The following cataloghas gaps in its pagenumbers, or doesn’thave any numbers.We have chosen to

leave the pagenumbering in theorder that Acrobat

assigns it.

PARTS CATALQG

INSTRUCTIONS FOR ORDERINGREPAIR PARTS

QNAN PARTS

All parts ii? this list are Onan parts, For Onarr parts orservice, contact the dealer from whom you purchasedt his equipment or your nearest authorized service sta-tion. To avoid errors or delay in filling your order,please refer to the Onan nameplate and give the com-plete MODEL, SPECIFICATION and SERIAL NUMFER.

WAUKESHA PARTS

All M’aukesha parts must be ordered from the Waukesha

Motor Company of Waukesha, Wisconsin, or their nearestauthorized distributor. When ordering parts, refer to theWaukesha nameplate and give the complete MODEL,

SIZE and SERIAL NUMBER.

RolLtiE

SERIAL [ j DATEI Is=cl II

WAUKESHA MOTOR COMPANY WAUK ESHA, WISCONSIN I

This catalog applies to the standard WE plants .:s listed below. Powered by a Waukesha engine (see Waukesha

Manual). Engine parts modified or added by Onan will be in this list and have Onan part numbers. These super-sede similar parts Ixsted in the Waukesha manual. Onan parts are arranged in groups or related items and are

identified by a reference. All parts illustrations are typical. Using the Model and Spec No. from the Onan plantnameplate, select parts from this catalog that apply to your plant. Unless otherwise mentioned, parts are inter-changeable. Right and left plant sides are determined by facing the front end of the engine.

PLANT DATA TABLE

ELECTRICAL DATAMODEL AND SPEC NO. I!

WATTS “ HERTZ I PHASE WIRE

I 15.OWE-515R/ I I 5,000 50 3 12

I 5t3,0wE-9xR/ I 50,000 60 3 4

150.OWE- 15R/ I 50,000 60 3 12

L - The specification Letter advances (A to B, B to C, etc. ) with manufacturing changes.

* - Maximum rating is shown. Continuous rating also appears on nameplate.

NOTE: Hertz is a unit of frequency equal to on? cycle per seccnd.

REPLACEMENT ENGINE

IOOPIO07 I Engine. Replacement (Waukesha - Gasoline Carburetor, Model H-884)

General Description:

Includes - Complete Cylinder Block, Carburetor, Fuel Pump, 0:1 Filter, Oil Cooier,

Distributor, High Tension Leads, Coil, Spark Plugs, Governor, Fan Blades and Belt,

Flywheel and Flywheel Housing, Water Pump, Oil Pan, Exhaust Manifold and Intake

Manifold.

Excludes - Alternator, Voltage Regulator, Oil Pres sure and Water Temperature Gauges,

Ammeter, Air Cleaner, Radiator, Alternator Belt, Alternator Mounting Bracket and

Alternator Adjust in g Bracket,

WATER JiicKET biEh4TE~ 6ROUP - OPTIO INAL

?’r~u———’

REF. PARTNO. NO.

I 309PI062 333A123 333A134 333P535 503-1836 332A6727

8 I 30A755

QTY.USED

IIII42I

I

PARTDESCRIPTION

ThermostatBc x, ThermostatCover, Thermostat BoxHeater, Tank Type - I 10 VoltClamp, HoseStud, Thermostat Box Mtg.Hose (Order 6 feet of Bulk

Hose #503 P386)Bracket, Heater Support

COOLING SYSTEM GROUP

rl4

r’

REF. PARTNO. NO.

130C836; 130 B4493 504-284 130C8425 130A8486 503 P6257 503P3S48 503 P6169 130 B843

10 130D846II 130D84012

13 5030626

QTY .USED

IIII2I6

;III

I

PART

RadiatorCap, RadiatorValve, Radiator DrainShroud, RadiatorBrace, Radiator SupportHose, Rar!iatorClamp, HoseHose, Radiator - UpperBracket, Radiator SupportShroud. FmGuard, FanHose. Radiator (Order

3 “of Bulk i-lose #S03P5Tube. Hose Connector

I 2)

25

MI SCELLANEO{JS EN~lNE PARTS GROUP

Po

‘12

25

(5$o

14 ,3

e

i6

— .—

1

1

29

~27

en___.21

R!. F. PART QTY, PART IREF. PART?@. NO, USED DESCRIPTION NO. NO.

