Airborne Sensing Platform - EDGEedge.rit.edu/content/P05009/public/PDR_presenatation.pdfAirborne...
Transcript of Airborne Sensing Platform - EDGEedge.rit.edu/content/P05009/public/PDR_presenatation.pdfAirborne...
Airborne Sensing Platform#05009
Concept Development – Sponsor Session
Team: Jonathan Fentzke – Project Leader
Joseph O’Day – Mechanical LeadEric Greenwood – Airframe Lead
John Priestly – RF LeadJean Laurin – Vision Lead
Sponsor: The Center for Imaging ScienceSponsor: The Center for Imaging ScienceMentor: Dr. Kevin KochersbergerMentor: Dr. Kevin KochersbergerCoordinator: Dr. Wayne WalterCoordinator: Dr. Wayne WalterTerm: Winter 2004/2005Term: Winter 2004/2005
Outline• Introduction• Mission Statement• Performance Objectives• Concept Development
– Guidance and Telemetry, Control/Communication• Feasibility and Overall System Selection• Analysis and Synthesis
– Airframe, Structural, Power Consumption, Communication, and Circuitry
• Questions and Answer Session
Mission StatementOur objective is to design and implement an Unmanned Aerial Vehicle guidance system for the Center for Imaging Science. This project
will produce a stable airborne sensing platform test bed with a flight control system.
Performance Objectives• Flight duration of 1 hour • The platform must fly to a maximum 1,000 ft.• The platform must fly up to 2 miles away from the
base station.• The platform must fly at speeds between 15-
25mph.• The platform will carry a 3-lb. modular payload
designated by CIS • Prototype to be completed by May 2005 at or
below budget
Trade Study
• Specification Weighting• Concrete Selection Criteria• Clear Concept Down Select• Defense Industry Standard
Communication - Concept
• Streaming Video Feedback• Real-time Platform Telemetry and Stability Feedback• Maintain Quality Link up to 2 miles
Communication – Trade Study• Frequency Modulation• 500 mW Output Power• Extremely Small
– 2.1 oz– 2.5”x1.0”x0.3”
• 100 mW Output Power• -114 dBm Sensitivity• Integrated on AP50
Feasibility – RF• 900 MHz
– Highest Theoretical Margin– Low Power Consumption– Low Cost– Provides Enough Bandwidth
for Streaming Video Requirement
Feasibility – Comm Architecture• Combine Components
– Low Power Consumption
– Smaller Space Requirement
– Low Cost– Reduces Interference
Video Camera Selection
• Image Sensor: CCD• Lens: 3.6mm, 92o
• Signal: NTSC/EIA• Resolution: 420TVlines• Min. Illum.: 0.05 Lux• Power: 1.08 W• Cost: $35
0.05 Lux
1.0 Lux
Piloted / Autonomous Control
• Communication at distance• Take Off / Landing
• Navigation / Stability / Feedback• Reduce Pilot Work Load
Piloted Control
• Actuate Control Surfaces: aileron, rudder, elevator etc. • Take off / Landing• Customization / Pilot Comfort• Receiver Size / Ease of Use
Autonomous Control• Power / Weight /
Overall Dimension• Stability Augmentation• Operating Modes• Range and Reliability• Ease of Implementation• Development Potential
Overall System Selection
• 900 MHz Video Tx/Rx• 9 Channel RC Controller / Receiver• Omni Directional Antennas• AP50 AutoPilot with GroundPilot GUI• B/W CCD Camera• Sensor Package
Airframe#05008 Stability Redesign – Problem Identification• High passive stability required for automatic
