XLS1000 – 2500 Service Manual - Audio Lab of Ga

XLS1000 – 2500

Service Manual

142195-1 4/10

XLS3 Tech Support.doc

XLS-3 MENU:

The XLS main menu structure communicates functionality of the amplifier in terms of its input routing (MODE), filter selection (FILTER), and frequency of the filter (FREQ)…when available.

MODE: Amplifier audio routing.

STEREO: Channel 1 input to Channel 1 output, Channel 2 input to Channel 2 output.

BRIDGE: Channel 1 input to Channel 1, with the inverted Channel 1 input to Channel 2. By taking the two positive outputs of the amplifier, twice the output voltage (twice the power) is realized. In BRIDGE mode, Crossover (XOVER) filters are not allowed since the same audio is required for both output channels.

INPUT Y: Channel 1 input to both Channel 1 and Channel 2’s processing and output. Switching occurs pre-pot and pre-filter.

FILTER: Audio filtering.

BYPASS: Both channels are full spectrum audio (20Hz – 20KHz). In BYPASS mode, no FREQ choice is allowed.

LOWPASS: Both channels are 4th order Linkwitz-Riley filters with frequency breakpoint determined by the FREQ choice.

HIGHPASS: Both channels are 4th order Linkwitz-Riley filters with frequency breakpoint determined by the FREQ choice.

XOVER: When XOVER is selected, the MODE choice is automatically changed to INPUT Y. Channel 1 is fed to both channels’ processing with Channel 1 being Lowpass and Channel 2 being Highpass. The crossover frequency is determined by the FREQ choice.

CLIP COMPRESSOR: Allows the clip compressor for each channel to be either turned on or off. The Clip compressor is a proprietary algorithm that limits clipping on a real-time basis.

DIAGNOSTIC MENU:

A set of diagnostic menus can be accessed at anytime by pushing all three menu buttons at the same time. The amplifier continues to pass audio, but the diagnostic menus are displayed until the MODE/MENU button is pushed and normal amplifier functionality returns.

MODEL & VOLTAGE TYPE: Displays the Model and voltage type.

POWER SUPPLY TEMP & LOW VOLTAGE RAIL: Displays the Power Supply Heatsink Temperature and the Low Voltage rail (in volts).

AMPLIFIER CHANNEL TEMP: Displays the heatsink temperature for the power devices of each channel.

HIGH VOLTAGE RAILS: Indicates the Amplifier voltage rails, Positive (VP) and Negative (VN).

FIRMWARE VERSION: Shows the firmware version.

FAULT STATUS: Indicates the latest fault that the amplifier has had and the number of instances of that fault. Refer to the Error Codes section for specific Fault/Error codes.

ERROR CODES:

The amplifier’s processor runs through a series of Power On Self Tests (POST) when the amplifier is first powered up. If the processor encounters an error, it will communicate the error via the front panel Thermal LED’s.

These error codes are unique and based upon a Major and Minor element. The Major element is determined by which portion of the amplifier failed POST, while the Minor portion is which part of the Major element failed. They are displayed by CH1 Thermal LED = MAJOR, CH2 Thermal LED = MINOR. The MAJOR is blinked 1st, then the MINOR.

MAJOR MINOR ERROR COMMENT

0 1 Processor POST Fail Internal MCU error (PLL, etc)

0 2 Processor Assert Fail Something catastrophic in the firmware.

0 3 Processor Watchdog Fail Firmware error where watchdog timeout has not been attended.

0 4 Power Fail Power Sequencing of the Power Supply has failed.

1 1 LCD POST Fail Initialization of LCD failed

1 2 LCD Communications Fail MCU unable to communicate with LCD. Can occur anytime as opposed to POST

2 1 DSP Boot Fail MCU is unable to boot the DSP via I2C

2 2 DSP POST Fail MCU was able to boot the DSP, but not able to communicate and control.

2 3 DSP Communications Fail Can happen anytime. Would have been found via Boot or POST failure if full time I2C problem

3 1 RUBY POST Fail Unable to communicate with Ruby on amplifier board initially.

3 2 RUBY Communications Fail I2C communications failure for some reason. Not caught at POST

3 3 RUBY ADC Sensor Fail An illegal ADC value was encountered by MCA via Ruby

4 1 MFGTEST Result Byte Failure APM’s MFGTEST byte indicates test failure or not

tested.

4 2 MFGTEST GPIO Comm Fail APM is unable to communicate with the MFG Test fixture’s I2C GPIO registers.

4 3 MFGTEST ADC Comm Fail APM is unable to communicate with the MFG Test fixture’s I2C ADC registers.

CHASSIS LEVEL SELF-TEST:

This test is used to ensure the functionality of the LCD, Buttons, and Fan once the amplifier is assembled. The self-test is initiated by holding down the PREVIOUS (middle) button during power up. The amplifier enters a test mode where all of the front panel LED’s except the SPI indicators are lit. Additionally, the fan is at full speed and the LCD indicates which of the three front panel buttons are pushed. Once all three buttons have been pushed and released, the test completes and the amplifier returns to normal operation.

APM SECTION THEORY OF OPERATION

ANALOG INPUTS: The input to the APM can accept 1.4Vrms input and drive the resultant APM output to a level that drives the amplifier to full rated power into 8Ω. The differential analog inputs come from J700 which connects to the MAIN board of the amplifier. The input XLR, ¼”, and RCA connectors tie directly to this point on the MAIN board. The following will be for CH2, with CH1 being identical except for the analog Y input switch (U601).

U600-A,B form a differential to single ended gain stage with a gain of -3.54dB. See Gain Block Diagrams below. The output of U600B drives the input of U601, which is a unity gain amplifier that selects either the ‘A’ input (CH2) or ‘B’ input (CH1) dependent upon the INPUT_Y drive from the microprocessor (Q600 to U601-1). U601 provides the Input Y audio routing. The output of U601 drives front panel pot R610 that feeds single ended amplifier section U600-C. This stage has a maximum gain of +13.86dB as shown.

For CH2, the output of U601-5,6 drives a comparator, U700-B, that lights the front panel SPI LED when the input signal is >-40dBu. R600/601 provides the DC bias

that provides the comparator reference point. For CH1, the input to the SPI indicator comes from U500-7.

U600-D acts as a unity gain inverter that creates a differential signal (+6dB gain) to feed the attenuator for either the TI DSP’s ADC (XLS1000) or Cirrus Codec (XLS1500, 2000, 2500). For the XLS1000, R618-619, R621-623 form a voltage divider and bias network into the TI DSP (CH2±_DSP_AD). In the case of the XLS1500 – 2500, R613-614, R617, R620 form the voltage divider and bias network into the Cirrus codec (CH2±_AD).

As you can see, the major difference between the XLS1000 and XLS1500 – 2500 APM’s resides in the use of an external Cirrus Codec (U702) for the larger amplifiers. This results in ~4dB better S/N, but at an additional cost of $2.

ANALOG OUTPUTS: The output of the APM is driven by a differential gain stage (U701-C,D) that receives its input from the DAC. In the case of the XLS1000, the DAC resides within the TI DSP (CH2±_DSP_DA), while in the case of the XLS1500 – 2500, the DAC is part of the Cirrus codec (CH2±_DA). This gain stage matches the output of the DAC to the amplifier’s input requirement of 5.66Vrms to drive the amplifier’s output to full rated power.

DIGITAL PROCESSING:

The TAS3202 is an integrated converter and DSP that provides all of our signal processing at an affordable cost. The IC is powered from +3.3V and uses ~200mA.

Clock Generation:

The amplifier runs from a single clock that is generated by the TAS3202 (U703) using the 24.576MHz crystal, Y700. This clock is divided by 2 internally by the DSP and sent to the microprocessor (MCLK_UP) and Cirrus codec (MCLK_CODEC). The fundamental clock is divided internally in the DSP to 768KHz and sent to Divide-by-2 (U704-B) to provide differential 384KHz to the MAIN board’s Ruby PWM IC and the 384KHz is then divided by U704-A to provide 192KHz to the MAIN SMPS via J700.

Digital Audio:

The DSP runs at 48KHz sampling rate and also requires that the external codec also samples at 48KHz. The DSP utilizes I2S digital audio to get audio to/from the external codec (DSP_SDIN, DSP_SDOUT). The timing diagram below shows the relationship between serial clock (SCLK), channel clock (LRCK), and digital audio (SDIN, SDOUT).

CLIP Inputs:

The Ruby IC (U1) on the MAIN PWA supplies individual channel clip indications via J700. In order to get these clip indications directly into the TI DSP (U703) as an input for the clip compressor, a 2nd I2S input is used. The channel clip indications (CLIP1 & CLIP2) are gated into their own I2S channel using the LRCK signal and U708. CLIP1 events are gated onto the ‘L’ I2S channel and the CLIP2 events are gated onto the ‘R’ I2S channel. This provides 48KHz sampling of the Ruby clip events into the DSP for the clip compressor.

Serial Communications:

The TAS3202 has two I2C channels: I2C1 and I2C2 for external communications and booting. The DSP initially tries to use I2C2 to access an external EEPROM to boot itself. In this design, an external EEPROM is not used and the DSP is booted from the microprocessor (U706) via I2C1. The DSP acts as a slave with the processor being the master. Control for filter selection, frequency setting, input level monitoring, clip events, and other control and monitoring functions are handled thru this serial communications port.

NOTE: Don’t confuse I2C with I2S. Both are used in this device. I2C is a 2-wire serial communications protocol that allows an external processor to boot, monitor, and control the TAS3202. I2S is a 3-wire serial digital audio protocol that supports 2 channels of real-time audio and allows digital audio to move in and out of the TAS3202.

Thermal Limiter Compressor (TLC):

There are thermistors that monitor each of the amplifier channel’s heatsinks as well as one that monitors the heatsink for the secondary diodes (±Vcc) of the power supply. The TLC adjusts the gain at a rate of 1.25dB/°C at temperatures greater than 75°C. The TLC takes the worst case of the three thermistor readings and adjusts both channels at the same rate.

compressor threshold

0

5

10

15

20

25

30

35

70 80 90 100

Temp (C )

Gain reduction (dB)

Series1

Bridge Mode:

As can be seen by the DSP signal flow, when the amplifier is placed in Bridge mode, CH1 signal is taken post-crossover, inverted, and sent to CH2 output. This ensures that the gains are matched and that the same signal is on both outputs (CH2 = -CH1). When in Bridge mode, both channel’s clip signals are or’ed together and the output clip indicators are driven from the same signal.

MICROPROCESSOR CONTROL: Boot & POST:

The microprocessor boots from its internal FLASH and does a variety of Power On Self-Tests (POST). See the Error Codes section of the manual for a description of all of the error codes and their meanings.

RUBY Interface:

Part of the processor’s POST involves interface with Ruby and ensuring that it is up and working. The processor has two separate I2C interfaces: One for Ruby (I2C1) and one for the TI DSP (I2C2).

DSP Interface:

As discussed previously, the processor boots the DSP via the dedicated I2C port. Processor interfacing for various controls and monitoring is via this interface.

LCD Interface:

The LCD is purchased as a module and has an interface composed of an Enable, Read/Write, Register Select, and Data Lines. The module works in nibble mode where only Data Lines LCD_D[7:4] are used. The module has an internal character register that generates the correct letter in the correct position based upon the processor’s inputs. While the LCD module runs from +5V, the processor utilizes +3.3V. The interface works due to the processor’s LCD’s I/O lines using open drain outputs with +5V pullups.

Bias for the LCD’s contrast is provided via the processors PWM output that is filtered by R725/C761. The module’s LED backlight is set by R730 from +5V.

Front Panel LED’s & Switches:

The processor monitors the (3) front panel control switches and provides the necessary interface to the display and amplifier. In addition, the processor monitors the thermal sensors from Ruby and provides thermal LED lights during over temperature. The processor lights the output -20dB, -10dB, and CLIP LED’s as required.

PWM DeadTime Control:

Although not presently used, the processor has the capability of changing the switching deadtime of the PWM amplifier channels through the use of the processors PWM outputs and filtering.

Fan Control:

The processor monitors the thermal sensors as discussed earlier and controls the fan speed using a PWM output and filter R704/C721. The curve below shows the relationship of temperature to fan speed.

PWM as a function of temp

0.0

10.0

20.0

30.0

40.0

50.0

60.0

70.0

80.0

90.0

100.0

0 20 40 60 80 100

Temp ( C )

PWM register

raw equation

fan speed

BOM: 141558-4 XLS1500/2000/2500 APM

REF. DES. CPN DESCRIPTION

MAP LOC.

C500 139719-1 CAP, 1.0UF 25V X7R 10% 0805 F 2

C501 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO B 2

C502 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO B 2

C503 A11369-101J1 100PF 50V 5% NPO 0603 B 2

C504 126623-1 47UF 16V 6.3X5.5MM 20% SMT C 2

C505 A11369-101J1 100PF 50V 5% NPO 0603 A 2

C506 A11369-101J1 100PF 50V 5% NPO 0603 A 2

C507 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 A 3

C508 126623-1 47UF 16V 6.3X5.5MM 20% SMT B 3

C509 126623-1 47UF 16V 6.3X5.5MM 20% SMT A 3

C511 OPEN B 3

C512 A11369-101J1 100PF 50V 5% NPO 0603 A 2

C513 A11369-101J1 100PF 50V 5% NPO 0603 A 2

C514 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 B 1

C515 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 1

C516 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C517 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 B 2

C518 126623-1 47UF 16V 6.3X5.5MM 20% SMT A 1

C519 126623-1 47UF 16V 6.3X5.5MM 20% SMT A 2

C600 139719-1 CAP, 1.0UF 25V X7R 10% 0805 F 2

C601 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO G 1

C602 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO G 2

C603 A11369-101J1 100PF 50V 5% NPO 0603 G 2

C604 126623-1 47UF 16V 6.3X5.5MM 20% SMT G 2

C605 A11369-101J1 100PF 50V 5% NPO 0603 G 2

C606 A11369-101J1 100PF 50V 5% NPO 0603 G 2

C607 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 3

C608 126623-1 47UF 16V 6.3X5.5MM 20% SMT F 3

C609 126623-1 47UF 16V 6.3X5.5MM 20% SMT E 3

C611 OPEN D 4

C612 A11369-101J1 100PF 50V 5% NPO 0603 B 2

C613 A11369-101J1 100PF 50V 5% NPO 0603 B 2

C614 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 B 2

C615 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C616 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 1

C617 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 B 1

C618 126623-1 47UF 16V 6.3X5.5MM 20% SMT C 2

C619 126623-1 47UF 16V 6.3X5.5MM 20% SMT B 1

C620 135505-1 CAP, 0.1UF 25V 10% X7R 0603 F 2

C621 135505-1 CAP, 0.1UF 25V 10% X7R 0603 F 2

C700 135505-1 CAP, 0.1UF 25V 10% X7R 0603 F 2

C701 135505-1 CAP, 0.1UF 25V 10% X7R 0603 F 2

C702 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 2

C703 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 2

C704 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C705 135505-1 CAP, 0.1UF 25V 10% X7R 0603 A 2

C706 139947-1 CAP, 10UF 10V 10% X5R 1206 A 3

C707 141914-104KB CAP, 100NF 16V 10% X7R 0402 A 3

C708 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C709 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C711 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C713 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2

C714 OPEN D 2

C715 OPEN D 2

C716 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 2

C717 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 2

C718 139719-1 CAP, 1.0UF 25V X7R 10% 0805 D 3

C719 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 2

C720 138663-1 CAP, 10UF 6.3V X5R 0805 D 2

C721 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 2

C722 139947-1 CAP, 10UF 10V 10% X5R 1206 B 3

C723 141914-104KB CAP, 100NF 16V 10% X7R 0402 B 3

C724 141914-104KB CAP, 100NF 16V 10% X7R 0402 B 3

C725 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 3

C726 126623-1 47UF 16V 6.3X5.5MM 20% SMT B 3

C727 141914-104KB CAP, 100NF 16V 10% X7R 0402 B 3

C728 138663-1 CAP, 10UF 6.3V X5R 0805 C 3

C729 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C730 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C731 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C732 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C733 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C734 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 4

C735 138663-1 CAP, 10UF 6.3V X5R 0805 C 4

C736 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO C 2

C737 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO C 3

C738 138663-1 CAP, 10UF 6.3V X5R 0805 B 3

C739 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C740 138663-1 CAP, 10UF 6.3V X5R 0805 B 3

C741 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C742 138663-1 CAP, 10UF 6.3V X5R 0805 C 3

C743 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C744 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 4

C745 138663-1 CAP, 10UF 6.3V X5R 0805 C 4

C746 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C747 138663-1 CAP, 10UF 6.3V X5R 0805 C 3

C748 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 3

C750 141914-104KB CAP, 100NF 16V 10% X7R 0402 E 2

C751 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 3

C752 141914-104KB CAP, 100NF 16V 10% X7R 0402 E 2

C753 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 2

C754 141914-104KB CAP, 100NF 16V 10% X7R 0402 E 3

C755 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 2

C756 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 3

C757 141914-104KB CAP, 100NF 16V 10% X7R 0402 F 3

C758 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 2

C759 141914-104KB CAP, 100NF 16V 10% X7R 0402 G 3

C760 141914-104KB CAP, 100NF 16V 10% X7R 0402 D 3

C761 139719-1 CAP, 1.0UF 25V X7R 10% 0805 F 2

C762 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C763 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C764 141914-104KB CAP, 100NF 16V 10% X7R 0402 B 3

C765 141914-104KB CAP, 100NF 16V 10% X7R 0402 C 3

C766 138663-1 CAP, 10UF 6.3V X5R 0805 E 2

D500 135343-1 DIODE, DUAL MMBD4148SE SOT-23 B 2

D501 135343-1 DIODE, DUAL MMBD4148SE SOT-23 B 2

D502 OPEN B 2

D503 OPEN B 2

D600 135343-1 DIODE, DUAL MMBD4148SE SOT-23 G 1

D601 135343-1 DIODE, DUAL MMBD4148SE SOT-23 G 1

D602 OPEN G 2

D603 OPEN G 2

E500 126473-1 LED, GRN SMT 1206 B 2

E600 126473-1 LED, GRN SMT 1206 G 2

E700 131105-1 LED, RED 638NM 1206 SMT B 3

E701 131105-1 LED, RED 638NM 1206 SMT B 3

E702 126473-1 LED, GRN SMT 1206 B 3

E703 126473-1 LED, GRN SMT 1206 B 2

E704 131105-1 LED, RED 638NM 1206 SMT G 3

E705 131105-1 LED, RED 638NM 1206 SMT G 3

E706 126473-1 LED, GRN SMT 1206 G 3

E707 126473-1 LED, GRN SMT 1206 G 2

E708 141620-1 LCD, 38MMX16MM 40X16 DOT BKLIGHT E 3

FB700 125846-1 FERRITE BEAD, 600 OHM .5A 0805 B 3


FB702 125846-1 FERRITE BEAD, 600 OHM .5A 0805 C 2


HW1 OPEN D 1

HW2 OPEN E 1

HW3 OPEN F 1

HW11 141621-1 SPCR, 0.098"X0.18"X0.156" NYL D 3

HW12 141621-1 SPCR, 0.098"X0.18"X0.156" NYL D 2

HW13 141621-1 SPCR, 0.098"X0.18"X0.156" NYL F 3

HW14 141621-1 SPCR, 0.098"X0.18"X0.156" NYL F 2

J700 141746-1 CON, FFC 50P ZIF LOC LTCH SM HOR C 2

J702 OPEN F 3

J703 141668-1 HDR, 6POS TH G 3

PWB1 141557-4 PWB, XLS3 DISPLAY

Q600 C 7448-1 MMBT3904 CHIP NPN F 2

R500 A11371-2250 RES, 2.2 MOHM 1/16W 5% 0603 F 2

R501 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 F 2

R502 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 2

R503 A11371-2223 2.2K 0.25W 5% 1210 T/R F 2

R504 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF B 2

R505 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF B 2

R506 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF B 2

R507 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF B 2

R508 A11368-10000 RES, 100 OHM 1/16W 1% 0603 B 2

R509 A11368-66511 RES, 6.65 KOHM 1/16W 1% 0603 B 2

R510 138593-1 POT, ALPHA RV110T-40E1-125A-B10K-0E C 3

R511 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 C 2

R512 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 A 2

R513 A11368-82500 RES, 825 OHM 1/16W 1% 0603 A 3

R514 A11368-82500 RES, 825 OHM 1/16W 1% 0603 A 3

R515 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 2

R516 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 2

R517 A11368-15000 RES, 150 OHM 1% 1/16W 0603 A 3

R518 OPEN B 3

R519 OPEN B 3

R520 A11368-15000 RES, 150 OHM 1% 1/16W 0603 A 3

R521 OPEN B 3

R522 OPEN B 3

R523 OPEN B 3

R524 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 A 2

R525 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 A 2

R526 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 A 2

R527 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 A 2

R528 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 1

R529 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 2

R530 A11368-40200 402 OHM 1/16W 1% 0603 T/R B 2

R531 A11368-75000 RES, 750 OHM 1/16W 1% 0603 B 1

R532 A11368-75000 RES, 750 OHM 1/16W 1% 0603 B 2

R533 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 A 3

R535 OPEN A 2

R536 OPEN A 2

R537 OPEN B 2

R538 OPEN B 2

R539 OPEN C 2

R600 A11371-2250 RES, 2.2 MOHM 1/16W 5% 0603 F 2

R601 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 F 2

R602 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 2

R603 A11371-2223 2.2K 0.25W 5% 1210 T/R F 2

R604 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF G 1

R605 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF G 1

R606 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF G 1

R607 140467-10020 RES, 10KOHM 0.063W 0.1% 0603 THNF G 2

R608 A11368-10000 RES, 100 OHM 1/16W 1% 0603 G 2

R609 A11368-66511 RES, 6.65 KOHM 1/16W 1% 0603 G 2

R610 138593-1 POT, ALPHA RV110T-40E1-125A-B10K-0E F 3

R611 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 G 2

R612 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 G 2

R613 A11368-82500 RES, 825 OHM 1/16W 1% 0603 A 3

R614 A11368-82500 RES, 825 OHM 1/16W 1% 0603 B 3

R615 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 G 2

R616 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 G 2

R617 A11368-15000 RES, 150 OHM 1% 1/16W 0603 A 3

R618 OPEN D 4

R619 OPEN D 4

R620 A11368-15000 RES, 150 OHM 1% 1/16W 0603 B 3

R621 OPEN D 4

R622 OPEN D 4

R623 OPEN C 4

R624 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 B 2

R625 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 B 2

R626 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 B 2

R627 A11368-15010 RES, 1.5 K OHM 1/16W 1% 0603 B 2

R628 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 2

R629 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 1

R630 A11368-40200 402 OHM 1/16W 1% 0603 T/R B 1

R631 A11368-75000 RES, 750 OHM 1/16W 1% 0603 B 2

R632 A11368-75000 RES, 750 OHM 1/16W 1% 0603 B 1

R633 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 A 3

R635 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 2

R636 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 2

R639 OPEN G 3

R700 OPEN A 3

R702 A11368-40200 402 OHM 1/16W 1% 0603 T/R A 3

R703 A11368-40200 402 OHM 1/16W 1% 0603 T/R A 3

R704 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 F 2

R705 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R706 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 4

