Cal-OSHA and Fumigation Even Some OSHA & General Pest Pest Control Operators of California The...
-
Upload
elfreda-webster -
Category
Documents
-
view
220 -
download
0
Transcript of Cal-OSHA and Fumigation Even Some OSHA & General Pest Pest Control Operators of California The...
Cal-OSHA and FumigationEven
Some OSHA & General Pest
Pest Control Operators of California
The Peacock Group Inc. www.pcocinsurance.com
Copyright 2002 Pest Control Operators of California Inc.
Fumigation & Cal/OSHA Exposure to employee of heights
of 4.5 feet or higher must be covered under a fall protection plan.
Additional Standards above 6 feet Fumigators in non-compliance Two recent incidents in San Diego One recent incident in San Jose And a 1998 Fumigation Death
have caused Cal/OSHA to re-examine fumigators.
Copyright 2002 Pest Control Operators of California Inc.
Incidents which triggered Cal/OSHA Investigation
First San Diego Incident: October 2001 – San Diego fumigator carrying a tarp up
a ladder on a single story house. As he steps off the ladder he slips and falls to the ground breaking his neck: Many violations possible, but the two big issues are: Fall Protection Ladder Use (still a fall protection issue)
Copyright 2002 Pest Control Operators of California Inc.
2nd San Diego Incident December 2001 – San Diego fumigator is
electrocuted when the aerial he is taking down hits a power line. Many violations possible, clearly the accident itself is reason for worry and something we all should be concerned with when lowering an aerial. But the concern Cal/OSHA brought to my attention from this incident as it relates to the industry as a whole are: Fall Protection Ladder Use (still a fall protection issue)
Copyright 2002 Pest Control Operators of California Inc.
San Jose Incident
January 2002 – San Jose fumigator falls from roof breaking his back. Fumigator beginning to get some movement into his legs. Employer still awaiting the official Cal-OSHA investigation; they told him they would perform a “surprise” inspection and investigation “sometime in March”. We anticipate them making an issue of: Fall Protection Ladder Use (still a fall protection issue)
Copyright 2002 Pest Control Operators of California Inc.
1998 Fumigation fall death
assessment
Copyright 2002 Pest Control Operators of California Inc.
Fall Protection Recommendations:
Recommendation #1
Fumigation employers should provide fall protection for employees who work at heights
Acknowledges that fall protection for our industry is difficult, but still necessary
“Must engineer or have fall protection engineered to meet requirements of the American National Standards Institute, Inc.,(ANSI) and Cal/OSHA.
Continued on next slide
Copyright 2002 Pest Control Operators of California Inc.
Recommendation #1 Continued
If fall protection in not feasible, then an alternative method must be used to
protect the employee. For example:
A. Aerial lifts, meetings regulations for lifting a person or persons could be used to access the tarps at or near the leading edge of roofs.
B. Safety harnesses and lanyards may be used if they can be attached at an approved anchor point.
Copyright 2002 Pest Control Operators of California Inc.
Fall Protection Recommendations:
Recommendation #2
Employers should employ external lighting when working after dark.
With no lighting and dark colored tarps, it most likely would have been difficult for the decedent to discern the edge of the roof. Proper portable lighting for employees may have prevented this incident.
Copyright 2002 Pest Control Operators of California Inc.
Fall Protection Recommendations:
Recommendation #3
Employers should ensure employees do not approach a roof edge so closely that it places them in danger of falling off
Tarps do not provide safe footing Folds in tarps can provide tripping hazard Without fall protection “this is a very dangerous
task”
Copyright 2002 Pest Control Operators of California Inc.
Fall Protection Recommendations:
Recommendation #4Employers should develop a written procedure
which covers the manner in which tarp laying should be performed
The employer failed to provide written instructions describing the tarp laying procedure to employees. Such instructions would normally contain safety precautions such as not walking too close to roof edges, use of ladders and fall protection, etc. When the tarps have been laid, the roof edge becomes less distinct because it is hidden by the tarp. In such cases, it is especially important to adhere to those safety precautions that address falling. If such instructions were provided, and followed, this fatality may not
have happened.
Copyright 2002 Pest Control Operators of California Inc.
Fall Hazard Issues: OSHA mandates fall protection for
employees. It is pretty clear that one way or another, fumigators fall under these standards.
