f Fig. · 2014. 5. 26. · 5831 6 5834 12 5835. 5844 5836 12 5838 12 5839 6 5840 12 5841 12 5842 12...

All units are Re-manufactured and carry the same guarantee as the original units.

NOTE: The information contained herein is based upon data which we believe to be correct and has been obtained from sources which we regard reliable, but we assume no liability for errors or omissions therein.

INTERCHANGE QUICK REFERENCE GUIDE - ORIGINAL TO OUR CODE .................................. ...................................... Pages 4 to 6 Incl. ............................................................................................ INTERCHANGE GENERATORS TO REGULATORS TO OUR CODE Pages 7 to 12 Incl.

APPLICATION CARS. TRUCKS. ETC. TO OUR CODE P a s 13 to 30 Incl. - - ~

IMPORTANCE OF BATTERY POLARITY Pages 31 to 33 Incl.

IMPORTANT - GUARANTEE AND INSTRUCTION This Replacement Unit will give you maximum service when properly installed. Regulators are guaranteed for ninetv days against defective workmanship and materials. Regulators are bench tested and set for correct charging rate according to original factory specifications. DO NOT TAMPER WITH ADJUSTMENTS. The fact that you are replacing the old regulator indicates the possibility that some trouble may exist in the electrical system that caused the old regulator to fail. To avoid damaging the replacement regulator follow these instructions carefully.

Fig. I Fig. I1 Fig. 111

f AUTOLITE DELCO-REMY I FORD I AUTOLITE DELCO-REMY FORD I

BEFORE INSTALLING DO NOT REMOVE OLD REGULATOR UNTIL THESE TESTS HAVE BEEN MADE

IF BATTERY IS LOW AND CHARGING RATE LOW OR NO CHARGE AT ALL MAKE THESE TESTS.

1. check battery water and general battery conditions to see if will take and hold a charge. Check each cell with volt meter.

2. Check wiring for damage. Make sure all wiring connections at kt- generator, regulator and battery are tlght and free from corrosion.

3. Check fan belt for slippage.

4. Run motor at medium speed, using a wire to touch one end to regulator base and other end to a good ground. If this corrects trouble, make certain regulator base is well grounded.

5. If the above does not correct the trouble make this test: Fig. 1

AUTOLiTE, DELCO-REMY AND SOME FORD TRACTOR REGU- LATORS use an "A" or STANDARD circuit generator. The qenerator field is traced from the generator armature through the generator field co~ls and then through the requlator to ground at the requlator base.

F1q. I1 FORD REGULATORS (except some tractors) AND SOME SPECIAL AU'TOLITE AND DELCO-REMY use a "B" circuit generator. The generator field circuit is traced from the generator armature

through the regulator, then through the generator fields to the ground inside of the generator.

Fig. I11 6. If the fault is not corrected, connect one of a wlre to the ARM

terminal and the other end to the BAT terminal with motor running at medium speed. If charging rate increases, replace the requlator.

7. If the above tests do not indicate a faulty regulator you probably have a defective battery or - Loose or dirty connections at the generator, regulator, starter switch, battery or ground straps. Faulty generator, bad brushes, weak brush pressure, open or shorted windings.

IF BATTERY IS OVERCHARGED AND CHARGING RATE REMAINS HIGH. MAKE THESE TESTS

1. Make sure the regulator base is well grounded to car.

2. With motor running at medium speed disconnect FLD terminal of regulator. If charging rate reduces, replace the requlator.

3. If the charging rate remains high the generator field is shorted at the generator or in the wires to the regulator.

INSTALLATION INSTRUCTIONS

ck application with catalog for proper regulator. Each 3. Be sure the wires are connected to the proper terminal on the ulator has the stock number stamped on the base. You can voltage regulator. Reversal of wires can Instantly damage a

etermlne polarity and peak amperage capacity by referring new regulator or bum out the generator. 9 "quick reference guide". Please bear in mind 4. B~ sure the connection is clean and conductive. All arging rate as shown on the ammeter will not always

peak listed as 1t will vary with the electrical load OR regulators have a ground strap on the base to provide a ground

HOW ONLY A SLIGHT READING IF THE BATTERY connection through the mounting screw. On some Ford and

CHARGED. IF IT SHOWS DISCHARGE REPEAT Mercury applications there is a special ground wire in the

STS TO LOCATE TROUBLE. harness. This can be connected under the mounting screw head on the ground strap.

ry to determine which is If a posi- 5. BEFORE STARTING MOTOR. Polarize the generator by mo- requlator is installed on a car with negative ground the regulator will burn out in short time. mentarily touching a wire from the terminal marked ARM to

the terminal marked BAT. 2. When disconnecting the wires from the old regulator, tempo- DO NOT TOUCH FLD TERMINAL

rarily tape the terminal end of the battery wire. 6. START MOTOR TAG WIRES WITH IDENTlFJCATION TAGS included in each If trouble still exists, repeat tests shown above to locate fault. carton. Thls wlll ellmlnate guess work or posslble trouble. Otherwise replacement regulator will be damaged.

WARNING! Warranty on this regulator is void if it is damaged due to incorrect connections or usage. - - - - - - -

WARNING-The material, style and numbering system used in this Catalog is copyrighted and any infringement thereon will be promptly prosecuted. Copyrighted October 1957, by H. P. Lester, Los Angeles 58. California, U.S.A. Prlnted in US..&

REGULATOR - QUICK REFERENCE GUIDE Oriqinal No. Volts Amps

0 1 Polarity

N-P N-P N-P N-P N-P N-P N-P N-P N-P N-P N-P , N-P N-P N-P N-P

Nes Pos

Pos Nes Pos

Nes

Neg Pos Pos Nes Pos Pos Neg Pos Pos Pos Po5 Nes Pos Nes Pos

Pos Pos Neg Pos Neg Pos Pos Neg Pos Neg Pos Neg Pos Pos Pos Pos

Pos Pos Pos Pos Neg Pos

Pos Neg Pos

Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Neg Pos Pos Pos Pos

lr Code 1 Original No. Volts

AUTO 6 6 6 6 6

6 6

6 6 6 6 6 6 6 6 6 6

12 12 12 12 12 12

' 12

6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6 6

6 6 6 6 6 6 6

6 6 6 6 6 6 6 6

6 6 6

Amps - 1LITE

28 30 35 28 35

40 50

BC BC BC BC BC BC BC BC BC BC

20 26 26 55 55 55 55

35 32 28 30 25 40 35 28 35 35 35 35 30 32 28 40 35 25 30 35 40 35 32 40 30 25 28 32 40 35 40 35 30 40 25 32

22 22 20 20 35 35 17

35 40 32 35 40 40 38 32

35 40 35

o u Polarity

Pos Neg Nes Pos Pos

Pos Pos

Pos Pos Pos Neg Pos Pos Pos Pos Pos Pos

Pos Pos Neg N-P N-P N-P N-P

Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Neg Neg Neg Pos Pos Pos Pos Pos Neg Pos Pos Neg Neg Neg Pos

Pos Pos Pos Neg Pos Pos Pos

Pos Pos Pos Pos Pos Neg Pos Pos

Pos Pos Pos

r Code No. - 17318 17317 17319 17314 17320

17344 17346

17334 17336 17340 17333 17334 17334 17336 17340 17334 17334

17254 17256 17255 17260 17260 17260 17260

17320 17322 17314 17318 17316 17330 17320 17314 17320 17320 17320 17320 17318 17322 17314 17330 17320 17316

I Original No. Volts

AUTC 6 6 6 6 6 6 6 6 6 6 6 6 6

6 6 6 6 6 6 6 6 6 6 6 6 6

12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12 12

Amps - )LITE

40 38 35 40 35 35 40 28 40 28 3 5 40 14

BC BC BC BC BC BC BC BC BC BC BC BC BC

15 17 18 12 20 12 17 20 12 20 18 18 12 17 17 12 12 12

BC BC BC BC

8 10 5

17 14 16 14 14 14 14 14 17

30 30 2 5 35 26 30 26 30 30

25 30 30 30 30 30 30

25 40

0 Polarity

Pos Pos Pos Pos Pos Neg Pos Pos Pos Pos Pos Pos Nes Pos Pos Pos Nes Pos Pos Pos Neg Pos Pos Neg Pos Pos

Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Neg Nes Pos Pos Pos Neg Pos Pos Pos Pos Neg Pos Neg Pos Neg Pos Neg Pos Neg Pos Nes Neg Pos Pos

Pos Neg Nes Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Neg Neg Neg Pos

Pos Neg

ur Code No.

' 17332 17324 17320 17333 17320 17319

'17332 17314 17332 17314 17320 17330 17329

17340 17334 17336 17333 17334 17334 17336 17333 17338 17338 17335 17338 17342

17272 17272 17254 17266 17254 17266 17272 17254 17266 17254 17267 17267 17266 17268 17268 17269 17266 17266 17270 17270 17273 17278 17283 17292 17293 17352 17352 17352 17353 17352 17352 17353 17352 17352

17102 17103 17107 17104 17106 17102 17106 17102 17102 17108 17106 17114 17112 17109 17109 17115 17114

17374 17373

AUTOLITE TC43Ol A-B-C-D TC4302A-C TC4303B-D-E TC4304A TC4305A-B-C-E TC4310A TC4317A TC4323B TC4324A TC4326A-B TC4327A-B-C TC4327D-E-F TC4329A-B-C TC433 1 A-B TC4332A

6 Man'l 6 Man'l

6 14 6 14

6 Man'l

24 26

REGULATOR - QUICK REFERENCE Original No.

Our Code Volts Amps Polarity No.

DELCO-REMY 12 BC N-P 12 - Pos 12 18 Pos 12 50 Pos 12 80 Pos 6 BC Pos

12 BC Pos 12 BC Pos 6 BC Pos 6 - N-P 6 16 N-P 6 - ' N-P 6 1.3 N-P 6 - N-P 6 - N-P 6 - N-P 6 - N-P 6 - Neg 6 - N-P

32 14 Pos 32 10 Pos 12 50 Pos 6 40 Pos

12 30 Pos 12 57 Pos 32 25 Pos 12 BC Neg 12 40 Neg 12 33 Neg 12 33 Pos 6 50 Pos

12 40 Pos 12 55 Pos 6 BC N-P 6 - N-P 6 - N-P

12 - N-P 6 BC Neg 6 BC Pos 6 BC Neg 6 - N-P 6 - N-P 6 21 Pos 6 27 Pos

12 17 Pos 6 27 Neg

Pos Pos Pos Pos Neg Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Neg Pos Pos Pos Pos Pos Pos Pos

N-P Nes Pos N-P Pos Neg Neg Neg Pos

Original No. Volts

DELCC 5811. 5813 6 5812, 5817 6 5814 6 5818 6 5819 6 5820 6 5821 6 5822 6 5823 12 5824 12 5826 12 5827 6 5828 6 5829 12 5830 6 5831 6 5834 12 5835. 5844 6 5836 12 5838 12 5839 6 5840 12 5841 12 5842 12 5843 12 5844 8 5847 6 5849 12 5850 6 5851 6 5852 6 5854 6 5856 12 5858 6 5859 24 5860 6 5861 6 5862 6 5863 6 5864 6 5867, 5874 6 5868 6 5869 6 5870 6 5877 6 5879 6 5880 6 5881 6 5882 12 5883 6 5884 12 5885 6 5888 12 5890 6 5891 12 5893 6 5894 6 5896 12 5898 12 5899 24

0 Amps Polarity

D-REMY 25 Pos BC Pos BC Neg 25 Pos 27 Neg BC Pos BC N-P BC Neg 17 Neg

BC N-P 20 Pos

BC Pos 27 Pos

8 Pos BC N-P 27 Pos BC N-P BC Neg 25 Pos - N-P BC N-P 13 Pos 25 Pos 26 Neg BC Neg BC Neg 35 Pos - N-P BC N-P - N-P 35 Pos 30 Neg 15 Pos

BC Neg - N-P BC N-P 29 Pos BC Pos BC N-P - N-P 29 Pos - N-P - N-P BC Pos 29 Pos - N-P - N-P - N-P - N-P - N-P - N-P 39 Pos

BC N-P - N-P - N-P - N-P N-P N-P - N-P - N-P

- N-P - N-P

35 Neg 35 Pos

BC Neg BC Pos BC Neg BC Pos 30 Neg 30 Pos 20 Neg 20 Pos 40 Neg 40 Pos

BC Neg 25 Pos 25 Pos 20 Pos

8 Pos

--

ur Code No.

18202 18204 18203 18202 17945 18204 17946 18203 18209 17947 17948 18204 17949 17950 17951 18202 17952 18203 17953 17954 17955 17986 17956 17957 17958 18203 17959 17960 17961 17962 17963 18207 17964 18203 17933 18204 18202 18204 17965 17982 18202 17966 17967 18204 17968 17969 17970 17971 17972 17973 17974 17975 17976 17977 17978 17979 17980 17981 17983 17985

17984 17982

18201 18202 18203 18204 18205 18204 18207 18208 18209 18210 18211 18212 18213 18214 18215 18210 18218

Original No.

- --

Or Volts Amps Polarity

DELCO-REMY 12 25 Neg 12 12 Pos 6 25 Neg 6 35 Pos 6 35 Neg 6 13 Neg

12 15 Pos 12 BC Pos 12 BC Neg 6 35 Neg 6 27 Pos 6 BC Pos 6 35 Pos 6 25 Neg 6 25 Pos

12 8 Pos 6 40 Pos 6 40 Neg 6 40 Pos 6 18 Neg

12 31 Pos 6 35 Neg 6 BC Neg 6 50 Pos

12 25 Neg 12 25 Pos 12 40 Pos 12 20 Pos 12 31 Neg 6 30 Pos 8 30 Neg

12 20 Pos 12 20 Neg 6 50 Pos 6 45 Pos

12 40 Pos 6 35 Pos

12 50 Pos 24 20 Pos

6 BC Neg 12 25 Pos 12 17 Pos 12 50 Neg 6 45 Neg 6 50 Neg 6 - Pos

24 10 Pos

6 40 Neg 6 35 Neg 6 35 Pos 6 30 Pos

12 20 Pos 6 - Pos

12 - Pos 6 BC Neg 6 - Pos 6 - Neg 6 BC Pos 6 35 Neg

12 20 Neg 6 40 Neg 6 40 Pos

12 25 Pos 12 25 Neg 12 25 Pos 12 BC Pos 12 8 Pos 12 12 Pos 6 18 Neg

12 31 Pos 12 31 Neg 6 35 Pos 6 BC Neg 6 50 Pos 6 50 Neg 6 50 Pos 6 50 Neg

12 40 Pos 12 40 Pos 12 50 Pos

11 Code No.

REGULATOR - QUICK REFERENCE GUIDE Oc

Volts Amps Polarity

DELCO-REMY 12 50 Neg 12 20 Pos 6 45 Neg 6 45 Pos

24 20 Pos 24 10 Pos

6 25 Neg 6 25 Pos 6 35 Pos 6 35 Neg

12 20 Pos 12 20 Neg 6 40 Neg 6 42 Pos 6 25 Neg

12 20 Pos 6 40 Neg

12 12 Pos 6 45 Pos

12 50 Pos 6 18 Neg 6 35 Pos

12 - Pos 6 40 Pos 6 32 Pos

12 40 Neg 6 55 Neg 6 40 Pos 6 40 Pos 6 52 Pos 6 55 Pos 6 35 Neg

lr Code No. - Oriainal No.

O u Volts A ~ D S Polarity

r Code No. -

O u r Code Orisinal No. Volts Amps Polarity No. Original No.

