ALL MODELS 2002

433
1 2W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004 WARNING! REMOTE START SYSTEMS ARE ONLY APPLICABLE TO VEHICLES WITH AUTOMATIC TRANSMISSION! BOTH ORIGINAL KEYS ARE REQUIRED FOR ALL REMOTE START SYSTEMS ON VEHICLES EQUIPPED WITH SECURILOCK! EXPERT FITMENT REQUIRED Subject to Change Without Notice INSTALLATION AND TECHNICAL REFERENCE MANUAL ALL MODELS 2002 Use Caution - Personal Injury Use Caution - Vehicle Damage See shop manual TOOLS REQUIRED Silicone sealer D6AZ-19562-AA SILICONE RUBBER 1/4” 8mm 7mm 9/32” Technical Support (800) FORD-KEY ! Important note 101871-2 Super Seal F3AZ-19515-SA

Transcript of ALL MODELS 2002

Page 1: ALL MODELS 2002

12W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

WARNING! REMOTE START SYSTEMS ARE ONLYAPPLICABLE TO VEHICLES WITH AUTOMATICTRANSMISSION!BOTH ORIGINAL KEYS ARE REQUIRED FOR ALLREMOTE START SYSTEMS ON VEHICLES EQUIPPEDWITH SECURILOCK!

EXPERT FITMENT REQUIRED

Subject to Change Without Notice

INSTALLATION AND TECHNICALREFERENCE MANUAL

ALL MODELS 2002 Use Caution -Personal Injury

Use Caution -Vehicle Damage

See shop manual

TOOLS REQUIRED

Silicone sealerD6AZ-19562-AA

SILICO

NERU

BBER

1/4”8mm 7mm

9/32”

Technical Support(800) FORD-KEY

! Important note

101871-2

Super SealF3AZ-19515-SA

Page 2: ALL MODELS 2002

2Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

TABLE OF CONTENTS

READ ME FIRST ........................................................................................................... 3KIT CONTENTS ................................................................................................................................... 4PARTS BAG CONTENTS .................................................................................................................... 5KIT BILL OF MATERIALS LISTS ........................................................................................................ 6MODULE PREPARATION ................................................................................................................... 9VEHICLE PREPARATION ................................................................................................................. 11DIPOLE ANTENNA MOUNTING ....................................................................................................... 12STATUS LED ..................................................................................................................................... 13SECURILOCK INTERFACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB .................................... 14SECURILOCK INTERFACE KIT - 1L3Z-19G365-AB ........................................................................ 16SIREN INSTALLATION...................................................................................................................... 17HOOD TILT SWITCH INSTALLATION ............................................................................................... 18MOUNTING THE CONTROL MODULE ............................................................................................. 19SYSTEM WIRING CONNECTIONS ................................................................................................... 20WARNING LABEL INSTALLATION .................................................................................................. 20SYSTEM PROGRAMMING INSTRUCTIONS.................................................................................... 21

TRANSMITTER PROGRAMMING: .............................................................................................. 21OPTION PROGRAMMING: .......................................................................................................... 21SHOCK SENSOR SETTING ........................................................................................................ 22TACH (IDLE SPEED) PROGRAMMING ...................................................................................... 23

REFERENCE SECTION .............................................................................................. 25SECURILOCK INTERFACE AND RELAY APPLICATION CHART................................................... 25OPTION PROGRAMMING CHARTS ................................................................................................. 27

RKE/VSS/RMST OPTION CHART .............................................................................................. 27RKE/RMST OPTION CHART....................................................................................................... 29RMST OPTION CHART ............................................................................................................... 31DELUXE RKE/VSS OPTION CHART.......................................................................................... 32RKE/VSS & VSS OPTION CHART.............................................................................................. 33RKE OPTION CHART .................................................................................................................. 34LOT MODE ONLY OPTION CHART ............................................................................................ 35

WIRING HARNESS LEGEND ........................................................................................................... 36CIRCUIT TESTING - IDENTIFYING CIRCUIT POLARITY ................................................................ 37WIRE CONNECTION PROCEDURES.............................................................................................. 38VEHICLE SPECIFIC WIRING DIAGRAMS ............................................................... 39

Page 3: ALL MODELS 2002

32W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

READ ME FIRSTFor convenience this document uses short names when referring to a particular system or kit. The list below identifies theshort names used herein:Remote Start System with Deluxe Vehicle Security and Keyless Entry —> RKE/VSS/RMSTRemote Start System with Keyless Entry —> RKE/RMSTRemote Start System —> RMSTDeluxe Vehicle Security System with Keyless Entry —> Deluxe RKE/VSSVehicle Security System with Keyless Entry —> RKE/VSSVehicle Security System for Vehicles Equipped with Factory Keyless Entry —> VSSKeyless Entry System —> RKE

Navigating this document can be accomplished by: 1) using the buttons in the Acrobat toolbar, 2) clicking on thebookmark links in the bookmark pane to the left. (Clicking on the (+) symbols next to a bookmark will expand that bookmark,revealing additional selections) or 3) clicking on a topic in the table of contents located on page 2.

The most current version of this document can be accessed at www.mcdistributor.com and/or www.fmcdealer.com. As new/updated material becomes available, this document will be updated and posted on those sites.

This installation instruction covers the installation of all PowerCode based Convenience/Security and Remote start kits,therefore follow only the steps that apply to the kit that you are installing. For example, the Securilock interface kits are onlyused on systems that include remote start (RMST). Therefore, if you are installing a security only kit, skip the steps pertainingto the Securilock interface kit.

Vehicle wiring is subject to change. All possible efforts have been taken to ensure that the information contained herein isaccurate as of the revision dates indicated. As such, it is critical that vehicle circuits are tested prior to making anyconnections, to ensure that the proper vehicle circuit has been located.

Prior to beginning this installation it is recommended that you lower the drivers door window to prevent locking the keys in thevehicle.

The installation instructions are presented in three sections. The first section (which begins immediately following this page)contains installation instructions for the systems various components and tips for prepping the systems wiring harnesses.These steps are presented in a generic format. The procedures for these installation steps are basically the same regardlessof the model vehicle or system that you are working on. The drawings depicted in this section are for reference only and maynot reflect the vehicle on which you may be working.The second (reference) section contains the system option programming charts and various other reference type information.The last section presents vehicle specific wiring diagrams for each application. Within the wiring section for each vehicle,there are separate wiring diagrams for each different system. The vehicle specific wiring drawings are arranged in thefollowing order:1. RKE/VSS/RMST & RKE/RMST (in the same drawing) - Typically 4 pages;2. RMST - 1 page3. Deluxe RKE/VSS - 3 - 4 pages;4. RKE/VSS & RKE installation options - 1 page;5. VSS - Typically 1 page;6. Pre-load system wiring - 1 page;7. Fuse placement and vehicle specific programming requirements - 1 page.Vehicles that are equipped with 100% factory keyless entry will not have the RKE/VSS & RKE drawing. Some drawings willhave blank pages inserted to maintain the page order.

Prior to beginning your first installation of this product it is recommended that you:1. Thoroughly review and print out the first section;2. Skim through the reference section to become acquainted with the additional information that is available.Then, when going through the installation print out the vehicle specific wiring section and use as a reference during theinstallation.

Page 4: ALL MODELS 2002

4Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

A

E

I

O

B

F

J

P

C

G

K

D

H

L

KIT CONTENTS

WARNING: / AVERTISSEMENTThis vehicle is equipped with a remote controlled engine starter. To reduce the risk of serious Injury or death, switch engine startersystem into service mode and disconnect the vehicle batterybefore performing any service on the vehicle.Ce véhicule est doté d'un démarreur à distance. Pour réduire les risques de blessures graves ou mortelles, mettre le démarreur à distance en mode service et débrancher la batterie du véhicule avant d'effectuer des travaux d'entretien sur celui-ci.

M N

Q R

30sec.

2 sec.

5X

2 sec.

PC-12 - 2W7J-19A498-AAPC-32 - 2W7J-19G367-AA 2W7J-15K601-BA 2W7J-15K601-BASEE KIT BOM

2W7J15603-AA N/A2W7J-15K601-AA2W7J-15K601-AA

2W7-J12060-AA N/A2W7J-19A206-AA2W7J-19A205-AA

N/A N/A2W7J-15W593-AA2W7J-19G366-AA

N/A N/A

Owner's ManualManual del propietarioGuide de l’utilisateur

Vehicle Security and Remote Start Systems

Remote Start System with Deluxe Vehicle Security

Système de démarrage à distance avec antivol de voiture de luxe

Sistema de encendido por control remoto y seguridad para vehículos de lujo

TM

Featuring PowerCode TechnologyFortheUltimateinComfort,ConvenienceandSecurity

Page 5: ALL MODELS 2002

52W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

S

W

AA

T

X

BB

U

Y

CC

V

Z

PARTS BAG CONTENTS

DD

5A 15A

750 OHM 1800 OHM

1X 1X 2X 6X

2X 5X 10X 1X

2X 7X 1XPC-12 - 4XPC-32 - 7X

NOTE: Part bag contents are not available asservice items

Page 6: ALL MODELS 2002

6Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

2W7Z-19G364-AARemote Start System w/Deluxe Vehicle Security and Keyless Entry Kit(RKE/VSS/RMST)

REF DESCRIPTION QTYA PC-32 MODULE ASSEMBLY 1B RKE/VSS/RMST DNA ASSEMBLY (2W7J-19G367-BA) 1C 4 BUTTON POWERCODE TRANSMITTER W/REMOTE START ICONS 2I 24-WAY WIRING HARNESS (BASE) 1J 16-WAY WIRING HARNESS (ADVANCE FUNCTIONS) 1K 10-WAY WIRING HARNESS (CAR START FUNCTIONS) 1L STATUS INDICATOR ASSEMBLY 1G DIPOLE ANTENNA 1M HOOD SAFETY SWITCH ASSEMBLY 1N 125 DB SIREN ASSEMBLY 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1O VSS WINDOW WARNING DECAL 2P UNDERHOOD WARNING LABEL 1

KIT BILL OF MATERIALS LISTS

2W7Z-19G364-BARemote Start System w/Keyless Entry Kit (RKE/RMST)

REF DESCRIPTION QTYA PC-32 MODULE ASSEMBLY 1B RKE/RMST DNA ASSEMBLY (2W7J-19G367-DA) 1C 4 BUTTON POWERCODE TRANSMITTER W/REMOTE START ICONS 2I 24-WAY WIRING HARNESS (BASE) 1J 16-WAY WIRING HARNESS (ADVANCE FUNCTIONS) 1K 10-WAY WIRING HARNESS (CAR START FUNCTIONS) 1L STATUS INDICATOR ASSEMBLY 1G DIPOLE ANTENNA 1M HOOD SAFETY SWITCH ASSEMBLY 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1P UNDERHOOD WARNING LABEL 1

Page 7: ALL MODELS 2002

72W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

2W7Z-19G364-CARemote Start System Kit (RMST)

REF DESCRIPTION QTYA PC-32 MODULE ASSEMBLY 1B RMST DNA ASSEMBLY (2W7J-19G367-CA) 1F 2 BUTTON POWERCODE TRANSMITTER W/REMOTE START ICON 2I 24-WAY WIRING HARNESS (BASE) 1K 10-WAY WIRING HARNESS (CAR START FUNCTIONS) 1L STATUS INDICATOR ASSEMBLY 1G DIPOLE ANTENNA 1M HOOD SAFETY SWITCH ASSEMBLY 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1P UNDERHOOD WARNING LABEL 1

2W7Z-19A361-DADeluxe Vehicle Security and Keyless Entry Kit (Deluxe RKE/VSS)

REF DESCRIPTION QTYA PC-12 MODULE ASSEMBLY 1B Deluxe RKE/VSS DNA ASSEMBLY (2W7J-19A498-DA) 1D 4 BUTTON POWERCODE TRANSMITTER W/HEADLIGHT ICONS 2I 24-WAY WIRING HARNESS (BASE) 1J 16-WAY WIRING HARNESS (ADVANCE FUNCTIONS) 1L STATUS INDICATOR ASSEMBLY 1G DIPOLE ANTENNA 1N 125 DB SIREN ASSEMBLY 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1O VSS WINDOW WARNING DECAL 2

Page 8: ALL MODELS 2002

8Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

2W7Z-19A361-CAVehicle Security and Keyless Entry Kit (RKE/VSS)

REF DESCRIPTION QTYA PC-12 MODULE ASSEMBLY 1B RKE/VSS DNA ASSEMBLY (2W7J-19A498-CA) 1C 2 BUTTON POWERCODE TRANSMITTER W/LOCK, UNLOCK ICONS 2I 24-WAY WIRING HARNESS (BASE) 1L STATUS INDICATOR ASSEMBLY 1H WHIP ANTENNA 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1O VSS WINDOW WARNING DECAL 2

2W7Z-19A361-BAVehicle Security Kit (VSS)

REF DESCRIPTION QTYA PC-12 MODULE ASSEMBLY 1B VSS DNA ASSEMBLY (2W7J-19A498-CA) 1I 24-WAY WIRING HARNESS (BASE) 1L STATUS INDICATOR ASSEMBLY 1H WHIP ANTENNA 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1O VSS WINDOW WARNING DECAL 2

2W7Z-19A361-AAKeyless Entry Kit (RKE)

REF DESCRIPTION QTYA PC-12 MODULE ASSEMBLY 1B RKE DNA ASSEMBLY (2W7J-19A498-BA) 1I 24-WAY WIRING HARNESS (BASE) 1L STATUS INDICATOR ASSEMBLY 1H WHIP ANTENNA 1S - BB INSTALLATION PARTS BAG 1CC, DD FUSE PARTS BAG 1R OPERATORS INSTRUCTION 1S OPERATORS QUICK REFERENCE WALLET CARD 1

Page 9: ALL MODELS 2002

92W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

MODULE PREPARATION

Place the supplied fuses into the power distributionblock on the control module. Refer to the fuseplacement drawing for the specific vehicle that you areworking on. Fuse placement drawings are located invehicle specific wiring sections.In this diagram, the parking light fuse is shown in thepositive polarity position and the Dome light fuse isshown in the negative polarity position.Note: The HVAC1, HVAC2 and IGNITION fuses are onlyused on systems including remote car start (requiresPC-32 module).

Place the software cartridge (DNA) onto the controlmodule as shown.

Plug the wiring harness(es) into the module.

Harness A: 24-way, used on all systems;Harness B: 10-way, used on all systems with car start;Harness C: 16-way, used on systems with conveniencefeatures (i.e. Headlight control, memory seat control)along with some preload system installations in vehicleswithout factory equipped RKE.

If you are installing a system that uses the whipantenna (RKE, RKE/VSS or Preload), plug the whipantenna into the module at this time.

1

515151515 15 15

15

51515

151515

-+

-+

HVAC 1

HVAC 2

MAIN B+

IGNITION

DOME LIGHT

DRIVER DOOR UNLOCK/TRUNK RELEASE

PK LIGHTS

DOOR LOCKS

C BA

2

3

Page 10: ALL MODELS 2002

10Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

MODULE PREPARATION (Cont’t)

Tape the harness sections together, making sure to cover all of the unused wires.

4

5

Unused wires

Steering column harness

Driver kick panel harness

Referring to the vehicle specific wiring section for thesystem being installed, gather all individual wires thatwill be routed to the same areas of the vehicle intogroups. Cover each wire group with tape forapproximately 18”. Depending upon the vehicle, therewill be 2 - 5 different wire groups.Trim the unused wires approximately 6 - 8” from themodule. Do not cut the override/programming button offof the harness, it is used for all installations.

3” - 4”

2” - 3”

Page 11: ALL MODELS 2002

112W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

VEHICLE PREPARATION

All models except LS, T-Bird, Escort, Econoline andSuper-Duty Pick-ups, remove the steering columnshroud to allow access to the PATS transceiver antennaring around the ignition switch lock cylinder.

A. To allow access to the necessary vehicle circuits,remove the interior panels as required.

B. Identify the control module mounting location andappropriate vehicle circuit connection points. Planwire harness routings that will be free and clear ofall moving underdash components (i.e. acceleratorpedal, adjustable position brake pedal assemblyand parking brake mechanism.

1

2

3 Test for Factory Perimeter Alarm (vehicles equipped with factory RKE only):1. Roll down the driver’s door window and then close all doors, hood, trunk or hatch;2. Lock the doors using the factory RKE transmitter;3. Wait one minute, then reach in the driver door window and open the drivers door (do not unlock doors with the factory

RKE remote).€ If the vehicle’s horn begins sounding when the door is opened, the vehicle is equipped with factory perimeter alarm.

Unlock the doors with the factory RKE remote to turn off the alarm. In this case, wire the systems factory perimeteralarm disarm wire to the vehicle’s perimeter alarm disarm input (See the vehicle specific wiring section). Skip the testfor door trim switch disable below.

€ If the horn does not begin sounding when the door is opened, the vehicle is not equipped with factory installedperimeter alarm. Follow the test procedure below for door trim switch disable.

Test for Door Trim Switch Disable option (vehicles equipped with factory RKE only):1. Roll down the driver door window and close all doors, hood, trunk or hatch;2. Lock the doors using the factory RKE transmitter;3. Wait one minute, then reach in the driver door window and press the door trim unlock switch.€ If the doors unlock, the door trim disable feature is not enabled and no further action is required.€ If the doors do not unlock, connect the system’s factory alarm disarm output as shown in the vehicle specific wiring

section or disable the door trim switch disable feature using the NGS or WDS testers.

Page 12: ALL MODELS 2002

12Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

DIPOLE ANTENNA MOUNTING

2

1 The optimum operating range for this system isdependant upon proper selection of the mountinglocation for the Dipole antenna.

• Never mount the antenna behind (or on) any metalfilm or metal film window tint on the windshield.

• Never mount the antenna so that one of the antennaelements touches or crosses any vehicle wiring and/or metal.

• On vehicles with no metal film in the windshieldaround the mirror and a non-electronic mirror, mountthe di-pole antenna between the headliner andrearview mirror.

• On vehicles equipped with an “Electronic” mirror orvehicles with metal film in the windshield near themirror, mount the di-pole antenna approximately 3”below the mirrors attachment point to the windshieldand/or any mirror electronics;

A. Clean the selected mounting location using aalcohol based glass cleaning solution.

B. Mount the Di-pole antenna as shown. Remove theprotective backing from the adhesive. Use care notto touch the adhesive backing. Firmly press on thebody of the antenna to ensure good glass toadhesive bond.

ELECTRONIC MIRROR

NON-ELECTRONICMIRROR

Route the antenna cable to the control module mountinglocation. Make sure that the antenna cable is routed freeand clear of all moving assemblies such as theemergency brake and/or the adjustable brake pedalassembly.The antenna cable can generally be “tucked” behind theheadliner and “A-pillar” trim panel(s) without the need toloosen or remove any of the trim panels. If it isnecessary to loosen or remove any of the interior trimpanels to run the antenna cable, proceed with caution asthese trim pieces are sometimes easily damaged. Alsonote that some interior trim fasteners are “one-time” useand must be replaced if removed.

!

Metal Film in windshield

Page 13: ALL MODELS 2002

132W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

STATUS LED

Identify a suitable mounting location for the status LED.Make sure that there is at least 3/4” clearance behindthe selected mounting location.

1

Drill a 9/32” mounting hole.

If necessary, remove the selected trim panel2

3 4Insert status LED into drilled hole.

5 If necessary, reinstall any interior trim panels removedduring this procedure.

6 The LED will plug into the main wiring harness duringthe wiring steps. Make sure to leave the LED pigtailaccessible.

Page 14: ALL MODELS 2002

14Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

SECURILOCK INTERFACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB

Route the loop end of Securilock interface antenna ( B )up along steering column to the area around the PATStransceiver antenna coil. Then using the supplied smalltie wraps, secure the antenna harness to existing vehiclewiring harnesses along the steering column allowingenough slack for the antenna loop to go around thePATS transceiver antenna.

NOTE: On LS and T-Bird, the ignition switch is mountedon the dash to the right of the steering column. On thosevehicles, route the securilock interface antenna loop tothe ignition switch.

1

Following the directions on the supplied ampule ofadhesive primer ( D ), apply a thin coating primer toentire transceiver antenna coil. Allow the primer to dryfor 5 minutes before proceeding with the next step.

2

Remove backing from one side of supplied two-way tape( E ) and apply tape around transceiver antenna coil.

3

D

E

A

BC

D

E

SECURILOCK KITCOMPONENTS

Page 15: ALL MODELS 2002

152W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

CORRECTINCORRECT

SECURILOCK INTERFACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB (Con’t)

Remove backing on tape ( E ) and position antennaloop ( B ) on tape around antenna coil.Make sure to align stripe (Black or Red) on antenna loopdirectly over the PATS antenna coil. The antenna islocated near the outer edge (key side) of the transceiverhousing. Press on antenna loop wire to ensure initialbond between tape and wire.

4

5

Vehicle wiring harness

X

6

A

B

Use a tie wrap (Y) to complete the bottom of the antennaloop as shown. Make sure that the Securilock PATSantenna loop ( B ) is as close to the PATS antenna aspossible.

Y

A. Mount the Securilock Interface Module ( A ) to anunderdash wiring harness using one of the suppliedlong tie wraps (X) as shown. DO NOT mount theSecurilock Interface Module: 1) To or within 3” of ametal surface, including any underdash brackets, or2) In the knee bolster area.

B. Route the harness and connector ( C ) to modulemounting location.

Stripe

Page 16: ALL MODELS 2002

16Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

SECURILOCK INTERFACE KIT - 1L3Z-19G365-AB

Route the loop end of PATS interface antenna ( B ) leadup along steering column to area around transceiverantenna coil.

Slip antenna loop ( B ) over PATS transceiver.2

3

1A

BC

B

Vehicle wiring harness

XA

SECURILOCK KITCOMPONENTS

A. Mount the Securilock Interface Module ( A ) to anunderdash wiring harness using one of the suppliedlong tie wraps (X) as shown. DO NOT mount theSecurilock Interface Module: 1) To or within 3” of ametal surface, including any underdash brackets, or2) In the knee bolster area.

B. Route the harness and connector ( C ) to modulemounting location.

Page 17: ALL MODELS 2002

172W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Locate a suitable mounting location that away from hotand/or moving vehicle/engine components.

SIREN INSTALLATION

Mount siren using screws provided (BB). Applyrustproofing compound (Super Seal #F3AZ-19515-SA)to drilled holes and mounting screws.

Locate a vehicle grommet to route wire throughbulkhead panel.

1 2

Pass wires into vehicles interior compartment. Usesilicone sealer (P/N D6AZ-19562-AA) as necessary toseal grommet.

3 4

A B C

BB

BB

SILICO

NERU

BBER

Page 18: ALL MODELS 2002

18Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

2x

Locate an easy to access area near the drivers sidehood hinge.

Mount the hood safety switch using the supplied sheetmetal screws (BB) so that the switch will be biaseddownward when the hood is closed. Route the wirecarefully avoiding any moving parts or excessive heat.

Select a proper grounding point and clean surface ofpaint, grease and dirt. Attach ground lug to connectionpoint using the sheet metal screw provided (BB). Torqueground screw to 10 in / lbs. Apply rustproofing compound(Super Seal #F3AZ-19515-SA) to drilled hole.Note: Ground connection must be tight and secure.Failure of ground connection can prevent properoperation of system.

The remaining hood switch wire will be connected duringthe wiring steps. Refer to the siren installation steps fordirections on routing this wiring through the bulkheadpanel.

1

2

3

HOOD TILT SWITCH INSTALLATION

10 in / lbs

M

BB

BB

Page 19: ALL MODELS 2002

192W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

MOUNTING THE CONTROL MODULE

1

3

To Securilockmodule

Trim and tape off

WHITE

RF Antenna

A. Using the supplied long tie wraps (X), mount thecontrol module to underdash wiring harnesses and/or dash mounting brackets. Module mountinglocations are provided on the last page of thevehicle specific wiring sections. DO NOT mount thecontrol module in the knee bolster area. To ensurebest performance of the built-in shock sensor,securely tie wrap the control module at three pointsto the vehicle.

B. Route the different sections of the wiring harness tothe appropriate underdash areas of the vehicle.Neatness in this area is very important in ensuring aquality finished installation. Wherever possible, routethe PowerCode system wires along with existingvehicle wiring harnesses and tie wrap thePowerCode wiring harnesses to existing vehiclewiring harnesses.

Make sure to route the PowerCode system wiring sothat it is free and clear of all moving underdashcomponents (i.e. accelerator pedal, adjustable brakepedal assembly and/or parking brake mechanism).

Plug the connectors for the Securilock interface andantenna (if not already done) into the control module asshown.

To Status LED

Main wire harness

2 Plug the Status LED into the main wiring harness.

!

Page 20: ALL MODELS 2002

20Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

SYSTEM WIRING CONNECTIONS

1 A. Finish routing the systems wiring harnesses to their destination points and secure all system wiring using the supplied tiewraps (Y).

B. Make the wiring connections as shown. Vehicle specific wiring diagrams begin on page 38, or if viewing this documentelectronically, click here to go there now

Make sure to test each vehicle circuit prior to making any connections - All vehicle wiring is subject tochange.Instructions on proper wiring connection methods and circuit testing can be found in the reference section of thismanual.

C. After completing all the system wiring, follow the instructions beginning on the next page to program and test the systemsfunctionality.NOTE: The system will not function properly if not programmed.

RMST SYSTEMS ONLY - Install the Orangewarning label on the radiator shroud (or similararea).

VSS SYSTEMS ONLY - Install the window decals onboth the driver and passenger side windows.

WARNING: / AVERTISSEMENTThis vehicle is equipped with a remote controlled engine starter. To reduce the risk of serious Injury or death, switch engine startersystem into service mode and disconnect the vehicle batterybefore performing any service on the vehicle.Ce véhicule est doté d'un démarreur à distance. Pour réduire les risques de blessures graves ou mortelles, mettre le démarreur à distance en mode service et débrancher la batterie du véhicule avant d'effectuer des travaux d'entretien sur celui-ci.

1 2WARNING LABEL INSTALLATION

Page 21: ALL MODELS 2002

212W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Transmitter programming:

A. Open the driver’s door (press and hold in brake pedal on Remote Start only system);

NOTE: On vehicles with negative polarity door trigger circuits (Refer to the vehicle specific programmingsection), the door is closed during this step unless the door trigger polarity option has been previously changedto negative.

B. Turn the ignition key to the ON or RUN position;C. Press and hold the programming/override button;

After 10 seconds the horn will chirp 3 times, indicating the system is now in the transmitter learn mode.D. Release the programming/override button;E. Press transmitter button 1( on all, except RMST system which is ) on the on the remote control transmitter to

be programmed.The horn will chirp one time to indicate that the transmitter has been learned.

Notes:A. Up to a total of 8 transmitters can be programmed at this timeB. Transmitters shipped with complete kits or personality kits are pre-programmed to the DNA and do not need to be

programmed at this time.C. If the vehicle is equipped with memory seats/functions, the last two transmitters programmed will activate the memory

seats/functions.D. All programmed transmitters can be erased from memory by pressing the door trim switch “unlock button” while in

transmitter learn mode (requires that the Disarm input and Unlock sense input wires be connected)

System Programming Instructions

1

Each system has several user programmable options which can be changed to accommodate different vehicle options and/or consumers desires. Virtually every installation will require that some option(s) to be changed. Charts listing the optionsfor each system and the factory default settings are located on the following pages.

Option programming:A. Follow the instructions above to enter transmitter learn mode;B. Press and release the programming/override button.

The horn will chirp four times indicating the system has entered the first option bank.Note:Depending upon the system that you are working with, there will be anywhere from 2 – 5 option programming banks. Eachoption bank contains anywhere from 2 – 8 options.

To change the setting of an option (Remote control systems):A. Press button 3 (see chart to the right) to advance to the desired option (refer to

the programming charts on the following pages for the specific system that youare programming;The horn will chirp a number of times to indicate which option is selected (i.e. Twochirps indicates that option number two has been selected).

B. Press the button 1 to change the setting of the optionThe status LED indicates the setting of the option: LED ON indicates that theoption is on, LED OFF indicates that the option is off.

Note:Pressing transmitter button 2 while in any option bank will reset all options, except forthe “Installer” options and the shock sensor to their factory settings. The system willrespond by chirping the horn 4 times.

2

1 2 1 2

3

3

4 ButtonTransmitter

2 ButtonTransmiter

Press both buttons together

!

Page 22: ALL MODELS 2002

22Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

To change the setting of an option (VSS system):A. Press the door trim “Lock” switch to advance to the desired option (refer to the programming charts on the following

pages for the specific system that you are programming;The horn will chirp a number of times to indicate which option is selected (i.e. Two chirps indicates that option number twohas been selected).

B. Press the door trim “Unlock” switch to change the setting of the optionThe status LED indicates the setting of the option: LED ON indicates that the option is on, LED OFF indicates that theoption is off.

Note:Pressing the door trim switch “lock button” while in transmitter learn mode will reset all options to their factory default settings,except for the installer options and shock sensor settings. The system will respond by chirping the horn 4 times.

To advance to the next option bank:A. At any point while in option programming, press and release the programming/override button to advance to the next

option bank.The horn will chirp a number of times, indicating which option bank the system has entered (i.e. 5 chirps indicates thatthe system is in option programming bank #2. Refer to the option programming chart to correlate the horn chirps to optionbank).

System Programming Instructions (Con’t)

2 CONTINUED

3 Shock sensor setting (not applicable to RKE or RKE/RMST systems)The “Lite-touch” and “Full shock” sensor settings are always the first and second options, respectively, in thefirst option bank. To change a shock sensor setting, follow these steps:

Remote control systems:A. Enter option learn mode, option bank 1, as shown in step 2 of this section.B. Go to option #1 for Lite-touch or option #2 for Full shock.C. After the desired option is selected, pressing transmitter button 1 will increase sensitivity and pressing transmitter

button 2 will decrease sensitivity.The system will chirp the horn each time a impact is detected that is greater than the current setting while the system isin shock sensor setting mode.

VSS SystemA. Make sure that the drivers window is rolled down.B. Enter option learn mode, option bank 1, as shown in step 2 of this section.C. Go to option #1 for Lite-touch or option #2 for Full shock.D. Select the desired option and close all doors.E. Press the door trim “Unlock” switch to increase sensitivity and pressing the door trim “Lock” switch to decrease sensitivity.

The system will chirp the horn each time a impact is detected that is greater than the current setting while the system isin shock sensor setting mode.

F. Once the desired sensitivity is achieved, open a door to advance to the next option.

All Security Sytems:A. The Full trigger shock sensor setting must be set within 10 increments of the least sensative setting and the “lite-touch”

setting must be set to within 30 increments of the least sensative setting.B. Deviation from this setting recomendation introduces the potential of false alarm triggers, due to electrical or mechanical

interference.

Page 23: ALL MODELS 2002

232W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Securilock (PATS) Interface Programming and Remote Start Operation Test(two programmed PATS ignition keys are required for this step)NOTE: This step does not apply to Econoline, SuperDuty Pick-ups and EscortA. Sitting in the driver seat, be prepared to press the brake pedal to shut down the remote starter system.B. Using the first key, turn the ignition on, wait for the THEFT light to turn off, then turn the ignition off and remove key from the ignition

switch.C. Using the second key, turn the ignition on, wait for the THEFT light to turn off, then turn the ignition off and remove key from the ignition

switch.D. Activate the remote start function using the PowerCode remote control transmitter.

The system should flash the parking lights and chirp the horn one time, pause for four seconds then start then start the engine.E. After the engine is started. Press the brake pedal to shutdown the engine.

The Securilock interface is now programmed. If the theft light begins flashing rapidly and/or the engine does not crank or cranks butwill not start, refer to the troubleshooting information below.

