SURE GRIP DAILY CLEANER / DEGREASER TRACTION · DOT Hazard Classification: NON-REGULATED Identity...
2
MATERIAL SAFETY DATA SHEET This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174 Manufactured For: SURE GRIP FLOOR SYSTEMS, INC. Address: 2801-3 Capital Circle NE Tallahassee, Florida 32308 Phone: 1-800-928-6281 NFPA Rating: Health-1; Flammability-0; Reactivity-0; Special- - HMIS Rating: Health-1; Flammability-0; Reactivity-0; Personal Protection-B DOT Hazard Classification: NON-REGULATED Identity (trade name as used on label): SURE GRIP DAILY CLEANER / DEGREASER Emergency Response Number: 1-800-424-9300 NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA MSDS Number: B07148 Revision – 1 Date Prepared: 07/01/09 Prepared By: IB Information Calls: (770) 422-2071 SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION COMPONENTS-CHEMICAL NAMES AND COMMON NAMES (Hazardous Components 1% or greater; Carcinogens 0.1% or greater) DODECYLBENZENE SULFONIC ACID HYDROXYACETIC ACID CAS Number 27176-87-0 79-14-1 SARA III LIST No No OSHA PEL (ppm) NE NE ACGIH TLV (ppm) NE NE Carcinogen Ref. Source ** d d SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS Boiling Point: 212ºF Vapor Pressure: PSIG @ 70°F (Aerosols): N/A Vapor Density (Air = 1): N/D Solubility in Water: Miscible Appearance and Odor: Water based clear, green liquid with citrus odor. Specific Gravity (H2O=1): 1.04 Vapor Pressure (Non-Aerosols) (mm Hg and Temperature): N/D Evaporation Rate ( water = 1): approximately 1 Water Reactive: No SECTION 3 - FIRE AND EXPLOSION HAZARD DATA FLAMMABILITY as per USA FLAME PROJECTION TEST (aerosols) N/A FLASH POINT AND METHOD USED (non-aerosols): None to boiling (TCC) SPECIAL FIRE FIGHTING PROCEDURES: None. Unusual Fire & Explosion Hazards: None Auto Ignition Temperature N/A Flammability Limits in Air by % in Volume: % LEL: N/A % UEL: N/A EXTINGUISHER MEDIA: Non-combustible. Use media compatible with surrounding fire. SECTION 4 - REACTIVITY HAZARD DATA STABILITY [ X ] STABLE [ ] UNSTABLE Incompatibility (Mat. to avoid): Stong oxidizers. Hazardous Decomposition Products: Oxides of carbon, nitrogen, sulfur & other unidentified organic compounds. HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR Conditions to Avoid: None known. SECTION 5 - HEALTH HAZARD DATA PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ X ] INGESTION [ X ] SKIN ABSORPTION [ X ] EYE [ ] NOT HAZARDOUS ACUTE EFFECTS: Inhalation: Product is not volatile. Inhalation of product vapor unlikely. Eye Contact: Irritant. Skin Contact: Irritant. Ingestion: Irritating. May cause nausea, vomiting or diarrhea. CHRONIC EFFECTS: None known. Medical Conditions Generally Aggravated by Exposure: Any irritated tissue present may be further irritated by repeated or prolonged exposure. EMERGENCY FIRST AID PROCEDURES Eye Contact: Flush with water for 15 minutes. If irritation persists, get medical attention. Skin Contact: Remove contaminated clothing. Wash with soap and warm water. If irritation persists, get medical attention. Inhalation: Remove to fresh air. Ingestion: DO NOT INDUCE VOMITING. Drink 2 glasses of water and call for medical advisal. SECTION 6 - CONTROL AND PROTECTIVE MEASURES Respiratory Protection (specify type): None required. Particulate mask recommended if product application yields a fine particle mist that suspends in the air. Protective Gloves: Rubber or nitrile, if desired. Eye Protection: Safety glasses or goggles as appropriate. Ventilation Requirements: None required. Other Protective Clothing & Equipment: Readily accessible fresh water or potable water source that provides a gentle irrigation of ambient or cool temperature water for flushing eyes. Hygienic Work Practices: Do not eat, drink or smoke in work area. Wash hands after handling. SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE Steps To Be Taken If Material Is Spilled Or Released: Soak up in absorbent material & seal in properly labeled non-leaking containers for proper authorized waste disposal. Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations. Precautions To Be Taken In Handling & Storage: Store in original shipping containers. Keep closed when not in use. Protect from freezing. Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Read & follow label directions. IDENTITY AND DISTRIBUTOR'S INFORMATION TRACTION DAILY CLEANER /DEGREASER We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. ** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only SureGrip Daily Cleaner / Degreaser is the first line of defense in the battle against slippery floors. Unlike most cleaner-degreasers, it is alkaline free. Alkaline cleaners leave residue behind and will turn a wet floor into a serious slip hazard. Our Daily Cleaner / Degreaser emulsifies and suspends oil, grease and other contaminates, lifting from deep in the microscopic pores of the floor surface. Once the grease is emulsified, it can easily be extracted or rinsed away leaving the floor surface residue- free. When SureGrip Cleaner / Degreaser is used daily it will reduce the occurrence of polymerization, greatly improving surface traction. TRACTION DAILY CLEANER /DEGREASER Foam Gun Daily Maintenance: 4 oz. per Gallon (1:32) Recommended uses: All flooring including: Slate Ceramic Saltillo Quarry Recycled PVC Terrazzo Concrete Wood VCT Walls Equipment Alkaline Free – No Slippery Residue Effectively Emulsifies Grease Contains no Phosphates, Butyl or Bleaches Cost Effective NSF Registered and Approved (800) 928.6281 (800) 928.6281 Making the world a safer place ...one step at a time! www.SureGripFloors.com Dilution Ratios Mop Bucket Daily Maintenance: 2oz.per Gallon (1:64) Heavy Soil: 4oz. per Gallon (1:32) Data Appearance: Green liquid Odor: Fresh DOT Hazardous ingredients: None Vapor pressure (mm/hg): 17mm @ 20 C Boiling point, F: 212 F (ASTM D-1120) Solubility in water: Complete Flash Point: >101C (ASTM D-56) Tag closed cup
Transcript of SURE GRIP DAILY CLEANER / DEGREASER TRACTION · DOT Hazard Classification: NON-REGULATED Identity...
MATERIAL SAFETY DATA SHEETThis MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
Manufactured For: SURE GRIP FLOOR SYSTEMS, INC.Address: 2801-3 Capital Circle NE Tallahassee, Florida 32308Phone: 1-800-928-6281
NFPA Rating: Health-1; Flammability-0; Reactivity-0; Special- - HMIS Rating: Health-1; Flammability-0; Reactivity-0; Personal Protection-BDOT Hazard Classification: NON-REGULATEDIdentity (trade name as used on label):SURE GRIP DAILY CLEANER / DEGREASER
Emergency Response Number: 1-800-424-9300NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
MSDS Number: B07148 Revision – 1Date Prepared: 07/01/09 Prepared By: IBInformation Calls: (770) 422-2071
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATIONCOMPONENTS-CHEMICAL NAMES AND COMMON NAMES(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)DODECYLBENZENE SULFONIC ACIDHYDROXYACETIC ACID
CAS Number
27176-87-079-14-1
SARAIII LIST
NoNo
OSHA PEL(ppm)
NENE
ACGIHTLV (ppm)
NENE
CarcinogenRef. Source **
dd
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICSBoiling Point: 212ºFVapor Pressure: PSIG @ 70°F (Aerosols): N/AVapor Density (Air = 1): N/DSolubility in Water: MiscibleAppearance and Odor: Water based clear, green liquid with citrus odor.
