Mercedes Vito-Viano Wiring Diagrams in English

264
Transporters • Electrical System VITO/VIANO (Model 639) Wiring Diagrams Technical training for Customers r As at 06/05 a mb

Transcript of Mercedes Vito-Viano Wiring Diagrams in English

a mbTransporters Electrical System VITO/VIANO (Model 639) Wiring Diagrams Technical training for Customers

r

As at 06/05

Wiring Diagram Manuals Part Number: Z6517 2111 02

This document is intended solely for use in training and is not subject to regular updating. Part numbers and documentation included in this document may change and the latest information should always be used.

Printed in England 2005 Copyright DaimlerChrysler UK LTD Publisher: Mercedes-Benz CV Electrics & Telematics Team This document with all its sections is protected under the laws of copyright. Its use for any purpose whatsoever requires the prior written consent of DaimlerChrysler UK LTD. This applies in particular to its reproduction, distribution, modification, translation, recording on microfilm or storage and/or processing in electronic systems, including databases and on-line services.

Note: The term employees does not imply any preference of gender and incorporated male and refers to male and female employees alike.

ContentsChapter 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Title Use of wiring diagrams Abbreviations for wiring diagrams Location and assignment of ground points Location and assignment of plug connectors Battery starting charging circuit Voltage supply fuses Fuse and relay board (SRB) Signal Acquisition and actuation module (SAM) Exterior lights Central locking CAN bus Instrument cluster (IC) Electronic ignition switch (EIS) Electronic stability control (ESP) Common rail diesel injection (CDI) Standard heater

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

Use of Wiring Diagrams

Chapter 1

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

OV00.01-S-1901-03VA

Use of wiring diagrams a The wiring diagrams are prepared as function diagrams or control unit diagrams and are built up as follows: -Function diagrams The control units and electrical components belonging to the function are shown as symbols. The functional connections are realized by direct lines or by the data bus. -Control unit diagrams Control units are represented complete with all connected components. The feed of the control units appears first. The wiring diagrams also contain linkages of possible versions and functions. Linkages, recognizable as versions, are framed and provided with an abbreviated designation/ abbreviation. The versions are designated with 1 and 2 -------------------------------------------------------------------------------------

Wiring diagrams a The wiring diagrams are assigned to the familiar function groups 00-91. The systems are listed alphabetically with an indication of the function group/ function subgroup in the "Search aid for all wiring diagram groups" OV00.01-S-1901VA or A3 (paper version). a The wiring diagrams are filed in the respective function group arranged according to the PE number, e.g.: PE07.16-S-2000VA PE07.16-S-2000IVB To check the completeness of the volume the sequence of the wiring diagrams filed can be seen from the lists of contents of the respective function group. For supplements the wiring diagrams should be filed as per the supplement sheet. e.g.: PE00.19-P-1100VA Overview of wiring diagrams.... -----------------------------------------------------------------------------------

a Notes on the accompanying documents for connectors/ terminal blocks (B1) Special equipment (SA) is specifically highlighted in the notes column. For connectors, which are installed in special equipment, the special equipment is specified in the notes column in the row in front of the connector designation. For connectors, which are installed as standard, special equipment specification is noted directly at the respective jack and/or connector. The feed of the terminal blocks is shown by means of an arrow pointing to the left, the outputs by means of arrows pointing to the right. The grouping of the individual variants/ special equipment (SA) is highlighted by means of broken lines. All outputs to components, which are installed as standard, are listed up to the first broken line.

Connection designation a b c Component Clutch Socket

P00.19-0402-01

Wire designation a b c Conductor cross-section in mm Basic color Identification color 2

P00.19-0403-01

Identification of truncated wires a b Component to which the truncated electric line leads Connection designation on component

Fuse blocks a b c d e f Receptacle numbering, output (A, B, C or D) Line bridge Terminal designation Fuse rating in amp(s) Receptacle numbering, input (E) Fuse number

Components and switches a b Component which are not represented completely are shown dismantled. Switching contacts are shown in the rest position.

a b

Illustration of a function-specific component with connection designation and corresponding line Illustration of a function-independent component connection with corresponding line

Looped lines a b Function-specific components The looped line connects two function-specific components across one or more functionindependent component connections.

P00.19-2089-01

Indirect line (only for terminal 31 or terminal 58) a b c Function-specific component Indirect line for more than two intermediate function-independent component connections/ loops. Connection to either terminal 31 or terminal 58

Installation date a b Installation of a component up to date Installation of a component as of date

P00.19-2094-01

BK BN BU GN GY OG PK RD TR VT WH YE

= = = = = = = = = = = =

Black Brown blue green gray orange pink red transparent violet white yellow

= black = brown = blue = green = gray = orange = pink = red = transparent = violet = white = yellow

Abbreviations for Wiring Diagrams

Chapter 2

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

OV00.01-S-1001-27VA

Abbreviations for wiring diagrams

MODEL

639.601/603/605/701/703/ 705/711/713/811/813/815

Abbreviation AB ABL ABS AT AHV AKC ACSR BCAPC APS

Designation Airbag Exterior lights Antilock brake system Automatic transmission Trailer hitch Anti-knock control Automatic child seat recognition Barometric pressure/charge air pressure compensation Auto pilot system

Code

FG.FUG 91.00 82.10 42.30

G40 - Automatic transmission Q22 - Fixed trailer hitch Q50 - Trailer hitch with detachable ball head

27.19 31.19

91.60

EN2 - Auto pilot system with TMC interface EN4 - Auto pilot system with TMC interface, large display EN9 - Auto pilot system for Japan, large display

82.61

EGR ART DSV ASR ATS BAS CDI CDC D2B

Exhaust gas recirculation Adaptive cruise control Drive authorization system shutoff valve (DSV) Acceleration slip regulation Antenna systems Brake Assist Common rail diesel injection CD changer Digital data bus EP5 - CD changer EH3 - Portable CTEL preinstallation linked to D2B network BB3 - Electronic Stability Program (ESP) BB3 - Electronic Stability Program (ESP) IN18 - Distronic

14.20 80.35 42.40 82.62 82.70 42 07.16 82.64 82

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

OCP DTR EDC EDS ATA EFH ISC ELC ESP ESA DFI EIS RFL/IRCL HFS GPS ETR HEAT HFM-SFI HHS IRCL IMS TWC IC AAC LHD ISC LS

Overhead control panel control unit Distronic (adaptive cruise control) Electronic diesel control Electronic diesel system Anti-theft alarm system Power windows Electronic idle speed control Electronic level control Electronic stability program Electric seat adjustment Diesel injection system (electronic distributortype fuel injection) Electronic ignition switch control unit Radio frequency locking/infrared remote central locking Hands-free system Global positioning system Emergency tensioning retractor Automatic heater HFM sequential multiport fuel injection/ignition system Heated rear window Infrared remote central locking Interior motion sensor Catalytic converter Instrument cluster Automatic air conditioning Left-hand drive vehicle Idle speed control Power steering gear

LD0 - Dome lamp with reading lamp for driver/front passenger IN18 - Distronic

54.21

07.16 07 FZ5 - Anti-theft alarm system 80.50 72.29 07 CL0 - Rear lowerable/raisable air suspension BB3 - Electronic Stability Program (ESP) SF1 - Electrically adjustable luxury driver seat 32.33 42.45 91.00 07.16 54.21 FZ5 - Anti-theft alarm system 80.50 82.70 91.00 83 07.61 67.29 80.20 80.50 07 54.30 HH4- Automatic air conditioning 83.00

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

HRA

Headlamp range adjustment

82.10

ME-SFI

ME-SFI fuel injection and ignition system

07.61

MT

Manual transmission

MOST

Media Oriented System Transport

82

REST

Residual engine heat utilization system

OSL

Orthopedic seat backrest

PTS

Parktronic system

EZ8 - Parktronic System (PTS)

54.65

RHD

Right-hand drive vehicle

SR

Tilting/sliding roof

D24 - Glass tilting/sliding roof in passenger compartment D27 - Glass tilting/sliding roof in driver compartment

54.21

77.20

HS

Heated seats

H15 - Heater for front passenger

91.00

H16 - Heater for driver seat

SOUND

SOUND systems

82.85

SPH

Mirror heater

88.79

HCS

Headlamp cleaning system

82.35

STH

Stationary heater

H12 - Warm water auxiliary heater H85 - Preinstallation for auxiliary heater HZ1 - Warm air auxiliary heater (Westfalia)

83.70

TEL

Telephone

EH3 - Portable CTEL preinstallation linked to D2B network JV4 - Portable CTEL telephone preinstallation

