April 2018 - substation7 TNB Ulu Terengganu 132 kV Substation. 8 Petronas Kemaman Project 9 Jalan...

1 All rights reserved worldwide. Copyright © 2014 - 2015 by Delta Sama Jaya Sdn. Bhd.(DSSB) | www.substation.com.my April 2018

Introduction

Advantages

Very lightweight- reduce risk of personal injury.Designed for easy transportation.

High impact resistantReduce the cost for repairingAccidental dropping does not damage cablesNo risk of accidental breakagesMaintenance freeGives the clearest warningEnviromental Friendly

Marking and Embossing

Note

HIGH QUALITY PLASTIC SLABS / TILES(TRIPLE / SINGLE HOOK)

Cable Slabs/Cover are used as visual warning indicators for cables laid underground, while at the same time provides mechanical protection for underground laidcables in the event of excavation work. The Cable Slab/Cover are buried below the ground level and above the underground cables.

Very high impact strength properties to provides good mechanical protectionfor underground laid cables and pipes.

Designed with interlocking end (hook and slot) to make simple and effectiveconnection at site.Can be supplied in any colour and language, identifying the type of servicesburied below.Prevent or minimise damages to Electrical Cables, Telecommunication Cables, Signalling Cables, Fibre Optic Cables, Gas Pipes, Water Pipes, etc.

The slabs shall be embossed with lettering to provide visual warning during excavation works and permanently marked as per customer's requirements.

Various feedback from sites and customers indicated that, conventional type single hook/slot interlocking slabs/covers easily disconnected/break from the next slab/cover due to only one single hook and slot system. Our Cable Slab is designedand improvised with 3 hooks/slots to withstand 3 times the pulling forceand do not come off or break during excavation work or during installation.

6mm thick (Triple Hook)


HIGH QUALITY PLASTIC CABLE SLABS/TILES (TRIPLE HOOKS)(Thickness: 6mm)

ColourYellowOrangeGreenCustomize250mm(W) x 1000mm (L) x 6.0mm (T)

Item CodeDSSB-CSAP250Y-3-6DSSB-CSAP250O-3-6DSSB-CSAP250G-3-6DSSB-CSAP-250C-3-6

Size (mm)250mm(W) x 1000mm (L) x 6.0mm (T)250mm(W) x 1000mm (L) x 6.0mm (T)250mm(W) x 1000mm (L) x 6.0mm (T)

Laying of Protection Cover for gas pipe

Laying of fine Sand (covering the gas pipe) Laying of Gas Pipe


HIGH QUALITY PLASTIC CABLE SLABS/TILES (TRIPLE HOOKS)(Thickness: 2mm)

ColourOrangeGreenYellowRedDSSB-CSAP-250R-3-2

Size (mm)250mm(W) x 1000mm (L) x2.0mm (T)250mm(W) x 1000mm (L) x2.0mm (T)

250mm(W) x 1000mm (L) x2.0mm (T)250mm(W) x 1000mm (L) x2.0mm (T)

Other size/colour please call for enquiry

Item CodeDSSB-CSAP-250O-3-2DSSB-CSAP-250G-3-2DSSB-CSAP-250Y-3-2


HIGH QUALITY PLASTIC CABLE SLABS/TILES (SINGLE HOOK)(Thickness: 2mm)

ColourCustomizeGreenYellowYellowOrangeGreen

Size (mm)100mm (W) x 1000mm(L) x 2mm(T)150mm (W) x 1000mm(L) x 2mm(T)200mm (W) x 1000mm(L) x 2mm(T)

250mm (W) x 1000mm (L) x 2mm (T)DSSB-CSAP250O-1

DSSB-CSAP250G-1

Other size/colour please call for enquiry

250mm(W) x 1000mm (L) x 2mm (T)250mm(W) x 1000mm (L) x 2mm (T)

