Parts List - Ingersoll Rand Productsmanualarchive.ingersollrandproducts.com/manuals/manuals...This...

Parts List

Model

COMP 5&4X7 PHE7 NL

Customer Order Number Machine Serial Number

Item No

M/s Taigang Engineering Co. Ltd X26397 PHN7907 24038200

Parts Book

Model / Configuration Model / Configuration

5 & 4 x 7 PHE7 LUBE

Compressor Serial Number

PHN 7907

List Number

24038200

This parts book is for use with Ingersoll Rand equipment of the type listed above only. The compressor serial number, model, and List number are the key to identify your equipment. These numbers are stamped on the compressor nameplate. For your convenience, we suggest that you record these numbers.

General Information: This parts book is provided as an important part of your Ingersoll-Rand equipment. It has been written and illustrated for quick identification of all standard parts for basic compressor, ordering requirements, and to help plan spares to maintain trouble free operation of the equipment.

This book contains two sections. Section 1: Parts List

(Helps identify basic components / assemblies used in this equipment)

Section 2: Recommended Spares (Helps you to plan spares for trouble free operation)

This technical manual contains IMPORTANT DATA and should be kept with the equipment at all times.

Safety Instructions: The use of parts (1) other than those included within this book or (2) not approved by Ingersoll-Rand or (3) not supplied by Ingersoll-Rand, may create hazardous condition over which the Ingersoll-Rand has no control. Such hazardous condition can lead to accidents that may be life threatening, cause substantial body injury, result in damage to the equipment, or poor performance / life of the equipment. Therefore, Ingersoll-Rand can bear no responsibility for equipment in which such non-approved parts are used.

Please verify components before any attempt is made to install or replace upon receipt from Ingersoll-Rand. For any further information or assistance please contact nearest Ingersoll-Rand distributor or branch office.

Before any attempt is made to restart the equipment after replacement of part(s), please verify that is properly assembled as per recommended procedure by Ingersoll-Rand. For any further information or assistance please contact nearest Ingersoll-Rand distributor or branch office.

Terms and Conditions:

Restrictions on use: This manual is created and owned by Ingersoll-Rand (IR) and contains confidential, trade secret information and is protected by international copyright and trademark laws. This is the property of Ingersoll-Rand, and is given to the receiver in confidence. The receiver by reception and retention of the manual accepts it in confidence and agrees that, except as authorized in writing by Ingersoll-Rand, it will (1) NOT use the manual OR any copy thereof OR the confidential OR trade secret information therein; (2) NOT copy the manual OR part of it; (3) NOT disclose to others either the manual OR any copy thereof OR the confidential OR trade secret information therein; and (4) upon completion of the need to retain the manual, OR upon demand, return the manual, all copies thereof, and all material copied there from. You may not modify, copy, reproduce, republish, upload, post, transmit or distribute in any way any material from this manual including code and software. You may print material from this manual for your personal, non-commercial use only, provided you keep intact all copyright and other proprietary notices.

Disclaimer:

Limitation of Liability: Under no circumstances, including, but not limited to, negligence, shall IR, its subsidiary or affiliates be liable for any direct, indirect, incidental, special or consequential damages that result from the use of, or the inability to use, IR materials. You specifically acknowledge and agree that IR is not liable for any defamatory, offensive or illegal conduct of any user.

Parts List

General Information: This illustrated parts list identifies the various assemblies, sub-assemblies and detailed parts that make up this machine. A series of illustrations show each part clearly and in it's correct location relative to the other parts in the illustration. Each part in an illustration is referenced with a number. The number, description and quantity needed per assembly are listed in following pages. Contents of Parts List: Parts list contains following information.

ILL#: Each illustration is accompanied by the list of parts on next page. This column lists the reference number on the illustration that identifies that item. The illustration number is usually not required for ordering parts. It is required only for locating parts in the parts list. Item No.: This number identifies the part and its specification. All parts listed in this section bear Ingersoll-Rand unique item number. This number must always be specified when ordering spares or replacement parts. Description: The description column identifies items by standard name, or nomenclature, and modifiers. The modifiers are used to identify specific characteristics (I.e. dimensions, capacity, pressure, setting, etc.) and / or particular location or function on the unit. The relationship of a component or sub assembly to higher assembly is shown by indentation. Description is very important to provide while ordering parts. Qty: Quantities listed in this column reflects the number of each item used in the next higher assembly, and are not necessarily the total quantity of the part in complete model. Specify desired quantity when ordering. Remark: This column may list following abbreviations for specific item. "NA": This item is not available as a spares or replacement parts. "NSS": This item is not sold separately. Such item must be ordered as a part of next higher assembly or where applicable as parts of a kit.

