New PARTS CATALOG - DRACO Equipment Manuals/Parts... · 2018. 3. 16. · 12 2 172437-03300...

PARTS CATALOG

Last update Mar., 2015

0CS10-M40201EN

Directions for the Parts Catalog. 1.This Parts Catalog shows both standard and optional parts. 2.Parts may change without prior notice. 3.The following is an example of the Parts Catalog format.

Ref. No.The Ref. No. listed may not be in accordance with the illustration Ref. No. (Ex.) Illustration No. List Ref No. 1 1 (Before change)

For interchangeable symbols N, R and K, illustrations for new parts may be abbreviated.

Lev. (Level) Level indication The numbers below indicate the level of relativity towards the main part.1 ----- Main parts (Assembly parts) 2 ----- Sub component included in ” 1 ”. 3 ----- Sub component included in ” 2 “. Note) Parts that are not for sale are partially illustrated but not listed.

Interchangeability SymbolWhen a part change takes place, one of the following interchangeability symbols is indicated beside the part.

Effective Machine No. When a part changes, the effective Machine No. will be indicated in the (A)-(F) column.

Note 1) A date may follow the symbol. (Ex.) 1996.01Note 2) ” XXXXX ” and ” ZZZZZ ” are for parts that could not be predicted or for engine models that could not be identified.Note 3) (A=E00185) is the E (Engine Serial Number) for the column (A) model (in this case 4JH-DT) after the parts design change.

RemarksFigures or alphabets (symbols) are entered in the remarks column. The comments (remarks) on parts that are indicated at the bottom of the illustration are the same symbols as those stated above.

1- 1 (After change)

Product Symbol Product No. Product Symbol Product No. C Clutch No. Compressor No.

Machine No.Machine No. (Agricultural Equip.)

MF

.oNevirDDE Engine No.

R

S

WZ

K

N

Q

F

NewOld YesNoNo

YesYes

Yes

NewOld

No

No

NewOld

NewOld

Contents noteInterchangeabilitySymbol

New/ Old Parts are both interchangeable.

New/ Old Parts are both not interchangeable.

Part discontinued. Part newly added.

Changes only for used parts quantities.

New Part is interchangeable for Old Part but Old Part is not interchangeablefor New Part.New Part is not interchangeable for Old Part but Old Part is interchangeablefor New Part.

Not interchangeable by a single part but interchangeable together with relatedparts.

1

2

4

3

5

0CF10-G21601 29. FUEL INJECTION PUMP(W/BOOST)

(F)=(E)=4JH-DTZY(D)=4JH-DTZA

(C)=4JH-DTZP(B)=4JH-DTZ(A)=4JH-DT

LEV.REF. PARTS NO. DESCRIPTION RIQ'TY(F)(D)(C)(B)(A) (E)

1FUEL INJECTION PUMP729595-5139011 111111FUEL INJECTION PUMP729595-5139111-1 N11111

(A=E00185) (B=E00200)

SCREW M 6X 1626022-06016223 99999SCREW M 6X 1626022-06016223-1 K44444

(A=E00156) (B=E00156) (C=E00156) (D=E00156) (E=E00156)

CAMSHAFT129470-5104024 11111BEARING, ROLLER122710-5105025 22222RETAINER129470-5106026 11111

Remarks(1) BOOST COMPEMSATOR TYPE. OPTIONAL

PART, TO E00155,(4JH-DT, 4JH-DTZ

3 51 2

4

Contents 0CS10-M40201

Fig. No. Fig. Name Fig. No. Fig. Name

VEHICLE VIO75(US,AS,NZ)

LABEL(CABIN) 1.

LABEL(CANOPY) 2.

LABEL(QUICK COUPLER SPEC.) 3.

SAFETY LABEL(CABIN) 4.

SAFETY LABEL(CANOPY) 5.

SAFETY LABEL(QUICK COUPLER SPEC.) 6.

ACCESSORY 7.

MUFFLER 8.

AIR CLEANER 9.

ACCELERATOR LEVER 10.

ENGINE MOUNT 11.

RADIATOR & SUB-TANK 12.

RADIATOR MOUNT 13.

FUEL TANK 14.

FUEL LINE 15.

BATTERY 16.

ELECTRIC PART(WIRING) 17.

ELECTRIC PART(WIRING)(A/C SPEC.) 18.

ELECTRIC PART(EQUIPMENT) 19.

ELECTRIC PART(QUICK COUPLER SPEC.) 20.

CANOPY LIGHT 21.

TRAVEL ALARM 22.

INDICATOR BOX 23.

HEATER 24.

HEATER(AIR CONDITIONER SPEC.) 25.

WIND WASHER 26.

AIR CONDITIONER(ENGINE RELATED 27.

AIR CONDITIONER(CONDENSER RELATED) 28.

AIR CONDITIONER(CABIN RELATED) 29.

AIR CONDITIONER(PIPING) 30.

SPROCKET & ROLLER 31.

IDLER & ADJUST 32.

CRAWLER 33.

CONTROL EQUIPMENT(LOCK LEVER & STAND) 34.

CONTROL EQUIPMENT(TRAVEL) 35.

CONTROL EQUIPMENT(BLADE) 36.

CONTROL EQUIPMENT(SWING) 37.

CONTROL EQUIPMENT(LOW-HIGH PEDAL) 38.

CONTROL EQUIPMENT(P.T.O.) 39.

CONTROL VALVE PLATE 40.

FRAME & TURNING BEARING 41.

COVER(FRAME) 42.

COVER(AROUND THE CONTROL:1) 43.

COVER(AROUND THE CONTROL:2) 44.

STEP & INSTRUMENT PANEL 45.

SEAT & SEAT MOUNT 46.

HOOD(BODY) 47.

HOOD(UPPER COVER) 48.

HOOD(SIDE & REAR COVER) 49.



HOOD(FRONT) 50.

CABIN(BODY) 51.

CABIN(EXTERIOR) 52.

CABIN(ROOF PAD) 53.

CABIN(WINDOW) 54.

CABIN(ELECTRIC) 55.

CABIN(DOOR) 56.

CABIN(FRONT WINDOW) 57.

CANOPY 58.

HYD.OIL PUMP & JOINT 59.

HYD.OIL PUMP & JOINT(QUICK COUPLER SPEC.) 60.

BOOM CYLINDER 61.

ARM CYLINDER 62.

ARM CYLINDER(QUICK COUPLER SPEC.) 63.

BUCKET CYLINDER 64.

BUCKET CYLINDER(QUICK COUPLER SPEC.) 65.

SWING CYLINDER 66.

BLADE CYLINDER 67.

HITCH CYLINDER(QUICK COUPLER SPEC.) 68.

TRAVEL MOTOR 69.

TURNING MOTOR 70.

SWIVEL JOINT 71.

CONTROL VALVE(1/4) 72.




2-WAY VALVE 76.

REMOTE CONTROL VALVE 77.

LUB.OIL COOLER 78.

HYD.OIL TANK 79.

HYD.OIL PIPING(TANK - PUMP - VALVE) 80.

HYD.OIL PIPING(VALVE - TURNING MOTOR,BOOM) 81.

HYD.OIL PIPING(PUMP,VALVE - SWIVEL,SWING) 82.

HYD.OIL PIPING(RETURN:1) 83.

HYD.OIL PIPING(RETURN:2) 84.

HYD.OIL PIPING(P.T.O.:FRAME END) 85.

HYD.OIL PIPING(TRACK FRAME) 86.

HYD.OIL PIPING(BOOM) 87.

HYD.OIL PIPING(P.T.O.:ARM END) 88.

HYD.OIL PIPING(QUICK COUPLER) 89.

CONTROL PIPING(RETURN) 90.

CONTROL PIPING(REMOTE CONTROL V. - 2-WAY V. - CONTROL V.) 91.

GREASING 92.

BOOM BRACKET 93.

BOOM 94.

SHORT ARM(1650) 95.

LONG ARM(2150) 96.

ARM(QUICK COUPLER SPEC.) 97.

BUCKET ARM & LINK 98.

QUICK COUPLER(QUICK COUPLER SPEC.) 99.



BUCKET 100.

BUCKET PIN 101.

BLADE 102.

Remarks (1)RUBBER CRAWLER SPEC. (2)NOT APPLIED FOR LONG ARM SPEC. (3)LONG ARM SPEC.

Lev. No. Parts No. Description R I Q'ty (F) (D) (C) (B) (A) (E)

LABEL SET,VIO75(US C 772478-03230 1 1 1 1 LABEL SET,VIO75(US C 772478-03231 1 1-1 N 1 1 1

(A=M/#00641) (B=M/#00641)

1 LABEL,ADJUST CRAWLER 172463-03280 2 2 1 1 1 LABEL, BOOM 172187-03160 2 3 1 1 1 LABEL,REAR 172478-03160 2 4 1 1 1 LABEL,ACCELERATOR 172458-03220 2 5 1 1 1 LABEL, P.T.O. 172165-03231 2 6 1 1 1 LABEL,LOCK 172458-03240 2 7 1 1 1 TAG ASSY, CAUTION 172437-03250 2 8 1 1 1 LABEL 172524-03271 2 9 1 1 1 LABEL,LOCK 172183-03280 2 10 1 1 1 LABEL,HYD.OIL US 172463-03290 2 11 1 1 1 LABEL,MANUAL 172437-03300 2 12 1 1 LABEL,MANUAL US 172448-03600 2 12-1 N 1 1 1

(A=M/#00541) (B=M/#00541) LABEL 172438-03300 2 13 1 1 1 LABEL,SLOPE 172437-03310 2 14 1 1 1 LABEL, MODEL L LW.US 172463-03310 2 15 1 1 1 LABEL,GREASE E 172146-03320 2 16 1 1 1 LABEL,HYD.OIL TANK 172437-03320 2 17 1 1 1 LABEL,COVER 172463-03330 2 18 1 1 1 LABEL,TRANSPORT 172437-03340 2 19 1 1 1 LABEL,GREASE CYL. 172437-03351 2 20 2 2 2 LABEL, START SWITCH 172141-03360 2 21 1 1 1 LABEL,BATTERY 172437-03360 2 22 1 1 1 LABEL 172437-03371 2 23 1 1 1 LABEL,SWING AREA 172437-03380 2 24 1 1 1 LABEL,RADIATOR 172437-03390 2 25 1 1 1 LABEL,FUSE US 172478-03390 2 26 1 1 1 LABEL,ENG.HOOD 172437-03400 2 27 1 1 1 LABEL,ENG.ROOM 172437-03410 2 28 1 1 1 LABEL,MUFFLER 172437-03421 2 29 1 1 1 LABEL,OIL & WATER 172478-03420 2 30 1 1 1 LABEL,STEERING 172437-03431 2 31 1 1 1 LABEL,GREASING 172478-03430 2 32 1 1 1 LABEL,L-US 172478-03440 2 33 1 1 1 LABEL,SEAT BELT 172437-03450 2 34 1 1 1 LABEL,R-US 172478-03450 2 35 1 1 1 LABEL,LEVER LOCK 172437-03470 2 36 1 1 1

2 LABEL,LIFTING 172478-03480 2 37 1 1 2 LABEL, LIFTING 172478-03481 2 37-1 N 1 1 1

(A=M/#00585) (B=M/#00585) LABEL,FUEL 172437-03500 2 38 1 1 1 LABEL,HOOK 172437-03510 2 39 3 3 3 LABEL 172437-03600 2 40 1 1 1 LABEL 172437-03610 2 41 1 1 1 LABEL 172437-03620 2 42 1 1 1 LABEL,BOOM 172187-03940 2 43 2 2 2 LABEL, AIR CLEANER 172125-03950 2 44 1 1 1 LABEL, RADIATOR 121120-44800 2 45 1 1 1

++ CONTINUE ++ Copyright (C) YANMAR CO., LTD. All RightsReserved.

0CS10-M40201

Fig.1. LABEL(CABIN) VEHICLE VIO75(US,AS,NZ)

(F)=VIO75 P(NZ) (E)=VIO75 P(AS) (D)=VIO75 P(US)

0CS10-M40201 Fig.1

(C)=VIO75 C(NZ) (B)=VIO75 C(AS) (A)=VIO75 C(US)



LABEL,SUB-TANK 124764-44810 2 46 1 1 1 LABEL, ANTI-FREEZING 124764-44920 2 47 1 1 1 LABEL,F/W LOWER US 172463-03320 2 48 1 1 1 LABEL,SUPPORT US 172463-03370 2 49 1 1 1 LABEL,TOPS US 172463-03380 2 50 1 1 1 LABEL,PATTERN A 172478-03400 2 51 1 1 1 LABEL,SPECIFICATION 172478-03410 2 52 1 1 LABEL,SPECIFICATION 172478-03411 2 52-1 N 1 1 1

(A=M/#00641) (B=M/#00641)

LABEL,WINDOW 172437-03550 2 53 1 1 1 3 LABEL, LIFT L US 172478-03490 2 54 W 1

(A=M/#00539)

Copyright (C) YANMAR CO., LTD. All RightsReserved.

