Rectifier L1
-
Upload
mohsinaliqureshi02 -
Category
Documents
-
view
112 -
download
7
description
Transcript of Rectifier L1
![Page 1: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/1.jpg)
1
RECTIFIERS
![Page 2: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/2.jpg)
2
AIM
• To Increase the Technical Knowledge about basic function of Rectifier and Battery Backup,
• To know about different types of rectifiers installed in BTS cell sites and BSC’s
• To know about the un-interrupted power supplied to the system.
![Page 3: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/3.jpg)
3
Table of Contents
• Basic Working of Rectifiers
• Classification of Rectifiers
• Low Voltage Disconnect LVD
• Battery Bank
• Grounding of Rectifiers
• Precautions and Safety
• Tools Required
![Page 5: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/5.jpg)
5
Basic Working of Rectifiers
Half – Wave RectificationFull – Wave Rectification
(Bridge Rectification)
3 – phase input AC Supply 3 – phase Full wave rectification3 – phase half wave rectification
![Page 6: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/6.jpg)
6
Basic Working of Rectifiers
![Page 7: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/7.jpg)
7
Classification of Rectifiers
Various types of Rectifiers are classified as:
1- Eltek Flat Pack Rectifier – 1500
2- Delta Rectifier– 1200watts & 2000watts
3- Emerson Rectifier
![Page 8: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/8.jpg)
8
Eltek Flat Pack 1500
General Specifications:
• 1 & 3 phase AC Input Voltage
• 15 KWatts, 48VDC supply Output
• 8 Modules Capacity (1500watts, 30Amps each)
• Monitoring and Control Unit MCU
• 10+2 C.B’s (16 and 32 Amps)
• Protection against Surges (lightning or switching transients)
![Page 9: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/9.jpg)
9
Brief System Description - Eltek
![Page 10: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/10.jpg)
Rectifier Module – Eltek
Equipment Features
• Front LED Indicators (0 to 29A bar graph, Power & Alarm indication)
• Wide Input Voltage Range (85 VAC to 300 VAC)
• Automatic Shutdown at high input voltages
• Power Factor close to Unity
• High Efficiency (above 90% at 230VAC)
•Temperature monitoring, Automatic shutdown at high internal temperatures.
• Constant power charging during battery recharge
• Front Accessible Potentiometer (output voltage adjust)
• 2 – Front Fan Cooled Rectifier units
![Page 11: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/11.jpg)
Equipment Features
• RS232 Serial Interface from local PC/modem (Engineer’s Password – 0000)
• Menu – driven operation via front key pad & display
• Current & Voltage output monitoring
• Voltage level adjustment
• Temperature compensated charging
• Manual/Automatic boost charging
• Battery monitoring and testing
• Low voltage battery and load disconnect (LVD 1&2)
• Storage and reporting of Env. and system Alarms
• Adjustable Alarm Limits
Monitoring & Control Unit (MCU)
![Page 12: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/12.jpg)
User Options (General Users)
• Switch the System ON/OFF
• Resetting Alarms
• Display important System Voltages
• NormVolt• BoostVolt• LowBatt 1 & 2• HighBatt 1 & 2• LVD 1 & 2
• Display Alarm Messages
• Display System Software’s and version number
Menu Structure for MCUService Options (Authorized Users)
• Authentication Password (0000 or user defined)
• Adjustment of Important System Voltages• NormVolt• BoostVolt• LowBatt 1 & 2• HighBatt 1 & 2• LVD 1 & 2
• Change of Service Options Passwords
• Setting of Boost Function duration
• Start or Stop Boost Function
• Selection of type of Output Control• Preset Rect.Volt• Temp.Comp.• Voltage Control
• Set Date and Time• Alarm/Message Logs• Automatic Battery Test• Modem Callback
![Page 13: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/13.jpg)
Delta Rectifiers – 1200/2000watts
General Specifications: • 1 & 3 phase AC Input Voltage Supply
• 1200Watts, 48VDC Output Supply
• 2000Watts, 48VDC Output Supply
• 6 Modules Capacity (1200watts, 28Amps each)
• 8 Modules Capacity (2000watts, 46Amps each) • Power System Controller PSC-1000
• 8+2 C.B’s (16 and 32 Amps)
• 4 Surge Voltage Protection Arrestor units
![Page 14: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/14.jpg)
Power System Controller PSC-1000
Equipment Features
• Engineers Password
• Remote Alarming (system & environment)
• System Calibrations
• System Voltage Programming and control
• Alarm Stop
• Remote access (terminal and MODEM)
• RS – 232 user interface
• Serial Bus cable for COBOMO to PSC
![Page 15: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/15.jpg)
15
COBOMO Card & Remote Alarms
![Page 16: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/16.jpg)
Rectifier – 1200 Watts
![Page 17: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/17.jpg)
Rectifier 2000watts
![Page 18: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/18.jpg)
Menu Structure for PSC 1000Main Menu Structure (General Users)
• Display
• Protocol (events and alarms)
• General
• Alarms
• System Voltage USYS
• Temp Comp
• Boost Charge
• Battery Test
• Equalize
• SAE
• Auxiliary
• PC/Modem
Configuration/Extended Configuration
![Page 19: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/19.jpg)
19
Emerson Rectifiers
![Page 20: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/20.jpg)
Rectifier Unit Emerson
![Page 21: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/21.jpg)
21
Power Control Unit PCU
![Page 22: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/22.jpg)
22
Menu Structure PCU
![Page 23: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/23.jpg)
23
Low Voltage Disconnect Relay LVD
![Page 24: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/24.jpg)
24
![Page 25: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/25.jpg)
25
Batteries
12 V Batteries in Series 12 V Batteries in Parallel
![Page 26: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/26.jpg)
26
Types of Batteries
![Page 27: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/27.jpg)
27
Battery Bank
![Page 28: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/28.jpg)
Grounding
![Page 29: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/29.jpg)
Grounding of Rectifiers
![Page 30: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/30.jpg)
30
Safety Precautions
![Page 31: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/31.jpg)
Tools
![Page 32: Rectifier L1](https://reader033.fdocuments.net/reader033/viewer/2022061510/55721313497959fc0b918aa8/html5/thumbnails/32.jpg)
THANKS