Specific Gravity (H2O=1): 1.04Vapor Pressure (Non-Aerosols) (mm Hg and Temperature):N/DEvaporation Rate ( water = 1): approximately 1Water Reactive: No
SECTION 3 - FIRE AND EXPLOSION HAZARD DATAFLAMMABILITY as per USA FLAME PROJECTION TEST(aerosols) N/A
FLASH POINT AND METHOD USED (non-aerosols): None to boiling (TCC)SPECIAL FIRE FIGHTING PROCEDURES: None.
Unusual Fire & Explosion Hazards: None
Auto Ignition TemperatureN/A
Flammability Limits in Air by % in Volume:% LEL: N/A % UEL: N/A
EXTINGUISHER MEDIA: Non-combustible. Use media compatible withsurrounding fire.
SECTION 4 - REACTIVITY HAZARD DATASTABILITY [ X ] STABLE [ ] UNSTABLEIncompatibility (Mat. to avoid): Stong oxidizers.Hazardous Decomposition Products: Oxides of carbon, nitrogen, sulfur & other unidentified organic compounds.
HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCURConditions to Avoid: None known.
SECTION 5 - HEALTH HAZARD DATAPRIMARY ROUTES OF ENTRY: [ ] INHALATION [ X ] INGESTION [ X ] SKIN ABSORPTION [ X ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS:Inhalation: Product is not volatile. Inhalation of product vapor unlikely.Eye Contact: Irritant. Skin Contact: Irritant.Ingestion: Irritating. May cause nausea, vomiting or diarrhea.CHRONIC EFFECTS: None known.Medical Conditions Generally Aggravated by Exposure: Any irritated tissue present may be further irritated by repeated or prolonged exposure.
EMERGENCY FIRST AID PROCEDURESEye Contact: Flush with water for 15 minutes. If irritation persists, get medical attention.Skin Contact: Remove contaminated clothing. Wash with soap and warm water. If irritation persists, get medical attention.Inhalation: Remove to fresh air.Ingestion: DO NOT INDUCE VOMITING. Drink 2 glasses of water and call for medical advisal.
SECTION 6 - CONTROL AND PROTECTIVE MEASURESRespiratory Protection (specify type): None required. Particulate mask recommended if product application yields a fine particle mist that suspends in the air.Protective Gloves: Rubber or nitrile, if desired. Eye Protection: Safety glasses or goggles as appropriate.Ventilation Requirements: None required.Other Protective Clothing & Equipment: Readily accessible fresh water or potable water source that provides a gentle irrigation of ambient or cool temperature water for
flushing eyes.Hygienic Work Practices: Do not eat, drink or smoke in work area. Wash hands after handling.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USESteps To Be Taken If Material Is Spilled Or Released: Soak up in absorbent material & seal in properly labeled non-leaking containers for proper authorized waste disposal.Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations.Precautions To Be Taken In Handling & Storage: Store in original shipping containers. Keep closed when not in use. Protect from freezing.Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Read & follow label directions.
IDENTITY AND DISTRIBUTOR'S INFORMATION
TRACTION DAILY CLEANER/DEGREASER
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind.** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
SureGrip Daily Cleaner / Degreaser is the first line of defense in the battle against slippery floors. Unlike most cleaner-degreasers, it is alkaline free. Alkaline cleaners leave residue behind and will turn a wet floor into a serious slip hazard. Our Daily Cleaner / Degreaser emulsifies and suspends oil, grease and other contaminates, lifting from deep in the microscopic pores of the floor surface. Once the grease is emulsified, it can easily be extracted or rinsed away leaving the floor surface residue-free. When SureGrip Cleaner / Degreaser is used daily it will reduce the occurrence of polymerization, greatly improving surface traction.