R707 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 4

R708 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 4

R709 A11368-10000 RES, 100 OHM 1/16W 1% 0603 C 3

R710 A11368-10000 RES, 100 OHM 1/16W 1% 0603 C 3

R711 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R712 A11368-10040 RES, 1.00 MOHM 1/16W 1% 0603 C 3

R713 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 3

R714 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 3

R715 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 3

R716 A11368-22120 RES, 22.1 KOHM 1% 1/16W 0603 B 3

R717 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 2

R718 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 E 2

R719 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 E 3

R720 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 E 3

R721 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 E 2

R722 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R723 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R724 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R725 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 E 2

R726 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 C 2

R727 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 C 2

R728 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 3

R729 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 3

R730 A11368-10000 RES, 100 OHM 1/16W 1% 0603 D 3

R731 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 2

R732 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R733 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 3

R734 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 3

R735 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R736 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R737 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 B 3

R738 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 B 3

R739 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 B 3

R740 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 B 2

R741 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 G 3

R742 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 G 3

R743 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 G 3

R744 A11368-34001 RES, 340 OHM 1% 0.1W SMT 0805 G 3

R745 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 E 2

R746 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 2

R747 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 2

R748 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 3

R749 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 E 2

R750 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 2

R751 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 3

R752 OPEN E 3

R753 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 E 3

R754 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 F 3

R755 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R756 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 3

R757 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 D 2

R758 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 F 3

R759 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 F 3

R760 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 F 2

R761 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 F 2

R762 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 E 3

R765 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 B 3

R766 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 3

R767 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 3

R768 A11368-10000 RES, 100 OHM 1/16W 1% 0603 E 2

R769 A11368-10000 RES, 100 OHM 1/16W 1% 0603 E 2

R772 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 4

R773 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 E 3

R776 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 E 3

R777 A11368-10000 RES, 100 OHM 1/16W 1% 0603 F 3

R778 A11368-10000 RES, 100 OHM 1/16W 1% 0603 F 3

S700 141850-1 SW, 1P1T PB 250V 50MA SM VRT D 2

S701 141850-1 SW, 1P1T PB 250V 50MA SM VRT E 2

S702 141850-1 SW, 1P1T PB 250V 50MA SM VRT F 2

U500 C 9012-3 OP AMP, QUAD LO NOISE MC33079D B 2

U600 C 9012-3 OP AMP, QUAD LO NOISE MC33079D G 2

U601 141622-1 IC, OPAMP HISPD W/SW NJM2121 SO8 F 2

U700 126559-1 COMPARATOR, LM393 SO-8 DUAL F 2


U702 138251-1 IC, CS4272 24 BIT 192KHZ CODEC B 3

U703 141593-1 IC, DSP 48BIT 135MHZ I2C TAS3202 PQFP64 C 3

U704 C10344-7 74HC74AD DUAL D FLIP FLOP SOIC D 2

U706 141881-1 IC, MCU 32BIT 36MHZ FLASH128KB LQFP64 E 3

U707 141588-1 IC, REG LDO 3.3V 800MA LD1117 TO-252 D 2

U708 135219-1 IC, 74HC00 QUAD 2-IN NAND E 3

Y700 140549-1 XTAL, 24.576MHZ HC49SM 30PPM 18PF C 3

600061NONE

REFERENCE DESIGNATIONS============================500-599 IS CHAN #1 SPECIFIC600-699 IS CHAN #2 SPECIFIC700-799 IS NOT CHAN SPECIFIC800-899 IS ADAPTOR BOARD

ANALOG SECTION

2 OF 3

CH2SPI

CH1SPI

A

--N

C

--N

C

PWA, XLS3 DISPLAY 1500/2000/2500

NOTES: SEE 141558-4_A.XLS FOR DATA & REVS 1. ALL RESISTORS ARE IN OHMS, 0.1W, 1% UNLESS OTHERWISE SPECIFIED. 2. ALL CAPACITORS ARE IN MICROFARADS UNLESS OTHERWISE SPECIFIED.

141558-4

R5292.49K

R6292.49K

R537OPEN

R535OPEN

R531750

R6002.2M

5%

R5032.2K

0.25W5%

R50210K

R6032.2K

0.25W5%

R60210K

R532750

R5282.49K

R6282.49K

R536OPEN

R538OPEN

R631750

R632750

C603100PF

R5002.2M

5%

-

+

U700-A

2

31

LM393D

-

+

U700-B

6

57

LM393D

-

+

U700-C8

4

LM393D

-

+

U701-E4

11

MC33079D

-

+

U701-B

6

57

MC33079D

-

+

U701-D

13

1214

MC33079D

-

+

U701-C

9

108

MC33079D

-

+

U701-A

2

31

MC33079D

R5241.5K

R5251.5K

R6241.5K

R6251.5K

R5261.5K

R5271.5K

R6261.5K

R6271.5K

R63510K

C5001

E500GRN

E600GRN

R630402

R530402

R608100

C6001

C613100PF

C7080.1

C512100PF

C7010.1

C7000.1

C513100PF

C612100PF

C7090.1

C6162200PF

1%

C6152200PF

1%

C5162200PF

1%

C5152200PF

1%

C514680PF

1%

C614680PF

1%

C617680PF

1%

C517680PF

1%

R702402

R703402

R700OPEN

R53310K

D5004148SE

R508100

D5014148SE

-

+

U500-B

6

57

MC33079D

-

+

U500-A

2

31

MC33079D

-

+

U500-E

4

11

MC33079D

-

+

U600-E

4

11

MC33079D

C503100PF

C50122PF

C50222PF

C7020.1

C7030.1

C7040.1

C7050.1

R513825

R514825

C5074700PF

5%

R63610K

D6004148SE

-

+

U600-A

2

31

MC33079D

Q600MMBT3904

B-INP

B+INP

V+

OUT

SW CTRL

A-INP

A+INP

V-

U601

1

2

3

4 5

6

7

8

NJM2121

C60122PF

C60222PF

C6200.1

C6210.1

-

+

U600-B

6

57

MC33079DD601

4148SE

R6112K

C6074700PF

5%

R613825

R614825

R63310K

C706

10V

10

C707100NF

16V

+

C518

16V

47

+

C519

16V

47

+

C618

16V

47

+

C619

16V

47

+

C604

16V

47

R5096.65K

R6096.65K

R610-A

3

2

1

4 10K

R510-A

3

2

1

4 10K

R5112K

+

C504

16V

47

R617150

R620150

R520150

R517150

R607

0.1%10K

R606

0.1%10K

R605

0.1%10K

R604

0.1%10K

R504

0.1%10K

R505

0.1%10K

R506

0.1%10K

R507

0.1%10K

R5014.99K

R6014.99K

R518OPEN

+

C609

16V

47

-

+

U600-D

13

1214

MC33079D

+

C509

16V

47

C605100PF

R61210K

-

+

U500-D

13

1214

MC33079D

R519OPEN

R619OPEN

R51210K

R618OPEN

R623OPEN

C611OPEN

R6152.49K

-

+

U600-C

9

108

MC33079D

+

C608

16V

47

R621OPEN

R622OPEN

R6162.49K

C606100PF

D602OPEN

C505100PF

R523OPENC511

OPEN

R5152.49K

-

+

U500-C

9

108

MC33079D

+

C508

16V

47

R521OPEN

R522OPEN

R5162.49K

C506100PF

D603OPEN

D503OPEN

D502OPEN

SHEET

B

C

D

A

345678 2

1345678 2

B

C

D

A

1

REV

PROJ NO.SCALE

SIZE DWG NO.

DTHESE DRAWINGS AND SPECIFICATIONS ARE THEPROPERTY OF CROWN INTERNATIONAL, INC. ANDSHALL NOT BE REPRODUCED, COPIED, OR USEDAS THE BASIS FOR THE MANUFACTURE OR SALEOF APPARATUS OR DEVICES WITHOUT PERMISSION.

UNLESS OTHERWISE MARKED IN RED INK BY CM AS ACONTROLLED COPY, COPIES OF THESE DOCUMENTSINCLUDING ASSOCIATED ELECTRONIC REPRODUCTIONSARE FOR REFERENCE ONLY.

UNCONTROLLED

TITLE

CH2+

CH1+_DA

CH1-_DA

CH2-_DA

CH1

CH1-

CH1+

CH2+_DA

CH2-

CH2

CH1+_DSP_DA

CH1-_DSP_DA

CH2-_DSP_DA

CH2+_DSP_DA

VQ1

CH1+_AD

CH1-_AD

IN_CH1+

IN_CH1-

CH1

IN_CH2-

CH2

CH1

INPUT_Y

IN_CH2+

CH2-_AD

CH2+_AD

CH2-_DSP_AD

CH1-_DSP_AD

CH2+_DSP_AD

CH1+_DSP_AD

+3.3V

-LV

-LV-LV

+LV

+3.3V

+LV

-LV

+5VA+3.3VA

+LV

-LV

+LV

-LV

-LV

+LV

DB3

600061NONE

REFERENCE DESIGNATIONS============================500-599 IS CHAN #1 SPECIFIC600-699 IS CHAN #2 SPECIFIC700-799 IS NOT CHAN SPECIFIC800-899 IS ADAPTOR BOARD

A

3 OF 3

DIGITAL

K

DB1

MODE/MENU

DB0

CH2

NEXT

PREV

THERM

DB2

LCD CONN

CLIP

NC----

-20

-10

CLIP

THERM

NC----NC----NC----

-10

CH1

-20

NC---

----NC

AMP CONN

----NC

PROCDEBUG

---NC

2

1

3

----NC

----NC

A

----NC----NC----NC

NC----NC----

PWA, XLS3 DISPLAY 1500/2000/2500

NOTES: SEE 141558-4_A.XLS FOR DATA & REVS 1. ALL RESISTORS ARE IN OHMS, 0.1W, 1% UNLESS OTHERWISE SPECIFIED. 2. ALL CAPACITORS ARE IN MICROFARADS UNLESS OTHERWISE SPECIFIED.

141558-4

R744340

0.10W

R74510K

R74710K

R74610K

R740340

0.10W

R737340

0.10W

R74810K

J703

1

2

3

4

5

6

R738340

0.10W

R739340

0.10W

R741340

0.10W

R742340

0.10W

R743340

0.10W

R7211K

XTP21

XTP20XTP23

R7762K

R75733.2

R715

33.2

R7732K

R714

33.2R71110K

FB700

R71622.1K

R75510K

R75610K

U708-B

4

56

74HC00D

U708-D

12

1311

74HC00D

U708-A

1

23

74HC00D

U708-C

9

108

74HC00D

U708-E14

7

74HC00D

C750100NF

16V

R70510

U704-C

14

7

74HC74AD

D

CLK

CL

'Q'

Q

PR

U704-A1

2

3

4

5

6

74HC74AD

R76010K

R7612K

R720 33.2

R76210K

XTP16

R704100K

R7261K

R7271K

R71933.2

J700

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

R7121M

Y70024.576MHZ

R76633.2

E707GRN

E706GRN

E703GRN

E702GRN

E700RED

E701RED

E704RED

E705RED

C7251

C7111

C7131

C7181

C7621

C7631

C73622PF

C73722PF

U707

VIN

GND

VOUT

LD1117

R765 33.2

R7722.49K

S700

1 3

2 4

S701

1 3

2 4

S702

1 3

2 4

C72210

10V

R768 100R769 100

C715OPEN

C714OPEN

FB701

R76733.2

C766

6.3V10

AOUTA+

AOUTB-AOUTB+

SDIN

XTOXTI

VA

AINB-

VCOM

AGND

AINA+

MCLKI2SM1M0

SCLK

VD

VL

AINA-

AINB+

FILT+

SDOUT

/AMUTEC/BMUTEC

DGND

/RST

AOUTA-

LRCK

U702

12

3

45

67

8

9

10

111213

14

15

1617

1819

20

21

2223

2425

2627

28

CS4272

C747

6.3V

10C745

6.3V

10

C740

6.3V

10C738

6.3V

10C742

6.3V

10

C728

6.3V

10

C720

6.3V

10

R777 100R778 100R749

10KR754

1K

I2C2_SCL

REXT

AIN1R+

CS0

AIN2R+

VR_PLL

I2C2_SDA

AIN2L-

/RST

/MUTE

AIN1R-

I2C1_SDA

VR_ANA

SDIN2

DVS

S1

DVS

S3

DVS

S2

AVSS3

AVSS2

AVSS1

GPIO2

VR_DIG

AIN2R-AIN2L+

GPIO1

VMID

I2C1_SCL

VREF

SDIN1

/PDN

AIN1L+AIN1L-

NC

AOUTL+

MCLK OUT1

NC

LRCK IN

NC

XO

AOUTL-

NC

SCLK IN

NCNC

AOUTR-

MCLK OUT2

NCNC

AOUTR+

NC

SCLK OUT

RESV/VREG_EN

XI

MCLK IN

MCLK OUT3

LRCK OUTSDOUT

DVD

D3

AVD

D1

AVD

D2

DVD

D1

AVD

D3

DVD

D2

U703

12

34

5

6

7

89

10

11

12131415

16171819

20212223

24

25

26

27

28

29303132

33343536

37

38

39

40

4142

43

44

45

464748

4950

5152

53

54

55

56

57

5859

6061

62

6364

TAS3202

+C726

16V

47

PA12PA13PA14PA15

PA1

PC12

PC1PA2

PC11

PC15

VSS_3

VDD_1

PC9

PA11

PA0

PA10PA9

PA5PA4PA3

PA8PA7PA6

PC0

PC4

PD1/OSC_OUT

VBAT

PB0

VDD_4VDD_3

PB4PB3BOOT1PB1

PB12

PB14

PB5

VDD_2

PB6PB7

PB11

PB15

PB13

PB8PB9PB10

VSS_4

VSS_1VSS_2

VSSA

VDDA

PD2

PC2

PC7

PC14

PC5

PC10

BOOT0

NRST

PC3

PC8

PD0/OSC_IN

PC6

PC13

U706

1

234

56

7

891011

12

13

14151617

18

19

20212223

2425

262728

2930

31

32

33343536

37383940

414243444546

47

48

4950

515253

545556575859

60

6162

63

64

STM32F101C8T6

FB702

FB703

C757100NF

16V

C756100NF

16V

C759100NF

16V

C717100NF

16V

C719100NF

16V

C716100NF

16V

C723100NF

16V

C724100NF

16V

C764

16V

100NF

C727100NF

16V

C760100NF

16V

C751100NF

16V

C752100NF

16V

C753100NF

16V

C754100NF

16V

C755100NF

16VC735

6.3V

10

C721100NF

16V

C729100NF

16V

C730100NF

16V

C731100NF

16V

C748100NF

16V

C744100NF

16V

C743100NF

16V

C739100NF

16V

C746100NF

16V

C741100NF

16V

C765

16V

100NF

R75

92

K

R75

82

K

R70

710K

R70

810K

R75

110K

R70

610K

R75310K

R709100

R710100

R752OPEN

R730100

R73610K

E708

1 2

3 4

5 6

7 8

9 10

11 12

13 14

15 16

DISPLAY R73110K

R73210K

C7611

R733 33.2

R734 33.2

R7251K

R72410K

R72310K

R72210K

R729 33.2

R728 33.2

R73510K

C758100NF

16V

D

CLK

CL

'Q'

Q

PR

U704-B

13

12

11

10

9

8

74HC74AD

R71733.2

R71833.2

R75033.2

R71333.2

C732100NF

16V

C733100NF

16V

C734100NF

16V

J702

123456789

10111213141516171819202122232425

OPEN

SHEET

B

C

D

A

345678 2

1345678 2

B

C

D

A

1

REV

PROJ NO.SCALE

SIZE DWG NO.

DTHESE DRAWINGS AND SPECIFICATIONS ARE THEPROPERTY OF CROWN INTERNATIONAL, INC. ANDSHALL NOT BE REPRODUCED, COPIED, OR USEDAS THE BASIS FOR THE MANUFACTURE OR SALEOF APPARATUS OR DEVICES WITHOUT PERMISSION.


UNCONTROLLED

TITLE

CH1-_ADCH1+_AD

CH2-_ADCH2+_AD

VQ1

CODEC_/RST

CLKN384K

CLKP384K CLKP192K

CLKN192K

MCLK_CODEC

DSP_SDOUT

SCLK

CH2+_DSP_DACH2-_DSP_DACH1+_DSP_DACH1-_DSP_DA

CLIP1

LRCK

CLIP2

CLKP384K

CLKN384K

CLIP2

CLIP1

CH1-

CH1+

CH2-

CH2+

CLKP192K

CLKN192K

I2C1_SDA

I2C1_SCL

SOFTSTART

CH1_RELAY

CH2_RELAY

STBY_1

STBY_2

FAN

IN_CH1+

IN_CH1-

IN_CH2+

IN_CH2-

CH1_DT

CH2_DT

AMP_SENSE

CH1_DT_PWMCH1_DT

FAN_PWMFAN

CH2_DT_PWMCH2_DT

MCLK_UP

LRCK

CH1-_DA

MCLK_CODECSCLK

CH1+_DA

LRCK

DSP_SDOUT

CH2+_DA

DSP_SDIN

CH2-_DA

I2C2_SCLI2C2_SDA

DSP_SDIN

DSP_/BOOT

DSP_/RST

CH2-_DSP_ADCH1+_DSP_ADCH1-_DSP_AD

CH2+_DSP_AD

AMP_SENSE

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3VA

+3.3VA

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3VA

+3.3V

+3.3V

+3.3V

+3.3V

+LV

-LV

+3.3V +LV

+3.3V

+3.3V

+3.3V

+5VA

+3.3V +3.3V

+5VD

+5

+5

+3.3V

+3.3V

+3.3V

+5VD+5VD

+5VD

+5VD

+5VD

SW_MODE/MENU

SW_PREV

SW_NEXT

CH1_THERM

CH1_CLIP

CH1_-10

CH1_-20

CH2_THERM

CH2_CLIP

CH2_-10

CH2_-20

LCD_EN

LCD_D5

LCD_D7

LCD_RS

LCD_RW

LCD_D4

LCD_D6

LCD_PWM

JTAG_TRST

JTAG_TDO

JTAG_TDI

JTAG_TCK

JTAG_TMS

UART_RX

UART_RX

UART_TX

UART_TX

UC_/RST

UC_/RST

BOOT0

BOOT0

SW_MODE/MENU

CH1_THERMCH1_CLIP

CH1_-10CH1_-20

CH2_THERMCH2_CLIP

CH2_-10CH2_-20

SW_PREVSW_NEXT

MCLK_UP

CH1_RELAYCH2_RELAY

LCD_RS

UC_/RST

BOOT0 BOOT0

LCD_RWLCD_EN

JTAG_TDIJTAG_TCKJTAG_TMSAMP_SENSE

CH1_DT_PWMCH2_DT_PWM

INPUT_Y

FAN_PWM

SOFTSTART

UART_RXUART_TX

LCD_PWMDSP_/BOOT

I2C1_SDA

CODEC_/RSTCODEC_/RST

JTAG_TRSTJTAG_TDO

DSP_/RST

I2C2_SCLI2C2_SDA

LCD_D7LCD_D6LCD_D5LCD_D4

I2C1_SDAI2C1_SCL

STBY_2STBY_1I2C1_SCL

AMPLIFIER SECTION THEORY OF OPERATION

Amplifier Block Diagram: One channel shown w/ common Ruby Since the 2 channels are the same we will discuss just channel one and know that the same applies to channel two.

Balanced to unbalanced input stage. The channel one balanced audio enters the amplifier at one of the back panel connectors J101, J102 or J3. The signal is then routed to the APM (Audio Processing Module) through J700B pins 3 and 4. The function of the APM is covered elsewhere in this document. The signal returns from the APM on J700B pins 6 and 7. It is converted from balanced to un-balanced at U101B where it is filtered before being combined with the feedback signal at the junction of R108 and R115. This combined signal connects to the error amplifier opamp inside the Ruby IC ( U1 ) at pin 61. We will go into detail of the Ruby IC a little later but for now let’s look at the feedback circuitry.

Feedback Circuits. The feedback circuit is comprised of two distinct feedback paths, the High Frequency feedback and the Low Frequency feedback. The Low frequency feedback comes directly from the output signal at the output relay which maximizes the damping factor. The Low Frequency feedback is fed into U101D, pin 13, through the resistors R132 and R133. This circuit attenuates the output signal to a level acceptable to U101C, provides the 2V DC offset required by the Ruby error amplifier, filters out the higher frequency switching content and provides the low frequency/DC feedback to be summed with the High Frequency Feedback.

The High Frequency Feedback comes directly from the switching node at the junction of the output MOSFETs and the input to the output filter at L101. This signal has the full switching signal on it and therefore must be filtered. R139/140 and C176 provide the first filtering to attenuate the VHF spectrum. The next filter is a notch filter tuned to the 384KHz switching frequency and includes R139/138/137/136 as well as C137/138/139. This notch filter attenuates the switching frequency and passes it on to the next 2 filtering done by C136 and C135. This additional filtering helps to keep the switching noise out of the feedback while allowing the audio band signals to pass at an attenuated level to U101A. The feedback summing is done by resistor/capacitor network at R126/127/128/129 C130/131/132. This summing combines the HF Feedback and LF Feedback in equal parts to create a resultant full audio band feedback. U101C does the function of buffering the summed feedback and adds phase lead ( C128/129; R125 ) to improve stability margin. The feedback signal out of U101C is then further filtered by the 2nd harmonic (768KHz) trap comprised of R116/117/118/119 and C122/123/124. Passing through R115 we are back to the combining point of the input signal and the feedback which as stated earlier goes to the Ruby (U1) error amplifier.