—— ——

QTY.USED

PARTDESCRIPTION

l$3Al G@ I Sender, CIII Pressure Gwge193 A!09 I Sender, Water Temperature

Gauge309A178 I Switch, High Water ‘I *IP.309A 169 I Switch, Low Oil P e505- I 17 I Bushing, Reducer ( I x 3 ‘8 “iNIPPLE. OIL SENDER & SWITCH505-98 1 I“8X3’4”505-!04 I l’8xl-l/2°505-59 2 Tee, Ott Sender & Switch (1/8 “)505-57 I Plug, Pipe (1/8) - Oil Sender

& SwitchCABLE, BATTERY4}6A444 I Positive416A445 I Negative416A446 I Cable, Battery Jumper15SP658 I Flange, Muffler Mounting3 12A58 i Condenser, Ignition Coil314-156 8 Suppressor, Spark Plug.314P6 I Suppressor, Coil155P675 I Gasket, Muffler Mounting800-160 8 Screw (3/4-10 x 3-1/4”) -

Muffler Flange Mounting

17 Nut, Hex (3/4) - MufflerFlange Mounting

Cleaner, Air (Includes Element)Element, Air ClemerClamp, Alr Cleaner MountingCap, Air CleanerBracket. Air Cleaner Piounti~$Hose, Air Cleaner (Order 43 of

bulk hose #s03P620)Clanp, Air Cleaner HoseSwitch, Low Engine Temperate

- OptionalVent. Gas RegulatorPlug, Pipe (1/8) - Carburetor -

Gas-Gasoline SetsValve, Solenoid - LPG SetsRegulator, Gas- Natural Gas SetsElbow (1-1/4) - Natural Gas SetsNipple (1-1/4 x 3“) - Natural

Gas SetsMsnifold, Oil Sender

862-8 82

181920212223

14081131140 PI156140AI 130140A I 132140A I 125

II1III

3456

78

2425

503 P622309P269

2I

9 2627

I 48- I 07SOS-57

II

10II1213141516

28293031

307 PI041148-59650S-42S0S-2S8

III2

32 193 B209 I

ALTERNATOR ANQ STARTER MOTOR GROUP

REF.NO.

PART QTY. PARTNO, USED DESCRIPTION

*AI ternatur, Charge - IncludesRegulator & Fan (Motorola#70 D44039B)

Rr?gul ator, AlternatorPulley, AlternatorGuard, Alternator 13e!tScrew (1/2-13 x 2-1/4) -

Alternator MountingWasher, Lock (1/2) -

Alternator MountingNut, Hex (1/2) - Alternator

Mount ingCondenser, Alternator -

0, I Mfd.Belt, Alternator DriveBracket, Alternator Mtg,Bracket, Alternator Adj.

*Motor, Starting (DelcoRemy #l I 13376)

Stud ( I/2 x 3/8) - StarterMounting

Washer, Lock - Starter Mtg.Nut, Hex (3/8) - Starter Mtg.

191 B66S II

2345

6

7

8

910II12

13

14Is

*.

*-

191 P732191 B649191 B72S800-95

IiII

850-60 I

862-16 I

312AS8 I

511P%191 B690I 91 B868I 91 PS68

IIII

520A69 I 3

850-50862-3

33

For components, contact your nearest Delco Remy Dealeror Delco Remy Division of General Motors Corporation,%derson, Indiana 4601 I .

For components, contact your nearest Motorola Dealer orMotorola” Automotive Products, inc., 9401 W. Grand Ave.,Franklin Park, llllnols 60131.

27

ANTI D1ESELINC3 CONTIRC)L AND CHOKE G3ROUP

+

0

00!25

1

2’5

?6 27

!2I 3

I -\I

I ‘ ‘l#39*

o %.3*i 10

4,140

\

28

REr-. PART QTY. PART’NO. NO, USED L)ASCRIPTION

.— —

I

2

345

6

7

8

9

10

II

12

13

14

Is

i6

17

18

19

20

STUD, ADJUSTING150A96 I Gasoline Sets150A213 I Gas- Gasollne & LPG-

Gasel tne SetsSPRING, Tti ROT’rLE145A 158 I Gasollne Sets:45AI19 [ Gas- Gaso\ ine & LPG.

Gasoline Sets145 A414 I L,nk, Throttle Spring

150A302 I Spacer, Llrrkage

BRACKET, SOLENOID MOUNTING145A369 Gasollne Sets145A383 I Gas-Gas ollne & !_PG-

Gasoline 5ets

LINK, 50 LENOID145A437 I Gasoline Sets145A423 ! Ga~=G=~~ line & LPG.

Gasoline Sets307 BI093 I Solenoid & Lead Assembly

BRACKET, THROTTLE145A37014SA3&32

153P213

153 A49

153 B413

153B412

803-2

I 53 A287

148A317

I S3 A288

I S3A282

153A41 I

518-47

153 A283

II

I

I

I

I

I

I

I

I

I

I

I

I

Gasoline SetsGas-Gasoline & LPG-

Gasoline SetsChoke, Auto. (Sisson) -

Gas-Gasoline & LPGGasoline Sets

Cover Assembly, Choke -Gas-Gasoline & LPG-Gasoline Sets

Bracket, Choke Mounting -Gas-Gasoline & LPG-Gasoline Sets

Adapter, Choke - Gas-

Gasoline & LPG-GasolineSets

Screw, Set (8-32 x 3/ 16”) -Counter-Weight - Gas-Gasoline & LPG-Gaso!ineSets

Shaft, Choke - Gas-Gas olirie& LPG-Gasol ine Sets

Counterweight, Choke Shaft -Gas-Gasoline & LPGGasolineSets

Plate, Choke - Gas-Gasoline& LPGGasoline Sets

Arm, ChGke - Gas-Gasol ine& LPG-Gasoline Sets

Rod, Choke - Gas-Gasoline& LPG-Gasol ine Sets

Clip, Rod End (Adapter End). Gas. Gaso!ine & LPG-

Gasoline SetsArm, Choke C)ver-Ri de - Gas-

Gasoline & LPCi GasolineSets

REF. PARTNO. NO.

