Electric Fence Design & Supply Guide Fencing Accessories and... · PM 714 Self-Dispensing Wire...
Transcript of Electric Fence Design & Supply Guide Fencing Accessories and... · PM 714 Self-Dispensing Wire...
Electric Fence Design &
Supply Guide
Place Store Label/Logo Here
2
Comparing Stafix and Patriot Branded Chargers
Helpful Tips for Selecting A Charger
Focus on Joule Rating The number of Joules in a charger is the primary rating to consider when deciding how “powerful” a charger is. Miles, Acreage, Volts, and Watt Ratings on chargers can be very deceptive and should only be used as a general guideline. A Joule, or the unit of measurement of energy exerted per pulse, is the only statistic that will accurately provide the power of the charger. Output vs. Stored Energy should be evaluated as well. Some manufacturers only market the Stored Energy Joule Rating. The Output Rating is what the charger can actually produce in terms of Joules. A good rule of thumb is selecting a charger that has a 1 Joule (J) output energy rating for every 6 miles of electric wire.
Power Source While using 110v AC (plug in) may be the most efficient use of power for a charger, the 12v DC (battery or solar powered) offers benefits if AC power is unavailable or unreliable. Generally, an AC powered charger is sufficient for permanent fencing needs. A DC powered charger provides flexibility for temporary, rotational grazing fencing systems.
Energizer vs Unigizer This is simply how Stafix distinguishes between an AC powered charger (Energizer) and a charger that can be powered via AC or DC source (Unigizer)
Stafix Patriot Power Source 110v/AC or 12v/DC 110v/AC only
Plug in or Battery/Solar capable Plug in only
Repairs/Maintenance Repairable Replace
Peak Output Joule Rating Up to 63 J Up to 12 J
FENCE CHARGERS *Chargers shown are only a sample of full line up offered by Pasture Management Systems in partnership with Stafix and Patriot. Please reference Pasture Management Systems Product Catalog for full energizer availability or ask your dealer for more information.
3
GROUNDING EQUIPMENT
PM 126 PMSI HD Ground Rod Clamp
5/pack
PM 125 PMSI 5/8in x 6ft Galvanized Ground Rod
UNDERGROUND CABLE & JOINT CLAMP
PM 254 HD Insul-Tubing PM 257A
SHD (.33 OD) Direct-Burial Underground Cable
165ft on Plastic Spool; 12.5ga; C3 Galvanized; Double
PM 257 SHD (.33 OD) Direct-Burial
Underground Cable
330ft on Plastic Spool; 12.5ga; C3 Galvanized; Double Insulated
PM 293-SHD Super HD Joint
Clamp 20/Jar
PM 294HD HD Cutoff Switch with
Stainless Steel Contacts and Wing Nuts
SAFTEY & ACCESSORIES
PM 258-66 66ft roll HD 12.5ga C3
Double Insulated Underground
PM 295 Clip-on Electric Fence
Warning Sign
PM 501 Single Jumper Lead
Length: 39in
PM 143 PMSI 8-Light Fence Tester
Voltage Tester designed for low-impedance and standard duty energizers
8 easy-to-read lights. Voltage readings - from 600v to 7000v. Indicates fence line & energizer voltage.
FSTFA Stafix Fence Alert
Simple device which flashes when low voltage is detected. Works with all low-impedance energizers.
821956 Stafix Lightning Diverter
Redirect lightning to ground to minimize charger/fence damage.
Works great with wood posts.
PM 122 PMSI Porcelain
Lightning Arrestor
2/pack
PM 123 PMSI Lightning Diverter
(Choke) Kit
(Instructions included)
FSTFC Stafix Fault Finder
A combined volt meter and current meter designed for quick location of faults.
PM 714 Self-Dispensing Wire
1320ft, 14ga, C3 on Wooden Spool.
118128 Hi-Tensile Wire
Bekaert 4,000ft coil 170K psi, 12.5ga, C3
20/pallet Wt. 100lbs
PM 740-5 Hi-Tensile Wire
PMSI 5,000ft coil 210K psi minimum,
14ga, C3 25/pallet Wt. 89lbs
HI-TENSILE ELECTRIC FENCE WIRE, SPINNERS, & STRAINERS
PM 680 HD Wire Payout Spinner 100% steel!
823827 Patriot Economy Spinning Jenny
PM 774 Handle for In-Line Wire Strainer
Fits PM 772, PM 773’s
PM 777 SHD Spring Clip Strainer with Stainless Steel Strap
Tighten with 1/2in Drive Ratchet, 7/8in Wrench, Adjustable Wrench,
or use Trellis-style!