The Ruby signal path. Before the Ruby IC (U1) will pass a signal the STBY pin (17, 18) must be pulled high. This line is an open collector output/input on Ruby so an external source can pull the pin low to inhibit PWM switching ( Q101 ) or the Ruby IC can pull the line low in case of a Ruby determined fault condition. This pin must be high for the Ruby to be enabled. The ruby error amplifier uses a triple integrated feedback (C116-121 and R109-111) to maximize the amount of feedback in the audio frequency range. R142 and C158 provide a high frequency load for the error amp to improve the internal opamp stability. Inside of the Ruby IC the resultant error signal is compared to the Ruby generated triangle wave which creates the PWM signal used to drive the Output Stage. Ruby varies the amplitude of the triangle wave based on the Vcc voltage it senses through R7-10 which it also uses for an overvoltage protection circuit. U2-B is a buffer/filter for the Ruby Reference Voltage called VR on the schematic. This VR signal connects directly to the Ruby error amp and must be highly filtered to reduce noise injected into the feedback.

The Output Stage. The PWM signal from Ruby ( pin 54 ) drives the gate drive IC (U102). The transistors Q102 and Q109 use the PWM signal to determine if the gate drive IC should be enabled and will only enable U102 if there is a valid PWM signal coming from Ruby. U102 does several functions. First it translates the signal from the ground referenced signal that Ruby provides to signals capable of driving the MOSFETs that are referenced to –Vcc (Q104) and to the switching node (Q103). This drive signal is buffered by Q110-113 in order to provide adequate current to drive the MOSFETs.

U102 has programmable dead-time which can be changed by the APM through a programming current drive into Q107-108. U102 provides current limit protection for the MOSFETs. R153-154 set the negative current limit and R158-159 set the positive current limit. U102 provides under-voltage protection for the MOSFETs to protect against low gate drive voltage. U102 is supplied 12V for the low side drive from the gate supply powered from the LVAC winding on the transformer and is regulated to 12V by U3. The output PWM from the MOSFETs is filtered by L101 and a series of capacitors as shown on the schematic. Further reduction of the switching frequency ripple is achieved by the 384KHz trap consisting of C147/173 and L102. L102 is tuned for minimum ripple at the output terminals. From the output filter the signal passes through a relay (K101) before going to the output terminals. The relay is controlled by the APM and is enabled after the power on self test has passed.

Ruby control circuits. The Ruby IC is placed in slave mode and in order for Ruby to function it must be provided a clock signal on pins 5 and 6. This is a 384KHz signal that is provided by the APM. It must be powered by 5VDC at pins 29,30,38 and 59. Pins 12 and 13 provide I2C communications with the APM. The Ruby IC has several ADC channels that the APM reads and uses to control the operation of the amplifier. These inputs are all referenced to the VREFSAR internal voltage reference which is buffered by U2A. RT1 is a temperature sensor (NTC) placed under the Secondary Diode heatsink and is connected to pin 19. This temperature is then read by the APM and used to limit the temperature in case of a fault. RT101 is a temperature sensor (NTC) placed under the Channel 1 heatsink and is connected to pin 53. This temperature is then read by the APM and used to limit the temperature in case of a fault. RT201 is a temperature sensor (NTC) placed under the Channel 2 heatsink and is connected to pin 52. This temperature is then read by the APM and used to limit the temperature in case of a fault. As mentioned before a scaled version of the +/-Vcc levels are connected to pins 20 and 21. These signals can be queried by the APM and also will shut down the PWM signal in case of an overvoltage on the Vcc’s.

A scaled version of the output signal is also provided to the Ruby (pins 22 and 24) and is available to the APM. The LVAC signal is rectified and provided to pin 23 for the APM and is used to display line voltage and provide under voltage and overvoltage protection in case the line voltage is out of bounds. R13 programs the current applied to the Ch1 and Ch2 temperature sensors. Pins 15 and 16 provide a signal informing the APM that a clip event has occurred. It will be triggered by either a voltage limit or current limit event. R22/23/24 provides a way for the APM to know what model of amplifier it is connected to. See the chart below.

XLS 2000/2500 Amplifier Theory of operation. The XLS2000 and XLS2500 are very similar to the XLS1000/1500 and so only the differences will be discussed here.

XLS 2000/2500 Output Stage. There are value differences of some of the resistors and capacitors but the main difference in the amplifier section, between the 1000/1500 and the larger 2000/2500, is in the output stage topology. Were the 1000/1500 uses the MOSFET body diode to carry the current to the Vcc supplies when the MOSFET is turned off, the 2000/2500 uses diodes D108, 109 to block the current and force it though the anti-parallel diodes D105, 106. This improves the efficiency of the amplifier. The rest of the amplifier circuits are the same as the smaller amplifiers. The APM determines the model and voltage rating of the amplifier by the values of R22, 23 and R24. Below is a chart showing the values for each model.

Model Voltage Part

Number R22 R23 R24

XLS1000 100V 141576 Open 10K 1.1K

XLS1000 120V 141577 Open 10K 2.49K

XLS1000 220V 141578 Open 4.99K 2.49K

XLS1000 240V 141579 Open 4.99K 4.99K

XLS1500 100V 141580 Open 2.49K 4.99K

XLS1500 120V 141581 Open 2.49K 10K

XLS1500 220V 141582 Open 1.1K 10K

XLS1500 240V 141583 Open 10Ω Open

XLS2000 100V 141607 20K 15K Open

XLS2000 120V 141608 20K 20K Open

XLS2000 220V 141609 15K 20K Open

XLS2000 240V 141610 1.1K 2K Open

XLS2500 100V 141603 10K 1K Open

XLS2500 120V 141604 10K 2K Open

XLS2500 220V 141605 20K 6.81K Open

XLS2500 240V 141606 20K 10K Open

PWR SUPPLY SECTION THEORY OF OPERATION

Note:

• Any component references will be to the 141576-4 thru 141583-4, 141607-5 thru 141610-5, and 142028-3 thru 142031-2 PWAs. Later PWAs should be compatible except where additions have been made.

• Underlined text references components that are only used on 141607-5 thru 141610-5, and 142028-3 thru 142031-2 PWAs.

Brief summary of operation

The power supplies of the XLS series of amplifiers are efficient and light weight, but yet extremely robust switchmode designs. The topology of the main supply employed is a half-bridge series resonant converter. The use of this topology allows for soft switching of the main semiconductors Q903 and Q906 reducing dissipation at idle and throughout the operating power range. Two other buck derived switching power supplies are employed. One serves as a bias supply for the main power supply and the other generates the +5V from the low voltage output of the main supply

Front end This power supply is equipped with an internal EMI filter that both reduces the transfer of power supply related noises onto the power line, and improves the power supplies immunity from voltage transients on the power line. The AC line voltage is converted to DC by a bridge rectifier D901. 120Vac and 100Vac models use voltage doubler, while 220V and 230-240Vac models use a full wave rectifier. Z901 determines this operating mode. It is present on the 120Vac and 100V models, and is open on the 220V and 230-240Vac models When switch S901 is closed the bulk storage capacitors C911, C912, C955, and C956 begin charging thru the PTC (RT901). This PTC limits the inrush current, eliminating circuit breaker trips at turn on. After the charging cycle is complete the soft start relay (K901) bypass the PTC.

Bias Supply The main supply’s integrated control IC & gate driver (U902) is powered by a primary referenced 15V buck power converter that is supplied by the “V_BULK” rail. The heart of this bias supply is the Power Integration LinkSwitch-TN control IC (U901). This IC contains an integrated MOSFET, control circuitry, current limit, and thermal protection. It provides a regulated 15V during power up, normal operation, brownouts and line transients. The Buck converters major components are the integrated MOSFET in U901, freewheeling diode D903, filter inductor L903, and filter capacitor C915. Voltage feedback to the control IC is feedback thru D902 which charges C914 only when the freewheeling diode D903 is conducting. The voltage stored on C914 is scaled down by R909 and R908 which feed pin #2 of U901. The control loop within U901 adjusts the duty cycle of the MOSFET in the order of 60,000 times per second such that the voltage on Pin #2 remains constant. This mechanism regulates the +15V output voltage.

Main supply The main supply consists of a half-bridge power converter utilizing two IGBT power devices, a center tapped secondary transformer, a full-wave secondary rectifier, a half

wave-secondary rectifier, and control circuitry. In addition two components are added to form a resonant tank which significantly increases the overall efficiency of the converter. The IGBTs, Q903 and Q906, switch at approximately 40% duty cycle each at a frequency of 96kHz. During their on time period the IGBTs transfer energy from the primary bulk storage (C911, C912, C955, and C956) and the AC line through the resonant tank (C923//C954 & L904) to the transformer, T901. The energy is magnetically coupled to the secondary of the transformer, rectified by D905-D908, and stored in C925 & C926 for the amplifier to use. The transformer (T901) magnetizing inductance results in a small triangular shaped current flow in the primary of the transformer. This current provides a soft switching action to the IGBTs by charging/discharging the parasitic capacitance of the devices during dead time such that the IGBT turns on with near zero voltage across its collector to emitter terminals. This reduces power loss on the IGBTs. As the power output increases, the voltage developed across the resonant capacitor (C923//C954) reduces this effect. Another form of soft switching is also employed with the additional of components: C923//C954 & L904 that form a series resonant tank. The resonant frequency of this tank circuit is greater than that of the switching frequency. The tank forces the load current to be drawn in half sinewave portions. Thus the current drops to near zero before the IGBTs gate is turned off. This is a form of zero current turn off, which greatly reduces the dissipation associated with the turn off of the IGBTs, and thus results in higher power supply efficiency. The current through the converter is passively limited two main variables. The maximum current through the converter is directly proportional to the driving “VBULK” voltage and by the impedance of the tank itself, C923//C954 & L904. This along with the proper selection of semiconductors (Q903, Q906, and D905-D908) and temperature limiting result in a very robust design. A single auxiliary winding on the transformer is half-wave rectified by D909 & D910, creating both the “+LV” and “-LV” unregulated supplies. Another supply is also derived from this winding via an AC coupled voltage doubler referenced to the “-VCC” supply. This output is then regulated to +12V referenced to “-VCC” via U3 for the gate drive ICs U102 & U202. Modulating the main converter is a control IC with an integrated high side gatedriver (U902), and a comparator (U903) that controls when the converter starts and stops. Both sections of the comparator U903 outputs must be high for the converter to run. Comparator section U903A output goes high when the “+15V_CONTROL” voltage above 13V and goes low when “+15V_CTRL drops below 12V. U903B enables the power supply if the AC supply voltage above 75% of the nominal line voltage, and disables it is the AC supply voltage is below 50% of nominal line.

C947 & R910 set the free running frequency of the internal oscillator of U902, until synchronization to the master clock is achieved. The deadtime between when one IGBT turns off and the other one turns on is set by R911. During startup C917 forms a time constant with R911 that determines the rate at which the duty cycle increases from 0% (off) at startup to the final duty cycle of approximately 40% on each switch when it is running. the duty cycle is also forced to zero when either comparator section of U903 goes low. Transistors Q901, Q902, Q904, and Q905 increases the current available to drive IGBTs Q903 and Q906 over what U902 can source or sink.

Low voltage Power Supply A regulated and noise +5V supply is required by the APM/Display and U1. This is generated with a buck topology switching power supply operating from the “+LV” rail and switches at 192 kHz when synchronized. Q908, D911, L905, C950, and C940 process the power, and U905 a TL494 control IC contains the control loop and modulator. The free running oscillator frequency is set by R942 which controls the charging current of C944. The +5V output is filtered by R938, and C941 before it is fed directly into the mom-inverting input (U905 pin#1) of the TL494 internal error amp. This error amp is a non-inverting stage, and is compensated by components R940, R939, and C942. A second error amp is used as a 7.5V under voltage lockout is formed by R943 & R944. Its purpose is to prevent the converter from starting when the supply voltage is too low to for the internal +5V reference (U905 pin#14) to maintain regulation. P channel MOSFET Q908 is turned on via R937 & R936 when the gate driver output (U905 pin#8&11) of the control IC pulls low.

Soft Start Relay control The softstart relay (K901) provides an alternate high current path around the power switch (S901) and the inrush limiting PTC (RT901). This maximizes the rail voltage available for improved power output compared to simpler NTC inrush limiting designs. The microprocessor U706 controls the softstart relay via common base transistor Q911 which supplies base current to Q912 which switches the relay on and off. D915 is present to catch the flyback voltage coming off K901 as it de-energizes. Softstart relay (K901) engages once the microprocessor determines that the +Vcc and –Vcc rails are with their nominal range. If the rails are either too high or too low the softstart relay will disengage to protect the power supply and amplifier channels.

Temperature sensor circuit The NTC temperature sensor RT1 measures the temperature of the main secondary diodes (D905-D908) which are mounted to a heatsink (HS3). This sensor is a surface mount 0603 NTC that picks up the heatsink temperature near diode D906.

Synchronization circuit and AC Buss generation The synchronization circuit forces the +5V supply to switch at 192 kHz, which is half of the amplifier stages switching frequency. It also forces the main supply to switch at 96

kHz, one quarter the amplifier switching frequency. The synchronization is necessary to prevent beat tones from forming in the amplifier output stage. A 192 kHz balanced square wave signal is generated on the APM and is routed to the main board via J700B pins #24 & #25. Q909 resets the timing cap (C944) on the +5V control IC (U905) when the “CLKP192K” signal rises, forcing the control IC to operate at this frequency. Optocoupler (U906) transfers the clock signal from the secondary ground referenced side to the primary AC line referenced side. Transistor Q910 turns on when the Optocoupler output voltage rises, when this happens C947 is charged as the emitter voltage drops. This forces U902, the main supply control IC to follow synchronization signal.

Fan Driver Circuit A variable speed 12V fan is controlled by the uP via the fan driver circuit. The fan driver uses a simple NPN (Q907) pass transistor and a feedback control loop (U904) to regulate the voltage applied to the fan to four times the “FAN” drive voltage. The feedback control loop is purposely slow responding so that it does not react to the impulsive motor currents drawn by the brushless DC fan motor. This isolates –LV supply from these noise currents, yet precisely regulates the fan to desired voltage.

BOM: 141581-5_A XLS1500/120V MAIN PWA REF. DES. CPN DESCRIPTION

MAP LOC.

C1 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C2 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C3 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 1

C4 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 1

C5 135505-1 CAP, 0.1UF 25V 10% X7R 0603 K 1

C7 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C8 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C10 OPEN C 5

C11 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2

C12 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 4

C13 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C14 103429-474K8 CAP, 470NF 250V 10% X7R 1812 I 3

C15 C 4477-3 470 UF 35V VERT I 3

C16 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R E 2

C17 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C18 135505-1 CAP, 0.1UF 25V 10% X7R 0603 E 2

C19 139947-1 CAP, 10UF 10V 10% X5R 1206 C 1

C20 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 1

C21 139947-1 CAP, 10UF 10V 10% X5R 1206 C 1

C22 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C98 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C100 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 5

C101 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 5

C102 A11369-101J2 100 PF 50V 5% NPO MLC 0805 T/R A 5


C104 A11369-101J2 100 PF 50V 5% NPO MLC 0805 T/R B 5




C108 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 1

C109 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 A 1

C110 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C111 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 A 1

C112 130561-1 10UF 25V 20% ALUM ELEC SMT T/R B 2

C113 102438-150J2 CAP, 15PF 5% 200V NPO 0805 C 2

C114 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C115 A11369-101J2 100 PF 50V 5% NPO MLC 0805 T/R C 5

C116 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 C 2

C117 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C118 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C119 A11369-102F2 1000PF 50V 1% CHIP CAP B 2

C120 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 2

C121 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C122 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C123 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C124 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C125 OPEN B 3

C126 OPEN B 2

C127 OPEN B 2


C129 A11369-121J1 CAP, 120PF 50V 5% NPO 0603 B 2

C130 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C131 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C132 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C133 132191-1 CAP, 22UF 16V ELECTROLYTIC SMT A 2

C134 A11369-391F2 CAP, 390PF 1% 50V 0805 A 2

C135 102438-150J2 CAP, 15PF 5% 200V NPO 0805 A 2

C136 102438-470J2 47PF 200V 5% NPO 0805 A 1

C137 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C138 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C139 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C141 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 3

C142 130561-1 10UF 25V 20% ALUM ELEC SMT T/R E 3

C143 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 3

C144 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 2


C146 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD I 4

C147 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD H 4



C150 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD J 4


C152 135224-1 .001UF 10% 500V X7R MLC 1206 H 4

C153 135224-1 .001UF 10% 500V X7R MLC 1206 J 5

C154 103429-474K8 CAP, 470NF 250V 10% X7R 1812 G 2

C155 103429-103J5 0.01UF 250V 5% X7R 1206 T/R F 3

C156 103429-103J5 0.01UF 250V 5% X7R 1206 T/R F 2

C157 103429-474K8 CAP, 470NF 250V 10% X7R 1812 F 3

C158 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 3

C159 135224-1 .001UF 10% 500V X7R MLC 1206 J 5

C160 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 3

C161 135224-1 .001UF 10% 500V X7R MLC 1206 J 5

C162 135224-1 .001UF 10% 500V X7R MLC 1206 L 4

C163 135224-1 .001UF 10% 500V X7R MLC 1206 L 4

C164 135224-1 .001UF 10% 500V X7R MLC 1206 M 4

C165 OPEN J 5

C166 OPEN J 5

C167 135505-1 CAP, 0.1UF 25V 10% X7R 0603 E 2

C168 OPEN L 5

C169 OPEN L 5

C170 OPEN G 3

C171 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2

C172 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2



C175 135224-1 .001UF 10% 500V X7R MLC 1206 F 3

C176 102438-150J2 CAP, 15PF 5% 200V NPO 0805 A 2

C198 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C199 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C200 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 5

C201 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 5

C202 A11369-101J2 100 PF 50V 5% NPO MLC 0805 T/R D 5






C208 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 D 1

C209 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 D 1

C210 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 D 2

C211 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 D 1

C212 130561-1 10UF 25V 20% ALUM ELEC SMT T/R D 2

C213 102438-150J2 CAP, 15PF 5% 200V NPO 0805 C 2

C214 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2


C216 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 C 2

C217 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C218 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C219 A11369-102F2 1000PF 50V 1% CHIP CAP C 2

C220 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C221 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 C 2

C222 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C223 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C224 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C225 OPEN D 3

C226 OPEN D 3

C227 OPEN D 2


C229 A11369-121J1 CAP, 120PF 50V 5% NPO 0603 D 2

C230 A11369-102F2 1000PF 50V 1% CHIP CAP E 2

C231 A11369-102F2 1000PF 50V 1% CHIP CAP E 2

C232 A11369-102F2 1000PF 50V 1% CHIP CAP E 2

C233 132191-1 CAP, 22UF 16V ELECTROLYTIC SMT E 2

C234 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C235 102438-150J2 CAP, 15PF 5% 200V NPO 0805 D 2

C236 102438-470J2 47PF 200V 5% NPO 0805 D 1

C237 A11369-391F2 CAP, 390PF 1% 50V 0805 E 1

C238 A11369-391F2 CAP, 390PF 1% 50V 0805 E 1

C239 A11369-391F2 CAP, 390PF 1% 50V 0805 E 1

C241 139719-1 CAP, 1.0UF 25V X7R 10% 0805 F 1

C242 130561-1 10UF 25V 20% ALUM ELEC SMT T/R G 1

C243 139719-1 CAP, 1.0UF 25V X7R 10% 0805 G 1

C244 139719-1 CAP, 1.0UF 25V X7R 10% 0805 G 1


C246 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD K 4


C248 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD L 4




C252 135224-1 .001UF 10% 500V X7R MLC 1206 K 4

C253 135224-1 .001UF 10% 500V X7R MLC 1206 K 5

C254 103429-474K8 CAP, 470NF 250V 10% X7R 1812 G 2

C255 103429-103J5 0.01UF 250V 5% X7R 1206 T/R H 2

C256 103429-103J5 0.01UF 250V 5% X7R 1206 T/R G 1

C257 103429-474K8 CAP, 470NF 250V 10% X7R 1812 H 1

C258 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 3

C259 135224-1 .001UF 10% 500V X7R MLC 1206 K 5

C260 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 3

C261 135224-1 .001UF 10% 500V X7R MLC 1206 K 5

C262 135224-1 .001UF 10% 500V X7R MLC 1206 N 5

C263 135224-1 .001UF 10% 500V X7R MLC 1206 N 5

C264 135224-1 .001UF 10% 500V X7R MLC 1206 N 4

C265 OPEN L 5

C266 OPEN K 5

C267 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 1

C268 OPEN N 5

C269 OPEN N 5

C270 OPEN G 3

C271 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C272 139719-1 CAP, 1.0UF 25V X7R 10% 0805 D 2



