EReg ANNUAL CONFERENCE 11 th MAY 2010 Vehicle Administrative Platform Walter Nissler European...

ERegEReg ANNUAL CONFERENCE ANNUAL CONFERENCE 1111thth MAY 2010 MAY 2010

VehicleVehicle Administrative Administrative PlatformPlatform

Walter NisslerEuropean CommissionDirectorate General Mobility & TransportRoad Safety Unit

| 2EGEA General Assembly, 29th October 2009

ContentContent

.Vehicle Administration .Link to Road Safety.Changes in EU Legislation.Continuous Compliance.Data and Information.Actions


ContentContent

.Vehicle AdministrationVehicle Administration .Link to Road Safety.Changes in EU Legislation.Continuous Compliance.Data and Information.Actions


Vehicle AdministrationVehicle Administration

.Type-ApprovalType-Approval.RegistrationRegistration.Periodic Technical InspectionPeriodic Technical Inspection.Roadside Technical InspectionRoadside Technical Inspection.Vehicle Re-callsVehicle Re-calls.End of life certificateEnd of life certificate


Situation TodaySituation Today

. Type-Approval COC DocumentType-Approval COC Document

. Registration re-typing COC DocumentRegistration re-typing COC Document

. InspectionInspection missing vehicle data missing vehicle data

(COC Document & technical information) (COC Document & technical information)

. Re-registrationRe-registration re-typing old registrationre-typing old registration

.Mutual recognition of inspections Mutual recognition of inspections

not existing not existing

. Vehicle re-callVehicle re-call voluntary basis only voluntary basis only

. End of life certificateEnd of life certificate unsolved problemunsolved problem


ContentContent

.Vehicle Administration .Link to Road SafetyLink to Road Safety.Changes in EU Legislation.Continuous Compliance.Data and Information.Actions


Link to Road Link to Road SafetySafety (1) (1)

.Approval:Approval: vehicle has to meet highest vehicle has to meet highest required safety standard required safety standard.Registration:Registration:

» Definition:Definition: administrative authorisation for the administrative authorisation for the entry into service in road trafficentry into service in road traffic

» Main criteria:Main criteria: vehicle to be approved and in a vehicle to be approved and in a roadworthy conditionroadworthy condition

» Any Any introduction of a new safety featureintroduction of a new safety feature is is linked to the date of first registration linked to the date of first registration


Link to Road Safety (2)Link to Road Safety (2)

.Roadworthiness testRoadworthiness test» Periodic Technical Inspection (PTI): Periodic Technical Inspection (PTI):

Continuous Compliance, keep the level of Continuous Compliance, keep the level of vehicle safetyvehicle safety

» Roadside Technical Inspection: Keep the safety Roadside Technical Inspection: Keep the safety level continuous and level continuous and not for the day of the PTI not for the day of the PTI onlyonly


Link to Road Safety (3)Link to Road Safety (3)

.Vehicle Re-callsVehicle Re-calls» For safety related defectsFor safety related defects» Enforcement of repairEnforcement of repair

.Vehicles in a not roadworthy condition shall Vehicles in a not roadworthy condition shall be out of service in road traffic!be out of service in road traffic!


ContentContent

.Vehicle Administration .Link to Road Safety.Changes in EU LegislationChanges in EU Legislation.Continuous Compliance.Data and Information.Actions


Changes in European LegislationChanges in European Legislation

.Amendment of Directive 2009/40/EC on Amendment of Directive 2009/40/EC on Roadworthiness Tests for Vehicles and Roadworthiness Tests for Vehicles and their Trailerstheir Trailers

.Amendment of Directive 2000/30/EC on Amendment of Directive 2000/30/EC on Roadside Technical Checks for Commercial Roadside Technical Checks for Commercial Vehicles Circulating in the UnionVehicles Circulating in the Union


Directive 2009/40/ECDirective 2009/40/EC

.Amendment of Annex IIAmendment of Annex II» Introduction of inspection certificate» New testing items on modern electronic safety

systems (Not comfort systems!)• First step based on check of MIL only• Member States may use scan tools (~ field

test)» Testing methods for each of the items» Examples of failures for each of the items» No assessment of failures (» Commission

Recommendation)


Changes to Directive 2009/40/ECChanges to Directive 2009/40/ECTest CertificateTest Certificate

Roadworthiness certificates issued in case of mandatory periodic vehicle tests shall cover at least the following elements:

1 VIN number2 registration plate number and country symbol of state of

registration3 place and date of the test4 odometer reading at time of the test if available5 vehicle class if available6 identified defects (it is recommended to follow the numerical

order of Paragraph 5 of this Annex) and its category7 overall assessment of the vehicle8 date of next periodical test (if this information is not provided by

other means)9 name of inspection organisation and signature or identification of

the inspector responsible for the test


Changes to Directive 2009/40/ECChanges to Directive 2009/40/ECNew test itemsNew test items

.New testing items on modern electronic safety systems (Not comfort systems!)» First step based on check of MIL only» Member States may use scan tools (~ field test)

• Anti-lock Braking System (ABS)• Electronic Brake System (EBS)• Electronic Power Steering (EPS)• Electronic Stability Control (ESC)• Safety Belt Load Limiter• Safety Belt pre-tensioner• Airbag• SRS Systems


Directive 2000/30/ECDirective 2000/30/EC

.Amendment of Annex I» Include VIN number one report per vehicle» Checklist in line with Annex II of Directive

2009/40/EC» Reverse side with all possible test items for

easy marking of detected deficiencies.Amendment of Annex II» Brakes and exhaust emissions only» In line with Directive 2009/40/EC


ContentContent

.Vehicle Administration .Link to Road Safety.Changes in EU Legislation.Continuous ComplianceContinuous Compliance.Data and Information.Actions


