Chemical Wedn 83 Am Handout
-
Upload
david-monroy-valdivia -
Category
Documents
-
view
10 -
download
0
description
Transcript of Chemical Wedn 83 Am Handout
![Page 1: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/1.jpg)
NFPA 400 Hazardous Materials Code
NANCY PEARCE CIH
SENIOR F IRE PROTECTION ENGINEER
NATIONAL F IRE PROTECTION ASSOCIATION
![Page 2: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/2.jpg)
OSHA Comparison to NFPA
OSHA focus solely on worker protection
◦ Few limits established for storage of hazardous materials◦ Few construction requirements for hazardous materials storage
NFPA focus on fire safety-protection of property and worker
◦ Prevention focus◦ Addresses limits above which special construction and other requirements apply◦ Construction requirements
![Page 3: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/3.jpg)
Hazardous Materials Storage Handling and Use under OSHA
1910.106 Flammable Liquids
1910.119 Process Safety Management-prevent releases of toxic, reactive, flammable, or explosive chemicals
1910.1200 Hazard Communication-information about hazards, safe handling, storage and use, incompatibilities, PPE etc.
1910.120 Hazardous Waste Operations and Emergency Response
![Page 4: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/4.jpg)
NFPA 400 Purpose
Provide fundamental safeguards for the storage, use, and handling of hazardous materials in all occupancies and facilities.
(1) Ammonium nitrate solids and liquids
(2) Corrosive solids and liquids
(3) Flammable solids
(4) Organic peroxide formulations
(5) Oxidizer — solids and liquids
(6) Pyrophoric solids and liquids
(7) Toxic and highly toxic solids and liquids
(8) Unstable (reactive) solids and liquids
(9) Water-reactive solids and liquids
(10) Compressed gases and cryogenic fluids (NFPA 55)
![Page 5: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/5.jpg)
NFPA Codes and Standards
Currently ~ 300 codes and standards published by NFPA including the Life Safety Code and the National Electrical Code
Codes and Standards are “consensus” and are developed by a committee composed of various backgrounds and interest
Virtually every building, process, service, design, and installation in society today is affected by NFPA documents
NFPA is NOT an enforcement agency
Codes and standards adopted by States, Towns, Federal agencies are then enforced by those entities
4/14/2015
![Page 6: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/6.jpg)
Who enforces NFPA 400?
~ Half the states adopt NFPA 1 Fire Code
NFPA 1 incorporates NFPA 400 as part of code requirement
Typically enforced by State fire marshal and/or local fire department
IFC has similar concept of MAQ
2015 edition of IFC incorporates NFPA 400 requirements for Ammonium nitrate
![Page 7: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/7.jpg)
NFPA 400 ScopeStorage, handling, use of Hazardous Materials
Ammonium nitrate
Corrosive materials
Flammable solids
Organic peroxide formulations
Solid and liquid oxidizers
Pyrophoric materials
Toxic and highly toxic solids and liquids
Unstable (reactive) solids and liquids
Water-reactive solids and liquids
Compressed gases and cryogenic fluids as defined by NFPA 55, Compressed Gases and Cryogenic Fluids Code
![Page 8: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/8.jpg)
Other NFPA Hazardous Materials Codes that address storage, use and handling include:
NFPA 30 Flammable and Combustible Liquids
NFPA 30B Aerosol Products
Combustible Dusts◦ NFPA 484 Metals
◦ NFPA 654 Dusts
◦ NFPA 664 Wood
NFPA 495 Explosives
LP Gases◦ NFPA 58
◦ NFPA 59
![Page 9: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/9.jpg)
Chapters in NFPA 400
Chapter 1 – Scope, purpose, application
Chapter 2 – References
Chapter 3 – Definitions
Chapter 4 – Classification
Chapter 5 – Permissible storage and use (MAQ Tables)
Chapter 6 – Fundamental requirements
Chapter 7- Emergency
Chapter 8-Reserved
Chapter 9-Security
Chapter 10-Performance based option
Chapter 11 Ammonium Nitrate
Chapter 12 Corrosives
Chapter 13 Flammable Solids
Chapter 14 Organic Peroxides
Chapter 15 Oxidizers
Chapter 16 Reserved
Chapter 17 Pyrophorics
Chapter 18 Toxics
Chapter 19 Unstable Reactives
Chapter 20 Water Reactives
Chapter 21 Compressed Gases
9
![Page 10: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/10.jpg)
NFPA 400
Classifies the hazardous material
Provides you with the maximum amount (MAQ) that should be stored in a particular occupancy before requiring special construction requirements.
Provides methods for increasing amounts by using special protections such as sprinklers or special storage requirements.
Provides storage use and handling requirements for all covered materials.
![Page 11: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/11.jpg)
Key Definitions and Conceptsused in NFPA 400
Classification
Maximum Allowable Quantity (MAQ)
Control area
Protection level
![Page 12: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/12.jpg)
12
Classify hazardous material
Determine quantity to be used or stored
Quantity exceeds MAQ?