0CS10-M40201

Fig.1. LABEL(CABIN) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.1




LABEL SET,VIO75(US P 772478-03250 1 1 1 1 LABEL SET,VIO75(US P 772478-03251 2 1-1 N 1 1 1

(D=M/#00641) (E=M/#00641)

1 LABEL,ADJUST CRAWLER 172463-03280 2 2 1 1 1 LABEL, BOOM 172187-03160 2 3 1 1 1 LABEL,REAR 172478-03160 2 4 1 1 1 LABEL,ACCELERATOR 172458-03220 2 5 1 1 1 LABEL, P.T.O. 172165-03231 2 6 1 1 1 LABEL,LOCK 172458-03240 2 7 1 1 1 TAG ASSY, CAUTION 172437-03250 2 8 1 1 1 LABEL 172524-03271 2 9 1 1 1 LABEL,LOCK 172183-03280 2 10 1 1 1 LABEL,HYD.OIL US 172463-03290 2 11 1 1 1 LABEL,MANUAL 172437-03300 2 12 1 1 LABEL,MANUAL US 172448-03600 2 12-1 N 1 1 1

(D=M/#00541) (E=M/#00541) LABEL 172438-03300 2 13 1 1 1 LABEL,SLOPE 172437-03310 2 14 1 1 1 LABEL, MODEL L LW.US 172463-03310 2 15 1 1 1 LABEL,GREASE E 172146-03320 2 16 1 1 1 LABEL,HYD.OIL TANK 172437-03320 2 17 1 1 1 LABEL,COVER 172463-03330 2 18 1 1 1 LABEL,TRANSPORT 172437-03340 2 19 1 1 1 LABEL,GREASE CYL. 172437-03351 2 20 2 2 2 LABEL, START SWITCH 172141-03360 2 21 1 1 1 LABEL,BATTERY 172437-03360 2 22 1 1 1 LABEL 172437-03371 2 23 1 1 1 LABEL,SWING AREA 172437-03380 2 24 1 1 1 LABEL,RADIATOR 172437-03390 2 25 1 1 1 LABEL,FUSE US 172478-03390 2 26 1 1 1 LABEL,ENG.HOOD 172437-03400 2 27 1 1 1 LABEL,ENG.ROOM 172437-03410 2 28 1 1 1 LABEL,MUFFLER 172437-03421 2 29 1 1 1 LABEL,OIL & WATER 172478-03420 2 30 1 1 1 LABEL,STEERING 172437-03431 2 31 1 1 1 LABEL,GREASING 172478-03430 2 32 1 1 1 LABEL,L-US 172478-03440 2 33 1 1 1 LABEL,SEAT BELT 172437-03450 2 34 1 1 1 LABEL,R-US 172478-03450 2 35 1 1 1 LABEL,LEVER LOCK 172437-03470 2 36 1 1 1


(D=M/#00585) (E=M/#00585) LABEL,FUEL 172437-03500 2 38 1 1 1 LABEL,HOOK 172437-03510 2 39 3 3 3 LABEL 172437-03600 2 40 1 1 1 LABEL 172437-03610 2 41 1 1 1 LABEL 172437-03620 2 42 1 1 1 LABEL,BOOM 172187-03940 2 43 2 2 2 LABEL, AIR CLEANER 172125-03950 2 44 1 1 1 LABEL, RADIATOR 121120-44800 2 45 1 1 1


0CS10-M40201

Fig.2. LABEL(CANOPY) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.2




LABEL,SUB-TANK 124764-44810 2 46 1 1 1 LABEL, ANTI-FREEZING 124764-44920 2 47 1 1 1 LABEL,2 SPEED 172147-03210 2 48 1 1 1 LABEL 172149-03430 2 49 1 1 1 LABEL,ROPS 172437-03440 2 50 1 1 1 LABEL,SUPPORT 172478-03470 2 51 1 1 1 LABEL,SPECIFICATION 172478-03510 2 52 1 1 LABEL 172478-03511 2 52-1 N 1 1 1

(D=M/#00641) (E=M/#00641)

3 LABEL, LIFT L US 172478-03490 2 53 W 1 (D=M/#00539)

LABEL,FOPS2 P 172478-03660 2 54 1 1 LABEL 172478-03661 2 54-1 N 1 1 1

(D=M/#00641) (E=M/#00641) SCREW 172519-04350 2 55 2 2 2


0CS10-M40201

Fig.2. LABEL(CANOPY) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.2


Remarks (1)RUBBER CRAWLER SPEC.


LABEL SET VIO75(US Q 772979-03100 1 1 1 1 1 LABEL, LIFT 172978-03100 2 2 1 1 1 LABEL, SPECIFICATION 172978-03110 2 3 1 1 1 LABEL 172958-03160 2 4 1 1 1 LABEL,OPERATION PIN 172472-03230 2 5 1 1 1 LABEL,LOCK 172458-03240 2 6 1 1 1 LABEL,PIN US 172472-03240 2 7 1 1 1 LABEL,OPERATION Q US 172472-03250 2 8 1 1 1 LABEL,FINGER 172472-03260 2 9 1 1 1 LABEL,SAND US 172472-03270 2 10 1 1 1 LABEL 172472-03280 2 11 1 1 1 LABEL,SWITCH 172472-03290 2 12 1 1 1 LABEL,COVER 172472-03300 2 13 1 1 1

1 LABEL,ADJUST CRAWLER 172463-03280 2 14 1 1 1 LABEL, BOOM 172187-03160 2 15 1 1 1 LABEL,REAR 172478-03160 2 16 1 1 1 LABEL,ACCELERATOR 172458-03220 2 17 1 1 1 LABEL, P.T.O. 172165-03231 2 18 1 1 1 LABEL,LOCK 172458-03240 2 19 1 1 1 TAG ASSY, CAUTION 172437-03250 2 20 1 1 1 LABEL 172524-03271 2 21 1 1 1 LABEL,LOCK 172183-03280 2 22 1 1 1 LABEL,HYD.OIL US 172463-03290 2 23 1 1 1 LABEL 172438-03300 2 24 1 1 1 LABEL,SLOPE 172437-03310 2 25 1 1 1 LABEL, MODEL L LW.US 172463-03310 2 26 1 1 1 LABEL,GREASE E 172146-03320 2 27 1 1 1 LABEL,HYD.OIL TANK 172437-03320 2 28 1 1 1 LABEL,COVER 172463-03330 2 29 1 1 1 LABEL,TRANSPORT 172437-03340 2 30 1 1 1 LABEL,GREASE CYL. 172437-03351 2 31 2 2 2 LABEL, START SWITCH 172141-03360 2 32 1 1 1 LABEL,BATTERY 172437-03360 2 33 1 1 1 LABEL 172437-03371 2 34 1 1 1 LABEL,SWING AREA 172437-03380 2 35 1 1 1 LABEL,RADIATOR 172437-03390 2 36 1 1 1 LABEL,FUSE US 172478-03390 2 37 1 1 1 LABEL,ENG.HOOD 172437-03400 2 38 1 1 1 LABEL,ENG.ROOM 172437-03410 2 39 1 1 1 LABEL,MUFFLER 172437-03421 2 40 1 1 1 LABEL,OIL & WATER 172478-03420 2 41 1 1 1 LABEL,STEERING 172437-03431 2 42 1 1 1 LABEL,GREASING 172478-03430 2 43 1 1 1 LABEL,L-US 172478-03440 2 44 1 1 1 LABEL,SEAT BELT 172437-03450 2 45 1 1 1 LABEL,R-US 172478-03450 2 46 1 1 1 LABEL,LEVER LOCK 172437-03470 2 47 1 1 1 LABEL,FUEL 172437-03500 2 48 1 1 1 LABEL,HOOK 172437-03510 2 49 3 3 3 LABEL 172437-03600 2 50 1 1 1 LABEL,MANUAL US 172448-03600 2 51 1 1 1


0CS10-M40201

Fig.3. LABEL(QUICK COUPLER SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.3


Remarks (1)RUBBER CRAWLER SPEC.


LABEL 172437-03610 2 52 1 1 1 LABEL 172437-03620 2 53 1 1 1 LABEL,BOOM 172187-03940 2 54 2 2 2 LABEL, AIR CLEANER 172125-03950 2 55 1 1 1 LABEL, RADIATOR 121120-44800 2 56 1 1 1 LABEL,SUB-TANK 124764-44810 2 57 1 1 1 LABEL, ANTI-FREEZING 124764-44920 2 58 1 1 1 LABEL,F/W LOWER US 172463-03320 2 59 1 1 1 LABEL,SUPPORT US 172463-03370 2 60 1 1 1 LABEL,TOPS US 172463-03380 2 61 1 1 1 LABEL,PATTERN A 172478-03400 2 62 1 1 1 LABEL,WINDOW 172437-03550 2 63 1 1 1


0CS10-M40201

Fig.3. LABEL(QUICK COUPLER SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.3


Remarks (1)NOT APPLIED FOR LONG ARM SPEC. (2)LONG ARM SPEC.


TAG ASSY, CAUTION 172437-03250 1 1 1 1 1 LABEL,MANUAL 172437-03300 1 2 1 1 LABEL,MANUAL US 172448-03600 1 2-1 N 1 1 1

(A=M/#00541) (B=M/#00541) LABEL,SLOPE 172437-03310 1 3 1 1 1 LABEL,HYD.OIL TANK 172437-03320 1 4 1 1 1 LABEL,TRANSPORT 172437-03340 1 5 1 1 1 LABEL,GREASE CYL. 172437-03351 1 6 2 2 2 LABEL,BATTERY 172437-03360 1 7 1 1 1 LABEL 172437-03371 1 8 1 1 1 LABEL,SWING AREA 172437-03380 1 9 1 1 1 LABEL,RADIATOR 172437-03390 1 10 1 1 1 LABEL,ENG.HOOD 172437-03400 1 11 1 1 1 LABEL,ENG.ROOM 172437-03410 1 12 1 1 1 LABEL,MUFFLER 172437-03421 1 13 1 1 1 LABEL,STEERING 172437-03431 1 14 1 1 1 LABEL,SEAT BELT 172437-03450 1 15 1 1 1 LABEL,LEVER LOCK 172437-03470 1 16 1 1 1


(A=M/#00585) (B=M/#00585)

LABEL 172437-03600 1 18 1 1 1 LABEL,BOOM 172187-03940 1 19 2 2 2 LABEL,SUB-TANK 124764-44810 1 20 1 1 1 LABEL,SUPPORT US 172463-03370 1 21 1 1 1 LABEL,TOPS US 172463-03380 1 22 1 1 1 LABEL,WINDOW 172437-03550 1 23 1 1 1

2 LABEL, LIFT L US 172478-03490 1 24 W 1 (A=M/#00539)


0CS10-M40201

Fig.4. SAFETY LABEL(CABIN) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.4


Remarks (1)NOT APPLIED FOR LONG ARM SPEC. (2)LONG ARM SPEC.


TAG ASSY, CAUTION 172437-03250 1 1 1 1 1 LABEL,MANUAL 172437-03300 1 2 1 1 LABEL,MANUAL US 172448-03600 1 2-1 N 1 1 1

(D=M/#00541) (E=M/#00541) LABEL,SLOPE 172437-03310 1 3 1 1 1 LABEL,HYD.OIL TANK 172437-03320 1 4 1 1 1 LABEL,TRANSPORT 172437-03340 1 5 1 1 1 LABEL,GREASE CYL. 172437-03351 1 6 2 2 2 LABEL,BATTERY 172437-03360 1 7 1 1 1 LABEL 172437-03371 1 8 1 1 1 LABEL,SWING AREA 172437-03380 1 9 1 1 1 LABEL,RADIATOR 172437-03390 1 10 1 1 1 LABEL,ENG.HOOD 172437-03400 1 11 1 1 1 LABEL,ENG.ROOM 172437-03410 1 12 1 1 1 LABEL,MUFFLER 172437-03421 1 13 1 1 1 LABEL,STEERING 172437-03431 1 14 1 1 1 LABEL,SEAT BELT 172437-03450 1 15 1 1 1 LABEL,LEVER LOCK 172437-03470 1 16 1 1 1


(D=M/#00585) (E=M/#00585)

LABEL 172437-03600 1 18 1 1 1 LABEL,BOOM 172187-03940 1 19 2 2 2 LABEL,SUB-TANK 124764-44810 1 20 1 1 1 LABEL,ROPS 172437-03440 1 21 1 1 1 LABEL,SUPPORT 172478-03470 1 22 1 1 1

2 LABEL, LIFT L US 172478-03490 1 23 W 1 (D=M/#00539)


0CS10-M40201

Fig.5. SAFETY LABEL(CANOPY) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.5



LABEL, LIFT 172978-03100 1 1 1 1 1 LABEL,PIN US 172472-03240 1 2 1 1 1 LABEL,FINGER 172472-03260 1 3 1 1 1 LABEL,SAND US 172472-03270 1 4 1 1 1 LABEL 172472-03280 1 5 1 1 1 TAG ASSY, CAUTION 172437-03250 1 6 1 1 1 LABEL,SLOPE 172437-03310 1 7 1 1 1 LABEL,HYD.OIL TANK 172437-03320 1 8 1 1 1 LABEL,TRANSPORT 172437-03340 1 9 1 1 1 LABEL,GREASE CYL. 172437-03351 1 10 2 2 2 LABEL,BATTERY 172437-03360 1 11 1 1 1 LABEL 172437-03371 1 12 1 1 1 LABEL,SWING AREA 172437-03380 1 13 1 1 1 LABEL,RADIATOR 172437-03390 1 14 1 1 1 LABEL,ENG.HOOD 172437-03400 1 15 1 1 1 LABEL,ENG.ROOM 172437-03410 1 16 1 1 1 LABEL,MUFFLER 172437-03421 1 17 1 1 1 LABEL,STEERING 172437-03431 1 18 1 1 1 LABEL,SEAT BELT 172437-03450 1 19 1 1 1 LABEL,LEVER LOCK 172437-03470 1 20 1 1 1 LABEL 172437-03600 1 21 1 1 1 LABEL,MANUAL US 172448-03600 1 22 1 1 1 LABEL,BOOM 172187-03940 1 23 2 2 2 LABEL,SUB-TANK 124764-44810 1 24 1 1 1 LABEL,SUPPORT US 172463-03370 1 25 1 1 1 LABEL,TOPS US 172463-03380 1 26 1 1 1 LABEL,WINDOW 172437-03550 1 27 1 1 1


0CS10-M40201

Fig.6. SAFETY LABEL(QUICK COUPLER SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.6



CASE, MANUAL 172469-07330 1 1 1 1 1 1 1 1


0CS10-M40201

Fig.7. ACCESSORY VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.7



PIPE, EXHAUST 172478-11300 1 1 1 1 1 1 1 1 PIPE, EXHAUST 172478-11301 1 1-1 N 1 1 1 1 1 1

(A=XXX) (B=XXX) (C=XXX) (D=XXX) (E=XXX) (F=XXX)

