MEE/ GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY ... GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY OFFER...

MEE/ GC2 / 05 / 2013 / Dy.CME(ES&CH)

BUDGETARY OFFER

FOR

SUBMITTING FEASIBILITY REPORTS OF ELECTRICAL ENERGY

AUDIT AND DIESEL ENERGY AUDIT IN THE CHENNAI PORT

TRUST

SUBMISSION ON OR BEFORE 06 .06.2013

THE CHIEF MECHANICAL ENGINEER 7TH Floor, Centenary Building Rajaji Salai, Chennai – 600 001.

BUDGETARY OFFER FOR SUBMITTING FEASIBILITY REPORTS OF ELECTRICAL ENERGY AUDIT AND DIESEL ENERGY AUDIT IN THE CHENNAI PORT TRUST

TECHNICAL SPECIFICATION SCHEDULE ‘A’

1.0 GENERAL:

Chennai port trust has proposed to conduct the Electrical Energy Audit and

Diesel Energy Audit with in the port areas. This will be focused to study of entire HT

& LT power distribution, load pattern, maximum demand & connected load, load

distribution (like motors under different operational conditions) mechanical power

transmission system, power factor, monitoring & control system, Harmonic analysis,

water pumping system, Refrigeration and Air conditioning system, to study of

illumination for street light, wharf crane, tower light, yard light and office, to study of

fuel consumption and reduce wastages.

2.0 SCOPE OF WORK

Requirements:

1. Certified Energy Auditors by State Electricity Board

2. Registered society at BEE / State Electricity Board

3. Accredited by the BEE (Bureau of Energy Efficiency) to conduct electrical

energy audit and Diesel Energy Audit.

4. Previous experience in energy (Electrical & Diesel) Audit in Industries.

5. To carryout preliminary and detailed energy audit to be mainly targeted for

identifying practical sustainable & economical viable energy saving

opportunities in all section of the plant on sites for Electrical energy audit

and Diesel energy audit for intensive equipment.

6. To reduce energy consumption and to save energy cost.

7. To create awareness, importance, benefits and methods of conserving

Electrical energy renewable energy and diesel conservation for clean

environment.

8. To conducting feasibility studies to identify the area where waste can occur

and where scope for improvement exists. In general energy audit is carried

out to know the present energy consumption scenario and to determine

ways to reduce energy throughout the Port Trust.

9. Techno Economic feasibility report/ site feasibility report.

10. Detailed project Report

11. Resource Assessment (Potential Survey RA /PS)

SUBSTATION

1. 33 KV Substation (Near MOHP)

The maximum permitted demand (PMD) is 7000 KVA. The 33 KV

incomer power supply is fed from TNEB kalmandapam substation near 2A

gate to 33 KV substation through 33 KV switching station at Gate No.2A. The

average energy consumption per day is 55,512 units. (kwhr)

2. E Substation (Near Heavy work shop)

The Maximum permitted demand (PMD) is 1250 KVA. The 11KV

Supply is fed from TNEB substation (near sea farers club, Rajaji salai to ‘E’

Substation. The average energy consumption per day is 5,513 units. (kwhr).

3. In addition there are 8 Nos. 11KV substation are interconnected and

distribute the power system viz A, B, C, F, G, H, SQ-I, & CB at various

locations.

4. 3.3. KV substation for ore handling plant.

5. 3.3. KV substation for oil dock.

OUT SIDE PORT AREAS

6. Fisheries Harbour 11 KV substation.

The Maximum permitted demand (PMD) is 800 KVA. The 11KV Supply is fed

from TNEB substation.

7. Tondiarpet Housing Colony 11KV substation.

The Maximum permitted demand (PMD) is 650 KVA. The 11KV Supply is fed

from TNEB substation.

TRANSFORMER

1. To study the loading pattern and estimation of efficiency and losses of

transformer.

ENGINES:

MOTORS

1. To study of loading & operation efficiency of motors at various locations

pump motor, crane motor and machineries.

2. Feasibility of replacement by energy efficient motors.

3. To study of existing motor drives and suggest improvement in the present

drives to reduce energy consumption.

AIR CONDITIONERS

Transformer for Air conditioners, power consumption of Air conditioners, Air

flow measurement, Temperature measurements, Humidity measurements in

the air conditioned area estimation of energy efficiency ratio for split, window

type Air conditioners.

PUMPS

Pump performance shall be done by simultaneous measurements of head

flow and power.

DIESEL ENGINE:

To study performance, efficiency and fuel consumption of Tugs, launches,

generators sets, locomotives, Automobiles etc,.

