7/28/2019 Metal Roof Iko

1/4

F i n a l l y !The truth about

METALROOFSis leaking out

7/28/2019 Metal Roof Iko

2/4

In fact, there are two kinds of metal roofing systems and each has its own set of problems.The less expensiveconsists of metal sheets or panels installed with exposed screws and neoprene washers. Sure, theyre quick and

easy to install. And you dont need a plywood substrate, so they may seem more economical in the short term.

But

Our weather extremes cause severe thermal expansion and contraction.This leads to metal fatigue of thepanels. If the screws are too tight, the neoprene washers may become damaged, elongating the screw holes

and causing leaks.They also tend to deteriorate because of their exposure to the suns ultraviolet rays and theweather. Its not uncommon for contractors to have to replace such fasteners with bigger screws after only

ten years. Sometimes even less. So, if you have to replace these fasteners every few years, have you reallysaved any time or money?

But perhaps you knew this, so you decided to spring for the more expensive system a standing seam metalroof.This would eliminate the problems and leaks caused by exposed fasteners. However, because this type

of roof needs to be manufactured on site, proper application is difficult and must be done by a qualified, expe-

rienced roofer with a journeyman sheet metal ticket. And there just arent too many of those people around.

Another problem with standing seam metal roofs is that they usually specify an underlayment of asphalt felt orpeel and stick membrane in order to control leaks and the condensation that can form on the underside of the

metal. If your buildings roof lines include a lot of dormers and valleys, the application becomes that much more

difficult and the cost starts to soar.

At first glance, it may appear that a metal roof is watertight, but take a closer look. Whats really preventing

water from penetrating the roof deck is the underlayment, as well as the foam tape and caulking, which breakdown and need to be replaced long before the metal panels wear out.

The last time you put a new roof on your out-buildings, you probably chose metal.You thought it would bemore durable, more cost-effective and easier to install than a shingle roof.It seemed like a good idea at the time. After all, metal itself does have an incredibly long life. But a metal roofing

system is so much more than just metal panels.

At IKO,we believe that the peel and stick ice/water membrane that is usually specified as an underlayment formetal roof systems should, instead, be specified as the primary roof seal.Thats why shingles are a better overall

choice than metal because theyre more effective as the first line of defense against the elements.

According to various sources, such as the Wall Street Journal, CNN and other news agencies, this is because of

several factors including, but not limited to, increased demand/export to China and decreased productioncapacity with the closure of mills due to tariffs which have since been lifted.While this applies specifically to the

United States, the effects are being felt worldwide. Consumers will soon be paying substantially more for steelproducts such as metal roofing systems.

Did you know that the cost of steel has been steadily increasing 20 to 30%

recently in the US?

7/28/2019 Metal Roof Iko

3/4

As you can see, even our most expensive shingle is substantially less than the standing seam roof system! And sevenof our shingles are less than the cheaper of the two metal roof systems! Plus, our limited warranties are more

comprehensive, too! Metal roof systems are typically guaranteed for 1 to 2 years. Some metal roof systems carrya 5-year warranty but only under certain conditions, such as requiring a plywood deck with a peel and stick mem-

brane adhered to it. Compare this to our shingles,which are backed with limited warranties for 25 to 50 years!

* See Limited Warranty term. Underlayment may be required for some products. See shingle installation instructions for details.

The damaging effects of hail.

For agricultural buildings, the look of a roof isnt quite as important as other factors but its certainly nice to have

some choice. IKO shingles are available in a wide variety of blended colors.They have a texture or pattern thatadds depth to the roofs appearance.To harmonize with your natural surroundings, choose IKO shingles in the

colors of nature. Or choose a color that will stand out and add contrast. Metal roofs only come in solid colors

and offer no textured appearance.Theyre prone to fading over time, whereas the mineral granules in our shinglescontain UV inhibitors to minimize this. As metal roofs age, rust can also cause damage and unsightly streaks.

Asphalt shingles keep looking great, year after year.

IKO Shingles Price per 25 years (approximate)

Aristocrat (25-year)*

Renaissance XL (25-year)*

5000 sq. ft. x $1.00/sq. ft. 25 yrs

5000 sq. ft. x $1.35/sq. ft. 25 yrs

$200/yr

$270/yr

Cambridge (30-year)* 5000 sq. ft. x $1.60/sq. ft. 25 yrs

Regency (50-year)*

Grandeur (50-year)*

Crowne Slate (50-year)*

5000 sq. ft. x $2.40/sq. ft. 25 yrs

5000 sq. ft. x $2.60/sq. ft. 25 yrs

5000 sq. ft. x $3.25/sq. ft. 25 yrs

$320/yr

Cambridge (50-year)* 5000 sq. ft. x $1.95/sq. ft. 25 yrs $390/yr

$480/yr

$520/yr

$650/yr

Metal Roofs Price per 25 years (approximate)

29-ga exposed fastener systemNote: Fasteners might have to be replaced after 10 years

26-ga standing seam roof systemNote: Will require an underlayment in order to qualify for labor warranty

Revised pricing to come based on 20-30% industry increases.

5000 sq. ft. x $3.30/sq. ft. 25 yrs

5000 sq. ft. x $5.75/sq. ft. 25 yrs

$660/yr

$1150/yr

Our Crowne Slate, Grandeur,Regency and Cambridge 50 & 30 shingles alsoinclude additional warranty coverage against wind. And Grandeur has a Class

4 UL2218 rating against hail! If youve ever seen what hail can do to a metalroof, youll appreciate that kind of extra protection.

Superior Strength that Outlasts the Elements -

and the Competition

Still not convinced? Take a look at the chart below. It lists an average supply and install price on new constructionover OSB or plywood, with a 6/12 pitch gable building. Underlayment and primary insulation costs are extra.

Weve compared both types of metal roofing to IKOs most popular asphalt shingles, based on 5000 square feet

of roof deck at current prices in your market.The cost is then broken down into an approximate price per year

for 25 years.

7/28/2019 Metal Roof Iko

4/4

When it comes to protecting your property and livestock, the

choice of roofing material is up to you. At IKO, we thought you

should know the facts that you do have a choice.

To help you make an informed roofing decision, please contact an IKO Sales Representative

or ask a professional roofing contractor.Theyll be pleased to prove our mettle!

Find out more about our products now by talking to an IKO sales representative, your professional roofing contractor or contact us directly at:

United States 1-888-IKO ROOF, Eastern Canada 1-800-361-5836, Western Canada 1-800-661-1034,

or visit our web site at:

Copyright 09/05 - US - MR1L053