Telescopic Handler - TUFF Equipmenttuffequipco.com/pdfs/Gehl Owners Manuals/Gehl Telescopic... ·...

RS6-34 Telescopic Handler

Par

ts M

anua

l

Form No.913317

Revision DMay2013

Serial Number 21541 thru 21700 (Tier III Engine)Serial Number 21701 and up (Interim Tier IV Engine)

Introduction RS6-34 Telescopic Handler

RS6-34 J D 00 00000

Model

Year (E=13, F=14, etc.) Month

Unit NumberEngine

When ordering service parts, specify the correct part num-ber, full description, quantity required, the machine modelnumber, and serial number. For your safety, and continuedproper operation, use only genuine Manitou service parts.

“Right” and “left” are determined from a position sitting onthe seat inside the cab and facing forward.

Gehl Company reserves the right to make changes orimprovements in the design or construction of any part of themachine without incurring the obligation to install suchchanges on previously delivered machines.

NOTE: This parts manual identifies both standard andoptional features for this model. Depending on the featuresof your machine, some of the items identified in the partslists may, or may not, be included with your machine.

Operator's Manual: P/N 913323

SERIAL NUMBER

MANUALS

A1Represents a port designation onhydraulic components (e.g., valves,cylinders, etc.)

Serial number breaks are indicated as follows:

• (SN 999 and before) - indicates serial numbers up to and including 999.

• (SN 1000 - 2000) - indicates serial numbers from 1000 to 2000.

• (SN 999 and up) - indicates serial numbers including 999 and after.

NOTE: When ordering parts, be sure to identify the last fivedigits of the machine's serial number.

HYDRAULIC AND ELECTRICAL SCHEMATICSHydraulic and electrical schematics can be found in theOperator’s and Service Manuals for this machine; pleaserefer to the information at the right for the correct manual.

SOME ABBREVIATIONS LISTED IN THIS MANUALASSY AssemblyAR As RequiredCFPD Contact Factory Parts DepartmentEU European Union (standards)HYD HydraulicIN Inch(es)INC/INCL Included or includesLN Lock NutMM/mm MillimeterNA Not Applicable or Not AvailableNPT National Pipe ThreadNSS Not Sold SeparatelyORB O-Ring BossREF ReferenceSN Serial NumberW/ WithW/O Without

TiltCylinderparts are

on page 247.

Interior CabOptions areon page 18.

Refer to page126 for the

warningdecal.

Identifies whereadditional pagesfor component

parts, seals, andkits can be found.

Identifies whereadditional

information canbe found.

Alerts and directsuser to investigatemore information.

The following icons shown on various pages provideimportant information or identify where additionalinformation can be found.

NOTE:Hydraulicbulkhead

fitting.

Identifies missing,hidden parts, or

adds informationalcomments.

Warning or Important

Information

Important information to

follow

Seal Kit Repair Kit

PRINTED IN U.S.A. 1 913317/DP0513

PageINTRODUCTIONTable of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

CABCab and Covers (Standard) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6Glass - Front and Rear Window Group (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Glass - Top and Left Window (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14Instruments, Switches and Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16Heater (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18Steering Column and Shifter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22Cab Components - Tri-Function Controls (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24Brake and Accelerator Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26Cab Mounts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28

CHASSISHydraulic Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30Fuel Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32Battery Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34Hoods and Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36Front and Rear Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

PERSONNEL WORK PLATFORMBoom Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40Chassis Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Radio Remote Transmitter and Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

ENGINEExternal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44Radiator and Cooler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46Air Intake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48Exhaust Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50

TRANSMISSIONExternal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52Converter Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54Case and Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56Torque Converter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58Gear Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60Drive Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62Charge Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Reverse Idler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64Forward and Reverse Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66Third Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68(Transmission continued on next page.)

RS6-34 Telescopic Handler Table of Contents

913317/DP0513 2 PRINTED IN U.S.A.

Page(Transmission continued)First and Second Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70Output Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72Control Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73Drive Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74Modulation Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75

AXLEExternal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76Front Axle - Steer Cylinder and Tie Rods Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78Rear Axle - Steer Cylinder and Tie Rods Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79Front Axle - Differential Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80Rear Axle - Differential Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81Front Axle - Brake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82Rear Axle - Brake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83Front Axle - Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84Front Axle - Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86Rear Axle - Outer End Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88Rear Axle - Differential Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90

BOOMOuter Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92Intermediate Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96Dynattach Bracket Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98

HYDRAULIC SYSTEMSHydraulic Pump Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100Steer Motor and Select Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102Brake Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104Brake and Steering Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106Main Hydraulic Valve and Hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108Main Hydraulic Valve - Dual Controls (Standard) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110Main Valve with Tri-Function Control (Option) - Standard Hydraulics . . . . . . . . . . . . . . . . . . . . . . . .112Main Valve with Tri-Function Control (Option) and Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . .114Main Valve with Radio Remote (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116Dual Controls - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118Dual Controls with only Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120Dual Controls with only PWP (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122Dual Controls with PWP and Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124Dual Controls with Radio Remote (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126Dual Controls with Radio Remote and Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . .128Tri-Function Control (Option) with only PWP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130Tri-Function Control (Option) with PWP and Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . .132Tri-Function Control (Option) with Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134Tri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . .136

Table of Contents RS6-34 Telescopic Handler


Page(Hydraulic Systems continued.)Frame Level Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138Lift Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140Tilt / Slave Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .142Boom Extend Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .144Auxiliary Hydraulics Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .146

HYDRAULIC COMPONENTSHydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .148Joystick Relief - Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149Main Hydraulic Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150PWP Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .153Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .154Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .155Pilot Apply Manifold - Tri-Function Controller (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .156Radio Remote (Option) Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .157Controller - Tilt/Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .158Controller - Lift/Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160Controller - Tri-Function (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162Controller - Auxiliary Hydraulics (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .164Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .166Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .168Slave Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .170Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .172Boom-Extend Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174Fork-Shift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .176Rotating-Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .177

ATTACHMENTSCarriage Forks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .178Standard Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .180Fork-Shift Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .182Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .184Truss Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .186180º Swing Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .188Work Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .190Bucket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .192

DECALSGeneral Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .194New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .194Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .195

INDEXESNumeric Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .200Subject Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .208

RS6-34 Telescopic Handler Table of Contents


3

64

5

12

EngineOil

TransmissionFuel

Primary AirSecondary AirHydraulic

Filters RS6-34 Telescopic HandlerAll


Item Part Description Qty. Item Part Description Qty.No. No. Req. No. No. Req.

01 137498 PRIMARY AIR FILTER (outer) . . . . 102 137501 SECONDARY AIR FILTER (inner) . 103 L97489 HYDRAULIC FILTER. . . . . . . . . . . . 104a 102173 ENGINE OIL FILTER. . . . . . . . . . . . 1

05 211040 FUEL FILTER . . . . . . . . . . . . . . . . . 106 L99184 TRANSMISSION FILTER . . . . . . . . 1

a Use Dust Seal P/N 102742 as needed.

RS6-34 Telescopic Handler FiltersAll


9

Cab RS6-34 Telescopic HandlerCab and Covers (Standard)

LOWER SUPPORT

UPPER SUPPORT

SKID PLATE

INSTRUMENT PANELAND LOAD CHARTS

23

22

21

20

19

1110 12

18

171615

14

413

33

33

32

6

7 8

31

21

30

6

29

21 4

28

27

26

25

18

15161714

24

21

32

5

4

1

InstrumentPanel and

switches areon page 16.

Load Chartsare listed onpage 198.



01 103089 CAB WELDMENT (without glass) . . 102 L69297 PLATE, INCLMT MOUNT . . . . . . . . 103 L66011 INDICATOR/FRAME LEVEL . . . . . . 1

L50417 #8-32X1” SCREW . . . . . . . . . . . . . . 204 L52025 5/16”-18X3/4” BUTT. HD BOLT . . . . 405 L50051 1/4”-20 WHIZ LOCK NUT. . . . . . . AR06 102692 COVER, FUSE PANEL . . . . . . . . . . 107 102882 PANEL, DASH . . . . . . . . . . . . . . . . . 108 L63634 LOAD CHART PLATE . . . . . . . . . . . 209 L63887 1/4”-20 U-BOLT . . . . . . . . . . . . . . . . 110 103022 BULB SEAL, RIGHT WINDOW. . . . 111 103021 GLASS, RIGHT HAND . . . . . . . . . . 1

103675 SCREEN (option)12 L500057 CLIP, WINDOW . . . . . . . . . . . . . . . . 2

L500055 SCREW, FLANGE . . . . . . . . . . . . . . 413 102880 MOUNT, REAR GLASS UPPER . . . 214 L50051 1/4”-20 WHIZ NUT. . . . . . . . . . . . . . 315 L500022 WASHER, FLAT (BLACK) . . . . . . . . 316 L500020 BUSHING, NYLON . . . . . . . . . . . . . 317 L500021 GROMMET, 1/2”ID X 1/4”GROOVE 318 L52024 1/4”-20X1” BUTT. HD BOLT . . . . . . 319 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 1

20 103024 BULB SEAL, REAR WINDOW . . . . 121 L50202 1/4”-20X5/8” BUTTON HD . . . . . . AR22 L50139 1/4” LOCK WASHER. . . . . . . . . . . . 223 102881 MOUNT, REAR GLASS LOWER . . 124 654024 5/16” LOCK WASHER. . . . . . . . . . . 225 650486 5/16”-18X3/4” BOLT . . . . . . . . . . . . 226 103371 HANGER BRACKET . . . . . . . . . . . . 127 103370 SKID PLATE . . . . . . . . . . . . . . . . . . 128 102778 MASTER CYLINDER COVER. . . . . 129 102769 COVER, HYD. CONTROLLERS . . . 130 101550 1/4”-20 SELF THREADING BOLT. . 431a 102728 PANEL, HEATER. . . . . . . . . . . . . . . 132a 102727 PANEL, DASH COVER . . . . . . . . . . 133 L63813 HOLE PLUG, 2-1/2” DIA. . . . . . . . AR

-- ITEMS NOT SHOWN---- 105835 HARNESS, CANOPY (kit) . . . . . . . . 1-- L54002 TREAD STRIP, 6” WIDE (4 FT.) . . AR-- L71305 PLUG (top of cab) . . . . . . . . . . . . . . 2

a Use when not equipped with a heater.

RS6-34 Telescopic Handler CabCab and Covers (Standard)


20

16

19

16

16

1714 14

1318

12 10

9

3

2

84561

11

3

64

15

1

7

2

15

FRONT WINDOW HINGE

REAR WINDOW HINGE

Cab RS6-34 Telescopic HandlerGlass - Front and Rear Window Group (Option)



01 L500038 5/16”-18 ACORN NUT . . . . . . . . . AR02 651639 5/16”-18X1” BUTTON HD BOLT . . . 403 651640 5/16”-18X3/4” BUTTON HD BOLT . 804 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 405 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 606 651641 5/16” FLAT WASHER (BLACK). . . . 407 L500111 HINGE, FRONT WINDOW . . . . . . . 208 L500024 HINGE, PLASTIC (rear window) . . . 109 103023 GLASS, REAR. . . . . . . . . . . . . . . . . 110 103024 BULB SEAL, REAR GLASS . . . . . . 111 103022 BULB SEAL, FRONT GLASS . . . . . 112 103019 GLASS, FRONT . . . . . . . . . . . . . . . 113 101727 HOLD OPEN, T-STYLE. . . . . . . . . . 114 L500025 PIN, QUICK DETACH . . . . . . . . . . . 4

15a 104846 MOUNT, REAR WINDOW LATCH . 116 L500019 PIN, ROLL - 3/16”x1/2” . . . . . . . . . . 317 L500028 HOLD OPEN, L-STYLE. . . . . . . . . . 118 L500027 HOLD OPEN, L-STYLE. . . . . . . . . . 119a 103029 MOUNT, WIND. HOLD OPEN (RH) 120a 102722 MOUNT, WIND. HOLD OPEN (LH). 1

a Use the parts listed below to fasten mount to frame:-- 650863 1/4” FLAT WASHER . . . . . . . . . . AR-- 654002 1/4” LOCK WASHER. . . . . . . . . . AR-- L50202 1/4”-20X5/8” BUTTON HD BOLT AR

RS6-34 Telescopic Handler CabGlass - Front and Rear Window Group (Option)


Cab RS6-34 Telescopic HandlerWipers — Front and Top (with Enclosed Cab)

Late-StyleWiper

Early-StyleWiper

1 7

8

9

3 10

411

125

6

5

6

2313

1415

17

22

2120

19

18

16

2


RS6-34 Telescopic Handler CabWipers — Front and Top (with Enclosed Cab)


01 50380577 WIPER BLADE, 16". . . . . . . . . . . . . 102 WIPER ARM, PANTOGRAPH . . . . . 1

50380576 Front Window50380682 Top Window

03 50380579 PLATE, PANTO ARM MOUNT . . . . 104 50380583 PIN, PANTO ARM MOUNT . . . . . . . 105 L500706 M5, ACORN NUT . . . . . . . . . . . . . . 106 L500700 M8, ACORN NUT . . . . . . . . . . . . . . 107 102913 WIPER BLADE, 16". . . . . . . . . . . . . 108 L500707 ADAPTER, PIN LOCK. . . . . . . . . . . 109 WIPER ARM, PANTOGRAPH . . . . . 1

NSS Front window—see note aNSS Top window—see note b

10 L500719 PANTO ADAPTER PLATE . . . . . . . 111 101717 WASHER, #10 WEATHERTITE . . . 112 L500711 SCREW, M5 16mm . . . . . . . . . . . . . 113 L500696 COVER WIPER MOTOR. . . . . . . . . 114 L500718 BOLT / 10-24x1.25 HEX GR5 . . . . . 115 L500001 WASHER/BLK NYLON . . . . . . . . . . 116 139170 WASHER, #10 WEATHERTITE . . . 217 L500004 NUT/ACORN #10-24 BLK . . . . . . . . 118 L500709 RAIN SHIELD . . . . . . . . . . . . . . . . . 119 L500697 M18, NUT . . . . . . . . . . . . . . . . . . . . 120 L500701 GASKET, PANTO ADAPTER . . . . . 1

21 L500708 TOWER SEAL, TRICO WIPER. . . . 122 L500695 WIPER MOTOR, TRICO . . . . . . . . . 123 L500099 ADAPTER/WET ARM . . . . . . . . . . . 124 101495 BOTTLE, DUAL -PUMP WASHER . 1

-- ITEMS NOT SHOWN --(Windshield Wiper Harness)

-- 103179 HARNESS, TOP WIPER . . . . . . . . . 1-- 103180 HARNESS, FRONT WIPER . . . . . . 1

(Windshield Washer System)-- 102925 HARNESS, WASHER BOTTLE . . . 1-- 103013 TUBING, WASHER (15-1/2’) . . . . . . 1

a The early style front wiper arm is no longer available; it will be necessary to order part number 50380585 Wiper Arm Kit, which contains items 1-4.

b The early style top wiper arm is no longer available; it will be necessary to order part number50380683 Wiper Arm Kit, which contains items 1-4.

24

WASHER SYSTEM RESERVOIRLOCATED OUTSIDE CAB -

UNDER RIGHT SIDE WINDOW


9

8

4

3

1

10

2

3

56

7

10

Cab RS6-34 Telescopic HandlerGlass - Top and Left Window (Option)



01a 103027 GLASS, TOP . . . . . . . . . . . . . . . . . . 102 L500038 5/16”-18 ACORN NUT . . . . . . . . . AR03 102711 WINDOW MOUNT. . . . . . . . . . . . . . 204 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 405 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 406 651641 5/16” FLAT WASHER (BLACK). . . . 407 651639 5/16”-18X1” BUTTON HD BOLT . . . 4

08 103025 GLASS, LEFT REAR. . . . . . . . . . . . 109 103026 BULB SEAL, LEFT GLASS . . . . . . . 110 102712 WINDOW MOUNT. . . . . . . . . . . . . . 2

a Use P/N L500607 Adhesive Kit to attach top glass to cab.

RS6-34 Telescopic Handler CabGlass - Top and Left Window (Option)


21

20

16

10

14

127

11

8

156

78

9

4

3

21

5

5678

1718

19

22

9

Cab RS6-34 Telescopic HandlerDoor (Option)

32



-- 103014 CAB DOOR . . . . . . . . . . . . . . . . . . 1(includes items 1-10, 12 and 15)

01 102874 WELDMENT, CAB DOOR FRAME . 102 102705 BULB SEAL, DOOR FRAME . . . . . 103 102680 GLASS, UPPER DOOR . . . . . . . . . 104 102681 GLASS, LOWER DOOR . . . . . . . . . 105 651638 5/16”-18X1-3/4” BUTTN HD BOLT . 506 651641 5/16” FLAT WASHER (BLACK). . . . 507 L500042 BUSHING, STEEL . . . . . . . . . . . . . . 808 L500021 GROMMET, 1/2”IDX1/4”GROOVE . 809 L500038 5/16”-18 ACORN NUT (BLACK) . . . 710 651643 5/16”-18X2” BUTTON HD BOLT . . . 311 650730 3/8”X5” BOLT. . . . . . . . . . . . . . . . . . 312 102901 WELDMENT, DOOR HINGE . . . . . . 314 L520005 3/8” NYLON INSERT NUT . . . . . . . 315 102928 BUMPER, DOOR . . . . . . . . . . . . . . 116 L500036 HOLD OPEN/DOOR (SET) . . . . . . . 1

(includes item #18—mounts to cab)17 650588 1/4”-20x1-1/2” BOLT . . . . . . . . . . . . 118 NSS HOLD OPEN/DOOR STUD. . . . . . . 1

(included with item #16, as a set)19 101719 GLASS MOUNT . . . . . . . . . . . . . . . 1

20 102948 HANDLE, EXT. DOOR LOCKING . . 1101792 KEY ONLY . . . . . . . . . . . . . . . . . . . 1

21 102886 LATCH RELEASE, INTERIOR . . . . 1651635 1/4-20X1-1/4” FLAT HD SCREW . . 2L50202 1/4-20X5/8” BUTTON HD BOLT . . 1651636 M6-1X12 8.8 BOLT. . . . . . . . . . . . . 2L500022 FLAT WASHER (BLACK) . . . . . . . . 1L520003 1/4”-20 NYLON INSERT NUT . . . . 2L70069 1/2” HOLE PLUG . . . . . . . . . . . . . . 2

22 101436 STRIKER . . . . . . . . . . . . . . . . . . . . . 1654028 7/16” LOCK WASHER . . . . . . . . . . 1654046 7/16” FLAT WASHER . . . . . . . . . . . 1L50979 7/16”-14 NUT . . . . . . . . . . . . . . . . . 1

32 101746 COVER (included with #21) . . . . . . 1

-- ITEMS NOT SHOWN ---- L70069 1/2” PLUG . . . . . . . . . . . . . . . . . . . . 1

(access hole for door handle)

RS6-34 Telescopic Handler CabDoor (Option)


1

19

17

12 11

10

9

8

7

6543

141516

2

13

18

REFER TO “NOTE”ON FACING PAGE

32

31

30

29

2827

26

23

20

21

22

FUSES AND RELAYSLOCATED UNDER LOAD CHARTS

ON SIDE DASH

SWITCHES LOCATEDON LOWER DASH

25

24

103104 DIODE PACK

LOCATED UNDERTRANS. HOOD

33

34

F-N-R SHIFT MODULELOCATED NEXT TO FUSES

UNDER LOAD CHARTS

HORNSTART

Cab RS6-34 Telescopic HandlerInstruments, Switches and Fuses

IN-LINE DIODE

35

DIODE WIRE(ALTERNATOR)

36

DIODE WIRE(PARK BRAKE SWITCH)

37



01c L63640 GAUGE, FUEL . . . . . . . . . . . . . . . . 102c L66437 GAUGE, WATER TEMP. . . . . . . . . . 103 L71075 SWITCH, STEER MODE. . . . . . . . . 104 101278 SWITCH, ENGINE FAULT. . . . . . . . 105 L71086 SWITCH, CLUTCH CUT OUT. . . . . 106 L71074 SWITCH, PARK BRAKE . . . . . . . . . 107 L71082 SWITCH, LIGHTS . . . . . . . . . . . . . . 108 L71084 SWITCH, TURN SIGNALS . . . . . . . 109 L71077 SWITCH, HAZARD LIGHTS . . . . . . 110 L71691 SWITCH, PWP . . . . . . . . . . . . . . . . 111a NA OPTIONAL SWITCH . . . . . . . . . . . . 112 L71081 SWITCH, ETHER . . . . . . . . . . . . . . 113 L71076 SWITCH, WIPER/WASHER . . . . . . 114 L71076 SWITCH, WIPER/WASHER . . . . . . 115 072340 GAUGE, HOUR METER . . . . . . . . . 116 L63610 GAUGE, LIGHT CLUSTER . . . . . . . 117 102882 PANEL, DASH . . . . . . . . . . . . . . . . . 1

(does not include switches or gauges)18 L41848 SWITCH, PUSH BUTTON. . . . . . . . 219 089069 SWITCH, IGNITION w/KEY. . . . . . . 1

089070 KEY ONLY . . . . . . . . . . . . . . . . . . . 120b 105835 HARNESS, CANOPY (kit) . . . . . . . . 1

50380751 FUSE/RELAY COVER (not shown). 1272648 RELAY COVER (not shown) . . . . . . 1

21 L70075 CHANGE OVER RELAY . . . . . . . . 122 L70075 CHANGE OVER RELAY . . . . . . . . 123 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 124 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 125 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 126 103221 FUSE, MINI 25 AMP . . . . . . . . . . . . 127 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 128 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 129 103100 MICRO RELAY, 20 AMP . . . . . . . . . 130 103100 MICRO RELAY, 20 AMP . . . . . . . . . 131 103100 MICRO RELAY, 20 AMP . . . . . . . . . 132 103100 MICRO RELAY, 20 AMP . . . . . . . . . 133 103104 DIODE PACK, 4 DIODES . . . . . . . . 1

(included with item 00—103265wire harness below)

34 101877 MODULE, F-N-R SHIFTER. . . . . . . 1

35 L60587 3 AMP./800PIV (in-line diode). . . . ARLocations: Alternator - (purple wire);Park Brake Switch Connector -(inside dash); Tail Light Harness - (rear of machine inside wire loom between diode

pack and back-up alarm wires)36 105960 DIODE WIRE (park brake switch) . . 137 105959 DIODE WIRE (alternator) . . . . . . . . 1

-- ITEMS NOT SHOWN ----d 103265 WIRE HARNESS, FRAME . . . . . . . 1

(includes the following diodes and fuse)103104 DIODE PACK, 4 DIODES. . . . . . . . 1

(located under chassis cover justin front of transmission)

L500225 60 AMP MAXI FUSE . . . . . . . . . . . 1(located near engine starter)

210909 WIRE HARNESS, BRAKE RELAY . 1(attaches to trans. press. switch)

420-35602 RELAY . . . . . . . . . . . . . . . . . . . . . . . 2(included with 210909 harness)

-- L630004 GROUND STRAP . . . . . . . . . . . . . . 1-- 105580 TRI-FUNCTION WIRE HARNESS . 1

(when equipped with F3 option)-- 105620 WIRE HARNESS, CANOPY (T3) . . 1

a Use P/N L71088 Switch Hole Plug to cover hole when switches are not present.

b Not all connections or terminals are shown in this illustration. The fuse and relay blocks as shown are located under the load chart panel on theside dash.

c Back light kit #103227; for illuminating gauges.

d If ordering 103265, also order kit P/N 211124.

NOTE: Switches shown in the illustration or listedon this page are for reference purposes only.

FUSE AND RELAY REFERENCE

21 (Relay #2) - 40 AMP change-over relay - PARK BRAKE22 (Relay #1) - 40 AMP change-over relay - IGNITION23 (Fuse #2) - 15 AMP fuse - (IGNITION) - transmission, park brake, PWP, steer select, injector24 (Fuse #4) - 25 AMP fuse - (IGNITION) - heater, gauges25 (Fuse #6) - 25 AMP fuse - (IGNITION) - front wiper motor26 (Fuse #5) - 25 AMP fuse - (IGNITION) - top wiper motor27 (Fuse #3) - 15 AMP fuse - (IGNITION) - lights, ether, clutch cutout28 (Fuse #1) - 15 AMP fuse - (BATTERY) - ignition switch, horn, brake lights, backup alarm29 (Relay) - 20 AMP micro relay - top wiper30 (Relay) - 20 AMP micro relay - lights31 (Relay) - 20 AMP micro relay - bulb check32 (Relay) - 20 AMP micro relay - front wiper

RS6-34 Telescopic Handler CabInstruments, Switches and Fuses


1

7

8

6

5432

Cab RS6-34 Telescopic HandlerHeater (Option)

2

9

18

10

11

12

17

1612

15

13

14


RS6-34 Telescopic Handler CabHeater (Option)

01 102907 HEATER ASSEMBLY . . . . . . . . . . . 1(Includes items 5-11; 13-18)

02 L63545 GRILL, DEFROSTER . . . . . . . . . . . 203 102944 INSTRUMENT PANEL. . . . . . . . . . . 104 102945 DECAL, HEAT CONTROL. . . . . . . . 105 187841 CONTROL, TEMPERATURE . . . . . 1

(does not include knob)06 136304 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 107 136305 SWITCH, VARIABLE SPEED . . . . . 1

(includes knob)08 L500163 VALVE, WATER. . . . . . . . . . . . . . . . 1

09 NSS HOSE, 5/8" - FORMED . . . . . . . . . . 110 50380847 HEATER CORE. . . . . . . . . . . . . . . . 111 103033 BLOWER MOTOR. . . . . . . . . . . . . . 1

(does not include fan/cage)12 L50202 1/4”-20X5/8” BUTTN HD BOLT . . . 1013 136310 RESISTOR BLOCK . . . . . . . . . . . . . 114 NSS GROMMET 5/8" OD X 3/8" ID. . . . . 215 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 116 137503 LOUVER . . . . . . . . . . . . . . . . . . . . . 117 NSS HOSE, 5/8" - FORMED . . . . . . . . . . 118 NSS GROMMET 1-3/8" OD X 1" ID . . . . 2



STEER MOTORPORTS

RL

P

T LS

9

7

4

6

3

2

1

5

810

F-N-R SHIFT MODULELOCATED NEXT TO FUSES

UNDER LOAD CHARTS

Cab RS6-34 Telescopic HandlerSteering Column and Shifter Group



01 103359 CAP, STEERING WHEEL . . . . . . . . 102 L41261 NUT, STEERING WHEEL . . . . . . . . 103 L69595 STEERING WHEEL . . . . . . . . . . . . 104 L50101 M5X.8X35mm HX SKTHD BOLT . . 205 102783 COLUMN, STEERING. . . . . . . . . . . 106 L68772 F-N-R/1-2-3 SHIFTER (includes #7) 1

L99425 BOOT . . . . . . . . . . . . . . . . . . . . . . . 1

07 105236 CLAMP, SHIFTER(included w/ #6) . 108 651625 3/8”-16X1-1/4” BUTTON HD BOLT . 409 101882 MOTOR, STEER . . . . . . . . . . . . . . . 110 101877 MODULE, F-N-R SHIFTER. . . . . . . 1

102649 WIRE HARNESS, FNR SHIFTER. . 1(not shown)

RS6-34 Telescopic Handler CabSteering Column and Shifter Group


7

54

6 5

43

2

3

35

4

2

4

435

3

2

3

29

10

9

8

11

8

12

6

5

SUSPENSION SEAT(OPTION)

13

Cab RS6-34 Telescopic HandlerSeat

1


01 210170 SEAT . . . . . . . . . . . . . . . . . . . . . . . . 102 L70634 SEAT BELT (includes tethers) . . . . . 103 650630 7/16”-20X1” BOLT . . . . . . . . . . . . AR04 L50196 7/16” FLAT WASHER . . . . . . . . . . AR05 L50517 7/16”-20 NYLON INSERT NUT . . AR06 L70212 BRACKET, TETHER . . . . . . . . . . . . 207a L70201 MOUNT, SEAT BELT. . . . . . . . . . . . 108 654004 5/16” FLAT WASHER . . . . . . . . . . AR09 L50056 5/6”-18 NYLON INSERT NUT . . . AR10a 100071 SEAT RISER . . . . . . . . . . . . . . . . . . 1

11 L50823 5/16”-18X1” BOLT . . . . . . . . . . . . AR12b L68496 BELLOWS, SUSPENSION SEAT . . 1

(includes seat belt / tether bracket)13 103195 PEDESTAL / BOLT ON SEAT . . . . . 114b 210403 BELLOWS, SEAT (boot only) . . . . . 115b 210405 ADJUSTMENT KNOB . . . . . . . . . . . 116b 210404 SHOCK, SUSP. SEAT . . . . . . . . . . . 1

a Used for standard seat only. Not used with suspension seat option.

b Used for suspension seat option only.


