” (457.2)
12” (304.8)
A07832
25HBB3C
Unit Report For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 1 of 12
Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ...............................................25HBB Unit Size: ............................................... 1.5 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz
Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................................. FB4C Unit Size: ......................................... 18,000 Btuh Cabinet Insulation:Single-piece cabinet with 1-in. super thick insulation ............................................................... Voltage: .......................................... 208/230-1-60 V-Ph-Hz
System Parameter System Quantity: ............................................... 1 Heating Size: .......................................... No Heat Outdoor Unit Dimensions and Weight Unit Length: ............................................... 2' 3.0'' Unit Width: ................................................. 2' 6.0'' Unit Height: ................................................ 2' 9.0'' Unit Shipping Weight: .................................... 174 lb Note:Outdoor unit dimensions may vary depending on the minor series sent from the factory. .....................
Indoor Unit Dimensions and Weight Unit Length: ............................................. 1' 10.1'' Unit Width: ................................................. 1' 2.0'' Unit Height: ................................................ 3' 7.0'' Unit Shipping Weight: .................................... 112 lb
Warranty Information Indoor FB4C First Year - Parts Only (Standard) Warranty Information Outdoor 25HBB First Year - Parts Only (Standard) Ordering Information
Part Number Description Quantity Base Unit - Outdoor
25HBB318A003 25HBB Heat Pump with Puron 1.5 Tons Cooling 1 13 SEER @ ARI Conditions 1
Accessories KSAHS1701AAA Start Assist - Capacitor and Relay 1 KSALA0301410 Low Ambient Controller Switch 1
KAACH1701AAA Crankcase Heater 1 KAAFT0101AAA Evaporator Freeze Thermostat 1 KHAIR0101AAA Isolation Relay 1 KSATX0201PUR Thermostatic Expansion Valve (Hard Shutoff) 1
Base Unit - Indoor FB4CNF018000 FB4C Base Series Fan Coil with Puron 18000 BTU Cooling 1
Single-piece cabinet with 1-in. super thick insulation 1
Performance Summary For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 2 of 12
System: ........................................ 25HBB/FB4C System Quantity: ............................................... 1 Altitude: .......................................................... 0.0 ft Linear Pipe Length: ........................................ 0.0 ft Actual SEER: ................................................ 13.0 EER @ ARI Conditions:................................ 11.0 Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ 25HBB318A003 Unit Size (Nominal):............................... 1.5 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz Clg Ent Air DB Ambient: ............................... 95.0 °F Htg Ent Air DB Ambient: ............................... 47.0 °F
Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ FB4CNF018000 Unit Size (Nominal): ......................... 18,000 Btuh Voltage: .......................................... 208/230-1-60 V-Ph-Hz Actual Airflow: ............................................. 600.0 CFM Standard Airflow: ........................................ 600.0 CFM Total Net Clg Capacity: ............................... 18.00 MBH Net Sensible Clg Capacity: ......................... 13.50 MBH Ent Air DB: .................................................. 80.00 °F Ent Air WB: ................................................. 67.00 °F Ent Enthalpy: .............................................. 31.44 BTU/lb Lvg Air DB: ................................................. 59.17 °F Lvg Air WB: ................................................ 57.59 °F Lvg Enthalpy: .............................................. 24.77 BTU/lb Heating Size (Nominal): .......................... No Heat Indoor Unit External Static: ........................... 0.40 in wg Total System Power: .................................... 1.48 kW
Heat Pump Htg HP Capacity: ........................................ 18.00 MBH Htg HP Integrated Capacity: ....................... 18.00 MBH Heating HP Compressor Power: .................. 1.46 kW Htg Ent Air DB: ............................................. 70.0 °F Htg Lvg Air DB: ............................................. 97.8 °F COP @ 47 F: ................................................ 3.64 COP @ 17 F: ................................................ 2.34
Outdoor Electrical Data Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Fan Motor FLA:............................................. 0.77 Amps MCA: ............................................................ 12.5 Amps Max Fuse: ........................................................ 20 Amps Operating Range Min: ................................... 197 V Operating Range Max: .................................. 253 V Compressor RLA: ........................................... 9.4 Amps Compressor LRA: ......................................... 48.0 Amps Min Wire Size @ 60C: ..................................... 14 Min Wire Size @ 75C: ..................................... 14 Max Length Wire Size @ 60C: ........................ 66 ft Max Length Wire Size @ 75C: ........................ 62 ft
Indoor Electrical Data: (For units with no factory or field installed electric heaters) Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Unit FLA: ........................................................ 1.5 Amps Unit MCA: ....................................................... 1.9 Amps Unit MOCP: .................................................. 15.0 Amps Unit Min Wire Size: ....................................... 14.0 Unit Fuse/Ckt Bkr Amps: .............................. 15.0 Amps Motor HP: ....................................................... 1/5 HP
Acoustic Summary For FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 3 of 12
Outdoor Unit Parameters: Tag Name: .................................................................................................................................................................... FC-1.5-1 Unit Model: ..................................................................................................................................................................... 25HBB Unit Size: ..................................................................................................................................................................... 1.5 Tons
Octave Band Center Frequency, Hz 63 125 250 500 1k 2k 4k 8k dBA Sound Power,dB 0.0 51.5 61.5 67.0 68.5 66.5 63.5 58.5 A-Weighted Sound Power, dBA 74.0
Indoor Unit Parameters: Tag Name: FC-1.5-1 Unit Model: FB4C Unit Size: 18,000 Btuh Cabinet Insulation: Single-piece cabinet with 1-in. super thick insulation
Octave Band Center Frequency, Hz 63 125 250 500 1k 2k 4k 8k dBA Sound Power,dB 64.7 60.7 56.7 53.7 51.7 49.7 45.7 0.0 A-Weighted Sound Power, dBA 0.0
Certified Drawing for FC/CU-1.5-1 Project: Calabasas High School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 4 of 12
8
DIMENSIONS
25HBB3
Certified Drawing for FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 5 of 12
5
DIMENSIONS (cont.)