CAPACITOR

To asses the need for power factor improvement from the existing level

measurements of the power at individual capacitor at load centre.

LIGHTING:

To study of illumination levels at different work place, wharves, office, yard

and street area.

To study of feasibility of use energy efficient lighting system practices and

controls.

Note: All the Load details are enclosed separate sheets

3.0. COMPLETION PERIOD:

The contract period is for 2 months for study and further 1 month for report

submission from the date of receipt of order.

4.0. FEASIBILITY REPORT: Development & issue of final report including verification statement.

Original – 1 No.

Copies – 4 Nos.

PDF file – 1 No.

5.0. ESI CLAUSE: The details of employees proposed to be engaged shall be furnished to this office before the commencement of the work. (a) As per the Govt. Notification dated 20.07.2009, Chennai Port Trust has registered under the ESI Act on 26.09.2012 with ESI Corporation and provision of ESI Act, 1948 are applicable to Chennai Port Trust, a Social Security Act, is applicable to Factories using power and employing 10 or more personnel and establishment

employing 20 or more persons and drawing wages/salary upto Rs.15,000/- per month. Workers covered under ESI Act, are entitled for full medical care for self and family. Besides, cash benefit in the event of sickness, maternity and employment injury. Accordingly, the contractual/casual employees drawing wages upto Rs.15,000/- per month employed either directly by Port Trust or through contractor are covered under ESI Act, 1948. It is obligatory on the part of the employer to calculate and remit ESI contribution comprising of employers’ share of 4.75% plus employees’ share of 1.75% which is payable on or before 21st of the following month, to which the salary relates. (b) In case of Contractor employs more than 20 employees, they should register their name with ESI as per ESI Act, 1948 and obtain ESI Code. Both Employers share of 4.75% and Employees contribution of 1.75% (recovered from employees), totally 6.5% to be paid as contribution to ESI in their Code on or before 21st of following month to which the salary relates and acknowledgement for the same shall be submitted to the Port while claiming the bill. The bill without the acknowledgment of ESI contribution will not be entertained. In case the contractor has not paid the ESI contribution same will be recovered in the running bill and paid to the ESI Corporation in contractor’s code. The delay in payment of contribution payable under the Act may be recovered as an arrear of Land Revenue. (c) In case the contractor employs less than 20 employees, the list of employees’ names, their father’s name, identification proof, one passport photo shall be submitted to the Port Trust. The contribution of ESI amount, both Employers share of 4.75% and Employees contribution of 1.75% (recovered from Employees salary), totally 6.5% shall be paid by the Contractor in the Chennai Port Trust Code on or before 21st of the following month to which the salary relates or otherwise payment to the contractor will be withheld. If the contractor fails to comply with the above instruction, then the Principal Employer (Chennai Port Trust) will make payment to the ESI Corporation. Such amount will be deducted from any amount due to the contractor. The delay in payment of contribution payable under the Act may be recovered as an arrear of Land Revenue. 6.0 OTHER TERMS AND CONDITION i) The technical specification – “Schedule-A” and Price Schedule – A1” to be

read in conjunction to make sure of the supply and works involved. ii) The contractor is required to offer rates as per Trust’s format “Schedule-A1”

without fail and mention taxes and duties. iii) The Trust will not be responsible for any damage or loss of any of the firm’s

men and materials and for any damage / accident to the firm’s personnel.

iv) The contractor may inspect the site before quoting. v) Safety and safe custody of all men, materials, tools and plants that are

required by the firm during site works, till handing over to the Trust shall be entirely the responsibility of the firm.

vi) The Contractor shall arrange their own tools and plants and other materials

and components required for the above work. vii) For any clarifications, if any the firm may contact the ‘Executive Engineer’

(ES) at 2nd floor of the Old Administrative Office Building, Tel. Ph. 25362201, Extn. 2542 (or) S.E.(ES) at 2nd floor of the Old Administrative Office Building, Tel. Ph. 25362201, Extn. 2254 (or) Dy.CME(ES&CH) at 7th floor of Centenary Building, Tel. Ph. 25362201 Extn: 2707.

CHIEF MECHANICAL ENGINEER

CHENNAI PORT TRUST

BUDGETARY OFFER FOR SUBMITTING FEASIBILITY REPORTS OF ELECTRICAL ENERGY AUDIT AND DIESEL ENERGY AUDIT IN THE CHENNAI PORT TRUST

SCHEDULE OF PRICES AND QUANTITIES SCHEDULE ‘A1’

Sl.No. Description of Item Unit Qty Rate in Rup Amount in R 1. Cost for carryout

preliminary and detailed energy audit to be mainly targeted for identifying practical sustainable & economical viable energy opportunities in all section of the plant on sites for Electrical audit for intensive equipment as detailed in Schedule ‘A’.