TRACTION DAILY CLEANER/DEGREASER
Foam GunDaily Maintenance: 4 oz. per Gallon (1:32)
Recommended uses:All flooring including:Slate CeramicSaltillo QuarryRecycled PVC TerrazzoConcrete WoodVCT
Walls
Equipment
Alkaline Free – No Slippery ResidueEffectively Emulsifies GreaseContains no Phosphates, Butyl or BleachesCost EffectiveNSF Registered and Approved
(800) 928.6281(800) 928.6281Making the world a safer place ...one step at a time! www.SureGripFloors.com
Dilution RatiosMop Bucket Daily Maintenance: 2oz.per Gallon (1:64) Heavy Soil: 4oz. per Gallon (1:32)
DataAppearance: Green liquidOdor: FreshDOT Hazardous ingredients: NoneVapor pressure (mm/hg): 17mm @ 20 CBoiling point, F: 212 F (ASTM D-1120)Solubility in water: CompleteFlash Point: >101C (ASTM D-56) Tag closed cup
Always place signs in highly visible areas warning people that the floors are wet and could be slippery.
Coloque siempre señales en las zonas visibles advirtiendo a las personas de que los suelos están mojados y podrían ser resbaladizos.
Thoroughly sweep all debris from floor surface and remove.
Recoja todos los residuos del piso con una escoba y retírelos.
Fill mop bucket with SureGrip® Traction enhancing Daily Cleaner. Always mix according to the label or use a proportioning system.
Llene una cubeta con el limpiador Limpiador Diario SureGrip®. Mezcle de acuerdo a la etiqueta o utilice un sistema de dosificación.
For high traffic areas, liberally mop on solution to a medium sized area and then proceed to step #5. For non-high traffic areas, proceed to step #6
Para zonas alto tráfico, limpie abundantemente con la solución en un área de tamaño medio y continúe con el paso número 5. Para áreas sin tráfico, pase al número 6.
Using a deck brush quickly, but thoroughly scrub all high traffic areas, especially those next to the kitchen.
Utilizando un cepillo, limpie rápidamente fregando a fondo todas las áreas de mayor tráfico, especialmente aquellas que están mas cercanas a la cocina.
Mop area with tightly wrung out mop. Continue process until entire floor is clean. Change solution in mop bucket when it becomes visibly dirty.
Friegue la zona con una mopa bien escurrida. Continúe hasta que todo el suelo esté bien limpio. Cambie la solución en la cubeta cuando se ponga visiblemente sucia.
FRONT OF HOUSE FLOOR CLEANING PROCEDURES
Please visit www.SureGripFloors.com for a collection of Floor Cleaning Procedures and Training Material!
1. 2. 3.
4. 5. 6.
Instrucciones para el Mantenimiento Diario del Frente Instrucciones para el Mantenimiento Diario de la CocinaKITCHEN FLOOR CLEANING PROCEDURES
Using a deck brush quickly, but thoroughly scrub area.
Utilizando un cepillo, limpie rápido pero a fondo la zona a limpiar.
Rinse floor with clean water.
Enjuague el suelo con agua limpia.
Squeegee water down drain and allow floor to dry.
Pase el ecurridor hacia el desagüe y deje que se seque el suelo.
Thoroughly sweep all debris from floor surface and remove.
Barra todos los residuos del piso y retírelos.
Always place signs in highly visible areas warning people that the floors are wet and could be slippery.
Coloque siempre señales en zonas muy visibles advirtiendo a las personas de que los suelos están mojados y podrían ser resbaladizos.
Fill foam gun with SureGrip® Daily Cleaner and attach gun to water hose. Liberally apply foam to all floor areas.
Llene la pistola de espuma con el Limpiador Diario SureGrip® y fíjela a la manguera de agua. Aplique abundante espuma en todas las áreas del suelo.
1. 2. 3.
4. 5. 6.
CLEAN FLOORS = SAFE FLOORSMaking the world a safer place …one step at a time.For more information call 1-800-928-6281 or visit our website at www.suregripfloors.comPara mas información llámenos 1-800-928-6281 o visite nuestra website www.suregripfloors.com