DELCO-REMY 24 20 Pos 12 40 Pos 6 35 Pos 6 45 Pos

12 30 Neg 12 30 Neg 12 31 Pos 6 18 Neg

24 28 Pos 12 BC Neg 12 14 Pos 6 BC Pos

12 BC Pos 6 - Pos 6 BC Pos

12 14 Pos 12 - Pos 24 18 Pos 24 15 Pos

DELCO-REMY 12 30 Neg 12 40 Neg

12 25 Neg 12 25 Neg

12 10 Pos 12 17 Pos 12 17 Pcs 12 50 Neg 12 - Neg 12 35 Neg 12 35 Neg 12 15 Neg 12 - Neg 12 35 Neg 6 45 Pos

12 30 Pos 12 Neg 24 18 Pos

12 30 Neg 12 30 Neg 6 45 Neg 6 45 Pos 6 45 Pos 6 40 Pos 6 40 Neg 6 55 Pos 6 45 Pos 6 52 Neg

12 - Neg 12 50 Pos 12 30 Pos 6 36 Pos 6 40 Pos 6 40 Neg 6 40 Neg 6 40 Neg 6 50 Pos 6 50 Neg 6 52 Pos 6 30 Neg 6 30 Pos 6 19 Neg 6 18 Neg 6 BC Pos

12 50 Pos 12 50 Pos 12 40 Pos 12 40 Pos 12 40 Neg 12 31 Pos 12 31 Pos 12 31 Neq 12 25 Pos 12 25 Pos

FORD

Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos Pos

32 BC 6 40 Pos

12 80 Pos 32 14 Pi 24 10 Pi

6 40 Neg 32 10 Pi

12 40 Pos 24 10 Pi 32 10 Pi 12 55 Pos 32 40 Pi 32 10 Pi 12 55 Neg 24 50 Pi 12 80 Pos 12 40 Pos 24 10 Pi 12 55 Pos 32 25 Pi 32 10 Pi 32 40 Pi 12 120 Pi 12 18 Pi 32 15 Pi 12 120 Pos 24 10 P1 32 25 Pi 12 55 Pos

Pos Pos Pos Neg

FAB-10505A FAC-10505A FAD-10505A-C FAE-10505A FAG-10505 Tractor

FAJ-10505A FAL-10505A FAM-10505A FAP-10505B FAW-10505B FAY-10505B FBA-10505B FBB-10505A FBC-10505A

Pos Pos Pos Pos

12 20 Pos 12 20 Neg 12 20 Pos 12 12 Pos 12 12 Pos 12 55 Pos 6 54 Neg

12 25 Neg 6 18 Pos 6 54 Pos

12 40 Neg 6 45 Pos

12 30 Pos 12 25 Pos 12 35 Neg 12 35 Neg 12 50 Neg 24 25 Neg 12 14 Neg 12 14 Neg

Pos Pos Pos Neg Neg Neg Neg Neg Neg Pos

6 55 Pos 12 25 Pos 32 15 Pi 12 100 Pos 12 - Pos 24 25 Ni

6 38 Neg 6 40 Neg 6 52 Neg 6 45 Neg 6 45 Pos 6 45 Neg 6 45 Neg 6 45 Pos 6 36 Pos 6 45 Pos

12 27 Neg 12 29 Neg 12 35 Neg

ORIGINAL REGULATOR OUR CODE GENERATOR NO. NO. NO.

AU GAE 4037-40-A GAE 4040 A GAE 4041

GAG 4145 GAG 4145

GAR 4608 GAR 4609 GAR 4611 GAR 4612 GAR 4613 GAR 4636

GAS 4143 GAS 4143 GAS 4165 GAS 4167 GAS 4177 GAS 4179 GAS 4181 GAS 4182 GAS 4186 GAS 4188 GAS 4197 GAS 4301 GAS 4301 GAS 4302 GAS 4303

GBC 4103 GBC 4103 GBG 4601-02-03 GBG 4604-06 GBG 4607-08 GBM 4622 GBM 4802 B GBM 4802 B GBM 4807 GBM 4808 GBM 4809 GBM 4809 GBM 4809 GBM 4813 GBM 4814 GBM 4819 GMB 4820 GBM 4822 GBM 4824 GBM 4901 GBR 4601 GBR 4611 GBS 4611 GBU 4214-16 GBW 4803 GBW 4803 GBW4804

GCB 4820 GCD 4801 GCD 4803 GCD 4803-04 GCD 4808-10 GCE 4803 GCE 4806 GCE 4807 GCE 4812 GCE 4814 GCE 4816-17 GCE 4820 GCH 4601-03 GCH 4605-06 GCH 4607-08 GCH 4609 GCH 4610 GCH 4612-13 GCJ4801 GCJ4802 GCJ4802 GCJ4803 GCJ4805-06 GCJ4807

ORIGINAL REGULATOR 0 GENERATOR NO. NO.

AUTOLITE GCJ4808 VRD4006A-B l GCJ4808 VRR4002B l GCJ4811 VRR4004A

GCK4805 VRS4005D

GCM4802 TC4302A GCM4804-05 TC4302A GCM4810 TC4302A GCM4815-16 TC4302A GCM4822-23 TC4302A GCM4827 TC4302A

GC04801 VRB4004B GC04802 VRB4010A GC04803 VRP4002B GC04803 VRP4006C GC04807-10 VRP4002B

GCR4802 VRS4005A-B GCS4803 TC4302A GCS4804 TC4302A GCS4804 TC4317A GCS4805-06 TC4302A GCS4808 TC4302A GCS4809 TC4317A GCS48 11 TC4317Ae GCS48 11 TC4302Ae GCS4811 VRR4004A l GCS4812 TC4302A GCS4814-15 TC4302A GCU4801 TC4310A

GCW4806 VRS4005B

GDA4801 VRB4004B GDA4801 VRP4001C GDA4803 VRB4004B GDA4804 VRP4004A l GDA4804 VRP4004D l

GDB4805 TC4310A GDB4813 TC4303D GDB4814 TC4310A GDB4815 TC4303D GDB4816 TC4303D

GDF4801 VRD4002B GDF4801 VRR4003A GDF4802 VRD4008A GDF4804 VRD4006B GDF48 12 VRR4002B

GDJ4803 VRH4lOlA GDJ4804AA VRH4004B-E GDJ4804 VRH4 104B-E GDJ4805 VRH4101A GDJ4808 VRH4 104D GDJ4809 VRH4102A GDJ4809 VRH4lOlA GDJ48 11 VRH4lOlA GDJ4820 VRH4104F GDJ4822 VRH4lOlA GDJ4822 VRH4 102A-B GDJ4829 VRH4 102A GDJ4832 VRH4104D GDJ4833 VRH 4104F GDJ4836 VRA4102A l GDJ4836 VRH4102A l GDJ4837 VRH4102A-B GDJ4838 VRH4lOlA GDJ4838 VRH4102A-B GDJ4841 VRH4102A GDJ4844 VRH4102A GDJ4846 VRH4102B

GDM4803 VRX4001A-B GDM4804 VRX4002A GDM4806-07 VRX4001A GDM4808 VRX400 1A-B

GDS4801 VRD4008A GDS4801 VRR4001A GDS4802 VRD4010A

GDT4802-04 VRP4004E GDT4802-04 VRP4006F GDT4803 VRP4009C

1UR CODE NO.

ORIGINAL REGULATOR 0 GENERATOR NO. NO.

AUTOLITE

I VRP400 1 A-AX' GDZ4801 VRP4004F

POSITIVE VRP4401A A, B, F. G. R. VRP4402C T. V 1 VRP4501A

VRP4503A GDZ4801L 1 VRP4005A l

NEGATIVE VRP6003A l I VRP8003A l

GDZ4802 VRP4008C-D GDZ4803 VRP4004F GDZ4804 VRP4004F GDZ4804 VRP6001A GDZ4805A VRP4004F GDZ4805A VRP6001A GDZ4806 VRP4004F GDZ4809 VRP4004F GDZ4809 VRP6001A GDZ4810 VRP4004F GDZ4810 VRP6001A "uDZ48 1 1 VRP4004F l "uDZ4811 VRP6001A l GDZ4811 Neg VRP6003A l GDZ4813 VRP4004F.FX GDZ4817 VRP4007C GDZ4818 VRP4004F GDZ4820-23 VRP4302AM GDZ4822 VRW4001BX GDZ4822 VRW5005C

1 VRP4004P l VRP4004F l

GDZ6001B VRP6001A l VRP6002A l

POSITIVE VRP6004A l VRP6005A l

'VRP6lOl A* ( VRP61OlBe

GDZ6001 Neg VRP4007C GDZ6001 Neg VRP6003A GDZ6002 VRP6001A l GDZ6002 VRP6005A l GDZ6003 VRW5005Ce

GEA4801 VRP4002A GEA4801 VRP4201A GEA4802 VRP4002C GEA4802 VRP4003A GEA4802 VRP4202A-C GEA4803- VRP4004A GEA4803 VRP4008B GEA4804 VRP4004A GEB4801

i VRP4006E l

GEB4801 VRP4401Ce GEB4801 VRP4004G l

POSITIVE GEB4801A-B VRP4001B l GEB4801N Neg VRP4005BO GEB4802 VRP4008C-D GEB4802 VRP4002D GEB4803 VRP4004C GEB4804 VRP4004C GEB4804 VRP4006E GEB4805 VHP4006E GEB4806 VRP4004C GEB4806 VRP4006E GEB4807 VRP4004C l GEB4807 VRP4006E l GEB4807 VRP4004G l GEB4809 VRP4006E GEB4810 VRP4006E l GEB4810 VRP4004C l GEB4810 VRP4004G l GEB4811 VRP4006E GEB4812 VRP4004C GEB4813-14 VRP4006E GEB4815-16 VRP4006E GEB4819 VRP4004C-K GEB4819 VRP4006E GEB4820 VRW4004A GEB482 1 VRB4008A GEB4823 VRP4004C

IUR CODE NO.

l GENERATOR WITH VARIOUS REGULATORS: REPLACE WITH SAME NUMBER AS REMOVED. 7


A l GEB4824 GEB4827 GEB4828 GEB4834 GEB600 1 GEC480 1 GEC4801 GEF4806 GEF4806 GEF4813 GEF4813 GEF4813AN Neg GEF4819S GEG4801 GEG4802 GEG4802 GEG4807 GEG4811 GEG4811 GEG4812 GEG4812 GEG4812 GEG4813-14 GEG4818 GEG4818 Neg GEG4822 GEG4822 GEG4822 GEG4822 GEG4822 GEG4823 GEG4823 GEG4823 GEG4823 GEG4823BN Neg GEG4823BN Neg GEG4828N Neg GEG4829 GEG4829 GEG4829 GEG4831 GEG4833-34 GEG4836 GEG5001-02 GEG5lOl GEG6001 GEG6001 GEG6001 GEG6001 GEH4802 GEH4805 GEH4819 GEH4819 GEH482 1 GEH4822 GEH5001P GEH5002 GEH5002N Neg GEH6001 GEM4102 GE04803 GE04808 GE04808 GE04810 GE04810 GE04811-13 GE04815 GE04816

GEW4801 GEW4802- GEW4805

GEZ4801 GEZ4801 GEZ4801

GFA4801 GFA4806 GFA4806 GFA4807 GFA4808

JTOLITE VRW4004A VRP40 10A VRP4006E VRP4006E VRP4004C l VRR4001A VRD4008A VRS4004F l VRS4010A l VRS4004JX l VRS520llA-AX l VRS5010Ce VRS5010C VRP4008A VRP4004E VRP4006F VRP4006F VRP4004E VRP4006F VRP4004B l VRP4004C l VRP4004E VRP4006F VRP4001F l VRP4005E l VRP4004E l VRP4004F l VRP4006F l VRP6001A l VRW4001BXe VRP4001F VRP4401B VRP4402B VRP4501G VRP4005E l VRP4403A l VRP4 104B VRP4004B l VRP4004C l VRP4004E l VRP4006J VRP4004E VRP4004E

I VRY4203A-B 1 VRY4203E-G VRP4401C l VBA6001B l VBA6003A l VRP4004E l VRS4004A-B VRS4009A VRX4002B l VRX4003D l VRX4003D VRX4003B VRG4 102B-D VRG4 102B-D l VRG4 103B VRX4003D TC4326A TC4305B TC4301D TC4305B TC4305A-B TC4302A TC4302A TC4302A TC4327E

VRP4004G VRY420 1A-C VRY4201A-C

VRS4004C l VRS5001 l VRS5004C l

TC4323B TC4301C TC4305A TC4302A TC4323B

8 l GENERATOR WITH VAR - -

-


AUTOLITE GFA4808 TC4327E 17402 GFA4810 TC4305B 17401 GFA4811 GFA4812 TC4326A-B 17402 GFA4814 GFA4818 TC4326A 17402 GFA4831 GFA4831 GFA4834 GFB4805-06 GFB4809 GFE4801 GFF4lOl GFJ4801-02-03 GFL48 1 1 GFP4801 GFR4806-07-08 GFW4804-06 GFW4807-14 GFW4815 Neg GFW4815 GFW4816 GFY4802 GFZ4801

GGA4802 GGA4802 GGA4803 GGA4803 GGA4803 GGA4803 GGA4803 GGA4805-07 GGA4808 GGA4810 GGA4810 SGA4812 GGA4813 GGA4814 GGA4814 GGA48 14 Neg GGA4816 GGA4817 GGA6001

POSlTlVE A. B. C. D. E, F, G, S, S-1

SGA6001EN Neg GGA6002-03 GGC4802 GGE4806 GGE4806A-B-S Ne GGE4806C GGF4801 GGF4803 GGJ4801-03 GGJ4802-03 GGJ4803 GGJ4804 GGJ4804

POSITIVE

GGJ6001 NEGATIVE


AUTOLITE

I VAV4002C GGU6001 VAV4401B

POSITIVE VAV4404B A. B, C, D, E, VAV6001A-B F. G, H, J, K. VAV6005A P, R, S, S-1, T. VBA4lOlB u. v. W VBA4103A

VBA6001A GGU6002 I VAV4405B

VAV6002A-B NEGATIVE VBA4104B

VBA4206B GGU6002 GGU6004 VAV6001A-B GGU6005 VAV6001B GGU6005 VBA6001A GGU6006 VAV600 1A-B GGU6007 VBA6001A GGU6008 VAV6001B GGU6Oll VBA4206A GGU6013 VAV6001A-B GGW4801 VBEGlOlA@ GGW4801 VBE6104A l GGW4801 Neg VBE6105Ae GGW4802-03 VBE6lOlA GGW6001

POSITlVE I VRP4402C l A, AM, AT. B. VRP4503Be C. D. E. F, G, VRP4503BXe H. J, K, L, .P. VRP6001Be P-1, Q, QT, R, VRP6004Ae S, S-1, V, W, VBE6001Ae X. Y. Z I VBE6201Ae

GGW6002 VBE6001A GGW6002 VRP4503B l GGW6003 VRP4402Ce GGW6003 VBE6102A l GGW60007-08 VBE6001A GGW6009-10 VBE6001A GGW6Ol 1-12 VBE6001A GGW6013-14 VBE6001A GGW6016 VBE6001A GGW6016 VBE6201A GGW6017 VBE6001A GGZ6001-02-03 VBA4203A GHB4801 VRP6004B GHB4801 VRP6008A GHD6OO 1

POSITIVE AB-1. AC-1, VRP4103A l

I. I. P. Q. R. S. SS. v. W.

I AD, B-1, D-1, VRR4102A-B@ E. F, G. H. K. VRR4103Ae

X. Y, z GHD6001

I I NEGATIVE VRR4 10 1A l

A, AA, AB- VRR4104Ae AC, B, C. D. I L. Q-1. SSN

GHD6OO2A-B-S GHH6001B GGH6001E GHH6001E-J Neg GHH6002A-B GHH6OO2A-B-S GHH6003A GHK6001

IOUS REGULATORS: REPLACE WITH SAME NUMBER A S REMO

17270 17330

17115 17106 17106 17109 -

VED.


ORIGINAL REGULATOR OUR CODE ORIGINAL REGULATOR OUR CODE GENERATOR NO. NO. GENERATOR NO. NO. NO.

AUTOLITE AUTOLITE GJC7001 VRX6201A VRX6008A 17109 GJC7002 VRX6201A 17115 GJC7002 VRX6201A 17115 GJC7002-03-04 VBA6001C 17378 GJC7006 VRX6201A 17115

AUTOLITE GHM6003 VRX6201A@ 17115 GHM6004 VRX6201A 17115 GHM6007-08 VRX6201A 17115 GHM6009-10 VRX6201A 17115 CJC600 1 VRX6007A 17112

Original Generator No.