L.S. L.S.

2. Cost for carryout preliminary and detailed Diesel audit to be mainly targeted for identifying practical sustainable & economical viable energy opportunities in all section of the plant on sites for Diesel audit for intensive equipment.

3. Taxes and duties with break up d

Total amount in Rupees only inclusive of taxes and duties

Firm’s Signature and Seal LOAD DETAILS

ANNEXURE - I

Sl.No. Description of Item Location Quantity Wattage

1. 2X36 W Tube light fitting

Old Admn GF to IV floor

510 Nos. 80 W

2. 2X36 W Tube light fitting

COS building GF to IV floor

120 Nos. 80 W

3. 2 x28 W energy efficient fitting

CB building Basement to 10th floor

550 Nos. 80 W

4. 2 x36 W Tube light fitting

Main hospital, new building & Diamond jubilee building

1050 Nos. 80 W

5. 2 x36 W Tube light fitting

Guest house GF,I, II Floor & Annex VIP & VVIP Building

175 Nos. 80 W

6. 2 x36 W tube light fitting

HD 1,2,3 LHS 14,15,16, LHS2 QTRS

290 Nos. 80 W

7. 2x36 W tube light fitting

CDO complex GF to III floor

420 Nos. 80 W


Type V Quarters 650 Nos. 80 W


CISF barracks 400 Nos. 80 W


DCOS Stores 60 Nos. 80 W


Spare part wards 100 Nos. 80 W


EME II OFFICE 60 Nos. 80 W


Civil office & PWD Office

60 Nos. 80 W


Civil office old officers club

50 Nos. 80 W


M.yard loco shed SS room Rly control building

50 Nos. 80 W


Pay loader & FLT 40 Nos. 80 W

17. 2x36 W tube light JD I to VII & 40 Nos. 80 W

fitting Electronics section 18. 2x36 W tube light

fitting C/WS shop & AO canteen

60 Nos. 80 W


Time office and marine offices

180 Nos. 80 W


WQ I to V SM building

30 Nos. 80 W


Call point complex 120 Nos. 80 W

22. 2x36 W tube light fittin Passenger Terminal

160 Nos. 80 W

ANNEXURE – II

Sl.No. Description of Item Location Quantity Load

1. Ceiling fan Old Admn GF to IV floor

390 Nos. 80 W

2. Ceiling fan COS building GF to IV floor

60 Nos. 80 W

3. Ceiling fan CB building Basement to 10th floor

150 Nos. 80 W

4. Ceiling fan Main hospital, new building & Diamond jubilee building

60 Nos. 80 W

5. Ceiling fan Guest house GF,I, II Floor & Annex VIP & VVIP Building

75 Nos. 80 W

6. Ceiling fan HD 1,2,3 LHS 14,15,16, LHS2 QTRS

135 Nos. 80 W

7. Ceiling fan CDO complex GF to III floor

220 Nos. 80 W

8. Ceiling fan Type V Quarters 350 Nos. 80 W

9. Ceiling fan CISF barracks 30 Nos. 80 W

10. Ceiling fan DCOS Stores 25 Nos. 80 W

11. Ceiling fan Spare part wards 30 Nos. 80 W

12. Ceiling fan EME II OFFICE 40 Nos. 80 W

13. Ceiling fan Civil office & PWD

Office 40 Nos. 80 W

14. Ceiling fan Civil office old officers club

40 Nos. 80 W

15. Ceiling fan M.yard loco shed SS room Rly control building

30 Nos. 80 W

16. Ceiling fan Pay loader & FLT 20 Nos. 80 W

17. Ceiling fan JD I to VII & Electronics section

20 Nos. 80 W

18. Ceiling fan C/WS shop & AO canteen

30 Nos. 80 W

19. Ceiling fan Time office and marine offices

60 Nos. 80 W

20. Ceiling fan WQ I to V SM building

20 Nos. 80 W

21. Ceiling fan Call point complex 80 Nos. 80 W

22. Ceiling fan Passenger Terminal

75 Nos. 80 W

ANNEXURE – III


1. Geyser Old Admn GF to IV floor

10 Nos. 2000 W

2. Geyser CB building Basement to 10th floor

