Radio Sensortelemetry - Luchsinger · 2019. 1. 28. · GND UB R+ R R+ R R- R R- R Ud AD-Converterr...

Radio Sensortelemetry

* Short description of radio telemetry page 2 ... 3

* Rotating part to stationary part page 4 ... 20

* Point to point page 21

* Antenna diversity page 22

* Multi channel telemetry page 23 ... 26

* RMC page 27 ... 28

* Radio telemetry components page 29 ... 53

File: g:\...\FUNK_KATALOG.cdr // 20170508

+

-+

-

GND

UBR+ R

R+ R

R- R

R- R

Ud+- ~~

AD-Converterr

DA-Converter

12/16 Bit 12/16 BitFilter

Transmitter with direct transducer interface

Cod.Decoder

Dataprotection

CRC

Trans-mitter

Receiver

Range

0 to ±10V

DigitalInterface

USBRS 232

Short Description of Manner Radio-Sensortelemetry

Diagramm of one channel

-Page 2-

The Manner Radio Telemetry was especially developed for working in heavy environment conditions. It consists of radio transmitter and miniaturized sensor signal amplifier. The strain gage bridges and thermocouples, RTD (PT100) are direct interfaced with the sensor signal amplifier. The signal from the transducer will be enforced, filtered due to the antialiasing and digitized. The resolution of the signal can be 12 Bit or 16 Bit (option). Thereafter the digital data will be encoded and a special checksum word will be generated.This special checksum word guarantees absolute noisefree data transmission. The data word and special checksum word will be FM-modulated of the RF carrier 433/868 MHz. The guarantied wireless transmitting range depends on the data rate. It ranges from 5 to over 50 meters in free terrain. The system is available in single and multi channel version (2, 4, 8, 16, 32 channels). For each channel exists a separate power supply, amplifier, AD-Converter and DA-Converter. There is no crosstalk between the channels and no backlash in case of a short circuit. The range adjustment, auto zero can be programmed remote from a PC.

-Page 3-

Sensor SignalAmplifier

Position(differential transformer)

Contactless distance( transducer)me

90 to 270V AC (9 to 36 V DC)

Piezo electric

PT100 RTD

Receiver

RemoteCal

RemoteControl (option)

Strain gagehalf brigde

Strain gagefull brigde

Thermocouple

PT100

NS

Hall sensor

Configuration

rechargablebattery

Digital interface (USB; CAN, Ethernet ,IENA)

ServiceUSB

rotating stationary

Antenna

Receiver

MANNER Radio Sensortelemetry(shaft - stationary)

Easy mountingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: max. 16Sample rate: 40000 Sample/s (1 channel)Sample rate: 20000 Sample/s /channel at 8 channelsDigital transmitting: 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 12 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 3000 gOptional -40 to +120°C environmental temperature

Transmitter

Band clamp

Features:

ShaftShaft

Type: SV_4_____F

Type: AW_T______F

-Page 4-

Easy mountingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: 1Sample rate: 4000 Sample/s (1 channel)Digital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistoror optional electrical remote programmable range with 12 Bit resolution Transducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperature

Transmitter

Features:Shaft

Shaft

Type: AW_M___ __F

Type: SV_4_____F

-Page 5-

Band clamp

MANNER Radio Sensortelemetry(shaft - stationary)

Easy mountingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: 1Sample rate: 4000 Sample/s (1 channel)Digital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistoror optional electrical remote programmable range with 12 Bit resolution Transducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperature

Transmitter

Features:

Shaft

Shaft

Type: AW_M___ __F

Type: SV_4_____F

Band clamp

MANNER Radio Sensortelemetry(flexible power meter)

Speed sensor

speed mark

InterfaceU

SB

/CA

N

Optional

Torque

Speed

Power

USB


0 to ±10V

0 to ±10V

TTL

9 to 36 V DC

Receiver


Strain gagefull brigde

SpeedUSB

9 to 36 V -Page 6-

Further information:see “Messflansch”

Type: AW_M___ __F

Type: MF_____F

-Page 7-

Torque Meter based on Radio Telemetry

Universal torque meter for short term useRanges available: 10 Nm to 50 kNmLinearity and hysteresis: 0,2 %High bandwidth 0 to 1 kHz(-3 dB)High reliable digital transmitting 16 Bit resolutionZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Easy mountingTransmitting: Radio f = 433/868 MHzRF-Power: 10 mW; range: 40 m in open fieldIntegrated data protection by checksum (16 Bit CRC)Low current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Max. radial accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperatureSupply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN

Type system: type: MF______F_

Features:

10 Nmto50 kNm

0,25%0,1%0,05%

10 Hz100 Hz1 kHz

PCM12PCM16

AW_MAW_T

---

USBCAN

Type: AW_M___ __F

Type: MF_____F

Universal torque meter for short term useRanges available: 10 N to 5 000 kNLinearity and hysteresis: 0,2 %High bandwidth 0 to 1 kHz(-3 dB)High reliable digital transmitting 16 Bit resolutionZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Easy mountingTransmitting: Radio f = 433/868 MHzRF-Power: 10 mW; range: 40 m in open fieldIntegrated data protection by checksum (16 Bit CRC)Low current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Max. radial accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperatureSupply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN, TCP/IP

Type system: type: MFF______F_

Features:

10 Nto

10 000 kN

0,25%0,1%0,05%

10 Hz100 Hz1 kHz

PCM12PCM16

AW_MAW_T

Force Meter based on Radio Telemetry

F

F ---USBCAN

-Page 8-

Type: MFC_____F

-Page 9-

Climate Compressor Torque Meter based on Radio Telemetry

Type: AW_M___ __F

Climate compressor torque meter for short term useRanges available: 20 Nm to 50 kNmLinearity and hysteresis: 0,25 %High bandwidth 0 to 1 kHz(-3 dB)High reliable digital transmitting 16 Bit resolutionZerodrift / Gaindrift: 0,01 %/°C (0,003 %/°C optional)Easy mountingTransmitting: Radio f = 433/868 MHzRF-Power: 10 mW; range: 40 m in open fieldIntegrated data protection by checksum (16 Bit CRC)Low current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 25 hours (one cycle)Max. radial accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperatureSupply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN

Type system: type: MFC______F_

Features:

20 Nmto50 Nm

0,25%0,1%

10 Hz100 Hz1 kHz

PCM16 AW_MAW_P

---

USBCAN

Universal accelaration meter for short term useRanges available: 1 g ... 500 gLinearity and hysteresis: 0,2 %High bandwidth 0 to 1 (10) kHz(-3 dB)High reliable digital transmitting 16 Bit resolutionZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Easy mounting (srew or clamping)Transmitting: Radio f = 433/868 MHzRF-Power: 10 mW; range: 40 m in open fieldIntegrated data protection by checksum (16 Bit CRC)Low current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Temperature range: -10 to +85°COptional -40 to +120°C environmental temperatureSupply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN

Type system: type: MFA______F_

Features:Type: AW_M___ __F

1 gto

500 g

0,25%

0,1%

10 Hz100 Hz1 kHz

10 kHz

PCM12PCM16

AW_MAW_T

Acceleration Meter based on Radio Telemetry

a

-Page 10-

---

USBCAN

TCP/IP

a

a

t1Shaft

t2

Universal torsional accelaration meter for short term useRanges available: 1 g ... 100 gLinearity and hysteresis: 0,2 %High bandwidth 0 to 1 kHz (-3 dB)Zero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Easy mounting (srew or clamping)Transmitting: Radio f = 433/868 MHzRF-Power: 10 mW; range: 40 m in open fieldHigh reliable digital transmission, integrated data protection by checksumlow current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Eviromental temperature range: -10 to +85°C (-40..+125°C opt.)Supply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN, TCP/IP

Type system: type: MFB______F_

Features:

1 gto

500 g

0,25%

0,1%

10 Hz100 Hz1 kHz10 kHz

PCM12PCM16

AW_MAW_T

Torsional Acceleration Meter based on Radio Telemetrywith ICP Sensors

Receiver

Transmitter with integrateted antenna

-Page 11-

---

USBCAN

TCP/IP

Type: MFW_____F

-Page 12-

Wheel Torque Meter based on Radio Telemetry

Type: AW_M___ __F

Wheel torque meter for carsRanges available: 500 Nm to 4 kNmLinearity and hysteresis: 0,1 %Based on titanium with overload protectionHigh bandwidth 0 to 1 kHz(-3 dB)High reliable digital transmitting 16 Bit resolutionZerodrift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Easy mountingTransmitting: Radio f = 433/868 MHz, 16 different frequenciesIntegrated transmitting antenna, waterproofRF-Power: 10 mW; range: 20 m in open fieldIntegrated data protection by checksum (16 Bit CRC)Low current consumption by low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Max. radial accelaration: 1500 gTemperature range: -25 to +85°COptional -40 to +120°C environmental temperatureSupply receiver: 9 to 36 V DC, 100 mAOutput voltage: 0 to ±10 V, 0(4) to 20 mA, USB, CAN

Type system: type: MFW______F_

Features:

500 Nmto4 kNm

0,1% 100 Hz1 kHz

PCM16 AW_MAW_P

---

USBCAN

Receiver

Multichannel transmitter with integrated strain gage amplifier

(with Accu)

Gain fine

Zero point

Output: 0 to ±10VSupply 9 to 36 V DC

Interface-Box

CAN - Bus

or

Wheel Radio Telemetry with CAN-Bus Interface

Easy mountingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: 1 or multi channel (max. 16)Sample rate: 4000 Sample/s/channelDigital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 30 m in open fieldLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/Velectrical remote programmable range with 12 Bit resolutionTransducer: strain gage, full- / half bridge, Thermocouple type KZerodrift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 1500 gOptional -40 to +120°C environmental temperature

Type system: MSV_Rad_____F__

Features:

2to32

0,20,1

USBCAN

110

100040008000

40000

PCM12PCM16

85125150

-Page 13-

Wireless Temperature Sensor for rough Environment Condition opt. with CAN Bus or USB Interface

Easy mounting by clampswith exchangeable Battery, supply 3,6 V Low current consumption, 1/2 year operating time per battery setChannel count: 1 or multi channel (max. 16)Sample rate: 1 Sample/s (option 10 Sample/sec)Digital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433 MHz, 16 different frequenciesRF-Power: 10 mW; range: 30 m in open fieldLow current consumption by low power C-MOS technique: 3,6 V supplyTemperature ranges: -40 to 85°C, -40 to 120°CIntegrated temperatur sensor (optional external temperature sensor)AMax. accelaration: 500 gSize: 45 x 30 x 25 mm Optional -40 to +120°C environmental temperatureType: SV_8x_____

ccuracy: ±1,5°C

Features:

-Page 14-

Receiver

Gain fine

Zero point


InterfaceBox

CAN Bus

110

124816

85120

intext

Temperature acquisitionat the shaft

Direct contactingtemperature sensor

Rotatingshaft

Wireless Temperature Sensor for rough Environment Condition opt. with CAN Bus or USB Interface

Easy mounting by clampswith exchangeable Battery, supply 3,6 V Low current consumption, >1/2 year operating time per battery setChannel count: 1 or multi channel (max. 16)Sample rate: 1 Sample/s (option 10 Sample/sec)Digital transmitting 16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldLow current consumption by low power C-MOS technique: 3,6 V supplyTemperature ranges: -40 to 85°C, -40 to 120°CExternal temperature sensor Type PT100, (Thermoelement type K Option) range programmable (optional internal temperature sensor)AMax. accelaration: 500 gSize: 45 x 30 x 25 mm Optional -40 to +120°C environmental temperatureType: SV_8y____mod_

ccuracy: ±1,5°C

Features:

-Page 15-

110

1 85120

intext

44

26,5

Supply 9 to 36 V DC

Gain

Zero point

CAN-Bus/USB Interface

Clamps forexternal sensor

DimensionsUniversal adapter plate

Option centralSensor connector Lemo

Radial connetorstype Lemo orPG screws

Radial connetorstype Lemo orPG screws

21,0

Ø90

,0

Ø91

,0

20,5 1,5

Ø66

,0

Transduce with transmitter0 to ±10V

USB, CAN,TCP/IPReceiver

8 channel transmitter

-Page 16-

General Measurement Configuration for Multi Channel Systems

Statorantennas

RotorSystem 1

RotorSystem 2

RotorSystem 3

RotorSystem 4

Rotorantenna

Rotorantenna

Rotorantenna

Rotorantenna

Sensorsignal

amplifier

Sensorsignal

amplifier

Sensorsignal

amplifier

Sensorsignal

amplifier

FunktelemetrieFunktelemetrie Funktelemetrie

MAMA MA

AntennendiversityEmpfänger CAN-Bus

Antenne 1 IN

Antenne 2 OUT

E 1

E 2

-Page 17-

MannerSensor

Telemetry

MannerSensor

Telemetry

MannerSensor

Telemetry

MannerSensor

Telemetry

Antenna

Receiver

PT100Strain gage

Transmitter

Pressure

Easy mountingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: max. 16Sample rate: 40 000 Sample/s 1 channel)Sample rate: 2000/4000/8000 Sample/s /channel at 8 channelsDigital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open terrainIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 12 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 1500 gOptional -40 to + 120°C environmental temperature

Up to 50 m

Features:

Type: AW_T______F

Type: MSV___ ____F

-Page 18-

MANNER Radio Sensortelemetry(point to point)

SensortelemetriePCM-

MA

SensortelemetriePCM-

MA

V V V

V V V

V V V

V V V

N N N

N N N

N N N

N N N

Demultiplexer Demultiplexer Demultiplexer

MA MA MA

Statorantennas

Easy mountingwith Accu-supply 3,6 V Lithium,Max 35 hours (one cycle)Channel count: 16 (max. 32)Sample rate: 4000 Sample/s 1 channel)Sample rate: 750 Sample/s at 16 ch.Digital transmitting 12/16 Bit resolutionwith checksum (CRC)Transmitting: Radio f = 433/868 MHz,16 different frequenciesRF-Power: 10 mW; range: 30 mintegrated Data protectionAntenna diversity for improved receptionby checksum 16 Bit CRCLow current consumption by low powerC-MOS technique: 3,6 V supplyIntegrated transducer amplifier range:0,1 mV/V to 20 mV/VElectrical remote programmable rangewith 12 Bit resolutionTransducer: Strain gage, full- / ,half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°COptional inductive supplyMax. accelaration: 1500 gTemperature -40 to +85°C

Features:

-Page 19-

MANNER Radio Sensortelemetry special for Train Applicationwith Antenna Diversity

Multi channel receiverPlugin cards

Supply90 to 270 V AC

Transmitter withintegrated signal amplifier



.