DELC 1100002 1100003 1100003 1100003 1100004 1100004 1100005 1100006 1100008 1100008 1100008 1100009 1100012 1100013 1100013 1100018 1100018 1100018 1100019 1100019 1100021 1100022 1100027 1100028 1100029 1100031 1100033-34

Regulator Our No. Code No.

IO-REMY 5588 17911 5808. 18213 5835. 18203 5858. 18203 5814. 18203 5858. 18203 5827 18204

1118204 18204 5820. 18204 5862. 18204

1118231. 18204 5858 18203

1 1 18204 18204 1118720. 18301 1118731. 18302 1118725. 18725 1118827. 18725 1118828. 18730 1118731 18302 1118841 18302 1118731 18302 1118953 18328 1118786 18786 1118843 18300 1118790 18790 1118842 18314 1118790 18790

Original Regulator Our Generator No. No. Code No.

DELCO-REMY 1100953 5849. 17960 1100953 1118306. 18306 1100954 1118791 18791 1100955-956 1118306 18306 1100964 1118381. 18381 1100964 1118779. 18779 1100966 5849 17960 1100971 5838 17954 1100972 5838. 17954 1100972 5884. 17974 1100973 1118319 18227 1100986 1118381 18381 1100988 1118306 18306 1100990-996 1118779 18779 1100998 1118979 18979 1100998 1118981 18979 1100999 1118791 18791


DELCc 1101743 1101744 1101744 1101747 1101747 1101750 1101751-754 1101752 1101762 1101775-779 1101777-784 1101782


3-REMY I Original Generator No.

DELC 1102063 1102065 1102066 1102067 1102068 1102070 1102070 1102071-73 1102072 1102074-77 1102079 1102083-84 1102085 1102086 1102099


0-REMY 1119001 19000 1119123 19000 1119168 19002 1119002 19002 1118839 18328 1119002 19002 1119168 19002 1 1 19002 19002 1119165 19165 1119163 19002 1119002 19002 1119168 19002 1119001 19000 1119002 19002 1119002 19002

1119163 19002

GENERATOR WITH VARIOUS REGULATORS: REPLACE WITH SAME NUMBER AS REMOVED. 9





Original , Generator No.


Original Regulator Our Generator No. No. Code No.

DELC DELC 1102754 1102757 1102761 1102761 1102761 1102769-771 1102770 1102773 1102774 1102775 1102776 1102777 1102777 1102778 1102778 1102778 1102778 1102778 1102779 1102780-78 1 1102782 1102785 1102785 1102785 1102785 1102786 1102787 1102787

I 1102788 1102788 1102789

, 1102793 1102793 1102793 1102793 1102794 1102794 1102798 1102799 1102815 1102820 1102820 1102820 1102822

DELC 1105007-14 1105008 1105008 1105009-10 1105009-10 1105011-13

10 GENERATOR WITH VARIOUS REGULATORS: REPLACE WITH SAME NUMBER AS REMOVED.

Original Regulator Our Original Regulator Our Original Regulator Our Original Regulator Our Generator No. No. Code No. I Generator No. No. Code No. I Generator No. No. Code No. I Generator No. No. Code No.

DELCO-REMY 1105976 1118793. 18793 1105976 1119177. 19177 1105979-981 11 18793 18793 1105982-983 1118793 18793 1105984 1118793 18793

DEL 1106629-630 1106629-630

DELC 1106849 1106849 1106850 1106850 1106850 1106851 1106855 1106855 1106855 1106855 1106856 1106856 1106857-858 1106858 1106865 1106865 1106866 1106866 1106867 1106867 1106867-868 1106876 1106892 1106895-898

GENERATOR WITH VARIOUS REGULATORS; REPLACE WITH SAME NUMBER AS REMOVED. 11

GENERATORS TO REGULATOR CODE NUMBERS ORIGINAL

GENERATOR NO. REGULATOR OUR CODE

NO. NO.

FORD 01A-10505C 17010 01A-10505C 17010 01A-10505C 17010 01A-10505C 17010 01A-10505C 17010 51A-10505A 17010 8A-10505 17010 5EH-10505C 17014 8BA-10505A 17018 FAD-10505~' 17014 FAE-10505A 17026 8M-10505A 17011 19B-10505A 17054 8N-10505B 17034 8N-10505B 17034 19B-10505A 17054 01A-10505C 17010

ORIGINAL 1 GENERATOR NO.

REGULATOR OUR CODE NO. NO.

FORD 01A-10505C 01A-10505C 01A-10505C 19B-10505A B5A-10505C B5A-10505C B6A-10505A B5C-10505A B6C-10505B B6A-10505C B6A-10505B B6C-10505A B6A-10505A B6A-10505A FAC-10505A FAC-10505A FAD-10505A

ORIGINAL GENERATOR NO.

REGULATOR OUR CODE NO. NO.

FORD FAE-10505A FAG-10505 B5A-10505A FAM-10505A FAC-10505A PAL-10505A FAP-10505B FAP-10505B B5A-10505C FAJ-10505A FAC-10505A FAP-10505B FBF-10505A 8M-10505A 81-10505 7HNN-10505

New Regulator Code Numbers Issued By Autolite II Autolite

Code Original Our Autolite Original Our Original Autolite Our Original Autolite Our

Regulator No. No. Code Regulator No. No. Regulator No. Code No. Regulator No. Code

VAT4001A 17252 8-33 VRR4003A 17336 VAT4001A 8-1 17252 VRR4003A 8-33 17336 VAT4004AX 17252 8-34 VRR4008AX 17336 VAT4004AX 8-2 17252 VRR4008AX 8-34 17336 VAT6201A 17251 8-35 VRR4103A 17338 VAT6201A 8-4 17251 VRR4103A 8-35 17338 VAV6002B 17371 8-36 VRR4104A 17335 VAV6002B 8-5 17371 VRR4104A 8-36 17335 VAV6005A 17370 8-38 VRS6003AM 17266 VAV6005A 8-6 17370 VRS6003AM 8-38 17266 VBA4203A 17384 8-39 VRT4103A 17270 VBA4203A 8-7 17384 VRT4103A 8-39 17270 VBA4205A 17370 8-40 VRT4104A 17273 VBA4205A 8-8 17370 VRT4104A 8-40 17273 VBA4206A 17371 8-41 VRV4003A 17292 VBA4206A 8-9 17371 VRV4003A 8-41 17292 VBA4206B 17371 8-43 VRW4001BX 17352 VBA4206B 8-10 17371 VRW4001BX 8-43 17352 VBA6001A 17370 8-44 VRW6001AX 17352 VBA6001A 8-11 17370 VRW6001AX 8-44 17352 VBE6101A 17300 8-47 VRW8002BX 17352 VBE6101A 8-13 17300 VRWg002BX 8-47 17352 VBE6105A 17301 8-48 VRX4001A 17102 VBE6105A 8-15 17301 VRX4001A 8-48 17102 VBF6002A 17371 8-49 VRX4001BX 17102 VBF6002A 8-16 17371 VRX4001BX 8-49 17102 VBF6003A 17370 8-50 VRX6003A 17106 VBF6003A 8-17 17370 VRX6003A 8-50 17106 VRC4lOlB 17346 8-51 VRX6003B 17114 VRC4101B 8-18 17341 VRX6003B 8-51 17114 VRH4102A 17260 8-52 VRX6007A 17112 VRH4102A 8-19 17260 VRX6007A 8-52 17112 VRH4102B 17260 8-53 VRX6008A 17109 VRH4102B 8-20 17260 VRX6008A 8-53 17109 VRP4004C 17322 8-54 VRX6009A 17109 CRP4004C 8-21 17322 VRX6009A 8-54 17109 VRP4004F 17320 8-55 VRX6201A 171 15 VRP4004F 8-22 17320 VRX6201A 8-55 17115 VRP4006E 17322 VRP4006E 8-25 17322 VRP4007C 17319 VRP4007C 8-26 17319 VRP6002A 17320 VRP6002A 8-20 17320 VRP6004B 17314 VRP6004B 8-30 17314 VRR4001A 17340 VRR4001A 8-32 17340

See Next Page

REGULATOR . POPULAR YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . ALL STATE (See Henry J )

AUTOCAR 1937-48 GEG4822-36 ............................ AL VRP4004E 17330 1938 977U. 1106253 ...................... DR 5538 17884 1938 977V-Y .................................... DR 5535 17883 1938-39 930C. 9341) . 1105201 ............ DR 5598 lE210 1938-39 930B ....................................... DR 5596 17915 193839 960B. 1100451 ........................ DR 5542 17887 1938-39 930B. Mag . Sw.. 934V ............ DR 5806 17942 1938-41 930G ........................................ DR 5810 17944 1938-41 948V .................. A .................... DR 5540 17885 1939 1106630-642 x ........................... DR 5841 17956 1939 1106585 ................................. DR 5847 17959 1939-41 634 .......................................... DR 5526 17877 1939-41 634 .......................................... DR 5649 17938 1939-44 677 .......................................... DR 5535 17883 1940 GFJ4801, GEH4802 ................ AL VRS4004A-B 17272 1940-41 1102404 .................................. DR 5540 17885 1940-41 1105201 .................................. DR 1118210 18210 1940-41 934V ........................................ DR 1 1 18234 18230 1940-41 930B ........................................ DR 11 18215 18215 1940-41 930C ........................................ DR 11 18210 18210 1940-41 1106585588 ............................ DR 11 18222 18202 1940-42 1106630-642 ............................ DR 11 18214 lE214 1941-42 GEW4801 ................................ AL VRP4004G 17316 1941-42 GBG4607B .............................. AL VRA4102A 17294 1941-43 GEW4802-05 .......................... AL VRY4201A-C 17374 1941-44 GEB4823 .................................. AL VRP4004C 17322 1941-50 GDM4803-08 .......................... AL VRXQOOlA-B 17102 1942 934V ........................................ DR 11 18210 1B2l0 1942-45 634 .......................................... DR 5649 17938 1944-45 GDM4808 ................... :...... ...... AL VRX4001B 17lO2 1944-50 GGA48 10 ................................ AL VRX4004A l7lO2 1944-47 GGA4802-03 .......................... AL VRX4001 B 17102 1944-47 GG04801 ................................ AL VRS4005C 17254 1944-49 GGA4802-03 ............. ........... AL VRX4003C 17102 1945-47 634 DR 11 18507 18507 .......................................... 1945-48 1 106642-665 ............................ DR 1 1 18241 18241 1945-48 GGA4803 ................................ AL VAT4002A 17252 1946 GDJ4820 AL VRH4 104F 17260 .................................. 1946-48 GGA4810 ................................ AL VRX4005A 17102 1947 ' 1106630-660 ............................ DR 11 18214 18214 1948 1106805 .................................. DR 11 18279 18279 1948 1105886 .................................. DR 1 118271 18202 1948 1106801 .................................. DR 1118277 18261 1948 GCS4808 ................................ AL TC4302A 17401 1948 GEH4802 ................................ AL VRS4004B 17272 1948-50 GGA4803 ........... ..................... AL VAT4001 A 17252 1948-51 GEG4836 ................................ AL VRP4004E 17330 1949-50 GG04801 ................................ AL VRS4007D 17254 1949-53 1106808 ................................. DR 11 18339 18339 1949-53 1106665 .................................. DR 11 18328 18328 1949-53 1106815-822-849 DR 11 18368 18339 1949-53 1106816-821-850 .................... DR 1118337 18337

18339 ................................. 1949-53 1106822 DR 11 18339 1949-53 1106801 ... .............................. DR 11 18338 18337 1950-54 GGA4803-14 .......................... AL VAT4004AX 17252 1953-54 1117053 ............................... DR 11 18534 18534 1954 1106808. Buda Eng ............... DR 11 18880 18339 1954-55 1106822.849. White Eng ....... DR 11 18338 18337 1954-56 1106821.850. White Eng ....... DR 11 18886 18337 1954-56 1106805.822. Cummins ........ DR 11 18880 18339 1954-56 1106822. LeRoi Eng ............. DR 1 118838 18339

BUICK 1937 9 18A-B-F-G ............................ DR 5807 18213 1938 1101052-053-055 .................... DR 5807 18213 1939 1101052-053-055 .................... DR 5858 18203 1939 1101057 ................................. DR 1118309 18203

CARS AND TRUCKS YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . CADILLAC

........................... 1938 1102651-652 DR 5818 18202 1938 1101051-054 ............................ DR 5817 18204 1939 1 l a 6 5 5 DR 5867 18202 ................................. 1940-41 1102661-686-686 .................... DR 11 18202 18202 1942 1102693-694 DR 11 18202 18202 ........................... 1946-48 1102693 .................................. DR 11 18242 18201 1949 1102700 DR 11 18300 18300 .................................. 1950-51 1102700 .................................. DR 11 18357 18300 1951 1102770 .................................. DR 11 18727 18725 1952 1102781 DR 1118725 18725 .................................. 1953' 1102002-007 ............................ DR 11 18750 18825 1953 1117102 A.C. ....................... DR 1118773 18773 1954-55 1102002-011 ............................ DR 1118826 18825 1956 11020Q2-011 ........................... DR 11 19001 19000 1957 1102086-099 DR 11 19168 19002 ............................ 1957 1102060-100 DR 1119163 19002 .......................... 1957 1106989 (7059) DR 11 19175 19175 .....................

CHEVROLET CARS 1938 948R ................................... DR 11 18203 18203 1938 1100004 .................................. DR 5814 18203 1939 1106004 .................................. DR 5858 18203 1940-48 1 102667-674 ............................ DR 1 118201 18201 1949-50 1102710 .................................. DR 11 18301 18301 1951-52 1102749-761 .......................... DR 1118301 18301 1352 1102749, 1100013 .................. DR 1118720 18301 1953 1100018. 1102793 .................. DR 1118725 18725 1954 1100018. 1102793 .................. DR 11 18827 18725 1954 1 100028 .................................. DR 1 1 18843 18300 1955 1100310 .................................. DR 1118945 18945 1955 1 102020 .................................. DR 1 1 18826 18825 1955-57 1102014-041-056 .................... DR 11 19003 19003 1956-57 1100321-326 ............................ DR 1119000 19000 1956-57 1 102041 .................. DR 1 1 19000 19000 1956-57 1102042-056 . . . . . . . . . . . . DR 11 19001 19000

Special Equipment Cars & Trucks - See Trucks

CHEVROLET TRUCKS 1938 934V ..................................... DR 5806 17942 1938-39 934F .Oversize ...................... DR 5599 17916 1938-39 934F . Oversize ...................... DR 5854 18201

........................................ 1938-39 9346 DR 5801 17940

........................................ 1939 934F DR 5597 18202 1940-48 1102667-674 ............................ DR 11 18201 18201 1940-49 11Q2677. Door to Door .......... DR 1118233 18221 1941 934F . Optional ........................ DR 11 18221 18221 1949 1102726, Door to Door .......... DR 11 18349 18349 1949.52 1102710-749-761 .................... DR 11 18301 18301 1950 1102726. Door to Door ............ DR 1.1 18361 18349 1952 1 100013, 1 102749 .................. DR 1 1 18720 18301 1953 1100018. %, % & 1 Ton. . .............................. Eng 216 DR 1118727 18725 1953 1102793. 1% & 2 Ton,

. .................. Eng 235 & 261 DR 11 18727 18725 ........ 1954 1100018.1h. % & l T o n DR 1118827 18725

1954 1100028. %. % & 1 Ton ........ DR 1118843 18300 1954 1102793. 1% & 2 Ton,

. .............................. Eng 261 DR 1118827 18725 1955 1100310 Std ........................... DR 1118945 18945 1955 1117102 A.C. .......................... DR 1118972 18972

. ....... 1956 1102042 Std Buick Eng DR 1119001 19000 1956 1105947 .................................. DR 11 19001 19000

........................ 1956 1117102 A.C. DR 1119160 19160 1956 1 10698 1-982 .......................... ADR 1 1 19004 19004 1956-57 1100326 Std ........................... DR 11 19000 19000 1957 1102041 Chev . Pow . Steer ..... DR 11 19000 19000 1957 1102056 Buick Pow . Steer ..... DR 11 19001 19000

f 940 1102662-663-668-669 .............. DR 11 18201 18201 1941-42 1105857 State Police .............. DR 11 18237 18237 CHEVROLET SPECIAL EQUIPMENT 1941-48 1102668-679 ............................ DR 11 18201 1820 1 1938-39 934F ........................................ DR 5854 18201 1941-48 1102736 ................................. DR 11 18301 18301 1938-39 934G ........................................ DR 5801 17940 1949 1102679 .................................. DR 1118301 18301 1938-39 934V ........................................ DR 5806 17942

YEAR GENERATOR System REGULATOR OUR NO . NO . CODENO .


