10 Microwave

MICROWAVE2009

10SECTION

Wagner Electronics has been supplying accessories to the electronic manufacturing and servicing industry for over 25 years ! Wagner Electronics carries an extensive range of Magnetrons, Diodes, Lamps and Capacitors for Microwave Oven Servicing.

CONTENTSMagnatrons . . . . . . . 10-2Power Transformers . . 10-6Miscellaneous . . . . . . 10-7Door Switch . . . . . . . 10-8Diodes . . . . . . . . . . 10-9Lamps. . . . . . . . . . 10-10Roof Liners . . . . . . . 10-11Thermistor . . . . . . . 10-12Carousel Motor . . . . . 10-13Capacitor . . . . . . . . 10-14

MICROWAVE OVEN MAGNETRONSThese quality magnetronswill serve as replacementsin a majority of ovens frommany different manufacturers.

Manufacturer brand namesstipulated on the labelmay change from listing.

Due to global supply sourcesmay change labeling and/ormanufacturer of some listedmagnetrons. Units of betteror equivalent specificationswill be supplied if certainbrands become unavailable.Use branding as a guide only.

CHOOSING YOUR MAGNETRONThe important points to observe are:(A) Is it an Inverter type magnetron

See page 10-06 for Panasonic...(B) Will it physically fit in place.

Size & Mounting manner similar.Note: Air flow in relation tothe power socket and the tags.

(C) Do the tags have bolts or not.The bolts can be removed if necessary.

(D) After determining the physicallysame unit, you may find more thanone similar to your magnetron, then:

(E) Compare the P/No listed with each.If missing or not listed, dont fret!Just use the most similar magnetronfitting the criteria listed above.

(F) Then pick your wattage...

WATTAGEWattage output is determined bythe ovens internal circuitrysuch as the transformer voltages,capacitor values, etc,not necessarily just the magnetron.A Higher WattageMagnetron Can Be UsedIn A Lower Wattage Oven Safely.

Measurements are outer dimensionsor centre hole/stud distancesmeasured in millimeters. +/- 5mm

Again check the part numbers anddimensions as your best guide forselecting your replacement magnetron.

SERVICE TECHNICIANSTHIS IS NOT A HOBBY!Please beware of what youare doing because insidemicrowaves have LETHALvoltages, even when thepower is disconnected.

LETHAL VOLTAGES INSIDEThere is a rather largecapaciter inside thatstores thousands of volts.You should short this outto extinguish any residuecharge that may harm you.

QUALIFIED PERSONAL ONLYKnow what you are doing!

NO TAGS INLINE 850WSize 80x80x100mmMounting Holes on caseAproximatly = 65 x 65mm(+ other mount holes)Watts 850WFreq. 2458MHzFV 3.3VPAV 4000VPAI 300mAA650 HYIS2M214-04/HY2M218-HBYRVMZA080WREOOEM AWICode AM711

NO TAGS NOT-INLINE 850WSize 95x80x100mmWatts 850WP/No. CK623HY

A670-HY2M214-062M172-ADWI/JYB2M172(YC)OM75(51)S107JYB

OEM AWICode AM705

STUDS ALL-INLINE 850WSize 80x80x100mmWatts 850WFreq. 2458MHzFV 3.3VPAV 4000VPAI 300mAEquiv. A650-I

2M214-232M214-572M218HAM719

OEM AWICode AM719

ALL-INLINE 950WSize 80x80x100mmWatts 950WFreq. 2460MHzFV 3.3V 12APAV 4500VPAI 350mAP/No. 2M214

2M218/H2M238MS194W

41500215026324W1A003CBrand LGEquiv. Daewoo &

Sanyo, etc.Code AM742

10 - 2 Microwave Oven Parts

Magnatrons

ALL-INLINE 850WSize 80x95x100mmWatts 850WGeneral ReplacementSuit OM75S-21and many othersCode MAG703

NOTE:Tags are inline with theair vent & power socket.Referred to as All-In-Line.A higher wattage unitcan be used safely in aLower power oven.Brands supplied may change.Diagrams may differ slightly.