F. Open the hood.G. Sitting in driver’s seat, be prepared to press the brake pedal, activate the start function.

The system should chirp the horn two (2) times and abort the start sequence.H. Close the hood.I. Place ignition key in the ignition cylinder.J. Again, Sitting in driver’s seat, be prepared to press the brake pedal and activate a start sequence.

The system should chirp the horn one (1) time pause four seconds, then chirp the horn two (2) times and abort the start sequence.

In steps G and J above, the engine MUST NOT start! If the system starts the engine in either steps G or J, check your hood tilt switchinstallation and key-in-sense connection.

Troubleshooting steps:A. If the Securilock interface fails to program (theft light flashing), check the following:

When programming the Securilock Interface timing is important, make sure that you:1. Turn the ignition on with the second key within 5 seconds of the theft light going out on the first key;2. Engage the remote start within 5 seconds of the theft going out on the second key;3. Remove the second ignition key before engaging the remote starter.

NOTE: If a third (or more) PATS ignition key has been programmed to the vehicle using either the Ford NGS or WDS programmers, the “AddKey” mode described in the installation manual may have been disabled. If this is the case, use the NGS or WDS programmer to either re-enable the “add key” mode or program the Securilock Interface kit following the NGS or WDS procedure in the vehicle service manual foradding a new PATS key.B. If the theft light is solid and engine cranks but will not start:

Check all Ignition (Hot through run and crank circuits) and Heater (Run circuits). Make sure that the correct outputs from thePowerCode module are connected to the correct vehicle circuits. Reversing the heater and ignition circuits from the PowerCodesystem will not permanently damage the vehicle but may cause the remote start function to not work and/or set a PCM error codes(which will cause the check engine light to stay on). If the check engine light stays on, use the NGS or WDS testers to identify whichfault code has been set. The fault code will help identify which circuit is not properly connected.

5

!

4 Tach (Idle speed) programming - Remote Start Systems OnlyA. Make sure that the hood is closed before proceeding.B. Enter option learn mode as described in step 2 of this section.C. € RKE/VSS/RMST & RKE/RMST systems - Advance to option bank # 5 (8 chirps)

€ RMST system - Advance to option bank #2 (5 chirps) .D. € RKE/VSS/RMST & RKE/RMST system - Advance to option #6;

€ RMST system - Advance to option #2.E. Press and hold in the brake pedal and start the engine using the ignition key.

Allow the engine to settle to a normal idle speed. The system will chirp the horn every three (3) seconds if a valid tach signal isdetected.

F. After the engine has settled to a normal idle speed, press and release the programming/override button (the horn will honk four (4)times) and turn the ignition key off.

NOTE: If the system is not chirping the horn every three (3) seconds after the engine has started, the system is not seeing a valid tachsignal. Check your tach connection (refer to the appropriate vehicle specific wiring diagram)

System Programming Instructions - Remote Start Systems

Page 24: ALL MODELS 2002

24Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

System Programming Instructions - Security/Convenience Function Test

Convenience FunctionsAll Door Lock / All Door Unlock

Driver door unlock (if installed)

Parking light flash

Trunk or hatch release

Illuminated entry

Ignition triggered lock/unlock (if enabled)

Illuminated exit

Panic alarm

Memory Seat activation (if equipped)

Power Side Sliding door activation (if equipped - Windstar only)

Power Tonneau cover activation (Blackwood only)

Express window down (LS only)

Headlight illumination (if installed)

Security FunctionsSecurity System Arm / Disarm

Using PowerCode remote control transmitters

Using Factory RKE Keyfobs

Verify interior door trim unlock switch DOES NOT disarm system

All entry points trip alarm cycle

Status indicator flashes when armed

Siren (if installed)

Shock sensor settings (lite-touch & full shock)

Remote start convenience functionsHeater & A/C operation during remote start

Rear defroster (if installed)

Remote start safety functionsNo remote start activation with the ignition key inserted into the ignition switch

No remote start activation with the vehicle’s hood open

No remote start activation with the vehicle’s brake pedal depressed

Refer to the Operators manual as necessary and check out the following functions. If any of the functions below, fail tooperate, first refer to the vehicle specific wiring diagrams and check the wiring and system programming.

1

Page 25: ALL MODELS 2002

252W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

SECURILOCK INTERFACE AND RELAY APPLICATION CHART

Note: Application information is also located in thevehicle specific wiring section

Model Year / Model Relay Requirements

2002Securilock

Interface Kit HeadlightRear

DefrosterDriver Door

Unlock OtherCrown Victoria/Grand Marquis 1L3Z-19G365-ABEconoline Not Equipped 1Escort Not EquippedEscape 1S4Z-19G365-AB 1F-150 (Includes Supercrew) 1L3Z-19G365-AB 1F-250/350 (Super-Duty) Not Equipped 1 A, EExpedition/Navaigator 1L3Z-19G365-AB 1 BExcursion 1L3Z-19G365-AB 1 ALS-6/8 1S4Z-19G365-ABFocus 1S4Z-19G365-AB 1 AMustang 1L3Z-19G365-AB 1 1 1Ranger 1L2Z-19G365-AB 1Explorer/Mountaineer 1L2Z-19G365-AB 1 BExplorer Sport/Sport Trac 1L2Z-19G365-AB 1 1Town Car 1L3Z-19G365-AB 1 B, FTaurus/Sable 1L2Z-19G365-AB 1Windstar 1L2Z-19G365-ABT-Bird 1S4Z-19G365-AB2003Aviator 1L2Z-19G365-AB 1 DCrown Victoria/Grand Marquis 1L2Z-19G365-AB 1� E,FEconoline Not Equipped 1Escort Not EquippedEscape 1S4Z-19G365-ABF-150 (Includes Supercrew) 1L3Z-19G365-AB 1F-250/350 (Super-Duty) Not Equipped 1 A, EExpedition/Navaigator 1L2Z-19G365-AB 1Excursion 1L3Z-19G365-AB 1 ALS-6/8 1L2Z-19G365-AB 1 CFocus 1S4Z-19G365-AB 1 AMustang 1L3Z-19G365-AB 1 1 1Ranger 1L2Z-19G365-AB 1Explorer/Mountaineer 1L2Z-19G365-AB 1 BExplorer Sport/Sport Trac 1L2Z-19G365-AB 1 1Town Car 1L2Z-19G365-AB 1 B, FTaurus/Sable 1L2Z-19G365-AB 1Windstar 1L2Z-19G365-ABT-Bird 1L2Z-19G365-AB

111

11111

111

111

111

11111

111

111

Relay’s are available by ordering part numbers:Single: YL3Z-19G390-AA10 Pack:YL3Z-19G390-BA

A - Trim switchdisable,requires 1 relayB - Memory seats, requires 2 relaysC - Parking lights, requires 1 relayD - Key latch release - 1 relayE- Door Lock/Unlock, requires 2 relays for vehicles w/o factory RKEF- Remote Start Systemsrequires 2 relays

1� E

1� E, F

1

1� E

Page 26: ALL MODELS 2002

26Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

SECURILOCK INTERFACE AND RELAY APPLICATION CHART

Note: Application information is also located in thevehicle specific wiring section

Model Year / Model Relay Requirements

2004Securilock

Interface Kit HeadlightRear

DefrosterDriver Door

Unlock OtherAviator 1L2Z-19G365-ABCrown Victoria/Grand Marquis 1L2Z-19G365-ABEconoline Not Equipped 1Escape 1S4Z-19G365-ABF-150 (Classic Body) 1L3Z-19G365-AB 1F-150 (New Body) 1L2Z-19G365-AB 1

Expedition/Navaigator 1L2Z-19G365-AB 1Excursion 1L3Z-19G365-AB 1 A, GLS-6/8 1L2Z-19G365-AB C Focus 1S4Z-19G365-AB 1 A

Mustang 1L3Z-19G365-AB 1 1 1Ranger 1L2Z-19G365-AB 1Explorer/Mountaineer 1L2Z-19G365-AB 1Explorer Sport/Sport Trac 1L2Z-19G365-AB 1 1Town Car 1L2Z-19G365-AB 1 B, FTaurus/Sable 1L2Z-19G365-AB 1T-Bird 1L2Z-19G365-AB2005Aviator 1L2Z-19G365-AB 1 DCrown Victoria/Grand Marquis 1L2Z-19G365-AB 1 EEconoline Not Equipped 1Escape 1L2Z-19G365-AB

F-150 (New Body) 1L2Z-19G365-AB 1Expedition/Navigator 1L2Z-19G365-AB 1Excursion 1L3Z-19G365-AB 1 A, GFive Hundred/Freestyle 1L2Z-19G365-ABFocus 1S4Z-19G365-AB 1 AFreestar/Monterey 1L2Z-19G365-AB 1 1 1 C

Explorer/Mountaineer 1L2Z-19G365-AB 1Explorer Sport/Sport Trac 1L2Z-19G365-AB 1 1

Town Car 1L2Z-19G365-AB 1 BTaurus/Sable 1L2Z-19G365-AB 1

E, F1 E, G1

1

11

1

111

11

11

1111

1

1

1

Relay's are available by ordering part numbers:Single: YL3Z-19G390-AA10 Pack:YL3Z-19G390-BA

A - Trim switchdisable,requires 1 relayB - Memory seats, requires 2 relaysC - Parking lights, requires 1 relayD - Key latch release - 1 relayE- Door Lock/Unlock, requires 2 relays for vehicles w/o factory RKEF- Remote Start Systemsrequires 2 relaysG- Tach Inverter requiredfor vehicles with 6.0Literdiesel engines

1 E

1 D

1

1

F-250/350 (Super Duty) Not Equipped 1 1 A, E, G

Freestar/Monterey 1L2Z-19G365-AB 1 1 C

LS-6/8 1L2Z-19G365-AB C Mustang (New) 1 1L2Z-19G365-AB

T-Bird 1L2Z-19G365-AB 1

F-250/350 (Super Duty) Not Equipped 1 1 A, E, G

E, G

Ranger Not Equipped 1 1

Page 27: ALL MODELS 2002

272W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Option Bank 1 – 4 chirps1 – Lite-touch adjustment2 – Full shock adjustment3 – Optional alarm disable

Disables security functionality. .................................................................................................................... Off4 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off5 – Passive arming

Security system activates 1 minutes after key off event. ............................................................................ Off6 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off7 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On8 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Ignition lockAll doors lock when ignition key is turned to on (run). ................................................................................ Off

3 – Ignition unlockAll doors are unlocked when ignition key is turned to off. .......................................................................... Off

4 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

5 – Illuminated exitActivates dome light output for one minute when ignition key is turned off ................................................ On

6 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

7 – Noise controlLimits alarm trips to 5 per zone .................................................................................................................. On

8 – Factory RKE system does not arm alarmPrevents factory RKE from arming security system. Still allowsfactory RKE to disarm security system. ...................................................................................................... Off

Option Bank 3 – 6 chirps1 – Tach diagnostic mode

This feature should only be used for troubleshooting purposes only!Car start function ignores tach input and cranks starter one time for one second.WARNING – Over rev and stall detection is disabled when this option is enabled. ................................... Off

2 – Car start run timeLED On – 15 minutes, LED Off – 10 minutes ............................................................................................ Off

3 – Lock after start(Re)locks doors after remote start. ............................................................................................................. Off

4 – One button startActivates remote start by press and hold of start button. ........................................................................... Off

5 – Diesel timerDelays crank attempt 30 seconds after ignition on. .................................................................................... Off

6 – Aux2 is Rear Defrost outputAux2 output can only be activated after remote start. ................................................................................ On

RKE/VSS/RMST OPTION CHART

Factory setting

Factory setting

Factory setting

Page 28: ALL MODELS 2002

28Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

Option Bank 4 – 7 chirps1 – Aux1 (Headlight) time

LED On – 20 seconds, LED Off – .5 seconds ........................................................................................... On (20 sec.)2 – Aux2 (Rear defroster) time

LED On – 10 minutes, LED Off – .5 seconds ............................................................................................ Off (.5 sec.)3 – Aux3 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)4 – Aux4 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)5 – Aux4 remapped to Aux1

Switches headlight output to AUX functionality, controlled by pressingFind/Panic & Start buttons simultaneously. ................................................................................................ Off

Option Bank 5 – 8 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)2 – Unlock sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)3 – Key-in sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... Off (Negative)4 – Entry delay

5 Second entry delay. Used for vehicles with external door mounted RKE keypads ................................. Off5 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off6 – Learn tachometer

With hood open or brake pedal pressed start engine. System will chirp hornevery five seconds if a valid tach signal is present.

RKE/VSS/RMST OPTION CHART (Cont’t)

Page 29: ALL MODELS 2002

292W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Option Bank 1 – 4 chirps1 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off2 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off3 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On4 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Ignition lockAll doors lock when ignition key is turned to on (run). ................................................................................ Off

3 – Ignition unlockAll doors are unlocked when ignition key is turned to off. .......................................................................... Off

4 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

5 – Illuminated exitActivates dome light output for one minute when ignition key is turned off ................................................ On

6 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

7 – Factory RKE system does not arm alarmPrevents factory RKE from arming security system. Still allowsfactory RKE to disarm security system. ...................................................................................................... Off

Option Bank 3 – 6 chirps1 – Tach diagnostic mode

This feature should only be used for troubleshooting purposes only!Car start function ignores tach input, cranks starter one time for one second.WARNING – Over rev and stall detection is disabled. ................................................................................ Off

2 – Car start run timeLED On – 15 minutes, LED Off – 10 minutes ............................................................................................ Off

3 – Lock after start(Re)locks doors after remote start. ............................................................................................................. Off

4 – One button startActivates remote start by press and hold of start button. ........................................................................... Off

5 – Diesel timerDelays crank attempt 30 seconds after ignition on. .................................................................................... Off

6 – Aux2 is Rear Defrost outputAux2 output can only be activated after remote start. ................................................................................ On

RKE/RMST OPTION CHART

Factory setting

Factory setting

Factory setting

Page 30: ALL MODELS 2002

30Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

Option Bank 4 – 7 chirps1 – Aux1 (Headlight) time

LED On – 20 seconds, LED Off – .5 seconds ........................................................................................... On (20 sec.)2 – Aux2 (Rear defroster) time

LED On – 10 minutes, LED Off – .5 seconds ............................................................................................ Off (.5 sec.)3 – Aux3 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)4 – Aux4 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)5 – Aux4 remapped to Aux1

Switches headlight output to AUX functionality, controlled by pressingFind/Panic & Start buttons simultaneously. ................................................................................................ Off

Option Bank 5 – 8 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)2 – Unlock sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)3 – Key-in sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... Off (Negative)4 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off5 – Learn tachometer

With hood open or brake pedal pressed start engine. System will chirp hornevery five seconds if a valid tach signal is present.

RKE/RMST OPTION CHART (Cont’t)

Page 31: ALL MODELS 2002

312W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

RMST OPTION CHART

Factory setting

Factory setting

Option Bank 1 – 4 chirps1 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On2 – Horn used for alarm

Horn sounds during alarm/panic cycles ..................................................................................................... On3 – Tach diagnostic mode

This feature should only be used for troubleshooting purposes only!Car start function ignores tach input, cranks starter one time for one second.WARNING – Over rev and stall detection is disabled. ................................................................................ Off

4 – Car start run timeLED On – 15 minutes, LED Off – 10 minutes ............................................................................................ Off

5 – One button startActivates remote start by press and hold of start button. ........................................................................... Off

6 – Diesel timerDelays crank attempt 30 seconds after ignition on. .................................................................................... Off

Option Bank 2 – 5 chirps1 – Key-in sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... Off (Negative)2 – Learn tachometer

With hood open or brake pedal pressed start engine. System will chirp hornevery five seconds if a valid tach signal is present.

Page 32: ALL MODELS 2002

32Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

Deluxe RKE/VSS OPTION CHARTFactory setting

Factory setting

Factory setting

Option Bank 1 – 4 chirps1 – Lite-touch adjustment2 – Full shock adjustment3 – Optional alarm disable

Disables security functionality. .................................................................................................................... Off4 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off5 – Passive arming

Security system activates 1 minutes after key off event. ............................................................................ Off6 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off7 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On8 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Ignition lockAll doors lock when ignition key is turned to on (run). ................................................................................ Off

3 – Ignition unlockAll doors are unlocked when ignition key is turned to off. .......................................................................... Off

4 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

5 – Illuminated exitActivates dome light output for one minute when ignition key is turned off ................................................ On

6 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

7 – Noise controlLimits alarm trips to 5 per zone .................................................................................................................. On

8 – Factory RKE system does not arm alarmPrevents factory RKE from arming security system. Still allowsfactory RKE to disarm security system. ...................................................................................................... Off

Option Bank 3 – 6 chirps1 – Aux1 (Headlight) time

LED On – 20 seconds, LED Off – .5 seconds ........................................................................................... On (20 sec.)2 – Aux3 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)3 – Aux4 time

LED On – .5 seconds, LED Off – Time held .............................................................................................. On (.5 sec.)4 – Aux4 remapped to Aux1

Switches headlight output to AUX functionality, controlled by pressingFind/Panic & Headlight buttons simultaneously. ......................................................................................... Off

Option Bank 4 – 7 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)2 – Unlock sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)3 – Entry delay

5 Second entry delay. Used for vehicles with external door mounted RKE keypads ................................. Off4 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off

Page 33: ALL MODELS 2002

332W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

RKE/VSS & VSS OPTION CHARTFactory setting

Factory setting

Factory setting

Option Bank 1 – 4 chirps1 – Lite-touch adjustment2 – Full shock adjustment3 – Optional alarm disable

Disables security functionality. .................................................................................................................... Off4 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off5 – Passive arming

Security system activates 1 minutes after key off event. ............................................................................ Off6 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off7 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On8 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Ignition lockAll doors lock when ignition key is turned to on (run). ................................................................................ Off

3 – Ignition unlockAll doors are unlocked when ignition key is turned to off. .......................................................................... Off

4 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

5 – Illuminated exitActivates dome light output for one minute when ignition key is turned off ................................................ On

6 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

7 – Noise controlLimits alarm trips to 5 per zone .................................................................................................................. On

8 – Factory RKE system does not arm alarmPrevents factory RKE from arming security system. Still allowsfactory RKE to disarm security system. ...................................................................................................... Off

Option Bank 3 – 6 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)2 – Unlock sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)3 – Entry delay

5 Second entry delay. Used for vehicles with external door mounted RKE keypads ................................. Off4 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off

Page 34: ALL MODELS 2002

34Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

RKE OPTION CHARTFactory setting

Factory setting

Factory setting

Option Bank 1 – 4 chirps1 – Lite-touch adjustment2 – Full shock adjustment3 – Optional alarm disable

Disables security functionality. .................................................................................................................... Off4 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off5 – Passive arming

Security system activates 1 minutes after key off event. ............................................................................ Off6 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off7 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On8 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Ignition lockAll doors lock when ignition key is turned to on (run). ................................................................................ Off

3 – Ignition unlockAll doors are unlocked when ignition key is turned to off. .......................................................................... Off

4 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

5 – Illuminated exitActivates dome light output for one minute when ignition key is turned off ................................................ On

6 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

7 – Noise controlLimits alarm trips to 5 per zone .................................................................................................................. On

Option Bank 3 – 6 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)2 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off

Page 35: ALL MODELS 2002

352W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Option Bank 1 – 4 chirps1 – Lite-touch adjustment2 – Full shock adjustment3 – Optional alarm disable

Disables security functionality. .................................................................................................................... Off4 – Passive starter Interrupt

Starter interrupt activates 1 minutes after key off event. ............................................................................ Off5 – Passive arming

Security system activates 1 minutes after key off event. ............................................................................ Off6 – Passive door locks

All doors lock automatically 1 minutes after key off event. ......................................................................... Off7 – Selectable chirps

Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On8 – Silent choice

On – Confirmation chirp on second press of transmitter buttonOff – Confirmation chirp on first press of transmitter button.Requires option #7 (above) to be ON. ........................................................................................................ On

Option Bank 2 – 5 chirps1 – Drivers door priority unlock

Drivers door only unlocks on first press of Disarm/Unlock,All doors unlock on second press within 5 seconds. .................................................................................. Off

2 – Delayed door lockWaits 3 seconds after key on event before activating ignition locked.Used on vehicles with theater dimming interior lights. ............................................................................... Off

3 – Horn used for alarmHorn sounds during alarm/panic cycles ..................................................................................................... On

4 – Noise controlLimits alarm trips to 5 per zone .................................................................................................................. On

Option Bank 3 – 6 chirps1 – Blind Crank

Car start function ignores tach input, cranks starter one time for one second.WARNING – Over rev and stall detection is disabled. ................................................................................ Off

2 – Car start run timeLED On – 15 minutes, LED Off – 10 minutes ............................................................................................ Off

3 – Lock after start(Re)locks doors after remote start. ............................................................................................................. Off

4 – One button startActivates remote start by press and hold of start button. ........................................................................... Off

5 – Diesel timerDelays crank attempt 30 seconds after ignition on. .................................................................................... Off

Option Bank 4 – 7 chirps1 – Door trigger polarity

LED On – Positive, LED Off – Negative ..................................................................................................... On (Positive)3 – Key-in sense polarity

LED On – Positive, LED Off – Negative ..................................................................................................... Off (Negative)5 – Use trunk relay as Driver door unlock

Switches Trunk release and Drivers door unlock outputs ........................................................................... Off6 – Learn tachometer

With hood open or brake pedal pressed start engine. System will chirp hornevery five seconds if a valid tach signal is present.

LOT MODE ONLY OPTION CHART

Factory setting

Factory setting

Factory setting

Factory setting

Page 36: ALL MODELS 2002

36Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

5 1 2 3 4 6 7 8 9

10 11 12 13 14 15 16

9 10 11 12 1 2 3 4 5 6 7 8

13 14 15 16 17 18 19 20 21 22 23 24

2 3 5 1 4 6

7 8 9 10

WIRE END VIEWS

AMAIN HARNESS

BCAR START

BEXTENDED FUNCTION

WIRING HARNESS LEGEND

Main Harness (24-way)Terminal Wire Color Function

A-1 WHITE Parking Light OutputA-2 BLUE Door Lock OutputA-3 BLACK/WHITE Dome Light OutputA-4 RED BatteryA-5 BLACK GroundA-6 VIOLET/RED Starter Interrupt (Key

side)A-7 PINK Ignition 1 Input/Output

A-8 VIOLET Starter Interrupt (Motorside)

A-9 BROWN Disarm InputA-10 YELLOW/WHITE Door Trigger Input Pull-

upA-11 WHITE/BLUE Arm InputA-12 LT.GREEN Unlock Switch Sense

InputA-13 TAN Trunk Release/Driver

Door Unlock ReleaseOutput

A-14 GREEN Door Unlock OutputA-15 RED Siren FeedA-16 BLACK Siren OutputA-17 BROWN Programming/Override

ButtonA-18 BROWN Programming/Override

ButtonA-19 GRAY Hood Open Switch

InputA-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay OutputA-22 RED LEDA-23 BLACK LEDA-24 BLUE/GREEN (-) Drivers Door

Unlock/Trunk releaseOutput

Car Start Harness (10-way)Terminal Wire Color Function

B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputB-6 Open -B-7 BROWN Brake InputB-8 BLACK/WHITE Key-in-sense InputB-9 VIOLET/WHITE Tach Sense InputB-10 BLUE/BLACK Active Out

Extended Function Harness (16-way)Terminal Wire Color Function

C-1 BLUE/BLACK Door Lock Switch InputC-2 BLACK/GREEN AUX 3C-3 GREEN/BLACK Door Unlock Switch

InputC-4 LT.GREEN/BLACK Factory Perimeter

Alarm Disarm OutputC-5 Open -C-6 Open -C-7 BROWN/TAN Trunk Release Disarm

InputC-8 BLUE Trunk Ajar InputC-9 TAN/RED Trunk Release/Driver

Door Unlock SwitchInput

C-10 RED/WHITE Headlight Output /AUX 1

C-11 BLUE/WHITE Rear Defroster Output / AUX 2

C-12 GREEN/WHITE Memory 1 OutputC-13 YELLOW/GREEN Memory 2 OutputC-14 Open -C-15 Open -C-16 Open -

Page 37: ALL MODELS 2002

372W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Circuit Testing - Identifying Circuit Polarity

1

DC Volts

Digital Volt Meter (DVM) set to “DC Volts”.Negative lead (Black) connected to a chassis ground.Positive lead (Red) connected to circuit under test.Observe reading from meter.

2Actuate the circuit under test.

Observe reading from meter.A reading of 0V transiting to +12V when the switch ispressed, indicates that the circuit under test is aPositive polarity circuit.A reading of +12V transiting to 0V when the switch ispressed, indicates that the circuit under test is aNegative polarity circuit.

NOTE: When testing a Negative polarity circuit,the stand by voltage will not always be +12V. Insome cases the reading observed prior toactuating the circuit could be less than one (1)volt. However, when actuated the observedvoltage will be 0V or very close to it.

3

!

0V 12V

POSITIVEPOLARITYCIRCUIT

0V12V

NEGATIVEPOLARITYCIRCUIT

Page 38: ALL MODELS 2002

38Rev Date 8/25/04 © Copyright Ford Motor Company 20042W7Z-16A901-AA

2 4 3 1

2 3 4 5 1

1 Wire splice procedure

2 Butt splice procedure

Wire Connection Procedures

Page 39: ALL MODELS 2002

392W7Z-16A901-AA Rev Date 8/25/04 © Copyright Ford Motor Company 2004

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input C-4 LT GREEN/BLACK Factory alarm disarm outputA-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(YELLOW/BLACK)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

w/Factory RKE Deluxe RKE/VSSPage Revision Date

1 of 4 7/30/02

VEHICLE SPECIFIC WIRING DIAGRAMS

This section presents Vehicle/Product specific wiring diagrams are provided for all systems. The diagrams are organized byvehicle (Year/Model) and by Product. For example, to find a specific wiring diagram for installing a RKE/VSS/RMST system ina 2002 Explorer Sport:1. In the Bookmarks pane, click on the “+” symbol to the left of the bookmark for “2002MY”.2. Click on the “+” symbol to the left of the bookmark for for “Explorer Sport/Sport Trac.3. Select the system that you are installing in the links revealed under Explorer Sport/Sport Trac.4. Then using the buttons in the Acrobat toolbar, you can view the individual pages in the drawing.

1

A Title block:Box 1: Lists applicable vehicle(s) by year/make/model;Box 2: Lists any vehicle trim level or special equipment required on the vehicle. This will generally be: ALL, w/Factory

RKE or w/o Factory RKE. Note: If you are working on a vehicle with factory RKE, a drawing that lists “w/o RKE”in this box does not apply to this installation. Conversely, if you are working on a vehicle without factory RKE,disregard the drawings listing “w/Factory RKE” in this box.;

Box 3: Lists the system or systems covered by this drawing (System name --> Short name used in title block);• Remote Start System with Deluxe Vehicle Security and Keyless Entry —> RKE/VSS/RMST• Remote Start System with Keyless Entry —> RKE/RMST• Remote Start System —> RMST• Deluxe Vehicle Security System with Keyless Entry —> Deluxe RKE/VSS (shown in graphic below)• Vehicle Security System with Keyless Entry —> RKE/VSS• Vehicle Security System for Vehicles Equipped with Factory Keyless Entry —> VSS• Keyless Entry System —> RKE

Box 4: Page number and total number of pages which make up the complete drawing;Box 5: Revision date of drawing.

B Lists the systems wires by Connector/Terminal, Wire color, and function.C Lists the vehicle circuit by the vehicle wire color and circuit polarity - Circuit name (wire color) + or (indicates

vehicle’s circuit polarity).D List the circuit location in the vehicle. Clicking on the text will open another window showing a color photograph of the

circuit location in the vehicle (internet connection required).E Optional connections - clicking on the “Optional installation feature” text, will jump to a diagram showing the connection

of the optional circuit. Clicking on the “Go to Previous View” button will return to the original page.

2

B

CD

E

Box 2

Box 1

Box 4

Box 3

Box 5

A

Page 40: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL ALL - Fuse Placement

Page Revision Date

1 of 1 6/15/045151515

15 15 15

15

5151515

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

HATCH RELEASE**

PK LIGHTS

DOOR LOCKS**

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2003-2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - KEY LATCH RELEASE (CAR START SYSTEMS ONLY)

1 - HEADLIGHT ILLUMINATION (OPTIONAL)

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Aux 2 (Rear Defrost) 0.5 Sec pulse (Default)

MODULE MOUNTING LOCATION:

Left side of under dash between fuse/junction box and bulkhead panel.

Page 41: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 4 6/15/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-12 LT GREEN Unlock Switch SenseA-13 TAN Hatch Release

C-12 GREEN/WHITE Memory Seat 1 Output C-13 YELLOW/GREEN Memory Seat 2 OutputA-24 BLUE/GREEN Driver Door Unlock Output

C-9 TAN/RED DO NOT USE B-10 BLUE/BLACK Active Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Factory Alarm Disarm(GREEN/VIOLET)

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (TAN/BLACK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (VSS only) Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Hatch Release Output(PINK/ORANGE)

(NOTE: ALSO INCLUDES RKE/RMST

DRIVER'S REARDOOR SILL PLATEHARNESS

+Unlock Switch Sense(PINK/ORANGE)

DRIVERS SIDEREAR DOORJAMB BOOT

MEMORYSEATSWITCH

Memory Seat 1(TAN/LT GREEN)

Memory Seat 2(BLACK/ORANGE)

Optional Installation Feature

See Optional connections page Cut and tape off if not used

To Key Release Latch Relay*Must Be Connected*

see page 4 of 4

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 42: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (YELLOW)

Ignition (RED/GREEN)

Starter (GREEN)

Heater (GRAY/YELLOW)

IGNITION SWITCHHARNESS

Key-in-Sense (LT GREEN/VIOLET)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections pages

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 4 6/15/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Cut and tape off if not used

+

Page 43: ALL MODELS 2002

OPTIONAL CONNECTIONS

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION/

REAR DEFROSTERWhite

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Blue

Black

Yellow

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 4 6/15/04

REARDEFROST SWITCH

Rear Defroster

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR PRIORITY UNLOCK

White

30

87

87a

85 86

Blue

Black

Yellow

Red

'03 (BLUE/ORANGE)

'04/'05 (GRAY/LT.BLUE)

Page 44: ALL MODELS 2002

REQUIRED CONNECTION

Color Function

B-10 BLUE/BLACK Active Output

KEY LATCH RELEASE RELAY

White

Key switch latch wire (BLACK/PINK)

30

87

87a

85 86

IGNITIONSWITCH

+

Blue

Black

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL ALL RMST

Page Revision Date

4 of 4 6/15/04

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Ignition (RED/GREEN) +

+CUT

Red

NOTE:

This connection is required on all remote start

installations in Aviator's

Page 45: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 2 6/15/04 IGNITION SWITCH

Battery (YELLOW)

Starter (GREEN)

Heater (GRAY/YELLOW)

IGNITION SWITCHHARNESS

Key-in-Sense (LT GREEN/VIOLET)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

FUEL INJECTORTach Signal (TAN/BLACK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light OutputB-10 BLUE/BLACK Active Output

STEERING COLUMN HARNESS

Ignition (RED/GREEN)

+

MAKE THIS CONNECTION LAST!

