ETOPS Briefing European Academy For Aviation Safety ETOPS HIST RY ET PS Briefing Delhi - February...
-
Upload
anthony-corcoran -
Category
Documents
-
view
277 -
download
5
Transcript of ETOPS Briefing European Academy For Aviation Safety ETOPS HIST RY ET PS Briefing Delhi - February...
ETOPS BriefingETOPS Briefing European Academy For Aviation Safety
ETOPS HIST RY
ET PS BriefingET PS Briefing
Delhi - February 1999
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 2
DefinitionsDefinitions
What is the meaning of ETOPS?
Extended range with Twin engine aircraft OPerationS
What is the scope of ETOPS?
Operation of twin engine aircraft on routes that go further than 1 hour from a diversion airfield
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 3
DefinitionsDefinitions
NBO
JIB
SLL
KHI
BOM
CMB
Non ETOPS flight
60’ circles
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 4
DefinitionsDefinitions
NBO
JIB
SLL
KHI
BOM
CMB
ETOPS flight
60’ circles
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 5
ETOPS regulations are applicable to:
Overwater operations
Overland operations (desert areas...)
What is the meaning of EROPS?
Extended Range OPerationS EROPS describes the applicability of ETOPS requirements
to any aircraft, regardless the number of engines
DefinitionsDefinitions
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 6
HistoryHistory
Extended range “operations“ started very early:
1909: first English Channel crossing (L. Bleriot)
1919: first North Atlantic Ocean crossing (J. Alcock & A. Brown)
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 7
1927: first non-stop New York - Paris (C. Lindbergh)
first US Cost-Hawaï crossing (A.Hegenberger & L.Maitland)
first South Atlantic crossing (D. Costes & J. Le Brix)
• Extended range “operations“ started very early:
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 8
1928: first Pacific Ocean crossing (C.K. Smith & C.T. Ulm)
1930: first non-stop Paris - New York (D. Costes & M. Bellonte)
• Extended range “operations“ started very early:
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 9
“Extended range” commercial operations started in the late 1930s:
1936: first trans-Pacific commercial flights
1939: first trans-Atlantic commercial flights
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 10
These types of flights required large multi-engined flying-boats:
poor engine reliability and performance could not allow design of equally efficient twin engine aircraft
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 11
Piston engine reliability The following chart (1953 ICAO report) gives the probability of
failure for piston engines vs power at 1000 constant rpm:
the probability of failure increases as power is increased
12,03
3,36
4,97
6,84
8,94
0
1
2
3
4
5
6
7
8
9
10
1000 1500 2000 2500 3000 3500engine horsepower
Fp x 10-4 FH
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 12
Piston engine reliability (cont’d)
The 1953 ICAO report shows that for the same amount of installed horsepower, the risk of an engine failure is greater on a 2 engine design than on a 4 engine design:
design required hp
4000 5000 6000 7000
Engine Fp on Twin
Engine Fp on Quad
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 13
As reliable and reasonably light engines had limited power:
design of long range aircraft (high weight) implied installation of several engines (more than two)
twin engine aircraft had limited payload/range performance and were only operated on short flights
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 14
In 1953, further to a review of the piston engine reliability, the FAA published the initial “60 minutes” rule:
applicable to three (until 1964) and two engine aircraft special approval for operations beyond 60 minutes
At the same time, ICAO issued its “90 minutes” recommendations:
no airplane shall be operated beyond 90 min (all engines operative) from a diversion airfield, except if the route can be flown with two engines inoperative
common interpretation was that twin engine aircraft could be operated on 90 minutes routes
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 15
Until 1952, all commercial flights were operated with piston engine powered airplanes:
1952: first commercial operation with jet airplane (DH Comet 1) 1958: first transatlantic commercial jet operation (DH Comet 4)
Since 1960, jet engine powered aircraft progressively replaced piston engine powered aircraft:
on all long range routes on most of regional routes
Until 1952, all commercial flights were operated with piston engine powered airplanes:
1952: first commercial operation with jet airplane (DH Comet 1) 1958: first transatlantic commercial jet operation (DH Comet 4)
Since 1960, jet engine powered aircraft progressively replaced piston engine powered aircraft:
on all long range routes on most of regional routes
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 16
Higher performance of jet engines allowed operations of twins on 90 min routes (Caribbeans, Africa, Bay of Bengal, North Atlantic, South China Sea, ...)
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 17
Jet engine reliability More than 40 years of jet operations have shown that unlike piston
engines, jet engine failure probability is not affected by the thrust or the size of the engine:
Therefore, the probability of an engine failure is now higher on a quad-jet than on a twin-jet
0
0,01
0,02
0,03
JT8D V2500 RB211 CF6-80 PW4000
14-16K 22-25K 37-40K 48-50K 50-60K
IFSD rate(for 1000 FH)
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 18
The introduction in the 1980s of twin aircraft (A310, B767) powered with modern (fuel efficient) turbofan engines made the old 60/90 minute rules inadequate:
1984: ICAO ETOPS study group amend Annex 6
1985: FAA publishes first ETOPS regulation to address 120 min operations
1985: first ETOPS operation (SIA/A310 - TWA/B767)
HistoryHistory
ETOPS BriefingETOPS Briefing European Academy For Aviation SafetyHistory - 19
In 1988, the Authorities published rules for 180 minutes ETOPS based on the very good experience with 120 minutes operations:
today, ETOPS operation is representing over 60% of North Atlantic operations
Regulatory discussions are on-going to assess:
extension of the ETOPS limit beyond 180 minutes
increase of the non-ETOPS threshold above 60 minutes
HistoryHistory