Sidel SystemsSidel Systems

SRU Flue Gas CondenserSRU Flue Gas Condenser

Sidel Systems has been designing and Sidel Systems has been designing and installing high efficiency hot water heating installing high efficiency hot water heating

systems since 1978 …long before the natural systems since 1978 …long before the natural gas pricing crisis we are in today.gas pricing crisis we are in today.

Natural gas is one of their largest monthly expenses.

It has been our commitment to design an energy efficient heating system to keep natural gas bills as low as possible.

The heating system is one part of the design.

The boiler room is the second part

The design of the heating system has to work efficiently with the flue gas condenser.

The BasicsThe Basics

Boilers average 75% - 85% efficiency.

The heat not transferred into water escapes through the chimney and is lost into the atmosphere.

Adds up to be thousands and hundreds of thousands of dollars!

Natural gas, what was once only twenty cents per therm has rocketed to upwards of over a dollar per therm.

Some OptionsSome Options

Economizers are easily installed.

Some of the waste heat is transferred into the boiler feed water.

Will improve boiler efficiency by 2 – 4%.

Sidel SRU Flue Sidel SRU Flue Gas CondenserGas Condenser

Typically increases boiler efficiency to 90-95%.

Aluminum on the flue gas side.

Stainless steel on the water side.

Our tube is actually two tubes.

Aluminum is a high conductor, ideal for heat transfer purpose.

Each fin is individual, not spiral wound, flue gasses can travel smoothly up through the condenser.

Typically, back pressure across our unit is about ½” water column .

Most of the condensing takes place at the top of the unit, where cool water enters.

As the condensation runs down the unit, it is at the same time washing the fins clean.

Likely Applications

Food Processing Plants

Slaughter Houses

Hospitals

Hotels

Commercial Laundry Facilities

Universities

Federal and State Buildings

Chemical and Pharmaceutical Plants

Radiant Floor Heating Area is being heated almost

for free.

Operating at over 90% efficiency.

Fuel savings will far outdo the initial cost of the installation.

Created condensate can be collected for irrigation.

It is possible to create over 100 gallons of condensate an hour.

Now not only are we using natural gas efficiently, but also conserving water.

In most cases, the payback period, is under two years on smaller boilers.

For larger boilers, it can be as short as six months.

We look at each facility, and their requirements and design for maximum efficiency.

Sidel Systems USA Inc. is a recognized partner of Energy Star. Our product is guaranteed to save you money as well as helping to save the

environment.

We thank you for your time and interest.

Contact us at (805) 462-1250 or

1-800-668-5003

Sid Abma