82.70

TELE AID

Telematic Alarm Identification on Demand (emergency call system)

EZ9 - Car telephone emergency call system (Tele Aid)

DCU

Door control unit

72.29

HB

Heater booster

HZ9 - Heater booster

83.70

CL

Central locking

80.20Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

OV00.01-S-1001-28VA

Abbreviations of signal and circuit designations for wiring diagrams

Abbreviation (+) (-) 15 30 31 49 49a 49L 49R 50 55 56 56a 56b 58 58d 61 85 86 87 87a 87b 87c A-CDW-SIG

Designation Positive Negative Switched positive Battery voltage, positive (continuous positive) Return line to battery negative or ground, direct Turn signal generator input Turn signal generator output Left turn signal lamp Right turn signal lamp Starter control (direct) Front fog lamp Headlamp light High beam and high beam indicator Low beam Position, tail, license plate and instrument lamps Variable instrument/switch illumination Alternator monitor Negative or ground winding end Start of winding Input First output (NC side) Second output Third output CD-player with changer signal

Notes

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

A-P-EV1 A-P-EV2 A-P-EV3 A-P-EV4 A-S-LSHVK A-S-RPR A-STAR A-T-LUES A-ZUE1 A-ZUE2 AE AKSE (CSD) AL AS ASS/IRS ASV 1 ASV 2 Autom. Ant. A_AGR A_ANR A_Dachz_1 A_Dachz_2 A_DKS A_DRV A_EC_Daten A_EKA A_EKP A_IRS_2_ALARM A_IRS_2_ALARM A_KEH

Output - pulse width signal - injection valve, cyl. 1 Output - pulse width signal - injection valve, cyl. 2 Output - pulse width signal - injection valve, cyl. 3 Output - pulse width signal - injection valve, cyl. 4 Output - shift signal - oxygen sensor heater Output - fuel pumps signal - relay Output - starting relay Output, fan control Output, ignition coil 1 Output, ignition coil 2 Trailer recognition Automatic child seat recognition (ACSR) Exit lamp Towing sensor Towing sensor/interior protection Intake solenoid valve 1 Intake solenoid valve 2 Automatic antenna Actuation of exhaust gas recirculation positioner Output, fuse and relay box Roof sign lamp Roof sign lamp Intake air throttle valve actuator Grounded output, pressure regulator valve Mirror taximeter Actuation of inlet port shutoff switchover valve Actuation of inlet port shutoff switchover valve Interior protection Output, alarm Grounded output, vent line heater elementPage 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

A_Kl.31_MIC A_LDR A_LED_Funk A_LSH1 A_Mute A_RS485_H A_RS485_L A_TEL_Mute A_VDK A_Wegstr_SPT A_ZME BB+ B-D-DIAK BBVVR BF BFT BLS BS BSA (17, ADXL76) CAN (H) CAN (L) CD CDW Bus CDW Masse CDW Steuerung CDW Versorg. Cod. RXD Cod. TXD CROA

Voltage supply, microphone ground Grounded output, boost pressure control pressure transducer Roof sign switch LED Output, O2 sensor, upstream from TWC Radio muting RS 485 interface, high signal RS 485 interface, low signal Telephone muting Actuation of intake air throttle valve actuator Output, mirror taximeter vehicle speed signal Grounded output, quantity control valve Battery negative Battery positive Bus - data transfer - diagnosis (K-line) Brake wear, right front Front passenger Front passenger door Stop lamp switch NO contact Stop lamp switch NC contact Acceleration pick-up (piezoelectric, micromechanical) CAN (high) CAN (low) Compact Disc CD changer bus CD changer ground CD changer control CD changer supply Coding for service bus (RXD) Coding for service bus (TXD) Crash output, analogPage 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

DD+ D2B IN D2B OUT Daten IR DBE DFA hi.li. DFA hi.re. DFA-HR DFHL DFHR DFVL DFVR Diag. Diag. Sthzg DRS-1 DRS-AY DRS-Ref DRSS DS E-A-Crash E-A-Kupp. E-A-LSVK E-A-TMOT E-F-KS E-F-KWDGB E-F-NWHG E-S-AUS E-S-FSMOEL E-S-KSK

Dynamo, negative Dynamo, positive Input, digital data bus Output, digital data bus Infrared Overhead control panel Rpm sensor output, left rear Rpm sensor output, right rear Rpm sensor output, right rear Rpm sensor, left rear Rpm sensor, right rear Rpm sensor, left front Rpm sensor, right front Diagnosis Stationary heater diagnosis Yaw rate and lateral acceleration sensor Yaw rate and lateral acceleration sensor Yaw rate and lateral acceleration sensor Yaw rate and lateral acceleration sensor Pressure switch Input - analog signal - crash Input - analog - clutch switch Input - analog - oxygen sensor Input - analog - coolant temperature Input frequency - knock sensor Input frequency - crankshaft sensor Input frequency - camshaft Hall sensor Input - shift signal - off Input - signal - oil fill level and temperature Input - shift signal - control shift contactPage 4

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

E-S-S+B E-S-S-B E-S-v. Begr. E-S-WA ED EDW D EDW M EDW-ZA EHD ELV Magnetabsch. ELV-Daten EMV ENR-OFF ER ESG E_AT_NOTA E_Dachz/Funk_UBF E_DPF E_HFM E_HFM2 E_HFMT1 E_IRS_2_DATAS E_KIK E_KT_Dachz/Stat WLH_WVC E_KUP1 E_KW+ E_KWE_LDF E_LSH1

Input - shift signal - set plus accelerate Input - shift signal - set - accelerate (decelerate) Input - signal - variable limit Input - shift signal - resume Duty cycle ATA data Ground ATA state display Electrohydraulic pressure supply Solenoid switch for electric steering adjustment Electric steering lock control unit data Electromagnetic compatibility Actuation of level control lock-out switch LED Capacitor Electrical control unit Input, emergency alarm system activate button Input, roof sign switch Input, pressure differential sensor CAT (NAFTA) Input, mass air flow sensor hot film Input, mass air flow sensor hot film Input, mass air flow sensor hot film, temperature 1 Signal, interior protection sensor, rear Input, kickdown switch pedal value sensor Input, taximeter Input, clutch pedal switch Signal, crankshaft position sensor Signal, crankshaft position sensor Input, charge pressure sensor Input, O2 sensor, upstream from TWCPage 5

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

E_LSIA1 E_LSIP1 E_LSIP2 E_LSUN1 E_LSVM1 E_MOK E_NWDG E_P1 E_P3 E_PWG1 E_PWG2 E_RDS E_RT_NOTA E_T1_2 E_TANS E_TKS E_TMOT E_WSG F FMEA FSB FT FTA Fz GAL Gnd. RF-Ant. GPS-Ant. GS GSL

Input, O2 sensor, upstream from TWC Input, O2 sensor, upstream from TWC Input, common rail high pressure pump Input, O2 sensor, upstream from TWC Input, O2 sensor, upstream from TWC Input, oil sensor (oil level, temperature and quality) Input, Hall sensor for camshaft Input, pressure sensor, downstream from air filter Input, charge pressure sensor Input, pedal value sensor Input, pedal value sensor Input, rail pressure sensor Input, emergency alarm system cancel button Input, mass air flow sensor hot film Input, charge air temperature sensor Input, fuel temperature sensor Input, coolant temperature sensor Input, fuel filter water level sensor Driver Failure mode and effect analysis Parking brake Driver door Failure tree analysis Vehicle Speed-dependent volume control Ground, radio frequency antenne Global positioning system antenna Emergency tensioning retractor Seat belt bucklePage 6

E_Sitz_Bel/Stat ASD_WVC Input, pop-up roof (Westfalia)

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

GSLBF + GSLFA+ GUSFO li. GUSFO li.+ GUSFO re. GUSFO re.+ HFE HFE-HS HFE-IS HHS HL AV HL EV HR AV HR EV IP1S IP2S IPA IPDK IRS1 IS KDS L/R Lsp. hi.li. + Lsp. hi.li. Lsp. hi.re. + Lsp. hi.re. L_GAL L_MIC M SENS M-C-KS

Front passenger seat belt buckle, positive Driver seat belt buckle, positive Left rear emergency tensioning retractor, negative Left rear emergency tensioning retractor, positive Right rear emergency tensioning retractor, negative Right rear emergency tensioning retractor, positive Remote trunk lid release Switch on rear lock for remote trunk lid release Interior switch for remote trunk lid release Heated rear window Left rear pressure reduction solenoid valve Left rear pressure hold solenoid valve Right rear pressure reduction solenoid valve Right rear pressure hold solenoid valve Actual value potentiometer 1 Actual value potentiometer 2 Drive actual value potentiometer Throttle valve actual value potentiometer Signal, interior protection sensor, front Interior safety switch Kickdown switch position Left/right Left rear speaker, positive Left rear speaker, negative Right rear speaker, positive Right rear speaker, negative Speed-dependent volume control Microphone for speed-dependent volume control Ground, sensor Ground - knock sensorPage 7