To Key Release Latch Relay*Must Be Connected*

see page 2 of 2

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 46: ALL MODELS 2002

REQUIRED CONNECTION

Color Function

B-10 BLUE/BLACK Active Output

KEY LATCH RELEASE RELAY

White

Key switch latch wire (BLACK/PINK)

30

87

87a

85 86

IGNITIONSWITCH

+

Blue

Black

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL ALL RMST

Page Revision Date

2 of 2 6/15/04

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Ignition (RED/GREEN) +

+CUT

Red

NOTE:

This connection is required on all remote start

installations in Aviator's

Page 47: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 6/15/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-12 LT GREEN Unlock Switch SenseA-13 TAN Hatch Release Output

C-12 GREEN/WHITE Memory Seat 1 Output C-13 YELLOW/GREEN Memory Seat 2 Output A-24 BLUE/GREEN Driver Door UnlockC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Factory Alarm Disarm(GREEN/VIOLET)

Hatch Release Output(PINK/ORANGE)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

+Unlock Switch Sense(PINK/ORANGE)

DRIVERS SIDEREAR DOORJAMB BOOT

MEMORYSEATSWITCH

Memory Seat 1(TAN/LT GREEN)

Memory Seat 2(BLACK/ORANGE)

DRIVER'S REARSILL PLATEHARNESS

Page 48: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (GREEN)

Ignition (RED/GREEN)

IGNITION SWITCHHARNESSHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 6/15/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 49: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 6/15/04

UNDERHOOD HARNESS

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR P RIORITY UNLOCK

White

30

87

87a

85 86

Blue

Black

Yellow

Red

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 50: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (GREEN)

Ignition (RED/GREEN)

IGNITIONSWITCH

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+Unlock Switch Sense(PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch Sense

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 2 6/15/04

MAKE THIS CONNECTION LAST!

+

DRIVERS SIDEREAR DOORJAMB BOOT

Page 51: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD HARNESS

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

2 of 2 6/15/04

OPTIONAL CONNECTIONS

Page 52: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (GREEN)

Ignition (RED/GREEN)

IGNITIONSWITCHHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS MAKE THIS CONNECTION LAST!

Vehicle (Year/Make/Model)

'03-'05 Aviator

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1 6/15/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch Sense

A-13 TAN Hatch Release Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Hatch Release Output(PINK/ORANGE)

HARNESS UNDERDRIVERS SIDEREAR DOORSILL PLATE

+Unlock Switch Sense(PINK/ORANGE)

DRIVERS SIDEREAR DOORJAMB BOOT

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -Factory Alarm Disarm (GREEN/VIOLET)

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Page 53: ALL MODELS 2002

515151515 15 15

15

515151515 15 15 15

-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L3Z-19G365-AB2003-04: 1L2Z-19G365-AB

RELAY REQUIREMENTS:1 - IGNITION 2 OUTPUT (REQUIRED)1 - HVAC 1 OUTPUT (REQUIRED)1 - DRIVER DOOR UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)Rear Defroster time 0.5 sec. (Default setting)

MODULE MOUNTING LOCATION:Left side of PCM

Page 54: ALL MODELS 2002

+Door Lock (PINK/YELLOW)

+

+

+

DDMIN DRIVERSDOORDoor Unlock (PINK/GREEN)

Trunk Release (VIOLET/YELLOW)

+Trunk Release Disarm (RED)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-7 BROWN/TAN Trunk Release Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock Output

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMSTPage Revision Date

1 of 4 1/5/04 CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER’S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (4 of 4)

NOTE: ALSO COVERS RKE/RMST

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER’S DOOR AT KEYSWITCH

Passenger Door Unlock Motor (PINK/ORANGE) +

+

Page 55: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS/RMSTPage Revision Date

2 of 4 1/5/04

NOTE: ALSO COVERS RKE/RMST

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (4 of 4)

Trunk Release (VIOLET/YELLOW) +

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER’S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles interior.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(YELLOW) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

Fuse15 AMP

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 56: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 4 1/5/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (Lt GREEN/VIOLET)

Battery (YELLOW)

Battery (YELLOW) +

+

+

NOTE: ALSO COVERS RKE/RMST

Cut and tape off if not used

Optional Installation FeatureSee Optional connections (4 of 4)

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)+

Ignition 2 (BLACK/GREEN)

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

30

87

87a

85 86

White

Black

Yellow

Blue

Battery (YELLOW)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

+

Heater (PINK/BLACK)

30

87

87a8586White Black

Yellow

Blue

Battery (Lt GREEN/VIOLET)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Heater 2 (GREY/YELLOW) +

Starter (RED/BLUE )

+CUT

KEY SIDE(after cut)

PLUG RIGHT OF STEERINGCOLUMN

Horn (BLUE)Key-In Sense (BLACK/PINK) -

-

STEERING COLUMN HARNESS, cont’d

Color FunctionA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

Parking Lights (WHITE/BLACKHEADLIGHT SWITCH

-

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

BRAKESWITCH

+Brake (GREEN)

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 57: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

4 of 4 1/5/04

+

+

DDM (IN DRIVER’S DOOR)

+12V Feed (WHITE/LT.BLUE) Connector C501a Cavity #4

Driver Door Unlock (RED/ORANGE)

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

DRIVER’S DOOR UNLOCK

Blue

Red

DEFROSTERSWITCH

Headlights (RED/YELLOW)

-Defroster (D.BLUE/ORANGE)

NOTE: ALSO COVERS RKE/RMST

OPTIONAL CONNECTIONS

HEADLIGHT SWITCH

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

HEADLIGHTS/REAR DEFROSTER

-

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 58: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

VehicleInterior

EngineCompartment

HOOD TILT SWITCH

DRIVER’S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

Color Function A-5 BLACK Ground

DRIVER’S KICK PANEL HARNESS

CONNECTIONS UNDER HOOD

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 1/5/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (Lt GREEN/VIOLET)

Battery (YELLOW)

Battery (YELLOW) +

+

+

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)+

Ignition 2 (BLACK/GREEN)

30

87

87a

85 86

White

Black

Yellow

Blue

Battery (YELLOW)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

+

Heater (PINK/BLACK)

30

87

87a8586White Black

Yellow

Blue

Battery (Lt GREEN/VIOLET)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Heater 2 (GREY/YELLOW) +

Starter (RED/BLUE )

+CUT KEY SIDE

(after cut)PLUG RIGHT OF STEERINGCOLUMN

Horn (BLUE)Key-In Sense (BLACK/PINK) -

-

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

-

Page 59: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

+Door Lock (PINK/YELLOW)

+

+

+

DDMIN DRIVERSDOORDoor Unlock (PINK/GREEN)

Trunk Release (VIOLET/YELLOW)

+Trunk Release Disarm (RED)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-7 BROWN/TAN Trunk Release Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock Output

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

W/Factory RKE DELUXE RKE/VSSPage Revision Date

1 of 4 1/5/04 CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (4 of 4)

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER’S DOOR AT KEYSWITCH

Passenger Door Unlock Motor (PINK/ORANGE) +

+

Page 60: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSSPage Revision Date

2 of 3 1/5/04

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

Trunk Release (VIOLET/YELLOW) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles interior.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(YELLOW) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

Fuse15 AMP

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 61: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

3 of 3 1/5/04Battery (YELLOW)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputC-10 RED/WHITE Headlight OutputC-8 BLUE Trunk Ajar Input HEADLIGHT

SWITCH-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

HEADLIGHT SWITCH

Headlights (RED/YELLOW)

+

+

DDM (IN DRIVER’S DOOR)

+12V Feed (BLACK/WHITE) Connector C501a Cavity #26

Driver Door Unlock (RED/ORANGE)

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

DRIVER’S DOOR UNLOCK Blue

Red

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 24-WAY CONNECTOR

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 62: ALL MODELS 2002

+

+

+

DDM INDRIVER’S DOOR

Passenger Door Unlock Motor (PINK/ORANGE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE) Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 1/5/04Battery (YELLOW)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

CONNECTIONS UNDER HOOD OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Optional parts - notincluded in kit

’02 Ignition (BROWN/PINK)

’03/’04 Ignition (WHITE/YELLOW)

Page 63: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE, RKE/VSS & PRELOADPage Revision Date

1 of 1 1/5/04Battery (YELLOW)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

Parking Lights (WHITE/BLACK)UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+CUT KEY SIDE

(after cut)

MAKE THIS CONNECTION LAST!+

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release Output

DRIVERS SIDE KICK PANEL HARNESS

Trunk Release (VIOLET/YELLOW) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles interior.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(YELLOW) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

15 AMP Fuse

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 64: ALL MODELS 2002

+

Door Lock (PINK/YELLOW)

+

DDM INDRIVER’SDOOR

Door Unlock (PINK/GREEN)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm InputA-9 BROWN Disarm InputA-12 WHITE/BLUE Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

’02-’04 Crown Victoria/Grand MarquisEquipment or Trim level System(s) applicable to:

w/Factory RKE PRELOADPage Revision Date

1 of 1 1/5/04Battery (YELLOW)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+CUT KEY SIDE

(after cut)

MAKE THIS CONNECTION LAST!+

+

Passenger Door Unlock Motor (PINK/ORANGE) +

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)

IN DRIVER’S DOOR AT KEYSWITCH

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER’S DOOR AT KEYSWITCH

Page 65: ALL MODELS 2002

515151515 15 15

15

515151515 15 15 15

- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 6/15/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

2 - DOOR LOCKS w/o FACTORY RKE (REQUIRED)

1 - DRIVER DOOR UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Rear Defroster time 0.5 sec. (Default setting)

MODULE MOUNTING LOCATION:

Left side of driver's side under dash

Page 66: ALL MODELS 2002

+Door Lock (PINK/YELLOW)

+

+

+

DDMIN DRIVERSDOORDoor Unlock (PINK/GREEN)

Trunk Release (VIOLET/YELLOW)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 LT GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock Output

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMST

Page Revision Date

1 of 4 6/15/04 CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER'S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

Optional Installation Feature

See DRIVER'S DOOR UNLOCK (4 of 4)

NOTE: ALSO COVERS RKE/RMST

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER'S DOOR AT KEYSWITCH

+

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 67: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS/RMST

Page Revision Date

2 of 4 6/15/04

NOTE: ALSO COVERS RKE/RMST

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation Feature

See DRIVER'S DOOR UNLOCK (4 of 4)

Trunk Release (VIOLET/YELLOW) +

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER'S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles door.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(LT GREEN/VIOLET) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

Fuse15 AMP

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 68: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 4 6/15/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake Input C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Battery (RED)

+

+

+

NOTE: ALSO COVERS RKE/RMST

Cut and tape off if not used

Optional I nstallation F eature

See Optional connections (3 of 3)

Ignition (VIOLET/ORANGE)

+

+

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Heater 2 (WHITE/VIOLET)

Starter (DK GREEN )

+CUT

KEY SIDE(after cut)

STEERINGCOLUMNHARNESS

Horn (BLUE)

Key-In Sense (BLACK/PINK)

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

BRAKESWITCH

+Brake (LT GREEN/RED)

Heater (GRAY/YELLOW)

+

Page 69: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 4 6/15/04

+

+

DDM (IN DRIVER'S DOOR)

+12V Feed (WHITE/LT.BLUE) Connector C501a Cavity #4

Driver Door Unlock (RED/ORANGE)

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

DRIVER'S DOOR UNLOCK

Blue

Red

DEFROSTERSWITCH

Headlights (RED/YELLOW)

-Defroster (D.BLUE/ORANGE)

NOTE: ALSO COVERS RKE/RMST

OPTIONAL CONNECTIONS

HEADLIGHT SWITCH

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

HEADLIGHTS/REAR DEFROSTER

-

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 70: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

VehicleInterior

EngineCompartment

HOOD TILT SWITCH

DRIVER'S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

Color Function A-5 BLACK Ground

DRIVER'S KICK PANEL HARNESS

CONNECTIONS UNDER HOOD

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 6/15/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake Input

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Battery (RED)

+

+

+

Ignition (VIOLET/ORANGE)

+

+Heater 2 (WHITE/VIOLET)

Starter (DK GREEN)

+CUT

KEY SIDE(after cut)

STEERINGCOLUMNHARNESS

Horn (BLUE)

Key-In Sense (BLACK/PINK)

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

BRAKESWITCH

+Brake (LT GREEN/RED)

Heater (GRAY/YELLOW)

+

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 71: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

+Door Lock (PINK/YELLOW)

+

+

+DDMIN DRIVERSDOOR

Door Unlock (PINK/GREEN)

Trunk Release (VIOLET/YELLOW)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock Output

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

W/Factory RKE DELUXE RKE/VSS

Page Revision Date

1 of 3 6/15/04 CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Optional Installation Feature

See DRIVER'S DOOR UNLOCK (3 of 3)

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER'S DOOR AT KEYSWITCH

+

Page 72: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSS

Page Revision Date

2 of 3 6/15/04

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation Feature

See DRIVER'S DOOR UNLOCK (3 of 3)

Trunk Release (VIOLET/YELLOW) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles door.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(LT GREEN/VIOLET) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

Fuse15 AMP

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 73: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

3 of 3 6/15/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputC-10 RED/WHITE Headlight OutputC-8 BLUE Trunk Ajar Input HEADLIGHT

SWITCH-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (VIOLET/ORANGE)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

+

HEADLIGHT SWITCH

Headlights (RED/YELLOW)

+

+

DDM (IN DRIVER'S DOOR)

+12V Feed (BLACK/WHITE) Connector C501a Cavity #26

Driver Door Unlock (RED/ORANGE)

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

DRIVER'S DOOR UNLOCK

Blue

Red

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 74: ALL MODELS 2002

+

+

+

DDM INDRIVER'S DOOR

Passenger Door Unlock Motor (PINK/ORANGE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK Ground

A-9 BROWN Disarm Input

A-11 WHITE/BLUE Arm Input

A-12 Lt GREEN Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE) Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 6/15/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN)

Horn (BLUE)STEERINGCOLUMN-

CONNECTIONS UNDER HOOD

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Optional parts - notincluded in kit

Ignition (VIOLET/ORANGE)

Page 75: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE, RKE/VSS & PRELOAD

Page Revision Date

1 of 1 6/15/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN )

Horn (BLUE)

STEERINGCOLUMN-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

Parking Lights (WHITE/BLACK)UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+CUT KEY SIDE

(after cut)

MAKE T HIS CONNECTION L AST!+

+Ignition (VIOLET/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN Trunk Release Output

DRIVERS SIDE KICK PANEL HARNESS

Trunk Release (VIOLET/YELLOW) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOORJAMB BOOTHARNESS

Half of harness that goes back into the vehicles door.

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Battery(LT GREEN/VIOLET) + IGNITIONSWITCH

DRIVER DOORJAMB BOOTHARNESS

15 AMP Fuse

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 76: ALL MODELS 2002

+

Door Lock (PINK/YELLOW)

+

DDM INDRIVER'SDOOR

Door Unlock (PINK/GREEN)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK Ground A-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm InputA-9 BROWN Disarm InputA-12 WHITE/BLUE Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

'05 Crown Victoria/Grand Marquis

Equipment or Trim level System(s) applicable to:

w/Factory RKE PRELOAD

Page Revision Date

1 of 1 6/15/04

Battery (YELLOW)

Starter (DK GREEN )

Horn (BLUE)

STEERINGCOLUMN-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCH

+CUT KEY SIDE

(after cut)

MAKE THIS CONNECTION LAST!+

+

Passenger Door Unlock Motor (PINK/ORANGE) +

+Ignition (VIOLET/ORANGE)

IN DRIVER'S DOOR AT KEYSWITCH

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER'S DOOR AT KEYSWITCH

Page 77: ALL MODELS 2002

515151515 15 15

15

5151515

15 15 15

- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 8/25/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

RELAY REQUIREMENTS:

2 - Door Lock/Unlock (W/O Factory RKE)

1 - Headlight Illumination (Optional)

1 - Driver's Door Priority Unlock (Optional)

REMOTE START (RMST) PARTS REQUIRED:

Securilock (PATS) Interface:

Econoline is not equipped with PATS

Tach Inverter:

2004 - Part # 102818-2 (6.0 Liter Diesel Vehicles)

Call 800-FORD-KEY to order

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default Setting)

MODULE MOUNTING LOCATION:

Upper Left side of the driver's underdash.

REMOTE START (RMST) SPECIFIC PROGRAMMING:

Diesel Timer ON (Diesel vehicles only)

Key in Sense polarity Negative (Default setting)

Learn Tachometer Required on all vehicles

Page 78: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'02-'04 Econonline

Equipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMST

Page Revision Date

1 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 GRAY Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

+

+

Page 79: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'02-'04 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS/RMST

Page Revision Date

2 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (YELLOW) +

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 GRAY Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Page 80: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

HOOD TILT SWITCH

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

Tach Signal (WHITE/PINK)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

6.0 LITER DIESEL

OR

BLUNT CUT WIRE(CTO) IN ENGINECOMPARTMENT

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

7.3 LITER DIESEL

Page 81: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Ignition (RED/LT. GREEN)

Starter (WHITE/PINK)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 5 8/25/04 MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 82: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color Function

C-10 RED/WHITE Headlight Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

5 of 5 8/25/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ONw/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER SIDE JAMB BOOTHARNESS

Battery (YELLOW) IGNITION SWITCH

+

Page 83: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Ignition (RED/LT. GREEN)

Starter (WHITE/PINK)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Color Function

A-4 RED Battery B-2 RED HVAC1 Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 2 8/25/04 +

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+Park Lights (BROWN)

Page 84: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

2 of 2 8/25/04

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

HOOD TILT SWITCH

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

Tach Signal (WHITE/PINK)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

6.0 LITER DIESEL

OR

BLUNT CUT WIRE(CTO) IN ENGINECOMPARTMENT

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

7.3 LITER DIESEL

Page 85: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

VehicleInterior

Underhood REDBLACK

Optional Installation Feature

See Optional connections page

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

DRIVER SIDEKICK PANEL

+Driver Door Unlock Motor(RED/ORANGE)

+Passenger Door Unlock Motor (PINK/ORANGE)

Cut and tape off if not used

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

w/ Factory RKE Deluxe RKE/VSS

Page Revision Date

1 of 4 8/25/04

+

+

Page 86: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'02-'04 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSS

Page Revision Date

2 of 4 8/25/04

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (YELLOW) +

Page 87: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 4 8/25/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Page 88: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

4 of 4 8/25/04

UNDERHOOD

Hood Tilt Switch(Optional, Not Included with Kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER SIDE JAMB BOOTHARNESS

IGNITION SWITCHBattery (YELLOW) +

Page 89: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 8/25/04

MAKE THIS CONNECTION LAST!

+

Page 90: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'02-'04 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKE

Page Revision Date

1 of 1 8/25/04

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (YELLOW) +

Page 91: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS & VSS

Page Revision Date

1 of 1 8/25/04

OPTIONAL CONNECTIONS

Page 92: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESSMAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

w/Factory RKE PRELOAD

Page Revision Date

1 of 1 8/25/04

+

Lock Switch (PINK/YELLOW)

Unlock Switch (PINK/GREEN)

+

+

Page 93: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'02-'04 Econoline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE PRELOAD

Page Revision Date

1 of 1 8/25/04

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (YELLOW) +

Page 94: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 8/25/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

RELAY REQUIREMENTS:

2 - Door Lock/Unlock (W/O Factory RKE)

1 - Headlight Illumination (Optional)

1 - Driver's Door Priority Unlock (Optional)

REMOTE START (RMST) PARTS REQUIRED:

Securilock (PATS) Interface:

Econoline is not equipped with PATS

Tach Inverter:

2005 - Part # 102818-2 (6.0 Liter Diesel Vehicles)

Call 800-FORD-KEY to order

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default Setting)

MODULE MOUNTING LOCATION:

Upper Left side of the driver's underdash.

REMOTE START (RMST) SPECIFIC PROGRAMMING:

Diesel Timer ON (Diesel vehicles only)

Key in Sense polarity Negative (Default setting)

Learn Tachometer Required on all vehicles

Page 95: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'05 Econonline

Equipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMST

Page Revision Date

1 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 GRAY Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Page 96: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'05 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS/RMST

Page Revision Date

2 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (LT. GREEN/VIOLET) +

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 GRAY Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Page 97: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

HOOD TILT SWITCH

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

Tach Signal (WHITE/PINK)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

6.0 LITER DIESEL

OR

BLUNT CUT WIRE(CTO) IN ENGINECOMPARTMENT

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 98: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Battery (LT. GREEN/VIOLET)

Ignition (PINK/LT. GREEN)

Starter (WHITE/PINK)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 5 8/25/04 MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 99: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color Function

C-10 RED/WHITE Headlight Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

5 of 5 8/25/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ONw/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER SIDE JAMB BOOTHARNESS

Battery (LT. GREEN/VIOLET) IGNITION SWITCH

+

Page 100: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Battery (LT. GREEN/VIOLET)

Ignition (PINK/LT. GREEN)

Starter (WHITE/PINK)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Color Function

A-4 RED Battery B-2 RED HVAC1 Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 2 8/25/04 +

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+Park Lights (BROWN)

Page 101: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

2 of 2 8/25/04

HOOD TILT SWITCH

BLUNT CUT WIREIN ENGINECOMPARTMENT

Tach Signal (WHITE/PINK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

Tach Signal (WHITE/PINK)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

6.0 LITER DIESEL

OR

BLUNT CUT WIRE(CTO) IN ENGINECOMPARTMENT

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 102: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

VehicleInterior

Underhood REDBLACK

Optional Installation Feature

See Optional connections page

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

DRIVER SIDEKICK PANEL

+Driver Door Unlock Motor(RED/ORANGE)

+Passenger Door Unlock Motor (PINK/ORANGE)

Cut and tape off if not used

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Vehicle (Year/Make/Model)

'05 Econonline

Equipment or Trim level System(s) applicable to:

w/ Factory RKE Deluxe RKE/VSS

Page Revision Date

1 of 4 5/27/04

Page 103: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'05 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSS

Page Revision Date

2 of 4 5/27/04

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (LT. GREEN/VIOLET) +

Page 104: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 4 5/27/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Page 105: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

4 of 4 5/27/04

UNDERHOOD

Hood Tilt Switch(Optional, Not Included with Kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER SIDE JAMB BOOTHARNESS

IGNITION SWITCHBattery (LT. GREEN/VIOLET) +

Page 106: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 5/27/04

MAKE THIS CONNECTION LAST!

+

Page 107: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'05 Econonline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKE

Page Revision Date

1 of 1 5/27/04

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (LT. GREEN/VIOLET) +

Page 108: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS & VSS

Page Revision Date

1 of 1 5/27/04

OPTIONAL CONNECTIONS

Page 109: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESSMAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER SIDEKICK PANEL

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

w/Factory RKE PRELOAD

Page Revision Date

1 of 1 5/27/04

+

Lock Switch (PINK/YELLOW)

Unlock Switch (PINK/GREEN)

Page 110: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (WHITE/PINK)

Ignition (PINK/LT. GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'05 Econoline

Equipment or Trim level System(s) applicable to:

w/o Factory RKE PRELOAD

Page Revision Date

1 of 1 5/27/04

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (BROWN)

Door Unlock (RED) CUT

CUT

Half of harness that goes back into the vehicle door.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCHHARNESS

Fused Battery (LT. GREEN/VIOLET) +

Page 111: ALL MODELS 2002

515151515 15 15

15

5151515

15 15 15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002-04: 1S4Z-19G365-AB

RELAY REQUIREMENTS:

1 - REAR DEFROSTER (2002 MODEL YEAR)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative Unlock switch sense polarity NegativeKey in Sense polarity Positive

MODULE MOUNTING LOCATION:Behind fuse panel, High near bulkhead panel

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 5/27/03

Page 112: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 5/27/03

-Door Lock (WHITE/VIOLET)

+

+

-

GEMMODULE

Door Unlock (PINK/WHITE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USEC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Cut & tape if not used

Connect only on vehicles with factory RKE

NOTE: ALSO COVERS RKE/RMST

FUELINJECTOR(FRONT OFMOTOR)

Tach Signal

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Page 113: ALL MODELS 2002

BRAKE PEDAL SWITCH+Brake (GREEN)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-2 RED HVAC FeedA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputB-7 BROWN Brake Input

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 5/27/03MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

Heater (BLACK/GREEN)

Key-In Sense (BLACK/PINK)

+

+

+

+

+

CUT

KEY SIDE(after cut)

G.E.M.

Dome Lights (GREEN/ORANGE)

Horn (YELLOW/GREEN)

Perimeter Alarm Disarm(Dk BLUE/LT.GREEN)

-

-

-

-

Parking Lights (BLACK/GREEN)

G.E.M. HARNESS

Color FunctionA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay OutputC-4 Lt GREEN/BLACK Perimeter Alarm DisarmB-4 ORANGE/WHITE 2nd Heater OutputB-1 BLUE 2nd Heater PolarityC-10 RED/WHITE Headlight Output

NOTE: ALSO COVERS RKE/RMST

Optional Installation FeatureSee HEADLIGHT ILLUMINATION (3 of 3)

CHASSIS GROUND

Page 114: ALL MODELS 2002

REARDEFROSTERSWITCH

REARDEFROSTERSWITCH

Rear Defroster (Dk BLUE/ORANGE)

Rear Defroster Feed (BLACK/Lt BLUE)

WhiteBlack

30

87

87a

85 86

Yellow+

+

Rear Defroster (Dk BLUE/ORANGE) -

Blue

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 5/27/03

NOTE: ALSO COVERS RKE/RMST

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Headlights (RED/WHITE) - G.E.M.

2003 MODEL YEAR ONLY

2002 MODEL YEAR ONLY

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 115: ALL MODELS 2002

BRAKE PEDAL SWITCH+Brake (GREEN)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-2 RED HVAC FeedA-7 PINK Ignition Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputB-7 BROWN Brake Input

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 5/27/03

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

Heater (BLACK/GREEN)

Key-In Sense (BLACK/PINK)

+

+

+

+

+

CUT

FUELINJECTOR(FRONT OFMOTOR)

Tach Signal

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

G.E.M.Horn (YELLOW/GREEN)

--

Parking Lights (BLACK/GREEN)

G.E.M. HARNESS

Color FunctionA-1 WHITE Parking Light Output A-21 BROWN/BLACK Horn Relay OutputB-4 ORANGE/WHITE 2nd Heater OutputB-1 BLUE 2nd Heater Polarity

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK Ground CHASSIS GROUND POINT

IN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

KEY SIDE(after cut)

-Perimeter Alarm Disarm (DK.BLUE/LT.GREEN)

CHASSIS GROUND

Page 116: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

1 of 3 5/27/03

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

VehicleInterior

EngineCompartment

REDBLACK

Siren

-Door Lock (WHITE/VIOLET)

+

+

-

GEM MODULE

Door Unlock (PINK/WHITE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-7 TAN/RED DO NOT USEC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

Cut & tape if not used

Connect only on vehicles with factory RKE

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Page 117: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

2 of 3 5/27/03

G.E.M.

Dome Lights (GREEN/ORANGE)

Horn (YELLOW/GREEN)

Headlights (RED/WHITE)

Perimeter Alarm Disarm (Dk BLUE/LT.GREEN)

-

-

-

-

-

Parking Lights (BLACK/GREEN)

G.E.M. HARNESS

Color FunctionA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay OutputC-10 RED/WHITE Headlight OutputC-4 Lt GREEN/BLACK Perimeter Alarm Disarm

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Page 118: ALL MODELS 2002

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

Hood Tilt Switch

ChassisGround

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

3 of 3 5/27/03

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Deluxe RKE/VSSProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 119: ALL MODELS 2002

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKEPage Revision Date

1 of 1 5/27/03

G.E.M.Dome Lights (GREEN/ORANGE)

Horn (BROWN/BLACK)

-

-

-

Parking Lights (BLACK/GREEN)Color Function

A-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay Output

-Door Lock (WHITE/VIOLET)

-DRIVER’S KICKPANEL

Door Unlock (PINK/WHITE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock Output

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Page 120: ALL MODELS 2002

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

w/ Factory RKE VSSPage Revision Date

1 of 1 5/27/03

+

+

+

DRIVER’S KICKPANEL

Door Unlock (PINK/WHITE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

G.E.M.Dome Lights (GREEN/ORANGE)

Horn (BROWN/BLACK)

-

-

-

Parking Lights (BLACK/GREEN)Color FunctionA-1 WHITE Parking Light Output A-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay Output

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Page 121: ALL MODELS 2002

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED/Lt BLUE)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02-’04 EscapeEquipment or Trim level System(s) applicable to:

ALL PRELOADPage Revision Date

1 of 1 9/2/03

Door Lock (WHITE/VIOLET)

G.E.M.Dome Lights (GREEN/ORANGE)

Horn (YELLOW/GREEN)

-

-

-

Parking Lights (BLACK/GREEN)Color Function

A-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-21 BROWN/BLACK Horn Relay Output

-

+

+

-

DRIVER’S KICKPANELDoor Unlock (PINK/WHITE)

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock Output

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Connect only on vehicles with factory RKE

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output G.E.M.-Perimeter Alarm Disarm (DK.BLUE/LT.GREEN)

G.E.M. HARNESS

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Page 122: ALL MODELS 2002

515151515 15 15

15

5151515

15 15 15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

REMOTE START (RMST) PARTS REQUIRED

Securilock (PATS) Interface:

2005- 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1- Driver's Door Priority Unlock (Optional)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative

Unlock switch sense polarity Negative

MODULE MOUNTING LOCATION:Left Side of Driver's Underdash

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 8/20/04

REMOTE START (RMST) SPECIFIC PROGRAMMING

Key in Sense polarity Positive

Rear Defroster 0.5 sec. (Default Setting)

Learn Tachometer Required On All Vehicles

Page 123: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 8/20/04

Door Lock (WHITE/VIOLET)

+

+ DRIVER'SSIDE KICKPANELHARNESS

Door Unlock (PINK/WHITE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundB-1 BLUE HVAC 2 PolarityA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputC-4 LT.GREEN/BLACK Perimeter Alarm DisarmB-4 ORANGE/WHITE HVAC 2 OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-24 BLUE/GREEN Driver Door Unlock OutputC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!NOTE: ALSO COVERS RKE/RMST

FUELINJECTOR(SIDE OFMOTOR)

Tach Signal (TAN)

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Perimeter Alarm Disarm (DK BLUE/GREEN)

Dome Light (PINK)

Optional Installation Feature

See Optional Connections Page

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 124: ALL MODELS 2002

BRAKE PEDAL SWITCH

+Brake (GREEN)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-2 RED HVAC FeedA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 8/20/04

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/LT. BLUE)

Ignition (Lt GREEN/VIOLET)

Heater (BLACK/GREEN)

Key-In Sense (BLACK/PINK)

+

+

+

+

+

CUT

KEY SIDE(after cut)

NOTE: ALSO COVERS RKE/RMST

STEERINGCOLUMN

Horn (YELLOW/GREEN)

Parking Lights (WHITE/BLACK)

Optional Installation Feature

See Optional Connections

Page 3 of 3

Page 125: ALL MODELS 2002

REARDEFROSTERSWITCH

Rear Defroster (Dk BLUE/ORANGE)

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 8/20/04

NOTE: ALSO COVERS RKE/RMST

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Headlights (RED/YELLOW)STEERINGCOLUMN

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input +

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going to the back of the vehic

CUT

DRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option

bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER'SKICKPANELHARNESS

IGNITIONSWITCHBattery (RED) +

Page 126: ALL MODELS 2002

BRAKE PEDAL SWITCH

+Brake (GREEN)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-2 RED HVAC FeedA-7 PINK Ignition Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake Input

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 8/20/04

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/Lt BLUE)

Ignition (Lt GREEN/VIOLET)

Heater (BLACK/GREEN)

Key-In Sense (BLACK/PINK)

+

+

+

+

+

CUT

FUELINJECTOR(SIDE OFMOTOR)

Tach Signal (TAN)

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

Horn (YELLOW/GREEN)

Parking Lights (WHITE/BLACK)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundB-1 BLUE HVAC 2 PolarityB-4 ORANGE/WHITE HVAC 2 Output

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

KEY SIDE(after cut)

Perimeter Alarm Disarm (DK.BLUE/LT.GREEN)

STEERINGCOLUMNHARNESS

DRIVER'SKICK PANELHARNESS

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 127: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

1 of 3 8/20/04

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

VehicleInterior

EngineCompartment

REDBLACK

Siren

Door Lock (WHITE/VIOLET)

+

+

DRIVER'SSIDE KICKPANELHARNESS

Door Unlock (PINK/WHITE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputC-4 LT.GREEN/BLACK Perimeter Alarm DisarmA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Perimeter Alarm Disarm (DK BLUE/GREEN)

Dome Light (PINK)

Optional Installation Feature

See Optional Connections Page3 of 3

Page 128: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

2 of 3 8/20/04

STEERINGCOLUMNHARNESS

Horn (YELLOW/GREEN)

Headlights (RED/YELLOW)

Parking Lights (WHITE/BLACK)

STEERING COLUMN HARNESS

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputC-10 RED/WHITE Headlight Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/LT. BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Page 129: ALL MODELS 2002

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

Hood Tilt Switch

ChassisGround

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 8/20/04

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input +

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going to the back of the vehic

CUT

DRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option

bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

BlueDRIVER'SKICKPANELHARNESS

IGNITIONSWITCHBattery (RED) +

Page 130: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

W/O Factory RKE RKE/VSS & RKEPage Revision Date

1 of 1 8/20/04

STEERINGCOLUMNHARNESS

Horn (YELLOW/GREEN)

Parking Lights (WHITE/BLACK)

STEERING COLUMN HARNESS

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/LT. BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Door Lock (WHITE/VIOLET)

DRIVER'SSIDE KICKPANELHARNESS

Door Unlock (PINK/WHITE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (PINK)

Page 131: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

W/ Factory RKE VSS

Page Revision Date

1 of 1 8/20/04

STEERINGCOLUMNHARNESS

Horn (YELLOW/GREEN)

Parking Lights (WHITE/BLACK)

STEERING COLUMN HARNESS

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/LT. BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

+

+ DRIVER'SSIDE KICKPANELHARNESS

Door Unlock (PINK/WHITE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (PINK)

Page 132: ALL MODELS 2002

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output

DRIVER'SKICK PANELHARNESS

-Perimeter Alarm Disarm (DK.BLUE/LT.GREEN)

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Vehicle (Year/Make/Model)

'05 Escape / Mariner

Equipment or Trim level System(s) applicable to:

ALL PRELOAD

Page Revision Date

1 of 1 8/20/04

STEERINGCOLUMNHARNESS

Horn (YELLOW/GREEN)

Parking Lights (WHITE/BLACK)

STEERING COLUMN HARNESS

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Pull-UpA-7 PINK Ignition Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Starter (TAN/LT. BLUE)

Ignition (Lt GREEN/VIOLET)

+

+

+

CUT

KEY SIDE(after cut)

Door Lock (WHITE/VIOLET)

+

+

DRIVER'SSIDE KICKPANELHARNESS

Door Unlock (PINK/WHITE)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (PINK)

Page 133: ALL MODELS 2002

515151515 15 15

15

515151515 15 15 15-

+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 5/30/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

Escort is not equipped with Securilock

RELAY REQUIREMENTS:1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)2 - REAR DEFROSTER (OPTIONAL)1 - FACTORY ALARM DISARM (REQUIRED IF

VEHICLE IS EQUIPPED WITH FACTORY PERIMTER ALARM

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity NegativeUnlock switch sense polarity NegativeKey in Sense polarity Positive

MODULE MOUNTING LOCATION:UPPER LEFT KICK PANEL, TO LEFT OFBRAKE PEDAL.