.

.

.

.

.

1

2

16

Sensor with transmitter



Signal output0 to ±10 V

Easy handlingwith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)Channel count: 1 to 16 (every channel has its own frequency)Sample rate: 4000 (40 000) Sample/s (1 channel)Digital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 12 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Optional inductive supplyMax. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperature

Features:

Type: SV_4_____F

Type: AW_ES__ ___F

-Page 20-

Multi Channel Radio Sensortelemetry(separate frequencies)

Receiver

Receiver

Receiver

Receiver

0 to ±10V

0 to ±10V

0 to ±10V

0 to ±10V

RS232, USB

RS232, USB

RS232, USB

RS232, USB

Transmitter withintegrated

signal amplifier


signal amplifier


signal amplifier


signal amplifier

1

2

3

16





Easy handlingChannel count: 1(16 different frequencies)Sample rate: 4000 Sample/s (1 channel)Digital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCLow current consumption by low power C-MOS technique: 3,6 V supplyIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 12 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Max. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperaturewith Accu-supply 3,6 V Lithium, max 35 hours (one cycle)

Features:

or

Type: SV_4__ ___F

Type: SV_8__ ___F type: AW_M___

__F

-Page 21-

Multi Channel Radio Sensortelemetry(separate frequencies, point to point)

1

2

3

8

0 to ±10V

CAN, USB

9 to 36 V DC


signal amplifier


signal amplifier


signal amplifier


signal amplifier





Receiver

Easy handlingMultichannel (time multiplex)Channel count (max): 8(16 different frequencies)Sample rate: 10 Sample/s/channelDigital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 12 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Max. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperatureLow power mode, low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 150 hours (one cycle)

Features:Type: AW_M___ __F

Type: SV_8__ ___F

-Page 22-

Multi Channel Radio Sensortelemetry(multiplex mode, one frequency, multi point to point, low speed application)

1

2

8

0 to ±10V

CAN, USB

9 to 36 V DC


signal amplifier


signal amplifier


signal amplifier




Receiver

Easy handlingMultichannel (time multiplex)Channel count (max): 8(16 different frequencies)Sample rate: up to 4000 Sample/s/channelall transmitter signals synchronizedDigital transmitting 16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433/868 MHz, 16 different frequenciesRF-Power: 10 mW; range: 50 m in open fieldIntegrated data protection by checksum 16 Bit CRCIntegrated transducer amplifier range: 0,1 mV/V to 20 mV/VRange adjustable by solderable resistorsor optional electrical remote programmable range with 16 Bit resolutionTransducer: Strain gage, full- / half bridge, Thermocouple type KZero drift / Gain drift: 0,01 %/°C (0,003 %/°C optional)Max. accelaration: 1500 gTemperature range: -10 to +85°COptional -40 to +120°C environmental temperatureLow power mode, low power C-MOS technique: 3,6 V supplywith Accu-supply 3,6 V Lithium, max 20 hours (one cycle)

Features:Type: AW_F___ __For AW_TE42_...

Type: SV_8__ ___F

Multi Channel Radio Sensortelemetry(multiplex mode, one frequency, multi point to point, high speed application)

Antenna2Antenna 1

Receiver

Shaft

Features:

Up to thousandfold improvement of reception in case of interferences2 receiver systems with 2 separate antennasDiversity combiner selects every time the best signalAvoiding of lost of sensor data in case of bad reception or interferencesDigital transmitting 12/16 Bit resolution with checksum (CRC)Transmitting: Radio f = 433..2,4 GHzRF-Power: 10 mW; range: 50 m in open terrainIntegrated data protection by checksum 16 Bit CRCSpecial for large shaftsSpecial for train applicationSpecial for hard reception conditionsDiv__

-Page 23-

Option Radio Sensortelemetry with Antenna Diversity(Security of data transmission by use of 2 antennas)improvement

1..128 2..6

* Auto zero,* Adjusting tolerances in zero point* Adjusting tolerances in gain* Remote On/Off Transmitter

For initial remote setup of theof strain gage application

at installation

Remote online re-conditioningwithout opening of theamplifier

Receiver

Gain

Zero point


Interface-Box

USB - Bus

Strain µm/m

Zero adjustment

Gain adjustment

Nullpunkt

Meßbereich

-100

1

-80

2

-60

3

-40

4

-20

5

0

6

20

7

40

8

60

9

800

10 11 12

100

MV/V

% [-100..100]

MV/V [0...12,64]

Absolut[0.. 4095]-2,58 mV/V...+2,58 mV/V

Absolut[0.. 4095] Vmax...+Vmin

Übertragung Initialisieren

Exit

Transmit/Receive

Status

MA MANNERSensortelemetrieR

Datei Info

Werte erneut senden

Zusatzfunktionen

Torquedisplay

Nm

Laptop

-Page 24-

Option RMC Sensor Telemetry (Wireless)remote Controlvia Radio link

data

Sensor

Evaluationunit CAN

Ethernet+-

Electronicallyprogrammable

amplifier

Gain (remote)

Autozero, Zero (remote)

Digitaldata

Wireless remote programmable Sensor Telemetry

RMC Sensortelemetry

µP

USB0 to ±10V

Remote conditioning, ON/OFF

withlaptop

Output10 V

digits

Extentionmm/m

Zero pointcorrection

Gaincorrection

High resolution (16 Bit) initial remote setup of the

of strain gage applicationat installation and calibration

Addressgain and zero point storage

Monitoring of supply

Sensor signal amplifier

-Page 25-

Akku (Option)

Separateaddress for

each amplifier

gain, zero adjustable with 16 bitsresolution (internal storage)

wireless

ON/OFFwireless

remote Controlvia Radio link

data

Power suppy

Gain, Range

Zero, Offset

Logic

RMC Sensor signal amplifier Receiver

RFgenerator

Modulator/Demodulator/D/A-Converter

A/D-ConverterModulator/Demodulator

Cal.

Output signal0 to ±10 V

USBEnergie

Digitized sensor signal

Range, gain, zero, offset

Inductivecoupling

Remote shunt calibration

Logic

Type of sensor

frequency = 13,56 MHz

Rotating Stationary

Amplifier

Features:

uP

The control data for gain and zero will be online transferred via the telemetry channel

Remote shunt calibration Laptop,PDA

Transducer

Amplifier 1 Amplifier 2

Logicwith EEProm Remote RMC Data

Offset16 Bit resolution

Gain16 Bit resolution

Amplifier

CalRcal

Zero/Offset

Gain/Range

-100

1

-80

2

-60

3

-40

4

-20

5

0

6

20

7

40

8

60

9

800

10 11 12

100

MV/V

% [-100..100]

MV/V [0...10]

Absolute[0.. 65000]-2,58 mV/V...+2,58 mV/V

Absolute[0..65000] Vmax...+Vmin

Initiale

Exit

Transmit/Receive

Status

MA MANNERSensortelemetrieR

Datei Info

LaptopuPµP

-Page 26-

How does RMC Sensor Telemetry work?