C275 135224-1 .001UF 10% 500V X7R MLC 1206 H 1

C276 102438-150J2 CAP, 15PF 5% 200V NPO 0805 E 2

C298 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 2

C299 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 2

C300 OPEN I 1

C301 OPEN F 4

C302 OPEN G 3

C901 137030-1 CAP, 1UF X2 REDUCED SIZE P 4

C902 OPEN Q 4

C903 137030-1 CAP, 1UF X2 REDUCED SIZE Q 3

C904 OPEN Q 2

C905 137455-1 CAP, 4700 PF 10% FILM Y2 Q 3

C906 137455-1 CAP, 4700 PF 10% FILM Y2 P 3

C907 135224-1 .001UF 10% 500V X7R MLC 1206 J 2

C908 103429-474K8 CAP, 470NF 250V 10% X7R 1812 J 2

C909 137455-1 CAP, 4700 PF 10% FILM Y2 Q 1

C910 137455-1 CAP, 4700 PF 10% FILM Y2 P 1

C911 141944-1 CAP, 1800UF 200V 20% ELEC RAD SNAP-IN N 1

C912 141944-1 CAP, 1800UF 200V 20% ELEC RAD SNAP-IN M 2

C913 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R O 3

C914 130561-1 10UF 25V 20% ALUM ELEC SMT T/R O 3

C915 141679-1 CAP, 47UF 35V 20% ELEC RAD N 3

C916 139719-1 CAP, 1.0UF 25V X7R 10% 0805 M 1

C917 A11427-103K1 0.01UF 50V 10% X7R MLC 0603 M 2

C918 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R L 2

C919 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 1

C920 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 2

C921 103429-474K8 CAP, 470NF 250V 10% X7R 1812 M 1

C922 103429-474K8 CAP, 470NF 250V 10% X7R 1812 L 3

C923 134115-1 CAP, .22UF 630V 5% POLYPROP M 3

C924 140670-101J5 CAP, 100PF 5% 500V NPO 1206 K 2

C925 139192-1 CAP, 3300UF 100VDC PC MNT ELECT I 1

C926 139192-1 CAP, 3300UF 100VDC PC MNT ELECT I 2

C927 141924-1 CAP, 1000UF 25V 20% ELEC RAD J 3


C929 139719-1 CAP, 1.0UF 25V X7R 10% 0805 K 1

C930 139719-1 CAP, 1.0UF 25V X7R 10% 0805 K 2

C931 102438-470J2 47PF 200V 5% NPO 0805 M 2

C932 139719-1 CAP, 1.0UF 25V X7R 10% 0805 M 3

C933 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R N 3

C934 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R C 3


C936 141924-1 CAP, 1000UF 25V 20% ELEC RAD D 4

C937 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 4

C938 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO B 4

C939 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 3

C940 141924-1 CAP, 1000UF 25V 20% ELEC RAD B 3

C941 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 4

C942 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 4

C943 102438-470J2 47PF 200V 5% NPO 0805 B 3

C944 A11369-102F2 1000PF 50V 1% CHIP CAP B 4

C945 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R B 4


C947 A11369-102F2 1000PF 50V 1% CHIP CAP M 2

C948 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 2

C949 OPEN B 4

C950 141924-1 CAP, 1000UF 25V 20% ELEC RAD C 4

C951 103429-103J5 0.01UF 250V 5% X7R 1206 T/R J 1

C952 103429-103J5 0.01UF 250V 5% X7R 1206 T/R J 2

C953 OPEN D 4



C999 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 3

D1 135343-1 DIODE, DUAL MMBD4148SE SOT-23 K 1

D2 137118-1 DIODE, 30V 200MA DUAL SCHOTTKY D 1

D10 125593-1 DIODE, SCHOTTKY 40V 1A SMA I 3


D100 142022-1 DIODE, ZEN 15V 500MW DDZ15-7 SOD-123 E 3

D101 141801-1 DIODE, 200MA 250V BAS21 SOT23 E 3

D102 138997-1 DIODE, 600V 1A SMA E 3

D105 OPEN E 4

D106 OPEN E 3


D110 137118-1 DIODE, 30V 200MA DUAL SCHOTTKY C 3

D200 142022-1 DIODE, ZEN 15V 500MW DDZ15-7 SOD-123 G 2

D201 141801-1 DIODE, 200MA 250V BAS21 SOT23 G 2

D202 138997-1 DIODE, 600V 1A SMA G 1

D205 OPEN G 2

D206 OPEN G 2

D207 135343-1 DIODE, DUAL MMBD4148SE SOT-23 M 4


D901 142060-1 PRP, 141658-1 (RBV2506) 0.32" O 2

D901B 141776-1 CLIP, XLS3 RECTIFIER O 2

D901C 103415-10605 SCR, #6-32X.312 SEMS TFS CONE O 3

D901D 103415-10605 SCR, #6-32X.312 SEMS TFS CONE O 2

D902 138997-1 DIODE, 600V 1A SMA N 3

D903 138997-1 DIODE, 600V 1A SMA O 3

D904 138997-1 DIODE, 600V 1A SMA M 1

D905 142057-1 PRP, 141569-1 (FFPF10UP20S) 0.3" J 2

D906 142057-1 PRP, 141569-1 (FFPF10UP20S) 0.3" J 1

D907 142057-1 PRP, 141569-1 (FFPF10UP20S) 0.3" J 2

D908 142057-1 PRP, 141569-1 (FFPF10UP20S) 0.3" J 1

D909 125593-1 DIODE, SCHOTTKY 40V 1A SMA K 1


D911 125593-1 DIODE, SCHOTTKY 40V 1A SMA C 4

D912 135343-1 DIODE, DUAL MMBD4148SE SOT-23 J 3

D913 C 9773-0 DIODE, ZENER 5.1V 1N5231 SMT N 3

D914 135343-1 DIODE, DUAL MMBD4148SE SOT-23 N 3

D915 135343-1 DIODE, DUAL MMBD4148SE SOT-23 O 1

D916 137118-1 DIODE, 30V 200MA DUAL SCHOTTKY M 3


E901 131238-1 LED, BLUE 470NM 1206 SMT N 1

FB2 125846-1 FERRITE BEAD, 600 OHM .5A 0805 D 1


FB101 125846-1 FERRITE BEAD, 600 OHM .5A 0805 A 5

















HS1A 141678-1 HTSK, XLS3 AMP 202/402 F 3

HS1B 141669-1 INSL, 2.06" X 0.82" CRMC F 3

HS1C OPEN E 4

HS1D 140180-1 CLIP, 2 FINGER TO-220 F 3

HS2A 141678-1 HTSK, XLS3 AMP 202/402 G 2

HS2B 141669-1 INSL, 2.06" X 0.82" CRMC G 2

HS2C OPEN G 2

HS2D 140180-1 CLIP, 2 FINGER TO-220 H 1

HS3A 141563-1 HTSK, XLS3 PS I 2

HS3B 141669-1 INSL, 2.06" X 0.82" CRMC J 2

HS3C 140180-1 CLIP, 2 FINGER TO-220 J 2

HS3D 140180-1 CLIP, 2 FINGER TO-220 J 1

HS4A 141563-1 HTSK, XLS3 PS L 2

HS4B 141669-1 INSL, 2.06" X 0.82" CRMC L 2

HS4C 140180-1 CLIP, 2 FINGER TO-220 L 2

HS4D 140180-1 CLIP, 2 FINGER TO-220 L 1

HW901 141600-1 BRKT, XLS3 SML EMI FLTR O 5

J1 141695-1 CON, BDPT, F 4P RED/BLK N-TCH TH HOR V0 K 6

J3 141937-1 CON, RCA F 2P BRT TH VRT C 6

J101 141639-1 CON, PHN F 4P 0.25" TH HOR A 5

J102 138319-1 XLR, FEM HORZ PC PLASTIC B 5

J103 102473-1 SPEAKON, 4 POLE PCB HORZ M 5

J201 141639-1 CON, PHN F 4P 0.25" TH HOR E 5

J202 138319-1 XLR, FEM HORZ PC PLASTIC D 5

J203 102473-1 SPEAKON, 4 POLE PCB HORZ N 5

J700B 141746-1 CON, FFC 50P ZIF LOC LTCH SM HOR C 1

J901 141905-1 CON, HDR M 2P LOC TIN VRT D 4

K101 141719-1 RELAY, SPDT 12A 24VDC PC MT J 4

K201 141719-1 RELAY, SPDT 12A 24VDC PC MT M 4

K901 141719-1 RELAY, SPDT 12A 24VDC PC MT O 1

L101 141634-1 IND, 10UH 15A 5% T130-2 TH G 4

L102 133326-2 INDUCTOR, 1UH ADJUSTABLE H 4

L201 141634-1 IND, 10UH 15A 5% T130-2 TH H 3

L202 133326-2 INDUCTOR, 1UH ADJUSTABLE K 4

L901 141736-1 IND, CM 1MH 30% TOR 14AWG TH P 3


L903 141644-1 INDUCTOR, 3.3MH O 4

L904 141735-1 IND, 5.9UH 6% TOR 18AWG T94-2 K 3

L905 140543-1 IND, 100UH 1A 10X12.7 SMD C 3

P901 138320-1 IEC, ISA RA PC MNT P 6

PWB1 141574-4 PWB, XLS1000/XLS1500 AMP/PS A 1

Q101 C 7448-1 MMBT3904 CHIP NPN D 1

Q102 C 7448-1 MMBT3904 CHIP NPN C 3

Q103 142058-1 PRP, 141630-1 (FDP52N20) 0.3" F 3

Q104 142058-1 PRP, 141630-1 (FDP52N20) 0.3" F 2

Q105 125798-1 XSTR,MMBT3906 LT3 10K REEL A 3

Q106 C 7448-1 MMBT3904 CHIP NPN A 3

Q107 102483-1 PNP 300V 500MA SOT-23 E 2

Q108 125798-1 XSTR,MMBT3906 LT3 10K REEL E 2

Q109 C 7448-1 MMBT3904 CHIP NPN E 3

Q110 142034-1 XTOR, NPN 20V 4A NSS20201LT1G SOT-23 E 3






Q203 142058-1 PRP, 141630-1 (FDP52N20) 0.3" G 1

Q204 142058-1 PRP, 141630-1 (FDP52N20) 0.3" G 1

Q205 125798-1 XSTR,MMBT3906 LT3 10K REEL B 3

Q206 C 7448-1 MMBT3904 CHIP NPN B 3

Q207 102483-1 PNP 300V 500MA SOT-23 F 1

Q208 125798-1 XSTR,MMBT3906 LT3 10K REEL G 1


Q210 142034-1 XTOR, NPN 20V 4A NSS20201LT1G SOT-23 G 2




Q901 142034-1 XTOR, NPN 20V 4A NSS20201LT1G SOT-23 M 1


Q903 142056-1 PRP, 141567-1 (GW20NC60VD) 0.3" L 1



Q906 142056-1 PRP, 141567-1 (GW20NC60VD) 0.3" L 2

Q907 141640-1 XTOR, NPN 32V 2A FJD3076 TO-252 D 4

Q908 141641-1 XTOR, PFET 20V 1.5A FDN308P SOT23 C 4


Q910 C 7448-1 MMBT3904 CHIP NPN M 1

Q911 125798-1 XSTR,MMBT3906 LT3 10K REEL D 1


R3 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 1

R4 OPEN E 2

R5 OPEN E 1

R6 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 C 2

R7 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 E 1

R8 A11368-64910 RES, 6.49KOHM 0.063W 1% 0603 C 1

R9 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 E 1

R10 A11368-64910 RES, 6.49KOHM 0.063W 1% 0603 C 1

R11 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R12 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R13 A11368-30110 3.01KOHM 1/16W 1% 0603 T/R C 2

R14 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 2

R15 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R16 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 B 3

R17 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 C 1

R18 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 C 1

R19 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 C 1

R20 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 D 3

R21 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 C 1

R22 OPEN C 2

R23 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 C 2

R24 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R25 OPEN D 1

R26 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 2

R27 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 2

R101 A11371-8205 82 OHM 1W 5% SMD 2512 B 5

R102 A11368-69800 RES, 698 OHM 1/16W 1% 0603 B 1

R103 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 B 1

R104 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 2

R105 A11368-69800 RES, 698 OHM 1/16W 1% 0603 B 1

R106 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 B 1

R107 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 1

R108 A11368-11020 RES, 11.0 KOHM 1/16W 1% 0603 B 2

R109 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 B 2

R110 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R111 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R112 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R113 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 C 2

R114 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R115 A11368-54910 RES, 5.49KOHM 0.063W 1% 0603 B 2

R116 A11368-90900 RES, 909 OHM 1% 1/16W 0603 B 2

R117 A11368-90900 RES, 909 OHM 1% 1/16W 0603 B 2

R118 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 B 3

R119 A11368-10000 RES, 100 OHM 1/16W 1% 0603 B 3

R120 A11371-0R00 RES, 0 OHM 0603 50 MILOHM MAX B 3

R121 OPEN B 3



R124 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 B 2

R125 A11368-20000 RES, 200 OHM 1/16W 1% 0603 B 2

R126 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R127 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R128 A11368-56200 RES, 562 OHM 1/16W 1% 0603 A 2

R129 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R130 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 A 2

R131 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 A 2

R132 A11368-13721 13.7K 1/10W 1% SMD 0805 T/R A 2

R133 A11368-11821 RES, 11.8K 0.10W 1% 0805 A 3

R134 A11368-59010 RES, 5.9 KOHM 1/16W 1% 0603 A 2

R135 A11368-27411 2.74KOHM 0.1W 1% 0805 T/R A 2

R136 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 A 2

R137 A11368-14701 RES, 147 OHM 0.1W 1% 0805 A 1

R138 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 A 2

R139 A11368-34821 RES, 34.8KOHM 0.10W 1% 0805 A 2

R140 A11368-10013 1K 0.25W 1% 1210 T/R G 3

R141 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 3

R142 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R143 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 2

R144 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R145 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 A 3

R146 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R147 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R148 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R149 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R150 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 E 3

R151 OPEN C 3

R152 A11371-1035 RES, 10KOHM 1W 5% 2512 E 3

R153 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 E 2

R154 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 E 2

R155 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 E 2

R156 OPEN E 2

R157 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 E 2

R158 A11368-39211 3.92 KOHM 1% 0.10W 0805 E 3

R159 A11368-61911 6.19KOHM .1W 1% 0805 T/R E 3

R160 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 E 3

R161 A11368-34824 RES, 34.8KOHM 0.5W 1% 2010 E 3

R162 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 E 2

R163 A11368-36524 RES, 36.5K 0.5W 1% 2010 F 3

R164 A11371-5R11 5.1 OHM 0.1W 5% 0805 SMT F 3

R165 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R166 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R167 A11371-5R11 5.1 OHM 0.1W 5% 0805 SMT F 2

R168 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R169 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R170 A11371-7525 RES, 7.5KOHM 1W 5% 2512 H 4

R190 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R191 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R192 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R193 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R194 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 5

R195 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 4

R196 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 4

R197 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 5

R198 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 5

R199 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 5

R201 A11371-8205 82 OHM 1W 5% SMD 2512 D 5

R202 A11368-69800 RES, 698 OHM 1/16W 1% 0603 D 1

R203 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 D 1

R204 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 2

R205 A11368-69800 RES, 698 OHM 1/16W 1% 0603 D 1

R206 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 D 1

R207 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 1

R208 A11368-11020 RES, 11.0 KOHM 1/16W 1% 0603 C 2

R209 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 C 2

R210 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 D 2

R211 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 C 2

R212 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R213 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 C 2

R214 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 2

R215 A11368-54910 RES, 5.49KOHM 0.063W 1% 0603 C 2

R216 A11368-90900 RES, 909 OHM 1% 1/16W 0603 D 2

R217 A11368-90900 RES, 909 OHM 1% 1/16W 0603 D 2

R218 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 D 3

R219 A11368-10000 RES, 100 OHM 1/16W 1% 0603 D 3

R220 A11371-0R00 RES, 0 OHM 0603 50 MILOHM MAX D 3

R221 OPEN D 3



R224 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 D 2

R225 A11368-20000 RES, 200 OHM 1/16W 1% 0603 D 2

R226 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 E 2

R227 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 E 2

R228 A11368-56200 RES, 562 OHM 1/16W 1% 0603 D 2

R229 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 E 2

R230 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 E 2

R231 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 D 2

R232 A11368-13721 13.7K 1/10W 1% SMD 0805 T/R D 2

R233 A11368-11821 RES, 11.8K 0.10W 1% 0805 D 3

R234 A11368-59010 RES, 5.9 KOHM 1/16W 1% 0603 D 2

R235 A11368-27411 2.74KOHM 0.1W 1% 0805 T/R D 2

R236 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 E 2

R237 A11368-14701 RES, 147 OHM 0.1W 1% 0805 E 1

R238 A11368-17810 RES, 1.78KOHM 0.063W 1% 0603 E 2

R239 A11368-34821 RES, 34.8KOHM 0.10W 1% 0805 E 2

R240 A11368-10013 1K 0.25W 1% 1210 T/R G 3

R241 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 3

R242 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R243 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 2

R244 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R245 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 3

R246 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R247 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R248 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R249 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R250 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 F 2

R251 OPEN C 3

R252 A11371-1035 RES, 10KOHM 1W 5% 2512 F 2

R253 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 G 1

R254 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 G 1

R255 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 G 1

R256 OPEN G 1

R257 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 F 1

R258 A11368-39211 3.92 KOHM 1% 0.10W 0805 G 1

R259 A11368-61911 6.19KOHM .1W 1% 0805 T/R G 1

R260 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 G 1

R261 A11368-34824 RES, 34.8KOHM 0.5W 1% 2010 G 2

R262 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 F 1

R263 A11368-36524 RES, 36.5K 0.5W 1% 2010 G 1

R264 A11371-5R11 5.1 OHM 0.1W 5% 0805 SMT G 1

R265 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R266 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 2

R267 A11371-5R11 5.1 OHM 0.1W 5% 0805 SMT G 1

R268 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R269 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R270 A11371-7525 RES, 7.5KOHM 1W 5% 2512 I 3

R290 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R291 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R292 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R293 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R294 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R295 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R296 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R297 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R298 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R299 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R300 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 I 2

R301 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 F 4

R302 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 G 3

R303 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 E 3

R304 A11368-1R000 RES, 1 OHM 1/16W 1% 0603 F 3

R305 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 F 2

R306 A11368-10230 RES, 102KOHM 0.063W 1% 0603 B 2

R307 A11368-25520 RES, 25.5KOHM 0.063W 1% 0603 B 2

R308 A11368-1R000 RES, 1 OHM 1/16W 1% 0603 F 2

R309 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R310 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R311 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R312 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 4

R313 A11368-16204 RES, 162 OHM 0.5W 1% 2010 I 5

R314 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 4

R315 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 4

R316 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 5

R317 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 5

R318 A11368-16204 RES, 162 OHM 0.5W 1% 2010 J 5

R319 A11368-34821 RES, 34.8KOHM 0.10W 1% 0805 A 2

R403 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 G 1

R404 A11368-1R000 RES, 1 OHM 1/16W 1% 0603 G 1

R405 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 G 1

R406 A11368-10230 RES, 102KOHM 0.063W 1% 0603 D 2

R407 A11368-25520 RES, 25.5KOHM 0.063W 1% 0603 D 2

R408 A11368-1R000 RES, 1 OHM 1/16W 1% 0603 G 1

R409 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R410 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R411 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R412 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R413 A11368-16204 RES, 162 OHM 0.5W 1% 2010 K 4

R414 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R415 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R416 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R417 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R418 A11368-16204 RES, 162 OHM 0.5W 1% 2010 L 4

R419 A11368-34821 RES, 34.8KOHM 0.10W 1% 0805 E 2

R901 A11368-49923 49.9KOHM .25W 1% CHIP 1210 Q 1

R902 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 1

R903 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 1

R904 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 1

R905 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R906 OPEN N 3

R907 OPEN L 1

R908 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 O 3

R909 A11368-15421 15.4K 1/10W 1% SMD 0805 T/R O 3

R910 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 M 1

R911 A11368-20020 RES, 20.0 KOHM 1/16W 1% 0603 M 2

R912 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 M 1

R913 A11368-10R01 10 OHM .1W 1% 0805 T/R ROHS M 1

R914 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 M 2

R915 A11368-10R01 10 OHM .1W 1% 0805 T/R ROHS M 2

R916 A11368-10003 100 OHM 0.25W 1% 1210 T/R K 2

R917 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 N 3

R918 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 M 3

R919 A11368-20020 RES, 20.0 KOHM 1/16W 1% 0603 N 3

R920 A11368-51100 511 OHM 1/16W 1% 0603 T/R M 2

R921 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 M 2

R922 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 K 3

R923 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 J 3

R924 A11368-68130 RES, 681K OHM 1% 1/16W 0603 M 3

R925 A11368-20031 200K 0.1W 1% SMD CHIP 0805 N 3

R926 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 N 3

R927 A11368-12131 121KOHM, 0.10W 1% CHIP 0805 N 3

R928 A11368-20031 200K 0.1W 1% SMD CHIP 0805 N 3

R929 A11368-20031 200K 0.1W 1% SMD CHIP 0805 N 3

R930 A11368-40201 402 OHM 1% 0805 RES T/R K 1

R931 A11368-20031 200K 0.1W 1% SMD CHIP 0805 C 3

R932 A11368-49921 49.9KOHM .1W 1% CHIP 0805 C 4

R933 A11368-20031 200K 0.1W 1% SMD CHIP 0805 C 4

R934 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 3

R935 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 4

R936 A11368-40201 402 OHM 1% 0805 RES T/R B 4

R937 A11368-40201 402 OHM 1% 0805 RES T/R B 4

R938 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 4

R939 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 4

R940 A11368-49921 49.9KOHM .1W 1% CHIP 0805 B 4

R941 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 3

R942 A11368-60410 RES, 6.04 KOHM 1/16W 1% 0603 B 4

R943 A11368-49921 49.9KOHM .1W 1% CHIP 0805 B 4

R944 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 4

R945 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 B 3

R946 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 M 3

R947 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 1

R948 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 M 2

R949 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 M 3

R950 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 M 2

R951 OPEN M 1

R952 OPEN L 2

R998 OPEN A 4

R999 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 A 4

RT1 140098-1 THERMISTOR, 10K NTC 1% 0603 I 1

RT101 140098-1 THERMISTOR, 10K NTC 1% 0603 F 2

RT201 140098-1 THERMISTOR, 10K NTC 1% 0603 H 1

RT901 138466-1 PRP, 101103-1 PTC .125 O 1

S901 132498-1 SWITCH, DPST PUSHBUTTON VDECSA N 2

T901 141650-1 XFMR, MAIN XLS3 402 120V/240V K 1

TP1 OPEN A 4

TP901 OPEN O 3

TP902 OPEN N 3

TP903 OPEN N 3

TP904 OPEN I 3

TP905 OPEN N 4

U1 140419-1 IC, RUBY SOP64 SMD C 2

U2 C 8262-5 IC, OPAMP DUAL LONOIS 33078 SO8 B 2

U3 141744-1 IC, REG 12V 500MA 78M12C TO-263 F 2


U102 141643-1 IC, DRV PWM IRS20957S E 3

U201 C 9012-3 OP AMP, QUAD LO NOISE MC33079D D 2

U202 141643-1 IC, DRV PWM IRS20957S G 1

U901 141369-1 IC, REG ADJ LNK302DN SO8 O 3

U902 141572-1 IC, DRV SMPS FAN7387 SO8 M 2

U903 126559-1 COMPARATOR, LM393 SO-8 DUAL M 3

U904 133552-1 OP AMP, LM358 LOW PWR DUAL S08 C 4

U905 138341-1 IC, TL494 PWM CTRL SO-16 B 4

U906 141638-1 IC, OPTOCOUPLER J 3

WP1 141672-1 CBL, 16AWG BRN 2.1" STRP FLG Q 4

WP2 141671-1 CBL, 16AWG BRN 2.6" STRP FLG P 4

Z901 134606-2 JUMP, 14AWG CU TIN BUS .210" X.225" N 1

COMPONENT MAP: XLS1000/1500 MAIN PWA

2 OF 5

4.99K

NONE

RUN

RUN

1152 KHZ FILTER

10K

PS

TE

MP

600061

384 KHZ FILTER

1152 KHZ FILTER

768 KHZ FILTER

MUTE

384 KHZ FILTER

NOTES:

