DELUGE VALVE AND SKID
The Deluge system is designed to protect high hazard areas
containing a severe fuel hazard with a high heat release rate by
bringing a large number of open sprayers into action simultaneously
in the event of a fire or in the event of high Temperature to keep
equipments and asset on lower temperature.
A Deluge System can be activated by the following:
1. Manually (Push Buttons on Control Panel or Local Manual
Release Valve)
2. Electrically (F&G Signals )
3. Pneumatically (Glass Bulb Detectors)
4. Hydraulically (By pass valve)
‐To make sure that the Deluge Valve will be activated on any
condition, sometimes more than 1 activating mode are considered.
Also Deluge Valves could be supplied on 2 modes:
• On‐Off Valve
• Pressure Control Valve (Due to high pressure of Fire Water Pumps
or high Pressure Differential on Fire Water Ring Main and Spray
Nozzles, it needs to control outlet pressure of Deluge Valve.)
Deluge Skid (Customized):
A Deluge System can be a simple Valve or Skid mounted along with
By‐Pass Line, Isolating Valves, Strainers, Full Test/ Drain Line, Double
Inlet / Outlet, Release Monitoring Devices (High Pressure Switch),
Release Alarm Device (Hydraulic), Pressure Gages on Upstream and
Downstream of Deluge Valve, Pneumatic Line including Air
Regulator with by‐pass Line, Air Back‐Up Reservoir, Check Valves,
Isolating Valves, Pressure Safety Valve (PSV), Pressure Switch (Low
and Low‐Low), Junction Box, Weather Proof Cabinet and Lights AND
Heating Sys for cold‐weather places.
Material of Construction of Deluge Valve:Main Valve Body & Cover:
• Ductile Iron ASTM A‐536* UL, ULC
• Cast Steel ASTM A216‐WCB* UL, ULC
• Naval Bronze ASTM B‐61 UL, ULC
• Nickel Aluminum Bronze ASTM B148 UL, ULC
• Super Duplex Stainless Steel UL, ULC
• Stainless Steel ASTM A743‐CF‐8M UL, ULC
Main Valve Internal Trim:
• Bronze ASTM B61
• Monel QQ‐N‐281 Class B
Diaphragm and Disc:
• Buna‐N® synthetic rubber
Material of Construction of Deluge Skid:
Depends on location of plant, Seawater and Fresh Water are
demanded for fire fighting. Skid Piping should be suitable to
withstand against highly corrosive water . Cu‐Ni Piping and Ni‐Al
Bronze Deluge Valve are selected for Seawater demanded fire
water. As well as Skid and its cabinet is coated with suitable painting
to withstand against highly Saliferous and corrosive environment
(Marine Environment )
Hazardous Area:
On Oil and Gas Projects, all Instrument ( Solenoid Valves, Pressure
Switches, Junction Boxes, Control Panels and lightings) and
considered suitable for Classified Hazardous Area,
• Zone1, IIB, T3, IP 65,
• ZONE 2, EEXD IIB T3
• ATEX EEx dm IIC T4, IP65
CERTIFICATES:
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 1 - CVREFFPDE.doc - 09/08
Platforms
Norway / Statfjord-field
Statfjord C platfrom Fire protection pressure relief valves: Model 2050B-4KG-1
Norway / Valhall oil field
BP Valhall Redevelopment Fire protection pressure relief valves: Model 50B-4KG-1 size 10" in Super Austenitic Stainless UNS S32760
Russia / Sakhalin
Sakhalin Molikpaq platform Deluge valves: Model series 134 size 6" in Ni-Al-Brz (ATSM B-148) Pressure relief valves: Model series 50 size 4" and 6" in Monel 400
North Sea
GSF Artic III Pressure reducing valves
Qatar
PS-4 platform Fire pump protection valves: Model series 50 size 10" in Super Austenitic Stainless UNS S31254 Air release and vacuum Breaker: Model 33-A size 4'' in Super Duplex Stainless Steel UNS J93404
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 2 - CVREFFPDE.doc - 09/08
Libya
AGIP Gas Libyan Branch - Sabratha Platform Project HYUNDAI HEAVY INDUSTRIES Co Angle pressure relief valves: Model series 50 size 12" in Ni-Al-Brz (ATSM B-148) Air release and vacuum Breaker: Model 33-A size 2'' in Ni-Al-Brz (ATSM B-148)
Germany / North Sea
Platform H-7 Fire pump pressure relief valves: Model series 50-20 size 6'' in cast steel
Norway / North Sea
EKOFISK II complex Fire pump pressure relief valves: Model series 50-20 size 6'' in cast steel
Sea Launch
Sea Launch Platform Pressure relief valves Deluge valves
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 3 - CVREFFPDE.doc - 09/08
Industry Plants
United Arab Emirates / Abu Dhabi
