IC-F510/F520/F521 Service manual...UT-105 SmarTrank2 Logic Board UT-108 DTMF decoder unit UT-109...

SERVICEMANUAL

VHF TRANSCEIVER

iF510

iF520

iF521

VERSION

Europe

General

U.S.A.

U.S.A.

General

SYMBOL

EUR

GEN

USA

USA

GEN

INTRODUCTION

This service manual describes the latest service informationfor the IC-F510, IC-F520 and IC-F521 VHF TRANSCEIVERSat the time of publication.

DANGER

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 16 V. This will ruin thetransceiver.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply whenconnecting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100 mW)to the antenna connector. This could damage the transceiv-er’s front end.

ORDERING PARTS

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>

1110003490 S.IC TA31136FN IC-F510 MAIN UNIT 5 pieces

8810009990 Screw PH BT M3×8 ZK IC-F520 Bottom cover 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

REPAIR NOTES

1. Make sure a problem is internal before disassembling thetransceiver.

2. DO NOT open the transceiver until the transceiver is disconnected from its power source.

3. DO NOT force any of the variable components. Turnthem slowly and smoothly.

4. DO NOT short any circuits or electronic parts. An insu-lated tuning tool MUST be used for all adjustments.

5. DO NOT keep power ON for a long time when the trans-ceiver is defective.

6. DO NOT transmit power into a signal generator or asweep generator.

7. ALWAYS connect a 50 dB to 60 dB attenuator betweenthe transceiver and a deviation meter or spectrum ana-lyzer when using such test equipment.

8. READ the instructions of test equipment thoroughlybefore connecting equipment to the transceiver.

MODEL

IC-F510

IC-F520

IC-F521

To upgrade quality, any electrical or mechanical parts andinternal circuits are subject to change without notice orobligation.

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEW

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION

4 - 1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 1

4 - 2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 2

4 - 3 PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 3

4 - 4 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4

4 - 5 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4

SECTION 5 ADJUSTMENT PROCEDURES

5 - 1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 1

5 - 2 PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3

5 - 3 SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 4

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS

9 - 1 FRONT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 1

9 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 3

SECTION 10 BLOCK DIAGRAM

SECTION 11 VOLTAGE DIAGRAMS

11 - 1 FRONT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 1

11 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 2

EXPLICIT DEFINITIONS

136 – 174 MHz

FREQUENCY COVERAGE

12.5 kHz / 25.0 kHz

15.0 kHz / 30.0 kHz

12.5 kHz / 20.0 kHz

Narrow/Wide-type

Narrow/Middle-type

CHANNEL SPACING

1 - 1


All stated specifications are subject to change without notice or obligation.

Measurement method

Frequency coverage

Type of emission

Number of conventional channels

Power supply voltage (negative ground)

Current drain (approx.)

Frequency error

Usable temperature range

Dimensions (proj. not included)

Weight

RF output power

Modulation system

Maximum permissible deviation

Spurious emissions

Adjacent channel power

Audio frequency response

Audio hormonic distortion

FM hum and noise (typical)(without CCICT filter)

Residual modulation (typical)(with CCICT filter)

Limitting charact of modulator

Microphone connector

Receive system

Intermediate frequencies

Sensitivity (typical)

Squelch sencitivity (at threshold) (typical)

Adjcent channel selectivity (typical)

Spurious response

Intermoduration (typical)

Hum and noise (without CCITT filter)

(typical) (with CCITT filter)

Audio output power

External SP connector

USA/GEN EUR

RE

CE

IVE

RT

RA

NS

MIT

TE

RG

EN

ER

AL

EIA-152-C/204D or TIA-603 ETS 300 086

136.000–174.000 MHz

N/W (15 kHz; Narrow/30 kHz; Wide): 8K50F3E/16K0F3E [USA],N/W (12.5 kHz; Narrow/25 kHz; Wide): 8K50F3E/16K0F3E [EUR]/[GEN],N/M (12.5 kHz; Narrow/20 kHz; Middle): 8K50F3E/14K0F3E [EUR]

Max. 256 ch (16 channels × 16 banks)

13.6 V DC nominal 13.2 V DC nominal

TX (at 25 W) 7.0 A [25W], (at 50 W) 13.0 A [50W]Rx (max. audio) 1200 mA

(stand-by) 300 mA

5.0 ppm ±1.5 kHz

–30˚C to +60˚C (–22˚F to +140˚F) –25˚C to +55˚C (–13˚F to +131˚F)

140(W) × 40(H) × 170(D) mm; 51⁄2(W) × 19⁄16(H) × 611⁄16(D) inch

1.2 kg; 2 lb 10 oz

High/Low2/Low1: 25 W/10 W/2.5 W [25W], 50 W/25 W/5 W [50W]

Variable reactance frequency modulation

±2.5 kHz [Narrow], ±4.0 kHz [Middle], ±5.0 kHz [Wide]

70 dBc typical 0.25 µW ≤ 1GHz, 1.0 µW > 1 GHz

60 dB [Narrow], 70 dB [Middle]/[Wide]

+2 dB to –5 dB of 6 dB/octarverange from 300 Hz to 2550 Hz [Narrow]/3000 Hz [Middle]/[Wide]

3% typical at 1 kHz, 40% deviation

40 dB [Narrow], 46 dB [Wide] ——

——50 dB [Narrow], 53 dB [Middle],55 dB [Wide]

70–100% of max. deviation

8-pin modular (600 Ω)

Double-conversion superheterodyne system

1st: 46.35 MHz, 2nd: 450 kHz

0.25 µV at 12 dB SINAD –4 dBµV (emf) at 20 dB SINAD

0.25 µV –4 dBµV (emf)


75 dB

74 dB 67 dB


—— 50 dB [Narrow], 53 dB [Middle], 55 dB [Wide]

4 W typical at 10% distortion with a 4 Ω load

2-conductor 3.5 (d) mm (1⁄8")/4 Ω


2 - 1

Power module

8V regurator(IC9: TA7808F)

AF amplifier(IC8: LA4425A)

CPU 5V regurator*(IC10: AN78L05M)

VCO circuit

CPU*(IC20: HD64F2268TF)

Antenna switch/Low-pass filter circuits

1st mixer*(Q3: 3SK272)

2nd IF filter(FI2: ALFYM450F=K [N/W]

CFWLB450KGFA-B0 [N/M])

FM IF IC(IC1: TA31136FN)

D/A converter(IC6: M62364FP)

Referance crystal osillator(X2: CR-664A 15.3 MHz)

PLL IC(IC4: TB31256FL)

*Located under side of the point.

1st IF filter (FI1: FL-335 46.35 MHz)

IC3: RA30H1317 [25W]RA60H1317M [50W]


3 - 1

• Opening case➀ Unscrew 4 screws A, and remove the bottom cover.➁ Disconnect the flat cable B from J2.➂ Unscrew 2 screws c, and remove the front unit.

A

B

C

J2

➃ Unsolder 3 points D from the antenna connector.➄ Remove the clip E.➅ Disconnect the cable F from J5.➆ Unscrew 11 screws G.

G

FE

J5

D

➇ Lift up the front portion of the main unit and remove it.

• Instllation locationUT-105 SmarTrank2 Logic BoardUT-108 DTMF decoder unitUT-109

Voice scrambler unitUT-110UT-111 Trunking unit

UT-105UT-108UT-109UT-110UT-111

J1


4 - 1

4-1 RECEIVER CIRCUITS4-1-1 ANTENNA SWITCHING CIRCUIT (MAIN unit)The antenna switching circuit functions as a low-pass filterwhile receiving and as resonator circuit while transmitting.The circuit does not allow transmit signals to enter receivercircuits.

Received signals enter the antenna connector and passthrough the low-pass filter (L1–L3, C1, C2, C6–8). The fil-tered signals are then applied to the RF circuit passedthrough the λ⁄4 type antenna switching circuit (D5, D6, L6).

4-1-2 RF CIRCUIT (MAIN unit)The RF circuit amplifies signals within the range of frequen-cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit pass throughthe two-stage tunable bandpass filters (D8, D4). The filteredsignals are amplified at the RF amplifier (Q2) and then enterother two-stage bandpass filters (D9, D10) to suppressunwanted signals. The filtered signals are applied to the 1stmixer circuit (Q3).

The tunable bandpass filters (D4, D8–D10) employ varactordiodes to tune the center frequency of the RF passband forwide bandwidth receiving and good image response rejec-tion. These diodes are controlled by the CPU (IC20) via theD/A converter (IC7).

The gate control circuit reduces RF amplifier gain and atten-uates RF signal to keep the audio output at a constant level.

The receiver gain is determined by the voltage on the “RSSI”line from the FM IF IC (IC1, pin 12). The gate control circuitsupplies control voltage to the RF amplifier (Q2) and setsthe receiver gain.

When receiving strong signals, the “RSSI” voltage increasesand the gate control voltage decreases. As the gate controlvoltage is used for the bias voltage of the RF amplifier (Q2),then the RF amplifier gain is decreased.

4-1-3 1ST MIXER AND 1ST IF CIRCUITS(MAIN unit)

The 1st mixer circuit converts the received signals to a fixedfrequency of the 1st IF signal with the PLL output frequency.By changing the PLL frequency, only the desired frequencywill pass through a MCF (Monolithic Crystal Filter; FI1) at thenext stage of the 1st mixer.

The RF signals from the bandpass filter are applied to the1st mixer circuit (Q3). The applied signals are mixed with the1st LO signal coming from the RX VCO circuit (Q13) to pro-duce a 46.35 MHz 1st IF signal. The 1st IF signal passesthrough a MCF (Monolithic Crystal Filter; FI1) to suppressout-of-band signals. The filtered signal is amplified at the 1stIF amplifier (Q4) and applied to the 2nd IF circuit.

4-1-4 2ND IF AND DEMODULATOR CIRCUITS(MAIN unit)

The 2nd mixer circuit converts the 1st IF signal to a 2nd IFsignal. A double-conversion superheterodyne systemimproves the image rejection ratio and obtains stable receiv-er gain.

The 1st IF signal from the 1st IF amplifier (Q4) is applied tothe 2nd mixer section of the FM IF IC (IC1, pin 16) and isthen mixed with the 2nd LO signal for conversion to a 450kHz 2nd IF signal.

IC1 contains the 2nd mixer, limiter amplifier, quadraturedetector, active filter and noise amplifier circuits, etc. Atripled frequency from the PLL reference oscillator is usedfor the 2nd LO signal (45.9 MHz).

The 2nd IF signal from the 2nd mixer (IC1, pin 3) passesthrough a ceramic filter (FI2) to remove unwanted hetero-dyned frequencies. It is then amplified at the limiter amplifi-er section (IC1, pin 5) and applied to the quadrature detec-tor section (IC1, pins 10, 11 and X1) to demodulate the 2ndIF signal into AF signals.

The AF signals are output from pin 9 (IC1) and are thenapplied to the AF amplifier circuit.

• 2nd IF and demodulator circuits

FI2

2nd IF filter450 kHz

Noise detector

Q34

Limiteramp.

FM detector

Activefilter

AF signals

5VX1 Discriminator

IC6

RSSIMixer

X215.3 MHz

45.9 MHz

1st IF from the IF amplifier (Q4)

NOIS signal to the CPU (IC20)

8

24

23

7 5

BPF

3 2

3

161311109

IC1TA31136FN

4 - 2

4-1-5 AF AMPLIFIER CIRCUIT (MAIN unit)The AF amplifier circuit amplifies the demodulated AF sig-nals to drive a speaker.

The AF signals from the FM IF IC (IC1, pin 9) are amplifiedat the AF amplifier section of the compander IC (IC14, pins5, 4) and are then applied to the high-pass filter circuit(IC21b).

The high-pass filter characteristics are controlled by theFSW signal from the LCD driver IC (FRONT unit; IC1, pin 6).When FSW signal is high, the cut-off frequency is shiftedhigher to remove CTCSS or DTCS signals.

The filtered AF signals from the high-pass filter (IC21b,pin 7) are applied to the de-emphasis section of companderIC (IC14, pin 3) with frequency characteristics of –6dB/octave, and are then passed through the low-pass filter,high-pass filter, expander sections of compander IC (IC14).The output signal from IC14 (pin 38) is applied to the elec-tronic volume controller (IC6, pin 1).

The output AF signals from the electronic volume controller(IC6, pin 2) are applied to the AF amplifier (IC18) and AFpower amplifier (IC8) to drive the speaker.

4-1-6 RECEIVER MUTE CIRCUITS (MAIN unit)• NOISE SQUELCHThe noise squelch circuit cuts out AF signals when no RFsignals are received. By detecting noise components in theAF signals, the squelch circuit switches the AF mute switch.

Some noise components in the AF signals from the FM IF IC(IC1, pin 9) are passed through the level controller (IC6, pins24, 23). The level controlled signals are applied to the activefilter section in the FM IF IC (IC1, pin 8). Noise componentsabout 10 kHz are amplified and output from pin 7.

The filtered signals are converted into the pulse-type signalsat the noise detector section and output from pin 13 (NOIS).

The NOIS signal from the FM IF IC is applied to the CPU(IC20, pin 37). The CPU then analyzes the noise conditionand controls the AF mute signal via “AFON” line (IC20, pin18) to the AF regulator (Q39, Q40, D31).

• CTCSS AND DTCSThe tone squelch circuit detects AF signals and opens thesquelch only when receiving a signal containing a matchingsubaudible tone (CTCSS or DTCS). When tone squelch is inuse, and a signal with a mismatched or no subaudible toneis received, the tone squelch circuit mutes the AF signalseven when noise squelch is open.

A portion of the AF signals from the FM IF IC (IC1, pin 9)passes through the low-pass filter (IC5) to remove AF(voice) signals and is applied to the CTCSS or DTCSdecoder inside the CPU (IC20, pin 46) via the “CDEC” lineto control the AF mute switch.

4-2 TRANSMITTER CIRCUIT4-2-1 MICROPHONE AMPLIFIER CIRCUIT

(MAIN unit)The microphone amplifier circuit amplifies audio signalswithin +6 dB/octave pre-emphasis characteristics from themicrophone to a level needed for the modulation circuit.

The AF signals (MIC) from the FRONT unit via J2 (pin 1) arepassed through the level controller (IC6, pins 9, 10) to themicrophone amplifier circuit.

The AF signals from the level controller (IC6) are applied tothe microphone amplifier section of compander IC (IC14, pin12). The amplified signals are passed through the compres-sor, low-pass filter and high-pass filter sections of IC14.

The filtered AF signals are amplified at the buffer amplifier(Q21) and pre-emphasized with +6dB/octave at the pre-emphasis circuit (R122, C187), and are then applied to theIDC amplifier section of IC14 (pin 8).

The amplified AF signals are passed through the limitteramplifier, low-pass filter and smoothing filter sections ofIC14 after being passed through the AF mute switch insideof IC14.

The output signals from pin 6 are passed through the ana-log switch (IC15), splatter filter (IC21d) and applied to thelevel controller (IC6, pins 21, 22). The deviation level con-trolled signals are then applied to modulation circuit as the“MOD” signal.

The narrow/wide switch (Q22) is connected to the input ofthe splatter filter (IC21d) and switched by the “NWC” signalcoming from the CPU (IC20, pin 19). When “NWC” is at ahigh level, the narrow/wide switch (Q22) shifts the filter cut-off frequency for narrow deviation selection.

4-2-2 MODULATION CIRCUITThe modulation circuit modulates the VCO oscillating signal(RF signal) using the microphone audio signals.

The AF signals from the level controller (IC6, pin 22) changethe reactance of varactor diode (D18) to modulate the oscil-lated signal at the TX VCO circuit (Q14, D17, D53–D55).The modulated VCO signal is amplified at the buffer ampli-fiers (Q11, Q10) and is then applied to the drive amplifier cir-cuit via the T/R switch (D14).

The CTCSS/DTCS signals from the CPU (IC20, pins 89–91)are passed through the low-pass filter (Q37), level controller(IC6, pins 12, 11) and mixer (IC21a), and are then applied tothe VCO circuit via the splatter filter (IC21d).

4-2-3 DRIVE AMPLIFIER CIRCUIT (MAIN unit)The drive amplifier circuit amplifies the VCO oscillating sig-nal to the level needed at the power amplifier.

The RF signal from the buffer amplifier (Q10) passesthrough the T/R switch (D14) and is amplified at the YGR(Q9) and pre-drive (Q8) amplifiers. The amplified signal isapplied to the power amplifier circuit.

4 - 3

4-2-4 POWER AMPLIFIER CIRCUIT (MAIN unit)The power amplifier circuit amplifies the driver signal to anoutput power level.

The RF signal from the pre-drive amplifier (Q8) is applied tothe power module (IC3) to obtain 25 W for IC-F510/F520, or50 W for IC-F521 of RF power.

The amplified signal is passed through the antenna switch-ing circuit (D2), low-pass filter and APC detector, and is thenapplied to the antenna connector.

Control voltage for the power amplifier (IC3, pin 3) comesfrom the APC amplifier (IC2) to stabilize the output power.The transmit mute switch (D32) controls the APC amplifierwhen transmit mute is necessary.

4-2-5 APC CIRCUIT (MAIN unit)The APC circuit protects the power amplifier from a mis-matched output load and stabilizes the output power.

The APC detector circuit detects forward signals and reflec-tion signals at D11 and D1 respectively. The combined volt-age is at minimum level when the antenna impedance ismatched at 50 Ω, and is increased when it is mismatched.

The detected voltage is applied to the APC amplifier (IC2,pin 3), and the power setting “T4” signal from the D/A con-verter (IC7, pin 4), controlled by the CPU (IC20), is appliedto the other input for reference. When antenna impedance ismismatched, the detected voltage exceeds the power set-ting voltage. Then the output voltage of the APC amplifier(IC2, pin 4) controls the input current of the power module(IC3) to reduce the output power.

4-3 PLL CIRCUITS4-3-1 PLL CIRCUITA PLL circuit provides stable oscillation of the transmit fre-quency and receive 1st LO frequency. The PLL output com-pares the phase of the divided VCO frequency to the refer-ence frequency. The PLL output frequency is controlled bythe divided ratio (N-data) of a programable divider.

The PLL circuit contains the TX/RX VCO circuit (Q14, Q13).The oscillated signal is amplified at the buffer amplifiers(Q11, Q12) and then applied to the PLL IC (IC4, pin 17) viathe low-pass filter (L32, C298, C299, C509).

The PLL IC contains a prescaler, programable counter, pro-gramable divider and phase detector, etc. The entered sig-nal is divided at the prescaler and programable counter sec-tion by the N-data ratio from the CPU. The reference signalis generated at the reference oscillator (X2) and is alsoapplied to the PLL IC. The PLL IC detects the out-of-stepphase using the reference frequency, and outputs it frompin 13. The output signal is passed through the chargepump (Q50, Q51, Q54, Q55) and active loop filter (Q52,Q53), and is then applied to the VCO circuit as the lock volt-age.

If the oscillated signal drifts, its phase changes from that ofthe reference frequency, causing a lock voltage change tocompensate for the drift in the oscillated frequency.

4-3-2 VCO CIRCUITThe VCO circuit contains a separate RX VCO (Q13, D16,D50–D52) and TX VCO (Q14, D17, D18, D53–D55). Theoscillated signal is amplified at the buffer amplifiers (Q11,Q10) and is then applied to the T/R switch circuit (D14,D15). Then the receive 1st LO (Rx) signal is applied to the1st mixer (Q3) and the transmit (Tx) signal to the YGRamplifier circuit (Q9).

A portion of the signal from the buffer amplifier (Q11) is fedback to the PLL IC (IC4, pin 17) via the buffer amplifier (Q12)and low-pass filter (L32, C298, C299, C509) as the compar-ison signal.

• PLL circuit

Controller×3

16/17Phasedetector

Loopfilter

Chargepump LPF

PLL2

32/33Phasedetector

PLL1X215.3 MHz

45.9 MHz signalto the FM IF IC 10

Q13, D16, D50–D52

RX VCO

TX VCO

Buffer

Buffer

BufferQ10

Q12

Q11

Q34202122

SCK

19 FSW2

IC4 (PLL IC)

SOPLST

to transmitter circuit

to 1st mixer circuit

D15

D14

13 17

Q14, D17, D18, D53–D55

4 - 4

4-4 POWER SUPPLY CIRCUITS4-4-1 VOLTAGE LINES (MAIN unit)

4-5 PORT ALLOCATIONS4-5-1 OUTPUT EXPANDER (FRONT unit; IC1)

4-5-2 OUTPUT EXPANDER (MAIN unit; IC7)

4-5-3 CPU (MAIN unit; IC20)Description

The voltage from a DC power supply.

The same voltage as the HV line which is con-trolled by the power switching circuit (Q23, Q24).When the [POWER] switch is pushed, the CPUoutputs the “PWON” control signal to the powerswitching circuit to turn the circuit ON.

Common 5 V for the CPU converted from the HVline by the CPU5V regulator circuit (IC10). Thecircuit outputs the voltage regardless of thepower ON/OFF condition.

Common 8 V converted from the VCC line by the8V regulator circuit (IC9).

Common 5 V converted from the VCC line by the5V regulator circuit (Q27, Q28).

Receive 8 V controlled by the R8 regulator circuit(Q26, Q30, D24) using the “TXC” signal from theCPU (IC20, pin 16).

Transmit 8 V controlled by the T8 regulator circuit(Q25, Q29, D23) using the “TMUT” signal fromthe CPU (IC20, pin 17).

Line

HV

VCC

CPU5V

8V

5V

R8V

T8V

I/O port for data signals from/to the D/Aconverter (IC7).

Outputs strobe signals for the levelcontroller (or D/A converter) (IC6).

Output ports for LCD control signals tothe LCD driver (FRONT unit; IC1)

Outputs clock signal for the LCD driver(FRONT unit; IC1)

Outputs data signals for the LCD driver(FRONT unit; IC1)

Outputs strobe signals for the PLL IC(IC4).

Outputs control signal for the PLL IC(IC4).

Outputs R8 regulator circuit (Q26, Q30,D24) control signal.

Outputs T8 regulator circuit (Q25, Q29,D23) control signal.

Outputs control signal for the AF regu-lator circuit (Q39, Q40, D31).High : While AF amplifier (IC8) is acti-

vated.

Outputs IF bandwidth control signal.High : While IF bandwidth is narrow.

Input port for the data signals from theDTMF decoder (IC19).

Outputs clock signal to the DTMFdecoder (IC19).

Outputs data signals to the PLL IC(IC4), level controller (or D/A converter)(IC6), compander IC (IC14) and option-al board (connect to J1).

Input port for the clock signal from theoptional board via J1.

Outputs clock signal to the PLL IC(IC4), level controller (or D/A converter)(IC6), D/A converter (IC7), companderIC (IC14) and optional board (connectto J1).

Outputs chip select signal for theoptional board via J1.

Input ports for the key matrix.

Input port for the PTT switch from theoptional board via J1.Low : External PTT switch is ON.

Input port for the microphone hangerdetection signal.Low : Microphone on hook

Outputs BUSY detection signal for theoptional board via J1.

1

2

8,9

10

11

13

15

16

17

18

19

20

21

22

23

24

25

26–28

29

30

31

DSDA

DAST

LINH, LCS

LCK

LSO

PLST

FSW2

TXC

TMUT

AFON

NWC

DDSD

DDAC

SO

SI

SCK

CCS

KR2–KR0

PTTO

HANG

BUSY

Pin PortDescriptionnumber name

Output tunable band pass filter controlsignals.

Output port fortunable band pass filter control signalwhile receiving.output power control signal whiletransmitting.

1–3

4

T1–T3

T4


Output ports for key matrix.

Outputs LCD backlight control signal.Low : While LCD backlight is dim.

Outputs LCD backlight control signal.Low : While LCD backlight is OFF.

Outputs high-pass filter’s characteris-tics select signal.

Outputs external device control signal.High : When matched 2/5-tone signals

are received.

Output ports for LCD control signal.

1–3

4

5

6

7

12–55

KS0–KS2

DIM1

DIM2

FSW

HORN

SEG1–SEG40,COM1–COM4


4 - 5

CPU (IC20)—continued CPU (IC20)—continued

Input port for AF mute signal from theoptional board via J1.

Input port for MIC mute signal from theoptional board via J1.

I/O ports for the optional board controlsignals.

NOIS signal input port from the FM IFIC (MAIN unit; IC1) for noise squelchoperation.

Input for the POWER switch.Low : While POWER switch is pushed.

Input port for DTMF detection signalfrom the DTMF decoder (IC19).

Remote power control signal input portfrom the external connector (J8).

Outputs control signal for the powerswitching circuit (Q24, Q23) via D28.

Outputs single tone signal.

Outputs beep audio signals.

Single tone signal input port for decod-ing from the LPF (IC21c).

CTCSS/DTCS signals input port fordecoding from the LPF (IC5).

Input port for the PLL unlock signalfrom the PLL IC (IC4).

Input port for the overvoltage detectionfrom the connected power supply.

Input port for the PLL lock voltage.

Input port for receiving signal strengthlevel detection.

Input port for the transceiver’s internaltemperature.

Input port for the AF volume control(FRONT unit; R12).High : [VOL] is maximum clockwise.

Input port for the PTT switch from theexternal connector (J6).Low : External PTT switch is ON.

Input port for the reset signal.

Output port for the cloning signal.

Input port for the cloning signal.

Outputs CPU clock shift signal.

Outputs cut-off frequency control signalto the low-pass filter (IC5) forCTCSS/DTCS switching.

Input port for the connected modemunit via external connector (J9).

32

33

34–36

37

38

39

40

41

43

44

45

46

47

48

49

50

51

52

55

59

68

69

70

71

74

RMUT

MMUT

OPT1–OPT3

NOIS

POSW

DDST

IGSW

PWON

SENC

BEEP

SDEC

CDEC

ULCK

BATV

LVIN

RSSI

TEMP

AFVI

EPTT

RES

CLO

CLI

CSFT

DUSE

XCTS


Output port for the connected modemunit via external connector (J9).

Input port for serial data signals fromthe connected MAP27 unit via externalconnector (J9).

Outputs serial data signals for the con-nected MAP27 unit via external con-nector (J9).

Output serial data signals (data formatis in accordance with NMEA0183) forthe connected unit via external connec-tor (J8).

Input port for serial data signals (dataformat is in accordance withNMEA0183) from the connected unitvia external connector (J8).

Input port for interruption signal fromthe optional board via J1

Input port for the LCD backlight controlsignal from the external connector (J6).

Output ports for the CTCSS/ DTCS sig-nals.

Outputs reset signal for the companderIC (IC14).

Output control signals for the compan-der IC (IC14).

Outputs strobe signals to the compan-der IC (IC14).

Outputs control signal for the MSKPM/FM switching circuit (IC15).

I/O port for the data signals from theEEPROM (IC23).

Outputs clock signal for the EEPROM(IC23).

Outputs MIC audio select signal for theanalog switch (IC25).Low : While “Public-address” function

is ON.

75

76

77

79

80

81

88

89–91

92

94, 95

96

97

98

99

100

XRTS

XTXD

XRXD

NTXD

NRXD

CIRQ

DIM

CENC2–CENC0

AFCL

AMSK,ADIN

APST

PMFM

ESDA

ESCL

PA


5 - 1


+ Audio generator300 Hz to 3 kHz

ACmillivoltmeter

MICE

MIC

PTT

PTT switch

PTTE

Add a jumper wire here

• *OPC-1122 (JIG CABLE)

Electrolytic capacitor47 µF

OPC-1122(Cloning cable)

REQUIRED TEST EQUIPMENT

EQUIPMENT

DC power supply

RF power meter(terminated type)

Frequency counter

FM deviation meter

DC voltmeter

GRADE AND RANGE

Output voltage : 13.2 (13.6) V DCCurrent capacity : 20 A or more

Measuring range : 1–75 WFrequency range : 100–300 MHzImpedance : 50 ΩSWR : Less than 1.2 : 1

Frequency range : 0.1–300 MHzFrequency accuracy : ±1 ppm or betterSensitivity : 100 mV or better

Frequency range : DC–300 MHzMeasuring range : 0 to ±10 kHz

Input impedance : 50 kΩ/V DC or better

EQUIPMENT

Audio generator

Standard signal generator (SSG)

Oscilloscope

AC millivoltmeter

External speaker

Attenuator

GRADE AND RANGE

Frequency range : 300–3000 HzMeasuring range : 1–500 mV

Frequency range : 0.1–300 MHzOutput level : 0.1 µV–32 mV

(–127 to –17 dBm)

Frequency range : DC–20 MHzMeasuring range : 0.01–20 V

Measuring range : 10 mV–10 V

Input impedance : 4 ΩCapacity : 7 W or more

Power attenuation : 50 or 60 dBCapacity : 100 W or more

5-1 PREPARATIONWhen you adjust the contents on pages 5-4 and 5-5, SOFT-WARE ADJUSTMENT, the optional CS-F500 ADJ ADJUSTMENTSOFTWARE (Rev. 1.0 or later), *OPC-1122 JIG CABLE (modifiedOPC-1122 CLONING CABLE; see illustration below) are required.

SYSTEM REQUIREMENTS• IBM PC compatible computer with an RS -232C serial port

(38400 bps or faster)• Microsoft Windows 95/98 or Windows ME• Intel Pentium 100 MHz processor or faster• At least 16 MB RAM and 10 MB of hard disk space• 640×480 pixel display (800×600 pixel display recommended)

ADJUSTMENT SOFTWARE INSTALLATIONq Boot up Windows.

- Quit all applications when Windows is running.w Insert the ‘CS-F500’ into the appropriate CD-ROM drive.e Select ‘Run’ from the [Start] menu.r Type the setup program name using the full path name,

then push [Enter] key.(ex. D:\CSF500ADJ\disk1\Setup.exe)

t Follow the prompts.y Program group ‘CS-F500 ADJ’ appears in the ‘Programs’

folder of the [Start] menu.

STARTING SOFTWARE ADJUSTMENTq Connect IC-F510, F520 or F521 and PC with *OPC-1122

JIG CABLE.w Turn the transceiver power ON.e Boot up Windows, and click the program group ‘CS-F500

ADJ’ in the ‘Programs’ folder of the [Start] menu, thenCS-F500 ADJ’s window appears.

r Click ‘Connect’ on the CS-F500’s window, then appearsIC-F510, F520 or F521’s up-to-date condition.

t Set or modify adjustment data as desired.

IBM is a registered trademark of International BussinessMachines Corporation in the U.S.A. and other countries.Microsoft and Windows are registered trademarks ofMicrosoft Corporation in the U.S.A. and other countries.Screen shots produced with permission from MicrosoftCorporation. All other products or brands are registeredtrademarks or trademarks of their respective holders.

5 - 2

FM deviation meter(DC measurable)

Attenuator50 dB or 60 dB

to the MIC connector

to the antenna connector

to DC cable

to an RS-232C port

DB9 female plug

Personalcomputer

Standard signal generator–127 to –17 dBm(0.1 µV to 32 mV)

CAUTION:DO NOT transmit while SSG is connected to the antenna connector.

RF power meter50 Ω / 1–75 W

DC power supply13.2 (13.6) V / 20 A

Frequencycounter

RS-232C cable(straight)

*OPC-1122(JIG CABLE)

AC millivoltmeter

Audio generator

• Connections

CS-F500 ADJ Rev.1.0File

COM 1: OPEN

Option

Connect Reload (F5) Disp para

[A / D]VIN : 156 : 9Ch : 12.24 VTEMPS : 187 : BBh : 30.81 'CLVIN : 57 : 32h : 0.98 VSD : 36 : 24h : 0.71 V

Power (Hi) : 181 [ # # # # # # # # # # # # # # – – – – – – ]Power (L2) : 120 [ # # # # # # # # # – – – – – – – – – – – ]Power (L1) : 69 [ # # # # # – – – – – – – – – – – – – – – ]

Ballance : 54 [ # # # # – – – – – – – – – – – – – – – – ]MOD W : 157 [ # # # # # # # # # # # # – – – – – – – – ]MOD N : 83 [ # # # # # # # – – – – – – – – – – – – – ]

CTCS/DTCS : 67 [ # # # # # – – – – – – – – – – – – – – – ]SQL : 0 [ – – – – – – – – – – – – – – – – – – – – ]

BPF ALL : [Enter] to sweepBPF T1 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T2 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T3 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T4 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweep

TXF : [Enter] to startS-METER : [Enter] to start

[D / A]BPF T1 : 50 : 32h : 0.98 VBPF T2 : 50 : 32h : 0.98 VBPF T3 : 50 : 32h : 0.98 VT4/POW : 50 : 32h : 0.98 VREF : 45 : 2Dh : 0.88 VMOD BAL : 54 : 36h : 21.18 %Dev : 157 : 9Dh : 3.08 VCTCSS : 66 : 42h : 1.29 VSQL Lev : 0 : 00h : 0.00 %

CH No. : 01 RX Freq = 136.050, TX Freq = <– RF Power: High Mode: Wide

1

5

4

6

1011

12

15

9

14

16

3

2

8

7

13

: Transceiver's connection state: Reload adjustment data: Receive sensitivity measurement: Connected DC voltage

NOTE:

• Screen display exampe

1

2

3

4

9

10

: PLL lock voltage: Operating channel select: RF output power: Modulation balance

5

6

7

8

11

12

: FM deviation: CTCSS/DTCS deviation: Squelch level: Receive sensitivity (automatically)

13 : Receive sensitivity (manually): Reference frequency: S-meter: Adjustment items

14

15

16

The above values for settings are example only. Each transceiver has its own specific values for each setting.

