Hydro Chem Systems Master Catalog 3 25-2014

5550 Clay Avenue S.W. Grand Rapid, MI 49548 Phone 800‐66‐1992 | Fax 616‐531‐8692 www.hcsclean.com | [email protected] Cleaning Consultants • Automated Wash Systems • Detergents • Water Treatment • Pressure Washers • Cleaning Supplies

HYDRO CHEM’S EXTREME TRUCK MOUNTED PRESSURE CLEANING SYSTEMS

5550 Clay Avenue S.W. Grand Rapid, MI 49548 Phone 800-666-1992 | Fax 616-531-8692 www.hcsclean.com | [email protected] Cleaning Consultants • Automated Wash Systems • Detergents • Water Treatment • Pressure Washers • Cleaning Supplies

TRAILER, TANK, REELS EXTRA

LIST PRICE $16,895.00 SALE PRICE $12.995.00 LIMITED TIME OFFER

40% MORE HORSE POWER THEN HONDA GX690 ENGINES

EXCLUSIVE

UPGRADE

Huge Power - Super Low Price!

Custom truck & trailer units available and can be built to your specifications.

Single Axle Trailer 200 Gallons

Custom trailers

Optional Ladder / Sign Rack

Show with optional Sign on Rack

52” X 12’ Trailer & Recycling System

52” x 14’ Trailer 535 Tank & AZV88

SCU35009KAF Specifications Operating Pressure 3500 PSI Discharge Capacity 9 GPM *

4444.5 GPM Each 2 Guns 4.5, 5, 6, 7, 8 or 9 GPM

Optional Dual Guns

Adjustable Flow (GPM)

Temperature Adjustable to 200° + Gas Engine

2-Cylinder Electric Start New! 30 HP Kohler

Pump Triplex Ceramic Plunger, General Pump Belt Drive

Heat Exchanger Coil Burner Housing -

1/2" SCH80 Stainless Steel Enclosure

Diesel Burner 115 volt Oil Fired Gas & Diesel Tanks 18 gallons each

Generator NEW! 115 Volt 2900 Watt 2.9Kw.

Weight 765 pounds (dry) Dimensions 48”L x 38” W x 41” H

Warranty 1 year labor Ltd. 3-year engine Ltd. (New)

5-year pump warranty Ltd 6-year coil warranty Ltd

Optional Equipment Rotary Surface

Cleaners 16’’ to 38” Flat & Roof Cleaning Sandblasters Sewer Jet Kit Turbo Nozzles Hose Reels Wheel Kits Waste Water Recovery & Filtration Systems. Trailers Etc.

NEW! STAINLESS STEEL FRAME UPGRADE

included

Dan Swede Your Sales Engineer PH 800-666-1992 Ph 616-531-6420 Cell 616-490-4594 Fax 616-531-8692

Web www.hcsclean.com Email: [email protected]

RUN 3500 PSI @ 8 GPM UP-TO 200°F + RUN TWO OPERATORS 4 GPM @ 3500 PSI

LIST PRICE $12,895.00 / SALE PRICE: $ 9,795.00

New HydroNew HydroNew HydroNew Hydro----Tek SC3Tek SC3Tek SC3Tek SC35008500850085008KKKKAFAFAFAF

COMMERCIAL & INDUSTRIAL Clean Buildings, Parking Lots,

Malls, Gas Stations, Municipality, Interlocking Brick Pavers Gum & Mildew Removal

RESIDENTIAL Houses, Roofs,

Drive Ways, Fences, Decks TRANSPORTATION

Tractor Trailers, Trains, Aircrafts, Heavy Equipment

3500 PSI @ 8 GPM BELT DRIVE 120 VOLT BURNER

NEW! 27 HP KOHLER ENGINE 3000-WATT GENERATOR!

Features: Adjustable Temperature up to 200°F Plus Belt Drive Triplex General Pump, 115-Volt Diesel Fired Burner Upgrade!

120-Volt 3000-Watt Generator with 2-Auxiliary Power Outlets

CALL 800-666-1992 7 FOR THE SALES DEPARTMENT

Complete Custom Truck & Trailer Packages Available!

Huge Power - Super Low Price!

The Ultimate Line SC35008KAF Delivering 27 H27 H27 H27 HPPPP 3333555500 PSI @ 00 PSI @ 00 PSI @ 00 PSI @ 8888 GPMGPMGPMGPM and is set-up to run at

a full flow to one operator or can be divided to run two

operators at 4. 5 GPM @ 3500 PSI of cold or hot water, for

the serious cleaning contractor. Dual gun optional Full line

of features includes; belt drive pump, adjustable

temperature up-to 200200200200° +, new 120-volt 3030303000000000----WWWWattattattatt

generatorgeneratorgeneratorgenerator for burner system. Best of all is the quality you

expect from Hydro Tek & Hydro Chem Systems.