Page 134: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-13 TAN Trunk release outputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

AT FUSE BOX

Dome Light (VIOLET/WHITE)

+ AT FACTORYKEYLESS MODULERIGHT KICK+

Door Lock (GRAY)

Door Unlock (BLUE)

Lock Motor (GREEN/ORANGE)

Driver Door Unlock Motor(RED/WHITE)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (BLUE/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)Color Function

A-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 5/30/03

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

Trunk Release (GREEN/BLACK)AT RELEASESWITCH

Vehicles with factory perimeter alarm, see Factory perimeter alarm disarm connection (page 3 of 3)

Page 135: ALL MODELS 2002

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

Heater (BLACK/RED)

Heater (BLACK/WHITE)

TO RIGHT OFSTEERING COLUMN

Key-in-Sense (WHITE/BLACK)

Horn (GREEN/ORANGE)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the connector under the fuse box. Wire changes to RED/BLACK (+).

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 5/30/03MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

+

Page 136: ALL MODELS 2002

Driver Door Unlock Motor(RED/WHITE)

Headlights (BROWN)

AT SWITCH

HEADLIGHT SWITCH

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output

FACTORY PERIMETER ALARM DISARM

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 5/30/03

OPTIONAL CONNECTIONS(NOTE: ALSO INCLUDES RKE/RMST)

Rear Defrost (WHITE/RED)

30

87

87a

85 86

Blue

YellowWhite Battery (BLACK)

Ignition (BLUE)

+

+

IGNITIONSWITCH

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 137: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

Heater (BLACK/RED)

Heater (BLACK/WHITE)

TO RIGHT OFSTEERING COLUMN

Key-in-Sense (WHITE/BLACK)

Horn (GREEN/ORANGE)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE) HEADLIGHT SWITCH

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (BLUE/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 5/30/03

Note:Parking light circuit can also be found in the connector under the fuse box. Wire color changes to RED/BLACK (+).

+

Page 138: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-13 TAN Trunk Release OutputC-9 TAN/RED DO NOT USEA-24 BLUE/GREEN Driver Door Unlock Output

KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

AT FUSE BOX

Dome Light (VIOLET/WHITE)

Door Lock (GRAY)

Door Unlock (BLUE)

Lock Motor (GREEN/ORANGE)

VehicleInterior

Underhood REDBLACK

Optional Installation FeatureSee Optional connections page

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 5/30/03

AT FACTORY KEYLESS MODULERIGHT KICK

+

Driver Door Unlock Motor(RED/WHITE)

Connect only on vehicles with factory RKE

+

Cut and tape off if not used

Vehicles with factory perimeter alarm, see Factory perimeter alarm disarm connection (page 3 of 3)

Trunk Release (GREEN/BLACK)AT RELEASESWITCH

Page 139: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

TO RIGHT OFSTEERING COLUMN

Horn (GREEN/ORANGE)

Parking lights (WHITE) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the connector under the fuse box. Wire changes to RED/BLACK (+).

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 8/22/02

MAKE THIS CONNECTION LAST!

Headlights (BROWN)

HEADLIGHT SWITCH

Page 140: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 5/30/03

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output

FACTORY PERIMETER ALARM DISARM

30

87

87a

85 86

Blue

YellowWhite Battery (BLACK)

Ignition (BLUE)

+

+

IGNITIONSWITCH

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Driver Door Unlock Motor(RED/WHITE)

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 141: ALL MODELS 2002

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

TO RIGHT OFSTEERING COLUMN

Horn (GREEN/ORANGE)

Parking lights (WHITE) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the connector under the fuse box. Wire color changes to RED/BLACK (+).

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

AT FUSE BOX

Dome Light (VIOLET/WHITE)

+ AT FACTORYKEYLESS MODULERIGHT KICK+

Door Unlock (BLUE)

Lock Motor (GREEN/ORANGE)

Driver Door Unlock Motor(RED/WHITE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 5/30/03

MAKE THIS CONNECTION LAST!

Page 142: ALL MODELS 2002

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

TO RIGHT OFSTEERING COLUMN

Horn (GREEN/ORANGE)

Parking lights (WHITE) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the connector under the fuse box. Wire color changes to RED/BLACK (+).

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

AT FUSE BOX

Dome Light (VIOLET/WHITE)

-

-

Door Lock (GRAY)

Door Unlock (BLUE)

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

w/o Factory RKE VSS/RKE & RKEPage Revision Date

1 of 1 5/30/03

MAKE THIS CONNECTION LAST!

Page 143: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 5/30/03

OPTIONAL CONNECTIONS

Page 144: ALL MODELS 2002

IGNITION SWITCH

Battery (BLACK)

Starter (RED/WHITE)

Ignition (BLUE)

TO RIGHT OFSTEERING COLUMN

Horn (GREEN/ORANGE)

Parking lights (WHITE) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the connector under the fuse box. Wire color changes to RED/BLACK(+).

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

AT FUSE BOXDRIVER KICK

Dome Light (VIOLET/WHITE)

AT FACTORYKEYLESS MODULERIGHT KICK+

Door Unlock (BLUE)

Lock Motor (GREEN/ORANGE)

Driver Door Unlock Motor(RED/WHITE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense Input A-11 WHITE/BLUE Arm InputA-9 BROWN Disarm Input

KICK PANEL HARNESSDoor Lock (GRAY)

Vehicle (Year/Make/Model)

’02/’03 EscortEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 1 5/30/03

MAKE THIS CONNECTION LAST!

Connect only on vehicles with factory RKE

+

Page 145: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**SEE NOTES

Vehicle (Year/Make/Model)

’02/’03 Excursion/ Super DutyEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 10/13/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system.

FUSE PLACEMENT CHART

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - TRIM-SWITCH DISABLE1 - DRIVER’S DOOR PRIORITY UNLOCK (OPTIONAL)

MODULE MOUNTING LOCATION:

UPPER LEFT KICK PANEL

PATS INTERFACE:

2002 - 1L3Z-19G365-AB2003 - 1L3Z-19G365-AB

VEHICLE SPECIFIC PROGRAMMING:Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)Rear Defroster 0.5 Sec pulse (Default)

Page 146: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMSTPage Revision Date

1 of 4 5/27/03

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

NOTE: If vehicle is equipped with trim switchdisable, refer to page 4 for the wiring diagram

7.3L Tach Signal (LT.GREEN/WHITE)

DIESEL

GASOLINE

BEHINDFUSE PANEL(taped to harness)

6.0L Tach Signal (LT.GREEN/WHITE)

Page 147: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

W/O Factory RKE RKE/VSS/RMSTPage Revision Date

2 of 4 10/13/03(NOTE: ALSO INCLUDES RKE/RMST)

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

HOOD TILT SWITCH

Chassisground

Do Not Groundto Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

FUELINJECTORTach Signal (TAN)

7.3L Tach Signal (LT.GREEN/WHITE)

DIESEL

GASOLINE

6.0L Tach Signal (LT.GREEN/WHITE)

BEHINDFUSE PANEL(taped to harness)

30

87

87a

85 86

30

87

87a

85 86

+Battery (LT.GREEN/ORANGE)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Page 148: ALL MODELS 2002

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-4 BLUE/WHITE Rear Defrost Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (DARK GREEN)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 4 5/27/03

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Park Light Output

LEFT KICK PANEL

DRIVER SIDE KICK PANEL

+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Page 149: ALL MODELS 2002

White

Color FunctionA-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUT

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+

Headlight

Color FunctionC-11 BLUE/WHITE Rear Defroster Output

C-10 RED/WHITE Headlight Output

DRIVER’S DOOR PRIORITY UNLOCK

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

4 of 4 5/27/03

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

OPTIONAL CONNECTIONS(NOTE: ALSO INCLUDES RKE/RMST)

w/Factory RKE only

DEFROSTERSWITCH

Rear Defrost (BLUE/ORANGE)

TRIM SWITCH DISABLE RELAY SET-UPColor Function

A-15 RED Siren FeedC-4 LT.GREEN/BLACK Perimeter Alarm Disarm

White

30

87

87a

85 86

Blue

Red

Black CUT

DRIVER SIDE JAMB BOOTHARNESS

Driver Door Ajar(YELLOW/BLACK)

Excursion only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

+Battery (LT.GREEN/ORANGE)

Page 150: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-1 WHITE Parking Light Output

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!HOOD TILT SWITCHVehicle

InteriorUnderhood

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 5/27/03

+

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

DRIVER SIDE KICK PANELParking Lights (BROWN) +

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

BEHINDFUSE PANEL(taped to harness)

DIESEL

GASOLINE

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

7.3L Tach Signal (LT.GREEN/WHITE)

6.0L Tach Signal (LT.GREEN/WHITE)

Page 151: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

DRIVER SIDE KICK PANEL

+Dome Light (BLACK/BLUE)

UPPER LEFT KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

W/Factory RKE Deluxe RKE/VSSPage Revision Date

1 of 4 5/27/03

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-1 WHITE Parking Light Output

DRIVERS SIDE KICK PANEL HARNESS

Parking Lights (BROWN) +DRIVER SIDE KICK PANEL

Page 152: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK Siren (w/VSS only)Color Function

A-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSSPage Revision Date

2 of 4 9/2/03(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

DRIVER SIDEKICK PANEL

+Dome Light (BLACK/BLUE)

LOWER LEFT KICK PANEL

+Park Lights (BROWN)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Battery (LT.GREEN/ORANGE)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Page 153: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputC-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSSPage Revision Date

3 of 4 5/27/03(NOTE: ALSO INCLUDES RKE/RMST)

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Page 154: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

4 of 4 5/27/03

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

TRIM SWITCH DISABLE RELAY SET-UPColor Function

A-15 RED Siren FeedC-4 LT.GREEN/BLACK Perimeter Alarm Disarm

White

30

87

87a

85 86

Blue

Red

Black CUT

DRIVER SIDE JAMB BOOTHARNESS

Driver Door Ajar(YELLOW/BLACK)

Color FunctionA-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

+Battery (LT.GREEN/ORANGE)

Page 155: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 5/27/03

MAKE THIS CONNECTION LAST!

+

Color FunctionA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

DRIVER SIDEKICK PANEL

+Park Lights (BROWN)

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Page 156: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKEPage Revision Date

1 of 1 9/2/03

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

DRIVER SIDEKICK PANEL+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior

30

87

87a

85 86

30

87

87a

85 86

+Battery (LT.GREEN/ORANGE)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Page 157: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 5/27/03

OPTIONAL CONNECTIONS

Page 158: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/Factory RKE PreloadPage Revision Date

1 of 1 8/6/03

MAKE THIS CONNECTION LAST!

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER DOOR JAMB BOOT HARNESS

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE)

Color FunctionA-5 BLACK GroundA-11 WHITE/BLUE Arm InputA-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense InputA-2 BLUE Lock OutputA-14 GREEN Unlock OutputC-4 LT.GREEN/BLACK Perimeter Disarm Output

DRIVERS SIDE KICK PANEL HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

DRIVER SIDEKICK PANEL+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

30

87

87a

85 86Black

CUT

IGNITIONSWITCH+Battery (YELLOW)

DRIVER SIDE JAMB BOOTHARNESS

Driver Door Ajar(YELLOW/BLACK)

White

This connection only requiredif vehicle is equipped withtrim-switch disable

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

+

+

+

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor (RED/ORANGE)

Passenger Door Unlock (PINK/ORANGE)

Page 159: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 Excursion/Super DutyEquipment or Trim level System(s) applicable to:

w/o Factory RKE PreloadPage Revision Date

1 of 1 10/13/03

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

DRIVER SIDEKICK PANEL+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Battery (LT.GREEN/ORANGE)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Page 160: ALL MODELS 2002

515

15

15

15

15

15

15

515

15

15

15

15

15

- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'04-'05 Excursion/ Super Duty

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 8/25/04

*Only used on (PC-32) systems with Car Start (RMST)

** Not used on VSS system.

FUSE PLACEMENT CHART

RELAY REQUIREMENTS:

2 - Door Lock/Unlock (W/O Factory RKE)

1 - Headlight Illumination (Optional)

1 - Driver's Door Priority Unlock (Optional)

REMOTE START (RMST) PARTS REQUIRED:

Securilock (PATS) Interface:

2004-2005 - 1L3Z-19G365-AB (Excursion Only)

Tach Inverter:

2004-2005 - Part # 102818-2 (6.0 Liter Diesel Vehicles)

Call 800-FORD-KEY to order

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default Setting)

MODULE MOUNTING LOCATION:

Upper Left side of the driver's underdash behind fuse

panel near parking brake assembly.

REMOTE START (RMST) SPECIFIC PROGRAMMING:

Diesel Timer ON (Diesel vehicles only)

Key in Sense polarity Negative (Default setting)

Rear Defroster 0.5 Sec pulse (Default)

Learn Tachometer Required on all vehicles

Page 161: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER'S SIDEKICK PANEL HARNESS

+

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMST

Page Revision Date

1 of 5 8/25/04

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm Disarm Output

DRIVERS SIDE KICK PANEL HARNESS

NOTE: If vehicle is equipped with trim switchdisable, refer to page 4 for the wiring diagram

DRIVER'S DOORJAMB BOOT HARNESS

REAR OF DRIVER'SDOOR SILL PLATEHARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Page 162: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS/RMST

Page Revision Date

2 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Fused Battery (YELLOW)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITION SWITCH

REAR OF DRIVER'SDOOR SILL PLATEHARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Page 163: ALL MODELS 2002

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

BLUNT CUTWIRE BEHINDFUSE PANEL(taped to harness)

Tach Signal (LT.GREEN/WHITE)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 5 8/25/04

(NOTE: ALSO INCLUDES RKE/RMST)

6.0 LITER DIESEL

OR

Page 164: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defrost OutputC-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (DARK GREEN)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 5 8/25/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Page 165: ALL MODELS 2002

White

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUT

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+

Headlight

Color Function

C-11 BLUE/WHITE Rear Defroster Output

C-10 RED/WHITE Headlight

DRIVER'S DOOR PRIORITY UNLOCK

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

5 of 5 8/25/04

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

w/Factory RKE only

DEFROSTERSWITCH

Rear Defrost (BLUE/ORANGE)

TRIM SWITCH DISABLE (if equipped)

Color Function

C-4 LT.GREEN/BLACK Perimeter Alarm Disarm

DRIVER SIDE JAMB BOOTHARNESS

Driver Door Ajar(YELLOW/BLACK)

Excursion only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

+Battery (YELLOW) IGNITIONSWITCH

Page 166: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-1 WHITE Parking Light Output

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 2 8/25/04+

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

DRIVER SIDE KICK PANELParking Lights (BROWN) +

Ignition (RED/GREEN) +

Page 167: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

All RMST

Page Revision Date

2 of 2 8/25/04

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

GASOLINE

BLUNT CUTWIRE BEHINDFUSE PANEL(taped to harness)

Tach Signal (LT.GREEN/WHITE)

IGNITIONSWITCH

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Battery(YELLOW) +BLACKRED

BLUE

GREEN

Tach Inverter Part # 102818-2

Required For All 6.0 Liter Diesel

Applications Call 800-FORD-KEY to order

6.0 LITER DIESEL

OR

Page 168: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

REAR OF DRIVER SIDE SILL PLATEHARNESS

+Dome Light (BLACK/BLUE)

UPPER LEFT KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

W/Factory RKE Deluxe RKE/VSS

Page Revision Date

1 of 4 8/19/04

Connect only on vehicles with factory RKE

+Passenger Door Unlock (PINK/ORANGE)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-1 WHITE Parking Light Output

DRIVERS SIDE KICK PANEL HARNESS

Parking Lights (BROWN) +

DRIVER SIDE KICK PANEL ORHEADLIGHTSWITCH

DRIVER'S SIDEKICK PANELHARNESS

Page 169: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK Siren (w/VSS only) Color Function

A-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Deluxe RKE/VSS

Page Revision Date

2 of 4 8/20/04

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-1 WHITE Parking Light Output

DRIVER SIDEKICK PANEL

+Dome Light (BLACK/BLUE)

LOWER LEFT KICK PANEL

+Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Fused Battery (YELLOW)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCH

Page 170: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputC-10 RED/WHITE Headlight OutputC-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 4 8/19/04

Ignition (RED/GREEN) +

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Page 171: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

4 of 4 8/20/04

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

NOTE:Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

TRIM SWITCH DISABLE

Color Function C-4 LT.GREEN/BLACK Perimeter Alarm Disarm

DRIVER SIDE JAMB BOOTHARNESS

Driver Door Ajar(YELLOW/BLACK)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

+Battery (YELLOW) IGNITIONSWITCH

Page 172: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-20 GREEN/VIOLET Door Ajar Switch Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 8/19/04

MAKE THIS CONNECTION LAST!

+

Color FunctionA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANELDRIVER SIDEKICK PANEL ORHEADLIGHT SWITCH

+Park Lights (BROWN)

Ignition (RED/GREEN) +

REAR OF DRIVER SIDE SILL PLATEHARNESS

+Dome Light (BLACK/BLUE)

DRIVER'S SIDEKICK PANELHARNESS

Page 173: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKE

Page Revision Date

1 of 1 8/20/04

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

REAR OF DRIVER'SDOOR SILL PLATE HARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Ignition (RED/GREEN) +

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior

30

87

87a

85 86

30

87

87a

85 86

+Fused Battery (YELLOW)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCH

Page 174: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSS

Page Revision Date

1 of 1 8/19/04

OPTIONAL CONNECTIONS

Page 175: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/Factory RKE Preload

Page Revision Date

1 of 1 8/19/04

MAKE THIS CONNECTION LAST!

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Door Lock (WHITE/RED)

Door Unlock (BLACK/WHITE) Color Function

A-5 BLACK GroundA-2 BLUE Lock OutputA-14 GREEN Unlock OutputA-12 LT. GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm InputA-9 BROWN Disarm Input C-4 LT.GREEN/BLACK Perimeter Disarm Output

DRIVERS SIDE KICK PANEL HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

REAR OF DRIVER'SDOOR SILL PLATEHARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

DRIVER SIDE JAMB BOOTHARNESSDriver Door Ajar

(YELLOW/BLACK)

Ignition (RED/GREEN) +

+

+

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

+Passenger Door Unlock (PINK/ORANGE)

DRIVER'S SIDEKICK PANELHARNESS

Page 176: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Preload

Page Revision Date

1 of 1 8/20/04

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

REAR OF DRIVER'SDOOR SILL PLATEHARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Ignition (RED/GREEN) +

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutpuT

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Fused Battery (YELLOW)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

IGNITIONSWITCH

Page 177: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (DARK GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Excursion/Super Duty

Equipment or Trim level System(s) applicable to:

w/o Factory RKE Preload

Page Revision Date

1 of 1 6/16/04

MAKE THIS CONNECTION LAST!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-1 WHITE Parking Light Output

LOWER DRIVER SIDE KICK PANEL

REAR OF DRIVER'SDOOR SILL PLATEHARNESS+

+Dome Light (BLACK/BLUE)

Park Lights (BROWN)

Ignition (RED/GREEN) +

+(6.0 Diesel only) Ignition (WHITE/YELLOW)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutpuT

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

+Battery (LT.GREEN/ORANGE)

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

Page 178: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

*Only used on (PC-32) systems with Car Start (RMST)

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L3Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)2 - MEMORY SEATS (OPTIONAL)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)Aux 2 (Rear Defrost) 0.5 sec. (Default setting)

MODULE MOUNTING LOCATION:Driver side kick panel high, near bulkhead panel.

Page 179: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputC-4 LT.GREEN/BALCK Perimeter Alarm Disarm

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

KEYLESS ENTRYMODULE LEFTOF BRAKE PEDAL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 4 1/5/04

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

+Passenger Door Unlock (PINK/ORANGE)

DRIVER KICKPANELDriver Door Latch Switch (BLACK/YELLOW)

HRNESSABOVE DRIVERSKICK PANEL

+Dome Light (BLACK/BLUE)

Page 180: ALL MODELS 2002

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defrost Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02/’03 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 4 1/5/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCHPark Lights (BROWN)

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

+

Page 181: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color FunctionC-11 BLUE/WHITE Rear Defrost Output

C-10 RED/WHITE Headlight Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 4 1/5/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

REARDEFROSTSWITCH

Rear Defroster (BLUE/ORANGE)

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 182: ALL MODELS 2002

HARNESS UNDER DRIVER SILL PLATE

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

4 of 4 1/5/04(NOTE: ALSO INCLUDES RKE/RMST)

OPTIONAL CONNECTIONS

White

White

Black

30

87

87a

85 86

30

87

87a

85 86

Yellow

Memory Seats(BROWN/Lt GREEN)

Memory Seats(BLACK/ORANGE)

+

+

POWER OPTIONS

Color FunctionA-15 RED Power FeedC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

Blue

Blue

Black

Yellow

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 183: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 5/30/03

+

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+Park Lights (BROWN)

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

Page 184: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USEC-4 LT.GREEN/BLACK Perimeter Disarm Output

DRIVERS SIDE KICK PANEL HARNESS

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 1/5/04

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

HEADLIGHT SWITCH

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light (BLACK/BLUE)

Color FunctionA-1 WHITE Park Light Output

UPPER LEFT KICK PANEL

+ HEADLIGHTSWITCH

Park Lights (BROWN)Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

KEYLESS ENTRYMODULE LEFT OF BRAKE PEDAL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Connect only on vehicles with factory RKE

+

Passenger Door Unlock (PINK/ORANGE)

DRIVER KICKPANELDriver Door Latch Switch (BLACK/YELLOW)

Page 185: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defrost Output

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 1/5/04MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

REAR DEFROSTSWITCH

Rear Defroster (BLUE/ORANGE)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 186: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 1/5/04

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 187: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

KEYLESS ENTRYMODULE LEFTOF BRAKE PEDAL

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-20 GREEN/VIOLET Door Ajar

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 2 1/5/04

MAKE THIS CONNECTION LAST!

+

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light (BLACK/BLUE)

Page 188: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL VSSPage Revision Date

2 of 2 5/30/03

OPTIONAL CONNECTIONS

Page 189: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUTKEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESSMAKE THIS CONNECTION LAST!

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light (BLACK/BLUE)

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output

HEADLIGHTSWITCHPark Lights (BROWN) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

KEYLESS ENTRYMODULE LEFT OF BRAKE PEDAL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

+Passenger Door Unlock (PINK/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

DRIVERS SIDE KICK PANEL HARNESS

DRIVER KICKPANEL

Vehicle (Year/Make/Model)

’02 Expedition/NavigatorEquipment or Trim level System(s) applicable to:

ALL PRELOADPage Revision Date

1 of 1 1/5/04

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -Driver Door Ajar Switch (BLACK/YELLOW)

*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Page 190: ALL MODELS 2002

515

15 15 15

15

515

15

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 6/16/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2003-2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

1 - MOTORIZED RUNNING BOARDS (IF EQUIPPED)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Rear Defroster 0.5 Sec pulse (default)

MODULE MOUNTING LOCATION:

Above hood release cable near bulkhead panel, in front of parking brake.

15

Page 191: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-2 BLACK/GREEN Motorized Rear Gate OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

KEYLESS ENTRYMODULE

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Rear Hatch Release(WHITE/VIOLET)

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN)

Chassisground Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Optional Installation Features

See Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 4 6/16/04

(NOTE: ALSO INCLUDES RKE/RMST)

+Unlock Switch Sense (PINK/ORANGE)

Color FunctionA-13 TAN Hatch Release Output

PASSENGER SIDE KICK PANEL HARNESSCUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 192: ALL MODELS 2002

Color FunctionA-4 RED BatteryB-2 RED HVAC 1 12 volt Battery Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESS

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 4 6/15/04MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

+

Battery (GREEN/VIOLET) +

+Accessory (BLACK/GREEN)

Page 193: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86

REAR DEFROSTSWITCH

HEADLIGHT SWITCH

Rear Defroster(BLUE/ORANGE)

+

+Headlight

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 4 6/16/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUT

DRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON

White

30

87

87a

85 86

Blue

Black

Yellow

RedRelays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 194: ALL MODELS 2002

Color Function

C-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

OVERHEAD SWITCHOR

POWER LIFTGATEMODULE

HARNESS UNDER DRIVERS DOOR SILL PLATE

Color Function

C-2 BLACK/GREEN Motorized Rear Gate

MEMORY SEATS (IF EQUIPPED)

MOTORIZED REAR GATE (IF EQUIPPED)

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 4 6/16/04

(NOTE: ALSO INCLUDES RKE/RMST)

Memory Seat 1 (BROWN/Lt. GREEN)

Memory Seat 2 (BLACK/ORANGE)

Motorized Rear Gate(GRAY/RED)

OPTIONAL CONNECTIONS (con't)

Color Function

A-15 RED Siren Feed

C-4 LT.GREEN/BLACK Factory Disarm Output

AUTOMATIC RUNNING BOARDS (IF EQUIPPED)

White

30

87

87a

85 86Blue

Black

Yellow

IGNITIONSWITCH+Key-in-Sense (BLACK/PINK)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 195: ALL MODELS 2002

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED BatteryB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESS

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 6/16/04MAKE THIS CONNECTION LAST!

+

Battery (GREEN/VIOLET) +

+Accessory (BLACK/GREEN)

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 196: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-2 BLACK/GREEN Motorized Rear Gate OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

KEYLESS ENTRYMODULE

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Rear Hatch Release(WHITE/VIOLET)

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 6/16/04

+Unlock Switch Sense (PINK/ORANGE)

Color FunctionA-13 TAN Hatch Release Output

PASSENGER SIDE KICK PANEL HARNESS

Optional Installation Feature

See Optional connections page

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Page 197: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 6/16/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 198: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 E xpedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 6/16/04

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

OVERHEAD SWITCH ORACCESS PANEL DRIVERS SIDEREAR PANEL

Color Function

C-2 BLACK/GREEN Motorized Rear Gate

MOTORIZED REAR GATE (IF EQUIPPED)

Motorized Rear Gate(GRAY/RED)

Color Function

C-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HARNESS UNDER DRIVERS DOOR SILL PLATE

MEMORY S EATS (IF EQ UIPPED)

Memory Seat 1 (BROWN/Lt. GREEN)

Memory Seat 2 (BLACK/ORANGE)

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR P RIORITY UNLOCK

NOTE:

Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON

White

30

87

87a

85 86

Blue

Black

Yellow

RedRelays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 199: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 2 6/16/04

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Page 200: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

2 of 2 6/16/04

OPTIONAL CONNECTIONS

Page 201: ALL MODELS 2002

Vehicle (Year/Make/Model)

'03-'05 Expedition / Navigator

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1 6/16/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch Sense

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

KEYLESS ENTRYMODULE

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Rear Hatch Release (WHITE/VIOLET)

+Unlock Switch Sense (PINK/ORANGE)

Color FunctionA-13 TAN Hatch Release Output

PASSENGER SIDE KICK PANEL HARNESS

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Page 202: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 6/21/045151515

15 15 15

15

5151515

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2002-05: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Negative

Key in Sense polarity Positive

Rear Defroster .5 Sec pulse (Default)

MODULE MOUNTING LOCATION:

Left side of under dash between fuse/junction box and bulkhead panel.

Page 203: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 4 6/16/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Hatch ReleaseA-24 BLUE/GREEN Driver Door Unlock Output

C-12 GREEN/WHITE Memory Seat 1 Output C-13 YELLOW/GREEN Memory Seat 2 Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Factory Alarm Disarm(GREEN/VIOLET)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (PINK/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior Underhood

REDBLACK

Siren (VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

(NOTE: ALSO INCLUDES RKE/RMST

Optional Installation Feature

See Optional connections page

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Hatch Release Output(PINK/ORANGE)

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 204: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Ignition (RED/GREEN)

Starter (RED)

Heater (GREEN/LT. GREEN)

STEERING COLUMNHARNESS

Key-in-Sense (GREEN/VIOLET)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (TAN/BLACK)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections pages

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 4 6/21/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Cut and tape off if not used

+

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 205: ALL MODELS 2002

OPTIONAL CONNECTIONS

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTERWhite

Battery (DK. BLUE/ORANGE)

'02 Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Blue

Black

Yellow

REARDEFROST SWITCH

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 4 6/21/04

'02 Rear Defroster (BLUE/ORANGE)

'03-'05 Rear Defroster (GRAY/BLUE)

'03-'05 Headlights (RED/BLACK)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR P RIORITY UNLOCK

NOTE:

Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON

White

30

87

87a

85 86

Blue

Black

Yellow

Red

IGNITION SWITCH+Battery (YELLOW)FUSE15-AMP

Page 206: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

w/Factory RKE RKE/VSS/RMST

Page Revision Date

4 of 4 6/21/04

OPTIONAL CONNECTIONS (cont'd)

MEMORY SEATS (IF EQUIPPED)

Color FunctionC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

UNDER DRIVERS DOOR SILL PLATE

Memory Seat 2 (BLACK/ORANGE)

Memory Seat1 (BROWN/LT GREEN)

Page 207: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 6/21/04IGNITION SWITCH

Battery (YELLOW)

Starter (RED)

Heater (GREEN/LT GREEN)

STEERING COLUMNHARNESS

Key-in-Sense (GREEN/VIOLET)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (TAN/BLACK)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

IGNITION COILTach Signal (PINK/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Ignition (RED/GREEN)

+

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

MAKE THIS CONNECTION LAST!