RS6-34 Telescopic Handler CabSeat

Suspension Seat(Option)

14

16

15


1

5

7

6

5

8

11

109

5

4

2

12

3

Cab RS6-34 Telescopic HandlerCab Components - Tri-Function Controls (Option)

Controllerparts on arepage 162.

Controllerparts are onpage 164.


01 L71346 CONTROLLER, 4 BTN/W TRIG . . . 102 104304 BEZEL, JOYSTICK . . . . . . . . . . . . . 1

(included with item 1)03 L50202 1/4”-20X5/8” BTN HD BOLT. . . . . AR04 103582 JOYSTICK MOUNT. . . . . . . . . . . . . 105 L50051 1/4”-20 FLANGE LOCK NUT . . . . AR06 104214 SPACER, LEVEL CONTROLLER . . 207 103264 CONTROLLER, LEVEL. . . . . . . . . . 1

08 104219 1/4”-20X2-1/2” BTN HD BOLT. . . . . 209 L52024 1/4”-20X1” BTN HD BOLT. . . . . . . . 210 L52022 1/4”-20X5/8” BTN HD BOLT . . . . . . 211 103708 BRACKET, ARM REST . . . . . . . . . . 112 L69756 PAD, ARM REST . . . . . . . . . . . . . . . 1

-- ITEMS NOT SHOWN ---- 105580 TRI-FUNCTION WIRE HARNESS . 1


RS6-34 Telescopic Handler CabCab Components - Tri-Function Controls (Option)


2

15

1110

67

8

9

45

24

3

1

1718

1920

1314

12

11

141312

21

16

2223

22

Cab RS6-34 Telescopic HandlerBrake and Accelerator Pedals

BRAKE PEDAL RETURNSPRING - NOT SHOWN

25

MasterCylinder parts

are on page 155.



01 L63230 PAD, BRAKE PEDAL . . . . . . . . . . . 102 650545 5/16”-18X1-1/4” BOLT . . . . . . . . . . . 203 L50056 5/16”-18 FLANGE NUT . . . . . . . . . . 204 102785 BRAKE LEVER ASSEMBLY . . . . . . 1

(includes item 7)05 102530 BRAKE LINKAGE, WLDMNT . . . . . 106 654009 1/2” FLAT WASHER . . . . . . . . . . . . 107 L48179 BRONZE BUSHING . . . . . . . . . . . . 2

(included with item 4)08 102529 PIN, BRAKE LEVER PIVOT . . . . . . 109 L50628 ROLL PIN, .19X1. . . . . . . . . . . . . . . 110 L10465 ZERK, GREASE 1/4”-28 . . . . . . . . . 111 L44859 PIN, CLEVIS 1/2”X27/64” . . . . . . . . 212 655006 1/8”X1” COTTER PIN . . . . . . . . . . . 213 L580005 YOKE, CLEVIS 1/2”-13 . . . . . . . . . . 214 L50072 1/2”-13 NUT. . . . . . . . . . . . . . . . . . . 215 102534 ROD, BRAKE VALVE . . . . . . . . . . . 116 650533 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 617 654006 3/8” FLAT WASHER . . . . . . . . . . . . 618 L520005 3/8”-16 NYLON INSERT NUT . . . . . 619 L50150 7/16” LOCK WASHER. . . . . . . . . . . 220 650630 7/16”-20X1” BOLT . . . . . . . . . . . . . . 2

21 L63363 VALVE, BRAKE MASTER CYL. . . . 222 L63629 BRACKET, THROTTLE RETRN . . . 223 L62926 SPRING, CABLE TENSION . . . . . . 124 L68641 PEDAL, ACCELERATOR . . . . . . . . 1

L52024 1/4”-20X1” BUTTON HD BOLT . . . 3L50051 1/4”-20 FLANGE NUT . . . . . . . . . . 3L98865 BOOT . . . . . . . . . . . . . . . . . . . . . . . 1

25 202583 Clevis w/pin (1/4" x #10-24) . . . . . . 1(included with item #24)

-- ITEMS NOT SHOWN--(Throttle)

-- L63420 THROTTLE CABLE. . . . . . . . . . . . . 1L64664 COUPLER . . . . . . . . . . . . . . . . . . . 1L64663 THROTTLE ROD . . . . . . . . . . . . . . 1

Note: Refer to Engine Section for more information.

(Brake)-- L561004 RETURN SPRING (brake lever) . . . 1

(attaches to item 4)

RS6-34 Telescopic Handler CabBrake and Accelerator Pedals

2

7

24

4

2

7

4

2

7

65

43

1

Cab RS6-34 Telescopic HandlerCab Mounts



01 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 102 651151 1” SAE FLAT WASHER. . . . . . . . . . 703 102741 RETAINER, CANOPY NUT . . . . . . . 104 102781 1”-8 CLASS C LOCK NUT . . . . . . . 405 101667 WASHER, CANOPY NUT . . . . . . . 106 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 2

07 102780 1”-8X3” GR8 BOLT . . . . . . . . . . . . . 3

-- ITEMS NOT SHOWN---- L63813 HOLE PLUG, 2-1/2” DIA . . . . . . . . . 1

(plugs hole in cab where side boltattaches)

RS6-34 Telescopic Handler CabCab Mounts


25

16

17

18

21

22 23

2928

2726

30

1920

31

24

10

8

15

149 7

6

4

5

3

2

11

12

13

1

2

Chassis RS6-34 Telescopic HandlerHydraulic Tank Group



01 101879 ASSEMBLY, IN-TANK FILTER. . . . . 1(includes items 1-3)

02 50380450 SEAL KIT (three o-rings) . . . . . . . . . 103 L97489 HYDRAULIC FILTER ELEMENT. . . 104 650489 CS 3/8”-16X 7/8” C5Z . . . . . . . . . . . 405 654006 3/8” FLAT WASHER . . . . . . . . . . . . 406 L277944 ADAP., -20ORM -12JICM . . . . . . . . 107 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 108 L63215 CAP ASSEMBLY, HYDRAULIC. . . . 1

(includes item 9)09 L99163 GASKET, FILLER NECK . . . . . . . . . 210 L63756 MIRROR, CONVEX 6-1/2”X10”. . . . 111 103991 BRACKET, MIRROR . . . . . . . . . . . . 112 L520003 1/4”-20 NYLON INSERT NUT . . . . . 113 081379 5/16”x1/2” LOCK BOLT . . . . . . . . . . 414 650486 5/16”-18x3/4” BOLT . . . . . . . . . . . . 1015 654004 5/16” FLAT WASHER . . . . . . . . . . 1016 L65142 PLATE, HYDRAULIC TANK COVR. 117 L65144 GASKET, RUBBER . . . . . . . . . . . . . 1

18 50380516 HYDRAULIC TANK WELDMENT . . 1(includes items 22 and 23)

19 650569 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 420 L520019 1/2”-13 NYLON INSERT NUT . . . . . 421 L446025 PLUG, -8ORM SAE . . . . . . . . . . . . . 122 L49327 STRAINER, HYD. OIL . . . . . . . . . . . 123 L61620 1-1/2” THREADED PIPE . . . . . . . . . 124 L441010 ADAP., -24NPTM -24JICM . . . . . . . 125 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 126 103315 HOSE, -4 A6/DS6 60” . . . . . . . . . . . 127a 103318 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 128 L68805 HOSE, -6 A6/DS8 70” . . . . . . . . . . . 129 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 130 054994 ADAP., -6ORM -6JICM . . . . . . . . . AR31b 122778 PLUG, -6ORM SAE . . . . . . . . . . . . . 1

a Used on units equipped with PWP.b Used on units not equipped with PWP.

HOSE LOCATOR

07 HYDRAULIC FILTER MAIN VALVE “OUT”25 HYDRAULIC TANK HYDRAULIC PUMP “IN”26 HYDRAULIC TANK RETURN JOYSTICK27a HYDRAULIC TANK RETURN PWP VALVE “T”28 HYDRAULIC TANK RETURN STEER MOTOR “T”29 HYDRAULIC TANK RETURN FLOW DIVIDER “T”

RS6-34 Telescopic Handler ChassisHydraulic Tank Group


1011

1

2

5

4

9

8

7

6

1315

1314

12

Chassis RS6-34 Telescopic HandlerFuel Tank Group

Air cleanerparts areshown onpage 48.



01 210738 FUEL TANK WELDMENT . . . . . . . . 102 210722 CAP, FUEL (vented) . . . . . . . . . . . . 104a L61867 SENDER, FUEL LEVEL . . . . . . . . . 1

650387 #10-32X1/2” RD MACH SCREW . . 505 L41854 GASKET, FUEL SENDER . . . . . . . . 106 136383 AIR CLEANER ASSEMBLY. . . . . . . 107 136443 CLAMP, AIR CLEANER MOUNT. . . 108 L50056 5/16”-18 WHIZ LOCK NUT . . . . . . . 209 650545 5/16”-18X1-1/25” BOLT . . . . . . . . . . 2

10 L520019 1/2”-13 NYLON INSERT NUT . . . . . 411 650569 1/2”-13X1-3/4” BOLT . . . . . . . . . . . . 412 L446025 PLUG, -8ORM SAE . . . . . . . . . . . . . 113 110227 ADAP., -8ORM -6JICM 90º . . . . . . . 214 L68619 HOSE, -6 K6/XX 73” (Fuel Supply) . 1 15 102861 HOSE, -4 K6/XX 73” (Fuel Return) . 1

a Includes gasket; item #5

RS6-34 Telescopic Handler ChassisFuel Tank Group


9

8

7

6

3

5

4

2

10

1

Chassis RS6-34 Telescopic HandlerBattery Group



01 L63334 BAR, BATTERY HOLD-DOWN . . . . 102 L630004 GROUND STRAP, 14GA.X14” . . . . 103 L630001 CABLE, NEG. BATTERY . . . . . . . . . 104 L630003 BOOT, RUBBER . . . . . . . . . . . . . . . 105 L63248 CABLE, POS. BATTERY. . . . . . . . . 1

06 L41847 HORN, 12V ELEC B2I. . . . . . . . . . . 107 NSS BATTERY, 4DLT TYPE . . . . . . . . . . 108 090666 3/8”-16 FLANGE NUT . . . . . . . . . . . 409 L70146 ROD, BATTERY HOLD DOWN. . . . 210 653098 3/8”-16 WING NUT . . . . . . . . . . . . . 2

RS6-34 Telescopic Handler ChassisBattery Group


Chassis RS6-34 Telescopic HandlerHoods and Covers

3

2 1

32

1

110

8

7

6

5

8

9

4

312

11

15

16

3

2

1

13

12

3

21

2019

12

22

1

324

18

17

32

1

2

SKID PLATE(UNDER CAB)

MUFFLER GUARD

2423

COUNTER-WEIGHT BOLTS



01 650486 5/16”-18X3/4” BOLT . . . . . . . . . . . AR02 654004 5/16” FLAT WASHER . . . . . . . . . . AR03 L530004 FASTENER RETAINED NUT . . . . AR04 L52025 5/16”-18X3/4” BUTTON HEAD. . . AR05 L68866 FRONT COVER. . . . . . . . . . . . . . . . 106 210452 HOOD/TRANS COVER. . . . . . . . . . 107 103856 ACCESS COVER . . . . . . . . . . . . . . 108 104222 LATCH . . . . . . . . . . . . . . . . . . . . . . . 209 L64673 HANDLE, HOOD . . . . . . . . . . . . . . . 1

650387 #10-32x1/2” MACH. SCREW . . . . . 2650648 #10-32 NUT . . . . . . . . . . . . . . . . . . . 2

10 L50056 5/16”-18 WHIZ NUT . . . . . . . . . . . AR11 L41847 HORN, 12V . . . . . . . . . . . . . . . . . . . 1

12 650484 5/16”-18X1/2” BOLT . . . . . . . . . . . . 113 103199 HOOD, REAR . . . . . . . . . . . . . . . . . 115 210358 COVER, RADIATOR . . . . . . . . . . . . 116 210369 HOOD, REAR . . . . . . . . . . . . . . . . . 117 210394 COVER, ENGINE . . . . . . . . . . . . . . 118 103270 COVER, FUEL FILTER ACCESS . . 119 L67756 MUFFLER GUARD . . . . . . . . . . . . . 120 L50442 3/8”X1-1/4” BOLT . . . . . . . . . . . . . . 421 103370 SKID PLATE . . . . . . . . . . . . . . . . . . 122 103371 BRACKET . . . . . . . . . . . . . . . . . . . . 123 L50519 3/4” NYLON LOCK NUT . . . . . . . . . 424 L50333 3/4”X3” BOLT. . . . . . . . . . . . . . . . . . 5

RS6-34 Telescopic Handler ChassisHoods and Covers


6

8

7

9

10

8

7

5

43

2

1

FRONT OF CAB

REAR COVER

Chassis RS6-34 Telescopic HandlerFront and Rear Lights



01 L70039 HEAD LIGHT . . . . . . . . . . . . . . . . . . 202 654006 3/8” FLAT WASHER . . . . . . . . . . . . 203 L520005 3/8”-16 NYLON INSERT NUT . . . . . 204 101712 GROMMET, 5/8” . . . . . . . . . . . . . . . 205 103199 HOOD, REAR . . . . . . . . . . . . . . . . . 106 L70200 BACKUP ALARM. . . . . . . . . . . . . . . 1

650486 5/16-18X3/4” BOLT . . . . . . . . . . . . . 2L50056 5/16”-18 NUT. . . . . . . . . . . . . . . . . . 2654004 5/16” FLAT WASHER . . . . . . . . . . . 2

07 L500339 BEZEL, RUBBER . . . . . . . . . . . . . . 2(included with item #08)

08 L70701 LIGHT, BRAKE/TURN . . . . . . . . . . . 2(includes item #07 bezel) . . . . . . . . .

09 L500606 BEZEL, RUBBER . . . . . . . . . . . . . . 1(included with item #10)

10 L71595 LIGHT, HALOGEN BACKUP. . . . . . 1(includes item #09 bezel)

100102 JUMPER WIRE, BACKUP LIGHT . 1

-- ITEMS NOT SHOWN ----a 102647 WIRE HARNESS, REAR LIGHTS. . 1--b 102572 HARNESS, LIGHT PACKAGE . . . . 1

(dash to rear lights - includes thefollowing diodes:)

103101 DIODE PACK (see below). . . . . . . 1L500748 DIODE PACK (see below). . . . . . . 1L500747 CLEAR COVER, DIODE PACK . . . 2L60587 3 AMP./800PIV (in-line diode) . . . . . 2

(rear of machine inside the wire loom between diode pack (103101)and back-up alarm wires)

-- L63894 TURN SIGNAL FLASHER. . . . . . . . 1(located under dash through joystickaccess cover)

-- L70241 HARNESS, HEAD LIGHT . . . . . . . . 2(dash to head lights)

-- 103192 GROMMET 13/16”. . . . . . . . . . . . . . 2(under dash for head light harness)

a Standard wire harness, used on units not equipped with turn signals.

b Used with optional light package for units equipped with turn signals. Wire harness 102647 is not usedwhen unit is equipped with turn signals.

NOTE: Refer to page 93 for the work lights andwire harness associated with the boom.

103101 DIODE PACK

LOCATED NEARREAR LIGHTS

L500748DIODE PACK

LOCATED UNDER DASHNEAR SWITCHES

L500747DIODE PACK

CLEAR COVER

RS6-34 Telescopic Handler ChassisFront and Rear Lights

L60587IN-LINE DIODE


5612”

110 “

(Attached to PersonnelWork Platform)

1


-- L71729 REMOTE SWITCH W/CABLE. . . . . 1(Includes item 1-3)

01 102408 CABLE ASSEMBLY. . . . . . . . . . . . . 102 L71726 REMOTE STOP SWITCH . . . . . . . . 103 L71725 REMOTE SWITCH ENCLOSURE. . 1

4

3

2

04 L71750 REMOTE SWITCH POUCH . . . . . . 105 L71732 REMOTE SWITCH HARNESS . . . . 1

(Consists of two cables)

Personnel Work Platform RS6-34 Telescopic HandlerBoom Components


01 L71553 LEVEL SENSOR . . . . . . . . . . . . . . . 102 102321 MANIFOLD, PWP JOYSTICK . . . . . 103 104078 PWP CONTROL MODULE . . . . . . . 104a L71752 5/16” CHAIN SHACKLE . . . . . . . . . 105a L71751 5/16” CHAIN GR40 16 LINKS . . . . 1

-- ITEMS NOT SHOWN ---- L71691 PWP SWITCH (located on dash) . . 1-- 104064 PWP WIRE HARNESS . . . . . . . . . . 1

(under dash)

a Chain shackle and chain are used to secure the Personnel Work Platform.


Chain and Shackle(Used to secure

Personnel Work Platform)

54

2

1

3Located under dash inJoystick Access Cover

Located undertank/engine coverattached to inner

frame

RS6-34 Telescopic Handler Personnel Work PlatformChassis Components


Personnel Work Platform RS6-34 Telescopic HandlerRadio Remote (Option) - Transmitter and Receiver - (Late Style)

-- 50380274 RADIO REMOTE, SYSTEM . . . . . . 1(Includes all items shown)

01a 50220629 REMOTE TRANSMITTER. . . . . . . . 102 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 103 50220628 SWITCH, TOGGLE 2-POS.. . . . . . . 104 50220627 SWITCH, TOGGLE 3-POS.. . . . . . . 405 50220626 BUTTON, RADIO E-STOP . . . . . . . 106 103476 SNAP RING, LANYARD . . . . . . . . . 107 103475 LANYARD (wire cable) . . . . . . . . . . 108 50220630 RECEIVER, RADIO REMOTE . . . . 109 50380826 BRACKET, RECEIVER MOUNT . . . 110 L50051 1/4” WHIZNUT. . . . . . . . . . . . . . . . . 2

11 650426 1/4”X1-1/4” BOLT . . . . . . . . . . . . . . 212 L71553 LEVEL SENSOR . . . . . . . . . . . . . . . 113 50380825 DECAL, REMOTE TRANSMITTER. 1

(not included with item 1)

-- ITEMS NOT SHOWN ---- 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 1-- 50380836 HARNESS, RADIO REMOTE . . . . . 1

a Requires programming; refer to Radio RemoteOperator’s Manual an Parts Manual (50960060),included with the Radio Remote Control at the time of purchase, for more information.


13

1

3

2

4

5

7

6

11

8

9

10

12

NOTE:Late-StyleTransmitter

color is black


Radio receivermount bracket

Battery

13

RS6-34 Telescopic Handler Personnel Work PlatformRadio Remote (Option) - Transmitter and Receiver - (Early Style)

2

35

6

7

8

9

10

11

12

4

-- 103414 RADIO REMOTE, COMPLETE. . . . 1(Includes all items shown)

01a 103479 REMOTE TRANSMITTER. . . . . . . . 102 103482 SWITCH, TOGGLE 3 POS. MIL . . . 403 210867 SWITCH, E-STOP (push-button). . . 104 104675 LABEL (not shown-switch functions)105 106965 SPRING, TRIGGER. . . . . . . . . . . . . 106 NSS AA BATTERY. . . . . . . . . . . . . . . . . . 407 50220061 COVER w/MAGNET & SCREWS . . 108 103480 REMOTE RECEIVER . . . . . . . . . . . 109 210777 ENCLOSURE / CIRCUIT BOARD. . 1

(includes wire harness)10 103475 LANYARD (wire cable) . . . . . . . . . . 111 103476 SNAP RING, LANYARD . . . . . . . . . 1

12 102968 DECAL, REMOTE TRANSMITTER. 1(not included with item 1)

13 103994 BRACKET, RECEIVER MOUNT . . . 1650542 1/4”X1/2” BOLT . . . . . . . . . . . . . . . . 2L50051 1/4” WHIZNUT. . . . . . . . . . . . . . . . . 2

-- ITEMS NOT SHOWN ---- 103099 FUSE, MINI 15 AMP . . . . . . . . . . . . 1-- 103424 HARNESS, RADIO REMOTE . . . . . 1

(Connects to existing PWP wireharness.)

a Requires programming; refer to Radio RemoteOperator’s Manual an Parts Manual (913236),included with the Radio Remote Control at the time of purchase, for more information.


1

NOTE:Early-StyleTransmitter

color is yellow


19

11

10

076

5

4

08

09

1514

18

3

2

12

13

17

1

20

21

22

23

24

25

FUELTRANSFER

PUMP

26

Engine RS6-34 Telescopic HandlerExternal Components



01 NSS ENGINE. . . . . . . . . . . . . . . . . . . . . . 102 L41179 RELAY, ENGINE STARTER . . . . . . 103 L68571 MOUNT, RELAY . . . . . . . . . . . . . . . 104 210484 SENDER, WATER TEMP . . . . . . . . 105 L69166 FUEL LINE TUBE . . . . . . . . . . . . . . 106 103626 SENDER, OIL PRESSURE . . . . . . . 107 L68596 ENGINE MOUNT (right) . . . . . . . . . 108 L68595 ENGINE MOUNT (left) . . . . . . . . . . 109 L50305 M16-2X35M BOLT GR8.8 . . . . . . . . 410 650695 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 211 L64124 MOUNT, VIBRATION ISOLATOR . . 212 L64197 WASHER, ISOLATOR MOUNT. . . . 213 L520007 5/8”-11 NYLON INSERT NUT . . . . . 214b L69718 ADAP., M18 -6NPTF STR . . . . . . . . 115b L68592 SHUTOFF, MANUAL/WATER . . . . . 117 105850 FAN BELT . . . . . . . . . . . . . . . . . . . . 118b L447005 ADAP., M18 10 BEAD STR. . . . . . . 119 L68604 BRACKET, ALTERNATOR. . . . . . . . 120 105281 BRACKET, THROTTLE . . . . . . . . . 121 L64664 COUPLER, ROD TO CABLE . . . . . 1

650648 #10-32 NUT . . . . . . . . . . . . . . . . . . 222 L64663 ROD, THROTTLE EXTEND . . . . . . 123 L580009 BALL JOINT #10-32 . . . . . . . . . . . . 1

650648 #10-32 NUT . . . . . . . . . . . . . . . . . . 124 104340 ADAP., 5MJ -2MP90 . . . . . . . . . . . . 125 104341 ADAP., -6 PUSH-ON -5FEM JIC . . . 126 NSS FUEL TRANSFER PUMP . . . . . . . . 1

-- ITEMS NOT SHOWN ---- L65570 ENGINE BLOCK HEATER (opt.). . . 1-- 210126 CORD, HEATER EXTENSION . . . . 1

(Throttle Cable)-- L63420 CABLE, THROTTLE . . . . . . . . . . . . 1

(Ether - Optional)-- 102926 HARNESS, ETHER KIT . . . . . . . . . 1

(includes 21” BLU/WHT jumper wire)--a L70629 ETHER KIT (optional) . . . . . . . . . . . 1

(includes: thermostat, atomizer,valve bracket, fitting, clamp andtubing—does not include ethercanister)

-- L71081 SWITCH, ROCKER (ether) . . . . . . . 1(located in dash panel)

(Fuel Line)-- L68619 HOSE, 3/8” X 73” (supply). . . . . . . . 1-- 102861 HOSE, 1/4” X 73” (return) . . . . . . . . 1

a Thermostat is located on engine block; the switch is located on dash.

b Used on units equipped with cab heater (option).

