Mounting Instructions E84DGFCxxxx 8400 motec Communication ... · Mounting Instructions ....
Transcript of Mounting Instructions E84DGFCxxxx 8400 motec Communication ... · Mounting Instructions ....
Emotron CDN
Communication unit
Montageanleitung Mounting Instructions
Instructions de montage Instrucciones para el montaje
Istruzioni per il montaggio
CDN-COM-xxx, DE/EN/FR/ES/IT 3
0.75 4 kW 5.5 7.5 kW
CDN40-xxx
CDN-COM-xxx
CDN-WU-xxx
CDN-COM-xxx
CDN40-xxx
CDN-WU-xxx
4 CDN-COM-xxx, DE/EN/FR/ES/IT
Beachten Sie auch weitere wichtige Informationen zur Geräte− und Sicherheitstechnik auf der beiliegenden CD−ROM!
Please also observe more important information on device and safety technology provided on the enclosed CD−ROM!
Danger!
DANGEROUS VOLTAGE The power terminals carry dangerous voltages for up to 3 minutes
after mains disconnection. POSSIBLE CONSEQUENCES:
Death or severe injury if the power terminals are touched. PROTECTIVE MEASURES:
Switch off the mains voltage and wait at least 3 minutes before starting to work on the device.
Check that all power terminals are deenergised.
Gefahr!
GEFÄHRLICHE ELEKTRISCHE SPANNUNG Die Leistungsanschlüsse führen bis zu 3 Minuten nach
Netz−Ausschalten gefährliche elektrische Spannung. MÖGLICHE FOLGEN:
Tod oder schwere Verletzungen beim Berühren der Leistungsanschlüsse. SCHUTZMAßNAHMEN:
Vor Arbeiten am Gerät Netzspannung ausschalten und mindestens 3 Minuten warten.
Prüfen, ob alle Leistungsanschlüsse spannungsfrei sind.
Warnings!
Operation of this equipment requires detailed installation and operation instructions provided in the Hardware manual intended for use with this product. This information is provided on the CD−ROM included in the box this device was packaged in. It should be retained with this device at all time.
CDN-COM-xxx, DE/EN/FR/ES/IT 5
Veuillez également tenir compte des consignes importantes sur la technologie des appareils et les fonctions de sécurité comprises sur le cédérom joint !
Observe también la información importante sobre aspectos relativos a la técnica del dispositivo y de seguridad incluida en el CD−ROM adjunto!
¡Peligro!
VOLTAJE ELÉCTRICO PELIGROSO Las conexiones de potencia siguen vivas hasta 3 minutos después
de la desconexión de red. POSIBLES CONSECUENCIAS: Muerte o serias lesiones al tocar las conexiones de potencia. MEDIDAS DE PROTECCIÓN: Antes de trabajar en el equipo, desconectar la alimentación de red y esperar
por lo menos 3 minutos. Comprobar, si todas las conexiones de potencia están libres de voltaje.
Danger !
TENSION ÉLECTRIQUE DANGEREUSE Les raccordements de puissance sont susceptibles de véhiculer une
tension dangereuse jusqu’à 3 minutes après une coupure réseau. RISQUES ENCOURUS : Mort ou blessures graves en cas de contact avec les raccordements de puissance MESURES DE PROTECTION : Avant toute manipulation de l’appareil, couper la tension réseau et
attendre 3 minutes au minimum. S’assurer que tous les raccordements de puissance sont hors tension.
6 CDN-COM-xxx, DE/EN/FR/ES/IT
Osservare anche le ulteriori informazioni importanti relative a installazione e sicurezza incluse nel CD−ROM allegato!!
Pericolo!
TENSIONE ELETTRICA PERICOLOSA I collegamenti di potenza presentano una tensione elettrica pericolosa fino
a 3 minuti dopo la disinserzione della rete. POSSIBILI CONSEGUENZE: Morte o gravi lesioni in caso di contatto con i collegamenti di potenza. MISURE DI PROTEZIONE: Attendere almeno 3 minuti prima di eseguire qualsiasi intervento sui
collegamenti di potenza. Controllare tutti i collegamenti di potenza per accertare l’assenza di tensione.