LVPLL lock voltage check pointC134

PLL lock voltage adjustment for TX

C133PLL lock voltage adjustment for RX

DC power supply 13.2 (13.6) V / 20 A

5 - 3

5-2 PLL ADJUSTMENT

PLL LOCKVOLTAGE

1

2

3

4

• Operating freq. : 136.000 MHz• Receiving

• Output power : Low1• Transmitting

• Operating freq. : 174.000 MHz• Receiving


MAIN Connect a digital multi-meter or an oscillo-scope to the checkpoint, “LV”.

1.4 V

1.0 V

3.5–4.5 V

3.0–4.0 V

MAIN C133

C134

Verify

ADJUSTMENT ADJUSTMENT CONDITIONSUNIT LOCATION

VALUEUNIT ADJUST

MEASUREMENT ADJUSTMENT

5 - 4

5-3 SOFTWARE ADJUSTMENTSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

1

1

2

3

1

1

2

• Operating freq. : 174.000 MHz• Output power : Low1• Connect the RF power meter or 50 Ω

dummy load to the antenna connector.• Transmitting

• Operating freq. : 155.000 MHz• Output power : High• Transmitting



• Operating freq. : 155.000 MHz• Output power : Low1• Push [P0] key while transmitting

• Operating freq. : 155.000 MHz• Output power : Low1• IF bandwidth : Wide• Connect an audio generator to the [MIC]

jack through the JIG cable and set as:1.0 kHz/40 mVrms

• Set an FM deviation meter as:HPF : OFFLPF : 20 kHzDe-emphasis: OFFDetector : (P–P)/2

• Transmitting

• IF bandwidth : Narrow• Transmitting

• Operating freq. : 155.000 MHz• Output power : Low1• IF bandwidth : Wide• CTCSS : 88.5 Hz• DTCS code : 007• Set the FM deviation meter as:

HPF : OFFLPF : 20 kHzDe-emphasis: OFFDetector : (P–P)/2

• No audio applied to the [MIC] connector.• Transmitting

REFERENCEFREQUENCY[TXF]

OUTPUTPOWER[Power (Hi)]

[Power (L2)]

[Power (L1)]

MODULATIONBALLANCE[Ballance]

FMDEVIATION[MOD W]

[MOD N]

CTCSS/DTCSDEVIATON[CTCS/DTCS]

Rearpanel

Rearpanel

Rearpanel

Rearpanel

Rearpanel

Loosely couple a frequnecycounter to the antenna connec-tor.

Connect an RF power meter tothe antenna connector.

Connect an FM deviation meterwith an oscilloscope to theantenna connector through anattenuator.

Connect an FM deviation meterto the antenna connectorthrough the attenuator.


174.0000 MHz

25.0 W [25W]50.0 W [50W]

10.0 W [25W]25.0 W [50W]

2.5 W [25W]5.0 W [50W]

±4.1 kHz [N/W]±3.3 kHz [N/M]

±2.1 kHz

±0.7 kHz

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

Set to square wave form

5 - 5

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

SOFTWARE ADJUSTMENT – continuedSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

Minimum distortionlevel

Push [ENTER] keyon the connectedcomputer keyboardto set “S3 level”.


Set “SQL level” toclose squelch.

Then set “SQL level”at the point wherethe audio signalsjust appears.

1

1

2

1

• Operating freq. : 136.000 MHz• IF bandwidth : Wide• Connect a standard signal generator to

the antenna connector and set as:Frequency : 136.000 MHzLevel : 10 µV* (–87 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]

±2.8 kHz [N/M]• Receiving

• Operating freq. : 136.000 MHz• IF bandwidth : Wide• Connect an SSG to the antenna con-

nector and set as:Frequency : 136.000 MHzLevel : 14 µV* (–84 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]


• Set an SSG as :Level : 0.45 µV* (–114 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]


• Operating freq. : 155.000 MHz• IF bandwidth : Narrow• Connect an SSG to the antenna con-

nector and set as:Frequency : 155.000 MHzLevel : 0.2 µV* (–121 dBm)Modulation : 1 kHzDeviation : ±1.75 kHz

• Receiving

RXSENSITIVITY[BPF T1] – [BPF T4]

S-METER[S-METER]

SQUELCHLEVEL[SQL]

MAIN

Rearpanel

Connect a SINAD meter with a4 Ω load to the external [SP]jack.



VALUEUNIT LOCATION

CONVENIENT:The BPF T1–BPF T4 can be adjusted automatically.q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER] key.q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.

orw-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.w-2: Push [ENTER] key to start tuning.w-3: Repeat w-1 and w-2 to perform additional BPF tuning.

[FRONT UNIT][FRONT UNIT]

IC1 1130010800 S.IC LC75824WIC2 1130008560 S.IC TC75S51F (TE85L)

Q1 1590000720 S.TRANSISTOR DTA144EUA T106Q2 1590000430 S.TRANSISTOR DTC144EUA T106Q3 1590000430 S.TRANSISTOR DTC144EUA T106Q4 1590000720 S.TRANSISTOR DTA144EUA T106

D1 1790001670 S.DIODE RB706F-40T106D2 1790001670 S.DIODE RB706F-40T106D3 1790001670 S.DIODE RB706F-40T106D4 1790001250 S.DIODE MA2S111-(TX)D5 1790001250 S.DIODE MA2S111-(TX)D6 1790001250 S.DIODE MA2S111-(TX)

L1 6200003960 S.COIL MLF1608A 1R0K-T

R1 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R2 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R3 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)R4 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)R5 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R6 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R7 7030000330 S.RESISTOR MCR10EZHJ 390 Ω (391)R8 7410000950 S.ARRAY EXB-V8V 102JVR9 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R10 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R11 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R12 7210003020 VARIABLE EVU-F2KFK1 B14 (10KB)R13 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ)R14 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R16 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R17 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R18 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R19 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R20 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R21 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R22 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R24 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R25 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)

C1 4030007090 S.CERAMIC C1608 CH 1H 470J-TC2 4030007090 S.CERAMIC C1608 CH 1H 470J-TC3 4030007090 S.CERAMIC C1608 CH 1H 470J-TC4 4030007090 S.CERAMIC C1608 CH 1H 470J-TC5 4030007090 S.CERAMIC C1608 CH 1H 470J-TC6 4030007090 S.CERAMIC C1608 CH 1H 470J-TC7 4030007090 S.CERAMIC C1608 CH 1H 470J-TC8 4030007090 S.CERAMIC C1608 CH 1H 470J-TC9 4030007090 S.CERAMIC C1608 CH 1H 470J-TC10 4030007090 S.CERAMIC C1608 CH 1H 470J-TC11 4030007090 S.CERAMIC C1608 CH 1H 470J-TC12 4030007090 S.CERAMIC C1608 CH 1H 470J-TC13 4030007090 S.CERAMIC C1608 CH 1H 470J-TC14 4030007090 S.CERAMIC C1608 CH 1H 470J-TC15 4030007090 S.CERAMIC C1608 CH 1H 470J-TC16 4030007090 S.CERAMIC C1608 CH 1H 470J-TC17 4030007090 S.CERAMIC C1608 CH 1H 470J-TC18 4030007090 S.CERAMIC C1608 CH 1H 470J-TC19 4030006860 S.CERAMIC C1608 JB 1H 102K-TC20 4030007090 S.CERAMIC C1608 CH 1H 470J-TC21 4030007090 S.CERAMIC C1608 CH 1H 470J-TC22 4030007090 S.CERAMIC C1608 CH 1H 470J-TC23 4030007090 S.CERAMIC C1608 CH 1H 470J-TC24 4030007090 S.CERAMIC C1608 CH 1H 470J-TC25 4030007090 S.CERAMIC C1608 CH 1H 470J-TC26 4030007090 S.CERAMIC C1608 CH 1H 470J-TC27 4030007090 S.CERAMIC C1608 CH 1H 470J-TC28 4030007090 S.CERAMIC C1608 CH 1H 470J-TC29 4030007090 S.CERAMIC C1608 CH 1H 470J-T

S.=Surface mount

C30 4030011600 S.CERAMIC C1608 JB 1E 104K-TC31 4030011600 S.CERAMIC C1608 JB 1E 104K-TC32 4030011600 S.CERAMIC C1608 JB 1E 104K-TC33 4030007130 S.CERAMIC C1608 CH 1H 101J-TC34 4030007090 S.CERAMIC C1608 CH 1H 470J-TC35 4030007090 S.CERAMIC C1608 CH 1H 470J-TC37 4550000550 S.TANTALUM TESVA 1V 224M1-8LC39 4030006900 S.CERAMIC C1608 JB 1H 103K-TC40 4550005980 S.TANTALUM TEMSVA 1A 475M-8LC41 4030006860 S.CERAMIC C1608 JB 1H 102K-T

J1 6450002210 CONNECTOR 3017-8821J2 6510023090 S.CONNECTOR 20FLT-SM1-TB

DS1 5040002310 S.LED SML-311YTT86DS2 5040002310 S.LED SML-311YTT86DS3 5040002310 S.LED SML-311YTT86DS4 5040002310 S.LED SML-311YTT86DS5 5040002310 S.LED SML-311YTT86DS6 5040002310 S.LED SML-311YTT86DS7 5040002310 S.LED SML-311YTT86DS8 5040002310 S.LED SML-311YTT86DS9 5040002310 S.LED SML-311YTT86DS10 5040002310 S.LED SML-311YTT86DS11 5040002310 S.LED SML-311YTT86DS12 5030002230 LCD L1-0483TAT

W1 8900010950 CABLE OPC-1126 (P=0.5 N=20 L=90)

EP1 0910054932 PCB B 5809BEP2 8930057820 LCD CONTACT SRCN-2526-SP-N-W

6 - 1


REF ORDER DESCRIPTIONNO. NO.REF ORDER DESCRIPTIONNO. NO.

S.=Surface mount

[MAIN UNIT][MAIN UNIT]

IC1 1110003490 S.IC TA31136FN (D, EL)IC2 1130008560 S.IC TC75S51F (TE85L)IC3 1150002040 IC RA30H1317M-01 [25W]

1150002070 IC RA60H1317M-21 [50W]IC4 1130010860 S.IC TB31256FL (EB)IC5 1110005330 S.IC NJM12904V-TE1IC6 1190001350 S.IC M62364FP 600DIC7 1190001340 S.IC M62334FP 600CIC8 1110003090 IC LA4425AIC9 1180001250 S.IC TA7808F (TE16L)IC10 1180000970 S.IC AN78L05M-(E1)IC11 1130008560 S.IC TC75S51F (TE85L)IC14 1130009330 S.IC TC35453F (BR, DRY)IC15 1130006220 S.IC TC4W53FU (TE12L)IC18 1110002750 S.IC TA75S01F (TE85R)IC19 1130009700 S.IC LC73872M-TRMIC20 1140010190 S.IC HD64F2268TF (EMPTY)IC21 1110005340 S.IC NJM12902V-TE1IC22 1130004200 S.IC TC4S66F (TE85R)IC23 1140009240 S.IC HN58X24128FPIIC24 1130009110 S.IC S-80942ANMP-DD6-T2IC25 1130004200 S.IC TC4S66F (TE85R)IC26 1180001150 S.IC S-81230SG-QB-T1

Q1 1560000840 S.FET 2SK1829 (TE85R)Q2 1580000730 S.FET 3SK293 (TE85L)Q3 1580000660 S.FET 3SK272-(TX)Q4 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q5 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q6 1590000720 S.TRANSISTOR DTA144EUA T106Q8 1530002620 S.TRANSISTOR 2SC3585-T1B R44Q9 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q10 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q11 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q12 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q13 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q14 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q15 1590001400 S.TRANSISTOR XP1214 (TX)Q16 1590000430 S.TRANSISTOR DTC144EUA T106Q17 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q18 1560000540 S.FET 2SK880-Y (TE85R)Q19 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q20 1530003090 S.TRANSISTOR 2SC4213-B (TE85R)Q21 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q22 1590000430 S.TRANSISTOR DTC144EUA T106Q23 1550000020 S.FET 2SJ377 (TE16R)Q24 1590000430 S.TRANSISTOR DTC144EUA T106Q25 1540000550 S.TRANSISTOR 2SD1664 T100QQ26 1540000550 S.TRANSISTOR 2SD1664 T100QQ27 1520000460 S.TRANSISTOR 2SB1132 T100 RQ28 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ29 1590000430 S.TRANSISTOR DTC144EUA T106Q30 1590000430 S.TRANSISTOR DTC144EUA T106Q31 1590001450 S.FET 2SJ144-GR (TE85R)Q32 1590000430 S.TRANSISTOR DTC144EUA T106Q33 1590000430 S.TRANSISTOR DTC144EUA T106Q34 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q35 1590001400 S.TRANSISTOR XP1214 (TX)Q36 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q37 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q38 1590000430 S.TRANSISTOR DTC144EUA T106Q39 1590000990 S.TRANSISTOR DTC363EK T146Q40 1590000430 S.TRANSISTOR DTC144EUA T106Q41 1590000720 S.TRANSISTOR DTA144EUA T106Q42 1590000430 S.TRANSISTOR DTC144EUA T106Q43 1590000430 S.TRANSISTOR DTC144EUA T106Q44 1590000430 S.TRANSISTOR DTC144EUA T106Q48 1590000430 S.TRANSISTOR DTC144EUA T106Q49 1590000430 S.TRANSISTOR DTC144EUA T106Q50 1530002060 S.TRANSISTOR 2SC4081 T106 RQ51 1510000510 S.TRANSISTOR 2SA1576A T106RQ52 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q53 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q54 1590003090 S.TRANSISTOR XP2401-(TX)Q55 1590003100 S.TRANSISTOR XP2501-(TX)Q56 1590000430 S.TRANSISTOR DTC144EUA T106Q57 1590001050 S.TRANSISTOR DTC114TUA T106 [25W]

1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) [50W]

D1 1790001210 S.DIODE 1SS375-TLD2 1750000510 S.DIODE UM9401F [25W]D3 1710001060 DIODE XB15A407 [50W]D4 1750000710 S.VARICAP HVC350BTRFD5 1750000760 S.DIODE MA4PH224D6 1790000620 S.DIODE MA77 (TX)D7 1790001240 S.DIODE MA2S728-(TX)D8 1750000710 S.VARICAP HVC350BTRFD9 1750000710 S.VARICAP HVC350BTRFD10 1750000710 S.VARICAP HVC350BTRFD11 1790001210 S.DIODE 1SS375-TLD14 1790000620 S.DIODE MA77 (TX)D15 1790000620 S.DIODE MA77 (TX)D16 1750000710 S.VARICAP HVC350BTRFD17 1750000710 S.VARICAP HVC350BTRFD18 1720000400 S.VARICAP 1SV245 (TPH3)D19 1790001250 S.DIODE MA2S111-(TX)D20 1790001250 S.DIODE MA2S111-(TX)D21 1750000830 S.VARICAP HVC362TRFD22 1790000700 DIODE DSA3A1D23 1750000370 S.DIODE DA221 TLD24 1750000370 S.DIODE DA221 TLD25 1790001250 S.DIODE MA2S111-(TX)D26 1790001250 S.DIODE MA2S111-(TX)D27 1790000620 S.DIODE MA77 (TX)D28 1160000070 S.DIODE DAN202K T146D31 1160000070 S.DIODE DAN202K T146D32 1790001240 S.DIODE MA2S728-(TX)D34 1790001250 S.DIODE MA2S111-(TX)D35 1790001250 S.DIODE MA2S111-(TX)D50 1750000710 S.VARICAP HVC350BTRFD51 1750000710 S.VARICAP HVC350BTRFD52 1750000710 S.VARICAP HVC350BTRFD53 1750000710 S.VARICAP HVC350BTRFD54 1750000710 S.VARICAP HVC350BTRFD55 1750000710 S.VARICAP HVC350BTRFD56 1790001250 S.DIODE MA2S111-(TX)D58 1790001240 S.DIODE MA2S728-(TX)D59 1790001240 S.DIODE MA2S728-(TX)D60 1790001240 S.DIODE MA2S728-(TX)D61 1790001240 S.DIODE MA2S728-(TX)D63 1160000070 S.DIODE DAN202K T146D65 1160000070 S.DIODE DAN202K T146D67 1160000070 S.DIODE DAN202K T146D68 1750000150 S.DIODE DA204K T146D69 1790001240 S.DIODE MA2S728-(TX)D70 1790001250 S.DIODE MA2S111-(TX)D71 1750000520 S.DIODE DAN222TLD72 1750000350 S.VARICAP 1SV252 (TE85L)

FI1 2030000150 S.MONOLITH FL-335 (46.350 MHz)FI2 2020001840 CERAMIC ALFYM450F=K [N/W]

2020001410 CERAMIC CFWLB450KGFA-B0 [N/M]FI3 2040001440 S.LC NFE31PT152Z1E9LFI4 2040001440 S.LC NFE31PT152Z1E9LFI5 2040001440 S.LC NFE31PT152Z1E9L [50W]

X1 6070000190 S.DISCRIMINATOR CDBCB450KCAY24-R0X2 6050011070 S.XTAL CR-664A (15.300 MHz)X3 6050009910 S.XTAL CR-563 (3.579545 MHz)X4 6050009520 S.XTAL CR-520 (19.6608 MHz+)

L1 6110001670 COIL LA-253L2 6110001600 COIL LA-243L3 6110001670 COIL LA-253L4 6200008150 S.COIL 0.35-1.6-7TL 44NL5 6170000230 COIL LW-25L6 6200008150 S.COIL 0.35-1.6-7TL 44NL7 6200008260 S.COIL 0.30-1.7-8TL 60NL8 6200007750 S.COIL LQW2BHN56NJ01LL9 6200004660 S.COIL MLF1608A 1R8K-TL11 6200008090 S.COIL LQW2BHN68NJ01LL12 6200009180 S.COIL ELJRE R10J-F3L13 6200003330 S.COIL NL 322522T-1R0J-3L16 6110001670 COIL LA-253L18 6200005740 S.COIL ELJRE 47NG-F [25W]

6200007000 S.COIL ELJRE 82NG-F [50W]L19 6200009570 S.COIL ELJRE R12G-F3L20 6200009530 S.COIL ELJRE R15G-F3

6 - 2


S.=Surface mount


L21 6200009530 S.COIL ELJRE R15G-F3L23 6200002000 S.COIL NL 252018T-3R3JL24 6200002000 S.COIL NL 252018T-3R3JL25 6200009460 S.COIL 0.25-1.9-7TL 67NL26 6200009460 S.COIL 0.25-1.9-7TL 67NL27 6200002610 S.COIL NL 252018T-R47JL28 6200002610 S.COIL NL 252018T-R47JL29 6200004660 S.COIL MLF1608A 1R8K-TL31 6200007750 S.COIL LQW2BHN56NJ01LL32 6200005720 S.COIL ELJRE 33NG-FL33 6200002850 S.COIL NL 252018T-R82JL35 6200002840 S.COIL NL 252018T-R22JL36 6200002860 S.COIL NL 252018T-4R7JL37 6200003960 S.COIL MLF1608A 1R0K-TL50 6200008150 S.COIL 0.35-1.6-7TL 44NL51 6200009460 S.COIL 0.25-1.9-7TL 67NL52 6200006670 S.COIL ELJRE 68NG-FL53 6200004660 S.COIL MLF1608A 1R8K-TL54 6200007750 S.COIL LQW2BHN56NJ01LL55 6200006980 S.COIL ELJRE R10G-F

R1 7030000620 S.RESISTOR MCR10EZHJ 100 kΩR2 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470)R3 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470)R4 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)R5 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [25W]

7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) [50W]R6 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [25W]

7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) [50W]R7 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)R8 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)R9 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)R10 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R11 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R13 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R14 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R15 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)R16 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)R18 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R19 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R20 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R21 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R22 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R23 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R25 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R26 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R27 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R28 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω)R29 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R30 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R31 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R32 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R33 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω)R34 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R35 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R36 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R37 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R38 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R39 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R40 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R41 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R42 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R43 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R44 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R45 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)R46 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)R47 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R50 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R52 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)R53 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R54 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R55 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R56 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R57 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R58 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [25W]

7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) [50W]R59 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) [25W]R61 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)

R63 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) [25W]7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) [50W]

R64 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) [50W]R65 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R66 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R67 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R68 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R69 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R70 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R71 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R73 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R74 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R75 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R76 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R77 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R78 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R79 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ)R80 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω) [N/W]

7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) [N/M]R83 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ)R84 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R85 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R86 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R89 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R90 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R91 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R92 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R93 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R94 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R95 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)R96 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R97 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R98 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R100 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)R101 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R102 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R103 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ)R104 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R105 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R106 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R107 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R108 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R109 7410000800 S.ARRAY EXB-V8V 103JV (10 kΩ)R110 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R111 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R112 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R113 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)R115 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R116 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R117 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)R118 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R119 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R120 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R121 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R122 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R123 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R124 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R125 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R126 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R127 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R128 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R129 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R130 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R131 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R132 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R133 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R134 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R135 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R136 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R137 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R138 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R139 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R140 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R141 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R142 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R143 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R144 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R145 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R146 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R147 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R148 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R149 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)

6 - 3


S.=Surface mount


R151 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R152 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R153 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R154 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R155 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R156 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R157 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R158 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R159 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R173 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R174 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R175 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R176 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R177 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R178 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R179 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R180 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)R181 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R182 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R185 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R186 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)R187 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R188 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)R189 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R190 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)R191 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R192 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R193 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R194 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R195 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R196 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R197 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R198 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R199 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R200 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R201 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R202 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR203 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR204 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR205 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR206 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R207 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R208 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)R209 7510001470 S.THERMISTOR NTCG20 4AG 473JTR210 7030005871 S.RESISTOR ERA3YKD 104V (100 kΩ)R215 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R216 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R217 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R218 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R219 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R220 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R221 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R222 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R223 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R224 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R225 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R226 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R227 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R228 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R229 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R230 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R231 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R233 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R234 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)R235 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R236 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R237 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 kΩ)R238 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R239 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R240 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R241 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R242 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)R243 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R244 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)R245 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R246 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R247 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R248 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R249 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R250 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R251 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R252 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)

R253 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)R254 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R255 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R256 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R257 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R258 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R259 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R260 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R261 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R262 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)R263 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R264 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)R265 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R266 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R267 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R268 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R269 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R270 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R271 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R272 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R273 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R274 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R275 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R276 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R277 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R278 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R280 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R281 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R282 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R284 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R285 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R286 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R287 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R288 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R289 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R290 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R291 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R292 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R293 7410000950 S.ARRAY EXB-V8V 102JVR294 7410000950 S.ARRAY EXB-V8V 102JVR295 7410000950 S.ARRAY EXB-V8V 102JVR296 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R297 7030005651 S.RESISTOR ERA3YKD 304V (300 kΩ)R298 7030005871 S.RESISTOR ERA3YKD 104V (100 kΩ)R299 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R302 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R303 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R304 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R305 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R306 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R307 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R308 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R312 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R316 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R317 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R318 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R319 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R320 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R322 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R323 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R324 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R500 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R501 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω)R502 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω)R503 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R504 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R507 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R508 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)R509 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R510 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)R511 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R512 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)R513 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R515 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)R516 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R517 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R518 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R519 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R520 7510001650 S.THRMISTOR NTCG16 4BH 222KTR521 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R522 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R523 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)

6 - 4


S.=Surface mount


R524 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R525 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R526 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R527 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R528 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω)R529 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) [25W]R530 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R534 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R535 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R536 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R537 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) [25W]

7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) [50W]R538 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R539 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R540 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) [25W]

7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) [50W]R541 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)R542 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R543 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) [50W]R544 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) [50W]R546 7520000160 S.POSISTOR PRF21BD471QB3RA [50W]R547 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) [25W]

7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) [50W]

C1 4030011120 S.CERAMIC GRM31M2C2H100JV01LC2 4030011120 S.CERAMIC GRM31M2C2H100JV01LC3 4030011340 S.CERAMIC C1608 CH 1H 471J-TC4 4030008560 S.CERAMIC C1608 CH 1H 300J-TC5 4030011340 S.CERAMIC C1608 CH 1H 471J-TC6 4030011210 S.CERAMIC GRM31M2C2H330JV01LC7 4030011510 S.CERAMIC GRM31M2C2H560JV01L [25W]

4030011190 S.CERAMIC GRM31M2C2H270JV01L [50W]C8 4030011210 S.CERAMIC GRM31M2C2H330JV01LC9 4030011170 S.CERAMIC GRM31M2C2H180JV01LC10 4030006860 S.CERAMIC C1608 JB 1H 102K-TC11 4030006860 S.CERAMIC C1608 JB 1H 102K-TC12 4030011340 S.CERAMIC C1608 CH 1H 471J-TC13 4030007090 S.CERAMIC C1608 CH 1H 470J-TC14 4030017200 S.CERAMIC GRM31BR32J102KY01L [25W]C15 4030011210 S.CERAMIC GRM31M2C2H330JV01LC17 4030007010 S.CERAMIC C1608 CH 1H 100D-T [25W]

4030009920 S.CERAMIC C1608 CH 1H 050B-T [50W]C18 4030011770 S.CERAMIC C1608 CH 1H 060B-TC19 4030006860 S.CERAMIC C1608 JB 1H 102K-TC20 4030006860 S.CERAMIC C1608 JB 1H 102K-TC21 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC22 4030009540 S.CERAMIC C1608 CH 1H 1R5B-TC23 4030006860 S.CERAMIC C1608 JB 1H 102K-TC24 4030006860 S.CERAMIC C1608 JB 1H 102K-TC25 4030011770 S.CERAMIC C1608 CH 1H 060B-TC26 4030006860 S.CERAMIC C1608 JB 1H 102K-TC27 4030006860 S.CERAMIC C1608 JB 1H 102K-TC28 4030006860 S.CERAMIC C1608 JB 1H 102K-TC29 4030009920 S.CERAMIC C1608 CH 1H 050B-TC30 4030007050 S.CERAMIC C1608 CH 1H 220J-TC32 4030006860 S.CERAMIC C1608 JB 1H 102K-TC33 4030007090 S.CERAMIC C1608 CH 1H 470J-TC34 4030006860 S.CERAMIC C1608 JB 1H 102K-TC35 4030006860 S.CERAMIC C1608 JB 1H 102K-TC37 4030006860 S.CERAMIC C1608 JB 1H 102K-TC38 4030006860 S.CERAMIC C1608 JB 1H 102K-TC39 4030006860 S.CERAMIC C1608 JB 1H 102K-TC40 4030009540 S.CERAMIC C1608 CH 1H 1R5B-TC41 4030009350 S.CERAMIC C1608 CH 1H 3R5B-TC42 4030006860 S.CERAMIC C1608 JB 1H 102K-TC43 4030006860 S.CERAMIC C1608 JB 1H 102K-TC44 4030009520 S.CERAMIC C1608 CH 1H 020B-TC45 4030007170 S.CERAMIC C1608 CH 1H 221J-TC46 4030006860 S.CERAMIC C1608 JB 1H 102K-TC47 4030006860 S.CERAMIC C1608 JB 1H 102K-TC48 4030007090 S.CERAMIC C1608 CH 1H 470J-TC49 4030006990 S.CERAMIC C1608 CH 1H 080D-TC50 4030006860 S.CERAMIC C1608 JB 1H 102K-TC51 4030006860 S.CERAMIC C1608 JB 1H 102K-TC52 4030007020 S.CERAMIC C1608 CH 1H 120J-TC53 4030006900 S.CERAMIC C1608 JB 1H 103K-TC54 4030006860 S.CERAMIC C1608 JB 1H 102K-TC55 4030006990 S.CERAMIC C1608 CH 1H 080D-TC56 4030007050 S.CERAMIC C1608 CH 1H 220J-TC58 4030006860 S.CERAMIC C1608 JB 1H 102K-TC59 4030011600 S.CERAMIC C1608 JB 1E 104K-T

C60 4030006860 S.CERAMIC C1608 JB 1H 102K-TC61 4030007130 S.CERAMIC C1608 CH 1H 101J-TC62 4030007120 S.CERAMIC C1608 CH 1H 820J-TC63 4030006860 S.CERAMIC C1608 JB 1H 102K-TC64 4030011340 S.CERAMIC C1608 CH 1H 471J-TC65 4030006860 S.CERAMIC C1608 JB 1H 102K-TC66 4030006860 S.CERAMIC C1608 JB 1H 102K-TC67 4030006860 S.CERAMIC C1608 JB 1H 102K-TC69 4030011330 S.CERAMIC C1608 CH 1H 391J-TC70 4030011330 S.CERAMIC C1608 CH 1H 391J-TC71 4030011600 S.CERAMIC C1608 JB 1E 104K-TC72 4030011600 S.CERAMIC C1608 JB 1E 104K-TC74 4030011600 S.CERAMIC C1608 JB 1E 104K-TC75 4550006050 S.TANTALUM TEMSVA 0J 106M8LC76 4030006900 S.CERAMIC C1608 JB 1H 103K-TC77 4030006860 S.CERAMIC C1608 JB 1H 102K-TC78 4030006860 S.CERAMIC C1608 JB 1H 102K-TC79 4030011810 S.CERAMIC C1608 JB 1A 224K-TC80 4030011600 S.CERAMIC C1608 JB 1E 104K-TC81 4030006860 S.CERAMIC C1608 JB 1H 102K-TC82 4030011270 S.CERAMIC GRM31M2C2H200JV01L [25W]C83 4030011270 S.CERAMIC GRM31M2C2H200JV01L [25W]C84 4030007090 S.CERAMIC C1608 CH 1H 470J-TC85 4030006860 S.CERAMIC C1608 JB 1H 102K-TC86 4030007090 S.CERAMIC C1608 CH 1H 470J-TC87 4030006860 S.CERAMIC C1608 JB 1H 102K-TC88 4030006860 S.CERAMIC C1608 JB 1H 102K-TC89 4030007020 S.CERAMIC C1608 CH 1H 120J-T [25W]

4030007030 S.CERAMIC C1608 CH 1H 150J-T [50W]C90 4030007020 S.CERAMIC C1608 CH 1H 120J-TC91 4510005750 S.ELECTROLYTIC ECEV1EA220SPC92 4030006990 S.CERAMIC C1608 CH 1H 080D-TC93 4030007050 S.CERAMIC C1608 CH 1H 220J-T [25W]

4030011770 S.CERAMIC C1608 CH 1H 060B-T [50W]C94 4030007090 S.CERAMIC C1608 CH 1H 470J-TC95 4030006860 S.CERAMIC C1608 JB 1H 102K-TC96 4030006860 S.CERAMIC C1608 JB 1H 102K-TC97 4030007090 S.CERAMIC C1608 CH 1H 470J-TC98 4030007030 S.CERAMIC C1608 CH 1H 150J-TC99 4030006860 S.CERAMIC C1608 JB 1H 102K-TC100 4030007040 S.CERAMIC C1608 CH 1H 180J-TC101 4030006860 S.CERAMIC C1608 JB 1H 102K-TC102 4030007010 S.CERAMIC C1608 CH 1H 100D-TC103 4030006990 S.CERAMIC C1608 CH 1H 080D-TC104 4030006860 S.CERAMIC C1608 JB 1H 102K-TC105 4030006860 S.CERAMIC C1608 JB 1H 102K-TC106 4030007090 S.CERAMIC C1608 CH 1H 470J-TC107 4030006860 S.CERAMIC C1608 JB 1H 102K-TC108 4030006900 S.CERAMIC C1608 JB 1H 103K-TC109 4030006860 S.CERAMIC C1608 JB 1H 102K-TC110 4030011340 S.CERAMIC C1608 CH 1H 471J-TC111 4030007090 S.CERAMIC C1608 CH 1H 470J-TC113 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC114 4030007040 S.CERAMIC C1608 CH 1H 180J-TC115 4030007070 S.CERAMIC C1608 CH 1H 330J-TC116 4030006860 S.CERAMIC C1608 JB 1H 102K-TC117 4030011340 S.CERAMIC C1608 CH 1H 471J-TC118 4030009560 S.CERAMIC C1608 CH 1H R75B-TC119 4030006900 S.CERAMIC C1608 JB 1H 103K-TC120 4030011340 S.CERAMIC C1608 CH 1H 471J-TC121 4030007070 S.CERAMIC C1608 CH 1H 330J-TC122 4030007070 S.CERAMIC C1608 CH 1H 330J-TC123 4030007130 S.CERAMIC C1608 CH 1H 101J-TC124 4030007050 S.CERAMIC C1608 CH 1H 220J-TC126 4030007110 S.CERAMIC C1608 CH 1H 680J-TC127 4030011280 S.CERAMIC C1608 CH 1H 271J-TC128 4030007020 S.CERAMIC C1608 CH 1H 120J-TC129 4030009510 S.CERAMIC C1608 CH 1H 010B-TC130 4030009980 S.CERAMIC C1608 JB 1H 152K-TC132 4030006860 S.CERAMIC C1608 JB 1H 102K-TC133 4610001970 S.TRIMMER TZC3P200A110R00C134 4610001970 S.TRIMMER TZC3P200A110R00C139 4030011600 S.CERAMIC C1608 JB 1E 104K-TC140 4030011600 S.CERAMIC C1608 JB 1E 104K-TC141 4030006860 S.CERAMIC C1608 JB 1H 102K-TC142 4030006860 S.CERAMIC C1608 JB 1H 102K-TC143 4030006860 S.CERAMIC C1608 JB 1H 102K-TC145 4030007090 S.CERAMIC C1608 CH 1H 470J-TC146 4550000530 S.TANTALUM TESVA 1V 104M1-8LC147 4550006150 S.TANTALUM ECST1CY105RC148 4510004630 S.ELECTROLYTIC ECEV1CA100SRC151 4030007090 S.CERAMIC C1608 CH 1H 470J-T