CUMMINS ENGINES (Cant., CHEVROLET SPECIAL EQUIPMENT ((Cont.1- 1948-51 1106751-57 .............................. DR 11 18334 18334 1948-51 1106752-58 .............................. DR 11 18343 18725

49-51 1102729 Taxi .......................... DR 11 18300 18300 2 1102786 .................................. DR 11 18725 18725 2 1105001 .................................. DR 11 18722 18334 2 1105002 .................. ................ DR 11 18721 18300

CHRYSLER 1935-36 GAR4608 ................................ AL 1937 GBW4803 ................................ AL

i 1937-39 GC04801 . GDA4801 ............ AL

1948-50 GDZ4801 A-R .......................... AL VRP4503A 17320 1949 GGW6001A-B ........................ AL VRP4503B '17332 1950 GGW6001A-B-J-K .................. AL VRP6004A 17332 1950 GGU6001A-EG-H .................. AL VAV6001A 17370 1951-55 GGW6001-07-08-16-17 .......... AL VBE6001A 17300

9 GGU6001A-E Early ................ AL 9 GGU6001A-E Late ................ AL 0 GGW6001A-J .......................... AL

'Three Terminals in line

For Negative Ground and Special Equipment see Dodge Truck . 'Three Terminals in line

For Negative Ground and Special Equipment see Dodge Truck . DIAMOND T

CUMMINS ENGINES

1946-48 GCH4607 ................................ AL VRC4 1 OlB 17346

1117510 .................................. DR 11 17558 .................................. DR 634. 692. 11 17204 ................ DR 692 Shock Mounts ................ DR 1106662 .................................. DR 1117313 .................................. DR 1117313 .................................. DR 11 17313 Shock Mounts ... : ...... DR 1106510-514 ........................ ...D R

YEAR GENERATOR NO.

System REGULATOR OUR NO. CODENO.

YEAR GENERATOR System REGULATOR OUR NO. NO. CODENO.

DODGE PASSENGER CARS 1935-36 GAR4608 .............................. AL TC4301A 17401 1937 GBW4803 .............................. AL VRP4lOlA 17312 1937-39 GCJ4802, GDF4801 .............. AL VRR4003A 17336 1938-39 GDA4801 ................................ AL VRP4001C 17314 1940-42 GDZ4801 A-B .......................... AL VRP4001A 17320 1946-47 GDZ480 1A-B .......................... AL VRP440 1 A 17320 1947-48 GDZ4801A-B .......................... AL VRP4501A 17320 1948-50 GDZ4801A-B-D-R .................... AL VRP4503A 17320 1949 GGW6001A-B-D ................... AL VRP4503B ' 17332 1950 GGW6001A-B-D-J-K-L .......... AL VRP6004A 17332 1951-55 GGW6001-08-09-10-12

14-16-17 .............................. AL VBE6001A 17300 1955 GGW6001J-16 ........................ AL VBE6201A 17300 1956-57 ~ ~ ~ 7 0 0 1 - 0 2 - 0 3 - f 2 .................. AL VRX6201A 17115 1956-57 GHM6003-03-07 ...................... AL VRX6201A 17115


FEDERAL TRUCK

84 U DODGE TRUCKS

............................ GDZ480 1-02 AL .......................... GGW6001-02 AL

GGW6001-02-11-12-13 ....... AL .............................. GGW Late AL .............................. GJC Types AL

...................... GHM6007-08-09 AL .................... GHM6004D-E-G AL .... ............. GJC7002-04-10-12 : AL

VRY420 1 A-C

I 'Three Terminals in line

Negative Ground and Special Equipment Chrysler, DeSoto, Dodge, Plymouth 1947-51 1105877 .................................. DR 1118314 18314

1947-53 1105855 .................................. DR 11 18350 18303 1 1948 1102691 .................................. DR 11182C)B 18208

1948 1106751 .................................. DR 11 18275 18244 .................................. 1948 1105887 DR 11 18271 18202

1948 1106801 ........... ; ........ ............. DR 11 18277 18261 1948 1 106802 .................................. DR TI18279 18279 1948-53 1105921, 1106651 .................. DR 1118316 18316 1949 1106751 .................................. DR 11 18335 18333 1949 1106752 .................................. DR 11 10344 18725 1949 1106802-805-822 ........ : ........... DR 11 18339 18339 1949-52 1106587 ................................... DR 1118314 18314 1949-53 1102691, 1102721, 1105887 .... DR 11 18303 18303 1949-53 1106757-766 ............................ DR 11 18333 18333

.................................. . 1949-53 1 106758 DR 1 1 18366 18726 1950-53 1105930 ............... .: ................. DR 11 18354 18304 1950-53 1106805-822 ..... ...................... DR 11 18368 18339 1950-53 1106803-821-822 .................... DR 1118337 18337 1951-53 1102746-752 .......................... DR 11 18382 18314

FORD PASSENGER CARS 6 THUNDERBIRD 1939-48 ALL ............................................ F . 17010 1949-51 6 Cyl. .................................. : ..... F 17010 1949-50 8 Cyl. ................ : F 17011 1950-55 ALL . 35 Amp ........................... F 17011 1950-55 ALL . 40 Amp ........................... F 17014 1956-57 ALL - 12 Volt ............................ F 17012 Optional Equipment - See Quick Reference Guide FORD TRUCK 1939-54 ALL ............................................ F 17010 1948-55 ALL - 35 Amp ........................... F 17011 1948-55 ALL - 40 Amp ........................... F 17014 1956-57 Popular . 12 Volt ...................... F 17012

SPECIAL EQUIPMENT 1954-56 GGJ6101-03 ............................ AL VBF6003A 17370 1956-57 GGA6001Z, 6006C-D-F ........ AL VAT6005A 17251 1956-57 GGA6006B .............................. AL VAT6002A 17251 Optional Equipment - See Quick Reference Guide

15

SPECIAL EQUIPMENT ................................ 1940-42 GEB4801 AL

............ 1940-42 GEB4801 Neq, Grd. AL 1941-47 GEG4818-4823 ...................... AL 1941-49 GEG4818-4823 .... Neq. Grd. AL

................................ 1942 GFP4801 AL 1947-49 GEG4823 ................................ AL

.......... 1947-49 GGU6001 Neq. Grd. AL ...................... 1947-49 GGJ6001 Early AL

............ 1947-49 GGJ6001 Neq. Grd. .AL 1947-50 GEG4823 ................................ AL

............ 1947-50 GEG4823 Neq. Grd. AL ................................ 1948.49 GGU6001 AL ............................... 1949 GGJ6001A AL

........................ 1949 GGJ6001 .Late AL ............ 1949 GGJ6001 Neq. Grd. AL

1949 GGU6001 Late ...................... AL .......... 1949 GGU6001 Neq. Grd. AL ................................ 1949-50 GGA6001 AL ................................ i950 GGU6001 AL .......... 1950 GGU6001 Neq. Grd. AL

.......................... 1950-51 GGJ6001-03 AL 1950-52 GGJ6001 ............ Neq. Grd. AL

.................. 1951,55 GGJ6001-03-04-08 AL ...... 1951-55 GGU6001-04-05-06-08-13 AL

.......... 1951-55 GGU6001 Neq. Grd. AL ...................... 1951-55 GGZ6001-02-03 AL

1952-55 GGJ6001 ............ Neq. Grd. AL ................................ 1953-54 GHM6002 AL .............................. 1955-56 GHM6003 AL

............... 1956-57 GGA6001-02-03-07 AL 1956-57 GHM6001-07-08-09-10 ......... AI

VAV600 1 A-B VAV6002A VBA4202A VBA4204A VBF600 1A VAV6001B VAV6002B

YEAR GENERATOR NO . System REGULATOR OUR

NO . CODENO . -- -- . -

FRAZER 1947-50 GDZ4818 ................................ AL VRP4004F 17320 1949-5 1 GGU6001 Taxi ........................ AL VAV4002C 17370 1950-51 GDZ6001 ................................ AL VRP6001A 17320

FREIGHTLINER (See White.

GMC 1938 1100452 ................................. DR 11 18204 18204 1938 1106576 ................................. DR 11 18222 18202 1938 934F ....................... ................. D 5597 18202 1939 9688 ........................................ R 5540 17885

J 1939-42 1102413 .................................. DR 5863 17965 1940-42 934F ........................................ D 11 18230 18230 1940-42 1106584 DR 1118212 . .................................. 18212

1950-51 1106757 .................................. DR .................................. 1950-51 1 106758 DR

...... 1 1951-53 1 102716-49-61 Delivery , DR ' . 1951 1102746 .................................. DR

1951 1106757 .................................. DR 1 9 5 2 1100013 .................................. DR

1953 1102793 . 1100018 ................. DR

1954 1102788 .................................. DR .................................. 19$4 1106758 DR

'. I954 1106828 . Belt Drive Pos . Gr . DR

HENRY J 1951-52 GDZ6001 ................................ AL VRP6001A 17320 1952-54 1102789 .................................. DR 11 18841 18302

HUDSON (See Rambler\-

SPECIAL EQUIPMENT 1940-41 GEA4803 ................................ AL VRP4008B 17320 194042 GEE44802 .................................. AL VRP4008D 17320 1940-42 GEG4801 ................................ AL VRP4008A 17330 1954 GGJ6101 .................................. AL VBF6003A 17370

System REGULATOR OUR NO . CODENO .

IMPERIAL (Chrysler) 1955-56 GHM6003A ............................ AL VRX6003B 17114

INTERNATIONAL TRUCKS 1937-39 934G ........................................ D 5598 18210

KAISER 1947-50 GDZ48 18 ................................ AL VRP4004F 17320 1949 GGU600 1 Taxi ...................... AL VAV4002C 17370 195 1 GDZ600 1 ................................ AL VRP600 1 A 17320 1951 1 102733 .................................. DR 1 1 18302 18302 1952-53 1 102782 .................................. DR 1 1 18392 18314 1954 1 102782 .................................. DR 1 1 18842 18314 1954-55 GGW4801 .............................. AL VBE6105A 17301

LA SALLE 1938 1101051 .................................. DR 5817 18204 1939 1101056 .................................. DR 5860 18204 1940 1102661 .................................. DR 1118202 18202

LINCOLN (Not Ford) ................................ 1935 GBC4103 AL TC4302A 17401 ................................ 1936-39 GBC4103 AL TC4305A 17401

See Next Page

YEAR GENERATOR System REGULATOR NO . NO . coD"E"N"0 . I YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . LINCOLN 1939-45 ALL ............................................ F 1946-47 ALL . 35 Amp ........................... F 1948-53 ALL . 40 Amp ........................... F 1954-55 ALL . 50 Amp ........................... F 1956-57 ALL . 12 Volt ............................ F

MACK (Cont.1- ............................ 1944-47 11 17005-050 DR

.................................. 1944-48 1102670 DR 1945 1117313 .................................. DR . 1945-47 955, 960, 11 17313 ................ DR , 1945-47 1106662 .................................. DR 1945-47 11 12050 .................................. DR 1945-48 11 17557 .................................. DR

.................................. 1945-48 11 17567 DR Optional Equipment . See Quick Reference Guide

1946 GEH4819 ............ Neg . Grd . AL 1946-47 11 17005 .................................. DR 1948 1106805-810 ............................ DR 1948 1106753 .................................. DR 1949-50 1102716 .................................. DR 1949-50 1 106756 .................................. DR 1949-50 1106761 .................................. DR 1949-53 1106753 .................................. DR 1949-53 1106757-759 ............................ DR

............................ 1949-53 1106805-810 DR

MACK- 1938 1938 1938 1938 1938

MERCURY 1939-47 ALL ............................................ F 17010 1948-53 ALL . 35 Amp ........................... F 17011

.......................... . 1954-55 ALL 40 Amp F 17014 . ............................ 1956-57 ALL 12 Volt F 17012

Optional Equipment . See Quick Reference Guide

NASH (See Rambler)- 1937-39 GC04802 ................................ AL VRB4010A 1939 GDS4802 ................................ AL VRD4010A 1940-48 GDZ4803-06 ............................ AL VRP4004F

.............................. 1941 GEB4803A AL VRP4004C

OLDSMOBILE 1936-37 936T ........................................ DR 5588 1937-38 936T . 918H . 1100002 ............ DR 5814

1940-41 1102664 .................................. DR 1118201 1941-42 1102680. Hydra ..................... DR 11 18242 1942-48 1102664-680 ............................ DR 11 18242


PACKARD 1935-36 GAR461 1. G3R4601 ............ AL TC4302A 17401 1937 948U ...................................... D R 5812 18204 1937 961M ...................................... DR 5813 18202 1937-39 GCJ4801-07 AL VRR4005A . ........................... 17334 1937-38 GC04803 ................................ AL VRP4006C 17314 1938 1100005 ................................. DR 5827 18204 1938-39 GCE4803 ................................ AL VRB4008A 17318


RAMBLER (Hudson-Nashl- 1950-51 1102712-730-751 .................... DR 11 18302 18302 1951 1102748 .................................. DR 11 18382 18314 1952 1102776 .................................. DR 11 18841 18302 1952 1102776 Std ........................... DR 11 18731 18302 1953 1100021Std ........................... DR 1118731 18302 1953-55 1100021 .................................. DR 11 18841 18302

1957 GGA6001SN Taxi .................. AL VAT6003A 17251

SPECIAL EQUIPMENT 194 1-47 GEB4802 Taxi ........................ AL VRP4002D 17320 1948-49 GGJ4804 Hearse .................... AL VAV4401A 17370 1948-50 GEG4823 Taxi ........................ AL VRP4402B 17330 1950 GGJ4804 Hearse .................... AL VBA4103A 17370 1950 GGU6001 Taxi ...................... AL VAV4401B 17370

PLYMOUTH 1935-36 GAR4608 ................................ AL TC4301A 17401 1937-39 GCJ4802. GDF4801 .............. AL VRR4003A 17336 1939 GDA4801 ................................ AL VRP4001C 17314 1940-42 GDZ4WIlA-B ......................... AL VRP4001A 17320 1946-47 GDZ4801A-B .......................... AL VRP4401A 17320 1947-48 GDZ4801A-B ................. : ........ AL VRP4501A 17320

1106751.757 ...... r ..................... DR 1106752-758 .......................... ..DR 1102670-716 ................. : .......... DR 11 05877 ................................ DR 1 105909 .................................. DR 1106801 .................. i ............. DR 1106801-821 ............................ DR

.......... ...................... 1102746 : DR 1106757 Opt . Hvy . Dut]i ...... DR

.......................... 1 106757-758 DR .................... 1955 . GGW6001-12-16 AL VBE6201A

1956-57 GHM6003-04-07 ...................... AL VRX6201A ........ 1956-57 GJC7001-02-03-06-11-12 AL VRX6201A


For Negative Ground and Special Equipment see Dodge Truck . .................... 1954-56 1106821-~2&919 DR 11 18886

.................... 195456 1106757-763-778 DR 1 1 18832 ......... . 195456 1106758 Std 45 Amp DR 11 18834 PONTIAC

1936 935W ............................ .. .... DR 5557 1937-38 1100003 .................................. DR 5835

......... . 1954-56 1106758 Opt 55 Amp DR 11 18854 1955 GD14841 S~ec ia l .................... AL VRH4 102A

............... . 1956 GDJ4846 Pow Steer AL VRH4102B STUDEBAICER PASSENGER CAR-

............ . 1935-37 GAR4609 GCM4802 AL TC4302A 1938 1102653 ............................... ... DR 5818

. . .

