W100 WS/WE100-P4430, Online data sheet - Usługowe Proton · 2016. 11. 6. · DOL-0804-G02M 6009870...
Transcript of W100 WS/WE100-P4430, Online data sheet - Usługowe Proton · 2016. 11. 6. · DOL-0804-G02M 6009870...
-
On
lin
e d
ata
sh
ee
t
WS/WE100-P4430W100
PRODUCT PORTFOLIO
-
ABCDEF
HIJKLMNOPQRST
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Illustration may differ
Ordering information
Type Part no.
WS/WE100-P4430 6028589
Other models and accessories www.sick.com/W100
Detailed technical data
FeaturesSensor/detection principle Through-beam photoelectric sensor
Dimensions (W x H x D) 11 mm x 31 mm x 20 mm
Housing design (light emission) Rectangular
Sensing range max. 0 m ... 15 m
Sensing range 0 m ... 12 m
Type of light Visible red light
Light source LED 1)
Light spot size (distance) Ø 1,500 mm (12 m)
Angle of dispersion Approx. 7.2°
Wave length 680 nm
Adjustment Potentiometer, 270°
1) Average service life: 100,000 h at TU = +25 °C.
Mechanics/electronicsSupply voltage 10 V DC ... 30 V DC 1)
Ripple ± 10 % 2)
Power consumption, sender ≤ 15 mA 3)
Power consumption, receiver ≤ 20 mA 3)
Output type PNP, Open Collector
1) Limit values when operated in short-circuit protected network: max. 8 A.2) May not exceed or fall below Uv tolerances.3) Without load.4) Signal transit time with resistive load.5) With light/dark ratio 1:1.6) A = VS connections reverse-polarity protected.7) B = inputs and output reverse-polarity protected.8) D = outputs overcurrent and short-circuit protected.
2 | SICK Online data sheet | 2016-07-20 20:10:10
Subject to change without notice
http://www.sick.com/6028589http://www.sick.com/6028589https://www.sick.com/W100
-
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Switching mode Light/dark switching
Switching mode selector Selectable via light/dark rotary switch
Signal voltage PNP HIGH/LOW UV - 1,8 V / ca. 0 V
Output current Imax. ≤ 100 mA
Response time ≤ 0.5 ms 4)
Switching frequency 1,000 Hz 5)
Angle of reception Approx. 15°
Connection type Connector M8, 4-pin
Circuit protection A 6)
B 7)
D 8)
Weight 18 g
Housing material ABS/PC/POMplastic
Optics material Plastic, PMMA
Enclosure rating IP 65
Ambient operating temperature –25 °C ... +55 °C
Ambient storage temperature –40 °C ... +70 °C
1) Limit values when operated in short-circuit protected network: max. 8 A.2) May not exceed or fall below Uv tolerances.3) Without load.4) Signal transit time with resistive load.5) With light/dark ratio 1:1.6) A = VS connections reverse-polarity protected.7) B = inputs and output reverse-polarity protected.8) D = outputs overcurrent and short-circuit protected.
Classifications
ECl@ss 5.0 27270901
ECl@ss 5.1.4 27270901
ECl@ss 6.0 27270901
ECl@ss 6.2 27270901
ECl@ss 7.0 27270901
ECl@ss 8.0 27270901
ECl@ss 8.1 27270901
ECl@ss 9.0 27270901
ETIM 5.0 EC002716
ETIM 6.0 EC002716
UNSPSC 16.0901 39121528
2016-07-20 20:10:10 | Online data sheet
Subject to change without notice
| SICK 3
-
ABCDEF
HIJKLMNOPQRST
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Adjustments possibleW100-2
2 1
3
4L D
① LED indicator orange: switching output active② LED indicator green: power on③ Sensing range adjustment: potentiometer④ Light/ dark rotary switch: L = light switching, D = dark switching
Connection diagramCd-057
1 2
+ (L+)
not connected
- (M)
brn
wht
blu
1
2
3
not connectedblk 4
+ (L+)
not connected
- (M)
brn
wht
blu
1
2
3
Qblk 4
① Sender② Receiver
4 | SICK Online data sheet | 2016-07-20 20:10:10
Subject to change without notice
-
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Characteristic curveWS/WE100
100
10
1m
(feet)4
(13.12)8
(26.25)12
(39.37)16
(52.49)20
(65.62)
Distance in m (feet)
Sensingrange
Sensing rangetyp. max.
1
3
2
45
① Without masks② With polarization filter tip adapter③ With slotted mask, width 2.0 mm④ With slotted mask, width 1.0 mm⑤ With slotted mask, width 0.5 mm
Sensing range diagramWS/WE100
0 4(13.12)
8(26.25)
12(39.37)
16(52.49)
20(65.62)
3
2
1
Distance in m (feet)
Sensing range Sensing range max.
