Cultivation Of Patchouli, NHB
-
Upload
kisan-forum-pvt-ltd -
Category
Documents
-
view
265 -
download
8
description
Transcript of Cultivation Of Patchouli, NHB
PatchouliArea Under Cultivation
It is cultivated in Bangalore and coastal areas of South India, Bengal and Assam.
Botanical Name : Pogostemon patchouli
Family : Lamiaceae
Plant Discription : It is a branched,erect or ascending pubscent herb or undershrub with quadrangular stem about 1
to 1.2 m tall.The leaves are simple,ovate to oblong ovate, pale to purplish green in colour. It does
not flower under cultivation.
Centre of Origin : Phillipines
Pollination System : Self pollinated
Chromosome No. : 2n=32
PatchouliDiseases
Leaf Blight (Cercospora sp)
Mostly when the plants are almost one year old brown spots are formed near the margin or at the apical
region, which enlarge irregularly, coalesce, cover the entire lamina and create drying. It is, however,
not of common occurrence and less serious as compared to root-knot.
Control : The disease can be controlled with two sprays of Dithane Z-78 0.5%, at one-month interval.
This, however, depends upon the severity of the disease.
PatchouliHarvesting
The first harvest of the crop is taken about 5 months after transplanting. The stage at which crop has to
be harvested is very important for good yield and better quality of oil. It has to be harvested when the
foliage becomes pale green to light brownish and when the stand emits characteristic patchouli odour,
which could be easily smelt by a passer-by, especially in the morning hours. Subsequent harvest can
be taken after every 3-4 months depending upon the local conditions and management practices. The
crop can be maintained for about 3 years. The first 2 or 3 harvests of newly planted plantation give good
yield and high quality oil. Harvesting is done with the help of small sharp shear or secateur. Usually the
length of the harvested portion ranges from 40-60 cm. It is necessary to leave 4-6 juvenile sprouting
buds at the basal region for fast regeneration, while harvesting. The crop should not be harvested
prematurely as it gives less yield and oil of inferior quality.
Yield :The oil is found mainly in the leaf and small quantity is present in the ender parts of the stem. The yield
of fresh leaves/ha/year from three harvests is about 8,000kg which on shade drying reduces to 1600kg
and on distillation yields about 40kg of oil. The yield of oil varies from 2.5 to 3.5% on shade dry basis of
the leaves and an average yield of 2.5% may be considered satisfactory in commercial distillations.
Uses :The oil of patchouli is used so extensively it is very difficult to specify its field of application. It blends
well with sandalwood, germanium, vetiver, ionones, cedar wood derivatives, clove oil, lavender,
bergamot and many others. The oil is almost a perfume by itself. It is widely used in soap, cosmetic,
tobacco and incense. The oil gives one of the finest attars when blended with sandalwood oil. The oil
possesses antibacterial activity and it is used as an ingredient in insect repellant preparations. The
leaves and tops are added in bath for their anti-rheumatic action. It is also used as a masking agent for
alcoholic breath. Tenacity of odour is one of the virtues of patchouli oil and is one of the reasons for its
versatility.
PatchouliManuring & Fertilization
Patchouli requires rich soil in order to obtain proper yield and better quality of oil. Normally, a basal
dose of 25 kg N, 50 kg P O and 50 kg K O per hectare is given in the form of Urea, 2 5 2
Superphosphate and Muriate of potash. After about two months, 25 kg N as urea is applied.
Likewise, for each harvest 50 kg N is applied in two split doses, the first dose just after the harvest
and the other about two months later. In total, 150 kg N per hectare per year is applied to the crop.
PatchouliIrrigation
For getting good yield of the crop, the area should receive good and evenly distributed rainfall, because
it does not do well under rainfed conditions. Immediately after transplanting the field must be irrigated
every day for the first 3 to 4 days and subsequently on alternate days for 10 to 15 days. After three
weeks irrigation once or twice a week depending on the type of soil and climate is considered sufficient.
The crop is highly susceptible to water logging.
PatchouliIntercultural Operations
The field should be kept weed-free during the first 2 to 3 months of crop growth either by hoeing 2
to 3 times or by hand weeding. Weeding is also necessary after about a month of each of the
foliage harvests.
PatchouliPests
Root-knot Nematode (Meloidogyne Incognita)
The nematode is an obligate parasite which enters into the root by thrust with the mouth spear, usually
in the region of cell elongation or at the base of lateral roots. They reach cortex, multiply and cause
galling which is commonly called as root-knot. The diameter of the knots varies from 0.2 cm to 5.0 cm.
Heavily infected plants show stunting of top growth and wilting. Initially it will be difficult to differentiate
between the infested and healthy plants. Typical symptoms of an infested plant become apparent only
after 8 months. In case of severe attack the crop dwindles and the whole stand may perish during the
next 2 or 3 months.
The plot should be treated with a proper nematicide. Furadan @ 20 kg / ha (3% a.i.) or Dasanit 150 kg
/ha (5% a.i.) are found to be very effective. First dose of the nematicide should be given as a pre-
planting treatment and the second dose can be given one year after transplanting as pocket
application to the plants. In order to get a good crop of patchouli in nematode-infested soil, it is
desirable to take a crop of citronella or other nematode-resistant crop for next few years before planting
patchouli.
Nursery should be raised from healthy mother stock under nematode-free conditions. Application of
farmyard manure should be avoided
PatchouliPost Harvest Technology
Drying
The harvested material is spread out under shade in thin layers and is turned periodically to ensure
proper drying. For higher recovery and good quality of oil, moisture content of herbage should be
between 2.5 and 8.3%. Drying normally requires 3-6 days. It, however, depends much on available
sunshine and atmospheric humidity. Properly dried leaves develop characteristic patchouli aroma,
which is less noticeable in fresh leaves.