ALL-INLINE 850WSize 80x95x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. A670-IH2M224(62)2M172AH/DW/P/HBRVMZA047WREO2M219HB2M107A-33/94,OM75-020,S107HB,OEM AWICode AM707

ALL-INLINE 850WSize 80x95x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. Dae-Woo &

Sanyo.OEM AWICode AM741

STUDS ALL-INLINE 850WSize 80x95x100mmWatts 850WFreq. 2458MHzFV 3.15VP 4KV 300mAA670-I, NL2555-2,2M172H/AH/Y/CB.N2M219H,2M107(79)2M189AM4,2M128D1OM75-A(20)/9020OM75S-20,S107H,H172AWICode AM708

DAI-1CHICode MAG704

ALL-INLINE 1KWSize 80x95x100mmWatts 1000WFreq. 2458MHzFV 3.3VPAV 4000VPAI 300mAEquiv. A670-IH

2M107A(94)2M247H(B)OM75(020)S107HB

OEM AWICode AM724

ALL-INLINE 1KWSize 80x95x100mmWatts 1000 (1KW)Freq. 2460MHzFV 3.15VPAV 4350VPAI 330mAP/No. 2M248H

2M248H-B6324W1A001NCode MAG2481

AWI NOTE:Please note thatbrand labeled maychange dependingon stock supplied

ALL-INLINE 1KWGENUINE SHARP OEMSize 80x95x100mmWatts 1000WFV 4.35V(Peak)Original OEM SharpRV-MZ A295 WRE02M248H(L)350 562 0254Code MAG295

STUDS ALL-INLINE 1KWSize 80x95x100mmWatts 1000WFreq. 2458MHzFV 3.15VPAV 4000VPAI 350mAAWI 1000WEquiv. 2M107(79),

OM75(20),2M247,S107H,H3801-03

Code AM722

Microwave Oven Parts 10 - 3

TAGS INLINE SOCKET NOT-INLINE 600WSize 70x75x95mmWatts 600WGeneral ReplacementCompact MicrowaveP/No. AM698

OM52-S11Code MAG698

NOTE:Tags are inline with theair vent but are NOT inlinewith the power socket.Tags Inline - Socket Not InlineA higher wattage unitcan be used safely in aLower power oven.

STUDS INLINE SOCKET NOT-INLINE 600WSize 70x75x95mmWatts 600WP/No. AM700

OM52-S102M209A

Code MAG700

TAGS INLINE SOCKET NOT-INLINE 850WSize 80x80x100mmWatts 850WFreq. 2458MHzFV 3.3VPAV 4000VPAI 300mAP/No. A650-OH

2M207-222M218-JB

OEM AWICode AM717

*AWIPlease note that theBrand may change.

TAGS INLINE SOCKET NOT-INLINE 910WSize 80x80x100mmWatts 910WFreq. 2460MHzFV 3.75V 10.5APAV 4100VPAI 1200mAEquiv. 2B71732A

2B71732B2M214-392M218JXZ2M218JQZ2M229JCLAM734EAS50093701MS305CL

Code MAG710

TAGS INLINE SOCKET NOT-INLINE 950WSize 80x80x100mmWatts 950WFreq. 2460MHzFV 3.3V 12.5APAV 4500VPAI 350mAP/No. 2M2142M214.A01GLK2B71732GBrand LG*Code AM743

*Brand may change.

TAGS INLINE SOCKET NOT-INLINE 850WSize 80x95x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. A670-OH,2M107A,2M204M3,2M219JB,2M240J(Y),OM75(11),S107JBOEM AWICode AM701

TAGS INLINE SOCKET NOT-INLINE 850WSize 80x95x100mmWatts 850WGeneral ReplacementOM75S-11 and more...Code MAG701

TAGS INLINE SOCKET NOT-INLINE 1KWSize 80x95x100mmWatts 1000 (1KW)Freq. 2458MHzFV 3.3VPAV 4000VPAI 300mAEquiv. AM670-OH

2M240J(Y)2M247JBS107JB

OEM AWICode AM723


TAGS INLINE SOCKET NOT-INLINE 1KWSize 80x95x100mmWatts 1025WFreq. 2460MHzFV 3.15V 12APAV 4850VPAI 380mAP/No. 2M248J

MS364F6324W1A001ABrand Toshiba*Code AM727

*Brand may change.