* Remote high resolution adjustment (16 Bit) of gain, range ( 0,05 to 10 mV/V)* Auto zero* Remote high resolution adjustment (16 Bit) of zero, offset (±500% from the adjusted range)* Digitizing of sensor signal with 16 Bit resolution inside the sensor signal amplifier* Integrated sensor signal amplifier for direct interface of strain gage: Standard: strain gage, PT100 Option: Thermocouple, piezo electric, ICP, LVDT* Remote shunt calibration (option)* Integrated power supply for transducer and amplifier* Very small zero/gain drift: 0,003 %/°C* Very good linearity:

Radio-SensortelemetryComponents

-Page 27-

Sensor Signal Amplifier Type 2End of Shaft

50,0

40,0 6,0

42,0

32,0

Ø5,0

4 x Ø4,5

1 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth (10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gage: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: SV_2___Fu____

1 kHz 0,020,010,005

85120

PCM12PCM16

-RC

-TC

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 28-

Sensor Signal Amplifier Type 4a

Weight: about 12g

1/2 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gage: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: SV_4a___Fu____

1 kHz2 kHz10 kHz

0,020,010,005

85120

PCM16

Ø3,1

Ø3,1

34,017,0

36,0

13,0

1,0

30,0

24,0

-RC

-TC

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 29-

Gnd

Gnd

3,3..16V Supply

+3VI+I-

Antenna

cable exits

aktivation line active high+5..16volts

SGE=1 mV/V(default)

gain resistor

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

+/-0,118

+/-0,131

+/-0,110

Sensor Signal Amplifier Type Epoxy

1 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth (10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gage: 350 W (1000 Transmission: Radio Sensortelemetry PCM, 433 MHzIntegrated filterResolution: 16 BitDrift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 16 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)weight. 20 g, Max load: 3 000 g (depends on fixing)Type: SV_7a___Fu____

W)

1 kHz 0,020,010,005

85120

PCM16 -RC

-TC

shaft

batterytransmitter

clamp

housing: Epoxy

Weight: about 13g

4 mal Ø2,24,0

47,0

Ø18

,0

Ø 2

0,0

Ø 2

5,0

With integrated axial antenna

UB CalGNDRv1

I+I- Rv2Tk

Sensor signalamplifierEnd of shaft

Sensor Signal Amplifier Type 2b (End of shaft, Cartridge, Turbine)integrated antenna

1 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gage: 350 WTransmission: Radio Sensortelemetry PCM integrated antennaIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: SV_4b___Fu____

1 kHz2 kHz10 kHz

0,020,010,005

85120

PCM16 -RC

-TC

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 30-

Lemo socket:HVG.03.304.CLLSV5 x M3depth: 4 mm

21,0

Ø80

,0

Ø81

,0

Ø63

,1

Connectorfor remote control

Magnet forremote shunt

calibration

20,5 1,5

Ø56

,0

Sensor Signal Amplifier Type SV_Rad

+

+-

-R

R

RCal RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

1 Channel Radio Sensortelemetry transmitterfor wheels or shaft end applicationsFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 V, battery or accu (rechargeable)Strain gages: 350 WTransmission: Radio Sensortelemetry PCMDiameter: 80 mm, height: 43 mmResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Recharging by inductive recharging cap (contactless)Operating time between recharging: 30 hoursActivating by switchRemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Protection: IP67Max load: 1 000 g (depends on fixing)Type: SV_Rad___Fu____IP67_

1 kHz2 kHz10 kHz

0,020,010,005

85120

PCM16 -RC

-TC

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 31-

1 Channel FM/PCM TransmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 mV/V to 20 mV/VBandwidth: 0 (10) Hz to 50 kHzStrain gage brigde supply: 6 V (3,3 V*)Strain gage bridge resistance: 1000 WTransmission: inductive sensortelemetry FM, PCMIntegrated filterResolution: 14 Bits, 16 Bits*Zero point drift: 0,02, (0,01, 0,003* option)Remote shunt calibrationRemote gain, zero, auto zero with 16 Bit resolution (option)additonal temperature channel (option)Enviromental temperature range: -25 to +85°C (125°C, 150°C)Max load: 5 000 g (depending on fixing)Type: SV_8a___Fu____wa_

1 kHz10 kHz40 kHz

0,020,010,003

85125150

Sensor Signal Amplifier Type 8a(waterproof)

50,0

30,0

24,0

45,0

22,5

15,0

Housing BOPLA A100

18,0

30,0

I+UB

HFGND

HF1 Rv2Rv1

Cal

HF2

5,8V

GNDI-

Tk

Thermocouple

* PCM-Version

PCM16 -RMC

-TC

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 32-

-IP52IP65IP67

Sensor Signal Amplifier Type 8bspecial for tension belt fixing (waterproof)

50,0

I+UB

HFGND

HF1 Rv2Rv1

Cal

HF2

5,8V

GNDI-

Tk

1 Channel Radio Sensortelemetry transmitterwith integrated transmitting antenna and accu pack For strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mA, operating with 1 accu charge 30 hoursRemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)protection: IP65Max load: 1 000 g (depends on fixing)Type: SV_8b___Fu____wa_

80,0

45,0

Tension belts

18,0

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

Shaft

-Page 33-

1 kHz10 kHz40 kHz

0,020,010,003

85125150

FMPCM16

-RMC

-TC

-IP52IP65IP67

Sensor Signal Amplifier Type 9

Øinner Øouter

Through holeØ = 7mm for weight reduction

Inner diameter: 17 to 50mmOuter diameter = Inner diameter + 20mm (without integrated battery)or Outer diameter = Inner diameter + 30 mm (with integrated rechargeable battery)

M3 Inbus

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

1 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: SV_9___Fu_____

1 kHz 0,020,010,005

85120

PCM12PCM16

-RMC

-TC

-IP52IP65IP67

battery

+

+-

-R

R

RG or RVR

RUd

I+

GND

I-

UB

Rv1Rv2

Transmitter RF1

-Page 34-

Multi channel signal Amplifier Type M waterproof

2/4 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 10 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: MSV_M____Fu____wa_

0,020,010,005

85120150

R

R

PCM12PCM16

50,0

30,0 24,0

23,0

16

,9

Housing BOPLA A10018,0

25,5

I+ I+ I+ I+

UB

UB

UB

UB

Cal

Cal

Cal

Cal H

F

GN

D

GN

D

GN

D

GN

D

I- I- I- I-

1 2 3 4

45,0

HFG

ND

Antenna

tensionbelt

shaft

Prisma

sensor signal amplifier

battery

typical mounting on shaft

5004000800040000

24816

-RMC

-TC

i=1

i=n

Vcci

Gndii = channel number

TransmitterRF1

+

+-

-

.

.

.

-Page 35-

Supply voltage supervisionLED on --> supply voltage ³3,6 VLED off --> supply voltage

4/8 Channel Sensor Signal Amplifier Type M_wa(waterproof, IP65)

4/8 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: MSV_M____Fu____wa_

248

0,020,010,005

85120150

PCM12PCM16

*Option: current save mode for extrem long Battery lifetime

5004000800040000

-RMC

-TC

i=1

i=n

Vcci


TransmitterRF1

+

+-

-

.

.

.