——

21

22

23

24

25

26

27

28

29

3031

32

3334

35

36

37

383940

41

42

43

44

518-5

508-7

812-59

853-3

870-S3

813-100

232A979

800-6

862- I

860-8812-79

813-111

870-53815-178

86 I -8

153A304

800-3

860- I 3850-40308-68

308A 150

503-520

503P518

338A612

QTY. PART

USED DESCRIPTION

I

2

2

2

2

I

I

I

I

44

I

2I

I

I

2

22I

I

I

2

I

Clip, Rod End (Choke End] -Gas-Gasollne & LPG-Gasoline Sets

Washer, Choke Shaft Seal -Gas-Gas ollne & LPG-Gasoline Sets

Screw, Choke Plate Mount m g- Gas-Gasoline & LPG-Gasoline Sets

Washer, Choke plate Mounttng- Gas-Gasoline & LPG-Gaaoline Sets

Nut. Hex (10-32) - AdjustingStud

Screw ( IO-32 x 1/2) - ChokeLock - Gas-Gas oiine &LPG-Gasoiine Sets

Spring, Choke Lock - Gas-Gasoline & LPG-GasolineSets

Screw ( 1/4-20 x 7/13 “} ThrottleSpring Link

Nut, Hex ( 1,{4-20) - Thrott ieSpring Link

Nut, i-i-ax - Solenoid MountingScrew, Solenoid Mounting -

(8-32 X 1/2 “)Screw, Choke Plate Stop -

(10-32 X 2-1/4”)Nut, Hex (10-32)Screw ( IO-32 x 5/8) - Choke

Arm Mounting

Nut, Hex (10-32) - ChokeArm Mounting

Bracket, Choke Lock - Gas-Gasoline & LPGGasoiineSets

Screw (1/4-20 x 1/2”) -Bracket Mounting

Nut, Hex (1/4-20)Washer, Lock ( I /4)Switch, Toggle - Gas-Gasoline

& LPGGasoline SetsPlate, Switch Mounting - Gas-

Gasoline & LPG-GasolineSets

Hose, Adapter - Gas-Gasoline& LPGGasoline Sets

Clamp, Hose - Gas-Gasoline& LPG-Gasoline Sets

Harness, Wiring - Choke -Gas-Gaso line & LPG-Gasoline Sets

29

30

13\

.

REF.NO.

;3

4

5

6789

10II12

131415

PARTNO,

403D970405C 187940581856

405 D1858

405C 1876

405 f31$37440501890405CI 880406A157406P89405 D1883

QTY.USED

I

2I

2

4

6IIIII

PARTDESCRIPTION

Base, SkidPanel, Base (Housed Sets)Pmel, Lower Rear Housing

(Housed Sets)Panel, Rear Lower (Housed

Sets)Panel, Door - Side (Housed

Sets)Panel, Louver (Housed Sets)Panel, Top (Housed Sets)Panel, Rear Door (Housed Sets)Handle, Door (Housed Sets)Catch, Door (Housed Sets)Panel, Rear (Housed Sets)

BRACKET, PANEL MOUNTING40581854 2 Unhoused Sets40561854 8 Housed Sets405 D1884 i Panel, Front403 C969 I Support, Engine Mount301 C3154 I Saddle, Control Box Housing

i

,,

REF. PART QTY.NO. NO. USED——

1617

18

19

20

21

22

2324

25

26

30103155 I30183156 2

301 B3157 I

405 C1873 2

337P90 I

508P i I

MOUNT, VIBRATION402A37 I 2402A384 2405 A1872 16818-150 16

405 B 1888 2

405 B1887 2

31

PARTDESCRIPTION

Housing, Control BoxPanel, Control Box Housing

(Side)Panel, Control Box Housing

( Top)Support, Center Housing

(Housed Sets)Strap, Ground

Grommet, Rubber - Contro IBox Housing

Engine EndGenerator EndClip, Door (Housed Sets)Rivet, Door Clip Mounting

(Housed Sets)Bracket, Radiator and

Shroud Support (Upper)Bracket, Radiator and

Shroud Support (Lower)

CONTROL ~ROUP (AC OUTPUT PORTION) 18

2 I o 0 II 1. I I

5

0

0

e

I ●

1

24

‘1 61 27

10 I 20

32

PART Q-i-f. PARTREF.No.

