Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling...

34
2 - 5 Ton Cooling Capacity 12,800 to 85,300 Btuh (5 - 25kW) Optional Electric Heating Capacity FEATURES Designed for outdoor rooftop or ground level installations Down-flow or horizontal supply and return air configuration U.L. and U.L.C. listed, components bonded for grounding to meet safety standards for servicing by U.L., and National and Canadian Electrical codes U.S.E. certified based on ARI Standard 210/240-94 Sound tested in accordance with conditions included in ARI 270-95 Heavy gauge galvanized steel cabinet, base section and cabinet panels exposed to conditioned air are lined with insulation, powdered enamel paint finish, large removable access panels for ease of service, electrical inlets furnished for entry into cabinet, control box with factory installed controls located for easy service Factory sealed refrigeration system consists of compressor, condenser coil and fan, evaporator coil and blower, liquid line strainer, suction and liquid line service gauge ports and full refrigerant charge. All models have factory installed high pressure switch (manual reset), expansion valve and freezestat. Coil constructed of copper tube, and lanced ripple- edged aluminum fins for maximum heat transfer and low air resistance, high pressure factory tested Lifting brackets are factory installed Condenser fan is direct drive. Permanently lubricated, PSC motor is totally enclosed for maximum protec- tion. All models have a corrosion resistant PVC coated steel wire fan guard. Cleanable polyurethane one inch (25 mm) thick filter and rack is furnished for installation in all models for downflow applications. Filter rack will accept up to two inch (51 mm) thick filter. For horizontal applications without economizer, filters must be field installed in return air duct. Rugged and reliable compressor is hermetically sealed, suction cooled, overload protected and equipped with internal pressure relief valve. Compressor is installed on resilient rubber mounts for quiet and vibration free operation. Models 024-030 have an immersible self- regulating temperature actuated crankcase heater. Scroll compressor on 036-060 models. Direct drive centrifugal blower statically and dynamically balanced for maximum efficiency and minimal noise level. Multiple speed permanent split capacitor (PSC) motor is resiliently mounted. Economizer wiring is factory furnished for ease of installation. 1 Year warranty on parts 5 Year warranty on compressor CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit

Transcript of Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling...

Page 1: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2 - 5 Ton Cooling Capacity

12,800 to 85,300 Btuh (5 - 25kW) Optional

Electric Heating Capacity

FEATURES

◆ Designed for outdoor rooftop or ground levelinstallations

◆ Down-flow or horizontal supply and return airconfiguration

◆ U.L. and U.L.C. listed, components bonded forgrounding to meet safety standards for servicingby U.L., and National and Canadian Electrical codes

◆ U.S.E. certified based on ARI Standard 210/240-94◆ Sound tested in accordance with conditions

included in ARI 270-95◆ Heavy gauge galvanized steel cabinet, base section

and cabinet panels exposed to conditioned air arelined with insulation, powdered enamel paint finish,large removable access panels for ease of service,electrical inlets furnished for entry into cabinet,control box with factory installed controls located foreasy service

◆ Factory sealed refrigeration system consists ofcompressor, condenser coil and fan, evaporator coiland blower, liquid line strainer, suction and liquid lineservice gauge ports and full refrigerant charge. Allmodels have factory installed high pressure switch(manual reset), expansion valve and freezestat.

◆ Coil constructed of copper tube, and lanced ripple-edged aluminum fins for maximum heat transfer andlow air resistance, high pressure factory tested

◆ Lifting brackets are factory installed◆ Condenser fan is direct drive. Permanently lubricated,

PSC motor is totally enclosed for maximum protec-tion. All models have a corrosion resistant PVCcoated steel wire fan guard.

◆ Cleanable polyurethane one inch (25 mm) thickfilter and rack is furnished for installation in allmodels for downflow applications. Filter rack willaccept up to two inch (51 mm) thick filter. Forhorizontal applications without economizer, filtersmust be field installed in return air duct.

◆ Rugged and reliable compressor is hermeticallysealed, suction cooled, overload protected andequipped with internal pressure relief valve.Compressor is installed on resilient rubbermounts for quiet and vibration free operation.Models 024-030 have an immersible self-regulating temperature actuated crankcaseheater. Scroll compressor on 036-060 models.

◆ Direct drive centrifugal blower statically anddynamically balanced for maximum efficiency andminimal noise level. Multiple speed permanentsplit capacitor (PSC) motor is resiliently mounted.

◆ Economizer wiring is factory furnished for ease ofinstallation.

◆ 1 Year warranty on parts◆ 5 Year warranty on compressor

CHA16-024-030-036-048-060

Cooling & Electric HeatPackaged Unit

Page 2: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

22 CHA162

Model Number Guide

��� �� � ��� � �

���������������� �����

����������������

������ ������������������

���� !��������

"���#��"������$� %�&' (���)*)������ ��

�� � ���� %*��'

��������)� %���' +������#

��!����� %���!'

� ���� � %� ��'

�!����)� %�*�!'

Page 3: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

3

Specifications

��������� �� ���� �� ���� �� ��� �� ���� �� �� �

��������������� �� ������� ���� ����� �� ������ �� ������ �� ������

��������������

��������������� �!�"�#$�� �� ��%�����&��� ���&�������� ��%���������� ��%���������� ��%������&���

�����#����'���� ���� ���� ���� ��(� &�&�

)**���"�#$+������ ���� �����

**���"�#$+������ ��� ��& ��� (�� (��

��)�#�,��������#�-�.� �,-� �� ��

��/.��.�����$�.���0�1�!����� �-������2�

������ �

�� �-���&��2�

���(�� �

�� �-�������2�

������ �

�� �-������2�

����(� �

�� �-������2�

������ �

*3���.���.

"��'�.

"��'�.�'$������������,������.

4�'�,�$����� ����

(�4��

���(�4�����

���4��

�����4�����

���4��

�����4�����

����+��4�(

��(��4���(�

5���.�$�.����'�.� ��� �+�����(� �+������� �+����&��

*3���.���.�����

����/�����.���!��6��/��� ��7� ���� ������ ���� ������ ���� ������

#-��,������.�!� ���� �����8

�����/�.�'��+�� �(����!��

1������.����$���� �����(�� ����&&(� �����(��

���,����.�����

����/�����.��

�6��/��� ��7�

9#��.����� ��&� ������ ����� ������

:���.����� !!! ���� ������ ��(� ������ ����� ������

#-��,������.�!� ���� �����8

�����/�.�'��+�� �(����!�� �+�� �(����!�� �+�� �(����!�� �+�� �(����!��

1������.����$���� ��������

���,����.�1��

;������.�!� ���� �����8

�����/�-��,�����������!�� ����&����!��

<�.�3��#����/���=+�� ����������� ����������� ��������(�� �&���������

5���.�$�.����'�.� ��� �+&������ �+�������

5���.�'���� ��� ��� ��� ���

9�������

*����.���0���

������

*�0�&�!�

*�0�&!�

9#��#��!�"�#$�� �� �(%�������&� !!!

�<�1�>�*� ((? !!!

*�0�&�!�

*�0�&!�

9#��#��!�"�#$�� �� �&%�������&� ��%�������(� �&%�������&� ��%�������(�

�<�1�>�*� ((?

*�0�&�!��

*�0�&!��

9#��#��!�"�#$�� �� �&%���������� ��%���������� �&%���������� ��%����������

�<�1�>�*� ((?

*�0�&!��9#��#��!�"�#$�� �� ��%���������� ��%���������� ��%���������� ��%����������

�<�1�>�*� ((?

*�0�&!��9#��#��!�"�#$�� �� !!! ��%���������� ��%����������

�<�1�>�*� !!! ((?

*�0�&!��9#��#��!�"�#$�� �� !!! ��%����������

�<�1�>�*� !!! ((?

���,�������,.������2������!� ���� ���� �+����(�

�������8���2���/�/����.��!� ���� ���� �����&�4����4��� ���&�4�&���4���� �������4����4��� �����4�&���4����

����'��$���/�-�����#����!� �-��� � � �������&� ��������� ��������� ������((� ���������

)$������'��$���/�-�����#����!� �-�� � ������� �� ��������� ��������� ��������� ��������� ������&��

*����.������$�.����.�������!� �&��$2� ���+���3�!��� �$ ���+���3�!���$%����+���3%��&�3��.����3�!��� �$

���.��/��,���� ����.,�����'��$�>)*���.��/���������.�.��%�'$��$� ���-���,����<�:�)���,�.,����+������,�;9*�(�@1����@����#�,��.� ��.������.��#.�� ��,

���@1����@���,-+&�@1���(@���'-�����.����3���.���.� �������.�

��)�#�,��������#�-�.���� ����.,�����'��$������ ���,������� ����#,�,� ���<�:�)���,�.,����!(��

���������-��� ��� #.��$����/����.�

Page 4: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

44 CHA164

Optional Accessories��������� �� ���� �� ���� �� ��� �� ���� �� �� �

���������� !�AB�������,�������'�.��#�.,������.�������#�,��.�����

�� ����� ���������� �������������������

��#�.,����.��.,�.

���������#�.,����.��.,�.

����������!�0��3 �,#� �/���,� ��������,������#�.,��.������������/.���,�������� ����� ���������� ������������

���������#�.,����.��.,�.

���������#�.,����.��.,�.

���������!�<�#���#��.�����%� ��.�������.�.����%

���#����,�,�//#��.�-�4�'��$�/�����%�$�����.���

/#.���$�,%� ����.��.��.�����������3�����.�/��'�%� ����.����

�����,���.�3�����.���.�#�������%��,��������!-�.�������

.�,���.�������.���������!��������$�

�!"���#� !,�#-��

,�/�������

��#3�.�

$%��"&'� !�&���-��� ���� ������(��

)����� !� /�4�,-��,����#3�.�

)��"&'� !�����-��� ���� �� ����(&�

%�#�� ��#��� �!!�*��#�$� �#��"�>��,�'��$�,�//#��.�%� �����������

.��/���#�����/.���%���3���2�,������������.#�����%�/������/#.���$�,

/�.�,#�������������%� � /#�� � ���#����,�!��������$�

$%�&� !�����-��� �(� �� ��'����

+,�#�-�.���� ����/� *�+0���� ���-!������#")�����"�:��������,�.���� � �����-����%�.���.�#����,��.�,����.��'��$��.���#.�����.���,�.�3�� ��4$�#��

,����.%� /�.��,%��� ���,�,����.�-��,��%�� ���

-��.���%���3�,����.�����.�$����,C#���-��������#�

����������'���$%������.�����,���$�.����.������.%

�,C#���-����#�,��.���.����$��� �����.����>����2���/����.