PM 773-E Economy In-Line Wire
Strainer with Spring Lock
PM 775 HD Tension Spring
Class 3 Galvanized
PM 771 Handle for PM 770 Wheel Tightener
PM 770 HD Wheel Tightener
PM 899 Steel H-Brace Beams 14 ga steel - 14ga Galvanized Steel Tubing with Clear-Coat Protector 10ft x 2-3/8in diameter
PM 878 5 inch Brace Pins
Hot-Dip Galvanized 3/8in diameter
PM 879 10 inch Brace Pins
Hot-Dip Galvanized 3/8in diameter
BRACE PINS AND H-BRACE BEAMS
4
BRACE ASSEMBLY FOR 4FT HIGH FENCES
Brace Post 6” x 8’ Wood Posts PM 978-MD or PM 978-LG
Cross Member 5” x 10’ Wood Post or 2.375” x 10’ 14ga Steel Tubing
PM 980 or PM 899
Brace Pins 5’’ and 10” Brace Pins PM 878 and PM 879
Brace Wire 9ga C3 Brace Wire or PM 5570 or
Hi-Tensile Wire Coil or PM 118128 or
Speed Brace Kit PM 611-TUB
In Line Strainer Spring Clip Strainer PM 777
Staples 1.75” C3 Double Barbed Staples PM 958-40 or PM 957-10
5
Treated to minimum .40 CCA SPIB inspected for both penetration & retention 100% Pulpwood Posts No Peeler Cores!
ITEM NO. CCA TREATED WOOD POSTS # PER BDL
PM 976-SM 3-3.5in x 6-1/2ft Wood Post 100 or 120
PM 976-MD 3.5-4in x 6-1/2ft Wood Post 80 or 100
PM 976-LG 4-5in x 6-1/2ft Wood Post 60
PM 977-SM 4-5in x 7ft Wood Post 60
PM 977-MD 5-6in x 7ft Wood Post 45
PM 978-SM 4-5in x 8ft Wood Post 60
PM 978-MD 5-6in x 8ft Wood Post 45
PM 978-LG-35 6-7in x 8ft Wood Post 35
PM 978-XL 7-8in x 8ft Wood Post 25
PM 978XL-DF 7-8in x 8ft "Double Faced" Wood Posts Use it like a 6" x 6"
30
PM 980 5in NON-TAPERED x 10ft Wood Post 43
WOOD POSTS
6
FSTESG Stafix End Strain Insulator
Suitable for medium strain use.
Green - 25/bag
PM 239-SHD PMSI SHD 4 inch Fin
Tube Insulator
175/box
PM 240 PMSI SHD 24 inch
Wrap-Around Insulator
10/bag
PM 238 PMSI SHD 20 inch
Wrap-Around Insulator
10/bag
PM 228 PMSI Wood Post Wide Polytape and Polyrope
Insulator
Use with up to 1-1/2in wide tape.
White 25/bag
PM 337 PMSI Wood Post Pinlock Insulator
White 25/bag
PM 233-USA PMSI Large T-Post Pinlock Insulator
Black 25/bag
INSULATORS
PM 222-W Stafix XL SHD End Strain Insulator
Suitable for high strain use.
Reinforced glass filled polymer for maximum strength. White - 25/bag
PM 226-USA PMSI Wood Post Pinlock Insulator
Black 25/bag
PM 623 Crimp Sleeve 2-3
Use on 12.5ga Smooth wire 100/jar
PM 634-T 3-4T Taps One End Open 50/jar
CRIMP SLEEVES (NOT ALL SIZES SHOWN)
Types of Poly Fence Products
Polywire Ideal for temporary/portable fencing to support rotational grazing efforts Cattle, Horses and Sheep/Goat Use with Pigtail or Tread-In/Step-In Post
Polybraid Can be used for temporary or semi-permanent fencing 50% higher breaking point (strength) than polywire Ideal for larger/stronger livestock Use with Wood Post, T-Posts and Fiberglass Rod Posts
Polytape Can be used for temporary or semi-permanent fencing ½ inch to 1 ½ inch wide provides highest visibility fencing Horse Friendly Use with Pigtail or Tread-In/Step-In Post (½ inch tape) or Wood Post, T-Post and Fiberglass Rod
Posts (1 ½ inch tape)
Polyrope Ideal for semi-permanent fencing Wider diameter for higher visibility than polybraid Horse Friendly Use with Wood Post, T-Post and Fiberglass Rod Posts
What Voltage do I need for my Poly Fence?