1955 1100304 Std .......................... DR 1118945 18945 1955 1102018 ................................. DR 1118826 18825 1955 1102027-031-039 .................... DR 11 18967 18956

GDZ6001 ................................ AL .................................. 1102700 DR

........................ 1102778 Std ... DR ................................ 1105892 DR ............................... 1105893 DR .............................. GGW4801 AL ........................... 1102778 Std DR ........................... 1102778 Std DR

.................................. GJC7002 AL ........................... 1102003 Std DR

. . ~~ ....... . -~

1956 1106981 ................................. .D R 1119004 19004 1956-57 1100304 Std ............................ DR 11 19000 19000

YEAR GENERATOR System REGULATOR NO . NO . OUR

CODE NO . YEAR GENERATOR System REGULATOR OUR NO . NO . CODENO .

WHITE (Cont.) 1946-48 1105877. 1106586 .................. DR 11 18212 18212

.................................. 1946-48 1106751 DR 11 18275 18244 1947-49 GGJ4801-03 ............................ AL VAV4001A 17370

.................................. 1948 1106801 DR 11 18338 18337 ............................ 1948-50 1106752-758 DR 11 18344 18725

.................................. 1948-51 1105909 DR 11 18316 18316 1949 GGJ4803 .................................. AL VBA4001A 17370

.................................. 1949-50 1105912 DR 1118304 18304 1949-50 1106751-757 Shock Mtg ......... DR 11 18335 18333 1949-50 1106801-821 Shock Mtg ......... DR 11 18338 18337

.................................. 1949-51 1105877 DR 11 18314 18314 ............................ 1949-51 1106751-757 DR 11 18333 18333

1949-53 1 102670-716-739 .................... DR 11 18303 18303

STUDEBAKER TRUCK- 1936-37 GAR4609 . GCM4802 ............ AL TC4302A

GCE48 14 ................................ AL GCS4805 ................................ AL GEB4821 .................................. AL 960D. 960E ........! ..................... DR 1 102402 .... 1: ........................... DR GDA4804 ................................ AL 916H ...................................... DR 9161 .......................................... DR 1106628 .................................. DR GDZ4804-05 ............................ AL GEB4803.06. GEB6001 .......... AL GGJ4804 .................................. AL 1102728 .................................. DR 1105891 Opt .......................... DR GDZ6001 ................................ AL

1105936 .................................. DR 11 18328 1102739 .................................. DR 11 18303 1105895 .................................. DR 11 18854 1105896 Opt ......................... DR 1118830 1102788 .................................. DR 11 18828

1951 1102753 .................................. DR 11 18392 .............................. 1951 GDZ6001A AL VRP6005A

1951-53 1105892 Opt ........................... DR 11 18394

.............................. 1952-55 GGW4801 AL ~ ~ ~ 6 1 0 1 A ............................ 1954-55 1102778-787 DR 11 18828

1954-55 1105007-014 Opt ................... DR 11 18858

1106805-822-909 Cummins .... DR 11 18838 1106821 . White Ena ............... DR 11 18886 1106805 ~reightlinir ............ DR 11 18880 1105895 .................................. DR 11 18858 1106822. White Enq: .............. DR 11 18939

WHITE 1937-39 916K. 934H. 934W ................ DR 5597 1937-40 614. 962 .................................. DR 5577 1937-40 978A ........................................ DR 5584 i938-39 511. 519 .................................. DR 5531 1938-39 518 ........................................ D 5612 1938-39 916B ........................................ DR 5806 1938-39 934X. 1105732 ...................... DR 5598 1938-39 1106630 .................................. DR 5841 1038-40 615 . 630 .................................. DR 5526

WILLYS CARS & TRUCKS 1938-41 GCS4809 ................................ AL TC4317A 17401 1939-42 GCJ4811 .................................. AL VRR4004A 17333

.............. 1945-56 GDZ4817. GDZ6001 AL VRP4007C 17319 1950-56 GDZ600 1 ................................ AL VRP6003A 17319

........................ 1953 GGU6011 Taxi AL VBA4206A 17371 1953-57 GGW4801 .............................. AL VBE6105A 17301

SPECIAL EQUIPMENT 1942-45 GEG5001.02. 5101 WW2 ...... AL VRY4203A-B 17373 1942-45 GEG5001.02. 5101 WW2 ...... AL VRY4203E-G 17373 1942-45 GDJ4804 WW2 ........................ AL VRH4104B-E 17260 1942-45 GFZ4801 WW2 ...................... AL VA04001AM 17291

REGULATOR . YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . ADAMS 1938-40 1100453 ................................... DR 5844 18203

.................................. 1938.40 1101707 DR 5843 17958

.................................. 1939-40 1105734 DR 5806 17942 . 1940-42 1101707 .................................. DR 1118228 18228 1940-48 1102674 .................................. DR 11 18207 18207 1940-48 1102955 .................................. DR 11 18209 18209 1942-46 1102955 ................................. DR 1118210 18210

.................................. 1947-48 1105909 DR 1118252 18252 ................. 1949 1102955 ................ 1 DR 1118312 18209

....................... 1949-53 1105909 ......... i DR 11 18317 18945 .......... 1949-53 1102674. 1102714-737 DR 11 1831 1 18301

................................. 1950-53 1102976 DR 11 18355 18355 1953 1105936 .................................. DR 1118329 18945 1953-56 1106855 .................................. DR 11 18737 18737

.................................. 1954-55 1102714 DR 1118869 18301 1954-55 1105936 .................................. DR 11 18895 18895 1954-56 1102976 .................................. DR 11 18902 18209

.................................. 1956 1 102820 DR 11 18827 18725 .................... 1956 1105105 ............ .r DR 1118956 18956

AHRENS-FOX 1946-48 1106638 ................................. DR 11 18214 18214 1949-53 1106638 .................................. DR 11 18316 18316 1952-55 1106828 .................................. DR 1118337 18337

ALLIS CHALMERS 1935-42 GAE4037. GAE4040 AL TC4303B 17280 .............. 1940 971 DR 5622 17926 ......................................... 1940-46 GFE4801 AL VAA4004 17381 .................................. 1940-47 1105830 DR 5888 17976 .................................. 1940-51 GEM4813 ................................ AL TC4327A 17402 1940-52 GAE4040A ............................ AL TC4303D 17280 1952-53 1105939 .................................. DR 1118761 18328 1954-55 1105939 .................................. DR 11 18893 18328

18791 1954-56 1100994 .................................. DR 11 18791 17962 1955-56 1101414 .................................. DR 5851

1955-56 1105976 .................................. DR 11 19177 19177 1955.56 1105976-83-88 ........................ DR 11 18793 l8793 1955-56 1106660 .................................. DR 11 18896 lE316 1956 1105976-79-82 ....................... DR 11 18793 18793

ACF-AMERICAN CAR & FOUNDRY 1936-38 534 DR 5526 .......................................... 17877 1938 631 DR 5579 .......................................... 17906 1938 961L DR 5840 ........................................ 17986 1938 1105735 DR 5806 .................................. 17942 1938-39 503, 100 Amp DR 5606 ......................... 17'19 1938-39 502 D 5571 .......................................... 1938-39 520, 1117521. 100 Amp DR 5606

17899 ......... 17'19

1938-39 11 17521. 80 Amp . .........-....... DR 5605 17918 1938-39 916E . 1105745 ........................ DR 5806 17942 1938-41 11 17504-523-524 .................... DR 5571 17899 1938-41 503. 11 17531 .......................... DR 5605 17918 1938-41 631 . 632. 956 ........................ DR 5579 17906 1938-42 1106639 .................................. DR 11 18214 18214 1940 11 17029 .................................. DR 5623 1940 1117521 DR 5605

17988 ..................................

1940-41 1117524 .................................. DR 5571 17'18 1940-41 956, 975 DR 5579 .................................. 1940-41 503. 1117531 DR 1118452 .......................... 1940-42 . 916E . 1105745 ........................ DR 11 18210 1941 956 . 975 .................................. DR 5634 1941 11 17521 ................................. DR 11 18452 1941 11 17524 DR 5636 .................................. 1941 1117526 .................................. DR 5620 1941-42 1117537 DR 5619 ................................. 1942-47 1105745 .................................. DR 11 18210 1945-47 1105911 .................................. DR 1118260 i:::: 1945-47 1117322 .................................. DR 1118512 18512 1945-48 11 17553. 80 Amp DR 11 18452 18452 ...................

-1945-53 11 17553. 120 Amp DR 5620 17924 ................. . 1948 1105911. 25 Amp ................... DR 1118285 18214 1948 11 17322, 55 Amp ................... DR 11 18538 18538 1948-53 11 17573 DR 11 18542 18542 ............................... 1949-51 1105911. 25 Amp ................... DR 1118318 18328 1949-51 1106805. 50 Amp ................... DR 1118368 18339 1949-51 11 17322. 55 Amp DR 1118538 18538 ...................

.................................. 1949-51 11 17322 DR 11 18547 18547

.................................. 1949-53 11 17603 DR 11 18408 18408

20

MISCELLANEOUS EQUIPMENT YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . AMERICAN LA FRANCE

............... 1938-39 1105731. 1105501 DR 5598 18210 .................................. 1938-40 1105401 DR 5596 17915 .................................. 1938-40 1105401 DR 11 18215 18215 .................................. 1938-41 1105502 DR 11 18220 18225 .................................. 1940-42 1102670 DR 11 18208 18208 .................................. 1940-45 1105731 DR 1118210 18210 .................................. 1940-48 1102953 DR ..1118210 18210 .................................. 1940-48 1105501 DR 11 18220 18225 .................................. 1948-56 11 17306 DR 11 18527 18527 .................................. 1949-53 1105501 DR 1118322 18225 .................................. 1949-53 1 102953 DR 1 1 18304 18304

i949-53 1102985 ................................. DR 11 18354 18304 .................................. 1954-56 1102985 DR 11 18901 18304 .................................. 1954-56 1105501 DR 11 18907 18225

........................... 1955-56 11 17103 A.C DR 11 18879 18879 .................................. 1956 1106821 DR 11 18886 18337

. . . . . . 1956 1106822-26 . DR 1118838 18339

AUBURN MACHINE WORKS 1948-49 GDZ4817 .................. AL VRP4007C 17319

...................... 1950 GDZ6001 AL VRP6003A 17319

AUSTIN WESTERN CO . (Western Austin)- 1938-39 9751 . . . . . . . . . . . . . . . . . . . DR 5535 17883 1938-42 1105326 .................................. DR 5583 17907

.................................. 1938-42 1106302 DR 5834 17952 1938-46 934M .............. - ........................ D 11 18221 1940 1102417 DR 5800

18221 ..................................

1940-42 1101743 DR 5849 17939

.................................. 1940-48 1102955 DR 11 18209

17960 ...........*......................

1940-53 1101726 DR 5884 18209

................................ 17974 1941-45 1105532 .................................. DR 11 18221 18221 1941-48 1 102673 DR 1 1 18207 ................................ 18207 1944-48 I102688 .................................. DR 11 18240 18240 1944-48 1105881 ................................. DR 11 18272 18207 1947-48 1101722 .................................. DR 5849 17960 1947-48 1101738 .................................. DR 5838 17954 1948 1102968 .................................. DR 1118210 18210 1948-50 1101747 DR 1118260 .................................. 18214 1948-50 1105909 .................................. DR 1118317 18945 1949 1102688 ................................. DR 1118324 18324 1949-50 1101369 .................................. 3R 5839 17955

............................ 1949-50 1 102673-713 DR 1 1 1831 1 18301 .................................. 1949-50 1106857 DR 11 18540 18540

1949-52 1102955 ................................. DR 11 18312 18209 1949-52 1102976 .................................. DR 11 18354 18304 1949-52 1102976-78 .............................. DR 1118355 18355

.................................. 1949-52 1101737 DR 5838 17954 1949-52 1102968 ................................. DR 1118304 18304

.................................. 1949-52 1102985 DR 11 18362 18304 1955 1102005 ............................. DR 1118839 18328

AUTOCAR TRACTORS ....................... 1949-53 1106801 DR 11 18338 18337 ............................... 1949-53 1106821 DR 1118337 18337

AVAILABLE TRUCK 1938 934C. 934U. 934Y .................. DR 5597 18202 1938 '934D DR 5598 18210 ........................................

...................................... 1938 936B DR 5542 17887 1938 968B ........................................ DR 5586 17910 1938 1117001 DR 5604 17917 .................................. 1938-39 1 106627-632 ............................ DR 5841 17956 1938-40 1106577 DR 5852 17963 .................................. 1939 934D ........................................ DR 5806 17942 1939-40 934C . 934U . 934Y DR 5828 17949 .................. . . .................. 1939-43 934C 934U 934Y DR 11 18230 18230 1939-43 934D . 934J .............................. DR 1118210 18210 1939-45 1102674-75-76 ........................ DR 1 118208 18208

.................................. 1939-45 1106577 DR 11 18222 18202 1939-45 1106627-632 ............................ DR 1118214 18214

.......................................... 1940 974 DR 5579 17906

.......................................... 1940-42 974 DR 5634 17930 1940-42 11 17001 .................................. DR 5637 17917

.................................. 1941-42 11 17526 DR 5620 17924 ........................................ 1944-47 934D DR 1118210 18210

1945-48 934c. 934U . . . . DR 1118230 18230

See Next Page

-. .


AVAILABLE TRUCK (Cont.1- 1945-52 1101744 .................................. DR 1118227 18227 1946-47 1106638 .................................. DR 11 18214 18214

AVERY FARM MACHINERY CO . 1943-45 GAS4165 ................................ AL TC4305E 17401

BAKER ICE MACHINE CO . 1939-40 1106631-35 ............................. DR 1118214 18214

BAKER LULL (Travel Loader) 1953 GGA 6001E ............................ AL VAT4001A 17252

BAKER-RAULING 1954-56 1102731 .................................. DR 1118314 18314 1954-56 1102731 .................................. DR 11 18842 18314

BARBER GREENE 1938 934T ....................................... DR 5801 17940 1941-42 1101677 ................................ DR 5839 17955

BAY CITY SHOVELS . CRANES-----------------

BEAN (Sprayer) 1950-54 GAS4301 ................................ AL TC4326A 17402 1950-54 GAS4301 ................................ AL TC4329C 17402

JOHN BEAN 1948-50 GFA4818 ................................ AL TC4326A 17402

BEAVER METROPOLITAN COACH 1938-42 692 .......................................... DR 5574 17902 1938-42 692 ......................................... DR 11 18453 18453 1939-41 1 1 17026 .................................. DR 5604 17917 1941-44 977 . 986 ................................. DR 5634 17930 1945-50 977 .......................................... DR 1118512 18512 1949.50. 11 17378. 80 Amps ................. DR 11 18520 18520 1950-55 977 ......................................... DR 11 18597 18597

C . D . BECK CO . 1938-40 1106628 .................................. DR 5842 17957 1939-40 1105531 .................................. DR 5819 . 17945 1939-42 1106628 .................................. DR 1118219 18252

BIEDERMAN TRUCK 1938 9341 ........................................ DR 5801 17940

........................................ 1940-42 934C DR 11 18210 18210 .................................. 1945 GDJ4833 AL VRH4104F 17260 ................................ 1946-47 GEG4822 AL VRP4004E 17330 ................................ 1946-47 GEG4833 AL VRP4004E 17330

1947-49 GEG4822 ................................ AL VRP4004F 17320 1948-49 GDJ4838 .................................. AL VRH4102B 17260 1949 GEG4822 ................................ AL VRP6001A 17320


BROCKWAY TRACTOR 1949-51 GGE4806 ................................ AL VRWSOOSBX 17352

BROCKWAY TRUCKS

GDJ4822-29 ............................ AL GCH4612.13. 50 Amps ........... AL GDJ4833 .................................. AL GDJ4836 .................................. AL GEG48 11 ................................ AL GEB600 1 ................................ AL GDJ4844 .................................. AL GGU6001 ................................ AL

BROWJV EQUIPMENT MFG . CO . 1940-41 691 .......................................... DR 5604 17917

BUCYRUS ERIE CO .