Parts List24038200

COMP 5&4X7 BO NL PKG COMPLETE WITH VB

Ref Item Description Qty UM Rev Drawing ILL#

0010 24038234 COMP 5&4X7 PHE7NL BO ASSEMBLY WITH VB 1 EA A

0010 17310681 . COMP 5 & 4 X 7 PHE7 NL BARE 1 EA

0010 70408224 . . FRAME & RUNNING GEAR PHE-7 W/O CLOSURE 1 EA 00 FIG.1

0010 39643275 . . . ASSEMBLY FRAME COMPLETE 1 EA 00 FIG.1 NA

0010 39781521 . . . . FRAME PHE-7 STANDARD 1 EA N3 2

0011 95018024 . . . . O-RING 1 X 1-1/4 X 1/8 2 EA 0

0020 95593653 . . . . STUD 3/4IN X 3-1/2IN 8 EA 0 3

0030 95077822 . . . . NUT HEX 3/4 UNC ESV 8 EA 0 5

0040 39583869 . . . . GASKET FRAME PHE-7 2 EA 01 7

0050 39137245 . . . . GLASS OIL LEVEL 1 EA 01 6

0060 94432481 . . . . COVER FRAME PHE 1 EA 02 11

0070 39535216 . . . . GASKET COVER DISTANCE PIECE 1 EA 03 12

0080 95745766 . . . . STUD 3/4IN X 9-5/8 L 8 EA 0 4

0090 95077822 . . . . NUT HEX 3/4 UNC ESV 8 EA 0 5

0110 95104592 . . . . SCREW CAP HEX HEAD 3/4 X 1 4 EA 0

0120 42117838 . . . . ASSEMBLY DRAIN 5" & 7" STROKE ESV 1 EA 00 FIG.1 NA

0010 95097424 . . . . . NIPPLE PIPE 1/2IN X 4IN 1 EA 0 10

0020 97070213 . . . . . CAP PIPE SCREWED 1/2 IHE 1 EA 02 9

0160 95002143 . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 2 EA 0 8

0170 95033569 . . . . PLUG 1-1/4 NPT SQ.HEAD 1 EA 0

0020 39643283 . . . ASSEMBLY MB HOUSING COMPLETE W/O FILT 1 EA 00 FIG.1 NA

0010 42168690 . . . . HOUSING MB WITH BUSH 1 EA 32 14

0020 95101705 . . . . PLUG COUNTER SHUNK 3/8IN NPT 2 EA 0 19

0060 9 0 09 SC C 3/ 2 0 20060 95104709 . . . . SCREW CAP HEX HEAD 3/4 X 4 2 EA 0 27

0070 95018370 . . . . O-RING 14 X 14-1/2 X 1/4 1 EA 0 15

0080 94425162 . . . . ELBOW MAIN BEARING HOUSING-0.50 NPT 1 EA 02 22

0090 39314323 . . . . BREATHER ELBOW CAST AL. 1 EA 02 20

0130 30179220 . . . . ADAPTER OIL FILTER 1 EA 01 25

0140 30557888 . . . . CAP BREATHER 1 EA 01 21

0150 30557565 . . . . BUSH MBH 7ESV 1 EA 01 53

0030 42427971 . . . ASSEMBLY PIPE OIL SUC WITH NUT CONNECT 1 EA 01 NA

0010 94414612 PIPE WITH SCREEN FOR OIL SUCTION 1 EA N10010 94414612 . . . . PIPE WITH SCREEN FOR OIL SUCTION 1 EA N1

0020 97076277 . . . . NUT CONNECTOR 1 EA 01

0050 70264338 . . . ASSEMBLY OIL PUMP NL 1 EA 00 FIG.1 NA

0010 30427140 . . . . ASSEMBLY OIL PUMP ESV 1 EA 00 NA

0020 37141041 . . . . . SHAFT DRIVE OIL PUMP 1 EA 02 31

0030 37141058 . . . . . RING LOCATING - OIL PUMP 1 EA 02 32

0040 97059414 . . . . . ROTOR INNER GEAR IDLER 5 & 7 ESV 1 EA 01 81

0050 97059422 . . . . . ROTOR OUTER GEAR DRIVE 5 & 7 ESV 1 EA 01 81

0020 30253892 COVER SHAFT 1 EA 01 830020 30253892 . . . . COVER SHAFT 1 EA 01 83

0055 31165376 . . . ASSEMBLY OIL PUMP COVER 1 EA 06 NA

0010 39863683 . . . . COVER LUBRICATOR OIL PUMP WITH BUSH 1 EA 02 35

0020 95033825 . . . . PIN DOWEL -OIL PUMP-1/4DX1L 1 EA 0 16

0030 95033619 . . . . PLUG PIPE SQ.HD 1/2 NPT CS BLACK 1 EA 0 38

0040 30205280 . . . . GASKET COVER OIL PUMP 1 EA 01 36

0050 95104006 . . . . SCREW CAP HEX HEAD 7/16 X 1 5 EA 0

0060 95101705 . . . . PLUG COUNTER SHUNK 3/8IN NPT 1 EA 0 37

0070 95098653 . . . . PIN ROLL 5/16 X 1 1 EA 00 390070 95098653 . . . . PIN ROLL 5/16 X 1 1 EA 00 39

0008 30508741 . . . . SPRING VALVE RELIEF 1 E 01 23

0090 95320446 . . . . BALL RELIEF VALVE, 1/2 INCH, E52100 1 EA 0 24

0060 39642731 . . . ASSEMBLY CRANKSHAFT IHE WITH KEY 1 EA 00 FIG.2 NA

0010 39781364 . . . . CRANKSHAFT 7 INCH IHE/PHE 1 EA 04 42

0020 70408240 . . . . PIN DOWEL CRANKSHAFT 1 EA 01 43

0030 95545679 . . . . KEY CRNKSHFT 7/8INCH X 4.5INCH 1 EA N4 44

0070 37189628 . . . ASSEMBLY ROD CONN COMP 7 ESV 2 EA 00 FIG.2 NA

Parts List24038200



0005 42156448 . . . . ROD CONNECTING 7 WITH CAPBUSH &BOLT 1 EA 00 47

0010 30557540 . . . . BUSHING CRANKPIN 7ESV 1 EA 01 52

0020 30557532 . . . . BUSHING CONNECTING ROD 1 EA 01 51

0030 37605177 . . . . WIRE LOCKING ESV 1.5 FT 00

0080 37046414 . . . ASSEMBLY CROSSHEAD 7" PHE/ESV 2 EA 00 FIG.2 NA

0010 30559736 . . . . CROSSHEAD 7" STROKE 1 EA 03 55

0020 37087707 . . . . ASSEMBLY PIN CROSS HEAD 1 EA 00 NA

0010 90732538 . . . . . PIN CROSS HEAD 1 EA 03 57

0020 30206940 . . . . . PLUG CROSS HEAD PIN 1 EA 02 58

0030 95250932 . . . . . PLUG 1/4 1 EA 0 59

0030 30576136IM . . . . RING RETAINER 2 EA 00 60

0090 70315361 . . . ASSEMBLY HOUSING M.B. DRIVE END 1 EA 00 FIG.2 NA

0010 39535489 . . . . HOUSING M.B. DRIVE END IHE 1 EA 03 65A

0020 95104642 . . . . SCREW CAP HEX HEAD 3/4 X 1-3/4 16 EA 0 67

0030 39535224 . . . . GASKET BRG HSG DRIVE SIDE 1 EA 02 66

0040 30557565 . . . . BUSH MBH 7ESV 1 EA 01 53

0050 37794377 . . . . SEAL OIL CRANK SHAFT 2 EA 01 45

0100 70315379 . . . ASSEMBLY DISTANCE PIECE & GUIDE PHE 2 EA 00 FIG.2 NA

0010 39781430 . . . . DISTANCE PIECE & GUIDE 1 EA 06 61

0020 39464615 . . . . COVER DISTANCE PIECE 2 EA 03 62

0030 39535216 . . . . GASKET COVER DISTANCE PIECE 2 EA 03 63

0040 95104592 . . . . SCREW CAP HEX HEAD 3/4 X 1 8 EA 0 64

0050 95033593 . . . . PLUG PIPE SQ.HD. 1/4 NPT 1 EA 0

0110 97066765 . . . NAMEPLATE ESV AL 1 EA A

0020 42449678 . . AIREND 5IN PHE-7 1 EA 00 FIG.3

0005 39642996 . . . ASSEMBLY FR. HD. & DIST. PC. COMPL 1 EA 00 1

0010 39649264 . . . . ASSEMBLY SUB FR. HEAD & DIST. PC. 1 EA 00 NA

0005 39781513 . . . . . HEAD FRAME & DISTANCE PIECE 5X7 NL PHE 1 EA 05 2

0006 23636491 . . . . . KIT DISTANCE PIECE VENT AND DRAIN 1 EA -

0010 95243077 . . . . . . NIPPLE 1" X 3" XLE 2 EA 0

0020 95648275 . . . . . . ELBOW 90 DEG 1 NPT X 3000# SA105 2 EA 0

0040 95038055 BUSHING REDUCER 1 X 1/2 1 EA 00040 95038055 . . . . . . BUSHING REDUCER 1 X 1/2 1 EA 0

0050 39105739IM . . . . . . VALVE BALL 0.5" M-F 1 EA 00

0060 95002143 . . . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 1 EA 0

0070 23639339 . . . . . . DECAL CAUTION D/P RETROFIT KIT 1 EA 0

0080 23639347 . . . . . . DECAL WARNING D/P RETROFIT KIT 1 EA 0

0090 23639354 . . . . . . DECAL WARNING D/P COVER,RETROFIT KIT 1 EA 0

0011 95737417 . . . . . STUD 3/4 X 3-1/4 8 EA 0 3

0012 95077822 . . . . . NUT HEX 3/4 UNC ESV 8 EA 0 4