Continuous ComplianceContinuous Compliance

Shared responsibility:

• Vehicle manufacturer• Vehicle owner• Authorities



.At type – approval vehicles have to fulfil highest safety standards.Type approval requirements contain test methods and set levels of efficiency.Type approval requirements do not give technical design solutions

PTI has to consider all safety equipment that was installed when the vehicle was brought into service + retrofitting requirements



.Need for further technical data of each single vehicle

.Regulation EC - 715/2007 Requires vehicle manufacturer to make all data for service and inspection available as of January 2009



Regulation EC - 715/2007 Article 6

Manufacturers’ obligations1. Manufacturers shall provide unrestricted and

standardised access to vehicle repair and maintenance information to independent operators through websites using a standardised format in a readily accessible and prompt manner, and in a manner which is non-discriminatory compared to the provision given or access granted to authorised dealers and repairers.



The information referred to in paragraph 1 shall include:

(a) an unequivocal vehicle identification;(b) service handbooks;(c) technical manuals;(d) component and diagnosis information (such as minimum and

maximum theoretical values for measurements);(e) wiring diagrams;(f) diagnostic trouble codes (including manufacturer specific codes);(g) the software calibration identification number applicable to a

vehicle type;(h) information provided concerning, and delivered by means of,

proprietary tools and equipment; and(i) data record information and two-directional monitoring and test

data.


ContentContent

.Vehicle Administration .Link to Road Safety.Changes in EU Legislation.Continuous Compliance.Data and InformationData and Information.Actions


Data and InformationData and Information

.From today’s situation to a From today’s situation to a solution for the futuresolution for the future


EoL-Certificate

EnforcementEnforcement

InsuranceInsurance

Consumer Consumer protectionprotection

Vehicle Vehicle administrative administrative

platformplatform

Vehicle Vehicle technical technical databasedatabase

COC COC Document for Document for each vehicleeach vehicle

National roadworthiness

database

National National roadworthiness roadworthiness

databasedatabase

National National registration registration

databasedatabase

EU LevelEU Level

27x27x

National LevelNational Level

Single Single vehicle vehicle

approvalapproval

Vehicle manufacturersVehicle manufacturersSituation Situation todaytoday


EoL-Certificate


InsuranceInsurance



platformplatform




database


databasedatabase


databasedatabase

EU LevelEU Level

27x27x



approvalapproval


14 Mio/year

2,5 Mio/year284 Mio registered vehicles in EU 27

~ 260 Mio tests/year


NEW APPROACHNEW APPROACH

. Information availability wherever neededInformation availability wherever needed» national databasesnational databases: for registration, for roadworthiness : for registration, for roadworthiness

testing and for end of life certificates databases on national testing and for end of life certificates databases on national levellevel

» international databaseinternational database: for type-approval the existing : for type-approval the existing database should contain all COC documents, including database should contain all COC documents, including single approved vehicles as well as approvals of technical single approved vehicles as well as approvals of technical changes to vehicleschanges to vehicles+ necessary technical information for vehicle testing.+ necessary technical information for vehicle testing.

» interconnection of databasesinterconnection of databases: both national as well as : both national as well as international databases should be interconnected that data international databases should be interconnected that data between type approval, registration, roadworthiness tests between type approval, registration, roadworthiness tests and end of life certificates can be exchanged by electronic and end of life certificates can be exchanged by electronic means.means.

» ……. .


EoL-Certificate


InsuranceInsurance



platformplatform




database


databasedatabase


databasedatabase

EU LevelEU Level

27x27x



approvalapproval

Vehicle manufacturersVehicle manufacturersNew New approachapproach Use the Use the

existing existing basisbasis


EoL-Certificate


InsuranceInsurance


Vehicle Vehicle typeapproval typeapproval

databasedatabase



database


databasedatabase


databasedatabase

EU LevelEU Level

27x27x



approvalapproval


platformplatform

Vehicle manufacturersVehicle manufacturersNew New approachapproach Add what Add what

is missing is missing



databasedatabase



database


databasedatabase

InsuranceInsurance




databasedatabase

EU LevelEU Level

27x27x



approvalapproval


platformplatform

Vehicle manufacturersVehicle manufacturers

EoL-EoL-CertificateCertificate

New New approachapproach

Potential Potential benefitsbenefits


ContentContent

.Vehicle Administration .Link to Road Safety.Changes in EU Legislation.Continuous Compliance.Data and Information.ActionsActions


ACTIONSACTIONS

.EC:EC: » legal basis by changing / amending Directives legal basis by changing / amending Directives

2009/40/EC, 2000/30/EC, 1999/39/EC, 2009/40/EC, 2000/30/EC, 1999/39/EC, 2007/46/EC and …2007/46/EC and …

» Assistance to MS for implementingAssistance to MS for implementing.MS:MS: » Prepare the national environment (Databases)Prepare the national environment (Databases)» Connect to the network / platformConnect to the network / platform.Industry:Industry:» Provide the necessary vehicle dataProvide the necessary vehicle data


ACTIONSACTIONS

.Process started:Process started:» Impact Assessment » Stakeholder Consultation

.Target:Target:» Draft for legislative act by end of 2010


THANK YOUTHANK YOU



databasedatabase



database


databasedatabase

InsuranceInsurance




databasedatabase

EU LevelEU Level

27x27x



approvalapproval


platformplatform

Vehicle manufacturersVehicle manufacturers

EoL-EoL-CertificateCertificate

EReg ANNUAL CONFERENCE 11 th MAY 2010 Vehicle Administrative Platform Walter Nissler European...

Documents

Transcript of EReg ANNUAL CONFERENCE 11 th MAY 2010 Vehicle Administrative Platform Walter Nissler European...