Distillation
Shade-dried leaves of patchouli are subjected to steam distillation for obtaining the oil of patchouli.
The dried herb could be immediately distilled or could be stored for sometime according to
convenience. Proper dried leaves produce good oil yield and better quality of oil.
The distillation equipment needed for distilling the oil consists of boiler, distillation still, condenser and
receiver.
The distillation still is generally made up of mild steel. It has a perforated metal sheet at the bottom to
support the herb, which is loaded into the still for distillation. Loading and unloading can be
mechanised with the help of an over-head chain-pulley block. The lid of the still can be swung aside
during loading and unloading. It is important that the herb should be evenly packed inside the still as
otherwise steam channels may form during the distillation resulting in poor yield.
The condenser, which cools the hot vapours, received form the still consists of many tubes made up of
copper or stainless steel and mounted inside a jacket. The condenser is provided with inlet and outlet
for the circulation of cooling water. The hot vapours consisting of steam and essential oil vapours are
cooled in the condenser tubes and the condensate then flows out into the receiver. The oil being lighter
than water and insoluble floats on the receiver and only the water gets drained out. The oil can be
drawn off separately at the end of the distillation.
The receiver id fabricated out of stainless steel and consists preferably of two compartments, so that
the oil escaping from the first compartment can be retained in the adjoining compartment, which of
course rarely happens.
The process of distillation consists of loading the dried leaves into the still, closing the lid securely,
letting in steam (generated in a boiler) from the bottom of the still, condensing the vapours I the
condensor and collecting the oil in the receiver. It has been noted that interchange of high and low
pressures, i.e., 1.4 to 3.5 kg/sq. cm produces better yield as more cell walls rupture in this process. The
duration of the distillation varies from 6-8 hours. Prolonged distillation gives higher yield and better
quality of oil. But if it is distilled for to long, the oil will have disagreeable odour.
Patchouli resinoid is also prepared occasionally by extracting the have with volatile solvents such as
benzene. Such extraction gives 4.5 to 5.8% of resinoid, which contains 70-80% of alcohol-soluble
absolute.
PatchouliPlanting
Land Preparation
The main field for transplanting is thoroughly disced and tilled. Suitable nematicide, viz., Furadan @20
kg/ha.(active ingredient 30%) or Dasanit @ 150 kg/ha (active ingredient 5%) is broadcast and mixed
well into the soil a few days before transplanting. The plot is then laid out in ridges and furrows. The
ridge should be 20-25 cm high and 18-22 cm broad with 60 cm row to row distance. The beds should be
irrigated a day before the transplantation.
Shading
Patchouli is a shade loving plant. It is felt that patchouli could be tried under coconut in India. It could
also be taken up with some suitable crops that provide adequate shade. Gliricidia or Erythrina could be
planted well in advance at 5 X 5 m spacing in patchouli field in order to provide the necessary shade.
Method of Planting
Rooted cuttings are transplanted generally in the evening in the main field. The planting is done at 60 x
60 cm apart. Normally 28,000 cuttings will be required per hectare. Irrigate the field immediately after
transplantation. Planting of 15-20 cm long unrooted cuttings is also practiced in some areas. These
cuttings are planted at the rate of 2 to 3 cuttings per hill. During early stages shade and sufficient
moisture are most important requirements. Shade can be removed after the plants establish well.
PatchouliPropagation
Raising Seedlings in Nursery
Patchouli is propagated vegetatively. Since the crop is highly susceptible to nematode attack, it is
advisable to adopt phytosanitary measures from nursery stage itself.
Seed pans or polythene bags are filled with well-heated sand, which can be made by passing steam
through it for about one hour. If this is not practicable for a grower, the sand should be treated with
suitable nematicide like Furadan @ 20 kg/ha (active ingredient 3%). Dasanit @150 kg/ha (active
ingredient 5%) is also very effective.
Nursery that has to be under shade could be raised at any time during the year. Cuttings are prepared
preferably in the morning or in the evening to minimise desiccation. Cuttings are taken from healthy
stock and as far as possible from the apical region. Cuttings from fairly developed branches, 4-5 nodes
in length and with a crown of 2-3 leaves, are ideal for planting in nursery. The basal end of the cutting
should be neatly cut in oblique form just about 1 cm below the node. Application of a commercial
hormone like Seradix B-2 to the basal end of the cutting encourages early rooting. The cuttings should
then be planted in seed pans, nursery beds or in polythene bags with the help of a suitable dibbler at a
spacing of about 5 cm. Aeration, partial shade and regular watering are essential for early rooting. The
cuttings take about 30-35 days for rooting in nursery.
PatchouliSoil & Climate
Soil
Patchouli is a hardy plant and adapts itself to a wide range of soil conditions. However, it flourishes best
in loose deep loamy soils, rich in humus and nutrients, with a loose friable texture and without
impervious layer at the bottom. The pH of the soil from 5.5 to 6.2 is considered to be ideal. The plant
flourishes in low altitudes and foothills over slightly moist, well-drained soils in tropical and subtropical
conditions. It is also observes that the richest soil produces the best leaf material which gives better
yield and better quality oil.
Climate
Patchouli grows successfully upto an altitude of 800-1000m above the sea level. It prefers a warm
and humid climate. The crop can be grown successfully on a fairly heavy and evenly distributed
rainfall ranging from 1500-3000mm per annum. It is also observed that the moderate temperature
of 22-28°C and an average humidity of 75% have been found to be ideal for its growth.