0016 95593695 STUD 3/4IN X 4 1/2IN 4 EA 0 50016 95593695 . . . . . STUD 3/4IN X 4-1/2IN 4 EA 0 5

0017 95077822 . . . . . NUT HEX 3/4 UNC ESV 4 EA 0

0027 95038188 . . . . . REDUCER 1-1/2IN X 1/2IN STEEL 2 EA 0

0035 95033619 . . . . . PLUG PIPE SQ.HD 1/2 NPT CS BLACK 4 EA 0

0040 95002143 . . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 8 EA 0

0018 39550082 . . . . GASKET OUTER HEAD PHE 1 EA 02 7

0020 37133394 . . . . COVER DISTANCE PIECE PROC 2 EA 03 8

0025 37068293 . . . . GASKET COVER CORK 2 EA 01 9

0030 95104147 SCREW CAP HEX 1/2INX 1IN 24 EA 0 100030 95104147 . . . . SCREW CAP HEX 1/2INX 1IN 24 EA 0 10

0031 37771870 . . . . ADAPTER PROC 3 EA 01

0035 37133402 . . . . PLATE PARTITION 1 EA 01 11

0040 37123171 . . . . GASKET PLATE PARTITION 1 EA N2 12

0046 95103792 . . . . SCREW CAP HEX HEAD 3/8 X 1.5 " LG GRADE 5 4 EA 0 13

0005 30477632 . . . . GLAND 7 STK ESH OIL SCRAPR 1 E 03 14

0055 54491378 . . . . RING SCRAPPER 1.5 INCH ROD 2 EA 01 15


Parts List24038200



0065 95104188 . . . . SCREW CAP HEX HEAD 1/2 X 1-3/4 LG , GR = 5 2 EA 0 17

0010 70411491 . . . PACKING CASE 1-1/2 DIA ROD 1 EA 00 20

0010 42431791 . . . . PACKING CASE WATER COOLED 4 CUPS 1 EA 02 21

0020 30586127 . . . . GASKET PACKING CASE 1 EA 01 24

0040 39321245IM . . . . RING PACKING SET PHE-7 NL 4 EA 01 23

0050 95002143 . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 1 EA 0

0060 95002085 . . . . REDUCER BUSHING 3/4" X 1/4" NPT 1 EA 0

0015 39643010 . . . ASSEMBLY CYLINDER 5" PHE /ESV 1 EA 00 FIG.3

0010 39649272 . . . . ASSEMBLY SUB CYLINDER 5" PHE-7 1 EA 00 NA

0035 39479068 . . . . . COVER WATER W/HTR CONN 5 X 7 PHE 2 EA 01

0010 39463476 . . . . . . COVER WATER 5" CYLINDER 1 EA 03

0005 39781505 . . . . . CYLINDER 5X7 PHE NL 1 EA 08 26

0010 95811691 . . . . . STUD 7/8IN X 5-1/4IN 6 EA 0 27

0011 95866976 . . . . . STUD 7/8IN X 8IN 6 EA 0 28

0020 95210480 . . . . . NUT HEX 7/8IN 6 EA 0 30

0022 95210480 . . . . . NUT HEX 7/8IN 6 EA 0 28

0026 95684205 . . . . . STUD 3/4 X 3-3/4 16 EA N1 29

0030 95077822 . . . . . NUT HEX 3/4 UNC ESV 16 EA 0 32

0040 39535547 . . . . . GASKET WATER COVER PHE 2 EA 03 34

0045 95104147 . . . . . SCREW CAP HEX 1/2INX 1IN 16 EA 0 35


0057 95250932 . . . . . PLUG 1/4 3 EA 0

0015 37133584 . . . . COVER VALVE PROC 2 EA 03 36

0017 95250932 . . . . PLUG 1/4 4 EA 0

0020 30550842 . . . . GASKET VLV COVER CU SHROUDED 2 EA 00 37

0030 95077749 . . . . NUT HEX 1IN 2 EA 0


0045 30572945 . . . . SCREW SET DISCH 2 EA 00 41

0050 95077749 . . . . NUT HEX 1IN 2 EA 0 42

0055 37759438 . . . . GASKET NUT (1/8 LEAD WIRE) 1 FT 01 43

0060 37077252 . . . . HOLDER VALVE 1 EA 02

0031 39556527 PISTON 5X7 PHE 7 NL 2STG DSGN 1 EA 03 460031 39556527 . . . PISTON 5X7 PHE-7 NL-2STG DSGN 1 EA 03 46

0036 39322334IM . . . RING PISTON 5 X 7 ESV / PHE 5 EA 02 47

0041 39322318IM . . . RING WEARING 5X7 2 EA 00 48

0045 39570973 . . . ROD PISTON LIQUID NITRIDED 5X7 PHE 1 EA 05 49

0050 34578799 . . . NUT PISTON 1 EA 02 50

0055 30565675 . . . NUT JAM 7 INCH STROKE 1 EA 01 51

0060 30589568 . . . WASHER LOCK STAR 7 STK 1 EA 02 52

0065 37802279 . . . ASSEMBLY OIL STOP PLATE EXPORT 1 EA 01 FIG.3 53

0010 30253025 PLATE OIL STOP 1 EA 02 540010 30253025 . . . . PLATE OIL STOP 1 EA 02 54

0030 95235131 . . . . CLAMP 1 EA 0 55

0071 94443553 . . . HEAD OUTER 5X7 IHE 1 EA 04 56

0080 39550082 . . . GASKET OUTER HEAD PHE 1 EA 02 57

0098 97073118 . . . FOOTPIECE IHE 1 EA 01 18

0099 95104436 . . . SCREW CAP HEX HEAD 5/8 X 1-1/2 2 EA 0 19

0110 31174667 . . . CRAB VALVE A36 2 EA 03 44


0122 94471570 GASKET CLOSER FLANGE PHE-7 1 EA 010122 94471570 . . . GASKET CLOSER FLANGE PHE-7 1 EA 01

0123 97100754 . . . FLANGE CLOSURE 3IN X 300# 2 EA 02

0124 94452620 . . . GASKET CLOSER FLANGE PHE 2 EA 01

0125 95104592 . . . SCREW CAP HEX HEAD 3/4 X 1 8 EA 0

0130 54365648 . . . GASKET VALVE SEAT A36 4 EA 03

0140 95081873 . . . WASHER LOCK 1/4 4 EA 0

0150 95111142 . . . SCREW M/C 1/4IN X 1-1/8IN SS FI.HD 4 EA 0

0030 70452933 . . AIREND 4 X 7 PHE W/O CLOSURES 1 EA 00 FIG.6

Parts List24038200



0010 70414115 . . . ASSEMBLY FRHD & DIST PC 4X7 PHE 1 EA 00 NA

0001 30477632 . . . . GLAND 7 STK ESH OIL SCRAPR 1 E 03 14

0020 37068293 . . . . GASKET COVER CORK 2 EA 01 9

0030 37123171 . . . . GASKET PLATE PARTITION 1 EA N2 12

0040 37133394 . . . . COVER DISTANCE PIECE PROC 2 EA 03 8

0050 37133402 . . . . PLATE PARTITION 1 EA 01 11

0055 37771870 . . . . ADAPTER PROC 3 EA 01

0060 39486204 . . . . GASKET FR/OUTER HEAD PHE 1 EA 01 7

0070 42414292 . . . . ASSEMBLY FR HD & DIST PC(STD) 4X7 PHE 1 EA 00 FIG.6 NA

0010 39873690 . . . . . HEAD FRAME & DIST PC 4X7 PHE/ESV 1 EA 08 2

0011 23636491 . . . . . KIT DISTANCE PIECE VENT AND DRAIN 1 EA -

0010 95243077 . . . . . . NIPPLE 1" X 3" XLE 2 EA 0

0020 95648275 . . . . . . ELBOW 90 DEG 1 NPT X 3000# SA105 2 EA 0

0040 95038055 . . . . . . BUSHING REDUCER 1 X 1/2 1 EA 0

0050 39105739IM . . . . . . VALVE BALL 0.5" M-F 1 EA 00

0060 95002143 . . . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 1 EA 0

0070 23639339 . . . . . . DECAL CAUTION D/P RETROFIT KIT 1 EA 0

0080 23639347 . . . . . . DECAL WARNING D/P RETROFIT KIT 1 EA 0

0090 23639354 . . . . . . DECAL WARNING D/P COVER,RETROFIT KIT 1 EA 0

0020 95002143 . . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 8 EA 0


0050 95077822 . . . . . NUT HEX 3/4 UNC ESV 8 EA 0 4

0060 95077822 . . . . . NUT HEX 3/4 UNC ESV 4 EA 0 6

0075 95038188 . . . . . REDUCER 1-1/2IN X 1/2IN STEEL 2 EA 0

0080 95737417 . . . . . STUD 3/4 X 3-1/4 8 EA 0 3

0090 95903332 . . . . . STUD 3/4IN X 6IN 4 EA 0 5

0100 39486204 . . . . . GASKET FR/OUTER HEAD PHE 1 EA 01 7



0100 95103792 . . . . SCREW CAP HEX HEAD 3/8 X 1.5 " LG GRADE 5 4 EA 0 13

0110 95104147 . . . . SCREW CAP HEX 1/2INX 1IN 24 EA 0 10

0120 95104188 SCREW CAP HEX HEAD 1/2 X 1 3/4 LG GR 5 2 EA 0 170120 95104188 . . . . SCREW CAP HEX HEAD 1/2 X 1-3/4 LG , GR = 5 2 EA 0 17

