Scoop Tram Roll Over Incidents. 2 On September 19 th, an operator was mucking the right hand corner...
-
Upload
theodora-hoover -
Category
Documents
-
view
217 -
download
0
Transcript of Scoop Tram Roll Over Incidents. 2 On September 19 th, an operator was mucking the right hand corner...
2
On September 19th, an operator was mucking the right hand
corner of a pillar in 5156 charging station with a EJC 2
yard scoop.
3
While mucking the bucket caught something solid, the
operator lifted his bucket causing the rear of the scoop to lift off the ground and swing to the right, which is down ramp.
4
This caused the left side of the scoop tram to raise
approximately 2.5 feet off the ground. The bucket jammed against the face stopping the scoop from completely rolling
over.
Actions Taken to Prevent Similar Occurrences
Mucking down ramp procedure to be reviewed at line up huddles for every shift
Engineering is looking into starting the re-mucks flatter
10
On September 27th, a worker was mucking a face and re-muck with a EJC 11/4 yard scoop tram. He misjudged
where the edge of the muck pile was in the re-muck and ran the left wheel up on the muck pile approximately 1.5
feet. 12
Thus placing the scoop tram off balance. Since the full
bucket was raised the centre of gravity caused the scoop tram to flip onto its side.
13
Personal Factors
To much in a hurry
Job Factors
Scoop tram not designed to be on an angle with a full bucket in the air
24