Page 208: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 6/21/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Hatch Release Output

A-24 BLUE/GREEN Driver Door Unlock Output C-12 GREEN/WHITE Memory Seat 1 Output C-13 YELLOW/GREEN Memory Seat 2 OutpuT

DRIVERS SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Factory Alarm Disarm(GREEN/VIOLET)

VehicleInterior

Underhood REDBLACK

Optional Installation Feature

See Optional connections page

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

Hatch Release Output(PINK/ORANGE)

Cut and tape off if not used

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Page 209: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Starter (RED)

Ignition (RED/GREEN)

STEERING COLUMNHARNESSHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer 4-Door

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 6/21/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

'02 Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

'03-'05 Headlights (RED/BLACK)

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 210: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 6/21/04

UNDERHOOD HARNESS

Hood Tilt Switch(Optional)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

MEMORY SEATS (IF EQUIPPED)

Color FunctionC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

UNDER DRIVERS DOOR SILL PLATE

Memory Seat 2 (BLACK/ORANGE)

Memory Seat1 (BROWN/LT GREEN)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR PRIORITY UNLOCK

White

30

87

87a

85 86

Blue

Black

Yellow

Red

IGNITION SWITCH+Battery (YELLOW)FUSE15-AMP

Page 211: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED)

Ignition (RED/GREEN)

STEERING COLUMNHARNESS

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'02-'05 Explorer /Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 2 6/21/04

MAKE THIS CONNECTION LAST!

Page 212: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD HARNESS

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

2 of 2 6/21/04

Page 213: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED)

Ignition (RED/GREEN)

IGNITIONSWITCHHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-13 TAN Hatch Release Output

DRIVERS SIDE KICK PANEL HARNESSDoor Lock (PINK/YELLOW)

Vehicle (Year/Make/Model)

'02-'05 Explorer / Mountaineer (4-Door)

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1 6/21/04

MAKE THIS CONNECTION LAST!

Rear Hatch Release(PINK/ORANGE)

HARNESS UNDERDRIVERS SIDE REARDOOR SILL PLATE

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -Factory Alarm Disarm (GREEN/VIOLET)

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Page 214: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L2Z-19G365-AB2003: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - REAR DEFROST (OPTIONAL)1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - DRIVER DOOR UNLOCK PRIORITY (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity NegativeKey in Sense polarity Negative (Default setting)Aux 2 (Rear Defrost) 10 min.

MODULE MOUNTING LOCATION:Above hood release cable near bulkhead panel, in front of emergency brake.

Page 215: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(YELLOW/BLACK)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (TAN/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 5/30/03

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

Page 216: ALL MODELS 2002

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

Heater (BROWN)

Heater (BROWN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneath the driver’s side door sill plate. Wire changes to BROWN (+).

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 5/30/03MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 217: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86

30

87

87a

85 86 Battery (10Ga.Tan/Black)BACK OF FUSEPANEL (P91 JB)

HEADLIGHT SWITCH

Rear Defroster Grid(12 Ga. BROWN/LT BLUE)

+

+

+

+

Headlight

RearDefroster

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Blue

Black

Black

Yellow

Yellow

White

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 1/5/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 218: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

Heater (BROWN)

Heater (BROWN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (TAN/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 5/30/03

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate. Wire color changes to BROWN (+).

Page 219: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 5/30/03

DRIVER DOORJAMB BOOTHARNESS

+Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(YELLOW/BLACK)

Connect only on vehicles with factory RKE

Page 220: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate. Wire changes to BROWN (+).

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 1/5/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 221: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 1/5/04

UNDERHOOD

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 222: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate. Wire color changes to BROWN (+).

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

-

-

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

w/o Factory RKE VSS/RKE & RKEPage Revision Date

1 of 1 5/30/03

MAKE THIS CONNECTION LAST!

Page 223: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate. Wire color changes to BROWN (+).

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 5/30/03

MAKE THIS CONNECTION LAST!

Page 224: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

’02/’03 Explorer Sport / Sport TracEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 5/30/03

OPTIONAL CONNECTIONS

Page 225: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUTKEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESSDoor Lock (PINK/YELLOW)

Vehicle (Year/Make/Model)

’02-’03 Explorer Sport TracEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 1 1/5/04

MAKE THIS CONNECTION LAST!

Connect only on vehicles with factory RKE

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -Driver Door Ajar Switch (YELLOW/BLACK)

*NOTE: This connection is only needed when using Lot Management remotes. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

DRIVER DOORJAMB BOOTHARNESS

Page 226: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 7/6/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2004-2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - REAR DEFROST (OPTIONAL)

1 - HEADLIGHT ILLUMINATION (OPTIONAL)

1 - DRIVER DOOR UNLOCK PRIORITY (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Negative

Key in Sense polarity Negative (Default setting)

Aux 2 (Rear Defrost) 10 min.

MODULE MOUNTING LOCATION:

Above hood release cable near bulkhead panel, in front of emergency brake.

Page 227: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(YELLOW/BLACK)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (WHITE/YELLOW)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 7/6/04

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

Page 228: ALL MODELS 2002

Color Function

A-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Battery (RED)

Starter (RED/BLUE)

Ignition (LT GREEN/VIOLET)

Heater (BROWN)

Heater (GRAY/YELOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (LT GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneath the driver's side door sill plate. Wire changes to BROWN (+).

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 7/6/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 229: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86

30

87

87a

85 86 Battery (10Ga.Tan/Black)BACK OF FUSEPANEL (P91 JB)

HEADLIGHT SWITCH

Rear Defroster Grid(12 Ga. BROWN/LT BLUE)

+

+

+

+

Headlight

RearDefroster

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Blue

Black

Black

Yellow

Yellow

White

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 7/6/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

IGNITIONSWITCH

Battery (RED) +

Page 230: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (RED)

Battery (RED)

Battery (RED)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

Heater (BROWN)

Heater (GRAY?YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (WHITE/YELLOW)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color Function

A-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 7/6/04

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire color changes to BROWN (+).

Page 231: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 7/6/04

DRIVER DOORJAMB BOOTHARNESS

+Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(YELLOW/BLACK)

Connect only on vehicles with factory RKE

Page 232: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (RED)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 1/5/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver's side door sill plate. Wire changes to BROWN (+).

Page 233: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 1/5/04

UNDERHOOD

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IGNITIONSWITCH

Battery (RED) +

Page 234: ALL MODELS 2002

IGNITION SWITCH

Battery (RED)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

-

-

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKE

Page Revision Date

1 of 1 7/6/04

MAKE THIS CONNECTION LAST!

Page 235: ALL MODELS 2002

IGNITION SWITCH

Battery (RED)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 7/6/04

MAKE THIS CONNECTION LAST!

Page 236: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSS

Page Revision Date

1 of 1 7/6/04

OPTIONAL CONNECTIONS

Page 237: ALL MODELS 2002

IGNITION SWITCH

Battery (RED)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUTKEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESSDoor Lock (PINK/YELLOW)

Vehicle (Year/Make/Model)

'04/'05 Explorer Sport/Sport Trac

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1

MAKE THIS CONNECTION LAST!

Connect only on vehicles with factory RKE

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -Driver Door Ajar Switch (YELLOW/BLACK)

*NOTE: This connection is only needed when using Lot Management remotes. Part number

2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

DRIVER DOORJAMB BOOTHARNESS

7/6/04

Page 238: ALL MODELS 2002

515151515 15 15

15

5151515

15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

Only used on (PC-32) systems with Car Start (RMST)

Not used on VSS system.

FUSE PLACEMENT CHART

***

SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L3Z-19G365-AB2003: 1L3Z-19G365-AB2004: 1L3Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)2 - DOOR LOCK/UNLOCK VEHICLES w/o RKE

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:Driver side kick panel high, near bulkhead panel.

F-150 Classic (Classic Body Style)

Page 239: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

W/Factory RKE RKE/VSS/RMSTPage Revision Date

1 of 4 1/5/04(NOTE: ALSO INCLUDES RKE/RMST)

F-150 Classic (Classic Body Style)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputC-4 LT.GREEN/BALCK Perimeter Alarm DisarmA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

KEYLESS ENTRYMODULE LEFTOF BRAKE PEDAL

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

+Passenger Door Unlock (PINK/ORANGE)

DRIVER KICKPANELDriver Door Latch Switch (BLACK/YELLOW)

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Page 240: ALL MODELS 2002

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

W/O Factory RKE RKE/VSS/RMSTPage Revision Date

2 of 4 1/5/04(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

F-150 Classic (Classic Body Style)

Battery (YELLOW) +IGNITION SWITCH Fuse

15 AMP

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 241: ALL MODELS 2002

Color FunctionA-4 RED Battery B-2 RED HVAC1 12 volt Battery FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 4 1/5/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH HEADLIGHT SWITCH+Park Lights (BROWN)

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

F-150 Classic (Classic Body Style)

Page 242: ALL MODELS 2002

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color FunctionC-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

4 of 4 1/5/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

DEFROSTERSWITCH

Rear Defrost (BLUE/ORANGE)

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

F-150 Classic (Classic Body Style)

Page 243: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (GREEN) +

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-2 RED HVAC1 12 volt Battery FeedB-1 BLUE HVAC 2 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 1/5/04

+

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH+Park Lights (BROWN)

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

+

+

Heater (RED/BLACK)

Heater (GRAY/YELLOW)

F-150 Classic (Classic Body Style)

Page 244: ALL MODELS 2002

VehicleInterior

Underhood

REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output

UPPER LEFT KICK PANEL

+ HEADLIGHTSWITCH

Park Lights (BROWN)Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

W/Factory RKE Deluxe RKE/VSSPage Revision Date

1 of 4 1/5/04

+Passenger Door Unlock (PINK/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USEC-4 LT.GREEN/BALCK Perimeter Alarm Disarm

DRIVERS SIDE KICK PANEL HARNESS

DRIVER KICKPANEL

Driver Door Latch Switch (BLACK/YELLOW)

F-150 Classic (Classic Body Style)

HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Page 245: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK Siren (w/VSS only)Color Function

A-15 RED Siren Feed A-16 BLACK Siren Output

UNDERHOOD HARNESS

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output + HEADLIGHT

SWITCHPark Lights (BROWN)

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

W/O Factory RKE Deluxe RKE/VSSPage Revision Date

2 of 4 1/5/04

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-24 BLUE/GREEN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

F-150 Classic (Classic Body Style)

Battery (YELLOW) +IGNITION SWITCH Fuse

15 AMP

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

UPPER LEFT KICK PANEL HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 246: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputC-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (BLUE)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 4 5/30/03

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

F-150 Classic (Classic Body Style)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 247: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

4 of 4 1/5/04

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

F-150 Classic (Classic Body Style)

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 248: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Passenger Door Unlock (PINK/ORANGE)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 1/4/05

MAKE THIS CONNECTION LAST!

+

Note: Parking lights and brake switchconnections can also be found at the trailer connector right of the steering column.

F-150 Classic (Classic Body Style)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

UPPER LEFT KICK PANEL HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Page 249: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKEPage Revision Date

1 of 1 1/5/04

MAKE THIS CONNECTION LAST!

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

F-150 Classic (Classic Body Style)

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output + HEADLIGHT

SWITCHPark Lights (BROWN)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

UPPER LEFT KICK PANEL HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Battery (YELLOW) +IGNITION SWITCH Fuse

15 AMP

Page 250: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 5/30/03

OPTIONAL CONNECTIONS

F-150 Classic (Classic Body Style)

Page 251: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUTKEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 F-150Equipment or Trim level System(s) applicable to:

w/Factory RKE PreloadPage Revision Date

1 of 1 8/29/02

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output

HEADLIGHTSWITCHPark Lights (BROWN) +

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

+Passenger Door Unlock (PINK/ORANGE)

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT.GREEN/BALCK Perimeter Alarm Disarm

DRIVERS SIDE KICK PANEL HARNESS

DRIVER KICKPANEL

Driver Door Latch Switch (BLACK/YELLOW)

F-150 Classic (Classic Body Style)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

UPPER LEFT KICK PANEL HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

F-150 Classic (Classic Body Style)

1/5/04

Page 252: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

+

+

+

CUT KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02-’04 F-150 ClassicEquipment or Trim level System(s) applicable to:

w/o Factory RKE PreloadPage Revision Date

1 of 1 1/5/04

MAKE THIS CONNECTION LAST!

Color FunctionA-5 BLACK GroundA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+

+

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN) CUT

CUT

Half of harness that goes back into the vehicle interior.

30

87

87a

85 86

30

87

87a

85 86

White

White

Black

Black

Yellow

Yellow

Red

Blue

BlueRed

F-150 Classic (Classic Body Style)

HEADLIGHT SWITCH

Color FunctionA-1 WHITE Park Light Output + HEADLIGHT

SWITCHPark Lights (BROWN)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

UPPER LEFT KICK PANEL HARNESSABOVE DRIVERSKICK PANEL

+Dome Light MY 2002 (BLACK/BLUE)

PASSENGER SIDEKICK PANEL+Dome Light MY 2003/2004 (BLACK/BLUE)

Battery (YELLOW) +IGNITION SWITCH Fuse

15 AMP

Page 253: ALL MODELS 2002

515151515 15 15

15

5

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 7/6/04

*Only used on (PC-32) systems with Car Start (RMST)

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2004-2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Rear Defroster 0.5 sec. (Default setting)

MODULE MOUNTING LOCATION:

Upper left kick panel, near parking brake assembly.

1515

F-150 New Body Style

Important Note!

In order to access transmitter and option programmingit will be necessary to manually turn the interior light to the ON position using the dimmer switch.

Page 254: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 4 7/6/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch SenseA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Optional Installation Feature

See Optional connections page

Siren (w/VSS only) Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

+Unlock Switch Sense (PINK/ORANGE)

Optional Installation Feature

See Optional connections page DRIVER SIDEREAR SILL PLATEHARNESS

F-150 New Body Style

**CUT THIS WIRE OFF AS CLOSE

TO THE CONNECTOR AS POSSIBLE**

(NOTE: ALSO INCLUDES RKE/RMST)

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 255: ALL MODELS 2002

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking LightsC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defrost Output

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Battery (LT. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERINGCOLUMNHARNESS

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (LT GREEN)

STEERING COLUMN HARNESS

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections

Cut and tape off if not used

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 4 7/6/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

+Heater (BLACK/LT. GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

F-150 New Body Style

Page 256: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 4 7/6/04

(NOTE: ALSO INCLUDES RKE/RMST)

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86

REAR DEFROSTSWITCH

HEADLIGHT SWITCH

Rear Defroster(BLUE/ORANGE)

+

+Headlight

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON

White

30

87

87a

85 86

Blue

Black

Yellow

RedRelays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

F-150 New Body Style

Battery (LT.GREEN/VIOLET) IGNITIONSWITCH

+

Page 257: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

4 of 4 7/6/04

(NOTE: ALSO INCLUDES RKE/RMST)

Color Function

C-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HARNESS UNDER DRIVERS DOOR SILL PLATE

MEMORY SEATS (IF EQUIPPED)

Memory Seat 1 (BROWN/Lt. GREEN)

Memory Seat 2 (BLACK/ORANGE)

OPTIONAL CONNECTIONS (con't)

F-150 New Body Style

Page 258: ALL MODELS 2002

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED BatteryB-2 RED BatteryA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESS

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (LT GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 7/6/04

MAKE THIS CONNECTION LAST!

+

Battery (LT GREEN/VIOLET) +

F-150 New Body Style

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 259: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 7/6/04

+Unlock Switch Sense (PINK/ORANGE)

DRIVER'S SIDEREAR SILL PLATEHARNESS

F-150 New Body Style

**CUT THIS WIRE OFF AS CLOSE

TO THE CONNECTOR AS POSSIBLE**

Page 260: ALL MODELS 2002

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 7/6/04

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

F-150 New Body Style

Page 261: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 7/5/04

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color Function

C-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HARNESS UNDER DRIVERS DOOR SILL PLATE

MEMORY SEATS (IF EQUIPPED)

Memory Seat 1 (BROWN/Lt. GREEN)

Memory Seat 2 (BLACK/ORANGE)

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

DRIVER SIDEKICK PANEL+

Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back to RKE module.

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priority unlock" (Option #1, Option bank #2) option to ON

White

30

87

87a

85 86

Blue

Black

Yellow

RedRelays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

F-150 New Body Style

Battery (LT.GREEN/VIOLET) IGNITIONSWITCH

+

Page 262: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 2 7/6/04

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

DRIVER'S SIDEREAR SILL PLATEHARNESS

Passenger Door Unlock Motor (PINK/ORANGE) +

F-150 New Body Style

Page 263: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

2 of 2 7/6/04

OPTIONAL CONNECTIONS

F-150 New Body Style

Page 264: ALL MODELS 2002

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESS

Horn (BLUE)

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS & RKE

Page Revision Date

1 of 1 7/6/04

MAKE THIS CONNECTION LAST!

Color FunctionA-1 WHITE Parking Light Output

HEADLIGHT SWITCH

HEADLIGHT SWITCH

+Park Lights (BROWN)

Color Function

A-5 BLACK GroundA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output

DRIVERS SIDE KICK PANEL HARNESS DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

+Dome Light (BLACK/BLUE)

F-150 New Body Style

Page 265: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 F-150 (NEW BODY STYLE)

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1 7/6/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (BLACK/BLUE) +

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

+Unlock Switch Sense (PINK/ORANGE)

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (LT. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (BLUE/GREEN)

STEERING COLUMNHARNESSHorn (BLUE)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

DRIVER'S SIDEREAR SILL PLATEHARNESS

F-150 New Body Style

Page 266: ALL MODELS 2002

515151515 15 15

15

5151515

15 15 15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 6/29/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACE APPLICATION CHART

'04/'05: 1L2Z-19G365-AB (Required for systems with remote start)

RELAY REQUIREMENTS:

1 - PARKING LIGHTS (REQUIRED)

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

1 - REAR WINDOW DEFROST (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock sensitivity polarity Positive (Default setting)

Key in Sense polarity Negative (Default setting)

Aux 2 (Rear Defrost) 10 min. output

MODULE MOUNTING LOCATION:

Driver's side kick panel, below headlight switch and behind knee

blocker panel

IMPORTANT:

* In the base vehicle, Smart Junction Box (SJB) Software must be Level 56 or

higher

* Perform WDS (or an equivalent Diagnostic tool, like NGS Plus) Pre & Post

system installation tests

* Clear any initially existing codes (DTCs) and retest as necessary

* Vehicle must be clean/clear of any abnormal codes (DTSs) before any

Dealer Channel product installation

* Post installation codes testing should be performed after clearing/resetting

the vehicle's modules with the diagnostic tool

* There should be no abnormal codes set by remotely starting the vehicle or

using any of the remote start functions

* Any abnormal code(s) remaining after two test cycles means there is a

fault(s) in the installation of the system

* Troubleshoot the installation, fix and re-test with the diagnostic tool

15

LIFTGATE RELEASE**

Page 267: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 6/21/04

Passenger Door Unlock Motor (ORANGE) +

DRIVER SIDEKICK PANEL

Door Lock (WHITE/VIOLET)

Door Unlock (DK. BLUE/GREEN)

Driver Door Unlock Motor (YELLOW)

Factory Alarm Disarm(LT. BLUE/BLACK)

Driver Door Lock Motor (RED/ORANGE)

KICK PANEL HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 LT. GREEN/BLACK Factory Alarm Disarm A-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 LT. GREEN Unlock Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-11 BLUE/WHITE Rear Defroster Output

DIMMER SWITCHDome Lights (YELLOW)

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputC-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HARNESS UNDER DRIVER DOORSILL PLATE

Optional Installation Feature

See Page (3 of 3)

Optional Installation Feature

See POWER OPTIONS (3 of 3)

Optional Installation Feature

See POWER OPTIONS (3 of 3)

Cut & tape if not used

NOTE: ALSO INCLUDES RKE/RMST

30

87a

85 86

Headlight Off(TAN/WHITE)

BlackTO 12V BATTERYSOURCE ATIGNITION SWITCH

CUT

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

-

White

BlueRed

+

+

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 268: ALL MODELS 2002

BRAKE PEDAL SWITCHBrake (RED/GREEN)

FUELINJECTOR

Tach Signal (GREEN/ORANGE)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake Input

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMTST

Page Revision Date

2 of 3 6/21/04 MAKE THIS CONNECTION LAST!

IGNITION SWITCH

4-WAY PLUG (RIGHT OF COLUMN)

Battery (RED)

Battery (GREEN/VIOLET)

Starter (GREEN)

Ignition (WHITE/YELLOW)

Heater (BLACK/LT. GREEN)

Key-In Sense (BLACK/PINK)

Heater (VIOLET/ORANGE) +

+

+

-

+

+

Battery (GREEN/VIOLET) +

+

CUT

KEY SIDE(after cut)

UNDERDASH LIGHT (BAR BEHIND CRASH PANEL)Dome Light (YELLOW/BLUE)

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

NOTE: ALSO INCLUDES RKE/RMST

+

+

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 269: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 6/28/04

Memory Seat 2 (BLACK/ORANGE)

Memory Seat 1 (BROWN/Lt GREEN)

SLIDING DOOR SWITCH (OVERHEAD CONSOLE)

KICKPANELHARNESS

Power Sliding Door(TAN) -

Power Sliding Door(YELLOW)

-

POWER OPTIONS

Color Function C-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2C-11 BLUE/WHITE Rear Defroster Output

OPTIONAL CONNECTIONS

NOTE: ALSO INCLUDES RKE/RMST

White

Black

30

87

87a

85 86

Yellow

Blue

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor (YELLOW)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

NOTE: Power Sliding Doors

Program the "Aux 4 Remapped to Aux 1" (Option #5, Option bank #4) option to ON

IGNITIONSWITCH

+Battery (GREEN/VIOLET)

IGNITIONSWITCH

+Battery (GREEN/VIOLET)

DRIVER"SKICKPANEL

+Rear Defroster Grid (BROWN/BLUE)

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 270: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 6/27/04

Horn (DARK BLUE)

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-7 BROWN Brake InputB-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay Output

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

BRAKE PEDAL SWITCHBrake (RED/GREEN)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

CONNECTORRIGHT OFSTEERING COLUMN

Battery (RED)

Battery (GREEN/VIOLET)

Starter (GREEN)

Ignition (WHITE/YELLOW)

Heater (BLACK/LT GREEN)

Key-In Sense (BLACK/PINK)

Heater (YELLOW) +

+

+

+

+

+

+

Battery (GREEN/VIOLET)

CUT

KEY SIDE(after cut)

HOOD TILT SWITCH

FUELINJECTOR

Tach Signal (GREEN/ORANGE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Engine Compartment

IGNITIONSWITCH

30

87a85 86

CUTHeadlight Off(TAN/WHITE)

Black

+

Blue Red

Battery (RED) +

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

IMPORTANT! The tach sense input wire must be properly

insulated and secured. Avoid routing the wiring at or

near hot or moving parts. Failure to properly connect this

wire will result in vehicle damage!

Page 271: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/MontereyEquipment or Trim level system(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

1 of 3 6/27/04

HARNESSRIGHT OFSTEERINGCOLUMN

Horn (DARK BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-20 GREEN/VIOLET Door Ajar Switch Input

Battery (RED) +

Driver Door Lock Motor(RED/ORANGE)

Passenger Door Unlock Moror(ORANGE)

+

DRIVER SIDEKICK PANEL

Door Lock (WHITE/VIOLET)

Door Unlock (DK BLUE/GREEN)

+

Driver Door Unlock Motor(YELLOW)

Perimeter Alarm (LT BLUE/BLACK)

KICK PANEL HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 Lt GREEN/BLACK Factory Alarm Disarm A-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 LT GREEN Unlock Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN Power Liftgate

HARNESS UNDER DRIVER DOORSILL PLATECut & tape if not used

Optional Installation Feature

See page 3 of 3

UNDERDASHLIGHT (BAR BEHIND CRASHPANEL)

+Dome Light (YELLOW/WHITE)

+

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 272: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level system(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

2 of 3 6/27/04

Optional Installation Feature

See POWER OPTIONS (3 of 3)

Optional Installation Feature

See POWER OPTIONS (3 of 3)

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch(Optional - Not includedin kit)

ChassisGround Do Not Ground to Hood!

DIMMER SWITCHDome Lights (YELLOW)

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputC-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

30

87a

85 86

Headlight Off(TAN/WHITE)

BlackTO 12V BATTERYSOURCE ATIGNITION SWITCH

CUT

White

BlueRed

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 273: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 6/28/04

Memory Seat 2 (BLACK/ORANGE)

Memory Seat 1 (BROWN/Lt GREEN)

SLIDING DOOR SWITCH (OVERHEAD CONSOLE)

KICKPANELHARNESS

Power Sliding Door(TAN) -

Power Sliding Door(YELLOW)

-

POWER OPTIONS

Color Function C-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2C-11 BLUE/WHITE Rear Defroster Output

OPTIONAL CONNECTIONS

White

Black

30

87

87a

85 86

Yellow

Blue

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor (YELLOW)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

NOTE: Power Sliding Doors

Program the "Aux 4 Remapped to Aux 1" (Option #5, Option bank #4) option to ON

IGNITIONSWITCH

+Battery (GREEN/VIOLET)

IGNITIONSWITCH

+Battery (GREEN/VIOLET)

DRIVER"SKICKPANEL

+Rear Defroster Grid (BROWN/BLUE)

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 274: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE & RKE/VSS

Page Revision Date

1 of 1 6/28/04

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

KICK PANEL HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light Output

UNDERDASHLIGHTDome Light (YELLOW/BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE T HIS CONNECTION L AST!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-20 GREEN/VIOLET Door Ajar Switch Input

Battery (RED) +

+

DIMMER SWITCHDome Lights (YELLOW)

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

30

87a

85 86

Headlight Off(TAN/WHITE)

BlackTO 12V BATTERYSOURCE ATIGNITION SWITCH

CUT

White

BlueRed

PLUG RIGHT OFSTEERINGCOLUMN

Horn (DK BLUE)

Door Lock (WHITE/VIOLET)

Door Unlock (DK BLUE/GREEN)DRIVER"S SIDEKICK PANEL

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 275: ALL MODELS 2002

PLUG RIGHT OFSTEERINGCOLUMN

Horn (DK BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

DRIVER'S SIDE KICK PANEL

+

+

Driver Door Unlock Motor (YELLOW)

Driver Door Lock Motor (RED/ORANGE)

Passenger Door Unlock Motor(ORANGE)

+

Vehicle (Year/Make/Model)

'04/'05 Freestar/Monterey

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 6/29/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-20 GREEN/VIOLET Door Ajar Switch Input

KICK PANEL HARNESS

Color FunctionA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Sense Input

Battery (RED) +

Dome Light (YELLOW/WHITE)

UNDERDASHLIGHT (BAR BEHIND CRASHPANEL)

+

DRIVER'S SIDE SILL PLATEHARNESS

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

30

87a

85 86

Headlight Off(TAN/WHITE)

BlackTO 12V BATTERYSOURCE ATIGNITION SWITCH

CUT

White

BlueRed

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 276: ALL MODELS 2002

UNDER HOOD HARNESS (OPTIONAL)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren (Optional - Not Included in Kit)

Hood Tilt Switch(Optional - Not Included in Kit)Chassis

GroundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'04/'05 Freestar/MontereyEquipment or Trim level System(s) applicable to:

All VSS & RKE/VSSPage Revision Date

1 of 1 6/30/04

OPTIONAL CONNECTIONS

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE

CAREFULLY TAPED AND PROPERLY SECURED

PER GOOD WIRING PRACTICES. NO

EXCEPTIONS!

Page 277: ALL MODELS 2002

PLUG RIGHT OFSTEERINGCOLUMN

Horn (DK BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUTKEY SIDE(after cut)

MAKE T HIS CONNECTION L AST!

DRIVER'S SIDE KICK PANEL+

+

Driver Door Unlock Motor (YELLOW)

Driver Door Lock Motor (RED/ORANGE)

Passenger Door Unlock Motor(ORANGE)

+

Vehicle (Year/Make/Model)

'04/'05 Freestar/MontereyEquipment or Trim level System(s) applicable to:

w/Factory RKE PRELOAD

Page Revision Date

1 of 1 6/30/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-20 GREEN/VIOLET Door Ajar Switch Input

KICK P ANEL HARNESS

Color FunctionA-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Perimeter Alarm DisarmA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Sense Input

Battery (RED)

+

Dome Light (YELLOW/WHITE)UNDERDASHLIGHT+

DRIVER'S SIDE SILL PLATEHARNESS

CHASSIS GROUND POINTIN DRIVER'S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light Output

DIMMER SWITCHDome Lights (YELLOW)

HEADLIGHT SWITCHParking Lights

(BLACK/GREEN)

30

87a

85 86

Headlight Off(TAN/WHITE)

BlackTO 12V BATTERYSOURCE ATIGNITION SWITCH

CUT

White

BlueRed

Door Lock (WHITE/VIOLET)

Door Unlock (DK BLUE/GREEN)

Perimeter Alarm (LT BLUE/BLACK)

IMPORTANT!

ALL CUT AND SPLICED WIRES MUST BE CAREFULLY

TAPED AND PROPERLY SECURED PER GOOD WIRING

PRACTICES. NO EXCEPTIONS!

Page 278: ALL MODELS 2002

515151515 15 15

15

515151515 15

15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 3/19/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)2002-2005: 1S4Z-19G365-AB

RELAY REQUIREMENTS:1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)1 - TRIM SWITCH DISABLE OVERRIDE1 - HEADLIGHT ILLUMINATION (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Positive

MODULE MOUNTING LOCATION:Behind fuse panel

Page 279: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER KICK PANEL

Dome Light (BLACK/BLUE)

+

+

+

Door Lock (BLACK/RED)

Door Unlock (BLACK/YELLOW)

Factory Disarm* (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/BLACK)

Passenger Door Unlock Motor(WHITE/BLACK)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (BLACK/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)Color Function

A-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 3/19/04

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST) OVERHEAD DOMELIGHT

G.E.M.

Note: If vehicle is equipped with factory RKE, but no factory perimeter alarm, a relay (not supplied) must be wired to by-pass the trim switch disable feature. Relay wiring diagram on page 3 of this drawing.

*

Page 280: ALL MODELS 2002

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-13 TAN Trunk Release Output (-)A-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

Heater (YELLOW)

Key-in-Sense (RED/BLACK)

Horn (BLACK/BLUE)

BRAKE SWITCHBrake light (GREEN/RED)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

TRUNK RELEASESWITCHTrunk Release (BLACK/YELLOW)

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 3/19/04MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 281: ALL MODELS 2002

White

Battery (GREEN/BLACK)

Headlights (GREEN/RED)

30

87

87a

85 86

P91 JUNCTIONBLOCK

HEADLIGHT SWITCH

Rear Defroster(BLACK/ORANGE)

+

+Headlight

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

YellowIMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 3/19/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

White

30

87

87a

85 86

Blue

Black

Yellow

IGNITION SWITCH

Battery (RED)

Ignition (GREEN/YELLOW) +

+

TRIM SWITCH DISABLE BY-PASS RELAY

Required on Focus without factory perimeter alarm

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(WHITE/BLACK)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 282: ALL MODELS 2002

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (BLACK/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 3/19/04

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

Heater (YELLOW)

Key-in-Sense (RED/BLACK)

Horn (BLACK/BLUE)

BRAKE SWITCHBrake light (GREEN/RED)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

CUT

MAKE THIS CONNECTION LAST!