6 - 5


S.=Surface mount


C152 4030007090 S.CERAMIC C1608 CH 1H 470J-TC153 4030007090 S.CERAMIC C1608 CH 1H 470J-TC154 4030007090 S.CERAMIC C1608 CH 1H 470J-TC155 4030007090 S.CERAMIC C1608 CH 1H 470J-TC156 4030007090 S.CERAMIC C1608 CH 1H 470J-TC157 4030007130 S.CERAMIC C1608 CH 1H 101J-TC158 4030007130 S.CERAMIC C1608 CH 1H 101J-TC159 4030011600 S.CERAMIC C1608 JB 1E 104K-TC160 4030007000 S.CERAMIC C1608 CH 1H 090D-TC161 4030007130 S.CERAMIC C1608 CH 1H 101J-TC162 4030006900 S.CERAMIC C1608 JB 1H 103K-TC163 4510004630 S.ELECTROLYTIC ECEV1CA100SRC164 4030006860 S.CERAMIC C1608 JB 1H 102K-TC165 4030006860 S.CERAMIC C1608 JB 1H 102K-TC166 4030006860 S.CERAMIC C1608 JB 1H 102K-TC167 4030008890 S.CERAMIC C1608 JB 1H 273K-TC168 4030008910 S.CERAMIC C1608 JB 1H 393K-TC169 4030008910 S.CERAMIC C1608 JB 1H 393K-TC170 4030008900 S.CERAMIC C1608 JB 1H 333K-TC171 4030006880 S.CERAMIC C1608 JB 1H 472K-TC173 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC174 4510005950 S.ELECTROLYTIC ECEV1HA0R1SRC176 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC177 4030007030 S.CERAMIC C1608 CH 1H 150J-TC178 4030007040 S.CERAMIC C1608 CH 1H 180J-TC179 4030011340 S.CERAMIC C1608 CH 1H 471J-TC180 4030011600 S.CERAMIC C1608 JB 1E 104K-TC181 4030011600 S.CERAMIC C1608 JB 1E 104K-TC182 4030011600 S.CERAMIC C1608 JB 1E 104K-TC183 4030008920 S.CERAMIC C1608 JB 1H 473K-TC184 4030011600 S.CERAMIC C1608 JB 1E 104K-TC185 4030011600 S.CERAMIC C1608 JB 1E 104K-TC186 4030006870 S.CERAMIC C1608 JB 1H 222K-TC187 4030006870 S.CERAMIC C1608 JB 1H 222K-TC188 4030011600 S.CERAMIC C1608 JB 1E 104K-TC189 4030011600 S.CERAMIC C1608 JB 1E 104K-TC190 4030007090 S.CERAMIC C1608 CH 1H 470J-TC191 4030008910 S.CERAMIC C1608 JB 1H 393K-TC192 4030006880 S.CERAMIC C1608 JB 1H 472K-TC193 4030011600 S.CERAMIC C1608 JB 1E 104K-TC194 4030007140 S.CERAMIC C1608 CH 1H 121J-TC195 4510005950 S.ELECTROLYTIC ECEV1HA0R1SRC196 4030006900 S.CERAMIC C1608 JB 1H 103K-TC199 4030007090 S.CERAMIC C1608 CH 1H 470J-TC200 4030011600 S.CERAMIC C1608 JB 1E 104K-TC201 4030011600 S.CERAMIC C1608 JB 1E 104K-TC202 4030011600 S.CERAMIC C1608 JB 1E 104K-TC203 4030011600 S.CERAMIC C1608 JB 1E 104K-TC204 4030007090 S.CERAMIC C1608 CH 1H 470J-TC205 4030007090 S.CERAMIC C1608 CH 1H 470J-TC206 4030007090 S.CERAMIC C1608 CH 1H 470J-TC207 4030011600 S.CERAMIC C1608 JB 1E 104K-TC209 4030007090 S.CERAMIC C1608 CH 1H 470J-TC214 4030007090 S.CERAMIC C1608 CH 1H 470J-TC215 4030007090 S.CERAMIC C1608 CH 1H 470J-TC217 4030007090 S.CERAMIC C1608 CH 1H 470J-TC219 4030007090 S.CERAMIC C1608 CH 1H 470J-TC220 4030007090 S.CERAMIC C1608 CH 1H 470J-TC224 4030007090 S.CERAMIC C1608 CH 1H 470J-TC227 4030007090 S.CERAMIC C1608 CH 1H 470J-TC228 4030007090 S.CERAMIC C1608 CH 1H 470J-TC229 4030007090 S.CERAMIC C1608 CH 1H 470J-TC231 4030007090 S.CERAMIC C1608 CH 1H 470J-TC235 4030007090 S.CERAMIC C1608 CH 1H 470J-TC236 4030007090 S.CERAMIC C1608 CH 1H 470J-TC237 4030007090 S.CERAMIC C1608 CH 1H 470J-TC238 4030006860 S.CERAMIC C1608 JB 1H 102K-TC239 4030006860 S.CERAMIC C1608 JB 1H 102K-TC240 4030008880 S.CERAMIC C1608 JB 1H 223K-TC241 4030006860 S.CERAMIC C1608 JB 1H 102K-TC242 4030010020 S.CERAMIC C1608 JB 1H 122K-TC243 4030011280 S.CERAMIC C1608 CH 1H 271J-TC244 4030007100 S.CERAMIC C1608 CH 1H 560J-TC246 4030010760 S.CERAMIC C1608 CH 1H 331J-TC247 4030006860 S.CERAMIC C1608 JB 1H 102K-TC248 4030006860 S.CERAMIC C1608 JB 1H 102K-TC249 4030011340 S.CERAMIC C1608 CH 1H 471J-TC250 4030011600 S.CERAMIC C1608 JB 1E 104K-TC251 4030011600 S.CERAMIC C1608 JB 1E 104K-TC252 4030011600 S.CERAMIC C1608 JB 1E 104K-TC253 4030011600 S.CERAMIC C1608 JB 1E 104K-TC254 4030006860 S.CERAMIC C1608 JB 1H 102K-T

C255 4510005290 S.ELECTROLYTIC ECEV1EA221PC256 4510006260 S.ELECTROLYTIC ECEV1AA471UPC257 4030007090 S.CERAMIC C1608 CH 1H 470J-TC258 4510004510 ELECTROLYTIC 25 MV 470 HCC259 4030006860 S.CERAMIC C1608 JB 1H 102K-TC260 4030007090 S.CERAMIC C1608 CH 1H 470J-TC261 4030004760 S.CERAMIC C2012 JF 1H 104Z-TC262 4030011600 S.CERAMIC C1608 JB 1E 104K-TC263 4030004760 S.CERAMIC C2012 JF 1H 104Z-TC264 4030011600 S.CERAMIC C1608 JB 1E 104K-TC265 4510005290 S.ELECTROLYTIC ECEV1EA221PC266 4510004630 S.ELECTROLYTIC ECEV1CA100SRC268 4550006700 S.TANTALUM ECST1AY106RC269 4030006860 S.CERAMIC C1608 JB 1H 102K-TC270 4030006860 S.CERAMIC C1608 JB 1H 102K-TC271 4510005860 S.ELECTROLYTIC ECEV1HA2R2SRC272 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC273 4030006860 S.CERAMIC C1608 JB 1H 102K-TC274 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC278 4030011600 S.CERAMIC C1608 JB 1E 104K-TC279 4030011600 S.CERAMIC C1608 JB 1E 104K-TC280 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC281 4030011340 S.CERAMIC C1608 CH 1H 471J-TC282 4030011600 S.CERAMIC C1608 JB 1E 104K-TC283 4030006860 S.CERAMIC C1608 JB 1H 102K-TC284 4030006900 S.CERAMIC C1608 JB 1H 103K-TC286 4030011600 S.CERAMIC C1608 JB 1E 104K-TC287 4030006860 S.CERAMIC C1608 JB 1H 102K-TC288 4030011600 S.CERAMIC C1608 JB 1E 104K-TC289 4030011600 S.CERAMIC C1608 JB 1E 104K-TC290 4030006860 S.CERAMIC C1608 JB 1H 102K-TC291 4030006860 S.CERAMIC C1608 JB 1H 102K-TC292 4030007090 S.CERAMIC C1608 CH 1H 470J-TC293 4030006860 S.CERAMIC C1608 JB 1H 102K-TC294 4030006860 S.CERAMIC C1608 JB 1H 102K-TC295 4510004630 S.ELECTROLYTIC ECEV1CA100SRC296 4030011600 S.CERAMIC C1608 JB 1E 104K-TC297 4030007050 S.CERAMIC C1608 CH 1H 220J-TC298 4030007020 S.CERAMIC C1608 CH 1H 120J-TC299 4030007020 S.CERAMIC C1608 CH 1H 120J-TC301 4030006860 S.CERAMIC C1608 JB 1H 102K-TC302 4030007010 S.CERAMIC C1608 CH 1H 100D-TC303 4030006860 S.CERAMIC C1608 JB 1H 102K-TC304 4030007010 S.CERAMIC C1608 CH 1H 100D-TC305 4030007100 S.CERAMIC C1608 CH 1H 560J-TC306 4030009910 S.CERAMIC C1608 CH 1H 040B-TC307 4030006980 S.CERAMIC C1608 CH 1H 070D-TC308 4030009530 S.CERAMIC C1608 CH 1H 030B-TC309 4030006900 S.CERAMIC C1608 JB 1H 103K-TC310 4030011600 S.CERAMIC C1608 JB 1E 104K-TC311 4030011600 S.CERAMIC C1608 JB 1E 104K-TC313 4030007090 S.CERAMIC C1608 CH 1H 470J-T [25W]C314 4030006900 S.CERAMIC C1608 JB 1H 103K-TC315 4030008880 S.CERAMIC C1608 JB 1H 223K-TC316 4030009490 S.CERAMIC C1608 JB 1H 821K-TC317 4030009490 S.CERAMIC C1608 JB 1H 821K-TC318 4030011600 S.CERAMIC C1608 JB 1E 104K-TC319 4030008920 S.CERAMIC C1608 JB 1H 473K-TC320 4030008910 S.CERAMIC C1608 JB 1H 393K-TC321 4030011600 S.CERAMIC C1608 JB 1E 104K-TC322 4030006900 S.CERAMIC C1608 JB 1H 103K-TC323 4030009880 S.CERAMIC C1608 JB 1H 682K-TC324 4030011600 S.CERAMIC C1608 JB 1E 104K-TC325 4030008900 S.CERAMIC C1608 JB 1H 333K-TC327 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC328 4030017490 S.CERAMIC C1608 JB 1A 105K-TC329 4030008870 S.CERAMIC C1608 JB 1H 183K-TC330 4030007110 S.CERAMIC C1608 CH 1H 680J-TC331 4030006900 S.CERAMIC C1608 JB 1H 103K-TC332 4030017490 S.CERAMIC C1608 JB 1A 105K-TC333 4030006860 S.CERAMIC C1608 JB 1H 102K-TC334 4030009630 S.CERAMIC C1608 JB 1H 822K-TC335 4030008920 S.CERAMIC C1608 JB 1H 473K-TC336 4030009490 S.CERAMIC C1608 JB 1H 821K-TC337 4030017480 S.CERAMIC C1608 JB 1A 474K-TC338 4030006900 S.CERAMIC C1608 JB 1H 103K-TC339 4030007070 S.CERAMIC C1608 CH 1H 330J-TC340 4030006900 S.CERAMIC C1608 JB 1H 103K-TC341 4030006980 S.CERAMIC C1608 CH 1H 070D-TC342 4030007050 S.CERAMIC C1608 CH 1H 220J-TC343 4030011600 S.CERAMIC C1608 JB 1E 104K-TC344 4030008890 S.CERAMIC C1608 JB 1H 273K-T


6 - 6

S.=Surface mount

[MAIN UNIT]

C345 4030011600 S.CERAMIC C1608 JB 1E 104K-TC348 4030006860 S.CERAMIC C1608 JB 1H 102K-TC349 4030011600 S.CERAMIC C1608 JB 1E 104K-TC350 4030017490 S.CERAMIC C1608 JB 1A 105K-TC351 4030008920 S.CERAMIC C1608 JB 1H 473K-TC352 4510005430 S.ELECTROLYTIC ECEV0JA220SRC353 4030007090 S.CERAMIC C1608 CH 1H 470J-TC354 4030007090 S.CERAMIC C1608 CH 1H 470J-TC358 4030007090 S.CERAMIC C1608 CH 1H 470J-TC359 4030011600 S.CERAMIC C1608 JB 1E 104K-TC360 4030011600 S.CERAMIC C1608 JB 1E 104K-TC361 4030010020 S.CERAMIC C1608 JB 1H 122K-TC362 4030011600 S.CERAMIC C1608 JB 1E 104K-TC363 4030011600 S.CERAMIC C1608 JB 1E 104K-TC365 4550006170 S.TANTALUM ECST1AY225RC371 4030006900 S.CERAMIC C1608 JB 1H 103K-TC377 4030011600 S.CERAMIC C1608 JB 1E 104K-TC378 4030011600 S.CERAMIC C1608 JB 1E 104K-TC379 4030017490 S.CERAMIC C1608 JB 1A 105K-TC380 4510005750 S.ELECTROLYTIC ECEV1EA220SPC381 4030011600 S.CERAMIC C1608 JB 1E 104K-TC382 4030008920 S.CERAMIC C1608 JB 1H 473K-TC384 4030011600 S.CERAMIC C1608 JB 1E 104K-TC385 4030009910 S.CERAMIC C1608 CH 1H 040B-TC386 4030017480 S.CERAMIC C1608 JB 1A 474K-TC387 4010005490 CERAMIC HM60SJ CH 120J 500V [50W]C388 4010005490 CERAMIC HM60SJ CH 120J 500V [50W]C389 4010005790 CERAMIC HM60SJ YB 102K 500V [50W]C500 4030006860 S.CERAMIC C1608 JB 1H 102K-TC501 4030006860 S.CERAMIC C1608 JB 1H 102K-TC502 4030006860 S.CERAMIC C1608 JB 1H 102K-TC503 4030007090 S.CERAMIC C1608 CH 1H 470J-TC504 4030006860 S.CERAMIC C1608 JB 1H 102K-TC509 4030007010 S.CERAMIC C1608 CH 1H 100D-TC510 4030011770 S.CERAMIC C1608 CH 1H 060B-TC511 4030006860 S.CERAMIC C1608 JB 1H 102K-TC512 4030006860 S.CERAMIC C1608 JB 1H 102K-TC513 4030006860 S.CERAMIC C1608 JB 1H 102K-TC514 4030011600 S.CERAMIC C1608 JB 1E 104K-TC515 4550006150 S.TANTALUM ECST1CY105RC516 4550006700 S.TANTALUM ECST1AY106RC518 4030006860 S.CERAMIC C1608 JB 1H 102K-TC519 4030017490 S.CERAMIC C1608 JB 1A 105K-T [25W]

4030006860 S.CERAMIC C1608 JB 1H 102K-T [50W]C520 4030009530 S.CERAMIC C1608 CH 1H 030B-TC522 4550006480 S.TANTALUM TEMSVA 1C 475M-8LC523 4550006480 S.TANTALUM TEMSVA 1C 475M-8LC524 4550006410 S.TANTALUM ECST1VY334RC525 4550006700 S.TANTALUM ECST1AY106RC526 4030011190 S.CERAMIC GRM31M2C2H270JV01L [50W]

J1 6510018430 S.CONNECTOR AXN330C038PJ2 6510023090 S.CONNECTOR 20FLT-SM1-TBJ4 6450000140 CONNECTOR HSJ0807-01-010J5 6510007080 CONNECTOR PI28A-02MJ6 6510019250 S.CONNECTOR B11B-ZR-SM3-TFJ8 6510021300 S.CONNECTOR 52365-1091J9 6510021300 S.CONNECTOR 52365-1091

W1 7120000470 JUMPER ERDS2T0W2 8900004540 CABLE OPC-453W3 7030003860 S.JUMPER ERJ3GE JPW VW4 7030003860 S.JUMPER ERJ3GE JPW VW5 7030003860 S.JUMPER ERJ3GE JPW V

EP1 6910013370 S.BEAD BLM18BB221SN1DEP2 0910055013 PCB B 5818CEP3 6910011560 BEAD HF70BB4.5X5X1.6EP4 6910010280 BEAD HF70BB9.5X10.4X4.9EP5 6910010280 BEAD HF70BB9.5X10.4X4.9

6 - 7

REF ORDER DESCRIPTIONNO. NO.

J4 6450000140 Connector HSJ0807-01-010 1

W2 8900004540 Cable OPC-453 1

MP1 8930045070 2055 M-plate 1MP2 8510009980 1705 VCO case 1MP3 8510010080 1705 VCO cover 1MP4 8510011460 2055 filter case 1MP5 8510011610 2055 filter cover (A) 1MP6 8930057900 2526 module holder assembly 1MP7 8930057730 Shield sponge (J) 1MP8 8930045390 Sponge (FL) 1MP12 8930056510 2055 shield plate 1MP13 8510005070 599 sheild plate 1MP14 8930057830 Shield sponge (L) 1MP15 8930046150 Rubber sheet (AK)-1 1MP16 8930058610 Insulate plate (HD) 1


7 - 1

[CHASSIS PARTS]

J1 6510004880 Connector MR-DS-E 01 1

SP1 2510001030 Speaker VS-57-0837A 1

WS1 8600036900 Cable FX2526 P01CH 1

MP1 8010018880 2526 chassis 1MP2 8010018902 2055 cover (A)-2 1MP3 8210018571 2526 front panel-1 1MP4 8930057090 2526 front key 1MP5 8610011180 Knob N292 1MP7 8930044761 2055 SP net-1 1MP8 8930044100 2055 SP plate 1MP9 8930027480 1126 TR-A clip 1MP11 8810008660 Screw PH BT M3 × 8 NI-ZU 15MP12 8810008760 Screw PH BT M2 × 8 NI-ZU 4MP13 8810009990 Screw PH BT M3 × 8 ZK 6MP14 8930057890 Non-woven sheet (CF) 1MP15 8930057940 Shield sponge (N) 2MP18 8930046770 Thermally sheet (G) [50W] only 1

[ACCESSORY PARTS]

F1 5210000120 Fuse FGB 15A [25W] 25210000080 Fuse FGB 20A [50W] 2

MC1 Optional product Microphone HM-100N 1

W1 Optional product Cable OPC-345 [25W] 1Optional product Cable OPC-346 [50W] 1

W2 Optional product Cable OPC-049 1

MP1 8010016380 1542 mobil bracket (B) 1MP3 8820000530 Flange volt M4 × 8 NI 4MP4 8810000470 Screw PH M5 × 12 (+–) 4MP5 8810005840 Screw PH A M5 × 20 4MP6 8850000150 Flat washer M5 NI BS 4MP7 8850000390 Springe washer M5 4MP8 8830000120 Nut M5 4MP9 6910004210 731 mic hanger set 1MP10 8310053310 Label 1705 LCD seal (D) 1

[FRONT UNIT]

R12 7210003020 Variable resistor EVU-F2KFK1 1

J1 6450002210 Connector 3017-8821 1

DS12 5030002230 LCD L1-0483TAT 1

W1 8900010950 Cable OPC-1126 1

EP2 8930057820 LCD contact SRCN-2526-SP-N-W 1

MP1 8210018630 2526 reflector 1MP2 8930057150 2526 LCD holder 1MP3 8930057140 2526 earth plate 2MP4 8930057650 2526 LCD filter 1

[MAIN UNIT]

Screw abbreviations BT: Self-tapping PH: Pan headZK: Black BS: BrassNI: Nickel NI-ZU: Nickel-Zinc

MC1

MP1

MP9W2

W1

MP3

MP4

MP5

MP6 MP7 MP8 F1

ICOM

ORDERNO.

REF.NO. DESCRIPTION QTY.

ORDERNO.


ORDERNO.


ORDERNO.


7 - 2

MP3 (C)

MP5 (C)

MP4 (C)

MP2 (F)

DS12 (F)

EP2 (F)

MP1 (F)

MP3 (F)

MP4 (F) FRONT UNIT

W1 (F)

J1 (F)

MP12 (C)

MP1 (C)

MP13 (C)

MP18 (C)MP11 (C)

MP5 (M)

MP2 (M)

MP3 (M)

MP11 (C)

MP6 (M)

MP13 (C)

MP9 (C) MP8 (M)

W2 (M)

J4 (M)

MP15 (M)

MP1 (M)

MAIN UNIT

MP4 (M)

MP13 (M)

MP11 (C)

J1 (C)

MP7 (C)

SP1 (C)

MP8 (C)

MP11 (C)

Unit abbreviations (F): FRONT UNIT(M): MAIN UNIT(C): CHASSIS PARTS

MP2 (C)WS1 (C)

MP14 (C)

R12 (F)

MP12 (M)

MP7 (M)

MP15 (C)MP14 (M)

MP16 (M)

8 - 1


• TRANSSISTORS AND FET’S • DIODES

G1

G2

S

D

G1

G2

S

D

B

E

C

B

C

E

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

C

E

D

G

S

G

G

D

D

S

S

S

D

G

G

S

D

B

E

C

B

E

C

B

E

C

B

E

C

E1

B1

B2

C1

C2

E1

E2

B

C1

C2

E1

E2

B

C1

C2

E1

E2

B2

C1

B1

C2

2SA1576A T106 R 2SB1132 T100 R 2SC3585 T1B R44 2SC4081 T106 R 2SC4116 BL

2SC4213 B 2SC4215 O 2SC4226 T1 R25 2SC5107 O 2SD1664 T100Q

2SJ144 GR 2SJ377 2SK880 Y 2SK1829 3SK272

3SK293 DTA144EUA T106 DTC114TUA T106 DTC144EUA T106 DTC363 EK

XP1214 XP2401 XP2501 XP6501 AB

(Symbol: FR) (Symbol: BAR) (Symbol: R44) (Symbol: BR) (Symbol: LL)

(Symbol: AB) (Symbol: QO) (Symbol: R25) (Symbol: MFO) (Symbol: DAQ)

(Symbol: VG) (Symbol: 4L) (Symbol: XY) (Symbol: K1) (Symbol: K)

(Symbol: UF) (Symbol: 16) (Symbol: 04) (Symbol: 26) (Symbol: H27)

(Symbol: 9H) (Symbol: 7R) (Symbol: 5W) (Symbol: 5N)

A C

C

A1

A2

C

A1

A2

A C A C A C

A C

red dot

A C A C

Black line

A C

1SS375-TL 1SV245 1SV252 DA204 K T146 DA221 TL

DAN202 K T146 DAN222TL HVC350B HVC362 MA2S111

MA2S728 MA4PH224 MA77 RB706F-40 T106 UM9401F

(Symbol: FH) (Symbol: T3) (Symbol: BE) (Symbol: K) (Symbol: K)

(Symbol: N) (Symbol: N) (Symbol: B0) (Symbol: V2) (Symbol: A)

(Symbol: B) (Symbol: None) (Symbol: 4B) (Symbol: 3J) (Symbol: None)


9-1 FRONT UNIT• TOP VIEW

9 - 1

8V

2 8

tomicrophone

1 7

J1

AF

OM

ICE

GN

D

CLO

PT

TM

ICC

LI

1to MAIN unit J2

19

2 20

J2

GN

DP

WR

LIN

HLC

SLC

KLS

OA

FV

IC

LIG

ND

MIC

8V 5V KR

0K

R1

KR

2F

SW

HO

RN

CLO

PT

TA

FO

1

16

48

33

32 17

49 64

9 - 2

• BOTTOM VIEW (FRONT UNIT)

1

4

8

5

1

4

8

5

1 12

24 13

1

6

7

12 13

18

19

24

1

8

16

9

14

85

19

to FRONTunit J2

1

20 2J2

GN

DP

WR

LIN

HLC

SLC

KLS

OA

FV

IC

LIG

ND

MIC

8V 5V KR

0K

R1

KR

2F

SW

HO

RN

CLO

PT

TA

FO

GN

D

30 16

1 15J1

5V VC

CM

MU

TA

FO

NB

EP

OR

MU

TD

ET

DIS

CR

EM

CC

SC

IRQ

SO SI

SC

K

PT

TI

PT

TOM

CO

TM

CIN

AU

XB

US

YM

DW

NS

IGO

PT

1O

PT

2O

PT

3G

ND

OP

V3

OP

V2

OP

V1

to optional unit

PTT11

to optionalcable OPC-617

1

J6

GNDIN

GNDDISCGNDAFOGND

HORNDIMVCC

PG

O2

9 1

10 2J8

PG

I3P

GI1

NR

XD

8V

GN

DP

GO

1P

GI2

IGS

WN

TX

D

10 2

9 1

J9

VC

CM

D1

XC

TS

XR

XD

5V

GN

DG

ND

RE

SX

RT

SX

TX

D

SP- 21

to speaker

J5

SP+

ANT

J1

W1

GND

to DC cable

HV

9-2 MAIN UNIT• TOP VIEW

9 - 3

1

4

8

1

7

14

8

5

12

11 1

1

7

14

823 33

22

44

34

1

25

26

5051

75

76

100

9 - 4

• BOTTOM VIEW (MAIN UNIT)


DIMDIM

HORNOHORN

DISC DET

PTT

IN

ACC EPTT

SWLINE MOD

VCC

PWR

SWPOWER HV

19.66 MHz

HN58X24128FPI

CR-520X4

MA77D27

EEPROM

SW

IC23FRONT UNIT

AF VR

PWR

DN*2

UP*2

P0-P4

AFVI

POSW

ESDAESCL

KR0-KR2KEY MATRIX

OPC-453W2

IC24S-80942ANMP-DD6

CSFT

RESRESET

SHIFTDTC144EUQ242SJ377Q23

CPU5

AN78L05MIC10

Q38

REM

DTC144EU

CENC2TENC

DUSESWFIL

IC9 TA7808F

Q29 DTC144EU

8V

T8V

R8VTXC

TMUT

+8REG

Q25 2SD1664

Q26 2SD1664

REGT8

REGR8

E

D

F2SJ144Q31

SIGSIGOUT

J6

PROGIO

MD1RESXRTSXCTS

IGSWPGO1, 2PGI1-3

XRXDXTXD

USB232CMAP27FLAH

J9

NRXD

J8NTXD

GPS

DTC144EUQ42

DTC144EUQ46, Q47Q44, Q45

SIGOUT

AFONO

REM

BEPO

MCOTMCIN

PTTOPTTI

SCK

BUSY

OPV3 (AFCL)OPV2 (AMSK)OPV1 (APST)

J1

OPT3OPT2OPT1

CCS

MMUT

RMUT

SOSI

CIRQ

UNITOPTION

AFCLARDTARTMSO

APST

ADIN

ATRDSOSCKDAST

SCK

AMSK

Q30 DTC144EU

5V

DDSODDAC DDST

DEC

LPF

LPF

+5REG

DTMF

2SC4116

(J1)3.58 MHzCR-563IC14 X3

TC35453F

Q28 XP6501Q27 2SB1132

MCINCOMPANDER

REG+5

TONE SENC

Q37

2SC4116Q36

(J1)MCOT

2SC4116 CENC1CENC0

IC20

HD64F2268TF

DSDASCK

CPU

LINH, LCS, LCK, LSO

FSWHORN

LC75824W

COM1-4SEG1-40

KS0-KS2

IC1

LCD DRIVER Q2, Q3 DTC144EU

DIM2DIM1

8VDS7-DS11

DS1-DS6

8V

Q1, Q4 DTA144EU

SML-311YT

SML-311YT

SWLED

AFOMIC MIC JACK

PTT

J1

CLO CLI

C

PTTO (J1)

PTTI (J1)DS12

LCD

MICI

D35 MA2S111

NJM12902VIC21

D31 DAN202K

M62334FPIC7

TONECTCSSIG

TC4W53FUIC15

PM/FM AMP

D/A

A

DEREXPAN

Q21

DEMODMSK

HPF AMP AMP

LPF

AMP

LPF

MODMSK

NJM12902V

CTCS

MICO

IC6

IC21

HPF AMP LPF

HPF

AMP LPF HPF BUFF

LIMITAMP

BPF

M62364FP

SSORCOMPRE

D/A

REF

DUSE

TENC

MICI

B

DIS

C

BAL

MOD

TC4S66FIC22

XP1214Q35

SWFIL

CDECNJM12904V

IC5

NJM12902VIC21

SDEC

SWFIL

RATIONRESTO-

450 kHz

NOIS

CDBC450CX24X1

Q6 DTA144EUQ5 2SC4116

NWCSWW/N

DE

T ALFYM450F=K [N/W]CFWM450G [N/M]

FI2

RSSI

SQ

IN

SQL AMPDETECTOR

2SC4213Q20

FSWSWFIL

TONEBEEPOBEEP

NJM12902VIC21

W/N

DTC144EUQ22

MIXER

SWNWC

T4

M62364FPIC6

Q40 DTC144EUQ39 DTC363EK

TA75S01FIC18

AFONO

AFON

Q23SK293

T2T3

HG

LA4425AIC8

T1

J4

SP-

SP+INT SP

MA2S728D32

TMUTSW

MUTE

DETPWR

D8 HVC350B

TC75S51FIC2

T4

D4 HVC350B

Q12SK1829

RSSI

D10 HVC350B D9 HVC350B

RX LO182.35-220.35 MHz

46.35 MHz

Q33SK272

Q12

Q4FL-335FI1

2SC4215

2SC4226Q14

2SC5107

PUMPCHARGE

FILTERLOOP

1SV245

HVC350BD17, D53-D55

D18

IC1TA31136FN (D)

TX VCO

MOD

LPF

AMP

BUFF

BUFF BUFF

ATT

BPF BPF

D/A AMP

BPF

PWRAMP

BPF

AFMUTE

AFAMP

TX/RXSW

YGRAMP

PREDRIVE LPF

GATECTRL

RFAMP

ATT LPF LPF LPFANTSW

APCAMP

XTALBPF

CERAMICBPF

IF AMPSECOND MIXER

FSW2

DET

LPF

LPF

REFAMP

x3 UNLKSCKSOPLST

Q342SC411645.9 MHz

15.3 MHz

FRACTIONAL N

MOD

BPF

TC75S51FIC11

BALTB31256FL Q55 XP2501

Q54 XP2401Q51 2SA1576Q50 2SC4081

CR-664AX2 IC4

PLLIC

LVIN

Q53 2SC4116Q52 2SC4116

ACTIVE

HVC350BD16, D50-D52

8V2SK880Q18

2SC4116Q17

RIPPLEFIL

BUFF

RX VCO

TXC

Q11

Q16

Q10

2SC4226Q13

XP1214Q15DTC144EU

2SC5107 2SC5107

SWVCO

D14, D15MA77 2SC5107

Q92SC3585

MAIN UNIT

1SV252D72 RA30H1317 [25W]

RA60H1317M [50W]

IC3Q8

1SS375

D2 UM9401F [25W]

D6 MA77D5 MA4PH224 D1, D11

136-174 MHz

DATA BUS LINE

CONTROL LINE

RX LINE

TX LINE

COMMON LINE

Explanatory notes

10 - 1


5V

8V

5V

5V

GND

to MAINunit J2

AFO

HORNFSW

MIC

CLIGNDPTT

CLOAFVILSOLCKLCSLINH

KR2KR1KR0

PWR5V8V

8V

AFVI

CLI (HANG)

CLO

GNDMICMICEPTTAFO

CLI

8V

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

SE

G37

SE

G36

SE

G35

SE

G34

SE

G33

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

SE

G1

CO

M1

SE

G3

SE

G2

CO

M2

CO

M3

CO

M4

KS2KS1

KR2

5V

MIC

PTT

PW

R

8V

CLI

CLO MIC

PW

R

AF

VI

HORNFSW

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

SE

G37

SE

G36

SE

G35

SE

G34

SE

G33

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

SE

G3

SE

G2

SE

G1

CO

M1

HO

RN

FS

W

KS0

AF

O

CO

M4

CO

M3

CO

M2

DIM2

CLI

CLOAFO

LIN

H

LCS

LCK

LSO

AF

VI

KR

0

KR

1

KR

2

PT

T

KS1

LCS

LCK

LSO

LIN

H

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

KS0

KS2DIM1DIM2

SEG1SEG2SEG3SEG4SEG5

SE

G6

SE

G7

SE

G8

SE

G9

SE

G10

SE

G11

SE

G12

SE

G13

SE

G14

SE

G15

SE

G16

SE

G17

SE

G18

SE

G19

SE

G20

SE

G21

SEG34SEG33SEG32SEG31SEG30SEG29SEG28SEG27SEG26SEG25SEG24SEG23SEG22

SEG35SEG36SEG37

KR1KR0

DIM1

D5

D6

MA2S111

MA2S111

MA2S111D4

0.22C37

47k

R25

5

43

2

1

IC2TC75S51F

2.2kR24

10k

R23

10k

R22

1MR21

4.7kR20

4.7

C39 0.