TAGS INLINE SOCKET NOT-INLINE 1KWSize 80x95x100mmWatts 1025WFreq. 2460MHzFV 3.15V 12APAV 4850VPAI 380mAP/No. 2M2466324W1A001LBrand LG*Code MAG2461

*Brand may change.

TAGS INLINE SOCKET NOT-INLINE 1.1KWSize 80x95x100mmWatts 1100WFreq. 2460MHzFV 3.15V 12.5APAV 4850VPAI 380mAP/No. 2M2466324W1A001BBrand LG*Code MAG2462

*Brand may change.

TAGS INLINE SOCKET NOT-INLINE 1.2KWSize 80x95x100mmWatts 1200WFreq. 2470MHzFV 3.6V 12APAV 4850VPAI 330mAP/No. 2M246Brand LG*6324W1A001LCode MAG2463

*Brand may change.

TAGS INLINE SOCKET NOT-INLINE 1.1KWSize 80x95x100mmWatts 1080WFreq. 2460MHzFV 3.15V 12.5APAV 4850VPAI 380mAP/No. 2M282J

MS4842HB6324W1A001EBrand Toshiba*Code MAG2821

*Brand may change.

STUDS INLINE SOCKET NOT-INLINE 850WSize 80x95x115mmWatts 850WGeneral ReplacementP/No. OM75S-10

NL2555-1Code MAG702

STUDS INLINE SOCKET NOT-INLINE 850WSize 80x95x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. A670-02M172AJ/JA/N,2M1282M107A-11/66/8252M107A-82/95/96/972M142,2M157/M2B,FVMZA0108WRKO,H3801-01OM75-10/010,OEM AWICode AM702

STUDS INLINE SOCKET NOT-INLINE 1KWSize 80x95x100mmWatts 1000 (1KW)Freq. 2458MHzFV 3.3VPAV 4000VPAI 300mAEquiv. S1075, OM75,

AM670-02M157 M2B2M161,2M107A,2M218,2M247J

OEM AWICode AM721


TAGS NOT-INLINE 850WSize 95x80x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. A670-WTOH

2M186M22M219JWBOM75(41)S107JWB

OEM AWICode AM706

TAGS NOT-INLINE 850WSize 95x80x100mmWatts 850WFreq. 2458MHzFV 3.15VPAV 4000VPAI 300mAEquiv. A670-FOH2M107A3252M157M12M1612M172FJB2M210M1OM75(11)S107FJBOEM AWICode AM703

TAGS NOT-INLINE 850WSize 95x80x100mmWatts 850WGeneral ReplacementSuit A670-FOH

AM703DE03-30012AOM75S-31DOM75SD-312M204-M12M210-M12M244-M12M244-M23many others

Code MAG708

TAGS NOT-INLINE 1KWSize 95x80x100mmWatts 1000 (1KW)P/No. 2M244-M23Code MAG709

PANASONIC INVERTER TYPETWO MODELS:

Code 2M236M42E

Code 2M261M32G

WARNING!Use forInverter typeovens only!

PANASONIC INVERTER TYPECode 2M261-M22

WARNING!Use forInverter typeovens only!