ETHER KIT-- OPTIONAL --

ATOMIZER

THERMOSTAT

FITTING

VALVE - BRACKET

TUBING

CLAMP

RS6-34 Telescopic Handler EngineExternal Components


Engine RS6-34 Telescopic HandlerRadiator and Cooler Group

1

1

2

1412

3

6

8

7

10

11

13123

1617

18

1

2223

21

12

24

9

20

19

19

15

Transmission(Top Right Side)

Transmission(Left Side)

2625

5



01 L76020 HOSE CLAMP . . . . . . . . . . . . . . . . . 402 210347 HOSE, UPPER RADIATOR. . . . . . . 103 650486 5/16”-18X3/4” BOLT . . . . . . . . . . . AR05 210477 MOUNT, TOP HOOD. . . . . . . . . . . . 106 104808 RUBBER SEAL (not shown) . . . . . 107 055005 ADAP., -12ORM -12JICM 90º . . . . . 108 L63406 HOSE -12 A12/DS12 114” . . . . . . . . 109 210309 RADIATOR/OIL COOLER . . . . . . . . 1

(includes item #10)10 102063 RADIATOR CAP (10 LB.) . . . . . . . . 111 102262 HOSE, OVERFLOW 42’ . . . . . . . . . 112 654004 5/16” FLAT WASHER . . . . . . . . . . AR13 420-19671 VINYL CLAMP 3/8” HOSE . . . . . . . 2

14 L50056 5/16” FLANGE LOCK WASHER . . . 615 210321 FAN SHROUD . . . . . . . . . . . . . . . . . 116 L50677 M8X1.25X45MM BOLT . . . . . . . . . . 417 L69264 FAN, 20” . . . . . . . . . . . . . . . . . . . . . 118 L70521 SPACER, FAN (2”) . . . . . . . . . . . . . 119 210329 FAN GUARD . . . . . . . . . . . . . . . . . . 220 650484 5/16”-18X1/2” BOLT . . . . . . . . . . . AR21 072587 ADAP -12ORB - 12JICM ST . . . . . . 122 L63399 HOSE -12 DS12/A12 82” . . . . . . . . 123 210346 HOSE, LOWER RADIATOR . . . . . . 124 L40805 VALVE, DRAIN COCK. . . . . . . . . . . 125 210148 3/8”-16X2” STUD. . . . . . . . . . . . . . . 226 090666 3/8”-16 FLANGE LOCK NUT . . . . . 2

HOSE LOCATOR

08 TRANSMISSION (top right side - near filter) TRANSMISSION COOLER “UPPER”22 TRANSMISSION (left side - just under hyd. pump) TRANSMISSION COOLER “LOWER”

RS6-34 Telescopic Handler EngineRadiator and Cooler Group


4

2

16

7

8

9

5

1211

6

10

3

1720

1514

14

13

1

Pre-cleaner(Optional)

19

18

Engine RS6-34 Telescopic HandlerAir Intake Group

20



01 136383 AIR CLEANER ASSEMBLY. . . . . . . 1(Includes items 1-6; does not include item 10)

02 137659 EJECTOR/DUST . . . . . . . . . . . . . . . 103 NSS END CAP. . . . . . . . . . . . . . . . . . . . . 104 137498 PRIMARY AIR FILTER . . . . . . . . . . 105 137501 SECONDARY AIR FILTER . . . . . . . 106 NSS HOUSING . . . . . . . . . . . . . . . . . . . . 107 103088 REDUCER, 3.84’ TO 3.25” . . . . . . . 108 L51781 CLAMP, #72 SAE . . . . . . . . . . . . . . 109 L64863 CAP, AIR INLET (standard) . . . . . . . 1

10 136443 CLAMP, AIR CLEANER MOUNT. . . 111 L50056 5/16”-18 WHIZ LOCK NUT . . . . . . . 212 650545 5/16”-18X1-1/25” BOLT . . . . . . . . . . 213 183629 GAUGE, AIR RESTRICTION . . . . . 114 L51099 CLAMP, #52 SAE . . . . . . . . . . . . . . 415 136686 ELBOW, RUBBER 90º . . . . . . . . . . 116 L67657 ELBOW, METAL 3” OD 90º . . . . . . . 117 L120041 ELBOW, RUBBER 3” ID 90º . . . . . . 218 101926 PRE-CLEANER (optional) . . . . . . . . 119 102974 REDUCER, RUBBER 4”-3.25” . . . . 120 L70467 CLAMP, 3-1/2” T-BOLT . . . . . . . . . . 2

RS6-34 Telescopic Handler EngineAir Intake Group


Muffler Bracket

FRONT

3

2

13

14

2

15

2

16

115

12

10

09

08

07

6

5

4

1

Engine RS6-34 Telescopic HandlerExhaust Group



01 210493 TAILPIPE . . . . . . . . . . . . . . . . . . . . . 102 L520005 3/8”-16 NYLON INSERT NUT . . . AR03 L60492 3” MUFFLER CLAMP . . . . . . . . . . . 104 L64764 TAILPIPE HANGER. . . . . . . . . . . . . 105 654006 3/8” FLAT WASHER . . . . . . . . . . . AR06 650490 3/8”-16X1” BOLT . . . . . . . . . . . . . AR07 L99434 TURBO CLAMP. . . . . . . . . . . . . . . . 108 105214 PIPE/ OUTLET EXHAUST . . . . . . . 109 L60492 3” MUFFLER CLAMP . . . . . . . . . . . 2

10 MUFFLER/EXHAUST PURIFIER . . 1L64821 MUFFLER (standard)L68796 CATALYTIC MUFFLER (option)

11 L50442 3/8”-16X1-1/4” SELF TAP BOLT . . . 412 L67756 MUFFLER GUARD . . . . . . . . . . . . . 113 650579 3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 114 L61021 MUFFLER STRAP. . . . . . . . . . . . . . 115 L64572 MUFFLER BRACKET . . . . . . . . . . . 116 L50705 M12-1.75X30mm BOLT. . . . . . . . . . 2

RS6-34 Telescopic Handler EngineExhaust Group


Transmission RS6-34 Telescopic HandlerExternal Components

LEFT

RIGHT5

19

6

9

8

10

11

1213

17

16

1518

13

14

1

32

20

21

22

24

23

20

17

16

15

14

21

21

23

21

4

20

20

25



01 104425 SWITCH, REVERSE PRESSURE . 1(activates back-up alarm)

L444070 ADAP., -3ORM (not shown) . . . . . . 102 L63406 HOSE, -12 DS12/A12 114” . . . . . . . 103 054819 ADAP., -10ORM -12JICM STR . . . . 104 L99184 FILTER, TRANSMISSION OIL . . . . 105 L66965 SENDER, TEMP 250 DEGREE . . . 106a L50727 M10X1.5X35mm . . . . . . . . . . . . . . . 208 L50952 M10X1.5X25mm . . . . . . . . . . . . . . 1009b L50833 3/8”-24X2” GRADE 8 BOLT . . . . . . 810 072587 ADAP., -12ORM -12JICM STR . . . . 111 075235 ADAP., -12JICM -12JICFS 90º . . . . 112 L63399 HOSE, -12 DS12/A12 82” . . . . . . . . 113 650695 5/8”-11X3-1/2” BOLT . . . . . . . . . . . . 214 L50704 M12-1.75X40mm BOLT. . . . . . . . . . 415 L64124 MOUNT, VIBRATION ISOLATOR . . 216 L64197 WASHER, ISOLATOR MOUNT. . . . 217 L520007 5/8”-11 NYLON INSERT NUT . . . . . 218 L68533 TRANS. MOUNT (right) . . . . . . . . . . 1

19 L68531 TRANS MOUNT (left) . . . . . . . . . . . 120 L99182 UNIVERSAL JOINT. . . . . . . . . . . . . 4

(includes bolts)21c L50468 3/8”-24X1-3/4” GR8 BOLT. . . . . . . 1622 L68563 DRIVESHAFT, REAR . . . . . . . . . . . 123d 650965 3/8”-24X1-1/4” GR 8 BOLT . . . . . . . 8

654026 3/8” LOCK WASHER. . . . . . . . . . . . 824 L68562 DRIVESHAFT, FRONT . . . . . . . . . . 125 210356 TRANSMISSION, 1102 T12000 . . . 1

--ITEMS NOT SHOWN---- 210909 WIRE HARNESS, BRAKE RELAY . 1

(attaches to item #1)420-35602 RELAY . . . . . . . . . . . . . . . . . . . . . . . 2

(included with 210909 harness)

a Used to fasten throttle bracket to transmission.(Refer to Engine section for throttle bracket.)

b Used to fasten flex plate to flywheel.c Used to fasten universal joint to transmission

and axle yokes.d Used to fasten universal joint to driveshaft.

HOSE LOCATOR

02 TRANSMISSION (top right side - near filter) TRANSMISSION COOLER “UPPER PORT”12 TRANSMISSION (left side - just under hyd. pump) TRANSMISSION COOLER “LOWER PORT”

RS6-34 Telescopic Handler TransmissionExternal Components Group


14

1110

3

2

158

11

12

13

12

9

11

13

32

1

5

6

74

Transmission RS6-34 Telescopic HandlerConverter Housing Group



01 L99286 HOUSING/CONVERTER . . . . . . . . 102 NSS PLUG. . . . . . . . . . . . . . . . . . . . . . . . 4

(includes item 3)03 L99284 O-Ring/Plug . . . . . . . . . . . . . . . . . . . 4

(part of item 2)04 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 105 NSS PLUG. . . . . . . . . . . . . . . . . . . . . . . . 1

(includes item 6)06 L99284 O-Ring/Plug . . . . . . . . . . . . . . . . . . . 1

(part of item 5)

07 L99262 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 609 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . . 310 L99261 SCREW . . . . . . . . . . . . . . . . . . . . . . 111 L99029 WASHER/LOCK . . . . . . . . . . . . . . 1012 L99260 SCREW . . . . . . . . . . . . . . . . . . . . . 1313 L99029 WASHER/LOCK . . . . . . . . . . . . . . 1314 L98938 GASKET/HSG. TO PLATE. . . . . . . . 115 L99249 PLUG/TEMP PICKUP . . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionConverter Housing Group


28

1415 21

20

19

1

6

26

33

32

835

349

22

5

34

18

17

3029

31

2316

2

18

17

7

36

2713

12

25

241030

29

31

2119

11

Transmission RS6-34 Telescopic HandlerCase and Plate Group



01 NSS CASE-TRANSMISSION . . . . . . . . . 102 L94824 BREATHER/AIR . . . . . . . . . . . . . . . 103 L99251 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 2

(includes item 4)04 L99013 O-RING/PLUG. . . . . . . . . . . . . . . . . 2

(part of item item 3)05 L99253 PLUG/MAGNETIC DRAIN. . . . . . . . 106 L98927 PIN/DOWEL PLATE TO CASE . . . . 207 L98926 GASKET/PLATE TO CASE . . . . . . . 108 L98185 RING/TUBE SEAL. . . . . . . . . . . . . . 109 L98176 CLIP/OIL TUBE RETAINER . . . . . . 110 102949 PLATE, SPACER. . . . . . . . . . . . . . . 111 L98935 SEAT/SAFETY VALVE . . . . . . . . . . 112 L98932 SNAP RING. . . . . . . . . . . . . . . . . . . 113 L98226 POPPET/SAFETY VALVE . . . . . . . . 114 L98218 SPRING. . . . . . . . . . . . . . . . . . . . . . 115 L98217 WASHER/POPPET . . . . . . . . . . . . . 116 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 117 NSS PLUG. . . . . . . . . . . . . . . . . . . . . . . . 3

18 L99284 O-RING/PLUG. . . . . . . . . . . . . . . . . 319 L99018 SCREW . . . . . . . . . . . . . . . . . . . . . . 720 L99045 SCREW . . . . . . . . . . . . . . . . . . . . . . 221 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 922 L98184 ASSY/TUBE & SCREEN. . . . . . . . . 123 L99274 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 124 L99246 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 125 L99262 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 126 L99270 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 127 L98734 TUBE/TRANS DIPSTICK . . . . . . . . 128 L98735 TRANS DIPSTICK TUBE . . . . . . . . 129 L99287 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 230 L99312 O-RING . . . . . . . . . . . . . . . . . . . . . . 231 L99288 SCREW . . . . . . . . . . . . . . . . . . . . . . 232 L99285 SCREW . . . . . . . . . . . . . . . . . . . . . . 133 L99294 WASHER/SEAL. . . . . . . . . . . . . . . . 134 L99295 WASHER/SCREW. . . . . . . . . . . . . . 135 L99296 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionCase and Plate Group


10

11

13

9

8

13

16

6

14

3

2

1

5

4

6

12

15

7

Transmission RS6-34 Telescopic HandlerTorque Converter Group



01 L98203 ASSY/STATOR SUPPORT . . . . . . . 102 L98204 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L98197 BEARING/FRONT . . . . . . . . . . . . . . 104 L98201 RING/PISTON . . . . . . . . . . . . . . . . . 105 L98202 EXPANDER/RING . . . . . . . . . . . . . . 106 L98200 RING/SNAP. . . . . . . . . . . . . . . . . . . 207 L98194 SEAL/OIL CONV. HSG. . . . . . . . . . . 108 L500294 ASSY/TORQUE CONVERTER . . . . 1

09 L98189 PLUG/BORE . . . . . . . . . . . . . . . . . . 110 L97525 O-RING/BORE PLUG . . . . . . . . . . . 111 L97526 RING/RET. BORE PLUG. . . . . . . . . 112 L98199 IMPELLER/HUB GEAR . . . . . . . . . . 113 L98191 SNAP RING/IMPELLER HUB . . . . . 214 L98205 WASHER/HUB GEAR . . . . . . . . . . . 115 L98198 BEARING/TORQUE CONVERTER. 116 L98196 RING/OIL DISTRIBUTOR . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionTorque Converter Group


13

12

11

9

104 6

5

13

2

15

148

7

16

Transmission RS6-34 Telescopic HandlerGear Group



01 NSS ASSY/REV. GEAR & BEARING . . . 1(includes items 2 and 3)

02 L98253 BEARING/NEEDLE . . . . . . . . . . . . . 2(part of item 1)

03 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1(part of item 1)

04 NSS ASSY/FOR. GEAR & BEARING . . . 1(includes items 5 and 6)


06 L98254 SPACER/CLUTCH GEAR . . . . . . . . 1(part of item 4)

07 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 1(includes item 8)

08 L500408 BEARING-3RD CLUTCH GEAR . . . 2(part of item 7)

09 L98968 1st CLUTCH GEAR/BRG. ASSY . . . 1(includes item 9)


11 L98276 2nd CLUTCH GEAR/BRG. ASSY . . 1(includes item 12)


13 L98277 GEAR/THIRD DRIVEN - 18T . . . . . 114 L98284 GEAR/OUTPUT SHAFT - 40T . . . . 115 L98955 GEAR/REVERSE IDLER - 28T . . . . 116 L500409 GEAR/FIRST DRIVEN - 27T. . . . . . 1

RS6-34 Telescopic Handler TransmissionGear Group



01 L98945 IDLER/SHAFT & PIN. . . . . . . . . . . . 1(includes item 2)

02 L98947 ROLL PIN . . . . . . . . . . . . . . . . . . . . 1(part of item1)

03 L98944 GEAR/IDLER,PUMP DRIVE . . . . . . 1

04 L98943 BEARING/IDLER GEAR . . . . . . . . . 105 L98211 GEAR/DRIVE. . . . . . . . . . . . . . . . . . 106 L98942 WASHER/THRUST . . . . . . . . . . . . . 207 L98212 RING/SNAP. . . . . . . . . . . . . . . . . . . 1

5

1

6

7

6

4

3

2

Transmission RS6-34 Telescopic HandlerDrive Pump Group



01 L98220 PUMP/T12000 CHARGE. . . . . . . . . 102 L99184 ASSY/ HYDRAULIC SPIN FILTER . 103 L98953 SLEEVE. . . . . . . . . . . . . . . . . . . . . . 104 L98950 PISTON . . . . . . . . . . . . . . . . . . . . . . 105 L98951 SPRING. . . . . . . . . . . . . . . . . . . . . . 106 L98224 PIN/CLARK TRANS. . . . . . . . . . . . . 107 L98949 ASSY/BALL CHECK VALVE . . . . . . 1

(includes items 8 thru 11)08 L98215 BALL . . . . . . . . . . . . . . . . . . . . . . . . 109 L98216 SPRING. . . . . . . . . . . . . . . . . . . . . . 110 L98214 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1

11 L98948 O-RING . . . . . . . . . . . . . . . . . . . . . . 112 L98219 GASKET/CHARGE PUMP . . . . . . . 113 L99025 SCREW . . . . . . . . . . . . . . . . . . . . . . 414 L99023 SCREW . . . . . . . . . . . . . . . . . . . . . . 115 L99020 WASHER/LOCK . . . . . . . . . . . . . . . 516 L99027 SCREW . . . . . . . . . . . . . . . . . . . . . . 117 L99029 WASHER/LOCK . . . . . . . . . . . . . . . 1

--ITEMS NOT SHOWN---- L98954 ASSY/FILTER MOUNT . . . . . . . . . . 1

(includes items 3-6)

3

6

54

2

17

16

131415

1

12

10

9

8

7

11

RS6-34 Telescopic Handler TransmissionCharge Pump Group

Transmission Charge Pump;not to be confused with the

hydraulic system pump


2

95

7

6

4

8

3

1

Transmission RS6-34 Telescopic HandlerReverse Idler Group



01 L98229 SHAFT IDLER & PILOT . . . . . . . . . 102 L98228 RING/SNAP. . . . . . . . . . . . . . . . . . . 103 L98231 BEARING/REV IDLR GEAR . . . . . . 104 L98230 WASHER/THRUST . . . . . . . . . . . . . 1

05 L98232 END PLATE. . . . . . . . . . . . . . . . . . . 106 L99031 CAPSCREW . . . . . . . . . . . . . . . . . . 107 L99032 WASHER . . . . . . . . . . . . . . . . . . . . . 108 L98233 END PLATE. . . . . . . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionReverse Idler Group


16

17

18

19

20

17

16

17

17

19

3

2

4

9

8

151413

12

1

7

6

5

10

17

1617

9

8

15

1413

12

11

1716

1719

2019

21

22

7

11

105

6

Transmission RS6-34 Telescopic HandlerForward and Reverse Group



01 L98248 ASY/TURB SHFT DRUM & PLUG . 102 L98251 SLEEVE/OIL DISTRIBUTOR. . . . . . 103 L98252 SCREW . . . . . . . . . . . . . . . . . . . . . . 104 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 305 L99278 ASY/PISTON . . . . . . . . . . . . . . . . . . 2

(includes items 6 and 7)06 L98246 SEAL/OUTER PISTON . . . . . . . . . . 2

(part of item 5)07 L98247 SEAL/INNER PISTON. . . . . . . . . . . 2

(part of item 5) 08 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 209 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 210 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 211 L98961 ASY/DISC SPRING Pkg 5. . . . . . . . 2

12 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 213 L98241 RETAINER/SNAP RING . . . . . . . . . 214 L98240 CLUTCH/OUTER FWD . . . . . . . . . 1215 L98239 CLUTCH/INNER FWD. . . . . . . . . . 1216 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 417 L98235 WASHER/THRUST . . . . . . . . . . . . . 818 L98249 BEARING/REAR . . . . . . . . . . . . . . . 119 L98253 BEARING/CLUTCH GEAR . . . . . . . 420 L98254 SPACER/CLUTCH GEAR . . . . . . . . 221 L98962 ASSY/REV. AND BRG. . . . . . . . . . . 1

(includes items 19 and 20)22 L98255 ASSY/FOR. GEAR AND BRG. . . . . 1

(includes items 19 and 20)

RS6-34 Telescopic Handler TransmissionForward and Reverse Group


7

34

2421

1

10

5

1920

2222

23

2019

2021

1413

12

11

1817

16

15

8

9

6

20

221

Transmission RS6-34 Telescopic HandlerThird Shaft Group



01 L500410 ASY-3RD SHAFT, DRUM & PLUG . 102 L500411 BEARING-ROLLER. . . . . . . . . . . . . 103 L500273 ASSY/BEARING & SEAL . . . . . . . . 104 L500412 WASHER-BEARING SUPPORT . . . 105 L98258 SLEEVE/OIL DISTRIBUTOR. . . . . . 106 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 107 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 208 L99279 ASSY/CLTCH PISTON & BALL. . . . 109 L98246 SEAL/OUTER PISTON . . . . . . . . . . 110 L98247 SEAL/INNER PISTON. . . . . . . . . . . 111 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 512 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 5

13 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 114 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 115 L98244 RING/SNAP. . . . . . . . . . . . . . . . . . . 116 L98961 ASY/DISC SPRG PKG 5. . . . . . . . . 117 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 118 L98241 RETAINER/SNAP RING . . . . . . . . . 119 L500413 BEARING-THRUST NEEDLE . . . . . 220 L500414 WASHER/CLTCH GEAR THRUST . 421 L99696 RING/SNAP. . . . . . . . . . . . . . . . . . . 322 L500408 BEARING-3RD CLUTCH GEAR . . . 223 L500407 ASY. 3RD CLUTCH GEAR . . . . . . . 124 L500408 GEAR-FIRST DRIVEN . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionThird Shaft Group


65

10

12

1314

20

218

915

16

25

24

15

16

3

418

19

17

15

16

24

26

15

16

98

2322

14

11

13

10

5

6

71

7

27

2

Transmission RS6-34 Telescopic HandlerFirst and Second Shaft Group



01 L98274 ASY-1ST 2ND SHAFT. . . . . . . . . . . 102 L98275 BEARING/REAR . . . . . . . . . . . . . . . 103 L500273 ASSY/BEARING & SEAL . . . . . . . . 104 L98250 RING/PISTON . . . . . . . . . . . . . . . . . 205 L99038 PISTON/CLUTCH & SEALS . . . . . . 206 L98246 SEAL/OUTER PISTON . . . . . . . . . . 207 L98247 SEAL/INNER PISTON. . . . . . . . . . . 208 L98238 PLATE/END . . . . . . . . . . . . . . . . . . . 209 L98237 RING/SNAP. . . . . . . . . . . . . . . . . . . 210 L98244 PLATE/WEAR . . . . . . . . . . . . . . . . . 211 L98961 ASSY/DISC SPRG PKG 5 . . . . . . . 112 L98967 SPRING/DISC ASSY PKG (7). . . . . 113 L98242 RETAINER. . . . . . . . . . . . . . . . . . . . 214 L98241 RETAINER/SNAP RING . . . . . . . . . 215 L98236 BEARING. . . . . . . . . . . . . . . . . . . . . 4

16 L98235 WASHER/THRUST . . . . . . . . . . . . . 817 L98260 RING/SNAP. . . . . . . . . . . . . . . . . . . 218 L98272 SLEEVE/OIL DISTRIBUTOR. . . . . . 119 L98257 SCREW/SLEEVE LOCK . . . . . . . . . 120 L98240 CLUTCH/OUTER FWD . . . . . . . . . 1021 L98239 CLUTCH/INNER FWD. . . . . . . . . . 1022 L98240 CLUTCH/OUTER FWD . . . . . . . . . . 523 L98239 CLUTCH/INNER FWD. . . . . . . . . . . 524 L98253 BEARING/CLUTCH GEAR . . . . . . . 425 L98968 1ST CLUTCH GEAR/BRG ASSY . . 1

(includes item 24)26 L98276 2ND CLUTCH GEAR/BRG ASSY . . 1

(includes item 24)27 L98277 GEAR/3RD DRIVEN . . . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionFirst and Second Shaft Group


Transmission RS6-34 Telescopic HandlerOutput Shaft Group

1

6

45

32

6

7

62

35

46

8

9


01 L500274 SHAFT/OUTPUT . . . . . . . . . . . . . . . 102 L98282 BEARING/SHAFT . . . . . . . . . . . . . . 203 L98281 SLEEVE/OIL SEAL . . . . . . . . . . . . . 204 L98268 O-RING/SLEEVE. . . . . . . . . . . . . . . 205 L96053 SEAL/OUTPUT SHAFT OIL . . . . . . 2

06 L98264 RING/SNAP. . . . . . . . . . . . . . . . . . . 407 L98266 RING/SNAP. . . . . . . . . . . . . . . . . . . 208 L98279 FLANGE/OUTPUT & PLUG ASSY . 109 L98278 PLUG/FLANGE . . . . . . . . . . . . . . . . 1


12

11

1

10

9 87

2

6

54 3


01 102950 SOLENOID, W / DEUTSCH CON. . 4(includes items 2 thru 5)

02 102951 O-RING, 21.5 X 1.5MM . . . . . . . . . . 4(included with item 1)

03 102952 O-RING, 15.1 X 1.60MM . . . . . . . . . 4(included with item 1)



06 102955 PLUG, SOLENOID BORE . . . . . . . . 1(includes items 7, 8 and 9)




10 102957 CLAMP, SOLENOID . . . . . . . . . . . . 611 106259 CAPSCREW . . . . . . . . . . . . . . . . . 1212 102959 WASHER, PLAIN. . . . . . . . . . . . . . 12

RS6-34 Telescopic Handler TransmissionControl Group


6

5

4

3

2

2

1


01 NSS ASSY/DRIVE PLATE. . . . . . . . . . . . 1(included in item 6)

02 NSS DRIVE PLATE . . . . . . . . . . . . . . . . . 2(included in item 6)

03 L98316 RING/DRIVE PLATE BACKING . . . 1

04 L99785 SCREW/DRIVE PLATE MNTG . . . . 605 L99030 LOCKWASHER/DRIVEPLATE . . . . 606 L98317 KIT/DRIVE PLATE ASSY . . . . . . . . 1

(includes items 1 thru 5)

Transmission RS6-34 Telescopic HandlerDrive Plate Group


1

14

7

6

10

11

13

12

9

5

4

3

8

2

15


01 L98291 HOUSING MODULATOR VALVE . . 102 L98292 O-RING . . . . . . . . . . . . . . . . . . . . . . 103 L98294 SPRING INNER. . . . . . . . . . . . . . . . 104 L98295 SPRING MIDDLE . . . . . . . . . . . . . . 105 L98304 SPRING OUTER . . . . . . . . . . . . . . . 106 L98298 SLEEVE-MODULATION VALVE . . . 107 L98307 O-RING . . . . . . . . . . . . . . . . . . . . . . 108 L98293 PIN STOP . . . . . . . . . . . . . . . . . . . . 1

09 L98303 SPOOL ACCUMULATOR . . . . . . . . 110 L98958 SPOOL . . . . . . . . . . . . . . . . . . . . . . 111 L98300 SPRING. . . . . . . . . . . . . . . . . . . . . . 112 L98302 RETAINER. . . . . . . . . . . . . . . . . . . . 113 L98301 SPACER . . . . . . . . . . . . . . . . . . . . . 114 L98956 PIN-UPPER . . . . . . . . . . . . . . . . . . . 115 L98957 PIN-LOWER . . . . . . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler TransmissionModulation Valve Group


1

1213

14

15

11

10

9

7

4

32

17

18

19

16

20

22

Front axle (shown)

LEFT

RIGHT

AXLE MODEL ANDSERIAL NUMBER PLATE

Axle RS6-34 Telescopic HandlerExternal Components

Driveshaftsare on

page 52.



01 NSS TIRE AND WHEEL ASY . . . . . . . . ARL63222 VALVE STEM . . . . . . . . . . . . . . . . ARNSS TIRE, 15.00X19.5 12 PLYL68875 WHEEL ONLY (for above tire) . . . ARNSS TIRE, 9.00R 20XMINE D2L67504 WHEEL ONLY (for above tire) . . . AR

02a L50253 3/8”-16 BUTTON HD BOLT. . . . . . . 603a L99951 FENDER . . . . . . . . . . . . . . . . . . . . . 104a 105857 FENDER MOUNT . . . . . . . . . . . . . . 107a 102587 M12-1.5 NUT . . . . . . . . . . . . . . . . . . 409 L50201 M20-2.5 CLASS 10 LOCK NUT . . . 410 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 811 210569 FRAME LEVEL MNT (front axle). . . 112 L69734 M22-1.5 WHEEL NUT . . . . . . . . . AR13 L50084 3/4”-10 GR8 LOCK NUT . . . . . . . . . 8

14 210572 PLATE, FRAME LEVEL. . . . . . . . . . 115 651543 M20-2.50X130 C10.9 BOLT . . . . . . 416 L500543 THRUST BUSHING. . . . . . . . . . . . . 217 L500544 SUPPORT . . . . . . . . . . . . . . . . . . . . 218 L98355 GREASE FITTING. . . . . . . . . . . . . . 219 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 220 L500542 REDUCTION BUSING . . . . . . . . . . 421 NA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 022b AXLE ASSEMBLY, 212

102668 FRONT (with internal park brake) . . 1L68849 REAR. . . . . . . . . . . . . . . . . . . . . . . . 1

a Available only on the front axle: left side.b Axle assembly only—does not include any other

items shown in the illustration.

