VW Golf VII TROC Web - ECS Electronics

Part No: VW-190-07MU

1/22

Electric wiring kit for towbars / 7-pin / 12N / 12 Volt / ISO 1724

This electric kit has to be installed by a professional workshop or a suitable qualified person.The installation instructions must have been read and fully understood before the start of any installation. Please contact your wiring kit provider or the hotline shown in the footer should you need assistance!Make sure the vehicle is approved/homologated by the manufacturer to tow a trailer! Also please check that there is a definite compatibility between this vehicle and the electric kit!Following the installation of the electric kit, the fitting instructions should be kept together with the vehicle service document and vehicle handbook. The fitting instructions contain important information relating to the use and function of the towing kit as well as for any diagnostic or activation process, that might have to be repeated in the future (e.g. after the performance of a vehicle software update).All warranty claims will be forfeited if the electric kit or components contained therein are used incorrectly or modified. If a towing socket adaptor has been used to connect to the trailer or bike rack, this must be removed from the trailer socket once the trailer or bike rack has been disconnected.If the trailer or bike rack is not equipped with a rear fog lamp, depending on the towing vehicle type, the correct function of the towing kit cannot be guaranteed. In such cases, a rear fog lamp should be retro fitted.This towing electric kit will not be covered under warranty if any technical or electrical modifications or software updates have been performed by the vehicle manufacturer after the initial commissioning of the kit. That applies especially to modifications or updates which may cause malfunctions in the trailer socket or any other part of the trailer electrical equipment!Depending on the type of trailer module used in this electric kit, diagnostic interrogation with the vehicle’s electrical system may be limited or will not function. The error memory inside the trailer module may not be able to be accessed by vehicle manufacturers diagnostic system.Error logs relating to the trailer electrical equipment, that may be generated in the vehicle manufacturers diagnostic system as a result of a test procedure, may be due to the incorrect installation of the towing electric kit or the false activation of the trailer module.We always recommend whenever possible, the following troubleshooting process: An analysis of the vehicle’s error memory and possibly clearing of all faults before the start of the installation! Try disconnecting the trailer module from the towing harness and re-start the fault clearing process! If in doubt, limit the time for troubleshooting to a max of 0,5 hours and call our Technical Support Team!Please follow our instructions carefully and always test the towing electrics using a true lighting board or a specifically designed bulb tester. If an LED tester is used, ensure it is equipped with correct load resistors or malfunctions will occur! This instruction is subject to changes and we reserve the right to make changes to design, colour etc. All of the data and illustrations may not be an exact representation but the text contained in this instruction must be observed!

e-GolfGolf VIIGolf VII VariantGolf VII SportsvanGolf VII AlltrackT-RocT-Roc Cabrio

Volkswagen2014 >>11/2012 >>08/2013 >>06/2014 >>02/2015 >>11/2017 >>03/2020 >>

[email protected]

www.ecs-electronicsuk.co.uk

Revision: 3 / 06.08.2021 VW-190-07MU

ECS Electronics UK20 Speedwell Close Hun�ngtonChester, CH3 6DX

Email-sales: [email protected]: [email protected]

SALE: +44 (0) 7590 564639TECHNICAL: +44 (0) 7440 202052WEB: www.ecs-electronicsuk.co.uk

2/22

M

24-37 15-23

5x

U

B

L1

L3

L4

L2

X

A

C

M1

G

T

3x3x1x

3x

1x20 Amp.

20 Amp.1x

2x

10x3x

8-15

Part No: **-***-***

*/**

Electric wiring kit for towbars / **-pin / 12 Volt / ISO *****


******** **/**** >>

************

[email protected]


Revision: * / **.**.******-***-***




Revision: 3 / 06.08.2021 VW-190-07MU




3/22

SYMBOL EXPLANATION

TOOLS

ATTENTION!

ATTENTION!