Choosing the right Poly Fence Product is just as important as having the right charger. Voltage is not absolute! What may measure 8,000 volts at the start of the fence may only measure 550 volts at the end. The best way to determine the power through the entire length of the fence is the OHMS/Mile rating. The lower the OHMS/Mile number, the longer down the fence the initial voltage rating will hold. For under 400ft of fence powered by a strong charger with a high Joule rating, the OHMS/Mile rating will not mean as much. Any length greater than 400ft and you will want to invest in a product with a superior OHMS/Mile Rating. This will ensure that all sections of your fence will be “hot” enough to deter your livestock or potential intruders.
7
POLYWIRE UV Stabilized for MAXIMUM Longevity
POLYTAPE UV Stabilized for MAXIMUM Longevity!
ITEM NO. DESCRIPTION ROLL SIZE OHMS
HOT!
PM 526-16 6 Strand Stainless Steel 1/2 inch Polytape - .16mm Conductors 660ft 12,500
PM 527-16 6 Strand Stainless Steel 1/2 inch Polytape - .16mm Conductors 1320ft 12,500
HOTTER!!
PM 551-13 13 MEGA Strand 1-1/2 inch Wide Polytape - .20mm Conductors 165ft 6,000
PM 552-13 13 MEGA Strand 1-1/2 inch Wide Polytape - .20mm Conductors 660ft 6,000
HOTTEST!!!
PM 527-MV 5 MEGA Strand 1/2 inch Wide Polytape - .30mm Conductors
When it comes to conductivity, SIZE MATTERS! 1320ft 3,400
PM 526-16 PM 552-13 PM 527-MV PM 551-13 PM 527-16
ITEM NO. DESCRIPTION ROLL SIZE OHMS
HOT!
PM 525-16 6 Strand Stainless Steel - .16mm Conductors 660ft 12,300
PM 556-16 6 Strand Stainless Steel - .16mm Conductors 1650ft 12,300
HOTTER!!
PM 549-MV 9 MEGA Strand PREMIUM Stainless Steel - .20mm Conductors 1320ft 4,400
PM 589-MV 9 MEGA Strand PREMIUM Stainless Steel - .20mm Conductors 2640ft 4,400
HOTTEST!!! Superior Strength, Longevity and Conductivity!
PM 575-MV+ 6 Strand Super Conductive (3 Stainless Steel and 3 Copper) Ideal for long-distance fencing & temporary perimeter fences!
1650ft 100
PM 589-MV PM 575-MV+ PM 525-16 PM 549-MV PM 556-16
8
EXTREME WIRE & TAPE PRODUCTS
STAFIX EXTREME WIRE
6 tinned copper strands
ITEM ROLL SIZE OHMS
FSTXW200 660ft 105
FSTXW400 1320ft 105
815238 2640ft 105
STAFIX EXTREME TAPE
6 tinned copper strands - 1/2 inch wide
ITEM ROLL SIZE OHMS
FSTXT200 660ft 105
FSTXT400 1320ft 105
FSTXW200 FSTXW400 815238 FSTXT200 FSTXT400
POLYROPE & BRAID UV Stabilized - Highly Visible.
ITEM NO. DESCRIPTION ROLL SIZE OHMS
BRAID
PM 649-MVB 9 Strand Stainless Steel Conductors - White 1320ft 5,100
PM 659-MV+B 9 Strand (6 Stainless Steel and 3 Tinned Copper) Conductors
Red & White 1320ft 400
HS-1 Equine Polybraid Braided Polyester Fiber with Poly-propylene Core
Tinned Copper Conductors - 1800 lb. Breaking Strength! 25-YEAR WARRANTY!
1000ft 40
ROPE
821450 Patriot ECONOMY Polyrope
6 Stainless Steel Strands - .6mm diameter, 660ft 18,500
PM 538-MV+ 9 Strand Super-Conductive Polyrope
(6 Stainless Steel and 3 Copper) - .65mm 660ft 200
821450 PM 538-MV+ PM 659-MV+B PM 649-MVB HS-1
Ideal for long-distance fencing & temporary perimeter fences!
9
ELECTRIFIED GATE HOOK HANDLES & SPRING GATE KITS
REELS
PM 590+ Geared 3:1 Fence Reel with Insulated Hook Gate Handle
Holds 1640ft polywire or 660ft polytape UV-stabilized plastic nylon brushings reduce wear - Galvanized steel
frame and crank handle. One Year Warranty!
PM 580-MR Mini Reel 1:1 Ratio
Hold 800ft of polywire or 330ft of polytape.
Economical choice for shorter lengths.