systems and turbulent environments • Analysis showed tail and control surface volume
coefficients to be as much as 85% below reference• Static margin computed to be less than 7%• Ailerons located in region of high vortex losses
Airframe#05008 Stability Redesign – Recommendations• Increase horizontal and vertical tail spans by 50%• Increase control surface chords by 25%• Relocated aileron centers to 2/3 half-span point• Add 3 degrees dihedral to main wing#05008 Stability Redesign – Results• Static margin of 15% to 20%• Increased control effectiveness• Increase tail volume coefficients from 0.01 to 0.06 for the
vertical and from 0.21 to 0.30 for the horizontal
AirframeSenior Telemaster Performance Evaluation• Offer CIS an alternative airframe for better uptime
and increased performance• Avionics and powerplant shared between
Telemaster and #05008 airframes• The Senior Telemaster was designed to lay
telecommunications cable between mountaintops and is well designed for this application
AirframeSenior Telemaster Performance Evaluation• Calculations assume payload in excess of 11 lbs• Computed flight velocities for best range and
endurance• Takeoff and Landing rollouts
AirframeSenior Telemaster Performance EvaluationSpeed for Best Endurance
CL3/2/CD at Sea Level and Cruise Condition
0
2
4
6
8
10
12
14
0 5 10 15 20 25 30 35 40
Velocity (m/s)
CL3/
2 /CD
AirframeSenior Telemaster Performance EvaluationSpeed for Best Range
Lift to Drag Ratio vs. Velocity at Sea Level and Cruise Conditions
0
2
4
6
8
10
12
0 5 10 15 20 25 30 35 40
Velocity (m/s)
CL/C
D
AirframeSenior Telemaster Performance Evaluation –Results
Range and Endurance Calculations Lowest Power Consumption (W) 71.00 Cruise Speed at LPC (m/s) 9.00 Stored Energy (W - h) 148.00 Endurance (h) 2.08 Range at Lowest Consumption (km) 67.54 Best Range Consumption (W) 84.00 Cruise Speed at BRC (m/s) 13.00 Stored Energy (W - h) 148.00 Endurance (h) 1.76 Range at BRC (km) 82.46 Energy Expenditure for 300m climb (W - h) 23.00 Remaining Energy (W - h) 125.00 Minimum Time to 300m Altitude (s) 93.00 Endurance at Altitude (h) 1.76
Structural• Asymmetric beam bending
• Max compressive stress 9920 psi
• Max tensile stress 8020 psi
• Transverse shear
• Max shear stress 114 psi
• Torsion
• Max torsional stress of 3930 psi
• Max fillet stress of 6840 psi
• Von Mises failure criteria
• Principal stresses used predict a margin of safety of 3.9
Power Consumption
•18.5 Volt 8000 mAhr Lithium Polymer Battery for Motor•14.8 Volt 2100 mAhr Lithium Polymer Battery for Electronics and Servos
Communication Link Budget
• Determine Baseline Requirements for Each Component
• Shoot for +30 dB Margin
2/18/2005
Product NumberTeam
ChargedDescription Status Quantity
Retail Price Per Unit
Total Price
LXPT40 #05008 Tower Hobbies Build-It CA- Thick Glue 2 oz. Arrived 1 $5.99 $5.99#05008 Derek Aero-Team Tail Build Complete 1 N/A $200.00
LXPT38 #05008 Tower Hobbies Build-It CA Thin Glue 2 oz. Arrived 1 $5.99 $5.99LXK110 #05008 Great Planes CA Hinges 3/4"x1" (24) Arrived 1 $2.99 $2.99LXL431 #05008 Hobbico Latex Foam Rubber 1/2" Arrived 3 $4.49 $13.47LXK108 #05008 Great Planes Nylon Control Horns Large (2) Arrived 3 $0.95 $2.85LX3609 #05008 Astro Flight Power Supply 13.5V Arrived 1 $74.95 $74.95