RS6-34 Telescopic Handler AxleExternal Components



01 ARTICULATED TIE ROD . . . . . . . . 1(Right [Front Axle], Left [Rear Axle])

L500546 Note a and d50220265 Note b and c

02 STEER CYLINDER . . . . . . . . . . . . . 150220264 Note cL500540 Note d

SEAL KIT . . . . . . . . . . . . . . . . . . . . . 150220267 Note cL500943 Note dL500539 STEER CYLINDER BOLT . . . . . . . 4

(not shown)

03 ARTICULATED TIE ROD . . . . . . . . 1(Left [Front Axle], Right [Rear Axle])

L500541 Note a and c50220266 Note b and d

a L99969 Tie Rod Nut and Pin Kitb 50220268 Tie Rod Nutc Axle SN R-ITA-73643 and up d Axle SN R-ITA-73642 and before

LEFT

RIGHT

3

1

2

Axle RS6-34 Telescopic HandlerFront Axle - Steer Cylinder and Tie Rods Group


LEFT

RIGHT

3

1

2

RS6-34 Telescopic Handler AxleRear Axle - Steer Cylinder and Tie Rods Group


01 ARTICULATED TIE ROD . . . . . . . . 1(Right [Front Axle], Left [Rear Axle])

L500546 Note a and d50220265 Note b and c

02 STEER CYLINDER . . . . . . . . . . . . . 150220264 Note cL500540 Note d

SEAL KIT . . . . . . . . . . . . . . . . . . . . . 150220267 Note cL500943 Note dL500539 STEER CYLINDER BOLT . . . . . . . 4

(not shown)

03 ARTICULATED TIE ROD . . . . . . . . 1(Left [Front Axle], Right [Rear Axle])

L500541 Note a and c50220266 Note b and d

a L99969 Tie Rod Nut and Pin Kitb 50220268 Tie Rod Nutc Axle SN R-ITA-73643 and up d Axle SN R-ITA-73642 and before



01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 302 L500451 INTERMEDIATE COVER . . . . . . . . 103 102573 HOUSING . . . . . . . . . . . . . . . . . . . . 104 104518 COVER . . . . . . . . . . . . . . . . . . . . . . 105 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 1

06 NA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 007 102575 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 109 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 1

Axle RS6-34 Telescopic HandlerFront Axle - Differential Housing Group


01 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 302 L500451 INTERMEDIATE COVER . . . . . . . . 103 L500452 HOUSING . . . . . . . . . . . . . . . . . . . . 104 L500453 COVER . . . . . . . . . . . . . . . . . . . . . . 1

05 L500454 VENT . . . . . . . . . . . . . . . . . . . . . . . . 106 L500455 SEAL WASHER. . . . . . . . . . . . . . . . 207 L98318 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 108 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 1

6

4

8

7

653

1

2

1

1


RS6-34 Telescopic Handler AxleRear Axle - Differential Housing Group



01 102617 SPACER . . . . . . . . . . . . . . . . . . . . . 202 102618 SPRING. . . . . . . . . . . . . . . . . . . . . . 403 102619 PISTON . . . . . . . . . . . . . . . . . . . . . . 204 102620 O-RING . . . . . . . . . . . . . . . . . . . . . . 205 102621 O-RING . . . . . . . . . . . . . . . . . . . . . . 406 102622 BACKUP RING . . . . . . . . . . . . . . . . 407 102623 COVER . . . . . . . . . . . . . . . . . . . . . . 208 L98368 O-RING . . . . . . . . . . . . . . . . . . . . . . 209 102624 BACKUP RING . . . . . . . . . . . . . . . . 210 102625 PISTON . . . . . . . . . . . . . . . . . . . . . . 211 102626 INTERMEDIATE BRAKE DISC . . . . 212 102627 SPRING. . . . . . . . . . . . . . . . . . . . . . 613 102628 ADJUSTING BOLT . . . . . . . . . . . . . 614 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 6

15 L500536 INTERMEDIATE BRAKE DISC . . . . 616 103390 SPACER . . . . . . . . . . . . . . . . . . . . . 217 103391 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 418 103392 ADJUSTING BOLT . . . . . . . . . . . . . 619 102632 SPRING. . . . . . . . . . . . . . . . . . . . . . 620 102633 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 421 102634 LOCK WASHER . . . . . . . . . . . . . . . 422 104655 BLEEDING BOLT . . . . . . . . . . . . . . 423 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 424 102635 SHIM (2mm) . . . . . . . . . . . . . . . . . . 2

102636 SHIM (3mm) . . . . . . . . . . . . . . . . . . 2102637 SHIM (5mm) . . . . . . . . . . . . . . . . . . 2

25 104621 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 426 104607 SEAL WASHER. . . . . . . . . . . . . . . . 4

1

2

3

4

5

6

2322

25

26

7 89

10

11

1213

19

18

14

1516

24

21 2017

Axle RS6-34 Telescopic HandlerFront Axle - Brake Group

10

1

14

23

45

6

7

12

11

9

8

13



01 L500527 BRAKE DISC. . . . . . . . . . . . . . . . . . 602 L500528 ADJUSTING BOLT . . . . . . . . . . . . . 603 L500529 SPRING. . . . . . . . . . . . . . . . . . . . . . 604 NSS PISTON . . . . . . . . . . . . . . . . . . . . . . 205 L500531 SPRING. . . . . . . . . . . . . . . . . . . . . . 606 L500532 BACK-UP RING. . . . . . . . . . . . . . . . 207 L500533 O-RING . . . . . . . . . . . . . . . . . . . . . . 208 L500534 BACK-UP RING. . . . . . . . . . . . . . . . 2

09 L500535 O-RING . . . . . . . . . . . . . . . . . . . . . . 210 L500536 INTERMEDIATE BRAKE DISC . . . . 811 104655 BLEEDING BOLT . . . . . . . . . . . . . . 212 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 213 L500537 DOWEL . . . . . . . . . . . . . . . . . . . . . . 214 L500538 PISTON . . . . . . . . . . . . . . . . . . . . . . 2

(includes items 3,4, 6-9)

RS6-34 Telescopic Handler AxleRear Axle - Brake Group


26

25

24

2321

20

16

1514

1312

11

8

54

5

36

12

9

23

24

29

27

33

4544

43

42

41

36

3938

3635

19

18

30, 31

28 29

27

10

46

51

40

34

5049 848

47

7

22

32

3717

Axle RS6-34 Telescopic HandlerFront Axle - Outer End Group

FRONT

31

30FRONT AXLE



01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 202 L500484 BOLT . . . . . . . . . . . . . . . . . . . . . . . . 203 103394 BOLT . . . . . . . . . . . . . . . . . . . . . . . 2404 102614 STUD. . . . . . . . . . . . . . . . . . . . . . . . 805 L500487 WASHER . . . . . . . . . . . . . . . . . . . . 3206 102615 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 807 103393 AXLE CASE. . . . . . . . . . . . . . . . . . . 208 102575 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 409 102576 MAGNET PLUG. . . . . . . . . . . . . . . . 210 L500488 REDUCTION BUSHING (set) . . . . . 211 L98372 SNAP RING. . . . . . . . . . . . . . . . . . . 212 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 213 L98371 BALL BEARING. . . . . . . . . . . . . . . . 214 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 215 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 216 103395 JOINT . . . . . . . . . . . . . . . . . . . . . . . 217 NSS (included as part of item 18) . . . . . . 018 105958 SEAL/DUST EXCLUDER . . . . . . . . 219 L500492 THRUST BUSHING. . . . . . . . . . . . . 220 102587 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 521 102583 WASHER . . . . . . . . . . . . . . . . . . . . . 822 102893 STUD. . . . . . . . . . . . . . . . . . . . . . . . 823 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 424 L98355 GREASE FITTING. . . . . . . . . . . . . . 425 103398 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 226 L500523 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2

L500524 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2L500525 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2

27 NSS (not used on this axle) . . . . . . . . . . . 028 103396 BUSHING . . . . . . . . . . . . . . . . . . . . 229 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 430 L500501 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 19)31 L500504 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 19)32 L500498 PIVOT PIN (set). . . . . . . . . . . . . . . . 233 L500500 BEARING. . . . . . . . . . . . . . . . . . . . . 234 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1235 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 236 104604 BEARING. . . . . . . . . . . . . . . . . . . . . 437 102601 WHEEL STUD . . . . . . . . . . . . . . . . 1638 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 239 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 240 L500519 SNAP RING. . . . . . . . . . . . . . . . . . . 241 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 242 L500510 RING GEAR SUPPORT . . . . . . . . . 243 L500522 LOCKING PLATE . . . . . . . . . . . . . . 244 104600 SNAP RING. . . . . . . . . . . . . . . . . . . 845 104641 PLANET GEAR . . . . . . . . . . . . . . . . 846 104642 BEARING. . . . . . . . . . . . . . . . . . . . . 847 103399 PLANET GEAR CARRIER . . . . . . . 248 104504 COUNTERSUNK BOLT. . . . . . . . . . 449 103401 PLANET GEAR CARRIER . . . . . . . 2

(includes items 41-48)50 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 1651 L500517 STUD. . . . . . . . . . . . . . . . . . . . . . . 16

RS6-34 Telescopic Handler AxleFront Axle - Outer End Group


Axle RS6-34 Telescopic HandlerFront Axle - Differential Group



01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 102 L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L98414 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 104 L98380 TAPER ROLLER BEARING . . . . . . 205 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 206 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 407 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 208 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1209 L500468 FRICTION WASHER. . . . . . . . . . . . 210 DIFFERENTIAL SIDE GEAR . . . . . .

L500469 Note a . . . . . . . . . . . . . . . . . . . . . . . 2105266 Note b (DIFF. SIDE GEAR KIT) . . . 1

11 103402 PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 412 L500471 SNAP RING. . . . . . . . . . . . . . . . . . . 413 L500472 FRICTION WASHER. . . . . . . . . . . . 4

14 DIFFERENTIAL PINION GEAR . . . . L500473 Note a . . . . . . . . . . . . . . . . . . . . . . . 4105266 Note b (DIFF. SIDE GEAR KIT) . . . 1

15 L500474 DIFFERENTIAL CARRIER . . . . . . . 116 L500475 TAPER ROLLER BEARING . . . . . . 217 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1


18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 119 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 120 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 122 102863 FLANGE . . . . . . . . . . . . . . . . . . . . . 123 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 124 L500481 SNAP RING. . . . . . . . . . . . . . . . . . . 4

a For axle SN I-ITA-728844 and before.

b For axle SN I-ITA-728845 and up; Differential GearKit #105266 includes 2 of item #10 (L500469)and 4 of item #14 (L500473).

RS6-34 Telescopic Handler AxleFront Axle - Differential Group


46

2728

29

3031

2832

43

33 3435

3650 37

38

4142

40 3925

25

44 48

2019

1318

16

15

24

2

1 45

3

15161749

1921,26

12

2

1

4

1122

10

5

96

7814

13

FRONT

47

Axle RS6-34 Telescopic HandlerRear Axle - Outer End Group

FRONT 21

26

REAR AXLE



01 L500483 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 202 L500484 STEERING ADJUST BOLT . . . . . . . 203 L500485 AXLE CASE. . . . . . . . . . . . . . . . . . . 204 L500486 BOLT . . . . . . . . . . . . . . . . . . . . . . . 3205 L500488 REDUCTION BUSHING . . . . . . . . . 2

(includes items 6-9, and 47)06 L500489 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 207 L98371 BALL BEARING. . . . . . . . . . . . . . . . 207 L98372 SNAP RING. . . . . . . . . . . . . . . . . . . 209 L500490 O-RING . . . . . . . . . . . . . . . . . . . . . . 210 L500491 JOINT . . . . . . . . . . . . . . . . . . . . . . . 211 L500492 THRUST BUSHING. . . . . . . . . . . . . 2

(included with items 21 and 26)12 L500493 OUTER RACE . . . . . . . . . . . . . . . . . 213 L500494 BOLT . . . . . . . . . . . . . . . . . . . . . . . 2014 L500495 COVER . . . . . . . . . . . . . . . . . . . . . . 215 L500496 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 416 L98355 GREASE FITTING. . . . . . . . . . . . . . 217 L500497 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 2

(includes item 16)18 L500498 PIVOT PIN. . . . . . . . . . . . . . . . . . . . 2

(includes items 16, 19 and 20)19 L500499 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 220 L500500 ARTICULATION. . . . . . . . . . . . . . . . 221 L500501 STEERING CASE . . . . . . . . . . . . . . 1

(includes item 11)22 105958 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 224 102576 MAGNETIC PLUG. . . . . . . . . . . . . . 225 L98318 PLUG. . . . . . . . . . . . . . . . . . . . . . . . 4

26 L500504 STEERING CASE . . . . . . . . . . . . . . 1(includes item 11)

27 L500505 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 228 104604 BEARING. . . . . . . . . . . . . . . . . . . . . 429 L500507 WHEEL STUD . . . . . . . . . . . . . . . . 1630 L500508 WHEEL HUB . . . . . . . . . . . . . . . . . . 231 L98417 O-RING . . . . . . . . . . . . . . . . . . . . . . 232 L500509 RING GEAR . . . . . . . . . . . . . . . . . . 233 L500510 RING GEAR SUPPORT . . . . . . . . . 234 104600 SNAP RING. . . . . . . . . . . . . . . . . . . 835 104641 PLANET GEAR . . . . . . . . . . . . . . . . 836 104642 BEARING. . . . . . . . . . . . . . . . . . . . . 837 L69734 WHEEL NUT . . . . . . . . . . . . . . . . . 1638 L500455 SEAL WASHER. . . . . . . . . . . . . . . . 639 104504 COUNTERSUNK BOLT. . . . . . . . . . 440 L500516 PLANET GEAR CARRIER . . . . . . . 241 L500517 STUD. . . . . . . . . . . . . . . . . . . . . . . 1642 L500518 NUT . . . . . . . . . . . . . . . . . . . . . . . . 1643 L500519 SNAP RING. . . . . . . . . . . . . . . . . . . 244 104546 ADJUSTING BOLT (includes #45) . 445 NSS NUT (included with item #44) . . . . . 446 L500522 LOCKING PLATE . . . . . . . . . . . . . . 247 L98373 SNAP RING. . . . . . . . . . . . . . . . . . . 248 L500555 SPACER . . . . . . . . . . . . . . . . . . . . . 249 L500523 SHIM - .15mm . . . . . . . . . . . . . . . . . 2

L500524 SHIM - .20mm . . . . . . . . . . . . . . . . . 2L500525 SHIM - .50mm . . . . . . . . . . . . . . . . . 2

50 103401 PLANET GEAR CARRIER . . . . . . . 2(includes items 32-36, 40-41)

RS6-34 Telescopic Handler AxleRear Axle - Outer End Group


12

15

4

7

5

924

3

17

1618

2

16

20

21

19

22

1

23

1411

65

413

1313

14

12

24

11

24

1310

12

11

7 8

11912

24

Axle RS6-34 Telescopic HandlerRear Axle - Differential Group


01 L500457 O-RING . . . . . . . . . . . . . . . . . . . . . . 102 L98415 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

L500459 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500460 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L500461 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1L98414 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1

03 L500463 BEVEL GEAR SET . . . . . . . . . . . . . 104 L98380 TAPER ROLLER BEARING . . . . . . 205 L500464 RING NUT . . . . . . . . . . . . . . . . . . . . 206 L500465 CYLINDER BOLT . . . . . . . . . . . . . . 407 L500466 CYLINDER BOLT . . . . . . . . . . . . . . 208 L500467 BOLT . . . . . . . . . . . . . . . . . . . . . . . 1209 L500468 FRICTION WASHER. . . . . . . . . . . . 210 DIFFERENTIAL SIDE GEAR . . . . . .

L500469 Note a . . . . . . . . . . . . . . . . . . . . . . . 2105266 Note b (DIFF. SIDE GEAR KIT) . . . 1

11 L500470 PIN W/CLIP (includes item 12) . . . . 412 L500471 SNAP RING. . . . . . . . . . . . . . . . . . . 413 L500472 FRICTION WASHER. . . . . . . . . . . . 4

14 DIFFERENTIAL PINION GEAR . . . . L500473 Note a . . . . . . . . . . . . . . . . . . . . . . . 4105266 Note b (DIFF. SIDE GEAR KIT) . . . 1

15 L500474 DIFFERENTIAL CARRIER . . . . . . . 116 L500771 TAPER ROLLER BEARING . . . . . . 217 L98404 SHIM . . . . . . . . . . . . . . . . . . . . . . . . 1


18 L500478 SPACER . . . . . . . . . . . . . . . . . . . . . 119 L98396 RING NUT . . . . . . . . . . . . . . . . . . . . 120 L98395 SEAL . . . . . . . . . . . . . . . . . . . . . . . . 121 L98394 COVERPLATE. . . . . . . . . . . . . . . . . 122 102863 FLANGE . . . . . . . . . . . . . . . . . . . . . 123 L500480 NUT . . . . . . . . . . . . . . . . . . . . . . . . . 124 L500481 SNAP RING. . . . . . . . . . . . . . . . . . . 4

a For axle SN I-ITA-728826 and before.

b For axle SN I-ITA-728827 and up; Differential GearKit #105266 includes 2 of item #10 (L500469)and 4 of item #14 (L500473).


RS6-34 Telescopic Handler AxleRear Axle - Differential Group


FRONT

REAR

26

4

32

22

23

24

25

27

282927

1

33

353410

32

27

3130

171819

15

16

20

1413

15

21

7

6

5

25

10

89

1211

43

B

36

42

Boom RS6-34 Telescopic HandlerOuter Boom Section

45

44



01 L68350 OUTER SECT. WELDMENT . . . . . . 102 L70242 5/16”-18 NUTSERT . . . . . . . . . . . . . 203 L65640 PLATE, BOOM ANGLE IND. . . . . . . 104 654004 5/16” FLAT WASHER . . . . . . . . . . . 205 L52048 5/16”-18X1” BTNHD BOLT . . . . . . . 206 L65638 INCLINOMETER-ANGLE IND. . . . . 107 L50491 #8X5/8” RND HD MACH.SCREW. . 208 L50380 1/2”-20X1-1/4” BOLT . . . . . . . . . . . . 209 654030 1/2” LOCK WASHER. . . . . . . . . . . . 210 655001 PIN, COTTER 1/16”X3/4” . . . . . . . . 611 L63169 PIN, OUTER BOOM CLEVIS . . . . . 112 L63173 CLEVIS, OUTER BOOM . . . . . . . . . 113 L63131 REAR OUTER COVER . . . . . . . . . . 114 L50226 5/16”-18X1” SELF TAP SCREW . . . 415 L68006 BUSHING 2.5IDX2.75ODX4” . . . . . 216 L68003 LIFT CYL. PIVOT BUSHING. . . . . . 217 L520004 5/16”-18 NYLON INSERT NUT . . . . 418 L50878 5/16”-18X3” STUD. . . . . . . . . . . . . . 419 L68358 CUSHION TOP PLATE . . . . . . . . . . 220 L68348 .88 HOSE CUSHION SINGLE . . . . 421 L63099 PIN, PIVOT PIN. . . . . . . . . . . . . . . . 1

L50462 1/2”-13X5 BOLT . . . . . . . . . . . . . . . 1L520019 1/2”-13 NYLON INSERT NUT . . . . . 1

22 L63694 EXT. CYL. BRACKET . . . . . . . . . . . 1650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2654026 3/8” LOCK WASHER. . . . . . . . . . . . 2

23 L61708 SLIDE PAD 5/8”X4”X6” . . . . . . . . . . 224 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 225 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . . 6

26 650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 227 654026 3/8” LOCK WASHER. . . . . . . . . . . 1228 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 429 L62733 SHIM .06”X3”X4” . . . . . . . . . . . . . . . 230 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 431 L64143 SHIM 1/2”X3”X4” . . . . . . . . . . . . . . . 232 650533 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 433 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 234a L63166 CLEVIS, CHAIN ADJUSTMENT . . . 235 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 436 L71748 TOP CLAMP PLATE . . . . . . . . . . . . 137b 103333 BRACKET, LIGHT MOUNT . . . . . . . 138b L70040 WORK LIGHT . . . . . . . . . . . . . . . . . 239b 654006 3/8” FLAT WASHER . . . . . . . . . . . . 440b 090666 3/8”-16 WHIZ LOCK NUT . . . . . . . . 441b 650491 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 242 103330 CLAMP, BOOM HOSES . . . . . . . . AR43 103331 CLAMP, BOOM W/INSERT . . . . . AR44 L50056 5/16” FLANGE LOCK NUT. . . . . . AR45 L51035 5/16”X2” BOLT . . . . . . . . . . . . . . . AR

--- ITEMS NOT SHOWN ---00b L70462 WIRE HARNESS, WORK LIGHT . . 1

a Refer to page 96 for boom chains.b When equipped with Optional Boom Work Lights.

(Refer to illustration below.)

38

37

40

3941

40

39

Optional Boom Work Lights

(mounts to front of boom;reference B on facing page)

RS6-34 Telescopic Handler BoomOuter Boom Section

B


FRONT

REAR

20

16

29

28

27

9108

118

12

19

16

17

16

18

19

14

15

21

21

54

3

6

7

891011

812

13

1721 19

223

22

26

252413

16

19

16

211719

211

17

Boom RS6-34 Telescopic HandlerIntermediate Boom Section



01 L68744 INTERMEDIATE SECT WLDMNT. . 102 L63006 TRAY, INTERMEDIATE . . . . . . . . . . 103 650484 5/16”-18X1/2” BOLT . . . . . . . . . . . . 104 L50207 CLAMP, VINYL .69 DBL . . . . . . . . . 105 L520004 5/16”X18 NYLON INSERT NUT . . . 106 L520005 3/8”-16 NYLON INSERT NUT . . . . . 207 651625 3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 208 L68697 WASHER, CHAIN SHEAVE . . . . . . 609 L63158 RING, BEARING-INNER . . . . . . . . . 310 L63157 BEARING, BOOM SHEAVE . . . . . . 311 L63153 SHEAVE, CHAIN . . . . . . . . . . . . . . . 312 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 213 L520005 3/8”-16 NYLON INSERT NUT . . . . . 214 L68695 PIN, FRONT SHEAVE. . . . . . . . . . . 115 650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 4

16 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . 1217 L62734 SHIM, .105”X3”X4” . . . . . . . . . . . . . 818 L62733 SHIM, .06”X3”X4” . . . . . . . . . . . . . . 219 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . 2820 654026 3/8” LOCK WASHER. . . . . . . . . . . . 821 L61709 SLIDE PAD, 5/8”X3”X4”. . . . . . . . . 1222 650533 3/8”-16X1-1/2” BOLT . . . . . . . . . . . . 123 654026 3/8” LOCK WASHER. . . . . . . . . . . . 124 L68696 PIN, REAR SHEAVE . . . . . . . . . . . . 125 L63239 SPACER, TRAY BRACKET. . . . . . . 126 L61699 SLIDE PAD, 2”X3” . . . . . . . . . . . . . . 127 L61708 SLIDE PAD, 5/8”X4”X6”. . . . . . . . . . 228 L62731 SHIM, .06”X4”X6” . . . . . . . . . . . . . . 229 L62732 SHIM, .105”X4”X6” . . . . . . . . . . . . . 2

NOTE: Refer to page 96 for boom chains.

RS6-34 Telescopic Handler BoomIntermediate Boom Section


REAR

FRONT

22

27

26

2524 23

9

11

7 9

10

20

19

21

171615

1413

12

7

111098

7

21

22

3

4

18

5

6

Boom RS6-34 Telescopic HandlerInner Boom Section

29

28



01 L68762 INNER BOOM WELDMENT . . . . . . 102 L63005 HOSE TRAY, INNER BOOM . . . . . . 103 L71748 TOP PLATE, HOSE CLAMP . . . . . . 104 L61699 SLIDE PAD 2”X3” . . . . . . . . . . . . . . 105 103330 CLAMP, BOOM HOSES . . . . . . . . . 106 103331 CLAMP, BOOM W/INSERT . . . . . . 107 650488 3/8”-16X3/4” BOLT . . . . . . . . . . . . 1708 654026 3/8” LOCK WASHER. . . . . . . . . . . . 109 L61709 SLIDE PAD 5/8”X3”X4” . . . . . . . . . . 410 L62734 SHIM .105”X3”X4” . . . . . . . . . . . . . . 211 L62715 FLAT-BOLT LOCK . . . . . . . . . . . . . . 812 L66783 SHIM .105”X3”X8” . . . . . . . . . . . . . . 213 L66782 SHIM .06”X3”X8” . . . . . . . . . . . . . . . 214 L66780 SLIDE PAD 3”x8”. . . . . . . . . . . . . . . 215a L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 216 655001 PIN, COTTER 1/16”X3/4” . . . . . . . . 417 L63168 PIN, INNER BOOM CLEVIS . . . . . . 118b L63156 CHAIN, BOOM LEAF . . . . . . . . . . . 119 L63166 CLEVIS, CHAIN ADJUSTMENT . . . 1

20 L63167 PIN, CLEVIS ADJUSTMENT. . . . . . 121 L50086 3/4”-10 NUT. . . . . . . . . . . . . . . . . . . 222 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 223 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 224 L63716 CUSHION, HOSE-TWIN .68 . . . . . . 225 L63715 PLATE, TWIN CUSHION TOP . . . . 126 L520005 3/8”-16 NYLON INSERT NUT . . . . . 227 651625 3/8”-1-1/4” BOLT . . . . . . . . . . . . . . . 228 L50056 5/16” FLANGE LOCK NUT. . . . . . AR29 L51035 5/16”X2” BOLT . . . . . . . . . . . . . . . AR

a Attaches from the rear of the inner boom to the chain adjustment clevis’ located on the front of theouter boom section. (Refer to Outer Boom Section, item #34, chain adjustment clevis.)

b Attaches from item #19 (chain adjustment clevis) toouter boom clevis. (Refer to Outer Boom Section,item #12, outer boom clevis.)

RS6-34 Telescopic Handler BoomInner Boom Section


2

76

212

11

109

9

1314

3

54

3

1

Tilt Cylinder

15

Boom RS6-34 Telescopic HandlerDynattach® Bracket Assembly

TiltCylinderparts are

on page 172.



01 L98700 DYNATTACH WELDMENT . . . . . . . 102 L520005 3/8”-16 NYLON INSERT NUT . . . . . 303 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 304 L63274 PIN, TAPPED 1-1/2” DIA . . . . . . . . . 205 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 206 L63272 PIN, TILT CYL.(ROD END) . . . . . . . 107 L63018 BUSHING, TILT CYL (ROD END) . . 109 L66456 BUSHING, LOCK PIN . . . . . . . . . . . 210a NSS PIN, DYNATTACH LOCK . . . . . . . . 111a NSS DYNATTACH LOCK WLDMNT . . . . 1

12 L50646 3/16”X1-3/4” ROLL PIN . . . . . . . . . . 113 L65097 LOCK SPRING . . . . . . . . . . . . . . . . 114 L65098 SPRING MOUNT. . . . . . . . . . . . . . . 115 L63957 LOCK AND PIN ASSEMBLY . . . . . . 1

(includes items 10-11)

-- ITEMS NOT SHOWN ---- L66613 DECAL, DYNATTACH UNLOCKED 1

(adheres to item #11)

a Not sold separately; order item #15.