A-COIL
NOTES:1. CONDENSATE PAN DRAIN CAPS NOT SHOWN FOR CLARITY. 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.
* HORIZONTAL MOUNT LOCATIONS - DIMPLES PROVIDED IN TOP PANEL, AND BACK OF CABINET. IN CABINET BOTTOM. HOLES PROVIDED
SLOPE COIL
3 1/4"2 9/16"
2 7/8"
2 3/16" TYP.
(2 PLACES)*
7/16" TYP. (2 PLACES)*
1" TYP. (2 PLACES)*
1 1/4"
AIRFLOW
SECONDARY DRAIN
PRIMARY DRAIN
UPFLOW(AS SHIPPED)
7/8"TYP.*
1/2"TYP.* 2 1/8"
1 5/8"
F 1 1/4"
PRIMARY DRAIN
SECONDARY DRAIN
HORIZ. RIGHT(FIELD CONVERTED)
1 1/4"
3 1/4"
1" TYP. (2 PLACES)*
7/16" TYP. (4 PLACES)*
2 3/16" TYP.(2 PLACES)*
G F
AIRFLOW
SECONDARY DRAIN
PRIMARY DRAIN
DOWNFLOW(FIELD CONVERTED)
1 13/16"TYP.*
5/16" TYP.*
1 5/8"
5/16" TYP.*
7/8"TYP.*
2 7/8"
5"
1 1/4"
1/2"TYP.*
SECONDARY DRAIN
PRIMARY DRAIN
HORIZ. LEFT (AS SHIPPED)
1 13/16"TYP.
5/16" TYP.*
1" TYP. (2 PLACES)*
7/16" TYP,(4 PLACES)*
4 3/4"
3 1/16" F
2 3/16" TYP.(2 PLACES)*
G
AIRFLOW
DOWNFLOW(FIELD CONVERTED)
SECONDARY DRAIN
PRIMARY DRAIN
7 7/8"1 3/16"
1 1/2"
1/2"TYP.*
1 13/16"TYP.
5 7/8"
5/16" TYP.*
7/8"TYP.* HORIZ. RIGHT
(FIELD CONVERTED)
PRIMARY DRAIN
SECONDARY DRAIN
7 7/8"1 3/16"
1 1/2"
1 13/16"TYP*
5/16" TYP*
7/8"TYP*
1/2"TYP* 5 7/8"
PRIMARY DRAIN
SECONDARY DRAIN
HORIZ. LEFT (AS SHIPPED)
2 3/16" TYP.
(2 PLACES)*
1" TYP. (2 PLACES)
7/16" TYP.(4 PLACES)
2 11/16"
3" 1/8
3 1/16"
4 3/4"
AIRFLOW
UPFLOW(AS SHIPPED)
PRIMARY DRAIN
SECONDARY DRAIN
A10006
Fig. 2 -- FB4CNF --English
FB4C
Certified Drawing for FC/CU-1.5-1 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 6 of 12
4
DIMENSIONS
UNIT A B C D E F G H J COIL
CONFIGURATION SHIPPING WT
(LBS) NON TIN-COATED
SHIPPING WT (LBS)
TIN-COATEDSLOPE "A"
FB4CNF018 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112
FB4CNF024 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112
FB4CNF030 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122
FB4CNF036 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122
FB4CNF042 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157
FB4CNF048 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157
FB4CNF060 53 7/16" 21 1/8" 19 1/4" 19 1/8" 19 1/2" 27 1/4" 26 15/16" - - - X 175 175
NOTE: 1. SERIES DESIGNATION IS THE 14TH POSITION OF UNIT PRODUCT NUMBER 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.