/#.���$�,�'��$�#���%� /����.�.�� �'�����������#������� ���

��������/����.������3�-����4$�#��� ��.�$��,���,

�#�,��.���.����� ��$��,�'��$���#���#�����$�/����.�

�$������/��������2�.�����.�����5�,�������!����

���$��!����%���2���/�/����.%� ���%�����

��1��� ��#$+2��&"��

����-��� ���� �� �'(����$+2��&"&'

&&��-��� ���� �� �'(��'�

2���� �#3$+2��&2"��

����-��� ���� �� �'(����$+2��&2"&'

&&��-��� ���� �� �'(����

45#�� � �����&�4����4��� ���&�4�&���4�����������4����4��

�����4�&���4����

6� �� �������4����4��� ���&�4�&���4�����������4����4��

�����4�&���4����

+,�#�-�.����-!�������.�# ����!� :�������� ,�.���� �����-����%����-���������#�,��.���.���,�.���.�#����,���.

,����.%� /�.��,%��� ���,�,����.�-��,��%�� ���

-��.���%���3�,����.�����.�$����,C#���-��������#�

����������'���$%������.�����,���$�.����.������.%

�,C#���-����#�,��.���.����$��� �����.������ ��� �������

/�-�.�����/����.�/#.���$�,%�/����.�.�� �'�����������#����

������ ��������/����.%��#�,��.���.� ���� ��$��,�'��$

��#���#�����$�/����.���$������/��������2�.�����.����

5�,�������!��������$��!�����8���2���/�/����.%� ���� ����

��1��� ��#+2���&"��

�����-��� ���� �� �������+2���&"&'

�����-��� ��(� �� �����(�

2���� �#3+2���&2"��

�����-������� ���������+2���&2"&'

�����-����(� �� �������

5#�� �������4����4��� �����4�&���4����

�����&�4����4��

���&�4�&���4����

�������4����4��

���&�4�&���4����

6� �� ������4����4��� �����4�&���4����������4����4��

�����4�����4����

+# ���!*���# ��7������# ����"�>��,�������C#�������'��$��#�,��.

��.����$��� �����.����;���.��������,���������'$��$���.�$����$�

��'�������$��� �����#.����.����$��� ������.�/���,� ��������� ��

�������2�.�,����.���������

�'�����

��/� *�+0���� ���-!���!�1�.�#���'��$�*5;0�&��A.���#.�

���.���,������-� �/���,� ��������� ����$��.��#.����.�,#����,C����������$�

�������2�.������-� ��:���#,���-�.,���.����!��������$��

�+���&"&'� !��� �-��� ��� �� �����&�

+��, �,���� � !�1���,� ��������,%�$���4�'�#�,����$.������������%�����

,��� �/�.��������������%���,�3�,#����������� ����������.���%�'�.��

$�.����%��� �-���'�!���������.����,�

)���*����.���0����;�����-���

+���&$� !�)#������������$�.�����#��//���/�� �/#������,��$�.���

.��� ���6#����.�)���*����.���0����;�����-���

+���&� !�)#����������������,�. � ������%�$����������.���.��� %

/#���-��� %��$�.����.��� ���6#����.� ���!��� �����+���3!��$�

��,���3���2�,�����������.���-�4�

)���*����.���0����;�����-���

D:�,��.� /����.���� ���� /#.���$�,�'��$��������2�.���*5;�&�#����2����4������ /����.�/#.���$�,�'��$��0<�&�#����

Page 5: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

5

Optional Accessories��������� �� ���� �� ���� �� ��� �� ���� �� �� �

+��, �,���� � �#3���1��# �1���� ��,�� �8")����9�0�"�>���'��$

*�0�&�������.���$����.�%�#���������C#�������'��$�*�0�&�/#���-�4�/�.������

��������'�.���#.���������������%� ��������� ����.�������#���%� /#����/#.���$�,%

�����.#���,��/���3���2�,�������'��$��.��#��$�,���#�����$�����

)���*����.���0����;�����-���

:#� � �#3���1��# �1���� ��,�� �8�)����9�0�!� :�������� ����.������#���%��.�3�,����#-!/#��������$��#���%�#��,�������C#�������'��$�*�0�&��.

*�0�&��/�.���������������'�.���#.���������������%�/#����/#.���$�,%

�����.#���,��/������2�,�������'��$��.��#��$�,���#�����$�������,

�����.����� ��������,��#�����$����%�$���,�-�4���3�.�

)���*����.���0����;�����-���

;���<-8��# ���# ���=� �!�>����� ���.����,�'�������@1� �!�@����#�,��.���.

�����.��#.�� ������������,��'��$�#���� ��,,������������.�����<�=�'

<�-�����E�������-��/���,� ��������,%����-����#����������.�����.���.� �,�'�

�����1� �!��������

�������

$������8�1����+# *�=� � !�<���'����'�.����. ��$.�#$

.��/���#�����/.���%� ��� �#����.�3�,�,����.��/�/.���%� ��

���������������� ����&������.��.�,����,#�����,�������������

$�.,'�.�%��'�� �����.��.�6#�.�,%�����/�.� ��'�3��������,

����/�.�$�$�3�������)���;���������;.�'����

�>���#��������

��(����

���#�� ��&���� ��(����

���>���#���(����

��(����

$����2��# �#3�)�-�� !������.���.���/#.���$�,%����������#���%�>�)�

������������/�������.����.��<��.�3�,%��$����,� ��� �,�,�'����51�&!��

�� �-��#��,����������2��%�'��$������$��#�����3�.$�������0A�&!������,

�0A�&!&���#�����!��������$���6%+� !�)�#�,���,#������A������#��� -�

�.,�.�,�����.���� �/�.�/���,� �������������

$2)�&"���!�����-��� ���� �����'��

A����� ��.,�.�,�����.���� �

����(��

$2)�&"��� !�����-��� ���� �����'��

A����� ��.,�.�,�����.���� �����(��

$2)�&"&'� !��&��-��� ��(� �����&��

A����� ��.,�.�,�����.���� �

����(��

6� ���<����-!�� �, ��#� !�1�.�,�'�!/��'�������������%�,����.

�����-� �.��������-��'�.�������������%����#��� ��,C#���-��%���!���?

�/�4�,���#�,��.���.%��#�,��.���.�$��,�'��$�������-���/����.� ����#,�,%��#�-�.

��,���2���/�/����.�!��������$�

6<��&"��� !�����-��� ��� ���'����

������4����4��� ���

�����4�����4�������

6<��&"&'� !�����-��� ��� ���'����

������4����4��� ���

�����4�����4�������

6� ���<����-!�� �, ��#�!�1�.�$�.�2������������������%� ��������� ��.��#.����.�,#����,C���������#���%����#��� ��,C#���-��� �/�4�,���#�,��.���.�!

�������$�

6<��"�&>&'� !��� �-��� ��� �� ���'���

6� ���%��-�� � �=� � !�>��,���� ��� ��#��������/��$�

�����.���$��������������������,��.�#�����'$�.���'������

����.��� ����������-����9#�,��.��$�.������������������$�

$���������,�����$����'���'�.� ���#����� ������������-��

-�/�.������'����$��/#�����'�.� ���,�����������������

%��-�� � �=� � �'&<(��

2��# �#3�9�0 ����&��

%�-��6�����# ���!�A.�3���������.����.��$�.�!� �������,�����'�������/�.

�#��������,�,���$�.���.���#.������6#���2�%���.��������$������.����.���

���.�� ������#����,�,����,�������<#��������.����� ����.����.�3�,���������

,��� �-��'��������.����.��$#��//���,����.�!#��

� �������

:#� � �#"6���2��# �#3�=� �!�*��3�����$�.�2������������������#������-�3���#������#./�����:���#,�����4�$�$����������� �� .��������,!�//���#����

)���,���������,.�'����

��(��(�

Page 6: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

66 CHA166

�� ����� ��������� ��������� ��������� ��������� ���������

������������� ������� ��������� �������

��������������������� ���� ���� ���� ���� ����

��� ����������� �� �!�" ��� ��� ���

��������������#��$���

#%��� ������� ��� ���

��� ����������� ��� "�"

&������'��(���$���

$�����%�%� ���)*+ ����)�"!+ ����)���+ ��"�),��+

#%��� ������� ��� ��� ��! ,��

��� ����������� "�� ��� ��� ��

�������������-��%��.%�������)���+

�, �� "� ,� ��

/�$����%������%��0����1 �� �� �� �" "��������������� ����������� ������ ��������� � ������������������� ������������������������ �������������

��������������������������� ��������� �������������� ���� ����!� ����

�� ����� ��������� ��������� ���������

������������� �������� ������� �������� "��� ,�,� �������� "��� ,�,� �������� "��� ,�,�

��������������������� ���� ��� "�� ���� ��" ,�� ���� � ��,

��� ����������� �� �! �� !� "� �� ��" �� "���

��������������#�$���

#%��� ������� ��� ��� /��� ��� ��� /��� ��� ��� /���

��� ����������� ��� ��� /��� "�" ��� /��� "�" ��� /���

&������'��(���$���

$�����%�%� ����)*+ ����)�"!+ ����)���+ ��"�),��+

#%��� ������� � ��� /��� ��! ��� /��� ,�� ��� /���

��� ����������� ��� "�" /"�" ��� "�" /"�" ���� ��� /���

�������������-��%�.%��������)���+

�� �, �, �, "� �� �,

//�$����%������%��0����1 �� �� ! �� �� �� �� �" ���"��������� �������#$��!� ���� %� � ��������&������� ���� ���������� ������������������

��������������� ����������� ������ ��������� � ������������������� ������������������������ �������������

��������������������������� ��������� �������������� ���� ����!� ����

Electrical Data - Single Phase Voltage

Electrical Data - Three Phase Voltage

Field Wiring - Basic Models

A B

ThermostatDisconnect

Switch

(Not Furnished) Single

Package

Unit

A - *Four Wire Low Voltage (Electro-mechanical)

- *Five Wire Low Voltage (Electronic)

B - Two or Three Wire Power (See Electrical Data Table)-Field Wiring Not Furnished-

*When economizer with two stage thermostat is used,

one additional wire is required.

NOTE - All wiring must conform to NEC or CEC and local

electrical codes.