I

2

3

4!567s9

10II12

j3

14

Is

16

1?i8

NO USED DESCRIPTION

301 D3158 I Box Only, CorIm OlPANEL ONLY. CONTROL?OIC3342301 C3170

402A78

337A49320B43 I332 A124231513342303P32303-763080284303P 170350-556

VOLTMETER302 B779302f3718

307 BI061

322A I 30

322A131

301 B324433201268

II

4

IIIIIIIII

II

I

I

I

II

“150. OWE-9XR Sets115. OWE-515R and

i50.oWE-i5fl SetsRubber, Mounting - Control

Bo XStrap, GroundBreaker, CircuitStrip, MarkerTransformer, VoltageKnob, RheostatKnob, Selector SwitchSwitch, SelectorRheostatResistor, 47,000-Ohm, YzWatt

{ I 15. OWE-515R ana 150.0 WE-I?3R Sets) - Part of WiringHarness

I 50. OWE-9XR Sets1 I5,0WE-515R and 150,0WE-

15R SetsRelay, Voltage Selector -

I I 5. OWE-515R and150,0WE-I !5R Sets

Light, Lower Scale -I 15. OWE-51SR andISO.OWE- 15R Sets

Light, Upper Scale -I 15. OWE-515R and150,0WE-I 5R Sets

Bracket, Relay MountingBoard A SSY., Printed Circuit

(See Separate Group forComponents)

REF. PART QTY. PART

NO. NO, USED DESCRIPTION—— —

i9

202122232425

26

27

28

29

30

31

32

33

34

35

HARNESS, WIRING - AC CONTROL338057 I I 150. OWE-9XR Sets

338D525 I I 15.owE-515R a’rd 150.0 WE-15R Sets

332-50 2 Clip, Tinnerman406-332 2 Fastener

406-333 2 Stud, Fastener

406-334 2 Washer, Stud Fastener

508P I 4 GrommetMETER, RUNNING TIME302P469 I 50 Hertz Sets302P466 I 60 Hertz SetsMETER, FREQUENCY302B256 I 50 Hertz Sets302022 I I 60 Hertz SetsAMMETER, AC30264 I i I I 50,0 WE-9XR Sets

3026723 I I I 5. OWE-51 5R Sets

302B724 I 150,0WE- 15R SetsTRANSFORMER, CURRENT302BI06 3 I 50. OWE-9XR Sets

302B547 3 I IS. OWE-515R Sets302647 I 3 150,0 WE- 15R SetsBRACKET. TRANSFORMER MOUNTING3026729 ‘ I 150,0 WE-9XR Sets3026764

302A235

302A236

302-253

332A795

323A764

332AI 280

I I 15.OWE-515R and 150.0WE-15R Sets

3 Clamp, Transformer Mtg. -Upper - I 50. OWE-9XR Sets

3 Cl amp, Transformer Mtg. -Lower - i 50. OWE-9XR Sets

3 Shim, Transformer Mounting- I 50. OWE-9XR Sets

I Block, Terminal (Part ofWiring Harness)

I Socket, Relay (Part of WiringHarness) - I 15,0WE-515Rand 150,0 WE- 15R Sets

As Req. Terminal, Crimp

CONTROL f3ROUP (ENC31NE INSTRUMENTS PORTION)

o0c)

6’13

mm’=0

*

17

28

f

REF. PART QTY. PARTNO. No. USED DESCRIPTION

——.. -..

QTY.USED

I

PARTDESCRIPTION

REF. PARTNO.

18

19202122

2324

2526

27282930313233343536

NO.

338D528

332A537332A795323A765332 B1271

332-51338C61 I

307 BI031357A4

320P 165332Bl 382870P 196508-15809-35332AI 269332 A1280332 CI043307 BI061323 A764

301 D3165 I301 K)3253 I308P 138 I308-2 I193 BI07 I193 BI06 I302A6 I I

332 A1239 I

Panel Only, Engrne CcnrrolBracket, Engine ControlSwitch. SelectorSwitch, Panel LightGauge, Oil PressureGauge, Water TemperatureAmmeter, Charge (30-0-30)

Strip, Marker (B+, Remote,Grid. Aim)

Strip, Marker (21 through 36)Plate, Switch (On-Off)Plug, KeyingRelay ( I ) Start Disconnect

(1) IgnitionHolder, LampLamp, PanelLamp, Fault

Harness Assembly, Wiring -Control (Includes PartsMarked *)

*Block, Terminal - 4 Place*Block, Terminal - 16 Place●Socket, Relay - I I Place*Hcusing, Printed Circuit

Board TerminalClip, TinnermanHarness Assembly, Wiring -

Engine to ControlRelay, Starter PilotRectifier, Diode (Part of

~34

567

8

II22

II9

10II12

332 A1241 I308 A3 I332-1276 2307 BI058 2

II

Standard Cranker Control)I Breaker, CircuitI Bracket, Terminal MountingI Nut. InsulatorI Washer, FiberI Screw, Metal (#8 x 3/4)

As Req. *Terminal, PC BoardAs Req. *Terminal, Crimp

I *Jumper, TerminalI Relay, Starter ProtectionI *Socket, Relay -8 Place

1314Is16

322P73 I322P74 I322A I 28 ICONTROL, CRANKER300A733 I300C714 I

Standard CrankerCycle Cranker (Optional)

See Separate Group forComponents.