KEY SIDE(after cut)

Page 283: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER KICK PANEL

Dome Light (BLACK/BLUE)

+

+

+

Door Lock (BLACK/RED)

Door Unlock (BLACK/WHITE)

Factory Disarm* (BLACK/YELLOW)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/BLACK)

Passenger Door Unlock Motor(WHITE/BLACK)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 3/19/04

Connect only on vehicles with factory RKE

OVERHEAD DOMELIGHT

G.E.M.

* Note: If vehicle is equipped with factory RKE, but no factory perimeter alarm, a relay (not supplied) must be wired to by-pass the trim switch disable feature. Relay wiring diagram on page 3 of this drawing.

Page 284: ALL MODELS 2002

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release Output (-)A-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

Horn (BLACK/BLUE)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

TRUNK RELEASESWITCHTrunk Release (BLACK/YELLOW)

+

+

+

+

CUT

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 3/19/04MAKE THIS CONNECTION LAST!

KEY SIDE(after cut)

Page 285: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 3/19/04

UNDERHOOD

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output White

30

87

87a

85 86

Blue

Black

Yellow

IGNITION SWITCH

Battery (RED)

Ignition (GREEN/YELLOW) +

+

TRIM SWITCH DISABLE BY-PASS RELAY

Required on Focus without factory perimeter alarm

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(WHITE/BLACK)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 286: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

w/o Factory RKE VSS/RKE & RKEPage Revision Date

1 of 1 3/19/04

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER KICK PANEL

Dome Light (BLACK/BLUE)

Door Lock (BLACK/RED)

Door Unlock (BLACK/YELLOW)

OVERHEAD DOMELIGHT

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release Output (-)A-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

Horn (BLACK/BLUE)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

TRUNK RELEASESWITCHTrunk Release (BLACK/YELLOW)

+

+

+

+

CUT

MAKE THIS CONNECTION LAST!

KEY SIDE(after cut)

*NOTE:Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Alarm Disarm Output.

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output White

30

87

87a

85 86

Blue

Black

Yellow

IGNITION SWITCH

Battery (RED)

Ignition (GREEN/YELLOW) +

+

TRIM SWITCH DISABLE BY-PASS RELAY

Required on Focus without factory perimeter alarm

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 287: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 3/19/04

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release Output (-)A-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

Horn (BLACK/BLUE)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

TRUNK RELEASESWITCHTrunk Release (YELLOW/BLACK)

+

+

+

+

CUT

MAKE THIS CONNECTION LAST!

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER KICK PANEL

Dome Light (BLACK/BLUE)

+

+

+

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/BLACK)

Passenger Door Unlock Motor(WHITE/BLACK)

OVERHEAD DOMELIGHT

G.E.M.

KEY SIDE(after cut)

Page 288: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 3/19/04

OPTIONAL CONNECTIONS

Page 289: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 2 3/19/04

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release Output (-)A-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLACK/BLUE)

Parking lights (ORANGE/YELLOW) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

TRUNK RELEASESWITCHTrunk Release (BLACK/YELLOW)

+

+

+

+

CUT

MAKE THIS CONNECTION LAST!

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER KICK PANEL

Dome Light (BLACK/BLUE)

+

+

+

Door Lock (BLACK/RED)

Door Unlock (BLACK/YELLOW)

Factory Disarm* (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/BLACK)

Passenger Door Unlock Motor(WHITE/BLACK)Connect only on vehicles

with factory RKE

OVERHEAD DOMELIGHT

G.E.M.* Note: If vehicle is equipped with factory RKE, but no factory perimeter alarm, a relay (not supplied) must be wired to by-pass the trim switch disable feature. See page 2 of 2 for diagram.

KEY SIDE(after cut)

Page 290: ALL MODELS 2002

X

X

X

X

X

X

515151515 15 15

15

5151515

15 15

15- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**(FIVE HUNDRED ONLY)

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 5/24/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2005: 1L2Z-19G365-AB (Kit 3)

RELAY REQUIREMENTS:

1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

MODULE MOUNTING LOCATION:

Left side of dashboard behind headlight switch

Rear Defrost (Aux 2) Time 0.5 Sec. (Default Setting)

Page 291: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 5/24/04

X

X

X

X

X

X

Location: Behind Driver's Side Lower Dashboard Crash Panel

(SJB)

Page 292: ALL MODELS 2002

Color FunctionA-4 RED BatteryB-2 RED HVAC1 Battery Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC1 OutputB-8 BLACK/WHITE Key-in-sense Input A-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key Side

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

+

+

HOOD TILT SWITCH

FUELINJECTORTach Signal (UNCOMMON SIDE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 5/24/04

(NOTE: ALSO INCLUDES RKE/RMST)

Battery (RED)

Battery (RED)

MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

Heater (GRAY/YELLOW)

Key-in-Sense (YELLOW)

XCUT

Key SideAfter Cut

+

+

+Starter (DK GREEN)

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wirewill result in vehicle damage!

Color FunctionA-5 BLACK Ground C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

DRIVER'S SIDE KICK PANEL HARNESSOptional Installation Feature seeOptional Connections page 3 of 3

X

X

X

X

X

Page 293: ALL MODELS 2002

Parking Lights (ORANGE/BLACK)

Brake Switch (RED/LT. GREEN)

Horn (DK. BLUE)

Optional Installation Feature

See Optional connections

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 5/24/04

(NOTE: ALSO INCLUDES RKE/RMST)

X

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake InputA-24 BLUE/GREEN Driver Door Unlock OutputC-11 BLUE/WHITE Rear Defroster Output

SJB HARNESS

SJB J5CONNECTOR

Dome Light (BLACK/LT. BLUE)

Lock Motor (PINK/BLACK)

Driver's Door Unlock Motor(YELLOW)

Passenger Door Unlock Motor(PINK/WHITE)

+

+

+

+

SJB J3CONNECTOR

Door Lock Switch (PINK/YELLOW)

Door Unlock Switch (PINK/LT GREEN)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release (PINK/ORANGE)(Five Hundred Only)

SJB J2CONNECTOR

SJB J4CONNECTOR

SJB J1CONNECTOR

X

X

X

X

X

See "SJB Layout" page for

connector locations.

+

+

Page 294: ALL MODELS 2002

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(YELLOW)

Connect to the half of the wire going back to the SJB

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

30

87

87a

85 86White

Yellow

Black

Red

BlueSJB J5CONNECTOR

X

IGNITION SWITCHHARNESS

Battery (RED) +

Color Function

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

MEMORY SEATS

X

Rear Defroster (TAN/LT BLUE)SJB J2CONNECTOR Color Function

C-11 BLUE/WHITE Rear Defroster Output

REAR DEFROSTER

Memory Seat 1 (BROWN/LT GREEN) DRIVER'S SIDEKICK PANELHARNESSMemory Seat 2 (BLACL/ORANGE)

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 5/24/04

(NOTE: ALSO INCLUDES RKE/RMST)

X

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

X

X

X

Page 295: ALL MODELS 2002

X

Color Function

A-5 BLACK GroundA-4 RED BatteryB-2 RED HVAC1 Battery Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC1 OutputB-8 BLACK/WHITE Key-in-sense Input A-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

+

+

HOOD TILT SWITCH

FUELINJECTORTach Signal (UNCOMMON SIDE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 5/24/04

Battery (RED)

Battery (RED)

MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

Heater (GRAY/YELLOW)

Key-in-Sense (YELLOW)

XCUT

Key SideAfter Cut

+

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Parking Lights (ORANGE/BLACK)

Brake Switch (RED/LT. GREEN)

SJB J1CONNECTOR

Horn (DK. BLUE)SJB J2CONNECTOR

X

X

X

X

+

+

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 296: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

X

X

Color FunctionA-4 RED Battery Feed A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key Side

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 5/24/04

Battery (RED)MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

DRIVER'S SIDE KICK PANEL HARNESSOptional Installation Feature seeOptional Connections page 3 of 3

X

X

X

Page 297: ALL MODELS 2002

X

X

X

Parking Lights (ORANGE/BLACK)

Horn (DK. BLUE)

Optional Installation Feature

See Optional connections

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 5/24/04

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-11 BLUE/WHITE Rear Defroster Output

SJB HARNESS

SJB J5CONNECTOR

Dome Light (BLACK/LT. BLUE)

Lock Motor (PINK/BLACK)

Driver's Door Unlock Motor(YELLOW)

Passenger Door Unlock Motor(PINK/WHITE)

+

+

+

+

SJB J3CONNECTOR

Door Lock Switch (PINK/YELLOW)

Door Unlock Switch (PINK/LT GREEN)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release (PINK/ORANGE)(Five Hundred Only)

SJB J2CONNECTOR

SJB J4CONNECTOR

SJB J1CONNECTOR

X

X

X

See "SJB Layout" page for

connector locations.

+

Page 298: ALL MODELS 2002

X

X

X

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(YELLOW)

Connect to the half of the wire going back to the SJB

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

30

87

87a

85 86White

Yellow

Black

Red

BlueSJB J5CONNECTOR

IGNITION SWITCHHARNESS

Battery (RED) +

Color Function

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

MEMORY SEATS

Memory Seat 1 (BROWN/LT. GREEN) DRIVER'S SIDEKICK PANELHARNESSMemory Seat 2 BLACK/ORANGE)

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 5/24/04

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

UNDERHOOD

Hood Tilt Switch(Optional - Not supplied in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

X

X

X

Page 299: ALL MODELS 2002

X

X

X

Color FunctionA-4 RED Battery Feed A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key Side

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS & RKE

Page Revision Date

1 of 1 5/24/04

Battery (RED)MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Parking Lights (ORANGE/BLACK)

Horn (DK. BLUE)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light Output

SJB HARNESS

SJB J5CONNECTOR

Dome Light (BLACK/LT. BLUE) +

SJB J3CONNECTOR

Door Lock Switch (PINK/YELLOW)

Door Unlock Switch (PINK/LT GREEN)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release (PINK/ORANGE)(Five Hundred Only)

SJB J2CONNECTOR

SJB J4CONNECTOR

SJB J1CONNECTOR

X

X

+

See "SJB Layout" page for

connector locations.

Page 300: ALL MODELS 2002

X

X

X

X

Color FunctionA-4 RED Battery Feed A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key Side

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 1 5/24/04

Battery (RED)MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Parking Lights (ORANGE/BLACK)

Horn (DK. BLUE)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

SJB HARNESSSJB J5CONNECTOR

Dome Light (BLACK/LT. BLUE)

Lock Motor (PINK/BLACK)

Driver's Door Unlock Motor(YELLOW)

Passenger Door Unlock Motor(PINK/WHITE)

+

+

+

+

SJB J2CONNECTOR

SJB J1CONNECTOR

X

+

See "SJB Layout" page for

connector locations.

Page 301: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSS

Page Revision Date

1 of 1 5/24/04

OPTIONAL CONNECTIONS

X

X

X

X

X

X

Page 302: ALL MODELS 2002

*NOTE:Part number 2W7Z 19C757 BA

(Extended Function Harness) must be

ordered to access the Factory Alarm

Disarm Output.

X

X

X

X

X

Color FunctionA-4 RED Battery Feed A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key Side

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION SWITCHHARNESS

+

+

Vehicle (Year/Make/Model)

'05 Five Hundred/Freestyle

Equipment or Trim level System(s) applicable to:

ALL PRELOAD

Page Revision Date

1 of 1 5/24/04

Battery (RED)MAKE THIS CONNECTION LAST!

Ignition (LT GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Parking Lights (ORANGE/BLACK)

Horn (DK. BLUE)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-2 BLUE Door Lock OutputA-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light Output

SJB HARNESS

SJB J5CONNECTOR

Dome Light (BLACK/LT. BLUE)

Lock Motor (PINK/BLACK)

Driver's Door Unlock Motor(YELLOW)

Passenger Door Unlock Motor(PINK/WHITE)

+

+

+

+

SJB J3CONNECTOR

Door Lock Switch (PINK/YELLOW)

Door Unlock Switch (PINK/LT GREEN)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release (PINK/ORANGE)(Five Hundred Only)

SJB J2CONNECTOR

SJB J4CONNECTOR

SJB J1CONNECTOR

+

See "SJB Layout" page for

connector locations.

Page 303: ALL MODELS 2002

Color FunctionC-4 LT GREEN/BLACK Factory Alarm Disarm Output White

30

87

87a

85 86

Blue

Black

Yellow

IGNITION SWITCH

Battery (RED)

Ignition (GREEN/YELLOW) +

+

TRIM SWITCH DISABLE BY-PASS RELAY

Required on Focus without factory perimeter alarm

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02-’05 FocusEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

2 of 2 3/19/04

*NOTE:Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Alarm Disarm Output.

Page 304: ALL MODELS 2002

515151515 15 15

15

5151515 15 15 15-

+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1S4Z-19G365-AB

RESISTOR REQUIREMENTS:Parking Lights- 1.8k ohm required on all systems

Headlights (optional)- 750 ohm required on all systems

VEHICLE SPECIFIC PROGRAMMING:Door trigger polarity Negative Unlock switch sense polarity Positive (Default setting)Key in Sense polarity PositiveRear Defroster 10 Min.

MODULE MOUNTING LOCATION:Behind headlight switch panel

Brown GrayOrange

A-1 White Parking Light (WHITE/GREEN)

VioletGreenRed

C-10 Red/White Headlight (WHITE/GREEN)

Page 305: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 4 1/5/04(NOTE: ALSO INCLUDES RKE/RMST)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-13 TAN Trunk Release OutputC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-2 BLACK/GREEN Windows Down Output

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVERS SIDEUNDERDASHLIGHT

Dome Light (BLACK/WHITE)

+DDM INSIDEDRIVERS DOOR

+

Door Lock (BLACK/BLUE)

Door Unlock (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior Underhood

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

UNDER DRIVERSSIDE REARDOOR SILL PLATE

+Unlock Switch Sense(WHITE/BLACK)

Trunk Release (WHITE) TRUNK RELEASESWITCH

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Page 306: ALL MODELS 2002

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Heater (PINK/WHITE)

IGNITION SWITCH

Key-in-Sense (RED/WHITE)

Horn (BROWN/RED)

BRAKE SWITCHBrake light (ORANGE/YELLOW)

Parking lights(WHITE/GREEN)

HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 4 1/5/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

REQUIRES GROUNDTHROUGH A 1.8K ohm RESISTOR INLINE

FEMMODULE

+

Page 307: ALL MODELS 2002

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 4 1/5/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

HEADLIGHTSWITCH

REM PASSENGERSIDE OF TRUNK

Headlights (WHITE/GREEN)

REQUIRES GROUNDTHROUGH A 750 ohm RESISTOR INLINE

Rear Defroster (BROWN/WHITE)

DRIVER DOOR UNLOCK NOTE:

Driver door only or All door unlock on the first press of unlock is controlled by the programming of the DDM (same as with the factory RKE system). To change the behavior of this feature refer to the vehicle service manual.

NOTE:

Program the "Aux 2 (Rear Defroster) time" (Option #2, Option Bank #4) option to ON.

Page 308: ALL MODELS 2002

Color FunctionC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

DDM INSIDEDRIVERS DOOR

Color FunctionA-14 GREEN Door Unlock OutputC-2 BLACK/GREEN Windows Down Output

MEMORY SEATS (IF EQUIPPED)

EXPRESS WINDOWS DOWN (IF EQUIPPED)

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

4 of 4 1/5/04

OPTIONAL CONNECTIONS Contd

DDM INSIDEDRIVERS DOORDoor Unlock (BLACK/WHITE)

Memory Seat 2 (WHITE/BLUE)

Memory Seat 1 (WHITE/RED)

NOTE:

Program the "Aux 3 time" (Option #3, Option Bank #4) option to OFF.

(NOTE: ALSO INCLUDES RKE/RMST)

Page 309: ALL MODELS 2002

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground Do Not Ground to Hood!

VehicleInterior

UnderhoodColor Function

A-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-4 RED Battery B-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Heater (PINK/WHITE)

IGNITION SWITCH

Key-in-Sense (RED/WHITE)

Horn (BROWN/RED)

BRAKE SWITCHBrake light (ORANGE/YELLOW)

Parking lights(WHITE/GREEN)

HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 1/5/04

MAKE THIS CONNECTION LAST!

REQUIRES GROUNDTHROUGH A 1.8K ohm RESISTOR INLINE

FEMMODULE

+

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Page 310: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 09/07/02

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-2 BLACK/GREEN Windows Down OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputA-12 LT GREEN Unlock Switch SenseA-13 TAN Trunk Release Output

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVERS SIDEUNDERDASHLIGHT

Dome Light (BLACK/WHITE)

+DDM INSIDEDRIVERS DOOR

+

Door Lock (BLACK/BLUE)

Door Unlock (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

UNDER DRIVERSSIDE REARDOOR SILL PLATE

+Unlock Switch Sense(WHITE/BLACK)

Trunk Release (WHITE) TRUNK RELEASESWITCH

Memory Seat 2 (WHITE/BLUE)

Memory Seat 1 (WHITE/RED)

Page 311: ALL MODELS 2002

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 09/07/02MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Headlights, Parking Lights(WHITE/GREEN

HEADLIGHTSREQUIRES GROUNDTHROUGH A 750 ohm RESISTOR INLINE

PARKING LIGHTSREQUIRES GROUNDTHROUGH A 1.8k ohm RESISTOR INLINE

Page 312: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 09/07/02

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Page 313: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DDM INSIDEDRIVERS DOOR

Dome Light (BLACK/WHITE)

+

UNDER DRIVERSSIDE REAR DOOR SILL PLATE

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch Sense

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL VSSPage Revision Date

1 of 1 09/07/02

+

DRIVERS SIDEUNDERDASHLIGHT

+Driver Door Unlock Motor(WHITE/BLACK)

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Parking Lights(WHITE/GREENREQUIRES GROUND

THROUGH A 1.8k ohm RESISTOR INLINE

Page 314: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 09/07/02

OPTIONAL CONNECTIONS

Page 315: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-24 BLUE/GREEN Trunk Release Output

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVERS SIDEUNDERDASHLIGHT

Dome Light (BLACK/WHITE)

+DDM INSIDEDRIVERS DOOR

+

Door Lock (BLACK/BLUE)

Door Unlock (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Vehicle (Year/Make/Model)

’02 LS- 6/8Equipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 1 09/07/02

UNDER DRIVERSSIDE REARDOOR SILL PLATE

+Unlock Switch Sense(WHITE/BLACK)

Trunk Release (WHITE) TRUNK RELEASESWITCH

Color FunctionA-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Parking Lights(WHITE/GREEN

REQUIRES GROUNDTHROUGH A 1.8k ohm RESISTOR INLINE

Page 316: ALL MODELS 2002

515151515 15 15

15

5151515 15 15 15-

+

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT

TRUNK RELEASE

PK LIGHTS

DOOR LOCKS

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 7/18/04

*Only used on (PC-32) systems with Car Start (RMST)

FUSE PLACEMENT CHARTREMOTE START REQUIRED PARTS:

SecuriLock (PATS) Interface 2003-05: 1L2Z-19G365-AB

In-line Diode Harness 2003-05: 5W4Z-14A604-AA

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Aux 2 (Rear Defroster Time) 10 minute

MODULE MOUNTING LOCATION:

Behind headlight switch panel

15ADDITIONAL PARTS NEEDED

1-Relay-Parking Lights Part # YL3Z-19G390-AA

1-Relay-Headlights (Optional) Part # YL3Z-19G390-AA

Page 317: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT GREEN Unlock Switch SenseA-13 TAN Trunk Release OutputC-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 OutputC-2 BLACK/GREEN Windows Down Output

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVERS SIDEUNDERDASHLIGHT

Dome Light (BLACK/WHITE)

+DDM INSIDEDRIVERS DOOR

+

Door Lock (BLACK/BLUE)

Door Unlock (BLACK/WHITE)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior Underhood

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL RKE/RMST

Page Revision Date

1 of 4 7/18/04

UNDER DRIVERSSIDE REARDOOR SILL PLATE

+Unlock Switch Sense(WHITE/BLACK)

Trunk Release (WHITE) TRUNK RELEASESWITCH

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 318: ALL MODELS 2002

Color Function

A-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upB-1 BLUE HVAC 2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Ignition 2 (PINK/YELLOW)

IGNITION SWITCH

Key-in-Sense (RED/WHITE)

Horn (BROWN/RED)

BRAKE SWITCH

Brake light (ORANGE/YELLOW)

(GRAY/ORANGE)HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL RKE/RMST

Page Revision Date

2 of 4 7/18/04

MAKE THIS CONNECTION LAST!

FEMMODULE

+

Battery (RED) +

+

CUT

White

Battery (RED)

30

87

87a

85 86Black

IGNITION SWITCH

+

Yellow

Red

Parking Lights (WHITE/BLUE)

Heater (YELLOW) +

Heater (PINK/WHITE)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

RED

BLACK/WHITEIn-line Diode Harness RequiredPart #5W4Z-14A604-AA

Page 319: ALL MODELS 2002

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL RKE/RMST

Page Revision Date

3 of 4 7/18/04

OPTIONAL CONNECTIONS

REM PASSENGERSIDE OF TRUNK

Rear Defroster (BROWN/WHITE)

(GRAY/ORANGE)HEADLIGHT SWITCH

CUT

White

Battery (RED)

30

87

87a

85 86Black

IGNITION SWITCH

+

Yellow

Red

Headlights (WHITE/GREEN)

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

NOTE:

Program the "Aux 2 (Rear Defroster) time" (Option #2, Option Bank #4) option to ON.

DRIVER DOOR UNLOCK NOTE:

Driver door only or All door unlock on the first press of unlock is controlled by the programming of the DDM (same as with the factory RKE system). To change the behavior of this feature refer to the vehicle service manual.

Page 320: ALL MODELS 2002

Color Function

C-12 GREEN/WHITE Memory Seat 1 OutputC-13 YELLOW/GREEN Memory Seat 2 Output

DDM INSIDEDRIVERS DOOR

Color Function

A-14 GREEN Door Unlock Output C-2 BLACK/GREEN Windows Down Output

MEMORY SEATS (IF EQUIPPED)

EXPRESS WINDOWS DOWN (IF EQUIPPED)

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL RKE/RMST

Page Revision Date

4 of 4 7/18/04

OPTIONAL CONNECTIONS Contd

DDM INSIDEDRIVERS DOORDoor Unlock (BLACK/WHITE)

Memory Seat 2 (WHITE/BLUE)

Memory Seat 1 (WHITE/RED)

NOTE:

Program the "Aux 3 time" (Option #3, Option Bank #4) option to OFF.

Page 321: ALL MODELS 2002

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Color FunctionA-4 RED Battery B-1 BLUE HVAC 2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Heater (PINK/WHITE)

Horn (BROWN/RED)

BRAKE SWITCHBrake light (ORANGE/YELLOW)

STEERING COLUMN HARNESS

+

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE T HIS CONNECTION L AST!

FEM MODULE

Battery (RED) +

Heater (YELOW/WHITE) +

Vehicle (Year/Make/Model)

'03-'05 LS- 6/8

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 7/18/04

(GRAY/ORANGE) HEADLIGHT SWITCH

CUT

White

Battery (RED)

30

87

87a

85 86Black

IGNITION SWITCH

+

Yellow

Red

Parking Lights (WHITE/BLUE)

Ignition 2 (PINK/YELLOW) +

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IGNITION SWITCH

Key-in-Sense (RED/WHITE) +RED

BLACK/WHITEIn-line Diode Harness RequiredPart #5W4Z-14A604-AA

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 322: ALL MODELS 2002

515151515 15 15

15

515151515 15 15 15

-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 7/15/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002-04: 1L3Z-19G365-AB

RELAY REQUIREMENTS:

1 - DRIVERS DOOR PRIORITY UNLOCK 1 - REAR DEFROST (OPTIONAL)1 - HEADLIGHT ILLUMINATION (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:Door trigger polarity Positive (Default setting)Unlock switch sense polarity PositiveKey in Sense polarity Negative (Default setting)Rear Defroster 0.5 sec pulse (Default)

MODULE MOUNTING LOCATION:Above fuse box near upper drivers side kick panel.

Page 323: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

GEM MODULEDRIVERS KICKPANEL

Dome Light (BLACK/WHITE) +

+

DRIVERS KICKPANEL

+

Door Lock (GREEN)

Door Unlock (VIOLET)

Lock Motor (RED/WHITE)

Driver Door Unlock Motor(RED/ORANGE)

Factory Alarm Disarm(GREEN/VIOLET)

HOOD TILT SWITCH

PASSENGERFRONT FUELINJECTOR

Tach Signal (TAN/BLACK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

All RKE/VSS/RMSTPage Revision Date

1 of 3 7/15/03

Trunk Release (VIOLET/YELLOW)

+

+

+

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMTSTR)

Page 324: ALL MODELS 2002

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

C-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (RED/BLACK)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneath the driver’s side door sill plate.

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMTSTRPage Revision Date

2 of 3 7/15/03

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMTSTR)

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 325: ALL MODELS 2002

OPTIONAL CONNECTIONS

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTERWhite

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Blue

Black

Yellow

REARDEFROST SWITCHRear Defroster

(BLACK/TELLOW)

30

87

87a

85 86

Battery (Dk. GREEN/WHITE)

Blue

Black

Yellow

White

Red

+

GEMMODULEDRIVERSKICK PANEL

+Driver Door Unlock Motor(RED/ORANGE)

CUT

Color FunctionA-24 BLUE/GREEN Driver Door Unlock Output (-)

A-9 BROWN Disarm Input

DRIVER’S DOOR PRIORITY UNLOCK

Connect to the half of the wire going back into the vehicle’s interior

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2)

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMTSTRPage Revision Date

3 of 3 7/15/03

+

Battery (PINK/Lt. BLUE)

+White

30

87

87a

85 86

Rear Defrost

Blue

Yellow

Black

Page 326: ALL MODELS 2002

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (RED/BLACK)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANELMAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

PASSENGERFRONT FUELINJECTOR

Tach Signal (TAN/BLACK)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 7/15/03

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate.

Page 327: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-13 TAN Trunk Release OutputA-24 BLUE/GREN Driver Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

GEM MODULEDRIVERS KICKPANEL

Dome Light (BLACK/WHITE) +

+

DRIVERS KICKPANEL

+

Door Lock (GREEN)

Door Unlock (VIOLET)

Lock Motor (RED/WHITE)

Driver Door Unlock Motor(RED/ORANGE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

All Deluxe RKE/VSSPage Revision Date

1 of 3 7/15/03

Trunk Release (VIOLET/YELLOW)

+

+

+

Factory Alarm Disarm(GREEN/VIOLET)

Connect only on vehicles with factory RKE

Page 328: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight OutputC-8 BLUE Trunk Ajar Input

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 7/15/03

MAKE THIS CONNECTION LAST!

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Blue

Black

Yellow

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 329: ALL MODELS 2002

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 7/15/03

Color FunctionA-24 BLUE/GREEN Driver Door Unlock Output (-)C-4 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

CUT

DRIVER’S DOOR PRIORITY UNLOCK

Connect to the half of the wire going back into the vehicle’s interior

NOTE:Program the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

OPTIONAL CONNECTIONS

30

87

87a

85 86

Blue

Black

Yellow

White

Red

Battery (Dk. GREEN/WHITE)

+

GEM MODULEDRIVERS KICKPANEL

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 330: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate.

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

GEM MODULEDRIVERSKICK PANEL

Dome Light (BLACK/WHITE) +

+

+

Door Unlock (VIOLET)

Lock Motor (RED/WHITE)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

w/ Factory RKE VSSPage Revision Date

1 of 1 7/15/03

MAKE THIS CONNECTION LAST!

Page 331: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-13 TAN Trunk Release Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

FEM MODULEDRIVERSKICK PANEL

Door Lock (GREEN)

Door Unlock (VIOLET)

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKEPage Revision Date

1 of 1 7/15/03

Trunk Release(VIOLET/YELLOW)

DRIVERSKICK PANEL

+

+

+

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate.

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

MAKE THIS CONNECTION LAST!

Page 332: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD HARNESS

Hood Tilt Switch(Optional)

Chassisground

Do Not Ground to Hood!

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 7/15/03

OPTIONAL CONNECTIONS

Page 333: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-13 TAN Trunk Release Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

GEM MODULEDRIVERS KICKPANEL

Dome Light (BLACK/WHITE) +

+

DRIVERS KICKPANEL

+

Door Lock (GREEN)

Door Unlock (VIOLET)

Lock Motor (RED/WHITE)

Driver Door Unlock Motor(RED/ORANGE)

Vehicle (Year/Make/Model)

’02-’04 MustangEquipment or Trim level System(s) applicable to:

All PreloadPage Revision Date

1 of 1 7/15/03

Trunk Release (VIOLET/YELLOW)

+

+

+

IGNITION SWITCH

Battery (YELLOW)

Starter (WHITE/PINK)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Note:Parking light circuit can also be found in the wiring harness that runs underneth the driver’s side door sill plate.

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

MAKE THIS CONNECTION LAST!

Factory Alarm Disarm(GREEN/VIOLET)

Connect only on vehicles with factory RKENote: C-4 connection only required on vehicles

with factory perimeter alarm

Page 334: ALL MODELS 2002

X

X

X

X

X

515151515 15 15

15

5151515 15 15 15-

+

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**(FIVE HUNDRED ONLY)

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 7/21/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTREMOTE START REQUIRED PARTS

SecuriLock (PATS) Interface 2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - Driver Door Priority Unlock (Optional) Part#YL3Z-19G390-AA

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative

Unlock switch sense polarity Negative

Key in Sense polarity Positive

MODULE MOUNTING LOCATION:

Left side of dashboard behind headlight switch

Rear Defrost (Aux 2) Time 0.5 Sec. (Default Setting)

Page 335: ALL MODELS 2002

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Input Pull-upB-2 RED HVAC1 Battery Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC1 OutputB-8 BLACK/WHITE Key-in-sense Input A-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER'S CENTER UNDERDASHHARNESS

+

+

+

+

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 7/21/04

(NOTE: ALSO INCLUDES RKE/RMST)

Battery (LT GREEN/VIOLET)MAKE THIS CONNECTION LAST!

Ignition (WHITE/YELLOW)

Heater (BLACK/PINK)

Key-in-Sense (LT. GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

XNote: The Key-in-Sense wire is the same color and

guage as the Battery wire. Properly test and verify

this circuit prior to connection

Horn (BLUE)

Parking Lights (BLACK/GREEN)

BRAKE SWITCHBrake Light (LT. GREEN) +Optional Installation Feature

See Optional Connections Page

X

X

X

Battery (LT GREEN/VIOLET) +

Page 336: ALL MODELS 2002

HOOD TILT SWITCH

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Optional Installation Feature

See Optional connections page

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 7/21/04

(NOTE: ALSO INCLUDES RKE/RMST)

X

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wirewill result in vehicle damage!