9 Nos. 2000 W

3. Geyser Main hospital, new building & Diamond jubilee building

25 Nos. 2000 W

4. Geyser Guest house GF,I, II Floor & Annex VIP & VVIP Building

30 Nos. 2000 W

5. Geyser HD 1,2,3 LHS 30 Nos. 2000 W

14,15,16, LHS2 QTRS

6. Geyser CDO complex GF to III floor

4 Nos. 2000 W

7. Geyser Type V Quarters 80 Nos. 2000 W

8. Geyser CISF barracks 5 Nos. 2000 W

9. Geyser Civil office & PWD Office

2 Nos. 2000 W

10. Geyser Civil office old officers club

2 Nos. 2000 W

11. Geyser M.yard loco shed SS room Rly control building

2 Nos. 2000 W

12. Geyser Pay loader & FLT 1 No. 2000 W

13. Geyser JD I to VII & Electronics section

1 No. 2000 W

14. Geyser C/WS shop & AO canteen

3 Nos. 2000 W

15. Geyser Time office and marine offices

1 No. 2000 W

ANNEXURE - IV

GENERATOR SET


1. 1000 KVA 33 KV Substation 4 Nos. 3.3 KV

2. 1000 KVA 33 KV Substation 1 No. 11 KV

3. 500 KVA ‘A’ Substation 2 Nos. 415 V

4. 500 KVA ‘CB’ Substation 2 Nos. 415 V

5. 1000 KVA Old Admn Building 1 No. 415 V

6. 320 KVA ‘E’ substation 1 No. 415 V

7. 100 KVA Signal station 1 No. 415 V

8. 500 KVA ‘G’ Substation 1 No. 415 V

ANNEXURE – V

DETAILS OF TRANSFORMERS AND GENERATORS AT VARIOUS SUB STATIONS INSIDE THE CHENNAI PORT TRUST Sl.No Substation and

Location Maximum Demand

Total Capacity

Transformer & Quantity

1. 33 KV Substation (Location: Ore berth)

7000 KVA 25,615 KVA 6300 KVA 33/11KV - 1No. 4000 KVA 33/11KV - 1 No. 4000 KVA 33 / 3.3 KV - 3 Nos. 3000 KVA 3.3 /11 KV - 1 No. 11 /3.3 KV 315 KVA 3.3 / 415 V - 1 No.

2. ‘A’ Substation (Location: Southern side of boat basin)

2000 KVA 500 KVA 11 KV /415 V - 4 Nos.

3. ‘B’ Substation (Location: WQ 1 car export Terminal)

2000 KVA

1000 KVA 11 KV /415 V - 2 Nos.

4. ‘C’ Substation (Location: Near container Terminal)

6250 KVA

3150 KVA 11 /3.3 KV - 2 Nos.

5. ‘CB’ Substation (Location: Marshalling yard – FF Road

2500 KVA

1000 KVA 11 KV /415 V - 2 Nos. 500 KVA 11 KV /415 V - 1 No.

6. ‘E’ Substation (Location: Heavy work shop)

1250 KVA

1000 KVA

500 KVA 11 KV /415 V - 2 Nos.

7. ‘F’ Substation (Location: User complex)

1500 KVA

750 KVA 11 KV /415 V - 2 Nos.

8. ‘G’ Substation (Location: Diabetic specialty centre)

500 KVA

500 KVA 11 KV /415 V -- 1 No.

9. ‘H’ Substation (Location: Opposite to bubble structure on INS Adyar)

500 KVA

500 KVA 11 KV /415 V - 1 No.

10. ‘Hydraulic Power House’ Substation (Location: WQ IV area)

1000 KVA

500 KVA 11 KV /415 V - 2 Nos.

11. ‘South Quay I’ Sub substation (Location: Eastern side of Boat basin)

1000 KVA

500 KVA 11 KV /415 V - 2 Nos.

12. Fisheries Harbour Substation (Location: Fisheries Harbour)

800 KVA

1000 KVA

500 KVA 11 KV /415 V - 2 Nos. 350 KVA 11KV/ 415 V - 1 No.

13. Tondiarpet Housing Colony Substation (Location: TH colony)

650 KVA

1000 KVA

500 KVA 11 KV /415 V - 2 Nos.

ANNEXURE - VI ENERGY CONSUMPTION OF CHENNAI PORT TRUST AND FIRM’S

Sl N

Location Permitted Max Demand

Reached Max Demand (Ave)

Billed Max Demand (Min-90%)

Energy Consumption/month

Billed Energy Consumption Amt in Rs.

1

33 KV sub station HT A/C No. 1291

7000 KVA

6300 KVA

17,61,390

1,47,32,993

2.