RS6-34 Telescopic Handler BoomDynattach® Bracket Assembly


Hydraulics RS6-34 Telescopic HandlerHydraulic Pump Group — (SN 21789 and up)

01 L445014 ADAP., -20ORM -24JICM 90º . . . . . 102 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 103 L46865 GASKET, HYD PUMP . . . . . . . . . . . 104a 50380843 HYDRAULIC PUMP, 47cc . . . . . . . 105 651148 1/2” FLAT WASHER . . . . . . . . . . . . 206 650495 1/2”-13X1-1/4” BOLT . . . . . . . . . . . . 207 100012 90 MJ04-FJS04 . . . . . . . . . . . . . . . . 108 L63402 HOSE, -4 A4/A6 48" . . . . . . . . . . . . 109 076143 TEE MJ08-FJS08-MJ08 . . . . . . . . . 110 055064 ADAP., -12ORM -12JICM 45º . . . . . 111 193709 HOSE, MP -12 X 23.5” . . . . . . . . . . 112 102836 HOSE, -6 A8/DS6 19” . . . . . . . . . . . 113 L63384 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 114 054994 ADAP., -6ORM -6JICM STR. . . . . AR15 102313 FLOW DIVIDER. . . . . . . . . . . . . . . . 1

16 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 117 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 118b 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 119c L63381 HOSE, -4A6/A6 15” . . . . . . . . . . . . . 120 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 121 079026 ADAP., -6ORM -6JICM 45º . . . . . . . 122 055005 90 MJ12-MAORB12 . . . . . . . . . . . . 223 088442 90 MJ08-FJS08 . . . . . . . . . . . . . . . . 124 054626 ST MJ08-MORB08 . . . . . . . . . . . . . 1

a Before ordering, verify the pump on the machine matches with the one in the illustration.

b Standard (units not equipped with PWP).c Option (units equipped with PWP).


HydraulicTank

Main ValveFront-Right

portPWP Manifold

"P" Port(Note c)

Joysticks(Note b)

Front Axle"PB" (left side)

HydraulicTank Return

Steer Motor"P" Port

Steer Motor"LS" Port

1

2

3

4

5

68

7

11

14

12

22

10

15

14

1918

20

1112

17

21

16

9

13

22

23

24

14

HydraulicPump parts

are on page 148.

Flow Dividerparts are onpage 149.


01 L445014 ADAP., -20ORM -24JICM 90º . . . . . 102 L63309 HOSE, -24 A24/A24 35” . . . . . . . . . 103 L46865 GASKET, HYD PUMP . . . . . . . . . . . 104a 103130 HYDRAULIC PUMP . . . . . . . . . . . . 105 651148 1/2” FLAT WASHER . . . . . . . . . . . . 206 650495 1/2”-13X1-1/4” BOLT . . . . . . . . . . . . 207 137784 ADAP., -4ORM -6JICM 90º . . . . . . . 108 L69930 HOSE, -4 A6/A6 46” . . . . . . . . . . . . 109 114742 ADAP., -8 RUN TEE . . . . . . . . . . . . 110 055064 ADAP., -12ORM -12JICM 45º . . . . . 311 L68802 HOSE, -12 A12/A12 17” . . . . . . . . . 112 102836 HOSE, -6 A8/DS6 19” . . . . . . . . . . . 113 L63384 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 1

14 054994 ADAP., -6ORM -6JICM STR. . . . . AR15 102313 FLOW DIVIDER. . . . . . . . . . . . . . . . 116 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 117 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 118b 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 119c L63381 HOSE, -4A6/A6 15” . . . . . . . . . . . . . 120 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 121 079026 ADAP., -6ORM -6JICM 45º . . . . . . . 1

a Before ordering, verify the pump on the machine matches with the one in the illustration.

b Standard (units not equipped with PWP).c Option (units equipped with PWP).

RS6-34 Telescopic Handler HydraulicsHydraulic Pump Group — (SN 21788 and before)


15

1

2

5

6 10

11

12

9

13

14

34

7

810

20

10

1918

17

14

21

16

HydraulicTank

Steer Motor"LS" Port

Main ValveFront-right

port PWP Manifold"P" Port(Note c)

Joysticks(Note b)

Front Axle"PB" (left side)

HydraulicTank Return

Steer Motor"P" Port

HydraulicPump parts

are on page 148.



15

6

7

9

10

11

12

6

5

16

14

1213

17

3

2

1

Steer Motor

Steer Select Valve

RIGHT

LEFT

R

LS

T

B

A

P

P

L

T

Hydraulics RS6-34 Telescopic HandlerSteer Motor and Select Valve Group

Steer Motorparts are onpage 154.

Steer Selectvalve parts

are onpage 153.



01 101882 STEER MOTOR . . . . . . . . . . . . . . . 102 137784 ADAP., -4ORM -6JICM 90º . . . . . . . 103 L69930 HOSE, -4 A6/A6 46” . . . . . . . . . . . . 105 L69747 VALVE, STEER SELECT . . . . . . . . 1

651089 1/4”-20X3” BOLT . . . . . . . . . . . . . . 2L520003 1/4”-20 NYLON INSERT NUT . . . . 2

06 079026 ADAP., -6ORM -6JICM 45º . . . . . . . 207 103319 HOSE, -6 A8/A6 22” . . . . . . . . . . . . 109 054994 ADAP., -6ORM -6JICM STR . . . . . . 2

HOSE LOCATOR

03 STEER MOTOR PORT “LS” HYDRAULIC PUMP07 STEER SELECT VALVE PORT “T” STEER CYLINDER, FRONT AXLE RIGHT SIDE10 STEER SELECT VALVE PORT “B” STEER CYLINDER, REAR AXLE RIGHT SIDE11 STEER SELECT VALVE PORT “A” STEER CYLINDER, REAR AXLE LEFT SIDE12 STEER MOTOR PORT “R” STEER SELECT VALVE PORT “P”13 STEER MOTOR PORT “L” STEER CYLINDER, FRONT AXLE LEFT SIDE14 STEER MOTOR PORT “P” HYDRAULIC PUMP15 STEER MOTOR PORT “T” HYDRAULIC TANK RETURN MANIFOLD

10 L69936 HOSE, -6 A8/DS6 100” . . . . . . . . . . 111 L69936 HOSE, -6 A8/DS6 100” . . . . . . . . . . 112 L63383 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 113 L63387 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 114 L63384 HOSE, -6 A8/DS8 40” . . . . . . . . . . . 115 L68805 HOSE, -6 A6/DS6 70” . . . . . . . . . . . 116 L64524 VALVE, CHECK, -8ORM . . . . . . . . 117 054626 ADAP., -8ORM -8JICM STR . . . . . . 3

RS6-34 Telescopic Handler HydraulicsSteer Motor and Select Valve Group


Hydraulics RS6-34 Telescopic HandlerBrake Valve Group

Front AxleService Brake(right side tee)

Rear AxleService Brake(left side tee)

Located behindjoystick access

panel.

BRAKE LIGHTPRESSURE

SWITCH

CLUTCH CUT-OUT(OPTION)

14

1311

12

10

8

9

1

7

5

4

2

3

6

9

6

3

1

4

5

MasterCylinder parts

are on page 155.



RS6-34 Telescopic Handler HydraulicsBrake Valve Group

01 101320 HOSE, -4 A4/A4 45” . . . . . . . . . . . . 102 102840 HOSE, -4 A4/A6 90” . . . . . . . . . . . . 103 L63651 HOSE, -4 A4/DM4 17” . . . . . . . . . . . 104 230-32694 ADAP., -4 SWIVEL TEE . . . . . . . . . 205 L62741 ADAP., HYDROMAX -4JICM STR. . 206 L63651 HOSE, -4 A4/DM4 17” . . . . . . . . . . . 107 L63363 VALVE, MASTER CYLINDER . . . . . 208 L63564 SWITCH, DIFF. PRESSURE. . . . . . 109 230-32195 ADAP., -4ORM -4JICM STR. . . . . AR10 104428 SWITCH, PRESSURE 150 PSI. . . . 111 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 112a 104428 SWITCH, PRESSURE 150 PSI. . . . 1

13 095601 ADAP., -40RM -4JICM 90º . . . . . . . 314 103320 HOSE, -4 A4/A6 40” . . . . . . . . . . . . 1

-- ITEMS NOT SHOWN---- L66162 WIRE, 16ga. 6” . . . . . . . . . . . . . . . . 1

(ground wire for item #8)--b 230-32364 PLUG, -4ORM SAE . . . . . . . . . . . . . 1

a Used on units equipped with Clutch Cut-Out option.

b Used on units not equipped with ClutchCut-Out option; the plug is used in place ofpressure switch.


STEER MOTORPORT “L”

BRAKE MASTERCYLINDER “TEE”

1

914915

8 8

2

1

133

12

22

1

31

56

7

8

11

9

10

SERVICE BRAKE PORT

PARK BRAKE PORT

SERVICE BRAKE PORT

REAR AXLE

FRONT AXLE

LEFT

RIGHT

STEER SELECTVALVE15

18

11

14

BRAKEMANIFOLD

5

20

19

22

BRAKE MASTERCYLINDER “TEE”

21

23

24

STEER MOTORPORT “R”

FLOWDIVIDER“PB” 16

4

6

Hydraulics RS6-34 Telescopic HandlerBrake and Steering Circuit



01 L66139 ADAP., M14X1.5ORM -6JICM. . . . . 602 091039 ADAP., -6JICFS -6JICM 90º . . . . . . 303 095457 ADAP., -6 SWIVEL TEE . . . . . . . . . 304 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 105 103320 HOSE, -4 A6/A4 40” . . . . . . . . . . . . 106 103317 HOSE, -6 A6/A6 28” . . . . . . . . . . . . 107 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 108 100011 ADAP., M18 ORM - 8JICM STR . . . 409 088442 ADAP., -8JICFS -8JICM 90º . . . . . . 410 L63387 HOSE, -6 A8/DS8 67” . . . . . . . . . . . 111 103319 HOSE, -6 A8/A6 22” . . . . . . . . . . . . 112 102840 HOSE, -4 A4/A6 90” . . . . . . . . . . . . 1

13 L69928 HOSE, -4 A6/A6 25” . . . . . . . . . . . . 114 L69936 HOSE, -6 A6/A8 100” . . . . . . . . . . . 115 L69936 HOSE, -6 A6/A8 100” . . . . . . . . . . . 116 L63383 HOSE, -6 A6/DS8 52” . . . . . . . . . . . 118 L69747 VALVE, STEER SELECT . . . . . . . . 119 L70428 MANIFOLD, BRAKE LINE. . . . . . . . 120 110227 ADAP., -4ORM -4JICM STR. . . . . AR21 102837 HOSE, -4 A4/A4 52” . . . . . . . . . . . . 122 095601 ADAP., -40RM -4JICM 90º . . . . . . . 123 102668 AXLE, FRONT (w/ int. park brake) . 124 L68849 AXLE, REAR . . . . . . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler HydraulicsBrake and Steering Circuit


AB

Left Side Bulkhead

Right Side Bulkhead

Hydraulics RS6-34 Telescopic HandlerMain Hydraulic Valve and Hoses

HydraulicMain valve

parts are onpage 150.

8

11

10

12

2221

2018

17

1615

7

6

9

5

4

1

321

6

7

19

14

13

28

26

29

30

29

30

OptionalHydraulics

1 24

7

25

26

27

23

LEVEL

LIFT

BOOM

TILT



01a 137542 ADAP., BLKHEAD 90º -10JICM . . . 402 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 103 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 104 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 105 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 106 076143 ADAP., -8JICFS -8JICM RUN T . . . 407a 089099 ADAP., -10ORM -8JICM . . . . . . . . . 408 L68817 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 109 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 110 650833 5/16”-18X3” BOLT . . . . . . . . . . . . . . 311 L520004 5/16”-18 NYLON INSERT NUT . . . . 312 L68694 VALVE, MAIN CONTROL (V20) . . . 113 072587 ADAP., -12ORM -12JICM STR . . . . 214 L60253 ADAP., -10ORM -6JICM STR . . . . . 215 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 116 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 117 L68807 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 1

HOSE LOCATOR

02 MAIN VALVE SECTION 3 PORT “A” BULKHEAD FITTING TO (BOOM EXTEND)03 MAIN VALVE SECTION 3 PORT “B” BULKHEAD FITTING TO (BOOM RETRACT)04 MAIN VALVE SECTION 4 PORT “B” BULKHEAD FITTING TO (TILT CYL. RETRACT)05 MAIN VALVE SECTION 4 PORT “A” BULKHEAD FITTING TO (TILT CYL. EXTEND)08 MAIN VALVE SECTION 4 PORT “B” SLAVE CYLINDER (BOTTOM-RETRACT)09 MAIN VALVE SECTION 4 PORT “A” SLAVE CYLINDER (TOP-EXTEND)15 MAIN VALVE SECTION 2 PORT “A” LIFT CYLINDER (RIGHT) (OUTSIDE-EXTEND)16 MAIN VALVE SECTION 2 PORT “B” LIFT CYLINDER (RIGHT) (INSIDE-RETRACT)17 MAIN VALVE SECTION 2 PORT “B” LIFT CYLINDER (LEFT) (OUTSIDE-RETRACT)18 MAIN VALVE SECTION 2 PORT “A” LIFT CYLINDER (LEFT) (INSIDE-EXTEND)19 MAIN VALVE SECTION 1 PORT “B” LEVEL CYLINDER (OUTSIDE-RETRACT)20 MAIN VALVE SECTION 1 PORT “A” LEVEL CYLINDER (INSIDE-EXTEND)21 MAIN VALVE “IN” FLOW DIVIDER PORT “EF”22 MAIN VALVE “OUT” HYDRAULIC TANK (FILTER COVER FITTING)23 OPTIONAL HYD. SECTION PORT “B” BULKHEAD FITTING TO (OPTION - RETRACT)24 OPTIONAL HYD. SECTION PORT “A” BULKHEAD FITTING TO (OPTION - EXTEND)

18 L68808 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 119 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 120 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 121 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 122 L63406 HOSE, -12 A12/DS12 114” . . . . . . . 123 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 124 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 125 L68778 KIT, VALVE SECTION . . . . . . . . . . . 1

(includes item #27)26 068938 ADAP., -6ORM -6JICM 90º. . . . . . AR27 NSS BOLT KIT (included with item #25) . 128 072580 ADAP., -10ORM -10JICM . . . . . . . . 229 054994 ST MJ06-MORB06 . . . . . . . . . . . . . 230 091039 90 MJ06-FJS06 . . . . . . . . . . . . . . . . 2

a Add (2) to quantity when unit is equipped withoptional hydraulics.

RS6-34 Telescopic Handler HydraulicsMain Hydraulic Valve and Hoses


TILT “FORWARD” (R)

TILT “BACK”(E)

LEVEL “LEFT” (E)

LEVEL “RIGHT” (R)BOOM “DOWN”(R)

EXTEND

RETRACT

LEVEL (RIGHT)BOOM (OUT)

BOOM (DOWN)

TILT (FORWARD)HYDRAULIC OPTION

TILT (BACK)HYDRAULIC OPTION

BOOM (UP)BOOM (IN)

LEVEL (LEFT)

7 7

49

5

9

5

6

66

6

3

4

2

1

4

(R) = retract(E) = extend

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

8Main Valve shown with

Auxiliary Hydraulics Option 8

BOOM “UP”(E)

BOOM “IN” (R)

BOOM “OUT” (E)

OUT

DOWNUP

IN

RIGHTLEFT

FORWARDBACK

FRONT

Hydraulics RS6-34 Telescopic HandlerMain Hydraulic Valve - Dual Controls (Standard)

Controllersare on pages

158 - 164.



01 103264 CONTROLLER, AUX. HYD . . . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 103262 CONTROLLER, TILT/LEVEL. . . . . . 104 054994 ADAP., -6ORM -6JICM STR. . . . . AR05 L68811 HOSE, -4 A6/A6 108” . . . . . . . . . . . 206 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 407 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 2

08a L68694 MAIN VALVE . . . . . . . . . . . . . . . . . . 109 L64275 HOSE, -4 A6/A6 102” . . . . . . . . . . . 2

a The illustration on the facing page shows the (optional) auxiliary hydraulic work section with themain valve.

RS6-34 Telescopic Handler HydraulicsMain Hydraulic Valve - Dual Controls (Standard)


P 4

3

1

2

T

B

TA

P

FLOW DIVIDERPORT “J”

HYDRAULICTANK MANIFOLD

LEGEND

BOOM IN/OUTBOOM UP/DOWNFRAME LEVEL

6

78

4

3

7

3

8

3

2

4

12

1011

7

4

10

3

14

13

7

3

14

64

3

9

5

7

1

16

15

17

3

P

T

7

Hydraulics RS6-34 Telescopic HandlerMain Valve with Tri-Function Control (Option) - Standard Hydraulics


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . 1404 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 905 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 207 L68810 HOSE, -6 A6/A6 96” . . . . . . . . . . . . 608 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 209 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 110 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 2

11 072806 ADAP., -6JICM -6JICFS RUN TEE . 112 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 113 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 114 102843 HOSE, -4 A6/DS6 35” . . . . . . . . . . . 115 106898 PILOT APPLY MANIFOLD. . . . . . . . 116 L50741 STUD, 1/4”X3-1/4”. . . . . . . . . . . . . . 217 L50051 NUT, 1/4”-20 WHIZ NUT . . . . . . . . . 2

-- ITEMS NOT SHOWN ---- 105580 TRI-FUNCTION WIRE HARNESS . 1-- L62761 1/4” MALE ELEC. CONNECTOR . . 8


RS6-34 Telescopic Handler HydraulicsMain Valve with Tri-Function Control (Option) - Standard Hydraulics


P

P 4

3

1

2

A

T

B

TA

P

B

T

FLOW DIVIDERPORT “J” HYDRAULIC

TANK MANIFOLD

LEGEND

BOOM IN/OUTBOOM UP/DOWNFRAME LEVEL

6

78

4

3

7

3

8

3

2

15

18

13

19 16

12

1011

7

4

7

10

11 3 415

13

18

3

7

3

14

4

14

9

5

7

1

3

17

P

T

3

Hydraulics RS6-34 Telescopic HandlerMain Valve with Tri-Function Control (Option) with Auxiliary Hydraulics


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . 1904 068938 ADAP., -6ORM -6JICM 90º . . . . . . 1005 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 L68810 HOSE, -6 A6/A6 96” . . . . . . . . . . . . 608 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 209 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 110 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 072806 ADAP., -6JICM -6JICFS RUN TEE . 212 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

13 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 214 102843 HOSE, -4 A6/DS6 35” . . . . . . . . . . . 215 106898 PILOT APPLY MANIFOLD. . . . . . . . 216 L50745 STUD, 1/4”X5-3/4”. . . . . . . . . . . . . . 217 L50051 NUT, 1/4”-20 WHIZ NUT . . . . . . . . . 218 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 219 L51762 ADAP., -6ORM -6JICM B TEE . . . . 1



RS6-34 Telescopic Handler HydraulicsMain Valve with Tri-Function Control (Option) with Auxiliary Hydraulics


Boom Up

Boom Down

Boom Out

Boom In

T

J1

J2

P

JS

E1

E2

E3

E4

J4

J3

UP

INL

EXTRET

DN

Boom Up

Boom In

Boom Out

Boom Down

3

8

4

1

8

1

2

5

6

7

5

9

9

AA

BB

CC

NOTE: Hose reference AA, BB, and CC attach to joysticks and manifolds.Refer to “Hydraulic Controls - Radio Remote” section for more information.

TILT (FORWARD)BOOM (UP)

BOOM (IN)

LEVEL (LEFT)

Hydraulics RS6-34 Telescopic HandlerMain Valve with Radio Remote (Option)

Radio RemoteManiofold

parts are onpage 157.



01 L68804 HOSE, -4 A6/DS6 26” . . . . . . . . . . . 402 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 203 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 104 137784 ADAP., -4ORM -6JICM 90º . . . . . . . 605 129124 ADAP., -4ORM -6JICM STR . . . . . . 5

06 103413 MANIFOLD, RADIO REMOTE . . . . 107 103425 MOUNT, RADIO REMOTE . . . . . . . 108 L69902 HOSE, -4 A6/H6 20” . . . . . . . . . . . . 409 L68810 HOSE, -4 A6/A6 96” . . . . . . . . . . . . 4

RS6-34 Telescopic Handler HydraulicsMain Valve with Radio Remote (Option)


P

P

T

T

J

HYDRAULICTANK

FRONT

TILTLEVEL

LIFTEXTEND

FLOW DIVIDER

7

5

6

4

3

5

5

5

3

2

1

8

Hydraulics RS6-34 Telescopic HandlerDual Controls - Standard


158 - 164.



01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 404 072806 ADAP., -6 SWVL RUN TEE . . . . . AR

05 L69903 HOSE, -4 A6/DS6 17”. . . . . . . . . . AR06 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 107 102313 MANIFOLD, JOYSTICK RELIEF. . . 108 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1


RS6-34 Telescopic Handler HydraulicsDual Controls - Standard


P

P

P

T

T

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

2

1

12

11

13

7

96

53

4

12

10

9

8

7

4

3

8

103

J

FLOW DIVIDER

Hydraulics RS6-34 Telescopic HandlerDual Controls with only Auxiliary Hydraulics (Option)


158 - 164.



01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 091039 ADAP., -6JICM -6JICFS 90º . . . . . AR06 068938 ADAP., -6ORM -6JICM 90º. . . . . . AR07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

08 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 110 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 112 103264 CONTROLLER, AUX. HYD . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 1


RS6-34 Telescopic Handler HydraulicsDual Controls with only Auxiliary Hydraulics (Option)


P

P

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

1

6

4

35

7

7

8

3

2

J2

J1

T

8

5

12

9

11

10PWP VALVEFLOW DIVIDER

J

p

Hydraulics RS6-34 Telescopic HandlerDual Controls with only PWP (Option)


158 - 164.


PWP valveparts are onpage 152.


01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 106 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 107 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1

08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 109 102313 MANIFOLD, JOYSTICK RELIEF. . . 110 102321 MANIFOLD, PWP JOYSTICK . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

(to hydraulic tank)12 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 1


RS6-34 Telescopic Handler HydraulicsDual Controls with only PWP (Option)


P

P

P

T

T

T

HYDRAULICTANK

TILTLEVEL

LIFTEXTEND

HYDRAULICOPTION

7

96

5

3

12

10 8

7

4

3 11

4

3

16

1

2

9

8

11

13

14

15

17

J2J1

FLOW DIVIDER

PWP VALVE

p

Hydraulics RS6-34 Telescopic HandlerDual Controls with PWP and Auxiliary Hydraulics (Option)


158 - 164.




01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR. . . . . AR04 072806 ADAP., -6 SWIVEL RUN TEE. . . . AR05 091039 ADAP., -6JICM -6JICFS 90º . . . . . AR06 068938 ADAP., -6ORM -6JICM 90º. . . . . . AR07 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 108 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 109 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

10 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 111 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 112 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 116 103264 CONTROLLER, AUX. HYD . . . . . . . 117 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 1

(to hydraulic tank)


RS6-34 Telescopic Handler HydraulicsDual Controls with PWP and Auxiliary Hydraulics (Option)


P

P

T

TILTLEVEL

LIFTEXTEND

1

4

3 87

8

32

T

J

P

T

T

AA

BB CC

11

8

10

13

12

4

3

9

10

NOTE: Hose reference AA, BB, and CC attach to radio remote manifold.Refer to the “Main Valve - Radio Remote” section for more information.

5

J1 J2

8

6 6HYDRAULIC

TANK MANIFOLD

3

JS

T P

14

Hydraulics RS6-34 Telescopic HandlerDual Controls with Radio Remote (Option)


158 - 164.




01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 072806 ADAP., -6 SWIVEL RUN TEE . . . . . 205 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 106 L69905 HOSE, -4 A6/DS6 130” . . . . . . . . . . 207 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1

08 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 309 102321 MANIFOLD, PWP JOYSTICK . . . . . 110 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 211 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 112 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 113 102313 MANIFOLD, JOYSTICK RELIEF. . . 114 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1

RS6-34 Telescopic Handler HydraulicsDual Controls with Radio Remote (Option)



P

P

T

TILTLEVELLIFT

EXTEND

1

4

9

11

8

3

2

T

P

T

T

AABB

12

11

6

10

15

13

4

3

14

6

J

T

P

58

6

8

8

37

8

CCNOTE: Hose reference AA, BB, and CC attach to radio remote manifold.Refer to the “Main Valve - Radio Remote” section for more information.

J2J1

HYDRAULICTANK MANIFOLD

3

3

10

11

JS

TP

11

16

Hydraulics RS6-34 Telescopic HandlerDual Controls with Radio Remote and Auxiliary Hydraulics (Option)


158 - 164.


01 103262 CONTROLLER, TILT/LEVEL. . . . . . 102 103263 CONTROLLER, LIFT/EXTEND . . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 904 072806 ADAP., -6 SWIVEL RUN TEE . . . . . 205 103264 CONTROLLER, AUX. HYD . . . . . . . 106 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 307 091039 ADAP., -6ORM -6JICFS 90º . . . . . . 108 L69904 HOSE, -4 A6/DS6 20” . . . . . . . . . . . 309 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 1

10 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 211 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 312 L63381 HOSE, -4 A6/A6 15” . . . . . . . . . . . . 113 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 102313 MANIFOLD, JOYSTICK RELIEF. . . 116 103505 HOSE, H6/DS6 109” . . . . . . . . . . . . 1

RS6-34 Telescopic Handler HydraulicsDual Controls with Radio Remote and Auxiliary Hydraulics (Option)





P

T

T

P

2

J2J1

TP

T

J

PILOT APPLY VALVE(REAR OF MACHINE)

T

P

T

P

14

9

6

5

1

3

9

10

4

13

3

10

10 8

4

4

3

3

9

11

7

3

4

15

12

9

9HYDRAULIC TANKRETURN MANIFOLD

Hydraulics RS6-34 Telescopic HandlerTri-Function Control (Option) with only PWP


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 505 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 3

10 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 103368 HOSE, -6 A6/DS6 52”



RS6-34 Telescopic Handler HydraulicsTri-Function Control (Option) with only PWP



Pilot Applyvalve parts

are on page 156.


P

T

T

P

2

J2J1

TP

T

J


T

P

T

P

12

10

16

13

16

15

10

4

10

7

6

5

3

9

9

4

8

1

3

3

3

17

9

3

4

11

9

14

9

HYDRAULIC TANKRETURN MANIFOLD

Hydraulics RS6-34 Telescopic HandlerTri-Function Control (Option) with PWP and Auxiliary Hydraulics


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 804 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 505 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 2

11 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 114 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L51762 ADAP., -6ORM -6JICM B TEE . . . . 116 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 217 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 1



RS6-34 Telescopic Handler HydraulicsTri-Function Control (Option) with PWP and Auxiliary Hydraulics




are on page 156.