Item CodeDSSB-CSAP-100C-1

DSSB-CSAP-150G-1

DSSB-CSAP-200Y-1

DSSB-CSAP250Y-1GSM ANGLE PLATE TYPE DOUBLE RIB

1000mm

1000mm

1000mm

100mm

150mm

200mm

1000mm

100mm


HIGH QUALITY CONCRETE CABLE SLAB / TILES(11kV, 33kV, 132kV and 275kV)

Item No.123456789

1011

DSSB-CSM-CCS150CDSSB-CSM-CCS350CDSSB-CSM-CCS150C

***other wording are available upon request

350mm X 870mm X 65mm150mm X 900mm X 50mm150mm X 900mm X 50mm

Wording : MERBAHAYA LETRIK

Weight (kg)1536153022292714391313

Item CodeDSSB-CSM-CCS150CDSSB-CSM-CCS300CDSSB-CSM-CCS150CDSSB-CSM-CCS300CDSSB-CSM-CCS300CDSSB-CSM-CCS280CDSSB-CSM-CCS345C

Size150mm X 1000mm X 50mm300mm X 1000mm X 50mm150mm X 1000mm X 50mm300mm X 1000mm X 50mm300mm X 610mm X 50mm280mm X 900mm X 50mm345mm X 840mm X 50mm150mm X 900mm X 50mm

DSSB-CSM-CCS150C

Item 5

Item 2 Item 3

Item 6

Item 7 Item 8

Item 9

Item 10 Item 11

Item 4

Item 1


HYBRID CONCRETE PLASTIC CABLE SLAB

DSSB-CSM-CPCS300C 36kgItem Code Weight (kg)Size

300mm X 1000mm X 50mm


HIGH QUALITY CONCRETE CABLE MARKER(Square)

A (top) B (heightt) C (base)1 125mm x 300mm x 175mm2 100mm x 400mm x 150mm3 100mm x 400mm x 150mm

HIGH QUALITY CONCRETE CABLE MARKER(Round)

A (top) B (height) C (base)100mm x 375mm x 200mm150mm x 375mm x 225mm

20 kgDSSB-CSM-CCMR375100

Item Code

DSSB-CSM-CCMS300DSSB-CSM-CCMS400

Size Weight

15 kg18 kg

Item No.

DSSB-CSM-CCMS400 13 kg

Item Code

DSSB-CSM-CCMR375150

Size Weight (kg)

20 kg

Item 3 Item 1

Item 2


CONCRETE POST MARKER(Square)

ABC

C (base) B160mm B135mm B125mm

H770mm x H800mm x

TS400mm x TS125mm x

DSSB-CSM-CMP-770135DSSB-CSM-CMP-800125

TYPE B (height)

H760mm x

TYPE A

TYPE B

TYPE C

A(top) TS160mm x

SizeItem Code

DSSB-CSM-CMP-760160


HIGH QUALITY CEMENT CABLE MARKER(Round)

A(top) B (height) C (base)DSSB-CSM-CCMR300 75mm x 300mm x 150mm

HIGH QUALITY CONCRETE JOINT MARKER

A(top) B (height) C (base)1 194mm x 781mm x B375mm2 200mm x 700mm x 85mm

Weight (kg)

3224

Item Code

DSSB-CSM-CJM781DSSB-CSM-CJM200

Item No. Size

6

Weight (kg)SizeItem Code

Item 2

Item 1


PENGERANG RAPID PROJECT: HIGH QUALITY PLASTIC CABLE SLAB/ TILES (INSTALLATION WORKS)


Reference List: High Quality Plastic Cable Slab / Tile Supplied / installed in various project for the last 5 years.

