• Over 369 Units Sold
• Total Fleet logged over 30 Million Hours of Operation
• Widest Fuel Experience in Industry
• High Availability Demonstrated
1
 
Mong Duong 1 Boiler Size is Within FW’s CFB Experience
700
600
  e    )
Poland
JEA
300
 
0
1970 1975 1980 1985 1990 1995 2000 2005 2010 2015 2020
Start-Up Year 
And:
Cyclone
Fly Ash
Feature Benefit
Low Furnace
Eliminates Need for Expensive SCR by
Allowing Use of SNCR
Temperature: 825-925 °C
Fuel Quality
Simple Fuel Feed System
Capture
 
ANTHRACITE FIRED CFB PLANT COUNTRY START-UP YEAR
Foster Wheeler CFB Boilers
(and Vietnamese Anthracite) Is Considered in the Boiler Design
Selection of Fuel Particle Size
Selection of Furnace Temperature
Determine Fuel Distribution Requirements (No. of Fuel Feed Points)
, .
Guarantee and Limestone System Sizing)
Estimation of Split Between Fly Ash and Bottom Ash (Ash Cooler Sizing)
Erosion Protection Requirement
 
Feedwater Temperature °C 295.9 290.4 274.2 261.2
Spray Water Temperature °C 295.9 290.4 274.2 261.2
Reheat Steam Flow kg/hr   731,046 681,723 508,124 406,647
Reheat Inlet Pressure MPa(g) 4.679 4.364 3.303 2.668
Reheat Inlet Temperature °C 347.8 342.46 350.6 355.2
Reheat Outlet Temperature °C 540 540 540 --
9
. . . .
Ultimate Analysis, (As Received)
3.10 2.68 3.52
4 450 4 332 4 493
HHV (As Received) kcal/kg 4,645 4,522 4,690
Hardgrove Grindability HGI 50 45 60
10
2 x 300 MWe
SLIDE ALONG ARRANGEMENT (NOT MIRROR IMAGE)
AIR HEATER
HEAT RECOVERY
VCHEC (VIRGINIA, USA)
13
STEAM DRUM STEAM COOLED CONVECTION CAGE
HANGER TUBES
PRIMARY SUPERHEATER
PRIMARY REHEATER
FINISHING REHEATER
14
with Lower Furnace Refractory Minimizes Tube Erosion
• Offered Since 1990
Worldwide
Experience
15
16
Maintenance and Have Lower Heat Loss
INSULATING REFRACTORY
CYCLONES
And Reheater Tubes
 
Trips with 5 Second Delay When 2 of 3
Transmitters Confirm
Normal - 275 mm
REAR WALL
FUEL SILOS
(SINGLE OUTLET)
FRONT WALL
FUEL SILOS
(DOUBLE OUTLET)
 
 
ave a a n ess ee ner
with a 2B Finish to Improve
Flow
Improves Fuel Flow Out of
22
 
Fuel is Distributed Evenly Across the Front and Rear Walls
8 GRAVIMETRIC BELT FEEDERS
 
23
 
The Boiler is Equipped with a Tri-Sector Regenerative Air Heater 
- VCHEC (VIRGINIA, USA) – 2 x 300 MWe
24
Two Primary Air Fans Provide Air to the Furnace Grid
PRIMARY AIR DUCTS
25
 
26
Two Secondary Air Fans Supply a 3 Level Ring Duct
DUCT SPLITS AT
AIR HEATER OUTLET
27
3 LEVEL RING DUCT
UPPER SA NOZZLES
 
Through Nozzles at Various Elevations in the Lower Furnace Walls
UPPER SA NOZZLES
LOWER SA NOZZLES
 
Limestone is Fed Through Secondary Air Ports in the Lower Furnace
30
SILO WITH TWO OUTLETS
ROTARY FEEDERS
31
3 x 50% LIMESTONE BLOWERS
32
• 4 Stripper Coolers
•
OPTIONAL
COOLING
TUBES
34
SIDE WALL
   U    R    N    A    C    E    R    E    A    R
 
Furnace Bed Temperature Above the Solid Fuel Ignition Point
36
 
Conclusions
 
Vietnamese Anthracite
Foster Wheeler Does not Require Additional Bench Scale or Pilot Scale
 
and Operational Feedback from the Replicated Existing Boilers
The Proposed Boiler is Designed to Ensure that the Boiler is Protected
Against Damage Due to Transient/Upset Conditions
All Auxiliary Systems (Fuel Feed, Air Feed, etc) are Adequately Sized to
 
Foster Wheeler Expects the Mong Duong Boilers to Demonstrate all
Guaranteed Steam Parameters and Emissions While Demonstrating High
.
 
39
42
43
44
45
46
47