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

M-C-KWDGB M-R-LSVK MBBVVR MDFHL MDFHR MDFVL MDFVR MH Mikr. Mikr.+ MKL MMV MRS MTSG MV+ M_AGR M_DPF M_EDW M_EKA M_HFM M_KW M_LDF M_MOK M_NWDG M_P1 M_PWG1 M_PWG2 M_RDS M_TANS M_TKS

Ground - crankshaft sensor Ground - oxygen sensor Ground, brake pad wear, right front Ground, vehicle speed sensor, rear left Ground, vehicle speed sensor, right rear Ground, vehicle speed sensor, left front Ground, vehicle rpm sensor, right front Engine hood Microphone negative Microphone positive Multicontour backrest Solenoid valve Multiple restraint system Motor - door control unit Solenoid valve positive Ground, exhaust gas recirculation positioner Ground, pressure differential sensor CAT (NAFTA) Ground, interior protection sensor, rear Ground, inlet port shutoff switchover valve Ground, mass air flow sensor hot film Ground, crankshaft position sensor Ground, charge pressure sensor Ground, oil sensor (oil level, temperature and quality) Ground, Hall sensor for camshaft Ground, pressure sensor, downstream from air filter Ground, pedal value sensor Ground, pedal value sensor Ground, rail pressure sensor Ground, charge air temperature sensor Ground, fuel temperature sensorPage 8

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

M_TMOT M_VDK M_WSG N-R-NWHC NAV MUTE NAV NF NF NF li NF re NOE NSL -LL NSL -RL NV P1 P2 P3 PIC Poti (+) Poti (-) Pu P RL RT RW SAB SAL SAR SBE SEO SFS

Ground, coolant temperature sensor Ground, intake air throttle valve actuator Ground, fuel filter water level sensor Ground - camshaft Hall sensor Navigation system muting Navigation low frequency negative Low frequency Low frequency, left Low frequency, right Emergency opening Rear fog lamp - left-hand drive vehicle Rear fog lamp - right-hand drive vehicle Ancillary consumer (accessory) Gearshift lever gear recognition Selector lever gear recognition Shift intention detection Peripheral integrated circuit (peripheral component with various functions) Potentiometer (positive) Potentiometer (negative) Vacuum Overpressure Backup lamp Interior temperature Residual heat utilization Sidebag Left sidebag Right sidebag Seat occupied recognition Selective unlocking Safingswitch, mechanical safety switchPage 9

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Sig. Sig. RF-Ant. SL -1 SL -2 SL-GND SL_Vcc SN SN-HD SN1 SN2 SP1M SP1S SP2M SP2S SR-1 SR-2 SR-GND SRU SR_Vcc ST T-HS T-OFF TD Temp Temp+ TK TKBFT TKFT TKHT U87

Signal Signal, radio frequency antenna Signal, level sensor, left rear Signal, level sensor, left rear Ground, level sensor, left rear Voltage supply, level sensor, left rear Lock switch Trunk lid lock switch (voltage-coded) Lock switch 1 Lock switch 2 Set value potentiometer 1 ground Set value potentiometer 1 signal Set value potentiometer 2 ground Set value potentiometer 2 signal Signal, level sensor, right rear Signal, level sensor, right rear Ground, level sensor, right rear Manifold vacuum assist Voltage supply, level sensor, right rear Tappet switch (trunk lid) Raise/lower level adjustment switch Level control lock-out switch Tank lid Temperature negative Temperature positive Door contact Door contact front passenger door Door contact driver door Door contact rear doors and tailgate Voltage supply, circuit (terminal) 87Page 10

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

UB KB UMRFP USP1 USP2 USV 1 USV 2 U_DPF U_DRV U_DRVa U_EDW U_HFMb U_KEH U_LDF U_LDRb U_MOK U_NWDG U_P1 U_PWG U_RDS U_V2 U_WSGb U_ZMEa U_ZMEb V-AB V-QL V-QR VL AV VLEV vo.li. -

Voltage operation Excess force limiter Return flow pump monitor Voltage supply, set value potentiometer 1 Voltage supply, set value potentiometer 2 Switchover solenoid valve 1 Switchover solenoid valve 2 Voltage supply, pressure differential sensor CAT (NAFTA) Voltage supply, pressure regulator valve Voltage supply, pressure regulator valve Voltage supply, interior protection sensor, rear Voltage supply, mass air flow sensor hot film Voltage supply, vent line heater element Voltage supply, charge pressure sensor Voltage supply, boost pressure control pressure transducer Voltage supply, oil sensor (oil level, temperature and quality) Voltage supply, Hall sensor for camshaft Voltage supply, pressure sensor, downstream from air filter Voltage supply, pedal value sensor Voltage supply, rail pressure sensor Voltage supply, charge pressure sensor Voltage supply, fuel filter water level sensor Voltage supply, grounded output Voltage supply, common rail high pressure pump Air suspension compressor assembly valve ELC [ENR] valve unit ELC [ENR] valve unit Left front pressure reduction solenoid valve Left front pressure hold solenoid valve Left front negativePage 11

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

vo.li. + vo.re. + vo.re. VR AV VR EV V_Signal_Eing. WALA WL (SRS) ZA ZA-LED ZK Zp. AB, BFZp. AB, BF+ Zp. AB, FAZp. AB, FA+ Zp. GS, BF Zp. GS, BF+ Zp. GS, FA Zp. GS, FA+ Zp. SB,li. Zp. SB,li.+ Zp. SB,re. Zp. SB,re.+

Left front positive Right front positive Right front negative Right front pressure reduction solenoid valve Right front pressure hold solenoid valve Input, mirror taximeter vehicle speed signal See WL Warning lamp (supplemental restraint system) State display State displays - light emitting diode Ignition circuit(s) Front passenger airbag squib, negative Front passenger airbag squib, positive Driver airbag squib, negative Driver airbag squib, positive Front passenger ETR [GUS] squib, negative Front passenger ETR [GUS] squib, positive Driver ETR [GUS] squib, negative Driver ETR [GUS] squib, positive Left sidebag squib, negative Left sidebag squib, positive Right sidebag squib, negative Right sidebag squib, positive

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 12

Location and assignment of ground points

Chapter 3

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

GF00.19-S-2000VB

Location and assignment of ground points

19.7.05

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815

W10

Ground (battery)

GF00.19-S-2000-04VB

W10/4

Ground (additional battery)

GF00.19-S-2000-05VB

W12

Ground (cockpit and center console)

GF00.19-S-2000-26VB

W2

Ground (right front lamp unit)

GF00.19-S-2000-02VB

W2/1

Ground (right front ABS)

GF00.19-S-2000-02VB

W26

Ground (restraint systems control unit)

GF00.19-S-2000-26VBGF00.19-S-2000-21VBGF00.19-S-2000-21VBGF00.19-S-2000-25VBGF00.19-S-2000-24VBGF00.19-S-2000-30VBGF00.19-S-2000-34VBGF00.19-S-2000-01VBGF00.19-S-2000-01VBGF00.19-S-2000-01VBGF00.19-S-2000-02VBGF00.19-S-2000-04VBGF00.19-S-2000-05VBGF00.19-S-2000-21VB

W29/8W29/9W33/4W38W43/1W43/2W9W9/3GF00.19-S-2000-01VBGF00.19-S-2000-02VBGF00.19-S-2000-04VBGF00.19-S-2000-05VBGF00.19-S-2000-21VB

Ground (left D-pillar)Ground (right D-pillar)Ground (tank filler neck)Ground (roof)Ground (left interior compartment firewall)Ground (right interior compartment firewall)Ground (left front lamp unit)Ground (left front ABS)Arrangement and assignment of ground points, engine compartment, leftLocation and assignment of ground points, engine compartment, rightArrangement and assignment of ground points interior leftLocation and assignment of ground points, interior compartment, rightLocation and assignment of ground points - rearend

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

GF00.19-S-2000-01VB

Location and assignment of ground points, engine compartment, left

Model 639

N01.00-2433-06

Ground point Designation

Component Designation

Connector. Pin

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

W9

Ground (left front lamp unit)