CDN-COM-xxx, DE/EN/FR/ES/IT 7
CDN-COMx.. XNx / xJx X3 X31 X32 X4 X5
CAN C Standard I/O S
Extended I/O
X
12 CDN-COM-xxxx, DE/EN/FR/ES/IT
X3 2 CAN
DIP c b a Baud rate
BAUD c b a
ON
OFF
ON OFF ON 20 kBit/s
OFF ON ON 50 kBit/s OFF ON OFF 125 kBit/s OFF OFF ON 250 kBit/s OFF OFF OFF 500 kBit/s ON ON OFF 800 kBit/s
ON OFF OFF 1000 kBit/s
ON
OFF
ADDRESS 64 32 16 8 4 2 1
DIP 64 Address
32 16 8 4 2 1
ON
OFF OFF OFF OFF OFF OFF OFF C00350
OFF OFF OFF OFF OFF OFF ON 1 OFF OFF ON ON ON ON ON ON
63 ON
CDN-COM-xxxx, DE/EN/FR/ES/IT 13
IO X3, X4, X5 3
X4 − DIO, Relay X4, X5 – AIO
X4, X5 a [mm]
b [mm]
[mm2] [AWG]
DIO, Relay
90
-
0.5 ... 1.5 20 ... 16
0.5 ... 1.0 20 ... 18
AIO
90
10
0.5 20
X3 a
[mm] b
[mm] [mm2]
[AWG]
24E, GND
90
-
0.5 ... 1.5 20 ... 16
0.5 ... 1.0 20 ... 18
0.5 20
X3, X4, X5
14 CDN-COM-xxxx, DE/EN/FR/ES/IT
3 X3, X4, X5 I
1) alternativ / alternatively / option / alternativo / alternativo
X4 –CDN-COM-xxx (Standard I/O)
+10 V/ 5 mA
100 mA
- S1
+ 24 V ext.
0 ... 10 V / 0/4 ... 20 mA 1)
X4, X5 − CDN-COM-xxx (Extended I/O)
100 mA +10 V/ 5 mA
- S1
+ 24 V ext.
1)
X4
X4
NO
n. c
.
CO
M
n. c
.
DI1
DI2
DI3
DI4
DI5
DI6
DI7
DI8
RFR
DO
1
NO
n. c
.
CO
M
n. c
.
AR
3.3k
3.3k
AU
/AI
GN
D
RFR
DI1
DI2
DI3
DI4
DI5
DO
1
2k ..
. 10k
3.
3k
3.3k
3.
3k
3.3k
3.
3k
3.3k
3.
3k
3.3k
3.
3k
3.3k
3.
3k
3.3k
3.
3k
X3
X3
24O
24O
GN
D
GN
D
n. c
.
n. c
.
n. c
.
100
mA
24O
24O
GN
D
GN
D
n. c
.
n. c
.
n. c
.
24 V
int.
24 V
int.
X5
AR
A1U
A2U
GA
GA
-10
... +
10 V
2k ..
. 10k
CDN-COM-xxxx, DE/EN/FR/ES/IT 15
CAN X3, X4, X5 3
X4 – CDN-COM-xxx ( CAN)
AS-i
100 mA
CAN
EtherCAT PROFINET EtherNet/IP PROFIBUS
24 V ext.
-
+
- S1
+ 24 V ext.
1)
n. c
.
AS
-i+
AS-i
-
CH
CL
CG
1) alternativ / alternatively / option / alternativo / alternativo
X4
n. c
.
n. c
.
n. c
.
n. c
.
n. c
.
n. c
.
n. c
.
RFR
DI1
DI2
DI3
DI4
DI5
DO
1
3.3k
3.3k
3.3k
3.3k
3.3k
3.3k
X3
24O
24O
GN
D
GN
D
24 V
int.
16 CDN-COM-xxxx, DE/EN/FR/ES/IT
3 X3, X4, X5
4
0.75 ... 4 kW 5.5 ... 7.5 kW
CDN Hardware 01-6460-01 CDN Hardware 01-6460-01
© 12/2012 /13522550 / 01-6464-11R0, 2017-01-27 CG DRIVES & AUTOMATION Mörsaregatan 12, Box 222 25 SE- 250 24 Helsingborg, Sweden +46 42 16 99 00 Info: [email protected] Order: [email protected]