COVER ASSY, MANIFOLD 172478-11500 1 2 1 1 1 1 1 1 WOOL, GLASS 172478-11520 2 4 1 1 1 1 1 1 WOOL, GLASS 172478-11530 2 5 1 1 1 1 1 1 WOOL, GLASS 172478-11540 2 6 1 1 1 1 1 1 WOOL, GLASS 172478-11550 2 7 1 1 1 1 1 1 CLAMP 121120-13580 1 8 1 1 1 1 1 1 CLAMP 172A21-11310 1 8-1 N 1 1 1 1 1 1

(A=XXX) (B=XXX) (C=XXX) (D=XXX) (E=XXX) (F=XXX) BOLT 172519-63240 1 9 2 2 2 2 2 2 BOLT, M10X 65 PLATED 26106-100652 1 10 1 1 1 1 1 1 NUT, M10 26706-100002 1 11 1 1 1 1 1 1 WASHER, 10 22117-100000 1 12 1 1 1 1 1 1 WASHER, SPRING 10 22217-100000 1 13 1 1 1 1 1 1


0CS10-M40201

Fig.8. MUFFLER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.8



CLEANER ASSY, AIR 172455-11500 1 1 1 1 1 1 1 1 BODY ASSY 172455-11650 2 2 1 1 1 1 1 1 VALVE, UNLOADER 119808-12540 2 3 1 1 1 1 1 1 ELEMENT 129062-12560 2 4 1 1 1 1 1 1 COVER-ASSY 129062-12570 2 5 1 1 1 1 1 1 HOSE ASSY, INTAKE 172455-11510 1 6 1 1 1 1 1 1 HOSE, AIR INTAKE 172455-11520 2 7 1 1 1 1 1 1 HOSE, AIR INTAKE 172455-11530 2 8 1 1 1 1 1 1 SILENCER ASSY 119160-12060 2 9 1 1 1 1 1 1 CLAMP, 80 23000-080000 2 10 2 2 2 2 2 2 HOSE, AIR INTAKE 172455-11540 1 11 1 1 1 1 1 1 PIPE ASSY, SUCTION 172455-11550 1 12 1 1 1 1 1 1 PIPE ASSY, SUCTION 172455-11551 1 12-1 N 1 1 1 1 1 1

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) HOSE, AIR INTAKE 172455-11580 1 13 1 1 1 1 1 1 BRACKET, AIR CLEANER 172455-11601 1 14 1 1 1 1 1 1 CLIP, HOSE 172183-16560 1 15 1 1 1 1 1 1 CLAMP, 70 23000-070000 1 16 2 2 2 2 2 2 CLAMP, 80 23000-080000 1 17 3 3 3 3 3 3 BOLT, M8X 20 26013-080202 1 18 2 2 2 2 2 2 BOLT, M10X 20 26013-100202 1 19 2 2 2 2 2 2 BOLT, M10X 25 26013-100252 1 20 2 2 2 2 2 2


0CS10-M40201

Fig.9. AIR CLEANER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.9



LEVER,ACCELERATOR 172458-12100 1 1 1 1 1 1 1 1 GRIP 172A79-12150 2 1A W 1 1 1 1 1 1

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) (D=MXXXXX) (E=MXXXXX) (F=MXXXXX)

CABLE, ACCELERATOR 172463-12111 1 2 1 1 1 1 1 1 CABLE, ACCELERATOR 172463-12112 1 2-1 N 1 1 1 1 1 1

(A=*2008.05) (B=*2008.05) (C=*2008.05) (D=*2008.05) (E=*2008.05) (F=*2008.05)

CABLE, ACCELERATOR 172463-12113 1 2-2 N 1 1 1 1 1 1 (A=*2008.05) (B=*2008.05) (C=*2008.05) (D=*2008.05) (E=*2008.05) (F=*2008.05)

SUPPORT 172187-12120 1 3 1 1 1 1 1 1 GROMMET 172455-12140 1 4 2 2 2 2 2 2 JOINT, CABLE 172137-12270 1 5 1 1 1 1 1 1 PIN, SNAP 6 1C6281-52310 1 6 2 2 2 2 2 2 PIN, 6X17 1A1040-56900 1 7 2 2 2 2 2 2 WASHER, 6 22137-060000 1 8 2 2 2 2 2 2 BOLT, M10X 16 26013-100162 1 9 2 2 2 2 2 2 BOLT, M10X 25 26013-100252 1 10 2 2 2 2 2 2 BAND 146 933168-55770 1 11 2 2 2 2 2 2


0CS10-M40201

Fig.10. ACCELERATOR LEVER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.10



BRACKET RR 172455-13101 1 1 1 1 1 1 1 1 BRACKET FR 172455-13131 1 2 1 1 1 1 1 1 BRACKET LR 172455-13151 1 3 1 1 1 1 1 1 WASHER 172162-13170 1 4 2 2 2 2 2 2 MOUNT,ENGINE 172162-13180 1 5 8 8 8 8 8 8 WASHER 172165-13220 1 6 8 8 8 8 8 8 BRACKET RF 172187-13731 1 7 1 1 1 1 1 1 STOPPER ASSY 172187-13830 1 8 2 2 2 2 2 2 BOLT 10X35 1E6480-16920 1 9 12 12 12 12 12 12 BOLT 10X35 172A21-13100 1 9-1 N 12 12 12 12 12 12

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) SEAT, SPRING 172137-46040 1 10 12 12 12 12 12 12 WASHER, SPRING 10 22217-100000 1 11 12 12 12 12 12 12 WASHER, SPRING 12 22217-120000 1 12 8 8 8 8 8 8 WASHER, SPRING 16 22217-160000 1 13 4 4 4 4 4 4 BOLT, 10.912X 35 26076-120352 1 14 8 8 8 8 8 8 BOLT, 10.916X130 26076-161302 1 15 4 4 4 4 4 4


0CS10-M40201

Fig.11. ENGINE MOUNT VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.11


Remarks (1)NOT APPLIED FOR A/C SPEC. (2)PLEASE USE THIS PART WITH FOLLOW- ING LABEL AT THE SAME TIME. REF.NO.33A (3)LABEL IS NOT ILLUSTRATED.


COCK ASSY, 2-WAY 172444-13210 1 1 1 1 1 1 1 1 BODY 172444-13220 2 2 1 1 1 1 1 1 PLUG, DRAIN 121250-49121 2 3 1 1 1 1 1 1 O-RING, 1AP16.0 24311-000160 2 4 1 1 1 1 1 1 SHROUD ASSY 172187-13261 1 5 1 1 1 1 1 1 HOSE, RADIATOR 172187-13300 1 6 1 1 1 1 1 1 RADIATOR CMP 172478-13300 1 7 1 1 1 1 1 1 HOSE, RUBBER 172187-13921 2 9 1 1 1 1 1 1 CAP, RADIATOR 119259-44570 2 10 1 1 1 1 1 1 CLAMP 121250-44590 2 11 2 2 2 2 2 2 HOSE, RADIATOR 172187-13310 1 12 1 1 1 1 1 1 SEAL 172187-13360 1 13 1 1 1 1 1 1 SEAL 172187-13370 1 14 1 1 1 1 1 1 HOSE 172122-13381 1 15 1 1 1 1 1 1 SEAL 172187-13480 1 16 1 1 1 1 1 1

1 NET ASSY, WIRE 172187-13501 1 17 1 1 1 1 1 1 2 TANK ASSY, SUB 171064-44510 1 18 1 1 1 1 1 1

CAP 121450-44531 2 20 1 1 1 1 1 1 RETAINER 124450-44560 2 21 1 1 1 1 1 1 GASKET 121470-44581 2 22 1 1 1 1 1 1 HOSE 7X 225 23065-070225 2 23 1 1 1 1 1 1 BAND 124450-44550 1 24 1 1 1 1 1 1 BRACKET, SUB TANK 121256-44600 1 25 1 1 1 1 1 1 CLIP, HOSE 12 124766-59050 1 26 2 2 2 2 2 2 SEAL, STEP 172162-62540 1 27 1 1 1 1 1 1 CLAMP, 50 23010-050000 1 28 4 4 4 4 4 4 BOLT, M8X 16 26013-080162 1 29 3 3 3 3 3 3 BOLT, M8X 16 26013-080162 1 30 2 2 2 2 2 2 BOLT, M8X 25 26013-080252 1 31 2 2 2 2 2 2 SCREW, M8X16 26022-080162 1 32 2 2 2 2 2 2

3 LABEL,SUB-TANK 124764-44810 1 33A 1 1 1 1 1 1


0CS10-M40201

Fig.12. RADIATOR & SUB-TANK VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.12


Remarks (1)PLEASE USE THIS PART WITH FOLLOW- ING LABEL AT THE SAME TIME. REF.NO.48A (2)LABEL IS NOT ILLUSTRATED.


BRACKET R ASSY 172455-13301 1 1 1 1 1 1 1 1 MOUNT, RADIATOR 172122-13310 1 2 2 2 2 2 2 2 PLATE ASSY 172455-13361 1 3 1 1 1 1 1 1 MOUNT L ASSY 172455-13400 1 4 1 1 1 1 1 1 SEAL, RADIATOR 172187-13530 2 6 1 1 1 1 1 1 SEAL, RADIATOR 172187-13540 2 7 1 1 1 1 1 1 BRACKET L 172187-13420 1 8 1 1 1 1 1 1 MOUNT R ASSY 172455-13430 1 9 1 1 1 1 1 1 SEAL, RADIATOR 172187-13530 2 11 1 1 1 1 1 1 SEAL, RADIATOR 172187-13540 2 12 1 1 1 1 1 1 GRILLE ASSY, DUCT 172455-13601-1 1 13 1 1 1 1 1 1

1 DUCT ASSY, RADIATOR 172478-13600 1 14 1 1 1 1 1 1 RUBBER, SEAL 172183-13480 2 15 1 1 1 1 1 1 RUBBER, SEAL 172164-13520 2 16 2 2 2 2 2 2 RUBBER, SEAL 172455-13610 2 17 1 1 1 1 1 1 SEAL, DUCT 172455-13630 2 19 1 1 1 1 1 1 SEAL, DUCT 172455-13640 2 20 1 1 1 1 1 1 SEAL 172162-61120 2 25 1 1 1 1 1 1 RUBBER, SEAL 172164-61250 2 26 1 1 1 1 1 1 RUBBER, SEAL 172171-65850 2 27 1 1 1 1 1 1 RUBBER, SEAL 172455-13620 2 28 1 1 1 1 1 1 COVER, DUCT 172478-13700-1 1 29 1 1 1 1 1 1 MOUNT 42-87,EVAPORTR 172162-13780 1 32 2 2 2 2 2 2 MOUNT 42-87,EVAPORTR 172162-13780 1 33 1 1 1 1 1 1 BOLT M10X20 172168-46760 1 34 3 3 3 3 3 3 BOLT M10X20 172168-46760 1 35 2 2 2 2 2 2 BOLT M10X20 172168-46760 1 36 4 4 4 4 4 4 BOLT M16X 40 172165-53490 1 37 3 3 3 3 3 3 BOLT 172519-63240 1 38 1 1 1 1 1 1 CAP 172187-64800 1 39 1 1 1 1 1 1 WASHER, 10 22137-100000 1 40 1 1 1 1 1 1 WASHER, 10 22157-100000 1 41 2 2 2 2 2 2 WASHER, SPRING 16 22217-160000 1 42 3 3 3 3 3 3 BOLT, M8X 16 26013-080162 1 43 6 6 6 6 6 6 BOLT, M10X 20 26013-100202 1 44 2 2 2 2 2 2 BOLT, M10X 25 26013-100252 1 45 2 2 2 2 2 2 NUT, M8 26051-080002 1 46 4 4 4 4 4 4 NUT, M10 26051-100002 1 47 6 6 6 6 6 6

2 LABEL,RADIATOR 172437-03390 1 48A 1 1 1 1 1 1


0CS10-M40201

Fig.13. RADIATOR MOUNT VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.13



TANK ASSY, FUEL 772455-14101-1 1 1 1 1 1 1 1 1 COCK, WATER 104200-11920 2 2 1 1 1 1 1 1 GASKET 172162-14200 2 4 1 1 1 1 1 1 GAUGE, FUEL 172187-14220 2 5 1 1 1 1 1 1 HOSE, FUEL GAUGE 172455-14240 2 6 1 1 1 1 1 1 FLOAT 172141-14260 2 7 1 1 1 1 1 1 NET, FUEL 172187-14290 2 8 1 1 1 1 1 1 CAP ASSY, TANK 172455-14340 2 9 1 1 1 1 1 1 GASKET 172187-14320 3 10 1 1 1 1 1 1 HOSE 172455-14400 2 11 1 1 1 1 1 1 HOSE, DRAIN 172444-14410 2 12 1 1 1 1 1 1 RUBBER, FUEL CATCH 172455-14500 2 13 1 1 1 1 1 1 BRACKET, PUMP 172122-55061 2 14 2 2 2 2 2 2 WASHER, SPRING 5 22217-050000 2 15 5 5 5 5 5 5 CLAMP, 14 23010-014000 2 16 2 2 2 2 2 2 CLAMP, 14 23010-014000 2 17 1 1 1 1 1 1 CLAMP, 13 23080-013000 2 18 1 1 1 1 1 1 BOLT, M6X 10 26013-060102 2 19 4 4 4 4 4 4 SCREW, M5X12 26022-050122 2 20 5 5 5 5 5 5 WASHER, 16 22137-160000 1 21 4 4 4 4 4 4 WASHER, SPRING 16 22217-160000 1 22 4 4 4 4 4 4 BOLT, M16X 45 PLATED 26116-160452 1 23 4 4 4 4 4 4


