NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT
-
Upload
farah-nawaz -
Category
Documents
-
view
1.550 -
download
24
description
Transcript of NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT
![Page 1: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/1.jpg)
NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES
PRESENTED BY -
CHANDAN ASHISH (118/08)
FARAH NAWAZ (138/08)
![Page 2: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/2.jpg)
Nondestructive testing (NDT) is a wide group of analysis techniques used to evaluate the properties of a material, component or system without causing damage.
INTRODUCTION
Non Destructive Testing
![Page 3: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/3.jpg)
TYPES OF TESTING OF CONCRETE STRUCTURES
DESTRUCTIVE TESTING
NON-DESTRUCTIVE
TESTING
![Page 4: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/4.jpg)
DESTRUCTIVE TESTING
Stress Testing Crash Testing Hardness Testing
Destructive testing of a 6-storey concrete building using a shake table
![Page 5: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/5.jpg)
TYPICAL DEFECTS IN CONCRETE STRUCTURES
Cracks due to concrete settling Sketch of exposed aggregate
![Page 6: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/6.jpg)
Cracks due to differential settlement Rusting of reinforcing bars
![Page 7: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/7.jpg)
Effect of atmospheric conditionsCracks due to bending and shear stresses
![Page 8: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/8.jpg)
SCHMIDT REBOUND HAMMER TEST
Principle : It works on the principle that the rebound of an elastic mass depends on the hardness of the surface against which the mass impinges.
Schmidt Rebound Hammer
![Page 9: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/9.jpg)
A cutaway schematic view of the Schmidt rebound hammer.
![Page 10: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/10.jpg)
Relationship between Compressive strength of concrete and Rebound Number
![Page 11: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/11.jpg)
CARBONATION DEPTH MEASUREMENT TEST
Carbonation of concrete occurs when the carbon dioxide, in the atmosphere in the presence of moisture, reacts with hydrated cement minerals to produce carbonates, e.g. calcium carbonate
t = (d/k)2
Where, t = carbonation time d = concrete cover k = permeability
Concrete Grade Permeability 15 17 20 10 25 6 30 5 35 4 40 3.5
![Page 12: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/12.jpg)
Estimation of depth of Carbonation
7.2 R2(4.6x – 1.76)2 C2
Where, y = Age of building in years x = Water-Cement Ratio C = Carbonation depth R = Constant (R= αβ)
y =
![Page 13: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/13.jpg)
ULTRASONIC TESTING – Pulse Velocity Test
A pulse of longitudinal vibrations is produced by a transducer, which is held in contact with one surface of the concrete under test. Electronic timing circuits enable the transit time T of the pulse to be measured.
Longitudinal pulse velocity (in km/s or m/s) is given by:
v = L/T where , v = Longitudinal pulse velocity L = Path Length T = Time taken by the pulse to traverse that length.
![Page 14: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/14.jpg)
Transducer Arrangement
Direct transmission Semi-direct transmission
Indirect or surface transmission
Key : Transmitter (T) Receiver (R)
![Page 15: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/15.jpg)
(a) Results for concrete with the top 50 mm of inferior quality(b) Results for homogeneous concrete.
Pulse velocity determination by indirect (surface) transmission.
![Page 16: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/16.jpg)
RADIOGRAPHIC TESTING
The intensity of a beam of X rays or gamma rays suffers a loss of intensity while passing through a material. The amount of radiation lost depends on the quality of radiation, the density of the material and the thickness traversed
The relationship between the intensity of photons incident and transmitted is:
I = I0 e-µx
Where, I = Transmitted photon intensity I0 = Incident photon intensity µ = Attenuation coefficient x = Thickness of object
![Page 17: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/17.jpg)
Equipment for Radiographic Testing :
X-Ray Equipment Gamma Rays Equipment
Principle of radiography
![Page 18: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/18.jpg)
X-Ray Image of reinforced concrete column
X-Ray Equipment
![Page 19: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/19.jpg)
Other Non Destructive testing Methods
Ground Penetration RadarHalf Cell Electrical Potential MethodPermeability TestInfrared Thermography
![Page 20: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/20.jpg)
CASE STUDY : BRIDGE
Schmidt Hammer , GPR Test being conducted on a bridge
A well-established and accepted application of GPR is the accurate condition assessment of bridge decks as well as other reinforced concrete structures.
Infrared imaging technologies to find defects in the concrete parts of bridges.
Ultrasonic testing allows also the visualization of perpendicularly arranged reinforcement bars.
![Page 21: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/21.jpg)
CONCLUSION
A large range of NDT techniques are deployed for a wide variety of application in Civil Engineering. NDT techniques can be used for evaluation and inspection of both new and existing structures. Apart from methods discussed here, they are still a constant field of research and development due to their significance.
![Page 22: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/22.jpg)
REFERENCES
INTERNATIONAL ATOMIC ENERGY AGENCY ,VIENNA,2002 Guidebook on Non Destructive testing of Concrete Structures .
Wikipedia.org and Internet.
![Page 23: NON DESTRUCTIVE TESTING OF CONCRETE STRUCTURES PPT](https://reader033.fdocuments.net/reader033/viewer/2022061409/55cf9c3f550346d033a92d85/html5/thumbnails/23.jpg)
THANK YOU