DC Axial Fans...52 – DC fans with electronically commutated external rotor motor. Fully integrated...
4
52 – DC fans with electronically commutated external rotor motor. Fully integrated commutation electronics. With electronic protection against reverse polarity and blocking; electronic motor current limitation in the start-up phase and when rotor is blocked. – Metal fan housing, impeller of fibre-glass reinforced plastic PA. – Air exhaust over struts. Rotational direction CCW looking at rotor. – Electrical connection via 2 flat pins 3 x 0.5 mm. Housing with ground lug M4 for M4 x 8 screws. 48 V DC with screws. – Mass 820 g. – Optional Vario-Pro: Highly adaptable software configuration of the fan enables a tailor-made solution to the specific requirements of your applications. ebm-papst • St. Georgen DC Axial Fans Series 6200 N 172 Ø x 51 mm Nominal Voltage Air Flow Air Flow Voltage Range Noise Sintec-Sleeve Bearings Ball Bearings Power Input Nominal Speed Temperature Range Service Life L 10 at 40 °C Nominal Data at t max Curve Specials Type m 3 /h CFM V DC V DC dB(A) Bel / Watt min -1 °C Hours Hours P. 83-92 6212 NM 350 206.0 12 8...15 50 5.7 12.0 2 850 -20...+72 80 000 / 37 500 2 6224 NM 350 206.0 24 12...32 50 5.7 12.0 2 850 -20...+72 80 000 / 37 500 2 /12; VP 6224 N 410 241.3 24 12...28 55 6.1 18.0 3 400 -20...+72 75 000 / 35 000 3 /2; VP 6224 NH 480 282.5 24 12...28 61 6.9 26.0 4 000 -20...+55* 70 000 / 50 000 4 VP 6248NL 205 120.7 48 28...60 35 4.5 4.0 1 700 -20...+72 86 000 / 40 000 1 VP 6248 NM 350 206.0 48 28...60 50 5.7 11.5 2 850 -20...+72 80 000 / 37 500 2 VP 6248 N 410 241.3 48 28...60 55 6.1 17.0 3 400 -20...+72 75 000 / 35 000 3 /2;/12;VP 6248 NH 480 282.5 48 36...56 61 6.9 26.0 4 000 -20...+55* 70 000 / 50 000 4 VP 6224 NT 205 120.7 24 12...28 35 4.5 8.5 1 700 -10...+72 77 500 / 35 000 1 VP 410 241.3 55 6.1 18.0 3 400 4 6248 NT 205 120.7 48 28...60 35 4.5 8.5 1 700 -10...+72 77 500 / 35 000 1 /12; VP 410 241.3 55 6.1 17.0 3 400 Temperature sensor (NTC-resistor) for controlling the motor speed is positioned directly in the air flow. 30°C 50°C 30°C 50°C VARIOFAN100 * 72 °C upon request 0 50 100 150 200 250 100 200 25 50 100 125 150 p f 175 300 400 D m³/h Pa V • S S 75 CFM 2 1 3 4 0,5 0,6 0,4 0,3 0,2 0,1 (in H O) ² 0 40 80 120 160 200 100 25 50 p f 75 200 D m³/h Pa V • 100 125 150 300 S S 3 1 50°C 30°C CFM 0,5 0,4 0,3 0,2 0,1 (in H O) ² Barcelona • Telf. (+34) 93 462 08 19 • Fax. (+34) 93 462 07 88 www.servorecambios.com www.sr-electricmotors.com
Transcript of DC Axial Fans...52 – DC fans with electronically commutated external rotor motor. Fully integrated...
-
52
– DC fans with electronically commutated external rotor motor. Fully integrated commutationelectronics. With electronic protection against reverse polarity and blocking; electronic motor current limitation in the start-up phase and when rotor is blocked.
– Metal fan housing, impeller of fibre-glass reinforced plastic PA.– Air exhaust over struts. Rotational direction CCW looking at rotor.– Electrical connection via 2 flat pins 3 x 0.5 mm.
Housing with ground lug M4 for M4 x 8 screws. 48 V DC with screws.– Mass 820 g.– Optional Vario-Pro: Highly adaptable software configuration of the fan enables
a tailor-made solution to the specific requirements of your applications.