0CS10-M40201

Fig.14. FUEL TANK VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.14



HOSE 172187-14430 1 1 1 1 1 1 1 1 CLAMP 172187-14460 1 2 1 1 1 1 1 1 HOSE ASSY 172187-14470 1 3 1 1 1 1 1 1 HOSE, FUEL OIL 172171-14610 1 4 1 1 1 1 1 1 BRACKET, W.S. 172463-14610 1 5 1 1 1 1 1 1 HOSE, FUEL OIL 172463-14650 1 6 1 1 1 1 1 1 CLAMP 172112-16650 1 7 1 1 1 1 1 1 PUMP ASSY, FUEL FEED 129412-52100 1 8 1 1 1 1 1 1 SEPARATOR,WATER 129335-55705 1 9 1 1 1 1 1 1 VALVE, TAPER 104200-55321 2 10 1 1 1 1 1 1 SPRING, VALVE 104200-55330 2 11 1 1 1 1 1 1 HANDLE 104200-55341 2 12 1 1 1 1 1 1 COVER 121254-55510 2 13 1 1 1 1 1 1 O-RING 102103-55520 2 14 1 1 1 1 1 1 RING, RETAINING 110250-55610 2 15 1 1 1 1 1 1 SCREEN 121850-55710 2 16 1 1 1 1 1 1 SPRING 121257-55720 2 17 1 1 1 1 1 1 FLOAT 121257-55731 2 18 1 1 1 1 1 1 PLUG, 6 101720-55750 2 20 2 2 2 2 2 2 SCREW, M4 104200-55750 2 21 1 1 1 1 1 1 GASKET, 6X1.0 23418-060000 2 22 2 2 2 2 2 2 O-RING, 1AP10A 24311-240100 2 23 1 1 1 1 1 1 CLIP, HOSE 12 124766-59050 1 24 8 8 8 8 8 8 CLAMP, CORD 1A1380-59480 1 25 2 2 2 2 2 2 WASHER, 6 22137-060000 1 26 2 2 2 2 2 2 WASHER, 8 22137-080000 1 27 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 28 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 29 2 2 2 2 2 2 WASHER, SPRING 10 22217-100000 1 30 1 1 1 1 1 1 BOLT, M6X 16 26013-060162 1 31 2 2 2 2 2 2 BOLT, M10X 16 26013-100162 1 32 1 1 1 1 1 1 BOLT, M10X 16 26013-100162 1 33 1 1 1 1 1 1 BOLT, M8X 16 PLATED 26116-080162 1 34 2 2 2 2 2 2 BOLT, M8X 65 PLATED 26116-080652 1 35 1 1 1 1 1 1 BOLT, M10X 16 PLATED 26116-100162 1 36 1 1 1 1 1 1 BAND 146 933168-55770 1 37 1 1 1 1 1 1 BAND 300 172126-11510 1 38 1 1 1 1 1 1


0CS10-M40201

Fig.15. FUEL LINE VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.15



CORD ASSY, BATTERY 172478-16100 1 1 1 1 1 1 1 1 HARNESS C 172478-16120 2 3 1 1 1 1 1 1 CORD, BATTERY 172187-16110 1 4 1 1 1 1 1 1 BATTERY 172187-16150 1 5 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 6 1 1 1 1 1 1 WASHER, SPRING 10 22217-100000 1 7 1 1 1 1 1 1 BOLT, M10X 16 PLATED 26116-100162 1 8 1 1 1 1 1 1 NUT, M8 26716-080002 1 9 1 1 1 1 1 1 RETAINER, BATTERY 172112-16201 1 10 1 1 1 1 1 1 ROD, CLAMP 172512-16350 1 11 2 2 2 2 ROD 172164-16370 1 11-1 N 2 2 2 2 2 2

(A=M/#00619) (B=M/#00619) (D=M/#00619) (E=M/#00619)

WASHER, 8 22157-080000 1 12 2 2 2 2 2 2 NUT, M8 26716-080002 1 13 4 4 4 4 4 4


0CS10-M40201

Fig.16. BATTERY VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.16



BAND 300 172126-11510 1 1 5 5 5 5 5 5 HARNESS A 172478-16500 1 2 1 1 1 1 1 1 HUSE,SLOW BLOW (50A 172458-16550 2 4 1 1 1 1 1 1 DIODE 172648-16600 2 5 1 1 1 1 1 1 HARNESS B 172478-16520 1 7 1 1 1 1 1 1 HARNESS D 172187-16530 1 8 1 1 1 1 1 1 CLIP, HOSE 172183-16560 1 9 1 1 1 1 1 1 CORD, ENGINE EARTH 172187-16600 1 10 1 1 1 1 1 1 CLAMP 172112-16650 1 11 1 1 1 1 1 1 CLAMP 194440-51620 1 12 1 1 1 1 1 1 WASHER, 8 22137-080000 1 13 1 1 1 1 1 1 WASHER, 10 22137-100000 1 14 2 2 2 2 2 2 WASHER, SPRING 5 22217-050000 1 15 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 16 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 17 1 1 1 1 1 1 WASHER, SPRING 10 22217-100000 1 18 2 2 2 2 2 2 WASHER, SPRING 10 22217-100000 1 19 1 1 1 1 1 1 BOLT, M8X 16 PLATED 26116-080162 1 20 1 1 1 1 1 1 BOLT, M8X 16 PLATED 26116-080162 1 21 1 1 1 1 1 1 BOLT, M10X 16 PLATED 26116-100162 1 22 2 2 2 2 2 2 BOLT, M10X 16 PLATED 26116-100162 1 23 1 1 1 1 1 1 NUT, M5 26716-050002 1 24 1 1 1 1 1 1 BAND 170 933152-09280 1 25 5 5 5 5 5 5 GROMMET 933171-15680 1 26 1 1 1 1 1 1


0CS10-M40201

Fig.17. ELECTRIC PART(WIRING) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.17



HARNESS, AIR CON. 172455-16600 1 1 1 1 1 BAND 170 933152-09280 1 2 2 2 2


0CS10-M40201

Fig.18. ELECTRIC PART(WIRING)(A/C SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.18


Remarks (1)IMMOBILIZER SPEC. REFER TO FIG.23.


1 SWITCH ASSY, STARTER 172187-17100 1 1 1 1 1 1 1 1 CORD ASSY 172187-17070 2 2 1 1 1 1 1 1 COVER 172187-17080 2 3 3 3 3 3 3 3 COVER 172187-17090 2 4 2 2 2 2 2 2 KEY ASSY 933110-00301 2 6 1 1 1 1 1 1 BRACKET, RELAY 172455-17110 1 7 1 1 1 1 1 1 BOX, FUSE 172187-17200 1 8 1 1 1 1 1 1 PULLER 172175-17120 2 9 1 1 1 1 1 1 COVER 172187-17220 2 11 1 1 1 1 1 1 FUSE, B 5A 29420-050000 2 12 2 2 2 2 2 2 FUSE, B 15A 29420-150000 2 13 6 6 6 6 6 6 FUSE, B 30A 29420-300000 2 14 2 2 2 2 2 2 LAMP COMP.,WORKING 172162-17400 1 15 1 1 1 1 1 1 BULB 172141-17211 2 16 1 1 1 1 1 1 BOLT, M8X 20 26013-080202 2 17 2 2 2 2 2 2 WASHER, 8 22157-080000 2 18 2 2 2 2 2 2 LAMP ASSY, HEADLIGHT 172162-17410 1 19 1 1 1 1 1 1 BULB, 12V 25W 29220-788200 2 20 1 1 1 1 1 1 SWITCH, SAFETY START 194464-52190 1 21 2 2 2 2 2 2 HORN 194151-57100 1 22 1 1 1 1 1 1 RUBBER, SEAL 172146-61370 1 23 1 1 1 1 1 1 COLLAR, 9X12X24 172173-76690 1 24 1 1 1 1 1 1 RELAY, SAFETY 119247-77100 1 25 3 3 3 3 3 3 RELAY, SAFETY 129136-77200 1 26 1 1 1 1 1 1 RELAY ASSY, GLOW 119650-77910 1 27 1 1 1 1 1 1 NUT, LOCK M18 26776-180002 1 30 2 2 2 2 2 2 WASHER, 6 22157-060000 1 31 3 3 3 3 3 3 WASHER, SPRING 10 22217-100000 1 32 3 3 3 3 3 3 BOLT, M6X 12 26013-060122 1 33 2 2 2 2 2 2 BOLT, M6X 12 26013-060122 1 34 1 1 1 1 1 1 BOLT, M6X 16 26013-060162 1 35 2 2 2 2 2 2 BOLT, M6X 20 26013-060202 1 36 2 2 2 2 2 2 BOLT, M6X 20 26013-060202 1 37 2 2 2 2 2 2 BOLT, M6X 45 26013-060452 1 38 1 1 1 1 1 1 BOLT, M8X 16 26013-080162 1 39 2 2 2 2 2 2 BOLT, M10X 16 PLATED 26116-100162 1 40 3 3 3 3 3 3


0CS10-M40201

Fig.19. ELECTRIC PART(EQUIPMENT) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.19


Remarks (1)PLEASE USE THIS PART WITH FOLLOW- ING LABELS AT THE SAME TIME. REF.NO.10A & 10B. (2)LABELS ARE NOT ILLUSTRATED.


HARNESS, QUICK HITCH 172978-16501 1 1 1 1 1 BAND 172458-17880 1 2 2 2 2 BAND 170 933152-09280 1 3 2 2 2

1 BOX,SWITCH 172958-17100 1 4 1 1 1 STAY ASSY, SWITCH 172978-17100 1 5 1 1 1 SCREW 172137-46210 1 6 3 3 3 BOLT M 8X 16 172455-61710 1 7 2 2 2 PLUG 172187-64900 1 8 1 1 1 STEP 933169-15231 1 9 2 2 2

2 LABEL,SWITCH 172472-03290 1 10A 1 1 1 2 LABEL,COVER 172472-03300 1 10B 1 1 1


0CS10-M40201

Fig.20. ELECTRIC PART(QUICK COUPLER SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.20



HARNESS,CANOPY LAMP 172478-16550 1 1 1 1 1 LAMP 150X95 172458-17400 1 2 1 1 1 BULB 172458-17420 2 3 1 1 1 STAY, LAMP 172458-17410 1 4 1 1 1 WASHER, 10 22137-100000 1 5 1 1 1 BOLT, M10X 20 26013-100202 1 6 1 1 1


0CS10-M40201

Fig.21. CANOPY LIGHT VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.21



HANESS D 172478-16570 1 1 1 1 1 1 1 1 HARNESS,ALARM 172478-16580 2 2 1 1 1 1 1 1 SWITCH, PRESSURE 172478-17200 1 3 1 1 1 1 1 1 BUZZER, BACK 172511-17351 1 4 1 1 1 1 1 1 CASE ASSY, ALARM 172472-17400 1 5 1 1 1 1 1 1 COVER, ALARM CASE 172472-17470 1 9 1 1 1 1 1 1 CONNECTOR,PF1/4PT1/8 172156-76110 1 10 1 1 1 1 1 1 O-RING, 1BP11.0 24315-000110 1 11 1 1 1 1 1 1 BOLT, M6X 12 26013-060122 1 12 3 3 3 3 3 3 BOLT, M8X 12 26013-080122 1 13 1 1 1 1 1 1 BOLT, M10X 16 26013-100162 1 14 2 2 2 2 2 2 BAND 146 933168-55770 1 15 1 1 1 1 1 1


0CS10-M40201

Fig.22. TRAVEL ALARM VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.22


Remarks (1)HOUR METER = ANALOG TYPE. (2)IMMOBILIZER SPEC. (3)HOUR METER = L.C.D. TYPE. .


1 BOX,INDICATOR(CANOPY 172458-17500 1 1 1 1 1 SWITCH ASSY, LIGHT 172187-17280 2 3 1 1 1 PACKING 172187-17320 2 5 1 1 1 GAUGE ASSY 172187-17341 2 7 1 1 1 METER ASSY, HOUR 172187-17350 2 8 1 1 1 PRINT,CIRCUIT 172187-17360 2 9 1 1 1 CIRCUIT ASSY 172187-17371 2 10 1 1 1 BULB 172187-17380 2 11 4 4 4 PLATE 172187-17470 2 15 1 1 1 BULB 172187-17480 2 16 2 2 2 CAP 172187-17560 2 18 2 2 2 GASKET 172187-17570 2 19 2 2 2 BOLT 8X20 172458-46720 1 20 2 2 2 2 2 2 BOLT 172519-63240 1 21 2 2 2 2 2 2

1 INDICATOR BOX (CABIN 172472-17350 1 22 1 1 1 SWITCH ASSY, LIGHT 172187-17280 2 25 1 1 1 SWITCH ASSY, HEATER 172187-17290 2 26 1 1 1 SWITCH ASSY, WASHER 172472-17300 2 27 1 1 1 PACKING 172187-17320 2 29 1 1 1 GAUGE ASSY 172187-17341 2 31 1 1 1 METER ASSY, HOUR 172187-17350 2 32 1 1 1 PRINT,CIRCUIT 172187-17360 2 33 1 1 1 CIRCUIT ASSY 172187-17371 2 34 1 1 1 BULB 172187-17380 2 35 4 4 4 PLATE 172187-17470 2 39 1 1 1 BULB 172187-17480 2 40 2 2 2

1 INDICATOR BOX(A/C 172478-17350 1 41 1 1 1 SWITCH ASSY, LIGHT 172187-17280 2 43 1 1 1 SWITCH ASSY, WASHER 172472-17300 2 44 1 1 1 PACKING 172187-17320 2 46 1 1 1 GAUGE ASSY 172187-17341 2 48 1 1 1 METER ASSY, HOUR 172187-17350 2 49 1 1 1 PRINT,CIRCUIT 172187-17360 2 50 1 1 1 CIRCUIT ASSY 172187-17371 2 51 1 1 1 BULB 172187-17380 2 52 4 4 4 PLATE 172187-17470 2 56 1 1 1 BULB 172187-17480 2 57 2 2 2 CAP 172187-17560 2 58 1 1 1 GASKET 172187-17570 2 59 1 1 1

2 CYLINDER ASSY, KEY 172A47-17210 1 60 W 1 1 1 1 1 1 (A=M/#XXXXX) (B=M/#XXXXX) (C=M/#XXXXX) (D=M/#XXXXX) (E=M/#XXXXX) (F=M/#XXXXX)