PANASONIC SMPS PARTSTWO TRANSISTOR OEM KITUpdate Kit from PanasonicIncludes Two TransistorsP/No. A691E4V00GPSP/No. A691E4V10GPQ701 *GT60N321 (G60N90)

AESCGT60N321Q702 1M30D-060

AESPGT30J322

PARTS KITCode KIT691

MORE SMPS PARTSMAY ALSO REQUIRE REPLACINGThe following are parts that themanufacturer recommends replacing:

BRIDGE RECTIFIERAESTRBV6206Code D20XB60

362K 3KV CAPECKK3FF362KDUCode ECK362

CAPACITORSSee last page orSee Section 2

Power Transformers


HIGH VOLTAGE PROBEDONT GET ZAPPED!Test the capacitor forvoltage first. Also forchecking correct voltageand rectification, etc.40KV. 2% 1GW 1000:1 ratio.Suitable for Analogue &Digital Multi-meters.Code HV40

NEON MICROWAVE TESTERIndicates the existenceof microwave energydistribution within theoven cavity with adancing light display.Code TM319

MICROWAVE LEAKAGE MONITORFully tested and calibrated fortesting the integrity of sealsfor microwave leakage.Detects microwave energy withthe one range of 010mW/cm.Includes instructions,battery and carry pouch.With instrument failure indicator.Code TM318

SCREW DRIVERS & FIXING NUTS100MM SHAFT JAPANCode HT15H200MM SHAFT JAPANCode HT15HLG" HEX BITCode HEX815DRILL BIT HOLDERSuit HEX815, etc.Code HTCM40

SEE SECTION 14 FOR MORE......

MAGNETRON FIXING NUTS Supplied ina bag of four.Code M35

TOUCH-UP PAINT FOR MICROWAVEInspect oven and cavities.Scratches may cause sparks andreduce the life of the magnetron.Special paint formulated forMicrowave oven internal surfaces.Touch-up scratches in the cavity, etc.Available in classic white or creamSupplied in little 15ml hobby tins

WHITE15ml MWP15W

CREAM15ml MWP15C

Paint brushes available - See section 14 Tools...

MICROWAVE MANUALThere are many dangers involved inservicing microwave ovens. You shouldprepare yourself with information on thecorrect safety precautions and basicoperations. This 66 page book offers allthis information and much moreincluding oven testing, door leakage,cooking sensors, common faults anddiagnostic flow charts, popularcircuits, and lots of generalknowledge for microwave servicing.A must for every workshop or even forthose of you who are curious abouthow these things operate.Code MAN-MICRO

INNER DOOR LININGClear transparent film.Heat and microwaveproof type plastic.A replacement forthe damaged innerlinings of oven doors.With sticky adhesiveon one side forapplication.Simply cut to sizeand stick on!Size 500x350mmCode ADF535

SECURITY TAMPER LABELSWARNINGWARRANTY VOID IF SEAL BROKEN OR TAMPERED WITH.Place over screws andseals to preventtampering. Suitrepair shops, etc.Special type stickerthat will notpeel off in one go.Convenient dispenser box.

Roll 500 pcs.Code WL500

Miscellaneous


MICRO-SWITCHPREMIUM GRADESafety switches need tobe reliable and dependableChange your door switchwith genuine quality...

MICRO-SWITCH COMMON ECONOMYSingle Pole Double Throw6mm Spade ContactsPower 10A/240VacLever 25mmCode SWM420

OEM PANASONIC MICROWAVE OVEN SWITCHSingle Pole Single ThrowPwr. 15A 240VacCode SW1600

AWI SWITCH ECONOMYPwr. 15ATags 4.6mmCode MS107

AWI SWITCH NORMAL #1HoneywellPwr. 10ATags 4.6mmCode MS098


AWI SWITCH LIGHT PRESSUREHoneywellPwr. 16ATags 4.6mmCode MS298

AWI SWITCH LEVER ACTIONHoneywellLever 25mmPwr. 16ATags 4.6mmCode MS199

ROLLER-LEVER SWITCH 14mmRoller wheel formechanical triggering14mm lever length10A 250Vac FTMCode SWM424

ROLLER-LEVER SWITCH 28mmRoller wheel formechanical triggering28mm lever length3A 250V / 6A 110VCode SWM425

OEM SHARP OVEN SWITCHSharp P/No.QSW-M0085WREOCode SW5110

AWI SWITCH ECONOMYPwr. 16ATags 6.3mmCode MS106



AWI SWITCH LIGHT PRESSUREHoneywellPwr. 16ATags 6.3mmCode MS301

AWI SWITCH LEVER ACTIONHoneywellLever 25mmPwr. 16ATags 6.3mmCode MS202

Door Switch


HVR-1X-3T RECTIFIER DIODESPADE TERMINALSDiode HVR1X3THVCA 12KV 500mA8mS 30A Surge Max.