Custom truck & trailer units

available and can be built to

your specifications.

Single Axle Trailer 200 Gallon Tank

52” X 12’ Trailer AZV88 335 Gallon Tank

T300 Trailer 300 Gallons

6.5’ X 14’ Trailer 535 Gallon Tank

Custom Built Trailers 2- 270 Gal Tanks

Custom Built Trailers 535 Gallons

SC35008KAF Specifications Operating Pressure 3500 PSI Discharge Capacity 8 GPM

4444 GPM to 2 Guns 4, 5, 6, 7, 8 GPM

Optional Dual Guns

Adjustable Flow (GPM) Temperature Adjustable to 200° + Gas Engine

Cylinder Electric Start

27 HP New!

Pump NEW! General Triplex Ceramic Plunger, Belt Drive

Heat Exchanger Coil Burner Housing -

1/2" X SCH80, Stainless Steel

Enclosure Diesel Burner 115 volt Oil Fired Gun / Hose Opt. 2-100' hose & guns

Generator NEW! 115-Volt 2900 Watt

Weight 680 pounds (dry) Dimensions 51"L x 34"W x 41"H

Warranty 2-year engine Ltd. 5-year pump warranty

Optional Equipment

Rotary Surface Cleaners

16’’ to 38” Flat & Roof

Cleaning Sandblasters

Sewer Jet Kit

Turbo Nozzles

Hose Reels

Wheel Kits

Pressure Gauge

Waste Water Recovery &

Filtration Systems.

Trailers Etc.

Stainless Steel Frame

Upgrade Available

Dan Swede Your Sales Engineer

PH 800-666-1992 Ph 616-531-6420 Cell 616-490-4594 Fax 616-531-8692

Web www.hcsclean.com Email: [email protected]

Hydro-Chem Systems Line of High-Speed Surface Cleaners Other Models are Available

Phone 800-666-1992 Email [email protected] Website www.hcsclean.com

ANTV5 Hydro Tek Vacuum Recovery surface

Cleaners

We did not inherit the earth from our ancestors.

We only borrowed it from our children.

Hydro Tek Line of Surface Cleaners ANT5V 30” VAC MODEL ANT4C 4 IN 1 28” SURFACE CLEANER ANT28 28” SURFACE CLEANER ANT21 20” MODEL

5550 Clay Avenue S.W. Grand Rapid, MI 49548 Phone 800‐66‐1992 | Fax 616‐531‐8692 www.hcsclean.com | [email protected] Cleaning Consultants • Automated Wash Systems • Detergents • Water Treatment • Pressure Washers • Cleaning Supplies

HCS 48” Surface Cleaner

UNDERSTANDING THE DIFFERENCES IN THE PERFORMANCE OF A PRESSURE CLEANING SYSTEMS BY COMPARING THEM TO THE

PERFORMANCE OF LANDSCAPING EQUIPMENT

Note: we do not sell landscaping equipment productivity comparison only. Hydro Chem Systems, Inc. Phone 800-666-1992 Cell 616-490-9594 Fax 616-531-8692

Website www.hcsclean.com email [email protected]

One of the main questions we are always asked, is what is the difference between a commercial belt-driven pump and an economy direct-driven pump on a pressure washer?

Commercial and Industrial Grade Belt Driven Pump verses High-Speed Direct Driven Pressure Washer.

1. Belt driven pumps Fig #1 can rotate up to one million less times day, compared to a direct drive pump. Fig #2

Rotational speed is measured by RPM’s or Rotations Per Minute this is when a pump or motor make one complete 360° rotation. I will try to explain it this way, think of driving a car or truck at 65 miles per hour that is stuck in 1st gear. You can only image the damage that you would do to your vehicle. That is what it is like for a high-speed direct drive pump working day after day. Belt drive pumps are the opposite they are compared too driving in 5th gear when on a highway no problem everything is running at a low RPM.

2. Heat coming off a typical air-cooled engine normally is around 350° F to 400° F. Figure #1

A direct driven pump is mounted directly to the back of an air cooled engine running at 350° F to 400° F. That extreme amount of convection heat transfers directly into the pump. On fig#1 you also notice that the muffler is very close to pump and unloader, that means radiant heat from the muffler is also transferring to the pump assembly. Finally you have metal to metal heat transfer, since the pump driven by the crankshaft of the engine. All together that is enough heat to cook a turkey. Belt drive pumps Figure #2 has no extreme heat transfer problems. The pump is not connecting directly to the engine or is it in the 350° F. airflow (air-cooled engine). Ambient temperature air is drawn in from the front recoil side of the engine and then passes over the outside cooling fins of the engine and exits around muffler side of the engine at around 350° F. plus. Take a look at the belt drive pressure washer figure #2; you will see how the muffler is on the left side of the fuel tank and in rear of the engine where the heat exits the engine. Notice that the belt driven pump that is mounted on the far right side of the frame. (Best)

1. Vibrations from the direct drive pump mounted to the engine also can increases pump wear and can often damage the crankshaft of the engine. When we pull the pumps off the engines, very often the crankshaft keyways are damaged; some pumps actually fuse themselves to the engine needing to be cut off.