0020 42428037 . . . ASSEMBLY PACKING CASE & RINGS (CPI) 4X7 PHE NL 1 EA 00

0010 42437442 . . . . ASSEMBLY CASE PACKING-6 CUP 4X7 PHE 1 EA 02 21

0010 70332242 . . . . . FLANGE PACKING CASE,1.5 PISTON ROD 1 EA N5

0020 70332168 . . . . . CUP PACKING (CUP-4) 1 EA 01

0030 70436373 . . . . . ASSEMBLY CUP PACKING (CUP-2) 1 EA N1

0010 70332176 . . . . . . CUP -2 OR 3 FOR PACKING CASE 1 EA 01

0020 70332184 . . . . . . RING FOR CUP - 3 1 EA 01

0030 95022802 O RING 1/4 X 3/8 X 1/16 2 EA 00030 95022802 . . . . . . O-RING 1/4 X 3/8 X 1/16 2 EA 0

0040 95024139 . . . . . . O-RING 2-1/2 X 2-5/8 X 42370 2 EA 0

0040 70436381 . . . . . ASSEMBLY CUP PACKING (CUP-3) 1 EA N1 NSS

0010 70332176 . . . . . . CUP -2 OR 3 FOR PACKING CASE 1 EA 01 NSS

0020 70332200 . . . . . . RING FOR CUP - 2 1 EA 01 NSS

0030 95022802 . . . . . . O-RING 1/4 X 3/8 X 1/16 2 EA 0

0040 95024139 . . . . . . O-RING 2-1/2 X 2-5/8 X 42370 2 EA 0

0045 70412317 . . . . . CUP PACKING ( CUP-5 ) 2 EA 01 NSS

0050 70332218 CUP PACKING (CUP-1) 1 EA 01 NSS0050 70332218 . . . . . CUP PACKING (CUP-1) 1 EA 01 NSS

0060 95022802 . . . . . O-RING 1/4 X 3/8 X 1/16 10 EA 0

0070 95736302 . . . . . STUD 1/4 X 8-1/2 PROC 2 EA N1

0080 95077681 . . . . . NUT HEX 1/4 UNC -16A4C1 2 EA 0

0085 95081873 . . . . . WASHER LOCK 1/4 2 EA 0

0020 30586127 . . . . GASKET PACKING CASE 1 EA 01 24

0030 39321245IM . . . . RING PACKING SET PHE-7 NL 5 EA 01 23

0040 39321450IM . . . . RING PRESSURE BREAKER PHE-7 CPI 1 EA 02 23A

S

Parts List24038200



0050 95002143 . . . . PLUG PIPE SQ.HD.3/4"NPT CS BLACK 1 EA 0

0060 95002085 . . . . REDUCER BUSHING 3/4" X 1/4" NPT 1 EA 0

0030 42414300 . . . ASSEMBLY CYLINDER 4X7 PHE FOR PF28 VLVS 1 EA 00 FIG.6

0030 37575198 . . . . COVER VALVE BILLET CYL,1.375 SET SC 4 EA 03 36


0004 42414318 . . . . ASSEMBLY CYLINDER S/A 4X7 PHE PF28 VLV 1 E 00 FIG.6 NA

0010 39304340 . . . . . PLUG LUB HOLE 4X7 PHE 2 EA 02

0015 37759438 . . . . . GASKET NUT (1/8 LEAD WIRE) 2.3 FT 01

0020 39568787 . . . . . GASKET COVER WATER 2 EA 02 34

0040 39839436 . . . . . COVER CYLINDER 4X7PHE/ESV B 2 EA 07 33

0050 39873377 . . . . . CYLINDER 4 LUB,NL ESV/PHE 1 EA 05 25

0050 95567558 . . . . . WASHER 5/8" X 0.062" COPPER 46 EA 0

0060 95033593 . . . . . PLUG PIPE SQ.HD. 1/4 NPT 2 EA 0


0080 95077814 . . . . . NUT HEX 5/8 UNC 4 EA 0

0090 95104436 . . . . . SCREW CAP HEX HEAD 5/8 X 1-1/2 42 EA 0

0095 95567558 . . . . . WASHER 5/8" X 0.062" COPPER 42 EA 0

0100 95210480 . . . . . NUT HEX 7/8IN 6 EA 0 30

0110 95210480 . . . . . NUT HEX 7/8IN 6 EA 0 30

0120 95210480 . . . . . NUT HEX 7/8IN 24 EA 0 30

0130 95594081 . . . . . STUD 7/8IN X 4-5/8IN 24 EA 0

0140 95684650 . . . . . STUD 5/8IN X 2-7/8IN 4 EA 0

0150 95811691 . . . . . STUD 7/8IN X 5-1/4IN 6 EA 0

0160 95866976 . . . . . STUD 7/8IN X 8IN 6 EA 0

0165 31253834 . . . . . HOLDER VALVE 4-3/4 A28 1 EA 02

0170 31375496 . . . . . NUT SET SCRW 1-3/8IN 2 EA 00 43A

0175 30351068 . . . . . GASKET SET SCREW 1-3/8"IDX2-1/8"OD 2 EA 00

0180 34140293 . . . . . SCREW SET 2 EA 00 41

0190 37038064 . . . . . GASKET VALVE COVER 2 EA 00

0040 70453097 . . . ASSEMBLY PISTON & RINGS 4X7 PHE NL 1 EA 00 FIG.6

0010 39550264 . . . . PISTON 4X7 PHE-7 NL-2STG 1 EA 04 50

0020 54577416IM RING PISTON 4X7 6 EA 01 510020 54577416IM . . . . RING PISTON 4X7 6 EA 01 51

0030 54577440IM . . . . RING WEARING 4X7 2 EA 01 52

0050 37802279 . . . ASSEMBLY OIL STOP PLATE EXPORT 1 EA 01 FIG.6 NA

0010 30253025 . . . . PLATE OIL STOP 1 EA 02 58

0030 95235131 . . . . CLAMP 1 EA 0 59

0060 70452958 . . . ASSEMBLY PISTON ROD 4 X 7 PHE-7 1 EA 00 NA

0010 39570957 . . . . ROD PISTON LIQ.NITRIDED 4X7 PHE NL 1 EA 05 53

0020 30565675 . . . . NUT JAM 7 INCH STROKE 1 EA 01 55

0030 30589568 WASHER LOCK STAR 7 STK 1 EA 02 560030 30589568 . . . . WASHER LOCK STAR 7 STK 1 EA 02 56

0040 34578799 . . . . NUT PISTON 1 EA 02 54

0070 70452941 . . . ASSEMBLY OUTER HEAD 4 X 7 PHE-7 1 EA 00 NA

0010 39486204 . . . . GASKET FR/OUTER HEAD PHE 1 EA 01 61

0020 39317953 . . . . HEAD OUTER ESV/PHE 4X7 W/COOLED 1 EA 03 60

0080 97073118 . . . FOOTPIECE IHE 1 EA 01 18

0090 95104436 . . . SCREW CAP HEX HEAD 5/8 X 1-1/2 2 EA 0 19


0110 30533566 CRAB VALVE IS 210 GR 20 CI 2 EA 02 480110 30533566 . . . CRAB VALVE IS 210 GR 20 CI 2 EA 02 48

0120 54370663 . . . GASKET VALVE SEAT A28 4 EA 02 44A

0130 95096178 . . . WASHER LOCKAISI 300 SERIES 2 EA 0

0140 95111258 . . . SCREW SS M/C NO.10X1 2 EA 0

0040 39486204 . . GASKET FR/OUTER HEAD PHE -1 EA 01

0020 95104683 . SCREW CAP HEX HEAD 3/4 X 3-1/2 4 EA 0

0030 30608673 . WASHER 3/4IN 4 EA 2

0040 95104469 . SCREW CAP HEX HEAD 5/8 X 3 4 EA 0

Saturday, April 21, 2012 (10:05:40 AM) Page 5 of 13

Parts List24038200



0050 30472161 . FILTER OIL 1 EA 01

0060 70447149 . ASSEMBLY OIL DRAIN DISTANCE PC PHE 2 EA 00

0010 97084396 . . VALVE ISOLATION 1/2" SS BODY 1 EA R6

0020 95038055 . . BUSHING REDUCER 1 X 1/2 1 EA 0

0030 95273330 . . NIPPLE PIPE 1/2NPTx1.5 1 EA 0

0070 39590468 . VALVE INLET W/UNL W/ACTUATOR 2 EA 03 FIG.4

0010 37982873 . . VALVE SUCTION W/UNLOADER 1 EA 00

0010 37982907 . . . VALVE SUCTION 1 EA 00

0010 37980414 . . . . SEAT SUCTION 1 EA 00 1

0002 37980422 . . . . ASSEMBLY SUCTION GUARD 1 E 00 2

0010 37980430 . . . . . GUARD SUCTION 1 EA 00 3

0020 37980448 . . . . . BOLT CENTER 1 EA 00 4

0030 34032805 . . . . . PIN LOCATING 1 EA 00 5

0040 34032813 . . . . . PIN LOCATING 1 EA 00 6

0050 33019225 . . . . . BOLT LOCK 1 EA 00

0030 37944550 . . . . PLATE VALVE 1 EA 00 8

0040 37944568 . . . . WASHER LIFT 1 EA 00 9

0050 37944568 . . . . WASHER LIFT 1 EA 00 10

0060 34004960 . . . . PLATE DAMPING 2 EA 00 11

0070 33426883 . . . . SPRING CLOSING 4 EA 00 12

0080 33013889 . . . . NUT LOCK 1 EA 00 13

0020 37980406 . . . ASSEMBLY UNLOADER 1 EA 00 NA

0010 37980455 . . . . UNLOADER 1 EA 00 20

0020 37949997 . . . . COVER UNLOADER 1 EA 00 21

0030 37949963 . . . . WIRE LOCKING 1 EA 00 22

0040 34034033 . . . . SPRING UNLOADER 1 EA 00 23

0050 37949989 . . . . RING STOP 1 EA 00 24

0060 37949971 . . . . PIN UNLOADER 1 EA 00 25

0070 37950003 . . . . BUSHING GUIDE 1 EA 00 26

0020 37981917 . . COVER 1 EA 00 30

0030 37982899 . . CAGE 1 EA 00 31

0040 37981933 RING CRUSH 1 EA 02 320040 37981933 . . RING CRUSH 1 EA 02 32