Most Common OSHA solutions to our height hazards: Scaffolding Fall protection systems with harnesses.
Industry Response: Cost are Prohibitive OSHA Response:
expense is NEVER an acceptable reason not to implement systems to protect worker health & safety.
Costs should be simply passed along to the consumer
Copyright 2002 Pest Control Operators of California Inc.
The Oregon Negotiated Solution Professionally
installed, or industry (fumigator) installed OSHA approved Anchor Points, and connecting wires and…
Copyright 2002 Pest Control Operators of California Inc.
Oregon Agreement Continued
Employee Harnesses and full OSHA fall protection plan …..
Not mandated (from what I saw in writing) but probably a necessary are Self-Retracting life lines as pictured on the left.
Copyright 2002 Pest Control Operators of California Inc.
Horizontal Lifeline anchored to ends of ridgeline
Copyright 2002 Pest Control Operators of California Inc.
Sloped Roof Fall Arrest System
Anchored at ridgeline and near roof edge
Copyright 2002 Pest Control Operators of California Inc.
Practical Sloped Roof Fall Arrest Systems:
Kits for compliance are readily available: the one pictured sells on the web for less than $200.00
c
Copyright 2002 Pest Control Operators of California Inc.
Fall Protection Continued
Probably the most difficult part of this system to set up and be addressed is the restriction of movement as to prevent the employee from falling off or from hitting the ground should he fall. This limitation will restrict the ability of the
fumigator to move about
the rooftop.
Copyright 2002 Pest Control Operators of California Inc.
Additional Possible Solution for Working near Edges
Portable Tie-offs Scaffolds
Copyright 2002 Pest Control Operators of California Inc.
Ladder Use
Issues of maximum weight on ladder
Both hands must be used for climbing or working from ladder
Can’t carry anything which might interfere with climbing ladder
Copyright 2002 Pest Control Operators of California Inc.
Ladders: Weight Rating
Most ladders come in 200, 225, 250, and 300 pound ratings.
Even using the 300 pound rating ladder it is still easy to exceed the weight rating when you combine the weight of the fumigator 160-190 pounds average with the weight of the tarp 90-150 pounds.
Many fumigators have lower weight rated ladders in service.
Copyright 2002 Pest Control Operators of California Inc.
Ladders: Carrying Items
Cal/OSHA Code says we can not have anything in our hands which will interfere with climbing the ladder.
Basic rule both hands need to be free when climbing ladder
Working from ladder as shown on the left is an OSHA no-no.
In Hawaii – fumigators specifically must use “lifts” to carry tarps up to the rooftop.
Copyright 2002 Pest Control Operators of California Inc.
In Hawaii: OSHA has said specifically that Ladder Lifts or something similar
are to carry tarps up to roof: Other lifts have
been used as well, but this general design (several manufacturers) seems most practical if we are to comply with the law
Copyright 2002 Pest Control Operators of California Inc.
Hand crank & more power Lifts
Copyright 2002 Pest Control Operators of California Inc.
Securing LaddersWorking From Ladders
Ladders need to be secured both at the bottom and top to ensure it does not slip
Industry has discussed “tying off” workers to ladders to ensure safety, and allow the workers to clip seams from ladders. This is a great idea, but we will have to properly secure the ladders so they will support the worker should they fall: In a June 4, 1991 Interpretation letter of Section 1910 makes it clear that industry must demonstrate how and that the ladder will stay in place if a tied off worker were to fall.
Copyright 2002 Pest Control Operators of California Inc.
PCOC Working with OSHA
We are tracking these situations to see what fines and violations are issued
Provided Cal-OSHA with the Height and Ladder safety programs which are part of the larger PCOC Fumigation Safety Package.
Copyright 2002 Pest Control Operators of California Inc.
PCOC Exploring Options: Seek Variance: - normally only done by
individual companies, not industries. Develop Plan for how we might fit into the
current regulatory structure. We will write up a compliance plan for the
industry We may write and as for “interpretations” to
clarify existing law to see if our creative compliance ideas really do fit into the law.
Seek Regulatory Changes so that we have our own set of law which applies to us.
Learning More from Hawaii Representatives from the PCOC Fumigation
Committee along with Northern & Southern California Subcontract fumigators groups: meeting to develop strategy & address these issues.
Copyright 2002 Pest Control Operators of California Inc.