Left (58-L) respectivelyRight (58-R) tail light

Stop light (54) / high mounted, third stop light (54)

Turn signal indicator left

Turn signal indicator right

Rear fog light(s)

Reversing light(s)

Trailer / trailer recognition

Permanent current power supply

Ground or Earth (31)

Ground connection battery terminal lug

Permanent power supply / 13pin socket, chamber 9

Charging wire for trailer battery / 13pin socket, chamber 10

+

15+

+

30+

Positive connection battery terminal lug

54 STOP

L

R

Reverse

B+/30

Fuse / fuse capacity 20 Ampère

Cigarette lighter /accessory socket

Loudspeaker / buzzer

Park Distance Control

Switch / source of function

Connect together

Disconnect

Look at / See further information

Look carefully at selected area

Present / Occupied / OK

Not present / Not occupied / Not OK

Acoustic indication

Attention / important advice

20 Amp.

20 Amp.

12V

In order to avoid mal-functions and damage to the vehicle’s electrical system the earth terminal must be disconnected from the vehicle’s battery before starting work!

Both the trailer module and the vehicle’s control unit for the electrical system can be damaged during workon the data bus connections if the battery is not disconnected!

Please pay attention to the manufacturer’s instructions when disconnecting and reconnecting the vehicle’s battery!

The vehicle's cooling capacity may have to be increased when retrofitting a trailer coupling!You must observe the manufacturer's instructions!!

!Code

3:3

Note: It may be necessaryto check if this vehicle hasa stored radio code beforedisconnecting the battery!

Co

Co

1

Revision: 3 / 06.08.2021 VW-190-07MU




2

4

3

Golf VII/ Variant/ Sportsvan/ Alltrack / T-Roc

2 3

4x

1

Golf VII/ Sportsvan/ T-Roc

3

5

6

2

4

1


2

1

4

3T-Roc Cabrio

4/22

Revision: 3 / 06.08.2021 VW-190-07MU




5/22

5

7

Variant/ Alltrack

Golf VII/ Variant/ Sportsvan/ Alltrack/ T-Roc

2

5

4

6

3

1

6

Variant/ Alltrack

2

13

2

3

1

Revision: 3 / 06.08.2021 VW-190-07MU




6/22

8


9

10

Variant/ Alltrack


1SEAL WITH SILICONE.4

3

3

1SEAL WITH SILICONE.

4

X

INFOXT

2

X

INFOXT

2

Revision: 3 / 06.08.2021 VW-190-07MU




7/22

11

All Models

12

All Models

13

All Models

14

All Models

15

All Models

X

X

Option 1 Option 2

Option 3

X

Option 1

X!

!

Option 2 1 2

3

Option 3 1 2

3

Page 22SOCKET CONNECTION

Revision: 3 / 06.08.2021 VW-190-07MU




8/22

16

All Models

17

18


Variant/ Alltrack

M

M

M

1 2 3

4

G

10 mm2

3

M1

M

10 mm 2

G3

1

Revision: 3 / 06.08.2021 VW-190-07MU




9/22

19


Vehicle with trailer preparation.


Vehicle without trailer preparation.

Black10 pin

Black/Violet6 pin

Black10 pin

Black/Violet6 pin

+20 22

38 52

23 52

20

A

21 3

1

2

3

4

Revision: 3 / 06.08.2021 VW-190-07MU




10/22



23

21

AB

21 3

1

2

3

38

22

Vehicle with trailer preparation (Only for vehicles >> 05/2014).

1 Blue2 pin

Orange/Brown

Orange/Green !CAN-Data Wire2

Orange/GreenOrange/Brown

Orange/Brown

Orange/Green

!4

5

3

Orange/GreenOrange/Green

Orange/Brown

Orange/Brown

Important! Please note informations in picture 1!