0050 37984820 . . PLUG DRAIN 1 EA 00 33

0060 37982881 . . ACTUATOR MULTI STACK 1 EA 00 NA

0010 37982915 . . . PISTON ACTUATOR 1 EA 00 NA

0010 37982147 . . . . HOUSING 1 EA 00 45

0020 37982923 . . . . ASSEMBLY PISTON 1 EA 00 46

0030 37980554 . . . . SPRING 1 EA 00 47

0040 37982105 . . . . SEAL 2 EA 00 48

0050 37982139 O RING 1 EA 00 490050 37982139 . . . . O-RING 1 EA 00 49

0060 37980588 . . . . SEAL 1 EA 00 50

0070 37980596 . . . . WASHER 1 EA 00 51

0080 37980604 . . . . RING RETAINING 1 EA 00 52

0090 37980612 . . . . GASKET 1 EA 00 53

0100 37980620 . . . . FILTER BREATHER 1 EA 00 54

0020 37982048 . . . ASSEMBLY STACK 1 EA 00 NA

0010 37982089 . . . . HOUSING 1 EA 00 60

0020 37982097 PISTON 1 EA 00 610020 37982097 . . . . PISTON 1 EA 00 61

0030 37982105 . . . . SEAL 1 EA 00 62

0040 37982113 . . . . SPRING 1 EA 00 63

0050 37982121 . . . . O-RING 1 EA 00 64

0060 37982139 . . . . O-RING 1 EA 00 65


0030 37982535 . . . SCREW CAP HEX 4 EA 00 70

0040 37980497 . . . WASHER SERRATED 4 EA 00 71

Parts List24038200



0050 37982543 . . . SCREW CAP SOCKET HEAD 2 EA 00 72

0060 37982071 . . . COVER 1 EA 00 73

0080 39329313 . VALVE DISCHARGE 2 EA 01 FIG.5

0010 37982188 . . ASSEMBLY DISCHARGE SEAT 1 EA 00 NA

0010 37982196 . . . SEAT DISCHARGE 1 EA 00 2

0020 37982204 . . . BOLT CENTER 1 EA 00 3

0030 33019225 . . . BOLT LOCK 1 EA 00

0020 37982949 . . ASSEMBLY DISCHARGE GUARD 1 EA 00

0010 37982956 . . . GUARD DISCHARGE 1 EA 00 6

0020 34032805 . . . PIN LOCATING 1 EA 00 7

0030 34032813 . . . PIN LOCATING 1 EA 00 8

0030 37944550 . . PLATE VALVE 1 EA 00 9

0040 37945375 . . WASHER LIFT 1 EA 00 10

0005 37945375 . . WASHER LIFT 1 E 00 11

0060 34004960 . . PLATE DAMPING 2 EA 00 12

0070 33426917 . . SPRING CLOSING 4 EA 00 13

0080 33013889 . . NUT LOCK 1 EA 00 14

0090 39590807 . VALVE INLET WITH U/L 2 EA 03 FIG.7

0010 37983210 . . VALVE INLET W/UNLOADER 1 EA 00 NA

0010 37983228 . . . VALVE INLET 1 EA 00

0010 37982394 . . . . ASSEMBLY SUCTION SEAT 1 EA 00 NA

0010 37982402 . . . . . SEAT SUCTION 1 EA 00 2

0020 37982410 . . . . . PIN LOCATING 1 EA 00 3

0030 37982428 . . . . . PIN LOCATING 1 EA 00 4

0020 37983236 . . . . ASSEMBLY SUCTION GUARD 1 EA 00 NA

0010 37983244 . . . . . GUARD SUCTION 1 EA 00 6

0020 37982451 . . . . . BOLT CENTER 1 EA 00 7

0030 34039453 . . . . . BOLT LOCK 1 EA 00

0030 37982279 . . . . PLATE VALVE 1 EA 00 9

0040 37982287 . . . . PLATE SPRING 1 EA 00 10

0050 37982295 . . . . WASHER LIFT 1 EA 00 11

0060 33982141 NUT LOCK 1 EA 00 120060 33982141 . . . . NUT LOCK 1 EA 00 12

0020 37985983 . . . ASSEMBLY UNLOADER 1 EA 00 NA

0010 37986205 . . . . UNLOADER 1 EA 00 20

0020 37982485 . . . . COVER UNLOADER 1 EA 00 21

0030 37949963 . . . . WIRE LOCKING 1 EA 00 22

0040 37284601 . . . . SPRING 1 EA 00 23

0050 37982493 . . . . RING STOP 1 EA 00 24

0060 37949971 . . . . PIN UNLOADER 1 EA 00 25

0070 37982501 BUSHING GUIDE 1 EA 00 260070 37982501 . . . . BUSHING GUIDE 1 EA 00 26

0020 37980349 . . COVER 1 EA 00 30

0030 37982329 . . PLATE 1 EA 00 31

0040 37982337 . . CAGE 1 EA 00 32

0050 37980372 . . SCREW CAP SOCKET HEAD 4 EA 00 33

0060 37980380 . . RING CRUSH 1 EA 02 34

0070 37211919 . . PIN LOCATING 2 EA 00 35

0080 37984820 . . PLUG DRAIN 1 EA 00 36

0090 37982311 ACTUATOR MULTI STACK 1 EA 00 NA0090 37982311 . . ACTUATOR MULTI STACK 1 EA 00 NA

0010 37982519 . . . PISTON ACTUATOR 1 EA 00 NA

0010 37980513 . . . . HOUSING 1 EA 00 45

0020 37982576 . . . . ASSEMBLY PISTON 1 EA 00 46

0030 37980554 . . . . SPRING 1 EA 00 47

0040 37980562 . . . . SEAL 2 EA 00 48

0050 37980570 . . . . O-RING 1 EA 00 49

0060 37980588 . . . . SEAL 1 EA 00 50

Parts List24038200



0070 37980596 . . . . WASHER 1 EA 00 51

0080 37980604 . . . . RING RETAINING 1 EA 00 52

0090 37980612 . . . . GASKET 1 EA 00 53


0020 37982527 . . . ASSEMBLY STACK 1 EA 00 NA

0010 37982550 . . . . HOUSING 1 EA 00 60

0020 37982568 . . . . PISTON 1 EA 00 61

0030 37980562 . . . . SEAL 1 EA 00 62

0040 37982113 . . . . SPRING 1 EA 00 63

0050 37982121 . . . . O-RING 1 EA 00 64

0060 37980570 . . . . O-RING 1 EA 00 65


0030 37982535 . . . SCREW CAP HEX 4 EA 00 70

0040 37980497 . . . WASHER SERRATED 4 EA 00 71

0050 37982543 . . . SCREW CAP SOCKET HEAD 2 EA 00 72

0060 37980505 . . . COVER 1 EA 00 73

0100 39590690 . VALVE DISCHARGE 2 EA 02 FIG.8

0001 37982238 . . ASSEMBLY DISCHARGE SEAT 1 E 00 NA

0010 37982246 . . . SEAT DISCHARGE 1 EA 00 2

0020 39199765 . . . BOLT CENTER 1 EA 00 3

0030 49962079 . . . PIN LOCATING 1 EA 00 4

0040 34032813 . . . PIN LOCATING 1 EA 00 5

0050 34039453 . . . BOLT LOCK 1 EA 00

0020 37982261 . . GUARD DISCHARGE 1 EA 00 7

0030 37982279 . . PLATE VALVE 1 EA 00 8

0040 37982287 . . PLATE SPRING 5 EA 00 9

0050 37982295 . . WASHER LIFT 1 EA 00 10

0060 33982141 . . NUT LOCK 1 EA 00 11

0110 17343724 . SUBBASE 5&4X7 PHE7 PKG W/O OBB 1 EA 01

0130 39492400 . SHIM SET PHE FOOT PIECE 6 ST 01

0140 24055386 . ASSEMBLY MOTOR + DRIVE SYSTEM FOR 125HP MOTOR 1 EA A

0010 24054058 MOTOR ELECTRIC 125HP 380V 50HZ 3PH SF 1 4 POL 1 EA A0010 24054058 . . MOTOR ELECTRIC 125HP 380V 50HZ 3PH SF-1 4 POL 1 EA A

0020 39902226 . . SHEAVE COMPRESSOR - 40.0 OD, 6 GROOVES, CI 1 EA 01

0030 17313206 . . SLIDE RAIL 36" WITH 0.875" BOLT 1 EA 00

0040 39169933 . . BELT 5VX 170" LONG COGGED CONSTRUCTION 4 EA 01

0045 17349200 . . GUARD BELT FOR 5&4X7 PHE7 NL W/O OBB 1 EA 01

0050 17310525 . . PULLEY MOTOR 15.40" OD 5V SEC,5 GROOVES,CI 1 EA 00

0060 17312133 . . BUSH FLANGED F TYPE, 75MM BORE,CI 1 EA 00

0070 95104493 . . SCREW CAP HEX HEAD 5/8 X 3-3/4 3 EA 0

0080 95081790 WASHER SPRING 5/8 3 EA 00080 95081790 . . WASHER SPRING 5/8 3 EA 0

0090 95035473 . . BOLT HEX HEAD 7/8IN X 2-1/2IN 16 EA 0

0150 24054116 . CONTROL PANEL INTELLISYS 125HP 380V SD 1 EA A

0010 39259254IM . . CONTROLLER WITH 39875158 & 39259098 1 EA 05

0020 68188473 . . SUPPRESSOR TVSS 1 EA 00

0030 70446042 . . CARD POWER SUPPLY 110V AC / 12V DC 1 EA 01

0160 70447198 . ASSEMBLY REGULATION 2 STEP PHE 1 EA 00

0010 39322649IM . . REGULATOR PRESSURE 0-3000PSI MITY MITE 1 EA 02

0020 39322763IM GAUGE PRESSURE 0/140PSIG & 0/10 KG/CM2 1 EA 010020 39322763IM . . GAUGE PRESSURE 0/140PSIG & 0/10 KG/CM2 1 EA 01