6mm 4mmCode HD200

HVR-1X-3T RECTIFIER DIODERING VERSIONVolts 12KVDiode HVR1X3TReplace2X062H

HV6X2P6mm RINGCode HD201

HVR-1X-4 RECTIFIER DIODE10K Volts, 500mAGenuine OEM.No Terminals.Code HVR1X4

HVR-1X-7 RECTIFIER DIODE6.35mm Spade to 4mm I/D Ring12KV 550mA Microwave OvenOEM Premium grade diodeAWI D202 HVR3-12 HVR1X-72Code HVR1X7

HV05-12 RECTIFIER DIODEHV05 550mA 12KV RectifierReplacement type diode

4.3mmRINGZA511

6.0mmRINGZA521

MICROWAVE SHORT PROTECTORDiode HVR-2X062H

HVR-062AWI D208P/No. A606V4760JPEquiv. A606V5110BP6mm & 6mmCode HD208

MICROWAVE SHORT PROTECTORNO TERMINALSHV-6X2PI 6KVCode HV6X2P

6mm 6mmCode ZA530

DIODE SETCommon microwave replacement set. HV6X2P & HV05-12Supplied already wired with connectors (6mm).Code ZA018

eg. Replacement forSHARP FHD ZA017 WREO

DIODE SET WITH LEADZA017 Diode set with lead wire off protector diode.Diodes HVR-1X4, 2X062HSharp FW-QZA025WRKO

350 536 0640Code MWD025

PANASONIC PROTECTOR DIODEOriginal cablingA606V5110BPDiode 2X062HCode MWD606

ANE6202 DIODEOrig. P/No.ANE6202-C90eq to ANE6202-F50Code MWD90

75HVP10 DIODEPWR 16KV, 750mAAWI 75-HVP16Code HD204M

ANE6202B60AP DIODECode MWD60

HIGH VOLTAGE DIODESTO RECTIFY & TO PROTECT

REMEMBER TO DISCHARGE THEHIGH-VOLTAGE CAPACITORS !

Generally Protection Diodesfail by going short-circuit.Always replace BOTH Diodes.

Diodes


LAMPS - MICROWAVE CONVECTION & FRIDGEAll lamps are premium quality,designed for use in microwaves.CONVECTION or Temp=300Cwill tolerate heat of convection ovens.

Any lamps will suit fridges, etc.Pictures are accurate at the timeof printing but may vary slightly.

AWI LAMP E14 NARROWCONVECTIONHigh-Temp GlobeP 25W 240VACTemp. 300CCode CL807

PANASONIC E14 NARROWEq. ANE6030Q50GNBase E14 SESWatt 25Volt 240Temp. 300CCode MWL50

AWI LAMP E14 PEARBase E14 SESWatt 15Temp 300CVolt 240Code CL806

AWI LAMP E14 ROUNDBase E14 SESWatt 40Volt 240Code CL801

AWI LAMP E14 LONGBase E14 SESPower 25W 240VACCode CL818

AWI LAMP E17 NARROWBase E17Power 15W 240VACTemp. 300CCode CL815

Power 20W 240VACCode CL821

AWI LAMP E17 NARROW 125VACBase E17Volt 125VACWatt 20WTemp 300CCode CL822

PANASONIC LAMP E17 NARROWOrig. A60304080BPBase E17Watt 250V 20WTemp 300CCode MWL80