BUFFALO FIRE APPLIANC- 1939-41 934T ........................................ R 5598 18210 1939-47 9341 ........................................ DR 1118210 18210 1942-48 1106629 .................................. DR 1118214 18214 1944-47 1105914 .................................. DR 1118273 18210

BUFFALO SPRAYER 1950-53 GAS4301 ................................ AL TC4329C 17402

BUFFALO SPRINGFIELD ROLLER CO . 1941-43 1101353 .................................. DR 5540 17885 1941-45 1101372 .................................. DR 5851 17962 1941-45 934V ........................................ DR 1118210 18210 1941-46 1101667 .................................. DR 5839 17955 1942-51 1101726 .................................. DR 5884 17974 1946-47 1 101381-92 .............................. DR 5851 17962 1946-47 GFA4810 ................................ AL TC4305B 17401

BURRO CRANE .......................... 1940-45 GCM4805-10 AL TC4302A 17401

1943-50 GE04810-13-15 AL TC4302A . ...................... 17401 1946-48 GFA4807 ................................ AL TC4302A 17401

BYERS (Cranes . Shovels)- 1946 GFA48 10 ................................ AL TC4305B 1740 1

. MISCELLANEOUS EQUIPMENT YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . CARRIER CORP . 1940-41 GDM4804 ................................ AL VRX4002A 17103 1940-41 GEH4805 ................................ AL VRS4009A 17267 1952-54 GGA6001 ................................ AL VAT6001A 17252

CASE TRACTORS & I M P L E M E N T S - - - - - - - - - - - - - 1938-39 GAG4145 ................................ AL TC4302C 17401 1939-40 GAG4145 ................................ AL TC4305B 17401 1940-41 GBM4808-09 .......................... AL TC4305C-E 17401 1940-49 GBM4809B ............................ AL TC4324A 17401

1951-53 GHD6001E .............................. AL VRR4102A 17338 1951-54 GHD6001C .............................. AL VRR4101A 17333 1952-56 GAS4301.4303 ........................ AL TC4329C 17402 1953-55 GHD6001Z .............................. AL VRR4103A 17338 1953-57 GHH600 1 E-J .......................... AL VRT4104A 17273 1955-57 GHH6002A-B .......................... AL VRT4105A 17278

CATERPILLAR

CENTAUR TRACTOR 1940-47 GAS4143 ................................ AL TC4305A 17401 1947-52 GAS4143 ................................ AL TC4301C 17401

CENTRAL FIRE TRUCK CORP . 1941 934T ........................................ DR 1118210 18210 1941 1106629 .................................. DR 1118214 18214

CHECKER CAB TAXI 1940-41 GEB4806 ................................ AL VRP4004C 17322

3 1947-49 GEG6001 ................................ AL VRP4401C 17330 1948 : GGT6001 .................................. AL VAV4002A 17370

CHICAGO PNEUMATIC (Compressors).........


CLARK EQUIPMENT CO .

CLARKTOR

CLETRAC (See Oliver) 1941-47 GAS4165-81-88 ...................... AL TC4305E 17401 1945 GGM4801 ................................ AL VAA4lOl 17384

CLEVELAND TRACTOR-CLETRAC ~

1938-41 1101662-669 ............................ DR 5839 17955 1938-41 1101712-713 .......................... DR 5838 17954 1938-41 1102515 .................................. DR 5838 17954

CLEVELAND TRENCHER 1940 GBU4214 ................................ AL TC4301B 17401 1940-48 GCM48 10 ................................ AL TC4302A 17401 1940-48 GFA4808 ................................ AL TC4323B 17402

CLINE TRUCK 1954-56 1105939 .................................. DR 1118893 18328

CLYDESDALE

1938 1106626 .................................. DR 5814 18203 1938 1106627 .................................. DR 5801 17940 1938 1106627 .................................. DR 5841 17956

COCKSHUTT

COLEMAN 1938-40 934M ........................................ DR 1938-42 934M ........................................ DR 1945 934N ........................................ DR 1946-47 992 .......................................... DR 1946-47 1106639 .................................. DR 1948 1106803 .................................. DR 1949 1106803 .................................. DR

CO-OP

REGULATOR . MISCELLANEOUS EQUIPMENT YEAR GENERATOR

NO . System REGULATOR OUR NO . CODENO .

CORBITT 1938-39 916E. 934R. 934T .................... DR 5598 18210 1938-39 934N . 1105734 ...................... DR 5598 18210 1938-39 950 ......................................... DR 5530 17879 1938-39 960A ........................................ DR 5820 18204 1938-40 9771 ......................................... DR 5538 17884

1947-49 11 17320 .................................. DR 1118512 18512 1949 1105912 .................................. DR 1118354 18304 1949 1105913 ................................. DR 1118316 18316

CRANE CARRIER 1955 1102785 .................................. DR 1118828 18730 1956 1102005 ................................. DH 1118839 18328

CROWN BODY 6 COACH 1941-44 GDM4803-06-07 ...................... AL VRX4001A 17102 1944-48 GDJ4811 .................................. AL VRH4lOlA 17260 1946-48 GDJ4822 .................................. AL VRH4102A 17260

CUSTOM TRACTOR ................................ 1948-49 GDZ4823 AL VRP4302AM 17326

1949-51 GDZ4822 ................................ AL VRW400 1BX 17352 ................................ 195 1-53 GHB480 1 AL VRP6004B 17316

DART TRUCK 1937-38 9758 ........................................ DR 5538 17884 1937-38 9751 ....................................... DR 5535 17883 1938-39 934T ........................................ DR 5598 18210 1938-40 9348 ........................................ DR 5597 18202 193840 1106578 ................................ DR 5852 17963 1938-44 934T, 1105742 ...................... DR 1118210 18210 1938-45 9346 ........................................ DR 11 18230 18230 1938-45 1106578 .................................. DR 11 18222 18202 1939-40 916D DR 5820 18204 1939-40 916D ........................................ DR 5597 18202 1939-44 1101736-744 ............................ DR 11 18227 18227 1939-45 916D, 934C, 960D ............... DR 11 18230 18230 1939-45 960A ........................................ DR 11 18204 18204 1939-47 1106629-638 ............................ DR 11 18214 18214 1940-45 1102404 .................................. DR 5540 17885 1941-42 11 17001 .................................. DR 5637 17917 194345 1106654 .................................. DR 11 18465 18465 1944-45 1106629-639-660 .................... DR 11 18214 18214 1944-48 934D , 934N ............................ DR 11 18210 18210


DAVEY COMPRESSOR .......................... 1940-50 GCM48 10-22 AL TC4302A 17401

1941 GAE4041 ................................ AL TC4303B 17280 ............................ 1944-56 GFA4808-34 AL TC4327E 17402

JOHN DEERE 1944 GBM4820 ................................ AL TC4327D 17402 1944-53 1101747 .................................. DR 5849 17960

............................ 1947-51 1101390-397 DR 1118305 18305

............................ 1947-53 1 100955-956 DR 11 18306 18306

DIVCO 1938-47 1102413 .................................. DR 5863 17965 1947-48 1105876 .................................. DR 11 18234 18230

DUPLEX TRUCK 1940-4 1 GEB4807 ................................ AL 1940-47 GDT4802 ................................ AL 1944 GBM4809 ................................ AL 1946-50 GEG4802-22 ............................ AL 1947-48 GDM4803 ................................ AL 1950-52 GEG4802.11 . GDT4802 ........ AL

ECONOMY TRACTOR ................................ 1949-51 GAS4177 AL

ELECTRO-MOTIVE 1941 1117510 .................................. DR 5617. 17987

ELGIN SWEEPERS ........................................ 1938-40 934V DR 5806 17942

.................................. 1939-41 1105532 DR 5828 17949 1939-44 1 105532 .................................. DR 11 18230 18230 1944-48 1102690 .................................. DR 1118208 18208 1949-53 1102720 .................................. DR 11 18303 18303

.................................. 1949-53 1105895 DR 11 18333 18333

.................................. 1949-54 1105877 DR 11 18314 18314 1955 1102793 .................................. DR 11 18828 18730

ELWELL PARKER HOIST 1943-47 GFA4812 ................................ AL TC4326A-B 17402

ESCO MOTOR CO . 1938 934M ........................................ DR 5599 17916 1946-47 1102670 .................................. DR 11 18208 18202

ESCO MOTOR CO . INDUSTRIAL TRUCK GEG4811 ................................ AL VRP4006F 17330

EUCLID ROAD MACHINERY 1938-40 1106451 .................................. DR 5829 17950 1941-43 1106455 .................................. DR 1118218 18218 1941-46 677. 11 17020 .......................... DR 5535 17883 1944-46 1106452 .................................. DR 11 18225 18225 1944-46 1106510 .................................. DR 11 18458 18458 1944-46 1106662 ................................. DR 11 18241 18241 1944-48 1106510-17-18 ........................ DR 11 18509 18509 1946 1117559 .................................. DR 1118519 18519 1946-48 1102971 .................................. DR 1118210 18210

See Next Page

YEAR GENERATOR System REGULATOR OUR NO . NO . CODENO . YEAR GENERATOR


FLXIBLE 1938-40 1105531 .................................. DR 5819 17945

EUCLID ROAD MACHINERY (Cont.1-

1106451 .................................. DR 11 18321 18321 1106851 ................................. DR 1118346 18346 1106855-56 .............................. DR 1118346 18346 1106867 ..................... ! ............ DR 1118346 18346

1 1106856-67 .......... ................... DR 1118737 18737 1106758-64-69 Liahts ............ DR 1 118366 18726

I954 1102983 .................................. DR 11 18903 18304 1954 1106892 .................................. DR 11 18737 18737 1954-56 1106758-64-69 Lights ............ DR 1118834 18726

1951-56 1117328 .................................. DR 1118597 18597 1953 1117100 A.C. .......................... DR 1118638 18638 1954 1117100 A.C. ........................ DR 1118662 18662 .. 1@5-56 955 Lights .............................. DR 11 18597 18597

' A ' 1955-56 1102023 .................................. DR 1118896 18328 ' 1955-56 1102024 .................................. DR 1118955 18316 FOOTE CO . (Paver)

1940 GEB4824 .................................. AL VRW4004A 17352 1946 GFA4807 ................................ AL TC4302A 17401

FORD BUS 1939-48 19B-10505A .............................. F 17054 1948-56 8MB-10505 ................................ F 17056

EVANS SPRAYER 1950-55 GAS4301-02-03 ...................... AL TC4329C 17402

FORD TRACTORS 6, INDUSTRIAG------------ . .................... 7HNN Industrial F 17052

.................... . 1948-50 Tractor Series A* F '17034 ........................................ 1950-52 Tractor F 17036

1952-56 Tractor ........................................ F 17038 'Series A

NOTE: On EN Ford Tractor Regulators it is important to check the replacement regulator with the old unit to make certain the position of the sequence B.F.A. terminals have the same sequence . Units with sequence A.F.B. terminals are not interchangeable with those having the sequence B.F.A. terminals .

FAIRMONT 1941-42 934U ....................................... DR 11 18230 18230 1949-53 1105004 .................................. DR 11 18394 18394 1954-56 1105004 .................................. DR 11 18858 18854

FARMASTER 1950-51 GFW4814 ................................ AL TC4303D 17280 1950-51 GE04816 ................................ AL TC4327E 17402

FATE ROOT HEATH (See Silver King)............ .................................. 1942 1100012 DR 11 18204 18204 .................................. 1942 1102962 DR 1118210 18210

1944-48 9341 ........................................ DR 1118210 18210 .................................. 1944-48 1105914 DR 11 18273 18210

1944148 . 1105915 .................................. DR 11 18260 18214 .................................. 1945-46 1101750 DR 1118227 18227 .................................. 1949-53 1105914 DR 11 18354 18304

FOUR WHEEL DRIVE . FWD 1938 9341 ....................................... DR 5806 17942 1938 1106629 .................................. DR 5841 17956 1938-39 1106582 .................................. DR 5885 17975 1938-40 550, 11 17002-018 .................. DR 5535 17883 1938-40 977J ......................................... DR 5538 17884 1938-41 934C 934U ............................ DR 5828 17949 1938-41 934D . 934J .............................. DR 5806 17942 1938-41 1106577 .................................. DR 5852 17963 1938-41 1106577 ................................. DR 11 18222 18202 1938-41 1106627-629 ............................ DR 5841 17956

............................ 1938-42 934C , 934U DR 11 18230 18230 1938-42 1106582 .................................. DR 11 18212 18202 1938-42 1106627-629 ............................ DR 11 18214 18214

.............................. 1938-43 934D, 934J DR 11 18210 18210 1940-4 1 GEG48 13 ................................ AL VRP4006F 17330 1941 9341 ........................................ DR 1118210 18210

......................................... 1942 974 DR 5634 17930 ............................ 1942 1101736-744 DR 11 18227 18227

FERGUSON (See Massey Harris'

FITZJOHN COACH CO .

FREIGHTLINER (See White)-

FRIDAY 1950-51 GDZ4822 ................................ AL VRW4001BX 17352

REGULATOR . MISCEL . YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . YEAR GENERATOR NO . System REGULATOR OUR

NO . CODENO . I . - -

FRIEND (Sprayer) I HAHN TRUCKS 1938 9341 ........................................ DR 5598 18210

GALION 1

HANSON (Shovel. Crane)- ............................... 1941-42 GE04803 AL TC4305B 17401

1945-46 GFA4806 ................................ AL TC4305A 17401 ................................ 1948 GFA4806 AL TC4301C 17401

HARDIE (Sprayer) ................................ 1952-54 GAS4301 AL TC4329C 17402

HARLEY DAVIDSON 1943-48 Police ...................................... DR 1 1 18224 18224 1948 Police ...................................... DR 11 18283 18283

HARNISCHFEGER (P 6 H EXCAVATOR)

GAMBLE FARMCREST 1951-54 GHD6001F .............................. AL VRR4102A 17338 1954-57 GHD6001Q-Y .......................... AL VRR4103A 17338

HARRIS (Harvesters. Tractors) GARDNER-DENVER 1939 934N ........................................ DR 5806 17942 1941 1105750 .................................. DR 1118210 18210 1946-56 GFW4806 .............................. AL TC4303D 17280 HENDRICKSON

1937-40 9751 . 9771 ................................ DR 5538 17884 GENERAL AMERICAN AEROCOACH CO . 1940 11 17004 .................................. DR 5604 17917

1945-50 1117560. 80 Amps ................... DR 11 18452 18452 1945-50 11 17560. 120 Amps ................. DR 5620 17924 1951-52 1117388 .................................. DR 1118583 18583 1 GENERAL EXCAVATOR 1

HOBART ELECTRIC WELDER 1940-44 GDZ4801 ................................ AL VRP4001A 17320 1944 GDZ801 Neg . Grd ............... AL VRP4005A 17319 1946-51 GDZ4801 ................................ AL VRP4001AX 17320 1947-48 GFL4811 ................................ AL VRV4 103A 17293

GENERAL FIRE TRUCK 1938-40 9341 ........................................ DR 5806 17942 1938-40 440 .......................................... DR 5535 17883

GENERAL TRACTOR 1940-44 GAS4165-81 ............................ AL TC4305E 17401 I HOUGH TRACTOR SHOVE'

GIBSON MFG . CO . TRACTORS--- - - - - - - - - - - - - - 1949-50 1101851 .................................. DR 5908 17982 1949-50 1101392 .................................. DR 5851 17962 I GLEANER HARVESTER CORP . I

HOWELL (Material Handling)- 1941-45 1102667 .................................. DR 1118201 18201

I= 7- *

REGULATOR . MISCELL YEAR GENERATOR

NO . System REGULATOR OUR NO . CODENO . I

HUBER COMBINE---- - - - - - - - 1942-43 GFA4806 ................................ AL

HUBER-WARCO 1941-43 1106584 .................................. DR 1950-52 1101392 1101417 .................. DR 1950-52 1101679 .................................. DR 1952-53 1102978 ..... ............................ DR 1952-53 1 105912-14 .................... 4 ......... DR 1952-53 1106812 ................ s. ............... DR 1952-54 1106822 ...........,..... , ................ DR 1952-55 . 1102720 .................................. DR

HUG 1947-48 GGA4812 ................................ Ai VAT4001A 17252

HYSTER 1932-4 1 GEB4810 ................................ AL VRP4006E 17322 1944-48 GAS4 179 ................................ AL TC4329B 17402 I INGERSOLL-RAND 1941-43 1101381 .................................. DR 5851 17962 1941-48 1101382 .................................. DR 5893 17979 1941-53 1101751 .................................. DR 5849 17960 1944-53 9391 .............. ; ......................... DR 5869 17967 1946-53 1101726 ................................. DR 5884 17974 1949-53 1105922 .... ; ............................. DR 11 18365 18225 1954-56 1102983 .................................. DR 1118903 18304 1955-56 1102024 ......... : ........................ DR 11 18955 18316 1956 1106867 .................................. DR 11 18346 18346

INSLEY MFG . CO . (Excavators\- 1938-40 934V ........................................ D 1118210 18210 1941-42 1102955 ................ 2 ................ DR 1118210 18210 1941-48 1102692 .................................. DR 11 18208 18208 1946-47 1105912 .................................. DR 11 18273 18210 1946-48 GFA4806 ................................ AL TC4305A 17401 1949 1105912 .................................. DR 1118354 18304 1949-56 1102692, 1102722 .................. DR 11 18303 18303

INTERCONTINENTAL TRACTOR: 1948-51 GGE4806 ................................ AL VRW5005BX 1949-51 GFW4814 ................................ AL TC4303D

INTERNATIONAL POWER UNITS and SOME TRACTOR-

1938-39 1101358 .................................. DR 5868 1938-40 1101732 .................................. DR 5849 1938-40 1105378 .................................. DR 5884 1938-40 1105728 .................................. DR 5806 1940-52 1101726. 1100972 .................. DR 5884 1944-48 1101369 .................................. DR 5839 1944r51 1105379 .................................. DR 5849 1944-52 1101737 . 1100971 .................. DR 5838

P@%

ANEOUS EQUIPMENT . 1 YEAR GENERATOR


1955-56 Negative Ground .................. DR 11 19001 1956 1105106-109 ............................ DR 1119153 19153

INTERNATIONAL TRACTORS (See McConnick deer in^)^ 4

... ...

