Oe Dealer Claim Form 20mc Final
1
Serial No: Dealer Name & Address: Customer Name & Address: A. Vehicle Details Original Warranty Card Original / Photo Copy of Vehice Service Book Ah Capacity B. Battery Details Brand Mfg. Code Designation Claim Form Made By: Ph. No: E. Mail: Complaint Date Ph.No: E. Mail: OED SAP Code Vehicle Make(Manufacturer) Model: OE MC DEALER CLAIM FORM - BATTERY (Ref: DCF-1A - MC/08) Claim Form No: Date Date of Sale Reg. No. KMS Covered Documents Enclosed Complaint Details Photocopy of RC book Original / Copy of Vehicle Sale Bill / Invoice C. Customer Complaint: ( Please give the customer voice in words of the customer only) Corroded Damaged Excess Above MAX Low below MIN SN PARAMATER SPECIFICATIONS OCV C1 C2 C3 C4 C5 C6 CCV OCV C1 C2 C3 C4 C5 C6 2 MEASURED VALUES At time of receipt OCV 12.5V. Sp.Gr. 1.24 - 1.25 (100% SOC) Charging not reqd. 1 Container Electrolyte Level Deformed D. Battery Inspection Details END Voltage on LOAD Tester 4 Appearance Check Terminals Damaged Test in Vehicle :1. Voltage at Battery Terminal with all Constant loads ON @ Engine Idle rpm. Specify Idle RPM:______________ 2. Current to be taken at the Pos. Cable. OCV 12.3V. Sp.Gr. 1.21 - 1.22 (80% SOC) Charging Reqd. OCV 12.1V. Sp.Gr. 1.17 - 1.18 ( 50% SOC) Charging Reqd. After Re - Charging a) Battery Open Circuit Voltage & Specific Gravity in Each Cell b) Close Circuit Voltage (CCV) E. Observations / Investigation of complaint by OE Dealer F. Decision / Remark by Exide Service Engineer (Name & Signature of SE) - Date: _______________ 1. Current to be +ve. 1. Voltage _________ V 2. Current _______Amps
-
Upload
sunny-kumar -
Category
Documents
-
view
6.342 -
download
1.130
Transcript of Oe Dealer Claim Form 20mc Final
Serial No:
Dealer Name & Address:
Customer Name & Address:
A. Vehicle Details
Original Warranty CardOriginal / Photo Copy of Vehice Service
Book
Ah Capacity
B. Battery Details
Brand
Mfg. Code
DesignationClaim Form Made By:
Ph. No:
E. Mail:
Complaint Date
Ph.No:
E. Mail:
OED SAP Code
Vehicle Make(Manufacturer)
Model:
OE MC DEALER CLAIM FORM - BATTERY (Ref: DCF-1A - MC/08)
Claim Form No:
Date
Date of Sale
Reg. No.
KMS Covered
Documents Enclosed
Complaint Details
Photocopy of RC book Original / Copy of Vehicle Sale Bill / Invoice
C. Customer Complaint: ( Please give the customer voice in words of the customer only)
Corroded Damaged Excess
Above MAX
Low below
MIN
SN PARAMATER SPECIFICATIONS
OCV C1 C2 C3 C4 C5 C6
CCV
OCV C1 C2 C3 C4 C5 C6
2
MEASURED VALUES
At time of receiptOCV 12.5V.
Sp.Gr. 1.24 - 1.25
(100% SOC)
Charging not reqd.
1
Container Electrolyte Level
Deformed
D. Battery Inspection Details
END Voltage on LOAD Tester
4
AppearanceCheck Terminals
Damaged
Test in Vehicle :1. Voltage at Battery Terminal with all Constant loads
ON @ Engine Idle rpm. Specify Idle RPM:______________
2. Current to be taken at the Pos. Cable.
OCV 12.3V.
Sp.Gr. 1.21 - 1.22
(80% SOC)
Charging Reqd.
OCV 12.1V.
Sp.Gr. 1.17 - 1.18
( 50% SOC)
Charging Reqd.
After Re - Charging
a) Battery Open Circuit
Voltage & Specific
Gravity in Each Cell
b) Close Circuit Voltage
(CCV)
E. Observations / Investigation of complaint by OE Dealer
F. Decision / Remark by Exide Service Engineer
(Name & Signature of SE) - Date: _______________
1. Current to be +ve.1. Voltage _________ V
2. Current _______Amps