Use with polywire, polybraid, polyrope and polytape. Not recommended for use with steel wire.
PM 559 14-48-7 Electric Netting
48in tall x 164ft long
Ideal for poultry, sheep, or goats. 14 horizontal stainless steel
conductors. Vertical stays every 7 inches.
Excellent predator control.
PM 559-3.5 14-48-3.5 Electric Netting
48in tall x 164ft long
Ideal for sheep, goats, pigs, chickens and dogs.
14 horizontal stainless steel conductors.
Vertical stays every 3.5 inches. Excellent predator control.
PM 558 9-40-7 Electric Netting 40in tall x 164ft long
Ideal for sheep, goats, and dogs. 9 horizontal stainless steel
conductors. Vertical stays every 7 inches.
Excellent predator control.
ELECTRIC NETTING
PM 353 PMSI Tape Gate Kit
Everything you need but the tape to make any width opening!
PM 329 PMSI HD Economy
Gate Handle
Electroplated Galvanized
Black
PM 381 PMSI Insulated Hook
Gate Handle
Ideal for temporary fence systems.
Yellow
PM 323 PMSI SHD Gate Handle
Works great with PM 355 HD Gate Activator or
any spring gate.
PASTURE MANAGEMENT SYSTEMS SPRING GATE KITS
Installation Hardware Included
Conveniently packaged kit provides everything needed to create an electrified gate that will do its job while providing safe
and easy access for you.
ITEM # DESCRIPTION
PM 358 14ft HD Spring Gate, C3 Galvanized
PM 358XL 24ft HD Spring Gate, C3 Galvanized
PM 358W 14ft HD WHITE Spring Gate, Powder-Coated
ITEM # Replacement Springs
PM 358RS For 14ft Spring Gate
PM 358XLRS For X-Long 24ft Spring Gate 10
PM 355 PMSI HD Gate Activator
Included in all PM 358 Spring Gate Kits. Works great with PM 323 Gate
Handle
PM 355WTA PMSI Wood Post
Wide Polytape Anchor
Bolt lock provides great support for polytape used over long distances.
TEMPORARY FENCING POSTS
ITEM DESCRIPTION
All Fiberglass Posts are SunGuard II coated for longevity and ease of use!
PM 921 11/16in x 60in Fiberglass Rod Post - 2in hole spacings - 25-Year Warranty!
PM 922 7/8in x 60in HD Fiberglass Rod Post - 2in hole spacings - 25-Year Warranty!
PM 924 7/8in x 66in HD Fiberglass Rod Post - 2in hole spacings - 25-Year Warranty!
PM 926 7/8in x 72in HD Fiberglass Rod Post - 2in hole spacings - 25-Year Warranty!
PM 930 1/2in x 48in Fiberglass Dropper - 2in hole spacings - 10-Year Warranty
PM 567 3/8in x 48in Fiberglass Rod - Lt Gray - 10-Year Warranty
ITEM NO. DESCRIPTION HEIGHT
PM 597 PMSI HD Tread-In Post
HD I-Beam Construction - Extended, Reinforced, HT Steel Spike UV-Stabilized - Yellow
41"
PM 599W-P PMSI SHD Steel Pigtail Post
White 43-1/4"
Fence Height: 36-1/4"
820013-White 820014-Black
Patriot Step-In Post 8 Different Positions; Pointed Tip; Wider Foot
UV Stable for Longer Life
49" 39" Above Ground
PM597-FG
Geotek Smart Clip Step-In Post SunGuard II Coated; Bigger & Stronger Clip Design; Super Fast and Easy to Use; Molded Top Drive Cap
Works with polywire, rope, braid, 2" wide tape and steel wire.
48"
10-YEAR WARRANTY
11
Basic Fence Systems Design Checklist
Notes:
For Permanent Electric Fencing Systems
Fence Charger
Ground Rods/Clamps
Underground Cable
Fence Alert
Fence Tester and/or Fault Finder, Volt Meter
Single Jumper Leads, Lightning Diverter, Warning Sign
Cut-Off Switch
Joint Clamps
Hi-Tensile Electric Fence Wire
Wire Spinner
Wire Strainers/Tighteners
Posts, Corner, and End Braces
Crimp Sleeves and Insulators
For Temporary Electric Fencing Systems Fence Charger
Ground Rods
Underground Cable
Fence Alert
Fence Tester and/or Fault Finder, Volt Meter
Single Jumper Leads, Lightning Diverter, Warning Sign
Reel
Polywire, Polybraid, Polyrope or Polytape & Netting
Insulated Hook Handle
Temporary Posts
Common Fence Measures