001

C41

0.01 C40

R81k

10kR19

10kR18

10kR17

R12

EV

U-

F2K

FK

1B14

1kR9

1kR16

48C

OM

4

47C

OM

3

46C

OM

2

45C

OM

1

44S

EG

40

43S

EG

39

42S

EG

38

41S

EG

37

40S

EG

36

39S

EG

35

38S

EG

34

37S

EG

33

36S

EG

32

35S

EG

31

34S

EG

30

33S

EG

29

32S

EG

28

31S

EG

27

30S

EG

26

29S

EG

25

28S

EG

24

27S

EG

23

26S

EG

22

25S

EG

21

24S

EG

20

23S

EG

19

22S

EG

18

21S

EG

17

20S

EG

16

19S

EG

15

18S

EG

14

17S

EG

13

16S

EG

12

15S

EG

11

14S

EG

10

13S

EG

9

12S

EG

8

11S

EG

7

10S

EG

6

9S

EG

5

8S

EG

4

7S

EG

3

6S

EG

2

5S

EG

1

4C

OM

1

3C

OM

2

2C

OM

3

1C

OM

4

DS12

FRONT UNIT

L1-0483TAT

100kR14

RB706F-40D1

100kR11

100kR10

DTA144EUQ4

SML-311YT

DS11

DS1-DS11

DTC144EUQ3

DTC144EUQ2

J2

100p

C33

270kR13

DI

64C

L63

CE

62IN

H61

OS

C60

VS

S59

VD

D2

58V

DD

157

VD

D56

CO

M4

55C

OM

354

CO

M2

53C

OM

152

S51

51S

5050

S49

49

S4848 S4747 S4646 S4545 S4444 S4343 S4242 S4141 S4040 S3939 S3838 S3737 S3636 S3535 S3434 S3333

S32

32

S31

31

S30

30

S29

29

S28

28

S27

27

S26

26

S25

25

S24

24

S23

23

S22

22

S21

21

S20

20

S19

19

S18

18

S17

17

S16 16

S15 15

S14 14

S13 13

P12/S12 12

P11/S11 11

P10/S10 10

P9/S9 9

P8/S8 8

P7/S7 7

P6/S6 6

P5/S5 5

P4/S4 4

P3/S3 3

P2/S2 2

P1/S1 1

IC1LC75824W

0.1

C32

0.1

C31 0.1

C30

S4

47p

C29

47p

C28

47p

C27

47p

C26

47p

C25

47p

C24

47p

C34

S10

P4

S9

P3

S8

P2

S6

P1

S5

P0

S7

V

V

S3S2

S1

PWR

DTA144EUQ1

390

R7

1kR6

4.7kR5

390R4

390R3

DS10

DS9

DS8

DS7

DS6

DS5

DS4

DS3

DS2

DS1

RB706F-40D3

RB706F-40D2

47p

C23

47p

C22

47p

C21

47p

C20

0.00

1C

19

47p

C18

1µL1

1kR2

1kR1

J1

tomicjack

47pC1

C17

4

7p

C16

4

7p

C15

4

7p

C14

4

7p

C13

4

7p

C12

4

7p

C11

4

7p

C10

4

7p

C2

47

p

C3

47

p

C4

4

7p

C5

47

p

C6

47

p

C7

47

p

C8

47

p

C9

47

p

C35

4

7p

TX: 5.0VRX: 0V

2.2V

ON: 7.6VDIM: 6.1VOFF: 0V

11 - 1

MAINUNIT(2)J1

toMICJACK

J2

GND

PWR

LINH

LCS

LCK

LSO

AFVI

CLI

GND

MIC

8V

5V

KR0

KR1

KR2

FSW

HORN

CLO

PTT

AFO

8VCL0AFOPTT

FRONT UNITJ2

J1

PTTI

PTTO

MCOT

MCIN

AUX

BUSY

MDWN

SIG

OPT1

OPT2

OPT3

GND

OPV3

OPV2

OPV1

GND

5V

VCC

MMUT

AFON

BEPO

RMUT

DET

DISC

REM

CCS

CIRQ

SO

SI

SCK

toOptionalunit

BUS LINE1

R138 47k

R139 47k

R140 47k

8V5V

R17

8

3

30k

R51

610

0k

R17

7

3

30k

R17

6

3

30k

R17

5

1

MR

174

1M

R17

3

1

M

R14

110

0k

R14

210

0k

C23

7

47p

CP4

APSTSI

AMSKSO

AFCL

CCSOPT3

OPT2DISCOPT1

DETSIGOUT

RMUT

BEPOBUSY

AFONO

FSW2SCKSOPLST

UNLK

5V

MMUTMCIN

MCOT

PTTO

AFOMICPTTGNDCLO

RESXCTSGNDMDIGNDVCC

XRXDXRTS5VXTXD

PGI2PGI1PGO1PGI3GNDPGO2

NRXDIGSW8VNTXD

CLIHORNAFVIFSWLSOKR2LCKKR1LCSKR0LINH5VPWR8VGND

BUS LINE2

R29

61k

R29

51k

10kR109

R29

31k

R29

41k

C20

70.

1

R316100k

CP1

0

MICIAFO

R2841k

R14

410

0k

C21

9

4

7p

C22

8

4

7pC

227

47p

C22

0

4

7pC

217

47p

C22

9

4

7pC

199

47p

C23

1

4

7p

C22

4

4

7pC

206

47p

C35

3

4

7pC

204

47p

C23

5

4

7pC

354

47p

C21

4

4

7p

C20

9

4

7p

R14

510

0k

POSWLINHLCS

LSCKKR0KR1KR2FSW

LSOAFVI

CLIHANG

HORNOCLO

13

5

2

4

R1084.7C523

56kBAL R30

610

0 C3630.1

R53

4

D70 10

0k

MA2

S111

C16

20.

01

IC11TC75S51F

IC26S-81230SG

IC4TB31256FL

R3081M

C16310

REF

R10747k

D21

HVC

362

C161100p

C16

09p

X2CR-664A

R10

682

k

R11

047

Q192SC4215

Q502SC4081

Q512SA1576

Q55XP2501

Q54XP2401

Q52

Q53

2SC4116

2SC4116

R10

547

kD

20M

A2S1

11

C15

710

0pC

158

100p

R10

4

R32

21 2.

2kR

530

R52

71.

5k

R52

6

1.2k

R209NTCG20

C20

30.

1

R21

010

0k

TEM

P

C15647p

C15

90.

1

LVIN

R10

11k

C14

30.

001

Q182SK880

R10

0

1kR524

R96330

3 2 1

1 2 3

4 5

5 4

6.8k

C14

10.

001

CP1

R91

33k

C13

20.

001

R89

R92

100k

10k

R951 1C147 C515

22k

R97

1kR

507

6.8k

C14

60.

110C51

6

56k

R5364.7k

4.7R307C522

FSW2CLKDATASTBLDFSW1

VCC

-PLL

2FI

N2

GN

DN

CSW

2C

P2

VCC

-PLL

1FI

N1

GN

DN

CSW

1C

P1

BS219

18 17 16 15 14 13

1 2 3 4 5 6

2021222324

121110987

VCC-XINTCXOGNDGNDBS1

R53

54.

7k

R51

947

k

C35

847

p

R90100k

MO

D

R29

110

0kR

504

100k

C35

01

R292

8V5VVCC

220k

C14547p

8V5V

D19

MA2

S111

C14

810

R98

2.2k

Q172SC4116

R93

10R

9410

L27

1.8µL29

0.47µ

C51

0

D51

D52

D16

D50

C123100p

C12

133

pC

122

33p

W3

R84

22p 67nC124 L25

C127270p

67n

44nL26

L50

C12

812

p

D54

D55

HVC

350B

HVC

350B

HVC

350B

HVC

350B

HVC

350B

HVC

350B

HVC

350B

HVC

350B

D53 D

181S

V245

D17 67n

L51

3.9kR831.8k

Q132SC4226

L24

3.3µ

C11

90.

01 C12

047

0p

C13

90.

1EP1

L280.47µ

C12668p

C11

418

p

C12

91p

C11

533

p

W4

R853.9k

R791.8k

L23

3.3 µ

C11

747

0p

C11

60.

001

R781k

R80560 [N/W]820 [N/M]

C29

912

pC

298

C50

910

p12

p

L32

33n

Q15XP1214

5

4

1

2

3

C1180.75p

C1130.5p

R77

10k

Q16DTC144EU

C11

147

p

C11

047

0p

R76

47

56 0.001

C10

40.

001

R74

L52

68n

10k

Q112SC5107

R73

100

R5251k

R10

2R

521

R52

2R

523

4.7k

1.2k

4.7k

4.7k

R52

0N

TCG

16

L55

0.1µ

Q122SC5107

R75

10k

C10

50.

001

C1038p

C10210p

R71470

C30

10.

001

R23

48.

2k

Q102SC5107

R70

100

L21

0.15

µ

C10

90.

001

C10018p

D14MA77

C1080.01

R68

1k

R67

10k

C9815p

R66

3.9k

C99

0.00

1

Q92SC5107

R65

100

C10

70.

001

L20

0.15

µ

C10

1

R64

470[

50W

]

0.00

1

C9322p[25W]6p[50W]

C96

0.00

1

C97

47p

L19

0.12

µR

6110

0

Q82SC3538

C10

647

p

C928p

R50

06p 1.2k

20p

C13

320

pC

134

C90

12p

C89

12p[

25W

]15

p[50

W]

L18

D721SV252

DA204KD68

D11 D11SS375 1SS375

DAN222D71

47n[25W]82n[50W]

IN VCC

1VC

C2

OU

T6 5

4 3 2 1

IC3RA30H1317[25W]RA60H1317M[50W]

0.33

C52

4

2.2

C36

5

C87

0.00

1

C86

L37

1µ

47p

C83

20p[

25W

]

C84

47p

C85

0.00

1

C91

22

L16LA-253

C82

20p[

25W

]

FI4NFM60R-20T152

FI3NFM60R-20T152

FI5NFM60R-20T152[50W]

R9

220

R8

220

L5 LW-2

5C

1247

0p

C13

47p

D2UM9401F[25W]

D3XB15A407[50W]

L4 44n

C15

33p

T8V

R69

4.7k

R50

33.

9k

D15MA77R

5010

kR

235

1k C30

30.

001

C30

210

p

R8VANT

C30410p

Q342SC4116

R23

768

0k

L35

0.22

µ

R23

61.

2kC

309

0.01

C30

556

pC3064p

C30

77p L3

30.

82µ

R63

12k[

25W

]2.

2k[5

0W]

R50

1

680

C95

0.00

1

C94

47p

0.00

1

R54

1

C88

C50

1

56 0.00

1

R50

2

C50

2

150

0.00

1

R50

9

R50

86.

8k

C51

1

470

0.00

1

1.2k

R51

3

R51

26.

8k

C51

30.

001

R51

1

R51

0

C51

2

470

8.2k

0.00

1

TXC

T8V

T8V

R8V

5V ANT

HV

R8V5V

R8VT8V

12345678 9

10111213141516

OSCINOSCOUTMIXOUTVCCIFINDECFILOUTFILIN

MIXINGND

N-RECN-DET

RSSIIFOUTQUAD

AFOUT

IC1TA31136FN

123

45

GND

3V

VINVOUT

NCNC

R4456k C

7039

0p

C71

0.1

C69

390pC371

0.01

R51

527

0 R4515k R

4656

0

R47

3.3k

O I

FI2ALFYM450F=K [N/W]CFWM450G [N/M]

C30

83p

5V

R39

47

C67

0.00

1

C75

10

SQIN

R38

100k

NO

IS

R36

3.9k

X1

CD

BC45

0CX2

4

C61100p

C6282p

C3480.001

C65

0.00

1

RSS

IC64

470p

C66

0.00

1

Q52SC4116

R41

47k

R4247k

C72

0.1Q6

DTA144EU

C9

18p

C8

33p

C52

627

p[50

W]

C7

56p[

25W

]27

p[50

W]

C6

33p]

C140.001[25W]

C3890.001[50W]

L3LA-253

L2LA-243

C5

470p C

430

p

R3

47 C3

470p C2

10p

C1

10p

L1LA-253

R1

10k

R53

71.

5k[2

5W]

680[

50W

]

2.2k

[25W

]4.

7k[5

0W]

1.5k

10 R53

8

R54

0

R53

9

C52

5

100k

R7

270

R4

270

R35

1k

R8V

T8V

R8V

SQIN

R29

047

0

C60

0.00

1

R34

120k

C580.001

R33150

Q42SC4215

FI1FL-335

C56

22p

R32

1L1

31µ C52

12p

R31

100

R30

1k

R29

470

C50

0.00

1

C48

47p

C54

0.00

1

8pC55

0.00

1C

51

C53

0.01

Q33SK272

R25

47k

C45

220p

D10

HVC

350B

C44

2p L11

68n

R23

150k

R2410k

C47

0.00

1

C46

0.00

1

12R28C49

8p

L12

0.1µ

470

470

R27

R26

C38

0.00

1

R28

91

C37

0.00

1

R20

100

L9 1.8µ

T4

C39

0.00

1D

9H

VC35

0B

R21

220k

C42

0.00

1

R2210k

C43

0.00

1

T3

Q23SK293

C32

0.00

1C

520

3pL54

56n

C50

347

p

R16

270

R15

390k

L8 56n

C35

0.00

1

R19

100k

R18

22k

R20

84.

7

C59

0.1

C34

0.00

1R

104.

7k

Q12SK1829

C3022p

C29

5pC

280.

001

R1410k

C27

0.00

1

R13

100k

D4

HVC

350B

C26

0.00

1

T2

RSS

I

R206470k

R20

710

k

D25

MA2

S111

C221.5p

L7 60n

C21

0.5p

C23

0.00

1R1210kC

240.

001

R11

100k

D8

HVC

350B

C20

0.00

1

T1

L31

56n

C18

6pD

6

D7

MA

2S72

8

MA7

7

D5

MA4

PH22

4

C17

10p[

25W

]5p

[50W

]

C19 0.001L644n

C81

0.00

1

R58100[25W]47[50W]

C77

0.00

1

0.00

1

0.00

1

0.00

1

C11 C50

0

C10

100[25W]10k[50W]

100[25W]10k[50W]

R6

R5

R53

1C

760.

01

42

31

5

R56150k

C790.22

D32MA2S728

C37

91

IC2

Q57DTC114TU[25W]2SC4116[50W]

TC75S51F

R59

120k

[25W

]

R54

310

0k[5

0W]

C80

0.1

R5215k

R5471[25W]18k[50W]

D56MA2S111

T4

R5710k

15k[25W]R529

C780.001

R5410k

C3347p

TMU

T

R554.7k

C31

347

p[25

W]

1[25

W]

0.00

1[50

W]

C51

9

R2

FWD

REV

47

R43470

REM

DET

NW

C

NWC

VCCVCC

C23

6

47p

C15

2

R3231

C15

3C

154

C15

1

47p

47p

47p

47p

0.04

7

47p

C38

2

C15

5

C24

7

0.0

01C

239

0

.001

C23

8

0.0

01

C21

5

47p

J9

J8

XTXD

XRXD

XRTS

XCTS

RES

MD

1

R155100k

NTXDNRXD

R15

110

0k

R15

210

0k

Q44DTC144EU IGSW

D63DAN202K PGI1

D67DAN202K

PGI2

R15

310

0k

PGI3

R158 10kR157 10k

PGO1PGO2

SCK

CIRQ

D34

MA2

S111

C14

2

D69

MA2

S728

D61

D60

D59

D58

MA2

S728

MA2

S728

MA2

S728

MA2

S728

0.00

1

C74

0.1

C413.5p

C401.5p 4p

C385

EP3

C38

812

p[50

W]

C38

712

p[50

W]

R86120k

MICEMICGNDCLI

MAIN UNIT (1)

C20

5

4

7p

R143100k

R154100k

Q42DTC144EU

D65DAN202K

C31

40.

01C

381

0.1

C13

0

4.7k

0.00

15

C51

40.

1

C14

00.

1

1.8k

R528 C518

R103

C297 22p

Q142SC4226

R401.5k

C63

0.00

1R

373.

3k

C256p

C38

022

R54

6PT

H9C

32[5

0W]

R54

415

0k[5

0W]

0.8Vp-p(15.3MHz)

5.0V7.0V

TX:4.3VRX:0V

TX:4.3VRX:0V

TX:0VRX:5.0V

800mVrms

6.9V

LOCK:5.0VUNLOCK:0V

6.6V

7.4V

TX:1.2VRX:1.2V

6.5V

TX:0VRX:2.9V

TX:2.9VRX:0V

TX:2.2VRX:3.1V

TX:0VRX:3.3V

TX:6.5VRX:0V

TX:6.4VRX:0V

3.0V

WIDE:0VNAR:5.0V

4.9V

4.9V

1.0V

TX:0VRX:5.4V

TX:3.3VRX:1.9V

TX:0VRX:7.7V

TX:0VRX:1.2V

Lo Level:1-6dBm

MEASUREMENT CONDITIONS VOLTMETER Amplitude(Oscilloscope):100MHz Frequency:155MHz Transmission:25W

TX:0VRX:7.9V

TX:0VRX:4.6V

TX:0VRX:7.9V

TX:0VRX:6.3V

TX:3.7VRX:0V

TX:3.6VRX:0V

TX:0VRX:5.0V

TX:3.3VRX:0V

11 - 2

12345678910111213141516171819202122232425

26272829303132333435363738394041424344454647484950

51525354555657585960616263646566676869707172737475

76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 9910

0

MAINUNIT(1)

IC20HD64F2268TF

PM6/SEG31PM5/SEG30PM4/SEG29PM3/SEG28PM2/SEG27PM1/SEG26PM0/SEG25PL7/SEG24PL6/SEG23PL5/SEG22PL4/SEG21

CVCCPL3/SEG20

PL2/SEG19PL1/SEG18PL0/SEG17PK7/SEG16PK6/SEG15PK5/SEG14PK4/SEG13PK3/SEG12PK2/SEG11PK1/SEG10PK0/SEG9

VSS

PJ7/

WKP

7/SE

G8

PJ6/

WKP

6/SE

G7

PJ5/

WKP

5/SE

G6

PJ4/

WKP

4/SE

G5

PJ3/

WKP

3/SE

G4

PJ2/

WKP

2/SE

G3

PJ1/

WKP

1/SE

G2

PJ0/

WKP

0/SE

G1

P10/

TIO

CA0

P11/

TIO

CB0

P12/

TIO

CC

0/TC

LKA

P13/

TIO

CD

0/TC

LKB

P14/

TIO

CA1

/IRQ

0P1

5/TI

OC

B1/T

CLK

CP1

6/TI

OC

A2/IR

Q1

P17/

TIO

CB2

/TC

LKD

AVSS

P97/

AN9/

DA1

P96/

AN8/

DA0

P47/

AN7

P46/

AN6

P45/

AN5

P44/

AN4

P43/

AN3

P42/

AN2

P41/AN1P40/AN0VREFAVCCPH7/TONED/TMCI4MD1OSC2OSC1RESNMISTBYVCCXTALVSSEXTALFWEMD2P77/TXD2P76/RXD2P75/TMO3/SCK2P74/TMO2P73/TMO1P72/TMO0

P71/TMRI23/TMCI23P70/TMRI01/TMCI01

P30/

TXD

0P3

1/R

XD0

P32/

SCK0

/SD

A1/IR

Q4

P33/

TXD

1/SC

L1P3

4/R

XD1/

SDA0

P35/

SCK1

/SC

L0/IR

Q5

PF3/

ADTR

G/IR

Q3

C2

C1

V3

V2

V1

PH3/

CO

M4

PH2/

CO

M3

PH1/

CO

M2

PH0/

CO

M1

PN7/

SEG

40PN

6/SE

G39

PN5/

SEG

38PN

4/SE

G37

PN3/

SEG

36PN

2/SE

G35

PN1/

SEG

34PN

0/SE

G33

PM7/

SEG

32

BUS LINE18V5V

BUS LINE2

T8VR8VANT

1234567891011

1213141516171819202122

23 24 25 26 27 28 29 30 31 32 33

3435363738394041424344

RXF

OR

XGS

RXI

NM

SKG

SM

SKIN

TXO

UT

IDC

GS

IOC

INTX

FOAG

ND

CST

MICINMICGSCALOALCOCMPINCCHGCMPOTXFIVDDAVDDDSTB

DIN

DC

KR

EGS1

REG

S2XO

UT

XIN

MSK

ETR

DR

TMR

DT

FCLR

VSSDVSSA

MSKSTPWROPPWRONPWRGSPWRINEXPOECHG

EXPGSEXPIN

IC14TC35453F

DET

DISC

CP2

R11122k

C16

40.

001

C1650.001

C1660.001

R11

339

0k

R28

54.

7k

SDEC

R24

110

0kR

320

3.3k

R31947k

R24239k

C316820p

R24382k

C31

782

0p

R24

518

0kC

318

0.1

-+

910

8

IC21cNJM12902V

R244390k

R2461.5k

C31

90.

047

R23

310

0k

R12

010

0k

Q202SC4213

R11

868

k

R11

918

0k

R11

512

k

C1670.027

C1680.039

C1690.039

R1161.5k

+-

56

7

IC21bNJM12902V

R1175.6k

C1700.033

C17

10.

0047

MC

OT

MC

IN

CP3

C1870.0022

C1860.0022

C1880.1

R12

210

k

Q212SC4116

R12

110

k

C18

50.

1

R12

34.

7k

R12

522

k

R12

433

k

C189 0.1

C17

64.

7

R230 10k R129 470kC19047p

R130 27k R131 68k

C180 0.1

C174 0.1

C181 0.1

R12722k

C36

10.

0012

R12622k

APST

5V

X3CR-563

C17

715

p

C17

818

p

ADIN

SCK

ADIN

AMSK

ATR

D

SO

AFC

L

R13

71k

ARTM

ARD

T

C193 0.1

R136 1k

C195 0.1

C194120p

R135100k

R134150k

R133220k

C1920.0047

C19

10.

039R132

47k

C1960.01

8765

1234

VCCWPSCLSDA

A0A1A2

VSS

IC23HN58X24128FPI

ESD

AES

CL

R282100k

R281 10k

C34

30.

11234567 8

91011121314

IC19LC73872M

INPUTNCPDOSCOOSCINCVSS LOADB

SDACKSTDESTNC

VDDMICI

FSW

C31

10.

1

C18

20.

1

DD

AC

R23

810

0k

R22

110

0k

DD

ST

DD

SD

123456789

101112 13

1415161718192021222324

VIN1VOUT1VOUT2VIN2VDDLDCLKDIVIN3VOUT3VOUT4VIN4 VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

IC6M62364FP

R216 33k

W5R215 3.9k

BEPO

R21827k

C3600.1

BEEP

DAST

C1830.047

SCKSOMICI

R14

610

0k

CTCSTENC

C28

40.

01

R22033k

C2830.001

R2311k

DET

SQIN

MOD

REF

5

4

123

CD

NC

OUTVDDVSSC

344

0.02

7

IC24S-80942ANMP-DD6

TEMPAFVI

EPTT

RES

CLOCLICSFTDUSE

XCTSXRTS

5V

R28810k

MD1

R29

910

0k

PWR

PWON

D28DAN202K

BAL

15

3

2

IC25TC4S66F4

Q49DTC144EU

Q56DTC144EU

R31

710

0k

C37

70.

1R

324

68k

C38

40.

1

Q41DTA144EU

PA

R28

010

X4CR-520

C34

17p C

342

22p

R27712k

100kR517

C33933p

R27

812

k

D27MA77

C34

00.

01

1234 5

678

AO1AO2AO3AO4 GND

SDASCLVCC

IC7M62334FP

VAG

R30

210

k

R22

247

0C

286

0.1

T1T2T3T4

R27

612

k

DET

R24722k

C32

00.

039

R24822k

C32

30.

0068

C32

20.

01

R249

R518 1k

22k+-

56

IC5NJM12904V

7

C321 0.1

R25

222

0k

C32

74.

7C

325

0.03

3

C3240.1

R25318k

R25447k

R25547k

-+

32

1

IC5NJM12904V

IC22TC4S66F

24

3

15

V+GND

8

4

C34

90.

1

CDEC

R25

847

0

VAGSQIN

Q35XP1214

1

2

3

5

4R25

168

k

DUSE

5V

SEN

C

C3281

R25

956

k

R26122k

R26

322

0k

R26

033

0k

C32

90.

018

R26218k

C33

068

pC

331

0.01

Q362SC4116

R26

42.

7k

R21

922

k

C33

30.

001

C33

21

TONE

REM

CENC2

CENC1

CENC0

R267 22k

R268 56k

R269 180k

R286 1k

R31

23.

9kR

266

3.9k R270

47k

C33

40.

0082

R27147k

IC5NJM12904V

R256 100k

SCKDSDA

R27247k

C33

682

0p

R27

447

k

Q372SC4116

R2734.7k

TEN

C

R27527k

C3370.47

Q38DTC144EU

XTXD

XRXD

ATR

DN

TXD

NR

XDC

IRQ

ARTM

DIM

R30

310

0k

CEN

C2

CEN

C1

CEN

C0

AFC

LAR

DT

AMSK

ADIN

APST

PMFM

ESD

AES

CL

PA

R14

910

0k

RSS

ILV

INBA

TVU

NLK

CD

ECSD

ECBE

EPSE

NC

PWO

NIG

SWD

DST

POSW

NO

ISO

PT3

OPT

2O

PT1

MM

UT

RM

UT

BUSY

HAN

GPT

TO KR0

KR1

KR2

C34

5 0.

1

DSDADASTPGO2PGO1PGI3PGI2PGI1LINHLCSLCKLSO

PLST

TXCTMUT

NWCDDSDDDAC

SOSI

SCKR542 1kCCS

5 6 7 8

4 3 2 1

PMFM

R1805.6k

C24

00.

022

C24

10.

001

R17933k

IC15TC4W53FU

+-

141213

IC21dNJM12902V

NW

C

C24

456

pC

243

270p

Q22DTC144EU

R18268k

C24

20.

0012

R18168k

R18533k

C24

633

0p

R18

639

k

R18

927

k

R18

756

k

TON

E

CTC

S

-+

23

1

IC21aNJM12902V

C29

60.

1

C50

40.

001

R1904.7

VAG

C362 0.1 R304 56k

5V

C378 0.1 R318 12k

C200 0.1C201 0.1C202 0.1

R147100k

13

5

2

4

R193100k

C249470p

R19

122

0kR

192

220k

VCC

CPU

5VR

8VR

8VT8

V5V 8V

VCC

CPU

5V

5V 8V

C25

0 0.

1

C3590.1

C35

10.

047

R19

622

k

R1951k

C2510.1

C38

60.

47

D35

MA2

S111

R1942.2k

AFON

SIG

AFONOCPU5V

AFON

D31DAN202K

C2530.1

VCC

IC18TA75S01F

4

3

5

21

C25

522

0

R19

810

k

C256470

R19

910

k

C25

4 0.

001

J4

R18

818

k

CP9CP8C2520.1

R19

710

k

J5

C25

7 47

p

D23DA221 C

269

0.00

1

Q252SD1664

R20

34.

7k

R20

24.

7k

C27

24.

7

Q29DTC144EU

TMUT

D24DA221 C

270

0.00

1

Q262SD1664

C27

12.

2

TXC

R20

44.

7k

R20

54.

7k

Q30DTC144EU

6 5 4

1 2 3

Q272SB1132

Q28XP6501

R15

64.

7k

R239 100k

R305 100k

C273

5VVCC

0.001

C2744.7

C26

610 C

262

0.1

O IG

IC9TA7808F

C26

10.

1

C26

522

0

R20

010

kR

201

470

Q232SJ377

HV HV

HV

VCC

8V

5V

C26

0 47

p

C25

9 0.

001

C25

8 47

0

D22

DSA

3A1

EP4

EP5W2

C26

810 C

264

0.1

GO I

IC10AN78L05M

C26

30.

1

R298100k R

297

300k

J6

C29

3 0.

001

VCCDIM

HORNGNDAFOGNDDISCGND

INGNDPTT

C29

2 47

p

C29

0 0.

001

C29

1 0.

001

C29

4 0.

001

Q48DTC144EU

PA

Q33DTC144EUD

IM

Q32DTC144EU

HO

RN

OD

ET

DET

VCC VCCCPU5V

EPTT

R22

810

0k

Q312SJ144

R22

71M

C29

510C

287

0.00

1

CP5MOD

CP6

CP7SIG

SIGOUT

D26MA2S111R

229

1M

R226100k

P1

+-

CHASSISSP1

AFO

Q24DTC144EU

PWR

CPU5

L364.7µC

352

22

GNDV+

4

11

C24

80.

001

IC21NJM12902V

8V5V

T8VR8VANT

VCC

8V5V

T8VR8V

ANT ANTANT

VCCVCC

8V5V

T8VR8V

VCC

CPU5R11210k

R12847k

C18

40.

1

LINH

5V

Q43DTC144EU

C1734.7

C179470p

C27

90.

1

R21727k

C278 0.1

R25

012

0k

R26547k

C33

80.

01

Q40DTC144EU

Q39DTC363EK

IC8LA4425A

R224 47 C289 0.1

R225 10k C288 0.1

R223 1k

MAIN UNIT (2)

R240100k

C31

50.

022

VAG

C3100.1

C28

20.

1

C2804.7 C

281

470p

R257470k

C3350.047

R14

810

0k

FSW2

CHASSISJ1

W1

R15910k

R28710k

toOPC-617

L531.8µ

5V

5V

5V

2.5V

2.5V

4.3Vp-p(3.579MHz)

16mVrmS

1.7Vp-p(2/5 TONE)

TX:0.5VRX:1.1V

2.5Vp-P(19.66MHz)

1.8V

0.6Vp-p(CTCSS)

4.9V

5.0V(AFON)

1.3V

TX:8.0VRX:0V

TX:0VRX:8.0V

5.0V

8.0V

13.1V

5.0V

4.5VMEASUREMENT CONDITIONS

VOLTMETER Amplitude(Oscilloscope):100MHz Frequency:155MHz Transmission:25W

11 - 3

Asia Icom Inc.6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.Phone : +886 (02) 2559 1899 Fax : +886 (02) 2559 1874URL : http://www.asia-icom.comE-mail : [email protected]

Zac de la Plaine, 1, Rue Brindejonc des MoulinaisBP 5804, 31505 Toulouse Cedex, FrancePhone : +33 (5) 61 36 03 03 Fax : +33 (5) 61 36 03 00URL : http://www.icom-france.comE-mail : [email protected]

Icom France S.a

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.Phone : +44 (01227) 741741 Fax : +44 (01227) 741742URL : http://www.icomuk.co.ukE-mail : [email protected]

Icom (UK) Ltd.

Crta. de Gracia a Manresa Km. 14,75008190 Sant Cugat del Valles Barcelona, SPAINPhone : +34 (93) 590 26 70 Fax : +34 (93) 589 04 46URL : http://www.icomspain.comE-mail : [email protected]

Icom Spain S.L

<Corporate Headquarters>2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.Phone : +1 (425) 454-8155 Fax : +1 (425) 454-1509URL : http://www.icomamerica.comE-mail : [email protected]<Customer Service>Phone : +1 (425) 454-7619

Icom America Inc.

Glenwood Centre #150-6165Highway 17 Delta, B.C., V4K 5B8, CanadaPhone : +1 (604) 952-4266 Fax : +1 (604) 952-0090URL : http://www.icomcanada.comE-mail : [email protected]

Icom Canada

A.B.N. 88 006 092 575290-294 Albert Street, Brunswick, Victoria, 3056, AustraliaPhone : +61 (03) 9387-0666 Fax : +61 (03) 9387-0022URL : http://www.icom.net.auE-mail : [email protected]

Icom (Australia) Pty. Ltd.

146A Harris Road, East Tamaki,Auckland, New ZealandPhone : +64 (09) 274 4062 Fax : +64 (09) 274 4708URL : http://www.icom.co.nzE-mail : [email protected]

Icom New Zealand

1305, Wanshang Plaza, Shijingshan Road, Beijing ChinaPhone : +86 (010) 6866 6337 Fax : +86 (010) 6866 3553URL : http://www.bjicom.comE-mail : [email protected]

Beijing Icom Ltd.Sopot, 3 Maja 54 PolandPhone : +48 (58) 550 7135 Fax : +48 (58) 551 0484E-mail : [email protected]

Icom Polska

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, JapanPhone : +81 (06) 6793 5302Fax : +81 (06) 6793 0013URL : http://www.icom.co.jp/world/index.html

Communication EquipmentHimmelgeister Str. 100, D-40225 Dusseldorf, GermanyPhone : +49 (0211) 346047 Fax : +49 (0211) 333639URL : http://www.icomeurope.comE-mail : [email protected]

Icom (Europe) GmbH

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan S-13817HZ-C1V-qC 2002 Icom Inc.

SERVICEMANUAL

UHF TRANSCEIVER

iF610

iF620

iF621

VERSION

Europe

General

Europe (MPT)

General (MPT)

U.S.A.

U.S.A. (MPT)

U.S.A.

General

SYMBOL

EUR

GEN

MTE

MTG

USA

MTU

USA

GEN

INTRODUCTION

This service manual describes the latest service informationfor the IC-F610, IC-F620 and IC-F621 UHF TRANS-CEIVERS at the time of publication.

DANGER

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 16 V. This will ruin thetransceiver.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply whenconnecting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100 mW)to the antenna connector. This could damage the transceiv-er’s front end.