Reference: I had 145 pressure washers on rental at our rental centers in South Florida. I have tested all types of pressure washer pumps, but nothing last longer than an industrial grade belt driven pumps.

If you any questions, please contact are highly trained sales staff 800-666-1992 or [email protected] www.hcsclean.com

Invest in the Best. HCS’s Eco-friendly trash can cleaning systems, fast, effective and

fuel efficient. HCS system heats the water to over 200 + degrees eliminating up to

99.9% of harmful organisms like E.Coli, Salmonella, Listeria, Mold and more!

Why heat the water? You would not wash dirty dishes in cold water, why would you

attempt to clean trash cans with without hot water / steam? HCS’s high-volume hot

water cleaning systems makes all the difference in the world.

Hydro Chem Systems, Inc.

Phone 800-666-1992 Cell 616-490-9594 Fax 616-531-8692


Dirty trash cans attract cockroaches, maggots / flies, mice, rats, possums, raccoons

and bears, and other pests that can bring all kinds of health hazards to your home.

Our systems are designed to clean two (2) trash cans at the same time! Doubling the

amount of trash cans you can clean per day.

We have the most powerful trash can cleaning systems on the market with systems

up to our 30 HP Kohler 3500 PSI @ 9 GPM high volume hot water.

Full 8 stage filtration waste water filtration system. You can reuse and recycle your

waste water. Our systems can vacuum up recovery waste water from up to 100’ away

from the trailer. You can pressure clean Walmart, Target, Lowes and Home Depot

stores as well as restaurants at night.


Phone 800-666-1992 Cell 616-490-9594 Fax 616-531-8692


Hydro Chem Systems uses the highest quality commercial grade hot water pressure

cleaning system. Our Systems open up other opportunities like pressure cleaning

dumpsters and dumpster areas, restaurant drive-through store fronts, driveways,

sidewalks and homes etc.

Pressure cleaning contractor training and pricing guide is included with purchase.

Ask about our hose reel package with 100’ inlet hose and 200’ high pressure hose.

We also offer high-speed surface cleaners with and without vacuum recovery.


Phone 800-666-1992 Cell 616-490-9594 Fax 616-531-8692


3020 Saturn Street, Ste 203Brea, Ca 92821T: 714.985.6203F: 714.985.6253 Attn: Jonathan Nery

T: 800.341.1288F: 714.986.1225

Industrial Cleaning Equipment & SupplyContact: Dan SwedeP: 954-714-4977 F: 954.714.4977 Email: [email protected]

LESSEE INFORMATIONCOMPANY NAME (Full Legal Name Including DBA if Applicable) CONTACT PHONE NO.

ADDRESS (City, State, County & Zip Code) FAX NO.

EQUIPMENT LOCATION ADDRESS (if different than above) (City, State, County & Zip Code) EMAIL ADDRESS

PROPRIETORSHIP PARTNERSHIP CORPORATION LLC YRS. CURRENT OWNERSHIP YRS. IN BUSINESS FED. TAX ID. NO.

BANK REFERENCES

BANK NAME & BRANCH CITY / STATE TELEPHONE NO. ACCOUNT TYPE CONTACT ACCOUNT NUMBER

1.

TRADE REFERENCES

COMPANY NAME TELEPHONE NO. CITY / STATE CONTACT ACCOUNT NUMBER

1.

PERSONAL INFORMATION “Personal Guarantee”NAME AND TITLE

STREET ADDRESS

CITY, STATE, ZIP

TELEPHONE NO.

SOCIAL SECURITY NO.

OWNERSHIP PERCENT

TERMSEQUIPMENT COST MONTHS

I M P O R T A N T — A P P L I C A N T R E A D B E F O R E S I G N I N GI hereby certify that all information contained in this application and all attachments hereto is true and complete to the best of my knowledge, andhas been supplied for the purpose of obtaining credit in the form of an equipment lease. I authorize Providence Capital to verify any and all of theinformation with the source(s) it deems appropriate and further authorize any of the above banks and trade references to release requestedinformation to Providence Capital. I understand that this constitutes an application only and shall not bind either Providence Capital or theapplicant in relation to the proposed lease transaction.

DATE SIGNATURE TITLE

DATE SIGNATURE TITLE

“Committed to CLEAN Since 1971”

5550 Clay Avenue SWGrand Rapids, MI 49548

Phone: 800-666-1992Fax: [email protected]

www.hydrochemsystems.com

Hydro Chem Systems Master Catalog 3 25-2014

Business

Transcript of Hydro Chem Systems Master Catalog 3 25-2014