VOC gas detection IR camera
-
Upload
fmjpguerrero -
Category
Documents
-
view
1.329 -
download
2
Transcript of VOC gas detection IR camera
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
VOC gas detection thermal imaging camera
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Increase on-site safety
Check site conformity to rules and regulations concerning VOC emissions
Decrease site inspection cost
Increase your revenue decreasing fugitive emissions of high value / toxic / dangereous products to the atmosphere
Planification of your maintenanc taskforce so they fix first the leaking equipments.
(LDAR Program –Leaks Detection And Repair)
IF THOSE ARE SOME OF YOUR DAILY TASKS … WE HAVE A SOLUTION !
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
A view of the inspected area appears on the buit-in screen showing emissions as « fumes » so the inspector can visualize leaks in real time.
Films are recorded on a SD card for later processing or storage.
Our camera allows you to visualize VOC gases emissions using their physical caracteristics.
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
On site leak detection, recorded with our camera
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Reffineries
Petrochemical
Cogeneration
Chemical
Natural gaz
Inspection companies
Our markets
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
-Traditional leak detection using sniffers can be harmful to inspectors due to their proximity to potential gas emitions.- With snifers, leak detection is limited to one spot. Big equipments require a number of inspection spots in relation with their size thus increasing the inspection time and its cost.- Inspection is limited to inspector vecinity. Unreacheable equipments are inspected at extra cost
Traditional detection limitations
- Spot detection reading can be misleading because of meteorological conditions (wind).
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Advantages of thermal imaging for gas leak detection…
On the contrary, our camera allows you to avoid many of previously cited downsides, its avantages being…
- Quick work procedure :Many components are inspected simulteanously reducing inspection time, thus requiring much less personnal to inspect a given area
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
- Remote inspection - Avoid process interuption- Allow inspection of difficult to reach equipments
(chemineys top, events…) - Reduce inspector exposition to fumes
- Leak detection accuracy- Inspector can pinpoint the exact leak origin and record it for
the maintenance team.
- Designed for industrial use- IP 65 enclosure- Certified : ATEX Zone 2 / UL1604 and CSA Class 1 Div 2
Advantages of our camera…
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
In United States, the EPA (Environmental Protection Agency) makes mandatory the use « Methode 21 » for on site LDAR(Leaks Detection And Repair) programs. In this procedure the use of a thermal imaging camera is allowed as an « alternative work methode ».
European CONCAWE association also agreed the thermal imaging camera is an acceptable alternative to COV meters or snifers.
Regulation
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
ApplicationsSafety
Detection of explosive and toxic compounds
EnvironmentalGHG and regulatory compliance
MaintenanceLDARFugitive emission due to rust below heat insulationPlant start up
Reduction of lost revenuesLost material can not reach the market for sell
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Applications
Our camera can detect leaks « unreacheable » with traditional snifers. In this case, a compressor vent.
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
32 Detected gases
Ethylene, 1-Hexane, Propanal, 1,3-Butadiene, 1-Butene, Methane, Propylene, 1-pentene, StyreneVinyl Benzene, Toluene, Vinyl acetate Acetic acid, ethenyl eater, Xylene 1,2-dimethyl-Benzene, Isobutylene 2methyl-1propene, Isoprene, 2methyl-1,3-butadiene, Benzene, Ethyl benzene, Ethylene oxide, Hexane, Methanol, Propylene oxide, Propylene, Ethane, Octane, Heptane, Isopropyl alchohol, MEK Methyl Ethyl Ketone 2-butanone, Propane, Butane, Pentane
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
How it works
Gas
Plu
me
Bac
kgro
und
• The leaking gas temperature differs from the background temperature
• The EYE-C-GAS camera spectral band coincides with the emissivity (absorbance) spectra of the leaking gas
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Technical specificationsImage Performance
- Objectif de 30 mm (18 de champ)- Digital Zoom x2, x4
Display- 3,5'' color, LCD 640x480
Power input- 12 VDC- Power consumption 14,4 W
Battery life4 hours continuous
Dimensions- Weight 2,5 kg- Size 230 x 110 x 130 mm
Environmental Conditions- Operating from – 20 to + 50 C- Storage from – 40 a to 70 C- Water and dust : IP65, humidity 95%- ATEX Zone 2 / UL1604 and CSA Class 1 Div 2
Digital video oand audio recording- Digital recorder built in with
conection to PV via USB 2- Up to 6 hours of MPEG4/H.264
in a 4 Gigabyte SD card (built in)
Connectivity- bluetooth, USB 2
Supplied accessories- 3 battery sets- Tri battery charger,- Carrying case- Glare shield
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Statistics show that up to 84 % of leaks are located in an area equivalent to only 1 % of a site area.
In other words you’re using time of an highly qualified (expensive) personal to inspect in details 99% of your site area where you’ll seldom find leaks.
Our camera allows you to inspect large areas of your site in one shot so you can rapidly discard the area where no action is required. Thus a substantial time and money saving allowing a fast return on investment.
Fast R.O.I.
YOUR SATISFACTION FIRST…FG – 30/09/2011 – rev 8 - English
Thank you
Should you need further information, please do not hesitate to contact me .
François Guerrero+33-6-84-72-27-83