Apply provisions for protection
levels
Apply provisions for multiplecontrol areas
No special construction
featuresrequired
Orgate
YES NO
![Page 13: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/13.jpg)
Step One-Classify the MaterialExample-Unstable Reactives
3.3.61.10.1* Class 1 Unstable (Reactive). Materials that in themselves are normally stable, but that can become unstable at elevated temperatures and pressures.
3.3.61.10.2* Class 2 Unstable (Reactive). Materials that readily undergo violent chemical change at elevated temperatures and pressures.
3.3.61.10.3* Class 3 Unstable (Reactive). Materials that in themselves are capable of detonation or explosive decomposition or explosive reaction, but that require a strong initiating source or that must be heated under confinement before initiation.
3.3.61.10.4* Class 4 Unstable (Reactive). Materials that in themselves are readily capable of detonation or explosive decomposition or explosive reaction at normal temperatures and pressures.
![Page 14: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/14.jpg)
Where Do I get the information Needed to Classify a Material?
Review Permits, SDS, Annex of NFPA 400 etc.
![Page 15: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/15.jpg)
15
Classify hazardous material
Determine quantity to be used or stored
Quantity exceeds MAQ?
Apply provisions for protection
levels
Apply provisions for multiplecontrol areas
No special construction
featuresrequired
Orgate
YES NO
![Page 16: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/16.jpg)
Step Two- Determine the MAQ
Allowable amounts per control area are dependent on the occupancy
Determine occupancy and go to MAQ table for that occupancy to see if amount exceeds the MAQ
Note the MAQ can be increase depending on a number of factors not including but not limited to
◦ Sprinkler protection (allows doubling)
◦ Storage in approved cabinets, safety cans etc (allows doubling)
![Page 17: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/17.jpg)
Maximum Allowable Quantity(MAQ) Concept
THRESHOLD above which you must have special construction (PROTECTION LEVEL) and follow the material specific chapters in NFPA 400.
MAQs are dependent on the type of occupancy
Not maximums-Can be exceeded just need to follow additional requirements
◦ MAQs are given per CONTROL AREA-Can have multiple control areas
![Page 18: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/18.jpg)
![Page 19: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/19.jpg)
19
Classify hazardous material
Determine quantity to be used or stored
Quantity exceeds MAQ?
Apply provisions for protection
levels
Apply provisions for multiplecontrol areas
No special construction
featuresrequired
Orgate
YES NO
![Page 20: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/20.jpg)
Step Three-Determine if above or below the MAQ
If below MAQ per control area no further requirements in material specific chapters just the general requirements in chapters 6-9 apply
If above MAQ per control area then must use special construction- Protection Levels 1-5 and the material specific chapters apply
![Page 21: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/21.jpg)
Control Area
A building or portion of a building or outdoor area within which hazardous materials are allowed to be stored, dispensed, used, or handled in quantities not exceeding the maximum allowable quantities (MAQ).
Can have multiple control areas up to a maximum depending on the floor level and fire resistance
Control Areas are separated by particular fire resistance-1-2 hours (includes floors, walls to completely separate from other areas)
![Page 22: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/22.jpg)
Number of Control Areas
Lower than 2 levels below grade is not allowed
![Page 23: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/23.jpg)
Control Areas Flammable
Solid Storage =
MAQ is 125 lb.
Sprinkler
Protection
Provided =
Footnote D
allows a 100%
increase
![Page 24: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/24.jpg)
Outdoor Control Areas
Outdoor control areas allow for greater storage amounts
More than one outdoor control area allowed depending on size of property.
◦ 10,000 ft2 property- 2 separated by 50 feet
◦ 35,000 ft2 separated by 300 feet
![Page 25: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/25.jpg)
25
Classify hazardous material
Determine quantity to be used or stored
Quantity exceeds MAQ?
Apply provisions for protection
levels
Apply provisions for multiplecontrol areas
No special construction
featuresrequired
Orgate
YES NO
![Page 26: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/26.jpg)
Protection Level
Protection Level describes a tier of building safety that exceeds the construction requirements for control areas
◦ The MAQ is able to be exceeded due to the increased protective measures associated with the Protection Level provisions imposed
◦ The Protection Level required is dependent on the Hazard Level of the contents
◦ Protection Level construction allows you to exceed the MAQ
![Page 27: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/27.jpg)
NFPA 400
Classifies the hazardous material
Provides you with the maximum amount (MAQ) that should be stored in a particular occupancy before requiring special construction requirements.
Provides methods for increasing amounts by using special protections such as sprinklers or special storage requirements.
Provides storage use and handling requirements for all covered materials.