Revision: 3 / 06.08.2021 VW-190-07MU




11/22

24


25


26


U

L1

L3

L4L2

3

1

5

4

2

6

Body Control Module

Revision: 3 / 06.08.2021 VW-190-07MU




12/22

BCM-A

Can-busDatawireCAN

H

Pos. 17Orange/BrownCAN

L

27


28


29


BCM-A BCM-C

1 54 8

2 6

3 7

1 2

3

BCM-A

Body Control Module

Pos. 16

Orange/Greenor Green

Revision: 3 / 06.08.2021 VW-190-07MU




13/22

30


31


LOCK Orange/BrownPos. 1

Orange/GreenPos. 2

CAN H

Pos. 1Orange/BrownCAN

L

1

2

3 L1

BCM-A

L2

2

1 BCM-A

Can-busDatawire

Pos. 16Orange/Green

Pos. 17Orange/Brown

4

Pos. 2

Orange/Greenor Green

Revision: 3 / 06.08.2021 VW-190-07MU




14/22

32


33


34


1 2

3

BCM-C

BCM-C

LOCK

Black/RedPos. 3

1

2

3 L3

BCM-C

L4 4

Pos. 58Black/RedSTOP

Revision: 3 / 06.08.2021 VW-190-07MU




Pos. 58STOP

Pos. 3STOP

15/22

35


37


1 2 BCM-C

8 5

7

6

4 1

3

2

BCM-A BCM-C

Body Control Module

36


38

Red/BluePos. 38

U

1

2

+30

20 Amp.

20 Amp.

Pos. 38

Revision: 3 / 06.08.2021 VW-190-07MU




16/22

38

All Models

40

All Models

39

All Models

! Code3:3

! MAX = 21WReverse

Optional

12S socket

Reverse

Reverse

Pink

AC

M1G

C

Set up trailer operation

VolkswagenSeatAudi

VolkswagenSeatAudi

!Diagnosis Services or diagnostic methods (local / offline):

Please note:

Always use the latest diagnostic version!The vehicle to be coded must be supported by the diagnostic service provider and already be implemented in the diagnostics version!Please contact your diagnostic service provider in case of any question.

- ODIS (page 21)- Hella Gutmann- VCDS- Autologic- Bosch / KTS- SP Diagnostic- SUN- Jifeline- Autocom- etc. pp.

Revision: 3 / 06.08.2021 VW-190-07MU




17/22

41

All Models

42

All Models

43

All Models

L 54 STOPR

Reverse

Trailer Simulator for 7- and13-pin Sockets

Optional

!

L R

MENUOK

P 500 miles6666 miles

Driving Aids

6:00 AM 36 F

C H0

1

23 4

56

7

8

RPMx1000

1/210

20

40

6080

100

120

140

160

20

40

60

80100

120 140160

180

200

220

240

260km/h

LED

RL

Consult your supplier.

Revision: 3 / 06.08.2021 VW-190-07MU




Functional test WARNING

OFF

VHz

Hz

Hz

Hz

A

V

COM10A

400mA

mA

V

mV

HOLD MINMAX RANGE

DC

Manual Range 60+

V

part no.

LIGHTMATE IILIGHTMATE III

18/22

44

46


Variant/ Alltrack

5

2

3

1

4

6

45

Variant/ Alltrack

2

31

4

6

2

3

5

1

Revision: 3 / 06.08.2021 VW-190-07MU




19/22

47

49

48



4

2

1

5

3

6


1 2

4x

3

3

4

1

2T-Roc Cabrio

Revision: 3 / 06.08.2021 VW-190-07MU




20/22

50

All Models

Adapter socketOptional

51

All Models

52

All Models

7-pin 13-pin

Part No: **-***-***

*/**

Electric wiring kit for towbars / **-pin / 12 Volt / ISO *****


******** **/**** >>

************

[email protected]


Revision: * / **.**.******-***-***




Revision: 3 / 06.08.2021 VW-190-07MU




21/22

Set up trailer operation

Revision: 3 / 06.08.2021 VW-190-07MU




22/22

SOCKET CONNECTION

1-7 STOP

21W21W 21W 52W 3x21W 52W

DIN/ISO 1724

Pmax

Yellow Blue White Green Brown Red Black

1/L 2 3/31 4/R 5/58-R 6/54 7/58-L

L R

Colour

SOCKET CONNECTION

12

76

54

3

1

6

7

53

4

2

Yellow

Blue

White

Green

Brown

Red

Black

Revision: 3 / 06.08.2021 VW-190-07MU




VW Golf VII TROC Web - ECS Electronics

Documents

Transcript of VW Golf VII TROC Web - ECS Electronics