PANASONIC LAMP E17 NARROW 125VANE6030540APBase E17Watt 20Volt 125Code MWL40

AWI LAMP E17 ROUND 250VBase E17Power 25W

240VacTemp. 300CCode CL816

AWI LAMP B15 NARROWBase B15 SBCWatt 15Volt 240Code CL803

AWI LAMP B15 ROUNDBase B15 SBCWatt 25Volt 240Code CL808

AWI LAMP B22 NARROWBase BC B22DWatt 15Volt 240Code CL804

Watt 25Code CL809

Lamps


AWI LAMP & BRACKETTags 4.3mmWatt 20Volt 240Suit NEC &

othersCode CL823

AWI LAMP & BRACKETTags 4.3mmWatt 20Volt 240Suit Toshiba

& othersCode CL825

AWI LAMP & BRACKETHigh-temp bulb & base as one40mm between mounting holeswith socket receptacle.Tags 4.3mmWatt 25Volt 240Code CL831

AWI LAMP & BRACKETHi-Temp bulb & base as one40mm between mounting holes25mm(Bulb) 66mm HeightTags 6mmWatt 25Volt 240Code CL827

AWI LAMP & BRACKETBulb & Base One-piece. T17040mm between mounting holes,25mm(Bulb) 60mm HeightTags 4.3mmWatt 25Volt 240Code CL828

SHARP LAMPHorizontal TypeRLMPUA001WRE0350 626 0293Code LMP001

ROOF LINER 450mmSimply cut to shape.Size 450 x 450mmMICACode RF501M



ROOF LINER SANYO OEMSpecific shape.Size 370 x 400mmType MicaSuit Sanyo

& others.Code RF503M

ROOF LINER SANYO OEMSpecific shape.Size 324 x 337mmType MicaSuit Sanyo

& others.Code RF505M

INNER DOOR LININGClear transparentreplacement forlinings of ovendoors. With stickyadhesive on one side.Size 500x350mmCode ADF535

TOUCH-UP PAINT FOR MICROWAVESpecial paint formulated forMicrowave oven internal surfacesTouch-up scratches in the cavityWhite MWP15W15ml

Cream MWP15C15ml

Roof Liners


MICROWAVE VARISTOROrig. ANE604V820JNCode MWV820

PANASONIC MICROWAVE SENSOROrig. ANE601LF70Code MWS601

SHARP THERMISTORConvection MicrowaveTemperature sensorOrig. FH-HZA010WREO

FH-HZA011WREOCode ZA010

SHARP THERMISTORConvection MicrowaveTemperature sensorOrig. FH-HZA041WREOCode ZA041

THERMAL CUT-OFFS 10ACODE TEMP Self ResettingMWT70 70 10A 240VACMWT75 75 Available in CMWT80 80MWT85 85MWT90 90MWT95 95MWT100 100MWT105 105MWT110 110MWT115 115MWT120 120MWT125 125MWT130 130MWT135 135MWT140 140MWT145 145MWT150 150MWT155 155MWT160 160MWT165 165

MICROWAVE GLASS TRAYSuit Sanyo & othersType Trigonal320mm O/DCode GT252

TRAY COUPLERSuit Sanyo

& othersType Trigonal to

Half MoonCode NT48

TRAY CARRIERSMicrowave oven plattersskate on tri-wheel basePlastic, safe materialsDiam. 200mmSuit Many brandsCode RBA251

PORTABLE APPLIANCE TESTERAs part of the new OHS laws in Australia (May Vary BetweenStates) it is required to regularly check power cables, powerboards, appliances such as electric power tools, microwaveovens, plug-in air conditioners, toasters, vacuum cleaners,computers, etc. to ensure that the equipment is electrically safe.The Kyoritsu 6201A is hand-held portable appliance tester thatensures the Safety of Class I and Class II appliances, Extension leads and Leakage Current. Large LCD displays the mainsvoltage, plus other functions. 4 LED indicators and buzzersound identifies if each test has passed or failed. Fuseprotected. Includes Mains cord, Test lead with safety alligatorclip / probe attachments & Extension lead test cable. Made inJapan. Pass / Fail Stickers Not Included. See Below.Code AT6201A

PASS / FAIL STICKERSOn completion of each test of the appliance / cable it isrequired to be labeled with a PASS or FAIL sticker thatis filled in with identification details.

