Complete Cryogenic Services, Inc. [email protected] [email protected].
-
Upload
norah-morgan -
Category
Documents
-
view
220 -
download
1
Transcript of Complete Cryogenic Services, Inc. [email protected] [email protected].
Complete Cryogenic Complete Cryogenic Services, Inc.Services, Inc.
Occasionally a low temperature storage tank must be removed from service for repair or upgrade. If the tank is equipped with column mounted (in-tank) pumps the last 250mm of liquid can not be pumped out. Waiting for the remainder to boil away results in unacceptable delays to project schedule.
BACKGROUNDBACKGROUNDCCS
PROBLEMPROBLEM
Most in-Tank pumps can not pump the liquid level below 250 mm.
When the tank is removed from service up to six weeks may be required for the remaining liquid to boil away
300 mmremaining
CCS
CCS TPOP (Patent Pending) will fit through any tank opening 6” or larger. The pump rests on tank floor and will pump liquid level down to 35 mm or less.
SOLUTIONSOLUTIONCCS
25 -30 mmremaining
LNGLPGLEG
SOLUTIONSOLUTION
CCS Temporary Pumpout Pump (TPOP)
CCS
TPOPAdaptor
CCS
Pum
p
TPOPAdaptor
CCS
Pum
p
Power cables
Ball valve
Insertion tube
TPOPAdaptor
Seal Disk with O-Ring (2 on each section)
O-Ring Seal
10 F
eet 1.5” Discharge Pipe
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
CCS
Pum
p
FlangeConnection
CCS
Pum
p
CCS
CCS
LNGLEGLPG
Junction Box
Electrical Seal
Pressure Gage
Control Valve
Gland Seal
Headplate
CCS
Advantages of TPOP (Patent Pending)
1. No special tank penetration required. TPOP will fit through any existing nozzle 6” or larger. The nozzle must have an unobstructed path to the tank floor.
3. There are no leaks to atmosphere during installation or removal of TPOP.
4. A special tank top crane is not required, TPOP can be installed with a chain hoist.
5. TPOP is supplied with appropriate connections to customers piping system.
6. This system can be installed in one day.
7. Uses any electric voltage less than 600 volts, 50/60 Hz.
8. Faster delivery than conventional pump systems.
9. Economical.
10. Lease or purchase option.
2. Pump rated at 15 m3/hr @ 110 m.
CCS
QuickTime™ and aTIFF (LZW) decompressor
are needed to see this picture.
Henry A. Smith IIIHenry A. Smith III PresidentPresident
Patrick N. DavisPatrick N. Davis Vice PresidentVice President
CCS