ebm-papst • St. Georgen
DC Axial FansSeries 6200 N 172 Ø x 51 mm
Nom
inal
Vol
tage
Air F
low
Air F
low
Volta
ge R
ange
Nois
e
Sint
ec-S
leev
e Be
arin
gsBa
ll Be
arin
gs
Pow
er In
put
Nom
inal
Spe
ed
Tem
pera
ture
Ran
ge
Serv
ice
Life
L10
at 4
0 °C
Nominal Data at t
max
Curv
e
Spec
ials
Type m3/h CFM V DC V DC dB(A) Bel / Watt min-1 °C Hours Hours P. 83-92
6212 NM 350 206.0 12 8...15 50 5.7 12.0 2 850 -20...+72 80 000 / 37 500 2
6224 NM 350 206.0 24 12...32 50 5.7 12.0 2 850 -20...+72 80 000 / 37 500 2 /12; VP
6224 N 410 241.3 24 12...28 55 6.1 18.0 3 400 -20...+72 75 000 / 35 000 3 /2; VP
6224 NH 480 282.5 24 12...28 61 6.9 26.0 4 000 -20...+55* 70 000 / 50 000 4 VP
6248NL 205 120.7 48 28...60 35 4.5 4.0 1 700 -20...+72 86 000 / 40 000 1 VP
6248 NM 350 206.0 48 28...60 50 5.7 11.5 2 850 -20...+72 80 000 / 37 500 2 VP
6248 N 410 241.3 48 28...60 55 6.1 17.0 3 400 -20...+72 75 000 / 35 000 3 /2;/12;VP
6248 NH 480 282.5 48 36...56 61 6.9 26.0 4 000 -20...+55* 70 000 / 50 000 4 VP
6224 NT205 120.7
24 12...2835 4.5 8.5 1 700
-10...+72 77 500 / 35 0001
VP410 241.3 55 6.1 18.0 3 400 4
6248 NT205 120.7
48 28...6035 4.5 8.5 1 700
-10...+72 77 500 / 35 0001
/12; VP410 241.3 55 6.1 17.0 3 400
Temperature sensor (NTC-resistor) for controllingthe motor speed is positioneddirectly in the air flow.
30°C
50°C
30°C
50°C
VARIOFAN100
* 72 °C upon request
0 50 100 150 200 250
100 200
25
50
100
125
150
pf
175
300 400
�
m³/h
Pa
V•
�
�
75
CFM
2
1
3
4
0,5
0,6
0,4
0,3
0,2
0,1
(in
HO
)²
0 40 80 120 160 200
100
25
50
pf
75
200
�
m³/h
Pa
V•
100
125
150
300�
�
3
1
50°C30°C
CFM
0,5
0,4
0,3
0,2
0,1
(in
HO
)²
Barcelona • Telf. (+34) 93 462 08 19 • Fax. (+34) 93 462 07 88
w w w . s e r v o r e c a m b i o s . c o mw w w . s r - e l e c t r i c m o t o r s . c o m
-
Nom
inal
Vol
tage
Air F
low
Air F
low
Volta
ge R
ange
Nois
e
Sint
ec-S
leev
e Be
arin
gsBa
ll Be
arin
gs
Pow
er In
put
Nom
inal
Spe
ed
Tem
pera
ture
Ran
ge
Serv
ice
Life
L10
at 4
0 °C
Nominal Data at t
max
Curv
e
Spec
ials
Type m3/h CFM V DC V DC dB(A) Bel / Watt min-1 °C Hours Hours P. 91
6224 NTD...90 53.0
24 16...2818 — 2.0 800
-20...+60 70 0001
TF600 353.1 65 7.4 50.0 5 100 2
6248 NTD...90 53.0
48 40...55*18 — 2.0 800
-20...+60 70 0001
TF600 353.1 65 7.4 50.0 5 100 2
Tech
nolo
gyDC
Axi
al F
ans
DC R
adia
l Fan
sAC
Rad
ial F
ans
Acce
ssor
ies
53
ebm-papst • St. Georgen
– Particularly powerful DC electronic fan with 3 phase EC drive and fully integrated operatingelectronics. For load-dependent speed control with highly intelligent motor management andpower and speed reserves which open up completely new areas of application.
– Metal fan housing, impeller of fibre-glass reinforced plastic PA.– Air exhaust over struts. CCW rotational direction looking at rotor.– Electrical connection via leads. Housing with ground lug M4 for M4 x 8 screws.
48 V DC with screws.– Mass 820 g.
DC Axial FansSeries 6200 NTD TURBOFAN 172 Ø x 51 mm
0 50 100 150 200 250 300 350
200 400
200
100
pf
300
400
300 500 600
�
�
�
m³/h
Pa
V•
100
nmin nmax1
2
CFM
1,2
0,8
0,4
(in
HO
)²
min
max
min
max
Type Version
– Fan with extended voltage range available on request.– Specific versions available on request.– Technical data are realizable benchmark figures.– Technical possibilities see Page 91.
6248 NTDI Temperature-controlled fan operation. NTC sensor integrated in fan6248 NTDT Temperature-controlled fan operation. NTC sensor externally connected to separate lead
NTDI and NTDT: Minimum speed 2550 min-1 with standard-NTC. Temperature range from 30...50°C6224 NTDA / 6248 NTDA Speed setting via control voltageNTDP Speed setting via PWM signal
Inte
llige
nt F
ans
AC A
xial
Fan
s
*
Barcelona • Telf. (+34) 93 462 08 19 • Fax. (+34) 93 462 07 88
w w w . s e r v o r e c a m b i o s . c o mw w w . s r - e l e c t r i c m o t o r s . c o m
-
54
– DC fans with electronically commutated external rotor motor. Fully integrated commutationelectronics. With electronic protection against reverse polarity and blocking; electronic motor current limitation in the start-up phase and when rotor is blocked.