PASS STICKER ROLL OF 250 PIECESCode PASS-TAGS

FAIL STICKER ROLL OF 250 PIECESCode FAIL-TAGS

Thermistor


CAROUSEL MOTOR 16+8mm/10mm240VAC 5RPM 2.5WOrig. GM1624FKC28mm MWM1624

SSM16H C2B72754F10mm TTM463

CAROUSEL MOTOR 20+12mmBody Height 20mmShaft Half moonOrig. MULJ24ZB73240VAC 2.5RPM 2.5WCode MWM462

CAROUSEL MOTOR 16+15mmBody Height 15mmShaft Half moonGM1624FEK1240VAC 5RPM 2.5WCode MWM467

CAROUSEL MOTOR 16+7mmBody Height 16mmShaft Double Flat240VAC 2.5RPMOrig. RMOTDA091WREOP/No. M2LJ24ZA02Code MWM91Orig. RMOTDA133WRE0Code MWM133

CAROUSEL MOTOR 16+11mmBody Height 16mmShaft Double Flat240VAC 2.5RPM 2.5WCode TTM468

Fits X Type tooSubs RMOTDA159WREO

CAROUSEL MOTOR 23+14mmBody Height 23mmDouble FlatOrig. A63265450QP

A63265451QP240VAC 2.5RPM 4WCode MWM450

CAROUSEL MOTOR WIDE FLANGEBody Height 16mmShaft Half-Moon10mm x 7mmOrig. GM-16-2F302

6549W1S017A21VAC 2.5RPM 3WCode MWM6549

AWI FUSES 10 x 38mmCeramic tube Brass nickel plated contact cupsTime delay(T) High breaking capacity.Rating Code8A HRC810A HRC1016A HRC1620A HRC2032A HRC32

MICROWAVE 5,000 VOLT FUSESSupplied complete withfuse holder & 6mm tags.Rating Code600mA MWF60700mA MWF70750mA MWF75800mA MWF801Amp MWF100

FUSESTOO MANY TO LIST HERE !

GLASS FUSES Common TypesCERAMIC FUSES Fast Blow TypesA comprehensive range of fusesStandard Glass tube types asused for 240Vac in microwaves.See Section 2 Components...

AWI FUSES 5 x 20mmCeramic tube Brass nickel plated contact cupsTime delay(T) High breaking capacity.Rating Code125mA AFD.125250mA AFD.2501A AFD11.25A AFD1.251.6A AFD1.62A AFD22.5A AFD2.53.15A AFD3.155A AFD56.3A AFD6.38A AFD810A AFD1012.5A AFD12.5

AWI FUSES 6.3 x 32mmCeramic tube Brass nickel plated contact cupsTime delay(T) High breaking capacity.1A AFC11.5A AFC1.51.6A AFC1.62A AFC23.15A AFC3.155A AFC56.3A AFC6.37A AFC78A AFC810A AFC1012A AFC1215A AFC1516A AFC1620A AFC20

Carousel Motor


Capacitor

10 - 14 Microwave Oven Capacitors

MICROWAVE OVEN BELTSHigh temperature tolorent. As used to rotate trays in ovens.Code . . . . . Orig. . . . . . . . . . A . . . . B . . . . C. . . . . Length . . TypeMWB95 . . . . ANE4060-850 . . . . 95. . . . 7.0 . . . 0.6 . . . . 300 . . . NeopreneMWB100 . . . ANE4060-820 . . . . 100 . . . 7.5 . . . 0.6 . . . . 320 . . . NeopreneMWB110 . . . ANE4060B60AP . . . 110 . . . 7.0 . . . 0.6 . . . . 340 . . . NeopreneMWB260 . . . ANE4110-820 . . . . 260 . . . 3.0 . . . Square. . 800 . . . NeopreneMWB280 . . . ANE4110-860 . . . . 280 . . . 3.0 . . . Square. . 880 . . . NeopreneMWB175 . . . ANE2132580AP . . . 175 . . . 2.5 . . . Round . . 550 . . . Neoprene