1. ALL CAPACITORS ARE IN MICROFARADS UNLESS OTHERWISE SPECIFIED.

768 KHZ FILTER

MUTE

R23

4.99K

OPEN

10K

141583 MED 240V

2.49K

10K

4.99K

141582 MED 220V

141581 MED 120V

141580 MED 100V

141579 SML 240V

141578 SML 220V

141577 SML 120V

141576 SML 100V

R22

4.99K

2.49K

1.1K

10K2.49K

OPEN

10

2.49K

OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

R24

1.1K

XLS1500 120V AMP/PS

141581-4 A

C125OPEN

C126OPEN

C127OPEN

C225OPEN

C1910

10V

C122

1%390PF

C123

1%390PF

C124

1%390PF

C224

1%390PF

C223

1%390PF

C222

1%390PF

C1721

-

+

U101-A2

31

MC33079D

-

+U101-B

6

57

MC33079D

-

+

U101-C

9

108

MC33079D

-

+

U201-C

9

108

MC33079D

-

+

U201-D

13

1214

MC33079D

C108

5%4700PF

C109

5%4700PF

C170.1

C232

1%0.001

C231

1%0.001

C230

1%0.001

C130

1%0.001

C132

1%0.001

C131

1%0.001

C228680PF

C128680PF

C1102200PF

1%

C1112200PF1%

C1204700PF

5%

C2110

10V

D14148SE

C200.1

C1184700PF

5%

C119

1%0.001

C121

1%2200PF

C2141

C11315PF

5%200V

FB100

C20.1

D110BAT54S

+T

RT10110K

C1584700PF5%

C1174700PF

5%

C1162200PF

1%

C10.1

C71

C81

C1600.1

C2184700PF

5%

C21315PF

5%200V

C2711

C2204700PF

5%

C2584700PF5%

C2162200PF

1%

C2174700PF

5%

C219

1%0.001

C221

1%2200PF

C1711

AGND1

VCTR1A0

AGND

A1

NC

CLKN

CLKP

A2

XTAL

XGND

AVDD

DVDD

AGND

TREF

VVG1

VERR1

PGND1

VR1

IS2NP

IS2PN

IS2PP

IS1NN

IS1NP

IS1PN

IS1PP

IS2NN

TSENSE2

TSENSE1

PGND2

PWM1PN

PWM1NP

PWM1PP

PWM1NN

PWM2PP

PWM2PN

PWM2NP

PWM2NN

VCTR2

AGND2

VR2

SLAVEN

DGND

V3P3D

SDA

SCL

INT1N

INT2N

STBY1N

STBY2N

VBAT_TRK

VCC_TRKP

VCC_TRKN

VOUT1P

VOUT1N

VOUT2P

VOUT2N

AGND

VREFSAR

VRSRC

VERR2

VVG2

AVDD2

AVDD1

U1

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

3233

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

RUBY

FB200

C2600.1

D210BAT54S

+T

RT20110K

C1141

FB2

C130.1

-

+U201-A

2

31

MC33079D

C208

5%4700PF

C209

5%4700PF

C2102200PF

1%

C2112200PF1%

-

+

U101-D

13

1214

MC33079D

C134

1%390PF

C234

1%390PF

-

+

U2-E

4

11

MC33079D

-

+U2-B

6

57

MC33079D

C2721

+T

RT110K

C41

C31

C227OPEN

C226OPEN

C229

5%120PF

C129

5%120PF

C170OPEN

-

+

U201-B

6

57

MC33079D

C270OPEN

C50.1

C220.1

D2BAT54S

C176

5%200V

15PF

C276

5%200V

15PFC237

1%390PF

C238

1%390PF

C239

1%390PF

C139

1%390PF

C138

1%390PF

C137

1%390PF

R2031.78K

R1031.78K

R31934.8K

0.10W

R41934.8K

0.10W

R13934.8K

0.10W

R23934.8K

0.10W

R11875

R1155.49K

R1230

5%

R1246.81K

R2111K

R40725.5K

R217909

R1296.81K

R1276.81K

R1266.81K

R128562

R125200

R2230

5%

R216909

R21875

R219100

R119100

R1111K

R117909

R116909

R1200

5%

R106.49K

R105698

R121OPEN

R102698

R1061.78K

R1072.49K

R1042.49K

R306102K

R221OPEN

R225200

R2246.81K

R228562

R2276.81K

R2266.81K

R2312K

R230100K

R9402K

R1220

5%

R25OPEN

R4OPEN

R178.87K

R194.99K

R218.87K

R2410K

R20402K

R2200

5%

R2220

5%

R62K

R16402K

R7402K

R10811K

R14610K

R14410K

R24610K

R24410K

R1484.99K

R2484.99K

R1101K

R14210

R133.01K

R14710

R2296.81K

R2733.2

R2633.2

R151OPEN

R24210

R2101K

R21210

R251OPEN R247

10

R11210

R86.49K

R2155.49K

R310

R21349.9

R11349.9

R1110

R1210

R2072.49K

R2042.49K

R205698

R202698

R20811K

R11410

R1352.74K

0.10W

R406102K

R1312K

R13311.8K

0.10W

R130100K

R30725.5K

R21410

R2352.74K

0.10W

R232.49K

R22OPEN

R5OPEN

R13213.7K

0.10W

R23213.7K

0.10W

R23311.8K

0.10W

R174698

R2361.82K

R2381.82K

R1345.9K

R2345.9K

R274698

R140

0.25W

1K

R240

0.25W

1K

R1830.1K

R2061.78K

R1091.78K

R2091.78K

C135

200V

15PF5%

C235

200V

15PF5%

C236

5%47PF

C136

5%47PF

TP1OPEN

+

C112

25V

10

+

C212

25V

10

+

C133

16V

22

+

C23322

16V

-

+

U201-E

4

11

MC33079D

R1510

R2810

R26610

R16610

-

+

U101-E

4

11

MC33079D

-

+

U2-A

2

31

MC33079D -

+

U2-C

9

108

MC33079D

R1681K

C111

R14100K

R2681K

-

+

U2-D

13

1214

MC33079D

Q101MMBT3904

Q201MMBT3904

R1361.82K

R1381.82K

R237200

R137200

C1981

C1991

C2981

C2991

C981

C971

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23

CTHESE DRAWINGS AND SPECIFICATIONS ARE THEPROPERTY OF CROWN INTERNATIONAL, INC. ANDSHALL NOT BE REPRODUCED, COPIED, OR USEDAS THE BASIS FOR THE MANUFACTURE OR SALEOF APPARATUS OR DEVICES WITHOUT PERMISSION.UNCONTROLLED


REV

TITLE

CH2_LFFB

CH1_HFFB

CLKP384K

CH1+

CH1-

I2C_SCL

LVAC

CH

1_LFFB

STBY_1

CH1_ENABLE

STBY_2

CH2_ENABLE

CLIP2

CLIP1

CH1_ENABLE

CH2_ENABLE

CLKN384K

I2C_SDA

VRSRC

CH1_DRV

CH2_DRV

PWM2PN

PWM2PP

CH2-

CH2+

CH2_HFFB

CH1_LFFB

CH

2_LFFB

PWM1PN

PWM1PP

VRSRC

VR2

A G N D

A G N D

A G N D

A G N D

+5VA

A G N D

+5VA

+5VA

A G N D

+5VA

+5VA

A G N D

A G N D

+5VAA G N D

VREFSAR

VR1

VR2

+5VA

+5VA

A G N D

+5VA

A G N D

VR1

+LV +LV

-LV

-VCC+5VA

-LV

+LV

+5VA

+VCC

-LV

-LV

VR1

VR2

+LV

3 OF 5

BLK

NONE

RUN

RED

MUTE

CRITICAL TO SAFETY COMPONENTS. REPLACE WITH SAME COMPONENT ONLY.

POWER SUPPLY FILTERING

600061

NOTES:


BLK

RED

MUTE

RUN

XLS1500 120V AMP/PS

141581-4 A

Q211NSS20200L

Q111NSS20200L

Q113NSS20200L

C155

5%0.01

250V

C255

5%0.01

250V

Q105MMBT3906

C2411

C2431

C1411

C160.1

C154

10%250V

0.47

C161

500V

0.001C153

500V

0.001C164

500V

0.001C163

500V

0.001

C253

500V

0.001C264

500V

0.001C263

500V

0.001

C162

500V

0.001

C261

500V

0.001C262

500V

0.001

VREFOCSETDT

CSH

VCC

CSD

LO

VB

VS

VDD

VSSIN

NC

HO

NC

COM

U102

12345678 9

10111213141516

IRS20957S

VREFOCSETDT

CSH

VCC

CSD

LO

VB

VS

VDD

VSSIN

NC

HO

NC

COM

U202

12345678 9

10111213141516

IRS20957S

C180.1

U3

1VI

2

GND

3VO

78M12C

C1441

C2441

J203N1

P2

N2

P1

J103N1

P2

N2

P1

Q205MMBT3906

Q107KST92

Q208MMBT3906

Q207KST92

C120.1

D101BAS21

C300OPEN

HS1AHTSK, XLS3 AMP 202/402

C302OPEN


C301OPEN

HS3AHTSK, XLS3 PS

C1750.001

500V

C1431

C1670.1

C2670.1

D201BAS21

D10STPS140A

D11STPS140A

C165OPEN

C166

OPEN

C168

OPEN

C169

OPEN

C269

OPEN

C268

OPEN

C266

OPENC265OPEN

C157

10%250V

0.47

K101

12

3

4

5C G N D 2

D1074148SE

D105OPEN

L201

1 2

3 4

10UH

J1-A

B L K 1

R E D 1

D2074148SE

J1-B

R E D 2

B L K 2

C1590.001

500V

C14

250V

0.4710%

C254

10%250V

0.47

Q108MMBT3906

R1583.92K

0.10W

R2583.92K

0.10W

R2544.99K

R1534.99K

R2534.99K

R26010K

R1544.99K

R16010K

R1430.915%0.50W

R2430.915%0.50W

R25710

R252

5%1W

10K

R152

5%1W

10K

R150402K

R156OPEN

0.10W

R250402K

R30110

R30210

R30010

R1622K

R16510K

R16910K

R14910K

R15710

R2622K

R24910K

R256OPEN

R26910K

R26510K

R1596.19K

0.10W

R2707.5K

1W5%

R2596.19K

0.10W

R2454.99K

R2412.49K

R1558.87K

R2558.87K

D102MURA160T3G

D100

15V

DDZ15

D200

15V

DDZ15

R16134.8K

0.50W

R40549.9

D202MURA160T3G

R26134.8K

0.50W

R30549.9

R3041

R3081

R1707.5K

1W5%

C146

10%250V

0.1

C246

10%250V

0.1

K201

12

3

4

5C G N D 2

L101

1 2

3 4

10UH

C173

10%250V

0.1C147

10%250V

0.1

L102

1

4

1UH

C1520.001

500V

C148

10%250V

0.1

C149

10%250V

0.1C150

10%250V

0.1C151

10%250V

0.1

D205OPEN

D106OPEN

R1412.49K

R1454.99K

C251

10%250V

0.1C250

10%250V

0.1

C248

10%250V

0.1

D206OPEN

C249

10%250V

0.1

C2590.001

500V

R163

0.50W

36.5K

R263

0.50W

36.5K

R164

0.10W

5.15%

R167

0.10W

5.15%

R264

0.10W

5.15%

R267

0.10W

5.15%

R30349.9

R40349.9

R4041

R4081

R190

162

0.50W

R191

162

0.50W

R192

162

0.50W

R193

162

0.50W

R194162

0.50W

R309162

0.50WR310

162

0.50WR311

162

0.50W

R312

162

0.50W

R313

162

0.50W

R195

162

0.50W

R196

162

0.50W

R197

162

0.50W

R198

162

0.50W

R199162

0.50W

R314162

0.50WR315

162

0.50WR316

162

0.50W

R317

162

0.50W

R318

162

0.50W

R290

162

0.50W

R291

162

0.50W

R292

162

0.50W

R293

162

0.50W

R294162

0.50W

R409162

0.50WR410

162

0.50WR411

162

0.50W

R412

162

0.50W

R413

162

0.50W

R296

162

0.50W

R295

162

0.50W

R297

162

0.50W

R298162

0.50W

R299 162

0.50WR414

162

0.50WR415

162

0.50WR416

162

0.50W

R417

162

0.50W

R418

162

0.50W

Q213NSS20200L

C257

10%250V

0.47C2750.001

500V

C2520.001

500VL202

1

4

1UH

C247

10%250V

0.1C273

10%250V

0.1

C156

5%0.01

250V

C256

5%0.01

250V

Q103FDP52N20

Q104FDP52N20

Q203FDP52N20

Q204FDP52N20

+ C24210

25V

+C14210

25V

+C14510

25V

+ C24510

25V

+ C15

35V470

Q109MMBT3904

Q102MMBT3904

Q209MMBT3904

Q202MMBT3904

Q206MMBT3904

Q106MMBT3904

Q210

NSS20201L

Q112

NSS20201L

Q110

NSS20201L

Q212

NSS20201L

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!

!

!

!

!

!

!

!

!

!

!

!

!

!

!

CH2_OUT

CH1_DRV

CH2_DRV

CH1_OUT

CH1_DT

CH2_OUT

CH2_DT

PWM1PN

PWM1PP

PWM2PN

PWM2PP

CH2_OUT

LVAC

CH2_LFFB

CH1_OUT

CH2_RELAY

CH1_HFFB

CH1_RELAY

CH1_LFFB

CH2_HFFB

-VCC

VGD

-VCC

+VCC

+VCC

-VCC

+VCC

+VCC

VGD

VGD

+VCC

-VCC

-LV

+LV

-LV

+LV

-VCC

+VCC

-VCC

+VCC

PR

IMA

RY

SECONDARY

SECONDARY

NONE

150K

CIRCUITBREAKER

PRIMARY

600061

NOTES:

100K

4 OF 5


SE

CO

ND

AR

Y

121K

30.1K

R927

PRIMARY

240V

220V

120V

SML 100V - 10SML 120V - 1KSML 220V - 10KSML 240V - 100KMED 100V - 200MED 120V - 2KMED 220V - 20KMED 240V - 200K100V

MODEL ID RESISTOR

GROUND

Z901

240V OPEN

OPEN220V

120V 134606-2

134606-2100V


XLS1500 120V AMP/PS

141581-4 A

C9130.1

2IN+

E2E1

2IN-REF

C2CTRL

VCC

RTC1

1IN+1IN-

GND

CTDTCFB

U905

123456

7

8 91011

12

13141516

TL494

-

+

U903-C8

4

LM393D

C9990.1

D911STPS140A

C9321

D904MURA160T3G

GND

RCT

VDD

DT/'SD

LO

VS

HO

VB

U902

1

2

3

4 5

6

7

8

FAN7387

C9980.1

-

+

U904-C8

4

LM358

C9970.1

-

+

U903-B

6

57

LM393D

C9371

C9391

C93822PF

C9190.1

C9450.1

C9460.1

C9422200PF1%

S901

1 2

3 4

C G N D 2

D903MURA160T3G

D902MURA160T3G

C947

1%0.001

C9161

C9480.1

C944

1%0.001

C9330.1

C909

275VAC4700PF

C910

275VAC4700PF

P901

N

L

E

C906

275VAC4700PF

C905

275VAC4700PF

C903

275VAC1

WP2BRN

D915

4148SE

K901

1

2

3

4

5C G N D 2

Z901

D916BAT54S

-

+

U903-A

2

31

LM393D

D913

5.1VMMBZ5231BLT1

D9124148SE

GND

ANODE

CATHODE

NCVO

VCC

U906

1

2

34

5

6

H11L1M

D9144148SE

D917BAT54S

C9412200PF1%

C9350.1

-

+

U904-A

2

31

LM358Q902

NSS20200L

Q905NSS20200L

C949OPEN

Q908

G

DS

FDN308P

WP1BRN

C908

10%250V

0.47

J901

1

2

C901

275VAC1

C9340.1

-

+

U904-B

6

57

LM358

E901BLU

D909STPS140A

D910STPS140A

C924

5%500V

100PF

C923

400VAC0.22

L904

1 2

3 4

5.9UH

T901

1

2

3

4

5

6

7

8

12

10 11

9

141650-1

C9291

C9301

C9070.001

500V

C921

10%250V

0.47

C922

10%250V

0.47

3

S

S

S

SD

NC

FB

BP

5

6

7

8

4

2

1

U901

LNK302

L901

12

3 4

1MHL902

12

3 4

1MH

R944100K

R9414.99K

R939100K

R920511

R91249.9

R937

0.10W

402R938

4.99K

R936

0.10W

402

R917100K

R9224.99K

R94049.9K

0.10W

R94349.9K

0.10W

R9472.49K

R9082K

R94549.9

R928200K

0.10W

R929200K

0.10W

R901

0.25W

49.9K

R904

0.25W

49.9K

R902

0.25W

49.9K

R903

0.25W

49.9K

R9054.99K

R949402K

R9104.99K

R94610K

R9211K

R91830.1K

R9231K

R91920K

R927121K

0.10W

R90915.4K

0.10W

R9501K

R925200K

0.10W

R91449.9

R913

0.10W

10

R915

0.10W

10

R931200K

0.10W

R933200K

0.10W

R9426.04K

R94875

R91120K

R93249.9K

0.10W

R93410K

R9354.99K

R924681K

R998OPEN

R916

0.25W

100

R9992K

R930402

0.10W

R906OPEN

R951OPEN

R952OPEN

R907OPEN

Q911MMBT3906

R92630.1K

C94347PF

5%

C93147PF

5%

C951

5%0.01

250V

C952

5%0.01

250V

C9170.01

TP903OPEN

TP904OPEN

TP901OPEN

TP902OPEN

TP905OPEN

L905100UH

L9033.3MH

+T

RT9016

D906FFPF10UP20S

D905FFPF10UP20S

D907FFPF10UP20S

D908FFPF10UP20S

Q903GW20NC60VD

Q906GW20NC60VD

D901

RBV2506

+ C925

100V3300

+ C926

100V3300

+C914

25V

10

+ C936

25V1000

+ C940

25V1000

+ C950

25V1000

+ C927

25V1000

+ C928

25V1000

+ C911

200V1800

+ C912

200V1800

+ C915

35V47UF

C9200.1

Q909MMBT3904

Q910MMBT3904

Q912MMBT3904

Q907FJD3076

Q904NSS20201L

Q901NSS20201L

C9180.1

R95333.2

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!!

!

!

!

!

!

!

!

!

!

!

! ! !

!

!

!

!

!

!

!

!

!

!

!

!

!

!

!!

! !

!

!

!

!

CLKP192K

SOFTSTART

CLKP192K

CLKN192K

1/2V_ BULK

FAN

1/2V_ BULK

LVAC

+LV

V_BULK

V_BULKRTN

+15V CONTROL

V_BULKRTN

+LV

-VCC

V_BULK

+LV

-LV

V_BULKRTN

V_BULKRTN

AC_SW

V_BULKRTN

+15V CONTROL

+15V CONTROL

AC_SW

2

V_BULKRTN

-LV

V_BULK

V_BULKRTN2

+LV

+15V CONTROL

+15V CONTROL

V_BULKRTN

+15V CONTROL

+5VA

2

+VCC

-LV

+LV

-LV

+5VA

+15V CONTROL

NC

CHANNEL 2 INPUT

NONE

CHANNEL 1 INPUT

600061

NOTES:


5 OF 5


XLS1500 120V AMP/PS

141581-4 A

FB101

FB102

FB103

FB104

J1021

2

3

G

C106100PF

C107100PF

FB107

IN_CH1+

FB108 IN_CH1-

C1010.1

FB201

XTP6

J700B

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

J1013

2

1

6

FB202

FB203

FB204J202

1

2

3

G C2010.1

J2013

2

1

6

FB208

IN_CH2-

C1000.1

C2000.1

C10OPEN

C207100PF

FB105

FB207

IN_CH2+

C206100PF

FB205

J3 1

2

3

R10182

1W5%

R20182

1W5%

C102100PF

C103100PF

C104100PF

C105100PF

C115100PF

C215100PF

C202100PF

C203100PF

C204100PF

C205100PF

FB206

C274100PF

C174100PF

FB106

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!

!

!

!

CH1_RELAY

SOFTSTART

CH2-

CH2+

FAN

I2C_SCL

I2C_SDA

CLKP384K

CLKN384K

CLKP192K

CLKN192K

CH1+

CH1-

CH1_DT

CH2_DT

CLIP1

CLIP2

CH2_RELAY

STBY_1

STBY_2

1

1

1

1

1

1

-LV

+LV

+5VA

A G N D

11

1

1

1

1

1

1

1

BOM: 142029-5_A XLS2500/120V MAIN PWA REF. DES. CPN DESCRIPTION

MAP LOC.