NOTE: ALLOW 21" FROM FRONT FOR SERVICE
1 7/8"
1 3/8"1 15/16" 1"
TOP VIEW
7/8"DIA. K.O. FOR LOW VOLTAGE CONTROL WIRING
7/8", 1 3/32" 2" DIA. K.O.'SFOR HIGH VOLTAGEPOWER WIRING
6 3/16"
2 5/8"
10 7/16"
1"
15/16"
5"
D
BLOWER, CONTROL,& ELECTRIC HEATER ACCESS PANEL
COIL ACCESS PANEL
DISCONNECT OR CIRCUIT BREAKER LOCATION
LIQUID LINE CONNECTION
SUCTION LINE CONNECTION
FILTER ACCESS PANEL
FITTING PANEL
B C
FRONT VIEWSHOWN WITH "A" COIL DETAILS CONNECTION
LOCATIONS FOR UPFLOW OR HORIZ. APPLICATIONS
INLET AIR
OPENING
10 3/4"
3 1/16"
4 11/16"
E
9 1/2"
ACCESS PANEL CONFIG. FOR
SLOPE COILS DOWNFLOW OR HORIZ.RIGHT APPLICATIONS
AND
"A" COILS DOWNFLOW APPLICATIONS
LIQUID LINE CONNECTION
LIQUID LINE CONNECTION
SUCTION LINECONNECTION
SLOPE COIL DETAILSCONNECTION LOCATIONS SHOWN
FOR UPFLOW OR HORIZ.LEFT APPLICATIONS
INLET AIR
1 1/2"
2 1/2"
1"
10 3/16"
3/4"
22 1/16"
OPENING 19 13/16"
2 1/8"
1 1/4"
A
FOR MODULAR UNITS
1 3/16"
MAX
7/8"11"
1 3/4"
19"
NOTE: MODULAR UNITS WILL HAVE A TWO-PIECE CABINET
RIGHT SIDE VIEW
OPTIONAL FIELD CONVERTEDRIGHT SIDE RETURN OPENING (SLOPE COIL UNITS ONLY)
ALTERNATE 7/8"DIA. K.O.
FOR LOW VOLTAGE CONTROL WIRING
ALTERNATE 7/8",1 3/32",2"DIA. K.O.'S FOR HIGH VOLTAGEPOWER WIRINGOPPOSITE SIDE
INLET AIR
OUTLET AIR
H J
SUCTION: 018 & 024 - 5/8" I.D. SWEAT 030 & 036 - 3/4" I.D. SWEAT 042 THRU 060 - 7/8" I.D. SWEAT LIQUID: 3/8" I.D. SWEAT CONDENSATE: 3/4" FPT
UNIT CONNECTION SIZES
A10005
Fig. 1 -- FB4CNF --English
FB4C
Unit Report For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 7 of 12
Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ...............................................25HBB Unit Size: .................................................. 3 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz
Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................................. FB4C Unit Size: ......................................... 36,000 Btuh Cabinet Insulation:Single-piece cabinet with 1-in. super thick insulation ............................................................... Voltage: .......................................... 208/230-1-60 V-Ph-Hz
System Parameter System Quantity: ............................................... 1 Heating Size: .......................................... No Heat Outdoor Unit Dimensions and Weight Unit Length: ............................................. 4' 10.0'' Unit Width: ................................................. 3' 4.0'' Unit Height: ................................................ 2' 9.0'' Unit Shipping Weight: .................................... 207 lb Note:Outdoor unit dimensions may vary depending on the minor series sent from the factory. .....................
Indoor Unit Dimensions and Weight Unit Length: ............................................. 1' 10.1'' Unit Width: ................................................. 1' 9.0'' Unit Height: ................................................ 4' 1.0'' Unit Shipping Weight: .................................... 122 lb
Warranty Information Indoor FB4C First Year - Parts Only (Standard) Warranty Information Outdoor 25HBB First Year - Parts Only (Standard) Ordering Information
Part Number Description Quantity Base Unit - Outdoor
25HBB336A003 25HBB Heat Pump with Puron 3 Tons Cooling 1 13 SEER @ ARI Conditions 1
Accessories KSAHS1701AAA Start Assist - Capacitor and Relay 1 KSALA0301410 Low Ambient Pressure Switch 1
KAACH1701AAA Crankcase Heater 1 KAAFT0101AAA Evaporator Freeze Thermostat 1 KHAIR0101AAA Isolation Relay 1 KSATX0201PUR Thermostatic Expansion Valve (Hard Shutoff) 1
Base Unit - Indoor FB4CNF036000 FB4C Base Series Fan Coil with Puron 36000 BTU Cooling 1
Single-piece cabinet with 1-in. super thick insulation 1
Performance Summary For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 8 of 12
System: ........................................ 25HBB/FB4C System Quantity: ............................................... 1 Altitude: .......................................................... 0.0 ft Linear Pipe Length: ........................................ 0.0 ft Actual SEER: ................................................ 13.0 EER @ ARI Conditions:................................ 11.2 Outdoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ 25HBB336C003 Unit Size (Nominal):.................................. 3 Tons Voltage: .......................................... 208/230-1-60 V-Ph-Hz Clg Ent Air DB Ambient: ............................... 95.0 °F Htg Ent Air DB Ambient: ............................... 47.0 °F