3 MONITOR ASSY 172A77-17500 1 61 W 1 1 1 1 1 1 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)


0CS10-M40201

Fig.23. INDICATOR BOX VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.23



BAND 300 172126-11510 1 1 2 2 2 BAND 300 172126-11510 1 1-1 K 1 1 1

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

HEATER 172162-17601 1 2 1 1 HEATER 172162-17602 1 2-1 N 1 1 1

(A=M/#00502) (B=M/#00502)

GUIDE ASSY, HOSE 172455-17601 1 3 1 1 1 VALVE ASSY, HEATER 172425-17630 1 4 1 1 1 JOINT, PIPE 172124-17640 1 5 1 1 1 JOINT 129122-44480 1 5-1 N 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) HOSE ASSY, HEATER 172175-17730 1 6 2 2 2 GROMMET 933171-15680 1 9 2 2 2 DUCT ASSY, HEATER 172455-64910 1 10 1 1 1 SEAL, HEATER 172455-64110 2 11 4 4 4 SEAL, HEATER 172455-64120 2 12 2 2 2 SEAL, HEATER 172455-64130 2 13 2 2 2 ELBOW 172168-79520 1 15 1 1 1 ELBOW 172499-17650 1 15-1 N 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) WASHER, 10 22137-100000 1 16 4 4 4 CLAMP, 22 23000-022000 1 17 4 4 CLAMP, HOSE 22 23001-022000 1 17-1 N 4 4 4

(A=M/#00603) (B=M/#00603)

CLAMP, 18 23080-018000 1 17-2 N 4 4 4 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

BOLT, M8X 16 26013-080162 1 18 2 2 2 BOLT, M10X 20 26013-100202 1 19 4 4 4 BOLT, M10X 20 26013-100202 1 20 2 2 2 BAND 170 933152-09280 1 21 1 1 1 BAND W 397 172187-78580 1 22 W 1 1 1



0CS10-M40201

Fig.24. HEATER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.24



BAND 300 172126-11510 1 1 2 2 2 BAND 300 172126-11510 1 1-1 K 1 1 1


GUIDE ASSY, HOSE 172455-17601 1 2 1 1 1 VALVE ASSY, HEATER 172425-17630 1 3 1 1 1 JOINT, PIPE 172124-17640 1 4 1 1 1 JOINT 129122-44480 1 4-1 N 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) HOSE ASSY, HEATER 172455-17780 1 5 1 1 1 HOSE ASSY, HEATER 172455-17790 1 8 1 1 1 HOSE ASSY, HEATER 172455-17800 1 11 1 1 1 HOSE ASSY, HEATER 172455-17830 1 14 1 1 1 HOSE ASSY, HEATER 172455-17860 1 17 1 1 1 JOINT, HOSE 172455-17930 1 20 2 2 2 GROMMET 933171-15680 1 21 2 2 2 DUCT ASSY 172455-63600 1 22 1 1 1 SEAL, RUBBER 172455-63660 2 24 2 2 2 SHEET, INSULATOR 172455-63700 2 25 1 1 1 SHEET, INSULATOR 172455-63710 2 26 1 1 1 SHEET, INSULATOR 172455-63720 2 27 1 1 1 SEAL, HEATER 172455-64110 2 28 2 2 2 SEAL, HEATER 172455-64130 2 29 2 2 2 RUBBER, SEAL 172164-66650 2 30 2 2 2 ELBOW 172168-79520 1 31 1 1 1 ELBOW 172499-17650 1 31-1 N 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) CLAMP, 22 23000-022000 1 32 10 10 CLAMP, HOSE 22 23001-022000 1 32-1 N 10 10 10

(A=M/#00603) (B=M/#00603) CLAMP, HOSE 22 23001-022000 1 32-2 K 6 6 6

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) BOLT, M8X 16 26013-080162 1 33 2 2 2 BOLT, M10X 20 26013-100202 1 34 2 2 2 BAND 170 933152-09280 1 35 1 1 1 CLAMP, 18 23080-018000 1 36 W 4 4 4


BAND W 397 172187-78580 1 37 W 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)


0CS10-M40201

Fig.25. HEATER(AIR CONDITIONER SPEC.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.25


Remarks (1)Interchangeable by simultaneous replacement with Ref.No.12,13,14, 15,16.


HARNESS, WIRE 172478-16610 1 1 1 1 1 BRACKET,WASHER 172478-17600 1 2 1 1 1 TANK ASSY, WASHER 172472-17610 1 3 1 1 1

1 TANK ASSY, WASHER 172472-17611 1 3-1 F 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

BRACKET 172472-17650 2 6 Z 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

WASHER, 6 22137-060000 2 7 Z 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

WASHER, SPRING 6 22217-060000 2 8 Z 2 2 2 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

BOLT, M6X 16 PLATED 26116-060162 2 9 Z 2 2 2 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

JOINT, PIPE 198127-86540 1 10 1 1 1 BOLT, M10X 16 26013-100162 1 11 2 2 2 BRACKET 120147-44810 1 12 W 1 1 1

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) WASHER, 6 22137-060000 1 13 W 1 1 1

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) WASHER, SPRING 6 22217-060000 1 14 W 2 2 2


PIPE, 4X3000 23061-043000 1 15 W 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

BOLT, M6X 16 PLATED 26116-060162 1 16 W 2 2 2 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)


0CS10-M40201

Fig.26. WIND WASHER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.26


Remarks (1)INTERCHANGEABLE BY SIMULTANEOUS REPLACEMENT WITH REF.NO.11-1 & 31-1. (2)INTERCHANGEABLE BY SIMULTANEOUS REPLACEMENT WITH REF.NO.25-1. REF.NO.10 T=6MM,NO.10-1 & 10-2 T=9MM.


PULLEY ASSY, TENSION 172187-11100 1 1 2 2 2 PULLEY, TENSION 172187-11121 2 2 2 2 2 RING, 35 22252-000350 2 3 2 2 2 BEARING, 6202UUC3 24104-062020 2 4 2 2 2 BAND 300 172126-11510 1 5 1 1 1 CONDITIONER ASSY,AIR 172455-18100 1 6 1 1 1 COMPRESSOR 172445-18201 2 7 1 1 1 TUBE, CORRUGATED 172478-18210 1 8 1 1 1 BRACKET (A) 172187-18300 1 9 1 1 1

1 BRACKET A ASSY,ID 172187-18301 1 9-1 F 1 1 1 (A=M/#01141) (B=M/#01141) (C=M/#01141)

BRACKET ASSY, A 172A21-18350 1 9-2 N 1 1 1 (A=M/#01146) (B=M/#01146) (C=M/#01146)

BRACKET (B) 172187-18340 1 10 1 1 1 2 BRACKET (B) 172187-18341 1 10-1 F 1 1 1

(A=M/#01146) (B=M/#01146) (C=M/#01146) BRACKET (B) 172187-18342 1 10-2 N 1 1 1

(A=M/#01146) (B=M/#01146) (C=M/#01146)

GUARD ASSY, BELT 172187-18401 1 11 1 1 1 GUARD ASSY, BELT 172187-18402 1 11-1 S 1 1 1

(A=M/#01141) (B=M/#01141) (C=M/#01141)

NUT, PULLEY 172187-18410 1 12 1 1 1 BRACKET 172187-18420 1 13 1 1 1 V-BELT 172187-18451 1 14 1 1 1 BAR, ADJUST 172187-18500 1 15 1 1 1 HOSE 172478-18500 1 16 1 1 1 BRACKET, COMP. 172455-18560 1 17 1 1 1 CLAMP, WIRE 1A1380-55310 1 18 2 2 2 SPACER 129466-96240 1 19 2 2 2 WASHER, 8 22137-080000 1 20 2 2 2 WASHER, 8 22137-080000 1 21 2 2 2 WASHER, 8 22137-080000 1 22 2 2 2 WASHER, 8 22137-080000 1 23 3 3 3 WASHER, 10 22137-100000 1 24 2 2 2 BOLT, M8X 16 26013-080162 1 25 2 2 2 BOLT, M8X 20 26013-080202 1 25-1 S 2 2 2

(A=M/#01146) (B=M/#01146) (C=M/#01146) BOLT, M8X 16 26013-080162 1 26 1 1 1 BOLT, M8X 25 26013-080252 1 27 1 1 1 BOLT, M8X 25 26013-080252 1 28 2 2 2 BOLT, M8X 25 26013-080252 1 29 2 2 2 BOLT, M8X 35 26013-080352 1 30 1 1 1 BOLT, M10X 16 26013-100162 1 31 2 2 2 BOLT, M8X 16 26013-080162 1 31-1 S 2 2 2

(A=M/#01141) (B=M/#01141) (C=M/#01141)

BOLT, M8X 35 PLATED 26106-080352 1 32 Z 1 1 1 (A=M/#01146) (B=M/#01146) (C=M/#01146)

BOLT, M8X 60 PLATED 26106-080602 1 33 1 1 1 BOLT, M10X 35 PLATED 26106-100352 1 34 2 2 2 BOLT, M8X 50 26450-080502 1 35 2 2 2


0CS10-M40201

Fig.27. AIR CONDITIONER(ENGINE RELATED VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.27



BRACKET 172162-18040 2 1 1 1 1 MOTOR 172164-18080 2 2 1 1 1 DRIER ASSY, RECEIVER 172187-18110 2 3 1 1 1 CONDENSER 172164-18780 2 4 1 1 1 FAN 172164-18790 2 5 1 1 1 MOUNT, RADIATOR 172122-13310 1 6 4 4 4 COVER ASSY, FAN 172455-18290 1 7 1 1 1 COVER ASSY 172455-18331-1 1 8 1 1 1 SEAL 172455-18340 2 9 3 3 3 SEAL 172455-18350 2 10 1 1 1 PLATE, COND. 172455-18500 1 12 1 1 1 BRACKET, R/D 172455-18940 1 13 1 1 1 WASHER, 6 22137-060000 1 14 4 4 4 WASHER, SPRING 6 22217-060000 1 15 4 4 4 WASHER, SPRING 8 22217-080000 1 16 8 8 8 BOLT, M8X 12 26013-080122 1 17 2 2 2 BOLT, M8X 20 26013-080202 1 18 2 2 2 BOLT, M8X 20 26013-080202 1 19 3 3 3 BOLT, M10X 20 26013-100202 1 20 4 4 4 SCREW, M5X12 26023-050122 1 21 3 3 3 BOLT, M6X 60 PLATED 26116-060602 1 22 4 4 4 NUT, M5 26367-050002 1 23 1 1 1 NUT, M8 26716-080002 1 24 8 8 8 BAND 170 933152-09280 1 25 2 2 2 WASHER, 10 22137-100000 1 26 W 4 4 4

(A=M/#00719) (B=M/#00719)


0CS10-M40201

Fig.28. AIR CONDITIONER(CONDENSER RELATED) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.28



CONDITIONER, AIR 172455-18120 2 1 1 1 1 EVAPORATOR ASSY 172455-18010 3 1A W 1 1 1

(A=M/#00539) (B=M/#00539) (C=M/#00539)

VALVE,EXPANSION 172455-18080 4 1AA W 1 1 1 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX)

CORE ASSY, HEATER 172455-18020 3 1B W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

FAN MOTOR 172455-18030 3 1C W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

HOSE, AIR 172455-18040 3 1D W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

RESISTOR 172455-18050 3 1E W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

THERMOSTAT 172455-18060 3 1F W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

ISOLATOR 172455-18070 3 1G W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

CLIP 198244-87040 3 1H W 1 1 1 (A=M/#00539) (B=M/#00539) (C=M/#00539)

SCREW, TAPPING M4X16 198244-88040 3 1I W 16 16 16 (A=M/#00539) (B=M/#00539) (C=M/#00539)

SWITCH, CONTROL 172455-18140 2 2 1 1 1 GRILLE 197830-87910 2 3 2 2 2 GRILLE 197821-88070 2 4 1 1 1 MOUNT, RADIATOR 172124-13500 1 5 4 4 4 BRACKET, A/U 172455-18520 1 6 2 2 2 DUCT ASSY 172478-18601 1 7 1 1 1 SEAL, DUCT 172455-18610 2 8 1 1 1 TRIM 172455-18640 2 9 1 1 1 SHEET, INSULATOR 172455-19110 2 11 1 1 1 SHEET, INSULATOR 172455-19120 2 12 1 1 1 SHEET, INSULATOR 172455-19130 2 13 1 1 1 SHEET, INSULATOR 172455-19140 2 14 1 1 1 SHEET, INSULATOR 172455-19150 2 15 1 1 1 RUBBER 172141-65330 2 16 1 1 1 SEAL, BONNET 172175-65530 2 17 1 1 1 SEAL, DUCT 172175-65680 2 18 1 1 1 DUCT, CABIN 172478-18800 1 19 1 1 1 SEAL, DUCT 172455-18811 2 20 1 1 1 SEAL, DUCT 172455-18820 2 21 1 1 1 SEAL 172455-18860 1 23 2 2 2 SEAL 172455-18870 1 24 1 1 1 BOLT 172519-63240 1 25 4 4 4 BOLT 172165-66980 1 26 4 4 4 RELAY, SAFETY 119247-77100 1 27 3 3 3 WASHER, 6 22137-060000 1 28 3 3 3 WASHER, 8 22137-080000 1 29 4 4 4 WASHER, SPRING 8 22217-080000 1 30 2 2 2 WASHER, SPRING 8 22217-080000 1 31 4 4 4 SCREW, 4X16 22869-400160 1 32 12 12 12 BOLT, M6X 12 26013-060122 1 33 3 3 3


0CS10-M40201

Fig.29. AIR CONDITIONER(CABIN RELATED) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.29



SCREW, M5X20 26559-050202 1 34 4 4 4 NUT, M8 26712-080002 1 35 2 2 2 NUT, M8 26712-080002 1 36 8 8 8 CLIP, TREE 172444-17660 1 37 W 2 2 2

(A=M/#00688) (B=M/#00688) PLUG 172176-67790 1 38 W 2 2 2

(A=M/#00719) (B=M/#00719)


0CS10-M40201

Fig.29. AIR CONDITIONER(CABIN RELATED) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.29



PLUG, DRAIN 172162-18070 2 1 2 2 2 CONNECTOR 172165-18080 2 2 1 1 1 VALVE, HOT WATER 172455-18160 2 3 1 1 1 CLAMP, WIRE 172455-18170 2 4 1 1 1 HOSE 172455-18180 2 5 1 1 1 HOSE 172455-18190 2 6 1 1 1 HOSE 172455-18200 2 7 1 1 1 HOSE 172455-18210 2 8 1 1 1 INSULATOR 197821-88380 2 9 1 1 1 HOSE, DRAIN 172455-18250 1 10 1 1 1 HOSE, DRAIN 172455-18260 1 11 1 1 1 HOSE, DRAIN 172455-18270 1 12 1 1 1 PLATE 172455-18510 1 13 2 2 2 WIRE, VALVE 172455-18540 1 14 1 1 1 SPONGE, HOSE 172455-19210 1 15 2 2 2 WASHER, 6 22137-060000 1 16 2 2 2 WASHER, 8 22137-080000 1 17 2 2 2 WASHER, 8 22137-080000 1 18 4 4 4 BOLT, M6X 25 26013-060252 1 19 2 2 2 BOLT, M8X 20 26013-080202 1 20 4 4 4 BOLT, M8X 25 26013-080252 1 21 2 2 2 SCREW, M5X10 26022-050102 1 22 3 3 3 SCREW, M4X 8 26023-040082 1 23 1 1 1 BAND 170 933152-09280 1 24 2 2 2 BAND 170 933152-09280 1 25 1 1 1 BAND 170 933152-09280 1 26 1 1 1


0CS10-M40201

Fig.30. AIR CONDITIONER(PIPING) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.30


Remarks (1)SHAFT,CARRIER ROLLER WAS STOOPED TO SUPPLY. (2)D=REF.NO.6,7-2,9-1 38MM, NO.6-1,7-3,9-2 40MM. (3)D1 : Ref.No.20 71mm, No.20-1 80mm.


