Cleaning and Maintenance Manual Compact Combi Oven...Cleaning and Maintenance Manual Compact Combi...

Rev: A - 02/02/2018

Model:CCO.KOM.KH101TW / CCO.KOM.KH061TW / CCO.KOM.KH0623TWCCO.KOM. KT101TW / CCO.KOM. KT061TW / CCO.KOM.KT0623TW

Cleaning and Maintenance Manual

Compact Combi Oven

Due to continuous product research and development,the information contained herein is subject to change without notice.

Page 1 www.stoddart.com.au

InformationCleaning - Important Information � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 2

General InformationSafety InformationCleaning and Maintenance Schedule

MaintenanceControl Panel � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 3

Basic User Interface FunctionsOperation � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 4

Technical Compartment Ventilation FilterMoisture DrainCleaning Glass

Wash Program - Automatic Cleaning � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 5Boiler Descaling (For Models KH��Only) � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 6Water Filtration � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 7

BWT Filter CartridgeReverse Osmosis Filter Cartridges

Order FormOrder Form � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 8


Page 2www.stoddart.com.au

IMPORTANT!Read through the User Manual before performing

any cleaning or maintenance procedures.

Information

Cleaning - Important Information

General Information• The Culinaire Kompatto oven comes standard with an automatic cleaning function, this should be used frequently before soil build up

occurs� Before running this automatic cycle, ensure that the cleaning fluid levels are at a sufficient level�• Visual inspections of the oven should be done while performing cleaning operations� Check for any soil build up, damage, loose or

removed parts or signs of scale�• Cleaning is recommended for health and safety purposes and to prolong the life of the unit• Do NOT use abrasive pads or cleaners on the stainless steel or any other metal parts of the unit• Do NOT use industrial chemical cleaners, caustic based cleaners or bleaches and bleaching agents, many will damage the metals and

plastics used on this unit• When drying, metal surfaces should be wiped with a soft cloth in the same direction as grained polish• Do NOT remove any screws for cleaning� All internal sections of the unit are to be cleaned by a qualified technician• This unit is NOT waterproof, do NOT hose, do NOT pour water directly onto the unit• Boiler descale is for Kompatto boiler Models� It should be performed as frequently as required and at least every 6 months�• Water filtration is critical� Filter cartridges MUST be replaced periodically� Failure to do so will void your warranty� (Frequency will

depend on your water quality and type of filtration system, see page 9)�• Ensure temperature probe is placed in the holder� Be careful not to damage probe during cleaning, maintenance and normal operation�

WARNING!Wait until the unit has cooled to a safe temperature before undertaking any cleaning or maintenance. Contact with hot surfaces can cause burns and

serious injury.DO NOT USE WATER TO COOL THE UNIT DOWN!

• Check all work cleaning and maintenance practices comply with industry safety standards�

Task Schedule

Daily Cleaning To be performed Daily at end of shift Descale To be performed a minimum of every six months or more frequently if required. The oven will alert you if

descale is required more frequently. This can be performed with the scheduled programmed maintenance.Replace Water Filtration Cartridges

To be performed a minimum of every six months (every twelve months for the Reverse Osmosis Membrane) or more frequently if required. The frequency of filter changes will depend on your water quality and filtration system.This can be performed with the scheduled programmed maintenance.

Safety Information

WARNING!Wear appropriate Personal Protective Equipment

and clothing when using cleaning chemicals.Contact with chemical can cause

burns and serious injury.

Cleaning and Maintenance Schedule



Control Panel

Basic User Interface Functions

T1

T1

Start-up and Shutdown: Press for three seconds to turn the oven on/off

T2

T2

Start/Stop Function key: Start and Stop the cooking cycle� This function can be:On: cooking in progress;Off: cooking not in progress or stopped;Flashing: cooking is in waiting state (door open, error messages or confirmation of operations)

T3

T3

Return key: Return to the previous page

T4

T4

Menu Function key: Return to the main menu

T5

T5

Oven Chamber Light Function key: Turns the oven chamber light on/off

T6

T6

Touch Screen: The operating parameters of the appliance are set and displayed on this screen

T7

T7

Dial With Encoder: The dial is used to set the values on the screen� If the dial is pressed, the value entered is confirmed

Fig� 1�

Note: The below function key reference numbers (T1, T2 etc) are used throughout this user manual� Refer back to this page for reference�

Maintenance



Technical Compartment Ventilation Filter

Moisture Drain

In order to keep the electronic components of the oven at a safety temperature, the ventilation filter should be cleaned periodically, at least once a month�The filter is located on the rear side of the oven “A” (Fig�2)�Proceed as follows:Holding the filter tab “C” (Fig�2), slide the filter upward to remove� Wash using with warm soapy water, dry with a clean cloth�

Moisture drain “B” (Fig�2) ejects the vapours produced inside the oven chamber�Check that it is clean and free from obstructions�

Important!If the oven enters Hi Temp alarm state, the most probable

cause is an excessive dirt accumulation on the filter. Clean the filter immediately

Fig� 2�

Cleaning Glass

The door window can be cleaned either on the outside and on the inside� Turn the latch that locks the internal window (Fig� 3), once opened clean with warm soapy water and a clean cloth� Never use abrasive materials� The glass should then be closed properly and locked in place by turning the latch�

Fig� 3�

Operation

Maintenance



Wash Program - Automatic CleaningThe wash program can be accessed by entering the Service menu from the main menu�

Select the cleaning option from the menu (Fig� 4) by pressing the dial T7� Next select the type of wash program (Fig� 5) based on how dirty is the inside of the oven� Press Start T2 to start the cleaning program�

At this point the program prompts “Bottle Change? YES/NO”� This feature allows the user to choose the amount of detergent to be loaded from the tank, depending on if the cleaner hose is full or empty; consequently it will vary the suction time of the first dose of detergent�

When “SOFT” wash is selected before “Bottle Change”, the program prompts “Make Dry? YES/NO” (unlike the HARD AND NORMAL washings, this feature is optional)�

In addition the RINSE function can also be selected from the menu (Fig� 5), press the START button to activate� This function does not use detergent (water only) the duration is 8 minutes�

Note: Before starting the wash program, verify that the detergent pipe is completely immersed in the detergent container and that there is a sufficient amount of product inside�

Note: in the case the oven chamber temperature is higher than 150°C, the oven automatically defaults to the cooling cycle for the oven chamber (refer to user manual pg 23)�Run the cooling mode and then restart the cleaning cycle�

Important!Do not open the door of the oven during

cleaning cycle

Fig� 4�

Fig� 5�

Fig� 6�

Maintenance



Boiler Descaling (For Models KH..Only)Ovens equipped with high performance boilers (model KH) should be descaled periodically to keep the boiler efficient and reduce the risk of damage�

Perform descaling by accessing the Service menu� Use the dial T7 to select the option Descaling (Fig� 7) and press Start T2�

The oven will start to empty the boiler, the operator will be prompted to introduce 400ml of vinegar through the steam inlet of the oven chamber (upper left inside wall) using a squeeze bottle (Fig� 8)�

Descaling will start automatically� The oven will shut down on completion�

Fig� 7�

Fig� 8�

Maintenance



Water Filtration

1� Turn off water supply at the isolation tap�2� Remove the old filter cartridge (unscrew clockwise)�3� Before installing the replacement filter cartridge, mark the installation

date and the replacement date (no later than 6 months) on the filter’s rating plate� Diarise the replacement date as a reminder�

4� Install new filter cartridge (screw in anti-clockwise)� To order new cartridge see �

5� Turn on the water supply�6� Flush/bleed the new cartridge by pressing the “Bleed Button” for a

minimum of 60 seconds (located on the top of the filter head)�

• Filter to be changed a minimum of every 6 months, or more frequently in areas with poor water quality�

• A reverse osmosis filter is required in areas where the water has high chlorides or other corrosive minerals present� Where appropriate, this system should have been recommended by your supplier at the time of your oven purchase�

• Filters 1, 2 and 3 to be changed a minimum of every 6 months, or more frequently in areas with poor water quality�

• Filter 4 to be changed a minimum of every 12 months, or more frequently in areas with poor water quality�

• Indicative minimum replacement frequency:

Old CartridgeNew Cartridge

BWT Filter Cartridge

Bleed Button

• Water filtration is critical to the performance of your oven� Users must establish a regular filter replacement schedule� Required frequency will depend on your water quality and type of filtration system�

• Filter change frequencies below are indicative minimums� If your water quality is poor, you may need to replace the filter more frequently�• Indicators that your filter may require changing are:

- Surface corrosion present in the oven cavity� Contact Stoddart for advice at 1300 307 289�- Scale building up more frequently than normal�- Oven starving for water creating error messages�

123

3 2 1

4

4

123

3 2 1

4

4

Reverse Osmosis Filter Cartridges

1� Turn off water supply at the isolation tap�2� Remove the old filter cartridge (unscrew clockwise) until it stops� Pull the

cartridge down to remove the cartridge�3� Repeat steps 2 on the remaining cartridges�4� All cartridges are labelled with a number on the top left hand corner�

Use the correct numbered cartridge for the replacement� To order replacement cartridge see Page 8�

5� Before installing the replacement filter cartridge, mark the installation date and the replacement date (no later than 6 months for filter 1, 2 and 3, no later than 12 months for filter 4) on the filter’s rating plate� Diarise the replacement date as a reminder�

6� Insert and turn anti-clockwise until the cartridge stops�7� Once all cartridge have been replaced turn on the water supply�

Old Cartridge

New Cartridge

1 - Sediment and Dirt Particles Removal Cartridge 6 months

2 - Chlorine, Taste/Odour Reduction Cartridge 6 months

3 - Reverse Osmosis Membrane Cartridge 12 months

Maintenance



Name of Business

Name of Contact

Street Address

Suburb State Postcode

Phone Email

SDS sheets will be provided with each delivery.

Code Description QTY.Required

CNCL.0105 Combi Foam Oven Cleaner - 5 Litre

KOM.SMOKER Digital Smoker

CCO.6000115 Sous Vide Probe

CCO.2026459 Air Vent Extension Kit

SPEL.LB970118Wall Mount Basket

(Combi Foam Oven Cleaner - 5 Litre)

Order formScan/Copy - Complete - Email to: [email protected]

or Contact 1300 307 289

SPAR.XSE.AX10-CCF Sediment and Dirt Particles Removal Cartridge

SPAR.XSE.AX10-GAC Chlorine, Taste/Odour Reduction Cartridge

SPAR.XSE.AX10-ROM Reverse Osmosis Membrane

SPAR.XSE.AX10-WS Water Stabiliser

F5300N00A00 BWT Best Protect 2XL Filter Cartridge

Order Form

Order Form

Stoddart SalesServicing and Replacement

Sales DepartmentTel: 1300 79 1954

Fax: (07) 3344 1000Email: fseorders@stoddart�com�au

Service & Spares Department Tel: 1300 307 289

Email: service@stoddart�com�auEmail: spares@stoddart�com�au

WaterMarkAS WMTS-101

Lic: WM-022773

Cleaning and Maintenance Manual Compact Combi Oven...Cleaning and Maintenance Manual Compact Combi...

Documents

Transcript of Cleaning and Maintenance Manual Compact Combi Oven...Cleaning and Maintenance Manual Compact Combi...