Indoor Unit Parameters Unit Quantity: ..................................................... 1 Unit Model: ................................ FB4CNF036000 Unit Size (Nominal): ......................... 36,000 Btuh Voltage: .......................................... 208/230-1-60 V-Ph-Hz Actual Airflow: ........................................... 1050.0 CFM Standard Airflow: ...................................... 1050.0 CFM Total Net Clg Capacity: ............................... 33.37 MBH Net Sensible Clg Capacity: ......................... 24.04 MBH Ent Air DB: .................................................. 80.00 °F Ent Air WB: ................................................. 67.00 °F Ent Enthalpy: .............................................. 31.44 BTU/lb Lvg Air DB: ................................................. 58.80 °F Lvg Air WB: ................................................ 56.97 °F Lvg Enthalpy: .............................................. 24.37 BTU/lb Heating Size (Nominal): .......................... No Heat Indoor Unit External Static: ........................... 0.40 in wg Total System Power: .................................... 2.98 kW
Heat Pump Htg HP Capacity: ........................................ 34.92 MBH Htg HP Integrated Capacity: ....................... 34.92 MBH Heating HP Compressor Power: .................. 2.99 kW Htg Ent Air DB: ............................................. 70.0 °F Htg Lvg Air DB: ........................................... 100.8 °F COP @ 47 F: ................................................ 3.58 COP @ 17 F: ................................................ 2.52
Outdoor Electrical Data Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Fan Motor FLA:............................................. 0.90 Amps MCA: ............................................................... 22 Amps Max Fuse: ........................................................ 35 Amps Operating Range Min: ................................... 197 V Operating Range Max: .................................. 253 V Compressor RLA: ......................................... 16.7 Amps Compressor LRA: ......................................... 79.0 Amps Min Wire Size @ 60C: ..................................... 12 Min Wire Size @ 75C: ..................................... 12 Max Length Wire Size @ 60C: ........................ 58 ft Max Length Wire Size @ 75C: ........................ 56 ft
Indoor Electrical Data: (For units with no factory or field installed electric heaters) Unit Voltage: ................................... 208/230-1-60 V-Ph-Hz Unit FLA: ........................................................ 2.7 Amps Unit MCA: ....................................................... 3.4 Amps Unit MOCP: .................................................. 15.0 Amps Unit Min Wire Size: ....................................... 14.0 Unit Fuse/Ckt Bkr Amps: .............................. 15.0 Amps Motor HP: ....................................................... 1/3 HP
Acoustic Summary For FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 9 of 12
Outdoor Unit Parameters: Tag Name: ....................................................................................................................................................................... FC-3-2 Unit Model: ..................................................................................................................................................................... 25HBB Unit Size: ........................................................................................................................................................................ 3 Tons
Octave Band Center Frequency, Hz 63 125 250 500 1k 2k 4k 8k dBA Sound Power,dB 0.0 50.5 61.5 54.0 71.5 62.0 61.0 54.5 A-Weighted Sound Power, dBA 75.0
Indoor Unit Parameters: Tag Name: FC-3-2 Unit Model: FB4C Unit Size: 36,000 Btuh Cabinet Insulation: Single-piece cabinet with 1-in. super thick insulation
Octave Band Center Frequency, Hz 63 125 250 500 1k 2k 4k 8k dBA Sound Power,dB 67.8 63.8 59.8 56.8 54.8 52.8 48.8 0.0 A-Weighted Sound Power, dBA 0.0
Certified Drawing for FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 10 of 12
8
DIMENSIONS
25HBB3
Certified Drawing for FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 11 of 12
5
DIMENSIONS (cont.)
A-COIL
NOTES:1. CONDENSATE PAN DRAIN CAPS NOT SHOWN FOR CLARITY. 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.
* HORIZONTAL MOUNT LOCATIONS - DIMPLES PROVIDED IN TOP PANEL, AND BACK OF CABINET. IN CABINET BOTTOM. HOLES PROVIDED
SLOPE COIL
3 1/4"2 9/16"
2 7/8"
2 3/16" TYP.
(2 PLACES)*
7/16" TYP. (2 PLACES)*
1" TYP. (2 PLACES)*
1 1/4"
AIRFLOW
SECONDARY DRAIN
PRIMARY DRAIN
UPFLOW(AS SHIPPED)
7/8"TYP.*
1/2"TYP.* 2 1/8"
1 5/8"
F 1 1/4"
PRIMARY DRAIN
SECONDARY DRAIN
HORIZ. RIGHT(FIELD CONVERTED)
1 1/4"
3 1/4"
1" TYP. (2 PLACES)*
7/16" TYP. (4 PLACES)*
2 3/16" TYP.(2 PLACES)*
G F
AIRFLOW
SECONDARY DRAIN
PRIMARY DRAIN
DOWNFLOW(FIELD CONVERTED)
1 13/16"TYP.*
5/16" TYP.*
1 5/8"
5/16" TYP.*
7/8"TYP.*
2 7/8"
5"
1 1/4"
1/2"TYP.*
SECONDARY DRAIN
PRIMARY DRAIN
HORIZ. LEFT (AS SHIPPED)
1 13/16"TYP.