E1

Lamp unit, left front

3

E1

Lamp unit, left front

4

E1

Lamp unit, left front

8

E22/1

Additional turn signal lamp, left

2

K40/9

Fuse and relay block

MK2.7

M5/1

Windshield washer fluid pump

222242.22.42.65.55.65.75.82.22.42.62.1132119A. 1A. 5

M5/2M5/3M5/31M6/1N3/9N3/9N3/9N3/10N3/10N3/10N3/10N3/20N3/20N3/20N14/2S11S62/5X15X25/14Y19/2k1W9/3Ground (left front ABS)N30/4N30/4

HCS [SRA] pumpRear window washer fluid pumpRear window washer fluid pump with headlamp cleaning system Windshield wiper motorCDI control unitCDI control unitCDI control unitME control unitME control unitME control unitME control unitCDI control unitCDI control unitCDI control unitGlow output stageBrake fluid indicator switchEmergency alarm system cancel buttonEngine fan 100 C temperature switch connectorO2 sensor/exhaust gas temperature sensor connectorWater valve relayESP control unitESP control unit

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

GF00.19-S-2000-02VB

Location and assignment of ground points, engine compartment, right

Model 639

N62.20-2030-06

Ground point Designation

Component Designation

Connector. Pin

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

W2

Ground (right front lamp unit)

M13/5

Heating water circulation pump

1

E2

Lamp unit, right front

3

E2

Lamp unit, right front

4

E2

Lamp unit, right front

8

E22/2

Additional turn signal lamp, right

2

H1

Audible warning device

A24MK2.722222.12.22.42.65.55.65.75.82.22.42.61112A. 1A. 5

H3/1K2K40/9M5/1M5/2M5/3M5/31N14/2N3/9N3/9N3/9N3/10N3/10N3/10N3/10N3/20N3/20N3/20S11X25/14X42/30W2/1Ground (right front ABS)N30/4N30/4

Alarm signal horn with additional batteryHeadlamp cleaning system relayFuse and relay blockWindshield washer fluid pumpHCS [SRA] pumpRear window washer fluid pumpRear window washer fluid pump with headlamp cleaning system Glow output stageCDI control unitCDI control unitCDI control unitME control unitME control unitME control unitME control unitCDI control unitCDI control unitCDI control unitBrake fluid indicator switchO2 sensor/exhaust gas temperature sensor connectorATA [EDW] separation point, engine hood contactESP control unitESP control unit

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

GF00.19-S-2000-04VB

Arrangement and assignment of ground points interior left

Type 639

N91.10-2171-11

Ground point Designation

Component Designation

Connector. Pin

W10

Ground (battery)

G1

Battery

2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

GF00.19-S-2000-05VB

Location and assignment of ground points, interior compartment, right

Type 639

N91.10-2170-11

Ground point Designation

Component Designation

Connector. Pin

W10/4

Ground (additional battery)

G1/1

Additional battery

2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

GF00.19-S-2000-21VB

Location and assignment of ground points - rear- Type 639 end

N64.20-2014-11

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

N64.20-2015-11

Ground point Designation

Comp-onent Designation

Connector. Pin

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

W29/8

Ground (left D-pillar)

E3

Taillamp, left

3

E22/3

Additional turn signal lamp, left rear

N19/3

Rear AC control unit FONDKLA

A. 4

N125

Telephone high frequency compensator

1.2

S81/1

Rear heater operating switch

A. 4

X8/22

Left rear-end door connector

8

X8/23X8/23X52/5X58/4X96/5Y67W29/9Ground (right D-pillar)A9/1E4E22/4H3/4N9/1N28/1N28/1N51/3S77S77/1X8/20X8/20X8/21X8/21X8/24X11/35X20/11X52/6X58X58X58/12Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Left rear-end door connectorLeft rear-end door connectorLeft taillamp connectorLoad compartment socket, left frontRear recirculation unit connector 3Refrigerant shutoff valveAir suspension compressor assemblyTaillamp, rightAdditional turn signal lamp, right rearBackup warning hornAdditional turn signal module control unitTrailer connection unit [AAG] control unitTrailer connection unit [AAG] control unitENR control unitRaise/lower level adjustment switchLevel control lock-out switchRight rear-end door connectorRight rear-end door connectorTailgate connectorTailgate connectorPop-up roof connector (Westfalia)Air suspension compressor assembly connectorRight taillamp connectorTrailer hitch socket (13-pin)Trailer hitch socket (13-pin)Load compartment socket, right rear

153111.232171.32.21.6101068158133131Page 3

Center high-mounted stop lamp connector, rear-end door 2

GF00.19-S-2000-24VB

Location and assignment of ground points - roof

Model 639

N65.00-2028-11

Ground point Designation

Component Designation

Connector. Pin

W38

Ground (roof)

A50

Taximeter

8

E15

Dome lamp with reading lamp, front

1

E15/6

Interior lamp, left front grab handle

AA

E15/7E15/8E15/9E25/7E25/8Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Interior lamp, right front grab handleInterior lamp, left rear grab handleInterior lamp, right rear grab handleTransistor lamp, leftTransistor lamp, right

AA

2

2Page 1

N70

Overhead control panel control unit

1.2

N70/1

Rear sliding roof unit control unit (SDE-H)

1.2

S62/6

Emergency alarm system activate button

2

S138/1

Left sun visor illumination switch

2

S138/2

Right sun visor illumination switch

2

X2/17

Antenna amplifier voltage supply connector

1

X2/79X2/97X2/98X8/25X29/17X41/6Z20/62Z83/15

TV antenna selector connectorTV double amplifier 1 connectorTV double amplifier 2 connectorSliding roof in pop-up roof separation point (Westfalia)MQS coupling (10-pin)Mirror taximeter separation pointScreening end connector sleeveShielding connector sleeve

111282

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

GF00.19-S-2000-26VB

Location and assignment of ground points center console

Model 639

N68.20-2061-11

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

N68.20-2062-11

Ground point Designation

Component Designation

Connector. Pin

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

W12

Ground (cockpit and center console)

A1

Instrument cluster

8

A1

Instrument cluster

12

A2/77

Telephone and communication unit

j8.12

A2/77

Telephone and communication unit

j8.13

A2/78

Audio-Video-Navigation (AVN)

AB. A8

A35/11

SBS control unit

1.31.391.86A. 51161.23PTCA1.11.1B. 21.111011010B. 124452MK2.71Page 3

A35/13A45/1A49A49/4A56E9/7E13/1K23/1N15/5N26/5N33/4N66/4N72/1N73N123R3S13/3S16/2S46/10S66/4S98S144X11X11X11/32X31/12W26Ground (restraint systems control unit)A53Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

D2B telephone transmitter/receiverSteering wheel clock spring contactTaxi two-way radioSTH radio receiverModular tachographIllumination, front ashtrayGlove compartment lightBlower motor relayElectronic selector lever module control unitElectric steering lock control unitHeater booster control unitRear conversation unit control unitUpper control panel control unitEIS [EZS] control unitHands-free system control unitFront cigar lighter (with illumination)Taxi two-way radio/roof sign switchBackup lamp switchStationary heater switchRear entertainment system switchAir conditioning operating moduleCombination switchData link connectorData link connectorConnector between selector lever module and data link connector Blower connector, terminal 31Thoraxbag and windowbag sensor, left

A54

Thoraxbag and windowbag sensor, right

1

N2/2

SRS control unit

1.83

N2/2

SRS control unit

1.84

N2/10

SRS control unit

1.83

N2/10

SRS control unit

1.84

N2/11

ARCADE airbag control unit

1.15

N2/11X28/18X55/32X55/42

ARCADE airbag control unitSwitch connector, driver seat belt buckleSwitch connector, front passenger seat belt buckle

1.1611

Seat occupied recognition with ACSR [AKSE] connector 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

GF00.19-S-2000-25VB

Location and assignment of ground points - side panel

Type 639

N63.00-2004-11

Ground point Designation

Component Designation

Connector. Pin

W33/4

Ground (tank filler neck)

W43/1

Ground (left interior compartment firewall)

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

GF00.19-S-2000-30VB

Location and assignment of ground points - left firewall

Model 639

N62.25-2068-11

Ground point Designation

Component Designation

Connector. Pin

W43/1

Ground (left interior compartment firewall)

A6n1

STH control unit

1.2

K40/9

Fuse and relay block

I1.6

M3/3

Fuel pump with fuel level sensor

42

M28/11M28/12M46/1N10/16N10/16Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Lumbar support adjustment motor, rightLumbar support adjustment motor, leftSTH fuel metering pumpCOU [ZBE] control unitCOU [ZBE] control unit