Page 7: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

7

Electric Heat Data - CHA16-024-030 - Single Phase

����� ������

������� ����

�� �� ���� �� �� ������!� ��" ��#�

�����$�� %&�!�#�&

'���&(�%)�

� �� *��+

,���-)-�� �)��

�-%����+

�� �� ��� ���"

(�%)�

�� �� ��� ��.�)#(�%)�

*%������������ ���������/ ��) � �.�0 &

1����������!��� �� ���� ��

� �� �)2�3)& �.�0

�����)2�3)&

.�0

�,���-)-�� �)��

�-%����+

�0�-)-3)& ��4

��������

�������

�����

)"� �2��+� )�� �+

�����)������+

��� �� ��� ��3���

&�4��� ���"� , ������

&�4�� ��� ������

�� ��

��� �� "�� �"3��� �! ��

��� �� "�� �,3��� �! ��

�"� �� ,�� ��3��� �! ��

�������

�����

),� �2��+� )�� �+

��� �� ,�� ��3!��

&�4��� ����, � ������

�, �,

��� �� ,�! ��3��� "� "�

��� �� ��" ��3!�� "� "�

�"� �� ��� ��3!�� "� "�

��������

�����

),� �2��+� )�� �+

��� "� ��, �,3���

&�4��� ����, ��� �����

"� ,�

��� ,� ��" ��3��� ,, ��

��� ,� !�� ��3��� ,, ��

�"� ,� ���� �"3��� ,, ��

��������

������

)����2��+� )�� �+

��� �� ���� ��3"��

�� ��

��� �! ���� "�3��� �� !�

��� �! ���� "�3��� �� !�

�"� �! �,�� ,�3��� �� !�

���������

�������

�����

)"� �2��+� )�� �+

�����)������+

��� �� ��� ��3���

&�4��� ���"� , ������

&�4�� ��� ������

�� ��

��� �� "�� �"3��� �� ��

��� �� "�� �,3��� �� ��

�"� �� ,�� ��3��� �� ��

�������

�����

),� �2��+� )�� �+

��� �� ,�� ��3!��

&�4��� ����, � ������

�� "�

��� �� ,�! ��3��� "� ",

��� �� ��" ��3��� "� ",

�"� �� ��� ��3!�� "� ",

��������

�����

),� �2��+� )�� �+

��� "� ��, �,3���

&�4��� ����, ��� �����

"! ,�

��� ,� ��" ��3��� ,� ��

��� ,� !�� ��3��� ,� ��

�"� ,� ���� �"3��� ,� ��

��������

������

)����2��+� )�� �+

��� �� ���� ��3"��

�� ��

��� �! ���� "�3��� �� !�

��� �! ���� "�3��� �� !�

�"� �! �,�� ,�3��� �� !�

������� ������� � ���������� ������ ��������� ������������������������� �������������� ����������������������������� ����� �� ���� �� �������� � !�"��#�

Page 8: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

88 CHA168

����� ������

������� �

���

�� �� ��� ��

�� �����!�� �

" ��#�

�����$�� %&�!�#�&

'���&(�%)�

� �� *��+

,���-)-�� �)��

�-%����+

�� �� ��� ����"

(�%)�

�� �� ��� ���.�)#

(�%)�

*%������������ ��������/ ���) � �.�0 &

1����������!��� �� ���� ��

� ��

�)2�3)& .�0

����

�)2�3)& .�0

,���-)-

�� �)���-%����+

�0�-)-

3)& ��4

���������

�������

�����

��������� ����

��� �����������

�� � ��� �����

������������ ������

��������� ������

� ��

� � �� ������ �� ��

�� � ��� ������ �� ��

�� � ��� ������ �� ��

�������

�����

��������� ����

�� � ��� ������

������������� ������

�� ��

� �� ��� ����� �� ��

�� �� ��� ����� �� ��

�� �� ��� ����� �� ��

��������

�����

��������� ����

�� �� ��� �����

�������������� �����

�� ��

� �� ��� ����� �� ��

�� �� �� ������ �� ��

�� �� ���� ������ �� ��

��������

������

��������������

�� �� ���� ������

���

� ��

� �� ��� ������ � ��

�� �� ���� ������ � ��

�� �� ���� ����� � ��

�������

������

���������� ����

�� �� ���� ����� �� ���

� ��� ���� ������ ��� ���

�� ��� ���� ����� ��� ���

�� ��� ��� ������ ��� ���

������� ������� ����������� ������ ��������� ��������������������������������������� �������������������'��������� ����( �� ������ �����$)*%� +),*�-�

Electric Heat Data - CHA16-036 - Single Phase

Page 9: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

9

������

���������

���������

��� ������ ��

�����������

�� ������

������

� �����

�����

��� ������

��� ������

!����"�"

#����

$"���

��� ��

��� ��

����

��� ��

��� �% ��

����

�� ������������

���� ���&��

������%�'��

(� ������ ������ ������

��� ���)*+���

%�'

!����"�"

#����

$"���

��'�"�"

+���

��,�

���������

�����

.�/0.1�!

�������

+�) (��-�+2� 3�-

�� ����

+1��&��-

.�/ �1 1�/ �.�/��

��4�$�#�1�

������

.� 1�

..� �, #�. �#�1�� .� 1�

.1� �, #�$ �,�)�� .� 1�

.#� �, ,�� �)���� .� 1�

�����

.�/0.1�!

�������

#$�! � �������

,),! � �������

+�) � (��-�+/� 3�-

.�/ �/ ,�1 �/���� .. 1�

..� .� ,�2 .����� ., 1�

.1� .� $�# ..���� ., 1�

.#� .� )�� .1�2�� ., 1�

##� �� ,�/ �2�/����4�$�#�1

�������

�1 �,

#$� �� $�, ..�.�� �1 �,

#/� �� )�� .1�2�� �1 �,

,,� / ,�/ �2�/����4�$�#�10,�1

�������

�� �,

,), / $�# .��/�� �� �,

$�� / )�� .1�2�� �� �,

�������

.�/0.1�!

�������

#$�! � ����� �

,),! � �������

+�) � (��-�+/� 3�-

.�/ .$ )�, .,�$��

��4�$�#�1

�����-

1� 1�

..� 1� /�# ./�)�� 1# 1,

.1� 1� 2�. 1��#�� 1# 1,

.#� 1� ���� 1#���� 1# 1,

##� �, /�# ./�)����4�$�#�1

�������

�/ .�

#$� �, 2�. 1��#�� �/ .�

#/� �, ���� 1#���� �/ .�

,,� �. /�# ./�)����4�$�#�10,�1

�������

�, �,

,), �. 2�. 1��#�� �, �,

$�� �. ���� 1#���� �, �,

������

.�/0.1�!

�������

#$�! � �������

,),! � �������

+�) � (��-�+/� 3�-

.�/ 12 ���1 1/�,��

��4�$�#�1

������

#1 #,

..� #, �.�$ #1���� #2 ,�

.1� #, �1�/ #)���� #2 ,�

.#� #, �,�� ,��.�� #2 ,�

##� .1 �.�$ #1������4�$�#�1

�������

., .,

#$� .1 �1�/ #)���� ., .,

#/� .1 �,�� ,��.�� ., .,

,,� �/ �.�$ #1������4�$�#�10,�1

�������

.� .,

,), �/ �1�) #)���� .� .,

$�� �/ �,�� ,��.�� .� .,

�������

.�/01�!

�������

#$�! � �������

,),! � �������

+.� � (��-�+2� 3�-

.������

+1��&��-

.�/ ,. �,�� ,��1��

��4�$�#�1

������

,$ $�

..� $� �$�/ ,)�1�� $# )�

.1� $� �/�# $.�/�� $# )�

.#� $� .��� $/�1�� $# )�

�� ����

+1��&��-

##� 1� �$�/ ,)�1����4�$�#�1

�������

11 1,

#$� 1� �/�# $.�)�� 11 1,

#/� 1� .��� $/�1�� 11 1,

,,� .# �$�/ ,)�1����4�$�#�10,�1

�������

.) 1�

,), .# �/�1 $.�)�� .) 1�

$�� .# .��� $/�1�� .) 1�

���������� ���� ���� ������� ������ � �������� � ������������������� ����������������������������������������������������� �������� �������� �!�"��#�

Electric Heat Data - CHA16-036 - Three Phase

Page 10: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

1010 CHA1610

����� ������

������� ����

�� �� ��� ��

�� �����!�� ��" ��#�

�����$�� %&�!�#�&

'���&(�%)�

� �� *��+

,���-)-�� �)��

�-%����+

�� �� ��� ����"

(�%)�

�� �� ��� ���.�)#

(�%)�

*%������������ ��������/ ���) � �.�0 &

1����������!�� �� ���� ��

� �� ��)2�3)& .�0

������)2�3)& �.�0

,���-)-�� �)��

�-%����+

�0�-)-3)& ��4

��������

�������

������

),� �2��+� )�� �+

�����)������+

��� �� ,�� ��3���

&�4��� ����, � ������

&�4�� ,�� ������

�� ,�

��� �� ,�! ��3��� "� ,�

��� �� ��" ��3��� "� ,�

�"� �� ��� ��3!�� "� ,�

��������

�����

),� �2��+� )�� �+

��� "� ��, �,3���

&�4��� ����, �� ������

,� ,�

��� ,� ��" ��3��� ,� ��

��� ,� !�� ��3��� ,� ��

�"� ,� ���� �"3��� ,� ��

�������

������

)����2��+� )�� �+

��� �� ���� ��3,��

�� ��

��� �! ���� "�3��� �� !�

��� �! ���� "�3��� �� !�

�"� �! �,�� ,�3��� �� !�

�������

�����

)�!��2��+� )!� �+

��� !� �,�� ,�3��� !� ���

��� ��, ���� ,�3��� ��! ���

��� ��, ���" ��3��� ��! ���

�"� ��, ���� ��3��� ��! ���

�������

������

)�!��2��+� )!� �+

��� ��� ���� �"3��� ��� ��,

��� ��� ���� ��3��� ��� �,�

��� ��� ���� ��3,�� ��� �,�

�"� ��� �,�� �,3��� ��� �,�������� ������� � ���������� ������ ��������� ������������������������� �������������� ����������������������������� ����� �� ���� �� �������� � !�"��#�

Electric Heat Data - CHA16-048 - Single Phase

Page 11: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

11

���������������

������ ���

��� ������ ����������������

�����

������� �����

�����

��� �����

��� ��� ���

!����"�"#����

$"���

��� ����� ��

����

��� ������ % �������

�� ����������������� ��&���������%�'��

(� ������ � ����� ������

��� � ��)*+����%�'�!����"�"�#����

$"��� ��'�"�"+������,�

��������

������

��������� � �� ��

����� �� ��

���� �����

� �������� ������

��������������

��� � �� �����

��� � �� �����

�� �

��� � �� ������ � �

��� � �� ������ � �

��� � ��� ������ � �

��� �� �����

��� �� �� �� � �����

�� � ������ �

��� ��� ������ �

� � �� �����

� � �� ������

�� � ��� ������

�������

��������� � �� ��

����� �� ��

���� �����

� �������� ������

��� �� �� ����

��� � �� �����

� �

��� � ��� ������ � �

��� � ��� � ���� � �

��� � ��� ��� �� � �

��� ��� ������

��� �� �� �� � �����

�� ��� � ���� �

��� ��� ��� �� �

� � ��� ������

� � ��� � ����

�� � ��� ��� ��

�������

��������� � �� �

����� �� �

���� ��� �

� �������� ������

��� �� �� �����

��� � �� �����

�� �

��� � �� ������ � �

��� � ��� ��� �� � �

��� � �� ���� � �

��� �� �� ������

��� �� �� ��� �����

� �

�� �� ��� ��� �� � �

��� �� �� ���� � �

� � �� ������ � �

� � ��� ��� �� � �

�� � �� ���� � �

�������

���������� �� ��

����� �� ��

���� �����

���������� ������

����������������

��� � �� ����

��� � �� �����

� �

��� �� ����� ��

��� ��� ����� ��

��� ���� ����� ��

��������������

��� � �� �����

��� �� �� �� �����

�� �

�� � ��� ����� �� �

��� � ���� ����� �� �

� �� �� ����� �� ��

� �� ��� ����� �� ��

�� �� ���� ����� �� ��

�������

���������� �� ��

����� �����

���� �����

���������� ������

����������������

��� ��� �����

��� � �� �����

�� ��

��� � � �� � ��� �� ��

��� � ���� ������ �� ��

��� � ��� ����� �� ��

��������������

��� �� � �� � ����

��� �� �� �� �����

�� ��

�� �� ���� ������ �� ��

��� �� ��� ����� �� ��

� � � � � ���� �� �

� � ���� ������ �� �

�� � ��� ����� �� �

!�"�#��$� %��&$'���$#� ��'�(&�'����)�#&)��� �$(��*�'+��� �$�(���#*&'��,&#��� "+����'(�(&�)$''�)���&-��#�.+&#�*�'����/���,&#����+&������"$#���� ������ �01���0���

Electric Heat Data - CHA16-048 - Three Phase

Page 12: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

1212 CHA1612

Electric Heat Data - CHA16-060 - Single Phase

������

�������

����������

���

��������

�����

���������

����

!���"�

�����#

���$%�

�"�%�

&���%

'�$(�

�����

)��*

+����,(,

���(��

�,$����*

��������

�����!

'�$(�

��������

����-�("

'�$(�

)$�������������������

��.�����(����-�/�%0���������� �������������

�������(1�

2(%��-�/

������(1�

2(%��-�/

+����,(,

���(��

�,$����*

��/�,(,

2(%�

��3�

��<�&"�&�

+���&$"��������

��� �-���� ��� �

������

����$����

��� �� ��� ��%���

*�0�&�!�&+&�!�

�����'�

*�0�&!&��

�������

�� &�

��� �� ��( ��%��� �� &�

��� �� &�� ��%��� �� &�

��� �� ��� ��%(�� �� &�

+���&$"�������(�

��� �-���� ��� �

��� �& ��� ��%&��

*�0�&�!�&+&�!��

�������

�� &�

��� �� ��� ��%��� �( &�

��� �� (�� ��%��� �( &�

��� �� ���� ��%��� �( &�

+���&$"�'����������� �-���

��� �

��� &� ���� ��%���

!!!

�� ��

��� �( ���& ��%��� �� (�

��� �( ���� ��%��� �� (�

��� �( ���� ��%��� �� (�

+���&"�������(���(� �-���

�(� �

��� (� ���� ��%��� (� ���

��� ��� �&�� ��%��� ��� ���

��� ��� ���� &�%��� ��� ���

��� ��� ���� &�%��� ��� ���

+���&"�'���������(� �-���

�(� �

��� ��� ���� &�%��� ��� ���

��� ��� ���� ��%��� ��� ���

��� ��� ���� ��%��� ��� ���

��� ��� ���� ��%��� ��� ���

���/�.� ������������ �.�����,����*����.�������,�����#������,���.�����'�.�%�/#�����,�,���������� ��2��.�6#�.��������>���'�.��� �#���-��� /�.� ��� �������&�@1� ���@���

Page 13: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

13

Electric Heat Data - CHA16-060 - Three Phase

��������������

����������� ���

��������������

���������� ����

!���"�

�����#

���$%�

�"�%�

&���%

'�$(�

������ )��*

+����,(,

���(��

�,$����*

������������

�!�'�$(�

������������

-�("�'�$(�

)$�������������������

��.�����(����-�/�%0���������� �������������

������(1�

2(%��-�/

+����,(,����(��

�,$����*

��/�,(,�2(%�

��3�

��<�&"�&�

+���&"����+���3��������

�&�3������&����3�������������-������� �

������

����$����

��� �( ��� ��%���

*�0�&!&��

�'(;���

�� ��

��� �� ��( ��%�� �� ��

��� �� &�� ��%��� �� ��

��� �� ��� ��%(�� �� ��

��� �� ��( ��%���*�0�&!���+&��

�������

�� ��

�&� �� &�� ��%��� �� ��

��� �� ��� ��%(�� �� ��

��� ( ��( ��%���*�0�&!&��

�������

�� ��

��� ( &�� ��%��� �� ��

&�� ( ��� ��%(�� �� ��

+���&"�����+���3��������

�&�3�����������3�������������-������� �

��� �� ��� ��%&��

*�0�&!&��

�'(;���

�� ��

��� �� ��� ��%��� �� ��

��� �� (�� ��%��� �� ��

��� �� ���� ��%��� �� ��

��� �� ��� ��%&��*�0�&!���+&��

�������

�( ��

�&� �� (�� ��%��� �( ��

��� �� ���� ��%��� �( ��

��� �� ��� ��%&��*�0�&!&��

�������

�& ��

��� �� (�� ��%��� �& ��

&�� �� ���� ��%��� �& ��

+���&"�'���+���3��������

�&�3������(����3�������������-������� �

��� �� ���� ��%���

*�0�&!&��

�'(;���

�& ��

��� �& ���& ��%��� �� &�

��� �& ���� ��%��� �� &�

��� �& ���� ��%��� �� &�

��� �� ���& ��%���*�0�&!���+&��

�������

�& ��

�&� �� ���� ��%��� �& ��

��� �� ���� ��%��� �& ��

��� �� ���& ��%���*�0�&!&��

�������

�� ��

��� �� ���� ��%��� �� ��

&�� �� ���� ��%��� �� ��

+���&"�����+���3��������

�&�3�����������3�������������-�����(� �

�������

����$����

��� �� ���� ��%���

*�0�&!&��

�'(;���

�( &�

��� &� �&�� ��%��� &� ��

��� &� ���� &�%��� &� ��

��� &� ���� &�%��� &� ��

������

����$����

��� �� �&�� ��%���*�0�&!���+&��

�������

�� ��

�&� �� ���� &�%��� �� ��

��� �� ���� &�%��� �� ��

��� �� �&�� ��%���*�0�&!&��

�������

�� ��

��� �� ���� &�%��� �� ��

&�� �� ���� &�%��� �� ��

+���&"�'���+���3������'�

�&�3�����������3������'������-�����(� �

�������

����$����

��� && ���� &�%���

*�0�&!&��

�'(;���

�� ��

��� �& ���� ��%&�� �� (�

��� �& ���( ��%��� �� (�

��� �& ���� ��%��� �� (�

������

����$����

��� �� ���� ��%���*�0�&!���+&��

�������

�� ��

�&� �� ���( ��%��� �� ��

��� �� ���� ��%��� �� ��

��� �� ���� ��%���*�0�&!&��

�������

�� ��

��� �� ���( ��%��� �� ��

&�� �� ���� ��%��� �� ��

���/�.���� ����������.� ����,����*����.����� ��,�����#��� ���,���.�����'�.�%� /#�����,�,������������2��.�6#�.��������>���'�.����#���-���/�.���� �������&�@1����@���

Page 14: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

1414 CHA1614

RatingsCHA16-024 Cooling Capacity

CHA16-030 Cooling Capacity

������

���

��

� ������

� �

��� �������������������������� � �������� � �

������� ��! �����"���! #$�����%#��! ##�����%&��!

� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!

-�.��� -�.��� -�.��� -�.���

)"* 2�� �3�+� �4/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ��

�01

� �0��

�� ��� ���� � �� �� ��� �� � �� �� �� ��� ��� ��� ��� �� �� � �� ��� ��� ��� � ���� ��� �� ���

��� ��� ��� �� ��� �� ��� ��� � �� �� ��� ��� ��� ��� ���� � �� � ��� �� ��� �� �� ���� ��� ��� ���

�� � ���� ��� �� ��� �� ��� ��� � ���� ��� ��� ��� � �� �� �� � �� ��� ��� ���� �� ��� ��� ��� ���

�01

� �0��

�� ��� ���� �� �� � �� �� ��� � ��� �� ��� ��� � �� �� �� �� ��� �� ��� �� ���� �� ��� ���

��� ��� ��� ��� ��� �� ��� ��� ���� �� ���� �� �� ��� � �� �� �� � � ��� ��� ��� �� ���� �� ��� ��

�� � �� ��� ��� � ��� ��� ���� ��� ��� �� ��� �� ���� � ��� �� ��� ��� � � �� ��� � �� ���

� 01

���0��

�� ��� ��� ��� �� ��� �� � ��� �� ���� ��� � �� ���� �� ���� ��� � �� � � �� ���� ��� �� ��

��� ��� ��� ��� ��� ��� �� �� ���� ��� �� � ��� �� ��� ��� �� ��� ��� �� �� ��� � ���� �� � ���

�� � ��� ��� �� ��� �� �� ��� ��� �� � �� � ��� ���� ��� ���� �� �� ��� ��� � ���� �� � ���

����������� ����� ��� ������������� ��� ��������������� ����� ����������� ����� ���������������

������

���

��

� ������

� �

��� �������������������������� � �������� � �

������� ��! �����"���! #$�����%#��! ##�����%&��!

� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!