50,0

68

58

30,0 24,0

18,8

Housing BOPLA A101

64

34

-Page 37-

12 Channel Sensor Signal Amplifier Type M(Standard)

3437

4450

12,5

1

26

6

5051,557,5

7,032,019,5

44,5

Diameter 3,2 mmRadius = 2 mm

Solder pins

Antenna

12 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: MSV_M____Fu____wa_

12 0,020,010,005

85120150

PCM12PCM16

5004000800040000

-RMC

-TC

i=1

i=n

Vcci


TransmitterRF1

+

+-

-

.

.

.

-Page 38-

16 Channel Sensor Signal Amplifier Type M(Standard)

3437

4450

12,5

1

33,2

6

5051,557,5

7,032,019,5

44,5

Diameter 3,2 mmRadius = 2 mm

Solder pins

Antenna

16 Channel Radio Sensortelemetry transmitterFor strain gage, PT100, ThermocoupleSensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 VStrain gages: 350 WTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Supply: 3,3 to 12 V, 50 mARemote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Max load: 1 000 g (depends on fixing)Type: MSV_M____Fu____wa_

16 0,020,010,005

85120150

PCM12PCM16

5004000800040000

-RMC

-TC

i=1

i=n

Vcci


TransmitterRF1

+

+-

-

.

.

.

-Page 39-


21,0

Ø90

,0

Ø91

,0

Ø63

,1

20,5 1,5

Ø56

,0

Multi Channel Radio Sensortelemetry transmitterfor wheels or end shaft applicationsFor strain gage, PT100, ThermocoupleChannels: 2, 4, 8, 16Sensitivity: 0,02 to 20 mV/VBandwidth 10 Hz / 0 Hz to 1 kHzBrigde supply: 3 V, Accu rechargeableStrain gages: 350 WTransmission: Radio Sensortelemetry PCMDiameter: 91 mm, height: 43 mmResolution: 12 Bit (16 Bit)Drift zero: 0,01, (0,005 option)RechargableOperating time between recharging. 20 hoursActivating by switch (option remote control)Remote range control, auto zero (option)Environmental temperature: -25 to +85°C (120°C)Protection IP67Max load: 1 000 g (depends on fixing)Type: MSV_Rad____Fu____wa_

1...16

0,020,010,005

-10+85°C-40+120°C

PCM12PCM16


Magnet forremote shunt

calibration

Sensor Signal Amplifier Type MSV_R

50010004000

-RMC

-TC

i=1

i=n

Vcci


TransmitterRF1

+

+-

-

.

.

.

-Page 40-

integratedtransmitting antenna


21,0

Ø80

,0

Ø81

,0

Ø63

,1

20,5 1,5

Ø56

,0


Sensor Signal Amplifier Type MSV_Rspecial for temperature aquisition at wheels

1

n

Thermocouple with transmitter

Thermocouple with transmitter

WirelessLAN

CAN, USB

9 to 36 V....

Multi Channel Radio Sensortelemetry transmitter for wheels or end shaft applicationsFor Thermocouple type KChannels: 2, 4, 8, 16Range: -50 to 1000°CSample/sec: 10Local aera LAN time multiplex (one frequencyBrigde supply: 3 V, Accu rechargeableTransmission: Radio Sensortelemetry PCMDiameter: 80 mm, height: 43 mmResolution: 12 Bit (16 Bit)Drift zero: 0,02 (0,01, 0,005 option)Low power consumption, operating time between recharging. 150 hoursRecharging by inductive recharging cap (contactless)Activating by switchEnvironmental temperature: -25 to +85°C (120°C)Protection IP68Max load: 1 000 g (depends on fixing)Type: MSV_Rad____Fu___wa_

0,1/s1/s10/s

1...16

0,020,010,005

85120

PCM12PCM16

-Page 41-

32 Channel Sensor Signal Amplifier Type MSV_Rspecial for helicopter use (IP65)

Multi Channel Radio Sensortelemetry transmitter for wheels or end shaft applicationsFor strain gage (optional thermocouple)Transmission: Radio Sensortelemetry PCM (digital transmission)Channels: 16, 32Sample/channel/sec: 500, 1000, 2000, 4000 Brigde supply: 3 V, Strain gage resistance: 350, (120, 1000) W Resolution: 12 Bit (16 Bit)Range: 0,05 ...16 mV/V (remote via wire and PC adjustable with 12 bits resolution)Auto zero/ offset adjust (remote via wire and PC adjustable with 12 bits resolution) Drift zero: 0,02 (0,01, 0,005 option)Integrated accu pack, 4000 mA/h, rechargeable by connectorLow power consumptionSize: Diameter: 136 mm, height: 70 mmEnvironmental temperature: -25 to +85°C (120°C)Protection IP54, (IP68 option)Max Speed: 3000 RPM (depends on fixing)Type: MSV_R__ __Fu__samplerate>__wa

1632

0,020,010,005

85120

PCM12PCM16

500100020004000800040000

117

126136

70

8

H6

12 x M4

Antenna

Connectors for strain gages

Recharging connector

Set up connectorgain, auto zero

i=1

i=n

Vcci


TransmitterRF1

+

+-

-

.

.

.

-Page 42-

Sensor Signal Amplifier Type RAHd

Øinner Øouter

Through holeØ = 7mm for weight reduction

Inner diameter: 17 to 50mmOuter diameter = Inner diameter + 20mm

M3 Inbus

Multi Channel Radio Sensortelemetry transmitterFor PT100, Thermocouplerange: 0..1200 °CBandwidth 10 Hz / 100 HzThermocouples: type K, T Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Drift zero: 0,02Supply: 3,6 to 12 V, 50 mAEnvironmental temperature: -25 to +85°C (120°C)Max load: 5 000 g (depends on fixing)Type: MSV_RAHd_T_

Pin Assignmentof the D-Sub connector

Pin 1 Output -10V to +10VPin 2 GND OutputPin 3 do not connectPin 4 do not connectPin 5 GND Power SupplyPin 6 do not connectPin 7 Power Supply 24 VDC ±10%Pin 8 do not connectPin 9 do not connect

Receiver (AW_D)

MA MANNERSensortelemetrieSensorsignal-Drehübertrager

Pin 1: Output U: 0 to +/- 10 Volt Pin 8: Output I: 0 to + 20 mAPin 1: Output U: 0 to +/- 5 Volt Pin 8: Output I: 4 to + 20 mAPin 3: Input Mod.(Cal.)aktive low Pin 9: Output F:100kHz ±50kHzPin 3: Input Mod.(Cal.)aktive high Pin 9: Output F:25kHz ±12,5kHzPin 6: RPM PCMPin 7: Supply +15V +/-2%

Pin 2: GND OutputPin 7: Supply +24V +/-10% Pin 5: GND SupplyLED yellow: SupplyLED green: Signal

49,0

79,0

20,0

42

,0

72,0 M2,51 Channel Radio Sensortelemetry ReceiverBandwidth: 0 to 1kHzOutput: ±10 V (0(4) to 20 mA, frequency, binary, USB)RF frequency: 433 MHzTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Environmental temperature: -25 to +85°C (-45 to +85°C)Supply: 24 V (±5%), 15 V (±2%), 9 to 36 V (board supply)Type: AW_D_Fu____

