Fish Seed Transportation From Jessore To Gazipur(2kg)Introduction:

Generally the fry trading season starts in April and continues until the end of September in Bangladesh. Nevertheless, mortality is the major problem of our traditional transportation system of fish fry. In Bangladesh, fish seed production hatcheries are typically situated far away from fish rearing ponds. I went to Chachra in Jessore District to purchase 2kg fish seed. I bought 2kg fish seed from Chachra in Jessore. The distance of Jessore to Gazipur is approximately 242 km away. The price of fish seed is 2000 to 3000Tk in case of Indian major carp. I have bought 2kg fish seed from Jessore to Gazipur by pick up. Approximately 2kg fish seed contain 7to 8 lac fry.The traditional fish seed transportation methods result in heavy mortality due to accumulation of toxic wastes such as ammonia, decrease in pH due to increase of carbon dioxide, depletion of oxygen in the water, thermal tolerance hyperactivity, stress and tiredness of the fry and infection contracted during transportation.

General guidelines for fish seed transportation:

Transportation early in the morning is better (Cool Hour). The water used in transportation should be cool and clean. Number of fish seeds per transportation unit should be

maintained, over number may lead to death of fishes. Oxygen packing is the best method of transportation. Anesthetics can be used while transportation to minimize the

metabolic activities of the fish seeds. Thereby, excretion of the nitrogenous compounds can be avoided.

Care should be taken so that no direct sunlight falls in the packing bags during transportation.

The seed packing bags should be covered with the wet gunny bags. So that, temperature of the seed packing bags will be maintained low.

If the transporting distance is long, glucose powder can be added to the seed packing bags.

Physiological effects of handling and transport on fish:

Live-transport of fish seed and brooders entail handling often involving chasing with or without net, catching and transfer from the

1 | P a g e

nursery/farm ponds to the equilibration (conditioning) system and thence to the transport container. The stress of this pre-transport handling can itself be high, sometimes causing injury and immediate death; the stress of transport itself can be distinguished from the handling stress. The severity of the transport stress would depend on the duration of transport and the physico-chemical characteristics of the medium/ containers of transport. The physiological effects of handling including hyperactivity can be mentioned first. Depending on the severity of handling the effects can last over a day even. Hyperactivity or increased physical activity and handling and concomitant excitement cause immediate depletion of the labile energy store in muscle, namely glycogen, mostly through the anaerobic pathway leading to the production of excess lactic acid. The lactic acid causes ‘acidosis’ and consequent lowering of pH, which results in the liberation of CO2. The acidic pH and increased pCO2 in blood would cause reduced loading of oxygen in the blood (Bohr and Root effects), which would seriously impair the energy yielding mechanism of the fish and can cause collapse of the fish.

Causes of mortality in time of fish seed transportation:

Several factors, as those given below, may be responsible for mortality of fish in transport:

Depletion of dissolved oxygen in ambient water due to the respiration of fish and also due to oxidation of any organic matter (BOD load), including excreted waste of the fish, by micro-organisms.

Accumulation of free carbon dioxide (CO2), resulting from respiration, and ammonia (NH3) as excretory end product.

Sudden fluctuations in temperature. Hyperactivity and stress due to handling and ‘confined space’ -

these result in lactate accumulation and affect again lessening of blood oxygen capacity and also ‘fatigue collapse’

Ion-osmotic imbalance due to stress. Physical injury due to handling before transport and during

transport. Diseases.

2 | P a g e

Conditioning of fish seed before transportation:

Conditioning is a process in which Spawn, fry and older fish for long time transportation have to be prepared or conditioned. The fish seed and brood fish are kept starving usually in a cloth ‘hapa’ or other containers in a quiet corner of the fish pond or in relatively quiet water in a canal or river for a period of time before transferring them to the transport carrier.

Period of conditioning:

The period of conditioning depends on the size and health of the fish seed. Fry need 48 to 72 hours of conditioning.

Conditioning containers: Various types of conditioning containers are used,

Boxes made of wire meshes Bamboo or cane wicker work Barrels or boats with perforated bottoms Temporary enclosures made of netting or bamboo matting, Cloth ‘hapa’ etc

Importance of conditioning before transportation:

The advantages of conditioning fish thus are:

The fish become used to confined condition. The fish are less excited and thus restrained in expenditure of

energy. The fish recover from the handling effect of capture - increased

blood lactate level and decreased blood pH become normal - excited high metabolic rates (O2 consumption, CO2 production, N-excretion) become normal.

The fish recover from minor injury - mucus loss etc - Ion-osmotic balance upset by handling becomes normal.