.................................. 1106822 DR 1118838 18339 i 1 106855 .................................. DR 11 18346 18346 d( ' 1106895-898 .................. ........ DR 11 18796 18796 1106910 Shock Mnte ............. DR 1119135 19135 i/r Couplins Drive ...................... DR 11 18975 18975 W

JAEGER (Mixers . Compressors!- I 1 1945-47 GBM4802 ............................... AL TC4329A 17402 1 1945-55 GBM4802 .............................. AL TC4327E 17402 '

1949-55 GEH4821 ................................ AL VRX4003D 17106 1954-55 GHD6001Q ....................... AL VRR4103A 17338 = JAMES (Plows. Cultivators- a 1948-49 GDZ4817 ............................. AL VRP4007C 173 19 a JUMBO (Tractors) W 1948-49 GDZ4823 ................................ AL VRP4302AM 17326 u 1949-51 GDZ4822 ................................ AL VRW4001BX 17352 1951-55 GHB4801 ................................ AL VRP6004B 17316

KENWORTH 1938-39 504 .......................................... DR 5605 17918 W a 1938-40 405. 613 .. 639 ........................ DR 5526 17877 ELI 1938-40 934A . 934M . 934S: ............... DR 5597 18202 W 193&43 527. 534. 538 .......................... DR 5526 17877 a 1938-43 568. 677 . 11 17020 ................ DR 5535 17883 1938-43 634. 637 .................................. DR 5526 1938-43 9348 . 934N, 934T .................... DR . 5598 17877 18210 x 1938-48 934N . 934T ............................ DR 11 18210 18210 1940 934M ........................................ DR 11 18230 18230 1940-47 1117520 .................................. DR 5619 1944-47 538 ............. - R 5649 17938 01 17923 !

.......................... 1945448 1.102957 .................................. DR 1118210 18210 1945-48 1105917 .................................. DR 1118273 18210 1946-48 11 17376 .................................. DR 11 18520 18520 1946-48 11 17565 .................................. DR 5620 17924 1947 GDJ4820 .................................. AL VRH4 104F 17260

................ 1949-53 1 102984. 1 105917 DR 1 1 18354 18304 . .................. 1954 1102984 1105917 DR 1118901 18304

KNUCKEY ........................................ 1941 934T DR 1118210 18210

KOEHRING 1938-41 GCM4804.05. GAR4613-36 .... AL TC4302A 17401 1938-41 GCW4806 .............................. AL VRS4005B 17272 1938-41 GDB4805 ................................ AL TC4310A 17280 1938-43 GDB4813-15-16 ...................... AL TC4303D 17280 1940 GAG4145 ................................ AL TC4305B 17401 1940-41 GEB4813 .................................. AL VRP4006E 17322

.......................... 1942-48 GCM4804-05 AL TC4302A 17401 ................................ 1947 GE04815 AL TC4302A 17401

REGULATOR . MISCELLANEOUS EQUIPMENT YEAR GENERATOR


KOHLER POWER UNIT 1954-56 1101856 ................................. DR 1118780 18780

LA PLANTE CHOATE .............. 1950-51 GEB4812. GEG4829 AL VRP4004C 17322

LE TOURNEAU 1943-45 677 .......................................... DR 5535 17883

................................ 1946 GGF4803 AL VRV4003A 17292 1946-47 1105914 ............ ,. .... 2 .............. DR 11 18273 18210 1946-48 GFR4806-07-P8 ...................... AL VAD4 109A 17290 1946-48 1117561 ................................... DR 1118519 18519 1947 1106517 .................................. DR 11 18509 18509 1947-48 . 1106805 .................................. DR 1118279 18279 1948-50 1106517 .................................. DR 1118526 18526

LEWIS SHEPARD ................................ 1946 GAS4179 AL TC4329B 17402 ................................ 1946-47 GAS4186 AL TC4332A 17402

1946-48 GAS4179. GAS4301 .............. AL TC4329C 17402

LIMA 1941-47 11 17021 .................................. DR 5637 17917 1941-47 1106638 .................................. DR 1118214 18214

LINCOLN ELECTRIC (Welders\- 1938-39 934N ........................................ DR 5806 17942 1945-50 GBM4622 ................................ AL TC4327E-F 17402

LINK BELT (Shovels. C r a n e s ) - 1944-45 934C ........................................ DR 11 18230 18230

................................ 1944-47 GFA4806 AL TC4305A 17401 1947-51 GFA4806 ................................ AL TC4301C 17401

LINN TRACTORS 1938-44 GDB4805. GCU4801 .............. AL TC43 10A 17280

................................ 1946-50 GEG4807 AL VRP4006F 17330

LOVE TRACTORS

MAC DONALD 1938-39 613 .......................................... DR 5526 17877 1941-42 1100469 .................................. DR 1118204 18204

MACK TRACTORS

MACK JR . TRUCK 1937-38 GCE48 12 ................................ AL VRX4002B 17107 1937-38 GCS4804 ................................ AL TC4302A 17401 1937-38 GCJ4805 .................................. AL VRD4004A 17355 1946 GEH4819 ................................ AL VRX4003D 17106 1946 GEH4819 Neg . Grd ................. AL VRX4002B 17107

MADSEN BUS 1954-56 1106822 .................................. DR 1118838 18339

MANITOWOC (Crane Shovel)- ................................ 1941-42 GCM4823 AL TC4302A 17401

1942-46 GFJ4802-03 ............................ AL VRS4004A 17272 ................................ 1944-46 GCR4802 AL VRS4005A 17272 ................................ 1947-48 GEH5001 AL VRG4102D 17256


MARMON HERRINGTON ... 1937-40 568 ................... DR 5573

1937-41 530 .......................... DR 5530 1937-42 973E ........................................ DR 5538 1937-42 9736 ........................................ DR 5535 1938-41 9341 ........................................ DR 5598 1939-40 927X ....................................... DR 5536 1941-42 469 .......................................... R 1 1 18453 1941-42 530 .......................................... DR 11 18456 1941-42 9341 ......................... ,.,, .......... DR 1118210 1941-42 1106639 ................................ DR I1 18214 1945-46 GEG5101 ................................ qL ' ~ ~ ~ 4 2 0 3 ~ 1945-48 1105875 .................................. DR 11 18212 1945-48 1106629 ................................. RR 1118214 1946-48 1105876 .................................. DA 11 18234 1949 1105875 .................................. DR 1118314

1954-56 1106823 ............................... DR 11 18838

MASSEY-HARRIS 1941 GBM4901 ............................... AL TC4327A 1946-51 GGP4801 ................................ AL VRWSOOSB-BX 1948-50 GDZ4820-23 ............................ AL VRP4302AM 1948-51 GEF4813 .................................. AL VRS520 1 A-AX 1949 GGW6001A ............................ AL VRP4503B 1949-50 GDZ4822 ................................ AL VRW4001BX

MAXIM (Fire Apparatus-

1949-5 1 GGA48 16 .............................. AL VRX4003A 17104 1949-52 GGA6001B .............................. AL VAT4001A 17252

McCORMICK DEERING .................. 1942-51 1101381. 1101419 DR 5851 17962

.................................. 1948-51 1101383 DR 5839 17955 1950-55 1 100501 .................................. DR 1 1 18308 18308

.................................. 1952-53 1100964 DR !I18381 18381 ............................ 1952-56 1100501-531 DR 1118780 18780

.................... 1954-56 1100964-990-996 DR 11 18779 18779

MERCER 1951-53 GE04816 ................................ AL TC4327E 17402 1951-53 GFW4814 ................................ AL TC4303D 17280

MERCURY TRACTORS .................................. 1949-53 1102726 DR 11 1831 1 18301

MICHIGAN (Shovels . Cranes)-

MINNEAPOLIS M O L I N P 1940-43 GAE4040 ............................... AL TC4303B 1944-49 GFW4804-07 .......................... AL TC4303D

.................. 1944-52 1101384. 1101416 DR 5894

.................. 1949-50 1101398 . 110050 5. JYR 11 18305 1950-53 GAS4301 ................................ AL TC4329C 1951-55 1100505-513-527 .................... DR 1118790 1953-56 1100954 .................................. DR 11 18791 1955-56 1100314 .................................. DR 1118791 1956 1100999 .................................. DR 1118791


NO . CODENO . MOBILIFT 1947-49 GDZ4804 ................................ AL VRP4004F 17320 1950-55 GDZ600 1 ................................ AL VRP600 1 A 17320

MYERS 195 1-54 GAS4301 ................................ AL TC4329C 17402

NATECO (Tractor) 1947-49 GGE4806 ............................... AL VRW5005B-BX 17352

NEW HOLLAND (Baler. ~kresterl- 1950-53 GAS4301 ................................ AL TC4329C 17402

NEW HOLLAND POWER UNIT 1942 1101752 .................................. DR 5891 17978 1952 1102505-518 ............................ DR 5838 17954

NEW IDEA (Hay Baler) 1952-53 GAS4301 ................................ AL* TC4329C 17402

NORTHWEST 1940-46 GCM4804 ................................ AL TC4302A 17401 1940-48 GDB4814 ................................ AL TC4310A 17280 1942 GCD4804 ................................ AL VRS4005C 17254 1942-46 GDW4602 .............................. AL VRV4003A 17292

OLNER 1940-42 1102683 .................................. DR 11 18208 18208

.......................................... 1944-45 677 DR 5535 17883 1944-48 934V ........................................ DR 11 18210 18210 1944-55 1102424 .................................. DR 5864 17982 1946-48 1101853 .................................. DR 5908 17982 1946-48 1102534 .................................. DR 5884 17974

OSHKOSH TRUCKS 1938-39 934D. 934T .............................. DR 5801 17940 1938-41 613 ........................................ D 5526 17877 1939 916D ........................................ D 5599 17916 1939 960A ........................................ DR 5822 18203 1939 960A ........................................ DR 11 18204 18204


NO . CODENO . PARSONS (Power Shovel\- 1947-48 GDB48 13 ................................ AL TC4303D 17280

PETER PIRSCH (Fie Apparatus)- 1940 GCM4805 ................................ AL TC4302A 17401

............ 1940-41 GCR4802. GCW4806 AL VRS4005A-B 17272 1941 1101736 .................................. DR 1118227 18227 1941-46 GEB4810-19 .......................... AL VRP4006E 17322 1941-48 GEB4819 ............................... AL VRP4004C 17322 1941-50 GCD4801-08-10 ..................... AL VRS4005C 17254

................................ 1948-53 GDJ4837 AL VRH4102A-B 17260

PETTIBONE NEW YORK (See Rome Grader)...... PULLMAN TROLLEY COACH 1941-42 11 17209 .................................. DR 5604 17917

1944-47 11 17204-209 ............................ DR 11 18507 18507 1947-48 1106807 .................................. DR 11 18277 18261 1949-51 1106807-825 ............................ DR 11 18338 18337

READY POWER 1938-41 934N ........................................ DR 5598 18210

194 1-54 GEM4102 ................................ AL TC4326A 17402 1942 934N ........................................ D 1118210 18210 1942-46 1101726-737 ............................ DR 5896 17981

REHBERGER BUS 1938 527 ......................................... DR 5526 17877

JOHN REINER & CO . 1940-42 1102955. 1105733 .................. DR 1118210 18210 1941 1106638 .................................. DR 1118214 . 18214 1941-43 1100012 .................................. DR 1118204 18204 1941-45 1101750 .................................. DR 1118227 . 18227 1941-45 1 101762 Insulated .................. DR 5898 17983 1942 1102956 .................................. DR 1118210 18210 1942 1105753 .................................. DR 5859 17933 1942-43 977E ........................................ DR 11 18458 18458

RIDDELL TRACTORS. GRADER- 1940-43 1101738 .................................. DR 5838 17954 1940-49 1101726 .................................. DR 5884 17974 1948 1102955-1102968 .................... DR 11 18304 18304 1949-52 977 ........................................ LDR 11 18597 18597 1949-52 1106822 ........................ : ........ DR 11 18368 18339 1949-53 1102976-78 .............................. DR 11 18354 18304 1954 1102983 .................................. DR 1118362 18304 1954 1 102983 .................................. DR 1 1 18903 18304

ROME (Pettibone New Yorkl- 1946-53 1102527 .................................. Dl? 11 18273 18210 1946-56 1 102534. 1 102538 .................. DR 5884 17874 1949-53 1105943 .................................. DR 11 18316 18316 1949-53 1106819 .................................. DR 1118338 18337 1954-56 1102024 .................................. DR 11 18955 18316 1954-56 1 102983 .............. : ................... DR 1 1 18903 18304 1954-56 1105943 .................................. DR 11 18896 18316

ROSS CARRIER CO . 1939-41 GCM4810-22 .......................... AL TC4302A 17401 1945-47 GEB4806-07-10 .... : ....-........... AL VRP4006E 17322 1946-56 GE04810-1 1 .......................... AL TC4302A 17401 1947-48 GAS4186 ................................ AL TC4332A 17402

................ 1949-56 GEB4807-10-6001D AL VRP4004G 17316 .......................... 1950-56 GEL3600 1D-H AL VRP4004C 17322

1951-54 GEG6001E ............................ :AL VBA6003A 17372 .............................. 1955-56 GEG6001E AL VBA6001B 17372

ST . LOUIS CAR CO . TROLLEY BUS- - - - - - - - - - - - - 1946-50 11 17209 .................................. DR 11 18507 18507 1948 1105911 .................................. DR 1118285 18214 1949-50 1106807-25 .............................. DR 11 18837 18945 1949-50 1106807-25 .............................. DR 11 18838 18339 1949-52 1105911 .................................. DR 1118318 18318 1951-52 1106805 .................................. DR 11 18740 18740

SANFORD FIRE EQUIPMENT 1941-44 1102961 .................................. DR 1118210 18210


SCHIELD-BANTAM CO . (Crane Carrier\- 1955-56 1105010 .................................. DR 1118831 18300

SCHRAMM 1940-41 1106535 .................................. DR 5608 17920 1944-48 1106660 .................................. DR 11 18214 18214 1944-49 1101737-38 .............................. DR 5838 17954 1948 1106517 .................................. DR 1118509 18509 1948-53 1102955 .................................. DR 11 18304 18304 1949-56 1106660 .................................. DR 1118316 18316 1950-53 110051 1 .................................. DR 5851 17962 1950-56 1 101723 ............,.... L .............. DR 1 1 18303 18303 1952-53 1102976 ................................. DR 11 18354 18304 1954-56 1102976 .................................. DR 11 18901 18304 1954-56 1106660 .................................. DR 11 18896 18316

SEAGRAVE . 1938-39 1105729 .................................. DR 5823 18209

SHEPPARD

SILVER KING (Fate-Root-Heath\- 1944-55 1101367. 1101421 ................ D R 5851 17962

SOUTHERN COACH MFG . CO . 1944-52 GDJ4809 .................................. AL VRH4 102A 17260 1947-51 1117307 .................................. DR 1118512 18512 1951-56 1117378 .................................. DR 1118583 18583

SPARTON COACH 1946-50 977 .......................................... DR 11 18512 18512

SPEED SPRAYER 1943-50 GFA48 18 ................................ AL TC4326A 17402 1944-46 GFW4815 ................................. AL . TC4331A 17280

STERLING TRUCK CO .