-�.��� -�.��� -�.��� -�.���

)"* 2�� �3�+� �4/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ��

�01

� �0��

��� ��� ���� ��� ���� ��� �� ��� �� ��� ��� ��� ��� ��� �� ��� ��� �� ��� ��� ���� �� ���� ��� ��� ���

��� ��� ���� �� ��� ��� ��� ��� ���� �� ���� ��� ��� ��� ��� ��� ��� �� �� ��� ���� ��� ���� ��� ��� ���

��� ���� ��� ���� ��� ��� ��� ��� ��� ���� ��� ��� ��� ��� ��� �� �� ��� ��� ��� �� ��� ��� ��� ���

�01

� �0��

��� ��� ���� ��� ���� �� ��� ��� ���� ��� ��� �� �� ��� ���� ��� �� �� ��� �� ��� ��� ���� �� �� ���

��� ��� ���� ��� ��� �� �� ��� ���� �� ���� � �� �� ���� �� ��� �� ��� ��� ��� ��� ���� �� �� ��

��� � � ��� ���� �� ��� ��� ���� ��� ��� �� ��� �� ���� ��� ��� � ��� ��� ��� ��� ���� �� �� ���

� 01

���0��

��� ��� � �� ��� ���� ��� � �� ���� ��� ��� ��� � �� ���� �� ���� ��� �� ��� ���� ��� ���� ��� �� ���

��� ��� ���� �� ��� ��� �� ��� � �� ��� �� ��� �� ��� ���� ��� ��� �� �� �� ���� ��� ���� �� �� ���

��� ��� ��� ���� �� � ��� � �� ��� ��� �� �� ��� ���� ��� ���� �� �� ��� ��� ��� ���� ��� � ���

����������� ����� ��� ������������� ��� ��������������� ����� ����������� ����� ���������������

Page 15: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

15

CHA16-036 Cooling Capacity

CHA16-048 Cooling Capacity

Ratings

������

���

��

� ������

� �

��� �������������������������� � �������� � �

������� ��! �����"���! #$�����%#��! ##�����%&��!

� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!� ���� �

����� ���

' � �

(�

)���

*������� � �� ��

+���

�*,�!

-�.��� -�.��� -�.��� -�.���

)"* 2�� �3�+� �4/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ���3�+� �4

/���

�%��

�$��

�/��

����

� ��

�01

� �0��

�� � ���� ��� ���� ��� ��� �� ���� ��� ���� �� �� ��� ��� �� ��� ��� ��� ��� � �� ��� ���� ��� ��� ���

��� ��� �� ���� �� ��� ��� �� ��� ���� �� ��� ��� ���� ��� ��� ��� ��� ��� ��� �� ���� ��� �� ���

��� �� ��� �� ���� ��� �� ��� ��� �� ��� ��� ��� ��� ��� ��� ��� ��� ��� ��� ���� ��� ���� �� ��� ���

�01

� �0��

�� � ���� ��� ���� � �� ��� ��� �� ���� � �� �� ���� ��� ��� � �� ��� ���� ��� ���� �� ��� ���

��� ���� �� ���� �� ��� ��� ��� ��� ���� �� ��� ��� ��� �� ��� �� �� �� ���� �� ���� �� �� ���

��� �� ���� � ���� � ��� ��� ���� � ���� � ��� �� �� ��� ��� �� �� �� �� ��� ��� �� ��� ���

� 01

���0��

�� � ��� � ��� �� �� � ���� �� ��� �� �� � ���� ��� ��� ��� �� �� �� ��� ���� ��� � ��

��� ���� �� ���� ��� � ��� ���� � ���� ��� �� �� ���� � �� ��� �� ��� �� ��� ���� ��� �� ���

��� �� � � ��� ��� ��� �� �� ��� �� ���� ��� �� ��� ���� �� ��� ��� � ��� ���� ��� �� �� �� ���

����������� ����� ��� ������������� ��� ��������������� ����� ����������� ����� ���������������

������

!��

-(�1

0��������

&���

)(����������0�,$����(������������ �����%��� ���

�452�6�758 7452�6�458 ��452�6��58 ��452�6� 58

0���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0�

9����

6�:08

;�*�-(�1 ;�*�-(�1 ;�*�-(�1 ;�*�-(�1

�/� =+� "�#$ �<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�7

&�@1

���@��

���� &�� ���� ���� ���� ��� ��� �(& ���& ���� ���( ��� ��� �(� ���� ���� ���� ��� ��� �(� ���� ���� ���� ��� ��( �

�&�� ��� �&�� ���� ���� ��& �(� ���� ���� ���� ���� ��� �(� ���� ���� ���� ���� ��� �(� ���� ���� ���� ���( ��� �(� �

�(�� (�� ���� ���� ���& ��� �(& ���� �&�� ���& ���� ��� �(� ���� ���� ���� ���( ��� �(( ���� ���� ���& ���� ��� ���� �

&�@1

��(@��

���� &�� ���� ���� ���� ��& �&� ��� �&�� ���� ���� ��& �&( ��� ���� ���� ���� ��� ��� ��� ���� ���� ���� ��� ��� �

�&�� ��� �(�� ���� ���� ��� ��� ��� ���& ���� ���& ��( ��� ��( ���� ���� ���� �&� ��& �(� ���( ���( ���� �&� ��� �

�(�� (�� ���� ���� ���( �&� ��� �(� ���& ���� ���� �&� ��� �(� �&�� ���� ���� �&� ��� �(� ���� ���� ���& �&� ��� �

��@1

���@��

���� &�� ���( ���( ���� ��� ��� �&& �(�� ���� ���( ��� ��� �&� ���� ���( ���� ��� ��� �&� ���� ���� ���� ��� ��& �

�&�� ��� ���� ���� ���� ��� ��� ��� ���� ���� ��(� ��� ��� ��� ���� ���� ���� ��� ��� ��� �&�& ���� ��(� ��� �&� �

�(�� (�� ���� ���& ���� ��� �&� ��& ���� ���� ��(� ��� �&� ��� �(�� ���� ���( ��� �&� ��( ���� ���( ��(� ��� �&� ������!�<��� 3��#����.��.��������������� ��,� ,����������#,�� ��,��.������-��'�.�����.�$����,�,#������

Page 16: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

1616 CHA1616

CHA16-060 Cooling Capacity

CHA16-024 Blower Performance @ 230 Volts (with Downflow Air Openings)

�0� ����������

� &&) �� �'��)- ����'� ��)&�.��/ ��% �&

����/��� �����# ��)-����# ��)-�5�/ 5�/

�$- 56& �$- 56& �$- 56& �$- 56&

� � ���� �", !,� ",� ��, "�, ��� ���

��, �� ���, �", !,, ",� ��� "�, ��� ��,

��� �, ��,� ��, !�� ",, ��, "�� ��, ���

��, �� ��"� ��� !�� ",, ��, "�� ��� ���

��� ,� ���� ��, !,, ",� ��� "�, ��� ���

��, �� ���� ��, !,� ",� ��, "�, ��� ���

��� �, ���� ��, !"� "", ��� "�� ��, ���

�"� ��� ���� ,�, !�� "�, �,� "�� ��� ���

�,� ��, ��,� ,", ��� "�, ��� ��, ��� �!,

��� �,� ���� ,�, ��, �!, ��, ��, ,�, ��,

��� ��, !�, "�� ��� ��� ��, �"� ,�, �,�

��, ��, !�, "�, �", �,� ��� ��� ,�� ��,%$����� 5����&#�(����&��*���+#�(��6��#'����$�����+'&��,&��� (#7�)$&�� �'(�,&��$+���&#� "&���#�

%$�����1$#������+'&��$��#��&$'�� (�#�����&#��$�+*���7��8�

Ratings

Blower Data

������

!��

-(�1

0��������

&���

)(����������0�,$����(������������ �����%��� ���

�452�6�758 7452�6�458 ��452�6��58 ��452�6� 58

0���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0�

0�����9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:080���������

�$��,$�

�����

�!

'�$(�

���%�1��� 0��0����

9����

6�:08

;�*�-(�1 ;�*�-(�1 ;�*�-(�1 ;�*�-(�1

�/� =+� "�#$ �<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�452

�75 "�#$ �

<452

��5

��52

�<5

�452

�75

&�@1

�����@��

���� ��� ���� ���� ���� ��� ��� �(( �&�� �&�� �&&� ��� ��( ���� ���� ���� �(�� ��� �(� ���� ���� ���� ���� ��� �(� ����

���� (�� &��� ���� ���� ��� �(� ���� ���� �&�� ���� ��� �(� ���� ���( �&�� ���� ��� �(� ���� ���� ���� ���� ��� �(� ����

���� ��&� &��� ���� ���� ��� �(� ���� �(�� ���� ���� ��� �(& ���� ���( �&�� ��&� ���� ���� ���� ���� ���� ���� ��� ���� ����

&�@1

��(��@��

���� ��� &��� ���� ���� ��� ��� ��� ���( ���� ���� ��� ��� ��& �&�� �&�� ���� ��( ��� ��� ���& ���� ���� ��( ��& �(�

���� (�� &��� ���� ��&� ��( ��� ��( &��& ���� ���� �&� ��& �(� ���� �&�( ���� �&� ��� �(� ���� �&�� ���� �&� ��( �(�

���� ��&� &��� �(�� ��(� �&� ��� �(� &��( ���� ���� �&� ��� �(� �(�� ���� ��(� �&� ��� �(� �&�� �&�� ���� �&� ��� �((

��@1

�����@��

���� ��� &��( ���� ���� ��� ��� ��� &��� ���� ���� ��� ��� ��� ���� ���� ���� ��� ��( ��� �&�� �&�� ���� ��� �&� ���

���� (�� &��� �(�� ���� ��� ��� ��� &��� ���� ���� ��� ��( ��� &��� ���� ���� ��� �&� ��� ���� �&�� ���� ��� �&� ���

���� ��&� &��� �(�� ��&� ��� �&� ��� &��� ���( �(�� ��� �&� ��� &��& ���� ���� ��� �&� ��� ���& ���� �&�� ��� �&� ���

�����!�<��� 3��#����.��.���� ����������� ��,� ,����������#,�� ��,��.������-��'�.�����.�$����,�,#������

Page 17: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

17

Blower Data

�0� ����������� &&)

�� �'��)- ����'� ��)&�.��/ ��% �&

����/��� �����# ��)-����# ��)-�5�/ 5�/

�$- 56& �$- 56& �$- 56& �$- 56&

� � �"�, ��, !�, "�, ��� ��, ��� �!,

��, �� �"�� ��� !�, ""� �", "�� �"� ���

��� �, ���, �,, !,, ",� ��, "�� �,, ���

��, �� ���� �", !�, "�� ��� "�, ��, ��,

��� ,� ��,, �"� !�, "�, �!� "�� ��� ��,

��, �� ���, ��� !!� "�, �!, "�� ��� ��,

��� �, ���� ��� !�, "�, �!� "�� ��� ��,

�"� ��� ���� ,!, !�, ",, ��� "�� �,� ��,

�,� ��, ��!, ,�, !�, "�� ��� �!� ��, �!�

��� �,� ���� ,�� �"� �!, ��, "�� ,�� ��,

��� ��, ���, "!� �"� �,� ��, ��� "!� ���

��, ��, !!� "�, ��, ��, ��� �!, "", ���%$��� �� 5����&#�(����&��*���+#�(� �6��#'����$�����+'&��,&��� (#7�)$&���'(�,&��$+���&#� "&���#�

%$�����1$#������+'&��$��#��&$'�� (�#�����&#��$�+*���7��8�

CHA16-024 Blower Performance @ 230 Volts (With Horizontal Air Openings)

�0� ����������� &&)

�� �'��)- ����'� ��)&�.��/ ��% �&

����/��� �����# ��)-����# ��)-�5�/ 5�/

�$- 56& �$- 56& �$- 56& �$- 56&

� � ��,, �"� ��,, ,!� ���, ,�� !�� "�,

��, �� ��", ��, ��,� ,!� ���� ,�� !�� "��

��� �, ���� ��� ��", ,!� ��!� ,�, !�, "��

��, �� ���� ��� ���, ,�, ���� ,�� !�, "��

��� ,� ��!� ��� ���� ,�, ���� ,�, !�� "��

��, �� ���� ��� ���, ,�� ��,, ,�� !�� "�,

��� �, ��", ,!� ���� ,,, ���, "!� �!� "��

�"� ��� ��!� ,�� ���� ,�, !!� "�, �,, "�,

�,� ��, ���, ,�� ���� ,�� !�, ""� ��, ���

��� �,� ��,� "!, !�� ,�� ��� "�� ��, �",

��� ��, !�� ",, ��, "�� �!� ��, �,, ���

��, ��, !�, "�� ��, �!, �", �,� ��, ��,%$��� �� 5����&#�(����&��*���+#�(� �6��#'����$�����+'&��,&��� (#7�)$&���'(�,&��$+���&#� "&���#�

%$�����1$#������+'&��$��#��&$'�� (�#�����&#��$�+*���7��8�

CHA16-030 Blower Performance @ 230 Volts (With Downflow Air Openings)

Page 18: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

1818 CHA1618

CHA16-030 Blower Performance @ 230 Volts (With Horizontal Air Openings)

Blower Data

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:%

� � ���� &�� ���� &�� ���� ��� (�� ���

��� �� ���� &�� ��(� &�� ���� ��� (�� ���

��� �� ���� &�� ���� &�� ���� ��� (�� ���

��� �� ���� &&� ���� &�� ���� ��� (�� ���

��� �� ���� &�� ��&� �(� ��(� ��� (�� ���

��� &� ��&� &�� ���� �(� ���� ��� (�� ���

��� �� ���� &�� ���� ��� ���� ��� (�� ���

��� ��� ���� &�� ���� �&� ���� �(� ��� ���

��� ��� ���� ��� ���� ��� ((� ��� ��� �(�

�&� ��� ���� ��� ���� ��� (�� ��� �(� ���

��� ��� ���� ��� ((� ��� ��� ��� ��� ���

��� ��� ���� ��� (�� ��� ��� �(� &�� ���

�����!� <�����.�,�����������#.�,��4��.��������$��#����'��$� ,. ������ ��,�'��$�#����.� /����.�

�����!�1�.����3�#�������.�����%� ,�.������.�3��#���- ��?�

CHA16-036 Blower Performance @ 230 Volts (With Downflow Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:%

� � ���� &�� ���� &�� ���� ��� (�� ���

��� �� ��(� &&� ���� &�� ���� ��� (�� ���

��� �� ���� &�� ���� &�� ���� ��� �(� ���

��� �� ��&� &�� ��(� &�� ���� ��� �(� ���

��� �� ���� &�� ���� &�� ���� ��� ��� ���

��� &� ���� &�� ���� �(� ��(� ��� ��� ���

��� �� ���� &�� ���� ��� ���� ��� �&� ���

��� ��� ��&� �(� ��(� �&� ��&� ��� ��� ���

��� ��� ���� ��� ���� ��� ���� ��� ��� �(�

�&� ��� ���� ��� ���� ��� (�� �&� ��� ���

��� ��� ���� ��� ���� �(� (�� ��� ��� ���

��� ��� ���� ��� ���� ��� �(� ��� &�� ���

�����!� <�����.�,�����������#.�,��4��.��������$��#����'��$� ,. ������ ��,�'��$�#����.� /����.�

�����!�1�.����3�#�������.�����%� ,�.������.�3��#���- ��?�

Page 19: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

19

CHA16-036 Blower Performance @ 230 Volts (With Horizontal Air Openings)

Blower Data

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:%

� � ��(� ��� ��&� &(� ���� ��� (�� ���

��� �� ���� &(� ���� &�� ���� ��� (�� ���

��� �� ���� &�� ���� &�� ���� ��� (�� ���

��� �� ���� &�� ��(� &&� ���� ��� �(� ���

��� �� ���� &�� ���� &�� ���� ��� �(� ���

��� &� ���� &&� ���� &�� ���� ��� ��� ���

��� �� ���� &�� ���� &�� ��(� ��� ��� ���

��� ��� ���� &�� ���� &�� ���� ��� ��� ���

��� ��� ���� &�� ���� ��� ���� ��� ��� �(�

�&� ��� ���� ��� ��(� �&� (�� �&� �(� ���

��� ��� ���� �&� ���� ��� (�� ��� ��� ���

��� ��� ��&� ��� ���� ��� (�� ��� &(� ���

�����!� <�����.�,�����������#.�,��4��.��������$��#����'��$� ,. ������ ��,�'��$�#����.� /����.�

�����!�1�.����3�#�������.�����%� ,�.������.�3��#���- ��?�

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � �&�� �&� ��&� &(� ���� ���

��� �� �&�� ��� ���� &�� ���� ���

��� �� ���� ��� ���� &�� ���� ���

��� �� ���� ��� ��(� &&� ��(� ���

��� �� ���� ��� ���� &�� ��(� ���

��� &� ���� ��� ��&� &�� ���� ���

��� �� ��&� &(� ���� &�� ���� ���

��� ��� ���� &&� ���� &�� ���� �(�

��� ��� ���� &�� ���� ��� ���� ���

�&� ��� ��&� �(� ��&� ��� (�� ���

��� ��� ���� ��� ���� ��� ��� ���

��� ��� ���� ��� ���� �(� ��� ���

����� !� <�����.�,�����������#.�,� �4��.��������$��#����'��$� ,. ��������,�'��$�#����.� /����.�

CHA16-036 Blower Performance @ 460/475 Volts (With Downflow Air Openings)

Page 20: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2020 CHA1620

CHA16-036 Blower Performance @ 460/475 Volts (With Horizontal Air Openings)

Blower Data

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � ���� ��� ��(� ��� ���� ���

��� �� �&�� �(� ��&� ��� ���� ���

��� �� �&�� ��� ���� ��� ���� ���

��� �� �&�� ��� ���� ��� ���� ���

��� �� �&�� �&� ��(� ��� ��(� ���

��� &� ���� ��� ���� &(� ���� ���

��� �� ���� ��� ���� &�� ���� ���

��� ��� ���� &(� ���� &�� ���� �(�

��� ��� ���� &&� ���� &�� ���� ���

�&� ��� ���� &�� ��&� �(� (&� ���

��� ��� ���� ��� ���� �&� ��� ���

��� ��� ���� ��� ���� ��� ��� �(�

����� !� <�����.�,�����������#.�,� �4��.��������$��#����'��$� ,. ��������,�'��$�#����.� /����.�

CHA16-048 Blower Performance @ 230 Volts (With Downflow Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:%

� � ��&� (�� ���� ��� ���� ��� ���� &��

��� �� ���� (�� ���� ��� ���� ��� ���� &��

��� �� ���� (&� �&(� ��� ��(� ��� ���� &��

��� �� ���� (�� �&�� �(� ���� ��� ��(� &��

��� �� ���� (�� �&&� ��� ���� &(� ��(� &��

��� &� �(�� (�� �&�� ��� ���� &(� ���� &��

��� �� �(�� (�� �&�� ��� ���� &�� ���� &��

��� ��� ���� �(� �&�� ��� ���� &�� ��&� �(�

��� ��� ���� ��� ��&� ��� ��(� &&� ���� ���

�&� ��� ���� ��� ���� ��� ��&� &�� ���� ���

��� ��� �&�� ��� �&�� ��� ���� &�� ���� ���

��� ��� �&�� ��� ���� &�� ��(� &�� ���� ���

�����!� <�����.�,�����������#.�,��4��.��������$��#����'��$� ,. ������ ��,�'��$�#����.� /����.�

�����!�1�.����3�#�������.�����%� ,�.������.�3��#���- ��?�

Page 21: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

21

CHA16-048 Blower Performance @ 230 Volts (With Horizontal Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:%

� � ���� ���� ���� ��� ���� ��� ���� &��

��� �� ���� ���� ���� ��� ���� ��� ���� &��

��� �� ��(� (�� ���� ��� ���� ��� ��(� &��

��� �� ���� (�� ���� ��� ���� ��� ��(� &��

��� �� ���� (&� ���� ��� ���� ��� ���� &��

��� &� ���� (�� ���� ��� ��(� ��� ���� &��

��� �� �((� (�� ���� ��� ���� ��� ���� &��

��� ��� �(�� (�� �&&� ��� ��&� &(� ��&� �(�

��� ��� ���� ��� �&�� ��� ���� &�� ���� ���

�&� ��� ���� ��� ���� ��� ���� &&� ���� ���

��� ��� ���� ��� ���� ��� ���� &�� ���� ���

��� ��� �&�� ��� ��(� ��� ���� &�� ���� ���

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

����� !� 1�.����3�#���� ���.�����%� ,�.������.� 3��#���- ��?�

Blower Data

CHA16-048 Blower Performance @ 460/475 Volts (With Downflow Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � ���� ���� ���� ��� ���� ���

��� �� ���� ���� ���� ��� ���� ���

��� �� ���� (�� ���� ��� ���� ���

��� �� ���� (&� ���� ��� ���� ���

��� �� ���� (�� �&(� ��� ��&� ���

��� &� �(�� (�� �&�� �(� ��&� ���

��� �� �(�� (�� �&&� ��� ���� ���

��� ��� ���� ��� �&�� �&� ���� ���

��� ��� ��(� ��� ���� ��� ���� ���

�&� ��� ���� ��� ���� ��� ���� ���

��� ��� �&�� �&� ���� &�� ���� ���

��� ��� ���� ��� ���� &�� ���� ���

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

Page 22: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2222 CHA1622

CHA16-048 Blower Performance @ 460/475 Volts (With Horizontal Air Openings)

Blower Data

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" 5�,�#� ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:% �#, =:%