22

1.8

1.25Page 1

N32/1

Left front seat adjustment control unit with memory

2.2

N32/2

Right front seat adjustment control unit with memory

2.2

N33/5

Hot air stationary heater control unit

1.10

N34

STH timer

1.4

N69/1

Door control unit, left front

2.4

S12

Parking brake indicator switch

1

X54/29X54/30X58/1X58/17

Heated seats connector, left frontHeated seats connector, right frontInterior socket12V socket

1111

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

GF00.19-S-2000-34VB

Location and assignment of ground points - right firewall

Type 639

N62.25-2067-11

Ground point Designation

Component Designation

Connector. Pin

W43/2

Ground (right interior compartment firewall)

A6n1

STH control unit

1.2

B37/3

Pedal value sensor

2.2

K2

Headlamp cleaning system relay

4I1.6

K40/9M28/11M28/12N26/15N32/1Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Fuse and relay blockLumbar support adjustment motor, rightLumbar support adjustment motor, leftPSM control unitLeft front seat adjustment control unit with memory

22

2.3

2.2Page 1

N32/2

Right front seat adjustment control unit with memory

2.2

N62

PTS control unit

1.10

N69/2

Door control unit, right front

2.4

S12

Parking brake indicator switch

1

S40/3

Clutch pedal switch

1

X30/27

Engine CAN bus connector

1.3

X54/29-2X54/30-1

Heated seats connector, left frontHeated seats connector, right front

11

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Location and assignment of plug connections

Chapter 4

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

GF00.19-S-1000VB

Location and assignment of line and plug connectors

19.7.05

X1/30 X8/20 X8/22 X11/32 X15 X18/2 X18/23 X26/23 X28/23 X30/24 X30/27 X52 X54/12 X62/6 X62/7 X62/8 X62/21 X62/22 X62/28 X62/39 X62/40 X72

Speaker connector Right rear-end door connector Left rear-end door connector Connector between selector lever module and data link connector Engine fan 100 C temperature switch connector Load compartment lamp connector Telephone ON Telephone connector Engine compartment to cockpit connector Airbag connector, driver and front passenger Interior CAN bus connector Engine CAN bus connector Trailer hitch connector 2-pin heated seats connector, left and right Rpm sensor and brake wear sensor connector, right front Rpm sensor and brake wear sensor connector, left front Rpm sensor and brake wear sensor connector, left rear ABS/ASR rpm signal connector, left rear ABS/ASR rpm signal connector, right rear Rpm sensor connector BBV rear axle connector, left BBV rear axle connector, right STH connector

GF00.19-S-1000-05VB GF00.19-S-1000-20VB GF00.19-S-1000-20VB GF00.19-S-1000-05VB GF00.19-S-1000-33VB GF00.19-S-1000-05VB GF00.19-S-1000-05VB GF00.19-S-1000-05VB GF00.19-S-1000-28VB GF00.19-S-1000-05VB GF00.19-S-1000-05VB GF00.19-S-1000-20VB GF00.19-S-1000-05VB GF00.19-S-1000-33VB GF00.19-S-1000-33VB GF00.19-S-1000-24VB GF00.19-S-1000-24VB GF00.19-S-1000-24VB GF00.19-S-1000-05VB GF00.19-S-1000-24VB GF00.19-S-1000-24VB GF00.19-S-1000-05VBPage 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

GF00.19-S-1000-05VB

Location and assignment of line and plug connectors, interior compartment, right

Model 639

N68.10-2199-08

Code

Designation

Cable colors

Cable colors

Notes

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

X1/30

Speaker connector

GY BNGY WH BNWH green BNGN BU BUBN

1 2 3 4 5 6 7 8 1 2 1 2 1

GY BNGY WH BNWH gn BNGN BU BUBN PKYE bn RDWH RD YE

X11/32

Connector between selector lever module and data link connector Load compartment lamp connector

PKYE bn

X18/2

RDWH RD

X18/23

Telephone ON Telephone connector

YE

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

X26/23

Engine compartment to cockpit connector

GNGY GNWH GNYE BNBU BURD green BUVT BUWH BUGY YERD YEWH RDBU GNYE BKGN BN RDGN BNGN BKBU

3 4 5 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 1 2

GNGY GNWH GNYE BNBU BURD GNWH BU BUWH BUGY YERD YEWH RDBU GNYE BKGN BN RDGN BNGN BKBU BNRD BN GNWH GN BNYE BKVT BKGY

X30/24

Interior CAN bus connector

X30/27

Engine CAN bus connector

1 2 3

X54/12

2-pin heated seats connector, left and right

BKVT BKGY

1 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

X62/28

Rpm sensor connector

BUBN BU YEBN YE

1 2 3 4 1 2 3 4 5 6

BUBN BU YEBN YE VTGN VTBK VTYE OG YEGN BUGY

X72

STH connector

VTGN VTBK VTYE OG YEGN BUGY

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

GF00.19-S-1000-20VB

Location and assignment of line and plug connectors - rear

Model 639

N68.30-2073-12

Code

Designation

Cable colors

Cable colors

Notes

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

X8/20

Right rear-end door connector

BURD BUBK BUWH BUGN BKYE BN GYGN BN BUWH

1 2 3 4 5 6 7 8 10 7 8 9 10 1 2 3 4 5

BURD BUBK BUWH BUGN BKYE BN GYGN BN BUWH GYGN BN BUGN BUWH BKBN BKRD RDYE BNBU BN

X8/22

Left rear-end door connector

GYGN BN BUGN BUWH

X52

Trailer hitch connector

BKBN BKRD RDYE BNBU BN

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

GF00.19-S-1000-24VB

Location and assignment of line and plug connectors - underfloor

Model 639

Shown on left side of vehicle

S54.18-4517-05

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 1

Illustrated on right side of vehicle

S35.00-4510-06

Code X62/8

Designation Rpm sensor and brake wear sensor connector, left rear

Cable colors BK WH WH 1 2 1

Cable colors GNRD GNBN BU

Notes

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 2

BK WH BK BK WH X62/21 ABS/ASR rpm signal connector, left rear WH BK X62/22 ABS/ASR rpm signal connector, right rear WH BK X62/39 BBV rear axle connector, left BK WH X62/40 BBV rear axle connector, right BK WH

2 1 2 1 2 1 2 1 2 1 2 1 2

BUBN YE YEBN green GNRD YE YEBN BU BUBN GN GNRD GNRD GNBN

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 3

GF00.19-S-1000-28VB

Location and assignment of line and plug connectors - center console

Model 639

Code

Designation

Cable colors

Cable colors

Notes

X28/23

Airbag connector, driver and front passenger

VT

1

VT

GN

2

GN

BUGN

3

BUGN

BNBK

4

BNBK

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 1

N01.00-2432-06

Code X15

Designation Engine fan 100 C temperature switch connector

Cable colors RD BN BUVT 1 2 3

Cable colors RD BN BU

Notes

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 2

BUWH X62/6 Rpm sensor and brake wear sensor connector, right front WH BK BK WH

4 1 2 1 2 3 4

BUWH WH WHYE

YEVT VTGN BK BKYE

X62/7

Rpm sensor and brake wear sensor connector, left front

WH BK BK WH

1 2 1 2 3 4

VTWH YEVT

Copyright DaimlerChrysler AG 12/3/05 G/11/05. This WIS printout will not be recorded by the update service.

Page 3

Battery, starting charging circuit

Chapter 5

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

PE15.00-S-2000VA ENGINES ENGINES

Wiring diagram for starter, alternator

25.3.03

646.982 /983, 112.951 /976, 642.990 up to 28.2.05 in MODELS 639.601 /603 /605 /701 /703 /705 up to 28.2.05 646.982, 112.951 /976, 642.990 up to 28.2.05 in MODELS 639.711 /713 /811 /813 /815 up to 28.2.05

PE15.00-S-2000-99VA PE15.00-S-2000-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram for starter, alternator Legend of wiring diagram for starter, alternator Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box - location/assignment Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

PE15.00-S-2000-99VA PE15.00-S-2000-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE15.00-S-2000-60VA

Legend of wiring diagram for starter, alternator

ENGINES 646.982 /983, 112.951 /976, 642.990 up to 28.2.05 in MODELS 639.601 /603 /605/ 701 /703 /705 up to 28.2.05 ENGINES 646.982, 112.951 /976, 642.990 up to 28.2.05 in MODELS 639.711 /713 /811/ 813 /815 up to 28.2.05

Code A0 F1 F4 F5 F34 F35 G1 G2/2 G2/5 K40/9

Designation Color code key 1-pin prefuse box Fuse box (1-pin) Fuse box (1-pin) Fuse block, 22-pin Fuse block, 22-pin Battery Alternator 200 A Alternator Fuse and relay block