ORDERING PARTS

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>

1110003490 S.IC TA31136FN IC-F610 MAIN UNIT 5 pieces

8810009990 Screw PH BT M3×8 ZK IC-F620 Bottom cover 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

REPAIR NOTES

1. Make sure a problem is internal before disassembling thetransceiver.

2. DO NOT open the transceiver until the transceiver is disconnected from its power source.

3. DO NOT force any of the variable components. Turnthem slowly and smoothly.

4. DO NOT short any circuits or electronic parts. An insu-lated tuning tool MUST be used for all adjustments.

5. DO NOT keep power ON for a long time when the trans-ceiver is defective.

6. DO NOT transmit power into a signal generator or asweep generator.

7. ALWAYS connect a 50 dB to 60 dB attenuator betweenthe transceiver and a deviation meter or spectrum ana-lyzer when using such test equipment.

8. READ the instructions of test equipment thoroughlybefore connecting equipment to the transceiver.

MODEL

IC-F610

IC-F620

IC-F621

To upgrade quality, any electrical or mechanical parts andinternal circuits are subject to change without notice orobligation.

TABLE OF CONTENTS





4 - 1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 1

4 - 2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 2

4 - 3 PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 3

4 - 4 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4

4 - 5 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 4


5 - 1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 1

5 - 2 PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3

5 - 3 SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 4





9 - 1 FRONT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 1

9 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 - 3



11 - 1 FRONT UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 1

11 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 - 2

EXPLICIT DEFINITIONS

H1-band

H2-band

400 – 430 MHz

440 – 490 MHz

480 – 512 MHz

480 – 520 MHz

L-band

M-band

H-band

FREQUENCY COVERAGE

12.5 kHz / 25 kHz

12.5 kHz / 20 kHz

Narrow/Wide-type

Narrow/Middle-type

CHANNEL SPACING

1 - 1


Measurement method

Frequency coverage

Type of emission

Number of conventional channels

Power supply voltage (negative ground)

Current drain (approx.)

Frequency error

Usable temperature range

Dimensions (proj. not included)

Weight

RF output power

Modulation system

Maximum permissible deviation

Spurious emissions

Adjacent channel power

Audio frequency response

Audio hormonic distortion

FM hum and noise (typical)(without CCICT filter)

Residual modulation (typical)(with CCICT filter)

Limitting charact of modulator

Microphone connector

Receive system

Intermediate frequencies

Sensitivity (typical)

Squelch sencitivity (at threshold) (typical)

Adjcent channel selectivity (typical)

Spurious response

Intermoduration (typical)

Hum and noise (without CCITT filter)

(typical) (with CCITT filter)

Audio output power

External SP connector

All stated specifications are subject to change without notice or obligation.

USA/GEN EUR

RE

CE

IVE

RT

RA

NS

MIT

TE

RG

EN

ER

AL

EIA-152-C/204D or TIA-603 ETS 300 086

[L-band]: 400.000–430.000 MHz[M-band]: 440.000–490.000 MHz[H-band]: 480.000–512.000 MHz [USA], 480.000–520.000 MHz [EUR]/[GEN]

[N/W]: 8K50F3E/16K0F3E (12.5 kHz; Narrow/25 kHz; Wide),[N/M]: 8K50F3E/14K0F3E (12.5 kHz; Narrow/20 kHz; Middle)

Max. 256 ch (16 channels × 16 banks), Max. 32 ch (MPT Trunking)

13.6 V DC nominal 13.2 V DC nominal

TX (at 25 W) 7.0 A [25W], (at 45 W) 13.0 A [45W]Rx (max. audio) 1200 mA

(stand-by) 300 mA

2.5 ppm ±1.5 kHz

–30˚C to +60˚C (–22˚F to +140˚F) –25˚C to +55˚C (–13˚F to +131˚F)

140(W) × 40(H) × 170(D) mm; 51⁄2(W) × 19⁄16(H) × 611⁄16(D) inch

1.2 kg; 2 lb 10 oz

High/Low2/Low1: 25 W/10 W/2.5 W [25W], 45 W/25 W/4.5 W [45W]

Variable reactance frequency modulation

±2.5 kHz [Narrow], ±4.0 kHz [Middle], ±5.0 kHz [Wide]

70 dBc typical 0.25 µW ≤ 1GHz, 1.0 µW > 1 GHz


+2 dB to –5 dB of 6 dB/octarverange from 300 Hz to 2550 Hz [Narrow]/3000 Hz [Middle]/[Wide]

3% typical at 1 kHz, 40% deviation


——50 dB [Narrow], 53 dB [Middle],55 dB [Wide]

60–100% of max. deviation

8-pin modular (600 Ω)

Double-conversion superheterodyne system

1st: 46.35 MHz, 2nd: 450 kHz

0.25 µV at 12 dB SINAD –4 dBµV (emf) at 20 dB SINAD

0.25 µV –4 dBµV (emf)


75 dB

75 dB 67 dB


—— 50 dB [Narrow], 53 dB [Middle], 55 dB [Wide]

4 W typical at 10% distortion with a 4 Ω load

2-conductor 3.5 (d) mm (1⁄8")/4 Ω


2 - 1

(

IC3: RA30H4047M [L]RA30H4452M [M]-25W, [H]RA45H4452M [M]-45W

8V regurator(IC9: TA7808F)

AF amplifier(IC8: LA4425A)

CPU 5V regurator*(IC10: AN78L05M)

VCO circuit

CPU*(IC20: HD64F2268TF)

Antenna switch/Low-pass filter circuits

1st mixer*(Q3: 3SK272)

2nd IF filter(FI2: ALFYM450F=K)

FM IF IC(IC1: TA31136FN)

D/A converter(IC6: M62364FP)

Referance crystal osillator(X2: CR-671A 15.3 MHz)

PLL IC(IC4: SA7026DH)

*Located under side of the point.

1st IF filter FI1: FL-313 [USA], [GEN]

FL-335 [EUR]( (

Power module


3 - 1

• Opening case➀ Unscrew 4 screws A, and remove the bottom cover.➁ Disconnect the flat cable B from J2.➂ Unscrew 2 screws c, and remove the front unit.

A

B

C

J2

➃ Unsolder 1 point D from the plate, and remove the plate.➄ Unsolder 3 points E from the antenna connector.➅ Remove the clip F.➆ Disconnect the cable G from J5.➇ Unscrew 11 screws H.

H

GF

D E

J5

➈ Lift up the front portion of the main unit and remove it.

• Instllation locationUT-105 SmarTrank2 Logic BoardUT-108 DTMF decoder unitUT-109

Voice scrambler unitUT-110UT-111 Trunking unit

UT-105UT-108UT-109UT-110UT-111

J1


4 - 1

4-1 RECEIVER CIRCUITS4-1-1 ANTENNA SWITCHING CIRCUIT (MAIN unit)The antenna switching circuit functions as a low-pass filterwhile receiving and as resonator circuit while transmitting.The circuit does not allow transmit signals to enter receivercircuits.

Received signals enter the antenna connector and passthrough the low-pass filter (L1–L3, C1, C2, C6–8, C16). Thefiltered signals are then applied to the RF circuit passedthrough the λ⁄4 type antenna switching circuit (D5, D6, L6).

4-1-2 RF CIRCUIT (MAIN unit)The RF circuit amplifies signals within the range of frequen-cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit pass throughthe two-stage tunable bandpass filters (D8, D4). The filteredsignals are amplified at the RF amplifier (Q2) and then enterother two-stage bandpass filters (D9, D10) to suppressunwanted signals. The filtered signals are applied to the 1stmixer circuit (Q3).

The tunable bandpass filters (D4, D8–D10) employ varactordiodes to tune the center frequency of the RF passband forwide bandwidth receiving and good image response rejec-tion. These diodes are controlled by the CPU (IC20) via theD/A converter (IC7).

The gate control circuit reduces RF amplifier gain and atten-uates RF signal to keep the audio output at a constant level.

The receiver gain is determined by the voltage on the “RSSI”line from the FM IF IC (IC1, pin 12). The gate control circuitsupplies control voltage to the RF amplifier (Q2) and setsthe receiver gain.

When receiving strong signals, the “RSSI” voltage increasesand the gate control voltage decreases. As the gate controlvoltage is used for the bias voltage of the RF amplifier (Q2),then the RF amplifier gain is decreased.

4-1-3 1ST MIXER AND 1ST IF CIRCUITS(MAIN unit)

The 1st mixer circuit converts the received signals to a fixedfrequency of the 1st IF signal with the PLL output frequency.By changing the PLL frequency, only the desired frequencywill pass through a MCF (Monolithic Crystal Filter; FI1) at thenext stage of the 1st mixer.

The RF signals from the bandpass filter are applied to the1st mixer circuit (Q3). The applied signals are mixed with the1st LO signal coming from the RX VCO circuit (Q13) to pro-duce a 46.35 MHz 1st IF signal. The 1st IF signal passesthrough a MCF (Monolithic Crystal Filter; FI1) to suppressout-of-band signals. The filtered signal is amplified at the 1stIF amplifier (Q4) and applied to the 2nd IF circuit.

4-1-4 2ND IF AND DEMODULATOR CIRCUITS(MAIN unit)

The 2nd mixer circuit converts the 1st IF signal to a 2nd IFsignal. A double-conversion superheterodyne systemimproves the image rejection ratio and obtains stable receiv-er gain.

The 1st IF signal from the 1st IF amplifier (Q4) is applied tothe 2nd mixer section of the FM IF IC (IC1, pin 16) and isthen mixed with the 2nd LO signal for conversion to a 450kHz 2nd IF signal.

IC1 contains the 2nd mixer, limiter amplifier, quadraturedetector, active filter and noise amplifier circuits, etc. Atripled frequency from the PLL reference oscillator is usedfor the 2nd LO signal (45.9 MHz).

The 2nd IF signal from the 2nd mixer (IC1, pin 3) passesthrough a ceramic filter (FI2) to remove unwanted hetero-dyned frequencies. It is then amplified at the limiter amplifi-er section (IC1, pin 5) and applied to the quadrature detec-tor section (IC1, pins 10, 11 and X1) to demodulate the 2ndIF signal into AF signals.

The AF signals are output from pin 9 (IC1) and are thenapplied to the AF amplifier circuit.

• 2nd IF and demodulator circuits

FI2

2nd IF filter450 kHz

Noise detector

Q34

Limiteramp.

FM detector

Activefilter

AF signals

5VX1 Discriminator

IC6

RSSIMixer

X215.3 MHz

45.9 MHz

1st IF from the IF amplifier (Q4)

NOIS signal to the CPU (IC20)

8

24

23

7 5

BPF

3 2

3

161311109

IC1TA31136FN

4 - 2

4-1-5 AF AMPLIFIER CIRCUIT (MAIN unit)The AF amplifier circuit amplifies the demodulated AF sig-nals to drive a speaker.

The AF signals from the FM IF IC (IC1, pin 9) are amplifiedat the AF amplifier section of the compander IC (IC14, pins5, 4) and are then applied to the high-pass filter circuit(IC21b).

The high-pass filter characteristics are controlled by theFSW signal from the LCD driver IC (FRONT unit; IC1, pin 6).When FSW signal is high, the cut-off frequency is shiftedhigher to remove CTCSS or DTCS signals.

The filtered AF signals from the high-pass filter (IC21b,pin 7) are applied to the de-emphasis section of companderIC (IC14, pin 3) with frequency characteristics of –6dB/octave, and are then passed through the low-pass filter,high-pass filter, expander sections of compander IC (IC14).The output signal from IC14 (pin 38) is applied to the elec-tronic volume controller (IC6, pin 1).

The output AF signals from the electronic volume controller(IC6, pin 2) are applied to the AF amplifier (IC18) and AFpower amplifier (IC8) to drive the speaker.

4-1-6 RECEIVER MUTE CIRCUITS (MAIN unit)• NOISE SQUELCHThe noise squelch circuit cuts out AF signals when no RFsignals are received. By detecting noise components in theAF signals, the squelch circuit switches the AF mute switch.

Some noise components in the AF signals from the FM IF IC(IC1, pin 9) are passed through the level controller (IC6, pins24, 23). The level controlled signals are applied to the activefilter section in the FM IF IC (IC1, pin 8). Noise componentsabout 10 kHz are amplified and output from pin 7.

The filtered signals are converted into the pulse-type signalsat the noise detector section and output from pin 13 (NOIS).

The NOIS signal from the FM IF IC is applied to the CPU(IC20, pin 37). The CPU then analyzes the noise conditionand controls the AF mute signal via “AFON” line (IC20, pin18) to the AF regulator (Q39, Q40, D31).

• CTCSS AND DTCSThe tone squelch circuit detects AF signals and opens thesquelch only when receiving a signal containing a matchingsubaudible tone (CTCSS or DTCS). When tone squelch is inuse, and a signal with a mismatched or no subaudible toneis received, the tone squelch circuit mutes the AF signalseven when noise squelch is open.

A portion of the AF signals from the FM IF IC (IC1, pin 9)passes through the low-pass filter (IC5) to remove AF(voice) signals and is applied to the CTCSS or DTCSdecoder inside the CPU (IC20, pin 46) via the “CDEC” lineto control the AF mute switch.

4-2 TRANSMITTER CIRCUIT4-2-1 MICROPHONE AMPLIFIER CIRCUIT

(MAIN unit)The microphone amplifier circuit amplifies audio signalswithin +6 dB/octave pre-emphasis characteristics from themicrophone to a level needed for the modulation circuit.

The AF signals (MIC) from the FRONT unit via J2 (pin 1) arepassed through the level controller (IC6, pins 9, 10) to themicrophone amplifier circuit.

The AF signals from the level controller (IC6) are applied tothe microphone amplifier section of compander IC (IC14, pin12). The amplified signals are passed through the compres-sor, low-pass filter and high-pass filter sections of IC14.

The filtered AF signals are amplified at the buffer amplifier(Q21) and pre-emphasized with +6dB/octave at the pre-emphasis circuit (R122, C187), and are then applied to theIDC amplifier section of IC14 (pin 8).

The amplified AF signals are passed through the limitteramplifier, low-pass filter and smoothing filter sections ofIC14 after being passed through the AF mute switch insideof IC14.

The output signals from pin 6 are passed through the ana-log switch (IC15), splatter filter (IC21d) and applied to thelevel controller (IC6, pins 21, 22). The deviation level con-trolled signals are then applied to modulation circuit as the“MOD” signal.

The narrow/wide switch (Q22) is connected to the input ofthe splatter filter (IC21d) and switched by the “NWC” signalcoming from the CPU (IC20, pin 19). When “NWC” is at ahigh level, the narrow/wide switch (Q22) shifts the filter cut-off frequency for narrow deviation selection.

4-2-2 MODULATION CIRCUITThe modulation circuit modulates the VCO oscillating signal(RF signal) using the microphone audio signals.

The AF signals from the level controller (IC6, pin 22) changethe reactance of varactor diode (D18) to modulate the oscil-lated signal at the TX VCO circuit (Q14, D17). The modulat-ed VCO signal is amplified at the buffer amplifiers (Q11,Q10) and is then applied to the drive amplifier circuit via theT/R switch (D14).

The CTCSS/DTCS signals from the CPU (IC20, pins 89–91)are passed through the low-pass filter (Q37), level controller(IC6, pins 12, 11) and mixer (IC21a), and are then applied tothe VCO circuit via the splatter filter (IC21d).

4-2-3 DRIVE AMPLIFIER CIRCUIT (MAIN unit)The drive amplifier circuit amplifies the VCO oscillating sig-nal to the level needed at the power amplifier.

The RF signal from the buffer amplifier (Q10) passesthrough the T/R switch (D14) and is amplified at the YGR(Q9) and pre-drive (Q8) amplifiers. The amplified signal isapplied to the power amplifier circuit.

4 - 3

4-2-4 POWER AMPLIFIER CIRCUIT (MAIN unit)The power amplifier circuit amplifies the driver signal to anoutput power level.

The RF signal from the pre-drive amplifier (Q8) is applied tothe power module (IC3) to obtain 25 W for IC-F610/F620, or45 W for IC-F621 of RF power.

The amplified signal is passed through the antenna switch-ing circuit (D2), low-pass filter and APC detector, and is thenapplied to the antenna connector.

Control voltage for the power amplifier (IC3, pin 3) comesfrom the APC amplifier (IC2) to stabilize the output power.The transmit mute switch (D32) controls the APC amplifierwhen transmit mute is necessary.

4-2-5 APC CIRCUIT (MAIN unit)The APC circuit protects the power amplifier from a mis-matched output load and stabilizes the output power.

The APC detector circuit detects forward signals and reflec-tion signals at D11 and D1 respectively. The combined volt-age is at minimum level when the antenna impedance ismatched at 50 Ω, and is increased when it is mismatched.

The detected voltage is applied to the APC amplifier (IC2,pin 3), and the power setting “T4” signal from the D/A con-verter (IC7, pin 4), controlled by the CPU (IC20), is appliedto the other input for reference. When antenna impedance ismismatched, the detected voltage exceeds the power set-ting voltage. Then the output voltage of the APC amplifier(IC2, pin 4) controls the input current of the power module(IC3) to reduce the output power.

4-3 PLL CIRCUITS4-3-1 PLL CIRCUITA PLL circuit provides stable oscillation of the transmit fre-quency and receive 1st LO frequency. The PLL output com-pares the phase of the divided VCO frequency to the refer-ence frequency. The PLL output frequency is controlled bythe divided ratio (N-data) of a programable divider.

The PLL circuit contains the TX/RX VCO circuit (Q14, Q13).The oscillated signal is amplified at the buffer amplifiers(Q11, Q12) and then applied to the PLL IC (IC4, pin 5) viathe low-pass filter (L32, C298, C299).

The PLL IC contains a prescaler, programable counter, pro-gramable divider and phase detector, etc. The entered sig-nal is divided at the prescaler and programable counter sec-tion by the N-data ratio from the CPU. The reference signalis generated at the reference oscillator (X2) and is alsoapplied to the PLL IC. The PLL IC detects the out-of-stepphase using the reference frequency and outputs it frompin 9. The output signal is passed thorough the loop filterand is then applied to the VCO circuit as the lock voltage.

If the oscillated signal drifts, its phase changes from that ofthe reference frequency, causing a lock voltage change tocompensate for the drift in the oscillated frequency.

4-3-2 VCO CIRCUITThe VCO circuit contains a separate RX VCO (Q13, D16)and TX VCO (Q14, D17, D18). The oscillated signal is ampli-fied at the buffer amplifiers (Q11, Q10) and is then applied tothe T/R switch circuit (D14, D15). Then the receive 1st LO(Rx) signal is applied to the 1st mixer (Q3) and the transmit(Tx) signal to the YGR amplifier circuit (Q9).

A portion of the signal from the buffer amplifier (Q11) is fedback to the PLL IC (IC4, pin 5) via the buffer amplifier (Q12)and low-pass filter (L32, C298, C299) as the comparisonsignal.

• PLL circuit

Shift register

×3

PrescalerPhasedetector

Loopfilter

Programablecounter

Programabledivider

X215.3 MHz

45.9 MHz signalto the FM IF IC

16

Q13, D16

RX VCO

TX VCO

Buffer

Buffer

Buffer

Q10

Q12

Q11

Q34

191817

PLST

IC4 (PLL IC)

SOSCK

to transmitter circuit

to 1st mixer circuit

D15

D14

8 5

Q14, D17, D18

LPF

4-4 POWER SUPPLY CIRCUITS4-4-1 VOLTAGE LINES (MAIN unit)

4-5 PORT ALLOCATIONS4-5-1 OUTPUT EXPANDER (FRONT unit; IC1)

4-5-2 OUTPUT EXPANDER (MAIN unit; IC7)

4-5-3 CPU (MAIN unit; IC20)Description

The voltage from a DC power supply.

The same voltage as the HV line which is con-trolled by the power switching circuit (Q23, Q24).When the [POWER] switch is pushed, the CPUoutputs the “PWON” control signal to the powerswitching circuit to turn the circuit ON.

Common 5 V for the CPU converted from the HVline by the CPU5V regulator circuit (IC10). Thecircuit outputs the voltage regardless of thepower ON/OFF condition.

Common 8 V converted from the VCC line by the8V regulator circuit (IC9).

Common 5 V converted from the VCC line by the5V regulator circuit (Q27, Q28).

Receive 8 V controlled by the R8 regulator circuit(Q26, Q30, D24) using the “TXC” signal from theCPU (IC20, pin 16).

Transmit 8 V controlled by the T8 regulator circuit(Q25, Q29, D23) using the “TMUT” signal fromthe CPU (IC20, pin 17).

Line

HV

VCC

CPU5V

8V

5V

R8V

T8V

I/O port for data signals from/to the D/Aconverter (IC7).

Outputs strobe signals for the levelcontroller (or D/A converter) (IC6).

Output ports for LCD control signals tothe LCD driver (FRONT unit; IC1)

Outputs clock signal for the LCD driver(FRONT unit; IC1)

Outputs data signals for the LCD driver(FRONT unit; IC1)

Outputs strobe signals for the PLL IC(IC4).

Outputs R8 regulator circuit (Q26, Q30,D24) control signal.

Outputs T8 regulator circuit (Q25, Q29,D23) control signal.

Outputs control signal for the AF regu-lator circuit (Q39, Q40, D31).High : While AF amplifier (IC8) is acti-

vated.

Outputs IF bandwidth control signal.High : While IF bandwidth is narrow.

Input port for the data signals from theDTMF decoder (IC19).

Outputs clock signal to the DTMFdecoder (IC19).

Outputs data signals to the PLL IC(IC4), level controller (or D/A converter)(IC6), compander IC (IC14) and option-al board (connect to J1).

Input port for the clock signal from theoptional board via J1.

Outputs clock signal to the PLL IC(IC4), level controller (or D/A converter)(IC6), D/A converter (IC7), companderIC (IC14) and optional board (connectto J1).

Outputs chip select signal for theoptional board via J1.

Input ports for the key matrix.

Input port for the PTT switch from theoptional board via J1.Low : External PTT switch is ON.

Input port for the microphone hangerdetection signal.Low : Microphone on hook

Outputs BUSY detection signal for theoptional board via J1.

Input port for AF mute signal from theoptional board via J1.

1

2

8,9

10

11

13

16

17

18

19

20

21

22

23

24

25

26–28

29

30

31

32

DSDA

DAST

LINH, LCS

LCK

LSO

PLST

TXC

TMUT

AFON

NWC

DDSD

DDAC

SO

SI

SCK

CCS

KR2–KR0

PTTO

HANG

BUSY

RMUT


4 - 4

Output tunable band pass filter controlsignals.

Output port fortunable band pass filter control signalwhile receiving.output power control signal whiletransmitting.

1–3

4

T1–T3

T4


Output ports for key matrix.

Outputs LCD backlight control signal.Low : While LCD backlight is dim.

Outputs LCD backlight control signal.Low : While LCD backlight is OFF.

Outputs high-pass filter’s characteris-tics select signal.

Outputs external device control signal.High : When matched 2/5-tone signals

are received.

Output ports for LCD control signal.

1–3

4

5

6

7

12–55

KS0–KS2

DIM1

DIM2

FSW

HORN

SEG1–SEG40,COM1–COM4


4 - 5

CPU (IC20)—continued CPU (IC20)—continued

Input port for MIC mute signal from theoptional board via J1.

I/O ports for the optional board controlsignals.

NOIS signal input port from the FM IFIC (MAIN unit; IC1) for noise squelchoperation.

Input for the POWER switch.Low : While POWER switch is pushed.

Input port for DTMF detection signalfrom the DTMF decoder (IC19).

Remote power control signal input portfrom the external connector (J8).

Outputs control signal for the powerswitching circuit (Q24, Q23) via D28.

Outputs single tone signal.

Outputs beep audio signals.

Single tone signal input port for decod-ing from the LPF (IC21c).

CTCSS/DTCS signals input port fordecoding from the LPF (IC5).

Input port for the PLL unlock signalfrom the PLL IC (IC4).

Input port for the overvoltage detectionfrom the connected power supply.

Input port for the PLL lock voltage.

Input port for receiving signal strengthlevel detection.

Input port for the transceiver’s internaltemperature.

Input port for the AF volume control(FRONT unit; R12).High : [VOL] is maximum clockwise.

Input port for the PTT switch from theexternal connector (J6).Low : External PTT switch is ON.

Input port for the reset signal.

Output port for the cloning signal.

Input port for the cloning signal.

Outputs CPU clock shift signal.

Outputs cut-off frequency control signalto the low-pass filter (IC5) forCTCSS/DTCS switching.

Input port for the connected modemunit via external connector (J9).

Output port for the connected modemunit via external connector (J9).

33

34–36

37

38

39

40

41

43

44

45

46

47

48

49

50

51

52

55

59

68

69

70

71

74

75

MMUT

OPT1–OPT3

NOIS

POSW

DDST

IGSW

PWON

SENC

BEEP

SDEC

CDEC

ULCK

BATV

LVIN

RSSI

TEMP

AFVI

EPTT

RES

CLO

CLI

CSFT

DUSE

XCTS

XRTS


Input port for serial data signals fromthe connected MAP27 unit via externalconnector (J9).

Outputs serial data signals for the con-nected MAP27 unit via external con-nector (J9).

Output serial data signals (data formatis in accordance with NMEA0183) forthe connected unit via external connec-tor (J8).

Input port for serial data signals (dataformat is in accordance withNMEA0183) from the connected unitvia external connector (J8).

Input port for interruption signal fromthe optional board via J1

Input port for the LCD backlight controlsignal from the external connector (J6).

Output ports for the CTCSS/ DTCS sig-nals.

Outputs reset signal for the companderIC (IC14).

Output control signals for the compan-der IC (IC14).

Outputs strobe signals to the compan-der IC (IC14).

Outputs control signal for the MSKPM/FM switching circuit (IC15).

I/O port for the data signals from theEEPROM (IC23).

Outputs clock signal for the EEPROM(IC23).

Outputs MIC audio select signal for theanalog switch (IC25).Low : While “Public-address” function

is ON.

76

77

79

80

81

88

89–91

92

94, 95

96

97

98

99

100

XTXD

XRXD

NTXD

NRXD

CIRQ

DIM

CENC2–CENC0

AFCL

AMSK,ADIN

APST

PMFM

ESDA

ESCL

PA


REQUIRED TEST EQUIPMENT

Note: [MPT] versions must use ‘CS-F600’ instead of ‘CS-F500’.

5-1 PREPARATIONWhen you adjust the contents on pages 5-4 and 5-5, SOFT-WARE ADJUSTMENT, the optional CS-F500 ADJ ADJUSTMENTSOFTWARE (Rev. 1.0 or later), *OPC-1122 JIG CABLE (modifiedOPC-1122 CLONING CABLE; see illustration below) are required.

SYSTEM REQUIREMENTS• IBM PC compatible computer with an RS -232C serial port

(38400 bps or faster)• Microsoft Windows 95/98 or Windows ME• Intel Pentium 100 MHz processor or faster• At least 16 MB RAM and 10 MB of hard disk space• 640×480 pixel display (800×600 pixel display recommended)

ADJUSTMENT SOFTWARE INSTALLATIONq Boot up Windows.

- Quit all applications when Windows is running.w Insert the ‘CS-F500’ into the appropriate CD-ROM drive.e Select ‘Run’ from the [Start] menu.r Type the setup program name using the full path name,

then push [Enter] key.(ex. D:\CSF500ADJ\disk1\Setup.exe)

t Follow the prompts.y Program group ‘CS-F500 ADJ’ appears in the ‘Programs’

folder of the [Start] menu.

STARTING SOFTWARE ADJUSTMENTq Connect IC-F610, F620 or F621 and PC with *OPC-1122

JIG CABLE.w Turn the transceiver power ON.e Boot up Windows, and click the program group ‘CS-F500

ADJ’ in the ‘Programs’ folder of the [Start] menu, thenCS-F500 ADJ’s window appears.

r Click ‘Connect’ on the CS-F500’s window, then appearsIC-F610, F620 or F621’s up-to-date condition.

t Set or modify adjustment data as desired.

5 - 1

EQUIPMENT

DC power supply

RF power meter(terminated type)

Frequency counter

FM deviation meter

DC voltmeter

GRADE AND RANGE

Output voltage : 13.2 (13.6) V DCCurrent capacity : 20 A or more

Measuring range : 1–75 WFrequency range : 300–600 MHzImpedance : 50 ΩSWR : Less than 1.2 : 1

Frequency range : 0.1–600 MHzFrequency accuracy : ±1 ppm or betterSensitivity : 100 mV or better

Frequency range : DC–600 MHzMeasuring range : 0 to ±10 kHz

Input impedance : 50 kΩ/V DC or better

EQUIPMENT

Audio generator

Standard signal generator (SSG)

Oscilloscope

AC millivoltmeter

External speaker

Attenuator

GRADE AND RANGE

Frequency range : 300–3000 HzMeasuring range : 1–500 mV

Frequency range : 0.1–600 MHzOutput level : 0.1 µV–32 mV

(–127 to –17 dBm)

Frequency range : DC–20 MHzMeasuring range : 0.01–20 V

Measuring range : 10 mV–10 V

Input impedance : 4 ΩCapacity : 7 W or more

Power attenuation : 50 or 60 dBCapacity : 100 W or more


+ Audio generator300 Hz to 3 kHz

ACmillivoltmeter

MICE

MIC

PTT

PTT switch

PTTE

Add a jumper wire here

• *OPC-1122 (JIG CABLE)

Electrolytic capacitor47 µF

OPC-1122(Cloning cable)

IBM is a registered trademark of International BussinessMachines Corporation in the U.S.A. and other countries.Microsoft and Windows are registered trademarks ofMicrosoft Corporation in the U.S.A. and other countries.Screen shots produced with permission from MicrosoftCorporation. All other products or brands are registeredtrademarks or trademarks of their respective holders.

5 - 2

FM deviation meter(DC measurable)

Attenuator50 dB or 60 dB

to the MIC connector

to the antenna connector

to DC cable

to an RS-232C port

DB9 female plug

Personalcomputer

Standard signal generator–127 to –17 dBm(0.1 µV to 32 mV)

CAUTION:DO NOT transmit while SSG is connected to the antenna connector.

RF power meter50 Ω / 1–75 W

DC power supply13.2 (13.6) V / 20 A

Frequencycounter

RS-232C cable(straight)

*OPC-1122(JIG CABLE)

AC millivoltmeter

Audio generator

• Connections

CS-F500 ADJ Rev.1.0File

COM 1: OPEN

Option

Connect Reload (F5) Disp para

[A / D]VIN : 156 : 9Ch : 12.24 VTEMPS : 187 : BBh : 30.81 'CLVIN : 57 : 32h : 0.98 VSD : 36 : 24h : 0.71 V

Power (Hi) : 181 [ # # # # # # # # # # # # # # – – – – – – ]Power (L2) : 120 [ # # # # # # # # # – – – – – – – – – – – ]Power (L1) : 69 [ # # # # # – – – – – – – – – – – – – – – ]

Ballance : 54 [ # # # # – – – – – – – – – – – – – – – – ]MOD W : 157 [ # # # # # # # # # # # # – – – – – – – – ]MOD N : 83 [ # # # # # # # – – – – – – – – – – – – – ]

CTCS/DTCS : 67 [ # # # # # – – – – – – – – – – – – – – – ]SQL : 0 [ – – – – – – – – – – – – – – – – – – – – ]

BPF ALL : [Enter] to sweepBPF T1 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T2 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T3 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweepBPF T4 : 0 [ # # # # # # # # # – – – – – – – – – – – ] [Enter] to sweep

TXF : [Enter] to startS-METER : [Enter] to start

[D / A]BPF T1 : 50 : 32h : 0.98 VBPF T2 : 50 : 32h : 0.98 VBPF T3 : 50 : 32h : 0.98 VT4/POW : 50 : 32h : 0.98 VREF : 45 : 2Dh : 0.88 VMOD BAL : 54 : 36h : 21.18 %Dev : 157 : 9Dh : 3.08 VCTCSS : 66 : 42h : 1.29 VSQL Lev : 0 : 00h : 0.00 %

CH No. : 01 RX Freq = 440.050, TX Freq = <– RF Power: High Mode: Wide

: Transceiver's connection state: Reload adjustment data: Receive sensitivity measurement: Connected DC voltage

NOTE:

• Screen display exampe

1

5

4

6

1011

12

15

9

14

16

1

2

3

4

9

10

: PLL lock voltage: Operating channel select: RF output power: Modulation balance

5

6

7

8

11

12

: FM deviation: CTCSS/DTCS deviation: Squelch level: Receive sensitivity (automatically)

13 : Receive sensitivity (manually): Reference frequency: S-meter: Adjustment items

14

15

16

The above values for settings are example only. Each transceiver has its own specific values for each setting.

3

2

8

7

13

LVPLL lock voltage check point

C134PLL lock voltage adjustment for TX

C133PLL lock voltage adjustment for RX

DC power supply 13.2 (13.6) V / 20 A

5 - 3

5-2 PLL ADJUSTMENT

PLL LOCKVOLTAGE

1

2

3

4

• Operating freq. : 400.000 MHz [L]440.000 MHz [M]480.000 MHz [H]

• Receiving



• Receiving


MAIN Connect a digital multi-meter or an oscillo-scope to the checkpoint, “LV”.