Monitor, Engine Control -See Separate Group forComponents.

17 300C6 I

* . Included in #338 D528 wiring Harness Assembly.

ENGINE CONTROL MONITOR ~ROUP

10 13 38

1

QTY.USED

PARTDESCRIPTION

Monitor Assembly Complete- Engine Control

RelayResistor ( 10,000-Ohm)Capacitor (22 Mfd. )Capacitor (10 Mfd. )Capacitor ( i Mfd. )Di ode, ZenerRectifier, DiodeRectifier, Gate ControlTran sisterTran sister, Fld. EffectTransistor, SiliconResistor ( 1,000-Ohm)Resistor ( lSO-Ohm)Resistor (22,000-Ohm)PotentiometerResistor (2.2 Megohm)Resistor (2.7-Ohm)Resistor (27-Ohm)Resistor (10 Megohm)Resistor (270-Ohm)Resistor (2,200-Ohm)Resistor (220-Ohm)

REF.NO.

PARTNO.

300C679I I

23456789

10II121314151617181920212223

307 AI039350P548355P5356A40356A30359A27357A4364A I I361A3362A25362A8350-536350-526350-552303A169350-576350-505350-5 I 7350-584350-529350-540350- I 128

II2III5I

2422I~

2IIII32I

20- .~ 4 196- ~~11- r ~ -“ ~21

21-4 21

72216- 4 22

T

12” 0 412

CONTROL, CYCLE CRANKER GROUP - OPTIONAL

A==Q J-4

16. 711-

4.6

14 4,

13 . .* 1- 512 . ‘u18 .

REF. PARTNO. NO,

- 30Z4

2 356A39

3 359A274 357A45 362A86 362-177 362A268 362AI 99 3(23A171

10 350-560II 350P54812 350-55813 350-42014 350-54615 350-52616 350-50017 352A152

18 355PI0

QTY.USED

I

I

I32III2I2IIIIII

I

PARTDESCRIPTION

Control, Cycle Cranker -Complete

Caoacitor, Electrolytic( 100 blfd. )

Diode, Zener (7.5 Volts)Rectifier, DiodeTransistor, SignalTransistorTransistor, SignalTransistor, PowerPotentiometer ( 100,000-Ohm)Resistor, Fixed (0.1 Megohm)Resistor, Fixed (10,000-Ohm)Resistor, Fixed (68,000-Ohm)Resistor, Fixed (24,000-Ohm)Resistor, Fixed (6,800-Ohm)Resistor, Fixed ( 150-Ohm)Resistor, Fixed (1. O-Ohm)Resistor, Fixed (5 Watt,

25-Ohm)Capacitor, Dielectric

(,0022 Mfd., 100 Volt)

44

?

4-5-6

PRINTED CIRCUIT BOARD ASSEMBLY GROUP (AC)

REF,NO.

I

234

5689

10II121314Is1617181920

:;232425

26

PARTNO.

33201268

332 B1252332B833812-81

853-5860-8355P 18355P5355P17355P6355P16355P15355P14357B14359A16359A25359A26307C I 063362-17361B4350-355350-351350=1075353 P40

353 P39

QTY.USED

I

I52

22I22i

2II8IIII2

;2II

I

PARTDESCRIPTION

Board Assembly, PrintedCircuit- Complete

Block, Terminal (I2 Place)Terminal, StandoffScrew, Round Head Machine

(#8-32 X 5/8)Washer, External Lock (#8)Nut, Hex (#8-32)Capacitor (.47 Mfd., 100 Volt)Capacitor (.22 Mfd., 200 Volt)Capacitor (,47 Mfd., 400 Volt)Capacitor (.47 Mfd., 200 Volt)Capacitor ( I Mfd., 100 Volt)Capacitor (, I Mfd., 200 Volt)Capacitor (,047 Mfd., 200 Volt)Rectifier, SiliconDiode, ZenerDiode, ZenerDiode, ZenerRelay, Magnetic ReedTransistor, Silicon NPN

Transistor, UnijunctionResistor ( 1/2 Watt, 47.Ohm)Resistor ( l/2 Watt, 33.Ohm)Resistor (2 Watt, 4.7 Megohm)Resistor, Fixed (10 Watt,

270-Ohm)Resistor, Fixed ( 15 Watt,

5,000-Ohm)

REF. PARTNO,

27282930

3132333435

3637

38

39

4041424344454647

37

NO.