Coordinates 48L 12G 27L 24L 29K 32L 12K 40A 4A 2K 9K 19K 21K 39K 10A 5K 34K 16K 26H 26H 1A 16HPage 1

M1 N3/9 N14/2 N33/4 U53 U54 U1001 U1002

Starter CDI control unit Glow output stage Heater booster control unit Valid for automatic air conditioning "Thermotronic" Valid for regulated air conditioning "Tempmatic" Valid for engine OM 646 with automatic transmission Valid for PTC element

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

U1080 U150 U740 U999 X22 Z66/1

Valid for alternator 14V / 200 A without automatic transmission Valid for engine M 112 Valid for engine OM 646 Valid for engine OM 646 without automatic transmission Engine compartment and engine connector Additional fuse box feed connector sleeve

41F 24H 37B 34H 37A 3H 30F

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

PE15.00-S-2000VB ENGINES ENGINES

Wiring diagram for starter, alternator

24.8.05

646.982 /983, 112.951 /976, 642.990 as of 1.3.05 in MODELS 639.601 /603 /605 /701 /703 /705 as of 1.3.05 646.982, 112.951 /976, 642.990 as of 1.3.05 in MODELS 639.711 /713 /811 /813 /815 as of 1.3.05

PE15.00-S-2000-99VB PE15.00-S-2000-60VB OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram for starter, alternator Legend of wiring diagram for starter, alternator Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box - location/assignment Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

PE15.00-S-2000-99VB PE15.00-S-2000-60VB OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE15.00-S-2000-60VB

Legend of wiring diagram for starter, alternator

ENGINES 646.982 /983, 112.951 /976, 642.990 from 1.3.05 in MODELS 639.601 /603 /605/ 701 /703 /705 from 1.3.05 ENGINES 646.982, 112.951 /976, 642.990 from 1.3.05 in MODELS 639.711 /713 /811/ 813 /815 from 1.3.05

Code A0 F1 F4 F5 F34 F35 G1 G2/2 G2/5 G2/6 K40/9

Designation Color code key 1-pin prefuse box Fuse box (1-pin) Fuse box (1-pin) Fuse block, 22-pin Fuse block, 22-pin Battery Alternator 200 A Alternator Alternator 200 A with LIN bus Fuse and relay block

Coordinates 64L 31G 53K 50K 42K 44K 35K 24B 17B 4B 8K 15K 22K 29K 37K 40K 29A 18K 3L 58K 11L 55KPage 1

M1 N3/9 N3/20 N14/2 N14/3

Starter CDI control unit CDI control unit Glow output stage Glow output stage

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

N33/4 U53 U54 U1001 U1002 U1080 U150 U740 U960 U999 X22 Z66/1 Z203/3

Heater booster control unit Valid for automatic air conditioning "Thermotronic" Valid for regulated air conditioning "Tempmatic" Valid for engine OM 646 with automatic transmission Valid for PTC element Valid for alternator 14V / 200 A without automatic transmission Valid for engine M 112 Valid for engine OM 646 Valid for engine OM 642 Valid for engine OM 646 without automatic transmission Engine compartment and engine connector Additional fuse box feed connector sleeve Alternator connector sleeve

47L 52H 52H 15B 47H 23G 21B 50H 58H 1B 55H 21B 16H 43G 3H

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

Voltage supply fuses

Chapter 6

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

PE54.15-S-2005VA

Wiring diagram of voltage supply of fuses

25.3.03

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 left seat frame

PE54.15-S-2005-99VA PE54.15-S-2005-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram of voltage supply of fuses Legend of wiring diagram for voltage supply of fuses Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

PE54.15-S-2005-99VA PE54.15-S-2005-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2005-60VA

Legend of wiring diagram for voltage supply of fuses

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 left seat frame

Code E25/7 E25/8 F6 F7 F7-b1 F7-b2 F7-b3 F7-b4 F7-b5 F7f1 F7f2 F7f3 F7f4 F7f5 F7f6 F7f7 F7f8 F7f9 G1 G1/1 K40/9 N26/15 N33/5

Designation Transistor lamp, left Transistor lamp, right Fuse box (1-pin) Fuse block (9-pin) Fuse connector (2-pin) Fuse connector (2-pin) Fuse connector (2-pin) Fuse connector (2-pin) Fuse connector (1-pin) Left door control unit fuse Right door control unit fuse Fuse 1 (PSM) Fuse 2 (PSM) 12V socket fuse, front passenger seat box Charge line to vehicle battery fuse Timer and illumination power supply fuse STH power supply fuse Pop-up roof power supply fuse Battery Additional battery Fuse and relay block PSM control unit Hot air stationary heater control unit

Coordinates 24K 27K 3E 6E 7D 12D 17D 22D 34D 7D 9D 12D 14D 17D 20D 22D 30D 34D 1E 37E 3K 12K 30KPage 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

N34 N69/1 N69/2 U26 U27 U1025 U1036 U1037 U1038 U1039 U1040 U1041 U1042 U1043 U914 U934 U947 U953 U978 U980

STH timer Door control unit, left front Door control unit, right front Valid for taxi version with emergency alarm system Valid for taxi version without emergency alarm system Valid for warm air auxiliary heater with timer and temperature control Valid for freezer vehicle Valid for refrigerator vehicle Valid for FUN equipment line with refrigerator box Valid for warm air auxiliary heater with timer and temperature control with FUN equipment line or comfort plus package Valid for FUN equipment line or comfort plus package without additional heavy-duty battery Valid for FUN equipment line or comfort plus package with heavy-duty battery in addition or for "Marco Polo" camper Valid for electrohydraulic "Easy up" pop-up roof without heavy-duty battery in addition Valid for electrohydraulic "Easy up" pop-up roof with heavy-duty battery in addition or gel additional battery 12V 80Ah Valid for rental vehicle package with emergency alarm system Valid for rental vehicle package without emergency alarm system Valid for parameterizable special module Valid for electrohydraulic "Easy up" pop-up roof Valid for FUN equipment line Valid for "Marco Polo" camper

22K 6K 9K 11G 11G 29G 11H 11H 16G 19B 21G 29B 31B 33B 35B 11H 11J 11G 14C 11G 34G 24G 19G 20B 24G 2L 37L 34L 20L 16KPage 2

W10 W10/4 X8/24 X8/29 X58/17

Ground (battery) Ground (additional battery) Pop-up roof connector (Westfalia) Separation point 2 (Westfalia) 12V socket

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

PE54.15-S-2005VB

Wiring diagram of voltage supply of fuses

25.7.03

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 1, E-box F34

PE54.15-S-2005-99VB PE54.15-S-2005-60VB OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram of voltage supply of fuses Legend of wiring diagram for voltage supply of fuses Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment

Sheet 1 Sheet 1

PE54.15-S-2005-99VB PE54.15-S-2005-60VB OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2005-60VB

Legend of wiring diagram for voltage supply of fuses

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 1, E-box F34

Code A49/4 E15 E15/3 E15/4 E15/6 E15/7 E15/8 E15/9 E15/29 E15/30 E18/1 F34 F34f21 F34f22 F34f23 F34f24 F34f25 F34f26 F34f27 F34f28

Designation STH radio receiver Dome lamp with reading lamp, front Dome lamp, front of rear Dome lamp, rear of rear Interior lamp, left front grab handle Interior lamp, right front grab handle Interior lamp, left rear grab handle Interior lamp, right rear grab handle Load compartment lamp 1, right Load compartment lamp 2, left Trunk lamp Fuse block, 22-pin Exterior lamp switch fuse TV console fuse Interior lamps fuse SHD overhead control panel fuse Rear sliding roof fuse STH radio receiver fuse Front climate control fuse Socket fuse, TV console

Coordinates 69K 54K 50K 48K 37K 39K 42K 45K 20K 30K 23K 33K 17K 27K 6C 7B 11B 37B 58B 64B 69B 73B 76BPage 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

N66/4 N70 N70/1 N72/1 S1 S66/4 S98 U15 U16 U37 U38 U53 U54 U1003 U1004 U1005 U1006

Rear conversation unit control unit Overhead control panel control unit Rear sliding roof unit control unit (SDE-H) Upper control panel control unit Exterior lamp switch Rear entertainment system switch Air conditioning operating module Valid for screen in rear and DVD player Valid for screen in rear, DVD player and TV tuner Valid for ATA [EDW] I Valid for ATA [EDW] II Valid for automatic air conditioning "Thermotronic" Valid for regulated air conditioning "Tempmatic" Valid for additional interior lamp in passenger compartment Valid for interior lamp in rear Valid without additional interior lamp in passenger compartment Valid without interior lamp in rear