E sub station HT A/C No.2052

1250 KVA

1125 KVA

1,86,626

14,39,671

3

ACT

400 KVA

228 KVA

360 KVA

4.

Fisheries Harbour HT A/C No.1208

800 KVA

720 KVA

38,12,870

2,51,62,812

5.

Tondiarpet Housing colony HT A/C No.1522

650 KVA

585 KVA

30,92,042

3,36,77,724

6.

M/S CITPL

2250 KVA

4,34,461

7.

M/S CCTPL

2100 KVA

10,39,526

ANNEXURE - VII

ENERGY CONSUMPTION OF CHENNAI PORT TRUST

Sl No

Location

Energy Consumption/month

Billed Energy Consumpt Amt in Rs).

1.

CISF Barracks

21000 Units

2

Firm’s (Permanent) supply

125330 units

3.

Firm’s (Temporary) supply

20380 units

4.

Officer’s Qtrs. (Type V)

13700 units

5.

LHS Qtrs.

9006 units

6.

Clive Battery Qtrs.

2359 units

7.

DLB Staff Qtrs.

2327 units

8.

Trust Villa Qtrs.

4770 units

ANNEXURE - VIII

MOTOR PUMP CONSUMPTION DETAILS

SL. No

LOCATION

CAPACITY OF MOTOR

IN H. P.

NUMBER OF

MOTORS

POWER

CONSUMPTION 1.

C.B. PUMP ROOM

10 5

3 4

135 KW

90 KW

2.

C.B. & Adm. Office

5 3

1 2

40.5 KW

27 KW 3.

Main Hospital

10 5

3 2

135 KW

45 KW 4.

Marshelling Yard

50

40

1 2

225 KW

360 KW 5.

Timber pond 40 5 900 KW

6.

HWH PUMP ROOM

20 5

2 1

180 KW

22.5 KW 7.

I Section Well water pump room

40

10

2 1

360 KW

45 KW 8. I Section Fresh

water pump room 40

20

1 1

180 KW

90 KW 9. MI – WH Pump

room

20 2 180 KW

10.

M 2 – WH pump room

20 2

2 1

180 KW

9 KW 11. Old tank pump

room 40

25

1 1

180 KW

112.5 KW

12.

ONB Yard pump room

5 2

1 1

22.5 KW

9 KW 13.

T/V quarters pump room

10 2 90 KW

14.

User complex pump room

5 2 45 KW

15.

Diabetic Hospital

10 5

1 1

45 KW

22.5 KW 16.

SCI

10 5

1 1

45 KW

22.5 KW 17.

Documentation office

10 5

1 1

45 KW

22.5 KW

TOTAL

858

50

3861 KW

ANNEXURE ‘IX’

OIL DOCK NEW PUMP HOUSE

Sl.No. Description of item Quantity Capacity

1. 3.3 KV 1 No. 500 HP

2. HT Motor 1 No. 500 HP

3. HT Motor 1 No. 400 HP

4. HT Motor 2 Nos. 350 HP

5. LT Motor 1 No. 30 HP

OLD PUMP HOUSE

6. LT Primary motor 1 No. 25 HP

7. LT Vacuum motor 1 No. 10 HP

BHARATHI DOCK – I

8. Marine Load Arm LT motor 2 Nos. 3.8 KW/ 5 HP

9. Foam motor LT Motor 1 No. 50 HP

10. Slope motor 2 Nos. 5 HP

11. Tower monitor 4 Nos. 0.5 HP

BHARATHI DOCK – III

12. Marine Load Arm LT motor 2 Nos. 7.5 KW /

13. Foam motor LT Motor 1 No. 50HP

14. Slope motor 2 Nos. 5 HP

15. Capstan motor 6 Nos. 10 HP

16. Capstan motor 4 Nos. 0.5 HP

ANNEXURE ‘X’

