L’évaluation de l’Entente 2001-2004 entre le MCC et les CRC 19 mai 2005 Colloque SQEP
Living Safely Powerpoint template 1 - internal audience - Group · • A SQEP (suitably qualified...
Transcript of Living Safely Powerpoint template 1 - internal audience - Group · • A SQEP (suitably qualified...
www.fultonhogan.com
Asbestos Awareness
www.fultonhogan.com
Learning Objectives
• What is asbestos and where is it found?
• How to recognise potential asbestos or ACM’s
• Effects on your health
• How to keep yourself safe
• What asbestos work can I do?
• Fulton Hogan asbestos permits and procedures
www.fultonhogan.com
What is asbestos?
www.fultonhogan.com
State of asbestos
• Friable, in relation to asbestos or ACM, means in a
powder form or able to be crumbled, pulverised, or
reduced to a powder by hand pressure when dry
• Non-Friable, in relation to asbestos or ACM, means
not friable. Includes asbestos material reinforced with
a bonding compound eg. Asbestos cement sheeting
• Friable asbestos is inherently more dangerous
www.fultonhogan.com
Where is it found?
www.fultonhogan.com
How to recognise potential
asbestos
An easy way to identify potential asbestos is to recognise
common asbestos containing materials (ACM’s) like:
• Cement pipe
• Cement sheet both flat and corrugate (super six)
• Millboard & low density/ insulating board
• Vinyl floor backing material (asbestos paper)
• Gaskets and rope seals
• Lagging around pipes
• Sprayed on insulation
• Bitumen linings and membranes (e.g. malthoid)
www.fultonhogan.com
Asbestos cement pipe
www.fultonhogan.com
Asbestos cement sheet
www.fultonhogan.com
Asbestos LD/ insulation board
www.fultonhogan.com
Asbestos gaskets & seals
More Chinese trains to be bought
despite asbestos headache
2:15 pm on 8 July 2016
KiwiRail has confirmed it will buy
another 15 Chinese locomotives,
despite reliability problems and
asbestos contamination in the
engines it already has.
KiwiRail has spent at least $12
million clearing the material from
the engines, and documents show
that 24 - at least half of them - that
had been given the all-clear still
contain asbestos.
www.fultonhogan.com
Asbestos pipe lagging
www.fultonhogan.com
How to identify asbestos/ACM’s
• The only way to positively identify the presence of
asbestos is to have a sample analysed by an
approved laboratory (IANZ accredited)
• If you suspect asbestos, treat it as asbestos
www.fultonhogan.com
Effect on your health
• Breathing in airborne asbestos fibres is a serious risk
to health. Once the fibres are breathed in, they lodge
in the lungs and may cause diseases like asbestosis,
lung cancer and mesothelioma
• Most asbestos-related diseases take around 20 years
before their symptoms start to show
• Risks increase when: People inhale more fibres
Exposure is more frequent
Exposure over long duration
You’re a smoker
www.fultonhogan.com
The Adam Sager Story
www.fultonhogan.com
How to keep yourself safe
Before starting a job – ask if there’s any asbestos and
review the Asbestos Management Plan (AMP) for the site
or building.
• If there’s no AMP in place but asbestos is present or if
you are unsure – STOP and talk with your SQTE
• Always plan the work to avoid disturbing asbestos
An Asbestos Management Plan must be in writing and:
• Tell you the location and condition of any asbestos
that has been identified on-site and describe how the
asbestos will be managed (controls)
www.fultonhogan.com
How to keep yourself safe
During the job - if you uncover or damage materials
that may contain asbestos
• Stop work immediately
• Warn people and keep them away
• Minimise the risk of spreading contamination to other
areas (close off the area, don’t remove anything)
• Get advice (contact your SQTE or manager)
• Do not attempt to clean it up without controls or help
www.fultonhogan.com
How to keep yourself safe
During the Job
• Always keep an eye out for suspect looking material
• If it looks like asbestos treat it as asbestos until
confirmed otherwise
• Always read and follow the management plan in place
• Read and follow the applicable procedure, guideline or
permit associated with the work
www.fultonhogan.com
How to keep yourself safe
If you must handle asbestos – remember
• Do not dry cut asbestos- ever!
• Use water suppression and sealants like PVA
• Collect and double bag any debris and run off
• Minimise breakage and damage
• Do not use power tools, unless used in a way that
suppresses airborne asbestos
• Always decontaminate yourself and anything else that
leaves an asbestos work area
• Wear and maintain your PPE and RPE
www.fultonhogan.com
Asbestos in soils
• Soils that are contaminated with asbestos must be
managed through an asbestos management plan or a
remedial action plan
• If you suspect that soil on a site may be contaminated
with asbestos, stop work and talk to your SQTE or
manager
• A SQEP (suitably qualified and experienced
practitioner). Is required for identifying and managing
asbestos contaminated soils
www.fultonhogan.com
HowTo Asbestos
• Video of HowTo – removal of contaminated asbestos
soil - Auckland
www.fultonhogan.com
What asbestos work can I do?
Where our work involves asbestos, it is either:
Asbestos removal work or Asbestos related work
• If the work involves the removal of asbestos, that work
is asbestos removal work. The quantity and type of
asbestos determines whether a licence is required
• If the work involves asbestos but is not removal work,
this will be asbestos related work
E.g. transport and disposal of asbestos waste, demolition
work, maintenance and servicing work, work with low level
contaminated soils, work with naturally occurring asbestos
www.fultonhogan.com
What asbestos work can I do?
You can only carry out asbestos related work or
unlicensed asbestos removal work if you have
received this or other equivalent asbestos awareness
training and:
• You have been trained in how to safely use
everything you need to work with including PPE/RPE
• You must be knowledgeable about and
experienced with asbestos and other work risks or
be supervised by someone with that knowledge and
experience
www.fultonhogan.com
What asbestos work can I do?
You cannot carry out licenced asbestos removal work
unless you hold the relevant unit standard:
• Unit standard 29766 to undertake class A work
• Unit standard 29765 to undertake class B work
And;
• You must be working under a current Asbestos
Removal licence
www.fultonhogan.com
What asbestos work can I do?
www.fultonhogan.com
Procedures
The following Fulton Hogan documentation is available on the
Hub to guide safe work with asbestos:
• Asbestos Guideline
• Class B and Unlicensed Asbestos Removal Procedure
• Working with Asbestos Cement Pipes Procedure
• Working with Asbestos Contaminated Soil Procedure
www.fultonhogan.com
Permits
The following Fulton Hogan permits are applicable to work
involving asbestos:
• Class B Asbestos Removal Work Permit
• Unlicensed Asbestos Removal Work Permit
• Asbestos Related Work Permit
If in doubt remember that ALL work involving asbestos
requires a permit!
www.fultonhogan.com
Personal Protective Equipment
• Play video or demonstrate how to wear the correct
PPE and RPE including how to remove and dispose
of after use