1.0 V

1.1 V

3.0–4.2 V [L]3.3–4.5 V [M]3.3–4.5 V [H]

MAIN C133

C134

Verify

ADJUSTMENT ADJUSTMENT CONDITIONSUNIT LOCATION

VALUEUNIT ADJUST

MEASUREMENT ADJUSTMENT

5 - 4

5-3 SOFTWARE ADJUSTMENTSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

1

1

2

3

1

1

2


• Output power : Low1• Connect the RF power meter or 50 Ω

dummy load to the antenna connector.• Transmitting


• Output power : High• Transmitting




• Output power : Low1• Push [P0] key while transmitting


• Output power : Low1• IF bandwidth : Wide• Connect an audio generator to the [MIC]

jack through the JIG cable and set as:1.0 kHz/40 mVrms

• Set an FM deviation meter as:HPF : OFFLPF : 20 kHzDe-emphasis: OFFDetector : (P–P)/2

• Transmitting

• IF bandwidth : Narrow• Transmitting


• Output power : Low1• IF bandwidth : Wide• CTCSS : 88.5 Hz• DTCS code : 007• Set the FM deviation meter as:

HPF : OFFLPF : 20 kHzDe-emphasis: OFFDetector : (P–P)/2

• No audio applied to the [MIC] connector.• Transmitting

REFERENCEFREQUENCY[TXF]

OUTPUTPOWER[Power (Hi)]

[Power (L2)]

[Power (L1)]

MODULATIONBALLANCE[Ballance]

FMDEVIATION[MOD W]

[MOD N]

CTCSS/DTCSDEVIATON[CTCS/DTCS]

Rearpanel

Rearpanel

Rearpanel

Rearpanel

Rearpanel

Loosely couple a frequnecycounter to the antenna connec-tor.

Connect an RF power meter tothe antenna connector.

Connect an FM deviation meterwith an oscilloscope to theantenna connector through anattenuator.



430.0000 MHz [L]490.0000 MHz [M]520.0000 MHz [H]

25.0 W [25W]45.0 W [45W]

10.0 W [25W]25.0 W [45W]

2.5 W [25W]4.5 W [45W]

±4.1 kHz [N/W]±3.3 kHz [N/M]

±2.1 kHz

±0.70 kHz [N/W]±0.56 kHz [N/M]


VALUEUNIT LOCATION

Set to square wave form

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

5 - 5

SOFTWARE ADJUSTMENT – continuedSelect an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

Minimum distortionlevel



Set “SQL level” toclose squelch.

Then set “SQL level”at the point wherethe audio signalsjust appears.

1

1

2

1


• IF bandwidth : Wide• Connect a standard signal generator to

the antenna connector and set as:Frequency : 400.000 MHz [L]

440.000 MHz [M]480.000 MHz [H]

Level : 10 µV* (–87 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]



• IF bandwidth : Wide• Connect an SSG to the antenna con-

nector and set as:Frequency : 400.000 MHz [L]

440.000 MHz [M]480.000 MHz [H]

Level : 14 µV* (–84 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]


• Set an SSG as :Level : 0.45 µV* (–114 dBm)Modulation : 1 kHzDeviation : ±3.5 kHz [N/W]



• IF bandwidth : Narrow• Connect an SSG to the antenna con-

nector and set as:Frequency : 415.000 MHz [L]

465.000 MHz [M]500.000 MHz [H]

Level : 0.2 µV* (–121 dBm)Modulation : 1 kHzDeviation : ±1.75 kHz

• Receiving

RXSENSITIVITY[BPF T1] – [BPF T4]

S-METER[S-METER]

SQUELCHLEVEL[SQL]

MAIN

Rearpanel




VALUEUNIT LOCATION

CONVENIENT:The BPF T1–BPF T4 can be adjusted automatically.q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER] key.q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.

orw-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.w-2: Push [ENTER] key to start tuning.w-3: Repeat w-1 and w-2 to perform additional BPF tuning.

[FRONT UNIT][FRONT UNIT]

IC1 1130010800 S.IC LC75824WIC2 1130008560 S.IC TC75S51F (TE85L)

Q1 1590000720 S.TRANSISTOR DTA144EUA T106Q2 1590000430 S.TRANSISTOR DTC144EUA T106Q3 1590000430 S.TRANSISTOR DTC144EUA T106Q4 1590000720 S.TRANSISTOR DTA144EUA T106

D1 1790001670 S.DIODE RB706F-40T106D2 1790001670 S.DIODE RB706F-40T106D3 1790001670 S.DIODE RB706F-40T106D4 1790001250 S.DIODE MA2S111-(TX)D5 1790001250 S.DIODE MA2S111-(TX)D6 1790001250 S.DIODE MA2S111-(TX)

L1 6200003960 S.COIL MLF1608A 1R0K-T

R1 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R2 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R3 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)R4 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)R5 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R6 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R7 7030000330 S.RESISTOR MCR10EZHJ 390 Ω (391)R8 7410000950 S.ARRAY EXB-V8V 102JVR9 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R10 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R11 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R12 7210003020 VARIABLE EVU-F2KFK1 B14 (10KB)R13 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ)R14 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R16 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R17 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R18 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R19 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R20 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R21 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R22 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R24 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R25 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)

C1 4030007090 S.CERAMIC C1608 CH 1H 470J-TC2 4030007090 S.CERAMIC C1608 CH 1H 470J-TC3 4030007090 S.CERAMIC C1608 CH 1H 470J-TC4 4030007090 S.CERAMIC C1608 CH 1H 470J-TC5 4030007090 S.CERAMIC C1608 CH 1H 470J-TC6 4030007090 S.CERAMIC C1608 CH 1H 470J-TC7 4030007090 S.CERAMIC C1608 CH 1H 470J-TC8 4030007090 S.CERAMIC C1608 CH 1H 470J-TC9 4030007090 S.CERAMIC C1608 CH 1H 470J-TC10 4030007090 S.CERAMIC C1608 CH 1H 470J-TC11 4030007090 S.CERAMIC C1608 CH 1H 470J-TC12 4030007090 S.CERAMIC C1608 CH 1H 470J-TC13 4030007090 S.CERAMIC C1608 CH 1H 470J-TC14 4030007090 S.CERAMIC C1608 CH 1H 470J-TC15 4030007090 S.CERAMIC C1608 CH 1H 470J-TC16 4030007090 S.CERAMIC C1608 CH 1H 470J-TC17 4030007090 S.CERAMIC C1608 CH 1H 470J-TC18 4030007090 S.CERAMIC C1608 CH 1H 470J-TC19 4030006860 S.CERAMIC C1608 JB 1H 102K-TC20 4030006860 S.CERAMIC C1608 JB 1H 102K-TC21 4030007090 S.CERAMIC C1608 CH 1H 470J-TC22 4030007090 S.CERAMIC C1608 CH 1H 470J-TC23 4030007090 S.CERAMIC C1608 CH 1H 470J-TC24 4030007090 S.CERAMIC C1608 CH 1H 470J-TC25 4030007090 S.CERAMIC C1608 CH 1H 470J-TC26 4030007090 S.CERAMIC C1608 CH 1H 470J-TC27 4030007090 S.CERAMIC C1608 CH 1H 470J-TC28 4030007090 S.CERAMIC C1608 CH 1H 470J-TC29 4030007090 S.CERAMIC C1608 CH 1H 470J-T

S.=Surface mount

C30 4030011600 S.CERAMIC C1608 JB 1E 104K-TC31 4030011600 S.CERAMIC C1608 JB 1E 104K-TC32 4030011600 S.CERAMIC C1608 JB 1E 104K-TC33 4030007130 S.CERAMIC C1608 CH 1H 101J-TC34 4030007090 S.CERAMIC C1608 CH 1H 470J-TC35 4030007090 S.CERAMIC C1608 CH 1H 470J-TC37 4550000550 S.TANTALUM TESVA 1V 224M1-8LC39 4030006900 S.CERAMIC C1608 JB 1H 103K-TC40 4550005980 S.TANTALUM TEMSVA 1A 475M-8LC41 4030006860 S.CERAMIC C1608 JB 1H 102K-T

J1 6450002210 CONNECTOR 3017-8821J2 6510023090 S.CONNECTOR 20FLT-SM1-TB

DS1 5040002310 S.LED SML-311YTT86DS2 5040002310 S.LED SML-311YTT86DS3 5040002310 S.LED SML-311YTT86DS4 5040002310 S.LED SML-311YTT86DS5 5040002310 S.LED SML-311YTT86DS6 5040002310 S.LED SML-311YTT86DS7 5040002310 S.LED SML-311YTT86DS8 5040002310 S.LED SML-311YTT86DS9 5040002310 S.LED SML-311YTT86DS10 5040002310 S.LED SML-311YTT86DS11 5040002310 S.LED SML-311YTT86DS12 5030002230 LCD L1-0483TAT

W1 8900010950 CABLE OPC-1126 (P=0.5 N=20 L=90)

EP1 0910054932 PCB B 5809BEP2 8930057820 LCD CONTACT SRCN-2526-SP-N-W

6 - 1



S.=Surface mount


IC1 1110003490 S.IC TA31136FN (D, EL)IC2 1130008560 S.IC TC75S51F (TE85L)IC3 1150002090 IC RA30H4047M-01 [L]

1150002030 IC RA30H4452M [M]-25W, [H]1150002060 IC RA45H4452M [M]-45W

IC4 1130010810 S.IC SA7026DH-TIC5 1110005330 S.IC NJM12904V-TE1IC6 1190001350 S.IC M62364FP 600DIC7 1190001340 S.IC M62334FP 600CIC8 1110003090 IC LA4425AIC9 1180001250 S.IC TA7808F (TE16L)IC10 1180000970 S.IC AN78L05M-(E1)IC11 1130008560 S.IC TC75S51F (TE85L)IC14 1130009330 S.IC TC35453F (BR, DRY)IC15 1130006220 S.IC TC4W53FU (TE12L)IC18 1110002750 S.IC TA75S01F (TE85R)IC19 1130009700 S.IC LC73872M-TRMIC20 1140010190 S.IC HD64F2268TF (EMPTY)IC21 1110005340 S.IC NJM12902V-TE1IC22 1130004200 S.IC TC4S66F (TE85R)IC23 1140009240 S.IC HN58X24128FPIIC24 1130009110 S.IC S-80942ANMP-DD6-T2IC25 1130004200 S.IC TC4S66F (TE85R)

Q1 1560000840 S.FET 2SK1829 (TE85R)Q2 1580000730 S.FET 3SK293 (TE85L)Q3 1580000660 S.FET 3SK272-(TX)Q4 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q5 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q6 1590000720 S.TRANSISTOR DTA144EUA T106Q8 1530000372 S.TRANSISTOR 2SC3356 R24-T1BQ9 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q10 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q11 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q12 1530003310 S.TRANSISTOR 2SC5107-O (TE85R)Q13 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q14 1530002920 S.TRANSISTOR 2SC4226-T1 R25Q15 1590001400 S.TRANSISTOR XP1214 (TX)Q16 1590000430 S.TRANSISTOR DTC144EUA T106Q17 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q18 1560000540 S.FET 2SK880-Y (TE85R)Q19 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)Q20 1530003090 S.TRANSISTOR 2SC4213-B (TE85R)Q21 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q22 1590000430 S.TRANSISTOR DTC144EUA T106Q23 1550000020 S.FET 2SJ377 (TE16R)Q24 1590000430 S.TRANSISTOR DTC144EUA T106Q25 1540000550 S.TRANSISTOR 2SD1664 T100QQ26 1540000550 S.TRANSISTOR 2SD1664 T100QQ27 1520000460 S.TRANSISTOR 2SB1132 T100 RQ28 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ29 1590000430 S.TRANSISTOR DTC144EUA T106Q30 1590000430 S.TRANSISTOR DTC144EUA T106Q31 1590001450 S.FET 2SJ144-GR (TE85R)Q32 1590000430 S.TRANSISTOR DTC144EUA T106Q33 1590000430 S.TRANSISTOR DTC144EUA T106Q34 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q35 1590001400 S.TRANSISTOR XP1214 (TX)Q36 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q37 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)Q38 1590000430 S.TRANSISTOR DTC144EUA T106Q39 1590000990 S.TRANSISTOR DTC363EK T146Q40 1590000430 S.TRANSISTOR DTC144EUA T106Q41 1590000720 S.TRANSISTOR DTA144EUA T106Q42 1590000430 S.TRANSISTOR DTC144EUA T106Q43 1590000430 S.TRANSISTOR DTC144EUA T106Q44 1590000430 S.TRANSISTOR DTC144EUA T106Q48 1590000430 S.TRANSISTOR DTC144EUA T106Q49 1590000430 S.TRANSISTOR DTC144EUA T106Q50 1590000430 S.TRANSISTOR DTC144EUA T106Q51 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R) [45W]

D1 1790000660 S.DIODE MA728 (TX)D2 1750000510 S.DIODE UM9401F [25W]D3 1710001060 DIODE XB15A407 [45W]D4 1750000710 S.VARICAP HVC350BTRFD5 1750000760 S.DIODE MA4PH224D6 1790000620 S.DIODE MA77 (TX)D8 1750000710 S.VARICAP HVC350BTRFD9 1750000710 S.VARICAP HVC350BTRF

D10 1750000710 S.VARICAP HVC350BTRFD11 1790000660 S.DIODE MA728 (TX)D14 1790000620 S.DIODE MA77 (TX)D15 1790000620 S.DIODE MA77 (TX)D16 1750000710 S.VARICAP HVC350BTRFD17 1750000710 S.VARICAP HVC350BTRFD18 1720000570 S.VARICAP MA368 (TX)D19 1790001250 S.DIODE MA2S111-(TX)D20 1790001250 S.DIODE MA2S111-(TX)D21 1750000830 S.VARICAP HVC362TRFD22 1790000700 DIODE DSA3A1D23 1750000370 S.DIODE DA221 TLD24 1750000370 S.DIODE DA221 TLD25 1790001250 S.DIODE MA2S111-(TX)D26 1790001250 S.DIODE MA2S111-(TX)D27 1790000620 S.DIODE MA77 (TX)D28 1750000520 S.DIODE DAN222TLD30 1790001250 S.DIODE MA2S111-(TX)D31 1750000520 S.DIODE DAN222TLD32 1790001250 S.DIODE MA2S111-(TX)D33 1790001250 S.DIODE MA2S111-(TX)D34 1790001250 S.DIODE MA2S111-(TX)D35 1750000520 S.DIODE DAN222TLD36 1750000520 S.DIODE DAN222TLD37 1750000520 S.DIODE DAN222TL

FI1 2010002450 S.XTAL FL-313 (46.35 MHz) [USA], [GEN]2030000150 S.MONOLITH FL-335 (46.350 MHz) [EUR]

FI2 2020001840 CERAMIC ALFYM450F=KFI3 2040001440 S.LC NFE31PT152Z1E9LFI4 2040001440 S.LC NFE31PT152Z1E9LFI5 2040001440 S.LC NFE31PT152Z1E9L [45W]

X1 6070000190 S.DISCRIMINATOR CDBCB450KCAY24-R0X2 6050011120 S.XTAL CR-671A (15.300 MHz)X3 6050009910 S.XTAL CR-563 (3.579545 MHz)X4 6050009520 S.XTAL CR-520 (19.6608 MHz+)

L1 6110001520 COIL LA-232 [25W]6110002110 COIL LA-382 [45W]

L2 6110001520 COIL LA-232L3 6110002110 COIL LA-382L4 6200008330 S.COIL 0.45-1.4-4TL 15NL5 6170000230 COIL LW-25L6 6200008330 S.COIL 0.45-1.4-4TL 15NL7 6200007230 S.COIL LQW2BHN15NJ01L [L]

6200007670 S.COIL LQW2BHN10NJ01L [M], [H]L8 6200007680 S.COIL LQW2BHN12NJ01L [L]



6200007670 S.COIL LQW2BHN10NJ01L [M], [H]L12 6200005720 S.COIL ELJRE 33NG-FL13 6200003350 S.COIL ELJNC R27K-FL16 6110001520 COIL LA-232 [25W]

6110002110 COIL LA-382 [45W]L18 6200005690 S.COIL ELJRE 18NG-F [L]

6200005680 S.COIL ELJRE 15NG-F [M], [H]L19 6200005690 S.COIL ELJRE 18NG-F [L]



6200005700 S.COIL ELJRE 22NG-F [M], [H]L22 6200005710 S.COIL ELJRE 27NG-FL23 6200004950 S.COIL NL 252018T-1R8JL24 6200004950 S.COIL NL 252018T-1R8JL25 6200009360 S.COIL 0.45-1.4-3TL 11NL26 6200009360 S.COIL 0.45-1.4-3TL 11NL27 6200004950 S.COIL NL 252018T-1R8JL28 6200004950 S.COIL NL 252018T-1R8JL29 6200004950 S.COIL NL 252018T-1R8JL31 6200007740 S.COIL LQW2BHN47NJ01LL32 6200005690 S.COIL ELJRE 18NG-F [L]

6200005680 S.COIL ELJRE 15NG-F [M], [H]L33 6200002850 S.COIL NL 252018T-R82JL35 6200002840 S.COIL NL 252018T-R22JL36 6200002860 S.COIL NL 252018T-4R7J

6 - 2


S.=Surface mount


L37 6200006980 S.COIL ELJRE R10G-FL38 6200005690 S.COIL ELJRE 18NG-F

R1 7030000620 S.RESISTOR MCR10EZHJ 100 kΩR2 7030000260 S.RESISTOR MCR10EZHJ 100 Ω (101)R3 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470) [25W]

7030000280 S.RESISTOR MCR10EZHJ 150 Ω (151) [45W]R4 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R5 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R6 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R7 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [25W]

7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) [45W]R8 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)R9 7030001170 S.RESISTOR MCR50JZHJ 220 Ω (221)R10 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ)R11 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R13 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R14 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R15 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R16 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω)R17 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)R18 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R19 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R20 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R21 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R22 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R23 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R25 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R29 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω)R30 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R31 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R32 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R33 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω)R34 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R35 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R36 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R37 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) [N/W]

7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) [N/M]R38 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R39 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R40 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R41 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R42 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R43 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R44 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R45 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R46 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R47 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R50 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R52 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R53 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R54 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R55 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) [L]

7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) [M], [H]R56 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R57 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R58 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) [L]

7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) [M], [H]R59 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) [25W]


7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) [45W]R62 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) [25W]


7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) [45W]R66 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R67 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R68 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R69 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R70 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R71 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω)R72 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R73 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)R74 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)

[L], [M]-45W7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)

[M]-25W, [H]R75 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)

R76 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)R77 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R78 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)R79 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R80 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R81 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R82 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)R83 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R84 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R85 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R86 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R88 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)R89 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R90 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R91 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) [L]

7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) [M], [H]R92 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R93 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R94 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R95 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R96 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R97 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R98 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R99 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R100 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R101 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R102 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)R104 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R105 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R106 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R107 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R108 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R109 7410000950 S.ARRAY EXB-V8V 102JVR110 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R111 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R112 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R113 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)R115 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R116 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R117 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)R118 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R119 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R120 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R121 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R122 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R123 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R124 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R125 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R126 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R127 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R128 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R129 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R130 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R131 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R132 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R133 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R134 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R135 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R136 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R137 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R138 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R139 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R140 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R141 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R142 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R143 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R144 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R145 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R146 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R147 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R148 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R149 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R150 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R151 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R152 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R153 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R154 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R155 7410000750 S.ARRAY EXB-V4V 104JV (100 kΩ)R156 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R157 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R158 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R159 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)

6 - 3


S.=Surface mount


R173 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R174 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R175 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R176 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R177 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R178 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)R179 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R180 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)R181 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R182 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R185 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R186 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)R187 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R188 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)R189 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R190 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)R191 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R192 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R193 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R194 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)R195 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R196 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R197 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R198 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R199 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R200 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R201 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R202 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR203 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR204 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR205 7030000460 S.RESISTOR MCR10EZHJ 4.7 kΩR206 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R207 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R208 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)R209 7510001470 S.THERMISTOR NTCG20 4AG 473JTR210 7030005871 S.RESISTOR ERA3YKD 104V (100 kΩ)R215 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R216 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R217 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R218 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R219 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R220 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R222 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R223 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R224 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)R225 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R226 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R227 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R228 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R229 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)R230 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R231 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R232 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω)R233 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R234 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R235 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R236 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R237 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 kΩ)R238 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R239 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R240 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R241 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R242 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)R243 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)R244 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)R245 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R246 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)R247 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R248 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R249 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R250 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)R251 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R252 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R253 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)R254 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R255 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R256 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R257 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)R258 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R259 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ)R260 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R261 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)

R262 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)R263 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R264 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)R265 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)R266 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R267 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R268 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R269 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R270 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R271 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R272 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R273 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R274 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R275 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)R276 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R277 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R278 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R280 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)R281 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R282 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R284 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R285 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)R286 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)R287 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R288 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R289 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R290 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)R291 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R292 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)R293 7410000950 S.ARRAY EXB-V8V 102JVR294 7410000950 S.ARRAY EXB-V8V 102JVR295 7410000950 S.ARRAY EXB-V8V 102JVR296 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ)R297 7030005651 S.RESISTOR ERA3YKD 304V (300 kΩ)R298 7030005871 S.RESISTOR ERA3YKD 104V (100 kΩ)R299 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R302 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)R303 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R304 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)R305 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)R306 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)R307 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)R308 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R309 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) [25W]

7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) [45W]R310 7030003230 S.RESISTOR ERJ3GEYJ 180 V (18 Ω) [25W]

7030004030 S.RESISTOR ERJ3GEYJ 5R6 V (5.6 Ω) [45W]R311 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) [25W]

7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) [45W]R312 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)R316 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R317 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R318 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ)R319 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R320 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)R321 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)R322 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)R323 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) [45W]R324 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)R325 7520000160 S.POSISTOR PRF21BD471QB3RA [45W]

C1 4030011090 S.CERAMIC GRM31M2C2H7R0DV01LC2 4030011090 S.CERAMIC GRM31M2C2H7R0DV01LC3 4030006860 S.CERAMIC C1608 JB 1H 102K-TC4 4030011770 S.CERAMIC C1608 CH 1H 060B-TC5 4030006860 S.CERAMIC C1608 JB 1H 102K-TC6 4030011050 S.CERAMIC GRM31M3C2H3R0CY21LC7 4030011090 S.CERAMIC GRM31M2C2H7R0DV01L [L]C7 4030011080 S.CERAMIC GRM31M2C2H6R0DV01L [M], [H]C8 4030011040 S.CERAMIC GRM31M4C2H2R0CY21LC9 4030011080 S.CERAMIC GRM31M2C2H6R0DV01LC10 4030006860 S.CERAMIC C1608 JB 1H 102K-TC11 4030006860 S.CERAMIC C1608 JB 1H 102K-TC12 4030006850 S.CERAMIC C1608 JB 1H 471K-TC13 4030007090 S.CERAMIC C1608 CH 1H 470J-TC14 4030011240 S.CERAMIC GRM31M2C2H470JV01L [25W]C15 4030011100 S.CERAMIC GRM31M2C2H8R0DV01LC16 4030011040 S.CERAMIC GRM31M4C2H2R0CY21L [L]

4030011020 S.CERAMIC GRM31M4C2H1R0CY21L [M], [H]C17 4030007010 S.CERAMIC C1608 CH 1H 100D-T [25W]

4030007000 S.CERAMIC C1608 CH 1H 090D-T [45W]

6 - 4


S.=Surface mount


C18 4030009910 S.CERAMIC C1608 CH 1H 040B-T [L]4030009530 S.CERAMIC C1608 CH 1H 030B-T [M], [H]

C19 4030006860 S.CERAMIC C1608 JB 1H 102K-TC20 4030009920 S.CERAMIC C1608 CH 1H 050B-T [L]

4030007010 S.CERAMIC C1608 CH 1H 100D-T [M], [H]C21 4030009540 S.CERAMIC C1608 CH 1H 1R5B-T [L]

4030009560 S.CERAMIC C1608 CH 1H R75B-T [M], [H]C22 4030009560 S.CERAMIC C1608 CH 1H R75B-TC23 4030006860 S.CERAMIC C1608 JB 1H 102K-TC24 4030006860 S.CERAMIC C1608 JB 1H 102K-TC25 4030009550 S.CERAMIC C1608 CH 1H 2R5B-TC26 4030006990 S.CERAMIC C1608 CH 1H 080D-T [L]

4030007010 S.CERAMIC C1608 CH 1H 100D-T [M], [H]C27 4030006860 S.CERAMIC C1608 JB 1H 102K-TC28 4030006860 S.CERAMIC C1608 JB 1H 102K-TC29 4030009530 S.CERAMIC C1608 CH 1H 030B-T [L]

4030009510 S.CERAMIC C1608 CH 1H 010B-T [M], [H]C30 4030009920 S.CERAMIC C1608 CH 1H 050B-TC32 4030006860 S.CERAMIC C1608 JB 1H 102K-TC33 4030007090 S.CERAMIC C1608 CH 1H 470J-TC34 4030006860 S.CERAMIC C1608 JB 1H 102K-TC35 4030006860 S.CERAMIC C1608 JB 1H 102K-TC36 4030009530 S.CERAMIC C1608 CH 1H 030B-T [L]

4030009520 S.CERAMIC C1608 CH 1H 020B-T [M], [H]C37 4030006860 S.CERAMIC C1608 JB 1H 102K-TC38 4030006860 S.CERAMIC C1608 JB 1H 102K-TC39 4030006990 S.CERAMIC C1608 CH 1H 080D-T [L]

4030007010 S.CERAMIC C1608 CH 1H 100D-T [M], [H]C40 4030009560 S.CERAMIC C1608 CH 1H R75B-TC41 4030007050 S.CERAMIC C1608 CH 1H 220J-TC42 4030006860 S.CERAMIC C1608 JB 1H 102K-TC43 4030006860 S.CERAMIC C1608 JB 1H 102K-TC44 4030009350 S.CERAMIC C1608 CH 1H 3R5B-T [L]

4030009550 S.CERAMIC C1608 CH 1H 2R5B-T [M], [H]C45 4030006990 S.CERAMIC C1608 CH 1H 080D-T [L]

4030007010 S.CERAMIC C1608 CH 1H 100D-T [M], [H]C46 4030006860 S.CERAMIC C1608 JB 1H 102K-TC47 4030006860 S.CERAMIC C1608 JB 1H 102K-TC48 4030007050 S.CERAMIC C1608 CH 1H 220J-TC49 4030009920 S.CERAMIC C1608 CH 1H 050B-TC50 4030006860 S.CERAMIC C1608 JB 1H 102K-TC51 4030006860 S.CERAMIC C1608 JB 1H 102K-TC52 4030007090 S.CERAMIC C1608 CH 1H 470J-TC53 4030006900 S.CERAMIC C1608 JB 1H 103K-TC54 4030006860 S.CERAMIC C1608 JB 1H 102K-TC56 4030007050 S.CERAMIC C1608 CH 1H 220J-TC58 4030006860 S.CERAMIC C1608 JB 1H 102K-TC59 4030011600 S.CERAMIC C1608 JB 1E 104K-TC60 4030006860 S.CERAMIC C1608 JB 1H 102K-TC61 4030007130 S.CERAMIC C1608 CH 1H 101J-TC62 4030007120 S.CERAMIC C1608 CH 1H 820J-TC63 4030006860 S.CERAMIC C1608 JB 1H 102K-TC64 4030011340 S.CERAMIC C1608 CH 1H 471J-TC65 4030006860 S.CERAMIC C1608 JB 1H 102K-TC66 4030006860 S.CERAMIC C1608 JB 1H 102K-TC67 4030006860 S.CERAMIC C1608 JB 1H 102K-TC69 4030007170 S.CERAMIC C1608 CH 1H 221J-TC70 4030007170 S.CERAMIC C1608 CH 1H 221J-TC71 4030011600 S.CERAMIC C1608 JB 1E 104K-TC72 4030011600 S.CERAMIC C1608 JB 1E 104K-TC74 4030011600 S.CERAMIC C1608 JB 1E 104K-TC75 4550006050 S.TANTALUM TEMSVA 0J 106M8LC76 4030006900 S.CERAMIC C1608 JB 1H 103K-TC77 4030006860 S.CERAMIC C1608 JB 1H 102K-TC78 4030006860 S.CERAMIC C1608 JB 1H 102K-TC79 4030011810 S.CERAMIC C1608 JB 1A 224K-T [L]

4030011600 S.CERAMIC C1608 JB 1E 104K-T [M], [H]C80 4030008920 S.CERAMIC C1608 JB 1H 473K-T [L]

4030011600 S.CERAMIC C1608 JB 1E 104K-T [M], [H]C81 4030006860 S.CERAMIC C1608 JB 1H 102K-TC82 4030011060 S.CERAMIC GRM31M2C2H4R0CY21L [25W]C83 4030011050 S.CERAMIC GRM31M3C2H3R0CY21L [25W]C84 4030007090 S.CERAMIC C1608 CH 1H 470J-TC85 4030006860 S.CERAMIC C1608 JB 1H 102K-TC86 4030007090 S.CERAMIC C1608 CH 1H 470J-TC87 4030006860 S.CERAMIC C1608 JB 1H 102K-TC89 4030006980 S.CERAMIC C1608 CH 1H 070D-T [L]

4030011770 S.CERAMIC C1608 CH 1H 060B-T [M], [H]C90 4030006980 S.CERAMIC C1608 CH 1H 070D-T [L]

4030011770 S.CERAMIC C1608 CH 1H 060B-T [M], [H]C91 4510005630 S.ELECTROLYTIC ECEV1EA330SP [L]

4510005750 S.ELECTROLYTIC ECEV1EA220SP [M], [H]

C92 4030009920 S.CERAMIC C1608 CH 1H 050B-TC93 4030009910 S.CERAMIC C1608 CH 1H 040B-T [25W]

4030009350 S.CERAMIC C1608 CH 1H 3R5B-T [45W]C94 4030007090 S.CERAMIC C1608 CH 1H 470J-TC95 4030006860 S.CERAMIC C1608 JB 1H 102K-TC96 4030006860 S.CERAMIC C1608 JB 1H 102K-TC97 4030007090 S.CERAMIC C1608 CH 1H 470J-TC98 4030009520 S.CERAMIC C1608 CH 1H 020B-T [25W]

4030009920 S.CERAMIC C1608 CH 1H 050B-T [45W]C99 4030006860 S.CERAMIC C1608 JB 1H 102K-TC100 4030009920 S.CERAMIC C1608 CH 1H 050B-TC101 4030006860 S.CERAMIC C1608 JB 1H 102K-TC102 4030007020 S.CERAMIC C1608 CH 1H 120J-TC103 4030009520 S.CERAMIC C1608 CH 1H 020B-TC104 4030006860 S.CERAMIC C1608 JB 1H 102K-TC105 4030006860 S.CERAMIC C1608 JB 1H 102K-TC106 4030007090 S.CERAMIC C1608 CH 1H 470J-TC107 4030006860 S.CERAMIC C1608 JB 1H 102K-TC108 4030006900 S.CERAMIC C1608 JB 1H 103K-TC109 4030006860 S.CERAMIC C1608 JB 1H 102K-TC110 4030006850 S.CERAMIC C1608 JB 1H 471K-TC111 4030007090 S.CERAMIC C1608 CH 1H 470J-TC113 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC114 4030006990 S.CERAMIC C1608 CH 1H 080D-TC115 4030011770 S.CERAMIC C1608 CH 1H 060B-TC116 4030006860 S.CERAMIC C1608 JB 1H 102K-TC117 4030006850 S.CERAMIC C1608 JB 1H 471K-TC118 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC119 4030006860 S.CERAMIC C1608 JB 1H 102K-TC120 4030007090 S.CERAMIC C1608 CH 1H 470J-TC121 4030007010 S.CERAMIC C1608 CH 1H 100D-T [L], [H]

4030006990 S.CERAMIC C1608 CH 1H 080D-T [M]C122 4030011770 S.CERAMIC C1608 CH 1H 060B-T [L], [H]

4030009920 S.CERAMIC C1608 CH 1H 050B-T [M]C123 4030007020 S.CERAMIC C1608 CH 1H 120J-T [L]

4030006990 S.CERAMIC C1608 CH 1H 080D-T [M], [H]C124 4030011770 S.CERAMIC C1608 CH 1H 060B-T [L]

4030009520 S.CERAMIC C1608 CH 1H 020B-T [M], [H]C125 4030008220 S.CERAMIC C1608 UJ 1H 070D-TC126 4030011770 S.CERAMIC C1608 CH 1H 060B-TC127 4030009350 S.CERAMIC C1608 CH 1H 3R5B-T [L]C128 4030008220 S.CERAMIC C1608 UJ 1H 070D-TC129 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC130 4030007130 S.CERAMIC C1608 CH 1H 101J-TC132 4030006860 S.CERAMIC C1608 JB 1H 102K-TC133 4610001590 S.TRIMMER TZC3R100A110R00C134 4610001920 S.TRIMMER TZC3Z060A110R00C136 4030006860 S.CERAMIC C1608 JB 1H 102K-TC137 4030006860 S.CERAMIC C1608 JB 1H 102K-TC138 4030006860 S.CERAMIC C1608 JB 1H 102K-TC139 4030011600 S.CERAMIC C1608 JB 1E 104K-TC140 4030011600 S.CERAMIC C1608 JB 1E 104K-TC141 4030006860 S.CERAMIC C1608 JB 1H 102K-TC142 4030006860 S.CERAMIC C1608 JB 1H 102K-TC143 4030006860 S.CERAMIC C1608 JB 1H 102K-TC144 4030006900 S.CERAMIC C1608 JB 1H 103K-TC145 4030007090 S.CERAMIC C1608 CH 1H 470J-TC146 4550000510 S.TANTALUM TESVA 1V 473M1-8LC147 4550000560 S.TANTALUM TESVA 1V 334M1-8LC148 4510004630 S.ELECTROLYTIC ECEV1CA100SRC150 4030007090 S.CERAMIC C1608 CH 1H 470J-TC151 4030007090 S.CERAMIC C1608 CH 1H 470J-TC152 4030007090 S.CERAMIC C1608 CH 1H 470J-TC153 4030007090 S.CERAMIC C1608 CH 1H 470J-TC154 4030007090 S.CERAMIC C1608 CH 1H 470J-TC155 4030011600 S.CERAMIC C1608 JB 1E 104K-TC156 4030007090 S.CERAMIC C1608 CH 1H 470J-TC157 4030007130 S.CERAMIC C1608 CH 1H 101J-TC158 4030007130 S.CERAMIC C1608 CH 1H 101J-TC159 4030011600 S.CERAMIC C1608 JB 1E 104K-TC160 4030007000 S.CERAMIC C1608 CH 1H 090D-TC161 4030007130 S.CERAMIC C1608 CH 1H 101J-TC162 4030006860 S.CERAMIC C1608 JB 1H 102K-TC164 4030006860 S.CERAMIC C1608 JB 1H 102K-TC165 4030006860 S.CERAMIC C1608 JB 1H 102K-TC166 4030006860 S.CERAMIC C1608 JB 1H 102K-TC167 4030008890 S.CERAMIC C1608 JB 1H 273K-TC168 4030008910 S.CERAMIC C1608 JB 1H 393K-TC169 4030008910 S.CERAMIC C1608 JB 1H 393K-TC170 4030008900 S.CERAMIC C1608 JB 1H 333K-TC171 4030006880 S.CERAMIC C1608 JB 1H 472K-TC173 4510004650 S.ELECTROLYTIC ECEV1EA4R7SR