FLOATING CRAFTS PILOT LAUNCHES & MOORING LAUNCHES

Sl.No. Description of Item Engine details

1. Pilot launch ‘Muthu’ MWM Engine – 2 Nos. TD 232 V8 BHP 232 RPM 2100

2. Pilot launch ‘ Progress’ MWM Engine – 2 Nos. TD 232 V8 BHP 232 RPM 2100

3. Pilot launch ‘Utility’ Ashok leyland – 2 Nos. ALMU 680/1 & ACMO 680/7 BHP 140 & BHP 172 RPM 1500 & 2000

4. Mooring Launch ‘Vettri’ Ashok leyland – 1 No. ALM 680 BHP 127 RPM 2000

5. Mooring Launch ‘Veeram’ MWM Engine – 1 No. TD 232 V6 BHP 152 RPM 2100

6. Mooring Launch ‘Vignesh’ MWM Engine – 1 No. TD 232 V6 BHP 152 RPM 2100

7. Mooring Launch ‘Velan’ MWM Engine – 1 No. TD 232 V6 BHP 152 RPM 2100

8. Nethaji Bergen Diesel – 2 Nos. KRM 8 BHP 1700 RPM 750

9. Singaravelu Bergen Diesel – 2 Nos. KRM 8 BHP 1700 RPM 750

10. Bharathiar Caterpillar – 2 Nos.

Model 3606 TA BHP 2481 RPM 1000

11. Sundaranar Yanmar Engine 8N21A –EN- 2 Nos. BHP 1324 RPM 900

12. Sekkizhar Yanmar Engine 8N21A –EN- 2 Nos. BHP 1324 RPM 900

ANNEXURE ‘XI’ EME – I WORK SHOP

Sl.No. Location Description of Items Quantity Capacity

1. ICE /BTC Air compressor 1 No. 7.5 KW

2. Machine Shop Lathe/ crank/drilling /grinding machine

20 Nos. 5 HP

3. Transport Shop Air compressor

3 Nos. 5 HP

4. Transport Shop Tier machine

2 Nos. 1.5 KW

5. Carpentry Shop Grinder/lathe/wood

4 Nos. 5 HP

6. Diesel Loco Welding generator

1 No.

7. Diesel Loco Travel motor

1 No. 20 HP

8. Diesel Loco Jack motor

4 Nos. 3HP

9. Diesel Loco Grinder

1 No. 1 HP

10. Diesel Loco Drilling machine

1 No. 0.5 HP

11. Diesel Loco Oven 1 No. 10 KW

12. Diesel Loco Air compressor 1 No. 5 HP

ANNEXURE ‘XII’ SE MARINE Sl.No. Description of work

Quantity Capacity

MRS & J.ZONE 1. Beeco lathe 1 No. 30 KW

2. E.O.T. crane 1 No. 18 KW

3. HMT Drilling machine 1 No. 7.5 HP

4. HMT lathe 1 No. 10 HP

5. HMT lathe 1 No. 1.5 HP

6. HMT Slating machine 1 No. 4 HP

7. Bench Grinder 3 Nos. 4 HP

8. Air compressor 1 No. each 10 HP & 1.5 HP

9. Power cutting machine 1 No. 3 HP

10. Water cooler 1 No. 3 HP

11. 250 & 400 W HPSV lamp 42 Nos. 15 KW

12. Welding plant 1 No. 15 KW

13. Battery charger 2 Nos. 4 KW

14. Distilled water plant 1 No. 2 KW

15. Wall/ceiling and tube light 2 KW

PLATING SHOP

16. Plate cutting machine 2 Nos. 20 HP & 5 HP

17. Plate bending machine 1 No. 10 KW

18. Bench grinder 1 No. 2 HP

19. Air compressor 1 No. 2 HP

20. 250 W M.V. Lamps 16 Nos. 4 HP

21. Water cooler & wall mounting 5 HP

22. Ceiling fans / tube lamps 3 HP

23. Welding plant 4 Nos. 60 KW

WELDING PLANT

24. Welding plants 2 Nos. 30 KW

25. M.V.Lamps/water cooler / ce fan/tube lamps

6.7 KW

MAIN SLIP WAY

26. Motor 2 Nos. 60 HP

27. Motor 1 No. 30 HP

28. Motor 2 Nos. 1.5 HP


30. Lighting/fans 2 KW

MINI SLIP WAY

31. Capstain motor 1 No. each 30 HP & 10 HP


PAINTING SHOP

33. Air compressor 4 Nos. 3 HP

34. Exhaust fan & Water cooler 2 Nos. 15 KW

T.O.SHOP

35. Punching machine 3 Nos.

36. Ceiling fan/ tube lamps 1.6 KW

ANNEXURE ‘XIII’

DETAILS OF DIESEL EQUIPMENTS

SL. No

NAME OF THE DIESEL PLANT

CAPACITY NUMBERS

POWER

CONSUMPTION

1 ACE make Mobile Crane 10 Ton 3 Nos.

2 JCB Pay loader 1.7 m3 2 Nos.

3 TATA P&H Crane 75 Ton 1 No.

4 Sonalika Tractor 1 No.

5 Swaraj make FLT 3 Ton 10 Nos.

ANNEXURE - XIV DETAILS OF FLOATING CRAFTS

SL. No. Name of the vessel Main Engine Generator

Main Harbour

1.