C1 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C2 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C3 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 1

C4 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 1

C5 135505-1 CAP, 0.1UF 25V 10% X7R 0603 K 1

C7 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C8 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C10 OPEN C 7

C11 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2

C12 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 6

C13 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C14 103429-474K8 CAP, 470NF 250V 10% X7R 1812 J 3

C15 C 4477-3 470 UF 35V VERT I 4

C16 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R F 3

C17 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C18 135505-1 CAP, 0.1UF 25V 10% X7R 0603 F 3

C19 139947-1 CAP, 10UF 10V 10% X5R 1206 C 1

C20 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 1

C21 139947-1 CAP, 10UF 10V 10% X5R 1206 C 1

C22 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 2

C98 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 2

C100 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 7

C101 135505-1 CAP, 0.1UF 25V 10% X7R 0603 B 7







C108 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 1

C109 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 A 1

C110 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C111 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 A 1

C112 130561-1 10UF 25V 20% ALUM ELEC SMT T/R B 2

C113 102438-150J2 CAP, 15PF 5% 200V NPO 0805 C 2

C114 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2


C116 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C117 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 2

C118 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 2

C119 A11369-102F2 1000PF 50V 1% CHIP CAP B 2

C120 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 2

C121 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 2

C122 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C123 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C124 A11369-391F2 CAP, 390PF 1% 50V 0805 B 2

C125 OPEN B 3

C126 OPEN B 2

C127 OPEN B 2

C128 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 B 2

C129 A11369-121J1 CAP, 120PF 50V 5% NPO 0603 B 2

C130 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C131 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C132 A11369-102F2 1000PF 50V 1% CHIP CAP A 2

C133 132191-1 CAP, 22UF 16V ELECTROLYTIC SMT A 2

C134 A11369-391F2 CAP, 390PF 1% 50V 0805 A 2

C135 102438-150J2 CAP, 15PF 5% 200V NPO 0805 A 2


C137 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C138 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C139 A11369-391F2 CAP, 390PF 1% 50V 0805 A 1

C141 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 5


C143 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 5

C144 139719-1 CAP, 1.0UF 25V X7R 10% 0805 E 4








C152 135224-1 .001UF 10% 500V X7R MLC 1206 I 6

C153 135224-1 .001UF 10% 500V X7R MLC 1206 J 7

C154 103429-474K8 CAP, 470NF 250V 10% X7R 1812 G 4

C155 103429-103J5 0.01UF 250V 5% X7R 1206 T/R F 6

C156 103429-103J5 0.01UF 250V 5% X7R 1206 T/R F 4

C157 103429-474K8 CAP, 470NF 250V 10% X7R 1812 F 3

C158 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 B 3

C159 135224-1 .001UF 10% 500V X7R MLC 1206 J 7

C160 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 3

C161 135224-1 .001UF 10% 500V X7R MLC 1206 J 7

C162 135224-1 .001UF 10% 500V X7R MLC 1206 L 7

C163 135224-1 .001UF 10% 500V X7R MLC 1206 L 7

C164 135224-1 .001UF 10% 500V X7R MLC 1206 L 7

C165 OPEN J 7

C166 OPEN J 7

C167 135505-1 CAP, 0.1UF 25V 10% X7R 0603 E 4

C168 OPEN L 7

C169 OPEN L 7

C170 OPEN G 6

C171 139719-1 CAP, 1.0UF 25V X7R 10% 0805 B 2

C172 139719-1 CAP, 1.0UF 25V X7R 10% 0805 A 2



C176 A11369-100J2 CAP, 10PF 5% 50V SMT 0805 A 2

C180 135224-1 .001UF 10% 500V X7R MLC 1206 F 5

C181 135224-1 .001UF 10% 500V X7R MLC 1206 F 4

C182 103429-103J5 0.01UF 250V 5% X7R 1206 T/R E 6

C183 103429-103J5 0.01UF 250V 5% X7R 1206 T/R F 4

C198 135505-1 CAP, 0.1UF 25V 10% X7R 0603 A 2

C199 135505-1 CAP, 0.1UF 25V 10% X7R 0603 A 2

C200 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 7

C201 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 7







C208 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 D 1

C209 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 D 1

C210 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 D 2

C211 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 D 1

C212 130561-1 10UF 25V 20% ALUM ELEC SMT T/R C 2

C213 102438-150J2 CAP, 15PF 5% 200V NPO 0805 C 2

C214 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2


C216 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 C 2

C217 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C218 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C219 A11369-102F2 1000PF 50V 1% CHIP CAP C 2

C220 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 2

C221 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 C 2

C222 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C223 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C224 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C225 OPEN D 3

C226 OPEN D 3

C227 OPEN D 2

C228 A11369-681F2 CAP, 680PF 50V 1% NPO 0805 D 2

C229 A11369-121J1 CAP, 120PF 50V 5% NPO 0603 D 2

C230 A11369-102F2 1000PF 50V 1% CHIP CAP D 2

C231 A11369-102F2 1000PF 50V 1% CHIP CAP E 2

C232 A11369-102F2 1000PF 50V 1% CHIP CAP E 2

C233 132191-1 CAP, 22UF 16V ELECTROLYTIC SMT D 2

C234 A11369-391F2 CAP, 390PF 1% 50V 0805 D 2

C235 102438-150J2 CAP, 15PF 5% 200V NPO 0805 D 2


C237 A11369-391F2 CAP, 390PF 1% 50V 0805 D 1

C238 A11369-391F2 CAP, 390PF 1% 50V 0805 E 1

C239 A11369-391F2 CAP, 390PF 1% 50V 0805 E 1

C241 139719-1 CAP, 1.0UF 25V X7R 10% 0805 F 2

C242 130561-1 10UF 25V 20% ALUM ELEC SMT T/R F 2

C243 139719-1 CAP, 1.0UF 25V X7R 10% 0805 G 2

C244 139719-1 CAP, 1.0UF 25V X7R 10% 0805 G 2







C251 A10434-104KD CAP, 0.1UF 250V 10% PEST RAD M 6

C252 135224-1 .001UF 10% 500V X7R MLC 1206 K 6

C253 135224-1 .001UF 10% 500V X7R MLC 1206 K 7

C254 103429-474K8 CAP, 470NF 250V 10% X7R 1812 H 2

C255 103429-103J5 0.01UF 250V 5% X7R 1206 T/R G 3

C256 103429-103J5 0.01UF 250V 5% X7R 1206 T/R H 1

C258 A11369-472J2 CAP, 4700PF 5% 50V SMT 0805 C 3

C259 135224-1 .001UF 10% 500V X7R MLC 1206 K 7

C260 135505-1 CAP, 0.1UF 25V 10% X7R 0603 C 3

C261 135224-1 .001UF 10% 500V X7R MLC 1206 K 7

C262 135224-1 .001UF 10% 500V X7R MLC 1206 N 7

C263 135224-1 .001UF 10% 500V X7R MLC 1206 N 7

C264 135224-1 .001UF 10% 500V X7R MLC 1206 N 7

C265 OPEN L 7

C266 OPEN K 7

C267 135505-1 CAP, 0.1UF 25V 10% X7R 0603 G 2

C268 OPEN N 7

C269 OPEN N 7

C270 OPEN H 5

C271 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 2

C272 139719-1 CAP, 1.0UF 25V X7R 10% 0805 D 2



C276 A11369-100J2 CAP, 10PF 5% 50V SMT 0805 E 2

C280 135224-1 .001UF 10% 500V X7R MLC 1206 H 3

C281 135224-1 .001UF 10% 500V X7R MLC 1206 H 1

C282 103429-103J5 0.01UF 250V 5% X7R 1206 T/R G 3

C283 103429-103J5 0.01UF 250V 5% X7R 1206 T/R G 1

C298 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 2

C299 135505-1 CAP, 0.1UF 25V 10% X7R 0603 D 2

C300 OPEN I 2

C301 OPEN F 6

C302 OPEN G 4

C901 137030-1 CAP, 1UF X2 REDUCED SIZE O 7

C902 OPEN Q 7

C903 137030-1 CAP, 1UF X2 REDUCED SIZE P 4

C904 OPEN P 4

C905 137455-1 CAP, 4700 PF 10% FILM Y2 Q 5

C906 137455-1 CAP, 4700 PF 10% FILM Y2 O 5

C907 135224-1 .001UF 10% 500V X7R MLC 1206 J 2

C908 103429-474K8 CAP, 470NF 250V 10% X7R 1812 J 2

C909 137455-1 CAP, 4700 PF 10% FILM Y2 Q 3

C910 137455-1 CAP, 4700 PF 10% FILM Y2 O 3



C913 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R L 5

C914 130561-1 10UF 25V 20% ALUM ELEC SMT T/R L 4

C915 141679-1 CAP, 47UF 35V 20% ELEC RAD L 5

C916 139719-1 CAP, 1.0UF 25V X7R 10% 0805 M 3

C917 A11427-103K1 0.01UF 50V 10% X7R MLC 0603 M 3

C918 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R M 3

C919 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 2

C920 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 3

C921 103429-474K8 CAP, 470NF 250V 10% X7R 1812 M 2

C922 103429-474K8 CAP, 470NF 250V 10% X7R 1812 L 4

C923 134115-1 CAP, .22UF 630V 5% POLYPROP L 2

C924 140670-101J5 CAP, 100PF 5% 500V NPO 1206 M 2

C925 139189-1 CAP, 4700UF 125V ALUM ELECT I 2

C926 139189-1 CAP, 4700UF 125V ALUM ELECT I 3



C929 139719-1 CAP, 1.0UF 25V X7R 10% 0805 K 3

C930 139719-1 CAP, 1.0UF 25V X7R 10% 0805 J 3

C931 A11369-470K1 CAP, 47PF 50V 10% NPO 0603 T/R M 3

C932 139719-1 CAP, 1.0UF 25V X7R 10% 0805 K 5

C933 A11427-104K2 .1UF 50V CHIP CAP 10% 0805 X7R K 5



C936 141924-1 CAP, 1000UF 25V 20% ELEC RAD D 6

C937 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 6

C938 A11369-220J1 CAP, 22PF 50V 5% 0603 NPO B 6

C939 139719-1 CAP, 1.0UF 25V X7R 10% 0805 C 6

C940 141924-1 CAP, 1000UF 25V 20% ELEC RAD B 5

C941 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 6

C942 A11369-222F2 CAP, 2200PF 50V NPO 1% 0805 B 6

C943 A11369-470K1 CAP, 47PF 50V 10% NPO 0603 T/R B 5

C944 A11369-102F2 1000PF 50V 1% CHIP CAP B 6



C947 A11369-102F2 1000PF 50V 1% CHIP CAP M 3

C948 135505-1 CAP, 0.1UF 25V 10% X7R 0603 M 3

C949 OPEN B 6

C950 141924-1 CAP, 1000UF 25V 20% ELEC RAD C 6

C951 103429-103J5 0.01UF 250V 5% X7R 1206 T/R J 2

C952 103429-103J5 0.01UF 250V 5% X7R 1206 T/R J 3

C953 OPEN J 4

C954 134115-1 CAP, .22UF 630V 5% POLYPROP L 1





C999 135505-1 CAP, 0.1UF 25V 10% X7R 0603 K 5


D2 137118-1 DIODE, 30V 200MA DUAL SCHOTTKY D 1



D100 142022-1 DIODE, ZEN 15V 500MW DDZ15-7 SOD-123 E 5

D101 141801-1 DIODE, 200MA 250V BAS21 SOT23 E 5

D102 138997-1 DIODE, 600V 1A SMA E 5

D105 141982-1 DIODE, DUAL 10A 300V TO-263 F 5

D106 141982-1 DIODE, DUAL 10A 300V TO-263 F 4


D108 142055-1 PRP, 138883-1 (B30H100G) 0.3" E 6

D109 142055-1 PRP, 138883-1 (B30H100G) 0.3" F 5


D200 142022-1 DIODE, ZEN 15V 500MW DDZ15-7 SOD-123 G 2

D201 141801-1 DIODE, 200MA 250V BAS21 SOT23 G 2

D202 138997-1 DIODE, 600V 1A SMA G 2

D205 141982-1 DIODE, DUAL 10A 300V TO-263 H 2

D206 141982-1 DIODE, DUAL 10A 300V TO-263 H 2

D207 135343-1 DIODE, DUAL MMBD4148SE SOT-23 N 6

D208 142055-1 PRP, 138883-1 (B30H100G) 0.3" G 3

D209 142055-1 PRP, 138883-1 (B30H100G) 0.3" G 2


D901 138689-1 PRP, 125427-1 (RBV5006) .300 O 2

D901B 141776-1 CLIP, XLS3 RECTIFIER O 2

D901C 103415-10605 SCR, #6-32X.312 SEMS TFS CONE O 3

D901D 103415-10605 SCR, #6-32X.312 SEMS TFS CONE O 2

D902 138997-1 DIODE, 600V 1A SMA L 4

D903 138997-1 DIODE, 600V 1A SMA L 5

D904 138997-1 DIODE, 600V 1A SMA M 3

D905 142061-1 PRP, 142004-1 (STTH30R04D) 0.3" J 3

D906 142061-1 PRP, 142004-1 (STTH30R04D) 0.3" J 2

D907 142061-1 PRP, 142004-1 (STTH30R04D) 0.3" J 3

D908 142061-1 PRP, 142004-1 (STTH30R04D) 0.3" J 2



D911 125593-1 DIODE, SCHOTTKY 40V 1A SMA C 6


D913 C 9773-0 DIODE, ZENER 5.1V 1N5231 SMT K 5


D915 135343-1 DIODE, DUAL MMBD4148SE SOT-23 P 1

D916 137118-1 DIODE, 30V 200MA DUAL SCHOTTKY K 4


E901 136344-1 LED, BLUE 1206 INNER LENS N 1




















HS1A 141597-1 HTSK, XLS3 AMP 602/802 F 5

HS1B 141596-1 INSL, 3.06"X0.70" CRMC F 5

HS1C 140180-1 CLIP, 2 FINGER TO-220 F 5

HS1D 140180-1 CLIP, 2 FINGER TO-220 F 4

HS2A 141597-1 HTSK, XLS3 AMP 602/802 G 2

HS2B 141596-1 INSL, 3.06"X0.70" CRMC G 2

HS2C 140180-1 CLIP, 2 FINGER TO-220 G 2

HS2D 140180-1 CLIP, 2 FINGER TO-220 G 3

HS3A 141563-1 HTSK, XLS3 PS J 2

HS3B 141669-1 INSL, 2.06" X 0.82" CRMC J 2

HS3C 140180-1 CLIP, 2 FINGER TO-220 J 3

HS3D 140180-1 CLIP, 2 FINGER TO-220 J 2

HS4A 141563-1 HTSK, XLS3 PS L 3

HS4B 141669-1 INSL, 2.06" X 0.82" CRMC L 3

HS4C 140180-1 CLIP, 2 FINGER TO-220 L 3

HS4D 140180-1 CLIP, 2 FINGER TO-220 L 3

HS4E 142134-1 INSL, 1.8"X0.85" NOMX M 3

HW901 141748-1 BRKT, XLS3 1800/2400 EMI FLTR O 7

J1 141695-1 CON, BDPT, F 4P RED/BLK N-TCH TH HOR V0 K 8

J3 141937-1 CON, RCA F 2P BRT TH VRT C 8

J101 141639-1 CON, PHN F 4P 0.25" TH HOR A 7

J102 138319-1 XLR, FEM HORZ PC PLASTIC B 8

J103 102473-1 SPEAKON, 4 POLE PCB HORZ M 8

J201 141639-1 CON, PHN F 4P 0.25" TH HOR E 7

J202 138319-1 XLR, FEM HORZ PC PLASTIC D 8

J203 102473-1 SPEAKON, 4 POLE PCB HORZ N 8

J700B 141746-1 CON, FFC 50P ZIF LOC LTCH SM HOR C 1

J901 141905-1 CON, HDR M 2P LOC TIN VRT D 6

K101 C10335-5 RELAY 30A 24V T90 SEALED CE J 6

K201 C10335-5 RELAY 30A 24V T90 SEALED CE N 6

K901 C10335-5 RELAY 30A 24V T90 SEALED CE P 1

L101 141635-1 IND, 10UH 30A 5% T157-2 TH G 5

L102 133326-2 INDUCTOR, 1UH ADJUSTABLE H 6

L201 141635-1 IND, 10UH 30A 5% T157-2 TH I 4

L202 133326-2 INDUCTOR, 1UH ADJUSTABLE K 6



L903 141644-1 INDUCTOR, 3.3MH 150MA T/H L 5

L904 141734-1 IND, 2.7UH 6% TOR 18AWG T94-2 M 1

L905 140543-1 IND, 100UH 1A 10X12.7 SMD C 6

P901 138320-1 IEC, ISA RA PC MNT P 8

PWB1 141601-5 PWB, XLS2000/XLS2500 AMP/PS A 1



Q103 142059-1 PRP, 141632-1 (FDP51N25) 0.3" E 5

Q104 142059-1 PRP, 141632-1 (FDP51N25) 0.3" F 4

Q105 125798-1 XSTR,MMBT3906 LT3 10K REEL A 6

Q106 C 7448-1 MMBT3904 CHIP NPN A 6

Q107 102483-1 PNP 300V 500MA SOT-23 E 4

Q108 125798-1 XSTR,MMBT3906 LT3 10K REEL E 4

Q109 C 7448-1 MMBT3904 CHIP NPN E 5







Q203 142059-1 PRP, 141632-1 (FDP51N25) 0.3" G 2

Q204 142059-1 PRP, 141632-1 (FDP51N25) 0.3" G 1

Q205 125798-1 XSTR,MMBT3906 LT3 10K REEL B 6


Q207 102483-1 PNP 300V 500MA SOT-23 F 1

Q208 125798-1 XSTR,MMBT3906 LT3 10K REEL F 1








Q903 142054-1 PRP, 137921-1 (2ON6OA4D) 0.3" M 2



Q906 142054-1 PRP, 137921-1 (2ON6OA4D) 0.3" L 3

Q907 141640-1 XTOR, NPN 32V 2A FJD3076 TO-252 C 6

Q908 141641-1 XTOR, PFET 20V 1.5A FDN308P SOT23 B 6


Q910 C 7448-1 MMBT3904 CHIP NPN M 3

Q911 125798-1 XSTR,MMBT3906 LT3 10K REEL D 1


R3 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 1

R4 OPEN E 2

R5 OPEN E 1

R6 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 C 2

R7 A11368-47530 RES, 475K OHM 1% 1/16W 0603 E 1

R8 A11368-64910 RES, 6.49KOHM 0.063W 1% 0603 C 1

R9 A11368-47530 RES, 475K OHM 1% 1/16W 0603 E 1

R10 A11368-64910 RES, 6.49KOHM 0.063W 1% 0603 C 1

R11 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R12 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R13 A11368-30110 3.01KOHM 1/16W 1% 0603 T/R C 2

R14 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 2

R15 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R16 A11368-47530 RES, 475K OHM 1% 1/16W 0603 A 3

R17 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 C 1

R18 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 C 1

R19 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 C 1

R20 A11368-47530 RES, 475K OHM 1% 1/16W 0603 D 3

R21 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 C 1

R22 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R23 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 C 2

R24 OPEN C 2

R25 OPEN D 1

R26 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 2

R27 A11368-33R20 RES, 33.2 OHM 1/16W 1% 0603 C 2

R100 A11371-1035 RES, 10KOHM 1W 5% 2512 H 6

R101 A11371-8205 82 OHM 1W 5% SMD 2512 B 7

R102 A11368-69800 RES, 698 OHM 1/16W 1% 0603 B 1

R103 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R B 1

R104 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 B 2

R105 A11368-69800 RES, 698 OHM 1/16W 1% 0603 A 1

R106 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R A 1

R107 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 1

R108 A11368-11321 RES, 11.3K 0.1W 1% 0805 B 2

R109 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R B 2

R110 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R111 A11368-33210 RES, 3.32 KOHM 1/16W 1% 0603 B 2

R112 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R113 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 C 2

R114 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R115 A11368-53610 RES, 5.36KOHM 0.063W 1% 0603 B 2

R116 A11368-90900 RES, 909 OHM 1% 1/16W 0603 B 2

R117 A11368-90900 RES, 909 OHM 1% 1/16W 0603 B 2

R118 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 B 3

R119 A11368-10000 RES, 100 OHM 1/16W 1% 0603 B 3


R121 OPEN B 3



R124 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 B 2

R125 A11368-20000 RES, 200 OHM 1/16W 1% 0603 B 2

R126 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R127 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R128 A11368-56200 RES, 562 OHM 1/16W 1% 0603 A 2

R129 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 A 2

R130 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 A 2

R131 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 A 2

R132 A11368-16221 RES, 16.2K 0.1W 1% 0805 A 2

R133 A11368-16221 RES, 16.2K 0.1W 1% 0805 A 3

R134 A11368-46410 RES, 4.64 KOHM 1/16W 1% 0603 A 2

R135 A11368-27411 2.74KOHM 0.1W 1% 0805 T/R A 2

R136 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R A 2

R137 A11368-14701 RES, 147 OHM 0.1W 1% 0805 A 1

R138 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R A 2

R139 A11368-34823 RES, 34.8KOHM 0.25W 1% 1210 A 2

R140 A11368-10013 1K 0.25W 1% 1210 T/R G 6

R141 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 6

R142 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 3

R143 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 G 4

R144 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R145 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 A 6

R146 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R147 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R148 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R149 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R150 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 D 5

R151 OPEN C 3

R152 A11368-15025 RES, 15KOHM 1W 1% 2512 E 5

R153 A11368-51100 511 OHM 1/16W 1% 0603 T/R E 4

R154 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 E 4

R155 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 E 4

R156 OPEN E 4

R157 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 E 4

R158 A11368-16511 1.65 KOHM 1% 0805 RES T/R E 5

R159 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 E 5

R160 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 E 5

R161 A11368-38325 RES, 38.3KOHM 1W 1% 2512 E 5

R162 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 D 4

R163 A11368-40225 RES, 40.2 KOHM 1W 1% 2512 E 5

R164 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 E 5

R165 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R166 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 B 2

R167 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 F 4

R168 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R169 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R170 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 6

R171 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 6

R172 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 5

R173 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 F 5

R190 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R191 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R192 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R193 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R194 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R195 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R196 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R197 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R198 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R199 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R200 A11371-1035 RES, 10KOHM 1W 5% 2512 J 5