P

T

T

P

2

AA BB CC

J2J1

P

T

J


JST P

T

P

PILOT APPLY VALVE(REAR OF MACHINE) T


3

14

4

9

43

11

15

3

312

10

3

10

10

4

9

4

3

8

7

6

59

3

1

17 17

916

T

P

4

13

3

189

Hydraulics RS6-34 Telescopic HandlerTri-Function Control (Option) with Radio Remote


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 704 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 405 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 1

12 102313 MANIFOLD, JOYSTICK RELIEF. . . 113 106898 PILOT APPLY MANIFOLD. . . . . . . . 214 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 116 072806 ADAP., -6JICM -6JICFS R TEE. . . . 117 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 218 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1


RS6-34 Telescopic Handler HydraulicsTri-Function Control (Option) with Radio Remote





are on page 156.


P

T

T

P

2

AA BB CC

J2J1

P

T

J


JST P

T

P


T

P

T


3

14

4

9

43

11

17

3

312

16

13

15

16

10

3

10

10

4

9

4

3

8

7

6

59

3

1

19 19

918

209

Hydraulics RS6-34 Telescopic HandlerTri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics


158 - 164.


01 L71346 CONTROLLER, TRI-FUNCTION. . . 102 103264 CONTROLLER, FRAME LEVEL . . . 103 054994 ADAP., -6ORM -6JICM STR . . . . . . 704 068938 ADAP., -6ORM -6JICM 90º . . . . . . . 405 054820 ADAP., -6ORM -6JICM RUN TEE . . 106 091039 ADAP., -6JICM -6JICFS 90º . . . . . . 107 103315 HOSE, -4 A6/A6 60” . . . . . . . . . . . . 108 L69903 HOSE, -4 A6/DS6 17” . . . . . . . . . . . 109 103318 HOSE, -4 A6/DS6 52” . . . . . . . . . . . 310 102831 HOSE, -4 A6/DS6 102” . . . . . . . . . . 211 L63381 HOSE, -4 A6/DS6 15” . . . . . . . . . . . 112 102313 MANIFOLD, JOYSTICK RELIEF. . . 1

13 106898 PILOT APPLY MANIFOLD. . . . . . . . 214 102321 MANIFOLD, PWP JOYSTICK . . . . . 115 L51762 ADAP., -6ORM -6JICM B TEE . . . . 116 105593 HOSE, -4 A6/DS6 12” . . . . . . . . . . . 217 103368 HOSE, -6 A6/DS6 52” . . . . . . . . . . . 118 072806 ADAP., -6JICM -6JICFS R TEE. . . . 119 L69905 HOSE, -4 A6/A6 130” . . . . . . . . . . . 220 103505 HOSE, -4 H6/DS6 109” . . . . . . . . . . 1



RS6-34 Telescopic Handler HydraulicsTri-Function Control (Option) with Radio Remote and Auxiliary Hydraulics




are on page 156.


Main ControlValve (V20)

FRONT AXLE

7

15

17

4

5

3

21

14

16

13

12

8

910

11

7

66

Hydraulics RS6-34 Telescopic HandlerFrame Level Circuit

Frame LevelCylinder parts

are on page 166.

Main valveparts are onpage 150.



01 Note a LEVEL CYLINDER . . . . . . . . . . . . . 102 L64367 BRONZE BEARING . . . . . . . . . . . . 103 650731 3/8”-16X3-1/2” BOLT . . . . . . . . . . . . 104 L63276 PIN, CYLINDER (BASE END). . . . . 105 L520005 3/8”-16 NYLON INSERT NUT . . . . . 106 L68794 ADAP., W/ORIFICE -8ORM -6JICM 207 L68809 HOSE, -4 A6/DS6 136” . . . . . . . . . . 208 650487 5/16”X1” BOLT. . . . . . . . . . . . . . . . . 209 L63715 PLATE . . . . . . . . . . . . . . . . . . . . . . . 110 210447 PIVOT PIN (ROD END). . . . . . . . . . 1

11 L63016 BRONZE BEARING . . . . . . . . . . . . 112 210569 FRAME LEVEL MOUNT . . . . . . . . . 113 210572 PLATE, FRAME LEVEL. . . . . . . . . . 114 L50712 3/4”-10X9” GR8 BOLT . . . . . . . . . . . 415 654014 3/4” FLAT WASHER . . . . . . . . . . . . 416 L50084 3/4”-10 STOVER NUT . . . . . . . . . . . 417 L60253 ADAP., -10ORM -6JICM . . . . . . . . . 2

a Refer to page 166.

RS6-34 Telescopic Handler HydraulicsFrame Level Circuit


2

2

4

5

3

1

7

53

4

8

12

9

10

11

FRAME

FRAME

RIGHT

LEFT

6

LIFT

RETRACT

EXTEND

RETRACT

EXTEND

MainValve

Hydraulics RS6-34 Telescopic HandlerLift Circuit

Lift cylinderparts are on page 168.



01 Note a LIFT CYLINDER . . . . . . . . . . . . . . . 202 L68003 BRONZE BUSHING . . . . . . . . . . . . 403 L63274 PIN, LIFT CYLINDER . . . . . . . . . . . 404 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 405 L520005 3/8”-16 NYLON INSERT NUT . . . . . 406 076143 ADAP -8JICFS -8JICM RUN TEE . . 2

07 089099 ADAP -10ORM -8JICM STR . . . . . . 208 L68807 HOSE, -6 A8/DS8 54” . . . . . . . . . . . 109 L68808 HOSE, -6 A8/DS8 48” . . . . . . . . . . . 110 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 111 L63407 HOSE, -6 A8/A8 48” . . . . . . . . . . . . 112 054816 ADAP -8ORM -8JICM 90º . . . . . . . . 4


RS6-34 Telescopic Handler HydraulicsLift Circuit


15

21

13 1218

17

20

19

1218

17

13

9

54

6

11

10

12

8

713

14

15

16

3

2

22

23

24

25

1

13

1412

Right Bulkhead

Main Valve

Slave Cylinder

Tilt Cylinder

11

Extend

Retract

Extend

TILT

26

Hydraulics RS6-34 Telescopic HandlerTilt / Slave Circuit

Tilt cylinderparts are onpage 172.

Slave cylinderparts are onpage 170.



01 L68351 TUBE, TILT/AUX . . . . . . . . . . . . . . . 202 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 103 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 104 137542 ADAP., -10JICM BLKHEAD 90º . . . 205 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 106 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 107 076143 ADAP., -8JICFS -8JICM RUN TEE . 208 089099 ADAP., -10ORM -8JICM . . . . . . . . . 209 L68817 HOSE, -6 A8/A8 26” . . . . . . . . . . . . 110 L63407 HOSE -6 A8/A8 48” . . . . . . . . . . . . . 111 054816 ADAP., -8ORM -8JICM 90º . . . . . . . 312 L520005 3/8”-16 NYLON INSERT NUT . . . . . 413 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 414 L63272 PIN, CYLINDER (rod end). . . . . . . . 215 L63018 BUSHING BUSHING (rod end) . . . . 216 Note a CYLINDER, SLAVE . . . . . . . . . . . . . 117 L68003 BUSHING (base end) . . . . . . . . . . . 218 L63273 PIN, CYLINDER BUSH. (base end) 219 Note a CYLINDER, TILT . . . . . . . . . . . . . . . 120b L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 1

21b L68374 HOSE, -6 A8/H10 322” . . . . . . . . . . 122 L520004 5/16”-18 NYLON INSERT NUT . . . . 823 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 824 L63715 PLATE, TWIN CUSHION. . . . . . . . . 825 L68039 5/8” DOUBLE TUBE CUSHION . . 1626 076880 ADAP., -8ORM -8JICM 45º . . . . . . . 1

--- ITEMS NOT SHOWN ----- L50207 VINYL CLAMP. . . . . . . . . . . . . . . . . 2-- 650484 5/16”-18X1/2” BOLT . . . . . . . . . . . . 2-- L520004 5/16”-18 NYLON INSERT NUT . . . 2

a Refer to page 172 for the tilt cylinder.Refer to page 170 for the slave cylinder.

b Used with protective fabric sleeve PN L500784.

RS6-34 Telescopic Handler HydraulicsTilt / Slave Circuit


Main Valve

BoomExtend/Retract

4

2

11

11

14

15

13

16

12

98

7

12

6

53

2

53

19

18

17

1

10

Hydraulics RS6-34 Telescopic HandlerBoom Extend Circuit

Boom Extendcylinder parts

are on page 174.



01 Note a CYLINDER, EXTEND . . . . . . . . . . . 102 126862 ADAP., -8ORM -8JICM 90º LONG . 203 L520005 3/8”-16 NYLON INSERT NUT . . . . . 204 L63273 PIN, CYLINDER (base end) . . . . . . 105 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 206 L68003 BUSHING (base end) . . . . . . . . . . . 107 L68348 7/8” HOSE CUSHION, SINGLE . . . 408 L68356 CUSHION TOP PLATE . . . . . . . . . . 209 L50878 5/-16”-18X3” STUD . . . . . . . . . . . . . 410 L520004 5/16”-18 NYLON INSERT NUT . . . . 411 L68352 HOSE, -8 A8/DS10 73” . . . . . . . . . . 112 L68352 HOSE, -8 A8/DS10 73” . . . . . . . . . . 113 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 1

14 L68814 HOSE, -8 A10/DS10 15” . . . . . . . . . 115 072580 ADAP., -10ORM -10JICM . . . . . . . . 216 137542 ADAP., -10JICM 90º BLKHEAD . . . 217 L63694 EXTEND CYL. BRACKET. . . . . . . . 1

650490 3/8”-16X1” BOLT . . . . . . . . . . . . . . . 2654026 3/8” LOCK WASHER. . . . . . . . . . . . 2

18 L63018 BUSHING (rod end). . . . . . . . . . . . . 119 L63272 PIN, CYLINDER (rod end). . . . . . . . 1


RS6-34 Telescopic Handler HydraulicsBoom Extend Circuit


13

20

19

4

3

21

5

78

6

13

14

1811

17

10

9

11

12

16

14

Left Bulkhead

Auxiliary HydraulicsValve Section

21

22

Hydraulics RS6-34 Telescopic HandlerAuxiliary Hydraulics Circuit

24

23



01 L68351 TUBE, TILT/AUX . . . . . . . . . . . . . . . 202 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 103 L68239 HOSE, -8 H10/DS10 54” . . . . . . . . . 104 137542 ADAP., -10JICM BLKHEAD 90º . . . 205a L68778 KIT, VALVE SECTION . . . . . . . . . . . 106 089099 ADAP., -10ORM -8JICM . . . . . . . . . 207 L68815 HOSE, -8 A10/DS8 17” . . . . . . . . . . 108 L68816 HOSE, -8 A10/DS8 14” . . . . . . . . . . 109 L520004 5/16”-18 NYLON INSERT NUT . . . 1010 L50877 5/16”-18X2-1/4” STUD. . . . . . . . . . . 811 L63715 PLATE, TWIN CUSHION. . . . . . . . . 812 L68039 5/8” DOUBLE TUBE CUSHION . . 1613b L68376 HOSE, -6 A8/H10 352” . . . . . . . . . . 114b L68376- HOSE, -6 A8/H10 352” . . . . . . . . . . 116 L71748 TOP PLATE, HOSE CLAMP.. . . . . . 1

17 650784 5/16”-18X2-3/4” BOLT . . . . . . . . . . . 2654024 5/16” LOCK WASHER . . . . . . . . . . 2

18 L63716 11/16” DOUBLE TUBE CUSHION. . 419 054626 ADAP., -8ORM -8JICM STR . . . . . . 220 L65273 COUPLER SET . . . . . . . . . . . . . . . . 121 103330 CLAMP, BOOM HOSES . . . . . . . . AR22 103331 CLAMP, BOOM W/INSERT . . . . . AR23 L50056 5/16” FLANGE LOCK NUT. . . . . . AR24 L51035 5/16”X2” BOLT . . . . . . . . . . . . . . . AR

a Kit includes a single V20 valve section and tie bolt kit for five-section valve.

b Used with protective fabric sleeve part number L500784.

RS6-34 Telescopic Handler HydraulicsAuxiliary Hydraulics Circuit



03 103130 HYDRAULIC PUMP . . . . . . . . . . . . 1(Aluminum Body) . . . . . . . . . . . . . . . .

02 L46865 GASKET . . . . . . . . . . . . . . . . . . . . . 104 L500368 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1

(Items included are not shown.)

32

4

Hydraulic Components RS6-34 Telescopic HandlerHydraulic Pump

01 50380843 HYDRAULIC PUMP, 47CC . . . . . . . 1(Cast Iron Body)

02 L46865 GASKET . . . . . . . . . . . . . . . . . . . . . 1

Late Style - Cast Iron Body(Originally installed on machines

with SN 21789 and up)

Early Style - Aluminum Body(Originally installed on machines

with SN 21788 and before)

1

2

Before ordering, verify the pump on the machine matches with the one in the illustration.

Before ordering, verify the pump on the machine matches with the one in the illustration.



4

5

3

6

2

1

7

00 102313 FLOW DIVIDER (complete) . . . . . . .101 103017 PILOTED SPOOL LOGIC ELEM.. . .102 L99927 RELIEF VALVE . . . . . . . . . . . . . . . .1

L99925 SEAL KIT . . . . . . . . . . . . . . . . . . . .103 105087 DEBRIS SCREEN . . . . . . . . . . . . . .104 NSS NUT, SOLENOID VALVE . . . . . . . . .1

(included with item 5)05 L99908 12 VDC WEATHER PACK COIL . . .1

(includes item 4)06 L99910 SOLENOID VALVE . . . . . . . . . . . . .1

L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . .1

07 P471997 TEST PORT . . . . . . . . . . . . . . . . . . .3L62840 CAP, DUST COVER (not shown) . .3

08 102313 MANIFOLD, FLOW DIVIDER . . . . .1(includes items 1-7)

-- ITEMS NOT SHOWN --(Mounting Hardware)

-- L50217 1/4”-20X3-1/2” BOLT . . . . . . . . . . . .2-- L50139 1/4” LOCK WASHER . . . . . . . . . . . .2-- 654002 1/4” FLAT WASHER . . . . . . . . . . . .2

NOTE: Items included in seal kits are not shown.

PARKINGBRAKEVALVE

RS6-34 Telescopic Handler Hydraulic ComponentsJoystick Relief - Flow Divider

8

00


1

14

4

1943

18

1712

16

14 15

4

14

4

6

14

14

9

13

121

111093

84

3

76

35

43

2

20

Auxiliary HydraulicsWork Section

SEAL KITS

LEVEL

TILT

BOOM

LIFT

‘B’ PORT

‘A’ PORT

OUTIN

21

21

Hydraulic Components RS6-34 Telescopic HandlerMain Hydraulic Valve

00



00 L68694 MAIN VALVE-V20 (complete) . . . . . 1(does not include items 19 and 20)

01 L98891 STUD KIT (tie bolts and nuts) . . . . . 102 L500954 INLET COVER. . . . . . . . . . . . . . . . . 103 L500134 HRO ACTUATOR “B” END . . . . . . . 404 L500132 NO RELIEF-NO ANTI-CAV.PLUG . . 4

L500130 SEAL KIT . . . . . . . . . . . . . . . . . . . . 105 L98895 WORK SECTION 1 (Level) . . . . . . . 1

(includes items 3, 4, 14 & 15)06 L500952 NO RELIEF - ANTI-CAV PLUG. . . . 107 L500953 WORK SECTION 2 (Lift) . . . . . . . . . 1

(includes items 3, 4, 6, 14 & 15)08 L500956 WORK SECTION 3 (Boom Ext.) . . . 1

(includes items 3, 4, 6, 14 & 15)09 L98896 RELIEF CARTRIDGE . . . . . . . . . . . 2

L98897 SERVICE KIT (less seals) . . . . . . . . 2L98898 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 2

10 L98899 WORK SECTION 4 (Tilt) . . . . . . . . . 1(includes items 3, 9, 14 & 15)

11 L500955 OUTLET COVER. . . . . . . . . . . . . . . 112 L500957 PLUG SAE-12 . . . . . . . . . . . . . . . . . 113 L500959 PLUG SAE 12 (SOCKET HEAD) . . 1

14 L500135 HRO ACTUATOR “A” END . . . . . . . 415 L500961 SCREW . . . . . . . . . . . . . . . . . . . . 32

654022 LOCK WASHER . . . . . . . . . . . . . . 3216 L500129 RELIEF CARTRIDGE (RP51-A) . . . 1

L96580 RELIEF SEAL KIT . . . . . . . . . . . . . 117 L500958 PLUG WITH TEST PLUG . . . . . . . . 118 SEAL KITS FOR WORK SECTIONS

L500127 SECTION SEAL KIT . . . . . . . . . . 1ea(used with items 5-7 & 10)

L98887 SPOOL SEAL KIT . . . . . . . . . . . . 1ea(used with items 3 & 14)

19 L98895 WORK SECTION (Aux. Hyd.) . . . . . 120 L500960 STUD ASSEMBLY KIT (Aux. Hyd.) . 1

(used with item 20)21 L500300 DUST BOOT. . . . . . . . . . . . . . . . . AR

-- ITEMS NOT SHOWN ---- L68778 KIT, VALVE SECTION (AUX.) . . . . . 1

(includes all items shown on facingpage in the “Auxiliary HydraulicsWork Section” group and item 20)

RS6-34 Telescopic Handler Hydraulic ComponentsMain Hydraulic Valve



00 102321 MANIFOLD, PWP JOYSTICK . . . . . 1(complete assembly)

01 NSS NUT, SOLENOID VALVE. . . . . . . . . 2(included with item 3 and 4)

02 L99908 12 VDC WEATHER PACK COIL . . . 203 L99909 SOLENOID VALVE . . . . . . . . . . . . . 1

L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1(Items included are not shown.)

04 L99910 SOLENOID VALVE . . . . . . . . . . . . . 1L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

(Items included are not shown)05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

5

2

34

1

Hydraulic Components RS6-34 Telescopic HandlerPWP Valve

00



01 L69747 STEER SELECT VALVE.. . . . . . . . . 1(Includes items 1-5)

02 210018 WEATHER PAK VALVE. . . . . . . . . . 103 NSS SHCS #10-24 x 1-3/4" . . . . . . . . . . . 4

(included with item #1)04 107000 SEAL KIT . . . . . . . . . . . . . . . . . . . . 1

(consists of the o-rings shown)

05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 106 50380338 WIRE HARNESS, JUMPER . . . . . . 2

-- ITEMS NOT SHOWN --00 L68711 WIRE HARNESS . . . . . . . . . . . . . . 2

(Connects wire leads to frame wiring.)

RS6-34 Telescopic Handler Hydraulic ComponentsSteer Select Valve

1

4

3

2

5

6



01 101882 STEERING CONTROL UNIT . . . . . 1

1

T

R

L

P

LS

2

02 L500968 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1(Items included are not shown.)

NOTE: Field service is limited to seals replacement.

Hydraulic Components RS6-34 Telescopic HandlerSteer Motor


RS6-34 Telescopic Handler Hydraulic ComponentsBrake Valve

Ref. Part Description Qty. Ref. Part Description Qty.No. No. Req. No. No. Req.

3

4

6

2

1

00 L63363 BRAKE VALVE ASY. (complete) . . . . (machine requires two brake valves)

01 NSS BAIL WIRE. . . . . . . . . . . . . . . . . . . . 102 NSS COVER . . . . . . . . . . . . . . . . . . . . . . 1

L98534 DIAPHRAGM GASKET . . . . . . . . . 1

03 NSS BODY04 NSS TUBE SEAT (not shown) . . . . . . . . . 105 L98536 RUBBER BOOT . . . . . . . . . . . . . . . 106 NSS PUSH ROD . . . . . . . . . . . . . . . . . . . 1

5

00


Hydraulic Components RS6-34 Telescopic HandlerPilot Apply Manifold - Tri-Function (Option)


01a 106898 PILOT APPLY MANIFOLD. . . . . . . . a(includes all items except item 9)

02 L500745 PRESSURE CONTROL . . . . . . . . . 2L99911 SEAL KIT . . . . . . . . . . . . . . . . . . . . 2

03 244655 CARTRIDGE, 3-WAY/2-POSITION . 2240202 SEAL KIT (for one cartridge) . . . . AR

04 106893 SCHS M5-.08X10MM . . . . . . . . . . . 405 NSS COIL NUT (included with item 7). . . 106 106892 COIL, 12VDC. . . . . . . . . . . . . . . . . . 1

07 L500746 VALVE, 2-WAY . . . . . . . . . . . . . . . . 1(includes item 5)

L99924 SEAL KIT, 2-WAY VALVE . . . . . . . . 108 L99917 PLUG -4 NWD STYLE . . . . . . . . . . 109 211161 WIRE HARNESS, TILT CONTROL . 1

a Units equipped with Auxiliary Hydraulics use(2) 106898 Pilot Apply Manifolds.

B

6

2

T

3

7

8

54

1

9


RS6-34 Telescopic Handler Hydraulic ComponentsRadio Remote Manifold — (Option)

01 103413 RADIO REMOTE MANIFOLD . . . . . 1(includes all items shown and listed)

02 103508 2/4 WAY SOLENOID VALVE . . . . . . 1103511 SEAL KIT FOR VALVE . . . . . . . . . . 1

03 103510 12 VDC COIL (DIN CONN.) . . . . . . 504 103509 PROPORTIONAL PRESS. VALVE . 4

103512 SEAL KIT FOR VALVE . . . . . . . . . AR05 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

-- ITEMS NOT SHOWN ---- 103514 SHUTTLE VALVE . . . . . . . . . . . . . . 4-- 103513 SEAL KIT FOR VALVE . . . . . . . . . AR

5

3 4

2

3


1

06 50380273 COMPLETE VALVE. . . . . . . . . . . . . 1(includes all items shown and listed)

07 50220634 2/4 WAY SOLENOID VALVE . . . . . . 150220635 SEAL KIT FOR VALVE . . . . . . . . . . 1

08 104736 12 VDC COIL (WEATHERPAK). . . . 109 50220631 PROPORTIONAL PRESS. VALVE . 4

50220632 SEAL KIT (one per valve) . . . . . . . . 450220633 SCREWS, M4-0.7x12mm . . . . . . . . 8

(not shown)10 NSS MANIFOLD . . . . . . . . . . . . . . . . . . . 1

78

9

6

10

Late-Style Early-Style

NOTE: Before ordering,verify the manifold on themachine matches with theone in the illustration.


10

8

6

5

4

3

2

9

7

1

Hydraulic Components RS6-34 Telescopic HandlerController - Tilt/Frame Level

00



00 103262 HYD. CONTROLLER (complete) . . 101 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 102 103112 LEVER ROD (as shown) . . . . . . . . . 103 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 104 102674 LOCK GATE . . . . . . . . . . . . . . . . . . 105 103114 SELECTOR DISC . . . . . . . . . . . . . . 1

06 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 107 103116 PLATE / BOOT MOUNT . . . . . . . . . 108 103403 METERING CURVE (as shown) . . . 409 103404 RETURN SPRING. . . . . . . . . . . . . . 410a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1

a Items included in seal kit are not shown.

RS6-34 Telescopic Handler Hydraulic ComponentsController - Tilt/Frame Level


9

7

5

4

3

2

8

6

1

Hydraulic Components RS6-34 Telescopic HandlerController - Lift/Extend

00



00 103263 HYD. CONTROLLER (complete) . . 101 103122 KNOB. . . . . . . . . . . . . . . . . . . . . . . . 102 103112 LEVER ROD (as shown) . . . . . . . . . 103 103113 BOOT. . . . . . . . . . . . . . . . . . . . . . . . 104 103114 SELECTOR DISC . . . . . . . . . . . . . . 105 103115 PIVOT/ BALL JOINT . . . . . . . . . . . . 106 103116 PLATE /BOOT MOUNT . . . . . . . . . . 1

07 103403 METERING CURVE (as shown) . . . 408 103404 RETURN SPRING. . . . . . . . . . . . . . 409a 103117 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


RS6-34 Telescopic Handler Hydraulic ComponentsController - Lift/Extend


11

10

6

9

7

4

5

3

2

1

3

8

12

Hydraulic Components RS6-34 Telescopic HandlerController - Tri-Function (Option)

00



00 L71346 JOYSTICK 4BUTTN/TRIGGER . . . 101 L500371 HANDLE W/4 BUTTONS . . . . . . . . 102 L62761 WIRE CONNECTOR . . . . . . . . . . . . 803 L500688 NUT M10 UNI . . . . . . . . . . . . . . . . . 204 L500656 RUBBER BOOT . . . . . . . . . . . . . . . 105 L500689 SELECTOR DISC . . . . . . . . . . . . . . 106 L500652 UNIVERSAL JOINT. . . . . . . . . . . . . 1

07 L500692 SPINDLE GUIDE ASSEMBLY. . . . . 408 L500690 HPV SPINDLE 10mm . . . . . . . . . . . 409 L500691 PILOT SPRING PACK C094 . . . . . . 410 NSS BODY ASSEMBLY. . . . . . . . . . . . . . 111a L500653 SEAL REPAIR KIT . . . . . . . . . . . . . 112 104304 BEZEL, JOYSTICK . . . . . . . . . . . . . 1

a Items included in the seal kit are not shown.

