Broiler farming
-
Upload
ashiq-toor -
Category
Education
-
view
124 -
download
3
Transcript of Broiler farming
Prepared by Dr Muhammad Ashiq Toor
DVM , Bs (Zoology)
from IUB BWP (2010 – 2015)
+92-344-499-7375
+92-300-364-2402
Broiler Farming
At commercial level
Open shed
Control Sheds
Open shed vs Control shed
Control shedOpen shed
Most of the things are automatic.Every thing manual
Construction cost very much high.Construction cost very low
Production satisfiedProduction not satisfied
Open Shed
• Every thing manually
• i.e Feeding , Watering Vaccination etc.
• Tem in open shed difficult to maintain.
• RH also not retain according to our requirement.
Open shed
Disadvantages
Because management not under our control so
• Production low
• FCR low
• Body wt vary from bird to bird
• High labour cost
• At the end not satisfy farmer
Open shed
Advantages
• Low construction & Running expenses (electricity , diesel etc.)
• Birds are more resistant to diseases then control shed.
Control shed
Advantages
• Almost Every thing auto control
(feeding , watering , may be vaccines, Tem , RH , Ventilation , etc.)
• Low labour cost
• Wt gain high
• FCR high
Control shed
Disadvantages
• Construction cost high
• Running cost high
• Less immune birds then open shed
m
Ventilation System
Tem & Humidity system
Feeding system
Feeding System
Broiler flock1. Preparation of shed
2. Selection of chicks
3. Brooding ( 1 – 9days)
4. Growing to Finishing (10-42days)
5. Catching
6. Sale
Control shed for BROILER
1.Preparation of shed
• Remove old litter
• Clean the shed by iron fiber brush(pillars walls roof doors etc.)
• After that remove any stain of feces by khurpi
• Then this method applied in stores.
• Feeders waterer & nipples wash with detergents (surf) carefully
• Floor walls pillars with simple water
• This method repeat 3-4 times for every thing & then take sample
• Clean the bazar by sweep
• Pads & fans also wash out after 4 washes complete
• If sample pass out then white wash on pillars & walls
• Then spray of formalin inside the shed on every thing
• Litter mix with formalin put in shallow , Turn on feed lines
• Normal 25 lit/800 lit of water
Setting of shed
• Set wateres & feeders put feeding trays in sequence
• Level the litter
• Chick guard according to no of chicks & required area
• 1sq f/10chicks
• Also cull pen separately
• Check nipples feeder lines fan pads each & every thing
• After that Litter on floor
• Spray on the litter
• Airtight every thing
• Now Fumigation for 24 hr.
Pinky (KMnO4) + Formalin
1 : 2
• White wash side of sheds at entry of farm
• Dips filled with water &mix pinky before receiving the chicks vehicles
• Dr.`s , Workers clothes ,shoes wash with formalin
• After 24hr open main door of shed
2.Selection of chicks
Must be careful In selection
• Chicks from standardize company e,g Big bird , A W Chicks , K&Ns Islamabad etc .
