Cable Wipes - PT PF Solvent Cable Cleaning & Jointing Wipes (LV HV)
Cable Jointing Accessories Electrical Stress Control Masticipdgroup.com.au/Pdf/Pronto product...
Transcript of Cable Jointing Accessories Electrical Stress Control Masticipdgroup.com.au/Pdf/Pronto product...
UUnnddeerrggrroouunndd DDiissttrriibbuuttiioonn
Cable Jointing Accessories
Electrical Stress ControlMastic
Formulated to provide enhanced tensilestrength, tack and surface appearance, themastic is highly resistant to impregnatingcompounds such as M.I.N.D and Rosin Oilwhich are commonly used in paperinsulated cables. It contains a highmolecular weight plasticiser which is nonextractable and therefore gives excellentcompatibility with polymeric insulatedcables.
ApplicationsUsed to control electrical stresses at the endof the outer screen in joints and terminationsfor polymeric cables.
Used to seal and control the stresses at thecrutch of 3 core paper insulated cables injoints.
Can also be used to control stresses atother locations in joints and terminationsand to fill voids and gaps.
A pliable self amalgamating tape for electrical stresscontrol, void and gap filling for MV power cable accessoryapplications. High permittivity and low loss tangent givesthe mastic excellent stress controlling properties.
• Non-toxic
• Compatible with paper andpolymeric insulated cables
• Excellent control of electrical stresses
• Low loss tangent
• Self amalgamating
• Good tack and adhesion to plasticsand metals
WT Henley Limited - Silverkey, Church Manorway, Belvedere, Erith, Kent DA8 1EX, England - www.wt-henley.comTelephone: +44 (0) 1322 444500 - Facsimile: +44 (0) 1322 444502 - Email: [email protected]
SICAME GROUP
8219 Electrical Stress Mastic:Layout 1 27/1/12 14:41 Page 1
Supply
Technical Data
Standard roll length 100M – other lengths are available, please contact us formore information.Width: 20mmProduct Code 53433-14
Appearance Light brown plastic
Odour Aromatic
pH Not applicable
Boiling point range Above 300 degrees C
Melting point range Not applicable
Flash point Not applicable
Flammability (Gas/Solid) Not flammable at normal temperatures
Auto-flammability May auto-ignite above 300 degrees C
Explosive properties Not applicable
Oxidising properties Not applicable
Vapour Pressure Not measurable
Relative Density Not applicable
Solubility (Water & Fat) Insoluble
Other Not soluble in more common hydrocarbon solvents
General Note The equipment detailed in this publication should be installed by a suitably qualified person. WT Henley Limited reserves the right to make changesin product specification without notice or liability. All information is subject to WT Henley’s own data and is considered accurate at time of going to print.
© 2011 WT Henley Limited. All rights reserved. No part of this document may be copied or reproduced in whole or in part without prior written approval of WTHenley Limited.
8219 2012-01-25
UUnnddeerrggrroouunndd DDiissttrriibbuuttiioonn
Cable Jointing Accessories
8219 Electrical Stress Mastic:Layout 1 27/1/12 14:41 Page 2