120
40
5
15
5.5
4 20 3
5 0
70
1
1.5
① Without masks② With polarization filter tip adapter③ With slotted mask, width 2.0 mm④ With slotted mask, width 1.0 mm⑤ With slotted mask, width 0.5 mm
2016-07-20 20:10:10 | Online data sheet
Subject to change without notice
| SICK 5
-
ABCDEF
HIJKLMNOPQRST
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Dimensional drawing (Dimensions in mm (inch))WS/WE100
20 (0.79)3(0.12)
25
.4 (
1.0
0)
2.8
(0.1
1)
31
(1
.22
)1
0.3
(0.4
1)
11(0.43)
19
(0
.75
)
1
12
45
3
① Threaded mounting hole M3② Center of optical axis③ Connection④ LED indicator orange: switching output active⑤ LED indicator green: power on
Recommended accessoriesOther models and accessories www.sick.com/W100
Brief description Type Part no.
Universal bar clamp systems
Plate N08 for universal clamp bracket, Zinc plated steel (sheet), Zinc die cast (clampingbracket), Universal clamp (5322626), mounting hardware
BEF-KHS-N08 2051607
Device protection (mechanical)
Safety bracket for floor mounting, Stainless steel 1.4571, mounting hardware included BEF-SW-W4S 2051497
Mounting brackets and mounting plates
Mounting bracket for wall mounting, Stainless steel, mounting hardware included BEF-W100-A 5311520
Mounting bracket for floor mounting, steel, zinc coated, mounting hardware included BEF-W100-B 5311521
Plug connectors and cables
Head A: female connector, M8, 4-pin, straightHead B: cableCable: PVC, unshielded, 2 m
DOL-0804-G02M 6009870
Head A: female connector, M8, 4-pin, straightHead B: cableCable: PVC, unshielded, 5 m
DOL-0804-G05M 6009872
6 | SICK Online data sheet | 2016-07-20 20:10:10
Subject to change without notice
https://www.sick.com/W100http://www.sick.com/2051607http://www.sick.com/2051607http://www.sick.com/2051497http://www.sick.com/2051497http://www.sick.com/5311520http://www.sick.com/5311520http://www.sick.com/5311521http://www.sick.com/5311521http://www.sick.com/6009870http://www.sick.com/6009870http://www.sick.com/6009872http://www.sick.com/6009872
-
WS/WE100-P4430 | W100PRODUCT PORTFOLIO
Brief description Type Part no.
Head A: female connector, M8, 4-pin, angledHead B: cableCable: PVC, unshielded, 2 m
DOL-0804-W02M 6009871
Head A: female connector, M8, 4-pin, angledHead B: cableCable: PVC, unshielded, 5 m
DOL-0804-W05M 6009873
Head A: female connector, M8, 4-pin, straightHead B: -Cable: unshielded
DOS-0804-G 6009974
Head A: female connector, M8, 4-pin, angledHead B: -Cable: unshielded
DOS-0804-W 6009975
Head A: male connector, M8, 4-pin, straightHead B: -Cable: unshielded
STE-0804-G 6037323
Masks
Single slotted mask, vertical/horizontal, slot width: 0.5 mm/ 1.0 mm/2.0 mm BL-140-10 5308458
2016-07-20 20:10:10 | Online data sheet
Subject to change without notice
| SICK 7
http://www.sick.com/6009871http://www.sick.com/6009871http://www.sick.com/6009873http://www.sick.com/6009873http://www.sick.com/6009974http://www.sick.com/6009974http://www.sick.com/6009975http://www.sick.com/6009975http://www.sick.com/6037323http://www.sick.com/6037323http://www.sick.com/5308458http://www.sick.com/5308458
-
Onlin
e da
ta s
heet
SICK AG | Waldkirch | Germany | www.sick.com
SICK At A GlAnCeSICK is one of the leading manufacturers of intelligent sensors and sensor solutions for industrial applica-tions. A unique range of products and services creates the perfect basis for controlling processes securely and efficiently, protecting individuals from accidents and preventing damage to the environment.
We have extensive experience in a wide range of industries and understand their processes and require-ments. With intelligent sensors, we can deliver exactly what our customers need. In application centers in Europe, Asia and North America, system solutions are tested and optimized in accordance with customer specifications. All this makes us a reliable supplier and development partner.
Comprehensive services complete our offering: SICK lifetime Services provide support throughout the ma-chine life cycle and ensure safety and productivity.
For us, that is “Sensor Intelligence.”
WOrldWIde preSenCe:Contacts and other locations – www.sick.com