5/16" TYP.*
1" TYP. (2 PLACES)*
7/16" TYP,(4 PLACES)*
4 3/4"
3 1/16" F
2 3/16" TYP.(2 PLACES)*
G
AIRFLOW
DOWNFLOW(FIELD CONVERTED)
SECONDARY DRAIN
PRIMARY DRAIN
7 7/8"1 3/16"
1 1/2"
1/2"TYP.*
1 13/16"TYP.
5 7/8"
5/16" TYP.*
7/8"TYP.* HORIZ. RIGHT
(FIELD CONVERTED)
PRIMARY DRAIN
SECONDARY DRAIN
7 7/8"1 3/16"
1 1/2"
1 13/16"TYP*
5/16" TYP*
7/8"TYP*
1/2"TYP* 5 7/8"
PRIMARY DRAIN
SECONDARY DRAIN
HORIZ. LEFT (AS SHIPPED)
2 3/16" TYP.
(2 PLACES)*
1" TYP. (2 PLACES)
7/16" TYP.(4 PLACES)
2 11/16"
3" 1/8
3 1/16"
4 3/4"
AIRFLOW
UPFLOW(AS SHIPPED)
PRIMARY DRAIN
SECONDARY DRAIN
A10006
Fig. 2 -- FB4CNF --English
FB4C
Certified Drawing for FC/CU-3-2 Project: Calabasas School 12/21/2010 Prepared By: Kyle Heinsen 06:00AM
Residential Carrier Products Bldr 1.16 Page 12 of 12
4
DIMENSIONS
UNIT A B C D E F G H J COIL
CONFIGURATION SHIPPING WT
(LBS) NON TIN-COATED
SHIPPING WT (LBS)
TIN-COATEDSLOPE "A"
FB4CNF018 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112
FB4CNF024 42 11/16" 14 5/16" 12 7/16" 12 5/16" 10 7/16" 18 1/8" 18 5/8" - 12" X - 112 112
FB4CNF030 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122
FB4CNF036 49 5/8" 17 5/8" 15 3/4" 15 5/8" 15 3/8" 23 1/8" 23 5/8" - 17" X - 122 122
FB4CNF042 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157
FB4CNF048 49 5/8" 21 1/8" 19 1/4" 19 1/8" 15 11/16" 23 7/16" 23 1/8" - - - X 157 157
FB4CNF060 53 7/16" 21 1/8" 19 1/4" 19 1/8" 19 1/2" 27 1/4" 26 15/16" - - - X 175 175
NOTE: 1. SERIES DESIGNATION IS THE 14TH POSITION OF UNIT PRODUCT NUMBER 2. ALL DIMENSIONS ARE IN "INCHES" UNLESS NOTED.
NOTE: ALLOW 21" FROM FRONT FOR SERVICE
1 7/8"
1 3/8"1 15/16" 1"
TOP VIEW
7/8"DIA. K.O. FOR LOW VOLTAGE CONTROL WIRING
7/8", 1 3/32" 2" DIA. K.O.'SFOR HIGH VOLTAGEPOWER WIRING
6 3/16"
2 5/8"
10 7/16"
1"
15/16"
5"
D
BLOWER, CONTROL,& ELECTRIC HEATER ACCESS PANEL
COIL ACCESS PANEL
DISCONNECT OR CIRCUIT BREAKER LOCATION
LIQUID LINE CONNECTION
SUCTION LINE CONNECTION
FILTER ACCESS PANEL
FITTING PANEL
B C
FRONT VIEWSHOWN WITH "A" COIL DETAILS CONNECTION
LOCATIONS FOR UPFLOW OR HORIZ. APPLICATIONS
INLET AIR
OPENING
10 3/4"
3 1/16"
4 11/16"
E
9 1/2"
ACCESS PANEL CONFIG. FOR
SLOPE COILS DOWNFLOW OR HORIZ.RIGHT APPLICATIONS
AND
"A" COILS DOWNFLOW APPLICATIONS
LIQUID LINE CONNECTION
LIQUID LINE CONNECTION
SUCTION LINECONNECTION
SLOPE COIL DETAILSCONNECTION LOCATIONS SHOWN
FOR UPFLOW OR HORIZ.LEFT APPLICATIONS
INLET AIR
1 1/2"
2 1/2"
1"
10 3/16"
3/4"
22 1/16"
OPENING 19 13/16"
2 1/8"
1 1/4"
A
FOR MODULAR UNITS
1 3/16"
MAX
7/8"11"
1 3/4"
19"
NOTE: MODULAR UNITS WILL HAVE A TWO-PIECE CABINET
RIGHT SIDE VIEW
OPTIONAL FIELD CONVERTEDRIGHT SIDE RETURN OPENING (SLOPE COIL UNITS ONLY)
ALTERNATE 7/8"DIA. K.O.