R201 A11371-8205 82 OHM 1W 5% SMD 2512 D 7

R202 A11368-69800 RES, 698 OHM 1/16W 1% 0603 D 1

R203 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R D 1

R204 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 2

R205 A11368-69800 RES, 698 OHM 1/16W 1% 0603 D 1

R206 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R D 1

R207 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 1

R208 A11368-11321 RES, 11.3K 0.1W 1% 0805 C 2

R209 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R C 2

R210 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 C 2

R211 A11368-33210 RES, 3.32 KOHM 1/16W 1% 0603 C 2

R212 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 2

R213 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 C 2

R214 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 2

R215 A11368-53610 RES, 5.36KOHM 0.063W 1% 0603 C 2

R216 A11368-90900 RES, 909 OHM 1% 1/16W 0603 D 2

R217 A11368-90900 RES, 909 OHM 1% 1/16W 0603 D 2

R218 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 D 3

R219 A11368-10000 RES, 100 OHM 1/16W 1% 0603 D 3


R221 OPEN D 3



R224 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 D 2

R225 A11368-20000 RES, 200 OHM 1/16W 1% 0603 D 2

R226 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 D 2

R227 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 E 2

R228 A11368-56200 RES, 562 OHM 1/16W 1% 0603 D 2

R229 A11368-68110 RES, 6.81KOHM 0.0625W 1% 0603 D 2

R230 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 D 2

R231 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 D 2

R232 A11368-16221 RES, 16.2K 0.1W 1% 0805 D 2

R233 A11368-16221 RES, 16.2K 0.1W 1% 0805 D 3

R234 A11368-46410 RES, 4.64 KOHM 1/16W 1% 0603 D 2

R235 A11368-27411 2.74KOHM 0.1W 1% 0805 T/R D 2

R236 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R D 2

R237 A11368-14701 RES, 147 OHM 0.1W 1% 0805 E 1

R238 A11368-17811 1.78K 0.1W 1% 0805 SMD T/R E 2

R239 A11368-34823 RES, 34.8KOHM 0.25W 1% 1210 E 2

R240 A11368-10013 1K 0.25W 1% 1210 T/R H 5

R241 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 A 6

R242 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R243 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 H 1

R244 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R245 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 6

R246 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 D 1

R247 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 C 3

R248 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R249 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R250 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 F 2

R251 OPEN C 3

R252 A11368-15025 RES, 15KOHM 1W 1% 2512 F 2

R253 A11368-51100 511 OHM 1/16W 1% 0603 T/R F 2

R254 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 G 2

R255 A11368-88710 RES, 8.87KOHM 0.063W 1% 0603 G 1

R256 OPEN F 2

R257 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 F 2

R258 A11368-16511 1.65 KOHM 1% 0805 RES T/R G 2

R259 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 G 2

R260 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 G 2

R261 A11368-38325 RES, 38.3KOHM 1W 1% 2512 F 3

R262 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 F 1

R263 A11368-40225 RES, 40.2 KOHM 1W 1% 2512 G 2

R264 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 G 2

R265 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R266 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 D 2

R267 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 G 1

R268 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 B 2

R269 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 2

R270 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 G 3

R271 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 G 3

R272 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 G 2

R273 A11371-R914 RES, 0.91 OHM 5% 1/2W 2010 H 2

R290 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R291 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R292 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R293 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R294 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R295 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R296 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R297 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R298 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R299 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R300 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 I 3

R301 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 F 6

R302 A11368-10R00 RES, 10 OHM 1/16W 1% 0603 G 4

R303 A11368- RES, 49.9 OHM 1% 1/16W 0603 E 5

49R90

R304 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 E 5

R305 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 E 4

R306 A11368-10230 RES, 102KOHM 0.063W 1% 0603 B 2

R307 A11368-32420 RES, 32.4 KOHM 1% 1/16W 0603 A 2

R308 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 E 4

R309 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R310 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R311 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R312 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R313 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R314 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 6

R315 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R316 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R317 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R318 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R319 A11368-34823 RES, 34.8KOHM 0.25W 1% 1210 A 2

R320 A11368-22104 RES, 221 OHM 0.5W 1% 2010 I 7

R321 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 6

R322 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 6

R323 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 7

R324 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 7

R325 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 7

R326 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 7

R327 A11368-22104 RES, 221 OHM 0.5W 1% 2010 J 7

R403 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 G 2

R404 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 G 2

R405 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 G 1

R406 A11368-10230 RES, 102KOHM 0.063W 1% 0603 D 2

R407 A11368-32420 RES, 32.4 KOHM 1% 1/16W 0603 D 2

R408 A11368-3R011 RES, 3.01 OHM .1W 1% 0805 G 2

R409 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 7

R410 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 7

R411 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R412 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R413 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R414 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R415 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 6

R416 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 7

R417 A11368-22104 RES, 221 OHM 0.5W 1% 2010 K 7

R418 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 7

R419 A11368-34823 RES, 34.8KOHM 0.25W 1% 1210 E 2

R420 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 7

R421 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R422 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R423 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R424 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R425 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R426 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R427 A11368-22104 RES, 221 OHM 0.5W 1% 2010 L 6

R901 A11368-49923 49.9KOHM .25W 1% CHIP 1210 Q 3

R902 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 3

R903 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 3

R904 A11368-49923 49.9KOHM .25W 1% CHIP 1210 P 3

R905 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 D 1

R906 OPEN M 4

R907 OPEN N 5

R908 A11368-20010 RES, 2.0 KOHM 1/16W 1% 0603 L 4

R909 A11368-15421 15.4K 1/10W 1% SMD 0805 T/R L 4

R910 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 M 3

R911 A11368-49920 RES, 49.9 KOHM 1/16W 1% 0603 M 3

R912 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 M 2

R913 A11368-10R01 10 OHM .1W 1% 0805 T/R ROHS M 2

R914 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 M 3

R915 A11368-10R01 10 OHM .1W 1% 0805 T/R ROHS M 3

R916 A11368-10003 100 OHM 0.25W 1% 1210 T/R M 1

R917 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 K 5

R918 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 K 4

R919 A11368-20020 RES, 20.0 KOHM 1/16W 1% 0603 K 4

R920 A11368-51100 511 OHM 1/16W 1% 0603 T/R M 3

R921 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 M 3

R922 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 K 5

R923 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 J 5

R924 A11368-68130 RES, 681K OHM 1% 1/16W 0603 K 5

R925 A11368-20031 200K 0.1W 1% SMD CHIP 0805 K 5

R926 A11368-30120 RES, 30.1 KOHM 1/16W 1% 0603 K 5

R927 A11368-12131 121KOHM, 0.10W 1% CHIP 0805 K 5

R928 A11368-20031 200K 0.1W 1% SMD CHIP 0805 L 5

R929 A11368-20031 200K 0.1W 1% SMD CHIP 0805 L 5

R930 A11368-40201 402 OHM 1% 0805 RES T/R K 1

R931 A11368-20031 200K 0.1W 1% SMD CHIP 0805 C 6

R932 A11368-49921 49.9KOHM .1W 1% CHIP 0805 C 6

R933 A11368-20031 200K 0.1W 1% SMD CHIP 0805 C 6

R934 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 C 6

R935 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 C 6

R936 A11368-40201 402 OHM 1% 0805 RES T/R B 6

R937 A11368-40201 402 OHM 1% 0805 RES T/R B 6

R938 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 6

R939 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 6

R940 A11368-49921 49.9KOHM .1W 1% CHIP 0805 B 6

R941 A11368-49910 RES, 4.99 KOHM 1/16W 1% 0603 B 5

R942 A11368-60410 RES, 6.04 KOHM 1/16W 1% 0603 B 6

R943 A11368-49921 49.9KOHM .1W 1% CHIP 0805 B 6

R944 A11368-10030 RES, 100.0 KOHM 1/16W 1% 0603 B 6

R945 A11368-49R90 RES, 49.9 OHM 1% 1/16W 0603 B 5

R946 A11368-10020 RES, 10.0 KOHM 1/16W 1% 0603 K 4

R947 A11368-24910 RES, 2.49 KOHM 1/16W 1% 0603 D 1

R948 A11368-75R00 RES, 75 OHM 1/16W 1% 0603 M 3

R949 A11368-40230 RES, 402KOHM 0.0625W 1% 0603 K 4

R950 A11368-10010 RES, 1.0 KOHM 1/16W 1% 0603 M 3

R951 OPEN N 3

R952 OPEN O 4

R998 OPEN A 6

R999 A11368-49900 RES, 499 OHM 1/16W 1% 0603 A 6

RT1 140098-1 THERMISTOR, 10K NTC 1% 0603 J 2

RT101 140098-1 THERMISTOR, 10K NTC 1% 0603 F 3

RT201 140098-1 THERMISTOR, 10K NTC 1% 0603 H 1

RT901 138466-1 PRP, 101103-1 PTC .125 P 2

S901 132498-1 SWITCH, DPST PUSHBUTTON VDECSA N 2

T901 141666-1 XFMR, MAIN XLS2500 120V/240V K 3

TP1 OPEN A 6

TP901 OPEN M 2

TP902 OPEN L 5

TP903 OPEN K 4

TP904 OPEN I 3

TP905 OPEN L 5

U1 140419-1 IC, RUBY SOP64 SMD C 2

U2 C 8262-5 IC, OPAMP DUAL LONOIS 33078 SO8 B 2

U3 141744-1 IC, REG 12V 500MA 78M12C TO-263 F 3

U101 C 9012-3 OP AMP, QUAD LO NOISE MC33079D A 2

U102 141643-1 IC, DRV PWM IRS20957S E 5

U201 C 9012-3 OP AMP, QUAD LO NOISE MC33079D D 2

U202 141643-1 IC, DRV PWM IRS20957S G 2

U901 141369-1 IC, REG ADJ LNK302DN SO8 L 5

U902 141572-1 IC, DRV SMPS FAN7387 SO8 M 3

U903 126559-1 COMPARATOR, LM393 SO-8 DUAL K 5

U904 133552-1 OP AMP, LM358 LOW PWR DUAL S08 C 6

U905 138341-1 IC, TL494 PWM CTRL SO-16 B 6

U906 141638-1 IC, OPTOCOUPLER K 5

WP1 141672-1 CBL, 16AWG BRN 2.1" STRP FLG Q 7

WP2 141671-1 CBL, 16AWG BRN 2.6" STRP FLG P 7

Z901 134606-2 JUMP, 14AWG CU TIN BUS .210" X.225" N 2

COMPONENT MAP: XLS2000/2500 MAIN PWA

RUN

RUN

1152 KHZ FILTER

PS

TE

MP

384 KHZ FILTER

1152 KHZ FILTER

768 KHZ FILTER

MUTE

384 KHZ FILTER

7

768 KHZ FILTER

MUTE

NONE 600061

10K

20K

20K

1K

R23

MASTER 141602-1

10K

PWA, XLS3 MASTER AMP/PS

2 OF 5

141606 XLRG 240V

141605 XLRG 220V

141604 XLRG 120V

141603 XLRG 100V

141610 LRG 240V

141609 LRG 220V

R24

141608 LRG 120V

141607 LRG 100V 20K

20K

15K

1.1K 2K

15K

20K

20K OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

OPEN

OPEN10K

6.81K

2K

R22

NOTES: 1. ALL RESISTORS ARE IN OHMS 2. ALL CAPACITORS ARE IN MICROFARADS UNLESS OTHERWISE SPECIFIED.

C225OPEN

C126OPEN

C226OPEN

C127OPEN

C122

1%390PF

C123

1%390PF

C124

1%390PF

C224

1%390PF

C223

1%390PF

C222

1%390PF C227

OPEN

-

+U101-B

6

57

MC33079D

-

+

U101-C

9

108

MC33079D

C108

5%4700PF

C109

5%4700PF

C11315PF

5%200V

C128

1%680PF

C170.1

C232

1%0.001

C231

1%0.001

C230

1%0.001

C130

1%0.001

C132

1%0.001

C131

1%0.001

C2110

10V

C1102200PF

1%

C1112200PF1%

C1204700PF

5%

C1910

10V

D14148SE

C200.1

+T

RT110K

C1184700PF

5%

C119

1%0.001

C121

1%2200PF

C2141

C2584700PF5%

FB100

C2174700PF

5%C20.1

D110BAT54S

+T

RT10110K

C1584700PF5%

FB200

C1174700PF

5%

C1162200PF

1%

D2BAT54S

-

+

U201-D

13

1214

MC33079D

C10.1

C1711

AGND1

VCTR1A0

AGND

A1

NC

CLKN

CLKP

A2

XTAL

XGND

AVDD

DVDD

AGND

TREF

VVG1

VERR1

PGND1

VR1

IS2NP

IS2PN

IS2PP

IS1NN

IS1NP

IS1PN

IS1PP

IS2NN

TSENSE2

TSENSE1

PGND2

PWM1PN

PWM1NP

PWM1PP

PWM1NN

PWM2PP

PWM2PN

PWM2NP

PWM2NN

VCTR2

AGND2

VR2

SLAVEN

DGND

V3P3D

SDA

SCL

INT1N

INT2N

STBY1N

STBY2N

VBAT_TRK

VCC_TRKP

VCC_TRKN

VOUT1P

VOUT1N

VOUT2P

VOUT2N

AGND

VREFSAR

VRSRC

VERR2

VVG2

AVDD2

AVDD1

U1

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

3233

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

RUBY

C21315PF

5%200V

+

C13322

16V

C1721

C236100PF

-

+

U101-D

13

1214

MC33079D

C234

1%390PF

+

C23322

16V

-

+

U201-C

9

108

MC33079D

C2721

C1141

D210BAT54S

+T

RT20110K

C2600.1

+

C112

25V

10

FB2

C130.1

C71

C81

C170OPEN

-

+

U101-A2

31

MC33079D

C13515PF

5%200V

C134

1%390PF

C139

1%390PF

C138

1%390PF

C137

1%390PF

-

+

U201-B

6

57

MC33079D

C23515PF

5%200V

C239

1%390PF

C238

1%390PF

C237

1%390PF

C270OPEN

C221

1%2200PF

C2162200PF

1%

C219

1%0.001

C2184700PF

5%

C2204700PF

5%

C1600.1

-

+U201-A

2

31

MC33079D

C208

5%4700PF

C209

5%4700PF

C2102200PF

1%

C2112200PF1%

+

C212

25V

10

C2711

C220.1

C31

C41

C50.1

C229

5%120PF

C125OPEN

C228

1%680PF

C136100PF

C129

5%120PF

R11875

R219100

R2230

5%

R1246.81K

R2200

5%

R31934.8K

0.25WR122

05%

R217909

R1296.81K

R1276.81K

R1266.81K

R128562

R125200

R216909

R21875

R121OPEN

R117909

R116909

R2733.2

R119100

R102698

R1031.78K

0.10W

R1072.49K

R105698

R1042.49K

R1061.78K

0.10W

R139

0.25W

34.8K

R2220

5%

R225200

R2246.81K

R228562

R2276.81K

R2266.81K

R221OPEN

R9475K

R1230

5%

R194.99K

R25OPEN

R24OPEN

R7475K

R62K

R14610K

R14410K

R24610K

R24410K

R1484.99K

R2484.99K

R1101K

R11210

R14210

R21210

R24210

R11349.9

R133.01K

R1110

R1210

R14710

R16475K

R310

R20475K

R1830.1K

R232K

R5OPEN

R4OPEN

R2633.2

R1091.78K

0.10W

R2091.78K

0.10W

R26610

R1312K

R13216.2K

0.10W

R130100K

R306102K

R230100K

R406102K

R40732.4K

R2296.81K

R21349.9

R251OPEN R247

10

R106.49K

R86.49K

R2344.64K

R1352.74K

0.10W

R174698

R30732.4K

R41934.8K

0.25W

R2352.74K

0.10W

R239

0.25W

34.8K

R2101K

R151OPEN

R2042.49K

R2072.49K

R205698

R202698

R2031.78K

0.10W

R2061.78K

0.10W

R2210K

R178.87K

R218.87K

R13316.2K

0.10W

R1200

5%

R2312K

R23216.2K

0.10W

R23316.2K

0.10W

R2113.32K

R1113.32K

R1344.64K

R20811.3K

0.10W

R10811.3K

0.10W

R2155.36K

R1155.36K

R1401K

0.25W

R2401K

0.25W

Q101MMBT3904

Q201MMBT3904

TP1OPEN

C176

5%10PF

C276

5%10PF

-

+

U2-E

4

11

MC33079D

R2810

R1510

R11410

-

+

U101-E

4

11

MC33079D

-

+

U201-E

4

11

MC33079D

R16610

R21410

C111

R2681KR14

100K

R1681K

-

+

U2-C

9

108

MC33079D

-

+

U2-D13

1214

MC33079D

-

+U2-A

2

31

MC33079D

-

+U2-B

6

57

MC33079D

R1361.82K

0.10W

R1381.82K

0.10W

R137200

R2361.82K

0.10W

R2381.82K

0.10W

R274698

R237200

C1981

C2981

C1991

C2991

C971

C981

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

CH1_HFFB

CH2_HFFB

I2C_SCL

CLKP384K

CH1+

CH1-

CH

1_LFFB

STBY_1

CH1_ENABLE

STBY_2

CH2_ENABLE

CLIP2

CLIP1

CH1_ENABLE

CH2_ENABLE

CLKN384K

I2C_SDA

CH1_LFFB

CH2_LFFB

CH2_DRV

CH1_DRV

PWM2PN

PWM2PP

VRSRC

PWM1PP

PWM1PN

CH2-

CH2+

CH

2_LFFB

LVAC

VRSRC

VREFSAR

+5VA

+5VA

+5VA

+5VA

+5VA

+5VA

-LV

+LV

VR1

VR2

+LV

VR1

VR2

+5VA

+5VA

+5VA

-LV

+5VA

+5VA

+VCC

-VCC

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

A G N D

-LV

+LV

-LV

+LV

VR2

VR1

MUTE

3 OF 5

RUN

POWER SUPPLY FILTERING


RUN

BLK

MUTE

RED

7

BLK

RED

NONE 600061

MASTER 141602-1



Q107KST92

Q108MMBT3906

K101

12

3

4

D1074148SE

C301OPEN

J1-B

R E D 2

B L K 2

C159

5%0.001

500V

C300OPEN

HS3AHTSK, XLS3 PS

C302OPEN


C1441

C1670.1

C2411

C1411

C160.1

C161

500V

0.001C153

500V

0.001C164

500V

0.001C163

500V

0.001

C250

10%250V

0.1

+C14210

25V

C151

10%250V

0.1

C253

500V

0.001C264

500V

0.001C263

500V

0.001

C162

500V

0.001

C261

500V

0.001C262

500V

0.001

VREFOCSETDT

CSH

VCC

CSD

LO

VB

VS

VDD

VSSIN

NC

HO

NC

COM

U102

12345678 9

10111213141516

IRS20957S

VREFOCSETDT

CSH

VCC

CSD

LO

VB

VS

VDD

VSSIN

NC

HO

NC

COM

U202

12345678 9

10111213141516

IRS20957S

U3

1VI

2

GND

3VO

78M12C

C2670.1

J203N1

P2

N2

P1

J103N1

P2

N2

P1

C120.1

C1800.001

500V

C2800.001

500V

C1810.001

500V

C2810.001

500V

C251

10%250V

0.1

C150

10%250V

0.1


L102

1

4

1UH

C147

10%250V

0.1

C259

5%0.001

500V

J1-A

B L K 1

R E D 1

C2441

K201

12

3

4

D2074148SE

C180.1

D10STPS140A

D11STPS140A

C2431

C157

10%250V

0.47

C254

10%250V

0.47C154

10%250V

0.47

C14

250V

0.4710%

C146

10%250V

0.1

C148

10%250V

0.1

C173

10%250V

0.1C149

10%250V

0.1

C248

10%250V

0.1

C249

10%250V

0.1

C1520.001

500V

C246

10%250V

0.1

C166

OPENC165OPEN

C168

OPEN

C169

OPEN

C269

OPEN

C268

OPEN

C266

OPENC265OPEN

C156

5%0.01

250V

C155

5%0.01

250V

C255

5%0.01

250V

C256

5%0.01

250V

C182

5%0.01

250V

C282

5%0.01

250V

C283

5%0.01

250V

C183

5%0.01

250V

+ C15

35V470

D105LQA20B300C

D106LQA20B300C

D205LQA20B300C

D206LQA20B300C

D201BAS21

+C24210

25V

C1431

+C24510

25V

D202MURA160T3G

+C14510

25V

D102MURA160T3G

D101BAS21

R156OPEN

0.10W

R167

0.10W

3.01

R2622K

R256OPEN

R30210

R25710

R1544.99K

R2544.99K

R15710

R1430.915%0.50W

R2430.915%0.50W

R150402K

R250402K

R1622K

R272

0.91

0.50W

R152

1W

15K

R252

1W

15K

R253511

R153511

R30110

R14910K

R16510K

R16910K

R24910K

R26510K

R26910K

R413

221

0.50W

R415

221

0.50W

R416

221

0.50W

R414

221

0.50W

R417

221

0.50W

R30010

R409

221

0.50W

R2581.65K

0.10W

R2604.99K

R30349.9

R2730.91

0.50W5%

R2710.91

0.50W5%

R270 0.91

0.50W

R30549.9

R40549.9

R412

221

0.50W

R421221

0.50W

R299

221

0.50W

R427

221

0.50W

R426

221

0.50W

R294

221

0.50W

R425

221

0.50W

R424

221

0.50WR423

221

0.50W

R418221

0.50WR422

221

0.50W

R298

221

0.50W

R420 221

0.50W

R295

221

0.50W

R410221

0.50W

R411221

0.50W

R297

221

0.50W

R296

221

0.50W

R292

221

0.50W

R293

221

0.50W

R1412.49K

R1454.99K

R291

221

0.50W

R290

221

0.50W

R2412.49K

R2454.99K

R1558.87K

R2558.87K

R170 0.91

0.50W

R1710.91

0.50W5%

R172

0.91

0.50W

R1730.91

0.50W5%

R317

221

0.50W

R316

221

0.50W

R315

221

0.50W

R314

221

0.50WR313

221

0.50WR312

221

0.50WR311

221

0.50W

R310 221

0.50W

R309221

0.50W

R194

221

0.50W

R193

221

0.50W

R192

221

0.50W

R191

221

0.50W

R190

221

0.50W

R195

221

0.50W

R196

221

0.50W

R197

221

0.50W

R198

221

0.50W

R199

221

0.50W

R318221

0.50W

R320 221

0.50WR322

221

0.50WR321

221

0.50WR323

221

0.50W

R324

221

0.50W

R325

221

0.50W

R326

221

0.50W

R327

221

0.50W

R264

0.10W

3.01

R267

0.10W

3.01

R40349.9

R1594.99K

R2594.99K

R1581.65K

0.10W

R200

1W5%10K

R100

1W5%10K

R26138.3K

1W

R1604.99K

R16138.3K

1W

R164

0.10W

3.01

R163

1W

40.2K

R263

1W

40.2K

D200

15V

DDZ15

D100

15V

DDZ15

L202

1

4

1UH

C2520.001

500V

C247

10%250V

0.1C273

10%250V

0.1

Q109MMBT3904

Q102MMBT3904

Q209MMBT3904

Q202MMBT3904

Q106MMBT3904

Q206MMBT3904

Q110

NSS20201L

Q112

NSS20201L

Q210

NSS20201L

Q212

NSS20201L

Q208MMBT3906

Q207KST92

Q105MMBT3906

Q205MMBT3906

Q111NSS20200L

Q211NSS20200L

Q213NSS20200L

Q113NSS20200L

D208MBR30H100CT

D209MBR30H100CT

D109MBR30H100CT

D108MBR30H100CT

R3043.01

0.10W

R3083.01

0.10W

R4043.01

0.10W

R4083.01

0.10W

Q103

FDP51N25

Q104

FDP51N25

Q203

FDP51N25

Q204

FDP51N25

L201

1 2

10UH

L101

1 2

10UH

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!