� � ���� ���� ��(� ���� ���� ���� �(�� (�� �&�� �&�

��� �� �&(� ���� ���� ���� ���� ���� �(�� (�� �&�� �&�

��� �� �&&� ��&� ���� ���� ���� ���� �(�� (�� �&�� �&�

��� �� �&�� ���� ���� ���� ��&� ���� �(�� (�� �&�� �&�

��� �� �&�� ���� ��(� ���� ���� ���� ��(� �(� ��(� ���

��� &� ���� ���� ��&� ���� ���� ���� ���� ��� ���� ���

��� �� ���� ���� ���� ���� ���� ���� ��&� ��� ��&� ���

��� ��� ���� ���� ���� ���� ��&� (�� ���� �&� ���� ���

��� ��� ���� ���� ���� ���� ���� (�� ��&� ��� ���� ���

�&� ��� ���� ���� ���� ���� �(�� (�� ���� ��� ���� &��

��� ��� ���� ���� ���� (�� ���� ��� �&&� ��� ���� &&�

��� ��� ���� ���� ���� (&� ���� ��� �&�� �&� ���� &��

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

����� !� 1�.����3�#���� ���.�����%� ,�.������.� 3��#���- ��?�

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � ��&� ���� ���� ��� ���� ���

��� �� ���� ���� ���� ��� ���� ���

��� �� ��(� ((� ��(� ��� ���� �&�

��� �� ��&� (�� ���� ��� ���� �&�

��� �� ���� (�� ��&� ��� ��(� �&�

��� &� �((� (�� ���� ��� ��(� �&�

��� �� �(�� (�� ���� ��� ���� �&�

��� ��� ���� �(� �&(� ��� ���� ���

��� ��� ���� ��� �&�� ��� ���� ���

�&� ��� ���� ��� ���� ��� ���� ���

��� ��� �&�� �&� ��(� ��� ��&� ���

��� ��� ��&� ��� ���� &�� ���� �(�

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

CHA16-060 Blower Performance @ 230 Volts (With Downflow Air Openings)

Page 23: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

23

Blower DataCHA16-060 Blower Performance @ 230 Volts (With Horizontal Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(,���" 5�,�#� ����(,�=�. =�.

�#, =:% �#, =:% �#, =:% �#, =:% �#, =:%

� � ���� ���� ���� ��(� ���� ��&� �(�� (�� �&�� ���

��� �� ���� ���� ���� ���� ���� ���� �(&� (�� �&�� ���

��� �� ��(� ���� ���� ���� ���� ���� �(�� (�� �&�� ���

��� �� ��&� ���� ���� ��&� ���� ���� �(�� (�� �&�� ���

��� �� ���� ���� ���� ���� ��&� ���� �(�� (�� �&�� �&�

��� &� �&�� ��&� ���� ���� ���� ���� �(�� (�� �&�� ���

��� �� �&�� ���� ���� ���� ���� ���� ��(� �(� ���� ���

��� ��� ���� ���� ���� ��(� ���� (�� ��&� ��� ��&� ���

��� ��� ���� ���� ���� ���� ���� (�� ��(� ��� ���� ���

�&� ��� ���� ���� ���� ���� �(&� (�� ���� ��� ���� &(�

��� ��� ���� ���� ���� ���� �(�� �(� �&(� ��� ���� &��

��� ��� ���� ���� ���� (�� ��&� ��� �&�� ��� ��(� &��

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

����� !� 1�.����3�#���� ���.�����%� ,�.������.� 3��#���- ��?�

CHA16-060 Blower Performance @ 460/475 Volts (With Downflow Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � ���� ���� ���� ���� �(�� (��

��� �� �&�� ��&� ��&� ���� ��(� �(�

��� �� �&�� ���� ���� ��(� ���� ���

��� �� ��(� ���� ��(� ���� ���� ���

��� �� ���� ���� ���� ��&� ���� ���

��� &� ���� ���� ���� ���� ���� �&�

��� �� ���� ���� ��(� ���� ��(� ���

��� ��� ��(� ���� ���� ���� ���� ���

��� ��� ���� ��(� ���� (&� �&�� �(�

�&� ��� ���� ���� �(�� (�� ���� ���

��� ��� ���� ���� �(�� �(� ��&� ���

��� ��� ���� ((� ��&� ��� ���� ���

�����!�<�����.� ,�����������#.�,��4��.���� ��� �$��#����'��$�,. ������ ��,�'��$�#�� ��.�/����.�

Page 24: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2424 CHA1624

Blower DataCHA16-060 Blower Performance @ 460/475 Volts (With Horizontal Air Openings)

�/�������������

���%%(������&��(,�����&����(%�-��.����$���%

����.��� ����" ����(, =�.

�#, =:% �#, =:% �#, =:%

� � ���� ���� ���� ���� �(�� (��

��� �� ���� ���� ���� ���� �(�� (��

��� �� ��&� ���� ���� ���� �(�� (��

��� �� ���� ���� ���� ��(� ���� �(�

��� �� �&�� ��&� ���� ���� ���� ���

��� &� �&�� ���� ���� ���� ���� ���

��� �� �&�� ���� ���� ���� ���� �&�

��� ��� ���� ���� ���� ���� ���� ���

��� ��� ���� ���� ���� ���� ���� ���

�&� ��� ���� ���� �((� (�� �&�� ���

��� ��� ���� ���� �(�� (�� ��(� ���

��� ��� ���� ���� ���� ��� ���� ���

�����!�<�����.�,�����������#.�,��4��.��������$��#���� '��$�,. ��������,�'��$�#����.�/����.�

Page 25: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

25

����

�����

���

����&��(,�

0���������9�%�%�������� ���"�%�.�������(���6��8

�>�6�4�,,8

2�����

2(���%"��

9��;� �;�.��2��.� �����,�3����;� ����3�����

�����,�3��

�#, =:%=�%%

2�����

!��"�)$������

�������

���*�%���

�>�64��,,8

2�����

!��"�)$������

2�1�����%%

�>�64�,,8

2�����

!��"

2(���%"��

�>�6�4�,,8

2�����

=�%%

2�����

�0<�&!���

�0<�&!���

�0<�&!��&

��� ��� �������� �������� �����&�� �������� �������� ��������

���� ��� �������� ��&����� �������� �������� ��&��&�� ��������

���� �&� �������� ��(����� ��������� �����&�� �������� ��������

���� &&� �����&�� �������� ��������� �������� ��&������ ��(�����

�0<�&!���

�0<�&!�&�

�&�� ��� �������� �������� �����((� �����&�� �������� ��������

���� ��� �������� ��&����� �������(� �������� �������� ��(�����

���� (�� �������� �������� ��&����(� ��(��(�� �����((� ��������

���� ���� �������� �������� �&&���&�� ��&������ ��������� ��&�����

��������������

����&��(,�0���������9�%�%�������� ���"�%�.�������(���6��8

90;7� 4�;�##(%��

2;7� 4�;�##(%���#, =:% �����%�)$��

������������%

)$��

�������%� �����%

)$��

�0<�&!���

�0<�&!���

�0<�&!��&

��� ��� �������� �������� �������� ��������

���� ��� ��(����� ��&����� �������� ��������

���� �&� �����&�� �������� �������� ��������

���� &&� �������� ��&��&�� �������� ��������

�0<�&!���

�0<�&!�&�

�&�� ��� ��������� �������� �������� �����&��

���� ��� ��&����(� �����(�� �������� ��������

���� (�� ��������� ��������� ��&��(�� ��&��(��

���� ���� �(�����&� �&������� �������(� �������(�

Filter and Accessory Air Resistance

Diffuser Air Resistance

Accessory Blower Data

Page 26: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2626 CHA1626

Step-Down Ceiling

Diffuser Air Throw Data

Accessory Blower Data

Wet Indoor Coil Air Resistance

��������� 90;7� 4 2;7� 4

����&��(,� ���##����?��0"��. ��##����?��0"��.

�/� =+� /�� � /�� �

���� ��� ��!�� �!� ��!�� �!&

���� �&� ��!�� �!& �&!�� �!�

���� &&� ��!�( �!& ��!�� �!�

�&�� ��� ��!�� �!& ��!�� �!�

���� ��� ��!�� �!& ��!�� &!(

���� (�� ��!�� �!� ��!�( &!(

���� ���� �&!�� �!� ��!�� �!(�*//����3�� �$.�'�-���,���� ��.������ 3���������� �/���� /�������(������.

���#���

�����

�(,1��

����&��(,� ����9�%�%�����

�#, =:% ����.��� ��

�0<�&!���

��� ��� ��& ��

���� ��� ��� ��

���� �&� ��� ��

�0<�&!���

��� ��� ��( ��

���� ��� ��� ��

���� �&� ��� ��

�0<�&!��&

��� ��� ��( ��

���� ��� ��� ��

���� �&� ��� ��

���� &&� ��� ��

�0<�&!���

�&�� ��� ��� ��

���� ��� ��� ��

���� (�� ��� ��

���� ���� ��� ��

�0<�&!�&�

�&�� ��� ��� ��

���� ��� ��( ��

���� (�� ��� ��

���� ���� ��� ��

Page 27: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

27

Guide Specifications

Prepared for the guidance of architects, consulting engineers andmechanical contractors.

General - Furnish and install single package air to air DXmechanical cooling system, complete with automatic controls. The singlepackage unit shall be a standard product of a firm regularly engaged in themanufacture of heating-cooling equipment. The manufacturer shall have partsand service available throughout the U.S. and Canada.

The installed weight shall not be more than........lbs. (kg). Entireunit shall have a width of not more than.....inches (mm), a depth of not morethan......inches (mm) and an overall height of not more than.....inches (mm).The equipment shall be shipped completely factory assembled, precharged,piped and wired internally ready for field connections. In addition, manufac-turer shall test operate system at the factory before shipment.

Air Distribution - Equipment shall be capable of bottom(downflow) or side (horizontal) handling of conditioned air. All air distributionducts shall be fiberglass or .....ga. galvanized steel insulated with .....inch(mm) thick .....lb./ft.³ (kg/m³) density fiberglass or equivalent.

Approvals - All electrical components shall have U.L. and U.L.C.Listing. All wiring shall be in compliance with NEC and CEC.

Equipment Warranty - Compressors have a limited warranty fora full five years. All other components have a limited warranty for one year.Refer to the Equipment Limited Warranty certificate included with the unit fordetails.

Cooling System - The total certified cooling capacity shall not beless than.....Btuh (kW) with an evaporator air volume of .....cfm (L/s), anentering wet bulb air temperature of .....ºF (ºC), an entering dry bulb airtemperature of .....ºF (ºC) and a condenser entering temperature of .....ºF (ºC).The compressor power input shall not exceed ......kW at these conditions.