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-14 GREEN Door UnLock OutputA-2 BLUE Door Lock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock Output

SJB HARNESS

SJB J6 GRAYCONNECTORDome Light (LT.GREEN/YELLOW)

Lock Motor (RED/ORANGE)

Driver's Door Unlock Motor(YELLOW)

+

+

HARNESSABOVEGAS PEDAL

Door Unlock Switch (BLUE/GREEN)

Door Lock Switch (WHITE/VIOLET)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release(WHITE/VIOLET)

SJB J3 BLACKCONNECTOR

X

X

X

X

COILPACK4.0 LiterTach Signal (PINK/WHITE)

FUELINJECTOR

4.6 LiterTach Signal (TAN/BLACK)

Page 337: ALL MODELS 2002

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(YELLOW)

Connect to the half of the wire going to the centerconsole area

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

30

87

87a

85 86White

Yellow

Black

Red

BlueSJB J5CONNECTOR

X

IGNITION SWITCHHARNESS

Battery (LT. GREEN/VIOLET) +

X

Headlights (RED/WHITE)

SJB J2 BLUECONNECTOR

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHTS / REAR DEFROSTER

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 7/21/04

(NOTE: ALSO INCLUDES RKE/RMST)

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

CENTERUNDERDASHHARNESS

Rear Defroster (PINK)

X

X

X

Page 338: ALL MODELS 2002

X

Color FunctionA-4 RED BatteryB-2 RED HVAC1 Battery Feed A-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC1 OutputB-8 BLACK/WHITE Key-in-sense Input A-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake Input

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER'S CENTERUNDERDASHHARNESS

+

+

+

+

HOOD TILT SWITCH

COILPACK4.0 LiterTach Signal (PINK/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 7/21/04

Battery (LT. GREEN/VIOLET)

MAKE THIS CONNECTION LAST!

Ignition (WHITE/YELLOW)

Heater (BLACK/PINK)

Key-in-Sense (LT. GREEN/VIOLET)

XCUT

Key SideAfter Cut

+

+Starter (DK GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Parking Lights (ORANGE/BLACK)

Brake Switch (LT. GREEN) BRAKESWITCH

Horn (DK. BLUE)

+

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Note: The Key-in-Sense wire is the same color and

guage as the Battery wire. Properly test and verify

this circuit prior to connection

X

X

X

FUELINJECTOR

4.6 LiterTach Signal (TAN/BLACK)

+Battery (LT. GREEN/VIOLET)

Page 339: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

X

X

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 7/21/04

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Door Trigger Input Pull-up A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputC-10 RED/WHITE Headlight Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER'S CENTER UNDERDASHHARNESS

+

+

Battery (LT GREEN/VIOLET)MAKE THIS CONNECTION LAST!

Ignition (WHITE/YELLOW)

XCUT

Key SideAfter Cut

+

+Starter (GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Horn (BLUE)

Parking Lights (BLACK/GREEN)

Headlights (RED/WHITE)

X

X

Page 340: ALL MODELS 2002

X

X

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 7/21/04

X

Optional Installation Feature

See Optional connections page

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-14 GREEN Door UnLock OutputA-2 BLUE Door Lock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock Output

SJB HARNESS

SJB J6 GRAYCONNECTORDome Light (LT.GREEN/YELLOW)

Lock Motor (RED/ORANGE)

Driver's Door Unlock Motor(YELLOW)

+

+

HARNESSABOVEGAS PEDAL

Door Unlock Switch (BLUE/GREEN)

Door Lock Switch (WHITE/VIOLET)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release(WHITE/VIOLET)

SJB J3 BLACKCONNECTOR

X

X

Page 341: ALL MODELS 2002

X

X

OPTIONAL CONNECTIONS

Color Function

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(YELLOW)

Connect to the half of the wire going back to the center console area.

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

30

87

87a

85 86White

Yellow

Black

Red

BlueHARNESSABOVEGAS PEDAL

DRIVER'S CENTERUNDERDASHHARNESS

Battery (LT.GREEN/VIOLET) +

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 7/21/04

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

UNDERHOOD

Hood Tilt Switch(Optional - Not supplied in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

X

X

X

Page 342: ALL MODELS 2002

X

X

X

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 2 7/21/04

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Doopr Trigger Input Pull-up A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER'S CENTER UNDERDASHHARNESS

+

+

Battery (LT GREEN/VIOLET)MAKE THIS CONNECTION LAST!

Ignition (WHITE/YELLOW)

XCUT

Key SideAfter Cut

+

+Starter (GREEN)

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Horn (BLUE)

Parking Lights (BLACK/GREEN)

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input

SJB HARNESS SJB J6 GRAYCONNECTORDome Light (LT.GREEN/YELLOW)

Lock Motor (RED/ORANGE)

Driver's Door Unlock Motor(YELLOW)

+

+ HARNESSABOVEGAS PEDAL

Door Unlock Switch (BLUE/GREEN)

X

Page 343: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

2 of 2 7/21/04

OPTIONAL CONNECTIONS

X

X

X

X

X

Page 344: ALL MODELS 2002

X

X

X

Vehicle (Year/Make/Model)

'05 Mustang (S197)

Equipment or Trim level System(s) applicable to:

ALL PRELOAD

Page Revision Date

1 of 1 7/21/04CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Color FunctionA-5 BLACK Ground

DRIVER'S SIDE KICK PANEL HARNESS

Color FunctionA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT. GREEN Unlock Switch Sense Input A-14 GREEN Door UnLock OutputA-2 BLUE Door Lock OutputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Trunk Release Output

SJB HARNESS SJB J6 GRAYCONNECTORDome Light (LT.GREEN/YELLOW)

Lock Motor (RED/ORANGE)

Driver's Door Unlock Motor(YELLOW)

+

+

HARNESSABOVEGAS PEDAL

Door Unlock Switch (BLUE/GREEN)

Door Lock Switch (WHITE/VIOLET)

Factory Alarm Disarm (LT. BLUE/BLACK)

Trunk Release(WHITE/VIOLET)

SJB J3 BLACKCONNECTOR

X

Color FunctionA-4 RED BatteryA-10 YELLOW/WHITE Doopr Trigger Input Pull-up A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt Motor SideA-6 VIOLET/RED Starter Interrupt Key SideA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

DRIVER'S CENTER UNDERDASHHARNESS

+

+

Battery (LT GREEN/VIOLET)MAKE THIS CONNECTION LAST!

Ignition (WHITE/YELLOW)

XCUT

Key SideAfter Cut

+

+Starter (GREEN)

Horn (BLUE)

Parking Lights (BLACK/GREEN)

Page 345: ALL MODELS 2002

515151515 15 15

15

51515

15 15

15-+

-+

HVAC 1*

HVAC 2***

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 6/2/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L2Z-19G365-AB2003: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Negative Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:High on driver side kick panel near bulkhead panel

*** HVAC2 circuit not used on Ranger

Page 346: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 6/2/03

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory alarm disarm outputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

UPPER DRIVERSKICK PANEL

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(BLACK/YELLOW)

HOOD TILT SWITCH

COIL PACKTach Signal (TAN/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD

HARNESS TO THERIGHT OF GASPEDAL

Connect only on vehicles with factory RKE

Note: Tach Signal wire can also be located at the Bulkhead harness inside the vehicle - TAN/YELLOW

(NOTE: ALSO INCLUDES RKE/RMST)

’02

’03 (YELLOW/BLACK)

Page 347: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 6/2/03

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Ignition (GREEN/VIOLET)

Starter (RED/BLUE)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Page 348: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 6/2/03

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color FunctionC-10 RED/WHITE Headlight Output

HEADLIGHT

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 349: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 8/28/02

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Heater (GREY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Ignition (GREEN/VIOLET)

MAKE THIS CONNECTION LAST!

COIL PACKTach Signal (TAN/WHITE)

Note: Tach Signal wire can also be located at the Bulkhead harness inside the vehicle - TAN/YELLOW

Page 350: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input C-4 LT GREEN/BLACK Factory alarm disarm outputA-9 BROWN Disarm InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD

HARNESS RIGHTOF GAS PEDAL

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 6/2/03

UPPER DRIVERSKICK PANEL

DRIVER DOORJAMB BOOTHARNESS

+Driver Door Unlock Motor(RED/ORANGE)

Connect only on vehicles with factory RKE

Driver Door Ajar Switch(BLACK/YELLOW)’02

’03 (YELLOW/BLACK)

Page 351: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 6/2/03

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OuputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Page 352: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 6/2/03

UNDERHOOD

Hood Tilt Switch(Optional)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

White

Battery (DK. BLUE/ORANGE)

Headlights (RED/YELLOW)30

87

87a

85 86 HEADLIGHT SWITCH

+

+

Color FunctionC-10 RED/WHITE Headlight Output

HEADLIGHT ILLUMINATION

Relay shown is not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

YellowIMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/ORANGE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 353: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 6/2/03

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory alarm disarm output

DRIVERS SIDE KICK PANEL

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

HARNESS RIGHTOF GAS PEDAL

UPPER DRIVERSKICK PANEL

DRIVER DOORJAMB BOOTHARNESS

+Driver Door Unlock Motor(RED/ORANGE)

Driver Door Ajar Switch(BLACK/YELLOW)’02

’03 (YELLOW/BLACK)

Page 354: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 6/2/03

OPTIONAL CONNECTIONS

Page 355: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS RIGHTOF GAS PEDALDome Light (BLACK/BLUE) +

+DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Driver Door Unlock Motor(RED/ORANGE)

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL

Door Lock (PINK/YELLOW)

Vehicle (Year/Make/Model)

’02/’03 RangerEquipment or Trim level System(s) applicable to:

w/Factory RKE PreloadPage Revision Date

1 of 1 6/2/03

MAKE THIS CONNECTION LAST!Connect only on vehicles with factory RKE

Page 356: ALL MODELS 2002

515151515 15 15

15

51515

15

15 15- +

- +

HVAC 1*

HVAC 2

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 8/20/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

REMOTE START (RMST) PARTS REQUIRED

Securilock (PATS) Interface:

2004- 1L2Z-19G365-AB

2005- Not Equipped With PATS

RELAY REQUIREMENTS:

1 - Headlight Illumination (Optional)

1 - Driver's Door Priority Unlock (Optional)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Negative

Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:

High on driver side kick panel near bulkhead panel

REMOTE START (RMST) SPECIFIC PROGRAMMING

Key in Sense polarity Negative (Default setting)

Learn Tachometer Required On All Vehicles

Page 357: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 8/20/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory alarm disarm outputA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trink Ajar InputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

+

DRIVER DOORJAMB BOOTHARNESS+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (RED)

Driver Door Unlock Motor(LT. BLUE)

Driver Door Ajar Switch

HOOD TILT SWITCH

COIL PACKTach Signal (TAN/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

HARNESS TO THERIGHT OF GASPEDAL

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

(YELLOW/BLACK)

CUT HIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Note: 2005 Ranger is not

equipped with PATS

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 358: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 8/20/04

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Ignition (GREEN/VIOLET)

Starter (RED/BLUE)

Heater (GRAY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Note: 2005 Ranger is not

equipped with PATS

MAKE THIS CONNECTION LAST!

Page 359: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 5/19/03

White

Color FunctionA-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

Driver Door Unlock Motor (LT. BLUE)

Battery (RED/YELLOW)

Headlights (VIOLET/.LT. BLUE)30

87

87a

85 86 HEADLIGHT SWITCH

+

+Headlight

Color Function

C-10 RED/WHITE Headlight Output

DRIVER'S DOOR PRIORITY UNLOCK

HEADLIGHT

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

Yellow

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

OPTIONAL CONNECTIONS

+

Connect to the half of the wire going back into the vehicle's interior

CUT

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

IGNITIONSWITCH

Battery (YELLOW) +

Note: 2005 Ranger is not

equipped with PATS

Page 360: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 8/20/04

IGNITION SWITCH

Battery (YELLOW)

Battery (YELLOW)

Starter (RED/BLUE)

Heater (GREY/YELLOW)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (YELLOW/GREEN)

BRAKE SWITCHBrake light (GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HOOD TILT SWITCH

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color Function

A-4 RED Battery B-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OuputB-4 ORANGE HVAC 1 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Ignition (GREEN/VIOLET)

MAKE THIS CONNECTION LAST!

COIL PACKTach Signal (TAN/WHITE)

Note: 2005 Ranger is not

equipped with PATS

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 361: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory alarm disarm output A-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar InputA-13 TAN DO NOT USE

C-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (RED)

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

HARNESS RIGHTOF GAS PEDAL

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 8/20/04

DRIVER DOORJAMB BOOTHARNESS+

Driver Door Unlock Motor (LT. BLUE)

Connect only on vehicles with factory RKE

Driver Door Ajar Switch(YELLOW/BLACK)

CUT HIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 362: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 8/20/04

Color Function

A-4 RED Battery A-7 PINK Ignition 1 Input/OuputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMNHorn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Page 363: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 8/20/04

UNDERHOOD

Hood Tilt Switch(Optional)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

White

Battery (RED/YELLOW)

Headlights (VIOLET/LT. BLUE)30

87

87a

85 86 HEADLIGHT SWITCH

+

+

Color Function

C-10 RED/WHITE Headlight Output

HEADLIGHT ILLUMINATION

Relay shown is not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

YellowIMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

OPTIONAL CONNECTIONS

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

Color FunctionA-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

Driver Door Unlock Motor (LT. BLUE)

DRIVER'S DOOR PRIORITY UNLOCK+

Connect to the half of the wire going back into the vehicle's interior

CUT

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue

DRIVER SIDE JAMB BOOTHARNESS

IGNITIONSWITCH

Battery (YELLOW) +

Page 364: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

w/o Factory RKE RKE/VSS & RKE

Page Revision Date

1 of 1 8/20/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 LT GREEN/BLACK Factory alarm disarm output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

DRIVER DOORJAMB BOOTHARNESS

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Driver Door Ajar Switch(YELLOW/BLACK)

HARNESS TO THERIGHT OF GASPEDAL

Page 365: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

w/Factory RKE VSS

Page Revision Date

1 of 1 8/20/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory alarm disarm output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

Dome Light (BLACK/BLUE) +

+

Door Unlock (PINK/GREEN)

Lock Motor (RED)

HARNESS RIGHTOF GAS PEDAL

DRIVER DOORJAMB BOOTHARNESS+

Driver Door Unlock Motor (LT. BLUE)

Driver Door Ajar Switch(YELLOW/BLACK)

Page 366: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSS

Page Revision Date

1 of 1 8/20/04

OPTIONAL CONNECTIONS

Page 367: ALL MODELS 2002

IGNITION SWITCH

Battery (YELLOW)

Starter (RED/BLUE)

Ignition (GREEN/VIOLET)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (YELLOW/GREEN)

Parking lights (WHITE/BLACK) HEADLIGHT SWITCH

+

+

+

CUT

KEY SIDE(after cut)

Color Function

A-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

STEERING COLUMN HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS RIGHTOF GAS PEDALDome Light (BLACK/BLUE) +

+DRIVER DOORJAMB BOOTHARNESS

+

Door Unlock (PINK/GREEN)

Lock Motor (RED)

Driver Door Unlock Motor (LT. BLUE)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-12 LT.GREEN Unlock Switch Sense InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Door Lock (PINK/YELLOW)

Vehicle (Year/Make/Model)

'04-'05 Ranger

Equipment or Trim level System(s) applicable to:

ALL PRELOAD

Page Revision Date

1 of 1 8/20/04

MAKE THIS CONNECTION LAST!Connect only on vehicles with factory RKE

Driver Door Ajar Switch(YELLOW/BLACK)

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output

DRIVER DOORJAMB BOOTHARNESS

This connection only needed if vehicle is equipped with "Trim Switch Disable"

Page 368: ALL MODELS 2002

515151515 15 15

15

515151515 15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 6/2/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L2Z-19G365-AB2003: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:On dash bracket above gas pedal and to right of steering column.

Page 369: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output C-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

PASSENGER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Factory Alarm Disarm (PINK/WHITE)

HOOD TILT SWITCH

IGNITION COIL

Tach Signal (WHITE/YELLOW)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 6/2/03

Connect only on vehicles with factory RKE

(NOTE: ALSO INCLUDES RKE/RMST)

Page 370: ALL MODELS 2002

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output A-13 TAN Trunk Release OutputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (BLACK/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

Trunk Release (GRAY/RED) TRUNK RELEASESWITCH

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 6/2/03MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

+

Page 371: ALL MODELS 2002

White

Ground (BLACK/YELLOW)

Headlights (RED/YELLOW)

30

87

87a

85 86

Rear Defroster (BLUE/ORANGE)REAR DEFROSTERSWITCH

HEADLIGHT SWITCHHeadlight

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

YellowIMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 9/2/03

OPTIONAL CONNECTIONS(NOTE: ALSO INCLUDES RKE/RMST)

+12 Volts (A-15 RED* - Module harness)

This is a low current feed (2A Max)*

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/WHITE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 372: ALL MODELS 2002

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

IGNITION COIL

Tach Signal (WHITE/YELLOW)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (BLACK/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 6/2/03

MAKE THIS CONNECTION LAST!

HOOD TILT SWITCH

Page 373: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output C-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

PASSENGER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Factory alarm disarm (PINK/WHITE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 8/26/02

Connect only on vehicles with factory RKE

Page 374: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 6/2/03

MAKE THIS CONNECTION LAST!

White

Ground (BLACK/YELLOW)

Headlights (RED/YELLOW)

30

87

87a

85 86

Headlight Blue

Black

Yellow

+12 Volts (A-15 RED* - Module harness)

TRUNK RELEASE SWITCH

Trunk Release (GRAY/RED) +

Page 375: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 9/2/03

UNDERHOOD

Hood Tilt Switch(Optional - Not supplied in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/WHITE)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:Deluxe RKE/VSSProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 376: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

w/o Factory RKE VSS/RKE & RKEPage Revision Date

1 of 1 6/2/03

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Page 377: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

PASSENGER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 6/2/03

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Page 378: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 6/2/03

OPTIONAL CONNECTIONS

Page 379: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output C-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

PASSENGER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Factory alarm disarm (PINK/WHITE)

Connect only on vehicles with factory RKE

Vehicle (Year/Make/Model)

’02/’03 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 1 6/2/03

Page 380: ALL MODELS 2002

515151515 15 15

15

515151515

15 15

15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 3/19/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2004: 1L2Z-19G365-AB2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

1 - HEADLIGHT ILLUMINATION (OPTIONAL)1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:On dash bracket above gas pedal and to right of steering column.

Page 381: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-12 LT.GREEN Unlock Switch Sense InputA-9 BROWN Disarm InputC-4 Lt GREEN/BLACK Factory Alarm DisarmA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

HOOD TILT SWITCH

FUELINJECTORTach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation FeatureSee Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'04-05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 3/19/04(NOTE: ALSO INCLUDES RKE/RMST)

CUT THIS WIRE OFF AS CLOSE TO THE CONNECTOR AS POSSIBLE

Factory Alarm Disarm (PINK/WHITE)

Connect on vehicles equipped with OE perimeter alarm

Driver's Door Latch (YELLOW/BLACK)

Connect on vehicles equipped w/o OE perimeter alarm

DRIVER SIDEDOOR JAMBBOOT HARNESS

Page 382: ALL MODELS 2002

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output A-13 TAN Trunk Release OutputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (BLACK/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

Trunk Release (VIOLET/YELLOW) TRUNK RELEASESWITCH

CUT

KEY SIDE(after cut)

Optional Installation FeatureSee Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 3/19/04MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Page 383: ALL MODELS 2002

White

Battery (YELLOW/WHITE)

Headlights (RED/YELLOW)

30

87

87a

85 86

Rear Defroster (BLUE/ORANGE)REAR DEFROSTERSWITCH

HEADLIGHT SWITCHHeadlight

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Blue

Black

YellowIMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 3/19/04

OPTIONAL CONNECTIONS(NOTE: ALSO INCLUDES RKE/RMST)

This is a low current feed (2A Max)*

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/WHITE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

+

+

Page 384: ALL MODELS 2002

Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color FunctionA-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

FUELINJECTOR

Tach Signal (TAN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

Heater (GREY/YELLOW)

Heater (BLACK/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Key-in-Sense (BLACK/PINK)

Horn (BLUE)

BRAKE SWITCHBrake light (RED/GREEN)

Parking lights (BROWN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 3/19/04

MAKE THIS CONNECTION LAST!

HOOD TILT SWITCH

Page 385: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

1 of 3 3/19/04

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-12 LT.GREEN Unlock Switch Sense InputA-9 BROWN Disarm InputC-4 Lt GREEN/BLACK Factory Alarm DisarmA-24 BLUE/GREEN Driver Door Unlock OutputC-8 BLUE Trunk Ajar Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Cut and tape off if not used

Optional Installation FeatureSee Optional connections pageCUT THIS WIRE OFF AS CLOSE

TO THE CONNECTOR AS POSSIBLE

Factory Alarm Disarm (PINK/WHITE)

Connect on vehicles equipped with OE perimeter alarm

Driver's Door Latch (YELLOW/BLACK)

Connect on vehicles equipped w/o OE perimeter alarm

DRIVER SIDEDOOR JAMBBOOT HARNESS

Page 386: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-13 TAN Trunk Release OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

2 of 3 3/19/04

MAKE THIS CONNECTION LAST!

White

Battery (YELLOW/WHITE)

Headlights (RED/YELLOW)

30

87

87a

85 86

Headlight Blue

Black

Yellow

TRUNK RELEASE SWITCH

Trunk Release (VIOLET/YELLOW) +

+

+

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 387: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 3/19/04

UNDERHOOD

Hood Tilt Switch(Optional - Not supplied in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

UnderhoodColor FunctionA-19 GRAY Hood Open Switch Input

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(RED/WHITE)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:Deluxe RKE/VSSProgram the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 388: ALL MODELS 2002

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

w/o Factory RKE VSS/RKE & RKEPage Revision Date

1 of 1 3/19/04

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output

DRIVER'S DOORJAMB BOOTHARNESS

-Driver's Door Latch (YELLOW/BLACK)

*NOTE: This connection is needed to interface with vehicles equipped with "Trim Switch Disable" Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered.

Page 389: ALL MODELS 2002

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-12 LT.GREEN Unlock Switch Sense Input

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 3/19/04

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Page 390: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

SirenColor FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL VSS & RKE/VSSPage Revision Date

1 of 1 3/19/04

OPTIONAL CONNECTIONS

Page 391: ALL MODELS 2002

Color FunctionA-4 RED Battery A-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (Lt. GREEN/VIOLET)

Starter (RED/BLUE)

Ignition (RED/GREEN)

6-WAY CONNECTOR TO RIGHT OFSTEERING COLUMN

Horn (BLUE)

Parking lights (BROWN)

STEERING COLUMN HARNESS

+

+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Vehicle (Year/Make/Model)

'04-'05 Sable / TaurusEquipment or Trim level System(s) applicable to:

ALL PreloadPage Revision Date

1 of 1 3/19/04

Color FunctionA-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-12 LT.GREEN Unlock Switch Sense InputA-9 BROWN Disarm InputC-4 Lt GREEN/BLACK Factory Alarm Disarm

DRIVERS SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

DRIVER SIDEKICK PANEL

Dome Light (BLACK/BLUE) +

+

+

+

Door Lock (PINK/YELLOW)

Door Unlock (PINK/GREEN)

Lock Motor (PINK/BLACK)

Unlock Motor (RED/WHITE)

Passenger Door Unlock Motor (PINK/ORANGE)

Factory Alarm Disarm (PINK/WHITE)

Connect on vehicles equipped with OE perimeter alarm

Driver's Door Latch (YELLOW/BLACK)

Connect on vehicles equipped w/o OE perimeter alarm

DRIVER SIDEDOOR JAMBBOOT HARNESS

*NOTE:Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Alarm Disarm Output.

Page 392: ALL MODELS 2002

515151515 15 15

15

515151515 15 15 15-

+

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 7/18/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART

REMOTE START REQUIRED PARTS

SecuriLock (PATS) Interface 2002: 1S4Z-19G365-AB

Securilock (PATS) Interface 2003-05: 1L2Z-19G365-AB

In-line Diode Harness 2002-05: 5W4Z-14B501-AA

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative

Unlock switch sense polarity Positive(default)

Key in Sense polarity Positive

Rear Defroster 10 Min.

MODULE MOUNTING LOCATION:

Behind headlight switch panel

RESISTOR REQUIREMENTS:

Parking Lights- 1.8k ohm required on all systems

Headlights (optional)- 750 ohm required on all systems

Brown GrayOrange

A-1 White Parking Light (WHITE/GREEN)

VioletGreenRed

C-10 Red/White Headlight (WHITE/GREEN)

ADDITIONAL PARTS REQUIREMENTS:

1 - Driver Door Priority Unlock (Optional) Part # YL3Z-19G390-AA

Page 393: ALL MODELS 2002

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

UNDERDASHLIGHT

Dome Light (Black/White)

+

DRIVER DOORJAMB BOOTHARNESS+

Door Lock (WHITE/BLACK)

Door Unlock (WHITE/VIOLET)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Factory Alarm Disarm(RED/WHITE)

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood REDBLACK

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

Siren (w/VSS only)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 7/18/04

(NOTE: ALSO INCLUDES RKE/RMST)

PASSENGERDOORJAMB BOOTHARNESS

+Passenger Door Unlock Motor(WHITE/GREEN)

Trunk Release (WHITE)

Color FunctionA-12 LT GREEN Unlock Switch Sense

PASSENGERS KICKPANEL HARNESS

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 394: ALL MODELS 2002

Color Function

A-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upB-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

C-11 BLUE/WHITE Rear Defroster Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Heater (PINK/YELLOW)

Heater (PINK/WHITE)

Horn (BROWN/RED)

BRAKE SWITCH

02'/03' Brake light (BLUE)

Parking lights (WHITE/GREEN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS

+

+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Optional Installation Feature

See Optional connections page

Cut and tape off if not used

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 7/18/04

MAKE THIS CONNECTION LAST!

(NOTE: ALSO INCLUDES RKE/RMST)

Heater (YELLOW) +

REQUIRES GROUNDTHROUGH A 1.8K ohm RESISTOR INLINE

FEMMODULE

04'/05' Brake Light (ORANGE/BLUE)

IGNITION SWITCH

Key-in-Sense (RED/WHITE) +RED

BLACK/WHITEIn-line Diode Harness RequiredPart #5W4Z-14A604-AA

Page 395: ALL MODELS 2002

Color Function

C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

HEADLIGHT ILLUMINATION / REAR DEFROSTER

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 7/18/04

OPTIONAL CONNECTIONS

(NOTE: ALSO INCLUDES RKE/RMST)

HEADLIGHTSWITCH

HARNESSBEHIND REARSPEAKER

Headlights (WHITE/GREEN)

REQUIRES GROUNDTHROUGH A 750 ohm RESISTOR INLINE

Rear Defroster (BROWN/WHITE)

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(WHITE/VIOLET)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

NOTE:

Program the "Aux 2 (Rear Defroster) time (Option #2, Option Bank #4) option to ON.

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 396: ALL MODELS 2002

Color Function

A-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputB-7 BROWN Brake InputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

Heater (PINK/YELLOW)

Heater (PINK/WHITE)

Horn (BROWN/RED)

Parking lights (WHITE/GREEN) HEADLIGHT SWITCH

STEERING COLUMN HARNESS+

+

+

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 7/18/04

MAKE THIS CONNECTION LAST!

Heater (YELLOW) +

REQUIRES GROUNDTHROUGH A 1.8K ohmRESISTOR INLINE

FEMMODULE

HOOD TILT SWITCH

FUEL INJECTOR

Tach Signal (BROWN/GREEN)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input B-9 VIOLET/WHITE Tach Sense Input

UNDERHOOD HARNESS

Color Function

A-5 BLACK Ground

DRIVER SIDE KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

BRAKE SWITCH

02'/03' Brake light (BLUE)+

04'/'05 Brake Light (ORANGE/BLUE)

IGNITION SWITCH

Key-in-Sense (RED/WHITE) +RED

BLACK/WHITEIn-line Diode Harness RequiredPart #5W4Z-14A604-AA

IMPORTANT! The tach sense input wire must be properly insulated

and secured. Avoid routing the wiring at or near hot or moving parts.

Failure to properly connect this wire will result in vehicle damage!

Page 397: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed

A-16 BLACK Siren Output

UNDERHOOD HARNESS

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

1 of 3 7/18/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputC-4 LT GREEN/BLACK Factory Alarm DisarmA-13 TAN Trunk Release OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-9 TAN/RED DO NOT USE

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

UNDERDASHLIGHT

Dome Light (Black/White)

+ DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (WHITE/BLACK)

Door Unlock (WHITE/VIOLET)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Factory Alarm Disarm(RED/WHITE)

Cut and tape off if not used

Optional Installation Feature

See Optional connections page

PASSENGER DOORJAMB BOOTHARNESS

+Passenger Door Unlock Motor(WHITE/GREEN)

Trunk Release (WHITE)

Color FunctionA-12 LT GREEN Unlock Switch Sense

PASSENGERS KICKPANEL HARNESS

Page 398: ALL MODELS 2002

Color Function

A-4 RED Battery

A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output C-10 RED/WHITE Headlight Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS

+

+

+

CUT

KEY SIDE(after cut)

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

2 of 3 7/18/04

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Headlights, Parking Lights(WHITE/GREEN

HEADLIGHTS

REQUIRES GROUNDTHROUGH A 750 ohm RESISTOR INLINE

PARKING LIGHTS

REQUIRES GROUNDTHROUGH A 1.8k ohm RESISTOR INLINE

Page 399: ALL MODELS 2002

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSS

Page Revision Date

3 of 3 7/18/04

UNDERHOOD HARNESS

Hood Tilt Switch(Optional - not included in kit)Chassis

groundDo Not Ground to Hood!

VehicleInterior

Underhood Color FunctionA-19 GRAY Hood Open Switch Input

OPTIONAL CONNECTIONS

Color Function

A-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor(WHITE/VIOLET)

Connect to the half of the wire going back into the vehicle's interior

CUTDRIVER'S DOOR PRIORITY UNLOCK

NOTE:

Program the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Page 400: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

HARNESS UNDERDRIVERS SIDEDOOR SILL PLATE

Dome Light (Black/White)

+

PASSENGERS DOORJAMB BOOT HARNESS

+

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm Input

DRIVERS SIDE KICK PANEL HARNESS

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 1 7/18/04

+

UNDERDASHLIGHT

Color Function

A-12 LT GREEN Unlock Switch Sense

PASSENGERS SIDE KICK PANEL HARNESS Driver Door Unlock Motor(WHITE/GREEN)

Color Function

A-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS+

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

HEADLIGHT SWITCH

Parking Lights(WHITE/GREEN

REQUIRES GROUNDTHROUGH A 1.8k ohm RESISTOR INLINE

Page 401: ALL MODELS 2002

VehicleInterior

Underhood REDBLACK

Siren Color FunctionA-15 RED Siren Feed A-16 BLACK Siren Output

A-19 GRAY Hood Open Switch Input

UNDERHOOD

Hood Tilt Switch(Optional - notincluded in kit)Chassis

groundDo Not Ground to Hood!

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 1 7/18/04

OPTIONAL CONNECTIONS

Page 402: ALL MODELS 2002

Color Function

A-4 RED Battery A-10 YELLOW/WHITE Door Trigger Pull-upA-7 PINK Ignition 1 Input/OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

IGNITION SWITCH

Battery (RED)

Starter (GRAY/BLACK)

Ignition (GREEN/BLACK)

FEM DRIVERSKICK PANELHorn (BROWN/RED)

STEERING COLUMN HARNESS

+

+

+

CUTKEY SIDE(after cut)

MAKE T HIS CONNECTION L AST!

HEADLIGHT SWITCH

Parking Lights(WHITE/GREENREQUIRES GROUND

THROUGH A 1.8k ohm RESISTOR INLINE

Vehicle (Year/Make/Model)

'02-'05 Thunderbird

Equipment or Trim level System(s) applicable to:

ALL Preload

Page Revision Date

1 of 1 7/18/04

Color Function

A-5 BLACK GroundA-20 GREEN/VIOLET Door Ajar Switch InputA-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-11 WHITE/BLUE Arm Input A-9 BROWN Disarm InputA-13 TAN Trunk Release Output

DRIVERS KICK PANEL HARNESS

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

MAKE THIS CONNECTION FIRST!