! !

!

!

!

!

!

!

!!

!

!

!

!

!

!

!

!

CH1_OUT

CH1_DT

CH2_OUT

CH1_DRV

CH2_DRV

CH1_OUTCH2_OUT

CH2_DT

LVAC

PWM1PN

PWM1PP

PWM2PN

PWM2PPCH2_OUT

CH1_RELAY

CH2_RELAY

CH1_HFFB

CH2_HFFB

CH1_LFFB

CH2_LFFB

+LV

-VCC

VGD

VGD

-VCC

+VCC

-VCC

VGD

-VCC

-LV

+VCC

+VCC

-VCC

+VCC

+VCC

-VCC

+LV

+VCC

-LV

+VCC

141608 LRG 120V

141609 LRG 220V

PR

IMA

RY

SECONDARY

- 7.5K

SECONDARY

GROUND

- 499

MODEL ID RESISTOR

CIRCUITBREAKER

- 49.9

PRIMARY

- 4.99K

141607 LRG 100V

SE

CO

ND

AR

Y

4 OF 5

100V

7

120V

220V

PRIMARY

NONE 600061

141606 XLRG 240V

240V

30.1K

150K

121K

100K

R927

MASTER 141602-1


SMD

- 49.9K

- 750

- 75

- 75K

141605 XLRG 220V

141604 XLRG 120V

100V 134606-2

134606-2120V

220V OPEN

OPEN240V

Z901

141603 XLRG 100V

141610 LRG 240V


CRITICAL TO SAFETY COMPONENTS. REPLACE WITH SAME COMPONENT ONLY. C9130.1

2IN+

E2E1

2IN-REF

C2CTRL

VCC

RTC1

1IN+1IN-

GND

CTDTCFB

U905

123456

7

8 91011

12

13141516

TL494

-

+

U903-C8

4

LM393DC9990.1

D911STPS140A

C9321

D904MURA160T3G

GND

RCT

VDD

DT/'SD

LO

VS

HO

VB

U902

1

2

3

4 5

6

7

8

FAN7387

C9980.1

-

+

U904-C8

4

LM358

C9970.1

-

+

U903-B

6

57

LM393D

C9371

C9391

C93822PF

D909STPS140A

D910STPS140A

C9450.1

C9460.1

C9422200PF1%

D903MURA160T3G

C947

1%0.001

C9161

C9480.1

C944

1%0.001

C9330.1

Q908

G

DS

FDN308P

P901

N

L

E

WP1BRN

C9301

+ C915

35V47UF

C9291

D916BAT54S

C93147PF

-

+

U903-A

2

31

LM393D

D913

5.1VMMBZ5231BLT1

D9124148SE

GND

ANODE

CATHODE

NCVO

VCC

U906

1

2

34

5

6

H11L1M

D9144148SE

D917BAT54S

C9412200PF1%

-

+

U904-B

6

57

LM358

-

+

U904-A

2

31

LM358

C949OPEN

+ C926

125V4700

C951

5%0.01

250V

C908

10%250V

0.47 + C925

125V4700

+C956

200V

1800

C901

275VAC1

3

S

S

S

SD

NC

FB

BP1

2

4

8

7

6

5

U901LNK302

+C914

25V

10

C94347PF

R95333.2

WP2BRN

J901

1

2

+ C927

25V1000

+ C928

25V1000

+ C950

25V1000

+ C936

25V1000

+ C940

25V1000

C9350.1

C9340.1

+ C912

200V

1800

C9170.01

C922

10%250V

0.47

C921

10%250V

0.47

C923

400VAC0.22

C954

400VAC0.22

T901

1

2

3

4

5

6

7

8

9

10 11

12

141666-1

+ C911

200V

1800+ C955

200V

1800

L9011 2

34

1MHC903

275VAC1

C909

275VAC4700PF

C910

275VAC4700PF

D915

4148SE

Z901

K901

1

2

4

3

L902

1 2

34

1MH

C905

275VAC4700PF

C906

275VAC4700PF

C924

5%500V

100PF

L904

1 2

3 4

2.7UH

TP903OPEN

TP901OPEN

TP902OPEN

TP905OPEN

D902MURA160T3G

E901BLUE

R944100K

R9414.99K

R939100K

R920511

R91249.9

R937

0.10W

402R938

4.99K

R936

0.10W

402

R917100K

R9224.99K

R94049.9K

0.10W

R94349.9K

0.10W

R9082K

R94549.9

R928200K

0.10W

R929200K

0.10W

R949402K

R9104.99K

R94610K

R9211K

R91830.1K

R9231K

R91920K

R90915.4K

0.10W

R9501K

R93410K

R9354.99K

R91449.9

R913

0.10W

10

R915

0.10W

10

R925200K

0.10W

R931200K

0.10W

R933200K

0.10W

R9426.04K

R927121K

0.10W

R998OPEN

R999499

R94875

R930402

0.10W

R93249.9K

0.10W

R92630.1K

R924681K

R9472.49K

R901

0.25W

49.9K

R904

0.25W

49.9K

R902

0.25W

49.9K

R903

0.25W

49.9K

R9054.99K

R951OPEN

R952OPEN

R916

0.25W

100

R906OPEN

R907OPEN

C952

5%0.01

250V

C9070.001

500V

TP904OPEN

Q909MMBT3904

Q910MMBT3904

Q907FJD3076

Q912MMBT3904

Q904NSS20201L

Q901NSS20201L

Q911MMBT3906

S901

12

34C G N D 2

+T

RT9016

D901

RBV5006

Q906HGTG20N60A4D

Q903HGTG20N60A4D

D905STTH30R04D

D906STTH30R04D

D908STTH30R04D

D907STTH30R04D

L905100UH

L9033.3MH

R91149.9K

Q902NSS20200L

Q905NSS20200L

C9200.1

C9190.1

C9180.1

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!

!

!

!

!

!

!

!

!

!!

!

!

!

!!

!

!

!

!

!

!

!

!

!

!

!

!

!

!

!!

!

!

!

!

!

!

!

!

LVAC

CLKP192K

CLKP192K

CLKN192K

FAN

1/2V_ BULK

SOFTSTART

1/2V_ BULK

+LV

V_BULK

V_BULKRTN

+15V CONTROL

V_BULKRTN

+LV

V_BULK

+LV

-LV

V_BULKRTN

V_BULKRTN

AC_SW

V_BULKRTN

+15V CONTROL

+15V CONTROL

V_BULKRTN

+15V CONTROL

+15V CONTROL

V_BULKRTN

+15V CONTROL

-LV

+5VA

2

+5VA

+LV

-LV

AC_SW

2

-LV

V_BULK

V_BULKRTN

+LV

2

+15V CONTROL

+VCC

-VCC

CHANNEL 2 INPUT

CHANNEL 1 INPUT

5 OF 5

NC

7NONE 600061

MASTER 141602-1




FB101

FB102

FB103

XTP6

J700B

1

2

3

4IN_CH1-

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48IN_CH2-

49

50

FB104

J1021

2

3

G

FB106

C1010.1

J1013

2

1

6

FB201

FB202

FB203

FB204

FB108

FB208

FB207

IN_CH2+

C2010.1

J2013

2

1

6

J202 1

2

3

G

C10OPEN

FB107

IN_CH1+

FB206

FB105

FB205

C2000.1

C1000.1

J31

2

3

C102100PF

C103100PF

C104100PF

C105100PF

C115100PF

C215100PF

C202100PF

C203100PF

C204100PF

C205100PF

C174100PF

C274100PF

C106100PF

C107100PF

C206100PF

C207100PF

R10182

1W5%

R20182

1W5%

SHEETSCALE

SIZE

PROJ NO.

DWG NO.

4

A

D

C

B

A

D

C

B

1234

23



REV

TITLE

!

!

!

!

!

!

CH1_RELAY

SOFTSTART

CH2-

CH2+

FAN

I2C_SCL

I2C_SDA

CLKP384K

CLKN384K

CLKP192K

CLKN192K

CH1+

CH1-

CH1_DT

CH2_DT

CLIP1

CLIP2

CH2_RELAY

STBY_1

STBY_2

1

1

1

1

1

1

1-LV

+LV

+5VA

A G N D

1

11

1

1

1

1

1

APPENDIX A: VIC’s Report of XLS-3 by Victor Marquis NEW XLS series Overview Page 1 of 6 Introduction to the new XLS family of amplifiers. Consisting of the XLS1000 XLS1500 XLS2000 XLS2500 Very efficient very powerful and very lightweight. Good specs and easy to use.

NEW XLS series Overview Page 2 of 6 XLS2500 this is a state of the art amplifier with Efficiency and weight as its major advantages. The input stage has simple easy to manipulate crossovers that can be setup as ch1 low pass and ch2 high pass or both channels low-pass and or both channels high-pass. The 6dB down crossover points are selectable from 50hz to 3Khz in very fine steps 72 steps to be exact Below is a chart where I only plotted every 4th possible crossover point for clarity The available crossover frequencies are the following Red were shown on the above plot. 50 53 56 59 63 66 70 74 79 83 88 94 99 105 111 118 125 132 140 149hz 157 167 177 187 198 210 223 236 250 265 281 297 315 334 354 375 397hz 420 445 472 500 530 561 595 630 667 707 749 794 841 891 944hz values in Khz 1.0 1.06 1.12 1.19 1.26 1.33 1.41 1.50 1.59 1.68 1.78 1.89 2.00Khz 2.12 2.24 2.38 2.52 2.67 2.83 3Khz

Audio Precision 01/13/10 07:57:21XLS2500 Cross over points skipping 3 for clarity

Crossover test.at27

Ch1 Low pass CH2 High pass (-)6dB at the selected frequency. for carity every 4th crossover setting is used

-24

-0

-22

-20

-18

-16

-14

-12

-10

-8

-6

-4

-2

d

B

r

B

-24

-0

-22

-20

-18

-16

-14

-12

-10

-8

-6

-4

-2

d

B

r

A

20 20k50 100 200 500 1k 2k 5k 10k

Hz

NEW XLS series Overview Page 3 of 6 Additionally you can turn down the high pass channel by adjusting the input Potentiometer and then you can drive the Low frequencies higher and not overwhelm the mid’s and highs. So you can have full power delivered to the woofers and 4- 6 to 12dB less delivered to the mid’s and highs. This is fully adjustable by varying the ch2 level control.

Audio Precision 01/13/10 10:05:25XLS2500 Cross over points skipping 3 for clarity

Crossover test.at27

Ch1 Low pass CH2 High pass (-)6dB at the selected frequency. adjusted ch2 pot

-24

-0

-22

-20

-18

-16

-14

-12

-10

-8

-6

-4

-2

d

B

r

B

-24

-0

-22

-20

-18

-16

-14

-12

-10

-8

-6

-4

-2

d

B

r

A

20 20k50 100 200 500 1k 2k 5k 10k

Hz

Here I turned ch2 Pot down a couple of clicks for –4db

Crossover set at 500hz and ch2 pot adjusted down a little

NEW XLS series Overview Page 4 of 6 The amplifiers efficiency is the highest efficiency I have ever tested. Especially at 2 ohms where efficiencies can hover between 25% for conventional Class AB output stage to 35% to 45% with a tracking supply depending on the topology of the tracking supply. BCA amps average 60% at 1/3rd power 2 ohms. SO this is one step in efficiency above that. At almost 80% efficient this about 90% power supply and 90% amplifier. At idle the amplifier only consumes 35Watts. While the output stage active. Sleep mode is not necessary in this case. This represents audio signals with signals heavily clipped. Most music signals only approach or exceed these levels briefly. CH1 CH2 total efficiency power power out 806.00

volts out 28.25 28.53 power out Pout/Pin dissipated line current 15.40

power out 399.00 407.00 806.00 Watts/ Amp 52.34

power in = 1019.99 79.02% 213.99

NEW XLS series Overview Page 5 of 6 The amplifiers output stage can recycle reactive load energies that are normally wasted as heat in the amplifiers output stage. You can see the Reactive power out is 346W or VA and the power consumed by the amp is only 114W. That is because the amplifier is recycling the power. You wouldn’t dare run a Linear Class AB amplifier into this load. Peak load currents are occurring at amp out Voltages near zero. The dissipations would be very high. Here I am driving very low frequencies into a large 60hz transformer and since I am less than 30hz the transformer is starting to saturate. As denoted by very large currents when amp out is at 0V. For most amps this is a very brutal if not damaging test. This plot was from an XLS1800 running at just under Extreme current protection shutdown. That briefly shuts amp down and then restarts and continues to run if conditions have improved. This ran like this overnight without shutting down.

NEW XLS series Overview Page 6 of 6 This was running music at max power into 2 ohms both channels driven for 1 hr continuous. All temperatures were well in control and stabilized. The thermals are very good considering the extreme levels used during this test. Most customers will never run this much power for this sustained time. Additionally the voice coils would have heated up and become like 4-ohm resistors. Here are the max temperatures inside any of the drawn circles.

Min. °C Max. °C Avg. °C Range °C

Circle 1 36.7 74.7 62.6 38.0

Circle 2 35.6 80.0 66.3 44.4

Circle 3 31.1 65.1 52.4 34.0

Circle 4 42.6 50.9 46.9 8.3

Circle 5 45.6 50.9 48.6 5.3

Circle 6 44.0 49.6 45.8 5.6

Circle 7 33.7 81.6 64.2 47.9

Circle 8 22.0 24.7 23.5 2.7

APPENDIX B: XLS-3 LCD TROUBLESHOOTING: Affects: 141673-x PWA, XLS DISPLAY 1000

141558-x PWA, XLS DISPLAY 1500/2000/2500 New functionality has been added to firmware version 1.1.2.2 that allows for more simplified troubleshooting of issues relating to the LCD. If troubleshooting an LCD on an audio processing module (APM) with older firmware, it is suggested to update the firmware to at least 1.1.2.2 before continuing. Please refer to the service manual for instructions on updating firmware. At bootup, the updated firmware initializes the LCD. Then the microcontroller writes to the registers in the LCD module and attempts to read them back. If there are no issues, the amp will continue booting. Otherwise, there are two possible error codes relating to the LCD that are:

MAJOR MINOR ERROR COMMENT

1 1 LCD POST Fail Initialization of LCD failed

1 2 LCD Communications Fail MCU unable to communicate with LCD. Can occur anytime as opposed to POST

These error codes are unique and based upon a Major and Minor element. The Major element is determined by which portion of the amplifier failed POST, while the Minor portion is which part of the Major element failed. They are displayed by CH1 Thermal LED = MAJOR, CH2 Thermal LED = MINOR. The MAJOR is blinked 1st, then the MINOR. Other symptoms may be observed like a row of solid squares in the LCD. This procedure was developed in order that the board could be troubleshot with an oscilloscope and one probe. It will be necessary to probe the signals on the LCD header. If a test fixture is available to power the APM outside of the amplifier, this is probably recommended for ease of probing the different pins on the header. However, it can be troubleshot inside the amplifier. Below is a figure to help identify pin one of the LCD header in either case.

Figure 1: Pin 1 of LCD header

A portion of the schematic is included in Figure 2, below, from the 141673-4 schematic and is not expected to deviate significantly in the future. There is also a list of signals in Table 1, below.

Figure 2: LCD portion of APM schematic

Pin Signal/Function

1 DGND

2 +5VD (SUPPLY V FOR LOGIC)

3 $2397; LCD_PWM THRU 1K (OPERATING V FOR LCD)

4 LCD_RS

5 LCD_RW

6 LCD_EN

7 $1837; DB0; TIED LOW TO DGND




11 LCD_D4

12 LCD_D5

13 LCD_D6

14 LCD_D7

15 $1830; LCD BACKLIGHT ANODE (A) TO +5VD THRU 100 OHMS

16 LCD BACKLIGHT CATHODE (K) TO DGND

Table 1: LCD header signals

The flowchart in Figure 3, below, walks through troubleshooting LCD issues beginning with the error code explained above. If identified as error code 0x11, the pins on the LCD need to be looked at with the scope according to the order in the flowchart. A scope set with 2 V/div and 5 µsec/div should be able to capture the toggling on the lines identified in the flowchart. As a reference, examples of the scope displaying toggling bits on different lines can be seen in Figures 4-6, below. The unit in the example displayed toggling on the LCD_EN, LCD_RW, and data lines but NOT on the LCD_RS line, therefore it was concluded and verified that something was wrong with the LCD_RS line. In this particular case, the microcontroller (U706) pin 51 was not soldered.

Figure 3: Flowchart for troubleshooting LCD issues

Figure 4: Toggling on LCD_EN

ERROR CODE

0X12?

BAD U706 (MICROPROCESSOR)

INTERMITTENT CONNECTION

LCD_EN (LCD PIN6) TOGGLE?

OPEN/SHORT U706 PIN 53

LCD_RW (LCD PIN5) TOGGLE?

LCD_D4-D7 (LCD PINS

11-14) TOGGLE?

LCD_RS (LCD PIN4) TOGGLE?

BAD LCD

Y

N

Y

Y

Y

Y

N

N

N

N

N

Y


OPEN/SHORT U706 PINS 33-36


ERROR CODE

0X11?

Figure 5: Toggling on LCD_RW

Figure 6: Toggling on data line

After determining the issue to be with a pin on the microcontroller U706, care must be taken to remove the LCD and identify the issue. Most likely there will be an unsoldered pin or shorted pins on the micro. There is a smaller chance there could be a broken path between the pins on the micro and the LCD header. The layout of the U706 is shown in Figure 7, below. A portion of the schematic around U706 is also provided for reference in Figure 8, below. U706 is a 64 pin LQFP.

Figure 7: Microcontroller (U706, 64 pin LQFP) layout

Figure 8: U706 portion of schematic

PIN1

PIN51

(LCD_RS)

PIN33

(LCD_D4)

U706 LCD PINS

LCD_EN53

LCD_RW52

LCD_RS51

LCD_D736

LCD_D635

LCD_D534

LCD_D433

U706 LCD PINS

LCD_EN53

LCD_RW52

LCD_RS51

LCD_D736

LCD_D635

LCD_D534

LCD_D433

APPENDIX C: XLS-3 PWA/PWB REFERENCE:

ASSEMBLIES: Model New Description

XXLS1000-0-US XLS 1000W AMP W/ XOVER & LIMTR 120V

XXLS1000-2-EU XLS 1000W AMP W/ XOVER & LIMTR 220V


XXLS1000-34-EU XLS 1000W AMP W/ XOVER & LIMTR 230-240V

XXLS1000-34-UK XLS 1000W AMP W/ XOVER & LIMTR 230-240V

XXLS1000-34-IN XLS 1000W AMP W/ XOVER & LIMTR 230-240V

XXLS1000-34-AU XLS 1000W AMP W/ XOVER & LIMTR 230-240V






















PWA’s:

141576-x PWA, XLS1000 100V AMP/PS

141577-x PWA, XLS1000 120V AMP/PS

141578-x PWA, XLS1000 220V AMP/PS

141579-x PWA, XLS1000 240V AMP/PS

141673-x PWA, XLS DISPLAY 1000

141580-x PWA, XLS1500 100V AMP/PS

141581-x PWA, XLS1500 120V AMP/PS

141582-x PWA, XLS1500 220V AMP/PS

141583-x PWA, XLS1500 240V AMP/PS

141607-x PWA, XLS2000 100V AMP/PS

141608-x PWA, XLS2000 120V AMP/PS

141609-x PWA, XLS2000 220V AMP/PS

141610-x PWA, XLS2000 240V AMP/PS

142028-x PWA, XLS2500 100V AMP/PS

142029-x PWA, XLS2500 120V AMP/PS

142030-x PWA, XLS2500 220V AMP/PS

142031-x PWA, XLS2500 240V AMP/PS

141558-x PWA, XLS DISPLAY 1500/2000/2500

PWB’s:

141557-3 PWB, XLS DISPLAY

141574-3 PWB, XLS1000/1500 AMP PS

141601-4 PWB, XLS2000/2500 AMP PS

AUX TEST ASSEMBLIES:

PWB PWA DESCRIPTION

141614-1 141615-1 RUBYLATOR

142104-1 142103-1 APM SELF-TEST BOARD, APM SIMULATOR, CORTEX ADAPTOR BOARD (MFG Version)

142104-1 142980-2 APM SELF-TEST BOARD, APM SIMULATOR, CORTEX ADAPTOR BOARD (DESIGN Version)

50POS FFC CABLE: 141747-1

TRANSFORMERS BY MODEL:

CPN DESCRIPTION

141646-1 XFMR, MAIN XLS1000 100V

141647-1 XFMR, MAIN XLS1000 120V/240V

141648-1 XFMR, MAIN XLS1000 220V

141649-1 XFMR, MAIN XLS1500 100V

141650-1 XFMR, MAIN XLS1500 120V/240V

BREAKERS BY MODEL:

141651-1 XFMR, MAIN XLS1500 220V

141662-1 XFMR, MAIN XLS2000 100V

141663-1 XFMR, MAIN XLS2000 120V/240V

141664-1 XFMR, MAIN XLS2000 220V

141665-1 XFMR, MAIN XLS2500 100V

141666-1 XFMR, MAIN XLS2500 120V/240V

141667-1 XFMR, MAIN XLS2500 220V

APPENDIX D: XLS1000/1500 ASSEMBLY DRAWING:

APPENDIX E: XLS2000/2500 ASSEMBLY DRAWING:

XLS1000 – 2500 Service Manual - Audio Lab of Ga

Documents

Transcript of XLS1000 – 2500 Service Manual - Audio Lab of Ga