SPROCKET 172187-29101-2 1 1 2 2 2 2 2 2 BOLT 14X35 172455-29140 1 2 24 24 24 24 24 24 WASHER 14X35 172455-29150 1 3 24 24 24 24 24 24 ROLLER,LOWER(GREEN82 172478-37300-1 1 4 10 10 10 10 10 10 ROLLER,LOWER(GREEN82 172478-37301-1 1 4-1 N 10 10 10 10 10 10

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146)

ROLLER ASSY, LOWER 172478-37302 1 4-2 N 10 10 10 10 10 10 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

BUSHING 182900-55790 3 6 20 20 20 20 20 20 2 BUSH 40X40 172478-37400 3 6-1 S 20 20 20 20 20 20

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) SHAFT 172478-37350 2 7 10 10 10 10 10 10 SHAFT ASSY 172478-37340 2 7-1 N 10 10 10 10 10 10

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) SHAFT ASSY 172478-37341 2 7-2 S 10 10 10 10 10 10

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) 2 SHAFT ASSY 172478-37342 2 7-3 S 10 10 10 10 10 10

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

COVER, SEAL 172478-37360 2 8 Z 10 10 10 10 10 10 (A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146)

COVER, SEAL 172478-37370 2 9 10 10 10 10 10 10 COVER, SEAL 172478-37371 2 9-1 S 10 10 10 10 10 10

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) 2 COVER, SEAL 172478-37372 2 9-2 S 10 10 10 10 10 10

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) SEAL, FLOATING 172478-37380 2 10 20 20 20 20 20 20 RING, 32 22242-000320 2 11 10 10 10 10 10 10 RING, 36 22242-000360 2 11-1 S 10 10 10 10 10 10

(A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146) RING, 38 22242-000380 2 11-2 S 10 10 10 10 10 10

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) O-RING, 1AP38.0 24311-000380 2 12 10 10 10 10 10 10 O-RING, 1AP34.0 24311-000340 2 12-1 S 10 10 10 10 10 10

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) PLUG PT1/8 933171-13691 2 13 10 10 10 10 10 10 WASHER, SPRING 20 22217-200000 1 14 20 20 20 20 20 20 BOLT, M20X 40 PLATED 26116-200402 1 15 20 20 20 20 20 20

1 ROLLER,CARRIER (82) 172478-37500-1 1 16 2 2 2 2 2 2 ROLLER ASSY, CARRIER 172478-37501 1 16-1 N 2 2 2 2 2 2

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) (D=MXXXXX) (E=MXXXXX) (F=MXXXXX) WASHER, CARRIER 172187-37530 2 19 2 2 2 2 WASHER, CARRIER 172478-37550 2 19-1 R 2 2 2 2 2 2

(A=M/#00541) (B=M/#00541) (D=M/#00541) (E=M/#00541) SEAL, CARRIER ROLLER 172478-37530 2 20 2 2 2 2 2 2

3 SEAL, OIL 172164-37351 2 20-1 S 2 2 2 2 2 2 (A=MXXXXX) (B=MXXXXX) (C=MXXXXX) (D=MXXXXX) (E=MXXXXX) (F=MXXXXX)

CAP, ROLLER 172187-37540 2 21 2 2 2 2 CAP, ROLLER 172478-37540 2 21-1 R 2 2 2 2 2 2

(A=M/#00541) (B=M/#00541) (D=M/#00541) (E=M/#00541) RING, 30 22242-000300 2 22 2 2 2 2 2 2 RING, 62 22252-000621 2 23 2 2 2 2 2 2


0CS10-M40201

Fig.31. SPROCKET & ROLLER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.31


Remarks (1)SHAFT,CARRIER ROLLER WAS STOOPED TO SUPPLY. (2)D=REF.NO.6,7-2,9-1 38MM, NO.6-1,7-3,9-2 40MM. (3)D1 : Ref.No.20 71mm, No.20-1 80mm.


BEARING, BALL 6206Z 24105-062064 2 24 4 4 4 4 4 4 PLUG PT1/8 933171-13691 2 25 2 2 2 2 2 2 WASHER, SPRING 16 22217-160000 1 26 2 2 2 2 2 2 BOLT, M16X 85 PLATED 26116-160852 1 27 2 2 2 2 2 2 NUT, M16 26716-160002 1 28 2 2 2 2 2 2


0CS10-M40201

Fig.31. SPROCKET & ROLLER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.31


Remarks (1)THIS PART IS USED BOTH IN RUBBER CRAWLER & IRON CRAWLER.


IDLER ASSY 772478-37120 1 1 W 2 2 2 2 2 2 (A=XXX)

1 IDLER ASSY 772478-37100-1 2 2 2 2 2 2 1 IDLER ASSY 772478-37101 2 2-1 R 2 2 2 2 2 2

(A=M/#00603) (B=M/#00603) (D=M/#00603) (E=M/#00603) IDLER ASSY 172478-37100-1 3 3 2 2 2 2 2 2 BUSHING 182900-57380 4 4 4 4 4 4 4 4 COVER, SEAL 172478-37140 3 5 2 2 2 2 2 2 COVER, SEAL 172478-37150 3 6 2 2 2 2 2 2 SEAL, FLOATING 172162-37171 3 7 4 4 4 4 SEAL, FLOATING 172455-37160 3 7-1 R 4 4 4 4 4 4

(A=M/#00603) (B=M/#00603) (D=M/#00603) (E=M/#00603)

SHAFT, IDLER 172455-37170 3 8 2 2 2 2 2 2 SP PIN 10AWX70 172455-37180 3 9 2 2 2 2 2 2 RING, 40 22242-000400 3 10 2 2 2 2 2 2 O-RING, 1AP38.0 24311-000380 3 11 4 4 4 4 4 4 PLUG PT1/8 933171-13691 3 12 2 2 2 2 2 2 ADJUSTER ASSY 172187-37700-2 2 13 2 2 2 2 2 2 PLATE,ADJUSTER 172162-37810 2 14 2 2 2 2 2 2 WASHER, SPRING 14 22217-140000 2 15 8 8 8 8 8 8 PLATE,ADJUSTER 172162-37810 2 16 2 2 2 2 2 2 TUBE ASSY, ADJUST 172162-37770 1 17 2 2 2 2 2 2 PISTON 172162-37800 1 18 2 2 2 2 2 2 VALVE ASSY, NIPPLE 172122-37844 1 19 2 2 2 2 2 2 O-RING, 1BP14.0 24315-000140 2 20 2 2 2 2 2 2 NIPPLE, GREASE PT1/8 24761-020000 2 21 2 2 2 2 2 2 O-RING, 1BG55.0 24325-000550 1 22 2 2 2 2 O-RING, 55.0 198072-17440 1 22-1 N 2 2 2 2 2 2

(A=M/#00537) (B=M/#00537) (D=M/#00537) (E=M/#00537) SEAL, OIL 933126-50500 1 23 2 2 2 2 2 2 RING G55,BACKUP 933138-12101 1 24 2 2 2 2 RING 55,BACKUP 172478-37710 1 24-1 N 2 2 2 2 2 2

(A=M/#00537) (B=M/#00537) (D=M/#00537) (E=M/#00537)


0CS10-M40201

Fig.32. IDLER & ADJUST VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.32



SHOE ASSY, TRACK 450 172455-38100-1 1 1 1 1 1 1 1 1 SHOE ASSY, TRACK 450 172455-38101-1 1 1-1 N 1 1 1 1 1 1


LINK ASSY 172455-38120 2 2 1 1 1 1 1 1 LINK ASSY 172455-38121 2 2-1 N 1 1 1 1 1 1


LINK, TRACK L 172455-38180 3 3 38 38 38 38 38 38 LINK, TRACK L 172455-38180 3 3-1 K 39 39 39 39 39 39


LINK, TRACK R 172455-38190 3 4 38 38 38 38 38 38 LINK, TRACK R 172455-38190 3 4-1 K 39 39 39 39 39 39


LINK, MASTER L 172455-38200 3 5 Z 1 1 1 1 1 1 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

LINK, MASTER R 172455-38210 3 6 Z 1 1 1 1 1 1 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

BUSH, TRACK 172455-38220 3 7 38 38 38 38 38 38 PIN, TRACK 172455-38230 3 8 38 38 38 38 38 38 BUSH, MASTER 172455-38240 3 9 1 1 1 1 1 1 PIN, MASTER 172455-38250 3 10 1 1 1 1 1 1 PIN,MASTER 172455-38290 3 10-1 S 1 1 1 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) COLLAR 172455-38260 3 11 2 2 2 2 2 2 COTTER PIN 172455-38270 3 12 Z 1 1 1 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) SEAL 172455-38280 3 13 76 76 76 76 76 76 SHOE, TRACK 450L 172455-38130-1 2 14 39 39 39 39 39 39 NUT, SHOE 172455-38160 2 15 78 78 78 78 78 78 NUT, SHOE 172455-38160 2 16 78 78 78 78 78 78 BOLT 172455-38170 2 17 78 78 78 78 78 78 BOLT 172455-38170 2 18 78 78 78 78 78 78 SHOE ASSY, TRACK 450 172455-38110-1 1 19 1 1 1 1 1 1 SHOE ASSY, TRACK 450 172455-38111-1 1 19-1 N 1 1 1 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) LINK ASSY 172455-38120 2 20 1 1 1 1 1 1 LINK ASSY 172455-38121 2 20-1 N 1 1 1 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) LINK, TRACK L 172455-38180 3 21 38 38 38 38 38 38 LINK, TRACK L 172455-38180 3 21-1 K 39 39 39 39 39 39

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) LINK, TRACK R 172455-38190 3 22 38 38 38 38 38 38 LINK, TRACK R 172455-38190 3 22-1 K 39 39 39 39 39 39

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) LINK, MASTER L 172455-38200 3 23 Z 1 1 1 1 1 1


LINK, MASTER R 172455-38210 3 24 Z 1 1 1 1 1 1 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

BUSH, TRACK 172455-38220 3 25 38 38 38 38 38 38 PIN, TRACK 172455-38230 3 26 38 38 38 38 38 38 BUSH, MASTER 172455-38240 3 27 1 1 1 1 1 1 PIN, MASTER 172455-38250 3 28 1 1 1 1 1 1


0CS10-M40201

Fig.33. CRAWLER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.33



PIN,MASTER 172455-38290 3 28-1 S 1 1 1 1 1 1 (A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ)

COLLAR 172455-38260 3 29 2 2 2 2 2 2 COTTER PIN 172455-38270 3 30 Z 1 1 1 1 1 1

(A=MZZZZZ) (B=MZZZZZ) (C=MZZZZZ) (D=MZZZZZ) (E=MZZZZZ) (F=MZZZZZ) SEAL 172455-38280 3 31 76 76 76 76 76 76 SHOE, TRACK 450R 172455-38140-1 2 32 39 39 39 39 39 39 NUT, SHOE 172455-38160 2 33 78 78 78 78 78 78 NUT, SHOE 172455-38160 2 34 78 78 78 78 78 78 BOLT 172455-38170 2 35 78 78 78 78 78 78 BOLT 172455-38170 2 36 78 78 78 78 78 78 CRAWLER, RUBBER 172455-38601 1 37 2 2 2 2 2 2 TRACK ASSY, MASTER 172455-38300-1 1 38 W 1 1 1 1 1 1

(A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09) SHOE, TRACK 450L 172455-38130-1 2 39 W 1 1 1 1 1 1

(A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09) NUT, SHOE 172455-38160 2 40 W 4 4 4 4 4 4

(A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

BOLT 172455-38170 2 41 W 4 4 4 4 4 4 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

MASTER LINK(L 172455-38200 3 42 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

MASTER LINK(R 172455-38210 3 43 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

BUSH, MASTER 172455-38240 3 44 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

TRACK ASSY, MASTER 172455-38310-1 1 45 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

SHOE, TRACK 450R 172455-38140-1 2 46 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

NUT, SHOE 172455-38160 2 47 W 4 4 4 4 4 4 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

BOLT 172455-38170 2 48 W 4 4 4 4 4 4 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

MASTER LINK(L 172455-38200 3 49 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

MASTER LINK(R 172455-38210 3 50 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)

BUSH, MASTER 172455-38240 3 51 W 1 1 1 1 1 1 (A=*2003.09) (B=*2003.09) (C=*2003.09) (D=*2003.09) (E=*2003.09) (F=*2003.09)