Gut evacuation takes place and during the period of transport the medium is not further contaminated by faecal matter.

Since the fish are starved there is exhaustion of available glycogen and this considerably reduces the chance for

3 | P a g e

accumulation of high amount of lactic acid in blood during transport and consequent acidocis and collapse as explained earlier.

Methods of Packing and Transportation:

Transport carriers are of two types: (a) open system comprising open carriers, with or without artificial aeration/oxygenation/water circulation and (b) closed system having sealed air tight carriers with oxygen.

Transportation in polyethylene bags:

This is one of the most widespread method for egg, fry and fingerling transportation.

Sometimes plastic bags are used also for brood fish transportation. For eggs and newly hatched fry bags of 0.04 mm thickness, and for fingerling bags of 0.06–0.08 mm thickness are recommended.

For transportation of fish bigger than fingerling, plastic bags of 0.1–0.15 mm thickness are preferred.

The simplest way is to prepare plastic bags using a plastic hose. It should be purchased in different width and cut on required length.

To avoid sharp increasing of water temperature in plastic bags some ice (packed in small plastic bag, and placed in the transportation bag) can be used. For an average size plastic bag 200–500 ml of water should be freezed.

If embryo is less developed, splashing of water can cause some injuries with tearing down of cells from embryo. Later, resistance of egg shell is lower against mechanical impacts.

At 27–28°C water temperature about 10 g oxygen is necessary for 2–4 hours transportation of 100–200 thousand eggs. For a very long transportation (2–3 day) larvae should be packed soon after hatching.

Newly hatched fry can survive such a period without difficulties, consuming their own yolk. Quantity of oxygen necessary for 3 days transport of 5–10 000 fry is 10 g.

Numbers of feeding larvae transported in plastic bags by Bangladeshi fish culturist are: For long distance transportation (for 7–8 hours) 125 g feeding fry (about 50 000) are packed in

4 | P a g e

standard bag of 80–90 × 40–50 cm. For short transportation, loading is about 200 g (80–90 000). Loading of plastic bags for silver carp and catla is less, about 80%.

Open system:

The simplest transport carrier is the earthern vessel, such as the traditional “Hundi” used in Bengal in India. Open packing system for transport of fish seed is going out of fashion mainly because it involves continuous vigilance and frequent renewal of water during long journeys. Galvanised iron drums of 180 L capacity, and open canvas containers (1 m × 1 m × 1.25 m) have been used successfully in transporting breeders. The galvanized iron drums are provided with an opening of 48 cm × 30 cm along the main body of the container for introduction of fingerlings and larger fish. The drums is often lined inside with foam rubber to avoid injury to the buffetting fish during transport. Recently plastic pools (250 litres and other sizes) have also been used for transporting fish.

Advantage:

The earthern hundi is now being replaced by aluminium vessels which are unbreakable, but the earthern hundies have the advantage that they keep the temperature of the water inside cool by means of evaporative cooling.

Disadvantage:

It is very expensive The seed get heavily stressed It suffer mortality during transport or soon after stocking

Closed system:

5 | P a g e

In this system the water surface is exposed to compressed air or pure oxygen introduced to fill the zone over the water surface in the carriers which are sealed air-tight Sealed metal containers, rubber and plastic bags have been used for the purpose. In a metal container of galvanized iron (45 × 35 × 35 cm) with two airtight openings, one to let in oxygen and other to let out water, 100 – 200 fingerlings of 7 – 10 cm, or 30 – 40 fingerlings of 13 – 20cm length, can be transported for a journey of 12 hours. Eighteen litre tins with airtight screw-capped lids for filling and provided with tubes for drawing in oxygen and letting out water, have been used in CIFRI, Barrackpore, for transporting 1000 fry of 1 – 2 cm length during a 20-hour journey.

.

Fig.: 1 1. Procedure of closing the bottom end of a polyethylene sleeve

6 | P a g e

Figure: Procedure of filling the bag with water, stocking with the fish, displacing the air, introducing oxygen and closing the upper

end.

Figure: Sealed plastic containers

A. container volume 25 litres, the oxygen-inlet valve is built in the screw cap;

B. container volume 50–150 litres, vertical plastic p pe keeps water at the required level.

7 | P a g e

Figure: Small tank to be carried in a car. Container volume 100 – 150 litres; the aeration grate is adjusted to s fit the dimensions of the tank.