1 kHz 15V24V

UI

PCM12PCM16

0 to ±10VSingle ChannelReceiver

Remotecalibration

Antenna

USB

24 volts

-Page 44-

Evaluation Unit (AW_M)50

,030

,0

Ø3,3

60,0

130,0140,0

+ -

Eva

luat

ion

Uni

t

MA

MAN

NER

Sens

orte

lemet

rieR G Z

0 to ±10VSingle ChannelReceiver

Remotecalibration

Antenna

CANUSB


Pin 1 Output -10V to +10VPin 2 GND OutputPin 3 Shunt Cal. (active low)Pin 4 do not connectPin 5 GND Power SupplyPin 6 do not connectPin 7 Power Supply 9 to 36 VDCPin 8 do not connectPin 9 do not connect

9..36 volts

1 Channel Radio Sensortelemetry ReceiverBandwidth: 0 to 1kHzOutput: ±10 V (0(4) to 20 mA, frequency, binary, USB)RF frequency: 433 MHzTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Environmental temperature: -25 to +85°C (-45 to +85°C)Supply: 24 V (±5%), 9 to 36 V (board supply)Type: AW_M_Fu____

1 kHz2 kHz10 kHz

152424B

UIBUSB

PCM12PCM16

-Page 45-

Evaluation Unit (AW_P)

150

137

120

101 80

60

36

MA MANNERSensortelemetrie

TelemetryReceiver

+

Power

Signal rangeHF

Signal

-

Pin 1 :Pin 2 :Pin 3 :Pin 5 :Pin 7 :Pin 8 :

ZER

O

GA

INØ5,2



0 to ±10V

Single ChannelReceiver

Remotecalibration

Antenna

SpeedPickup

Trace ATrace BTrace 0

Incremental/Absolutconverter(option)

Digital interface(option)

TCP/IPCANUSB

Shaft encoder interface (option)

9..36 volts

1/2 Channel Radio Sensortelemetry ReceiverBandwidth: 0 to 1kHzOutput: ±10 V (0(4) to 20 mA, frequency, binary, USB)RF frequency: 433 MHzTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Environmental temperature: -25 to +85°C (-45 to +85°C)Supply: 24 V (±5%), 9 to 36 V (board supply)Type: AW_P_Fu____

1 kHz2 kHz10 kHz

15V24V24V

UIBUSB

PCM12PCM16

-Page 46-

Pin Assignmentof the D-Sub connectorPin 1 DataPin 2 GND OutputPin 3 not connectedPin 4 Data Pin 5 GND Power SupplyPin 6 Trace 0 (option)Pin 7 Power Supply 9 to 36 VDCPin 8 DataPin 9 DataPin 10 Trace A (option)Pin 11 Trace B (option)Pin 12 not connectedPin 13 not connectedPin 14 not connectedPin 15 not connected

Multi Channel PCM ReceiverBandwidth: 0 to 1kHz (10 kHz)Number of channels: 1..32Output: ±10 V, (0(4) to 20 mA option)Digital interface (option): SPI, USB, CAN, Ethernet (TCP/IP)Frequency 433 Mhz, (750 MHz)Transmission: inductive sensortelemetry PCMResolution: 12 Bits, (16 Bit*)Remote shunt calibrationEnviromental temperature range: -25 to +85°C (-45 to +85°C)Supply: 24 V DC (+/-5%), 15 V DC (+/-2%), 9 to 36 V DC (board supply)Type: MAW_F__Fu____

2481216

152424B

USBCANTCP/IPHS

PCM12PCM16

4000020000 80004000200010001 *

*Option: current save mode forextrem long Battery lifetime

Evaluation Unit (AW_F)Digital Receiver


RemoteCalibration

Antenna

SpeedPickup

Trace A

Trace B

Trace 0

Incremental/Absolutconverter(option)


Ethernet(TCP/IP)CANUSB


Traffic

Link

MAsignal range

110

180

35

9..36 volts

-Page 47-

1 Channel Radio Sensortelemetry ReceiverBandwidth: 0 to 1kHzOutput: ±10 V (0(4) to 20 mA, frequency, binary, USB)RF frequency: 433 MHzTransmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Environmental temperature: -25 to +85°C (-45 to +85°C)Supply: +/-15VType: AW_ES_Fu____

UI

PCM12PCM16

+/-15

Evaluation Unit (AW_ES)

1 kHz2 kHz10 kHz


RemoteCalibration

Antenna

SpeedPickup

Trace A

Trace B

Trace 0

Incremental/absolutconverter(option)




+/-15 volts

-Page 48-

V V V V V V V V V V V V

N N N N N N N N N N N N

Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie Sensortelemetrie

M M M M M M M M M M M MA A A A A A A A A A A A

Evaluation Unit (84TE)

1/2/4/8 Channel PCM Receiver with Single ChannelsBandwidth: 0 to 1kHzOutput: ±10 V, (0(4) to 20 mA, binary, USB)Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 12 Bit (16 Bit)Max. Plugin cards: 12 (single channels)Environmental temperature: -25 to +65°CSupply: 9 to 270 V AC, 9 to 36 V (board supply) DCType: AW_84TE_Fu____

230V24V

UIBUSB

PCM12PCM16

1248

1 kHz2 kHz10 kHz

132(3HE)

for example420

(84TE)

Front side depth 300 mm

-Page 49-


Multi ChannelReceiver

Remotecalibration

Antenna

SpeedPickup

Trace A

Trace B

Trace 0





90..270 volts ac

Front side

G G G G G G G

G G G G G G G

G G G G G G G

G G G G G G G

O O O O O O O

O O O O O O O

O O O O O O O

O O O O O O O

Demultiplexer Demultiplexer Demultiplexer Demultiplexer Demultiplexer Demultiplexer Demultiplexer

M M M M M M MA A A A A A A

G

O

Sensortelemetry

MA

132(3HE)

300

430(84 TE)

1/2/4/8/16/32 Channel FM/PCM ReceiverBandwidth: 0 to 1kHzOutput: ±10 V, (0(4) to 20 mA, binary, USB)Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Remote shunt calibrationEnvironmental temperature: -25 to +65°CSupply: 90 to 270 V AC, 9 to 36 V (board supply) DCType: MAW_84TE__Fu____

230V24B

UIBUSBCANTCP

PCM12PCM16

12481632

4000080004000200010001 *

-Page 50-


MultiChannelReceiver

Remotecalibration

Antenna

Speedpickup

Trace A

Trace B

Trace 0





90..270 volts

Front side

G

O

Sensortelemetry

MA

132(3 HE)

225(42 TE)

300

G G

G G

G G

G G

O O

O O

O O

O O

Demultiplexer Demultiplexer

M MA A

1/2/4/8 Channel FM/PCM ReceiverBandwidth: 0 to 1kHzOutput: ±10 V, (0(4) to 20 mA, binary, USB)Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Remote shunt calibrationEnvironmental temperature: -25 to +65°CSupply: 90 to 270 V AC, 9 to 36 V (board supply) DCType: MAW_42TE__Fu____

230V24B

UIBUSBCANTCP

PCM12PCM16

1248

4000080004000200010001 *

-Page 51-


1/2/4 Channel FM/PCM ReceiverBandwidth: 0 to 1kHzOutput: ±10 V, (0(4) to 20 mA, binary, USB)Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Remote shunt calibrationEnvironmental temperature: -25 to +65°CSupply: 90 to 270 V AC, 9 to 36 V (board supply) DCType: MAW_22TE__Fu____

