Application Selling Guide CONCENTRATED SOLAR POWER · fresh water. 7 Application Selling Guide —...
Transcript of Application Selling Guide CONCENTRATED SOLAR POWER · fresh water. 7 Application Selling Guide —...
1 Application Selling Guide — Desalination
CONCENTRATED SOLAR POWER
Application Selling Guide
Experience In Motion
OCTOBER 2018
2 © 2018 Flowserve Corporation – October 2018
Parabolic trough with molten salt as the HTF
A CLOSER LOOK AT CONCENTRATED SOLAR POWER TECHNOLOGY
3 Application Selling Guide — Concentrated Solar Power
A CLOSER LOOK AT CONCENTRATED SOLAR POWER TECHNOLOGY
Parabolic trough with thermal oil as HTF and molten salt TES
4 © 2018 Flowserve Corporation – October 2018
Tower with molten salt as HTF and TES
A CLOSER LOOK AT CONCENTRATED SOLAR POWER TECHNOLOGY
5 Application Selling Guide — Concentrated Solar Power
A CLOSER LOOK AT CONCENTRATED SOLAR POWER TECHNOLOGY
Simplified integrated solar combined cycle plant
6 © 2018 Flowserve Corporation – October 2018
CSP integrated with MED desalination plant
A CLOSER LOOK AT CONCENTRATED SOLAR POWER TECHNOLOGY
Rather than utilize fossil energy, the sun’s radiation is used to distill seawater and produce potable fresh water.
FLOWSERVE OPPORTUNITIES IN CONCENTRATED SOLAR POWER – PRODUCTS AND CAPABILITIES
8 © 2018 Flowserve Corporation – October 2018
9 Application Selling Guide — Concentrated Solar Power
FLOWSERVE OPPORTUNITIES IN CONCENTRATED SOLAR POWER – PRODUCTS AND CAPABILITIES
LDFT
SH1
HPB
RH 1
Aux Stm
LPB
AFT
LDFT
RH 1
LPB
DT 1
DT 1
DT 1
M
MM
M
COOLING TOWER
TURBINE‐GENERATOR
M
M
CONDENSER
REHEATER
SUPERHEATER
EVAPORATOR
PREHEATER
ATTEMPERATOR
M
HPB
SH 1
M
DT 1
11
8
9
11 10
1213
7
6
5
A14
4 B 3
2
1
C8
DEAERATOR
M
COLDHOT
M
M
MM
MM
M
M
HT 1
HT 2
M
M
M
HT 2
HT 1
DT 1
MDT 1
C. AIR
SOLAR RECEIVER
MOLTEN SALT DRAIN TANK
2120
18
18
17
15
16
HOT MOLTEN SALT TANK COLD MOLTEN SALT TANK
D F
G
22
E
19
MDT 1
FLOWSERVE CONFIDENTIALPFD168-01;Concentrated Solar Power Application Guide;10Jan18;DRAFT;(Confidential-copyright(c) FLS) sheet-1
M
M
MM
M
M
M
M
M
M
MM
M
M
M
M
M
M
POWER TOWER PROCESS FLOW DIAGRAM
10 © 2018 Flowserve Corporation – October 2018
A. Condensate ExtractionB. Main FeedwaterC. Condenser Cooling D. Cold Molten SaltE. Hot Molten SaltF. Attemperator G. Drain Tank
1. Condensate Pump Minimum Flow2. Deaerator Level Control3. LP Heater Drain Control4. Feed Pump Minimum Flow5. Aux Pegging Steam6. Pegging Steam7. Stop‐Check/Non‐Return Steam Extraction 8. HP and LP Turbine Bypass9. Turbine Bypass Spray Water10. Attemperator Spray Water11. Reheater/Superheater Molten Salt Temperature Control12. Pre‐Heater/Evaporator/Superheater/Reheater Molten Salt Drain13. Evaporator Continuous Blowdown14. Evaporator Level Control15. Solar Receiver Level Control 16. Cold Molten Salt Pump Minimum Flow17. Attemperator Pump Minimum Flow18. Reheater/Superheater Molten Salt Temperature Control19. Hot Molten Salt Pump Minimum Flow20. Solar Receiver Inlet Vessel Air Pressure Control21. Solar Receiver Vent22. Solar Receiver Drain
SOLAR TOWER
FLOWSERVE CONFIDENTIALPFD168-00;Concentrated Solar Power Application Guide;22Dec17;DRAFT;(Confidential-copyright(c) FLS) sheet-2
11 Application Selling Guide — Concentrated Solar Power
FLS-1019 © 2018 Flowserve Corporation. All rights reserved. Printed in the U.S.A. October 2018. Kämmer, Logix, NAF, Valbart, Valtek, Flowserve, and the Flowserve design are registered marks of Flowserve Corporation. All other marks are the property of their respective owners.
Flowserve Corporation5215 North O’Connor BoulevardSuite 2300 Irving, Texas 75039flowserve.com
North America
Latin America
Europe
Middle East
Africa
Asia-Pacific