Data Sheet T 8012 EN Series 240 Type 3241-1 and Type 3241-7 ...
Hino 3241 Series700 8x4
Transcript of Hino 3241 Series700 8x4
Hino Motors,Ltd. TOKYO,JAPAN
Spec. No. SS-FY304Drawing No. CDRFY311
RATINGS & AXLE LOAD LIMIT (kg) ( ) ??Maker designGVM
RatingsFront: 315/80R22.5-156/153Rear : 295/80R22.5-153/150Front: 12R22.5-16PRRear : 11R22.5-16PRFront&Rear: 295/80R22.5-153/150
CHASSIS DIMENSIONS (mm) : All dimensions are to standard specifications and unladen chassisModelProduction Code FY1EUKA FY1EUKMApplication For dump For mixerWheelbase 1,850 + 3,500 + 1,310Overall length 9,340Overall width 2,490Overall Height 3,085Cab to rear axle center 5,295Rear overhang (at frame end) 1,170Front Chassis Height 1,080Rear Chassis Height 1,075Road clearance (at diff. case) 250Front Tread 2,035Rear Tread 1,855Turning radius on tire 11,100Turning radius on wall to wall 11,800
CHASSIS MASS (kg) : Chassis mass quoted is to standard specifications without spare tire & std. tool set(Total)(Front)(Rear)
PERFORMANCE & GEAR RATIOS : Calculations based on 32.0 ton GVM, 295/80R22.5 tireMax. Speed (km/h)Gradeability tanθ (%)
Model1st2nd3rd4th5th6th7th8th
Rev.ModelGear Ratio
- 1 -
THD174.100
RT
9,2556,2103,045
9,3056,250
(Low/High)
12.923 / 10.803
21,80015,00032,000 (35,000)
(STD-IRE)
21,800
SPECIFICATIONS
HHIINNOO 770000 SSeerriieess8x4, Truck Chassis
- RHD- 410 PS (Euro-4)- 35.0 ton GVMR
Front Axle Rear Axle
Rear Axle
3,055
6.529 / 5.4584.565 / 3.816
Chassis Mass
ZF 16S221
Transmission Gear Ratio
Axle Load Limit13,000
15,000
(OPT)
HINO 73241
HFHR
OH
1.430 / 1.195
13.804 / 11.5399.487 / 7.930
Below 90 Km/Hr (controlled by speed limiter)60.0
1.000 / 0.835
FT
2.078 / 1.7373.023 / 2.527
14,600(STD-UK)
EQUIPMENTS SS-FY304 ENGINE SERVICE BRAKE
1.Model HINO E13C UN 1.Type 2.Max. output;(JIS GROSS) 302 kW {410 PS} at 1,800
r/min 3.Max. torque;(JIS GROSS) 1,863 N m {190 kgf m} at 2.Wheel brake ass'y
1,100 r/min Drum diameter x Lining 4.Max. engine speed 2,000 r/min width 5.Type Front 406.4 x 152 mm
Rear 406.4 x 216 mm 3.Air drier Equipped 4.ABS system Equipped
6.Combustion system Direct injection type 5.Auto brake shoes adjuster Equipped 7.Bore and stroke 137 x 146 mm SECONDARY AND PARKING BRAKE 8.Piston displacement 12.913 L 1.Type 9.Compression ratio 17.010.Engine oil capacity 37.0 L11.Engine coolant capacity 28.5 L12.Fuel injection pump Type STEERING
1.Type Governor Electric governor13.Intake system Air cleaner Dual paper elements14.Air compressor Type Single cylinder, water- 2.Gear ratio 22.4
cooled RETARDER Bore and stroke 85 x 60 mm 1.Type Hino engine retarder15 Fly wheel P.T.O. FRONT SUSPENSION16 Engine control link Equipped 1.Type Semi-elliptic tapered leaf 17 Insect protection Equipped springs with shock
CLUTCH absorbers and stabilizer 1.Type Dry single plate with damper 2.Dimensions of springs
springs Span 1,500 mm 2.Clutch disc ass'y CS-430 series Width 90 mm 3.Facing material Semi-mold REAR SUSPENSION 4.Facing outside diameter 430 mm 1.Type Semi-elliptic leaf springs 5.Clutch cover ass'y DSP-430 series with torque rods 6.Control Hydraulic with air booster 2.Dimensions of springs
TRANSMISSION Span 1,310 mm 1.Type Width 90 mm
WHEEL AND TIRE 1.Wheel type
2.Control 2.Rim size, front 22.5 x 9.00 - offset 175 mm
PROPELLER SHAFT rear 22.5 x 8.25 - offset 165 mm 1.Propeller shaft ass'y 3.Tire size, front 315/80R22.5-156/153 T/M R/A Tube type rear 295/80R22.5-153/150 R/A R/A Solid type 4.Number of tires Twelve (12) numbers 2.Universal joints Round bearing type FUEL TANK 3.Center bearing 1-piece 1.Capacity 300 L
FRONT AXLE 2.Fuel pre-filter and Equipped 1.Front axle ass'y MF78 series sedimenter 2.Type Reversed Elliot, " " section 3.Fuel tank cap key Equipped
beam REAR AXLE
1.Type
- 2 -
Mechanical control withpower shift
ZF, sixteen forward and tworeverse speeds, overdrive,synchromesh 1st - 16th
Full air, dual circuit, taperroller type, leading & trailingshoes for front and rear
Diesel, turbo chargedintercooled, 4-cy., vertical,6-cyl., in-line, overheadcamshaft, water cooled
Electronic control commonrail type
Spring brake acting on frontrearward and rear frontwardwheels, for emergency andparking purpose, manualcontrol
Telescopic and tilt steeringcolumn with locking deviceRecirculating ball withhydraulic booster integraltype
10-stud disc wheels (ISOtype)
Tandem axle,dual drive withinter axle differential, full flotingsingle reduction, single speedby hypoid gearings with interaxle differetial lock, "No SPIN"