6 - 5


S.=Surface mount


C174 4030011600 S.CERAMIC C1608 JB 1E 104K-TC176 4510005430 S.ELECTROLYTIC ECEV0JA220SRC177 4030007030 S.CERAMIC C1608 CH 1H 150J-TC178 4030007040 S.CERAMIC C1608 CH 1H 180J-TC179 4030006850 S.CERAMIC C1608 JB 1H 471K-TC180 4030011600 S.CERAMIC C1608 JB 1E 104K-TC181 4030011600 S.CERAMIC C1608 JB 1E 104K-TC182 4030011600 S.CERAMIC C1608 JB 1E 104K-TC183 4030008920 S.CERAMIC C1608 JB 1H 473K-TC184 4030011600 S.CERAMIC C1608 JB 1E 104K-TC185 4030011600 S.CERAMIC C1608 JB 1E 104K-TC186 4030006870 S.CERAMIC C1608 JB 1H 222K-TC187 4030006870 S.CERAMIC C1608 JB 1H 222K-TC188 4030011600 S.CERAMIC C1608 JB 1E 104K-TC189 4030011600 S.CERAMIC C1608 JB 1E 104K-TC190 4030007130 S.CERAMIC C1608 CH 1H 101J-TC191 4030008910 S.CERAMIC C1608 JB 1H 393K-TC192 4030006880 S.CERAMIC C1608 JB 1H 472K-TC193 4030011600 S.CERAMIC C1608 JB 1E 104K-TC194 4030007140 S.CERAMIC C1608 CH 1H 121J-TC195 4030011600 S.CERAMIC C1608 JB 1E 104K-TC196 4030006900 S.CERAMIC C1608 JB 1H 103K-TC199 4030007090 S.CERAMIC C1608 CH 1H 470J-TC200 4030011600 S.CERAMIC C1608 JB 1E 104K-TC201 4030011600 S.CERAMIC C1608 JB 1E 104K-TC202 4030011600 S.CERAMIC C1608 JB 1E 104K-TC203 4030011600 S.CERAMIC C1608 JB 1E 104K-TC204 4030007090 S.CERAMIC C1608 CH 1H 470J-TC205 4030007090 S.CERAMIC C1608 CH 1H 470J-TC206 4030007090 S.CERAMIC C1608 CH 1H 470J-TC207 4030011600 S.CERAMIC C1608 JB 1E 104K-TC209 4030007090 S.CERAMIC C1608 CH 1H 470J-TC214 4030007090 S.CERAMIC C1608 CH 1H 470J-TC215 4030007090 S.CERAMIC C1608 CH 1H 470J-TC217 4030007090 S.CERAMIC C1608 CH 1H 470J-TC219 4030007090 S.CERAMIC C1608 CH 1H 470J-TC220 4030007090 S.CERAMIC C1608 CH 1H 470J-TC224 4030007090 S.CERAMIC C1608 CH 1H 470J-TC227 4030007090 S.CERAMIC C1608 CH 1H 470J-TC228 4030007090 S.CERAMIC C1608 CH 1H 470J-TC229 4030007090 S.CERAMIC C1608 CH 1H 470J-TC231 4030007090 S.CERAMIC C1608 CH 1H 470J-TC235 4030007090 S.CERAMIC C1608 CH 1H 470J-TC236 4030007090 S.CERAMIC C1608 CH 1H 470J-TC237 4030007090 S.CERAMIC C1608 CH 1H 470J-TC238 4030006860 S.CERAMIC C1608 JB 1H 102K-TC239 4030006860 S.CERAMIC C1608 JB 1H 102K-TC240 4030008880 S.CERAMIC C1608 JB 1H 223K-TC241 4030006860 S.CERAMIC C1608 JB 1H 102K-TC242 4030010020 S.CERAMIC C1608 JB 1H 122K-TC243 4030011280 S.CERAMIC C1608 CH 1H 271J-TC244 4030007100 S.CERAMIC C1608 CH 1H 560J-TC246 4030010760 S.CERAMIC C1608 CH 1H 331J-TC247 4030006860 S.CERAMIC C1608 JB 1H 102K-TC248 4030006860 S.CERAMIC C1608 JB 1H 102K-TC249 4030006850 S.CERAMIC C1608 JB 1H 471K-TC250 4030011600 S.CERAMIC C1608 JB 1E 104K-TC251 4030011600 S.CERAMIC C1608 JB 1E 104K-TC252 4030011600 S.CERAMIC C1608 JB 1E 104K-TC253 4030011600 S.CERAMIC C1608 JB 1E 104K-TC254 4030006860 S.CERAMIC C1608 JB 1H 102K-TC255 4510005290 S.ELECTROLYTIC ECEV1EA221PC256 4510006260 S.ELECTROLYTIC ECEV1AA471UPC257 4030007090 S.CERAMIC C1608 CH 1H 470J-TC258 4510004510 ELECTROLYTIC 25 MV 470 HCC259 4030006860 S.CERAMIC C1608 JB 1H 102K-TC260 4030007090 S.CERAMIC C1608 CH 1H 470J-TC261 4030004760 S.CERAMIC C2012 JF 1H 104Z-TC262 4030011600 S.CERAMIC C1608 JB 1E 104K-TC263 4030004760 S.CERAMIC C2012 JF 1H 104Z-TC264 4030011600 S.CERAMIC C1608 JB 1E 104K-TC265 4510005290 S.ELECTROLYTIC ECEV1EA221PC266 4510004630 S.ELECTROLYTIC ECEV1CA100SRC268 4510004630 S.ELECTROLYTIC ECEV1CA100SRC269 4030006860 S.CERAMIC C1608 JB 1H 102K-TC270 4030006860 S.CERAMIC C1608 JB 1H 102K-TC271 4510005860 S.ELECTROLYTIC ECEV1HA2R2SRC272 4510005860 S.ELECTROLYTIC ECEV1HA2R2SRC273 4030006860 S.CERAMIC C1608 JB 1H 102K-TC274 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC278 4030011600 S.CERAMIC C1608 JB 1E 104K-TC279 4030011600 S.CERAMIC C1608 JB 1E 104K-T

C280 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC281 4030011340 S.CERAMIC C1608 CH 1H 471J-TC282 4030011600 S.CERAMIC C1608 JB 1E 104K-TC283 4030006860 S.CERAMIC C1608 JB 1H 102K-TC284 4030006900 S.CERAMIC C1608 JB 1H 103K-TC286 4030011600 S.CERAMIC C1608 JB 1E 104K-TC287 4030006860 S.CERAMIC C1608 JB 1H 102K-TC288 4030011600 S.CERAMIC C1608 JB 1E 104K-TC289 4030011600 S.CERAMIC C1608 JB 1E 104K-TC290 4030006860 S.CERAMIC C1608 JB 1H 102K-TC291 4030006860 S.CERAMIC C1608 JB 1H 102K-TC292 4030007090 S.CERAMIC C1608 CH 1H 470J-TC293 4030006860 S.CERAMIC C1608 JB 1H 102K-TC294 4030006860 S.CERAMIC C1608 JB 1H 102K-TC295 4510004630 S.ELECTROLYTIC ECEV1CA100SRC296 4030011600 S.CERAMIC C1608 JB 1E 104K-TC297 4030009910 S.CERAMIC C1608 CH 1H 040B-T [L]

4030007020 S.CERAMIC C1608 CH 1H 120J-T [M], [H]C298 4030006980 S.CERAMIC C1608 CH 1H 070D-T [L]

4030011770 S.CERAMIC C1608 CH 1H 060B-T [M], [H]C299 4030006980 S.CERAMIC C1608 CH 1H 070D-T [L]

4030011770 S.CERAMIC C1608 CH 1H 060B-T [M], [H]C300 4030006860 S.CERAMIC C1608 JB 1H 102K-TC301 4030011340 S.CERAMIC C1608 CH 1H 471J-TC302 4030007010 S.CERAMIC C1608 CH 1H 100D-TC303 4030006860 S.CERAMIC C1608 JB 1H 102K-TC304 4030007010 S.CERAMIC C1608 CH 1H 100D-TC305 4030007100 S.CERAMIC C1608 CH 1H 560J-TC306 4030009910 S.CERAMIC C1608 CH 1H 040B-TC307 4030006980 S.CERAMIC C1608 CH 1H 070D-TC308 4030009530 S.CERAMIC C1608 CH 1H 030B-TC309 4030006900 S.CERAMIC C1608 JB 1H 103K-TC310 4030011600 S.CERAMIC C1608 JB 1E 104K-TC311 4030011600 S.CERAMIC C1608 JB 1E 104K-TC313 4030007090 S.CERAMIC C1608 CH 1H 470J-TC314 4030006900 S.CERAMIC C1608 JB 1H 103K-TC315 4030008880 S.CERAMIC C1608 JB 1H 223K-TC316 4030009490 S.CERAMIC C1608 JB 1H 821K-TC317 4030009490 S.CERAMIC C1608 JB 1H 821K-TC318 4030011600 S.CERAMIC C1608 JB 1E 104K-TC319 4030008920 S.CERAMIC C1608 JB 1H 473K-TC320 4030008910 S.CERAMIC C1608 JB 1H 393K-TC321 4030011600 S.CERAMIC C1608 JB 1E 104K-TC322 4030006900 S.CERAMIC C1608 JB 1H 103K-TC323 4030009880 S.CERAMIC C1608 JB 1H 682K-TC324 4030011600 S.CERAMIC C1608 JB 1E 104K-TC325 4030008650 S.CERAMIC C1608 JB 1H 332K-TC327 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC328 4030017490 S.CERAMIC C1608 JB 1A 105K-TC329 4030008870 S.CERAMIC C1608 JB 1H 183K-TC330 4030007110 S.CERAMIC C1608 CH 1H 680J-TC331 4030006900 S.CERAMIC C1608 JB 1H 103K-TC332 4030017490 S.CERAMIC C1608 JB 1A 105K-TC333 4030006860 S.CERAMIC C1608 JB 1H 102K-TC334 4030009630 S.CERAMIC C1608 JB 1H 822K-TC335 4030008920 S.CERAMIC C1608 JB 1H 473K-TC336 4030009490 S.CERAMIC C1608 JB 1H 821K-TC337 4030017480 S.CERAMIC C1608 JB 1A 474K-TC338 4030006900 S.CERAMIC C1608 JB 1H 103K-TC339 4030007060 S.CERAMIC C1608 CH 1H 270J-TC340 4030006900 S.CERAMIC C1608 JB 1H 103K-TC341 4030007020 S.CERAMIC C1608 CH 1H 120J-TC342 4030007050 S.CERAMIC C1608 CH 1H 220J-TC343 4030011600 S.CERAMIC C1608 JB 1E 104K-TC344 4030008890 S.CERAMIC C1608 JB 1H 273K-TC345 4030011600 S.CERAMIC C1608 JB 1E 104K-TC347 4510006260 S.ELECTROLYTIC ECEV1AA471UPC348 4030006860 S.CERAMIC C1608 JB 1H 102K-TC349 4030011600 S.CERAMIC C1608 JB 1E 104K-TC350 4030017490 S.CERAMIC C1608 JB 1A 105K-TC351 4030008920 S.CERAMIC C1608 JB 1H 473K-TC352 4510005430 S.ELECTROLYTIC ECEV0JA220SRC353 4030007090 S.CERAMIC C1608 CH 1H 470J-TC354 4030006850 S.CERAMIC C1608 JB 1H 471K-TC355 4010005420 CERAMIC HM60SJ CH 040C 500V [45W]C356 4010005450 CERAMIC HM60SJ CH 070D 500V [45W]C357 4010005730 CERAMIC HM60SJ SL 470J 500V [45W]C358 4030007090 S.CERAMIC C1608 CH 1H 470J-TC359 4030011600 S.CERAMIC C1608 JB 1E 104K-TC360 4030011600 S.CERAMIC C1608 JB 1E 104K-TC361 4030010020 S.CERAMIC C1608 JB 1H 122K-TC362 4030011600 S.CERAMIC C1608 JB 1E 104K-T


6 - 6

S.=Surface mount

[MAIN UNIT]

C363 4030006980 S.CERAMIC C1608 CH 1H 070D-TC364 4030006980 S.CERAMIC C1608 CH 1H 070D-TC365 4030009920 S.CERAMIC C1608 CH 1H 050B-TC366 4030011600 S.CERAMIC C1608 JB 1E 104K-TC367 4030007090 S.CERAMIC C1608 CH 1H 470J-TC368 4550002890 S.TANTALUM TESVA 1A 225M1-8LC369 4030007090 S.CERAMIC C1608 CH 1H 470J-TC370 4030007090 S.CERAMIC C1608 CH 1H 470J-TC371 4030006900 S.CERAMIC C1608 JB 1H 103K-TC372 4550002890 S.TANTALUM TESVA 1A 225M1-8LC373 4030006860 S.CERAMIC C1608 JB 1H 102K-TC374 4030009920 S.CERAMIC C1608 CH 1H 050B-TC375 4030006860 S.CERAMIC C1608 JB 1H 102K-TC376 4030006860 S.CERAMIC C1608 JB 1H 102K-TC377 4030011600 S.CERAMIC C1608 JB 1E 104K-TC378 4030006860 S.CERAMIC C1608 JB 1H 102K-TC379 4030007050 S.CERAMIC C1608 CH 1H 220J-TC380 4030006860 S.CERAMIC C1608 JB 1H 102K-TC381 4030007050 S.CERAMIC C1608 CH 1H 220J-TC382 4030006860 S.CERAMIC C1608 JB 1H 102K-TC383 4030007050 S.CERAMIC C1608 CH 1H 220J-TC384 4030007050 S.CERAMIC C1608 CH 1H 220J-TC385 4030006860 S.CERAMIC C1608 JB 1H 102K-TC386 4030011600 S.CERAMIC C1608 JB 1E 104K-TC387 4030011600 S.CERAMIC C1608 JB 1E 104K-TC388 4030017490 S.CERAMIC C1608 JB 1A 105K-TC389 4510005630 S.ELECTROLYTIC ECEV1EA330SP [L]

4510005750 S.ELECTROLYTIC ECEV1EA220SP [M], [H]C390 4030007050 S.CERAMIC C1608 CH 1H 220J-TC391 4030007170 S.CERAMIC C1608 CH 1H 221J-TC392 4030006860 S.CERAMIC C1608 JB 1H 102K-TC393 4030007050 S.CERAMIC C1608 CH 1H 220J-TC394 4030007170 S.CERAMIC C1608 CH 1H 221J-TC395 4030006860 S.CERAMIC C1608 JB 1H 102K-TC396 4030007050 S.CERAMIC C1608 CH 1H 220J-TC397 4030007170 S.CERAMIC C1608 CH 1H 221J-TC398 4030006860 S.CERAMIC C1608 JB 1H 102K-TC399 4030011600 S.CERAMIC C1608 JB 1E 104K-TC400 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC401 4030007050 S.CERAMIC C1608 CH 1H 220J-TC402 4030017480 S.CERAMIC C1608 JB 1A 474K-TC403 4030006860 S.CERAMIC C1608 JB 1H 102K-T [45W]

J1 6510018430 S.CONNECTOR AXN330C038PJ2 6510023090 S.CONNECTOR 20FLT-SM1-TBJ4 6450000140 CONNECTOR HSJ0807-01-010J5 6510007080 CONNECTOR PI28A-02MJ6 6510019250 S.CONNECTOR B11B-ZR-SM3-TFJ8 6510021300 S.CONNECTOR 52365-1091J9 6510021300 S.CONNECTOR 52365-1091

W1 7120000470 JUMPER ERDS2T0W2 8900004540 CABLE OPC-453

EP1 6910013370 S.BEAD BLM18BB221SN1DEP2 6910011560 BEAD HF70BB4.5X5X1.6EP3 6910010280 BEAD HF70BB9.5X10.4X4.9EP4 0910054925 PCB B 5808E

6 - 7

REF ORDER DESCRIPTIONNO. NO.

J4 6450000140 Connector HSJ0807-01-010 1

W2 8900004540 Cable OPC-453 1

MP1 8930045070 2055 M-plate 1MP2 8510011111 1922 VCO case-1 1MP3 8510011180 1923 VCO cover 1MP4 8510011460 2055 filter case 1MP5 8510011610 2055 filter cover (A) 1MP6 8930057900 2526 module holder assembly 1MP8 8930045390 Sponge (FL) 1MP11 8510014220 2055 SP-A plate [EUR] only 1MP12 8930056510 2055 shield plate 1MP13 8510005070 599 sheild plate 1MP14 8930046150 Rubber sheet (AK)-1 1MP15 8930057730 Shield sponge (J) 1MP16 8930057730 Shield sponge (J) 1MP17 8930057830 Shield sponge (L) 1MP19 8930046770 Thermally sheet (G) [45W] only 1MP20 8930058610 Insulate plate (HD) 1


7 - 1

[CHASSIS PARTS]

J1 6510004880 Connector MR-DS-E 01 1

SP1 2510001030 Speaker VS-57-0837A 1

WS1 8600036860 Cable FX2527 P01CH 1

MP1 8010018880 2526 chassis 1MP2 8010018902 2055 cover (A)-2 1MP3 8210018571 2526 front panel-1 1MP4 8930057090 2526 front key 1MP5 8610011180 Knob N292 1MP6 8610007420 Knob spring 1MP7 8930044761 2055 SP net-1 1MP8 8930044100 2055 SP plate 1MP9 8930027480 1126 TR-A clip 1MP11 8810008660 Screw PH BT M3 × 8 NI-ZU 15MP12 8810008760 Screw PH BT M2 × 8 NI-ZU 4MP13 8810009990 Screw PH BT M3 × 8 ZK 6MP14 8930057890 Non-woven sheet (CF) 1MP15 8930057940 Shield sponge (N) [EUR] only 1

[ACCESSORY PARTS]

F1 5210000120 Fuse FGB 15A [25W] 25210000080 Fuse FGB 20A [45W] 2

MC1 Optional product Microphone HM-100N 1

W1 Optional product Cable OPC-345 [25W] 1Optional product Cable OPC-346 [45W] 1

W2 Optional product Cable OPC-049 1

MP1 8010016380 1542 mobil bracket (B) 1MP3 8820000530 Flange volt M4 × 8 NI 4MP4 8810000470 Screw PH M5 × 12 (+–) 4MP5 8810005840 Screw PH A M5 × 20 4MP6 8850000150 Flat washer M5 NI BS 4MP7 8850000390 Springe washer M5 4MP8 8830000120 Nut M5 4MP9 6910004210 731 mic hanger set 1MP10 8310053310 Label 1705 LCD seal (D) [CONV] 1

8310054140 Label 1705 LCD seal (E) [MPT] 1

[FRONT UNIT]

R12 7210003020 Variable resistor EVU-F2KFK1 1

J1 6450002210 Connector 3017-8821 1

DS12 5030002230 LCD L1-0483TAT 1

W1 8900010950 Cable OPC-1126 1

EP2 8930057820 LCD contact SRCN-2526-SP-N-W 1

MP1 8210018630 2526 reflector 1MP2 8930057150 2526 LCD holder 1MP3 8930057140 2526 earth plate 2MP4 8930057650 2526 LCD filter 1

[MAIN UNIT]

Screw abbreviations BT: Self-tapping PH: Pan headZK: Black BS: BrassNI: Nickel NI-ZU: Nickel-Zinc

MC1

MP1

MP9W2

W1

MP3

MP4

MP5

MP6 MP7 MP8 F1

ICOM

ORDERNO.


ORDERNO.


ORDERNO.


ORDERNO.


7 - 2

MP3 (C)

MP5 (C)

MP4 (C)

MP2 (F)

DS12 (F)

EP2 (F)

MP1 (F)

MP3 (F)

MP4 (F) FRONT UNIT

W1 (F)

J1 (F)

MP12 (C)

MP1 (C)

MP13 (C)

MP11 (C)

MP5 (M)

MP2 (M)

MP3 (M)

MP11 (C)

MP6 (M)

MP13 (C)

MP9 (C) MP8 (M)

W2 (M)

J4 (M)

MP14 (M)

MP20 (M)

MP1 (M)

MAIN UNIT

MP4 (M)

MP13 (M)

MP11 (C)

J1 (C)

MP7 (C)

SP1 (C)

MP8 (C)

MP11 (C)

Unit abbreviations (F): FRONT UNIT(M): MAIN UNIT(C): CHASSIS PARTS

MP2 (C)WS1 (C)

MP14 (C)

R12 (F)

MP15 (M)

MP12 (M)

MP11 (M)

MP16 (M)

MP19 (M)

MP15 (C)MP17 (M)

8 - 1


• TRANSSISTORS AND FET’S • DIODES

B

C

E

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

C

ED

G

S

G

G

D

D

S

S

S

D

G

G

S

D

G1

G2

S

D

D

S

G2

G1

B

E

C

B

E

C

B

E

C E1

B1

B2

C1

C2

E1

E2

B2

C1

B1

C2

2SB1132 T100 R 2SC3356 R24 T2B 2SC4116 BL 2SC4213 B 2SC4215 O

2SC4226 T1 R25 2SC5107 O 2SD1664 T100Q 2SJ144 GR 2SJ377

2SK880 Y 2SK1829 3SK272 3SK293 DTA144EUA T106

DTC144EUA T106 DTC363 EK XP1214 XP6501 AB

(Symbol: BAR) (Symbol: R24) (Symbol: LL) (Symbol: AB) (Symbol: QO)

(Symbol: R25) (Symbol: MFO) (Symbol: DAQ) (Symbol: VG) (Symbol: 4L)

(Symbol: XY) (Symbol: K1) (Symbol: K) (Symbol: UF) (Symbol: 16)

(Symbol: 26) (Symbol: H27) (Symbol: 9H) (Symbol: 5N)

C

A1

A2

A C A C A C

A C

red dot

A C A C A C

DA221 TL DAN222TL HVC350B HVC362 MA2S111

MA368 MA4PH224 MA77 MA728 RB706F-40 T106

UM9401F

(Symbol: K) (Symbol: N) (Symbol: B0) (Symbol: V2) (Symbol: A)

(Symbol: 6L)(Symbol: None) (Symbol: 4B) (Symbol: 2A) (Symbol: 3J)

(Symbol: None)

Black line

A C


9-1 FRONT UNIT• TOP VIEW

9 - 1

8V

2 8

tomicrophone

1 7

J1

AF

OM

ICE

GN

D

CLO

PT

TM

ICC

LI

1to MAIN unit J2

19

2 20

J2

GN

DP

WR

LIN

HLC

SLC

KLS

OA

FV

IC

LIG

ND

MIC

8V 5V KR

0K

R1

KR

2F

SW

HO

RN

CLO

PT

TA

FO

1

16

48

33

32 17

49 64

9 - 2

• BOTTOM VIEW (FRONT UNIT)

1

4

8

5 1

4

8

5

1 12

24 13

1

10

20

11

1

8

16

9

14

85

19

to FRONTunit J2

1

20 2J2

GN

DP

WR

LIN

HLC

SLC

KLS

OA

FV

IC

LIG

ND

MIC

8V 5V KR

0K

R1

KR

2F

SW

HO

RN

CLO

PT

TA

FO

GN

D

30 16

1 15J1

5V VC

CM

MU

TA

FO

NB

EP

OR

MU

TD

ET

DIS

CR

EM

CC

SC

IRQ

SO SI

SC

K

PT

TI

PT

TOM

CO

TM

CIN

AU

XB

US

YM

DW

NS

IGO

PT

1O

PT

2O

PT

3G

ND

OP

V3

OP

V2

OP

V1

to optional unit

PTT11

to optionalcable OPC-617

1

J6

GNDIN

GNDDISCGNDPAAFGND

HORNDIMVCC

PG

O2

9 1

10 2J8

PG

I3P

GI1

NR

XD

8V

GN

DP

GO

1P

GI2

IGS

WN

TX

D

10 2

9 1

J9

VC

CM

D1

XC

TS

XR

XD

5V

GN

DG

ND

RE

SX

RT

SX

TX

D

SP- 21

to speaker

J5

SP+

ANT

J1

W1

GND

to DC cable

HV

9-2 MAIN UNIT• TOP VIEW

9 - 3

1

4

8

1

7

14

8

5

12

11 1

1

7

14

823 33

22

44

34

1

25

26

5051

75

76

100

9 - 4

• BOTTOM VIEW (MAIN UNIT)


DATA BUS LINE

CONTROL LINE

RX LINE

TX LINE

COMMON LINE

Explanatory notes

Q32 DTC144EUSW

DIM

HORN

DISC DET

PTT

IN

ACC

Q33 DTC144EUSW

DIM

HORNO

EPTT

SWLINE MOD

VCC

DSA3A1D22

PROTECT

MD1

PWON

Q41 DTA144EUD28 DAN222

SW

PWR

SWPOWER HV

19.66 MHz

HN58X24128FPI

CR-520X4

MA77D27

EEPROM

SW

IC23

FRONT UNIT

AF VR

D4, D5, D6: MA2S111

PWR

DN∗2

UP∗2

P0-P4

AFVI

POSW

ESDAESCL

KR0-KR2KEY MATRIX

OPC-453W2

IC24S-80942ANMP-DD6

CSFT

RESRESET

SHIFTDTC144EUQ242SJ377Q23

CPU5

+5REG

AN78L05MIC10

Q38

REM

DTC144EU

CENC2

TENC

DUSESWFIL

D23 DA221

IC9 TA7808F

Q29 DTC144EU

8V

T8V

R8V

TXC

TMUTQ25 2SD1664

Q26 2SD1664

REGT8

REGR8

REG+8

E

D

F

SIGSIGOUT

D26 MA2S111Q31 2SJ144

J6

PROGIO

MD1RESXRTSXCTS

IGSWPGO1, 2PGI1-3

XRXDXTXD

USB232CMAP27FLAH

J9

NRXD

J8NTXD

GPS

Q44 DTC144EUD37 DAN222D36 DAN222D35 DAN222

DTC144EUQ42

SIGOUT

AFONO

REM

BEPO

MCOTMCIN

PTTOPTTI

SCK

BUSY

OPV3 (AFCL)OPV2 (AMSK)OPV1 (APST)

J1

OPT3OPT2OPT1

CCS

MMUT

RMUT

SOSI

CIRQ

UNITOPTION

AFCLARDTARTMSO

APST

ADIN

ATRDSOSCKDAST

SCK

AMSK

D24 DA221

LC73872MIC19

Q30 DTC144EU

5V

DDSODDAC DDST

DECDTMF

2SC4116

(J1)

3.58 MHzCR-563IC14

X3

TC35453F

Q28 XP6501Q27 2SB1132

MCINCOMPANDER

REG+5

Q43 DTC144EU

LINHSW

LPF

LPF

TONESENC

Q37

2SC4116Q36

(J1)MCOT

2SC4116 CENC1CENC0

DSDASCK

CPU HD64F2268TFIC20

LINH, LCS, LCK, LSO

FSWHORN

LC75824W

COM1-4SEG1-40

KS0-KS2

IC1

LCD DRIVER

DIM2DIM1

8V

DS7-DS11

DS1-DS6

8V

Q1, Q4: DTA144EUQ2, Q3: DTC144EU

SML-311YT

SML-311YT

SWLED

CLO CLI

AFOMIC

MIC JACK

PTT

J1

D1, D2, D3: RB706F-40

TC75S51FIC2

L1-0483TAT

Q48DTC144EU

J6 PAAF

C

PTTO (J1)

PTTI (J1)DS12

LCD

MICI AFAMP

SW

D31 DAN222

DTC144EUQ50

SW

DTC144EUQ49

PA SW

NJM12902VIC21

M62334FPIC7

TONECTCSSIG

TC4W53FUIC15

PM/FM AMP

D/A

A

DEREXPAN

Q21

DEMODMSK

HPF AMP LPF

LPF

HPF AMP AMP

LPFLIMITAMP

AMPHPF BUFF

HPF

AMP

BPF MODMSK

NJM12902V

CTCS

MICO

IC6

IC21

M62364FP

SSORCOMPRE

D/A

DUSE

DIS

C

TENC

MICI

B

BALREF

MOD

TC4S66FIC22

XP1214Q35

SWFIL

CDECNJM12904V

IC5

NJM12902VIC21

LPF

LPF

SDEC

SWFIL

RATIONRESTO-

450 kHz

NOIS

DE

TS

QIN

CDBC450CX24X1

Q6 DTA144EUQ5 2SC4116

NWCSWW/N

ALFYM450F=KFI2

RSSISQL AMPDETECTOR

2SC4213Q20

FSWSWFIL

MIXER

XTALBPF

TONEBEEPOBEEP

NJM12902VIC21

W/N

DTC144EUQ22

SWNWC

T3

BPFBPF

LPF

D/A

T4

TC4S66FIC25

MOD

M62364FPIC6

Q40 DTC144EUQ39 DTC363EK

TA75S01FIC18

AFONO

AFON

AMP

Q23SK293

T2

HG

LA4425AIC8

T1

J4

SP-

SP+ INT SP

MA2S111D32

TMUTSW

MUTE

DETPWR

MA2S111D33

D8 HVC350B

TC75S51FIC2

T4

BPF

AFAMP

AFMUTE

BPFRFAMP

GATECTRL

MA2S111D25

D4 HVC350B

Q1 2SK1829

D10 HVC350B D9 HVC350B

RX LO353.65-473.65 MHz

Q33SK272

RSSI

[EUR][USA], [GEN]

FL-335

46.35 MHz

Q12

Q4FL-313

FI1

2SC4215

2SC5107

D17 HVC350B

D18

IC1TA31136FN(D)

MA368

2SC4226Q14

TX VCO

MOD

LPF

IF AMPSECOND MIXER

DET

UNLKSCKSOPLST

Q342SC4116

x3

45.9 MHz

15.3 MHz

FRACTIONAL N

MOD

BPF

HVC362D21

IC11

AMP

TC75S51F

BAL

REF

D20 MA2S111Q19 SC4215

CR-671A

8V

X2SA7026DH

IC4

2SK880Q18

BUFF

LOOPFIL

RIPPLEFIL

PLL IC

LVIN

MA2S111D19

D16 HVC350B 2SC4226Q13

2SC4116Q17

RX VCO

TXC

D14, D15

TX/RXSW

Q11

BUFF

BUFF

AMP

CERAMICBPF

BUFF

LPF

Q16

Q10

XP1214Q15DTC144EU

2SC5107 2SC5107 MA77

SWVCO

MAIN UNIT

RA30H4047M [L]RA30H4452M [M]-25W, [H]RA45H4452M [M]-45W

IC3

2SC5107Q9

YGRAMP

PREDRIVE

PWRAMP

LPF LPF LPFANTSW

APCAMP

2SC3356Q8

D2 UM9401F

D6 MA77D5 MA4PH224 D1, D11

MA728

400-520 MHz

10 - 1


5V

8V

5V

5V

8V

AFVI

CLI (HANG)

CLO

GNDMICMICEPTTAFO

CLI

8V

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

SE

G37

SE

G36

SE

G35

SE

G34

SE

G33

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

SE

G1

CO

M1

SE

G3

SE

G2

CO

M2

CO

M3

CO

M4

KS2KS1

KR2

5V

MIC

PTT

8V

PW

R

AF

VI

HORNFSW

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

SE

G37

SE

G36

SE

G35

SE

G34

SE

G33

SE

G32

SE

G31

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

SE

G3

SE

G2

SE

G1

CO

M1

KS0

CO

M4

CO

M3

CO

M2

DIM2

CLI

CLOAFO

KS1

LCS

LCK

LSO

LIN

H

CO

M4

CO

M3

CO

M2

CO

M1

SE

G40

SE

G39

SE

G38

KS0

KS2DIM1DIM2

SEG1SEG2SEG3SEG4SEG5

SE

G6

SE

G7

SE

G8

SE

G9

SE

G10

SE

G11

SE

G12

SE

G13

SE

G14

SE

G15

SE

G16

SE

G17

SE

G18

SE

G19

SE

G20

SE

G21

SEG34SEG33SEG32SEG31SEG30SEG29SEG28SEG27SEG26SEG25SEG24SEG23SEG22

SEG35SEG36SEG37

KR1KR0

DIM1

D5

D6

MA2S111

MA2S111

MA2S111

D4

0.22C37

47k

R25

5

43

2

1

IC2TC75S51F

2.2kR24

10k

R23

10k

R22

1MR21

3.9kR20

4.7

C39 0.