13K 75K 58K 65K 6K 4K 11K 72K 11D 75D 11E 75E 57E 57E 72D 72E 26E 36G 26E 47G 16E 16E 20G 30G 23G 33G 57E 53G 53G 53G 68D 65E 65DPage 2

U1007 U1009 U1011 U1012 U1013 U1014 U1015 U1016

Valid for additional interior lamp in load compartment without interior lamp in rear Valid for light/rain sensor Valid without glass tilting/sliding roof in passenger compartment Valid without glass tilting/sliding roof in driver/passenger compartment Valid without anti-theft alarm system with interior protection (EDW II) Valid for warm water auxiliary heater with radio remote control Valid for glass tilting/sliding roof in passenger compartment and roof and rear-end doors, high version Valid for glass tilting/sliding roof in passenger compartment without roof and rear-end doors, high version

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

U1017 U1018 U1019 U1024

Valid for electrohydraulic "Easy up" pop-up roof and glass sliding/lifting roof in driver area/front passenger area Valid without EDW I Valid without light/rain sensor

62D 53H 53H

Valid for DBE with 2 reading spotlights or garage door opener without glass tilting/sliding roof in 59D driver/passenger compartment, glass tilting/sliding roof in passenger compartment, light/rain sensor, EDW II or EDW I Valid for glass tilting/sliding roof in passenger compartment Valid for glass tilting/sliding roof in driver/passenger compartment Valid for alternator 14V / 200 Ah Valid for FUN equipment line 57E 57D 72E 17G 27G 36G 17H 27H 36G 17G 27G 17G 27G 17H 27H 53H 62L 63L 21F 30F 41G 49G 54G 1G

U949 U954 U955 U978

U980

Valid for "Marco Polo" camper

U982 U983 U984 U987 W29/9 X8/25 X18/2 Z4/1

Valid for MPV Valid for TREND equipment line Valid for AMBIENTE equipment line Valid without DBE with 2 reading spotlights Ground (right D-pillar) Sliding roof in pop-up roof separation point (Westfalia) Load compartment lamp connector Ceiling illumination terminal 30 connector sleeve

Z66/1

Additional fuse box feed connector sleeve

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 5

PE54.15-S-2005VC

Wiring diagram of voltage supply of fuses

25.7.03

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 2, E-box F34

PE54.15-S-2005-99VC PE54.15-S-2005-60VC OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram of voltage supply of fuses Legend of wiring diagram for voltage supply of fuses Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment

Sheet 2 Sheet 2

PE54.15-S-2005-99VC PE54.15-S-2005-60VC OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2005-60VC

Legend of wiring diagram for voltage supply of fuses

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 2, E-box F34

Code A0 A2

Designation Color code key Radio / Sound 10 / Sound 40 / Audio 10

Coordinates 72L 58K 61K 64K 54K 51K 4L 7L 48L 17K 7C 8B 14B 18B 20B 23B 24B 26B 27B 30B 33B 36B 45BPage 1

A2/56 A2/78 A35/11 A35/13 A40/3 A56 F34 F34f29 F34f30 F34f31 F34f32 F34f33 F34f34 F34f35 F34f36 F34f37 F34f38 F34f39 F34f40

Radio and navigation unit Audio-Video-Navigation (AVN) SBS control unit Telephone transmitter/receiver, D2B COMAND operating, display and control unit Modular tachograph Fuse block, 22-pin D2BPortable CTEL fuse, portable CTEL and SBS Heated seats fuse Fuse, tachograph Fuse 32 Data link connector fuse Fuse 34 Air conditioning pulsed valve power supply fuse SRA fuse ATA [EDW] siren fuse EIS [EZS] steering lock fuse Front blower fuse Brake system valve fuse

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

F34f41 F34f42 H3/1 K2 K23/1 N30/4 N72/1 N73 N123 S98 U10 U11 U13 U38 U51 U52 U53 U55 U285 U286 U507 U909 U910 U913 U922 U923 U928 U956 U957 U958

Brake system delivery pump fuse Radio fuse or DIN navigation Alarm signal horn with additional battery Headlamp cleaning system relay Blower motor relay ESP control unit Upper control panel control unit EIS [EZS] control unit Hands-free system control unit Air conditioning operating module Valid for Sound 40 Pro radio Valid for radio with cassette drive, Latin America Valid for auto pilot system with TMC interface Valid for ATA [EDW] II Valid for telephone preinstallation Valid for voice control Valid for automatic air conditioning "Thermotronic" Not valid for air conditioning Valid for partially electric seat adjustment, driver Valid for partially electric seat adjustment, front passenger Valid for Electronic Stability Program (ESP) Valid for radio preinstallation Valid for radio Sound 10 with cassette drive Valid for networked telephone preinstallation Valid for heater for front passenger seat Valid for heater for driver seat Valid for headlamp cleaning system Valid for auto pilot system for Japan, large display Valid for Audio 10 radio with cassette drive Valid for Audio 10 radio with CD

46B 57B 30K 27K 41L 45K 14K 33K 10L 36L 64D 61E 48D 30D 10D 4D 38G 35G 14E 14E 45D 67D 57D 7D 14D 14D 27D 51D 61D 61EPage 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

U959 U968 U998 W12 X31/9 Z66/1 Z151/3

Valid for Audio 30 APS radio with TMC interface Valid for 1 day/2 driver tachograph Valid for auxiliary heater without air conditioning system Ground (cockpit and center console) Blower switch feed-in connector Additional fuse box feed connector sleeve A/C 1st stage connector sleeve

54D 17D 41G 20L 36F 2G 39H

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

PE54.15-S-2005VD

Wiring diagram of voltage supply of fuses

25.8.05

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 E-box F35

PE54.15-S-2005-99VD PE54.15-S-2005-60VD OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram of voltage supply of fuses Legend of wiring diagram for voltage supply of fuses Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

PE54.15-S-2005-99VD PE54.15-S-2005-60VD OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2005-60VD

Legend of wiring diagram for voltage supply of fuses

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 E-box F35

Code A2/17 A2/77 A6n1 A32/1 A32/2 F35 F35f21 F35f22 F35f23 F35f24 F35f25 F35f26 F35f27 F35f28 F35f29 F35f30 F35f31 F35f32 F35f33 F35f34 F35f35 F35f36 F35f37

Designation Antenna amplifier voltage supply Telephone and communication unit STH control unit Rear air recirculation heater Rear automatic air conditioning air unit Fuse block, 22-pin Left passenger compartment 12V socket fuse Right passenger compartment 12V socket fuse Trailer socket fuse AAG fuse Driver seat adjustment fuse Front passenger seat adjustment fuse Left electric sliding door fuse Right electric sliding door fuse Rear blower fuse Air suspension or all-wheel drive fuse PTS fuse Tire pressure monitoring system fuse Communications unit (Japan) or telephone (USA) fuse Compensator fuse, VICS and TV amplifier (Japan) STH control unit fuse Tailgate power closing fuse Rear air conditioning fuse

Coordinates 58K 50K 63K 35K 38K 5B 7B 10B 16B 23B 27B 31B 33B 35B 37B 42B 46B 49B 51B 58B 63B 67B 68BPage 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

F35f38 F35f39 F35f40 F35f41 F35f42 N9/1 N19/3 N28/1 N32/1 N32/2 N51/3 N62 N125 S81/1 U1026 U1027

Brake controller fuse (NAFTA) Front blower fuse Rear 12V socket fuse Additional turn signal module fuse Fuse 42 Additional turn signal module control unit Rear AC control unit FONDKLA Trailer connection unit [AAG] control unit Left front seat adjustment control unit with memory Right front seat adjustment control unit with memory ENR control unit PTS control unit Telephone high frequency compensator Rear automatic air conditioning operating switch Valid for ashtray and beverage holder in passenger compartment Valid for additional heat exchanger in passenger load compartment

70B 71B 73B 76B 78B 76K 66K 18K 22K 26K 31K 42K 45K 55K 69K 2H 6D 2F 34D 35G 69D 2E 72D 15D 22D 18D 2G 26D 2G 30D 2F 45D 2E 54DPage 2

U1028 U1107 U1108 U285 U286 U538 U913

Valid for socket 12V in passenger compartment Valid up to08/2005 Valid as of09/2005 Valid for partially electric seat adjustment, driver Valid for partially electric seat adjustment, front passenger Valid for Parktronic System Valid for networked telephone preinstallation

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

U939

Valid for socket for rear-mounted bicycle carrier repeater lamps

2E 15E 15G 18D 22D 2D 15E 18E 22E 2H 15E 15G 18E 22E 2H 15E 15H 18E 22E 2F 63D 63D 2D 41D 2G 34D 38G 66D 50D 58D 2G 75D 51F 15F 15K 7K 72K 10KPage 3