The coils shall be nonferrous construction with aluminumenhanced fins mechanically bonded to durable copper tubes. Coils shall bepressure leak tested. Coil face area shall be not less than .....sq. ft. (m²)(evaporator) and .......sq. ft. (m²) (condenser). Condenser coil shall be formedcoil construction.

The compressor shall be resiliently mounted, have overloadprotection and internal pressure relief. 024 & 030 models shall havecompressor crankcase heater. 036, 048 and 060 models shall have scrollcompressors. The refrigeration system shall have suction and liquid lineservice gauge ports, liquid line strainer and full refrigerant charge. Allmodels shall have high pressure switch and lfreezestat. Control options shallconsist of thermostat, timed-off control and low ambient control. Shall berated in accrodance with ARI Standard 210/240-94 and DOE test procedures.

Cabinet - Shall be galvanized steel with a powdered enamel paintfinish electrostatically bonded to the metal. Cabinet panels where condi-tioned air is handled shall be fully insulated to prevent sweating andminimize sound. Openings shall be provided for power connection entry.Evaporator coil condensate drain extended outside cabinet shall be provided.Lifting brackets shall be provided for rigging. All models shall have lowvoltage terminal strip.

Service Access - All components, wiring and inspection areasshall be completely accessible through removable panels.

Supply Air Blowers - Centrifugal supply air blower shall bedriven by a multi-speed direct drive motor and be capable of delivering.....cfm (L/s) at an external static pressure .... inches water gauge (Pa) requiring.... bhp (W) and .... rpm. Blower shall be staticaly and dynamically balanced.

Condenser Fan(s) - Direct drive propeller type condenser fan(s)shall discharge vertically and be direct driven by a ....hp (W) motor. Fanmotor shall be permanently lubricated and inherently protected. Fan(s) shallhave a safety guard.

Air Filters - Disposable filters furnished shall have not less than.....sq. ft. (m²) of free area.

Optional AccessoriesAdditive Electric Heaters - The certified total heating

capacity output shall be .....Btuh with ........kW input at.......volts powersupply. Optional electric heaters shall be field installed. Heatingelements shall be nichrome bare wire exposed directly to the air stream.ECH16R safety devices shall consist of limit controls and thermal cut-offsafety fuses. ECH16 safety devices shall consist of limit controls andfuse block. ECH16-20 and 24kW (208/230v-3ph) heaters shall havethermal time delay between each element. Heaters shall be U.L. andU.L.C. listed. Optional heater sub-fuse box shall be available for ECH16Relectric heaters for single point power supply applications.

Roof Mounting Frame - Furnish and install a steel roofmounting frame for bottom discharge and return air duct connection. Itshall mate to the bottom perimeter of the equipment. When flashed intothe roof it shall make a unit mounting curb and provide weatherproof ductconnection and entry into the conditioned area. Flashing shall be theresponsibility of a roofing contractor. RMF16 frame shall be approved byU.S. National Roofing Contractors Association.

Economizer Damper Section - Funish and install completewith controls an air mixing damper assembly including outdoor air andrecirculated air dampers. REMD16 shall include pressure operated gravityexhaust dampers. The assembly shall provide for the introduction ofoutside air for minimum ventilation and free cooling. Damper motor shallbe 24 volt fully modulating or three position spring return. Controls shallinclude electronic discharge air sensor, minimum position switch, andsolid-state adjustable enthalpy control. Control option available shallconsist of differential enthalpy control (return air sensor).

Horizontal Gravity Exhaust Dampers - Pressure operateddampers shall install in return air duct for horizontal applications. Damperblades shall ride in nylon bearings and be gasketed for tight seal andquiet operation.

Outdoor Air Damper Section - Optional manual outdoordampers shall be available to provide outdoor air requirements of up to25%. Damper section field installs external to the unit. Shall be equippedwith outdoor air hood filter for extra air filtering and bird screen protec-tion.

Stand-Off Mounting Kit - Optional kit shall be available toelevate unit about mounting surface in horizontal applications.

Roof Curb Power Entry Kit - Optional kit shall providepower entry to the unit through thte roof mounting frame.

Ceiling Diffusers - Funish and install a (flush or stepdown)optional combination ceiling supply and return air diffuser. It shall becapable of not less then ..... ft. (m) radius of effective throw. Supply andreturn transitions shall be available, for field installation in the roofmounting frame, to provide duct connection to the diffuser.

Single Point Power Source Sub-Fuse Box - Optional boxshall field install internal to the unit and provide single point powersource connection and sub-fusing for unit. Shall be galvanized steel withmounting holes, electrical inlets and hinged cover.

Page 28: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

2828 CHA1628

Basic Unit Dimensions - Inches (mm)Corner Weights Center of Gravity

�������(,1���� -- ;;

�1%� �� �1%� �� �1%� �� �1%� ��

�0<�&!��� &� �� &� �( (� �� �� �(

�0<�&!��� && �� �� �� ��� �& (� ��

�0<�&!��& &� �( &� �� (� �� (� ��

�0<�&!��� �� �( (� �� ��� &� ��& ��

�0<�&!�&� (� �� (( �� ��& && ��& &�

�������(,1��� - ; � 2 @

���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,,

�0<�&!���

�0<�&!���

�0<�&!��&

�& ��&� &� ���� �� ��� �� ��� �� ��� �� ��� �� ���

�0<�&!���

�0<�&!�&��� ���� ����+� ���� �( ��� �� ��( �� ��� �� ��( ���+� �(�

����������� � � � �

���� ���� ���� ���� ���� ����

�$%��&'()�$%��&'*'�$%��&'*�

* �� ) �'( �� �+( ��" ( "� �*� *+) *), " �(�

�$%��&')-�$%��&'�'

" �(� * �� �� �+- �"� " �(� �*� *+) *), - ('*

$� %�����������&������� �����'(��)"��)"�*������� %������������+������!�,����#������'(��)�"�)�"*�������

�������(,1���� 22

���" ,, ���" ,,

�0<�&!���

�0<�&!���

�0<�&!��&

�( ��� �� &�&

�0<�&!����� ��( �� ���

�0<�&!�&�

Page 29: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

29

Accessory Dimensions - inches (mm)CHA16 Unit with REMD16 Economizer Damper Section

and RMF16 Roof Mounting Frame

Corner Weights Center of Gravity

�������(,1���� 22

���" ,, ���" ,,

�0<�&!���

�0<�&!���

�0<�&!��&

����+� &(( ����+� ���

�0<�&!���

�0<�&!�&�����+� ��� ����+� &��

�������(,1���� -- ;;

�1%� �� �1%� �� �1%� �� �1%� ��

�0<�&!��� ��� �& ��� �� ��� �( (� ��

�0<�&!��� ��� �� ��� �( ��& �� (� ��

�0<�&!��& ��� �( ��& �� ��� �� (& ��

�0<�&!��� ��� && ��� �� ��� &� ��& ��

�0<�&!�&� ��� �� ��� �� ��� �� ��� &�

�������(,1��� - ; � 2 +@ + A

���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,,

�0<�&!���

�0<�&!���

�0<�&!��&�& ��&� &� ���� �� ��� ����+� ��� �&��+� ��� ��+� �( !!! !!! !!! !!! !!! !!!

�0<�&!���

�0<�&!�&��� ���� ����+� ���� �( ��� ����+� ��� ����+� ��� ���+� �� � ��� �& ��& ���+� �(

�;����������.�/����� #����'��$��51�&!�����#����� /.����

Page 30: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

3030 CHA1630

Accessory Dimensions - inches (mm)CHA16 Unit with EMDH16 Horizontal Economizer Damper Section and

GEDH16-65 Gravity Exhaust Dampers

OAD3-46/65 Manual Minimum Outdoor Air Damper

�����

�(,1��

� - ; � 2 @ A B =

���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,,

�0<�&!���

�0<�&!���

�0<�&!��&&� �&�� ����+� ���� �& &&� �� ��� �& ��&� �& &&� (��+� ��� � �& � �& �� &�� �� ���

�0<�&!���

�0<�&!�&��(��+� ���( (� ���� ����+� ��� �( ��� �� ���� ����+� ��� �� ��� ���+� �� � ��� ����+� ��� �� ��(

Page 31: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

31

Accessory Dimensions - inches (mm)

Base Bottom Side Panel

Fiberglass

Insulation

(Furnished)

Nailer Strip

(Furnished)

Counter Flashing

(Field Supplied)

RMF16 Roof

Mounting FrameCant Strip

(Field Supplied)

Roofing

Material

Rigid Insulation

(Field Supplied)

�������(,1��� - ; � 2

���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,,

�51�&!���'��$�)���&!&� �&��+� ���� ����+� ���� ����+� ���� ����+� ���� �� ��� !!! !!!

�51�&!&��'��$�)��&!&� &( ���� &���+� �&&� ����+� ���� �&��+� ��(� � ��� � ���

����+�����$��� ��������/�.��0<�&!���%����%� ��&�

RMF16-41 & 65 Roof Mounting Frame with Double Duct Opening for CHA16 Units

RMF16-41 & 65 Roof Mounting Frames with SRT16-65 Supply and Return Air

Transisitons for FD9-65 & RTD9-65 Ceiling Diffusers

Typical Flashing Detail for

RMF16 Roof Mounting Frame

�����

�(,1��

� - ; � 2 @

���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,, ���" ,,

�51�&!�� �&��+� ���� ����+� ���� ����+� ���� ����+� ���� ����+� &�( ����(+�& ��� �� ��� !!! !!!

�51�&!&� &( ���� &���+� �&&� ����+� ���� �&��+� ��(� ����+� &�& ����+� ��� � ��� � ���

����+�� ���$��� �������/�.��0<�&!���%����%� ��&�

Page 32: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

3232 CHA1632

Accessory Dimensions - inches (mm)

Combination Ceiling supply and Return Diffusers

Page 33: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

33

Installation Clearances - inches (mm)

CHA16 Basic Unit

CHA16 with REMD16 Economizer Damper

CHA16 Unit with EMDH16 Horizontal Economizer and

GEDH16-65 Gravity Exhaust Dampers

Page 34: Packaged Unit Cooling & Electric Heat - Allied Commercial€¦ · CHA16-024-030-036-048-060 Cooling & Electric Heat Packaged Unit. 22 2 CHA16 Model Number Guide

All specifications are subject to changewithout notice.

by Armstrong Air Conditioning Inc.421 Monroe Street • Bellevue, OH 44811

(419) 483-4840

Form #CHA16-024-060 -100 (2/02) ©Armstrong Air Conditioning Inc. 2002Printed in U.S.A. www.aac-inc.com *CHA16-024-060-100-2-02*