NO . CODENO . STEWART TRUCKS 1938 440 .......................................... DR 5535 17883 1938-39 1105529. 934U ........................ DR 5597 18202 1941 934C ........................................ DR 1-1 18230 18230 1941 1106590 ................................. DR 1118212 18212

STUTZ FIRE APPARATUS 1939-40 934T ........................................ DR 5806 17942 1939-40 934T ........................................ DR 1118210 18210

SULLIVAN (Compressors\- 1940-41 GCM4827 ................................ AL TC4302A 17401 1941-47 GFA4806 ................................ AL TC4305A 17401 1945-48 GE04816 ................................ AL TC4327E 17402

SUPERIOR COACH .......................................... 1941 568 DR 5535 17883

1941 637 .......................................... DR 5649 17938 1941 692 ......................................... DR 1118453 18453 1947 GDJ4808-32 ............................ AL VRH4104D 17260

TERRATRAC 1950-5 1 GFW48 14 .............................. AL TC4303D 17280 1950-55 GGE4806 ................................ AL VRW5005BX 17352

THEW 1939 1939-43 1939-45 1940-45 1940-46 1941-45 1942-45 1945-48 1946 1946 1946-48 1946-56 1947-48 1947-48 1948 1949 1949-50 1949-50 1949-50 1949-52 1949-53 1949-53 1950-5 1 1950-53 1952-56 1954-56 1954-56 1954-56 1955-56 1956 1956

' (Lorain) 1106638 .................................. DR 5841 1 1 17021 .................................. DR 5604 11 17021 .................................. DR 5637 1101675 DR 5869 1106638 .................................. DR 1118214 934T ........................................ DR 1118210 1106637 .................................. DR 11 18214

.............................. 1102690-97 DR 11 18234 .................................. 1102676 DR 11 18208 .................................. 1117021 DR 1118507

............................. 1 f02518-27 DR 5838 .................................. 1101667 DR 5839

1105914 ................................ DR 11 18274 .................................. 1105915 DR 11 18260 .................................. 1102973 DR 1118269 .................................. 1102973 DR 11 18342

TOR0 (Tractor) 1940-41 GBM4807 ............................ AL TC4302A 1740 1

TOWMOTOR 1940-51 GBU4216 ................................ AL TC4301B 17401

TRACTOMOTIVE 1948-50 GBM4802 ................................ AL TC4327E 17402 1952-53 GHD6001D .............................. AL VRR4102A 17338 1953-55 GHD6001H ............................ AL VRR4103A 17338

TRACT-R-LIFT 1948-50 GBM48 14 ................................ AL TC4302A 17401

TRANSIT BUS 1948-50 11 17378 .................................. DR 11 18520 18528 1951-52 1117378 .................................. DR 1118583 18583

REGULATOR . MISCELL ANEOUS EQUIPMENT YEAR GENERATOR System REGULATOR OUR

NO . NO . CODENO . TWIN COACH (See Flxiblel- 1938 465 . 624 . 638 ............................ DR 5526 17877 I

1945-51 11 17554. 120 ~ k p s ............. DR 5620 17924 ............... 1947 1117569. 1 2 0 A m p s D 1118531 18531

................... 1950-51 11 17554. 80 Amps D! 11 18520 18520

UNITED PARCEL SERVICE 1938 934F ........................................ D 5597 18202 1939 1106584 .................................. DR 5885 17975 1939-40 1105532 ................... .'.............. DR 5828 17949 1940 1106584 .................................. DR 1118212 18212 1946-48 1105865 .................................. DR 11 18212 18212

UNIVERSAL (Power Shovel!- 1941 GE04803-08 ........................... AL TC4305B 17401

USTRAC 1948-49 GGE4806 ................................ AL VRW5005B 17352

WALTER TRUCKS 1938-42 440. 550. 9751 ...................... DR 5535 17883 1938-42 975s .................................. DR 5538 17884 1940-48 1102676 .................................. DR 11 18208 18208 1940-48 1106627-629-638 .................... DR 11 18214 18214 1941-48 1102957 .................................. DR 1118210 18210 1945-46 974 ......................................... D 5634 17930 1945-47 974 ......................................... DR 1118512 18512 1948 1105915 .................................. DR 1118260 18214 1948 1106809 ................................. DR 11 18279 18279

............................ 1949-53 1102957-984 DR 11 18304 18304 1949-53 , 1105915 .................................. DR 1118316 18316 1949-53 1 106627 .................................. DR 1 1 183 16 18316 1949-53 1106809-826 ............................ DR 11 18339 18339 1949-53 1106814 .................................. DR 1118337 18337 1949-53 1106826 .................................. DR 11 18368 18339 1949-55 1102676 .................................. DR 11 18303 18303 1954-55 1105915, 1106627 .................. DR 1118896 18316 1954-55 1106755 .................................. DR 11 18832 18832 1954-56 1 106826, 1 106822 .................. DR 1 1 18838 18339 1954-56 1106834 .............................. DR 11 18886 18337

WARD LA FRANCE 1938-39 9756 ........................................ DR 5538 17884 1938-42 975J . 11 17002 ........................ DR 5535 17883 1939 . 934'2 .................... .................... DR 5828 17949 1939 1105740 .................................. DR 5806 17942 1939 1106629 .................................. DR 5841 17956 1939-42 677 . 695 .................................. DR 5535 17883 1940 1105740 .................................. DR 11 18210 18210 1940-42 1106627-29 .............................. DR 11 18214 18214 1940-42 1 1 17002 .................................. DR 5535 17883 1940-42 11 17022 .................................. DR 5529 17878 1940-42 11 17002 .................................. DR 5647 17936 1941 1101742 .................................. DR 5838 17954 1941 1106638 .................................. DR 1118214 18214


WARD-LA FRANCE (Cant.- 1941 1106650 ................................. DR 1118241 18241 1941-42 1102957 .................................. DR 11 18210 18210 1941-48 1102676 .................................. DR 1118208 18208 1944-48 1102955-67 .............................. DR 1 1 18210 18210 1945-46 GEH4822 ................................ AL VRX4003B 17106

...................... 1945-48 GGA4805-07-14 AL VAT4001 A 17252 1945-48 1102957 .................................. DR 1118210 18210

WATERLOO 1949-50 GAS4302 .......................... AL TC4329C 17403 0 WESTERN AUSTIN (See Austin W e s t e r n ) i!

WILLYS TRACTORS . a ... 1949-5 1 GDZ48 17 ................................ AL VRP4007C 17319

1950-53 GDZ6001 ................................ AL VRP6003A 1953 GGW4801 ..... .: ....................... AL VBE6105A 17301 1954-55 GHD6001 ................................ AL VRR4104A 17335 1 WORTHINGTON (Compressors. pumps\ w I 1938-41 GBS461 1 ............................. AL TC4303B 17280 1938-41 GCS4815 ................................ AL TC4302A 17401 m 1939-40 GBU4214 ................................ AL TC4301B 17401 Cl : 1942 GFB4805 .................................. AL TC4303E 1942 1101726 ................... L..: .......... DR 5884 17280 17974 1

. YELLOW COACH 4

401 .......................................... DR 507 .......................................... DR 934F Taxi GMC ...................... DR 934F Taxi GMC ...................... DR 1100004 Taxi GMC ....,........... DR

.... ............ 507. 11 17506-513 .: DR ................ 512, 513. 1117509 DR

692. 1117019 ........................ DR

The Importance of Reprinted from and with permission of

AUTOMOTIVE SERVICE DIGEST MAGAZINE, August, 1953

BATTERY and GENERATOR POLARITY Exp la in ing w h y g e n e r a t o r s m u s t be c o r r e c t l y po lar ized, before s t a r t i n g the engine, whenever repai rs are made on e lect r ica l un i ts

B y L. V. L A R S O N

T HE automotive electrical system actually contains two generators. One is a chemical device that

produces voltage and current by chemical action and is called a storage battery. The other is a mechanical device which produces voltage and current when conductors arc forced to rotate through a magnetic field (Fig. 1 ) . In normal operation these two generators are hooked up so that the positive terminal of the battery and the positive terminal of the mechanical generator are connected together when the cutout relay contact points are closed. In other words, the voltages of these two generators normally oppose each other, although this is not always recognized.

I t is common practice, of course, to connect batteries and generators positive-to-positive and negative-to- negative, and it is assumed that current usually will flow into the battery. I t is this assumption which tends to hide the fact that these two units are opposing each other elec- trically. A review of important de- tails will help to clear up this point.

The voltage produced by a normal lead-acid storage battery is approxi- mately 2.1 volts per cell or 6.3 volts on a fully charged 6-volt battery on open circuit. The generator voltage, on the other hand, is limited by a voltage regulator on which a limit setting of 7.4 volts can be considered normal. Under these conditions the maximum generator voltage is ap- proximately one volt higher than the open circuit battery voltage, and this difference in voltage will cause current to flow from the generator into the battery. When the battery is in

CUTOUT CURRENT VOLTAGE RELAY R E G U U T C R REGULATOR

AMMETER

Above, Fig. 1: The battery and generator are the two electrical generators in the charging circuit. Below, Fig. 2: Vibrating cutout relay contact points is one result of wrong polarity

Left, Fig. 3: Method of polarizing generators of the "A" circuit type. (Externally grounded field) R i g h t , Fig. 4: Method of polarizing generators of the "B" circuit type. (Internally grounded field)

a discharged condition, its open circuit voltage is lower, being approxi- mately 6 volts. The greater difference between the voltage of the battery and the generator then results in a higher charging rate to the battery. As the battery becomes charged its voltage increases and there is thus less difference between the voltage of the battery and the regulator setting so less current will flow. This is the action which takes place when a battery is being charged.

The opposing voltage of the battery on charge is called its counter electromotive force. It is a variable voltage which changes according to the state of charge of the battery and its internal resistance. Since counter voltage always depends on the amount of charging current flowing, it cannot be measured separately. The voltage read across the charging circuit includes not only battery counter voltage but also voltage drop i n the leads and connections. T h i s total voltage equals t he controlled generator voltage. Thus it is the in-

crease in counter voltage which tends to reduce the charging rate as the difference between generator voltage and battery voltage becomes less and less.

The problem would be much sim- pler if we could always depend upon the generator having a polarity to match the polarity of the battery with which it is used. Unfortunate- ly, a generator will build up voltage of either polarity depending upon the magnetic polarity of the pole shoes in the generateor. Changing the direction of current flow in the field roils will change the magnetic polarity of these pole shoes and voltage then will build up in the reverse direction.

Whenever the battery, generator, regulator, or the wiring is removed from the vehicle, the generator polarity may be reversed accidentally by touching the battery circuit to the field terminal of the generator. Also, generators removed for repairs may be tested on a stand with a battery connected for the opposite polarity.

I t is for these reasons that all electri- cians are cautioned to always polarize the generator correctly after corn- pleting electrical repairs and before starting the engine.

Vibrating cutout relay contact points is on? result of wrong polarity (Fig. 2 ) . With high-resistance, low- output generator armatures, this condition is not too serious as the generator field usually is polarized correctly during an interval when the cutout relay points are closed. This can be called self-polarization. With low-resistance, high out-put generator armatures, as used in most current production generators, it is the exception rather than the rule for generators to be self-polarized. This operation must be performed by the mechanic or electrician work- ing on the vehicle.

To polarize generators with the "A" circuit, or externally grounded field, as in Delco-Remy passenger car systems, a jumper lead should be used to complete a temporary circuit

Left , Fig . 5 : Heavy arrows indicate paths of current flow as generator builds up voltage R i g h t , Fig. 6: Only one path for current flow when cutout relay contact points close

CUTOUT RELAY CUTOUT RELAY

between the BATTERY and AR- MATURE terminals of the regulator (Fig. 3). On the higher output generator it is necessary, in ad- dition, to insulate a generator brush from the commutator when making this flash connection. Otherwise, a high discharge will result.

To polarize generators with the "B" circuit, or the type with the field circuit grounded inside the generator, as on heavy-duty Delco-Remy generators, disconnect the field lead from the FIELD terminal of the regulator and flash on the BAT- TERY terminal of the regulator (Fig. 4). These procedures send battery current through the field circuit in a normal manner so that the generator will be polarized to produce voltage of the same polarity as the battery with which it is used.

As long as the relay points con- tinue to vibrate when the generator and battery are hooked together with

.the wrong polarities, the only trouble resulting is burned cutout relay points. Unfortunately, the arc occur- ring as the points separate is hot enough to melt the point material and the contact points may weld together. Under this condition the generator becomes properly polarized and the battery will be charged, but the points witl not open when the engine is stopped. The high current discharge which then occurs can - burn'up the wiring in the charging circuit or damage the generator armature.

The higher the system voltage the more chance for points welding together. On twenty-four-volt systems the points usually vibrate only once or twice before welding occurs. The complete story behind this action is rarely explained, but by following the direction of current flow in a circuit diagram the answer is quite simple.

As the generator buiIds up voltage, current flows through the field coils in the direction indicated, due to the magnetic polarity of the pole shoes in the generator (Fig. 5). There is also a path for current to flow through the charging circuit to the voltage or operating coil in the cutout relay. When the generator voltage is high enough to cRate enough magnetism in the core of the cutout relay, the armature is at- tracted and the cutout points are closed.

With the generator and the battery hooked up so that the positive terminal of the generator is connected to the negative terminal of the battery, two things take place. First, in a six-volt system, for in- stance, the six-volt mechanical generator is connected in series with the six-volt chemical generator. We then have twelve volts applied to a circuit with very low resistance, and a high current flows through the charging circuit. Secondly, at the same instant, the positive voltage of the generator is being impressed on the insulated side of the circuit, and

the positive battery voltage is being impressed on the ground side of the circuit (Fig. 6). With practically no difference in voltage between the two sides of the circuit, no current will flow through the field coils and the generator voltage falls to a low value. The current flow through the voltage coil of the cutout relay then drops to zero and the relay points open. The fact that an arc occurs as the contacts separate indicates that there still is current flow through the charging circuit at that instant. This arc becomes more severe at higher voltages with a greater tendency to weld the contact points.

As soon as the circuit is broken (by the relay conwts) the generator again builds up voltage to close the relay points and a repetition of the above action takes place. However, if the points weld during this action, the generator becomes polarized with the battery, as already dis- cussed, and normal charging will result. I t doesn't take long for trouble to occur, however, when the engine is stopped. The relay can no longer function, and the battery discharges at a high current rate through the low resistance of the charging circuit. The replacement of wiring and units destroyed in this way never fails to be expensive.

"A .stitch in time saves nine" is an old proverb, but it "pays off' to be sure that the generator is correctly polarized after repairs are completed and before the engine is started.

GENERATOR-REGULATOR CIRCUITS

REGULATOR I(

w

Two different methods are used to connect the generator field circuit to the generator armature. the "A" circuit and the "B" circuit.

4 REGULATOR

GENERATOR

"A" CIRCUIT The field resistance and contact points of the regulator are connected between the field terminal of the generator and ground so that the generator field is grounded through the regulator.

"B" CIRCUIT The field resistance and contact points of the regulator are connected between the field terminal and main terminal of the generator so that the field is connected to ground inside the generator.

f Fig. · 2014. 5. 26. · 5831 6 5834 12 5835. 5844 5836 12 5838 12 5839 6 5840 12 5841 12 5842 12...

Documents

Transcript of f Fig. · 2014. 5. 26. · 5831 6 5834 12 5835. 5844 5836 12 5838 12 5839 6 5840 12 5841 12 5842 12...