Floating crane Thangam

Electrical Motor Cummins -2Nos Power-815kw RPM-1500 BHP-1180

Cummins-1No 4 Stroke 6 cyl.

RPM-1500 BHP-163

2.

V.I.P Launch Greaves-2Nos TBD 4U12

HP822 RPM 2200

Ruston3YWMK5 Greaves-1 No GABCA 002M Output-25 KVA RPM 1500

Greaves-1No GABCA 002M Output-25 KVA

RPM1500

3.

ORV ANNAM Leyland -1Nos ALMU 680/1

BHP 140 RPM 1800

KIRLOSKAR – 1No TV 2 SR II

Ashok Leyland ALU 680 – 1No.

4.

MPHV PRESTIGE

DAF – 2Nos. DKT 1180

OUTPUT-177kw RPM 1800

DAF – 1Nos. DH 825 AG


DAF – 1Nos. DH 825 AG


5.

SURVEY III (CISF LAUNCH)

Leyland -2Nos ALMU 680/M

BHP 156 RPM 1800

KIRLOSKAR TV2 POWER -10 3KW

BHP-14 RPM-1500

NIL

6.

SURVEY IV Leyland -2Nos ALMU 680/M

BHP 172 RPM 2000

Greaves 2YWMK5 BHP-23.8

RPM-

NIL

7.

POLICE LAUNCH E.L.STRACEY

MWM ENGINE-2Nos.