U940

Valid for electrical system for trailer socket

U941

Valid for fixed trailer hitch

U942

Valid for removable trailer hitch

U945 U946 U951 U952

Valid for warm water auxiliary heater Valid for diesel heater booster Valid for raisable/lowerable rear air suspension Valid for Tempmatic/Additional air conditioning in rear

U956 U976 X2/18 X52 X58 X58/4 X58/12 X58/15

Valid for auto pilot system for Japan, large display Valid for additional turn signal lamps on rear of roof Antenna amplifier voltage supply connector Trailer hitch connector Trailer hitch socket (13-pin) Load compartment socket, left front Load compartment socket, right rear Load compartment socket, right front

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

X96/4 X137/1 Z51 Z66/1

Rear recirculation unit connector 2 VICS+ETC voltage supply separation point ELC [ENR] terminal 30 connector sleeve Additional fuse box feed connector sleeve

37F 61L 42G 3G

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 5

Fuse and relay board (SRB)

Chapter 7

06/05

Transporters Electrics Van - Electrical Systems Wiring Diagrams VITO (Model 639)

PE54.15-S-2001VA

Wiring diagram for fuse and relay box

14.5.03

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 1

PE54.15-S-2001-99VA PE54.15-S-2001-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram for fuse and relay box Legend of wiring diagram for fuse and relay box Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment

Sheet 1 Sheet 1

PE54.15-S-2001-99VA PE54.15-S-2001-60VA OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2001-60VA

Legend for wiring diagram of fuse and relay box

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 1

Code K40/9

Designation Fuse and relay block

Coordinates 3C 22C 44C 66C 7D 5K 57K 37K 36K 9K 56K 8K 8G 12G 7K 62D 36K 25K 30F 18D 29D 34K 35K 45KPage 1

K40/9f1 K40/9f2 K40/9f3 K40/9f4 K40/9f5 K40/9f6 K40/9f7 K40/9f8 K40/9f9 K40/9f10 K40/9f11 K40/9f12 K40/9f13 K40/9f14 K40/9f15 K40/9f16 K40/9f17 K40/9f18 K40/9f19 K40/9f20

Front wiper fuse Horn fuse Stop lamp switch fuse Heater fuse Data link connector fuse, exterior lamp switch, instrument cluster Engine components fuse Rear wiper fuse Engine components voltage supply fuse 1 Engine components voltage supply fuse 2 Engine components voltage supply fuse Engine terminal 30Z fuse Rear window heater fuse Instrument cluster fuse, EIS [EZS] Brake system fuse Headlamp range adjustment fuse Starter fuse FP fuse Cigar lighter fuse, glove compartment illumination Radio fuse Ignition coil M112 fuse

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

K40/9f21 K40/9f22 K40/9f23 K40/9f24 K40/9f25 K40/9f26 K40/9f27 K40/9f28 K40/9f29 K40/9f30 K40/9f31 K40/9f32 K40/9f33 K40/9f34 K40/9f35 K40/9f36 K40/9f37 K40/9f38 K40/9f39 K40/9f40 K40/9f41 K40/9k1 K40/9k2 K40/9k3 K40/9k4 K40/9k5 K40/9k6 K40/9k7 K40/9k8 K40/9k9

Electronic selector lever module fuse Fuse, tachograph Airbag control unit fuse Fuse AAG fuse Cutoff relay fuse (Westfalia) Body manufacturer terminal 15 fuse Terminal 87 fuse, ETC [EGS] Fuse Fuse ATA [EDW] horn fuse Portable CTEL fuse, VICS Airbag control unit fuse, ACSR [AKSE] Body manufacturer terminal 15 fuse Standard overhead control panel fuse Lumbar support adjustment fuse Vanity mirror fuse TV entertainment system fuse Fuse Engine fuse (diesel control unit) Engine fuse (diesel control unit) Horn relay Wiper On and Off relay Wiper level 2 relay Circuit 87 engine relay Starter relay Fuel pump relay Circuit 15R relay Circuit 15 relay Heated rear window relay

46K 47K 49K 45K 47K 48K 49K 52K 51K 50K 4K 40K 41K 42K 42K 43K 53K 53K 54K 10K 11K 4C 8C 11C 15C 17C 24C 33C 36C 58CPage 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

K40/9k10 K40/9k11 M1 N10

Terminal 15R relief relay Circuit 15 relief relay Starter SAM control unit

49C 54C 14L 3B 22B 45B 66B

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 4

PE54.15-S-2001VC

Wiring diagram for fuse and relay box

25.7.03

MODEL 639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 2

PE54.15-S-2001-99VC PE54.15-S-2001-60VC OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Wiring diagram for fuse and relay box Legend of wiring diagram for fuse and relay box Use of wiring diagrams Search aid for all wiring diagram groups Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Search aid for all electrical components Abbreviations for wiring diagrams Abbreviations of signal and circuit designations for wiring diagrams Location and assignment of line and plug connectors Location and assignment of connectors and sockets Location and assignment of ground points Location and assignment of Z connector sleeves (line connectors in wiring harness) Fuse and relay box, location/assignment

Sheet 2 Sheet 2

PE54.15-S-2001-99VC PE54.15-S-2001-60VC OV00.01-S-1901-03VA OV00.01-S-1901VA OV00.01-S-1909VA OV00.01-S-1909VB OV00.01-S-1909VC OV00.01-S-1909VD OV00.01-S-1909VE OV00.01-S-1001-27VA OV00.01-S-1001-28VA GF00.19-S-1000VB GF00.19-S-1100VB GF00.19-S-2000VB GF00.19-S-3000VB GF54.15-S-0900VA

Components from A to E Components from F to J Components from K to O Components from P to T Components from U to Z

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

PE54.15-S-2001-60VC

Legend of wiring diagram for fuse and relay box

MODEL

639.601 /603 /605 /701 /703 /705 /711 /713 /811 /813 /815 Sheet 2

Code A56 B2/7 B76 B85 K40/9

Designation Modular tachograph Hot film mass air flow sensor Fuel filter water level sensor O2 sensor, upstream from TWC Fuse and relay block

Coordinates 27K 14K 8K 12K 17L 20L 4A 11A 18A 25A 32A 39A 46A 53A 60A 13B 24B 28B 34B 37B 42B 47B 49B 51B 52B 54B 56BPage 1

K40/9f20 K40/9f21 K40/9f22 K40/9f23 K40/9f24 K40/9f25 K40/9f26 K40/9f27 K40/9f28 K40/9f29 K40/9f30 K40/9f31

Ignition coil M112 fuse Electronic selector lever module fuse Fuse, tachograph Airbag control unit fuse Fuse AAG fuse Cutoff relay fuse (Westfalia) Body manufacturer terminal 15 fuse Terminal 87 fuse, ETC [EGS] Fuse Fuse ATA [EDW] horn fuse

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

K57 N2/2 N2/10 N2/11 N15/3 N15/5 N28/1 U32 U33 U1031 U1033 U1107 U1108 U150 U939 U940 U941 U942 U943 U944 U960 U961 U968 U994 X18/66

Battery cutoff relay SRS control unit SRS control unit ARCADE airbag control unit EGS control unit Electronic selector lever module control unit Trailer connection unit [AAG] control unit Valid for left-hand drive vehicles Valid for right-hand drive vehicles Valid for additional heavy-duty battery Valid for engine OM 646 with fuel filter with water separator and engine version Euro 3 (diesel) Valid up to 08/2005 Valid as of 09/2005 Valid for engine M 112 Valid for socket for rear-mounted bicycle carrier repeater lamps Valid for electrical system for trailer socket Valid for fixed trailer hitch Valid for removable trailer hitch Valid with Window-Thoraxbag for driver and front passenger Valid without window thoraxbag for driver and front passenger Valid for engine OM 642 Valid for automatic transmission Valid for 1 day/2 driver tachograph Valid for fuel filter with water separator O2 sensor connector

47K 31K 34K 37K 50K 23K 40K 43K 17F 20F 47D 8D 30D 40D 37D 43D 4D 40D 43D 40E 43D 40E 43E 40E 43E 34E 30E 11D 23D 50D 27D 12F 20HPage 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

X25/14 Z3/29 Z3/64

Connector for O2-sensor/exhaust gas temperature sensor Circuit 15 connector sleeve (fused) Circuit 15 connector sleeve

19E 5G 15E

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 1

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 2

Copyright DaimlerChrysler AG 03.12.2005 CD-Ausgabe G/11/05 . This WIS print-out will not be recorded by Modification services.

Page 3

Copyr