Warranty Information - AMT GarageForum · T-SB-0078-09 March 2, 2009 Page 2 of 5 "No Start" DTC...
Transcript of Warranty Information - AMT GarageForum · T-SB-0078-09 March 2, 2009 Page 2 of 5 "No Start" DTC...
T-SB-0078-09 March 2, 2009
"No Start" DTC B2799
ServiceCategory Vehicle Interior
Section Theft Deterrent/Keyless Entry Market USA
Applicability
YEAR(S) MODEL(S) ADDITIONAL INFORMATION
2007 – 2008 Tundra
Introduction
Some customers may experience a crank and “No start” condition accompanied by immobiliser DTCB2799 and/or B2780, B2784, B2796, B2797, B279A. A production change has been made to theTransponder key ECU. Use the following repair procedure to address these customer concerns.
Warranty Information
OP CODE DESCRIPTION TIME OFP T1 T2
EL8053 R & R Transponder Key Computer Assembly 8.5 89780-0C011 01 73
APPLICABLE WARRANTY• This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for
36 months or 36,000 miles, whichever occurs first, from the vehicle’s in-service date.
• Warranty application is limited to correction of a problem based upon a customer’s specificcomplaint.
Parts Information
PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME QTY
89780-0C011 Same Transponder Key Computer Assy 1
© 2009 Toyota Motor Sales, USA Page 1 of 5
T-SB-0078-09 March 2, 2009 Page 2 of 5
"No Start" DTC B2799
Production Change Information
This TSB applies to vehicles produced BEFORE the Production Change Effective VINs shown below.
MODEL PLANT ENGINE DRIVETRAIN PRODUCTION CHANGE EFFECTIVE VIN
2UZ-FE 2WD 5TBRT541*8S459822
2UZ-FE 4WD 5TBBT541*8S461788
3UR-FE 2WD 5TBEV541*8S478648TMMI
3UR-FE 4WD 5TBDV581*8S508332
5TFJU521*8X0037821GR-FE 2WD
5TFRU541*8X010832
5TFJT521*8X002322
5TFRT541*8X0219212UZ-FE 2WD
5TFST541*8X002114
5TFKT521*8X002179
5TFBT541*8X0123432UZ-FE 4WD
5TFCT541*8X002317
5TFJV521*8X002886
5TFEV541*8X0551963UR-FE 2WD
5TFSV541*8X005572
5TFKV521*8X002885
5TFDV581*8X059442
Tundra
TMMTX
3UR-FE 4WD
5TFCV541*8X007115
Required Tools & Equipment
REQUIRED EQUIPMENT SUPPLIER PART NUMBER QTY
TIS Techstream*
NOTE: Software version 4.00.017 or later isrequired.
TSPKG1 1
R-134a Refrigerant Recovery/Recycling Machine
ADE
Robinair ROB34200 (orequivalent) 1
* Essential SST.
NOTEAdditional TIS Techstream units and refrigerant service equipment may be ordered by callingApproved Dealer Equipment (ADE) at 1-800-368-6787.
© 2009 Toyota Motor Sales, USA
T-SB-0078-09 March 2, 2009 Page 3 of 5
"No Start" DTC B2799
Required Tools & Equipment (Continued)
SPECIAL SERVICE TOOLS (SST’S) PART NUMBER QTY
Plastic Pry Tool Set* 00002-06000-01 1
* Essential SST.
NOTEAdditional SSTs may be ordered by calling 1-800-933-8335.
Repair Procedure
1. Verify that the vehicle will crank but not start.
2. Perform Health check and look for any immobiliser system DTCs.
3. If there are any immobiliser DTC’s present, test the vehicle using all keys. If the condition ispresent with all the keys, proceed to step 4. If the problem is isolated to a single key, refer to therepair manual diagnostic chart for the specific DTC.
4. Replace transponder key ECU.
• 2007 / 2008 Tundra:
Vehicle Interior – Theft Deterrent / Keyless Entry – Engine Immobiliser – TransponderKey ECU: “Removal”
A. Location of the Transponder Key ECU Assembly is on the Air Conditioning Unit betweenbulkhead on the left.
© 2009 Toyota Motor Sales, USA
T-SB-0078-09 March 2, 2009 Page 4 of 5
"No Start" DTC B2799
Repair Procedure (Continued)
Figure 1.
B. Back side of Air Conditioning Unit, where theTransponder Key ECU Assembly is mounted.
Figure 2.
© 2009 Toyota Motor Sales, USA
T-SB-0078-09 March 2, 2009 Page 5 of 5
"No Start" DTC B2799
Repair Procedure (Continued)
C. Remove the Transponder Key ECU Assemblyfrom the Air Conditioning Unit, by sliding thelower half out and moving downwards torelease the top.
Figure 3.
1 Slide Transponder Key ECU Assembly Out
2 Slide Transponder Key ECU Assembly Down
5. Install new Transponder Key ECU.
• 2007 / 2008 Tundra:
Vehicle Interior – Theft Deterrent / Keyless Entry – Engine Immobiliser – Transponder KeyECU: “Installation”
6. Connect TIS Techstream and clear all stored DTCs.
7. Verify Proper Operation of Immobilizer System.
© 2009 Toyota Motor Sales, USA