FOR LOW VOLTAGE CONTROL WIRING
ALTERNATE 7/8",1 3/32",2"DIA. K.O.'S FOR HIGH VOLTAGEPOWER WIRINGOPPOSITE SIDE
INLET AIR
OUTLET AIR
H J
SUCTION: 018 & 024 - 5/8" I.D. SWEAT 030 & 036 - 3/4" I.D. SWEAT 042 THRU 060 - 7/8" I.D. SWEAT LIQUID: 3/8" I.D. SWEAT CONDENSATE: 3/4" FPT
UNIT CONNECTION SIZES
A10005
Fig. 1 -- FB4CNF --English
FB4C
25HBB3Base 13 Heat Pumpwith Puronr Refrigerant1---1/2 to 5 Nominal Tons (Sizes 18 to 60)
Product Data
the environmentally sound refrigerant
Carrier heat pumps with Puronr refrigerant provide a collection offeatures unmatched by any other family of equipment. The 25HBBhas been designed utilizing Carrier’s Puron refrigerant. Theenvironmentally sound refrigerant allows consumers to make aresponsible decision in the protection of the earth’s ozone layer.As an Energy Starr Partner, Carrier Corporation has determinedthat this product meets the Energy Starr guidelines for energyefficiency. Refer to the combination ratings in the Product Data forsystem combinations that meet Energy Starr guidelines.NOTE: Ratings contained in this document are subject tochange at any time. Always refer to the AHRI directory(www.ahridirectory.org) for the most up--to--date ratingsinformation.
INDUSTRY LEADINGFEATURES / BENEFITSEfficiencyS 13 SEER/ 10.1 -- 10.8 EER/ 7.7 -- 8.3 HSPF (nominal)S Microtube Technologyt refrigeration systemS Indoor air quality accessories available
SoundS Sound level as low as 72 dBAS Sound levels as low as 70 dBA with accessory sound blanket
ComfortS System supports Edger Thermidistatt or standard thermostatcontrols
ReliabilityS Puronr refrigerant -- environmentally sound, won’t deplete theozone layer and low lifetime service cost.
S Scroll compressorS Internal pressure relief valveS Internal thermal overloadS High pressure switchS Loss of charge switchS Filter drierS Balanced refrigeration system for maximum reliability
DurabilityWeatherArmort protection package:S Solid, durable sheet metal constructionS Dense wire coil guard availableS Baked--on powder paint
ApplicationsS Long--line -- up to 250 feet (76.20 m) total equivalent length, upto 200 feet (60.96 m) condenser above evaporator, or up to 80 ft.(24.38 m) evaporator above condenser (See Longline Guide formore information.)
S Low ambient (down to --20_F/--28.9_C) with accessory kit
3
PHYSICAL DATAUNIT SIZE SERIES 18---31 24---31 30---31 36---31 42---31 48---31 60---31
Operating Weight lb (kg)173(78.5)
173(78.5)
191(86.6)
192(87.1)
255(115.7)
265(120.2)
287(130.2)
Shipping Weight lb (kg)202(91.6)
202(91.6)
223(101.2)
224(101.6)
287(130.2)
297(134.7)
319(144.7)
Compressor Type ScrollREFRIGERANT Puron� (R---410A)
Control TXV (Puron Hard Shutoff)Heating Piston Size 42 46 55 57 61 61 76
Charge lb (kg)6.63(3.01)
6.58(2.98)
6.56(2.98)
7.57(3.43)
11.07(5.02)
11.3(5.13)
12.58(5.71)
COND FAN Propeller Type, Direct DriveAir Discharge VerticalAir Qty (CFM) 2611 2611 3810 3810 3810 4046 4046Motor HP 1/10 1/10 1/5 1/5 1/5 1/4 1/4Motor RPM 1100 1100 800 800 800 800 800
COND COILFace Area (Sq ft) 19.40 19.4 20.12 25.15 20.12 20.12 25.15Fins per In. 20 20 20 20 20 20 20Rows 1 1 1 1 2 2 2Circuits 5 5 5 6 6 8 8
VALVE CONNECT. (In. ID)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 7/8Liquid 3/8
REFRIGERANT TUBES* (In. OD)Vapor 5/8 5/8 3/4 3/4 7/8 7/8 1---1/8Liquid 3/8
* For tubing sets between 80 and 200 ft. (24.38 and 60.96 m) horizontal or 20 ft. (6.09 m) vertical differential, consult the Longline Guideline.Note: See unit Installation Instruction for proper installation.