350-398350-447350-4233S2P151

350-1014350- I007350-443350-435351 P521

303A I 6835 I P520

351 P522

351 P523

355P20350-101 I303A 164350-167359A15356A393S5P6350.435

QTY. PARTUSED DESCRIPTION.—

I Resistor (1/2 Watt, 3,000-Ohm)2 Resistor ( I/2 Watt, 330,000-Ohm)2 Resistor ( l/2 Watt, 33,000-Ohm)I Resistor, Fixed (5 Watt, lS,OOO-

Ohm)i Resistor (2 Watt, 13,000-Ohm)I Resistor (2 Watt, 6,800-Ohm)I Resistor ( 1/2 Watt, 220,000-Ohm)I Resistor ( 1/2 Watt, 100,0O&Ohm)I Resisto~ Metal Film (1/4 Watt,

12,100-Ohm)I Potentiometer2 Resistor, Metal Film ( l/4 Watt,

28,000-Ohm)I Resistor, Metal Film ( i/4 Watt,

5, I 10-Ohm)[ Resistor, Metal Film (1/4 Watt,

8,870-Ohm)I Capacitor (, 1Mfd., 400 Volt)I Resistor (2 Watt, 10,000-Ohm)I PotentiometerI Resistor ( 1/2 Watt, 2.2 Megohm)I Diode, ZenerI Capacitor (100 Mfd., 10 Volt)I Capacitor (.47 Mfd., 200 Volt)I Resistor ( I /2 Watt, 100,000-Ohm)

23

12“

F6

13 ~

1’7I/

‘! 1

@ENERATOR @ROUP“32 I

QTY. PARTREF. PART QTY, PART REF.NO,

23

PARTNO,

305D49 I

NO, NO, USED DESCRIPTION—— USED DESCRIPTION

I Chassis Assembly, Vo ItageRegulatm - Includes PartsMarked A

AChassis, Voltage RegulatorARectifier, .Silicon (Avalanche)

- NegativeARectifier, Gate Control - Neg.kRectifier, Siliccm (Avalanche)

- NegativeAHeat Sink, RectifierAJumper, Terminal BoardkGrommet, Reactor LeadsABlock, TerminalkContact Assembly, C)verspeed

SwitchkNut, Insulator - Overspeed

SwitchANut, Hex ( 1/4-20) - Overspeed

SwitchkWasher, Lock - Overspeed

SwitchkReactor AssemblyAlnsulator, Heat Sink Mounting

Harness Assembly, VoltageRegulator

I

23456

7

89

10II12

1314Is16171819

202122

* I Rotor Assembly, Wound -Includes Collector Ring

20SC9S I Blower510BIOI I Bearing

* I Stator Assembly, Wound515A145 Key, Exciter RotorRECTIFIER, Dl~DE (PART OF EXCITER ROTOR)358C15 3 Negative358C16 3 Pos itiveBOLT, PLACE

2425

305D482358B29

II

364B14359035

22

2627

363 B53332CI043508A2332A1266I SOA723

32829303132

22

805-33805-32ISOA71721 IE185234B368232 C2208201 D1739

232C2037234 B370234B36 I509P 125526A238800A513220D 1528

232 A2102520A735305A48 I

88III2I

Drive Disc to HubDrive Disc to EngineSwitch Assembly, OverspeedBell, EndScreen, GeneratorBracket, Generator MountingRotor Assembly, Wound -

ExciterDisc, Generator DriveGrille, Generator Air inletWrapper, Generator End BellSeal. ““O”” Ring - BearingWasher, Bearing RetainerScrew, Bearing RetainerStator Assembly, Wound -

ExciterSpacer, BearingStud, End BellSpacer, Voltage Regulator

Chassis Mounting

II

33 870A250 I

34 862- I 2IIIIIII

35 853-13 I

363738

315D343332P 1265338B521

I6I

* Refer to factory giving complete Model, Spec and SerialNumber from the Onan nameplate.

A Included in the Chassis Assembly.

i42

38

\\

\‘\

NOTE: Remove Screw Furnished With Clamp, Item 2,and Substitute Screw, Item 3.

REF.NO.

I23456789

PARTNO,

155 PI170140-638812-162155A I 172526-172155 AI 171800-30850-45862-2

QTY.USED

244282888

PARTDESCRIPTION

Silencer. MobilClanp, Air CleanerScrew ( 1/4-20 ~ 3 “)Shield, Muffler HeatWasher, FlatTube Assembly, ExhaustScrew (5/16-18 x 1-114”)Washer, Lock (5/ 16”)Nut, Hex (5/16- 18)

EXHAUST MUFFLER INSTALLATION

39

-

o“23

8I

b10$=,.=+/I

t

(.-

Oib29 0 31

A

617

OAY TANK - FUEL PUMP INSTALLATION

GASOLINE SETS

REF. PARTNO, NO.

I23456789

10II12131415

1617

1819202122232425262728293031

1598668502-54159 B87 I

800-5850-40862-1307P268502-39.501 A179502-379I 59 A9!3Bf350-55800-69159A987

850-50

800-48149 B1297

501 A185850-79800-15 I503-189159 B989505-57159A705149/682149 A1293502-183!502- 143800-4862- I850-40

QTY.USED

12I222IIII1JIII

II

IIIII2IIIII222

PARTDESCRIPTION

Tank, ReservoirEl bow, StreetClamp, Day TankScrew (i/4-20 x 3/4”)Washer, Lock ( I /4)Nut, Hex ( l/4-20)Valve, Solenoid - 12 Volt DCElbow, MaleLine, Fuel (Flexible)Nipple, HexBrace, Day TankWasher, Lock (7/16”)Screw (7/ 16-14 x 3/4 “)Brace, Day TankWasher, Lock (3/8 “)