1 Petronas Bintulu, Sarawak2 Kota Kinabalu, Sabah3 ABB Algeria4 TNB Cameron Highland, Pahang5 SESB Sandakan, Sabah6 Bentong Mini Hydro7 TNB Pengkalan Industry, Perak8 TNB Puchong Perdana 275kV Substation9 TNB Shah Alam West 275kV Substation

10 TNB Ampang 275kV Substation11 Malaysia Airport Berhad KLIA Project12 Putrajaya Holding Fibre Optic Cable Laying13 Petronas, Kemaman14 Petronas, Bintulu15 P11, Putrajaya Holdings16 PRASARANA Projek Mass Rapid Transit

Lembah Kelang Jajaran Sg. Buloh - Kajang PackageV2: Gas Malaysia Pipe Relocation Works

17 EPCC of the Natural Gas System for 100MW Combined Cycle Power Plant in Kimanis, Sabah

18 EPCC of NGDS to Puching Serdang (Looping)FL Stage 1/12, Puchong Selangor

19 Sabah Sarawak Gas Pipeline Project For Petronas Carigali Sdn Bhd20 VTS Project21 MES Project22 Petronas, Negeri Sembilan23 Petronas, Segamat24 Petronas, Penang25 LNG Regasification Facility, Pengerang26 RAPID Pengerang Co-Generation Plant (PCP)27

28 RAPID Package 3, Pengerang29 LRT Extension KJ Line

RAPID Package 4, Pengerang - Amine recovery units, Sulfur recovery units, etc

Note: We have also been supplying to other companies, which we do not have any records of their sites.


Reference List: High Quality Plastic Cable Slab / Tile Supplied / installed in various project for the last 5 years.

1

2

Package 12B-Provision of Engineering Procurement Construction And Commissioning (EPCC) of Solid Product Jetty and Assosiated Handling Facilities (SPJ) at Tanjung Setapa.Package 14-0500 Provision of Utilities, Interconnection, Offsite (UIO)Facilities, Construction and Commissioning (CC) of Marine Works fo Storm Water Outfall (SWO) and Effeluent Treatment Plant (ETP) Outlet Pipeline for Rapid Project, Pengerang



CONCRETE CABLE SLAB / TILES INSTALLATION WORKS

1)Workers moving concrete cable slab / tiles into the location.2)Ready for Installation.3)Installation Complete.4)Sand is used to cover the cable slab.


CONCRETE CABLE SLAB / TILES INSTALLATION WORKS

Concrete Cable Slab / Tiles during relocation of underground power cables for MRT project in IKEA / One Utama Area.


Reference List: Concrete Cable Slab supplied / installed in various project for the last 5 years.

1 TNB Section 18 275 / 132 kV Substation Shah Alam2 Solar Farm Project, Alor Star3 TNB Taman Jaya Substation4 MRT Line 1, Kota Damansara5 MRT Line 1, Relocation ( One Utama )6 TNB Sg Abong 132kV Muar Substation7 TNB Ulu Terengganu 132 kV Substation8 Petronas Kemaman Project9 Jalan Pudu MRT Line 1 Project

10 Lachau Project Sarawak11 MRT Line 1 Sungai Buloh Depoh12 MRT Line 1 Mutiara Damansara


CABLE CLEATS &CABLE SLABS DATE : 15/01/2018

ROHS COMPLIANCE STATEMENT

EU-directive one substance restrictions (RoHS-Directive 2011/65/EU)

RoHS Directive 2011/65/EU has the restriction of the use of certain hazardous substances as their aim.

To this end, maximum values were specified for these substances.

The substances affected are:

• Lead, mercury, hexavalent chromium, polybrominated biphenyl (PBB),

polybrominated diphenyl ether (PBCE) – a maximum of 0.1% by weight is permissible for these

substances

• Cadmium- a maximum of 0.01% by weight is permissible for this substance

We confirm that our products in Cable Cleats & High-Quality Plastic Slabs are manufactured according

to the actual version of RoHS-Directive 2011/65/EU.

mailto:[email protected]



www.cablecleat.com.my

www.substation.com.my

We are constantly reviewing and updating our products,for the latest information please call us on (+603) 9281 3778

or visit our website at: www.substation.com.my

Delta Sama Jaya Sdn.Bhd.

April 2018 - substation7 TNB Ulu Terengganu 132 kV Substation. 8 Petronas Kemaman Project 9 Jalan...

Documents

Transcript of April 2018 - substation7 TNB Ulu Terengganu 132 kV Substation. 8 Petronas Kemaman Project 9 Jalan...