001

C41

0.01 C40

R81k

10kR19

10kR18

10kR17

R12

EV

U-F

2KF

K1B

14

1kR9

1kR16

48C

OM

4

47C

OM

3

46C

OM

2

45C

OM

1

44S

EG

40

43S

EG

39

42S

EG

38

41S

EG

37

40S

EG

36

39S

EG

35

38S

EG

34

37S

EG

33

36S

EG

32

35S

EG

31

34S

EG

30

33S

EG

29

32S

EG

28

31S

EG

27

30S

EG

26

29S

EG

25

28S

EG

24

27S

EG

23

26S

EG

22

25S

EG

21

24S

EG

20

23S

EG

19

22S

EG

18

21S

EG

17

20S

EG

16

19S

EG

15

18S

EG

14

17S

EG

13

16S

EG

12

15S

EG

11

14S

EG

10

13S

EG

9

12S

EG

8

11S

EG

7

10S

EG

6

9S

EG

5

8S

EG

4

7S

EG

3

6S

EG

2

5S

EG

1

4C

OM

1

3C

OM

2

2C

OM

3

1C

OM

4

DS12

FRONT UNIT

L1-0483TAT

100kR14

RB706F-40D1

DTA144EUQ4

SML-311YT

DS11

DS1-DS11

DTC144EUQ3

DTC144EUQ2

100p

C33

270kR13

DI

64C

L63

CE

62IN

H61

OS

C60

VS

S59

VD

D2

58V

DD

157

VD

D56

CO

M4

55C

OM

354

CO

M2

53C

OM

152

S51

51S

5050

S49

49

S4848 S4747 S4646 S4545 S4444 S4343 S4242 S4141 S4040 S3939 S3838 S3737 S3636 S3535 S3434 S3333

S32

32

S31

31

S30

30

S29

29

S28

28

S27

27

S26

26

S25

25

S24

24

S23

23

S22

22

S21

21

S20

20

S19

19

S18

18

S17

17

S16 16

S15 15

S14 14

S13 13

P12/S12 12

P11/S11 11

P10/S10 10

P9/S9 9

P8/S8 8

P7/S7 7

P6/S6 6

P5/S5 5

P4/S4 4

P3/S3 3

P2/S2 2

P1/S1 1

IC1LC75824W

0.1

C32

0.1

C31 0.1

C30

S4

47p

C29

47p

C28

47p

C27

47p

C26

47p

C25

47p

C24

47p

C34

S10

P4

S9

P3

S8

P2

S6

P1

S5

P0

S7

V

S3S2

S1

PWR

DTA144EUQ1

390

R7

1kR6

4.7kR5

390R4

390R3

DS10

DS9

DS8

DS7

DS6

DS5

DS4

DS3

DS2

DS1

RB706F-40D3

RB706F-40D2

47p

C23

47p

C22

47p

C21

0.00

1C

20

0.00

1C

19

47p

C18

1µL1

1kR2

1kR1

J1

tomicjack

47pC1

TX: 5.0VRX: 0V

2.2V

ON: 7.6VDIM: 6.1VOFF: 0V

GND

to MAINunit J2

AFO

HORNFSW

MIC

CLIGNDPTT

CLOAFVILSOLCKLCSLINH

KR2KR1KR0

PWR5V8V

PW

R

CLI

CLO MIC

HO

RN

FS

W

AF

O

LIN

H

LCS

LCK

LSO

AF

VI

KR

0

KR

1

KR

2

PT

T

100kR11

100kR10

J2

C17

4

7p

C16

4

7p

C15

4

7p

C14

4

7p

C13

4

7p

C12

4

7p

C11

4

7p

C10

4

7p

C2

47

p

C3

47

p

C4

4

7p

C5

47

p

C6

47

p

C7

47

p

C8

47

p

C9

47

p

C35

4

7p

V

11 - 1

MAINUNIT(2)J1

toMIC

toOptionalunit

JACK

J2

GND

PWR

LINH

LCS

LCK

LSO

AFVI

CLI

GND

MIC

8V

5V

KR0

KR1

KR2

FSW

HORN

CLO

PTT

AFO

8VCL0AFOPTT

FRONT UNITJ2

J1

PTTI

PTTO

MCOT

MCIN

AUX

BUSY

MDWN

SIG

OPT1

OPT2

OPT3

GND

OPV3

OPV2

OPV1

GND

5V

VCC

MMUT

AFON

BEPO

RMUT

DET

DISC

REM

CCS

CIRQ

SO

SI

SCK

BUS LINE1

R138 47k

R139 47k

R140 47k

8V5V

R17

8

3

30k

R17

7

3

30k

R17

6

3

30k

R17

5

1

MR

174

1M

R17

3

1

M

R14

110

0k

R14

210

0k

C23

7 47

pC

APSTSI

AMSKSO

AFCL

CCSOPT3

OPT2DISCOPT1

DETSIGOUT

RMUT

BEPOBUSY

AFONO

MMUTMCIN

MCOT

PTTO

AFOMICPTTGNDCLOCLIHORNAFVIFSWLSO

VCCGNDMDIGNDXCTSRESXRXDXRTS5VXTXD

PGO2GNDPGI3PGO1PGI1PGI2INRXDIGSW8VNTXD

KR2LCKKR1LCSKR0LINH5VPWR8VGND

BUS LINE2

R29

61k

R29

51kR

293

1k

R29

41k

C20

70.

1

R316100k

HAN

G

MICIAFO

R2841k

R14

410

0k

C21

9

4

7p

C22

8

4

7pC

227

47p

C22

0

4

7pC

217

47p

C22

9

4

7pC

199

47p

C23

1

4

7p

C22

4

4

7pC

206

47p

C35

3

4

7pC

204

47p

C23

5

4

7pC

354

470

pC

214

47p

C20

9

4

7p

R14

510

0k

POSWLINHLCS

LSCKKR0KR1KR2FSW

LSOAFVI

CLIHANG

HORNOCLO

13

5

2

4C36

747

p

R10822k

R30722k

BAL

VAG

R30

610

0 C3660.1C

162

0.00

1

IC11TC75S51F

R305220k

C3722.2

REF C378

0.001

R10747k

D21

HVC

362

C161100p

C16

09p

X2CR-671A

R10

682

k

R11

047

Q192SC4215

R10

547

kD

20M

A2S1

11

C15

710

0pC

158

100p

R10

41.

2k

R209NTCG20

C20

30.

1

R21

010

0k

TEM

P

1234567891011

121314151617181920

LOOKTESTVDDGND

RFIN+RFIN-

GNDCPPHPPHI

GNDCPPHAAUXINVDDCPRSETREFIN-REFIN+CLOCKDATASTROBEPON

IC4SA7026DH

C13

6 0.

001

R88

15k

R10

2 15

k

R1091k

C14

4 0.

01

C15

5 0.

1

C15

2 47

p

C15

3 47

p

C15

4 47

p

UNLKPLSTSO

C15647p

C15

90.

1L2

91.

8µ

C1400.1

C31

40.

01

C30

00.

001

LVIN

R10

11k

C14

30.

001

Q182SK880

R10

047

k

C14

10.

001

CP1

R991k

R92120k

R91

22k[

L]47

k[M

],[H

]

C13

20.

001

R8910k

C14

70.

33

C13

010

0pR

964.

7kR9710

R95470

C14

60.

047

C35

847

p

R90100k

MO

D

R29

110

0kC

350

1

R292

8V5VVCC

8.2k

C14547p

8V5V

D19

MA2

S111

C14

810

R98

2.2k

Q172SC4116

R93

47R

9447

L271.8µ C

125

7p C13

310

p

D16

HVC

350B

C12

46p

[L]

2p[M

],[H

]

C12

73.

5p[L

]

L25

11n

C12312p[L]8p[M],[H]

C12

110

p[L]

,[H]

8p[M

]

C12

26p

[L],[

H]

5p[M

]

R824.7

R843.3k

R833.3k

Q132SC4226

L24

1.8µ

C11

90.

001

C12

047

p

C13

90.

1EP1

L281.8µ C

128

7p C13

46p

D17

HVC

350B

L26

11n

C1266p

C11

48p

C11

56p

R8110

R853.3k

R793.3k

L23

1.8 µ

C11

747

0p

C11

60.

001

R78560

R801k

C12

90.

5p

C29

97p

[L]

6p[M

],[H

]

C29

87p

[L]

6p[M

],[H

]

L3218n[L]15n[M],[H]

D18

MA3

68

Q15XP1214

5

4

1

2

3

C1180.5p

C1130.5p

R77

10k

C38

70.

1

Q16DTC144EU

C11

147

p

C11

047

0p

R76

220

C10

40.

001

R74

100k

[L],[

M]-4

5W68

k[M

]-25W

,[H]

R72

470

Q112SC5107

R73

220

L22

27n

Q122SC5107

R75

150k

C10

50.

001

C1032p

C10212p

R7133

C30

147

0p

R23

447

k

Q102SC5107

R70

100

L21

27n[

L]22

n[M

],[H

]

C10

90.

001

C1005p

D14MA77

C1080.01 R

681k

R67

10k

C982p[25W]5p[45W]

R66

100k

C99

0.00

1

Q92SC5107

R65

220[

25W

]15

0[45

W]

C10

70.

001

L20

27n[

L]22

n[M

],[H

]

C10

10.

001

C934p[25W]3.5p[45W]

C4000.5p

C96

0.00

1

C97

47p

L19

18n[

L]15

n[M

],[H

]

R61

56[2

5W]

150[

45W

]

Q82SC3356

C10

647

p

C37

60.

001

C925p

R30

933

0[25

W]

820[

45W

]

R31018[25W]5.6[45W]

R31

133

0[25

W]

820[

45W

]

C90

7p[L

]6p

[M],[

H]

C89

7p[L

]6p

[M],[

H]

L1818n[L]15n[M],[H]

IN VCC

1VC

C2

OU

T6 5

4 3 2 1

C13

8 0.

001

IC3RA30H4047M[L]RA30H4452M[M]-25W,[H]RA45H4452M[M]-45W

C36

82.

2

C87

0.00

1

C86

47p

C83

3p[2

5W]

C35

54p

[45W

]

C35

67p

[45W

]

C40

122

p

C84

47p

C85

0.00

1

C91

33[L

]22

[M],[

H]

L16LA-232[25W]LA-382[45W]

C82

4p[2

5W]

FI4NFM60R-20T152

FI5NFM60R-20T152[45W]

FI3NFM60R-20T152

C38

00.

001

C37

922

p

C38

122

p

C38

20.

001

L37

0.1µ

R9

220

R8

220

L5 LW-2

5C

1247

0p

C37

50.

001

C13

47p

D2UM9401F[25W]

D3XB15A407[45W]

L4 15n

C15

8p

T8V

C36

55pR

694.

7k

D15MA77R

5010

kR

235

1k C30

30.

001

C30

210

p

R8VANT

C30410p

Q342SC4116

R23

768

0k

L35

0.22

µ

R23

61.

2kC

309

0.01

C30

556

pC3064p

C30

77p L3

30.

82µ

R62

12k[

25W

]22

k[45

W]

C37

45p

C95

0.00

1

C94

47p

C38

322

p

C38

422

p

TXC

T8V

T8VR8V

R8V

5V

5V

HV

C38

50.

001

C39

622

p

C39

722

0p

C39

80.

001

C39

322

p

C39

422

0p

C39

50.

001

C39

022

p

C39

122

0p

C39

20.

001

12345678 9

10111213141516

OSCINOSCOUTMIXOUTVCCIFINDECFILOUTFILIN

MIXINGND

N-RECN-DET

RSSIIFOUTQUAD

AFOUT

IC1TA31136FN

R4447k C

7022

0p

C71

0.1

C69

220pC371

0.01

R30

833

0 R4533k R

461.

5k

R47

3.3k

O I

FI2ALFYM450F=K

C30

83p

5V

T8V

R39

47

C67

0.00

1

C75

10

SQIN

R38

100k

NO

IS

R36

3.9k

X1

CD

BC45

0CX2

4

C61100p

C6282pC

348

0.00

1C

650.

001

RSS

I C64

470p

C66

0.00

1

Q5

Q512SC4116[45W]

2SC4116

R41

47k

R4247k

C72

0.1Q6

DTA144EU

C9

6p C8

2p

C7

7p[L

]6p

[M],[

H]

C6

3p

C162p[L]1p[M],[H]

C1447p[25W]

C35747p[45W]

L3LA-382

L2LA-232

C5

0.00

1

C4

6p

R3

47[2

5W]

150[

45W

]

C3

0.00

1

C2

7p C1

7p

L1LA-232[25W]LA-382[45W]

R1

100k

R7

100[

25W

]15

0[45

W]

R6

100

D11

MA7

28

R4

100

D1

MA7

28

R5

100

C11

0.00

1

C10

0.00

1

R35

1k

R8V

T8V

R8V

R29

047

0

C60

0.00

1R

3412

0k

C580.001

R33150

R32100

Q42SC4215

FI1FL-313 [USA], [GEN]FL-335 [EUR]

C56

22p

L13

0.27

µ

C52

47p

R31

100

R30

1k

R29

120

C50

0.00

1

C48

22p

C54

0.00

1

C51

0.00

1

C53

0.01

Q33SK272

R25

4.7k

C45

8p[L

]10

p[M

],[H

]

D10

HVC

350B

C44

3.5p

[L]

2.5p

[M],[

H]

L11

12n[

L]10

n [M

],[H

]

R23

220k

R2410k

C47

0.00

1

C46

0.00

1

L3818n

C495p

L12

33n

C36

47p C

363

7p

C38

0.00

1

R28

910

0

C36

947

p

C37

0.00

1

R20

1k

L9 12n[

L]10

n[M

],[H

]

C36

3p[L

]2p

[M],[

H]

T4

C39

8p[L

]10

p [M

],[H

]

D9

HVC

350B

R21

220k

C42

0.00

1

R2210k

C43

0.00

1

T3

R17

1

Q23SK293

C32

0.00

1

C37

047

p

R16

150

R15

82k

L8 12n[

L]10

n [M

],[H

]

C35

0.00

1

R19

220k

R18

10k

R20

84.

7

C59

0.1

C34

0.00

1R

101.

8k

Q12SK1829

C305p

C29

3p[L

]1p

[M],[

H]

C28

0.00

1

R1410k

C27

0.00

1

R13

220k

D4

HVC

350B

C26

8p[L

]10

p[M

],[H

]

T2

RSS

I

R206470k

R20

722

0k

D25

MA2

S111

C220.75p

L7 15n[

L]10

n[M

],[H

]

C21

1.5p

[L]

0.75

p[M

],[H

]C

230.

001

R1210k

C24

0.00

1

R11

220k

D8

HVC

350B

C20

5p[L

]10

p[M

],[H

]

T1

L31

47n

C18

4p[L

]3p

[M],[

H]

D6

MA7

7

D5

MA4

PH22

4

C17

10p[

25W

]9p

[45W

]

C19 0.001L615n

C81

0.00

1

R5847[L]100[M],[H]

C77

0.00

1

R53

100

C76

0.01

42

31

5

R56150k

C790.22[L]0.1[M],[H]

D32MA2S111

C38

81

C40

30.

001

[45W

]

R32

5PT

H9C

32[4

5W]

IC2TC75S51F

C80

0.04

7[L]

0.1[

M],[

H]

R59

10k[

25W

]12

k[45

W]

R52

10k

D33

MA2

S111

T4

R5710k

C780.001

R5410k

C3347p

TMU

T

R552.2k[L]1k[M],[H]

R323100k[45W]

C31

347

p

R2100

R43470

REM

DET

NW

C

NWC

VCCVCC

C23

6 47

p

C24

7 0.

001

C23

9 0.

001

C23

8 0.

001

C21

5 47

p

J9

J8

XTXD

XRXD

XRTS

XCTS

RES

MD

1

R155100k

NTXDNRXD

R15

110

0k

R15

210

0k

Q44DTC144EU IGSW

D36DAN222 PGI1

D35DAN222

PGI2

R15

310

0k

PGI3

R158 10kR157 10k

PGO1PGO2

SCK

SCK

CIRQ

D34

MA2

S111

R23

256

C14

20.

001

C74

0.1

C4122p

C400.75p

EP2

R86220k

MICEMICGNDCLI

MAIN UNIT (1)

C20

5

4

7p

R143100k

R154100k

Q42DTC144EU

D37DAN222

C13

70.

001

C15047p

C29

74p

[L]

12p[

M],[

H]

Q142SC4226

R401.5k

C63

0.00

1R

373.

3k [N

/W]

4.7k

[N/M

]

C252.5p

C38

933

[L]

22[M

],[H

]

T8V

R8V

5V

R32

447

k

LOCK:5.0VUNLK:0V

1.2Vp-p(15.3MHz)

5.0V6.9V

TX:3.0VRX:0V

TX:3.0VRX:0V

TX:0VRX:5.0V

800mVrms

5.8V

5.1V5.5V

TX:0VRX:2.9V

TX:2.9VRX:0V

TX:2.1VRX:2.2V

TX:6.5VRX:0V

TX:5.4VRX:0V

3.0V

WIDE:0VNAR:5.0V

4.9V TX:0VRX:5.4V

TX:0VRX:7.3V

TX:0VRX:0.8V


TX:0VRX:7.3V

TX:0VRX:1.2V

TX:0VRX:8.0V TX:3.6V

RX:0V

TX:0VRX:5.0V

11 - 2

R32

03.

3k

12345678910111213141516171819202122232425

26272829303132333435363738394041424344454647484950

51525354555657585960616263646566676869707172737475

76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 9910

0

MAINUNIT(1)

IC20HD64F2268TF

PM6/SEG31PM5/SEG30PM4/SEG29PM3/SEG28PM2/SEG27PM1/SEG26PM0/SEG25PL7/SEG24PL6/SEG23PL5/SEG22PL4/SEG21

CVCCPL3/SEG20

PL2/SEG19PL1/SEG18PL0/SEG17PK7/SEG16PK6/SEG15PK5/SEG14PK4/SEG13PK3/SEG12PK2/SEG11PK1/SEG10PK0/SEG9

VSS

PJ7/

WKP

7/SE

G8

PJ6/

WKP

6/SE

G7

PJ5/

WKP

5/SE

G6

PJ4/

WKP

4/SE

G5

PJ3/

WKP

3/SE

G4

PJ2/

WKP

2/SE

G3

PJ1/

WKP

1/SE

G2

PJ0/

WKP

0/SE

G1

P10/

TIO

CA0

P11/

TIO

CB0

P12/

TIO

CC

0/TC

LKA

P13/

TIO

CD

0/TC

LKB

P14/

TIO

CA1

/IRQ

0P1

5/TI

OC

B1/T

CLK

CP1

6/TI

OC

A2/IR

Q1

P17/

TIO

CB2

/TC

LKD

AVSS

P97/

AN9/

DA1

P96/

AN8/

DA0

P47/

AN7

P46/

AN6

P45/

AN5

P44/

AN4

P43/

AN3

P42/

AN2

P41/AN1P40/AN0VREFAVCCPH7/TONED/TMCI4MD1OSC2OSC1RESNMISTBYVCCXTALVSSEXTALFWEMD2P77/TXD2P76/RXD2P75/TMD3/SCK2P74/TMO2P73/TMO1P72/TMO0

P71/TMRI23/TMCI23P70/TMRI01/TMCI01

P30/

TXD

0P3

1/R

XD0

P32/

SCK0

/SD

A1/IR

Q4

P33/

TXD

1/SC

L1P3

4/R

XD1/

SDA0

P35/

SCK1

/SC

L0/IR

Q5

PF3/

ADTR

G/IR

Q3

C2

C1

V3

V2

V1

PH3/

CO

M4

PH2/

CO

M3

PH1/

CO

M2

PH0/

CO

M1

PN7/

SEG

40PN

6/SE

G39

PN5/

SEG

38PN

4/SE

G37

PN3/

SEG

36PN

2/SE

G35

PN1/

SEG

34PN

0/SE

G33

PM7/

SEG

32

BUS LINE18V5V

BUS LINE2

T8VR8VANT

1234567891011

1213141516171819202122

23 24 25 26 27 28 29 30 31 32 33

3435363738394041424344

RXF

OR

XGS

RXI

NM

SKG

SM

SKIN

TXO

UT

IOC

GS

IOC

INTX

FOAG

ND

CST

MICINMICGSCALOALCOCMPINCCHGCMPOTXFIVDDAVDDDSTB

DIN

DC

KR

EGS1

REG

S2XO

UT

XIN

MSK

ETR

DR

RM

RD

TFC

LR

VSSDVSSA

MSKSTPWROPPWRONPWRGSPWRINEXPOECHG

EXPGSEXPIN

IC14TC35453F

DET

DISC

B

R11122k

C16

40.

001

C1650.001

C1660.001

R11

339

0k

R28

54.

7k

SDEC

R24

110

0k

R24239k

C316820p

R24382k

C31

782

0p

R24

518

0kC

318

0.1

-+

910

8

IC21cNJM12902V

R244390k

R2461.5k

C31

90.

047

R23

310

0k

R12

010

0k

Q202SC4213

R11

868

k

R11

918

0k

R11

512

k

C1670.027

C1680.039

C1690.039

R1161.5k

+-

56

7

IC21bNJM12902V

R1175.6k

C1700.033

C17

10.

0047

MC

OT

MC

IN

A

C1870.0022

C1860.0022

C1880.1

R12

210

k

Q212SC4116

R12

110

k

C18

50.

1

R12

34.

7k

R12

522

k

R12

433

k

C189 0.1

C17

622

R230 10k R129 470kC190100p

R130 27k R131 68k

C180 0.1C174 0.1

C181 0.1

R12722k

C36

10.

0012

R12622k

APST

5V

X3CR-563

C17

715

p

C17

818

p

ADIN

SCK

ADIN

AMSK

ATR

D

SO

AFC

L

R13

71k

ARTM

ARD

T

C193 0.1

R136 1k

C195 0.1

C194120p

R135100k

R134150k

R133220k

C1920.0047

C19

10.

039R132

56k

C1960.01

8765

1234

VCCWPSCLSDA

A0A1A2

VSS

IC23HN58X24128FPI

ESD

AES

CL

R282100k

5V

R281 10k

C34

30.

11234567 8

91011121314

IC19LC73872M

INPUTNCPOOSCOOSCINCVSS LOADB

SDACKSTDESTNC

VDDMICI

5V

5V

5V

5V

FSWC

311

0.1

C18

20.

1

DD

AC

R23

810

0k

DD

ST

DD

SD

123456789

101112 13

1415161718192021222324

VIN1VOUT1VOUT2VIN2VDDLDCLKDIVIN3VOUT3VOUT4VIN4 VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

IC6M62364FP

R216 33kR215 3.9k

BEPO

R21827k

C3600.1

BEEP

DAST

C1830.047

SCKSOMICI

R14

610

0k

CTCSTENC

C28

40.

01

R22056k

C2830.001

R2311k

DET

SQIN

MOD

REF

5

4

123

CD

NC

OUTVDDVSSC

344

0.02

7

IC24S-80942ANMP-DD6

TEMPAFVI

EPTT

RES

CLOCLICSFTDUSE

XCTSXRTS

R28810k

MD1

R29

910

0k

PWR

PWON

D28DAN222

BAL

15

3

2

IC25TC4S66F4

Q49DTC144EU

Q50DTC144EU

R31

710

0k

C37

70.

1R

321

68k

C39

90.

1

Q41DTA144EU

PA

R28

010

X4CR-520

C34

112

p

C34

222

p

R27712k

C33927p

R27

812

k

D27MA77

C34

00.

01

1234 5

678

AO1AO2AO3AO4 GND

SDASCLVCC

IC7M62334FP

VAG

R30

210

k

R22

247

0C

286

0.1

T1T2T3T4

R27

612

k

DET

R24722k

C32

00.

039

R24822k

C32

30.

0068

C32

20.

01

R24922k

+-

56

IC5NJM12904V

7

C321 0.1

R25

222

0k

C32

74.

7C

325

0.00

33

C3240.1

R25318k

R25447k

R25547k

-+

32

1

IC5NJM12904V

IC22TC4S66F

24

3

15

V+GND

8

4

C34

90.

1

CDEC

R25

847

0

VAGSQIN

Q35XP1214

1

2

3

5

4R25

168

k

DUSE

SEN

C

C3281

R25

95.

6k

R26133k

R26

322

k

R26

033

k

C32

90.

018

R26233k

C33

068

pC

331

0.01

Q362SC4116

R26

42.

7k

R21

922

k

C33

30.

001

C33

21

TONE

REM

CENC2

CENC1

CENC0

R267 22k

R268 56k

R269 180k

R286 1k

R31

23.

9kR

266

3.9k R270

47k

C33

40.

0082

R27147k

IC5NJM12904V

R256 100k

SCKOSDA

5V

5V47k

C33

682

0p

R27

447

k

Q372SC4116

R2734.7k

TEN

C

R27527k

C3370.47

Q38DTC144EU

XTXD

XRXD

ATR

DN

TXD

NR

XDC

IRQ

ARTM

DIM

R30

310

0k

CEN

C2

CEN

C1

CEN

C0

AFC

LAR

DT

AMSK

ADIN

APST

PMFM

ESD

AES

CL

PA

R14

910

k

RSS

ILV

INBA

TVU

NLK

CD

ECSD

ECBE

EPSE

NC

PWO

NIG

SWD

DST

POSW

NO

ISO

PT3

OPT

2O

PT1

MM

UT

RM

UT

BUSY

HAN

GPT

TO KR0

KR1

KR2

C34

5 0.

1

OSDADASTPGO2PGO1PGI3PGI2PGI1LINHLCSLCKLSO

PLST

C15

1 47

p

TXCTMUT

NWCDDSDDDAC

SOSI

SCKCCS

5 6 7 8

4 3 2 1

PMFM

R1805.6k

C24

00.

022

C24

10.

001

R17933k

IC15TC4W53FU

+-

141213

IC21dNJM12902V

NW

C

C24

456

pC

243

270p

Q22DTC144EU

R18268k

C24

20.

0012

R18168k

R18533k

C24

633

0p

R18

639

k

R18

927

k

R18

756

k

TON

E

CTC

S

-+

23

1

IC21aNJM12902V

C29

60.

1

R1904.7

VAG

C362 0.1 R304 56kC386 0.1 R318 12k

C200 0.1C201 0.1C202 0.1

R147100k

R322100k

13

5

2

4

R193100k

C249470p

R19

122

0kR

192

220k

C25

0 0.

1

C3590.1

C35

1

VCC

CPU

5VR

8VT8

V5V 8V

0.04

7

R19

622

k

R1951k

C2510.1

C40

20.

47

D30

MA2

S111

R1942.2k

AFON

SIG

AFONOCPU5V

AFON

D31DAN222

C2530.1

VCC

IC18TA75S01F

4

3

5

21

C25

522

0

R19

810

k

C256470

R19

910

k

C25

4 0.

001

J4

R18

818

k

HGC2520.1

R19

710

k

J5

C25

7 47

p

D23DA221 C

269

0.00

1

Q252SD1664

R20

34.

7k

R20

24.

7k

C27

22.

2

Q29DTC144EU

TMUT

D24DA221 C

270

0.00

1

Q262SD1664

C27

12.

2

TXC

R20

44.

7k

R20

54.

7k

Q30DTC144EU

6 5 4

1 2 3

Q272SB1132

Q28XP6501

R15

64.

7k

R239 4.7k

R150 100k

C273

5VVCC

0.001

C2744.7

C26

610 C

262

0.1

O IG

IC9TA7808F

C26

10.

1

C26

522

0

R20

010

kR

201

470

Q232SJ377

HV

5V

VOC

8V

C26

0 47

p

C25

9 0.

001

C25

8 47

0

D22

DSA

3A1

EP3

EP3 W2

C26

810 C

264

0.1

GO I

IC10AN78L05M

C26

30.

1

R298100k R

297

300k

J6

C29

3 0.

001

VCCDIM

HORNGND

PAAFGND

DISCGND

INGNDPTT

C29

2 47

p

C29

0 0.

001

C29

1 0.

001

C29

4 0.

001

Q48DTC144EU

PAVCCVCC

CPU5V

Q33DTC144EUD

IM

Q32DTC144EU

HO

RN

OD

ET

DET

EPTT

R22

810

0k

Q312SJ144

R22

71M

C29

510C

287

CPU

5V

5V

R8V

8VVCC

0.00

1

FMOD

D

ESIG

SIGOUT

D26MA2S111R

229

1M

R226100k

HV

HV

P1

+-

CHASSISSP1

AFO

Q24DTC144EU

PWR

CPU5

L364.7µC

352

22C34

747

0

C37

30.

001

GNDV+

4

11

C24

80.

001

IC21NJM12902V

8V5V

T8VR8VANT

VCC

8V

ANT

5V

T8VR8V

VCC

8V

ANT

5V

T8VR8V

VCC

CPU5R11210k

R12847k

C18

40.

1

LINH

Q43DTC144EU

C1734.7

C179470p

C27

90.

1

R21727k

C278 0.1

R25

012

0k

R26539k

C33

80.

01

Q40DTC144EU

Q39DTC363EK

IC8LA4425A

R224 47 C289 0.1

R225 10k C288 0.1

R223 1k

MAIN UNIT (2)

R240100k

C31

50.

022

VAG

C3100.1

R31947k

C28

20.

1

C2804.7 C

281

470p

R257470k

C3350.047

R14

810

0k

PLRS

VCC

ANT

CHASSISJ1

R15910k

R28710k

toOPC-617

2.5V

4.1Vp-p(3.579MHz)

16mVrmS

1.7Vp-p(2/5 TONE)

TX:0.5VRX:1.1V

2.9Vp-P(19.66MHz)

1.8V

0.6Vp-p(CTCSS)

4.9V(DTCS)

5.0V(AFON)

TX:8.0VRX:0V

TX:0VRX:8.0V

5.0V

8.0V

13.1V

5.0V

4.5V(PWR ON)


11 - 3

Asia Icom Inc.6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.Phone : +886 (02) 2559 1899 Fax : +886 (02) 2559 1874URL : http://www.asia-icom.comE-mail : [email protected]

Zac de la Plaine, 1, Rue Brindejonc des MoulinaisBP 5804, 31505 Toulouse Cedex, FrancePhone : +33 (5) 61 36 03 03 Fax : +33 (5) 61 36 03 00URL : http://www.icom-france.comE-mail : [email protected]

Icom France S.a

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.Phone : +44 (01227) 741741 Fax : +44 (01227) 741742URL : http://www.icomuk.co.ukE-mail : [email protected]

Icom (UK) Ltd.

Crta. de Gracia a Manresa Km. 14,75008190 Sant Cugat del Valles Barcelona, SPAINPhone : +34 (93) 590 26 70 Fax : +34 (93) 589 04 46URL : http://www.icomspain.comE-mail : [email protected]

Icom Spain S.L

<Corporate Headquarters>2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.Phone : +1 (425) 454-8155 Fax : +1 (425) 454-1509URL : http://www.icomamerica.comE-mail : [email protected]<Customer Service>Phone : +1 (425) 454-7619

Icom America Inc.

Glenwood Centre #150-6165Highway 17 Delta, B.C., V4K 5B8, CanadaPhone : +1 (604) 952-4266 Fax : +1 (604) 952-0090URL : http://www.icomcanada.comE-mail : [email protected]

Icom Canada

A.B.N. 88 006 092 575290-294 Albert Street, Brunswick, Victoria, 3056, AustraliaPhone : +61 (03) 9387-0666 Fax : +61 (03) 9387-0022URL : http://www.icom.net.auE-mail : [email protected]

Icom (Australia) Pty. Ltd.

146A Harris Road, East Tamaki,Auckland, New ZealandPhone : +64 (09) 274 4062 Fax : +64 (09) 274 4708URL : http://www.icom.co.nzE-mail : [email protected]

Icom New Zealand

1305, Wanshang Plaza, Shijingshan Road, Beijing ChinaPhone : +86 (010) 6866 6337 Fax : +86 (010) 6866 3553URL : http://www.bjicom.comE-mail : [email protected]

Beijing Icom Ltd.Sopot, 3 Maja 54 PolandPhone : +48 (58) 550 7135 Fax : +48 (58) 551 0484E-mail : [email protected]

Icom Polska

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, JapanPhone : +81 (06) 6793 5302Fax : +81 (06) 6793 0013URL : http://www.icom.co.jp/world/index.html

Communication EquipmentHimmelgeister Str. 100, D-40225 Dusseldorf, GermanyPhone : +49 (0211) 346047 Fax : +49 (0211) 333639URL : http://www.icomeurope.comE-mail : [email protected]

Icom (Europe) GmbH

1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan S-13817HZ-C1U-qC 2002 Icom Inc.

IC-F510/F520/F521 Service manual...UT-105 SmarTrank2 Logic Board UT-108 DTMF decoder unit UT-109...

Documents

Transcript of IC-F510/F520/F521 Service manual...UT-105 SmarTrank2 Logic Board UT-108 DTMF decoder unit UT-109...