Screw (3/8- 16 x 3./4”)Pump Assy., Fwel (]2Volt)

(Includes Parts Marked *)Line, Fuel (Flexible)Washer, Lock (3/4)Screw (3/4- 10 x I “)Clamp, HoseBracket, Day TankPlug, PipeBushing, Restricted

●Pump, Fuel (12 Voit)● Bracket, Fuel Pump●Elbow, MalegAdapter, ReducerOScrew (1/4-2(3 x S/8”)*Nut, Hex (1/4-20)* Washer, Lock ( l/4)

40

—.

f- m“

t)3

I LOWER ENG\NE

FUEL PUMP MI+WTALLATION

t3AS-(3ASOLiNE SETS

\M

-f@-

REF. PAF!TNO. NO.——

I 17961297

2 501A1853 502-1564 4 I6A%!5 149A6826 149A12937 502-183a 502-1439 800-4

10 862-1II 850-40

QTY.USED

I

III

PARTDESCI?IPTION

PurnP Assy., Fuel (12 Volt)(Includes Parts Marked *)

Line, Fuel (Flexible)El bow, Street (450,C I atnD

f ●Pump, Fuel (i2Volt)i * Bracket, Fue I PumpI *Elbow, MaleI ●Adapter, Reducer2 *Screw (1/4-20 x 5/8”)2 *Nut, tit?x ( 1/4-20)2 ●Washer, Lock ( 1/4)

41

—

179-419 ‘—.

.-— —I

I

t

NOTE: Tie [tern 12 to Item II,

I23456789

10

II12

505- I68505-175S55-270505- I 77II OAI 168505-104812-162850-40862- I307A849

504-5 !504-52

HEAT EXCHANGER INSTALLATION

REF. PARTNO. NO,——

QTY,USED

IIIII222

PARTDESCRIPTION

Nipple, Pipe (2 x 2-1/2”)Elbow, Pipe(2 x 90°)Bushing, Reducer (2 x 1- I /4)Nifple, Pipe (l-1/4 x 1-5/8”)Bracket & Nipple AssemblyNipple - Spacer (l/8 x l-1/2”)Screw ( l/4-20 x 3”)Washer, Lock ( 1/4)

2. Nut, Hex (1/4-20)I Valve, Solenoid

I Valve, GlobeI Key, Valve

42

--——-J P’

‘/,

L---- .—~II I ‘9

II ,--% II

v..—..r L,

w., R--&J4L___.A ‘“mr--l{

!1

~-”1

. . L!)

G.d,---- -------L

REF.NO.

I2345

NOTE: Remove Thermostat From Engine. 6789

10II

1213

PARTNO.

S05-168505-175505-270505- I 77II OAI 168505- I 04812-162850-40862- I307 A849309P 243

505- I 29416-96

QTY.USED

IIIII2222II

HEAT EXCHANGER WITH MARSH RE@ULATOR INSTALLATION

PARTDESCRIPTION

Nipple, Pipe(2 x 2-1/2”)Elbow, Pipe (2 x 90°)Bushing, Reducer (2 x 1-1/4)Nipple. Pipe (1-1/4 x l-5/8”)Bracket & Nipple AssemblyNipple- Spacer (l/8 x 1-1/2”)Screw (1/4-20 x 3 “)Washer, Lock (1/4)Nut, Hex (1/4-20]Valve, SolenoidValve. Water Temperature

ControlBushing, Reducer ( I x 3/4)Clamp, Battery Cable

43

1?9-416 \

‘.,,

@,/‘

STANDPIPE COOLING INSTALLATION

REF. PARTNo. No.——

i 130C4252 504P623 505-2974 505- I 02

505-132: 505A3247 503P I 898

9 307A$3510 504-46II II OA810f2 BOO-713 850-4014 862-iIS I 308857[6 504-617 130B44218 800-9219 850-60

QTY.USED

II

;222I

III222IIIa8

PART REF. PARTDESCRIPTION NO. NO.——

Stan dpipe 20 862-5Va Ive, Vacuum Re Iief 21 130A873Bushing, Reducer ( 1-I/4 x 3/4) 22 505-418Nipple, Close (3/4) 23 130A871Elbow, PIPe (3/4 X 90”) 24 800-5 INtpple, Half (3/4 x 2“) 25 850-50Clamp, Hose 26 862-3Hose, Heater (Order 36 “of 27 505-749

Bulk Hose #503-249) 28 505-374Valve, Solenoid 29 505- [73Valve, Globe 30 505-35!3Bracket & Nipple fissembly 31Screw ( 1/4-20 x I )Washer, Lock ( 1/4) 32 503P354Nut, i+LT5X ( 1/4-20) 33 505A204Support, S@mdpipe Mounting 34Cock, Drain

505- I 4035 505- I 75

Base, Standpipe 36 504-20Screw (l/2-13 x 1-1/2”) 37 505-207Washer, Lock (1/2)

QTY.USED

72IIIIIIII[I

43IIII

PARTDESCRIPTION

Nut, Hex (1/2-13)Brace, StandpipeNipple, Pipe (2 x 24-1/2”)Clamp, Standpipe Mou~~mgScrew (3/8-16 x 1-1/4 )Washer, Lock (3/8)Nut, Hex (3/8-16)Nipple, PiPe (2 x l&l/2”)Tee, Pipe (2”)Nipple, Ptpe (2 x4”)Plug, PipeHose, Radtator (Order 21 “of

Bulk Hose #503-324)Clamp, HoseNIPPIC!, Half (;, x 2“)Plug, Pipe (1 )Elbow, Pipe (2

8ZX 90(>)

Key, Globe ValveBushing, Reducer (2-1/2 x 2)

44

NOTE: Remove Thermostat From Engine.