– Metal fan housing, impeller of fibre-glass reinforced plastic PA.– Air exhaust over struts. Rotational direction CCW looking at rotor.– Optional Vario-Pro: Highly adaptable software configuration of the fan enables
a tailor-made solution to the specific requirements of your applications.– Electrical connection via leads AWG 22, TR 64. Stripped and tinned ends.
Housing with ground lug M4 for M4 x 8 screws. 48 V DC with screws.– Mass 820 g.
ebm-papst • St. Georgen
DC Diagonal FansSeries DV 6200 172 Ø x 51 mm
0 50 100 150 200 250 300 350
200 400
200
150
100
50
pf
250
300
350
300 500 600
�
�
�
m³/h
Pa
V•
100
CFM
1
1,2
1,0
0,8
0,6
0,4
0,2
(in
HO
)²
Nom
inal
Vol
tage
Air F
low
Air F
low
Volta
ge R
ange
Nois
e
Sint
ec-S
leev
e Be
arin
gsBa
ll Be
arin
gs
Pow
er In
put
Nom
inal
Spe
ed
Tem
pera
ture
Ran
ge
Serv
ice
Life
L10
at 4
0 °C
Nominal Data at t
max
Curv
e
Spec
ials
Type m3/h CFM V DC V DC dB(A) Bel / Watt min-1 °C Hours Hours P. 83-92
DV 6224 540 317.8 24 16...28 63 7.1 40.0 4 300 -20...+75 90 000 / 40 000 1 /2;/12;/17;/19;VP
DV 6248 540 317.8 48 28...60 63 7.1 40.0 4 300 -20...+75 90 000 / 40 000 1 /12; VP
Barcelona • Telf. (+34) 93 462 08 19 • Fax. (+34) 93 462 07 88
w w w . s e r v o r e c a m b i o s . c o mw w w . s r - e l e c t r i c m o t o r s . c o m
-
Type Version
– Fan with extended voltage range available on request.– Specific versions available on request.– Technical data are realizable benchmark figures.– Technical possibilities see Page 91.
DV6248 TDI Temperature-controlled fan operation. NTC sensor integrated in fanlead TDI: Minimum speed 2700 min-1 with standard-NTC. Temperature range from 30...50°C
DV6224 TDA / DV6248 TDA Speed setting via control voltageDV6224 TDP / DV6248 TDP Speed setting via PWM signal
Nom
inal
Vol
tage
Air F
low
Air F
low
Volta
ge R
ange
Nois
e
Sint
ec-S
leev
e Be
arin
gsBa
ll Be
arin
gs
Pow
er In
put
Nom
inal
Spe
ed
Tem
pera
ture
Ran
ge
Serv
ice
Life
L10
at 4
0 °C
Nominal Data at t
max
Curv
e
Spec
ials
Type m3/h CFM V DC V DC dB(A) Bel / Watt min-1 °C Hours Hours P. 91
DV 6248 TD 700 412.0 48 40...55 69 7.8 86.0 5500 -20...+60 65 000 2 TF
DV 6224 TD...100 58.9
24 16...3629 — 2.0 800
-20...+60 65 0001
TF700 412.0 69 7.8 86.0 5 500 2
DV 6248 TD...100 58.9
48 40...55*29 — 2.0 800
-20...+60 65 0001
TF700 412.0 69 7.8 86.0 5 500 2
Tech
nolo
gyDC
Axi
al F
ans
DC R
adia
l Fan
sIn
telli
gent
Fan
sAC
Axi
al F
ans
AC R
adia
l Fan
sAc
cess
orie
s
55
ebm-papst • St. Georgen
– Particularly powerful DC electronic fan with 3 phase EC drive and fully integrated operatingelectronics. For load-dependent speed control with highly intelligent motor management and power and speed reserves which open up completely new areas of application.
– Metal fan housing, impeller of fibre-glass reinforced plastic PA.– Air exhaust over struts. CCW rotational direction looking at rotor.– Electrical connection via leads. AWG 22, TR 64. Stripped and tinned ends.
Housing with ground lug M4 for M4 x 8 screws. 48 V DC with screws.– Mass 820 g.– Diagonal fan with compression-proof curve and low noise level.
DC Diagonal FansSeries DV 6200 TD TURBOFAN 172 Ø x 51 mm
0 70 140 210 280 350
200100 300
100
300
pf
400
400 500
�
m³/h
Pa
V•
1
2
�
�
200
600
nmin nmax
CFM
1,6
1,2
0,8
0,4
(in
HO
)²
min
max
min
max
*
Barcelona • Telf. (+34) 93 462 08 19 • Fax. (+34) 93 462 07 88
w w w . s e r v o r e c a m b i o s . c o mw w w . s r - e l e c t r i c m o t o r s . c o m