VAPOR LINE SIZING AND COOLING CAPACITY LOSSLONG LINE APPLICATION: An application is considered ”Longline” when the total equivalent tubing length exceeds 80 ft. (24.38m) or when there is more than 20 ft. (6.09 m) vertical separationbetween indoor and outdoor units. These applications requireadditional accessories and system modifications for reliable systemoperation. The maximum allowable total equivalent length is 250ft. (76.2 m). The maximum vertical separation is 200 ft. (60.96 m)
when outdoor unit is above indoor unit, and 60 ft. (18.3 m) whenthe outdoor unit is below the indoor unit. Refer to AccessoryUsage Guideline below for required accessories. See LonglineApplication Guideline for required piping and systemmodifications. Also, refer to the table below for vapor tubediameters based on the total length to minimize the coolingcapacity loss.
UnitNominal
Size (Btuh)
MaximumLiquidLine
Diameters(In. OD)
VaporLine
Diameters(In.) OD
Cooling Capacity Loss (%)Total Equivalent Line Length ft. (m)
StandardApplication Long Line Application Requires Accessories
26---50(7.9---15.2)
51---80(15.5---24.4)
81---100(24.7---31.5)
101---125(30.8---38.1)
126---150(38.4---45.7)
151---175(46.0---50.3)
176---200(53.6---60.0)
201---225(61.3---68.6)
226---250(68.9---76.2)
18,0001---StagePuron HP
3/8
1/2 1 2 3 4 6 7 8 9 10
5/8 0 0 1 1 1 2 2 3 3
24,0001---StagePuron HP
5/8 0 1 1 2 3 3 4 4 5
3/4 0 0 0 0 1 1 1 1 1
30,0001---StagePuron HP
5/8 1 2 3 3 4 5 6 7 83/4 0 0 1 1 1 2 2 2 37/8 0 0 0 0 1 1 1 1 1
36,0001---StagePuron HP
5/8 1 2 4 5 6 7 9 10 113/4 0 0 1 1 2 2 3 3 47/8 0 0 0 0 1 1 1 1 2
42,0001---StagePuron HP
3/4 0 1 2 2 3 4 4 5 6
7/8 0 0 1 1 1 2 2 2 3
48,0001---StagePuron HP
3/4 0 1 2 3 4 5 5 6 7
7/8 0 0 1 1 2 2 2 3 3
60,0001---StagePuron HP
3/4 1 2 4 5 6 7 9 10 117/8 0 1 2 2 3 4 4 5 5
1---1/8 0 0 0 1 1 1 1 1 1Applications in this area are long line. Accessories are required as shown recommended on Long Line Application GuidelinesApplications in this area may have height restrictions that limit allowable total equivalent length, when outdoor unit is below indoor unit See Long Line Applica-tion Guidelines
25HBB3C
7
ELECTRICAL DATAUNITSIZE---
VOLTAGE,SERIES
V/PHOPER VOLTS* COMPR FAN
MCA
MINWIRESIZE†
MINWIRESIZE†
MAXLENGTH(FT)‡
MAXLENGTH(FT)‡
MAXFUSE**or BRKAMPSMAX MIN LRA RLA FLA 60° C 75° C 60° C 75° C
18---31
208/230/1 253 197
48 9.4 0.8 12.5 14 14 63 60 2024---31 58.3 12.8 0.8 16.8 14 14 47 45 2530---31 77 15.2 1.2 20.2 12 12 62 59 3036---31 79 16.7 1.2 22.0 12 12 57 54 3542---31 109 21.3 1.2 27.8 10 10 72 68 4048---31 117 21.8 1.2 28.4 10 10 70 67 4060---31 134 26.3 1.2 34.1 8 10 91 56 50
* Permissible limits of the voltage range at which the unit will operate satisfactorily{ If wire is applied at ambient greater than 30_C, consult table 310---16 of the NEC (ANSI/NFPA 70). The ampacity of non---metallic---sheathed cable (NM),
trade name ROMEX, shall be that of 60_C conditions, per the NEC (ANSI/NFPA 70) Article 336---26. If other than uncoated (no---plated), 60 or 75_Cinsulation, copper wire (solid wire for 10 AWG or smaller, stranded wire for larger than 10 AWG) is used, consult applicable tables of the NEC (ANSI/NFPA70).
} Length shown is as measured 1 way along wire path between unit and service panel for voltage drop not to exceed 2%.** Time---Delay fuse.FLA --- Full Load AmpsLRA --- Locked Rotor AmpsMCA --- Minimum Circuit AmpsRLA --- Rated Load AmpsNOTE: Control circuit is 24---V on all units and requires external power source. Copper wire must be used from service disconnect to unit.All motors/compressors contain internal overload protection.Complies with 2001 requirements of ASHRAE Standards 90.1
A--WEIGHTED SOUND LEVEL (dBA)
UNIT SIZE --- VOLTAGE,SERIESSTANDARDRATING(dBA)
TYPICAL OCTAVE BAND SPECTRUM (dB, without tone adjustment)
125 250 500 1000 2000 4000 8000
18---31 74 51.5 61.5 67.0 68.5 66.5 63.5 58.524---31 74 53.0 62.0 68.0 70.5 67.0 63.5 59.030---31 75 56.0 62.0 66.5 71.5 66.0 62.0 54.536---31 75 50.5 61.5 65.0 71.0 65.0 61.0 54.542---31 75 59.5 63.0 66.5 71.0 67.0 62.0 55.548---31 79 57.5 64.5 67.5 71.5 73.0 64.5 58.560---31 80 57.5 59.0 65.5 71.5 74.0 63.0 57.5
NOTE: Tested in accordance with AHRI Standard 270---95. (Not listed with AHRI).