0030 39331368IM . . VALVE SAFETY 90PSIG 0.5IN MNPT 221SCFM 1 EA 01

0040 39229463IM . . FILTER CONTROL AIR LINE RECIP RGLTR 1 EA 03

0050 40049942IM . . VALVE SOLENOID 3 WAY .38IN NPT 1 EA 04

0060 40079089 . . BRACKET SOLENOID VALVE MOUNTING 2 EA 00

0070 70234323 . . TUBE 1/2" OD X 0.035"THK SS304 WELDED 40 FT 01

0080 70435631 . . UNION 1/2T X 1/2T 6 EA 00

0090 70435615 . . CONNECTOR MALE 1/2T X 1/2 NPT 10 EA 00

Parts List24038200



0105 95254710 . . UNION 3/8IN TUBE 10 EA 0

0110 95409819 . . NIPPLE PIPE 1/2X3"NPT XS SS304 1 EA 0

0120 95451217 . . COUPLING FULL 1/2IN NPTX3000# SS304 2 EA 0

0140 95254330 . . CONNECTOR MALE 3/8 TUBE X 1/4 NPT 10 EA 0

0150 95273637 . . CONNECTOR 1/2NPTX3/8TUBE 10 EA 0

0160 95299046 . . CONNECTOR MALE 1/8NPT X 3/8TUBE 6 EA 0

0170 95254652 . . TEE UNION 3/8IN TX 3/8IN TX 3/8IN T 7 EA 0

0180 95254405 . . ELBOW 3/8 TUBE OD X 1/4 NPT MALE 8 EA 0

0190 70218912 . . TEE 1/4 NPT X 2000# SS 304 2 EA 00

0200 95243606 . . NIPPLE 1/4IN X 2IN BOTH NPT 6 EA 0

0210 95659207 . . COUPLING 1/8 NPT X 3000 SS 304 5 EA 0

0220 95277067 . . TEE UNION 1/2IN TUBE 1 EA 0

0230 95278503 . . CONNECTOR MALE 1/2IN T X 1/2IN NPT SS316 10 EA 0

0240 94468212 . . TUBE SS SEAMLESS 3/8X.035 60 FT 00

0250 70409628 . . CLIP TUBE FOR 3 TUBES 3/8 15 EA R1

0170 70454970 . SET OF INSTRUMENTS PHE 2 STG BOOSTER,1000 PSIG 1 EA 00

0010 39875539 . . TRANSDUCER PRESS 0-225# 5VDC SG 4 EA 3

0020 54364104IM . . TRANSDUCER PRESSURE HIGH 0-500 PSI 1 EA 00

0030 54364096IM . . TRANSDUCER PRESSURE HIGH 0-1000 PSI 1 EA 03

0040 39875570 . . CABLE SG TRANSDUCER 6 EA 2

0045 95299046 . . CONNECTOR MALE 1/8NPT X 3/8TUBE 6 EA 0

0005 95659207 . . COUPLING 1/8 NPT X 3000 SS 304 6 E 0

0060 39571310IM . . SENSOR RD-34.5 FT ONE PIECE CABLE 6 EA 02

0070 39198494IM . . SWITCH TEMPERATURE 50-650F-N 1/4/13 W/WELL 2 EA 01


0180 24042251 . ASSEMBLY AIR PIPING COOLERS+SEP+DAMP 1 EA A

0010 24042269 . . ASSEMBLY AIR PIPING 1ST STG INLET, VB TO CYL 1 EA A

0010 70477260IM . . . DAMPENER PULSATION INLET 66"HEIGHT,2%P-P 1 EA 00

0020 17299348 . . . GAUGE PRESS 0-16KG/CM^2G 4" BACK ENTRY 1 EA 00

0050 17349671 . . . PIPE AIR SUC VOL BOTT TO CYLINDER,3"X300# 1 EA 00

0010 70231139 . . . . PIPE 3IN SCH-40 SEAMLESS SA106 GR-B 1 FT 00

0020 95261079 FLANGE 3IN X 300# SORF SERR A105 2 EA 00020 95261079 . . . . FLANGE 3IN X 300# SORF SERR. A105 2 EA 0

0030 95491643 . . . . ELBOW 3"BW 90DEG LR SCH-40,A234WPB 1 EA 0

0060 94475506 . . . GASKET FLANGE 3IN X 300# 1/16IN THK 3 EA 00

0070 95104683 . . . SCREW CAP HEX HEAD 3/4 X 3-1/2 8 EA 0

0080 95077822 . . . NUT HEX 3/4 UNC ESV 8 EA 0

0090 95035457 . . . BOLT HEX HEAD 3/4IN X 2-1/4IN 8 EA 0

0100 95053054 . . . SCREW CAP HEX HEAD 1/2 X 3 LG- GRADE = 5 4 EA 0

0105 95077798 . . . NUT HEX 1/2 UNC 4 EA 0

0020 39317417IM VALVE SAFETY 160 PSIG 1 NPT 864 SCFM 1 EA0020 39317417IM . . VALVE SAFETY 160 PSIG,1 NPT,864 SCFM 1 EA

0021 95678991 . . ELBOW 2"NPT 90DEGX3000# SA105 1 EA 0

0022 95049219 . . NIPPLE 2" X 3" 1 EA 0

0023 95038238 . . REDUCER BUSHING 2" X 1" 1 EA 0

0030 24042277 . . ASSEMBLY AIR PIPING 1ST STG DISC 5&4X7 PHE7 1 EA A

0010 94475506 . . . GASKET FLANGE 3IN X 300# 1/16IN THK 3 EA 00


0020 95077822 . . . NUT HEX 3/4 UNC ESV 24 EA 0

0030 24073827 PIPE AIR CYL TO IC-1 CS 3"X300# TO 4"X300# 5&4X7 1 EA A0030 24073827 . . . PIPE AIR CYL TO IC-1,CS 3"X300# TO 4"X300#,5&4X7 1 EA A

0010 95261079 . . . . FLANGE 3IN X 300# SORF SERR. A105 1 EA 0



0040 95446530 . . . . COUPLING HALF 1/2IN NPT-3000# SA105 1 EA 0

0045 95446548 . . . . COUPLING HALF 3/4IN NPT CS 1 EA 0

0050 95277299 . . . . FLANGE 4 X 300# SORF SERR SA105 1 EA 0

0060 95247268 . . . . ELBOW 4"X90 LR SCH40 BW ASTM A234,WPB,CS 1 EA 0

Parts List24038200



0070 95525093 . . . . REDUCER CONCENTRIC 4 X 3 BW SCH-40,A234 1 EA 0

0080 70228978 . . . . PIPE 4" NB SCH 40 A106GRB,SEAMLESS 4 FT 00

0050 17298506IM . . . INTERCOOLER 300 PSI,59"L ASME,U-STAMP 1 EA 00

0130 40054496IM . . . SEPARATOR 3"WRIGHT AUSTIN MODEL:31L 1 EA 00

0140 17276718 . . . PIPE AIR REDUCER 4X3-300# 1 EA 01

0010 95392155 . . . . FLANGE 4X300# SORF SS 304 ASTM182 1 EA 0

0020 70414834 . . . . PIPE 3 INCH SCH 40 SS304 SEAMLESS 1 FT 00

0030 70387261 . . . . PIPE 4NB SCH-40, SS304 1 FT 00

0035 70462874 . . . . REDUCER 4X3 SS304 ASTMA403 BW SCH40 1 EA 00

0040 95465878 . . . . COUPLING 1 NPT X 3000 SS 304 1 EA 0

0050 70405253 . . . . FLANGE 3X300 SORF SS304 1 EA 00

0160 70473889IM . . . VALVE SAFETY 3/4"NPT SET 290 PSIG,963 SCFM,ASME 1 EA 00

0170 24073835 . . . PIPE AIR M/S TO CYL, CS 3"X300# TO 3'X600#,5&4X7 1 EA A


0020 95261079 . . . . FLANGE 3IN X 300# SORF SERR. A105 1 EA 0


0040 95041265 . . . . FLANGE 3 X 600 # SORF SERR SA105 1 EA 0

0050 95446647 . . . . COUPLING FULL 1/2IN NPTX3000# SA105 2 EA 0

0180 70212360 . . . GASKET FLANGE 4 X 300# 2 EA 00

0190 70220900 . . . GASKET FLANGE 3IN X 600# 1 EA 00

0195 70449624 . . . SUPPORT COOLERS 5 & 4 X 7 PHE 1 EA 00

0196 95458741 . . . BOLT - U CLAMP 6INCH PIPE 2 EA 0


0210 95077822 . . . NUT HEX 3/4 UNC ESV 16 EA 0


0026 95077822 . . . NUT HEX 3/4 UNC ESV 8 E 0

0300 95077798 . . . NUT HEX 1/2 UNC 4 EA 0

0040 24042301 . . ASSEMBLY AIR PIPING 2ND STG DISCHARGE 1 EA A

0010 70220900 . . . GASKET FLANGE 3IN X 600# 4 EA 00


0016 95077822 . . . NUT HEX 3/4 UNC ESV 32 EA 0

0020 39551825IM DAMPENER DISCH PULSATION BOTTLE 4X7 1 EA 010020 39551825IM . . . DAMPENER DISCH PULSATION BOTTLE 4X7 1 EA 01

0021 70461025IM . . . VALVE SAFETY 650PSIG 0.5NPT 1372SCF 1 EA 00

0022 95767323 . . . ELBOW 90DEG 1/2"NPT A182 F304L # 2000 1 EA 0

0023 95097390 . . . NIPPLE PIPE 1/2IN NPT X 2IN LG 1 EA 0

0024 17299371 . . . GAUGE PRESS 0-60KG/CM^2G 4" BACK ENTRY 1 EA 00

0030 24073843 . . . PIPE AIR V.B TO AC,5&4X7 3"X600#, CS 1 EA A



0040 95041265 FLANGE 3 X 600 # SORF SERR SA105 2 EA 00040 95041265 . . . . FLANGE 3 X 600 # SORF SERR SA105 2 EA 0

0100 24045718 . . . AFTERCOOLER 650PSIG, 3"X600#, 72" LONG 1 EA A

0110 39582697IM . . . PIPE AIR REDUCER 3X600# - 2.5X600# 1 EA 01

0120 95056032 . . . REDUCER BUSHING 3/4 NPT X 1/2 NPT 1 EA 0

0125 70461025IM . . . VALVE SAFETY 650PSIG 0.5NPT 1372SCF 1 EA 00

0140 70477799 . . . GASKET FLANGE 2.5 X 600# 1 EA 00


0150 95077822 . . . NUT HEX 3/4 UNC ESV 8 EA 0

0160 17294562IM SEPARATOR MOISTURE 2-1/2"X600# 640 PSIG 1 EA 000160 17294562IM . . . SEPARATOR MOISTURE 2-1/2 X600# 640 PSIG 1 EA 00