TD 232 V12 BHP 440

RPM 2300

KIRLOSKAR–1No TV2 SRII

NIL

8. THSD CAUVERY 2Nos. 1700 KW 1000RPM

2Nos. AC 210KW 1No. AC 210KW

9. DREDGER PRIDE Cummins – 2 Nos KTA 2300 M

BHP- 600 KW RPM – 1800

Cummins – 2 nos VTA – 1710

Power – 500 KVA RPM – 1500

N743 MG – 1 No. POWER – 11KVA

RPM - 1500

Cummins – 2 no VTA 1710

POWER – 500KVA RPM -1500

N743 MG – 1NO POWER-110 KVA

ANNEXURE XV

DETAILS OF DIESEL LOCO SHOP Sl.No. Description of Items Quantity Capacity

1. Loco machines 10 Nos. 700 HP

2. Loco machines 2 Nos. 1400 HP

3. Lorry/car/van 59 Nos.

ANNEXURE ‘XVI’ HIGH MAST TOWER DETAILS

Sl.No. LOCATION

CAPACITY TOTAL

1. WQ1 car park (wharf side)

18 X 400 W 7,200 W

2. WQ 1 car park (wharf side)

18 X 400 W 7,200 W

3. WQ 1 car park (wharf side)

18 X 400 W 7,200 W

4. Car park west

12 X 400 W 4,800 W

5. RLY track car park

18 X 400 W 7,200 W

6. RLY track car park

18 X 400 W 7,200 W

7. Centre berth fire service opposite

18 X 400 W 7,200 W

8. Centre berth road side

18 X 400 W 7,200 W

9. WQIII road side

12 X 400 W 4,800 W

10. Hydraulic power house SS

18 X 400 W 7,200 W

11. Opposite to central work shop

36 X 400 W 14,400 W

12. Central work shop near marine

20 X 400 W 4,000 W

13. SQ1 Yatch club

36 X 400 W 14,400 W

14. JD 1 entrance

36 X 400 W 14,400 W

15. Opposite to JD III passage

20 X 400 W 4,000 W

16. ‘A’ substation back side

20 X 400 W 4,000 W

17. ‘A’ substation opposite side

18 X 400 W 7,200 W

18. 8TH gate opposite

36 X 400 W 14,400 W

19. JD7 south wall

18 X 400 W 7,200 W

20. Gantry crane opposite

18 X 400 W 7,200 W

21. JD VI wharf side

18 X 400 W 7,200 W

22. JD IV wharf side

18 X 400 W 7,200 W

23. JD II wharf side

18 X 400 W 7,200 W

24. SQ II (Near IMC)

18 X 400 W 7,200 W

25. C substation 40 Mtrs. North

21 Nos. 12, 600 W

26. C substation 40 Mtrs. south

21 Nos. 12, 600 W

27. C substation opposite

18 X 400 W 7,200 W

28. E complex west

18 X 400 W 7,200 W

29. E.complex east new

36 X 400 W 14,400 W

30. O&B pay loader shop

18 X 400 W 7,200 W

31. S1 & S2 ware house

36 X 400 W 14,400 W

32. Radio road

18 X 400 W 7,200 W

33. Hazardous cargo near SE

20 X 400 W 4,000 W

34. Hazardous cargo – 20m

20 X 400 W 4,000 W

35. Power supply section

18 X 400 W 7,200 W

36. Marshalling yard SM bunk

18 X 400 W 7,200 W

37. Marshalling yard east 18 X 400 W 7,200 W 38. Marshalling yard as 18 X 400 W 7,200 W

shipping 39. Marshalling yard as

shipping

18 X 400 W 7,200 W

40. Marshalling yard back side

36 X 400 W 14,400 W

41. EME I civil office back side 20 M

20 X 400 W 4,000 W

42. 10 th gate opposite

36 X 400 W 14,400 W

43. EME I canteen

18 X 400 W 7,200 W

44. Balaji weigh bridge

36 X 400 W 14,400 W

45. H1 substation

20 X 400 W 4,000 W

46. New coal yard Rd

36 X 400 W 14,400 W

47. Blacky yard 20 M

20 X 400 W 4,000 W


36 X 400 W 14,400 W


36 X 400 W 14,400 W

50. WBM road south end

18 X 400 W 7,200 W

51. WBM road new

36 X 400 W 14,400 W

52. WBM ROAD

30 X 400 W 12,000 W

53. WBM ROAD

30 X 400 W 12,000 W

54. WBM ROAD New

36 X 400 W 14,400 W

55. WBM ROAD

20 X 400 W 4,000 W

56. WBM ROAD

20 X 400 W 4,000 W

57. WBM road north end

18 X 400 W 7,200 W

ANNEXURE ‘XVII’ STREET LIGHT POSTS IN CHENNAI PORT TRUST

1. HOD QUARTERS (1 TO 9) - 9 X 250W 2. PILLARKOIL STREET (10 TO 14) - 5 X 250W 3. SPRING HEAVEN ROAD (15 TO 33) - 19 X 250W 4. CWS BACK SIDE RD (OLD 7TH GATE) (34 TO 35) - 10 X 250 W 5. TIMBER POND ROAD (46 TO 49) - 4 X 250 W 6. 7TH GATE (50 TO 53) - 4 X 250 W 7. MAIN HOSPITAL (54 TO 56) - 3 X 250 W 8. JD SOUTH WALL ROAD (57 TO 66) - 8 X 250 W 9. JD VI WHARF (67 TO 70) - 4 X 250 W 10. FF ROAD CPT QTRS BACK SIDE (71TO 78) - 11 X 250 W 11. FF ROAD (ILL SECTION TO CB SS) (79 TO 84) - 6 X 250 W 12. FF ROAD (CIVIL OFF TO PUMP RM) (85 TO 90) - 6 X 250 W 13. NEWLY FORMED FF ROAD (91 TO 105) - 15 X 250 W 14. FF ROAD (BHEL PLOT TO AS SHIP) (106 TO 118)1- 13 X 1250 W 15. FF ROAD (AS SHIPPING TO SICAL) (119 TO 127) - 9 X 250 W 16. FF ROAD (ANDAMAN TIMB – DIA CUT RD) (128 – 129) – 2 X 250W 17. EME I CIVIL OFFICE (136 TO 137) - 2 X 250W

18. EME I OFFICE ROAD (138 TO 141) - 4 X 250W 19. NEW COAL YARD RD INS TO H SS ( 142 TO 156) - 15 X 250 W 20. NEW COAL YARD RD NORTH SIDE (157 TO 160) - 4 X 250 W 21. E COMPLEX ROAD (161 TO 170) - 9 X 250W 22. RADIO ROAD (171 TO 174) - 5 X 250 W 23. JD WEST RD (12 POSTS) - 43 X 250 W 24. S5 TO A SUBSTATION RD - 34 X 250 W 25. WQ WHARF SIDE - 48 X 250 W 26. SIGNAL STATION VIP ROAD - 13 X 250 W 27. B COY ROAD(MAIN GATE TO NORTH PIPE LINE) - 20 X 250 W 28. FF ROAD PERIPERAL WALL (HOD QTRS BACK) - 8 X 250 W 29. NEW COAL YARD RD ALU TOWER – 2Nos. - 16 x 250 W

MEE/ GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY ... GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY OFFER...

Documents

Transcript of MEE/ GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY ... GC2 / 05 / 2013 / Dy.CME(ES&CH) BUDGETARY OFFER...