RS6-34 Telescopic Handler Hydraulic ComponentsController - Tri-Function (Option)


6

5

4

3

2

1

Hydraulic Components RS6-34 Telescopic HandlerController - Auxiliary Hydraulics (Option) (Tri-Function - Level Valve)

00



00 103264 VALVE ASSEMBLY (complete).. . . . 101 103077 LEVER ROD (as shown) . . . . . . . . . 102 103084 BOOT (included with item #3) . . . . . 103 103078 CONTROL KIT. . . . . . . . . . . . . . . . . 1

(includes item #2 Boot)04 103403 METERING CURVE (as shown) . . . 2

05 103404 RETURN SPRING. . . . . . . . . . . . . . 206a 103083 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


RS6-34 Telescopic Handler Hydraulic Components(Tri-Function - Level Valve) Controller - Auxiliary Hydraulics


Hydraulic Components RS6-34 Telescopic HandlerFrame Level Cylinder

10

9

8

4

3

5

67

2

1

CylinderPart Number

Stamped Here

ExternalThreads

12

00


RS6-34 Telescopic Handler Hydraulic ComponentsFrame Level Cylinder


00 L63015 FRAME LEVEL CYL. (complete). . . 101 L98503 ROD. . . . . . . . . . . . . . . . . . . . . . . . . 102 L63016 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 104 L99857 5/16”-18x1/4” SET SCREW. . . . . . . 105 L98507 HEAD GLAND . . . . . . . . . . . . . . . . . 106 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

07 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 108 L64367 BUSHING 2.0X2.25X2.0” . . . . . . . . 109 NSS TUBE WELDMENT . . . . . . . . . . . . . 110 L98509 OIL LINE TUBE ASSEMBLY . . . . . . 111 L70495 COUNTER-BALANCE VALVE. . . . . 2

L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 112 L98506 CYLINDER SEAL KIT . . . . . . . . . . . 1



Hydraulic Components RS6-34 Telescopic HandlerLift Cylinder

1

9

8

7

3

65

4

2

10

ExternalThreads

CylinderPart Number

Stamped Here

00


RS6-34 Telescopic Handler Hydraulic ComponentsLift Cylinder


00 L63199 LIFT CYLINDER (complete) . . . . . . 2

Note: Quantities shown are for one cylinder.01 L98518 ROD WELDMENT . . . . . . . . . . . . . . 102 L98520 HEAD GLAND CAP. . . . . . . . . . . . . 103 L99857 5/16”-18X1/4” SET SCREW . . . . . . 104 L98522 HEAD GLAND . . . . . . . . . . . . . . . . . 105 L98523 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

06 L99405 1-1/4”-12 UNF LOCKNUT . . . . . . . . 107 NSS TUBE WELDMENT . . . . . . . . . . . . . 108 L98519 OIL LINE TUBE ASSEMBLY . . . . . . 1

(includes nuts and ferrules) 09 L64175 COUNTER-BALANCE VALVE. . . . . 1

L97889 SEAL KIT (CBV) . . . . . . . . . . . . . . . 110 L98521 CYLINDER SEAL KIT . . . . . . . . . . . 1



Hydraulic Components RS6-34 Telescopic HandlerSlave Cylinder

98

34

5

6

7

21

10

ExternalThreads

CylinderPart Number

Stamped Here

00


RS6-34 Telescopic Handler Hydraulic ComponentsSlave Cylinder


00 L63014 SLAVE CYLINDER (complete) . . . . 101 L98524 ROD WELDMENT . . . . . . . . . . . . . . 102 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L99857 5/16”-18X1/4” SET SCREW . . . . . . 104 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 105 L98528 HEAD GLAND . . . . . . . . . . . . . . . . . 1

06 L98516 PISTON . . . . . . . . . . . . . . . . . . . . . . 107 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 108 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 109 NSS TUBE WELDMENT . . . . . . . . . . . . . 110 L98527 CYLINDER SEAL KIT . . . . . . . . . . . 1



Hydraulic Components RS6-34 Telescopic HandlerTilt Cylinder

8

12

10

9

3

4

5

67

2

1

11

ExternalThreads

CylinderPart Number

Stamped Here

00


RS6-34 Telescopic Handler Hydraulic ComponentsTilt Cylinder


00 L63013 TILT CYLINDER (complete) . . . . . . 101 L98545 ROD WELDMENT . . . . . . . . . . . . . . 102 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L99857 5/16”-18X1/4” SET SCREW . . . . . . 104 L98547 HEAD GLAND CAP. . . . . . . . . . . . . 105 L99866 HEAD GLAND . . . . . . . . . . . . . . . . . 106 L98550 PISTON . . . . . . . . . . . . . . . . . . . . . . 107 L99405 1-1/4”-12 UN LOCKNUT . . . . . . . . . 1

08 NSS TUBE WELDMENT . . . . . . . . . . . . . 109 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 110 L70495 COUNTER-BALANCE VALVE. . . . . 1

L97889 SEAL KIT (CBV)11 L98548 CYLINDER SEAL KIT . . . . . . . . . . . 1

(Items included are not shown.)12 L98551 HYDRAULIC LINE ASSEMBLY. . . . 1


Hydraulic Components RS6-34 Telescopic HandlerBoom-Extend Cylinder

1

34

2

5

11

10

9

8

7

6

12

ExternalThreads

CylinderPart Number

Stamped Here

00


RS6-34 Telescopic Handler Hydraulic ComponentsBoom-Extend Cylinder


00 L63012 EXTEND CYLINDER (complete). . . 101 L98511 ROD WELDMENT . . . . . . . . . . . . . . 102 L63018 BUSHING . . . . . . . . . . . . . . . . . . . . 103 L99857 5/16”-18X1/4” SET SCREW . . . . . . 104 L98513 HEAD GLAND CAP. . . . . . . . . . . . . 105 L98515 HEAD GLAND . . . . . . . . . . . . . . . . . 106 L98516 PISTON . . . . . . . . . . . . . . . . . . . . . . 107 L500668 1-1/8”-12 UN LOCKNUT . . . . . . . . . 1

08 L68003 BUSHING . . . . . . . . . . . . . . . . . . . . 109 NSS TUBE WELDMENT . . . . . . . . . . . . . 110 L48868A COUNTER-BALANCE VALVE. . . . . 1

L96838 SEAL KIT (CBV)11 L98517 HYDRAULIC LINE ASSY. . . . . . . . . 112 L98558 CYLINDER SEAL KIT . . . . . . . . . . . 1




00 L68337 FORK-SHIFT CYL. (complete) . . . . 101 L500763 ROD WELDMENT . . . . . . . . . . . . . . 102 L500762 HEAD GLAND . . . . . . . . . . . . . . . . . 103 L500761 PISTON . . . . . . . . . . . . . . . . . . . . . . 1

04 L500367 3/4”-16 UNF LOCKNUT. . . . . . . . . . 105 NSS TUBE WELDMENT . . . . . . . . . . . . . 106 L500370 SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1


Hydraulic Components RS6-34 Telescopic HandlerFork-Shift Cylinder

1

5

43

2

6

00



00 L63594 ROTATE CYLINDER (complete) . . . 101 L99168 ROD WELDMENT . . . . . . . . . . . . . . 102 L63593 BUSHING . . . . . . . . . . . . . . . . . . . . 103 121554 HEAD GLAND CAP. . . . . . . . . . . . . 104 L99857 5/16”-18X1/4” SET SCREW . . . . . . 105 121554 HEAD GLAND . . . . . . . . . . . . . . . . . 106 L99174 SPACER, ROD . . . . . . . . . . . . . . . . 107 L99175 SUPPORT WASHER. . . . . . . . . . . . 1

1

12

11

10

4

3

5

6

27

89

06 121552 PISTON . . . . . . . . . . . . . . . . . . . . . . 109 L500367 3/4”-16 UN LOCKNUT. . . . . . . . . . . 110 L64175 COUNTER-BALANCE VALVE. . . . . 2

L97889 SEAL KIT (CBV)11 NSS TUBE WELDMENT . . . . . . . . . . . . . 112 L99170 CYLINDER SEAL KIT . . . . . . . . . . . 1


RS6-34 Telescopic Handler Hydraulic ComponentsRotating-Carriage Cylinder

00


Attachments RS6-34 Telescopic HandlerCarriage Forks

5

9

8

3

7

6

4

2

1

72” Long

42” Long

60” Long

48” Long

Forks with 2”Shaft Bore


RS6-34 Telescopic Handler AttachmentsCarriage Forks


01 L71350 FORK, 42”X4”X2” (8,400 lbs.) . . . . . 202a L61001 FORK, 48”X2”X2” (4,200 lbs.) . . . . . 403 L61017 FORK, 48”X4”X2” (8,400 lbs.) . . . . . 204 L66406 FORK, 48”X4”X2-1/4” (12,000 lbs.) . 205 L400929 FORK, 48”X5”X1-3/4” (8,500 lbs.) . . 206 L47263 FORK, 48”X5”X2” (10,500 lbs.) . . . . 2

07 L47265 FORK, 60”X5”X2” (10,500 lbs.) . . . . 208 L60961 FORK, 60”X6”X2-1/4” (12,500 lbs.) . 209 L68331 FORK, 72”X5”X2” (10,500 lbs.) . . . . 2

a Requires 2 sets (4 forks).

NOTE: Ratings are based on two forks with theload at 24” on center, except for item 2, for which four forks are required.WARNING

When ordering forks, select forks with a rat-ing capacity that meets or exceeds the liftingcapacity of the machine; failure to use thecorrect forks could result in injury or death.For more information contact dealer (or man-ufacturer).


1

4

5

32

Attachments RS6-34 Telescopic HandlerStandard Carriage



01 CARRIAGE, WELDMENT . . . . . . . . 1L99192 48” CarriageL99193 66” Carriage

02 FORK SHAFT BAR . . . . . . . . . . . . . 1L63319 48” Carriage (50-1/2”)L63320 66” Carriage (68-1/2”)

03 L400425 WASHER, FORK SHAFT . . . . . . . . 204 L520005 3/8”-16 NYLON INSERT NUT . . . . . 205 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2

RS6-34 Telescopic Handler AttachmentsStandard Carriage


32

67

8

910

16

152

11 9 12

1

13

18

20

19

1715

5

4

Attachments RS6-34 Telescopic HandlerFork-Shift Carriage



01 L500215 FORK SHIFT CARR., WLDMNT . . . 102 L50519 3/4”-10 NYLON INSERT NUT . . . . . 303 L400425 FORK SHAFT WASHER . . . . . . . . . 104 L50333 3/4”-10X3” BOLT . . . . . . . . . . . . . . 105 L66919 FORK SHAFT, 50” . . . . . . . . . . . . . . 106 L66931 FORK SLIDE PLATE . . . . . . . . . . . . 207 650500 3/4”-10X1-1/2” BOLT . . . . . . . . . . . . 108 FORK SLIDE COUPLER. . . . . . . . . 1

L66921 Used with 4” wide forksL66948 Used with 5” wide forks

09 L63715 TWIN CUSHION TOP PLATE . . . . . 2

10 L50242 5/16”-18X2-1/4” BOLT . . . . . . . . . . . 211 L63716 TWIN HOSE CUSHION. . . . . . . . . . 112 L520004 5/16”-18 NYLON INSERT NUT . . . . 213 L65273 QUICK COUPLER SET. . . . . . . . . . 115 L66918 CYLINDER MOUNT . . . . . . . . . . . . 216 L68337 FORK SHIFT CYLINDER . . . . . . . . 117 L50562 3/4”-10X4” BOLT . . . . . . . . . . . . . . . 218 L63143 ADAP -8ORM -6JICM W/.06 ORF . 219 L66950 HOSE -6 A6/A6 59” . . . . . . . . . . . . . 120 L66949 HOSE -6 A6/A6 56” . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler AttachmentsFork-Shift Carriage


1

5

43

129

1110

87

5

4

32

15

16

17

18

19

20

12

11

10

6

13

13

14

21

Attachments RS6-34 Telescopic HandlerRotating Carriage



01 ROTATE CARRIAGE, WELDMNT . 1L99225 48” CarriageL99224 66” Carriage

02 FORK SHAFT BAR . . . . . . . . . . . . . 1L63319 48” Carriage (50-1/2” long)L63320 66” Carriage (68-1/2” long)

03 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 204 L400425 RETAINER. . . . . . . . . . . . . . . . . . . . 205 L520005 3/8”-16 NYLON INSERT NUT . . . . . 206 L50205 2”-12 CASTELLATED NUT . . . . . . . 1

L61287 WASHER (not shown) . . . . . . . . . . 107 651625 3/8”-16X1-1/4” BOLT” . . . . . . . . . . . 608 654026 3/8” LOCK WASHER. . . . . . . . . . . . 609 L61709 SLIDE PAD 3”X4” . . . . . . . . . . . . . . 310 L65273 QUICK COUPLER SET. . . . . . . . . . 1

(includes both couplers)

11 L63143 ADAP., -8ORM -6JICM STR.. . . . . . 2(with orifice)

12 L63344 HOSE, -6 A8/A6 20” . . . . . . . . . . . . 213 L51968 ADAP., -6ORM -6JICM 90º . . . . . . . 214 L520005 3/8”-16 NYLON INSERT NUT . . . . 115a L63968 BASE END PIVOT PIN . . . . . . . . . . 116 650493 3/8”-16X2-3/4” BOLT . . . . . . . . . . AR17 L63594 ROTATE CYLINDER . . . . . . . . . . . . 118a L63969 ROD END PIVOT PIN . . . . . . . . . . . 1

650650 1/2”-13X3-1/2” BOLT . . . . . . . . . . . 1L520019 1/2”-13 NYLON INSERT NUT . . . . 1

19 NSS ROTATE PIN (welded to #20). . . . . 120 L63952 ROTATE, PLATE (incIudes #19) . . 121 L64367 BUSHING (not shown) . . . . . . . . . . 1

RS6-34 Telescopic Handler AttachmentsRotating Carriage


17 1623

2221

20

19 18

8’ Truss Boom

15

27

14

11

13

12

910

4

9

5

6

3

7

1

2

24

25

26

5’ Truss Boom

Hydraulic WinchWith Brake

Attachments RS6-34 Telescopic HandlerTruss Booms


01 L99237 8’ TRUSS BOOM WELDMENT . . . . 102 104835 5’ TRUSS BOOM WELDMENT . . . . 103 L64294 HOSE -8 A8/A8 53” . . . . . . . . . . . . . 204 114742 ADAP -8ORM -8JICM RUN TEE. . . 105 650706 1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2

L520003 1/4”-20 NYLON INSERT NUT . . . . 206 054626 ADAP -8ORM -8JICM STR . . . . . . . 207 L65273 QUICK COUPLER SET. . . . . . . . . . 109 054816 ADAP -8ORM -8JICM 90º . . . . . . . . 210 L82358 RELIEF VALVE . . . . . . . . . . . . . . . . 111a 100963 HYDRAULIC WINCH. . . . . . . . . . . . 112 650569 1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 613 L520019 1/2-13 NYLON INSERT NUT . . . . . 614 089099 ADAP -10ORM -8JICM . . . . . . . . . . 215 L400398 HOSE -6 A8/A8 18.5” . . . . . . . . . . . 216 650733 5/16”X2-1/2” BOLT . . . . . . . . . . . . . 217 100076 PIN, TRUSS WINCH . . . . . . . . . . . . 118 L520004 5/16”-18 NYLON INSERT NUT . . . . 219 L65338 WINCH SHEAVE . . . . . . . . . . . . . . . 120b L66946 3/8”X60’ WINCH CABLE . . . . . . . . . 1

(Includes hook and swivel)21 650492 3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2


22 654026 3/8” LOCK WASHER. . . . . . . . . . . . 223 L60451 WINCH BALL. . . . . . . . . . . . . . . . . . 124 L61411 PINTLE HOOK . . . . . . . . . . . . . . . . 125 L50380 1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 426 654030 1/2” LOCK WASHER. . . . . . . . . . . . 427c 088442 ADAP -8JICFS -8JICM 90º . . . . . . . 2

-- ITEMS NOT SHOWN --00 L500222 ADAPTER PLATE. . . . . . . . . . . . . . 1

a Used with 5’ truss booms after attachmentserial number 11182. The winch on 5’ trussbooms before attachment serial number 11183have been discontinued; you must purchase aboom and a winch.

b Used with 5’ truss booms with winch.

c Not used on some attachments.

RS6-34 Telescopic Handler AttachmentsTruss Booms


12 1

13

1511

14

10

12

3

5

97

8

4

6

Attachments RS6-34 Telescopic Handler180º Swing Platform


01 104478 VALVE ASSEMBLY . . . . . . . . . . . . . 102 104477 PUMP ASSEMBLY . . . . . . . . . . . . . 103 104476 HARDWARE KIT (pivot) . . . . . . . . . 104 104471 HUB ASSEMBLY . . . . . . . . . . . . . . . 205 104469 SHAFT AND KEY ASSEMBLY . . . . 106 104475 THRUST PLATE . . . . . . . . . . . . . . . 207 104474 BACK HALF (attachment) . . . . . . . . 108 104468 ACTUATOR . . . . . . . . . . . . . . . . . . . 109 104472 FRONT HALF . . . . . . . . . . . . . . . . . 110 103909 BACK SIDE . . . . . . . . . . . . . . . . . . . 111 103906 RIGHT DOOR . . . . . . . . . . . . . . . . . 112 103908 FRONT SIDE. . . . . . . . . . . . . . . . . . 1


13 103907 LEFT DOOR . . . . . . . . . . . . . . . . . . 114 104467 BASE . . . . . . . . . . . . . . . . . . . . . . . . 115 100883 DECAL, PLATFORM RULES . . . . . 2

-- ITEMS NOT SHOWN --00 104470 HOSE KIT . . . . . . . . . . . . . . . . . . . . 100 103911 PIN AND CHAIN KIT . . . . . . . . . . . . 100 103910 HARDWARE KIT (platform bolts) . . 100 101149 DECAL, FALL HAZARD . . . . . . . . . 2

RS6-34 Telescopic Handler Attachments180º Swing Platform


52

1

6

3

4

Attachments RS6-34 Telescopic HandlerWork Platform - Early Style

01 103905 BASE . . . . . . . . . . . . . . . . . . . . . . . . 102 105603 RIGHT DOOR . . . . . . . . . . . . . . . . . 103 105604 LEFT DOOR . . . . . . . . . . . . . . . . . . 104 105605 FRONT SIDE. . . . . . . . . . . . . . . . . . 105 105606 BACK SIDE . . . . . . . . . . . . . . . . . . . 106 100883 DECAL, PLATFORM RULES . . . . . 2


-- ITEMS NOT SHOWN --00 103911 PIN AND CHAIN KIT . . . . . . . . . . . . 100 101149 DECAL, FALL HAZARD . . . . . . . . . 200 103910 HARDWARE KIT . . . . . . . . . . . . . . . 1

RIGHT LEFT


RS6-34 Telescopic Handler AttachmentsWork Platform - Later Style

LEFT

RIGHT

34

65

2

1

87

8 7

9

10

9

1211

13 14


01 103905 BASE (platform). . . . . . . . . . . . . . . . 102 103906 PANEL, RIGHT DOOR . . . . . . . . . . 103 103907 PANEL, LEFT DOOR . . . . . . . . . . . 104 103908 PANEL, FRONT. . . . . . . . . . . . . . . . 105 103909 PANEL, REAR . . . . . . . . . . . . . . . . . 106 100883 DECAL, PLATFORM RULES . . . . . 207 105845 PIN, FORK SECURE. . . . . . . . . . . . 2

(secures platform to forks)08 076099 HAIRPIN CLIP (9/64”) . . . . . . . . . . . 209 103911 PIN, DOOR SAFETY. . . . . . . . . . . . 2

10 103910 HARDWARE KIT . . . . . . . . . . . . . . . 1(includes six bolts and nuts)

11 210917 PIN, GATE RETAINER . . . . . . . . . . 2(secures doors to platform when

front panel is removed)12 106917 PIN, HAIRPIN COTTER (1/8”) . . . . 213 101149 DECAL, FALL HAZARD . . . . . . . . . 214 106927 DECAL, DOOR SAFETY PIN . . . . . 2


1

01 L500373 1.3 CU. YD. BUCKET WELDMNT . 1L68831 CUTTING EDGE 98” (weld on) . . . . 1

Item Part Description Qty.No. No. Req.

Attachments RS6-34 Telescopic HandlerBucket


RS6-34 Telescopic Handler Notes


GENERAL INFORMATION

Decal location information is provided to assist inthe proper selection and application of newdecals, in the event original decals become dam-aged or the machine is repainted.

For correct replacement of decals, compare thelocation illustrations to your machine beforestarting to refinish the unit. Check off eachrequired decal using the illustration referencenumber to find the part number, description andquantity in the list. Refer to the appropriate illus-tration for replacement locations.

If there is a decal on a part that is to be replaced,be sure that a new decal is applied to thereplaced part.

NEW DECAL APPLICATIONBefore applying the new decals, surfaces mustbe free from dirt, dust, grease and other foreignmaterial. To apply a solid-formed decal, removethe smaller portion of the decal backing paperand apply this part of the exposed adhesivebacking to the clean surface while maintainingproper position and alignment. Slowly peel offthe other portion of the backing paper whileapplying hand pressure to smooth-out decal sur-face. To apply a die-cut decal, first remove thebacking paper. Then, properly orient and positionthe decal onto the clean mounting surface. Afterthe decal is firmly applied and smoothly presseddown, remove the front covering paper.

Paint Finish

Use this list to order paint for refinishing:

167788 One Gallon Yellow167789 6 (12 oz. Spray Cans) Yellow167754 One Gallon Gun-Metal Gray167755 6 (12 oz. Spray Cans) Gun-Metal Gray

CAUTIONALWAYS follow the safety precautions ondecals. Replace decals if they are damaged,or if the unit is repainted. If repainting, besure that all applicable decals are affixed intheir proper locations.

Boom Attachment Decals

L65927 WARNING - PINCH POINTL65348 WARNING - WINCHL66042 WARNING - TRUSS BOOM TILT

Decals RS6-34 Telescopic HandlerGeneral Information and Application Instructions

Decal Kits

104916 RS6-34 Telescopic Handler w/o PWP104917 RS6-34 Telescopic Handler w/ PWP



01 L70305 DANGER - HANDS OUT . . . . . . . AR02 L65927 WARNING - PINCH POINT . . . . . AR03 184069 GEHL, 6-3/4” . . . . . . . . . . . . . . . . AR04 137632 HYDRAULIC OIL FILL . . . . . . . . . AR05 L65932 WARNING - NO RIDERS. . . . . . . AR06 102026 GEHL, 2”. . . . . . . . . . . . . . . . . . . . AR

07 L65928 DANGER - PERSONAL INJURY . AR(units without PWP)

08 L66613 DYNATTACH UNLOCKED . . . . . . AR09 50301416 DIESEL FUEL. . . . . . . . . . . . . . . . AR10 104872 RS6-34, RIGHT HAND . . . . . . . . . AR11 L65942 HOT SURFACE . . . . . . . . . . . . . . AR

RS6-34 Telescopic Handler DecalsFrame and Boom

4

2

9

10

11

2

1

5

8

6

7

2

3


9

2

Decals RS6-34 Telescopic HandlerFrame and Boom

2

18

7

10

17

1

1116

13

14

12

4

698

2

5

2

3



01 L70305 DANGER - HANDS OUT . . . . . . . AR02 L65927 WARNING - PINCH POINT . . . . . AR03 L65933 WARNING - JUMP START. . . . . . AR04 102027 GEHL, 5”. . . . . . . . . . . . . . . . . . . . AR05 L65937 DYNATTACH DIAGRAM . . . . . . . AR06 184069 GEHL, 6-3/4” . . . . . . . . . . . . . . . . AR07 056859 ANTI-FREEZE . . . . . . . . . . . . . . . AR08 L62583 HALF ZONE MARKER . . . . . . . . . . 509 L67718 NO. “0” EXTENSION MARKER . . . 1

L67719 NO. “1” EXTENSION MARKER . . . 1L67720 NO. “2” EXTENSION MARKER . . . 1L67721 NO. “3” EXTENSION MARKER . . . 1L67722 NO. “4” EXTENSION MARKER . . . 1L67723 NO. “5” EXTENSION MARKER . . . 1

10 072798 COOLANT UNDER PRESSURE. . . 111 L65932 WARNING - NO RIDERS. . . . . . . AR12 L63474 BRAKE FLUID . . . . . . . . . . . . . . . AR13 100359 OPERATOR MANUAL WARNING. . 114 L65928 DANGER - PERSONAL INJURY . AR

(units without PWP)16 103229 LUBE CHART . . . . . . . . . . . . . . . . . 117 104871 RS6-34 LEFT HAND . . . . . . . . . . . . 118 184043 GEHL, 3.75". . . . . . . . . . . . . . . . . . . 1

RS6-34 Telescopic Handler DecalsFrame and Boom


DECAL LOCATIONS - OPERATOR STATIONItem Part Description Qty. Item Part Description Qty.No. No. Req. No. No. Req.

01 L70306 WARNING - TILT HAZARD . . . . . . . 1/GENERAL OPERATOR

02 L65930 WARNING - MACHINE LEVEL . . . . 103 L65926 WARNING - CARRY LOAD LOW . . 104 L68295 F-N-R SHIFT . . . . . . . . . . . . . . . . . . 105 140516 MADE IN U.S.A. . . . . . . . . . . . . . . . 106 101506 WARNING - PARK BRAKE . . . . . . . 1

/SEAT BELT-- LOAD CHARTS--

07 104875 STANDARD CARRIAGE . . . . . . . . . 1104876 ROTATING CARRIAGE . . . . . . . . . 1104877 BUCKET LOAD CHART . . . . . . . . . 1104878 TRUSS BOOM LOAD CHART . . . . 1104879 WINCH LOAD CHART . . . . . . . . . . 1104880 PWP LOAD CHART . . . . . . . . . . . . 1

08 L63632 ATTACHMENT TILT/FRAME LVL . . 109 L63631 BOOM CONTROL . . . . . . . . . . . . . . 110 102718 AUX. HYD. CONTROL (optional) . . 111 102717 IGNITION/START/HORN. . . . . . . . . 112 L70307 DANGER-HIGH VOLTAGE . . . . . . . 1

/MOVING PARTS

-- OPTIONAL TRI-FUNCTION CONTROLLER --13 104215 JOYSTICK CONTROL . . . . . . . . . . 114 L63311 SWAY CONTROL . . . . . . . . . . . . . . 100 L71378 VALVE ADJUSTMENT. . . . . . . . . . . 1

(not shown - attaches to pilot valve)

1

Decals RS6-34 Telescopic HandlerCab

Tri-function Hydraulic Controllers (Option)Dual Hydraulic Controllers (Standard)

13

14

7

108 97

6

12

3 4

7

11

5


DECAL LOCATIONS - PWP EQUIPPED UNITS

1


01 L71554 WARNING - PERSONNEL LIFT. . AR02 L71555 WARNING - WORK PLATFORM . AR

/RULES03 L71700 PERSONNEL LIFT SAFETY . . . . AR

/RULES

04 104880 PWP LOAD CHART . . . . . . . . . . . AR05 102969 PWP SWITCH . . . . . . . . . . . . . . . AR06 103028 PWP SYSTEM . . . . . . . . . . . . . . . AR

RS6-34 Telescopic Handler DecalsPWP Equipped Units

3

4

6

215


054626 100 24054994 100 14054994 101 14055005 100 22055064 100 10055064 101 10056859 196 07072340 17 15072798 196 10076099 191 08076143 100 09079026 100 21079026 101 21088442 100 23089069 17 19089070 17 19100011 107 08100012 100 07100071 23 10100076 187 17100102 39 10100359 196 13100883 189 15100883 190 06100883 191 06100963 187 11101149 189 00101149 190 00101149 191 13101278 17 04101320 105 01101436 15 22101495 11 24101506 198 06101667 29 05101712 39 04101717 11 11101719 15 19101727 9 13101792 15 20101877 17 34101877 21 10101879 31 01101882 103 01101882 154 01101882 21 09101926 49 18102026 195 06102027 196 04102063 47 10102173 5 04102262 47 11102313 119 07102313 121 13102313 123 09102313 125 13102313 127 13

102313 129 15102313 131 12102313 133 12102313 135 12102313 137 12102313 149 00102313 149 08102313 100 15102313 101 15102313 101 15102321 123 10102321 125 14102321 127 09102321 129 14102321 131 14102321 133 14102321 135 14102321 137 14102321 152 00102321 41 02102408 40 01102529 27 08102530 27 05102534 27 15102572 39 00102573 80 03102575 80 07102575 85 08102576 80 08102576 81 08102576 85 09102576 89 24102583 85 21102587 77 07102587 85 20102601 85 37102614 85 04102615 85 06102617 82 01102618 82 02102619 82 03102620 82 04102621 82 05102622 82 06102623 82 07102624 82 09102625 82 10102626 82 11102627 82 12102628 82 13102632 82 19102633 82 20102634 82 21102635 82 24102636 82 24102637 82 24102647 39 00

102649 21 10102668 107 23102668 77 22102674 159 04102680 15 03102681 15 04102692 7 06102705 15 02102711 13 03102712 13 10102717 198 11102718 198 10102722 9 20102727 7 32102728 7 31102741 29 03102769 7 29102778 7 28102780 29 01102780 29 07102781 29 04102783 21 05102785 27 04102831 113 10102831 115 10102831 131 10102831 133 10102831 135 10102831 137 10102836 100 12102836 101 12102836 101 12102837 107 21102840 105 02102840 107 12102843 113 14102843 115 14102861 33 15102861 45 00102863 87 22102863 91 22102874 15 01102880 7 13102881 7 23102882 17 17102882 7 07102886 15 21102893 85 22102901 15 12102907 19 01102913 11 07102925 11 —102926 45 00102928 15 15102944 19 03102945 19 04102948 15 20

102949 57 10102950 73 01102951 73 02102952 73 03102952 73 08102953 73 04102954 73 05102954 73 09102955 73 06102956 73 07102957 73 10102959 73 12102968 43 00102969 199 05102974 49 19103013 11 —103014 15 00103017 149 01103019 9 12103021 7 11103022 7 10103022 9 11103023 7 19103023 9 09103024 7 20103024 9 10103025 13 08103026 13 09103027 13 01103028 199 06103029 9 19103033 19 11103077 165 01103078 165 03103083 165 06103084 165 02103088 49 07103089 7 01103099 17 23103099 17 27103099 17 28103099 42 —103099 43 00103100 17 29103100 17 30103100 17 31103100 17 32103101 39 00103104 17 00103104 17 33103112 159 02103112 161 02103113 159 03103113 161 03103114 159 05103114 161 04103115 159 06

Part Page ItemNo. No. No.