0180 70449624 . . . SUPPORT COOLERS 5 & 4 X 7 PHE 1 EA 00

0190 95458741 . . . BOLT - U CLAMP 6INCH PIPE 2 EA 0

0195 95077798 . . . NUT HEX 1/2 UNC 4 EA 0

0190 70447297 . ASSEMBLY WATER PIPING FOR PACKING CASE 1 EA 00

0010 94468261 . . TUBE 1/4" OD X 0.035"THK SS316 SEAMLESS 3 FT 03

0020 70219795 . . ELBOW MALE 1/4T X 1/4 NPT 6 EA 00

0030 39171731 . . STRAINER Y,0.25"NPT 165PSIG, BRONZE 1 EA 00

Parts List24038200



0040 95069357 . . ELBOW 1/4 FORGED 2 EA 0

0050 95050043 . . NIPPLE PIPE 1/4IN X 1-1/2IN 7 EA 0

0060 39105630IM . . VALVE BALL 0.25" F-F 400 PSI WOG 2 EA 00

0070 95955464 . . INDICATOR SIGHT FLOW 3/8 INCH 1 EA 0



0110 95140034 . . COUPLING 3/8 NPT X 3000# SS304 1 EA 0

0120 95486916 . . COUPLING 1/4 NPT X 3000 SS 304 1 EA 0

0130 95038147 . . REDUCER BUSHING 3/8 NPTM X 0.25 NPTF 1 EA 0

0200 17276791 . ASSEMBLY CONDENSATE 2STG BOOSTER PHE7,1235 PSIG 1 EA 00

0010 70453212 . . ASSEMBLY CONDENSATE TUBING 1ST STG P.B 1 EA 00

0010 95395836 . . . NIPPLE PIPE 3/4IN X 3IN BOTH NPT 1 EA 0

0020 39105663IM . . . VALVE BALL 0.75" F-F 400 PSI WOG 1 EA B

0020 70453220 . . ASSEMBLY CONDENSATE TUBING 1ST STG M/S 1 EA 00

0010 39309034 . . . VALVE SOLENOID.2 WAY N.C..25IN NPT 1 EA 02

0020 39194998IM . . . VALVE BALL 0.5 HIGH PRESS 3000 PSI 3 EA 01

0030 70440748 . . . STRAINER 1/2IN 1235 PSIG 1 EA 00

0040 95531216 . . . REDUCER BUSHING 1IN X1/2IN BOTH NPT 1 EA 0

0050 95299152 . . . ELBOW 1/2INT X 1/2IN NPT 2 EA 0

0060 95277067 . . . TEE UNION 1/2IN TUBE 1 EA 0

0070 95278503 . . . CONNECTOR MALE 1/2IN T X 1/2IN NPT SS316 8 EA 0

0080 95278479 . . . CONNECTOR TUBE MALE 1/4NPTX1/2 TUBE 2 EA 0

0090 70234323 . . . TUBE 1/2" OD X 0.035"THK SS304 WELDED 4 FT 01

0100 95451217 . . . COUPLING FULL 1/2IN NPTX3000# SS304 2 EA 0

0110 95364162 . . . BOLT - U CLAMP 3/4 INCH PIPE 2 EA 0

0120 95077681 . . . NUT HEX 1/4 UNC -16A4C1 4 EA 0

0030 17276809 . . ASSEMBLY CONDENSATE TUBING 1235 PSIG 1 EA 00

0010 40057424IM . . . VALVE SOLENOID 1500 PSIG 0.375"NPT,2WAY,NC,120V 1 EA 01

0020 39194998IM . . . VALVE BALL 0.5 HIGH PRESS 3000 PSI 3 EA 01

0003 70440748 . . . STRAINER 1/2IN 1235 PSIG 1 E 00

0040 95531216 . . . REDUCER BUSHING 1IN X1/2IN BOTH NPT 1 EA 0

0050 95299152 ELBOW 1/2INT X 1/2IN NPT 2 EA 00050 95299152 . . . ELBOW 1/2INT X 1/2IN NPT 2 EA 0

0060 95277067 . . . TEE UNION 1/2IN TUBE 1 EA 0

0070 95278503 . . . CONNECTOR MALE 1/2IN T X 1/2IN NPT SS316 8 EA 0

0080 95278479 . . . CONNECTOR TUBE MALE 1/4NPTX1/2 TUBE 2 EA 0

0090 70234323 . . . TUBE 1/2" OD X 0.035"THK SS304 WELDED 4 FT 01

0100 95451217 . . . COUPLING FULL 1/2IN NPTX3000# SS304 2 EA 0

0105 95278487 . . . CONNECTOR TUBE 3/8NPT-MX1/2T 1 EA 0

0107 95575460 . . . ELBOW MALE 3/8NPT X1/2TUBE 1 EA 0

0110 95364162 BOLT U CLAMP 3/4 INCH PIPE 2 EA 00110 95364162 . . . BOLT - U CLAMP 3/4 INCH PIPE 2 EA 0

0120 95077681 . . . NUT HEX 1/4 UNC -16A4C1 4 EA 0

0205 24072894 . ASSEMBLY WATER PIPING 5&4X7 PHE7 PKG 1 EA A

0010 72039324 . . STRAINER 1.5INCH NPT 1 EA 00

0020 95239299 . . UNION 1-1/2" NPT FEMALE 2 EA 0

0030 95244513 . . CROSS 1.5IN SW,3000LB 2 EA 0

0040 95058707 . . CROSS 1IN THREADED,MALLEABLE IRON 2 EA 0

0050 95003547 . . CROSS 0.75IN NPT 6 EA 0

0060 95446449 TEE 1-1/2 IN NPT 8 EA 00060 95446449 . . TEE 1-1/2 IN NPT 8 EA 0

0080 95063491 . . TEE 1 IN NPT MALL. IRON BLACK 4 EA 0

0090 95063483 . . TEE 3/4 IN NPT 8 EA 0

0100 95063475 . . TEE 1/2 NPT 150 # MALLEABLE IRON 12 EA 0

0110 39111877IM . . VALVE SOLENOID 2-WAY 1.5" NPT 150 PSIG 1 EA 03

0120 39105663IM . . VALVE BALL 0.75" F-F 400 PSI WOG 3 EA B

0130 95492955 . . NIPPLE PIPE 1-1/2 IN X 2 IN BOTH NPT 8 EA 0

0140 95771242 . . NIPPLE PIPE 1-1/2"X3"NPT XS SS304 4 EA 0

Parts List24038200



0150 95658589 . . NIPPLE PIPE 1-1/2IN X 4.5INBOTH NPT 4 EA 0

0160 70230701 . . NIPPLE PIPE 1-1/2INX 6IN 4 EA 00

0170 95320537 . . NIPPLE PIPE 1 NPT X 2-1/2 LG 4 EA 0

0180 95243176 . . NIPPLE PIPE 1" X 4" LONG 4 EA 0

0190 70210455 . . NIPPLE PIPE 1" X 5"L 2 EA 00

0210 95444220 . . NIPPLE PIPE 3/4IN X 2IN BOTH NPT 4 EA 0


0220 95781563 . . NIPPLE PIPE 3/4"X6" NPT XS SS304 8 EA 0



0250 95494688 . . NIPPLE PIPE 1/2"X6"SS304 STD. WT 10 EA 0

0255 95411492 . . NIPPLE 1/2X4"NPT SS304 XS 5 EA 0

0260 95409819 . . NIPPLE PIPE 1/2X3"NPT XS SS304 10 EA 0

0270 95994166 . . ELBOW 1.5"NPT 37A10B23 2 EA 0

0280 95040374 . . ELBOW 1 NPT X 90 3 EA 0

0290 95422416 . . ELBOW 3/4IN NPTF SS304 12 EA 0

0300 95319950 . . ELBOW 1/2 INCH NPT SS 12 EA 0

0310 39105655 . . VALVE BALL 1/2 XLE (USE 39105655IM) 4 EA B

0320 40048423IM . . THERMOMETER 0/250F & -20/120C BACK 4 EA 02

0330 95463667IM . . THERMOWELL 65A12B4N 4 EA 0

0340 39488689IM . . VALVE THERMOSTATIC .75NPT 120F AMOT 2 EA 00

0350 54652524IM . . VALVE THERMOSTATIC 0.75NPT 110F 1 EA 00

0360 54408893IM . . VALVE THERMOSATTIC SET AT 110 F 1 EA 00

0380 95587895 . . INDICATOR SIGHT FLOW 3/4 INCH 3 EA 0

0390 95588026 . . INDICATOR SIGHT FLOW 1IN NPT(F) 1 EA 0

0410 70452610 . . TUBE 1.5IN OD X .095 SS304 SEAMLESS 10 FT 02

0430 70452602 . . TUBE 1"ODX.065 SS304 SEAMLESS 15 FT 02

0440 70443924 . . TUBE 3/4OD X.065THK SS304WELD ANNLD 30 FT 01

0450 70234323 . . TUBE 1/2" OD X 0.035"THK SS304 WELDED 12 FT 01

0460 17277112 . . CONNECTOR MALE 1.5"T X 1.5"NPT, CS 12 EA 00

0480 17273962 . . CONNECTOR MALE 1"TX1"NPT C.S. 8 EA 00

0490 70432240 CONNECTOR MALE 3/4T X 3/4 NPT 24 EA 000490 70432240 . . CONNECTOR MALE 3/4T X 3/4 NPT 24 EA 00


0051 17273988 . . ELBOW 90 DEG. 1TUBE X 1NPTM C.S 4 E 00

0520 70431978 . . ELBOW MALE 3/4 TUBE X 3/4 NPTM 10 EA 00

0525 70440706 . . ELBOW MALE 1/2T X 1/2 NPT 8 EA 00

0530 17274036 . . ELBOW UNION 3/4" TUBE TO TUBE C.S 8 EA 00

0535 95446654 . . COUPLING FULL 3/4IN NPTX3000# SA105 2 EA 0

0540 95446688 . . COUPLING FULL 1-1/2 NPTX3000#-SA105 2 EA 0

0555 95333290 REDUCER BUSHING 1 1/2INX1IN BOTHNPT 4 EA 00555 95333290 . . REDUCER BUSHING 1-1/2INX1IN BOTHNPT 4 EA 0

0560 95333308 . . REDUCER BUSHING 1-1/2INX3/4IN BOTH 7 EA 0

0570 95038204 . . REDUCER BUSHING 1-1/2" X 1/4" 2 EA 0

0600 95245452 . . BUSHING REDUCER SS304 1"NPTMX3/4"NPTF 4 EA 0

0610 95038071 . . REDUCER BUSHING HEX 1 X 1/4 2 EA 0

0620 95245452 . . BUSHING REDUCER SS304 1"NPTMX3/4"NPTF 10 EA 0

0630 95272415 . . REDUCER 3/4"X1/2" NPT SS304 28 EA 0

0640 95479325 . . REDUCER BUSHING 3/4 X 1/4 NPT SS304 4 EA 0

0650 95272407 BUSHING REDUCER 1/2IN X 1/4IN BOTH 2 EA 00650 95272407 . . BUSHING REDUCER 1/2IN X 1/4IN BOTH 2 EA 0

0660 94426210 . . VALVE DRAIN 1/4 NPT 4 EA 02

0210 39899760 . DECAL OPERATING INSTRUCT,INTELLISYS 1 EA 3