LXFWW2 #05008 Astro Flight 109 Lithium Charger 1-9 Cell 7.5 Amps BackOrder 1 $114.99 $114.99LXHRC2 #05008 APC 13x10 Folding Prop Arrived 2 $7.19 $14.38LXZL06 #05008 APC folding Propeller hub 45mm Arrived 2 $4.79 $9.58LXJD33 #05008 Tower Hobbies Plywood 1/8x6x12" Arrived 2 $1.79 $3.58LXJD32 #05008 Tower Hobbies Plywood 1/16x6x12" Arrived 2 $1.49 $2.98LXD867 #05008 Dubro Threaded Rod 2-56 12" (6) Arrived 1 $2.89 $2.89LXN666 #05008 Hitec HS-225MG Mighty Mini BB MG Servo J Arrived 4 $27.99 $111.96LXHV43 #05008 Top Flite Monokote Blue 6' Arrived 1 $10.99 $10.99
PM412018 #05008 AXI4120-18 Model Motors - DC Motor Arrived 1 $139.00 $139.00JESAP70P #05008 Jeti 70A Speed Controller Arrived 1 $147.20 $147.20
#05008 18.2v Lithium Battery Arrived 1 $399.00 $399.00PM41002 #05008 AXI4120 Model Motors - Motor Mount Arrived 1 $18.50 $18.50LXK196 #05008 Great Planes Nylon Wing Bolt ¼-20x2 (4) Arrived 3 $1.25 $3.75
#05009 9 Channel Futaba Radio Controller Pending 1 $799.99 $799.99#05009 AP50 AutoPilot Autonomous Flight Hardware: GPS, Inertial, Rx/Tx Pending 1 $6,000.00 $6,000.00
VC-210B-AUDIO #05009SONY CCD Camera w/Audio CH- Circuit Specialists Inc (yahoo store) http://shop.store.yahoo.com/webtronics/mibwcav.html4 Pending 1 $34.50 $34.50
#05009 Aluminum stock McMaster Pending 1 $22.48 $22.48399-2054-ND #05009 Digikey.com - Capacitor, ceramic, 0.1uF,50V Pending 5 $0.21 $1.05399-2099-ND #05009 Digikey.com - Capacitor, ceramic, 0.33uF,50V Pending 5 $0.83 $4.15
MC7812CTOS-ND #05009 Digikey.com - Regulator, pos, 1A, 12V Pending 2 $0.58 $1.16MC7805CTOS-ND #05009 Regulator, pos, 1A, 5V Pending 2 $0.58 $1.16
LXHUP0 #05009 Futaba R319DPS 9-Channel PCM Receiver Synthesized Pending 1 $179.99 $179.99LXH258 #05009 Futaba TK50 & 72 FM/PCM Transmitter Module Pending 1 $54.99 $54.99
#05009 TX-9500 A/V Mini-Transmitter Pending 1 $129.99 $129.99#05009 RX-900 A/V Receiver www.eyespyvideo.com Pending 1 $109.99 $109.99#05009 Winch System - Tom McCann Pending 1 $600.00 $600.00#05009 Telemaster Building Materials Pending 1 $200.00 $200.00
A09-HBMM-P5I #05009 Omni Directional Airborne Antenna - MaxStream Pending 2 $25.00 $50.00OD9-6 #05009 Omni Dir. Basestation Antenna - Streak Wave (Order Online) Pending 2 $68.95 $137.90
TP2100-4S #05009 14.8 V 2100 mAh 4 Cell Li Polymer Battery Pending 1 $99.95 $99.95
Total Budget: $10,000 Subtotal: $9,291.11
Percent Spent: 92.91%
Rochester Institute of Technology, www.designserver.rit.edu
Bill of Materials*Covers Costs incured by team #
05008 & #05009
Stability Analysis Detail( )( ) ( )( ) ( )( ) ( )( )
( )( ) ( )( ) ( )( ) ( )( )
)(
cossinsincos
cossinsincos
,0
21
2
21
2
21
2
21
2
222
1
11
1
11
1
11
1
111
ee LMWLM
TrimLMLMe
McgtailMcgwMcgwMcg
tailHTTMcgtail
w
cqwDw
w
cqwLw
w
acwcqDw
w
acwcqLwMacwMcgw
w
cqwDw
w
cqwLw
w
acwcqDw
w
acwcqLwMacwMcgw
CCCCCCCC
CCCC
VaC
cz
Cc
zC
cxx
Cc
xxCCC
cz
Cc
zC
cxx
Cc
xxCCC
δααδ
ααδ
αη
αααα
αααα
⋅−⋅⋅+⋅
−=
++=
⋅⋅⋅−=
−
+
−+
−+=
−
+
−+
−+=
cSlSV TT
H ⋅⋅
=bSlSVv Tv
⋅⋅
=bSyS
V⋅⋅
= ζζζ
4/cxac =
α
α
L
M
CC−
=Margin Static
ee
tLTHMcg
CVC δ
δη
∂∂
−=∆ ,
rr
vLTVNcg
CVC δ
δη
∂∂
−=∆ ,
Least-squares optimization routine used to calculate ideal tail sizes