Current Plan: Develop an OSHA Compliant Protocol
Work under Roofing Rules Ladders Secured at top & bottom Lifts for tarps Personal Fall Protection Plan and
equipment for structures with any portion of the roof over 21 feet.
Currently testing equipment
Copyright 2002 Pest Control Operators of California Inc.
Pest Control Technician Dies in 100 Foot Fall from Roof in Massachusetts
On August 13, 1997, a 25 year old male pest control technician died when he fell from the roof of an apartment building. The technician was spraying for spiders in the vents and other parts of the roof when the incident occurred. While spraying along a gutter of a roof-top penthouse, the technician walked off the edge of the roof and fell nine stories to the parking lot below.
The victim was a 25 year old male pest control technician. He was employed by the company for approximately seven months and was at the jobsite for less than an hour at the time of the incident. He had formal training in college in integrated pest management prior to joining the company.
Copyright 2002 Pest Control Operators of California Inc.
OSHA Fatality Assessment & Control Evaluation of Tech Death: Recommendation #1: Employers should develop
and implement a site specific health and safety plan for each site under contract.
Recommendation #2: Employers should employ alternative controls for fall hazards when personal fall arrest systems are not required or appropriate.
Recommendation #3: Building owners should consider the installation of guardrails at the perimeter of flat roofs wherever possible.
Copyright 2002 Pest Control Operators of California Inc.
Fumigation Risk Management : From 1996 through 1999 the PCOC
Safety Committee worked with the PCOC Termite Committee to develop a semi-comprehensive “Fumigation Risk Management” package for PCOC members.
Adopted June 19, 1999 by the PCOC Board of Directors as a “recommendation to PCOC member companies”
It was developed to address these issues by the fumigation industry insisted that the “standards” and issues addressed in this book do not go beyond what was their current practices.
Copyright 2002 Pest Control Operators of California Inc.
Fumigation Risk Management Package
1. Cal-OSHA General Standards as edited for the Fumigation Industry
2. Fumigation Ladder Safety
3. Fumigation Lifting Safety
4. Fumigation Hazard of Heights
5. Fumigation General Hazards & Ground Crew
6. Fumigation Rain & Wind Hazards
contains the following core documents:
Copyright 2002 Pest Control Operators of California Inc.
Additionally the Package contains: Written Injury & Illness Prevention
Program Outline SCBA Training Bi-annual Defensive Drivers
Training (OSHA & DOT Mandated) Bi-annual HM 181 & 126f Training
DOT Mandated Random Drug & Alcohol Testing information
Pesticide Safety Training Hazard Communication Training
Copyright 2002 Pest Control Operators of California Inc.
Bonus Safety Meetingsalso included
1. Defensive Driving Tips & Quiz2. What to do in Case of a Traffic
Accident3. Vehicle Code & Safety Quiz4. How to Properly Sit in Your
Vehicle5. Safety at Work and Home:
Children's Safety Seats 6. Physical Laws of Driving7. Driving in the Dark 8. Defensive Driving Quiz9. Driving & Car Phones10. Seat Belts11. Speeding12. 1997 CHP Fatal and Injury Traffic
Collision Statistics13. 1997 CHP Quick Collision Facts14. CHP & OTS Winter Driving Fact &
Tip Sheet15. Fumigation & Auto Sensor Lights16. Fumigator Back Injuries17. Hidden Hazards 18. Water & Rain Hazards19. Preventing Back Injuries
20. WORKER RIGHT TO KNOW/ HAZARD COMMUNICATION
21. COMPRESSED GAS CYLINDERS
22. DOT HAZMAT RULES REVIEW
23. ACCIDENT$ CO$T YOU MONEY
24. ANIMAL BITES A FORGOTTEN HAZARD
25. Falls Are Not Funny26. Safe Use of Ladders for
PCOs - Review27. The Dangerous Four28. Erection and Use of
Ladders29. Falling Objects30. Falls31. Guardrails32. Hazards of Falls 33. Ladder Safety 34. Slips Trips & Falls 35. Safe Scaffolding 36. Ladder Accident Analysis
& Prevention
Copyright 2002 Pest Control Operators of California Inc.
More Safety Resources from the Peacock Group – PCOC
Insurance Program
www.pcoc.orgwww.peacockgroup.org
www.pcocinsurance.com
Copyright 2002 Pest Control Operators of California Inc.