UNDERDASHLIGHT

Dome Light (Black/White)

+DRIVER DOORJAMB BOOTHARNESS

+

Door Lock (WHITE/BLACK)

Door Unlock (WHITE/VIOLET)

Lock Motor (YELLOW/BLACK)

Driver Door Unlock Motor(WHITE/VIOLET)

Factory Alarm Disarm (RED/WHITE)

PASSENGERDOORJAMB BOOTHARNESS

+Passenger Door Unlock Motor(WHITE/GREEN)

Trunk Release (WHITE)

Color FunctionA-12 LT GREEN Unlock Switch Sense

PASSENGERS KICKPANEL HARNESS

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

DRIVER DOORJAMB BOOTHARNESS

Page 403: ALL MODELS 2002

515151515 15 15

15

515151515 15

15

15

-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 1/5/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L3Z-19G365-AB2003-04: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

2 - MEMORY SEATS (OPTIONAL)1 - DRIVER DOOR UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)Unlock switch sense polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)Rear Defroster time 10 minutes

MODULE MOUNTING LOCATION:Left side of PCM

Page 404: ALL MODELS 2002

+Door Lock (PINK/YELLOW) Connector C501a Cavity #6

+

+

+DDM (IN DRIVER’S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

Trunk Release (WHITE/VIOLET) Connector C501b Cavity #2

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-12 GREEN/WHITE Memory 1 Output C-13 YELLOW/GREEN Memory 2 OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 1/5/04CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER’S SIDEFUELINJECTOR

Tach Signal (Lt GREEN/ORANGE)

ChassisGround

Do Not Ground to Hood!

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

NOTE: ALSO COVERS RKE/RMST

Factory Alarm Disarm (LT. BLUE/BLACK)IN DRIVER’S DOOR ATKEY SWITCH

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 405: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

2 of 3 1/5/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (Lt GREEN/VIOLET)

Battery (YELLOW)

Battery (YELLOW) +

+

+

NOTE: ALSO COVERS RKE/RMST

Cut and tape off if not used

Optional Installation FeatureSee Optional connections (4 of 4)

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)+

Ignition 2 (GREY/YELLOW)

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

30

87

87a

85 86

White

Black

Yellow

Blue

Battery (YELLOW)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

+

Heater (PINK/BLACK #1)

30

87

87a8586White Black

Yellow

Blue

Battery (LT. GREEN/VIOLET)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Heater 2 (PINK/BLACK #2) +

Starter (RED/BLUE )

+CUT

KEY SIDE(after cut)

PLUG RIGHT OF STEERINGCOLUMN

Horn (BLUE)Key-In Sense (BLACK/PINK) -

-

STEERING COLUMN HARNESS, cont’d

Color FunctionA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake InputC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

-

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

BRAKESWITCH

+Brake (GREEN)

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 406: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 1/5/04 +

+

DDM (IN DRIVER’S DOOR)

DDM (IN DRIVER’S DOOR)

+12V Feed (BLACK/WHITE) Connector C501a Cavity #10

Driver Door Unlock (RED/ORANGE)Connector C501a Cavity #21

White

White

White

30

87

87a8586

Black

Black

Yellow

30

87

87a

85 86

30

87

87a

85 86

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

DRIVER’S DOOR UNLOCK

Memory Seats(BROWN/Lt GREEN)

Memory Seats(BLACK/ORANGE)

+

+

POWER OPTIONS

Color FunctionC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

Blue

Blue

Blue

Red

Black

Yellow

DEFROSTERSWITCH

Headlights (RED/YELLOW)

-Defroster (GRAY/ Lt BLUE)

NOTE: ALSO COVERS RKE/RMST

OPTIONAL CONNECTIONS

HEADLIGHT SWITCH

-

NOTE: Rear defroster connection can also be located at the bulkhead panel harness (Pin 34, C210 Connector)

NOTE:Program both the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

++12V Feed (BLACK/WHITE) Connector C501a Cavity #10

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 407: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

VehicleInterior

EngineCompartment

HOOD TILT SWITCH

DRIVER’S SIDEFUELINJECTOR

Tach Signal (TAN/BLACK)

ChassisGround

Do Not Ground to Hood!

Color Function A-5 BLACK Ground

DRIVER’S KICK PANEL HARNESS

CONNECTIONS UNDER HOOD

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 1/5/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-3 PINK/WHITE Ignition 2 OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light Output

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (Lt GREEN/VIOLET)

Battery (YELLOW)

Battery (YELLOW) +

+

+

’03/’04 Ignition (WHITE/YELLOW)+

’02 Ignition (BROWN/PINK)+

Ignition 2 (GREY/YELLOW)

30

87

87a

85 86

White

Black

Yellow

Blue

Battery (YELLOW)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

+

Heater (PINK/BLACK #1)

30

87

87a8586White Black

Yellow

Blue

Battery (LT. GREEN/VIOLET)30 AMP Fuse

+

CHASSIS GROUND POINTIN DRIVERS KICK PANEL

Heater 2 (PINK/BLACK #2) +

Starter (RED/BLUE )

+CUT KEY SIDE

(after cut)PLUG RIGHT OF STEERINGCOLUMN

Horn (BLUE)Key-In Sense (BLACK/PINK) -

-

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

-

Page 408: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

+Door Lock (PINK/YELLOW) Connector C501a Cavity #6

+

+

+DDM (IN DRIVER’S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

Trunk Release (WHITE/VIOLET) Connector C501b Cavity #2

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-12 GREEN/WHITE Memory 1 Output C-13 YELLOW/GREEN Memory 2 OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

1 of 3 1/5/04CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

NOTE: ALSO COVERS RKE/RMST

Factory Alarm Disarm (LT. BLUE/BLACK)IN DRIVER’S DOOR ATKEY SWITCH

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 409: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

2 of 3 6/26/03

Battery (Lt GREEN/VIOLET)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputC-10 RED/WHITE Headlight OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-

-

Parking Lights (WHITE/BLACK)

Headlights (RED/YELLOW)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Page 410: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

3 of 3 1/5/04

DDM (IN DRIVER’S DOOR)

White

White

Black

30

87

87a

85 86

30

87

87a

85 86

Yellow

Memory Seats(BROWN/Lt GREEN)

Memory Seats(BLACK/ORANGE)

+

+

POWER OPTIONS

Color FunctionC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

Blue

Blue

Black

Yellow

++12V Feed (BLACK/WHITE) Connector C501a Cavity #10

+

+

DDM (IN DRIVER’S DOOR)

+12V Feed (BLACK/WHITE) Connector C501a Cavity #10

Driver Door Unlock (RED/ORANGE)Connector C501a Cavity #21

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

DRIVER’S DOOR UNLOCK

Blue

Red

OPTIONAL CONNECTIONS

NOTE:Program both the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ON

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 411: ALL MODELS 2002

+

+

+

DDM (IN DRIVER’S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL VSSPage Revision Date

1 of 1 6/26/03Battery (Lt GREEN/VIOLET)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

CONNECTIONS UNDER HOOD OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Optional parts - notincluded in kit

Page 412: ALL MODELS 2002

+Door Lock (PINK/YELLOW) Connector C501a Cavity #6

+

+

+

DDM (IN DRIVER’S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

DRIVER’S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock OutputA-2 BLUE Door Lock Output

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

CHASSIS GROUND POINTIN DRIVER’ S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

’02-’04 TowncarEquipment or Trim level System(s) applicable to:

ALL PRELOADPage Revision Date

1 of 1 1/5/04Battery (Lt GREEN/VIOLET)

Starter (RED/BLUE )

Horn (BLUE)

PLUG RIGHT OF STEERINGCOLUMN

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

IN DRIVER’S DOOR AT KEYSWITCH

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security. Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER’S DOOR AT KEYSWITCH

Page 413: ALL MODELS 2002

515151515 15 15

15

515151515

15

15

15

- +

- +

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT**

TRUNK RELEASE**

PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL ALL

Page Revision Date

1 of 1 5/26/04

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHARTSECURILOCK (PATS) INTERFACE

APPLICATION CHART

(Required for systems with remote start)

2005: 1L2Z-19G365-AB

RELAY REQUIREMENTS:

2 - MEMORY SEATS (OPTIONAL)

1 - DRIVER DOOR UNLOCK (OPTIONAL)

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Positive (Default setting)

Unlock switch sense polarity Positive (Default setting)

Key in Sense polarity Positive

Rear Defroster time 10 minutes

MODULE MOUNTING LOCATION:

Left side of driver's under dash

Page 414: ALL MODELS 2002

+Door Lock (PINK/YELLOW)

+

+

+DDM (IN DRIVER'S DOOR)

Door Unlock (PINK/GREEN)

Trunk Release (WHITE/VIOLET)

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-12 GREEN/WHITE Memory 1 Output C-13 YELLOW/GREEN Memory 2 OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)

Driver Door Lock Motor (PINK/BLACK)

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

1 of 3 6/9/04CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

DRIVER'S SIDEFUELINJECTOR

Tach Signal (LT GREEN/ORANGE)

ChassisGround

Do Not Ground to Hood!

Optional Installation Feature

See POWER OPTIONS (3 of 3)

Optional Installation Feature

See DRIVER'S DOOR UNLOCK (3 of 3)

NOTE: ALSO COVERS RKE/RMST

Factory Alarm Disarm (LT. BLUE/BLACK)IN DRIVER'S DOOR ATKEY SWITCH

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Page 415: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

2 of 3 5/26/04

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake Input C-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster OutputC-8 BLUE Trunk Ajar Input

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Battery (RED)

+

+

+NOTE: ALSO COVERS RKE/RMST

Cut and tape off if not used

Optional I nstallation F eature

See Optional connections (3 of 3)

Ignition (VIOLET/ORANGE)

+

+

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Heater 2 (WHITE/VIOLET)

Starter (DK GREEN )

+CUT

KEY SIDE(after cut)

STEERINGCOLUMNHARNESS

Horn (BLUE)

Key-In Sense (BLACK/PINK)

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

BRAKESWITCH

+Brake (LT. GREEN/RED)

Heater (GRAY/YELLOW)

+

Page 416: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMST

Page Revision Date

3 of 3 5/26/04 +

+

DDM (IN DRIVER'S DOOR)

DDM (IN DRIVER'S DOOR)

+12V Feed (WHITE/BLUE) Connector C501a Cavity #10

Driver Door Unlock (RED/ORANGE)Connector C501a Cavity #21

White

White

White

30

87

87a8586

Black

Black

Yellow

30

87

87a

85 86

30

87

87a

85 86

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

Color FunctionC-10 RED/WHITE Headlight OutputC-11 BLUE/WHITE Rear Defroster Output

DRIVER'S DOOR UNLOCK

Memory Seats(BROWN/LT. GREEN)

Memory Seats(BLACK/ORANGE)

+

+

POWER OPTIONS

Color FunctionC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

Blue

Blue

Blue

Red

Black

Yellow

DEFROSTERSWITCH

Headlights (RED/YELLOW)

-Defroster (GRAY/ LT. BLUE)

NOTE: ALSO COVERS RKE/RMST

OPTIONAL CONNECTIONS

HEADLIGHT SWITCH

-

NOTE: Rear defroster connection can also be located at the bulkhead panel harness (Pin 34, C210 Connector)

NOTE:

Program both the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

++12V Feed (WHITE/BLUE) Connector C501a Cavity #10

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 417: ALL MODELS 2002

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

VehicleInterior

EngineCompartment

HOOD TILT SWITCH

DRIVER'S SIDEFUELINJECTOR

Tach Signal (LT GREEN/ORANGE)

ChassisGround

Do Not Ground to Hood!

Color Function A-5 BLACK Ground

DRIVER'S KICK PANEL HARNESS

CONNECTIONS UNDER HOOD

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC 1 12 volt Battery FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputB-7 BROWN Brake Input

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

Battery (LT GREEN/VIOLET)

Battery (RED)

+

+

+

Ignition (VIOLET/ORANGE)

+

+Heater 2 (WHITE/VILOET)

Starter (DK GREEN)

+CUT

KEY SIDE(after cut)

STEERINGCOLUMNHARNESS

Horn (BLUE)

Key-In Sense (BLACK/PINK)

Parking Lights (WHITE/BLACK)HEADLIGHT SWITCH

BRAKESWITCH

+Brake (GREEN/RED)

Heater (GRAY/YELLOW)

+

IMPORTANT! The tach sense input wire

must be properly insulated and secured.

Avoid routing the wiring at or near hot or

moving parts. Failure to properly connect

this wire will result in vehicle damage!

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL RMST

Page Revision Date

1 of 1 5/26/04

Page 418: ALL MODELS 2002

CONNECTIONS UNDER HOOD

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

+Door Lock (PINK/YELLOW) Connector C501a Cavity #6

+

+

+DDM (IN DRIVER'S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

Trunk Release (WHITE/VIOLET) Connector C501b Cavity #2

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK GroundA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock OutputA-13 TAN Trunk ReleaseC-4 LT GREEN/BLACK Factory Alarm Disarm OutputA-24 BLUE/GREEN Driver Door Unlock OutputC-12 GREEN/WHITE Memory 1 Output C-13 YELLOW/GREEN Memory 2 OutputC-8 BLUE Trunk Ajar Input

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

1 of 3 5/26/04CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Optional Installation Feature

See OPTIONAL CONNECTIONS (3 of 3)

Factory Alarm Disarm (LT. BLUE/BLACK)IN DRIVER'S DOOR ATKEY SWITCH

CUT THIS WIRE OFF WITHIN 2 INCHES OF THE 16-WAY CONNECTOR

Page 419: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

2 of 3 5/26/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN )

Horn (BLUE)

STEERINGCOLUMNHARNESS

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputC-10 RED/WHITE Headlight Output A-3 BLACK/WHITE Dome Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-

-

Parking Lights (WHITE/BLACK)

Headlights (RED/YELLOW)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (VIOLET/ORANGE)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Page 420: ALL MODELS 2002

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL DELUXE RKE/VSS

Page Revision Date

3 of 3 5/26/04

DDM (IN DRIVER'S DOOR)

White

White

Black

30

87

87a

85 86

30

87

87a

85 86

Yellow

Memory Seats(BROWN/LT GREEN)

Memory Seats(BLACK/ORANGE)

+

+

POWER OPTIONS

Color FunctionC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

Blue

Blue

Black

Yellow

++12V Feed (WHITE/BLUE) Connector C501a Cavity #10

+

+

DDM (IN DRIVER'S DOOR)

+12V Feed (WHITE/BLUE) Connector C501a Cavity #10

Driver Door Unlock (RED/ORANGE)Connector C501a Cavity #21

White 30

87

87a8586

Black

Yellow

Color Function A-24 BLUE/GREEN Driver Door Unlock Output

DRIVER'S DOOR UNLOCK

Blue

Red

OPTIONAL CONNECTIONS

NOTE:

Program both the "Driver's door priorty unlock" (Option #1, Option bank #2) option to ON

IMPORTANT!

The relay wire colors shown here, are the colors used on the FORD accessory relay kits listed above. Wire colors on other relays may be different!

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 421: ALL MODELS 2002

+

+

+

DDM (IN DRIVER'S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK Ground

A-9 BROWN Disarm Input

A-11 WHITE/BLUE Arm Input

A-12 Lt GREEN Unlock Switch Sense

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL VSS

Page Revision Date

1 of 1 5/26/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN )

Horn (BLUE)STEERINGCOLUMNHARNESS

-

CONNECTIONS UNDER HOOD

OPTIONAL CONNECTIONS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

HOOD TILT SWITCH

ChassisGround

Do Not Ground to Hood!

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (VIOLET/ORANGE)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

Optional parts - notincluded in kit

Page 422: ALL MODELS 2002

+Door Lock (PINK/YELLOW) Connector C501a Cavity #6

+

+

+

DDM (IN DRIVER'S DOOR)

Door Unlock (PINK/GREEN)Connector C501a Cavity #18

DRIVER'S KICK PANEL HARNESS

Color FunctionA-5 BLACK Ground A-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Switch SenseA-14 GREEN Door Unlock Output A-2 BLUE Door Lock Output

Driver Door Unlock Motor (RED/ORANGE)Connector C501a Cavity #21

Driver Door Lock Motor (PINK/BLACK)Connector C501a Cavity #22

CHASSIS GROUND POINTIN DRIVER' S KICK PANEL

MAKE THIS CONNECTION FIRST!

Vehicle (Year/Make/Model)

'05 Towncar

Equipment or Trim level System(s) applicable to:

ALL PRELOAD

Page Revision Date

1 of 1 5/26/04

Battery (LT GREEN/VIOLET)

Starter (DK GREEN)

Horn (BLUE)STEERINGCOLUMNHARNESS

-

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-21 BROWN/BLACK Horn Relay OutputA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input

HEADLIGHT SWITCH

-Parking Lights (WHITE/BLACK)

UNDER-DASHLIGHT

+Dome Lights (BLACK/BLUE)

IGNITION SWITCHIgnition (VIOLET/ORANGE)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!+

IN DRIVER'S DOOR AT KEYSWITCH

Color FunctionC-4 LT.GREEN/BLACK Factory Alarm Disarm Output -

*NOTE: This connection is only needed when using Lot Management remotes on vehicles with OEM security.

Part number 2W7Z 19C757 BA (Extended Function Harness) must be ordered to access the Factory Disarm Output.

Factory Alarm Disarm (LT BLUE/BLACK)IN DRIVER'S DOOR AT KEYSWITCH

Page 423: ALL MODELS 2002

515151515 15 15

15

5151515

15 15 15-+

-+

HVAC 1*

HVAC 2*

MAIN B+

IGNITION*

DOME LIGHT** PK LIGHTS

DOOR LOCKS**

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL ALLPage Revision Date

1 of 1 6/2/03

*Only used on (PC-32) systems with Car Start (RMST)** Not used on VSS system

FUSE PLACEMENT CHART SECURILOCK (PATS) INTERFACEAPPLICATION CHART(Required for systems with remote start)

2002: 1L2Z-19G365-AB2003: 1L2Z-19G365-AB

RELAY REQUIREMENTS:1 - DRIVER DOOR PRIORITY UNLOCK (OPTIONAL)1 - PARKING LIGHT ACTIVATION(Only required if vehicle is equipped with autolamps)Relays are available by ordering Ford part number YL3Z-19G390-AA(single) or YL3Z-19G390-BA (10 pack).

VEHICLE SPECIFIC PROGRAMMING:

Door trigger polarity Negative (Default setting)Unlock sensitivity polarity Positive (Default setting)Key in Sense polarity Negative (Default setting)

MODULE MOUNTING LOCATION:Driver’s side kick panel, below headlight switch and behind knee blocker panel

Note: Headlight Illumination option is not available on Windstar.

Page 424: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

1 of 3 6/2/03

Driver Door Unlock Motor (YELLOW)Connector C201e Cavity #26

Driver Door Lock Motor (RED/ORANGE)Connector C201e Cavity #12

-

-

+

FEM

Door Lock (BLUE/ORANGE) Connector C201d Cavity #6

Door Unlock (GREEN/YELLOW)Connector C201d Cavity #4

+

-

-Horn (ORANGE/RED)Connector C201a Cavity #8

Perimeter Alarm (BLUE/BLACK)Connector C201e Cavity #14

-Rear Defroster (WHITE)Connector C201e Cavity #21

FEM HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 Lt GREEN/BLACK Perimeter Alarm Disarm A-21 BROWN/BLACK Horn Relay OutputC-11 BLUE/WHITE Rear Defroster Output A-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USE C-9 TAN/RED DO NOT USE

DIMMER SWITCHDome Lights (YELLOW) -

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH

-Parking Lights(BLACK/GREEN)

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputC-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

HARNESS UNDER PASS. DOORSILL PLATE

Passenger Door Unlock Motor (Lt BLUE) +

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

Cut & tape if not usedConnect only on vehicles with factory RKE

NOTE: ALSO INCLUDES RKE/RMST30

87a85 86

D.BLUE/WHITE

12V+ Constant IGNITION

SWITCH

CUT

*For vehicles w/autolamp lights*

Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Page 425: ALL MODELS 2002

BRAKE PEDAL SWITCH-Brake (RED/GREEN)

AT COILPACK

Tach Signal (PINK/WHITE)

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-8 BLACK/WHITE Key-in-sense InputA-20 GREEN/VIOLET Door Ajar Switch InputB-7 BROWN Brake Input

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMTSTPage Revision Date

2 of 3 6/2/03 MAKE THIS CONNECTION LAST!

IGNITION SWITCH

4-WAY PLUG (RIGHT OF COLUMN)

Battery (RED)

Battery (GREEN/VIOLET)

Starter (GREEN)

Ignition (WHITE/YELLOW)

Heater (BLACK/Lt GREEN)

Key-In Sense (BLACK/PINK)

Heater (YELLOW) +

+

+

-

+

+

Battery (GREEN/VIOLET) +

+

CUT

KEY SIDE(after cut)

UNDERDASH LIGHT (BAR BEHIND CRASH PANEL)Dome Light (YELLOW/BLUE) -

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch

ChassisGround

Do Not Ground to Hood!

NOTE: ALSO INCLUDES RKE/RMST

Page 426: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL RKE/VSS/RMSTPage Revision Date

3 of 3 6/2/03

+

+Memory Seat 2 (BLACK/ORANGE)

Memory Seat 1 (BROWN/Lt GREEN)

SLIDING DOOR SWITCH (OVERHEAD CONSOLE)

DRIVER SEAT MODULE

Power Sliding Door(Lt GREEN/RED) -

Power Sliding Door(WHITE/Lt GREEN)

-

POWER OPTIONS

Color Function C-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorA-15 RED Power FeedC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

OPTIONAL CONNECTIONS

NOTE: ALSO INCLUDES RKE/RMST

White

White

Black

30

87

87a

85 86

30

87

87a

85 86

Yellow

Blue

Blue

Black

Yellow Relays shown are not supplied in kit. Relays are available by ordering Ford part number YL3Z-19G390-AA (Single) or YL3Z-19G390-BA (10 pack).

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor (YELLOW)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 427: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL RMSTPage Revision Date

1 of 1 6/2/03

-Horn (ORANGE/RED)Connector C201a Cavity #8

STEERING COLUMN HARNESS

Color FunctionA-4 RED Battery B-1 BLUE HVAC2 FeedB-2 RED HVAC1 FeedA-7 PINK Ignition 1 Input/OutputB-4 ORANGE HVAC 1 OutputB-5 ORANGE/WHITE HVAC 2 OutputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)B-7 BROWN Brake InputB-8 BLACK/WHITE Key-in-sense Input

FEM HARNESS

Color FunctionA-21 BROWN/BLACK Horn Relay Output

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output

UNDER HOOD HARNESS

Color FunctionA-19 GRAY Hood Open Switch InputB-9 VIOLET/WHITE Tach Sense Input

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH-Parking Lights

(BLACK/GREEN)

BRAKE PEDAL SWITCH-Brake (RED/GREEN)

MAKE THIS CONNECTION LAST!

IGNITION SWITCH

FEM

4-WAY PLUG (RIGHT OF COLUMN)

Battery (RED)

Battery (GREEN/VIOLET)

Starter (GREEN)

Ignition (WHITE/YELLOW)

Heater (BLACK/Lt GREEN)

Key-In Sense (BLACK/PINK)

Heater (YELLOW) +

+

+

-

+

+

++

Battery (GREEN/VIOLET)

CUT

KEY SIDE(after cut)

HOOD TILT SWITCH

AT COILPACK

Tach Signal (PINK/WHITE)

Chassisground

Do Not Ground to Hood!

VehicleInterior

Engine Compartment

IGNITIONSWITCH

30

87a85 86

CUTD.BLUE/WHITE

*For vehiclesw/Autolamps

12v constant

Page 428: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level system(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

1 of 3 6/2/03

-

UNDERDASHLIGHT (BAR BEHIND CRASHPANEL)

Dome Light (YELLOW/BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-20 GREEN/VIOLET Door Ajar Switch Input

Battery (RED)

+

Driver Door Unlock Motor (YELLOW)Connector C201e Cavity #26

Driver Door Lock Motor (RED/ORANGE)Connector C201e Cavity #12

-

-

+

FEM

Door Lock (BLUE/ORANGE) Connector C201d Cavity #6

Door Unlock (GREEN/YELLOW)Connector C201d Cavity #4

+

-

-Horn (ORANGE/RED)Connector C201a Cavity #8

Perimeter Alarm (BLUE/BLACK)Connector C201e Cavity #14

FEM HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputC-4 Lt GREEN/BLACK Perimeter Alarm Disarm A-21 BROWN/BLACK Horn Relay OutputA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Sense InputA-24 BLUE/GREEN Driver Door Unlock OutputA-13 TAN DO NOT USEC-9 TAN/RED DO NOT USE

HARNESS UNDER PASS. DOORSILL PLATE

Passenger Door Unlock Motor (Lt BLUE) +

Cut & tape if not used

Connect only on vehicles with factory RKE

Optional Installation FeatureSee DRIVER’S DOOR UNLOCK (3 of 3)

Page 429: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level system(s) applicable to:

ALL DELUXE RKE/VSSPage Revision Date

2 of 3 6/2/03

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

Optional Installation FeatureSee POWER OPTIONS (3 of 3)

UNDER HOOD HARNESS

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren

Hood Tilt Switch(Optional - Not includedin kit)

ChassisGround Do Not Ground to Hood!

DIMMER SWITCHDome Lights (YELLOW) -

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

HEADLIGHT SWITCH-Parking Lights

(BLACK/GREEN)HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light OutputC-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

30

87a85 86

CUT D.BLUE/WHITE

12v constant (RED)

*For vehicles w/autolamp only*

IGNITION SWITCH

Page 430: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL Deluxe RKE/VSSPage Revision Date

3 of 3 6/2/03

+

+Memory Seat 2 (BLACK/ORANGE)

Memory Seat 1 (BROWN/Lt GREEN)

SLIDING DOOR SWITCH (OVERHEAD CONSOLE)

DRIVER SEAT MODULE

Power Sliding Door(Lt GREEN/RED) -

Power Sliding Door(WHITE/Lt GREEN)

-

FEM

POWER OPTIONS

Color Function C-2 BLACK/GREEN Power Sliding Door C-10 RED/WHITE Power Sliding DoorA-15 RED Power FeedC-12 GREEN/WHITE Memory Seat 1 C-13 YELLOW/GREEN Memory Seat 2

OPTIONAL CONNECTIONSNOTE: ALSO INCLUDES RKE/RMST

White

White

Black

30

87

87a

85 86

30

87

87a

85 86

Yellow

Blue

Blue

Black

Yellow

Color FunctionA-15 RED Siren Feed

A-24 BLUE/GREEN Driver Door Unlock OutputA-9 BROWN Disarm Input

+Driver Door Unlock Motor (YELLOW)

Connect to the half of the wire going back into the vehicle’s interior

CUTDRIVER’S DOOR PRIORITY UNLOCK

NOTE:RKE/VSS/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #2) option to ONRKE/RMSTProgram the "Driver’s door priorty unlock" (Option #1, Option bank #1) option to ON

w/Factory RKE only

30

87

87a

85 86White

Yellow

Black

Red

Blue DRIVER SIDE JAMB BOOTHARNESS

Page 431: ALL MODELS 2002

DIMMER SWITCHDome Lights (YELLOW) -

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

w/o Factory RKE RKE & RKE/VSSPage Revision Date

1 of 1 6/2/03

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

FEM

-

-

-Horn (ORANGE/RED)Connector C201a Cavity #8

HEADLIGHT SWITCH-Parking Lights

(BLACK/GREEN)

FEM HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-21 BROWN/BLACK Horn Relay Output

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output A-3 BLACK/WHITE Dome Light Output

UNDER HOOD HARNESS (OPTIONAL)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren (Optional - Not included in kit)

Hood Tilt Switch(Optional - Not includedin kit)Chassis

GroundDo Not Ground to Hood!

Door Lock (BLUE/ORANGE) Connector C201d Cavity #6

Door Unlock (GREEN/YELLOW)Connector C201d Cavity #4

-UNDERDASHLIGHT

Dome Light (YELLOW/BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-20 GREEN/VIOLET Door Ajar Switch Input

Battery (RED)

+

30

87a85 86

CUT D.BLUE/WHITE

12v constant (RED)

IGNITION SWITCH

*For vehicles w/autolamp only*

Page 432: ALL MODELS 2002

-

UNDERDASHLIGHT (BAR BEHIND CRASHPANEL)

Dome Light (YELLOW/BLUE)

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

MAKE THIS CONNECTION LAST!

FEM

+

+

Driver Door Unlock Motor (YELLOW)Connector C201e Cavity #26

Driver Door Lock Motor (RED/ORANGE)Connector C201e Cavity #12

-Horn (ORANGE/RED)Connector C201a Cavity #8

HEADLIGHT SWITCH

HARNESS UNDER PASS. DOORSILL PLATE

Passenger Door Unlock Motor (Lt BLUE) +

-Parking Lights(BLACK/GREEN)

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

w/Factory RKE VSSPage Revision Date

1 of 1 6/2/03

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)A-20 GREEN/VIOLET Door Ajar Switch Input

FEM HARNESS

Color FunctionA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-21 BROWN/BLACK Horn Relay OutputA-12 Lt GREEN Unlock Sense Input

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light Output

UNDER HOOD HARNESS (OPTIONAL)

Color FunctionA-15 RED Siren Feed A-16 BLACK Siren OutputA-19 GRAY Hood Open Switch Input

VehicleInterior

EngineCompartment

REDBLACK

Siren (Optional - Not Included in Kit)

Hood Tilt Switch(Optional - Not Included in Kit)Chassis

GroundDo Not Ground to Hood!

Battery (RED)

+

Page 433: ALL MODELS 2002

Vehicle (Year/Make/Model)

’02/’03 WindstarEquipment or Trim level System(s) applicable to:

ALL PRELOADPage Revision Date

1 of 1 9/3/03

DIMMER SWITCHDome Lights (YELLOW) -

Driver Door Unlock Motor (YELLOW)Connector C201e Cavity #26

Driver Door Lock Motor (RED/ORANGE)Connector C201e Cavity #12

-

-

+

FEM

Door Lock (BLUE/ORANGE) Connector C201d Cavity #6

Door Unlock (GREEN/YELLOW)Connector C201d Cavity #4

+

-

FEM HARNESS

Color FunctionA-2 BLUE Door Lock Output A-14 GREEN Door Unlock OutputA-21 BROWN/BLACK Horn Relay OutputC-4 LT.GREEN/BLACK Factory Alarm Disarm OutputA-9 BROWN Disarm InputA-11 WHITE/BLUE Arm InputA-12 Lt GREEN Unlock Sense Input

CHASSIS GROUND POINTIN DRIVER’S KICK PANEL

MAKE THIS CONNECTION FIRST!

UNDERDASHLIGHTDome Light (YELLOW/BLUE) -

HEADLIGHT SWITCH

-Parking Lights(BLACK/GREEN)

HEADLIGHT SWITCH HARNESS

Color FunctionA-5 BLACK GroundA-1 WHITE Parking Light OutputA-20 GREEN/VIOLET Door Ajar Switch Input A-3 BLACK/WHITE Dome Light Output

Horn (ORANGE/RED)Connector C201a Cavity #8

HARNESS UNDER PASS. DOORSILL PLATE

Passenger Door Unlock Motor (Lt BLUE) +

IGNITION SWITCH

Starter (GREEN)

Ignition (WHITE/YELLOW)

+

+

CUT

KEY SIDE(after cut)

MAKE THIS CONNECTION LAST!

STEERING COLUMN HARNESS

Color FunctionA-10 YELLOW/WHITE Door Trigger Pull-UpA-4 RED Battery A-7 PINK Ignition InputA-8 VIOLET Starter Interrupt (Motor side)A-6 VIOLET/RED Starter Interrupt (Key side)

Battery (RED)

+

NOTE: REVIEW PRELOAD CONFIGURATION SECTION BEFORE PROGRAMMING

Connect only on vehicles with factory RKE

30

87a85 86

CUT D.BLUE/WHITE

12v constant (RED)

*For vehicles w/autolamp only*

IGNITION SWITCH

-Perimeter Alarm (BLUE/BLACK)Connector C201e Cavity #14