• Economically suitable
• “A” grade chicks some conditions “B” grade
• Must be known either Hubbard or Arber Acer
Receiving of chicks
• Chicks packed in cartoons 80/cartoon in summer with 2 % extra and 100 in winter with 2 % extra
• Formalin spray chicks vehicle externally
• Check every cartoon at shed & count randomly 3 to 4 cartoons
• Check quality of chicks & wt. 37-41 g ideal day old chicks
COMMERCIAL SCALE
BROODING UNITS
BROODING
THE CHICKS WILL TELL YOU IF THEY ARE COMFORTABLE
Brooding ( 1 – 9days)
• Brooding most imp aspect in poultry farming
• In summer brooding easy process as compared to winter
• In summer no need of brooder almost
• In winter brooder requirement necessary
• Tem Auto Control by fans, pads & duct brooder system
• Ventilation controlled by vents fans pads
• RH(relative Humidity) controlled
• Water in water lines & drink through nipples some time also use baby drinkers early days
• Feeding at early days in feeding trays place on litters in sequence
• After 16-20 hr. crop test
• Mortality must be less then 0.26 during 1st
week
• Grading chicks every day
• Mortality open & diagnose problems
• Tem control most important
HOURS AFTER
PLACEMENT
2
12
24
CROP FILL
(% OF CHICKS)
75
85
95+
Body wt (g)
Vacc & Medic
Light duration
Water (ml)/ chick
Feed(g)/ chickRHTem C
Space/ bird
AgeDays
42Electrolyte1g/lit D/W
24hr.1510 Starter14(A)60-6532.271
52241814 “ “60-6531.5.272
65EC fort 1ml/lit D/W
24221860-6531.5.273
85Sugar 28g/lit24272260-6531.5.274
99.723.5 30off
312660-6531.275
119NDclone 30 @1.5dose/ chick spray
23.5383060-6531.346
140.76T.Dcol D/W23453460-6531.347
Body wt (g)
Vacc & Medic
Light duration
Water (ml)/ chick
Feed(g)/ chick
RHTem CSpace/ bird
AgeDays
167.6GallimuneND.3ml/ Sc
23hr.523865-6731.358
182Anti stress Tavet ADEK3 1ml/10lit D/W
23634265-6730.5.359
4.Growing to Finishing
(10-42days)
• Now no need of brooder
• Feed according to sequence add 4 g per day even 160 -165g
• Racking start at 8 or 9 day when see litter flaking
• Wet litter Change frequently
• In summer ,last days tem and RH difficult to control
• As required guard area extended
• Light off duration 13day to onward
2 hr from 12-2am
5.Catching & sale
• Catching start after 2am
• Feeding during sale days depend upon either you sale empty or full crop
• Sale also very imp aspect
• Sale the birds direct to butcher or sale man.
Weigh balance
• Digital weigh balance
• Classical weigh balance
FCR = Feed intake/Weight gain
BROILER AGE AND WATER CONSUMPTION
DAILY WATER CONSUMPTION
DAYS OF AGE X 6 ML
“BROILERS”(UNDER NORMAL CONDITIONS)
Vaccine schedule
RouteVaccine Day
S / CND + IB (at hatchery)Day old chick
sprayND clone 30 @1.5dose/ chick
6th Day
S / C (on neck)Gallimune ND0.3ml/Chick
8th Day
D / WIBD18th Day
D / WND clone 30 22-28 Days
D/WIBDL12th Day
D/WIB 2nd shot13th Day
Spray Spray
Medicine scheduleMedicationAge in days
Electrolyte 1g / lit D/WDay old chick
EC fort 1ml/lit D/W3rd Day
Sugar 28g / lit D/W4th Day
T.Dcol D/W7th Day
Anti stress Tavet ADEK3 1ml/10 lit D/W9th Day
Cholorination of waterWhen required
Vitamins etc.After 3 or 3 days
?How we determine RH
Mortality open & diagnostic Report
• Daily open mortality check specific lesions on specific sites
• If you find any sign of disease must control it immediately
ND New castle disease
Postmortem lesions
• Haemorrhage in proventriculus
After recovery
• Twisted neck
• Nervous signs
Treatment
• Antibiotics to control secondary bacteria
• Flushing
IBD (Gumboro)
Post-mortem lesions• Vent pecking• Diarrhoea with urates in
mucus• Haemorrhage on thigh
muscles• NephritisTreatment• No tretment• Antibiotics• Vit Supplementation
Coccidiosis
Lesions
• Bloody dropping
• Haemorrhage at central part of small intestine & cecum
Treatment
• Anticoccidial drugs
(Amproleum)
• Antibiotics
• Flushing
IB (Infectious Bronchitis)
Signs
• Coughing
• Gasping
Post-mortem lesions
• Trachial oedema
• Kidnies & Bronchi are swollen
Treatment
Sodium salicylate 1g/lit D/W
E. Coli
Signs
• Attack number of organs
• White layer on Liver
• Yellowish colour droping
Control
• Use water purifire
• Flushing