Equipped (for FY1EUKM only)
16s221
SS-FY304 CHASSIS FRAME 2.Warning, pilot lamps and buzzers
1.Type Ladder-shaped channel Engine oil pressure warning lamp and buzzersection side rails Air pressure warning lamp and buzzer
2.Rear chassis width 850 mm Buck-up warning buzzer 3.Max. section (depth x 302 x 88 x 9.0 mm Charging warning lamp flange x thickness) Beam indicator lamp 4.Tensile strength 540 N/m {55 kgf/m } Turn signal indicator lamp 5. Hooks Equipped for front and rear Parking brake indicator lamp
CAB Coolant level warring lamp and buzzer 1. Type Differential lock indicator lamp
Engine over-run warning buzzerFuel level warning lampBattery charging pilot lampABS warning lampEngine retarder indicator lamp
2. Seating capacity Two Sedimenter water level warning lamp 3. Driver's seat Transmission splitter range indicator lamp
3.Switches 4. Side passenger's seat Urethane foam pads, high- Lighting switch
back and reclining seat with Directional indicator, dimmer and passing switchfabric cover and under tray Wiper and washer switch
5. Center console Equipped Hazard lamp switch 6. Seat belts 3-point type on driver's & Fog lamp switch
side passenger's seat Doom lamp switch 7. Rear view mirrors Electrically adjustable & heated 8. Windshield wipers Electric, triple, intermittent Map lamp switch
and 2-speed Differential lock switch 9. Sun visor and Mirror heating switch
over-head console 4.Others10 Center over-head console Equipped One-key starting-stopping11 Cigarette lighter Equipped Throttle control knob12 Ventilator Forced type by electric Horn button
blower13 Car heater and defroster Equipped ELECTRICAL EQUIPMENT14 Sleeping bed Equipped 1.Type 24 volt, negative earth15 Audio
tape and CD player Number per vehicle 12 V x 2, series-connection16 Floor mat Vinyl type Capacity 432 kC {120 A?Kh} at 20-17 Cab step Equipped hour rate18 Trim 3.Alternator
Type With built-in rectifier and 19 Electrical power window Equipped with both side voltage regulator20 Electrical door lock Equipped Capacity 24 V, 90 A21 Door pockets Equipped at both door side 4.Starter22 Tire inflator Type Pinion shift23 Capacity 24 V, 6.0 kW
5.Lamps Headlamps24 Cushioned Rear Lamps Fog lamps25 Exterior Sunvisor License plate lamp26 Speaker Stop/Tail lamps27 Ashtray Back-up lamp28 Power window
INSTRUMENTS 1.Meter and gauges km-kg system
Speedometer with trip meterOdometerTachometer Map lampFuel gauge Step lamp (for driver)Coolant temperature gauge 6.Horn Electric horn (Air horn OPT)Air pressure gauge
- 3 -
Two, for driver and sidepassenger
Full trim type (side, roof andback)
Transmission P.T.O.and P.T.O. control
Equipped (for FY1EUKA only)
Driver and assistantDriver and assistant
Directional indicator andhazard lamps (front, sideand rear)Reading lamp (Fluorescentlamp)
Forward control, all steelwelded construction, fullfloating cab (front:air,rear:air)with electrical oil-pumptilting mechanism
Air Suspension seat
EquippedEquippedEquipped with front 3
AM/FM radio with cassette 2.Batteries
Warning lamp check switch
Not equipped
SS-FY304 OPTIONAL EQUIPMENT
12.
.Reversing Camera System
1. 14.15.
2. Alloy Road Wheels Alcoa forged alluminium alloy roadwheels.
16.
( 22.5X8.25 rim and or 22.5X9.00 rim )
17
.
.Muckaway Steel or Hardox TipperTipper GrabAlloy AggregateAlloy InsulatedHookloaderConcrete MixerBlock/Brick Carrier
18..
Bodies: 3. Central Chssis lubrication System
5. Illuminated Headboard 6. 7. Air conditioner 8. Sleeping bed curtain 9. Night Heater10. Comfort Matress
Front Roof spoiler11.Hi-Roof Conversion
Note: All specifications of the products are with normal manufacturing allowances and tolerances.Hino Motors, Ltd. reserve the right to alter specifications at any time without previous notice.Figures of axle capacity can be changed by the operating conditions and specifications of equipments concerned.When selecting optional equipment, consult Hino technical staff as the adaptation of some of the optional equipment on production line may require an extra lead time.
- 4 -
Visible “Diff Lock engaged” warning lampStainless Steel Lighting Bars: Roof and Front mount
“Handbrake not applied” audible warningVertical Exhuast in stainless steel incorporating O.EM. Muffler
4. Alloy Fuel Tank 300Ltrs
Rotating Beacons roof mounted
13.
Lighting options: Work Lamps Spot Lamps Lightbars
Cheese Wedge
.
19. Onboard Weighing Systems
FOH
WB1
WB2
WB3
OL
CA
OW
FW
ROH
CDRFY311
FY1EUKA/UKM