0220 42388769 . KIT DECALS PHE-7/PHE-9 PACKAGE 2 STAGE 1 EA 00

0010 39540273 . . DECAL LIFT HERE 1 EA 5

0020 39539622 . . DECAL AIR INLET 1 EA 04

0030 39546817 . . DECAL NON LUBRICATED CYLINDER 2 EA 03

0040 39460274 . . DECAL OIL CRANKCASE 1 EA 02

Parts List24038200



0050 39460688 . . DECAL DESSICANT BAG 1 EA 02

0060 39540257 . . DECAL AIR DISCHARGE 1 EA 5

0070 39544150 . . DECAL ROTATION NOTICE 1 EA 4

0080 39516661 . . DECAL FILLER PLUG CAUTION 1 EA A

0090 39541321 . . DECAL WATER OUT 1 EA 5

0100 39541339 . . DECAL WATER IN 1 EA 5

0110 39540166 . . DECAL CONTAMINATED AIR 1 EA 6

0120 39541206 . . DECAL WARNING-VALVES 1 EA 03

0130 39546809 . . DECAL HIGH PRESSURE 1 EA 03

0140 39540240 . . DECAL HI-PRESSURE 1 EA 5

0150 39546833 . . DECAL MOVING BELTS 1 EA 04

0160 39540174 . . DECAL HIGH VOLTAGE 1 EA 6

0170 23038466 . . DECAL IR LOGO 18" 3 EA A

0180 40036519 . . NAMEPLATE 1 EA 06

0190 39175070 . . SCREW MACHINE 0.114" X 0.25" 4 EA 01

0200 39569694 . . DECAL HOT SURFACE 2 EA 05

0210 39541081 . . DECAL CONDENSATE DRAIN 2 EA 5

0220 39332127 . . DECAL CONTROL AIR 1 EA 03

0230 39332135 . . DECAL PACKING WATER IN 1 EA 03

0240 39332143 . . DECAL PACKING WATER OUT 1 EA 03

Figure 1 Frame & Running Gear

Figure 2 Frame & Running Gear

Figure 3 5” Airend Complete

58

59

59

Figure 4 5” Cylinder Suction Valve

Figure 5 5” Cylinder Discharge Valve

Figure 6 4” Airend Complete

Figure 7 4” Cylinder Suction Valve

Figure 8 4” Cylinder Discharge Valve

Recommended Spares

Class 1 Class 2 Class 38,000 Hrs 40,000 Hrs 80,000 Hrs1 Year 5 Years 10 Years

1 PUMP‐OIL, INTERNAL 30427140 1 •2 GASKET, COVER OIL PUMP 30205280 1 •3 O‐RING, MAIN BRG. HOUSING 95018370 1 •4 CAP‐BREATHER 30557888 1 •5 OIL FILTER 30472161 1 • •6 GAUGE‐OIL LEVEL 39137245 1 •7 SPRING‐RELIEF VALVE 30508741 1 •8 BALL‐RELIEF VALVE 95320446 1 •9 BUSHING, MAIN BEARING (2 PER CRANKSHAFT) 30557565 2 •10 BUSHING, CRANKSHAFT JOURNAL 30557540 2 •11 BUSHING, CROSSHEAD PIN 30557532 2 •12 PIN‐CROSSHEAD 37087707 2 •13 RING, CROSSHEAD PIN RETAINING (2 REQ., PER PIN) 30576136 4 •14 CROSSHEAD COMPLETE 37046414 2 •15 GASKET‐MB HOUSING 39535224 1 •16 SEAL CRANKSHAFT OIL 37794377 2 •17 GASKET‐FRAME COVER TOP 39535216 1 • •18 GASKET, FRAME / DISTANCE PIECE 39583869 2 • •19 GASKET, DISTANCE PIECE SIDE COVER 39535216 4 • •20 LUBRICANT (XL‐740HT) 5 GALLONS DRUM 39163266 1 • •

18 VALVE INLET W/ACTUATOR 39590468 2 •

Spares List

Sr.# Description Item# QtyRecommended Spares

Start‐up

Frame and Running Gear

5" AirendINLET VALVES

18 VALVE, INLET W/ACTUATOR 39590468 2 •19 VALVE, INLET 37982907 2 •20 PLATE, VALVE 37944550 2 •21 ASSEMBLY, SUCTION GUARD 37980422 2 •22 SPRING, VALVE 33426883 8 •23 RING CRUSH 37981933 2 • •24 GASKET‐VALVE SEAT 54365648 2 • •

25 VALVE, DISCHARGE 39329313 2 •26 PLATE, VALVE 37944550 2 •27 SEAT, DISCHARGE 37982196 2 •28 SPRING, VALVE 33426917 8 •29 GASKET‐VALVE COVER 30550842 2 • •30 GASKET‐VALVE SEAT 54365648 4 • •31 SETSCREW 30572945 2 •

32 RING‐PISTON 39322334IM 5 •33 RING‐WEARING 39322318IM 2 •34 ASSY. ROD, PISTON (INCL. NUTS & WASHERS) CCN by ACP •35 ROD, PISTON 39570973 1 •36 NUT, CROSSHEAD JAM 34578799 1 •37 NUT, PISTON 30565675 1 •38 WASHER, STAR 30589568 1 •

39 RING, PACKING 39321245IM 4 •40 RING, PRESSURE BREAKER 39321450IM 1 •41 GASKET‐PACKING 30586127 1 •42 GASKET, PARTITION PLATE 37123171 1 •43 RING‐SCRAPER (DOUBLE ACTING) 54491386 1 •44 RING‐SCRAPER (SINGLE ACTING) 54491378 2 •

45 GASKET‐WATER COVER 39535547 2 •46 GASKET‐FRAME HEAD 39550082 1 •47 GASKET, OUTER HEAD 39550082 1 •48 GASKET, FRAME HEAD COVER 37068293 2 •

DISCHARGE VALVES

PISTON AND ROD

PACKING AND SCRAPERS

CYLINDER GASKETS

PRIYANKSHAH

Stamp


18 VALVE, INLET W/ACTUATOR 39590807 2 •19 VALVE, INLET 37983228 2 •20 PLATE, VALVE 37982279 2 •21 ASSEMBLY, SUCTION GUARD 37983236 2 •22 SPRING, VALVE 37982287 2 •23 RING CRUSH 37980380 2 • •24 GASKET‐VALVE SEAT 37980612 2 • •

25 VALVE, DISCHARGE 39590690 2 •26 PLATE, VALVE 37982279 2 •27 SEAT, DISCHARGE 37982246 1 •28 SPRING, VALVE 37982287 4 •29 GASKET‐VALVE COVER 37038064 2 • •30 GASKET‐VALVE SEAT 54370663 4 • •31 SETSCREW 34140293 2 •

32 RING‐PISTON 54577416IM 6 •33 RING‐WEARING 54577440IM 2 •34 ASSY. ROD, PISTON (INCL. NUTS & WASHERS) CCN by ACP •35 ROD, PISTON 39570957 1 •36 NUT, CROSSHEAD JAM 34578799 1 •37 NUT PISTON 30565675 1 •

Spares List

Start‐upSr.# Description Item# Qty

Recommended Spares

4" AirendINLET VALVES

DISCHARGE VALVES

PISTON AND ROD

37 NUT, PISTON 30565675 1 •38 WASHER, STAR 30589568 1 •

39 RING, PACKING 39321245IM 5 •40 RING, PRESSURE BREAKER 39321450IM 1 •41 GASKET‐PACKING 30586127 1 •42 GASKET, PARTITION PLATE 37123171 1 •43 RING‐SCRAPER (DOUBLE ACTING) 54491386 1 •44 RING‐SCRAPER (SINGLE ACTING) 54491378 2 •

45 GASKET‐WATER COVER 39568787 2 •46 GASKET‐FRAME HEAD 39486204 1 •47 GASKET, OUTER HEAD 39486204 1 •48 GASKET, FRAME HEAD COVER 37068293 2 •

49 VALVE, SAFETY‐REGULATION @ 90# 39331368IM 1 •50 VALVE, SAFETY‐INTERSTAGE @ 160# 39317417IM 1 •51 VALVE, SAFETY‐DISCHARGE @290# 70473889IM 1 •52 VALVE, SAFETY‐DISCHARGE @650# 70461025IM 2 •53 GAUGE, PRESSURE‐REGULATION (0‐140PSI) 39322763 1 •54 THERMOMETER 40048423 4 •55 INDICATOR, SIGHT FLOW‐CYLINDER & COOLERS 95587895 4 •56 INDICATOR, SIGHT FLOW‐PACKING WATER 95955464 2 •57 STRAINER, PACKING WATER 39171731 2 •58 STRAINER, CONDENSATE DRAIN VALVE 70440748 2 •59 VALVE, CONDENSATE SOLENOID 39309034 1 •60 VALVE, SOLENOID WATER 39111877IM 1 •61 VALVE, SOLENOID UNLOADER 40049942 1 •62 FILTER‐CONTROL AIR LINE 39229463 1 •63 PRESSURE REDUCING VALVE‐REGULATION 39322649 1 •64 V BELTS, COMPRESSOR DRIVE 39169933 4 •

PACKING AND SCRAPERS

CYLINDER GASKETS

PACKAGE ITEMSPackage Accessories

PRIYANKSHAH

Stamp


65 SWITCH, TEMPERATURE 39198494IM 2 •66 RTD‐34.5' 39571310 6 •67 SWITCH, TEMPERATURE 39198494 2 •69 TRANSDUCER, 0‐225# 39875539 4 •70 TRANSDUCER, 0‐500# 54364104IM 1 •71 TRANSDUCER, 0‐1000# 54364096IM 1 •72 GASKET, 3"‐300# 94475506 5 •73 GASKET, 3"‐600# 70220900 5 •74 GASKET, 4"‐300# 70212360 2 •75 GASKET, 2.5"‐600# NAB 70477799 1 •

76 INTERCOOLER 17298506IM 1 •77 SEPARATOR 40054496IM 1 •78 AFTERCOOLER 24045718 1 •79 SEPARATOR 17294562IM 1 •

Spares List

HEAT EXCHANGERS & SEPARATORS

Sr.# Description Item# Qty

Recommended SparesStart‐up

INSTRUMENTS & Gaskets

PRIYANKSHAH

Stamp

Parts List - Ingersoll Rand Productsmanualarchive.ingersollrandproducts.com/manuals/manuals...This...

Documents

Transcript of Parts List - Ingersoll Rand Productsmanualarchive.ingersollrandproducts.com/manuals/manuals...This...