Borouge 2 World's Largest Ethylene Cracker (EU2) Deluge valves: Model series 134 size 3"-4”-6”-8” in Cast Steel (ATSM A216 WCB)
Turkey / Izmit
Gasoline Specification Improvement Project (GSIP) at the Izmit Refinery Deluge valves: Model series 134 size 3"-4”-6”-8”-10” in Ductile Iron and Stainless Steel
UAE /Jebel Ali
EMOIL PETROLEUM PRODUCTS STORAGE AND DISTRIBUTION TERMINAL AT JAFZ; JEBEL ALI Deluge valves: Model series 134 size 2", 3", 4", 6", 8"and 10" in Ni-Al-Brz (ATSM B-148)
Portugal / Sines
Steam Cracker Capacity Creep project REPSOL POLIMEROS, LDA Deluge valves: Model series 834 size 3”, 4” and 6" in cast steel
China / Guangdong
Guangdong liquefied natural gas (LNG) terminal Pump pressure relief valves: Model series 50 size 6" in Ni-Al-Brz (ATSM B-148) Air release and vacuum Breaker: Model 33-A size 2'' in Ni-Al-Brz (ATSM B-148) Model 33-A size 4'' in Ni-Al-Brz (ATSM B-148)
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 4 - CVREFFPDE.doc - 09/08
Congo / Moho-Bilondo field
Deep offshore Moho-Bilondo field Air release and vacuum breaker valves Pressure reducing valves Fire pump pressure relief valves
Nigeria
AKPO Field development project Fire water and cooling water system High capacity air release and vacuum breaker valve with pressure relief function: sizes 3”, 4” ,6” and 8” in Ni-Al-Brz (ATSM B-148)
Nigeria
Yoho Development Project EPC2 NIGERIAN NATIONAL PETROLEUM CORPORATION (NNPC) Mobil Producing Nigeria Limited (MPN) Deluge valves: Model series 134 size 6" & 8" in Ni-Al-Brz (ATSM B-148)
Nigeria
Ehra Project EPC1 Air release and vacuum Breaker: Model 33-A size 3'' & 4" in Monel and size 10” Air release and vacuum Breaker: Model 33-A size 3'' & 4" in cast steel
Belgium / Antwerp
ANTWERP GAS TERMINAL Deluge valves: size 4"
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 5 - CVREFFPDE.doc - 09/08
France / Toulouse
Assembly hall Airbus A380 Fire protection pump relief valves Angle fire pump pressure relief valves: Model series 50 size DN 400 / PN 16
France / Porcheville
2400 MW thermic power plant AFFF foam system fire protection Pressure differential valves: Model series 250 size DN 50 / PN 16
France / Fos-Cavaou
Terminal Méthanier de Fos-Cavaou Air release and vacuum breaker valves: size 8”
Sub Structures
Sweden / Stockholm
Hallandsås Tunnel Project Pressure reducing valves: Model series 90 size 3"
Switzerland / Bassecourt
Fire protection system for the largest Swiss electrical transformer. Fire protection pressure reducing valves: Model series 90 size DN 200 / PN 16 Deluge control valves: Model series 134 size DN 200 / PN 16
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 6 - CVREFFPDE.doc - 09/08
High Rise Buildings / Hotels
United Arab Emirates / Dubai
Burj Dubai Skyscraper - The World's Tallest SS 316 Electro-polished stainless steel pressure reducing valves sizes DN 80; DN 100; DN 150 equipped with the unique LFS internal Low Flow Feature. SS 316 Electro-polished stainless steel 55F pressure relief valves.
Egypt /Alexandria
FOUR SEASONS HOTEL SAN STEFANO Fire protection pressure reducing valves: Model series 90-21 Fire pump pressure relief valves: Model series 50B-4G-1
United Arab Emirates / Abu Dhabi
Emirates Palace Pressure reducing valves with the unique LFS internal Low Flow System On/Off level control valves UL/FM fire protection valves
Qatar / Doha
Pearl Qatar Fire protection pressure reducing valves: Model series 90-21 Fire pump pressure relief valves: Model series 50B-4G-1
Germany / Frankfurt
Frankfurter Main Tower Fire protection pressure reducing valves: Model series 90 size DN 100 / PN 25
CLA-VAL Projects and References Fire Protection / Partial List
CLA-VAL Europe www.cla-val.ch [email protected] 7 - CVREFFPDE.doc - 09/08
Qatar / Doha
Fire protection pressure reducing valves: Model series 90-21 Fire pump pressure relief valves: Model series 50B-4G-1
Qipco Twin Towers
Al Noor Tower
2B+G+21 Tower
M Tower
Al-Reem Tower
Mergab Twin Towers
Qipco Tower
Dolphin Tower
La Cigal Hotel
West Bay Complex
Mercedes Showroom
Al-Faisal Tower (ASHGHAL)
West Bay Complex Four Seasons Hotel
City Center expansion Phase II & III
Luxury Hotel & Furnished Apartment
Top Related