Digital Temperature Control and Monitoring · Mixing Safety and Performance 1360 Elmwood Avenue...
Transcript of Digital Temperature Control and Monitoring · Mixing Safety and Performance 1360 Elmwood Avenue...
Mixing Safety and Performance
1360 Elmwood Avenue Cranston, RI 02910TF: 800.222.1208 P: 401.461.1200 F: 401.941.5310
www.leonardvalve.com
Low Lead Certified
Digital Temperature Control and Monitoring
for over 100 years
Digital Temperature Control and Monitoring
WHY WE WANT DIGITAL
Faster, More Accurate Temperature Control
User Programmable Set Point
Legionella Standards Compliance
BENEFITS
Self-balancing
No laptop required for setup or adjustments
Standard Check valves & Outlet ball valve
Integral daily shuttle sweep
Total Digital Temperature Gauges
Sanitization Mode
Multiple Point Alarms
Primary RTD Temperature measurement on mixed outlet
MONITOR & COMMUNICATE
Up to 8 temperature, 3 pressure, 2 flow channel inputs
Monitor and adjust local and remotely
Six (6) Standard Protocol Languages - BACNet IP & MS/TP - Modbus RTU & TC/IP - Metasys N2 by JCI - Ethernet/IP
Ability for Cloud Based Monitoring & Logging
2 Mixing Safety and Performance for over 100 years LEONARD VALVE – NUCLEUS
Nucleus Megatron NV-150-LF
NUCLEUS BASE VALVE ONLY NUCLEUS WITH INLET FITTINGS & RETURN TEMPERATURE SENSOR
NUCLEUS RECIRCULATION MANIFOLDS
NUCLEUS MEGATRON 2PS-HIGH CAPACITY UNITS
Configurations and Options – 16 Models Available!
LEONARD VALVE – NUCLEUS Mixing Safety and Performance for over 100 years 3
OPTIONS
RDU - Leonard Remote Display Unit - Alarm Delay Module with yellow, red, green LED indicators - Recommended maximum distance from controller to RDU is 500’
BPS - Backup Power Supply Option - Uninterruptable Power Supply with up to 2 hours run time
LC - Less Circulator - Megatron only
DB - Daughter Board - Display up to 4 additional temperature inputs, 1 flow channel
input, and 1 configurable flow or pressure input channel
Additional integral RTD Temperature measurement sensors for 3 critical measurement points:
- Inlet hot, inlet cold & return water temperature
Options to display: - Four (4) additional temperature inputs - One (1) additional pressure input - One (1) additional flow input - One (1) configurable channel input flow or pressure
1360 Elmwood Avenue Cranston, RI 02910TF: 800.222.1208 P: 401.461.1200 F: 401.941.5310
www.leonardvalve.com
10
20
30
40
50
NV-150-LFNV-200-LF
NV-300-LFNV-150-LF-2PS NV-200-LF-2PS
NV-300-LF-2PSNV-300-LF-3PS
50 60 70 80 100 150 200 300 400 500 600 700 900
0.7
1.4
2.1
2.8
3.4
BAR
FLOW RATE, GPM
PR
ES
SU
RE
DR
OP
, PS
I
LV-150 Rev 11/16©2016 Leonard Valve Company
Printed in the U.S.A
PIPING DIAGRAM
Flows & Capacities
NV-200-LF-2PS
NV-150-LF-2PS
NV-300-LF
NV-150-LF
NV-200-LF
1 1/4" 1 1/2"
(31.6mm) (38.1mm) 0.95*
0.25*
189
50
379
100
273
72
326
86
435
115
462
122 GPM
L/MIN515
136
530
140
625598
158 165
2" 2"
(50.8mm) (50.8mm) 0.95*
0.25*
303
80
556
147
435
115
492
130
625
165
655
173 GPM
L/MIN715
189
750
198
856814
215 226
0.95*
0.25*
366
97
722
191
510
135
616
163
805
213
888
235 GPM
L/MIN990
262
1089
288
11451119
296 3033" 3"
(76.2mm) (76.2mm)
0.95*
0.25*
378
100
756
200
544
144
669
177
839
222
922
244 GPM
L/MIN990
262
1058
280
12471153
305 3302" 3"
(50.8mm) (76.2mm)
0.95*
0.25*
605
160
1111
294
896
230
990
262
1210
320
1308
346 GPM
L/MIN1402
371
1497
396
17091603
424 2524" 4"
(102mm) (102mm)
MAXIMUM FLOW CAPACITY
MODEL IN OUT
MINIMUMFLOWGPM
L/MIN
PSI
BAR
5 2010 15 25 30 35 40 45 50
0.3 1.40.7 1.0 1.7 2.1 2.4 2.8 3.1 3.4
PRESSURE DROP
NV-300-LF-2PS0.95*
0.25*
733
194
1444
382
1021
270
1232
326
1633
432
1777
470 GPM
L/MIN1977
523
2177
576
22912253
596 6066" 6"
(152mm) (152mm)
VALVE ASSEMBLIES ARE ASSE 1017 CERTIFIED
ALL VALVE ASSEMBLIES ARE 3RD PARTY CERTIFIEDTO BE LEAD FREE
VALVE ASSEMBLIES ARE cUPC CERTIFIED
NV-300-LF-3PS0.95*
0.25*
1100
291
2166
573
1531
405
1848
489
2415
639
2665
705 GPM
L/MIN2967
785
3266
864
34363353
887 9096" 6"
(152mm) (152mm)
*WHEN INSTALLED NEAR HOT WATER SOURCE AND WITHA PROPERLY SIZED, CONTINUOUSLY OPERATINGRECIRCULATION PUMP