230V24B

UIBUSBCANTCP

PCM12PCM16

124


Remotecalibration

Antenna

Speedpickup

Trace A

Trace B

Trace 0





90..270 volts

Front side

G

G

G

G

O

O

O

O

Demultiplexer

MA

G

O

Sensortelemetry

MA

112(21TE)

132(3HE)

300

4000080004000200010001 *

-Page 52-

Front side

132(3HE)

300

x

G G

G G

G G

G G

O O

O O

O O

O O

Demultiplexer Demultiplexer

M MA A

G

O

Sensortelemetry

MA

1/2/4/8 Channel FM/PCM ReceiverBandwidth: 0 to 1kHzOutput: ±10 V, (0(4) to 20 mA, binary, USB)Transmission: Radio Sensortelemetry PCMIntegrated filterResolution: 14 Bit (16 Bit)Remote shunt calibrationEnvironmental temperature: -25 to +65°CSupply: +/-15 volts DCType: MAW_Es__Fu___+/-15V>_

UIBUSB

PCM12PCM16

1248


Remotecalibration

Antenna

Speedpickup

Trace A

Trace B

Trace 0





90..270 volts

4000080004000200010001 *

-Page 53-

1/2 Channel Radio Sensortelemetry ReceiverBandwidth: 0 to 1kHzOutput: ±10 V (0(4) to 20 mA, frequency, binary, USB)RF frequency: 433 MHzTransmission: Radio Sensortelemetry PCMSupply battery 3,6..12 volts or inductive 3,2 MHzIntegrated filterResolution: 12 Bit (16 Bit)Environmental temperature: -25 to +85°C (-45 to +85°C)Supply: 24 V (±5%), 15 V (±2%), 9 to 36 V (board supply)Type: AW_F_Fu_____

1kHz2 kHz10 Khz

1524B

UI

BUSB

PCM12PCM16

Alternative Battery or inductive Supply

0 to ±10V


Remotecalibration

Antennas Digital interface(option)

TCP/IPCANUSB

9..36 volts

inductive supply





alternativ

..

-Page 54-

14

ca. 35

Coaxial cable RG58Max. length 10 m

87

Receiving / Transmitting Antenna with magnetic Foot

Receiving AntennaFrequency 433 MHzHeight: 87 mmMagnic footCoax cable power max. 50 WCable length: 5 mEnvironmental temperature: -35 to +85°CType: AFu__PCM__

Transmitting Antennatype rodFrequency 433 MHzHeight: 87 mmEnvironmental temperature: -10 to +85°CType: Rot_FuS____PCM

Transmitting Antennatype wireFrequency 433 MHzHeight: 87 mmEnvironmental temperature: -10 to +85°CType: Rot_FuD_SMA___PCM

Features

-10_+85-25_+125-40_+160

-10_+85-25_+125-40_+160

-10_+85-25_+125-40_+160

BNCTNCSMALemo

N

TNCSMA

N

-wa

-wa

-wa

-Page 55-

Setup of the Interface Software(Software Package Remote Control)

MENUE -> SETUP -> HARDWARE CONFIGURATION

Choice between the various interface configurations. Please see seperate configuration sheet or the marked settings beside.The setup of the interface has to be configurated for eachsingle user of your computer.

Settings for RPM Channel (optional):Settings have to be made for correct RPM display in the software.Averaging factor has an effect on a fluctuating rpm value especial at high rotational frequencies.Type in the proper samplerate from the technical data on the last pages of the documentation.

MENUE -> SETUP -> SOFTWARE CONFIGURATION

Display SettingsCoice between standard-systems and temperature-systems

Data File Format for Aquisition:Coice between binary format and ASCII format

Integrated Remote ControlActivates or deactivates functions for RMC-programming of systems, which support data-aquisition and programming over the same USB-interface

Calibration Command (for non-RMC-systems)If this function is supported by the hardware the remote calibration function can also activated by the software

Different interfaces

-Page 56-

Using of Remote Control Function(Software Package Remote Control)

Status-Info:

Transmit: By transmission of a command in the first array of the 'Status Info' area the informtaion 'Transmit' is displayed (in green letters). In case of an inactive status the array is grey.

Acknowledge or Error status: After sending a command, the replay is displayed here.After a successful transmission 'Acknowledge' is displayed (in green letters).During an error status, the array in which 'Transmit' appears is marked red.In this array the 'Error status' is shown.

Adjustment:With this function an additional window for RMC settings is opened.(see following page)

Cal on:Via the RMC command the shunt calibration is activated.

Cal off:Via the RMC command the shunt calibration is deactivated.

Test ConnectionStart / Stop of the test transmission. With this function a RMC command is send cyclic.In the area 'Status Info' the replies can be checked.

-Page 57-

automatic zero adjustment

Using of Remote Control Function(Software Package Remote Control)

Transmission of the complete set of settings to the rotor electronic(Gain an Zero point for all selected channels)

Presetting of the memory

Digital value of the sensitivity0 to 4095 - Min value = high gain Max value = low gainDoubling the sensitivity is about half of the gain.

Digital value of the zero point(0 to 4095) 2048 is about in the middle

Setting of the RMC channel number of the telemetry system

Loading / storing of settings

Transmission of ‘Gain’ or ‘Zeropoint’of the relevant channel

-Page 58-

Activity display (green)at file operation

Activity display (green)at data transmissionfrom the Telemetry System

Information aboutdata rate, sample rate etc.

Exit programWhen data recording is activethen stop data recording beforeexiting the program toprevent loss of data

Start data display

Stop data display

Display of the binary valuesas they are sent(inverse to the output at theevaluation unit)

No other program must be active at the PC while recording data into a file.This can effect a loss of data.

Display selectionConfiguration/Bargraph-Oscilloscope/Data recording

Interface - Software(Software Package data acquisition - optional)

Display of the selected device(if multiple available)

-Page 59-

No other program must be active at the PC while recording data into a file.This can effect in buffer overflow and the loss of data. If buffer overflow occures, it will be displayed in a field on the left side of “Data recording”Due to some limitations, the maximum filesize should not exceed 4GB.

Control of Data acqisition(Software Package data acquisition - optional)

file name

recording of the measurement data in asingle file or in multiple files (to define in periods)

reducing of the sampling rate

Start recording into a file

Stop recording into a file

Show data with additional dataviewer PVIEW - if installed

-Page 60-

Data Display Software PView(Software Package Data Acquisition - optional)

Channel 2

Channel 3-100.00

Channel 1

Visualisation of recorded Data

-Page 61-

Data FormatThe data are recorded in the MDF format.Two files are generated. One binary file with the ending '.DAT' and one belonging description file with the ending '.MDF'.The description file is necessary for the data viewing software PVIEW from Stiegele Datensysteme GmbH.The binary file can be used from other data display or data analysing systems that are able to import digital values.

Correlation of the measured values:The range of a 12 bit system is from 0 to 4095, the range of a 16 bit system is from 0 to 65535Assignment to the analog values (custom specific systems and temperature-systems can differ from these values):

Range Analog value Digital value (16 Bit-system) Digital value (12 Bit-system)-100% -10V 3277 205 0% 0V 32768 2048+100% +10V 62259 3891

Values out of this range are not inside the measuring range and cannot be displayed correctly at the analog outputs.