Numerical Index RS6-34 Telescopic HandlerN

UM

ERIC

AL

IND

EX


103115 161 05103116 159 07103116 161 06103117 159 10103117 161 09103122 159 01103122 161 01103130 101 04103130 101 04103130 148 01103179 11 —103180 11 —103192 39 00103195 23 13103199 37 13103199 39 05103221 17 24103221 17 25103221 17 26103229 196 16103262 111 03103262 119 01103262 121 01103262 123 01103262 125 01103262 127 01103262 129 01103262 159 00103263 111 02103263 119 02103263 121 02103263 123 02103263 125 02103263 127 02103263 129 02103263 161 00103264 111 01103264 113 02103264 115 02103264 121 12103264 125 16103264 129 05103264 131 02103264 133 02103264 135 02103264 137 02103264 165 00103264 25 07103265 17 00103270 37 18103315 113 09103315 115 09103315 119 06103315 123 06103315 125 12103315 127 05103315 129 09

103315 131 07103315 133 07103315 135 07103315 137 07103315 31 26103317 100 17103317 101 17103317 101 17103317 107 06103318 100 18103318 101 18103318 101 18103318 113 12103318 115 12103318 119 08103318 121 11103318 123 05103318 123 08103318 123 11103318 125 08103318 125 11103318 125 17103318 127 08103318 129 11103318 131 09103318 133 09103318 135 09103318 137 09103318 31 27103319 103 07103319 107 11103320 105 14103320 107 05103330 147 21103330 93 42103330 97 05103331 147 22103331 93 43103331 97 06103333 93 37103359 21 01103368 100 16103368 101 16103368 101 16103368 127 12103368 129 13103368 131 15103368 133 17103368 135 15103368 137 17103368 31 29103370 37 21103370 7 27103371 37 22103371 7 26103390 82 16103391 82 17

103392 82 18103393 85 07103394 85 03103395 85 16103396 85 28103398 85 25103399 85 47103401 85 49103401 89 50103402 87 11103403 159 08103403 161 07103403 165 04103404 159 09103404 161 08103404 165 05103413 117 06103413 157 01103414 43 00103424 43 00103425 117 07103475 42 07103475 43 05103476 42 06103476 43 06103479 43 01103480 43 03103482 43 02103505 117 03103505 127 14103505 129 16103505 135 18103505 137 20103508 157 02103509 157 04103510 157 03103511 157 02103512 157 04103513 157 —103514 157 —103582 25 04103626 45 06103675 7 11103708 25 11103856 37 07103905 190 01103905 191 01103906 189 11103906 191 02103907 189 13103907 191 03103908 189 12103908 191 04103909 189 10103909 191 05103910 189 00103910 190 00

103910 191 10103911 189 00103911 190 00103911 191 09103991 31 11103994 43 09104064 41 00104078 41 03104214 25 06104215 198 13104222 37 08104304 163 12104304 25 02104425 53 01104428 105 10104428 105 12104467 189 14104468 189 08104469 189 05104470 189 00104471 189 04104472 189 09104474 189 07104475 189 06104476 189 03104477 189 02104478 189 01104504 85 48104504 89 39104518 80 04104546 89 44104600 85 44104600 89 34104604 85 36104604 89 28104607 82 26104621 82 25104641 85 45104641 89 35104642 85 46104642 89 36104655 82 22104655 83 11104675 43 04104736 157 08104808 47 06104835 187 02104846 9 15104871 196 17104872 195 10104875 198 07104876 198 07104877 198 07104878 198 07104879 198 07104880 198 07104880 199 04





RS6-34 Telescopic Handler Numerical IndexN

UM

ERIC

AL

IND

EX


105087 149 03105214 51 08105236 21 07105266 87 10105266 87 14105266 91 10105266 91 14105281 45 20105580 113 00105580 115 00105580 131 00105580 133 00105580 135 00105580 137 00105580 17 00105580 25 00105593 115 18105593 133 16105593 137 16105603 190 02105604 190 03105605 190 04105606 190 05105620 17 00105835 17 20105835 7 00105845 191 07105850 45 17105857 77 04105958 85 18105958 89 22105959 17 37105960 17 36106259 73 11106892 156 06106893 156 04106898 113 15106898 115 15106898 131 13106898 133 13106898 135 13106898 137 13106898 156 01106917 191 12106927 191 14106965 43 05107000 153 04114742 101 09121552 177 06121554 177 03122778 31 31136304 19 06136305 19 07136310 19 13136383 33 06136383 49 01136443 33 07

136443 49 10136686 49 15137498 49 04137498 5 01137501 49 05137501 5 02137503 19 16137542 109 01137632 195 04137659 49 02137784 101 07139170 11 16140516 198 05167754 194 00167755 194 00167788 194 00167789 194 00183629 49 13184069 195 03184069 196 06187841 19 05193709 100 11202583 27 25210018 153 02210126 45 00210170 23 01210309 47 09210321 47 15210329 47 19210346 47 23210347 47 02210356 53 25210358 37 15210369 37 16210394 37 17210403 23 14210404 23 16210405 23 15210447 139 10210452 37 06210477 47 05210484 45 04210493 51 01210569 139 12210569 77 11210572 139 13210572 77 14210738 33 01210772 33 02210777 43 04210867 43 03210909 17 00210909 53 00210917 191 11211040 5 05211161 156 09240202 156 03

244655 156 03272648 17 20420-19671 47 13420-35602 17 00420-35602 53 0050220061 43 0750220264 78 0250220264 79 0250220265 78 0150220265 79 0150220266 78 0350220266 79 0350220267 78 0250220267 79 0250220626 42 0550220627 42 0450220628 42 0350220629 42 0150220630 42 0850220631 157 0950220632 157 0950220633 157 0950220634 157 0750220635 157 0750301416 195 0950380273 157 0650380274 42 —50380338 153 0650380450 31 0250380516 31 1850380576 11 0250380577 11 0150380579 11 0350380583 11 0450380585 11 —50380682 11 0250380683 11 —50380751 17 2050380825 42 1250380826 42 0950380836 42 —50380843 100 0450380843 148 0150380847 19 10650426 42 11650484 37 12650489 31 04650495 100 06650495 101 06651148 100 05651148 101 05651151 29 02651543 77 15655001 93 10655001 97 16655006 27 12L10465 27 10

L120041 49 17L400398 187 15L400425 181 03L400425 183 03L400425 185 04L400929 179 05L40805 47 24L41179 45 02L41261 21 02L41847 35 06L41847 37 11L41848 17 18L41854 33 05L444070 53 01L445014 100 01L445014 101 01L446025 31 21L446025 33 12L447005 45 18L44859 27 11L46865 100 03L46865 101 03L46865 101 03L46865 148 02L47263 179 06L47265 179 07L48179 27 07L48868A 175 10L49327 31 22L500001 11 15L500004 11 17L500019 9 16L500020 7 16L500021 13 04L500021 15 08L500021 7 17L500021 9 05L500022 7 15L500024 9 08L500025 9 14L500027 9 18L500028 9 17L500036 15 16L500042 13 05L500042 15 07L500042 9 04L500057 7 12L500099 11 23L500111 9 07L500127 151 18L500129 151 16L500130 151 00L500132 151 04L500134 151 03L500135 151 14L500163 19 08L500215 183 01






UM

ERIC

AL

IND

EX






L500222 187 00L500225 17 00L500273 69 03L500273 71 03L500274 72 01L500294 59 08L500300 151 21L500339 39 07L500368 148 03L500370 176 06L500371 163 01L500373 192 01L500407 61 07L500407 69 23L500408 61 08L500408 69 22L500408 69 24L500409 61 16L500410 69 01L500411 69 02L500412 69 04L500413 69 19L500414 69 20L500451 80 02L500451 81 02L500452 81 03L500453 81 04L500454 80 05L500454 81 05L500455 81 06L500455 89 38L500457 87 01L500457 91 01L500459 87 02L500459 91 02L500460 87 02L500460 91 02L500461 87 02L500461 91 02L500463 87 03L500463 91 03L500464 87 05L500464 91 05L500465 87 06L500465 91 06L500466 87 07L500466 91 07L500467 87 08L500467 91 08L500468 87 09L500468 91 09L500469 87 10L500469 91 10L500470 91 11L500471 87 12L500471 91 12L500472 87 13





UM

ERIC

AL

IND

EX











UM

ERIC

AL

IND

EX






L66965 53 05L67504 77 01L67657 49 16L67718 196 09L67719 196 09L67720 196 09L67721 196 09L67722 196 09L67723 196 09L67756 37 19L67756 51 12L68003 141 02L68003 143 17L68003 145 06L68003 171 08L68003 173 09L68003 175 08L68003 93 16L68003 97 22L68003 99 05L68006 93 15L68239 143 02L68239 143 03L68239 147 02L68239 147 03L68295 198 04L68331 179 09L68337 176 00L68337 183 16L68348 145 07L68348 93 20L68350 93 01L68351 143 01L68351 147 01L68352 145 11L68352 145 12L68356 145 08L68358 93 19L68374 143 20L68374 143 21L68376 147 13L68376- 147 14L68496 23 12L68531 53 19L68533 53 18L68562 53 24L68563 53 22L68571 45 03L68592 45 15L68595 45 08L68596 45 07L68604 45 19L68619 33 14L68619 45 00L68641 27 24L68694 109 12L68694 111 08



L70495 173 10L70521 47 18L70629 45 00L70634 23 02L70701 39 08L71074 17 06L71075 17 03 L71076 17 13L71076 17 14L71077 17 09L71081 17 12L71081 45 00L71082 17 07L71084 17 08L71086 17 05L71305 7 00L71346 113 01L71346 115 01L71346 131 01L71346 133 01L71346 135 01L71346 137 01L71346 163 00L71346 25 01L71350 179 01L71378 198 00L71553 41 01L71554 199 01L71555 199 02L71595 39 10L71691 17 10L71691 41 00L71700 199 03L71725 40 03L71726 40 02L71729 40 00L71732 40 05L71748 147 16L71748 93 36L71748 97 03L71750 40 04L71751 41 05L71752 41 04L76020 47 01L82358 187 10L94824 57 02L96053 72 05L96580 151 16L96838 175 10L97489 31 03L97489 5 03L97525 59 10L97526 59 11L97889 167 11L97889 169 09L97889 173 10L97889 177 10


UM

ERIC

AL

IND

EX











UM

ERIC

AL

IND

EX






RS6-34 Telescopic Handler Numerical Index

L99031 65 06L99032 65 07L99038 71 05L99045 57 20L99163 31 09L99168 177 01L99169 177 03L99170 177 12L99171 177 05L99174 177 06L99175 177 07L99182 53 20L99184 5 06L99184 53 04L99184 63 02L99192 181 01L99193 181 01L99224 185 00L99225 185 01L99237 187 01L99246 55 04L99246 57 16L99246 57 24L99249 55 15L99251 57 03L99253 57 05L99260 55 09L99260 55 12L99261 55 10L99262 55 07L99262 57 25L99270 57 26L99274 57 23L99278 67 05L99279 69 08L99284 55 03L99284 55 06L99284 57 18L99285 55 08L99285 57 32L99286 55 01L99287 57 29L99288 57 31L99294 57 33L99295 57 34L99296 57 35L99312 57 30L99405 167 07L99405 169 06L99405 173 07L99425 21 06L99434 51 07L99696 69 21L99785 74 04L99866 173 05L99908 149 05

L99908 152 02L99909 152 03L99910 149 06L99910 152 04L99911 149 06L99911 152 03L99911 152 04L99911 156 02L99917 156 08L99924 156 07L99925 149 02L99927 149 02L99951 77 03L99969 78 00P471997 149 07

NU

MER

ICA

LIN

DEX


AAccelerator Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Access Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .189Air Cleaner Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33, 49Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 49Arm Rest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Attachment Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .181Attachment Forks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .179Attachment, Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .185Attachment, Truss Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .187Auxiliary Hydraulic Work Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .147, 151Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Axle Case . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85, 89Axle Steering Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78, 79Axle Tie Rod . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78, 79Axle, Planet Gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85, 89

BBack-up Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Back-up Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Battery Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Belt, Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Bevel Gear Set, Differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87, 91Block Heater, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Blower Motor, Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Boom Extend Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .175Boom Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Bottle, Windshield Washer Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Bracket, Alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Bracket, Arm Rest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Bracket, Light Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Bracket, Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Bracket, Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 45Brake Disc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82, 83Brake Lever Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Brake Line Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105, 107Brake Master Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .155Brake Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Brake Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .155

CCab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Cable, Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35Cable, Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45

PAGE

Subject Index RS6-34 Telescopic HandlerSU

BJE

CT

IND

EX


RS6-34 Telescopic Handler Subject Index

PAGECable, Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Canopy Wire Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 17Cap, Fuel Fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Cap, Hydraulic Fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Cap, Radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Cap, Steering Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Carriage, Rotating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .185Carriage, Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .181Charge Pump, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Coil, Weather Pack 12 VDC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149, 152, 157Column, Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Control Module, PWP/WPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Controller, Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 121, 125, 129, 165Controller, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25, 113, 115, 131, 135, 137Controller, Lift / Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 119, 121, 123, 125, 127, 129, 161Controller, Tilt / Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 119, 121, 123, 125, 127, 129, 159 Controller, Tri-Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 115, 131, 133, 135, 137, 163Cooler, Hydraulic / Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Cutting Edge, Bucket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .192Cylinder, Boom Extend . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .175Cylinder, Fork-Shift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .176, 183Cylinder, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .167Cylinder, Lift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169Cylinder, Rotating-Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .177, 185Cylinder, Slave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171Cylinder, Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .173

DDash Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 17Decal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .189, 190, 191Defroster Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87, 91Differential Gear Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87, 91Diode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 39Diode Wire, Alternator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Dipstick, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Door Striker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Door, Cab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Driveshaft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53

EEngine Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Ether Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Exhaust Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51

SUB

JECT IN

DEX


PAGE

Subject Index RS6-34 Telescopic Handler

FFan Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Fan Guard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Fan, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Fender . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Filter, Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 49Filter, Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Filter, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Filter, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 31Filter, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 53Flasher, Turn Signal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149F-N-R Shifter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21F-N-R Shifter Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 21Forks, Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .179Fork-Shift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .183Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .167Frame Level Indicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Frame Level Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77, 139Fuel Fill Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Fuel Line Tube . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Fuel Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Fuse Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Fuse, 60 AMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

GGauge, Air Restriction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Gauge, Hour Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Gauge, Warning Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Gauge, Water Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Glass Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Glass, Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Glass, Left Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Glass, Lower Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Glass, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 9Glass, Right-Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Glass, Top . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Glass, Upper Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Ground Strap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 35Guard, Window Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

HHandle, Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Handle, Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Head Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

SUB

JEC

T IN

DEX



PAGEHeater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Heater Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Heater Temperature Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Hinge, Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Hood, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Hood, Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Hood, Radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Hood, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37, 39Hood, Transmission Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Horn, 12 VDC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35, 37Hose Tray, Inner Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97Hose Tray, Intermediate Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95Hose, Fuel Return . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Hose, Fuel Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Hose, Radiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Hub, Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85, 89Hydraulic / Transmission Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Hydraulic Controller, Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 121, 125, 129, 165Hydraulic Controller, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25, 113, 115, 131, 135, 137Hydraulic Controller, Lift / Extend . . . . . . . . . . . . . . . . . . . . . . .111, 119, 121, 123, 125, 127, 129, 161Hydraulic Controller, Tilt / Level . . . . . . . . . . . . . . . . . . . . . . . . .111, 119, 121, 123, 125, 127, 129, 159 Hydraulic Controller, Tri-Function . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 115, 131, 133, 135, 137, 163Hydraulic Fill Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31 Hydraulic Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63Hydraulic Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 31Hydraulic Filter Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Hydraulic Main Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .109Hydraulic Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101, 148Hydraulic Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Hydraulic Valve, Main . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111, 151

IIgnition / Start / Horn Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Inclinometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Inner Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97Instrument Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Intermediate Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95

JJoystick Relief Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149

KKey . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15, 17

SUB

JECT IN

DEX


PAGE


LLevel Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Light, Halogen - Backup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Light, Brake / Turn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Linkage, Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27

MMain Valve, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .109, 111, 151Manifold, Brake Line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105, 107Manifold, Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149Manifold, Joystick Relief . . . . . . . . . . . . . . . . . . . . . . . . .121, 123, 125, 127, 129, 131, 133, 135, 137Manifold, Pilot Apply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 115, 131, 133, 135, 137Manifold, PWP/WPS Joystick . . . . . . . . . . . . . . . . . . .41, 123, 125, 127, 129, 131, 133, 135, 137, 152Manifold, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117, 157Master Cylinder, Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 105, 155Mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Module, F-N-R Shifter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 21Mount, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Mount, Fender . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Mount, Frame Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77, 139Mount, Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 15Mount, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117Mount, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Mount, Starter Relay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Mount, Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51

OOil Filter, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

PPaint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .194Panel, Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 17Panel, Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Pedal, Accelerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Pilot Apply Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113, 115, 131, 133, 135, 137Pintle Hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .187Pipe, Exhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Planet, Gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85, 89Platform, Personnel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .189, 191Pre-Cleaner, Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Pump, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101, 148PWP/WPS Control Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41PWP/WPS Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41, 199PWP/WPS Wire Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41SU

BJE

CT

IND

EX



PAGE

QQuick Coupler Set . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .185, 187

RRadiator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Radiator Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37Radiator Hose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .157Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Relay, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Relay, Engine Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Remote Control System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40Remote Stop Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40Resistor Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Return Spring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 159, 161, 165Rim, Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Ring Gear, Differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91Rod, Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Rod, Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 45Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .185Rotating-Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .177, 185

SScreen, Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Seat Belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Sender, Fuel Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33Sender, Oil Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Sender, Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Sender, Water Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Sensor, Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Shifter, F-N-R . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Shut-Off, Water Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Skid Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 37Slave Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171Spacer, Engine Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Spring, Return . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 159, 161, 165Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21, 103, 154Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .153Steering Cylinder, Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78, 79Steering Wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Stop Switch, Remote Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40Strainer, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Striker, Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Suspension Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23Swing Platform, Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .189

SUB

JECT IN

DEX


PAGE


Switch, 3-Position Toggle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Switch, Clutch Cut-Out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Differential Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105Switch, Engine Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Ether . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 45Switch, Hazard Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Heater Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Switch, Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Ignition / Start / Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Park Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105Switch, Pressure (Reverse) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Switch, Push Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, PWP/WPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17, 41, 199Switch, Steer Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Turn Signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Switch, Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

TTail Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51Temperature Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Test Port, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .149Throttle Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Throttle Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27Tie Rod, Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78, 79Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .173Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Torque Converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Transmission Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5, 53Transmission Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Tri-Function Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25Tri-Function Controller, Wire Harness . . . . . . . . . . . . . . . . . . . . . .17, 25, 113, 115, 131, 133, 135, 137Truss Boom, Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .187Turn Signal Flasher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

UUniversal Joint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53

VValve Stem, Wheel Rim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Valve, Brake Master Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27, 105Valve, Steer Select . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103, 107Valve, Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Valve, Radiator Drain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47

SUB

JEC

T IN

DEX



PAGE

WWasher Fluid Bottle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wheel Hub . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85, 89Wheel Nut . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77, 85, 89Wheel Rim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77Winch, Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .187Window Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wiper Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wiper Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wire Harness, Canopy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7, 17Wire Harness, Ether Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Wire Harness, F-N-R Shifter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21Wire Harness, Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17Wire Harness, Front Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wire Harness, Head Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Wire Harness, Light Package . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Wire Harness, PWP/WPs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41Wire Harness, Radio Remote . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Wire Harness, Rear Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39Wire Harness, Steer Select . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .153Wire Harness, Top Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wire Harness, Tri-Function Controller . . . . . . . . . . . . . . . . . . . . . .17, 25, 113, 115, 131, 133, 135, 137Wire Harness, Washer Bottle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Wire Harness, Work Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Work Light, Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93Work Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .189, 190, 191Work Section, Hydraulic Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .151

SUB

JECT IN

DEX


REFERENCEMETRIC BOLT TORQUE GUIDE

Grade 10.9 Grade 12.9

M5 4.1 (5.5) 6 (8) 7 (10) 4 (5) 5 (7)M6 7 (10) 10 (14) 13 (17) 6.3 (8.5) 9 (12)M8 18 ( 25) 26 (35) 31 (42) 15 (20) 22 (30)M10 33 (45) 48 (65) 59 (80) 30 (40) 44 (59)M12 64 (87) 81 (110) 108 (147) 51 (69) 74 (100)M14 100 (135) 133 (180) 170 (230) 81 (110) 118 (160)M16 155 (210) 203 (275) 258 (350) 125 (170) 184 (250)M18 207 (280) 302 (410) 354 (480) 181 (245) 254 (345)M20 302 (410) 420 (570) 509 (690) 251 (340) 361 (490)M22 406 (550) 575 (780) 686 (930) 339 (460) 487 (660)M24 524 (710) 738 (1000) 878 (1190) 435 (590) 620 (840)M27 767 (1040) 1092 (1480) 1305 (1770) 642 (870) 922 (1250)M30 1047 (1420) 1482 (2010) 1770 (2400) 885 (1200) 1254 (1700)

MetricCoarse-Pitch

Thread 8.8 10.9 12.9 8.8 10.9

DIN 912, DIN 931, DIN 933, etc... DIN 7984All torque values are in Foot-Pounds and Newton Meters (Nm).

M8X1.0 18 (25) 27 (37) 32 (43) 16 (22) 24 (32)M10X1.0 37 (50) 55 (75) 65 (88) 32 (43) 48 (65)M10X1.25 36 (49) 52 (71) 61 (83) 31 (42) 46 (62)M12X1.25 64 (87) 96 (130) 111 (150) 55 (75) 81 (110)M12X1.5 61 (83) 92 (125) 107 (145) 53 (72) 77 (105)M14X1.5 100 (135) 148 (200) 173 (235) 89 (120) 129 (175)M16X1.5 155 (210) 229 (310) 266 (360) 133 (180) 195 (265)M18X1.5 232 (315) 332 (450) 391 (530) 199 (270) 284 (385)M20X1.5 325 (440) 465 (630) 538 (730) 277 (375) 391 (530)M22X1.5 435 (590) 620 (840) 723 (980) 369 (500) 524 (710)M24X2.0 546 (740) 789 (1070) 922 (1250) 465 (630) 664 (900)M27X2.0 811 (1100) 1143 (1550) 1328 (1800) 679 (920) 959 (1300)M30X2.0 1106 (1500) 1586 (2150) 1844 (2500) 959 (1300) 1364 (1850)

MetricFine-Pitch

Thread 8.8 10.9 12.9 8.8 10.9

DIN 912, DIN 931, DIN 933, etc... DIN 7984All torque values are in Foot-Pounds and Newton Meters (Nm).

Grade 8.8

Use these torque values when tightening hardware—excluding: lock nuts, thread-forming, self-tap-ping, and metal screws—unless otherwise specified.


REFERENCESAE BOLT TORQUE GUIDE

Use these torque values when tightening hardware—excluding: lock nuts, thread-forming, self-tap-ping, and metal screws—unless otherwise specified.

NOTE: All torque values are in foot-pounds (lb.-ft.), except those marked with asterisks (*), whichare in inch-pounds (lb.-in.). To convert lb.-ft. to Newton Meter (Nm)—metric—torque values, multi-ply the lb.-ft. value by 1.355, or for inch pounds, multiply the lb.-in. value by 0.113.

* Value shown is in pound-force inch (lb.-in.)—inch pounds.

8-32 19* 14* 30* 22* 41* 31*8-36 20* 15* 31* 23* 43* 32*10-24 27* 21* 43* 32* 60* 45*10-32 31* 23* 49* 36* 68* 51*1/4-20 66* 50* 9 75* 12 91/4-28 76* 56* 10 86* 14 105/16-18 11 9 17 13 25 185/16/24 12 9 19 14 25 203/8-16 20 15 30 23 45 353/8-24 23 17 35 25 50 357/16-14 32 24 50 35 70 557/16-20 36 27 55 40 80 601/2-13 35 35 75 55 110 801/2-20 40 40 90 65 120 909/16-12 55 55 110 80 150 1109/16-18 60 60 120 90 170 1305/8-11 75 75 150 110 220 1705/8-18 85 85 180 130 240 1803/4-10 130 130 260 200 380 2803/4-16 150 150 300 220 420 3207/8-9 125 125 430 320 600 4607/8-14 140 140 470 630 660 5001-8 190 190 640 480 900 6801-14 210 210 710 530 1000 740

Grade 2

Dry Oiled

UnifiedNationalThread

Grade 5

Dry Oiled

Grade 8

Dry Oiled

Telescopic Handler - TUFF Equipmenttuffequipco.com/pdfs/Gehl Owners Manuals/Gehl Telescopic... ·...

Documents

Transcript of Telescopic Handler - TUFF Equipmenttuffequipco.com/pdfs/Gehl Owners Manuals/Gehl Telescopic... ·...