CAPACITORSCorrect metal can type replacement capacitors to suit microwave ovensValue . Voltage . . H . . W. . . D. . . . . Tabs . . . Code0.60F 2100 . . . 85 . . 53 . . 33 . . . . 6.3mm . . MWC6010.75F 2100 . . . 85 . . 53 . . 33 . . . . 6.3mm . . MWC4100.75F 2500 . . . 105 . . 53 . . 33 . . . . 6.3mm . . MWC6020.86F 2100 . . . 80 . . 53 . . 33 . . . . 6.3mm . . MWC86 0.90F 2100 . . . 70 . . 53 . . 33 . . . . 6.3mm . . MWC6120.91F 2100 . . . 80 . . 53 . . 33 . . . . 6.3mm . . MWC91 0.91F 2350 . . . 100 . . 53 . . 33 . . . . 6.3mm . . MWC6040.95F 2100 . . . 75 . . 53 . . 33 . . . . 6.3mm . . MWC6130.95F 2500 . . . 105 . . 53 . . 33 . . . . 6.3mm . . MWC6060.97F 2100 . . . 97 . . 52 . . 33 . . . . 6.3mm . . MWC97 1.00F 2100 . . . 75 . . 53 . . 33 . . . . 6.3mm . . MWC6141.05F 2100 . . . 75 . . 53 . . 33 . . . . 6.3mm . . MWC6151.07F 2100 . . . 85 . . 53 . . 32 . . . . 6.3mm . . MWC107 Sharp Original1.07F 2100 . . . 75 . . 53 . . 32 . . . . 6.3mm . . MWC6311.07F 2200 . . . 90 . . 52 . . 33 . . . . 6.3mm . . MWC633 Sharp Original1.07F 2200 . . . 80 . . 53 . . 32 . . . . 6.3mm . . MWC6321.10F 2100 . . . 80 . . 53 . . 33 . . . . 6.3mm . . MWC6161.10F 2500 . . . 130 . . 53 . . 33 . . . . 6.3mm . . MWC4091.13F 2100 . . . 85 . . 53 . . 31 . . . . 6.3mm . . MWC113 Sharp Original1.13F 2100 . . . 85 . . 53 . . 33 . . . . 6.3mm . . MWC6281.14F 2100 . . . 85 . . 53 . . 33 . . . . 4.6mm . . MWC114-41.14F 2100 . . . 95 . . 53 . . 33 . . . . 6.3mm . . MWC114-61.20F 2100 . . . 85 . . 53 . . 33 . . . . 6.3mm . . MWC618

DUAL CAP0.67F + 3x0.28F 2200 65 70 45 6.3MM MWC417

ORIGINAL SHARP CAPACITORSValue . Voltage . . H . . W. . . D. . . . . Tabs . . . CodeSharp . RCQZA192WREO. . . . RCQZA068WREO. . . . RCQZA075WREO

1.13F 2100 . . . 84 . . 52 . . 31 . . . . 6.3mm . . MWC113

Sharp . RCQZA172WREO1.07F 2100 . . . 85 . . 50 . . 32 . . . . 6.3mm . . MWC107

Sharp . RCQZA215WREO1.07F 2200 . . . 90 . . 52 . . 33 . . . . 6.3mm . . MWC633

MICROWAVE REPAIR ASSISTANCE MANUALThere are many dangers involved in servicing microwaveovens. You should prepare yourself with information on thecorrect safety precautions and basic operations. This 66 page book offers all this information and much more including oventesting, door leakage, cooking sensors, common faults anddiagnostic flow charts, popular circuits, and lots of generalknowledge for microwave servicing. A must for everyworkshop or even for those of you who are curious abouthow these things operate.Code MAN-MICRO

CONTENTSMagnatrons 10-2Power Transformers 10-6Miscellaneous 10-7Door Switch 10-8Diodes 10-9Lamps 10-10Roof Liners 10-11Thermistor 10-12Carousel Motor 10-13Capacitor 10-14

10 Microwave

Documents

Transcript of 10 Microwave