The analog value can be calculated by the following equation: Uout [V]=(Digitvalue-32768) / 2949.1 (16Bit) or Uout [V]=(Digitvalue-2048) / 184.3 (12Bit)(This correlation is only valid with calibrated analogue-output)

Format of the Binary File (.DAT)Definition: LB= Low Byte, HB=High-Byte,CHx = Channel x (e.g. Ch1 = Channel 1 corresponding to the analog output channel at the evaluation unit)First the Low-Byte and then the High-Byte of a channel is recorded.

LB-K17, HB-K17, LB-K16, HB-K16, ... , LB-K1, HB-K1 (first data set)LB-K17, HB-K17, LB-K16, HB-K16, ... , LB-K1, HB-K1 (next data set)...LB-K17, HB-K17, LB-K16, HB-K16, ... , LB-K1, HB-K1 (last data set)

Sample file shown with a Hex Viewer

Channel 17next data set

Data File - Binary Format(Software Package Data Acquisition - optional)

Channel 17E2=Low Byte channel 170F=High Byte channel 17

Channel 0

-Page 62-

Data File - ASCII Format(Software Package Data Acquisition - optional)

Data FormatThe data are recorded in the CSV-Format.The measured values are separated with a semicolon. After each complete data set a 'Carriage Return' + 'Linefeed' is added.The channel description is in the first row of the file.

Correlation of the measured values:The range of a 12 bit system is from 0 to 4095, the range of a 16 bit system is from 0 to 65535Assignment to the analog values (custom specific systems and temperature-systems can differ from these values):

Range Analog value Digital value (16 Bit-system) Digital value (12 Bit-system)-100% -10V 3277 205 0% 0V 32768 2048+100% +10V 62259 3891

Values out of this range are not inside the measuring range and cannot be displayed correctly at the analog outputs.

The analog value can be calculated by the following equation: Uout [V]=(Digitvalue-32768) / 2949.1 (16Bit) or Uout [V]=(Digitvalue-2048) / 184.3 (12Bit)(This correlation is only valid with calibrated analogue-output)

Format of the ASCII FileThe sample shows a recorded dataset of a 16 channel system:

CH16; CH15; CH14; CH13; CH12; CH11; CH10; CH09; CH08; CH07; CH06; CH05; CH04; CH03; CH02; CH0102050; 02047; 02047; 02047; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02604; 02050; 02050; 02047; 0204702050; 02047; 02047; 02046; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02626; 02050; 02050; 02047; 0204702050; 02047; 02047; 02047; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02624; 02050; 02050; 02047; 0204702050; 02047; 02047; 02047; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02605; 02050; 02047; 02047; 0204702050; 02047; 02047; 02047; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02572; 02050; 02047; 02047; 0204702050; 02047; 02047; 02047; 02050; 02049; 02048; 02050; 02046; 02050; 02047; 02561; 02050; 02050; 02047; 02047

-Page 63-

Signal Test Function via Scope Function(Software Package Data Acquisition Modul - optional)

Display of the received dataof the measuring channelsshowing the digital values,the equivalent analog values

Selection of the channel shown at the oscilloscope

Selection of time,gain and offset

Values, which are displayed in Volt accords to the voltage output to standard-systems.Temperature-measurement-systems or custom calibrated systems can differ from these values.

Analyse functions for the display

Autoscale functionfor the settings of gain and offset

Display of RPM

-Page 64-

Series in Assigned analog Descriptionthe binary file output channel 1 16 PT100 2 15 ICP 3 14 not used 4 13 not used 5 12 Strain gage channel 12 6 11 Strain gage channel 11 7 10 Strain gage channel 10 8 9 Strain gage channel 9 9 8 Strain gage channel 8 10 7 Strain gage channel 7 11 6 Strain gage channel 6 12 5 Strain gage channel 5 13 4 Strain gage channel 4 14 3 Strain gage channel 3 15 2 Strain gage channel 2 16 1 Strain gage channel 1 17 -- Rotation angle

Anpas

sen an

Anlag

e !!!

Channel Assignment

Für USB

-Page 65-

-Page 66-

Format of the binary file (.DAT) orASCII file (.CSV)

Definition: LB = low byte, HB =high byteFirst the low byte and then the high byte of a channel is recordedThe range of a 12 and 16 bit system is from 0 to 65535For 12 bit-systems, the lowest 4 bits are set to 0

Realtime recorded Data File

User specificanalysis program

Pviewvisualisation

program(part of software package

data acquisition)

Exel or other

analysisprogramms

Data Interface

Exportfunctions

radio wheel transmitter




CA

N In

terf

ace

or E

ther

Cat

digital Radio receiver

stationary data acquisitionstrain gauge/ thermocouple

8/16/24 channels syn

chro

nice

r/m

ultip

lexr

er

CAN-Bus,EtherCAT,USB

n

n

n

n

4 x n static sensors

Type: SV_Rad___Fu______

Type: AW_84H6_Fu____

RangeSensor type (SG,TC, PT,..) Waterproof/oilproofRemote Control

Output signal (U, I, USB, CAN, TCP)Supply

Bandbreite

bandwidth

Type of systemRadioType of signal transmission

Type of system RadioCoding (PCM/F)

Temperature rangeAccurracyHousing type

Housing type

Multi channel signal amplifier

Multi channel receiver

Product Key one Channel Radiotelemetry

Not all items are always used

-Page 67-

Type: MSV_Rad___________

Type: MAW_84H6_______

RangeSensor typeWaterproof/oilproof

Speed option

Remote Control

Output signal (U, I, USB, CAN, TCP/IP) Supply

Samplerate/channel/sec/spot

Samplerate/channel/sec

Type of system(Inductive, Radio, UHF) Type of signal transmission

Type of system RadioCoding (PCM/F)

Supply frequencyTemperature rangeAccurracyChannel count

Channel count

Housing type

Housing type

Multi channel signal amplifier

Multi channel receiver

Product Key Multichannel Radiotelemetry

-Page 68-

Seite 1Seite 2Seite 3Seite 4Seite 5Seite 6Seite 7Seite 8Seite 9Seite 10Seite 11Seite 12Seite 13Seite 14Seite 15Seite 16Seite 17Seite 18Seite 19Seite 20Seite 21Seite 22Seite 23Seite 24Seite 25Seite 26Seite 27Seite 28Seite 29Seite 30Seite 31Seite 32Seite 33Seite 34Seite 35Seite 36Seite 37Seite 38Seite 39Seite 40Seite 41Seite 42Seite 43Seite 44Seite 45Seite 46Seite 47Seite 48Seite 49Seite 50Seite 51Seite 52Seite 53Seite 54Seite 55Seite 56Seite 57Seite 58Seite 59Seite 60Seite 61Seite 62Seite 63Seite 64Seite 65Seite 66Seite 67Seite 68Seite 69Seite 70Seite 71

Radio Sensortelemetry - Luchsinger · 2019. 1. 28. · GND UB R+ R R+ R R- R R- R Ud AD-Converterr...

Documents

Transcript of Radio Sensortelemetry - Luchsinger · 2019. 1. 28. · GND UB R+ R R+ R R- R R- R Ud AD-Converterr...