REF. PARTNO. A

I I 30C4252 504P62~ 505-2974 505- I025 505- I 326 509U247 S03P1898

9 309P241 I

II

KI 2

10II12131415161718

307A835II OA81080G7850-40862- I130B8S7504-61308442800-92

PARTC##CRlisTION

5tandpipeValve, Vacuum ReliefRushing, Reducer ( 1-1/4 x 3/4)Nipple, Close (3/4)Elbow, Pipe (3!4 x 90°)Nipple, Half(3/4 x 2“’)Clamp, HoseHose, Heater (Order 36” of

Bulk Hose I?503-249)Valve, Water Temperature

ControlValve. SolenoidBracket & Nipple AssemblyScrew ( I /4-20 x I “)Washer, Lock ( 1/4)Nut, Hex ( 1/4-20)Support, Standp ipe MountingCock, DrainBase, Standpipe5crew {l/2-13 x 1-1/2”)

k-Q6

7

a

STANDPIPE COOLINQ WITH MARSH RE@ULATOR INSTALLATION

REF. PbuRT WY. PARTNO. NO. USED DESCRIPTION—— —

850-60 8 Washer, Lock ( I /2)

862-5 8 Nut, Hex (1/2-13)

130A$73 2 Brace, Standpipe%05-4 18 I Nipple, Pipe (2 x 2+1/2”)130A871 I Clamp, St*dpipe Mounting800-5 I I Screw (3/8-16 x 1-1/4”)

850-S0 I Washer, Lock (3/8)

862-3 I Nut, Hex (3/8-16)

505-749 I Ni!w!e, Pipe (2 x 10-1/2”)

505”374 2 Tee, Pipe (2”)

505- I 73 I Nipple, Pipe (2 x 4“)

505-359 I Plug, Pipe1 Ho,se. Radiator (Order 21 “of

222

H2122232425262728293031

3233343537

Bu ik Hose #S03-324)

503 P354 4 Clamp, Hose

505A204 3 Nipple, Half (2 x 2“)

S05- I40 I Plug, Pipe (1 ‘“)

505-3s1 I Bushing, Reducw (2 x 3/4)

505-2(77 I Bushing, Reducer (2-1/2 x 2)

.-45

Partsin this listapplyto the PENNSYLVANIAAPPROVEDGENERATINGSETS for thefollowingSeriesGeneratorSets,Operatorsand PartsManualsand Specificati~.lettersshownadjacentto the seriesdesignated. ... ~~,

,%..,

Operatorsand PartsManual Series Spec Letter

928-302 EK CD D and E928-302 EM C,DandE - .,,.“.......9s7.302 KB Q9S7-302 KR Q947-302 WA Fand G948-305 WB Hand J948-306 WE B and C

Use theseparts in placeof/or in additionto those listedin the standardoperatorsmanualand parts catalog, Partsthat are similarin appearanceto thosein the mainparts catalogare not illustrated,

Pennsylvaniaapprovedgeneratingsets can be identifiedby the numbers30 (gasolinefuel),31 (gaseousfuel),or 331 (liquidpetroleumfuel)appearingin the model. :’Thesenumbersmay appearjust beforeor afterthe diagonalline (/). The numberappearingafterthe diagonallinesignifiesa standardPennsylvaniaapprovedgener-atingset (Example:30.OEK-15R/31E).

REPLACEMENTENGINES

REF. PART QTY. PARTNO. NO. USED DESCRIPTION

100P1OOO 1 For WA (Gas-GasolineFueled]ModelF817GU(Gas-Gaso)

100P1OO8 1 For WA (GasFueled)WaukeshaModelF817GU(Gas)

100P1017 1 For WB [Gas-GasolineFueled)ModelF1197GU(Gas-Gaso)

100P1OO3 1 For WB (GasFueled)WaukeshaModel F1197GU(Gas)

100P1OO4 1 For WE (Gas-GasolineFueled]

Waukesha

Waukesha

Waukesha

NOTE:NOTE:

Model”H-884Roiline(Gas-Gaso)100P1OO5 1 For WE (GasFueled)Waukesha

ModelH-884Roiline(Gas)

See standardoperatorsmanualand partscatalogfor generaldescription.Replacementengineslistedaboveare for standardradiatorcooledgeneratingsets,referto factoryfor all otherenginesused on the WA, WB, and WE series.

1