0CS10-M40201

Fig.33. CRAWLER VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.33



GRIP 1D4070-23580 1 1 1 1 1 1 1 1 STAND ASSY, LINK 172478-45400 1 2 1 1 1 1 1 1 BRACKET,BOOT (12) 172455-45520 1 3 1 1 1 1 1 1 GUIDE, HOSE 172458-45850 1 4 1 1 1 1 1 1 O-RING 172124-46200 1 5 2 2 2 2 2 2 BRACKET ASSY,R (73) 172472-46210 1 6 1 1 1 1 1 1 BRACKET ASSY,L (73) 172472-46220 1 7 1 1 1 1 1 1 STAND, LEVER 172472-46600 1 8 1 1 1 1 1 1 BUSH 2015 172141-41370 2 9 2 2 2 2 2 2 BUSH, 25X15 24550-025150 2 11 2 2 2 2 2 2 SPRING 172162-46690 1 12 1 1 1 1 1 1 SPRING, GAS 172455-46890 1 13 1 1 1 1 1 1 BRACKET, SWITCH 172455-46950 1 14 1 1 1 1 1 1 BUSH 172165-47550 1 15 1 1 1 1 1 1 GUIDE, LOCK 172478-47600 1 16 1 1 1 1 1 1 LEVER L,LOCK(GRAY:72 172478-47620 1 17 1 1 1 1 1 1 ROD,SPRING (GRAY:72) 172458-47640-4 1 18 1 1 1 1 1 1 SHIM 172165-47980 1 19 2 2 2 2 2 2 WASHER 25.5X42 172165-47990 1 20 1 1 1 1 1 1 WASHER, 8 22137-080000 1 21 2 2 2 2 2 2 WASHER, 8 22137-080000 1 22 2 2 2 2 2 2 WASHER, 8 22137-080000 1 23 2 2 2 2 2 2 RING, 25 22242-000250 1 24 1 1 1 1 1 1 RING, E- 7 22272-000070 1 25 1 1 1 1 1 1 PIN, SPRING 3.5X40 22351-035040 1 26 1 1 1 1 1 1 PIN, SPRING 6.0X40 22351-060040 1 27 1 1 1 1 1 1 PIN, COTTER 2.0X20 22417-200200 1 28 2 2 2 2 2 2 O-RING, 1AP34.0 24311-000340 1 29 2 2 2 2 2 2 NIPPLE, GREASE C 24761-050000 1 30 2 2 2 2 2 2 BOLT, M8X 16 26013-080162 1 31 2 2 2 2 2 2 BOLT, M8X 16 26013-080162 1 32 2 2 2 2 2 2 BOLT, M8X 20 26013-080202 1 33 2 2 2 2 2 2 BOLT, M8X 20 26013-080202 1 34 6 6 6 6 6 6 BOLT, M10X 20 26013-100202 1 35 6 6 6 6 6 6 BOLT, M10X 20 26013-100202 1 36 2 2 2 2 2 2


0CS10-M40201

Fig.34. CONTROL EQUIPMENT(LOCK LEVER & STAND) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.34



BOOTS 172141-41340 1 1 2 2 2 2 2 2 LEVER L,TRACK (72) 172455-45101 1 2 1 1 1 1 1 1 BUSH 2015 172141-41370 2 3 2 2 2 2 2 2 LEVER R,TRACK (72) 172455-45131 1 5 1 1 1 1 1 1 BUSH 2015 172141-41370 2 6 2 2 2 2 2 2 GRIP, DRIVE 172187-45870 1 8 1 1 1 1 1 1 GRIP, DRIVE 172187-45880 1 9 1 1 1 1 1 1 O-RING 172124-46200 1 10 3 3 3 3 3 3 WASHER, 4 22117-040000 1 11 2 2 2 2 2 2 NIPPLE, GREASE PT1/8 24761-020000 1 12 2 2 2 2 2 2 BOLT, M10X 50 PLATED 26116-100504 1 13 4 4 4 4 4 4 SCREW, M4X12 26587-040122 1 14 2 2 2 2 2 2 NUT, M10 26716-100002 1 15 4 4 4 4 4 4 SHAFT ASSY, TRACK 172455-45151 1 16 1 1 1 1 1 1 BOLT, M10X 25 26013-100252 1 17 2 2 2 2 2 2 PEDALL CMP (GRAY:72) 172187-45220-1 1 18 1 1 1 1 1 1 PEDAL PAD L 172187-45250 1 19 1 1 1 1 1 1 PEDAL R CMP(GRAY:72) 172187-45260-1 1 20 1 1 1 1 1 1 PEDAL PAD R 172187-45280 1 21 1 1 1 1 1 1 BOLT, M6X 30 26013-060302 1 22 4 4 4 4 4 4 ROD 98.5 172162-46210 1 23 2 2 2 2 2 2 ELBOW 172122-46590 1 24 2 2 2 2 2 2 WASHER, 8 22137-080000 1 25 2 2 2 2 2 2 PIN, COTTER 1.6X16 22417-160160 1 26 2 2 2 2 2 2 NUT, M8 26051-080002 1 27 4 4 4 4 4 4 PIN 4.75X14 933110-54100 1 28 2 2 2 2 2 2


0CS10-M40201

Fig.35. CONTROL EQUIPMENT(TRAVEL) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.35



GRIP 172964-12140 1 1 1 1 1 1 1 1 LEVER,BLADE(GRAY:72) 172478-45100 1 2 1 1 1 1 1 1 BOLT, M10X 35 PLATED 26116-100354 1 3 2 2 2 2 2 2 NUT, M10 26716-100002 1 4 2 2 2 2 2 2 WASHER, SPRING 1A1040-43900 1 5 1 1 1 1 1 1 WASHER, SPRING 8 22217-080000 1 6 1 1 1 1 1 1 O-RING, 1AP21.0 24311-000210 1 7 2 2 2 2 2 2 BOLT, M8X 20 PLATED 26116-080202 1 8 1 1 1 1 1 1 CABLE, BLADE 172455-45800 1 9 1 1 1 1 1 1 JOINT, BALL 172458-45810 2 10 W 1 1 1 1 1 1

(A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502) NUT, LOCK M5 26757-050002 2 11 W 1 1 1 1 1 1

(A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502) PIN, COTTER 1.6X16 22417-160160 1 12 1 1 1 1 1 1 NUT, M8 26051-080002 1 13 1 1 1 1 1 1 PIN 4.75X14 933110-54100 1 14 1 1 1 1 1 1


0CS10-M40201

Fig.36. CONTROL EQUIPMENT(BLADE) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.36



LINK ASSY, SWING 172455-45170 1 1 1 1 1 1 1 1 BUSH 2015 172141-41370 2 2 2 2 2 2 2 2 LINK,PEDAL (GRAY:72) 172445-45550 1 4 1 1 1 1 1 1 BUSH 1415 172141-41360 2 5 2 2 2 2 2 2 SHAFT ASSY 172444-45850 1 7 1 1 1 1 1 1 WASHER, 10X36X4.5 1A1040-45890 1 8 1 1 1 1 1 1 O-RING 172124-46200 1 9 2 2 2 2 2 2 WASHER, SPRING 10 22217-100000 1 10 1 1 1 1 1 1 O-RING, 1AP21.0 24311-000210 1 11 2 2 2 2 2 2 NIPPLE, GREASE B 24761-040000 1 12 1 1 1 1 1 1 NIPPLE, GREASE C 24761-050000 1 13 1 1 1 1 1 1 BOLT, M8X 16 26013-080162 1 14 2 2 2 2 2 2 BOLT, M8X 25 PLATED 26116-080254 1 15 2 2 2 2 2 2 BOLT, M10X 20 PLATED 26116-100202 1 16 1 1 1 1 1 1 NUT, M8 26716-080002 1 17 2 2 2 2 2 2 PEDAL,SWING(GRAY:72) 172187-45500-4 1 18 1 1 1 1 1 1 SHAFT, COVER 172187-45650 1 19 1 1 1 1 SHAFT 172187-45651 1 19-1 R 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) COVER, PEDAL 172187-45720-4 1 20 1 1 1 1 1 1 COVER PAD 172187-45760 1 21 1 1 1 1 1 1 BOOTS, PEDAL 172157-45990 1 22 1 1 1 1 1 1 BOLT 172165-46340 1 23 2 2 2 2 2 2 WASHER, 10 22137-100000 1 24 2 2 2 2 WASHER, 10 22137-100000 1 24-1 K 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) PIN, COTTER 2.5X20 22417-250200 1 25 2 2 2 2 PIN, COTTER 2.5X20 22417-250200 1 25-1 K 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) NUT, M8 194200-37780 1 26 1 1 1 1 1 1 JOINT, BALL 172734-41300 1 27 1 1 1 1 1 1 ROD 140 172142-43540 1 28 1 1 1 1 1 1 ROD 250 M8LR 172455-45550 1 29 1 1 1 1 1 1 ELBOW 172122-46590 1 30 2 2 2 2 2 2 WASHER, 8 22137-080000 1 31 3 3 3 3 3 3 WASHER, SPRING 8 22217-080000 1 32 1 1 1 1 1 1 PIN, COTTER 1.6X16 22417-160160 1 33 1 1 1 1 1 1 NUT, M8 26051-080002 1 34 5 5 5 5 5 5 PIN 4.75X14 933110-54100 1 35 1 1 1 1 1 1


0CS10-M40201

Fig.37. CONTROL EQUIPMENT(SWING) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.37



SPRING, RETURN 172162-12480 1 1 1 1 1 1 1 1 WASHER, SPRING 1A1040-43900 1 2 1 1 1 1 1 1 PEDAL,LO-HI(GRAY:72) 172472-45900 1 3 1 1 1 1 PEDAL,LO-HI(GRAY:72) 172487-45900 1 3-1 N 1 1 1 1 1 1

(A=M/#00719) (B=M/#00719) (D=M/#00719) (E=M/#00719) BRACKET,PEDAL(GRAY72 172458-45920 1 4 1 1 1 1 1 1 BUSH 1415 172141-41360 2 5 2 2 2 2 2 2 PAD,PEDAL 172458-45950 1 7 1 1 1 1 1 1 O-RING, 1AP21.0 24311-000210 1 8 2 2 2 2 2 2 BOLT, M8X 16 26013-080162 1 9 2 2 2 2 2 2 BOLT, M8X 20 26013-080202 1 10 1 1 1 1 1 1


0CS10-M40201

Fig.38. CONTROL EQUIPMENT(LOW-HIGH PEDAL) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.38



SPRING 172068-28490 1 1 2 2 2 2 2 2 NUT, M8 194200-37780 1 2 1 1 1 1 1 1 JOINT, BALL 172734-41300 1 3 1 1 1 1 1 1 ROD 172732-42450 1 4 1 1 1 1 1 1 PEDAL,SWING(GRAY:72) 172187-45500-4 1 5 1 1 1 1 1 1 LINK,PEDAL (GRAY:72) 172445-45550 1 6 1 1 1 1 1 1 BUSH 1415 172141-41360 2 7 2 2 2 2 2 2 SHAFT, COVER 172187-45650 1 9 1 1 1 1 SHAFT 172187-45651 1 9-1 R 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) COVER, PEDAL 172187-45720-4 1 10 1 1 1 1 1 1 COVER PAD 172187-45760 1 11 1 1 1 1 1 1 PLATE,LOCK(PTO (11) 172448-45800 1 12 1 1 1 1 1 1 SHAFT ASSY 172444-45850 1 13 1 1 1 1 1 1 WASHER, 10X36X4.5 1A1040-45890 1 14 1 1 1 1 1 1 BOOTS, PEDAL 172157-45990 1 15 1 1 1 1 1 1 LINK ASSY,P.T.O. 172478-46100 1 16 1 1 1 1 1 1 BUSH 2015 172141-41370 2 17 2 2 2 2 2 2 SHAFT ASSY, PTO 172478-46150 1 19 1 1 1 1 1 1 O-RING 172124-46200 1 20 2 2 2 2 2 2 BOLT 8X10 172462-46230 1 21 1 1 1 1 1 1 BOLT 172165-46340 1 22 2 2 2 2 2 2 ROD, SPOOL 172151-46360 1 23 1 1 1 1 1 1 ELBOW 172122-46590 1 24 2 2 2 2 2 2 WASHER, 8 22137-080000 1 25 3 3 3 3 3 3 WASHER, 8 22137-080000 1 26 1 1 1 1 1 1 WASHER, 10 22137-100000 1 27 2 2 2 2 WASHER, 10 22137-100000 1 27-1 K 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) WASHER, SPRING 8 22217-080000 1 28 1 1 1 1 1 1 PIN, COTTER 1.6X16 22417-160160 1 29 1 1 1 1 1 1 PIN, COTTER 2.5X20 22417-250200 1 30 2 2 2 2 PIN, COTTER 2.5X20 22417-250200 1 30-1 K 1 1 1 1 1 1

(A=M/#00688) (B=M/#00688) (D=M/#00688) (E=M/#00688) O-RING, 1AP21.0 24311-000210 1 31 2 2 2 2 2 2 NIPPLE, GREASE C 24761-050000 1 32 2 2 2 2 2 2 BOLT, M8X 16 26013-080162 1 33 2 2 2 2 2 2 BOLT, M10X 20 26013-100202 1 34 2 2 2 2 2 2 BOLT, M10X 20 26013-100202 1 35 1 1 1 1 1 1 NUT, M8 26051-080002 1 36 5 5 5 5 5 5 BOLT, M8X 25 PLATED 26116-080254 1 37 2 2 2 2 2 2 NUT, M8 26347-080002 1 38 1 1 1 1 1 1 NUT, M8 26716-080002 1 39 2 2 2 2 2 2 NUT, M10 26716-100002 1 40 1 1 1 1 1 1 PIN 4.75X14 933110-54100 1 41 1 1 1 1 1 1


0CS10-M40201

Fig.39. CONTROL EQUIPMENT(P.T.O.) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.39



CUSHION ASSY 172187-45060 1 1 2 2 2 2 2 2 CUSHION ASSY 172187-45490 1 2 3 3 3 3 3 3 PLATE,VALVE 172478-45600 1 3 1 1 1 1 1 1 RING, 35 22242-000350 1 4 5 5 5 5 5 5 BOLT, M10X 35 PLATED 26106-100352 1 5 3 3 3 3 3 3 BOLT, M10X 55 PLATED 26106-100552 1 6 2 2 2 2 2 2


0CS10-M40201

Fig.40. CONTROL VALVE PLATE VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.40


Remarks (1)IRON CRAWLER SPEC.