Figure: Specialized tank for transport

8 | P a g e

In any carrier system the factors which basically determine successful transport of fish are:

Total biomass of fish to be transported. The rate of utilization of oxygen. Initial oxygen content of water carried. The rate of entry of oxygen into the system. The rate of accumulation of harmful excretory wastes,

especially CO2 and NH3 and capacity of the system to remove

Oxygen Requirement:

Oxygen requirement of fish ranges from 100–1100 mg/kg/hours. Oxygen consumption is not a standard value. It depends largely on fish species, size of fish, physiological condition of individual and on several environmental factors.

In general, oxygen consumption

grows with the increase of water temperature, decreases with weight of fish, at majority of warm-water species decreases with decreasing

oxygen saturation of ambient water, increases sharply after food consumption, significantly higher at stressed fish, and depends on physiological status of fish

With the increase or decrease of 10°C water temperature oxygen consumption duplicates or decreases to 50 percent.

Use of Chemicals in Live Fish Transport: Drugs and chemicals are either used as tranquilizers and sedatives or as antiseptics and antibiotics. General listing of anesthetics for fish has been given by several workers Sedatives are generally used for:

Reducing metabolic rates, mainly oxygen consumption and excretion of carbon dioxide and ammonia.

Reducing excitability of fish and injury, and Convenience in handling fish.

Dosages of drugs used: Different drugs have been studied for use as anaesthetic for transport of fish. They are

Sodium amytal,

9 | P a g e

Chloral hydrate, Tertiary amyl alcohol Tricaine methane sulphonate (ms 222 sandox), Urethane, Hydroxy quinaldine, Amobarbital sodium Barbital sodium etc

Use of Chemicals in Live Fish Transport: Drugs and chemicals are either used as tranquilizers and sedatives or as antiseptics and antibiotics. General listing of anesthetics for fish has been given by several workers Sedatives are generally used for:

Reducing metabolic rates, mainly oxygen consumption and excretion of carbon dioxide and ammonia.

Reducing excitability of fish and injury, and Convenience in handling fish.

Problems Faced During Transportation:

Dissolve oxygen level in transporting water reduces and Carbon dioxide level increases.

Due to metabolic activity of fishes the concentration of ammonia, urea and uric acid etc increase in the water, hence fish gets stress.

If transportation is done in high density it may lead to mortality of fish due stress of oxygen.

If transportation is done in improper vessels, physical damage of fishes may occur.

Cost Benefit Analysis of this Transportation: In this transportation I prefer train for transportation. Because,

train fare is low than other transportation system. Such as- Bus or Airplane. Main intention of this transportation to make profit. For short distance I used local transportation system. The price of per kg seed is approximately 2000/3000 taka. If I can able to grow them up to fingerling stage, then I can sale them at 2/3 taka per pcs. That is profitable for me. To make pond for growing the seed some cost is needed. After selling the fish fingerling, I would like to make profit. For this reason every calculation behind this transportation should appropriate.

Cost in Table:

10 | P a g e

Costing Purpose Amount of Cost (Taka)

Going to Jessor 1000Labour Cost 300

Seed price(2kg) 4000Processing of seed to transport 200

O2 Cost 200Lunch 200

Transportation(Back to Gazipur) 1000Transportation of short distance 200

Preparation of Pond 3000Rearing of fish seed 1000

Feed cost 500

Main thing of making profit is to sate the fingerling into

market. Price of finger ling is 2/3taka per pcs. From 2 kg fish seed we can able to produce fingerling about 3 lakh fingerling. Then we can sale it at 600000 taka( 2taka per pcs). And I can able to make profit totally.

Conclusion:

Fish seed needs intensive care for transportation. Any types of mishandling may lead to the loss. So, we need to stay very attentive at the time of transportation. A fish farmer must be very familiar with the principles technique and practice of fish transportation. The aim of transportation is to provide healthy live fish at the destination. Almost any clean and water proof container is be used. Doing of all works successfully help us to make profit in future.

11 | P a g e

Reference:

1. McFarland, W.N. 1960. The use of anaesthetics for the handling and the transport of fishes. Calif

2. Bell, G. R. 1964. A guide to the properties, characteristics and uses of some general anaesthetics for fish. Fisheries Res. Board of Can. Bull.

3. Berka, R. 1986. The transport live fish. A review. EIFAC Tech..4. Durve, V. S. 1975. Anaesthetics in the transport of fisht seed.

Aquaculture 5. Durve, V. S., A. K. Dharma Raja., 1974. Effects of anaesthetic

on the behaviour of mullet fingerlings and the scope of using these in different fishery procedures - I.J.Mar. Biol. Assoc.

12 | P a g e