A--WEIGHTED SOUND LEVEL (dBA) WITH SOUND SHIELD
UNIT SIZE --- VOLTAGE,SERIESSTANDARDRATING(dBA)
TYPICAL OCTAVE BAND SPECTRUM (dB, without tone adjustment)
125 250 500 1000 2000 4000 8000
18---31 73 51.5 62.0 67.0 68.0 66.0 63.0 58.524---31 74 53.0 62.0 67.5 69.0 66.5 63.0 58.030---31 74 57.0 61.5 66.0 70.0 65.0 60.5 52.536---31 73 51.0 61.5 64.5 69.0 63.5 60.5 53.042---31 73 60.0 63.5 66.5 69.5 66.0 60.5 52.548---31 77 57.0 65.5 67.5 69.5 71.0 61.0 53.560---31 77 57.5 58.5 65.0 68.5 71.0 60.0 53.0
NOTE: Tested in accordance with AHRI Standard 270---95. (Not listed with AHRI).
CHARGING SUBCOOLING (TXV--TYPE EXPANSION DEVICE)UNIT SIZE --- VOLTAGE,SERIES REQUIRED SUBCOOLING ° F (° C)
18---31 8 (4.4)24---31 10 (5.6)30---31 10 (5.6)36---31 11 (6.1)42---31 11 (6.1)48---31 12 (6.7)60---31 11 (6.1)
25HBB3C
9
DIMENSIONS -- ENGLISH
B
3 13/16”
K
1 1/8”L
C 3 1/2”1 7/8”
N
P
M
E
F
G
A
208-230-1-60
230-1-60
208/230-3-60
460-3-60
UNIT SERIES ELECTRICALCHARACTERISTICSA B C D E F G K L M N P OPERATING
WEIGHT (lbs)SHIPPING
25HBB318 0 X O O O 25 3/4” 35 1/4” 3 3/4” 5/8” 4 7/16” 21 1/4” 9 1/8” 2 13/16” 1/2” 13 1/2” 14 1/2” 14” 148 174
25HBB324 0 X O O O 31 3/16” 28 15/16” 3 3/4” 5/8” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 15 5/8” 16 3/4” 14 1/2” 162 189
25HBB330 0 X O X O 31 3/16” 39 1/8” 3 3/4” 3/4” 6 9/16” 24 11/16” 9 1/8” 2 13/16” 1/2” 16 1/2” 15 1/2’ 17” 186 215
25HBB336 0 X O X X 35” 28 15/16” 3 3/4” 3/4” 6 9/16” 28 7/16” 9 1/8” 2 13/16” 1/2” 15 1/2” 15 3/4” 12 1/2” 172 207
25HBB342 0 X O X X 35” 39 1/8” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17 1/4” 19 1/8” 15 3/4” 246 278
25HBB348 0 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 240 273
25HBB360 0 X O O O 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282
25HBB360 1 X O X X 35” 28 15/16” 3 7/8” 7/8” 6 9/16” 28 7/16” 9 1/8” 2 15/16” 5/8” 17” 16” 12” 250 282
1824,30,36
36,42,48,60
AIRDISCHARGE
AIR DISCHARGE
SQ. AIR IN
VAPOR LINE CONN.D
3/8”LIQUID LINE CONN.
AIR IN
AIR IN
3/8” TIEDOWN KNOCKOUTS(2) PLACES
FIELD CONTROLSUPPLY CONN.
7/8” HOLE
FIELD POWER SUPPLY CONN.7/8” HOLE WITH
1 1/8” KNOCKOUT
X = YESO = NO
NOTES:
1. ALLOW 30” CLEARANCE TO SERVICE SIDE OF UNIT,48” ABOVE UNIT, 6” ON ONE SIDE, 12” ON REMAINING SIDE,AND 24” BETWEEN UNITS FOR PROPER AIRFLOW.
2. MINIMUM OUTDOOR OPERATING AMBIENT IN COOLINGMODE IS 55
F, MAX. 125
25HBB3
10
CLEARANCES
Clearances (various examples)
Wall6”
(152.4)
24”(609.6) Service
Wall
Wall
Wall
12” (304.8)
12”(304.8)
18” (457.2)
24”(609.6) Service
6” (152.4)
12”(304.8)
24”(609.6) Service
24”(609.6) Service
24”(609.6) Service
Note: Numbers in ( ) = mm
18” (457.2)
18” (457.2)
12” (304.8)
A07832
25HBB3C