FRAME,LOWER(GREEN:82 172455-50102-1 1 1 1 1 1 1 1 1 FRAME ASSY,LOWER(82) 172455-50103-1 1 1-1 S 1 1 1 1 1 1

(A=M/#01049) (B=M/#01049) (C=M/#01049) (D=M/#01049) (E=M/#01049) (F=M/#01049)

FRAME ASSY,LOWER(82) 172455-50104 1 1-2 N 1 1 1 1 1 1 (A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146)

FRAME ASSY,LOWER(82) 172455-50105-3 1 1-3 N 1 1 1 1 1 1 (A=M/#01146) (B=M/#01146) (C=M/#01146) (D=M/#01146) (E=M/#01146) (F=M/#01146)

GROMMET 172141-50890 1 2 2 2 2 2 2 2 COVER, FRAME 172458-50480 1 2-1 S 2 2 2 2 2 2

(A=M/#01049) (B=M/#01049) (C=M/#01049) (D=M/#01049) (E=M/#01049) (F=M/#01049) 1 PLATE L, GUARD (82) 172187-50801-1 1 3 2 2 2 2 2 2 1 PLATE R, GUARD (82) 172187-50811-1 1 4 2 2 2 2 2 2 1 WASHER, 16 22137-160000 1 5 12 12 12 12 12 12 1 WASHER, SPRING 16 22217-160000 1 6 12 12 12 12 12 12 1 BOLT, M16X 40 PLATED 26116-160402 1 7 12 12 12 12 12 12

WEIGHT, COUNTER 172455-53301-1 1 8 1 1 1 1 1 1 WEIGHT, COUNTER 172455-53302-1 1 8-1 N 1 1 1 1 1 1

(A=MXXXXX) (B=MXXXXX)

WEIGHT 172455-53310-1 1 9 1 1 1 1 1 1 WEIGHT, SIDE 172455-53311-1 1 9-1 N 1 1 1 1 1 1

(A=MXXXXX) (B=MXXXXX)

WASHER 24.5X65X8 172187-53320 1 10 3 3 3 3 3 3 BOLT 24X140 172455-53330 1 11 3 3 3 3 3 3 BOLT M16X 60 172165-53480 1 12 2 2 2 2 2 2 WASHER 172165-53500 1 13 2 2 2 2 2 2 WASHER, SPRING 16 22217-160000 1 14 2 2 2 2 2 2 FRAME,TURNING (86) 172478-54101-1 1 15 1 1 1 1 1 1 BUSH 100X80 172187-54750 2 16 1 1 1 1 1 1 BUSH 100X40 172187-54760 2 17 1 1 1 1 1 1 PLATE (GREEN:86) 172478-54450-1 1 18 1 1 1 1 1 1 BOLT, M10X 25 26013-100252 1 19 2 2 2 2 2 2 TURNING BEARING 172187-57600 1 20 1 1 1 1 1 1 SEAL 172187-57630 2 22 1 1 1 1 1 1 SEAL 172187-57640 2 23 1 1 1 1 1 1 BOLT 16X90 172455-57650 1 24 30 30 30 30 30 30 PIN 16X40,STRAIGHT 172162-57660 1 25 2 2 2 2 2 2 PIN 16X40,STRAIGHT 172162-57660 1 26 2 2 2 2 2 2 BOLT 16X80 172455-57661 1 27 28 28 28 28 28 28 BOLT, M10X 12 PLATED 26106-100122 1 28 W 4 4 4 4 4 4

(A=*2003.07) (B=*2003.07) (C=*2003.07) (D=*2003.07) (E=*2003.07) (F=*2003.07)


0CS10-M40201

Fig.41. FRAME & TURNING BEARING VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.41


Remarks (1)PLEASE USE THIS PART WITH ATTACHED LABELS AT THE SAME TIME. CABIN SPEC.: REF.NO.34A & 34B CANOPY SPEC.: REF.NO.34A & 34C (2)PLEASE USE THIS PART WITH FOLLOW- ING LABEL AT THE SAME TIME. REF.NO.35A (3)LABELS ARE NOT ILLUSTRATED.


SEAT, SPRING 172137-46040 1 1 3 3 3 3 3 3 BOLT M10X20 172168-46760 1 2 3 3 3 3 3 3 COVER 172455-61100-2 1 3 1 1 1 1 1 1 COVER 172478-61111-1 1 4 1 1 1 1 1 1 COVER 172455-61120-2 1 5 1 1 1 1 1 1 COVER 172455-61130-2 1 6 1 1 1 1 1 1

1 COVER, FRAME 172478-61351-1 1 7 1 1 1 1 1 1 SEAL 172478-68910 2 10 1 1 1 1 1 1

2 COVER, FRAME 172455-61370-1 1 11 1 1 1 1 1 1 RUBBER 172478-61390 1 12 2 2 2 2 2 2 COVER, FRAME 172478-61401-1 1 13 1 1 1 1 1 1 SEAL 172478-68920 2 17 1 1 1 1 1 1 COVER ASSY 172478-61450-1 1 18 1 1 1 1 1 1 TRIM 172162-61500 1 19 4 4 4 4 4 4 COVER 172187-61500-2 1 20 1 1 1 1 1 1 PLATE (GREEN:86) 172478-61560-1 1 21 1 1 1 1 1 1 PLUG 28X3.2 172463-61600 1 22 6 6 6 6 6 6 COVER, TRAVEL 172455-61650-1 1 23 1 1 1 1 1 1 COVER, TRAVEL 172455-61660-2 1 24 1 1 1 1 1 1 WASHER, 10 22137-100000 1 25 15 15 15 15 15 15 WASHER, 10 22137-100000 1 26 8 8 8 8 8 8 WASHER, 10 22157-100000 1 27 2 2 2 2 2 2 WASHER, 12 22157-120000 1 28 4 4 4 4 4 4 BOLT, M10X 20 26013-100202 1 29 15 15 15 15 15 15 BOLT, M10X 20 26013-100202 1 30 2 2 2 2 2 2 BOLT, M10X 20 26013-100202 1 31 8 8 8 8 8 8 BOLT, M12X 30 26013-120302 1 32 4 4 4 4 4 4 BOLT, M10X 16 PLATED 26106-100162 1 33 26 26 26 26 26 26

3 LABEL,GREASE CYL. 172437-03351 1 34A 1 1 1 1 1 1 3 LABEL,SUPPORT US 172463-03370 1 34B 1 1 1 3 LABEL,SUPPORT 172478-03470 1 34C 1 1 1 3 LABEL,GREASE CYL. 172437-03351 1 35A 1 1 1 1 1 1


0CS10-M40201

Fig.42. COVER(FRAME) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.42



COVER, SEAL 172478-61180 1 1 1 1 1 1 1 1 COVER, MULTI 172478-61200 1 4 1 1 1 1 1 1 TRIM 172183-61350 2 6 1 1 1 1 1 1 TRIM 172183-61360 2 7 1 1 1 1 1 1 SEAL, SPONGE 172478-61270 1 8 1 1 1 1 1 1 COVER, BLADE 172455-61520-1 1 9 1 1 1 1 1 1 BOLT 172519-63240 1 10 3 3 3 3 3 3 WASHER, SPRING 10 22217-100000 1 11 1 1 1 1 1 1 BOLT, M10X 20 26013-100202 1 12 2 2 2 2 2 2 BOLT, M10X 20 26013-100202 1 13 2 2 2 2 2 2 BOLT, M10X 60 PLATED 26116-100602 1 14 1 1 1 1 1 1


0CS10-M40201

Fig.43. COVER(AROUND THE CONTROL:1) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.43


Remarks (1)AIR CONDITIONER SPEC. (2)PLEASE USE THIS PART WITH FLLOW- ING LABELS AT THE SAME TIME. REF.NO.44A & 44B. (3)LABELS ARE NOT ILLUSTRATED. (4)NOT APPLIED FOR A/C SPEC.


CLIP, TREE 172122-17190 1 1 2 2 2 2 2 2 BOLT 172164-45880 1 2 2 2 2 VENTILATOR 172187-61690 1 3 1 1 1

4 BOLT 172519-63240 1 4 2 2 2 4 COVER, SEAT MOUNT 172455-63371 1 5 1 1 1

TRIM 172455-63511 2 12 1 1 1 TRIM 172455-63521 2 13 1 1 1

2 COVER ASSY 172455-63440 1 14 1 1 1 GRILLE ASSY 172455-64960 1 17 1 1 1 TRIM 172455-64150 2 18 1 1 1 TRIM 172455-64160 2 19 1 1 1 BOLT 172165-66980 1 21 3 3 3

4 WASHER, 10 22137-100000 1 22 3 3 3 BOLT, M10X 20 26013-100202 1 23 2 2 2 2 2 2

4 BOLT, M10X 70 26013-100702 1 24 3 3 3 1 COVER ASSY, PANEL 172455-18650 1 25 1 1 1 1 COVER, SEAT MOUNT 172455-63301 1 29 1 1 1

TRIM 172455-63361 2 33 1 1 1 1 WASHER, 8 22137-080000 1 34 2 2 2 1 WASHER, 10 22137-100000 1 35 3 3 3 1 BOLT, M10X 70 26013-100702 1 36 3 3 3 1 NUT, M8 26051-080002 1 37 2 2 2

CLIP, TREE 172444-17660 1 38 4 4 4 GROMMET 172151-62240 1 39 3 3 3 COVER ASSY, MOUNT 172455-64080 1 40 1 1 1 TRIM 172455-64150 2 42 1 1 1 TRIM 172455-64160 2 43 1 1 1

3 LABEL,STEERING 172437-03431 1 44A 1 1 1 3 LABEL,LEVER LOCK 172437-03470 1 44B 1 1 1


0CS10-M40201

Fig.44. COVER(AROUND THE CONTROL:2) VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.44



STEP 172463-62101 1 1 1 1 1 1 1 1 MAT, FLOOR 172478-62160 1 5 1 1 1 MAT, FLOOR 172455-62170 1 6 1 1 1 BOLT, M10X 20 26013-100202 1 7 8 8 8 8 8 8 FLOOR MAT A 172478-62170 1 8 1 1 1 MAT B,CANOPY 172478-62180 1 9 1 1 1 BOLT 172458-46720 1 10 3 3 3 3 3 3 BOLT 172458-46720 1 11 1 1 1 1 1 1 BOLT 172458-46720 1 12 1 1 1 1 1 1 BOLT 172458-46720 1 13 2 2 2 2 2 2 SEAL, STEP 172162-62540 1 14 2 2 2 2 2 2 PANEL, INSTRUMENT 172458-63100 1 15 1 1 1 1 1 1 PANEL, INSTRUMENT 172458-63120 1 16 1 1 1 1 1 1 COVER ASSY 172478-63200 1 17 1 1 1 1 1 1 COVER 172472-63210 1 20 1 1 1 1 1 1 COVER 172472-63220 1 21 1 1 1 1 1 1 BOLT 172519-63240 1 22 2 2 2 2 2 2 BOLT 172519-63240 1 23 3 3 3 3 3 3 ARMREST 172441-44320 1 24 2 2 2 2 2 2 PLATE, ARMREST 172472-64531-1 1 25 1 1 1 1 1 1 PLATE, ARMREST 172472-64541-1 1 26 1 1 1 1 1 1 BOLT 172165-66980 1 27 4 4 4 4 4 4 SCREW, M8X12 26577-080122 1 28 4 4 4 4 4 4 WASHER, 10 22137-100000 1 29 W 8 8 8 8 8 8

(A=MXXXXX) (B=MXXXXX) (C=MXXXXX) (D=MXXXXX) (E=MXXXXX) (F=MXXXXX)


0CS10-M40201

Fig.45. STEP & INSTRUMENT PANEL VEHICLE VIO75(US,AS,NZ)


0CS10-M40201 Fig.45


Remarks (1)PLEASE USE THIS PART WITH ATTACHED LABELS AT THE SAME TIME. CABIN SPEC.: NOT APPLIED CANOPY SPEC.: REF.NO.70A,70B & 70C NOT APPLIED FOR A/C SPEC. (2)LABELS ARE NOT ILLUSTRATED. (3)AIR CONDITIONER SPEC.


SEAT, OPERATOR 172467-64100 1 1 1 1 1 1 1 1 CUSHION, BACKREST 172467-64110 2 2 W 1 1 1 1 1 1

(A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502)

CUSHION, SEAT 172467-64120 2 3 W 1 1 1 1 1 1 (A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502)

STOPPER 172467-64130 2 4 W 1 1 1 1 1 1 (A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502)

RAIL SET 172467-64140 2 5 W 1 1 1 1 1 1 (A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502)

BELT, SEAT 172989-64451 2 6 W 1 1 1 1 1 1 (A=M/#00502) (B=M/#00502) (D=M/#00502) (E=M/#00502)

BOLT 172519-63240 1 7 3 3 3 3 3 3 1 SEAT MOUNT,US (72) 172478-64000 1 8 1 1 1 1 1 1

SEAL, ENGINE 172156-11150 2 9 1 1 1 1 1 1 TRIM 172455-61580 2 10 1 1 1 1 1 1 BUSH 1415 172141-41360 2 12 2 2 2 2 2 2 MAT 172455-66580 2 20 1 1 1 1 1 1 RUBBE

New PARTS CATALOG - DRACO Equipment Manuals/Parts... · 2018. 3. 16. · 12 2 172437-03300...

Documents

Transcript of New PARTS CATALOG - DRACO Equipment Manuals/Parts... · 2018. 3. 16. · 12 2 172437-03300...