![Page 28: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/28.jpg)
NFPA 400 Quantity Requirements In a Nutshell
Keep amounts below the (MAQ) per control
OR
Construct to appropriate Protection Level and follow the material specific chapters
![Page 29: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/29.jpg)
Other Requirements in NFPA 400 for Hazardous Material-Chapters 6-9
Fundamental requirements that apply to all hazardous materials include:
◦ Haz-Mat releases
◦ Personnel training
◦ Ignition source controls
◦ Equipment and processes, tanks etc
◦ Shelf construction
◦ Separation of incompatibles
Additional requirements when above MAQ
◦ Fire Protection Systems
◦ Egress
◦ Dispensing requirements
◦ Chapter 7 Emergency planning
◦ Chapter 9 Security planning
![Page 30: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/30.jpg)
Permits and Plans
Permits are required in accordance with NFPA 1
The AHJ has the authority to require plans
◦ Hazardous Material Inventory Statement (HMIS)
◦ Hazardous Material Management Plan (HMMP)-above MAQ
◦ Closure plan
◦ Other plans as required may include Incident Investigation Plan, Security Plan
Emergency Action Plan-always required. Unauthorized releases activate the plan
![Page 31: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/31.jpg)
Example
31
![Page 32: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/32.jpg)
Calcium HypochloriteIndustrial Occupancy
100-5 gallon buckets
Used in open containers
![Page 33: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/33.jpg)
What Do I Need to Know to Apply NFPA 400? What is the Material?
Calcium Hypochlorite
What is the Occupancy?Industrial
How is the Material stored?
5 gallon pails in corner of building
How is the Material used-closed or open use?
Open use-1 bucket at a time (5 gal)
What is the Amount of Material?
~ 500 gallons in storage
5 gal in use
Are there Sprinklers?
No
What is the building construction?
One open building, single control area
![Page 34: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/34.jpg)
Classify the Material
G.3.4 Class 3 Oxidizers. The following are typical Class 3 oxidizers:
(1) Ammonium dichromate
(2) Calcium hypochlorite (over 50 percent by weight unless covered in other formulations in
(3) Calcium hypochlorite (over 50 percent by weight)
(4) Chloric acid (10 percent maximum concentration)
3.3.72.3 Class 3. An oxidizer that causes a severe increase in the burning rate of combustible materials with which it comes into contact or a solid oxidizer classified as Class 3 when tested in accordance with the test protocol set forth in G.1.
![Page 35: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/35.jpg)
Determining MAQ for the Occupancy
![Page 36: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/36.jpg)
36
Classify hazardous material
Determine quantity to be used or stored
Quantity exceeds MAQ?
Apply provisions for protection
levels
Apply provisions for multiplecontrol areas
No special construction
featuresrequired
Orgate
YES NO
![Page 37: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/37.jpg)
Amount Exceeds MAQ per Control Area
Must go to Protection Level Construction
Material is considered a High hazard level 3 as defined in standard so therefore Protection Level 3 construction applies.
AND… must follow Chapter 15 requirements for Class 3 Oxidizers
37
![Page 38: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/38.jpg)
38
![Page 39: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/39.jpg)
NFPA 400 and Ammonium Nitrate
39
![Page 40: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/40.jpg)
Fertilizer Plant ExplosionWest, Texas
On April 17, 2013, at approximately7:29 p.m. a fire was reported at theWest Fertilizer Plant in West, Texas.Approximately 22 minutes later a largeexplosion occurred. The explosioncaused damage in a 37 square blockarea and destroyed numerous homes.Several other homes were alsodamaged. In the end, a crater 93 feetwide was created at the seat of blast.
![Page 41: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/41.jpg)
West Texas Plant before
41
![Page 42: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/42.jpg)
West Texas Plant after
42
![Page 43: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/43.jpg)
Preliminary Findings of CSB
The warehouse and bins were combustible and contained seeds
The building lacked a sprinkler system or other systems to automatically detect or suppress fire.
Guidance for firefighters vague and confusing
No requirement for emergency planning under (EPCRA exempt)
![Page 44: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/44.jpg)
NFPA 400 2016 edition
CSB FINDING
The warehouse and bins were combustible and contained significant amounts of combustible seeds, which likely contributed to the intensity of the fire.
NFPA 400 CODE
All new construction required to be noncombustible. All bins for storage required to be non combustible.
Separation of combustibles by a 1 hour fire barrier wall
![Page 45: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/45.jpg)
NFPA 400 2016 edition
CSB FINDING
The building lacked a sprinkler system or other systems to automatically detect or suppress fire.
NFPA 400 CODE
Automatic Sprinklers required for all new construction
Automatic Sprinklers required for existing structures if Type III, IV or V combustible construction or if combustible contents.
![Page 46: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/46.jpg)
NFPA 400 2016 edition
CSB FINDING
Guidance for firefighters vague and confusing
NFPA 400 CODE
Annex material with clear instructions and information for firefighters
Improved signage – 704 Placard + DO NOT FIGHT FIRE
![Page 47: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/47.jpg)
NFPA 400 2016 edition
CSB FINDING
No requirement for emergency planning
NFPA 400 CODE
Pre-incident planning
Notification and Alert System
1 Mile Evacuation Distance
![Page 48: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/48.jpg)
48
2016 edition of NFPA 400www.nfpa.org/400
![Page 49: Chemical Wedn 83 Am Handout](https://reader033.fdocuments.net/reader033/viewer/2022042721/577c85f41a28abe054bf362d/html5/thumbnails/49.jpg)
Thank you!Questions???
49